2006 CHEVROLET SILVERADO 2500 Recalls, Complaints & Safety

265/75R16 9100 miles driven mostly on pavement with loads well within the vehicle capacity and never off road. Tires were rotated several months prior, about 100 miles ago and damage was not noted. Bubble appeared on sidewall which was noticed while parked; Tire shop dismounted the tire to inspect for possible causes and found nothing to explain damage (run flat, left deflated, road hazard damage). Secondary bubble slightly smaller on inside at same location. Smaller bubbles were felt inside tire and a longer, slight bubble follows the bead 1/3-1/2 of the diameter of the tire. Shop manager refused to remount tire due to risk to employees of catastrophic failure, indicating the tire poses significant safety risk if vehicle had been at highway speed and completed its deterioration. Mate to this tire on right rear shows same smaller bubble above the bead about 1/3 of tire diameter.

On 31 Dec 21, I drove the vehicle to the car wash, after the wash was completed, I drove the vehicle approx. 1/2 mile down the road. I pulled in to a fast food lane to order a meal. While I was stopped that speaker ordering the Air bags deployed. I was not moving or struck my another vehicle. If had happen when I was driving on the hi-way it may have caused injury to myself or damage to other vehicles. The vehicle is currently available for inspection. I will be taking the vehicle to the dealer for inspection on 3 Jan 22. There was no warning prior to the deployment of the airbags.

ANYTIME A TRAILER IS FIRST ATTACHED, THE TRUCK WILL RANDOMLY GO INTO REDUCED POWER MODE WHILE DRIVING. THIS IS VERY UNSAFE AS THE TRUCK CAN TO THIS AT HIGHWAY SPEED IN TRAFFIC. IT WILL DO THIS A FEW TIMES UNTIL THE PCM "LEARNS" THERE IS A TRAILER ATTACHED. GM IS AWARE OF THE ISSUE AND ISSUED SERVICE BULLETIN 06-06-04-042B TO ADDRESS THE ISSUE BY REPROGRAMMING THE PCM. BECAUSE OF THE SAFETY CONCERNS, THIS SHOULD BE ADDRESSED AS A RECALL. HOWEVER,I HAD TO TAKE THE TRUCK INTO THE DEALER FOR THE UPDATE AND WAS EXPECTED TO PAY FOR THEM FIXING A KNOWN SOFTWARE ISSUE. INSTEAD OF DOING THE UPDATE AT NO CHARGE, THEY MANAGED TO DAMAGE THE PCM WHILE PERFORMING THE UPDATE. THE PCM IS NO LONGER SERVICEABLE AND THE DEALER IS WANTING TO CHARGE ME FOR A REPLACEMENT EVEN THOUGH IT WAS DAMAGED DURING A CALLED FOR SERVICE BULLETIN UPDATE. THE VEHICLE WAS NOT ORIGINALLY EQUIPPED WITH A TRAILER HITCH SO THE PROBLEM DIDN'T ARISE UNTIL THE HITCH WAS INSTALLED AND A TRAILER WAS ATTACHED.

GOING DOWN A SNOWY GRAVEL ROAD AND LOST CONTROL. HIT A DITCH/SNOW BANK HEAD ON AT APPROX. 30MPH. AIR BAGS DID NOT DEPLOY. AS A RESULT DRIVER SUSTAINED HAND INJURY, A BROKEN JAW REQUIRING SURGERY, AND OTHER MINOR BODILY INJURIES. VEHICLE HAD 313,000 MILES

Crash 1 injured

EXHAUST MANIFOLD BOLTS ARE BROKEN OFF ON BOTH SIDES OF THE 6.0 ENGINE, CAUSING EXHAUST FUMES IN THE PASSENGER COMPARTMENT WHEN I DRIVING THE VEHICLE. I HAVE OWNED THIS VEHICLE SINCE NEW AND HAVE NEVER HAD ANY ENGINE WORK DONE TO THIS VEHICLE.

THE REAR BRAKES FAILED WITH LITTLE OR NO WARNING. THE BRAKES WENT FROM GOOD TO MUSHY WITHOUT WARNING LIGHT. I ADDED BRAKE FLUID TO TEST IN DRIVE WAY. PUMPED THE BRAKES AND THE WARNING LIGHT CAME ON. THE REAR LINE FAILED. I HAD THE TRUCK INSPECTED AT A GENERAL MOTORS DEALER IN JANUARY OF 2018 AND ALSO AT THE END OF FEBRUARY. THE SAID MY VEHICLE IS MAINTAINED IN EXCELLENT CONDITION. IF THIS COULD HAPPEN TO ME....ALL GM VEHICLES WITH THESE BRAKE LINES ARE AT RISK. I READ THEIR WAS A SAFETY BULLETIN 13-05-22-001. TODAY IS 4/12/2018...BECAUSE I TOW A BOAT TO FLORIDA I HAD THE TRUCK CHECKED 2 TIMES IN THE LAST 12 WEEKS....IF THE DEALERS CAN'T DETECT FAULTY LINES....A RECALL IS NEEDED.

UPON STARTING MY TRUCK, THE OIL PRESSURE GAUGE IMMEDIATELY GOES TO 80 WITH NO ACCELERATION. AT THIS POINT, THERE IS NO NOISE OR OTHER LIGHTS COMING ON TO WARN OF OTHER PROBLEMS. THIS PROBLEM STARTED A FEW DAYS AGO. WHEN TRUCK IS IN MOTION THE OIL PRESSURE GAUGE CONTINUES TO STAY ON 80. I KNOW THE 2006 CHEVY 2500 HEAVY DUTY 4X4 HAVE HAD RECALLS ON DIFFERENT THINGS, BUT NEED TO SEE IF THIS IS A PROBLEM FOR OTHER CHEVY TRUCKS AS WELL. I HAVE READ SEVERAL RECALLS ABOUT THESE TRUCKS AND A LOT OF THEM WE HAVE NEVER BEEN NOTIFIED TO TAKE IT TO A DEALER TO BE CHECKED. ANY HELP YOU CAN GIVE US WOULD BE DEEPLY APPRECIATED.

THE RIGHT FRONT BRAKE LINE ON MY TRUCK RUSTED THROUGH. I LOST BRAKING WHEN LOADING MY 10 FT CAMPER IN THE DRIVEWAY. I TOOK THE TRUCK TO DEALERSHIP AND IT WAS FOUND THAT ALL THE BRAKE LINES ARE RUSTED AND IN DANGER OF FAILURE AT ANY TIME. ALL OF THE BRAKE LINES ON THE TRUCK ARE BARE METAL AND PRONE TO RUST. NEW BRAKE LINES ARE PAINTED TO PREVENT THIS FROM HAPPENING. HAD TO BUY COMPLETE BRAKE LINE KIT TO GET RIGHT FRONT LINE FOR REPLACEMENT BY DEALERSHIP FOR $452.85 . THEY RECOMMEND THAT I REPLACE ALL OF THE LINES. I CALLED CHEVROLET CUSTOMER SERVICE, COMPLAINT # 8-3176545196. I HAVE GOTTEN NO COOPERATION, THEY HAVE TOLD ME THERE IS NOTHING THAT THEY CAN DO. BECAUSE OF THIS POTENTIALLY CAUSING A CATASTROPHIC FATAL ACCIDENT DUE TO COMPLETE OR PARTIAL LOSS OF BRAKING POWER - IT GIVES NO WARNING UNTIL FAILURE OCCURS. I TOLD THEM THEY NEEDED TO PUT OUT AN ALERT TO OTHER DRIVERS AND THEY DECLINED STATING THAT THEY DID NOT HAVE ENOUGH COMPLAINTS. THIS TRUCK ONLY HAS 99546 MILES ON IT AND IN ALL OF MY YEARS WORKING WITH AUTOMOBILES I HAVE NEVER SEEN A BREAK LINE RUST THROUGH.

APPEARS GM'S FAULTY BLOWER MOTOR RESISTOR HAS CLAIMED MY 2ND TRUCK. FIRE STARTED WHILE PARKED IN PARKING LOT. FIRE OCCURS ON PASSENGER SIDE AROUND GLOVE BOX AND GROWS. THIS TRUCK GAVE NO INDICATION OF "MELTING WIRES" THERE WAS NO SMELL OR SMOKE WHEN PARKED. THIS PART OF A SPECIAL COVERAGE #10240

Fire

SUDDEN FAILURE OF BRAKES DURING LOW SPEED STOP, BRAKE LINE FAILED NEAR FRAME UNDERSIDE IN DRIVER SEAT AREA. WAS ABLE TO QUICKLY STOP VEHICLE WITH EMERGENCY BRAKE JUST SHORT OF GOING INTO HEAVY TRAFFIC. THIS TRUCK IS METICULOUSLY MAINTAINED INCLUDING UNDERSIDE WASHES, NO BODY RUST ANYWHERE AND WAS UNDERCOAT PROTECTED FROM NEW. SHOCKED A LEVEL OF RUST ON WHAT ARE APPARENTLY HIGH CARBON STEEL LINES, THESE SHOULD BE STAINLESS STEEL.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 2500 EQUIPPED WITH COOPER TIRES, DOT NUMBER: UTV6C8E4808, TIRE LINE: COOPER DISCOVERER ATR, TIRE SIZE: 265/75/R16. THE CONTACT STATED THAT WHILE DRIVING AT 63 MPH, THE CONTACT STATED THAT THERE WAS AN ABNORMAL VIBRATION FROM THE REAR OF THE VEHICLE. THE CONTACT STATED THAT THE TREAD SEPARATED FROM THE TIRE WHICH CAUSED DAMAGE TO THE BED OF THE VEHICLE. THE FAILURE OCCURRED ON THE REAR DRIVER SIDE TIRE. THE CONTACT STATED THAT THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE TIRE FAILURE MILEAGE WAS UNKNOWN. THE FAILURE MILEAGE ON THE VEHICLE WAS 114,900.

WHEN NORMAL STOPPING ABS ACTIVATES AND KEEPS ACTIVATING UNTIL PEDAL GOES TO FLOOR AND BRAKES DO NO FUNCTION, THERE ARE NO WARNING LITES AND NO INDICATION OF A PROBLEM.I WAS UNDER THE IMPRESSION THAT ANY ABS FAILURE WOULD REVERT SYSTEM TO REGULAR BRAKE SYSTEM. THIS IS VERY DANGEROUS.

BLOWER MOTOR FOR THE HVAC STARTED ALL BY ITS SELF AND RAN FULL BLAST. THE CONTROL PANEL HAD NO EFFECT ON THE SYSTEM . I COULD NOT CONTROL OR SHUT OFF THE BLOWER. EVEN WHEN THE TRUCK WAS PARKED, IN PARK AND SHUT DOWN AND THE KEYS REMOVED THE BLOWER CONTINUED TO RUN AT FULL BLAST. HAD TO DISCONNECT THE BATTERY. LATER AFTER HAVING TO DRIVE THE TRUCK TO WORK I FOLLOWED THE FUSE SCHEMATIC AND REMOVED THE GREEN I BELIEVE FUSE BREAKER FROM THE UNDER HOOD FUSE BOX. I HAVE LEFT THIS FUSE REMOVED SO THE BATTERY DOESN'T RUN DOWN.

I WAS DRIVING MY TRUCK ON 3/30/16 ANOTHER VEHICLE PULLED OUT IN FRONT OF ME. I SLAMMED ON MY BRAKES TO AVOID A WRECK. AT THE NEXT RED LIGHT I NOTICED MY BRAKES WERE SOFT. I PULLED OVER TO CHECK MY FLUID. IT WAS DOWN ABOUT AN INCH. I DECIDED TO TRY TO MAKE IT HOME. THEN A SERVICE BRAKE LIGHT CAME ON. I DID MAKE IT HOME. I CRAWLED UNDER THE TRUCK AND BRAKE FLUID WAS FROM THE FRONT TO THE BACK OF THE TRUCK. I NOTICED TWO COMPROMISED METAL BRAKE LINES ON THE DRIVER SIDE FRAME RAIL THAT WERE RUSTED THROUGH. I TOUCHED THE LINES AND THEY WERE FALLING APART AND FLAKING OFF METAL AT THE TOUCH. I CONTACTED CHEVROLET AND IT WAS TOWED TO THE DEALER. THEY QUOTED ME $1,100 TO REPAIR THE PROBLEM. MY TRUCK IS A 2006 I BOUGHT IT BRAND NEW IT HAS 59,500 MILES ON IT AND I PAID RIGHT AT $50,000 FOR MY TRUCK. IT IS UNACCEPTABLE FOR THIS TO HAPPEN IN LESS THAN 10 YEARS OF OWNERSHIP. THIS IS A HUGE SAFETY ISSUE SINCE CHEVROLET USED INFERIOR AND CHEAP PRODUCTS IN THEIR TRUCKS. THERE SHOULD BE A RECALL ON THIS. SOMEONE COULD HAVE BEEN SERIOUSLY INJURED OR KILLED THE OTHER DAY WHEN I WAS DRIVING. I REPLACED ALL OF THE ROTORS AND BRAKE PADS AND ONE CALIPER NOT 9 MONTHS AGO. I NEVER THOUGHT THAT MY METAL LINES WERE COMPROMISED UNTIL I HAD A FAILURE. I HAVE LOST ALOT OF FAITH IN GM DUE TO THIS ISSUE. I AM STILL WORKING WITH GM AND THE DEALER TO GET THE PROBLEM RESOLVED, BUT IT IS NOT LOOKING GOOD. I AM WONDERING HOW MANY OTHER VEHICLES ARE COMPROMISED. I WAS TALKING TO MY UNCLE THE OTHER DAY AND A GENTLEMAN OVERHEARD MY CONVERSATION. HE TOLD ME THAT HE HAD A 2003 2500 CHEVROLET THE BRAKES ALSO FAILED ON. HE WAS TOWING A TRAILER AND TOATLED HIS TRUCK. I AM COMPLETELY OUT OF WARRANTY AS OF NEXT MONTH. GM SAYS TO KEEP MY BILL FOR THE REPLACEMENT OF THE LINES THAT I MAY GET PAID BACK. I DONT THINK THAT IS LIKELY AT ALL. THIS SHOULD BE A RECALL BECAUSE SAFETY IS COMPROMISED.

BREAK LINES ARE COMPLETELY RUSTED AND I AM AFRAID THEY WILL GO OUT WITHOUT WARNING. TRUCK ONLY HAS 67,000 MILES ON IT.

AIR BAG WARNING LIGHT COMING ON, HAVE NEVER HAD AN ACCIDENT IN THIS TRUCK.

BRAKE LINE FAILURE DUE TO EXCESSIVE CORROSION AS THE LINES LAY ON THE FRAME. LUCKILY, THE BREAK WAS AT HOME AND I WAS ABLE TO GET IT INTO THE SHOP FOR REPAIR. LESS THAN A MONTH LATER, ANOTHER LINE BROKE AS I WAS PULLING INTO MY DRIVE.

LOST BRAKES WHILE DRIVING IN RESIDENTIAL NEIGHBORHOOD DUE TO RUSTED BRAKE LINE. HAD IT TOWED TO MY MECHANIC WHO DID AN INSPECTION AND SAID ALL THE BRAKE LINES WERE RUSTED AT THE BRACKETS HOLDING THE LINES. MY MECHANIC IS IN THE PROCESS OF REPLACING THE BRAKE LINES. I TALKED TO SEVERAL OTHER PEOPLE WITH THE SAME YEAR TRUCK AND BOTH HAD ALSO EXPERIENCED BRAKE LINE FAILURE FROM RUST. TRUCK HAS ONLY 20K MILES AND HAS ONLY BEEN IN THE SALT TWICE AS I HAD AN OLDER VEHICLE I USED WHEN IT SNOWED. GM NEEDS TO CORRECT THIS SAFETY DEFECT.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 2500. WHILE THE TODDLER WAS PLACED IN THE DRIVER SEAT OF THE VEHICLE, SHE TURNED THE KEY TO THE ACCESSORY POSITION. THE VEHICLE ROLLED DOWN THE HILL AND CRASHED INTO A TREE. THE AIR BAGS DID NOT DEPLOY. THE TODDLER DID NOT SUSTAIN ANY INJURIES. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR DIAGNOSED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 215,000.

Crash

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 2500. WHILE THE TODDLER WAS PLACED IN THE DRIVER SEAT OF THE VEHICLE, SHE TURNED THE KEY TO THE ACCESSORY POSITION. THE VEHICLE ROLLED DOWN THE HILL AND CRASHED INTO A TREE. THE AIR BAGS DID NOT DEPLOY. THE TODDLER DID NOT SUSTAIN ANY INJURIES. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR DIAGNOSED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 215,000.

Crash

ONE BRAKE LINE BURST FROM BEING RUSTED OUT AND THE REMAINING 4 FRONT BRAKE LINES ARE IN BAD SHAPE AND NEED TO BE REPLACED. THE BRAKE LINE BURST WHILE I WAS PULLING MY BOAT TRAILER AND I NARROWLY AVOIDED AN ACCIDENT. I WAS IN A RESIDENTIAL AREA AND WAS ONLY GOING ABOUT 15MPH.AND WAS ABLE TO APPLY THE EMERGENCY BRAKE TO STOP THE TRUCK.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE BACKING OUT OF THE GARAGE, THE VEHICLE LUNGED BACKWARDS WITHOUT WARNING. THE CONTACT CONTINUED TO DEPRESS THE BRAKE PEDAL AND THE VEHICLE EVENTUALLY RESPONDED. THE VEHICLE WAS DRIVEN TO THE DEALER, WHO DIAGNOSED THAT THE HYDRO BOOSTER FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 54,942.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 2500. WHILE PULLING INTO THE DRIVEWAY AT APPROXIMATELY 7 MPH, THE BRAKE PEDAL WAS DEPRESSED TO THE FLOOR BUT THE VEHICLE DID NOT STOP. THE VEHICLE CRASHED INTO THE CONTACT'S PORCH. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES REPORTED. THE CONTACT OBSERVED BRAKE FLUID UNDER THE FRONT OF THE VEHICLE AND THE BRAKE LINES WERE COMPLETELY RUSTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000. MA 09/03/15 UPDATED 11/03/2017*CN

Crash

HOLE CAME IN BREAK LINE DUE TO RUST. ALL MOST RAN THRU A BUSY INTERSECTION. ALSO HAD A BREAK LINE TO RUST INTO ON 4/10/15.

WE WERE GETTING READY FOR A LONG TRIP (MARYLAND TO FLORIDA). WE HITCHED OUR TRAILER TO OUR TRUCK AND WERE TESTING LIGHTS, BRAKES, ETC. AT THE CAMPGROUND BEFORE WE LEFT. AS WE TESTED THE BRAKES AT A LOW SPEED, WE REALIZED THE BRAKES DID NOT WORK AT ALL. WE PARKED IT RIGHT THERE ON THE ROAD IN THE CAMPGROUND AND CALLED A TOW TRUCK TO TAKE US TO OUR MECHANIC'S SHOP. WHEN HE LOOKED AT IT, HE FOUND HE HAD TO REPLACE ALL THE BRAKE TUBING BECAUSE THEY WERE ALL RUSTED OUT. HAD WE BEEN ON THE ROAD WITH OUR TRAILER, WE WOULD HAVE HAD A CRASH AND COULD HAVE BEEN KILLED OR SEVERELY HURT.

GM MAD A FAULTY BOLT DESIGN AND NO ONE IS HOLDING THEM ACCOUNTABLE. I HAVE 3 BROKEN MANIFOLD BOLTS AND THE DEALERSHIP WANTS $2100 TO REPAIR. THERE ARE THOUSANDS UPON THOUSANDS OF OTHERS JUST LIKE ME WHO ARE HELPLESS. WHY ARE YOU AND THE EPA DOING NOTHING? THE VEHICLE CAN'T PASS EMISSIONS LIKE THIS!

ENGINE IDLER PULLEY SEIZED CAUSING SERPENTINE BELT TO BREAK WHICH RESULTED IN LOSS OF POWER STEERING AND LOSS OF POWER BRAKES..2 LOCAL GM DEALER PARTS DEPARTMENT'S STATED THIS IS COMMON ON THE DURAMAX DIESEL ENGINE. *TR

I WAS POSITIONING MY CHEVY SILVERADO 2500 YEAR 2006 TO HOOK UP MY TRAVEL TRAILER RV. AS I WAS BACKING UP TO LINE UP THE HITCH TO THE RV BALL THE BRAKE PEDAL WENT TO THE FLOOR AND I LOST ALL BRAKING. I HAD TO PUT THE GEAR SHIFT IN PARK TO STOP THE SLIGHT ROLL. I LOOKED UNDER THE TRUCK AND THERE WAS BRAKE FLUID ALL OVER MY DRIVEWAY WHERE IT HAD COME OUT OF A CORRODED BRAKE LINE UNDER THE DRIVERS SEAT. THIS TRUCK ONLY HAS 97,797 MILE ON IT. I AM VERY FORTUNATE THAT THE CORRODED BRAKE LINE FAILED BEFORE I WAS ABLE TO HOOK UP THE RV AND START DRIVING, I COULD HAVE HAD A SERIOUS ACCIDENT THAT MIGHT HAVE KILLED SOMEONE. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 2500. THE CONTACT STATED THAT THERE WAS CORROSION ON THE FRAME OF THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 64,000.

WHILE I WAS DRIVING DOWN THE STREET MY BRAKES WHEN OUT. I WAS ABLE TO MAKE IT TO MY DRIVEWAY TO DISCOVER MY BRAKE LINE RUTSTED AND THERE WAS A 1 CM HOLE IN THE BRAKE LINE. *TR

TRANSMISSION SLIPPING, BANGING PERIODICALLY 1,2,3 GEAR AND DOWN SHIFT. TRANSMISSION GAUGE RED-LINED, NOW IS NOT PROPERLY SHOWING TEMP. OIL GAUGE IS MOVING 0 TO 80 ALL THE TIME. SOME LIGHTS HAVE BEEN GOING OUT ON PANEL AND STEERING WHEEL. CHECK ENGINE LIGHT ON AND OFF. TRANSMISSION COMPANY DIAGNOSED AS A POSSIBLE ELECTRICAL ISSUE AND CHEVY STATES THE TRANSMISSION BANG AND SLIP IS COMMON AND NO REPAIRS ARE NEEDED? HELP.

I HAD A BRAKE LINE BRAKE DRIVING MY BABY TO THE DOC, TOWED IF TO THE SHOP & FOUND OUT ALL THE BRAKE LINES & HARDWARE WERE RUSTED BEYOND REPAIR & EVERYTHING NEEDED REPLACED, WE FOUND THAT GM HAD USED BAD PRODUCTS ON THEIR CHEVY TRUCKS FROM 99-07 BUT ONLY RECALLED 99-03, APPARENTLY THERE'S NOT ENOUGH DEATHS IN MODEL YEARS 04-07 TO RECALL, WELL IF WE WERE GOING FASTER IT PROB WOULDN'T HAVE ENDED WELL FOR US, THE COST OF THE REPAIRS WERE AROUND $700. *TR

UNIROYAL LAREDO HD/H LT265/75 R15 HAD A TREAD SEPARATION THAT CAUSED CONSIDERABLE SHEET METAL DAMAGE WITHIN AND BEHIND THE RIGHT REAR WHEEL WELL OF MY CHEVY SILVERADO 2500 HD PICKUP. THE INCIDENT OCCURRED AT 60 MPH WHILE I WAS TOWING A TRAVEL TRAILER. I NEVER LOST CONTROL OF THE VEHICLE AND WAS ABLE TO BRING IT SAFELY TO A CONTROLLED STOP. THE TIRE WAS ONE OF FOUR INSTALLED NEW BY THE AUTO DEALER IN EARLY 2012 WHEN I PURCHASED THE TRUCK USED. THE TIRE HAD APPROXIMATELY 17,000 MILES OF USE WHEN THE SEPARATION OCCURRED. I ALWAYS KEPT THE TIRE INFLATED TO THE TRUCK AND TIRE MANUFACTURERS' RECOMMENDED 80 PSI AND HAD JUST INFLATED THE TIRE TO THAT PRESSURE (IT WAS AT 74 PSI BEFORE I TOPPED IT OFF) THREE DAYS EARLIER, BEFORE STARTING MY TRIP. I NOTICED A RECALL OF TIRES OF SIMILAR VINTAGE IN THE UNIROYAL LAREDO HD/H LT 245/75 R16 SERIES, AND I AM CURIOUS IF MANY TREAD SEPARATIONS HAVE ALSO BEEN REPORTED FOR THE 265/75 R16 SERIES OR IF THIS IS A ONE OFF INCIDENT. *TR

DURING A NORMAL STOP AT A LIGHT, JUST AS THE VEHICLE WAS GETTING CLOSE TO A COMPLETE STOP THERE WAS A NOTICEABLE BUMP FELT IN THE BRAKE PEDAL AND RELEASE OF BRAKE APPLICATION ON ITS OWN WHILE STILL PUSHING ON THE BRAKE PEDAL. THIS OCCURRED AS VEHICLE WAS SLOWING, JUST BEFORE A COMPLETE STOP WAS ACHIEVED . AFTER RESEARCHING THE PROBLEM WHICH SEEMS TO BE WELL KNOWN IN AUTOMOTIVE FORUMS AND BY GM. I REMOVED THE FRONT WHEEL SPEED SENSORS, CLEANED THE CORROSION FROM THE MOUNTING PADS AND REASSEMBLED. BEFORE CLEANING THE SENSOR MOUNTING THE PROBLEM WOULD OCCUR 80-90% OF THE TIME BRAKES WERE APPLIED. AFTER CLEANING IT HAS NOT HAPPENED AGAIN. THERE IS A RECALL ON THIS VERY ISSUE ON EARLIER YEAR MODELS, CLEARLY THIS NEEDS TO BE EXPANDED TO MORE MODEL YEARS. IF SOMEONE HAD BEEN IN FRONT OF ME WHEN THIS OCCURRED THERE IS A VERY GOOD POSSIBILITY I WOULD HAVE HIT THE BACK OF THEIR VEHICLE. *TR

DRIVING ON HIGHWAY AT 60MPH TRAFFIC SLOWED SUDDENLY WHILE PRESSING DOWN ON BRAKES WHEN TO FLOOR I SWERVED TO AVOID SLOWING TRAFFIC AND RAN OFF SHOULDER IN TO GRASS AND SMALL TREES TO COME TO A STOP HAD TRUCK TOWED TO MY HOUSE FOUND LINE OVER GAS TANK SPLIT OPEN THEIR WAS NO PEDAL AT ALL AND NO WARNING LIGHT FOR BRAKES UNTIL ALL THE FLUID DRIPPED OUT IN TO MY DRIVEWAY. *TR

Crash

BRAKE LINES HAVE RUSTED OUT. ABS WARNING LIGHT CAME ON, THEN SOON AFTER ABS SERVICE LIGHT CAME ON. HAD TO REPLACE ALL OF THE LINES AND 3 CALIPERS WHERE LINES HAD RUSTED TO THE CALIPER. VEHICLE ONLY HAS 41200 MILES ON IT. COST ME $861 TO HAVE THEM REPLACED. SERVICE TECHNICIAN SAID HE HAD NEVER SEEN LINES THAT WERE THAT BAD FOR A VEHICLE WITH SUCH LOW MILEAGE. ONE OF THE LINES CRUMBLED AT THE TOUCH WHEN IT WAS REMOVED. *TR

BRAKE LINES BLEW FRONT AND REAR WHEN A MOTORCYCLE IN FRONT OF ME SLAMMED HIS BRAKES IN AN EMERGENCY STOP. LUCKILY HE WAS TOWARDS THE SIDE OF THE ROAD, I SLAMMED MY BRAKES AND MY PEDAL WENT TO THE FLOOR, I QUICKLY SWERVED AND DOWNSHIFTED AND EBRAKED AND MIRACULOUSLY WAS ABLE TO COME TO A SWERVING STOP AVOIDING COLLISION BUT IT COULD HAVE BEEN MUCH WORSE IF I HADN'T BEEN ABLE TO REACT SO QUICKLY. MY TRUCK IS VERY LOW MILEAGE AND METICULOUSLY MAINTAINED, I HAVE OWNED IT SINCE 2009. THERE AREN'T ANY OTHER CARS OUT THERE THAT WOULD HAVE A BRAKE LINE FAILURE WITHIN 8 YEARS AND ONLY 64K MILES, I'M VERY UPSET OVER WHAT HAPPENED. *TR

BRAKES LINES RUSTY PRESSED BRAKE PEDAL BRAKES FAILED. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 2500 THAT WAS EQUIPPED WITH BF GOODRICH COMMERCIAL T/A TIRES, SIZE LT265/75R16. THE CONTACT STATED THAT THREE OF THE FOUR TIRES EXPERIENCED TREAD SEPARATION WITHIN THE PAST SIX MONTHS. EACH TIRE NEEDED TO BE REPLACED, EXCEPT FOR THE FRONT PASSENGER SIDE TIRE. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNKNOWN. THE TIRE FAILURE MILEAGE WAS APPROXIMATELY 20,000. THE VEHICLE FAILURE MILEAGE WAS 180,000.

BRAKE LINES FAILED, CAUSING ME TO RUN OFF THE ROAD WHEN TRYING TO AVOID HITTING A DEER. HAD TO REPLACE ALL THE LINES DUE TO CORROSION ON MANY OF THEM. *TR

Crash

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 2500. THE VEHICLE IS EQUIPPED WITH FEDERAL COURAGIA A/T TIRES, SIZE 33512.50R/20LT (NA). THE CONTACT STATED THAT THE SIDEWALLS OF THE TIRES CONTAINED BUBBLES. THE TIRES WERE NOT REPLACED AND THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNAVAILABLE. THE TIRE FAILURE MILEAGE WAS 103,000 AND THE VEHICLE FAILURE MILEAGE WAS APPROXIMATELY 100,000.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 2500. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, THE PIVOT ARM FAILED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 63,000. UPDATED 8/28/14*CN

7-12-14, 11:15 MTN TIME MY WIFE AND I WERE DRIVING WESTBOUND ON I-76, IN A 2006 CHEVY SILVERADO, 2500 HD DURAMAX DIESEL TOWING A 24" CATALINA 5TH WHEEL, APPROXIMATELY 6,500 LBS, IN THE RIGHT HAND LANE, AT APPROXIMATELY 50 MPH IN COMMERCE CITY, CO APPROACHING 104TH AVE. AT THE 104TH AVE OVERPASS A DRUNK DRIVER PULLED OUT FROM BEHIND THE OVERPASS SUPPORT COLUMN IN THE CENTER MEDIUM AREA OF THE DIVIDED HIGHWAY APPROXIMATELY 1-2 CAR LENGTHS IN FRONT OF US. WE IMMEDIATELY HIT HIS VEHICLE IN THE RIGHT REAR. AT THE TIME HE WAS MOVING FORWARD 2-5 MPH. THE COLLISION WAS CATASTROPHIC WITH VERY SIGNIFICANT DAMAGE TO ALL VEHICLES. THE FRONT AIRBAGS OF THE 2006 CHEVY SILVERADO DID NOT DEPLOY. THIS VEHICLE IS A ONE OWNER VEHICLE. IN 2007 IT WAS INVOLVED IN A FRONTAL ACCIDENT IN WHICH A DRIVER TURNED IN FRONT OF THE DRIVER AT AN INTERSECTION RESULTING IN A FRONTAL COLLISION AT 35 MPH AND THE FRONTAL AIRBAGS DID NOT DEPLOY. CHEVY DID THE REPAIR AND CERTIFIED THE REPAIR OF THE VEHICLE. *TR

Crash