2022 CHEVROLET SILVERADO 2500 Recalls, Complaints & Safety

The contact owns a 2022 Chevrolet Silverado 2500. The contact stated that during or after it rained, the tailgate occasionally opened unexpectedly while driving. The dealer was notified of the failure, and the contact was informed that a diagnostic test was needed to determine the cause of the failure. The manufacturer was notified of the failure and provided the same information as the dealer. Upon investigation, the contact discovered NHTSA Campaign Number: 24V060000 (Latches/Locks/Linkages); however, the VIN was not included in the recall. The vehicle was not repaired. The failure mileage was approximately 24,000.

The Transmission on my truck down shifted and made it so I lost all power while driving. If I would have been on the freeway it probably would have killed me or caused a serious accident. It is at a shop waiting to be inspected but they said it was the valve body in the transmission. No warning lights came on at all, and the shop had to plug a computer into my transmission to get the codes. GM needs to make this right because it is going to kill someone or cause harm if a bad accident happens due to failure at freeway speeds.

Rear backup camera works intermittently especially after long drives. Screen is black with a camera in a red circle with a slash thru it.

Transmission Control Valve Body (Recall #N242454440) Your truck is part of the massive recall issued late last year (expanded in February 2026) regarding the 10-speed Allison transmission. The Problem: Internal wear in the valve body causes a drop in pressure, which can cause the rear wheels to lock up suddenly while you're driving. Multiple occurrences. It has been taken to the shop for this issue.

The contact owns a 2022 Chevrolet Silverado 2500. The contact stated that while driving at slower speeds, the vehicle hesitated to accelerate while the accelerator pedal was depressed. No warning lights were illuminated. The vehicle was taken to a local dealer, where it was diagnosed with a valve body failure. The vehicle was left with the local dealer for repair. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 113,000.

Driving near on the [XXX] had a blowout at because tire separated. My whole family and animals were in the truck. Putting us all at risk. The tires only had 18k miles on them. The truck also sustained damage. Tire size 29570r18 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

This is the 3rd complaint for the 3rd tire thay separated and almost blew rendering the truck undriveable for safety reasons. Only 22k miles on it. Size Tire size 29570r18

This is my second complaint of three as three of my falken wild peak AT3 tires separated with less than 20k miles on them. This one separated on the way to get the damage from the first blowout fixed. Tire size 29570r18

Concerned about the 10 speed transmission and the rear wheel lock-up , and how to obtain a extended warranty to cover this if trouble arises from issues with 10 speed transmission issues

The internal components of the tailgate are damaged by water and need to be replaced. They cause the tailgate to open and close randomly. This could cause items to fall from the truck bed on to the road.

It is a very well known issue with these make and model trucks, ( 19-current Silverado 1500,2500,3500) that the eurethane on the back glass and the back glass track/frame cracks and leaks water causing an unsafe environment inside the vehicle if not caught. There is little to no visible evidence this occurs unless you really look and or take apart the headliner and rear spoiler on the cab to search for this issue. Water intrusion into the cab of the vehicle can build mold / mildew and cause a severe health issue for occupants inside the vehicle. Gm has a TSB out on this issue and I believe it should be a recall as there are thousands of trucks out there with this issue risking a respiratory issue to those inside the vehicle.

I was in an accident where a drunk driver pulled out in front of me. I waw traveling at 55 and he drive in front of me without stopping from a side road. I swerved to miss him while applying the brakes. We collided I hit him with the driver front fender, where it crushes the fender and started peeling the driver door back. After the impact I continued through a ditch up onto a hill and struck a tree around 6" in diameter. I believe I was doing 40-50 when I struck the other vehicle and 25 when I struck the tree. The air bags did not deploy.

Crash

The contact owns a 2022 Chevrolet Silverado 2500. The contact stated that the tailgate occasionally opened and closed independently. The failure was intermittent. The vehicle was taken to the dealer, who determined that the tailgate switch needed to be replaced. The contact linked the failure to NHTSA Campaign Number: 24V060000 (Latches/Locks/Linkages); however, the VIN was not included in the recall. The vehicle was repaired. The manufacturer was informed of the failure, and a case was opened. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 22,000.

The vehicle was in a collision that occurred to the front of the vehicle causing the seat belts to lock up a burst of compressed air to come from the dash, the hazards to engage and the dome lights to engage, the vehicle then was taken into get repaired at a certified dealership, after dealing with the dealership and General Motors we find out the sensor did engage for the airbags to deploy but the airbags failed to deploy properly or break through the dash, the dealership and manufacturer are now not wanting to find out why this is doing this and just put a new airbag baffle in and call it a day.

Crash

The vehicle was in a collision that occurred to the front of the vehicle causing the seat belts to lock up a burst of compressed air to come from the dash, the hazards to engage and the dome lights to engage, the vehicle then was taken into get repaired at a certified dealership, after dealing with the dealership and General Motors we find out the sensor did engage for the airbags to deploy but the airbags failed to deploy properly or break through the dash, the dealership and manufacturer are now not wanting to find out why this is doing this and just put a new airbag baffle in and call it a day.

Crash

The vehicle was in a collision that occurred to the front of the vehicle causing the seat belts to lock up a burst of compressed air to come from the dash, the hazards to engage and the dome lights to engage, the vehicle then was taken into get repaired at a certified dealership, after dealing with the dealership and General Motors we find out the sensor did engage for the airbags to deploy but the airbags failed to deploy properly or break through the dash, the dealership and manufacturer are now not wanting to find out why this is doing this and just put a new airbag baffle in and call it a day.

Crash

There are recalls on other chevy with different vin numbers. On this truck the automatic tail gate keeps ope ing and closing and opening when driving down the road, I have been lucky not to loose stuff out the back when it decides to open while driving down the road.

Emergency brakes do not disengage all the time, resulting in brakes overheating.

When truck is turned off, cannot remove key. You have to wait 5 minutes or more before the key will come out of the ignition. Sometimes longer. This is an ongoing problem. We have another truck doing the same thing.

The contact owns 2022 Chevrolet Silverado 2500. The contact stated while driving approximately 50 - 70 MPH, the transmission shifted from second gear to eighth gear. No warning light was illuminated. A dealer was contacted. The vehicle was not taken to a dealer or independent mechanic to be diagnosed. The vehicle was not repaired. The contact stated that the failure had occurred on several occasions The contact related the failure to NHTSA Campaign Number: 24V797000 (POWER TRAIN); however, the VIN was not included in the recall. The manufacturer was not notified of the failure. The failure mileage was 100,000.

Three of four original Goodyear Wrangler TrailRunner AT tires (DOT 0222) on my 2022 GMC Sierra 3500 have experienced catastrophic tread separations under normal use with 28,095 miles. The first two failed under warranty and were replaced at my expense; the third failed at highway speed, causing vehicle damage and a $1,000 insurance deductible plus additional cost to replace the tire. The dealership advised GM sent the failed tires for analysis, but GM denies receiving or reviewing them. Multiple NHTSA complaints describe identical failures on this same tire model (e.g., #11522434, #11482843, #11457647). This pattern indicates a potential widespread safety defect.

These tires are good year wrangler trail runner at size lt275/65 r20. My total mileage on these tires was 40970These were the original tires that were installed when the truck was purchased new. My tires are rotated every 5000 miles. Tire pressure is maintained at the exact pressure. I was driving on an interstate at 70 mph. A vibration started. I checked the tire pressure monitors and all showed normal pressures - I stopped and observed the tires were no longer round but had bulges to one side of the tread surface Both are likely to blowout and have to be replaced Two did this same thing in last 2 weeks

See attached document for complaint.

While driving on the freeway in a construction zone, I smelled a burning oil smell. I considered the possibility it was in relation to road repairs being done (roads being repaved, ie tar resurfacing). I was cut off by another vehicle and depressed my brakes and I saw a poof of smoke over the front passenger area near tire. I noticed all of my gauges were in the normal ranges (temperature, battery voltage, etc.) In less than a minute my truck went into limp mode and advised it had a DEF system issue and it would be limited to a set MPH and a set number of miles. Check engine light came on and another driver alerted me that the underneath of my vehicle was on fire. I pulled over to the side of the highway and my truck became engulfed in flames in. Truck is under factory warranty, unmodified, never been in an accident and has had all recommended services performed at local dealership. There was a significant amount of traffic and luckily I did not collide with anyone or set neighboring dry grass field on fire. Fire department responded and extinguished the fire, but it is a total loss. Insurance company has been notified, and vehicle will be available for inspection by appropriate agencies. While local law enforcement did respond, they did not take a report because I didn't hit anything, and the only property damage was my own. (There is documentation of the event, but just dispatch notes.) Prior to the situation above the truck had been at operating temperature for at least 20 minutes and I had traveled for about 20 miles on the highway. The total distance traveled from when I smelled the burning smell was maybe 1.5 miles.

Fire

While driving on the freeway in a construction zone, I smelled a burning oil smell. I considered the possibility it was in relation to road repairs being done (roads being repaved, ie tar resurfacing). I was cut off by another vehicle and depressed my brakes and I saw a poof of smoke over the front passenger area near tire. I noticed all of my gauges were in the normal ranges (temperature, battery voltage, etc.) In less than a minute my truck went into limp mode and advised it had a DEF system issue and it would be limited to a set MPH and a set number of miles. Check engine light came on and another driver alerted me that the underneath of my vehicle was on fire. I pulled over to the side of the highway and my truck became engulfed in flames in. Truck is under factory warranty, unmodified, never been in an accident and has had all recommended services performed at local dealership. There was a significant amount of traffic and luckily I did not collide with anyone or set neighboring dry grass field on fire. Fire department responded and extinguished the fire, but it is a total loss. Insurance company has been notified, and vehicle will be available for inspection by appropriate agencies. While local law enforcement did respond, they did not take a report because I didn't hit anything, and the only property damage was my own. (There is documentation of the event, but just dispatch notes.) Prior to the situation above the truck had been at operating temperature for at least 20 minutes and I had traveled for about 20 miles on the highway. The total distance traveled from when I smelled the burning smell was maybe 1.5 miles.

Fire

While driving on the freeway in a construction zone, I smelled a burning oil smell. I considered the possibility it was in relation to road repairs being done (roads being repaved, ie tar resurfacing). I was cut off by another vehicle and depressed my brakes and I saw a poof of smoke over the front passenger area near tire. I noticed all of my gauges were in the normal ranges (temperature, battery voltage, etc.) In less than a minute my truck went into limp mode and advised it had a DEF system issue and it would be limited to a set MPH and a set number of miles. Check engine light came on and another driver alerted me that the underneath of my vehicle was on fire. I pulled over to the side of the highway and my truck became engulfed in flames in. Truck is under factory warranty, unmodified, never been in an accident and has had all recommended services performed at local dealership. There was a significant amount of traffic and luckily I did not collide with anyone or set neighboring dry grass field on fire. Fire department responded and extinguished the fire, but it is a total loss. Insurance company has been notified, and vehicle will be available for inspection by appropriate agencies. While local law enforcement did respond, they did not take a report because I didn't hit anything, and the only property damage was my own. (There is documentation of the event, but just dispatch notes.) Prior to the situation above the truck had been at operating temperature for at least 20 minutes and I had traveled for about 20 miles on the highway. The total distance traveled from when I smelled the burning smell was maybe 1.5 miles.

Fire

Tailgate going up and down on its own when in park. Now it will not open at all. There is a recall #N232426400 but dealership says it is not listed for my truck.

See recall N232426400 or customer satisfaction recall N232426401. My tailgate opens on its own and the button has quit working manually. My truck is apparently not a part of the recall?

After driving truck. Attempt to turn KEYED ignition off, they key will not move the the off position for removal. Must wait several minutes for the key lock mechanism to release then remove the key.

Vehicle was brought to Lone Star Chevrolet in Houston on 6/16/2025 because Tailgate would not open with the button and only would open with the fob. They stated no parts to fix and did not advise of the severity of risk from the recall when picked truck up. Saturday afternoon [XXX] while leaving a parking lot and driving on the feeder road the tailgate opened resulting in the large ice chest that was full of water bottles ice and and storage containers with food to fall on road along with battery power fan and several extra batteries. These items unexpectedly sliding down the feeder resulted in several cars making defensive maneuvers nearly resulting in several crashes and the ice chest bumping 1 vehicle. All lanes of traffic stopped and several people helped to pick up the debris off the road. No information from people who stopped was collected, and no report from driver of truck that hit cooler. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Crash

Service trailer brake system fault resulting in battery drain causing failure to strart

While towing our camper, the trailer brakes constantly turn off and on. The camper dealer already checked over the camper wiring, and hooked it to Ford and Ram tow vehicles and could not replicate the problem. The problem is obviously with my Silverado. For the additional details below; - The approximate date is Anytime and Everytime we tow the camper. - There could be a crash anytime the trailer brakes turn off. - A crash due to no trailer brakes Could cause a fire. - An injury or fatality would be highly likely if the trailer brakes "disconnect" at the wrong time causing a crash, with or without fire. - There would most certainly be a police report if any of the above happened.

Tail gate opens and shut by its self while I’m going down the road have dropped a couple things out and lost them could have been worse if some one hit by jack that fell out

So the electrical would be when I shut my truck off in park I cannot turn my key completely back to release the key so therefore I’m killing my battery leaving the power on as far as the tires they’re rated for 50 or 55,000 miles I have 37,000 miles and I have no tread left and as far as my drivetrain when accelerating onto a highway pulling my fifth wheel camper that is 16,000 pounds loaded the truck box really bad as far as the crash warning breaking system it does not break

Tail gate opens and shut by its self while I’m going down the road have dropped a couple things out and lost them could have been worse if some one hit by jack that fell out

I was driving to an event and I noticed my truck was pulling slightly. As I pulled onto the freeway and accelerated, I felt and heard a thumping sound but could not distinguish it between the pattern in the freeway or an issue with a tire. I continued to accelerate and the tire blew at about 55 mph. I was pulling a 5th wheel in a construction zone and was not immediately able to safely pull off the roadway. Extensive damage was done to the body of the truck with a current estimate at $4,832.18. The rim and tire were also destroyed with the rim being valued at $841.08 and tire at $408.

When vehicle is placed in park the safety lock will not allow the key to turn to the "off" position and be removed. The vehicle will not turn "off" any further than the accessory position. Sometimes after turning the steering wheel back and forth while working the ignition the key will release. If this does not work after a minute or so, sometimes you can start the truck and immediately turn it all the way off and get the key to release. If all of that fails the last option is to disconnect the battery. It is an intermittent issue that will happen 5 times a day for a week, and then will not replicate again for a week or two.

I was driving to an event and I noticed my truck was pulling slightly. As I pulled onto the freeway and accelerated, I felt and heard a thumping sound but could not distinguish it between the pattern in the freeway or an issue with a tire. I continued to accelerate and the tire blew at about 55 mph. I was pulling a 5th wheel in a construction zone and was not immediately able to safely pull off the roadway. Extensive damage was done to the body of the truck with a current estimate at $4,832.18. The rim and tire were also destroyed with the rim being valued at $841.08 and tire at $408.

the emergency brake warning light keeps coming on, service, reduced engine function. I have taken in to the dealership and they cant find the problem, this is on many forums and with little to no answers, just a lot of speculation.

I started to her a light tapping in engine and also noticed smoke color coming from exhaust when I used the remote start and at other time. Truck has been going through a quart of oil or more at roughly 3400 miles before the 5000 miles before the service is actually due. Spoke to dealership several times and they say that is normal. Called GM directly and filed a complaint.Never had a vehicle that needed oil before service was due. That’s not normal. I feel like I’m getting the run around

The contact owns a 2022 Chevrolet Silverado 2500. The contact stated that the tailgate intermittently unintendedly unlocked. The vehicle was taken to the dealer, and the contact was informed that the vehicle was previously included in NHTSA Campaign Number: 24V060000 (Latches/Locks/Linkages) and was repaired under the recall. The dealer could not confirm where and when the vehicle was repaired. The vehicle was not repaired a second time. The manufacturer was made aware of the issue. The failure mileage was 109,000.