1989 JEEP GRAND CHEROKEE

0 recalls — 7 complaints — 1 TSBs

No recalls found for this vehicle.

Complaint Statistics

7 total complaints 1 fires

Top Reported Components

Component	Complaints
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP	1
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR	1
STEERING:HYDRAULIC POWER ASSIST SYSTEM	1
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC	1
ENGINE	1
POWER TRAIN	1
EXTERIOR LIGHTING	1

Incident date: May 27, 2019

CATALIC CONVERTER RECALL ELECTRIC RECALL COOLANT TEMP CIRCUIT RECALL OCCURRED WHILE I WAS DRIVING ON THE ROAD I WILL NOT TEST IT ON FREEWAY WITH ALL THE SEVERE SYSTOMS HAPPENING WITH MY JEEP BEEN SMOKING FROM ENGINE SOMETHING WITH MY COOLANT AND TEMP CIRCUIT INPUT MY HEADLIGHTS ELECTRIC SYSTEM PERI... Read more

Incident date: May 27, 2019

WHEN BRAKES ARE APPLIED VEHICLE VIBRATES. DEALER HAS RESURFACED BRAKES TWICE, BUT PROBLEM HAS REOCCURRED. PLEASE PROVIDE FURTHER INFORMATION. *AK

Incident date: Dec 1, 1998

WHILE DRIVING 60 MPH, THE POWER STEERING UNIT FELL OUT OF THE VEHICLE, CAUSING THE STEERING WHEEL TO LOCK UP. *ML

Incident date: Dec 18, 1996

EXHAUST FIRE, CATALYTIC CONVERTER SYSTEM CAUGHT ON FIRE WHILE VEHICLE WAS PARKED. NOT THE OWNER, BUT INSURANCE CO REPORTED THE FIRE. *AK

Fire

Incident date: Jan 10, 1995

ABS RECALL DONE, ABS ACTUATOR MAKES LOUD SOUND WHEN BRAKES ARE APPLIED. TT

Technical Service Bulletins — 1989 JEEP GRAND CHEROKEE

1 manufacturer communications from 1 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
220000 SEATS	1

220000 SEATS

SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT

NHTSA Safety Investigations — JEEP GRAND CHEROKEE

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

RQ — Open — Model Year: 2022

Recall 23V-413 Post Remedy Failures

On June 8, 2023, Fiat Chrysler Automobiles US, LLC (FCA) filed Safety Recall 23V-413 affecting certain 2022–2023 Jeep Grand Cherokee and2021–2023 Jeep Grand Cherokee L vehicles to address rear coil springs that may not have been properly installed during vehicle production. An improperly install... Read more

PE — Closed — Model Year: 2014

False Positive Automated Braking

On June 1, 2015, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE15-021 to investigate 9 complaints alleging incidents of unintended braking in model year (MY) 2014 Jeep Grand Cherokee vehicles, including 2 alleging incidents of full ABS braking.ODI expanded the scope to in... Read more

RQ — Closed — Model Year: 2002

Jeep inadvertent air bag deployment

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cher... okee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404Read more

PE — Closed — Model Year: 2012

Power steering hose failure

The Office of Defects Investigation (ODI) analyzed complaint data provided by Chrysler as well as complaints submitted to ODI from consumers. ODI's analysis identified a total of 24 unique reports indicating power steering hose blow-offs resulting from a dislodged power steering cooler turbulator fi... n in some early production vehicles.According to Chrysler, a dislodged fin can occur when the turbulator is inserted into the power steering cooler or loaded into the assembly machine.A dislodged fin may block the flow of power steering fluid creating excess back-pressure in the power steering system leading to the possibility of a return hose blow-off.Chrysler and its power steering cooler supplier, Dana, modified the cooler assembly process to address factors that may contribute to hose blow-offs. The redesigned turbulator assembly stations were completely implemented in production by April 2012.During PE12-020, Chrysler identified occurrences where the power steering return hose may blow-off at the power steering cooler.This is a condition that typically occurs early in the life of the vehicle with 65% occurring at less than 2,000 miles and 96% occurring with less than 8,000 miles. The data also shows that 88% of the conditions occurred with less than 4 months in service. Over 50% of the blow-off complaints occurred on vehicles with build dates between November 22, 2011 and December 23, 2011. None of the conditions occurred with more than 12,000 miles or 7 months in service. Chrysler?s complaint analysis indicates up-to 14 additional vehicles may experience the hose blow off condition.None of the 24 unique reports with the hose blow-off condition alleged smoke or fire in the engine compartment. In the event of a blow-off, it is highly unlikely for power steering fluid to reach any of the ignition sources in the engine compartment and result in an engine fire. Complaint analysis identified five reports alleging engine compartment fires that resulted from other or unknown causes, including one attributed to an overheated transmission fluid. Two fires of unknown cause cited in the opening resume for PE12-020 involved vehicles equipped with V8 SRT 6.4L engines which are not equipped with the steering system affected by the turbulator fin concern. ODI will continue to monitor field experience in Jeep Grand Cherokee vehicles equipped with that engine.There have been no reports of loss of steering control, crashes or injuries as result of this condition.Additionally, all affected vehicles that may have experienced a hose blow-off condition were repaired under Chrysler?s 3 year/36,000 mile manufacturer?s warranty at no cost to the owner and supplier?s process improvements put in place have eliminated the likelihood of power steering hose blow offs. There is no indication of loss of motive power or unreasonable safety risk associated with the alleged defect in the subject vehicles. This preliminary evaluation is closed.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers (ODI Nos.): 10465379, 10461736, 10459178.Read more

PE — Closed — Model Year: 1993

Crash Related Fuel Tank Fires

NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles inc... luded in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.Read more

DP — Closed — Model Year: 1993

Fuel Storage System Crash Related Fires

In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged t... hat the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.Read more

EA — Closed — Model Year: 2000

FAN BLADE FAILURE (ENGINE COOLING FAN)

DAIMLERCHRYSLER CORPORATION (DCC) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (06V199) OF CERTAIN JEEP GRAND CHEROKEE VEHICLES TO REPLACE THE ENGINE'S ELECTRIC MOTOR DRIVEN COOLING FAN. THE 182,875 VEHICLES INCLUDED IN THE RECALL ARE MODEL YEAR (MY) 2002 EQUIPPED WITH 4.0 LITER (SIX... Read more

PE — Closed — Model Year: 2002

ENGINE COOLING FAN BLADE FAILURE

THIS INVESTIGATION WAS OPENED ON JULY 13, 2005, BASED ON FOUR ODI CONSUMER REPORTS.ODI CONTACTED ALL OF THOSE COMPLAINANTS AND EACH OF THEM REPORTED THAT PIECES OF THE BROKEN FAN BLADE HAD DAMAGED THE RADIATOR AND PENETRATED THROUGH THE PROTECTIVE FAN SHROUD.SINCE OPENING THE INVESTIGATION, ODI HAS ... Read more

EA — Closed — Model Year: 1993

HOOD LATCH FAILURE

ODI OPENED EA02-029 TO DETERMINE WHETHER A SAFETY-RELATED DEFECT TREND EXISTED IN THE MY 1997 JEEP GRAND CHEROKEE HOOD LATCH ASSEMBLIES.DURING EA02-029, THERE WAS NO SPECIFIC FAILURE MECHANISM IDENTIFIED THAT COULD DIFFERENTIATE THE MY 1997 VEHICLES FROM OTHER VEHICLES CONTAINING THIS SAME HOOD LATC... Read more

PE — Closed — Model Year: 1996

HOOD LATCH

There is no summary currently available

EA — Closed — Model Year: 1993

ROLL-AWAY IN REVERSE WHEN PARKED

DAIMLERCHRYSLER HAS RECALLED THE ZJ MODELS TO INCORPORATE A SECONDARY DETENT SPRING INTO THE SHIFTER.EVEN THOUGH THE WJ 6 CYL. VEHICLES USE THE SAME MANUAL DETENT LEVER THAT AS THE VEHICLES IN THE RECALL POPULATION, ODI BELIEVES THAT THE WJ REDESIGNED SHIFTER, WHICH IMPROVES FLOOR SHIFTER FUNCTIONAL... Read more

PE — Closed — Model Year: 1995

INADVERTENT ROLLAWAY IN REVERSE PARK

DP — Closed — Model Year: 1993

VISCOUS COUPLING FAILURE

ALLEGED THAT THE VISCOUS COUPLING IN THE TRANSFER CASE OF HIS 1993 GRAND CHEROKEE VEHICLE FAILED WHICH AFFECTED STEERING, BRAKING AND STARTING OF THE VEHICLE.

EA — Closed — Model Year: 1993

QCK-CONNECT FUEL LINE FAIL

There is no summary currently available

EA — Closed — Model Year: 1993

FUEL TANK LEAKAGE

There is no summary currently available

PE — Closed — Model Year: 1994

QUICK-CONNECT FUEL LINE FAILURE

There is no summary currently available

PE — Closed — Model Year: 1993

STEERING SHAFT FAILURE

There is no summary currently available

PE — Closed — Model Year: 1993

FUEL TANK LEAKAGE

There is no summary currently available

PE — Closed — Model Year: 1993

REAR LIFTGATE LATCH

There is no summary currently available

JEEP GRAND CHEROKEE — All Years Overview

Complete safety history for the JEEP GRAND CHEROKEE across all model years (1993–2026).

321 Total Recalls

39,806 Total Complaints

19 Investigations

2,786 Reported Crashes

848 Reported Fires

81 Reported Deaths

JEEP GRAND CHEROKEE — Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2026	3	6	View
2025	3	105	View
2024	14	402	View
2023	19	650	View
2022	11	454	View
2021	12	659	View
2020	3	338	View
2019	7	526	View
2018	11	1,197	View
2017	6	559	View
2016	9	437	View
2015	10	1,737	View
2014	19	3,379	View
2013	10	1,111	View
2012	11	2,320	View
2011	6	2,425	View
2010	5	171	View
2009	3	195	View
2008	5	990	View
2007	7	1,478	View
2006	6	1,754	View
2005	5	2,733	View
2004	14	1,572	View
2003	10	889	View
2002	16	1,771	View
2001	10	1,128	View
2000	12	1,855	View
1999	10	2,319	View
1998	10	1,349	View
1997	11	1,433	View
1996	12	1,250	View
1995	11	983	View
1994	8	775	View
1993	12	784	View
1992	0	4	View
1991	0	7	View
1990	0	5	View
1989 (current)	0	7

Other JEEP Models

Model	Recalls	Complaints
WRANGLER	313	22,084	View
CHEROKEE	297	20,619	View
WAGONEER	96	662	View
LIBERTY	92	11,701	View
COMPASS	53	5,936	View
GRAND WAGONEER	53	298	View
GLADIATOR	45	1,287	View
RENEGADE	34	3,433	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

1989 JEEP GRAND CHEROKEE

Complaint Statistics

Top Reported Components

Technical Service Bulletins — 1989 JEEP GRAND CHEROKEE

Most Affected Components

NHTSA Safety Investigations — JEEP GRAND CHEROKEE

JEEP GRAND CHEROKEE — All Years Overview

JEEP GRAND CHEROKEE — Year by Year

Other JEEP Models