2012 JEEP GRAND CHEROKEE

11 recalls, 2,329 complaints - 363 TSBs - 4/5 safety rating

ELECTRICAL SYSTEM

Defect Description

Chrysler (FCA US LLC) is recalling certain 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles equipped with a 3.6, 5.7, or 6.4 liter engine and previously recalled under NHTSA Recall 14V530 or 15V115. The fuel pump relay inside the Totally Integrated Power Module (TIPM-7) may fail, causing th... Read more

Consequence

A vehicle stall increases the risk of a crash.

Remedy

Chrysler (FCA US LLC) will replace the affected fuel pump relay and related wire harness. Interim notices informing owners of the safety risk were mailed beginning December 19, 2019. Vehicles that experience a fuel pump failure will receive an interim repair. Owners will receive a second notice w... Read more

528,594 vehicles affected

Manufacturer: Chrysler (FCA US LLC)

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER

Defect Description

Accessible Technologies, Inc. (ATI) is recalling certain ProCharger Superchargers, model numbers AB037A-100, AB037A-100P, and A037A-100B, sold for installation on 2012-2017 Jeep Grand Cherokee SRT8 and SRT vehicles. The supercharger mounting bracket may contact and damage the ABS line, possibly res... Read more

Consequence

A brake fluid leak may lengthen the distance needed to stop the vehicle, increasing the risk of a crash.

Remedy

ATI will notify owners and will replace the supercharger brackets, free of charge. The recall began on December 12, 2017. Owners may contact ATI customer service at 1-913-338-2886.

99 vehicles affected

Manufacturer: Accessible Technologies, Inc.

SERVICE BRAKES, HYDRAULIC:POWER ASSIST

Defect Description

Chrysler (FCA US LLC) is recalling certain 2011-2014 Dodge Durango and Jeep Grand Cherokee vehicles. The affected vehicles had brake booster shields installed under a previous campaign to prevent water from entering the brake booster and limiting braking ability. This recall is to verify that the ... Read more

Consequence

If the brake booster shield was not installed properly, the vehicle's braking ability may be reduced, increasing the risk of a crash.

Remedy

Chrysler will notify owners, and dealers will inspect the brake booster shield, correcting the installation as necessary, free of charge. The recall began November10, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T59.

646,394 vehicles affected

Manufacturer: Chrysler (FCA US LLC)

ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR

Defect Description

Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Challenger, Dodge Charger, Chrysler 300, Dodge Durango, and 2012-2014 Jeep Grand Cherokee vehicles. The affected vehicles have electro-hydraulic power steering (EHPS) and are equipped with a 5.7L or a 3.6L engine and a 160, 180 o... Read more

Consequence

If the alternator fails, the vehicle may stall without warning, increasing the risk of a crash. There is also the possibility that the alternator may short circuit, increasing the risk of a fire.

Remedy

Chrysler will notify owners, and dealers will inspect the alternator and depending on the part number, will replace the alternator, if necessary, free of charge. The recall began February 12, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall i... Read more

442,214 vehicles affected

Manufacturer: Chrysler (FCA US LLC)

ELECTRICAL SYSTEM:WIRING

Defect Description

Chrysler (FCA US LLC) is recalling certain model year 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured December 3, 2009, to September 1, 2012. In the affected vehicles, the wiring for the vanity lamp in the sun visor may short circuit, after having been remedied for a prior rec... Read more

Consequence

The vanity lamp wiring may short, increasing the risk of a vehicle fire.

Remedy

Chrysler will notify owners, and dealer will install clearance for sun visor wiring, protection from sharp edges, and replace the sun visor, free of charge. The recall began on July 28, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R71.

389,252 vehicles affected

Manufacturer: Chrysler (FCA US LLC)

ELECTRICAL SYSTEM

Defect Description

Chrysler (FCA US LLC) is recalling certain model year 2012-2013 Jeep Grand Cherokee vehicles manufactured September 17, 2010, to August 19, 2013, and equipped with a 3.6, 5.7 or 6.4 liter engine, and 2012-2013 Dodge Durango vehicles manufactured January 18, 2011, to August 19, 2013, and equipped wit... Read more

Consequence

A vehicle stall increases the risk of a crash.

Remedy

Chrysler will notify owners, and dealers will replace the fuel pump relay with one external to the TIPM. The recall began on August 7, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R09. Note: This recall is an expansion of recall 14V-5... Read more

339,525 vehicles affected

Manufacturer: Chrysler (FCA US LLC)

ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR

Defect Description

Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Chrysler 300, Dodge Charger, Challenger, and Durango; and 2012-2014 Jeep Grand Cherokee vehicles manufactured April 22, 2010, to January 2, 2014, and equipped with a 3.6L engine and a 160 amp alternator. In the affected vehicle... Read more

Consequence

If the alternator fails, the vehicle may stall without warning, increasing the risk of a crash.

Remedy

Chrysler has notified owners, and dealers will replace the alternator, free of charge. The recall began on February 27, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P60.

435,081 vehicles affected

Manufacturer: Chrysler Group LLC

ELECTRICAL SYSTEM:WIRING

Defect Description

Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Dodge Durango and Jeep Grand Cherokee vehicles manufactured January 5, 2010, through December 11, 2013. In the affected vehicles, the wiring for the vanity lamp in the sun visor may short circuit, after a service repair is perf... Read more

Consequence

If the vanity lamp wiring shorts, there is an increased risk of fire.

Remedy

Chrysler will notify owners, and dealers will inspect and repair any damaged wiring, and install a new sun visor that properly routes the wire, free of charge. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P36.

653,562 vehicles affected

Manufacturer: Chrysler Group LLC

SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM

Defect Description

Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured from January 5, 2010, through September 8, 2013. The subject vehicles have a brake booster with a center shell that may corrode and allow water to get inside.

Consequence

The water inside could freeze and limit the braking ability of the vehicle, increasing the risk of a crash.

Remedy

Chrysler will notify owners, and dealers will add a water diverter shield to the booster after the booster has been tested to confirm it can hold an acceptable amount of vacuum pressure. If the booster inspection confirms an unacceptable loss of vacuum pressure, the booster will be replaced. Repai... Read more

646,498 vehicles affected

Manufacturer: Chrysler Group LLC

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

Defect Description

Chrysler Group LLC (Chrysler) is recalling certain model year 2012-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured October 11, 2011, through October 1, 2012. Under certain braking events, the Ready Alert Braking System (RAB) may result in the driver experiencing a hard brake pedal ... Read more

Consequence

If the driver experiences a hard brake pedal, the driver may not push the pedal as intended, lengthening the distance needed to stop the vehicle and increasing the risk of a crash.

Remedy

Chrysler will notify owners, and dealers will update the ABS module software, free of charge. The recall began on April 3, 2014. Owners may contact Chrysler at 1-800-853-1403. Chrysler's number associated with this recall is P05.

18,780 vehicles affected

Manufacturer: Chrysler Group LLC

ENGINE AND ENGINE COOLING

Defect Description

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 CHRYSLER VEHICLES, INCLUDING 200 AND TOWN AND COUNTRY MODELS, DODGE VEHICLES, INCLUDING CHARGER, DURANGO, GRAND CARAVAN AND JOURNEY MODELS AND JEEP GRAND CHEROKEE VEHICLES MANUFACTURED FROM AUGUST 31, 2011, THROUGH SEPTEMBER 13, 2011, THAT ARE EQUIPPED W... Read more

Consequence

CONNECTING ROD FAILURE MAY LEAD TO ENGINE SEIZURE WHICH MAY INCREASE THE RISK OF A CRASH.

Remedy

CHRYSLER WILL NOTIFY OWNERS AND REPLACE THE ENGINE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT NOVEMBER 18, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

667 vehicles affected

Manufacturer: CHRYSLER GROUP LLC

Complaint Statistics

2,329 total complaints 68 crashes 145 fires 45 injuries

Top Reported Components

Component	Complaints
ELECTRICAL SYSTEM	791
SERVICE BRAKES	275
ENGINE	274
FUEL/PROPULSION SYSTEM	200
UNKNOWN OR OTHER	120
POWER TRAIN	105
STEERING	102
SUSPENSION	39
AIR BAGS	38
VEHICLE SPEED CONTROL	35

Incident date: Nov 15, 2025

Alternator smoking. it is available for inspection. Filled interior of vehicle with smoke the engine stopped running while driving. Took to dealership for a 2nd sun visor recall and had them diagnose the smoking alternator. The voltage light came on just before the alternator started smoking

Incident date: Aug 28, 2026

My 2012 Jeep Grand Cherokee suddenly was stalling, and would not re-start, especially when turning the steering. AAA Tech diagnosed as High Diode Ripple Voltage in the Alternator, damaging the Battery. Needed to Replace both Alternator and Battery at a cost of $1068. Car was recalled under T36, an... Read more

Incident date: Aug 28, 2026

Incident date: Jul 24, 2026

On 7/16/26, while driving, I heard loud clicking noises when turning and sometimes while driving straight. I took the vehicle to Coggin Deland Honda for inspection and they determined that both driveshafts are broken and need replacement. The service advisor shared that this is an ongoing problem wi... Read more

Incident date: Jul 24, 2026

Following the previous steering recall we noticed that the steering wheel had started to stick when turning. We brought it in for maintenance and to have them look at the steering. It has been identified as an internal failure of the steering rack.

Incident date: Jun 20, 2026

While flat towing my pickup truck behind my motorhome, on interstate 94 eastbound, in Minnesota I noticed smoke on my screen in the motorhome back facing camera. I safety pulled over to a truck rest area in Avon Minnesota. I went to investigate and realized that the pickup truck had flames coming fr... Read more

Fire

Incident date: Mar 26, 2026

The driver attention warning feature is defective and often requires you to take your eyes off the road and stare at the DAW sensor in order to eliminate the car's constant "attention" warnings. Even while looking straight ahead while driving, the DAW is often erroneous and will disengage safety fe... Read more

Incident date: Mar 26, 2026

MY CHECK ENGINE LIGHT IS ON ALONG WITH OTHER LIGHT. I AM GETTING THE VEHICLE STABILITY ASSIST SYSTEM PROBLEM, REDUCED TRACTION AND HANDLING. HILL START ASSIST PROBLEM VEHICLE MAY ROLL UPON BRAKE RELEASE, COLLISION MITIGATION BRAKING SYSTEM PROBLEM, ELECTRIC POWER STEERING SYSTEM PROBLEM. STEERING AS... Read more

Incident date: Jan 14, 2026

The contact owns a 2024 Honda Prologue. The contact stated while driving at 45 MPH with her wife in the vehicle, the vehicle instrument panel blacked out and displayed blank screen independently than minute and three seconds with instrument panel began to reset it self. A dealer was contacted. The v... Read more

Incident date: May 24, 2026

At times, the steering wheel becomes hard to turn exactly like changing lanes when the lane assist is on. This occurs when lane assist is off!

Incident date: May 1, 2026

The vehicle is a 2012 Jeep Grand Cherokee with open safety recalls T59 and V62. The brake warning light is currently illuminated, and based on the symptoms I believe the brake booster may be failing. The braking system is available for inspection upon request. The safety concern is that the vehicle ... Read more

Incident date: May 1, 2026

Incident date: Apr 22, 2026

The contact owns a 2013 Kia Soul. The contact stated that the vehicle spontaneously caught fire while parked unattended at 3 am. All the warning lights were illuminated prior to the failure, and the vehicle was undrivable. The contact had received the recall notification letter for NHTSA Campaign Nu... Read more

Fire

Incident date: Apr 22, 2026

The contact owns a 2021 Nissan Leaf. The contact received notification of NHTSA Campaign Number: 25V655000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. Th... Read more

Incident date: Apr 14, 2026

The check engine light came on at 101000 miles. I took it to the shop and the mechanic said there was no oil on the dipstick and he put in oil and said we need a new engine because it is knocking. We have noticed the vehicle has a rough idle now.

Incident date: Feb 6, 2018

The vehicle (2020 GLS 450) suffers from terminal infrastructure "Electronic Rot," resulting in a consistent Breach of FMVSS 111 (Rearview Visibility) and dangerous Automatic Emergency Braking hallucinations. On 03/08/2026, a routine car wash triggered multiple system failures, including "Camera View... Read more

Incident date: Feb 14, 2026

My wife and child drove the car to the grocery store and parked the car l. When she returned to leave , the car would not start and flashed a warning with key fob not detected and some kind of security light warning. The instrument cluster told her to place the key in left console cup holder to cran... Read more

Incident date: Feb 14, 2026

See attached document for complaint.

Incident date: Dec 4, 2025

While traveling on I-26 east near North Carolina MM 51 in the left lane, the vehicle suddenly pulled uncontrollably to the left resulting in a sideswipe of the guardrail. The vehicle then swerved to the right stopping near the center of the interstate. My wife was able to move the vehicle to the rig... Read more

Crash

Incident date: Jan 17, 2026

My vehicle experienced a catastrophic engine failure requiring full engine replacement after a recall remedy (oil change with thicker oil) was performed and the vehicle passed the pico test. Engine symptoms became more pronounced after the oil change. In addition, the vehicle has experienced repeate... Read more

Incident date: Jan 17, 2026

I used my automatic start to warm up my vehicle (it was on for about 5 minutes). When I went to open up by rear door (using my remote button), the back window completely shattered. I was walking up to my car when I heard the crackling of the glass. There was no warning about it. I will be callin... Read more

Incident date: Jan 17, 2026

Incident date: Nov 13, 2025

I was driving on the highway and I heard a loud bang , with grinding and a jerk i assumed the rear axel or differential something in the rear area along with smoke and I was able to swerve to the side of the highway along the grass and jump out with my kids multiple cars where behind me but I turned... Read more

Incident date: Nov 13, 2025

My car was inspected two times at the dealership for the door welds possibly cracking. The second time (a year ago) they said that I would need the entire door replaced. When I’m entering and exiting the vehicle the door shuts on me. I also live in a high wind area. The window will not go up or... Read more

Incident date: Nov 13, 2025

Driving at highway speed engine lost most power (limp mode), was able to get to an exit at low speed with flashers on but was creating a hazard on busy interstate. Dealer diagnosed truck needs new 3.0 liter duramax engine per GM TSB 25-NA-307, bad thrust bearing.

Incident date: Dec 18, 2025

After a complete stop vehicle acceleration lags when pressing accelerator.

Incident date: Nov 13, 2025

Incident date: Dec 18, 2025

Cvt transmission fails for no reason on a new car could be very dangerous for us and other on the road i think toyota should be responsible and resolve this issue

Incident date: Dec 15, 2025

Vehicle started to surge while driving (both small acceleration forward and large deceleration) without any change in brake or accelerator position. Eventually a "Propulsion Power Reduced" message was presented on the console followed immediately by no forward propulsion (accelerator completely unre... Read more

Incident date: Dec 15, 2025

Vehicle: 2018 Honda Accord Sport 1.5T, VIN [XXX] , 108,584 m, registered Indiana. Vehicle suffered from well-known 1.5L turbo oil dilution defect (TSB 19-091) since 5/24/21, 35k m, towed Honda dealership check engine light on, loss acceleration. Dealership diagnosed misfires cylinders 2 &3 caused... Read more

Incident date: Dec 13, 2025

I was driving to work in the morning and started to accelerate to the speed limit of 45, and at about 35mph my truck completely shut off. I tried to push the start button while coasting with no avail. I pulled to the shoulder and tried to start it and it would slowly crank similar to a dead battery.... Read more

Incident date: Dec 13, 2025

My vehicle is subject to NHTSA Safety Recall 14S06 related to loss of electric power steering assist. The Power Steering Control Module was reprogrammed in 2014, and Ford now considers the recall closed based on that reprogramming. In 2025, the vehicle again experienced loss of electric power steer... Read more

Incident date: Dec 13, 2025

Vehicle: 2023 Tesla Model X Component: Power-operated doors / door latching (auto-close / “cinch” close) Incident type: Finger pinch injury during powered door closing Summary of incident: While using my 2023 Tesla Model X, a powered door closing sequence resulted in a finger pinch injury. The ... Read more

Incident date: Nov 25, 2025

Transmission shudders and slipping gears at only 100k miles.

Incident date: Oct 29, 2025

Ever since the last recall got resolved the car has failed to go into the gear it’s set to. Such as it fails to go in park when you shift it into park. This is a serious issue as I have now almost rear ended cars in parking lots a few times because of this issue.

Incident date: Oct 29, 2025

Tesla remotely disabled Supercharging access on my vehicle without any warning, safety errors, or mechanical problems. The vehicle charged normally for months, including recent Supercharging sessions, and still operates safely. Tesla stated Supercharging was disabled due to a “salvage” title and... Read more

Incident date: Oct 29, 2025

Hybrid 2024 Toyota, was accelerating on freeway on ramp when I received a notification of hybrid system malfunction and engine shutdown notice, "pullover". I was not able to use either system as there was no charge on the hybrid system and the hybrid system was not functioning due to the error, and ... Read more

Incident date: Oct 28, 2025

The ABS module has gone out in the truck. Ram has no replacements available for the part. The part number is 68295368AC

Incident date: Oct 28, 2025

The contact owns a 2016 Land Rover Range Rover Sport. The contact received notification of NHTSA Campaign Number: 25V514000 (STEERING). However, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable ... Read more

Incident date: Oct 28, 2025

The contact owns a 2015 Ford Explorer. The contact received notification in March 2024 of NHTSA Campaign Number: 24V031000 (Structure). The contact stated that the trim on the passenger’s side A Pillar and the driver's side were loose, and both trims were cracking from the top and the bottom. The ... Read more

Incident date: Oct 18, 2025

The front upper control arms on my 2018 Tesla Model 3 have failed multiple times, producing loud clunking, popping, and binding noises during steering. The issue has worsened and poses a serious risk of loss of control while driving. Tesla replaced these parts under goodwill in the past, but the fai... Read more

Incident date: Oct 18, 2025

On Sunday, September 14, 2025, while driving northbound on the Palisades Parkway at approximately 11:30 PM, the vehicle suddenly lost all propulsion without any prior warning. I was traveling around 45– 50 mph when the dashboard lights began flashing, and the vehicle shut down completely in activ... Read more

Incident date: Jul 31, 2025

I picked up my son from school and got home at about 3:30 PM on Sunday 9/21/2025. My son got out of the car and I heard a “clicking” sound when turning my steering wheel to the left to prepare for backing into my garage. There were no warning lights or messages for this issue. I did get out of m... Read more

Incident date: Jul 31, 2025

Incident date: Sep 10, 2025

Unintended acceleration. On August 8, 2025, Honda C-RV Hybrid 2025 (sport touring) accelerated into a wall without the driver touching the gas pedal. The vehicle is deemed a constructive total loss by the insurance carrier. Since it can’t be driven, we are unable to reproduce the problem. A case i... Read more

Crash 1 injured

Showing 50 of 2,329 complaints.

NHTSA Safety Ratings, 2012 JEEP GRAND CHEROKEE

2012 Jeep Grand Cherokee SUV 4WD

Category	Rating
Overall Rating	4 / 5 ★★★★☆
Frontal Crash	4 / 5 ★★★★☆
Frontal Crash, Driver	5 / 5 ★★★★★
Frontal Crash, Passenger	4 / 5 ★★★★☆
Side Crash	5 / 5 ★★★★★
Side Crash, Driver	5 / 5 ★★★★★
Side Crash, Passenger	5 / 5 ★★★★★
Rollover	4 / 5 ★★★★☆
Rollover Risk	16.8%

Safety Technology

Feature	Status
Electronic Stability Control	Standard
Forward Collision Warning	Optional
Lane Departure Warning	No

Source: NHTSA 5-Star Safety Ratings Program. Ratings are based on crash tests conducted by the National Highway Traffic Safety Administration.

Technical Service Bulletins, 2012 JEEP GRAND CHEROKEE

363 manufacturer communications from 156 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
350000 EQUIPMENT	36
110000 ELECTRICAL SYSTEM	31
118000 ELECTRICAL SYSTEM:SOFTWARE	26
060000 ENGINE AND ENGINE COOLING	24
020000 SUSPENSION	16
100000 POWER TRAIN	16
160000 STRUCTURE	14
060000 ENGINE (PWS)	13

350000 EQUIPMENT

LIFTER, Hydraulic Roller Deactivating Please do not replace MDS lifters because the disconnecting pin is not lined up, this is normal and not a defect.

020000 SUSPENSION

LIFTER, Hydraulic Roller Deactivating Please do not replace MDS lifters because the disconnecting pin is not lined up, this is normal and not a defect.

110000 ELECTRICAL SYSTEM

Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. There is an error with the wiring diagrams in Service Library that is causing

114000 ELECTRICAL SYSTEM:WIRING

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Lubrication and Maintenance Fluids If MOPAR fluids and chemicals are not readily available, please review Service Library for specifications so a suitable alternative can be used

350000 EQUIPMENT

HEADLAMP WITHOUT BALLAST,IF BALLAST NEEDED ORDER PART NUMBER : 68086783A$

121000 EXTERIOR LIGHTING:HEADLIGHTS

HEADLAMP WITHOUT BALLAST,IF BALLAST NEEDED ORDER PART NUMBER : 68086783A$

350000 EQUIPMENT

wiTECH Small Leak Verification Test (SLVT) - P0456-EVAP SYSTEM SMALL LEAK

060000 ENGINE AND ENGINE COOLING

wiTECH Small Leak Verification Test (SLVT) - P0456-EVAP SYSTEM SMALL LEAK

060000 ENGINE AND ENGINE COOLING

ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY review and follow instructions from the latest STAR Online S1809000007 available on Dealer Connect. Also, consider the followin

060000 ENGINE AND ENGINE COOLING

280000 BACK OVER PREVENTION

ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY (with mileage above 30,000) review and follow instructions from STAR Online S1809000007 REV. C available on Dealer Connect. Als

060000 ENGINE AND ENGINE COOLING

160000 STRUCTURE

Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when welding

160000 STRUCTURE

163200 STRUCTURE:INTERIOR PANELS:DOOR

980000 UNKNOWN OR OTHER

160000 STRUCTURE

980000 UNKNOWN OR OTHER

Customer Satisfaction Notification V51 Reprogram Powertrain Control Module

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

Customer Satisfaction Notification V51 Reprogram Powertrain Control Module

350000 EQUIPMENT

If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils.

060000 ENGINE AND ENGINE COOLING

If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils.

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire. Upon investigation, it may be found that there is excessive camshaft lobe wear/lifter wear (roller failure) on one or more cam lobes and that camshaf

061700 ENGINE AND ENGINE COOLING:ENGINE:CRANK/CAMSHAFT POSITION SENSOR

980000 UNKNOWN OR OTHER

060000 ENGINE (PWS)

060000 ENGINE AND ENGINE COOLING

980000 UNKNOWN OR OTHER

Water Leak From Overhead Console, A Pillar And Or Headliner. Sunroof Drain Tube Inspection.

162900 STRUCTURE:BODY:ROOF AND PILLARS

Water Leak From Overhead Console, A Pillar And Or Headliner. Sunroof Drain Tube Inspection.

060000 ENGINE AND ENGINE COOLING

Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement engine has been installed in the vehicle.

060000 ENGINE AND ENGINE COOLING

Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement engine has been installed in the vehicle.

251000 ELECTRONIC STABILITY CONTROL:AUTOMATIC (ASC)

Air Suspension System Diagnosis

020000 SUSPENSION

Air Suspension System Diagnosis

110000 ELECTRICAL SYSTEM

No Start Intermittently, Vehicle Requires Multiple Keyless Push To Start Attempts To Start Vehicle, Intermittent Key Not Detected Message

100000 POWER TRAIN

No Start Intermittently, Vehicle Requires Multiple Keyless Push To Start Attempts To Start Vehicle, Intermittent Key Not Detected Message

100000 POWER TRAIN

Gear Ratio DTC?s, Transmission Shift Concerns, Does Not Shift At Times, Shudders

100000 POWER TRAIN

Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles. If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) are one-time usag

251000 ELECTRONIC STABILITY CONTROL:AUTOMATIC (ASC)

Air Suspension Inoperative And Or Compressor Freeze Up Or Sticking In Cold Weather.

020000 SUSPENSION

Air Suspension Inoperative And Or Compressor Freeze Up Or Sticking In Cold Weather.

020000 SUSPENSION

Air Suspension Inoperative And Or Compressor Freeze Up Or Sticking In Cold Weather.

060000 ENGINE AND ENGINE COOLING

ADAPTER, Engine Oil Filter (Pentastar V6) All vehicles equipped with a 3.2L or 3.6L except for model year 2014 vehicles with leak concern: 1) Ensure the Oil Filter Adapter (OFA) Cap O-ring is seated in the proper groove in the cap and not

061700 ENGINE AND ENGINE COOLING:ENGINE:CRANK/CAMSHAFT POSITION SENSOR

060000 ENGINE AND ENGINE COOLING

222300 SEATS:MID/REAR ASSEMBLY:HEAD RESTRAINT

Warranty Bulletin D-20-10 (X88) Active Head Restraint - Select 2012-2018 Dodge Durango (WD) and Select 2012-2018 Jeep Grand Cherokee (WK) (Rev. D)

221300 SEATS:FRONT ASSEMBLY:HEAD RESTRAINT

Warranty Bulletin D-20-10 (X88) Active Head Restraint - Select 2012-2018 Dodge Durango (WD) and Select 2012-2018 Jeep Grand Cherokee (WK) (Rev. D)

356000 EQUIPMENT ADAPTIVE/MOBILITY

Active Head Restraint (AHR) Inadvertent Deployment - X88 Warranty Extension This bulletin involves inspecting the sled bracket striker pin and possibly replacinga front seat AHR that has inadvertently deployed. Customers may comment on th

350000 EQUIPMENT

220000 SEATS

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Warranty Bulletin D-20-10 (X88) Active Head Restraint - Select 2012-2018 Dodge Durango (WD) and Select 2012-2018 Jeep Grand Cherokee (WK) (Rev. C)

220000 SEATS

Warranty Bulletin D-20-10 (X88) Active Head Restraint - Select 2012-2018 Dodge Durango (WD) and Select 2012-2018 Jeep Grand Cherokee (WK) (Rev. C)

222300 SEATS:MID/REAR ASSEMBLY:HEAD RESTRAINT

Warranty Bulletin D-20-10 (X88) Active Head Restraint - Select 2012-2018 Dodge Durango (WD) and Select 2012-2018 Jeep Grand Cherokee (WK) (Rev. C)

222300 SEATS:MID/REAR ASSEMBLY:HEAD RESTRAINT

Warranty Bulletin D-20-10 (X88) Active Head Restraint - Select 2012-2018 Dodge Durango (WD) and Select 2012-2018 Jeep Grand Cherokee (WK) (Rev. C)

221300 SEATS:FRONT ASSEMBLY:HEAD RESTRAINT

Warranty Bulletin D-20-10 (X88) Active Head Restraint - Select 2012-2018 Dodge Durango (WD) and Select 2012-2018 Jeep Grand Cherokee (WK) (Rev. C)

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Warranty Bulletin D-20-10 (X88) Active Head Restraint - Select 2011-2018 Dodge Durango (WD and Select 2011-2018 Jeep Grand Cherokee (WK) (Rev. B)

220000 SEATS

Warranty Bulletin D-20-10 (X88) Active Head Restraint - Select 2011-2018 Dodge Durango (WD and Select 2011-2018 Jeep Grand Cherokee (WK) (Rev. B)

222300 SEATS:MID/REAR ASSEMBLY:HEAD RESTRAINT

Warranty Bulletin D-20-10 (X88) Active Head Restraint - Select 2011-2018 Dodge Durango (WD and Select 2011-2018 Jeep Grand Cherokee (WK) (Rev. B)

222300 SEATS:MID/REAR ASSEMBLY:HEAD RESTRAINT

Warranty Bulletin D-20-10 (X88) Active Head Restraint - Select 2011-2018 Dodge Durango (WD and Select 2011-2018 Jeep Grand Cherokee (WK) (Rev. B)

356000 EQUIPMENT ADAPTIVE/MOBILITY

Warranty Bulletin D-20-10 (X88) Active Head Restraint - Select 2011-2018 Dodge Durango (WD and Select 2011-2018 Jeep Grand Cherokee (WK) (Rev. B)

350000 EQUIPMENT

Warranty Bulletin D-20-10 (X88) Active Head Restraint - Select 2011-2018 Dodge Durango (WD and Select 2011-2018 Jeep Grand Cherokee (WK) (Rev. B)

221300 SEATS:FRONT ASSEMBLY:HEAD RESTRAINT

Warranty Bulletin D-20-10 (X88) Active Head Restraint - Select 2011-2018 Dodge Durango (WD and Select 2011-2018 Jeep Grand Cherokee (WK) (Rev. B)

220000 SEATS

Active Head Restraint (AHR) Inadvertent Deployment - X88 Warranty Extension This bulletin involves inspecting the sled bracket striker pin and possibly replacing a front seat AHR that has inadvertently deployed. Customers may comment on t

350000 EQUIPMENT

Active Head Restraint (AHR) Inadvertent Deployment - X88 Warranty Extension This bulletin involves inspecting the sled bracket striker pin and possibly replacing a front seat AHR that has inadvertently deployed. Customers may comment on t

220000 SEATS

Active Head Restraint (AHR) Inadvertent Deployment - X88 Warranty Extension This bulletin involves inspecting the sled bracket striker pin and possibly replacing a front seat AHR that has inadvertently deployed. Customers may comment on t

356000 EQUIPMENT ADAPTIVE/MOBILITY

Active Head Restraint (AHR) Inadvertent Deployment - X88 Warranty Extension This bulletin involves inspecting the sled bracket striker pin and possibly replacing a front seat AHR that has inadvertently deployed. Customers may comment on t

350000 EQUIPMENT

Active Head Restraint (AHR) Inadvertent Deployment - X88 Warranty Extension This bulletin involves inspecting the sled bracket striker pin and possibly replacing a front seat AHR that has inadvertently deployed. Customers may comment on t

220000 SEATS

Active Head Restraint (AHR) Inadvertent Deployment - X88 Warranty Extension This bulletin involves inspecting the sled bracket striker pin and possibly replacing a front seat AHR that has inadvertently deployed. Customers may comment on t

160000 STRUCTURE

Leather Instrument Panel (IP) Cover Delaminating - X81 Warranty Extension This bulletin involves replacing upper leather IP covers that have suffered delamination issues. Customers may comment on the following:The upper leather IP cover i

117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

160000 STRUCTURE

117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

350000 EQUIPMENT

117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

356000 EQUIPMENT ADAPTIVE/MOBILITY

060000 ENGINE (PWS)

No Start Intermittently, Vehicle Requires Multiple Keyless Push To Start Attempts To Start Vehicle

980000 UNKNOWN OR OTHER

No Start Intermittently, Vehicle Requires Multiple Keyless Push To Start Attempts To Start Vehicle

116000 ELECTRICAL SYSTEM:IGNITION

No Start Intermittently, Vehicle Requires Multiple Keyless Push To Start Attempts To Start Vehicle

110000 ELECTRICAL SYSTEM

No Start Intermittently, Vehicle Requires Multiple Keyless Push To Start Attempts To Start Vehicle

020000 SUSPENSION

Air Suspension Inoperative And Or Compressor Freeze Up Or Sticking In Cold Weather.

350000 EQUIPMENT

Disinfectant Solution Recommended for COVID-19

160000 STRUCTURE

Disinfectant Solution Recommended for COVID-19

350000 EQUIPMENT

Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are nece

110000 ELECTRICAL SYSTEM

070000 FUEL SYSTEM, GASOLINE

Possible Driveability Issues due to the Winter-Blend Fuel into the Warmer Season

353000 EQUIPMENT:ELECTRICAL

162000 STRUCTURE:BODY

356000 EQUIPMENT ADAPTIVE/MOBILITY

117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

(X81) Leather Instrument Panel Top Pad Delaminating - 2011-2014 Jeep Grand Cherokee (WK)

020000 SUSPENSION

Air Suspension Components Star Parts Catalog has been updated to show individual service parts for the compressor assembly. This will allow service technicians to repair the root cause without over repairing the system. Replace only the pa

160000 STRUCTURE

Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.

130000 VISIBILITY

Authentic Mopar? Glass Replacement This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the recommended usage of Authentic Mopar? Glass.

160000 STRUCTURE

Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.

350000 EQUIPMENT

Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.

160000 STRUCTURE

Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.

130000 VISIBILITY

Authentic Mopar? Glass Replacement This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the recommended usage of Authentic Mopar? Glass.

350000 EQUIPMENT

Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.

160000 STRUCTURE

Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.

350000 EQUIPMENT

Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.

160000 STRUCTURE

Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.

160000 STRUCTURE

Dash and Door Appliques Delaminating - X77 Warranty Extension This bulletin involves replacing carbon fiber interior trim appliques that have suffered delamination issues. Some customers may comment on one of the following: The carbon fib

Showing 100 of 363 bulletins.

NHTSA Safety Investigations, JEEP GRAND CHEROKEE

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

RQ, Open , Model Year: 2022

Recall 23V-413 Post Remedy Failures

On June 8, 2023, Fiat Chrysler Automobiles US, LLC (FCA) filed Safety Recall 23V-413 affecting certain 2022–2023 Jeep Grand Cherokee and2021–2023 Jeep Grand Cherokee L vehicles to address rear coil springs that may not have been properly installed during vehicle production. An improperly install... Read more

PE, Closed , Model Year: 2014

False Positive Automated Braking

On June 1, 2015, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE15-021 to investigate 9 complaints alleging incidents of unintended braking in model year (MY) 2014 Jeep Grand Cherokee vehicles, including 2 alleging incidents of full ABS braking.ODI expanded the scope to in... Read more

RQ, Closed , Model Year: 2002

Jeep inadvertent air bag deployment

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cher... okee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404Read more

PE, Closed , Model Year: 2012

Power steering hose failure

The Office of Defects Investigation (ODI) analyzed complaint data provided by Chrysler as well as complaints submitted to ODI from consumers. ODI's analysis identified a total of 24 unique reports indicating power steering hose blow-offs resulting from a dislodged power steering cooler turbulator fi... n in some early production vehicles.According to Chrysler, a dislodged fin can occur when the turbulator is inserted into the power steering cooler or loaded into the assembly machine.A dislodged fin may block the flow of power steering fluid creating excess back-pressure in the power steering system leading to the possibility of a return hose blow-off.Chrysler and its power steering cooler supplier, Dana, modified the cooler assembly process to address factors that may contribute to hose blow-offs. The redesigned turbulator assembly stations were completely implemented in production by April 2012.During PE12-020, Chrysler identified occurrences where the power steering return hose may blow-off at the power steering cooler.This is a condition that typically occurs early in the life of the vehicle with 65% occurring at less than 2,000 miles and 96% occurring with less than 8,000 miles. The data also shows that 88% of the conditions occurred with less than 4 months in service. Over 50% of the blow-off complaints occurred on vehicles with build dates between November 22, 2011 and December 23, 2011. None of the conditions occurred with more than 12,000 miles or 7 months in service. Chrysler?s complaint analysis indicates up-to 14 additional vehicles may experience the hose blow off condition.None of the 24 unique reports with the hose blow-off condition alleged smoke or fire in the engine compartment. In the event of a blow-off, it is highly unlikely for power steering fluid to reach any of the ignition sources in the engine compartment and result in an engine fire. Complaint analysis identified five reports alleging engine compartment fires that resulted from other or unknown causes, including one attributed to an overheated transmission fluid. Two fires of unknown cause cited in the opening resume for PE12-020 involved vehicles equipped with V8 SRT 6.4L engines which are not equipped with the steering system affected by the turbulator fin concern. ODI will continue to monitor field experience in Jeep Grand Cherokee vehicles equipped with that engine.There have been no reports of loss of steering control, crashes or injuries as result of this condition.Additionally, all affected vehicles that may have experienced a hose blow-off condition were repaired under Chrysler?s 3 year/36,000 mile manufacturer?s warranty at no cost to the owner and supplier?s process improvements put in place have eliminated the likelihood of power steering hose blow offs. There is no indication of loss of motive power or unreasonable safety risk associated with the alleged defect in the subject vehicles. This preliminary evaluation is closed.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers (ODI Nos.): 10465379, 10461736, 10459178.Read more

PE, Closed , Model Year: 1993

Crash Related Fuel Tank Fires

NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles inc... luded in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.Read more

DP, Closed , Model Year: 1993

Fuel Storage System Crash Related Fires

In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged t... hat the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.Read more

EA, Closed , Model Year: 2000

FAN BLADE FAILURE (ENGINE COOLING FAN)

DAIMLERCHRYSLER CORPORATION (DCC) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (06V199) OF CERTAIN JEEP GRAND CHEROKEE VEHICLES TO REPLACE THE ENGINE'S ELECTRIC MOTOR DRIVEN COOLING FAN. THE 182,875 VEHICLES INCLUDED IN THE RECALL ARE MODEL YEAR (MY) 2002 EQUIPPED WITH 4.0 LITER (SIX... Read more

PE, Closed , Model Year: 2002

ENGINE COOLING FAN BLADE FAILURE

THIS INVESTIGATION WAS OPENED ON JULY 13, 2005, BASED ON FOUR ODI CONSUMER REPORTS.ODI CONTACTED ALL OF THOSE COMPLAINANTS AND EACH OF THEM REPORTED THAT PIECES OF THE BROKEN FAN BLADE HAD DAMAGED THE RADIATOR AND PENETRATED THROUGH THE PROTECTIVE FAN SHROUD.SINCE OPENING THE INVESTIGATION, ODI HAS ... Read more

EA, Closed , Model Year: 1993

HOOD LATCH FAILURE

ODI OPENED EA02-029 TO DETERMINE WHETHER A SAFETY-RELATED DEFECT TREND EXISTED IN THE MY 1997 JEEP GRAND CHEROKEE HOOD LATCH ASSEMBLIES.DURING EA02-029, THERE WAS NO SPECIFIC FAILURE MECHANISM IDENTIFIED THAT COULD DIFFERENTIATE THE MY 1997 VEHICLES FROM OTHER VEHICLES CONTAINING THIS SAME HOOD LATC... Read more

PE, Closed , Model Year: 1996

HOOD LATCH

There is no summary currently available

EA, Closed , Model Year: 1993

ROLL-AWAY IN REVERSE WHEN PARKED

DAIMLERCHRYSLER HAS RECALLED THE ZJ MODELS TO INCORPORATE A SECONDARY DETENT SPRING INTO THE SHIFTER.EVEN THOUGH THE WJ 6 CYL. VEHICLES USE THE SAME MANUAL DETENT LEVER THAT AS THE VEHICLES IN THE RECALL POPULATION, ODI BELIEVES THAT THE WJ REDESIGNED SHIFTER, WHICH IMPROVES FLOOR SHIFTER FUNCTIONAL... Read more

PE, Closed , Model Year: 1995

INADVERTENT ROLLAWAY IN REVERSE PARK

DP, Closed , Model Year: 1993

VISCOUS COUPLING FAILURE

ALLEGED THAT THE VISCOUS COUPLING IN THE TRANSFER CASE OF HIS 1993 GRAND CHEROKEE VEHICLE FAILED WHICH AFFECTED STEERING, BRAKING AND STARTING OF THE VEHICLE.

EA, Closed , Model Year: 1993

QCK-CONNECT FUEL LINE FAIL

There is no summary currently available

EA, Closed , Model Year: 1993

FUEL TANK LEAKAGE

There is no summary currently available

PE, Closed , Model Year: 1994

QUICK-CONNECT FUEL LINE FAILURE

There is no summary currently available

PE, Closed , Model Year: 1993

STEERING SHAFT FAILURE

There is no summary currently available

PE, Closed , Model Year: 1993

FUEL TANK LEAKAGE

There is no summary currently available

PE, Closed , Model Year: 1993

REAR LIFTGATE LATCH

There is no summary currently available

JEEP GRAND CHEROKEE - All Years Overview

Complete safety history for the JEEP GRAND CHEROKEE across all model years (1993, 2026).

326 Total Recalls

40,113 Total Complaints

19 Investigations

2,820 Reported Crashes

845 Reported Fires

85 Reported Deaths

JEEP GRAND CHEROKEE - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2026	5	23	View
2025	3	136	View
2024	15	439	View
2023	20	681	View
2022	12	482	View
2021	12	670	View
2020	3	363	View
2019	7	544	View
2018	11	1,223	View
2017	6	566	View
2016	9	440	View
2015	10	1,768	View
2014	19	3,405	View
2013	10	1,117	View
2012 (current)	11	2,329
2011	6	2,425	View
2010	5	171	View
2009	3	195	View
2008	5	990	View
2007	7	1,478	View
2006	6	1,754	View
2005	5	2,733	View
2004	14	1,572	View
2003	10	890	View
2002	16	1,771	View
2001	10	1,128	View
2000	12	1,855	View
1999	10	2,319	View
1998	10	1,349	View
1997	11	1,433	View
1996	12	1,250	View
1995	11	983	View
1994	8	775	View
1993	12	784	View
1992	0	4	View
1991	0	7	View
1990	0	5	View
1989	0	7	View

Other JEEP Models

Model	Recalls	Complaints
WRANGLER	313	22,084	View
CHEROKEE	297	20,619	View
WAGONEER	96	662	View
LIBERTY	92	11,701	View
COMPASS	53	5,936	View
GRAND WAGONEER	53	298	View
GLADIATOR	45	1,287	View
RENEGADE	34	3,433	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2012 JEEP GRAND CHEROKEE

Complaint Statistics

Top Reported Components

NHTSA Safety Ratings, 2012 JEEP GRAND CHEROKEE

Safety Technology

Technical Service Bulletins, 2012 JEEP GRAND CHEROKEE

Most Affected Components

NHTSA Safety Investigations, JEEP GRAND CHEROKEE

JEEP GRAND CHEROKEE - All Years Overview

JEEP GRAND CHEROKEE - Year by Year

Other JEEP Models