2006 JEEP GRAND CHEROKEE

6 recalls, 1,754 complaints - 100 TSBs

ELECTRICAL SYSTEM:IGNITION:SWITCH

Defect Description

This defect can affect the safe operation of the airbag system. Until this recall is performed, drivers should adjust their seat to allow clearance between the driver's knee and the ignition key, and remove all items from their key ring, leaving only the vehicle key. Chrysler Group LLC (Chrysler... Read more

Consequence

If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and... Read more

Remedy

Chrysler will notify owners, and dealers will replace the ignition switch, free of charge. Chrysler sent interim notifications to owners in September 2014. The recall began on October 9, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P4... Read more

649,353 vehicles affected

Manufacturer: Chrysler Group LLC

POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)

Defect Description

Chrysler Group LLC (Chrysler) is recalling certain model year 2005-2010 Jeep Grand Cherokee vehicles manufactured February 11, 2004, through March 9, 2010; and 2006-2010 Jeep Commander vehicles manufactured January 31, 2005, through March 10, 2010. A transfer case electrical failure may result in a... Read more

Consequence

If the vehicle shifts into neutral, it may roll away increasing the risk of a crash or personal injury.

Remedy

Chrysler will notify owners, and dealers will reflash the final drive controller which governs the transfer case, with new software, free of charge. The recall began on August 15, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N23.

295,345 vehicles affected

Manufacturer: Chrysler Group LLC

SUSPENSION

Defect Description

ROCK KRAWLER IS RECALLING 44 PERFORMANCE SUSPENSION SYSTEMS SOLD AS AFTERMARKET EQUIPMENT FOR USE ON THE VEHICLE LISTED ABOVE. THESE SUSPENSION SYSTEMS WERE PRODUCED WITH GRADE 2 CARRIAGE BOLTS INSTEAD OF THE PROPER GRADE 5 CARRIAGE BOLTS. THE IMPROPER GRADE 2 CARRIAGE BOLTS COULD EXPERIENCE A LOS... Read more

Consequence

THIS CONDITION COULD CAUSE A LOSS OF EFFECTIVE LIFT AND LOWERING OF THE AFFECTED VEHICLE, POSSIBLY CREATING THE DRIVER TO PANIC WHICH COULD POSSIBLY LEAD TO A VEHICLE CRASH.

Remedy

ROCK KRAWLER WILL NOTIFY OWNERS AND PROVIDE A FREE REMEDY. THE SAFETY RECALL BEGAN ON OCTOBER 15. 2008. ALL THE AFFECTED UNTITS HAVE BEEN REMEDIED. OWNERS MAY CONTACT ROCK KRAWLER AT 1-518-270-9822.

44 vehicles affected

Manufacturer: ROCK KRAWLER/PURE PERFORMANCE GROUP, INC

EXTERIOR LIGHTING

Defect Description

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES... Read more

Consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

16,270 vehicles affected

Manufacturer: SABERSPORT

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE

Defect Description

ON CERTAIN SPORT UTILITY VEHICLES, THE SOFTWARE PROGRAMMED INTO THE ABS ELECTRONIC CONTROL MODULE MAY ALLOW A MOMENTARY DELAY IN BRAKING WHEN COASTING UP A HILL DURING CERTAIN CONDITIONS.

Consequence

THIS COULD CAUSE A CRASH WITHOUT WARNING.

Remedy

DEALERS WILL REPROGRAM THE ABS ELECTRONIC CONTROL MODULE WITH NEW SOFTWARE THAT PREVENTS THIS CONDITION FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 22, 2007. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

296,550 vehicles affected

Manufacturer: DAIMLERCHRYSLER CORPORATION

AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

Defect Description

ON CERTAIN SPORT UTILITY VEHICLES, THE INFLATOR CONNECTOR FOR THE DRIVER'S AIR BAG MAY HAVE BEEN INCORRECTLY ASSEMBLED.

Consequence

THE AIR BAG MAY NOT INFLATE PROPERLY WHICH CAN INCREASE THE RISK OF INJURY IN CERTAIN CRASH CONDITIONS.

Remedy

DEALERS WILL REPAIR THE DRIVER'S FRONT AIR BAG INFLATOR FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN THE WEEK OF AUGUST 2, 2006. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

15,021 vehicles affected

Manufacturer: DAIMLERCHRYSLER CORPORATION

Complaint Statistics

1,754 total complaints 81 crashes 9 fires 65 injuries 6 deaths

Top Reported Components

Component	Complaints
ELECTRICAL SYSTEM	721
POWER TRAIN	145
ENGINE	122
UNKNOWN OR OTHER	75
EXTERIOR LIGHTING	56
STRUCTURE:BODY	55
AIR BAGS	55
SERVICE BRAKES	54
VEHICLE SPEED CONTROL	50
STRUCTURE:BODY:DOOR	41

Incident date: Nov 7, 2025

Transfer case failure limiting all wheel drive system. Needs new transmission and transfer case at 83000 miles.

Incident date: Nov 7, 2025

My 2024 Toyota Land Cruiser has exhibited persistent brake squealing since the day it was purchased. The noise occurs during normal braking conditions and has been present from the very first use of the vehicle. This is not a break-in issue, as it has never resolved on its own. Despite initially den... Read more

Incident date: Nov 7, 2025

Oil was changed and within a month was completely dried with no visible leak and without any warning or lights the engine shut off while driving and seized Turner Kia performed a thorough diagnostic and determined that will cost $13,508.90 to replace the engine.

Incident date: Jan 1, 2020

#1 ) el motor presento esta fallas en las 98mil millas, el motor empezó con un alto consumo de aceite de 5 cuartos de aceite cada 3 mil millas, en repetidas ocasiones estábamos de viaje junto a mi familia, mi esposa, [XXX]. Un dia Hicimos una para frente a un semáforo, y en seguida el vehículo e... Read more

Incident date: Feb 12, 2026

Transmission Clutch Shudder -transmission Clutch . I took my vehicle in before it would have severe issues to the Ashland Ohio Ford dealer and they told me that there was nothing wrong with my vehicle. And now my vehicle is not drivable due to this recall parked. Please help me it would be a blessi... Read more

Incident date: Jan 10, 2026

Tesla Supervised Self Driving (FSSD) update 14 removed the ability for the vehicle operator to set speed targets. Additionally, their system is unable to accurately determine speed limits for many roadways. The discrepancy between FSSDs perceived speed limit and actual speed limit can be as much at ... Read more

Incident date: Sep 8, 2025

On feb 28 2025 I bumped into car at stop light. Don’t know how it happened. 11 4th about 2 as I was stopped behind car at bank, the car lunged forward-jumped- no reason for it. This is the 4th time something has happed. I slammed on brakes so no incident this time. I am being cautious such as stay... Read more

Crash

Incident date: Sep 8, 2025

8/2023 one rear seat belt would no longer retract. The problem was reproduced by the service center and they replaced the rear seat belt. 10/2025 the same rear seat belt would no longer retract and 11/2025 the other rear seat belt would no longer retract. Brought into Jeep dealer and they verifie... Read more

Incident date: Sep 8, 2025

I am reporting a 2023 Volkswagen Taos, VIN [XXX] , purchased new on [XXX]. The vehicle has shut off completely while driving three times, each time with multiple warning lights. Incident 1 – [XXX]: Engine shut off while driving. The dealership told me it was “safe to drive in” and claimed to r... Read more

Incident date: Sep 20, 2025

Backup camera is appearing Upside down on display and sometimes inverted. When it gets dark outside, the backup camera has lines appear on the display so you can’t use it when it’s dark. This is a huge safety risk as to having the camera display upside down/inverted/not clear can cause major inc... Read more

Incident date: Jul 23, 2025

Front crash assistance unavailable. Camera not working. No auto dimming available either.

Incident date: Dec 1, 2024

We were sitting in a parking lot and the car was started, the steering wheel was very difficult to turn. Yes, the vehicle is available for inspection. No one’s safety was at risk. This is the first time this has happened, we have had the car since July 2024, we have not taken it to a mechanic yet.... Read more

Incident date: Nov 15, 2023

With no warning. my 2018 Subaru Forrester had its transmission lock up on me in the pouring rain while I was traveling 60 miles an hour. I purchased the car new in 2018, had it regularly serviced and it only has 4700 miles on it. If I was not buckled in, I would have gone through the windshield. The... Read more

Incident date: Nov 15, 2023

My 2016 X1 is showing in the dashboard a “secure vehicle against rolling” transmission message; the fault is due to a little spring in the selector level which has been reported in other BMW and MINI models. I recently found a report in the NHTSA website related to a 10 year warranty extension ... Read more

Incident date: Jun 15, 2024

After purchasing a 2017 Ford Escape with the 2.0L engine, a check engine light came on, indicating misfires in cylinder 1. Local mechanic found coolant leaking into the engine and advised not to drive more than a few miles as potential for further damage and/or possible engine fire may occur as oil... Read more

Incident date: Jun 15, 2024

My truck is brand new. The A/C lines and evaporator coil are freezing up when using the A/C, resulting in no air flow out of the vents in the cabin. I checked forums online and this has been a common problem with my vehicle yet Ford has filed no recall to fix it. Dealership states it’s a faulty t... Read more

Incident date: May 4, 2024

Due to an occurrence of other vehicles back windows blowing out dealer unplugged part of rear window defroster. Now several years later the defroster across entire back window does not work. Since I am now out of waranty and extended waranty this repair would come out of my pocket. Dealer should ... Read more

Incident date: Feb 26, 2024

The contact owns a 2007 Acura TSX. The contact stated that while attempting to start the vehicle, the vehicle failed to start. Several unknown warning lights were illuminated. The vehicle was towed to an independent mechanic, who diagnosed a failure with the ECU, and determined that corrosion had ca... Read more

Incident date: Feb 26, 2024

The contact's father-in-law owned a 2022 Genesis GV70. The contact stated while the driver was driving at an undisclosed speed during rainy weather conditions, the driver crashed into a Ford Fusion at an unknown location and there was a third vehicle impacted that crashed into a wall. The driver of ... Read more

Crash 2 deaths

Incident date: Sep 28, 2023

The contact owns a 2008 Hyundai Sonata. The contact stated while driving at an undisclosed speed, the air bag warning light illuminated the instrument panel. The vehicle was taken to an independent mechanic, who diagnosed failures with the passenger's side occupancy sensor and occupant classificatio... Read more

Incident date: Jan 30, 2024

I have tires sized 195/60r15. I was having problems with shaking at a certain speed. my mechanic checked all the options that could have been mechanical and directed me to a tire shop. I brought the car in for them to check for balance. rims, etc. During the inspection, they discovered that both re... Read more

Incident date: Nov 2, 2023

The steering wheel "sticks" when I am driving straight down a road, at both high and low speeds. It is more noticeable at high speeds.

Incident date: Nov 2, 2023

Drivers Side Door- The “Door Check/Hinge” failed. Originally made several loud popping noises and then became hard to secure/shut. The same situation as the 2021 Ford Escape that I traded for the 2022 Escape. Drivers side door wouldn’t shut properly. Yes. No.

Incident date: Nov 2, 2023

1) The rear axle bolt failed on my Max Tow equipped truck, the bolt head and washer broke off and were rattling around in the wheel. 2) The rear axle bolt secures the axle to the knuckle/hub and transmit power from the differential to the wheels. Without this bolt the axle could fall away from the ... Read more

Incident date: Oct 26, 2023

Driving down the road and Low Oil Pressure Light comes on car loses all power had to coast to try to get off the road got to a stop. The ford app shows power train malfunction ended up having it towed to a Ford dealership

Incident date: Oct 26, 2023

The contact owns a 2019 Volkswagen Atlas. The contact received notification of NHTSA Campaign Number: 23V215000 (Air Bags) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufactu... Read more

Incident date: Oct 26, 2023

Randomly on10/26/23 my car started shaking while in the drive mode at a stop light. When I took off from the light the car stalled. This continued to happen all the way to my job. When I realized it would not shake when it was in neutral at a stop I would just do that. The stalls would continue. Nex... Read more

Incident date: May 16, 2023

On October 13, almost lost control of my vehicle while driving at normal speeds in good weather. The car tried to pull off the road with every bump I hit. Drove it to tire dealership as I thought there might be problem with tire or suspension. Mechanic there told me the front engine frame ($595 part... Read more

Incident date: May 16, 2023

My 2011 Silverado has a very clean body, but the frame is completley rusted out. If you Google frame issues on these trucks you will see that many people are having the same issue and GM is doing nothing about it. I think GM should have to buy back these trucks as my truck went from being worth $120... Read more

Incident date: Apr 4, 2023

When I purchased the car it had been used as a police car in the state of Mississippi. So after I bought the car I checked for any recalls and found it to have 2 open recalls. 1 was a passenger side airbag and the other was the alternator. So I contacted Moss motor company in South Pittsburg Tenness... Read more

Incident date: Apr 4, 2023

Incident date: Jan 12, 2023

The sunroof screen that covers the panoramic sunroof has become detached from the retractable component. Because of this, the screen has begun to sag, which is now partially obstructing visibility through the rearview mirror. This obstruction is a life threatening situation because of lowered visibi... Read more

Incident date: Jan 12, 2023

The front control arms broke. I had it in for recall work and asked them to check the rear control arms. We had just gotten new tires on it and the tire shop recommended we bring it in to have Tesla look at the rear control arms. Tesla said they looked good and then last minute they said the front c... Read more

Incident date: Feb 21, 2023

What component or system failed or malfunction and is it available for inspection upon request. The CVT failsafe high fluid temperature protection mode enacted while I was driving on the highway at speeds of 65 to 70 mph going with the flow of traffic it is not available for inspection upon request ... Read more

Incident date: Jul 21, 2022

I can't buckle either front seatbelts. I bought the Jeep new and it started this recently. It started with the front passenger belt first.

Incident date: May 4, 2022

The vehicle's gauges will turn off while driving randomly. The speedometer, odometer, tachometer, fuel gauge will all zero out for unspecified amounts of time. Sometimes 10 seconds, other times until the vehicle is started back up. This occurs when the vehicle is in motion. So, is very dangerous. So... Read more

Incident date: May 4, 2022

Incident date: Dec 13, 2021

There wasn’t an accident while driving my vehicle (thank god). My key stopped working for my ignition. I had an ignition recall on my vehicle (as to what the dealership told me). My vehicle has now been with the dealership since around Christmas maybe even a little bit before that. They did my... Read more

Incident date: Dec 13, 2021

Incident date: Mar 6, 2022

The contact owns a 2006 Jeep Grand Cherokee. The contact stated while driving at 65 MPH, there was a sound of wind coming from the sunroof. The contact stated that as he opened the sunshade guard, the sunroof glass detached from the vehicle. The contact veered to the side of the road to check that t... Read more

Incident date: Jan 27, 2015

Air bags light in the dashboard is on without any accident. Air bags are original, seems to be in good conditions or without any physical damage on the exterior. Call my attention the recalls for the Air bags light in others Jeep Grand Cherokee from others years.

Incident date: Oct 10, 2021

Jeep cuts out in middle of driving it says engine misfire on 3 . Driving down road will almost died or not run in traffic im lucky I havent had wreck yet to scared to drive it have seen all over the interent how bad it is mechanics cant seem to fix even jeeps own mechanics

Incident date: Oct 10, 2021

Incident date: Nov 1, 2021

While driving all dashboard and exterior lighting goes off and engine and brakes seem to be impacted. Possibly an ignition switch failure.

Incident date: Nov 1, 2021

While driving all dashboard and exterior lighting goes off and engine and brakes seem to be impacted. Possibly an ignition switch failure.

Incident date: Nov 1, 2021

While driving all dashboard and exterior lighting goes off and engine and brakes seem to be impacted. Possibly an ignition switch failure.

Incident date: Jul 1, 2019

The Jeep dealer replaced my ignition switch that was part of the 2014 ignition switch recall. My Jeep continues to lose power after successfully turning on. It will turn on for a less than one minute, all the lights on the dash board will turn on, and the engine will have sudden loss of power. It... Read more

Showing 50 of 1,754 complaints.

Technical Service Bulletins, 2006 JEEP GRAND CHEROKEE

100 manufacturer communications from 75 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
110000 ELECTRICAL SYSTEM	16
100000 POWER TRAIN	10
350000 EQUIPMENT	10
103000 POWER TRAIN:AUTOMATIC TRANSMISSION	6
160000 STRUCTURE	6
118000 ELECTRICAL SYSTEM:SOFTWARE	5
060000 ENGINE AND ENGINE COOLING	5
061000 ENGINE AND ENGINE COOLING:ENGINE	5

100000 POWER TRAIN

Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles. If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) are one-time usag

100000 POWER TRAIN

NAG1 Transmission Before installing the transmission with the engine, check for dowel pins (2) for alignment. If the pins are missing request to add the dowel pin first and then install the transmission

100000 POWER TRAIN

350000 EQUIPMENT

Mechanical rocker arm, intake, 1.7 ratio.

100000 POWER TRAIN

Mechanical rocker arm, intake, 1.7 ratio.

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehi

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

350000 EQUIPMENT

Disinfectant Solution Recommended for COVID-19

160000 STRUCTURE

Disinfectant Solution Recommended for COVID-19

110000 ELECTRICAL SYSTEM

Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are nece

350000 EQUIPMENT

160000 STRUCTURE

Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.

350000 EQUIPMENT

Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.

160000 STRUCTURE

Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.

160000 STRUCTURE

Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.

350000 EQUIPMENT

Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.

160000 STRUCTURE

Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.

160000 STRUCTURE

Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.

350000 EQUIPMENT

Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.

130000 VISIBILITY

Exterior Mirror The latest version of these exterior mirrors have had their glass removed to be serviced separatly. To install, connect the electrial connector (if equipped) and snap the glass onto the mirror housing.

114700 ELECTRICAL SYSTEM:WIRING:CONNECTORS/PLUGS/RECEPTACLES

135200 VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR

060000 ENGINE AND ENGINE COOLING

Valve Body. These may cause over drive cycling.

060000 ENGINE AND ENGINE COOLING

NAG1 (5A580) Valve Body As per Warranty Bulletin D-13-22, please use R2108213A$ valve body for all Warranty (W), Mopar (M) and Mopar Vehicle Protection (F) claims.~ Assembly also includes Filter (52108325AA) and Gasket (52108332AA).~

118000 ELECTRICAL SYSTEM:SOFTWARE

FIAT CHRYSLER: TSB HAS AN OWNER NOTIFICATION LETTER. SELECT DOCUMENT SEARCH BUTTON BELOW. WHEN SHIFTING OUT OF CURRENT SELECTED MODE, FINAL DRIVE CONTROL MODULE (FDCM) SOFTWARE CAUSES SERVICE 4WD LIGHT TO ILLUMINATE AND SWITCHING OUT OF

140000 AIR BAGS

Customer Satisfaction Notification P73 Reprogram Final Drive Control Module The Final Drive Control Module (FDCM) software on about 295,600 of the above vehicles may cause the ?Service 4WD? light to come on and an inability to switch 4WD

110000 ELECTRICAL SYSTEM

Customer Satisfaction Notification P73 Reprogram Final Drive Control Module: The Final Drive Control Module (FDCM) software on about 295,600 of the above vehicles may cause the service 4WD light to come on and an inability to switch 4WD mod

104000 POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)

060000 ENGINE AND ENGINE COOLING

Part Description: 5.7L Long Block Issue Description: This 5.7L Long Block Assembly is compatible with both EGR and Non-EGR applications. An EGR Block-Off Plate (53032739AA) must be ordered when installing this Long Block Assembly in a

060000 ENGINE AND ENGINE COOLING

Part Description: Valve Body Assembly Issue Description: Valve body design was changed between 2010MY and 2011MY applications. To prevent mix matching valve bodies and solenoid packs the connectors are color coded.~ Valve bodies with

110000 ELECTRICAL SYSTEM

P41 Interim Repair Procedure Brazil ONLY Some Jeep Commander and Jeep Grand Cherokee vehicles may experience an unintended change in ignition switch position while driving which may result in loss of engine power, power steering, and bra

110000 ELECTRICAL SYSTEM

UConnect Hands Free Module Fails To Respond Due To Module Lock Up This bulletin involves replacing the Hands Free Module (HFM) if required. The HFM fails to operate causing the UConnect Hands Free Communications system to not respond when

100000 POWER TRAIN

4WD Lamp Illuminated and Diagnostic Trouble Code C140F Active in Final Drive Control Modules (FDCM) Memory This bulletin involves verifying FDCM software level and then flash reprogramming of the FDCM with new software. Customers may indi

118000 ELECTRICAL SYSTEM:SOFTWARE

SUMMARY TO BE PROVIDED ON A FUTURE DATE.

110000 ELECTRICAL SYSTEM

118000 ELECTRICAL SYSTEM:SOFTWARE

350000 EQUIPMENT

110000 ELECTRICAL SYSTEM

060000 ENGINE (PWS)

350000 EQUIPMENT

118000 ELECTRICAL SYSTEM:SOFTWARE

SUMMARY TO BE PROVIDED ON A FUTURE DATE.

100000 POWER TRAIN

110000 ELECTRICAL SYSTEM

Part Description: Actuator Motor

110000 ELECTRICAL SYSTEM

New Safety Recall Advanced Communication ? N23050813 Chrysler Group LLC (Chrysler) announced a safety recall on certain 2005 - 2010 model year (WK) Jeep Grand Cherokee and (XK) Jeep Commander vehicles equipped with a Quadra-Drive II or Qua

110000 ELECTRICAL SYSTEM

104000 POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)

110000 ELECTRICAL SYSTEM

350000 EQUIPMENT

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc

118000 ELECTRICAL SYSTEM:SOFTWARE

CHRYSLER/JEEP: FLASH: ESP SYSTEM MAY PREMATURELY ACTIVATE MOMENTARILY WHEN NEGOTIATING A CURVE OR MIL ILLUMINATION DUE TO DIAGNOSTIC TROUBLE CODE P0340, P0344 OR P0116. THIS INVOLVES SELECTIVELY ERASING AND REPROGRAMMING THE POWERTRAIN CON

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

063110 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)

POSITIVE CRANKCASE VENTILATION (PCV) SYSTEM FREEZES IN EXTREME COLD AMBIENT TEMPERATURES -- INVOLVES INSTALLING REVISED PCV SYSTEM COMPONENTS. *NJ

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

THIS BULLETIN INVOLVES SELECTIVELY ERASING AND REPROGRAMMING THE POWERTRAIN CONTROL MODULE (PCM) WITH NEW SOFTWARE. *NJ

061200 ENGINE AND ENGINE COOLING:ENGINE:DIESEL

3.0L DIESEL OIL FILTER CAP SERVICE. *NJ

061000 ENGINE AND ENGINE COOLING:ENGINE

ENGINE CRANKS BUT WILL NOT START AND APPLIES TO VEHICLES EQUIPPED WITH A 3.0L DIESEL ENGINE. *NJ

063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

THIS BULLETIN INVOLVES THE REPLACEMENT OF MECHANICAL CLIPS FOR THE INTAKE MANIFOLD RUNNER SWIRL VALVE LINKAGE. *NJ

120000 EXTERIOR LIGHTING

EXTERIOR LAMP - LENS FOGGING. *NJ

133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

FRONT DOOR WINDOW GLASS - LOOSE, STICKS, BINDS, OR EXPRESS - UP REVERSAL. *KB

061000 ENGINE AND ENGINE COOLING:ENGINE

MOMENTARY PREMATURE ACTIVATION OF THE TRACTION CONTROL SYSTEM. *KB

061000 ENGINE AND ENGINE COOLING:ENGINE

MIL ILLUMINATION DUE TO EGR POSITION SENSOR DTC - P0404, P0405, P0406. *KB

140000 AIR BAGS

PASSENGER AIR BAG DEACTIVATION. *KB

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

FLASH 42RLE - IMPROVED HILL CLIMB CAPABILITY IN REVERSE OR DIAGNOSTIC TROUBLE CODES (DTC) P1713/P1776. *KB

190000 TIRES

GOODYEAR EAGLE RSA EMT TIRES. *KB

131000 VISIBILITY:WINDSHIELD

CRACKED WINDSHIELD DUE TO BEING HIT BY A FOREIGN OBJECT LIKE A STONE. *KB

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

IDLE RPM FLARE COLD VEHICLE OPERATION-REVISED TRANSMISSION OIL FILL LEVEL. SOME VEHICLES MAY EXHIBIT SLIGHT IDLE FLARE AT LAUNCH. THIS MAY OCCUR DURING COLD 25 DEGREES TO 43 DEGREES TEMPERATURES AND IS MOST NOTICEABLE AFTER EXTENDED IDLING.

199000 TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

TIRE PRESSURE MONITOR SYSTEM INFORMATION. *KB

980000 UNKNOWN OR OTHER

REAR OF SUNROOF GLASS IS NOT FLUSH TO ROOF/SUNROOF WILL NOT CLOSE. *KB

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

POWERTRAIN CONTROL MODULE INITIALIZATION. *KB

103700 POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER

FLASH: ENHANCED TORQUE CONVERTER, GLOW PLUG, SKIM OPERATION. *AK

110000 ELECTRICAL SYSTEM

ENHANCED TORQUE CONVERTER AND GLOW PLUG OPERATION OR BRAKE SWITCH DTC P0504. *TT

350000 EQUIPMENT

STARSCAN@/STARMOBILE ABORT RECOVERY PROCEDURES. *TT

110000 ELECTRICAL SYSTEM

FLASH: MIL ILLUMINATION AT START-UP DUE TO DTC P2112 OR P1521. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION; A RATTLE-LIKE SOUND FROM THE TORQUE CONVERTER; AND INTERMITTENT TORQUE CONVERTER LOCK AND UNLOCK WHEN IN LOCK-UP MODE. *TT

180000 VEHICLE SPEED CONTROL

DRIVELINE NOISE DURING MODERATE TO HIGH THROTTLE ACCELERATION. *AK

062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM

HYDRAULIC RADIATOR COOLING FAN SYSTEM DIAGNOSTIC CHECK CHART AID. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

NAG1 (W5A580) TRANSMISSION - SHUDDER WHEN TORQUE CONVERTER CLUTCH ENGAGES. *TT

100000 POWER TRAIN

FLASH: 42RLE - IMPROVED HILL CLIMB CAPABILITY IN REVERSE OR DTC'S P1713 / P1776. *TT

010000 STEERING

STEERING ANGLE SENSOR (SAS) WHICH MAY CAUSE ONE OR MORE DIAGNOSTIC TROUBLE CODES - U0429, C1219, C123F, C1241 - REPAID RESPONSE TRANSMITTAL. *TT

162000 STRUCTURE:BODY

FRONT DOOR GLASS - LOOSE, STICKS, BINDS, MOAN-LIKE SOUND, OR EXPRESS-UP REVERSAL. *TT

121000 EXTERIOR LIGHTING:HEADLIGHTS

FRONT HEADLAMPS THAT MAY HAVE BEEN AIMED TOO HIGH - RAPID RESPONSE TRANSMITTAL. *TT

110000 ELECTRICAL SYSTEM

OUTSIDE AMBIENT TEMPERATURE READING INACCURATE AS DISPLAYED BY INSTRUMENT CLUSTER. *TT

090000 FUEL SYSTEM, OTHER

LOOSE FUEL CAP MESSAGE OR MALFUNCTION INDICATOR LAMP ILLUMINATION FOR DIAGNOSTIC TROUBLE CODE P0457 - EVAP SYSTEM - LOOSE FUEL CAP. *TT

110000 ELECTRICAL SYSTEM

FLASH TCM AND ECM TO IMPROVE TORQUE CONVERTER OPERATION. *TT

140000 AIR BAGS

DAIMLERCHRYSLER CORPORATION IS NOW OFFERING A PASSENGER AIRBAG DEACTIVATION WIRING PACKAGE. TO INCLUDE 2006 CHRYSLER TOWN AND COUNTRY AND 300/TOURING. *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

FLASH: ENGINE START AND DRIVE ABILITY AT ALTITUDE/BRAKE SWITCH DTC P0504. *AK

199000 TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

TIRE PRESSURE MONITOR - SYSTEM INFORMATION. *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

FLASH:MIL ILLUMINATION AT START-UP DUE TO DTC P2112 OR P1521. *AK

110000 ELECTRICAL SYSTEM

NO ENGINE CRANK - LOSS OF COMMUNICATIONS WITH FRONT CONTROL MODULE. *AK

015000 STEERING:HYDRAULIC POWER ASSIST SYSTEM

COLD TEMPERATURE INITIAL STARTUP - POWER STEERING WHINE-LIKE SOUND. *AK

111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

RAPID RESPONSE TRANSMITTAL SERVICE ACTION TEST AND REPLACE BATTERY AS NECESSARY. *TS

010000 STEERING

REVISED POWER STEERING SYSTEM BLEEDING PROCEDURES. *SC

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

AUTOMATIC TRANSMISSION DIAGNOSTIC TEARDOWN PROCEDURE. VARIOUS MODELS INCLUDING THE 2004 RAM TRUCK, DURANGO, SEBRING CONVERTIBLE, CHEROKEE, VISION, NEON, AND VOYAGER. *TT *SC

103600 POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES

CUSTOMER SATISFACTION NOTIFICATION E16 - TRANSMISSION COOLER RETURN FILTER. DELAYED ENGAGEMENT WHEN THE SHIFTER IS PLACED INTO GEAR AFTER THE ENGINE HAS BEEN OFF FOR MORE THAN 12 HOURS. *TT

100000 POWER TRAIN

45RFE/545RFE TRANS - DELAYED ENGAGEMENT DUE TO COOLER RETURN FILTER REPLACEMENT. *SC

100000 POWER TRAIN

RFE TRANSMISSION - DELAYED ENGAGEMENT AFTER AN EXTENDED OFF PERIOD. *SC

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

AIR CONDITIONING (A/C) COOLING COIL ODOR. *TT

102000 POWER TRAIN:MANUAL TRANSMISSION

CORRECT SHIFT TOWER SEALER APPLICATION TO PREVENT RESTRICTION OF VENT. *TT

100000 POWER TRAIN

NEW 42RLE VARIABLE LINE PRESSURE TRANSMISSION (VLP). *TT

NHTSA Safety Investigations, JEEP GRAND CHEROKEE

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

RQ, Open , Model Year: 2022

Recall 23V-413 Post Remedy Failures

On June 8, 2023, Fiat Chrysler Automobiles US, LLC (FCA) filed Safety Recall 23V-413 affecting certain 2022–2023 Jeep Grand Cherokee and2021–2023 Jeep Grand Cherokee L vehicles to address rear coil springs that may not have been properly installed during vehicle production. An improperly install... Read more

PE, Closed , Model Year: 2014

False Positive Automated Braking

On June 1, 2015, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE15-021 to investigate 9 complaints alleging incidents of unintended braking in model year (MY) 2014 Jeep Grand Cherokee vehicles, including 2 alleging incidents of full ABS braking.ODI expanded the scope to in... Read more

RQ, Closed , Model Year: 2002

Jeep inadvertent air bag deployment

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cher... okee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404Read more

PE, Closed , Model Year: 2012

Power steering hose failure

The Office of Defects Investigation (ODI) analyzed complaint data provided by Chrysler as well as complaints submitted to ODI from consumers. ODI's analysis identified a total of 24 unique reports indicating power steering hose blow-offs resulting from a dislodged power steering cooler turbulator fi... n in some early production vehicles.According to Chrysler, a dislodged fin can occur when the turbulator is inserted into the power steering cooler or loaded into the assembly machine.A dislodged fin may block the flow of power steering fluid creating excess back-pressure in the power steering system leading to the possibility of a return hose blow-off.Chrysler and its power steering cooler supplier, Dana, modified the cooler assembly process to address factors that may contribute to hose blow-offs. The redesigned turbulator assembly stations were completely implemented in production by April 2012.During PE12-020, Chrysler identified occurrences where the power steering return hose may blow-off at the power steering cooler.This is a condition that typically occurs early in the life of the vehicle with 65% occurring at less than 2,000 miles and 96% occurring with less than 8,000 miles. The data also shows that 88% of the conditions occurred with less than 4 months in service. Over 50% of the blow-off complaints occurred on vehicles with build dates between November 22, 2011 and December 23, 2011. None of the conditions occurred with more than 12,000 miles or 7 months in service. Chrysler?s complaint analysis indicates up-to 14 additional vehicles may experience the hose blow off condition.None of the 24 unique reports with the hose blow-off condition alleged smoke or fire in the engine compartment. In the event of a blow-off, it is highly unlikely for power steering fluid to reach any of the ignition sources in the engine compartment and result in an engine fire. Complaint analysis identified five reports alleging engine compartment fires that resulted from other or unknown causes, including one attributed to an overheated transmission fluid. Two fires of unknown cause cited in the opening resume for PE12-020 involved vehicles equipped with V8 SRT 6.4L engines which are not equipped with the steering system affected by the turbulator fin concern. ODI will continue to monitor field experience in Jeep Grand Cherokee vehicles equipped with that engine.There have been no reports of loss of steering control, crashes or injuries as result of this condition.Additionally, all affected vehicles that may have experienced a hose blow-off condition were repaired under Chrysler?s 3 year/36,000 mile manufacturer?s warranty at no cost to the owner and supplier?s process improvements put in place have eliminated the likelihood of power steering hose blow offs. There is no indication of loss of motive power or unreasonable safety risk associated with the alleged defect in the subject vehicles. This preliminary evaluation is closed.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers (ODI Nos.): 10465379, 10461736, 10459178.Read more

PE, Closed , Model Year: 1993

Crash Related Fuel Tank Fires

NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles inc... luded in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.Read more

DP, Closed , Model Year: 1993

Fuel Storage System Crash Related Fires

In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged t... hat the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.Read more

EA, Closed , Model Year: 2000

FAN BLADE FAILURE (ENGINE COOLING FAN)

DAIMLERCHRYSLER CORPORATION (DCC) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (06V199) OF CERTAIN JEEP GRAND CHEROKEE VEHICLES TO REPLACE THE ENGINE'S ELECTRIC MOTOR DRIVEN COOLING FAN. THE 182,875 VEHICLES INCLUDED IN THE RECALL ARE MODEL YEAR (MY) 2002 EQUIPPED WITH 4.0 LITER (SIX... Read more

PE, Closed , Model Year: 2002

ENGINE COOLING FAN BLADE FAILURE

THIS INVESTIGATION WAS OPENED ON JULY 13, 2005, BASED ON FOUR ODI CONSUMER REPORTS.ODI CONTACTED ALL OF THOSE COMPLAINANTS AND EACH OF THEM REPORTED THAT PIECES OF THE BROKEN FAN BLADE HAD DAMAGED THE RADIATOR AND PENETRATED THROUGH THE PROTECTIVE FAN SHROUD.SINCE OPENING THE INVESTIGATION, ODI HAS ... Read more

EA, Closed , Model Year: 1993

HOOD LATCH FAILURE

ODI OPENED EA02-029 TO DETERMINE WHETHER A SAFETY-RELATED DEFECT TREND EXISTED IN THE MY 1997 JEEP GRAND CHEROKEE HOOD LATCH ASSEMBLIES.DURING EA02-029, THERE WAS NO SPECIFIC FAILURE MECHANISM IDENTIFIED THAT COULD DIFFERENTIATE THE MY 1997 VEHICLES FROM OTHER VEHICLES CONTAINING THIS SAME HOOD LATC... Read more

PE, Closed , Model Year: 1996

HOOD LATCH

There is no summary currently available

EA, Closed , Model Year: 1993

ROLL-AWAY IN REVERSE WHEN PARKED

DAIMLERCHRYSLER HAS RECALLED THE ZJ MODELS TO INCORPORATE A SECONDARY DETENT SPRING INTO THE SHIFTER.EVEN THOUGH THE WJ 6 CYL. VEHICLES USE THE SAME MANUAL DETENT LEVER THAT AS THE VEHICLES IN THE RECALL POPULATION, ODI BELIEVES THAT THE WJ REDESIGNED SHIFTER, WHICH IMPROVES FLOOR SHIFTER FUNCTIONAL... Read more

PE, Closed , Model Year: 1995

INADVERTENT ROLLAWAY IN REVERSE PARK

DP, Closed , Model Year: 1993

VISCOUS COUPLING FAILURE

ALLEGED THAT THE VISCOUS COUPLING IN THE TRANSFER CASE OF HIS 1993 GRAND CHEROKEE VEHICLE FAILED WHICH AFFECTED STEERING, BRAKING AND STARTING OF THE VEHICLE.

EA, Closed , Model Year: 1993

QCK-CONNECT FUEL LINE FAIL

There is no summary currently available

EA, Closed , Model Year: 1993

FUEL TANK LEAKAGE

There is no summary currently available

PE, Closed , Model Year: 1994

QUICK-CONNECT FUEL LINE FAILURE

There is no summary currently available

PE, Closed , Model Year: 1993

STEERING SHAFT FAILURE

There is no summary currently available

PE, Closed , Model Year: 1993

FUEL TANK LEAKAGE

There is no summary currently available

PE, Closed , Model Year: 1993

REAR LIFTGATE LATCH

There is no summary currently available

JEEP GRAND CHEROKEE - All Years Overview

Complete safety history for the JEEP GRAND CHEROKEE across all model years (1993, 2026).

326 Total Recalls

40,113 Total Complaints

19 Investigations

2,820 Reported Crashes

845 Reported Fires

85 Reported Deaths

JEEP GRAND CHEROKEE - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2026	5	23	View
2025	3	136	View
2024	15	439	View
2023	20	681	View
2022	12	482	View
2021	12	670	View
2020	3	363	View
2019	7	544	View
2018	11	1,223	View
2017	6	566	View
2016	9	440	View
2015	10	1,768	View
2014	19	3,405	View
2013	10	1,117	View
2012	11	2,329	View
2011	6	2,425	View
2010	5	171	View
2009	3	195	View
2008	5	990	View
2007	7	1,478	View
2006 (current)	6	1,754
2005	5	2,733	View
2004	14	1,572	View
2003	10	890	View
2002	16	1,771	View
2001	10	1,128	View
2000	12	1,855	View
1999	10	2,319	View
1998	10	1,349	View
1997	11	1,433	View
1996	12	1,250	View
1995	11	983	View
1994	8	775	View
1993	12	784	View
1992	0	4	View
1991	0	7	View
1990	0	5	View
1989	0	7	View

Other JEEP Models

Model	Recalls	Complaints
WRANGLER	313	22,084	View
CHEROKEE	297	20,619	View
WAGONEER	96	662	View
LIBERTY	92	11,701	View
COMPASS	53	5,936	View
GRAND WAGONEER	53	298	View
GLADIATOR	45	1,287	View
RENEGADE	34	3,433	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2006 JEEP GRAND CHEROKEE

Complaint Statistics

Top Reported Components

Technical Service Bulletins, 2006 JEEP GRAND CHEROKEE

Most Affected Components

NHTSA Safety Investigations, JEEP GRAND CHEROKEE

JEEP GRAND CHEROKEE - All Years Overview

JEEP GRAND CHEROKEE - Year by Year

Other JEEP Models