EQUIPMENT
Defect Description
CURT MFG IS RECALLING CERTAIN CLASS 3 RECEIVER HITCHES, P/N 13347, SOLD AS AFTERMARKET EQUIPMENT FOR USE ON 1997-2007 CHRYSLER TOWN AND COUNTRY VANS, 1996-2007 DODGE CARAVANS, AND 1996-2004 PLYMOUTH VOYAGER VANS. WHEN THE HITCH IS LOADED TO THE MAXIMUM RATING, THE HITCH MAY FRACTURE OR BREAK AT THE
... BEND LOCATION WHERE THE MAIN BODY OF THE HITCH MEETS THE HITCH MUFFLER STRAP.Read moreConsequence
IF THE AREA IN QUESTION FRACTURES OR BREAKS, THIS COULD CAUSE AN UNSTABLE DRIVING CONDITION, POSSIBLY RESULTING IN A CRASH.
Remedy
CURT MFG WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE THE HITCH FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING AUGUST 2010. OWNERS MAY CONTACT CURT MFG AT 1-715-831-8713.
6,686 vehicles affected
Manufacturer: CURT MFG. INC.
VISIBILITY:GLASS, SIDE/REAR
Defect Description
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDER
... AL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."Read moreConsequence
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.
Remedy
SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER
... 'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.Read more1,657 vehicles affected
Manufacturer: SAFELITE FULFILLMENT, INC.
SERVICE BRAKES, HYDRAULIC
Defect Description
CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE
... MANUFACTURED FROM JULY 27, 2005 THROUGH JANUARY 17, 2006 (DATE CODES 0529 THROUGH 0602) ARE SUBJECT TO THIS RECALL. WHEN SUBJECT TO VERY COLD TEMPERATURES, AN INTERNAL SEAL IN THE MASTER CYLINDER COULD LOSE FLEXIBILITY AND MAY CAUSE BRAKE FLUID TO LEAK.Read moreConsequence
LOSS OF BRAKE FLUID CAN LEAD TO A DECREASE IN BRAKE LINE PRESSURE AND AN INCREASE IN STOPPING DISTANCE, WHICH CAN RESULT IN A VEHICLE CRASH.
Remedy
AFFINIA (BRAKE PARTS, INC.) WILL REPLACE THE SUBJECT BRAKE HYDRAULIC MASTER CYLINDERS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS CAN CONTACT AFFINA GROUP CUSTOMER SERVICE AT 1-800-323-0354.
7,440 vehicles affected
Manufacturer: BRAKE PARTS, INC.
AIR BAGS
Defect Description
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence
THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy
DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO
... REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.Read more955,344 vehicles affected
Manufacturer: DAIMLERCHRYSLER CORPORATION
FUEL SYSTEM, GASOLINE
Defect Description
CERTAIN AFTERMARKET REPLACEMENT FUEL FILTERS, MODELS WIX FILTER PART NUMBERS 33576, 33577, 33734; NAPA FILTER PART NUMBERS 3576, 3577, 3734; AND CARQUEST FILTER PART NUMBERS 86576, 86577, 86734 USED ON 1996-2000 DAIMLERCHRYSLER TOWN & COUNTRY, DODGE CARAVAN, AND PLYMOUTH VOYAGER VEHICLES, CAN CAUSE
... THE FUEL LINES TO LEAK.Read moreConsequence
A POSSIBLE FIRE CAN OCCUR IN THE PRESENCE OF AN IGNITION SOURCE.
Remedy
WIX WILL NOTIFY ITS CUSTOMERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. NOTE: THIS DOES NOT INVOLVE ANY PRODUCTS MANUFACTURED BY THE DAIMLERCHRYSLER CORP. NOR ANY DAILMERCHRYSLER DEALERS. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY
... WITHIN A REASONABLE TIME SHOULD CONTACT WIX AT 704-864-6711.Read more68,563 vehicles affected
Manufacturer: WIX FILTERATION PRODUCTS DIVISION
EQUIPMENT
Defect Description
AFTERMARKET REPLACEMENT FUEL FILTERS MANUFACTURED BETWEEN SEPTEMBER 17, 2002, AND JANUARY 20, 2003, SOLD UNDER THE BRAND NAMES LISTED ABOVE. THE FILTER MAY EXPERIENCE MALFUNCTION OF THE QUICK CONNECTOR EITHER BLOCKING FUEL FLOW TO THE ENGINE OR CAUSING A FUEL LEAK. THIS DOES NOT INVOLVE ANY PRODU
... CTS MANUFACTURED BY THE DAIMLERCHRYSLER CORP. NOR ANY DAILMERCHRYSLER DEALERS.Read moreConsequence
IF THIS CONDITION OCCURRED WHILE THE VEHICLE IS IN MOTION, THE ENGINE COULD STALL. ALSO, IN THE PRESENCE OF AN IGNITION SOURCE, THE FUEL LEAK COULD RESULT IN A VEHICLE FIRE.
Remedy
AFTERMARKET REPLACEMENT FUEL FILTERS FOR 1995-2000 SHORT WHEELBASE CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER AND DODGE CARAVAN MINIVANS PART NO. 18232 AND DATE CODE 0237, 0249, OR 0252. REPLACEMENT FUEL FILTERS FOR 1995-2000 LONG WHEELBASE CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER AND DODGE CARAV
... AN MINIVANS PART NO. 18230 AND DATE CODE 0237, 0249, 0251, OR 0304. REPLACEMENT FUEL FILTERS FOR 2001-2004 CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER AND DODGE CARAVAN MINIVANS PART NO. 28871 AND DATE CODE 0249. THESE PART NUMBERS AND DATE CODES APPEAR ON THE GOLD-TONE FILTER. DISTRIBUTORS AND RETAILERS WILL BE NOTIFIED TO ISOLATE AND RETURN AFFECTED INVENTORY. OWNERS WHO HAVE HAD THE FUEL FILTER SERVICED ON ONE OF THE APPLICABLE VEHICLES AFTER SEPTEMBER 17, 2002 SHOULD RETURN THEIR VEHICLE TO THE SERVICE FACILITY TO BE INSPECTED TO SEE IF THE FUEL FILTER THAT WAS INSTALLED IS ONE THAT IS INVOLVED IN THE RECALL. IF SO, THE OWNERS SHOULD HAVE THE FILTER REPLACED. TO RECEIVE A FULL REFUND PLUS THE COST OF POSTAGE, OWNERS SHOULD CUT THE CONNECTORS FROM THE HOSES, RINSE THE CONNECTORS AND RETURN THEM TOGETHER WITH PROOF OF THE AMOUNT PAID FOR THE REPLACEMENT PART AND LABOR, TO INTERCONTINENTAL AT INTERCONTINENTAL AUTO PARTS, INC., P.O. BOX 861, MAHWAH, NJ 07430, ATTN: FUEL FILTER RECALL. INTERCONTINENTAL WILL MAIL A FULL REFUND TO THE OWNER.Read more45,870 vehicles affected
Manufacturer: INTERCONTINENTAL AUTO PARTS
SEAT BELTS:REAR/OTHER
Defect Description
ON CERTAIN MINIVANS, SOME TRIM MATERIAL CAN LOOSEN AND DROP INTO THE REAR OUTBOARD SEAT BELT ASSEMBLY, CAUSING THE SEAT BELT TO BECOME INOPERATIVE.
Consequence
IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy
DEALERS WILL REPLACE THE TRIM WITH FOAM BLOCKERS AND INSPECT AND REPLACE ALL 3RD ROW SEAT BELT ASSEMBLIES. OWNER NOTIFICATION BEGAN JUNE 3, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOUL
... D CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.Read more545,311 vehicles affected
Manufacturer: DAIMLERCHRYSLER CORPORATION
SEAT BELTS:FRONT:RETRACTOR
Defect Description
VEHICLE DESCRIPTION: CERTAIN VAN, WAGON, PICKUP TRUCKS, PASSENGER AND SPORT UTILITY VEHICLES, FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE FRONT SEAT BELT RETRACTOR MAY NOT COMPLY WITH THE REQUIREMENTS OF THE STANDARD.
Consequence
IF THE RETRACTOR DOES NOT WORK PROPERLY, IT WILL NOT ADEQUATELY PROTECT OCCUPANTS IN THE EVENT OF A CRASH.
Remedy
DEALERS WILL REPLACE THE SEAT BELT RETRACTOR. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
161,682 vehicles affected
Manufacturer: DAIMLERCHRYSLER CORPORATION
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
Defect Description
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence
FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy
DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOT
... IFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.Read more1,163,000 vehicles affected
Manufacturer: DAIMLERCHRYSLER CORPORATION
Complaint Statistics
485 total complaints
21 crashes 32 fires 35 injuries 11 deaths
Top Reported Components
| Component | Complaints |
|---|
| SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER | 42 |
| AIR BAGS | 37 |
| POWER TRAIN:AUTOMATIC TRANSMISSION | 23 |
| WHEELS:RIM | 20 |
| ELECTRICAL SYSTEM | 20 |
| ELECTRICAL SYSTEM:HORN | 17 |
| ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS | 16 |
| AIR BAGS:FRONTAL | 12 |
| SUSPENSION | 12 |
| STEERING | 11 |
Incident date: Jun 1, 2018
Strut mounts are very rusty, the Chrysler recommended repair could not be done, due to extensive rust around the strut tower. This is confirmed by many other owners of this year and generation of vehicle. The vehicle is is good shape except for this and the problem was caused by a manufacturing defe
... ct which allowed rusting in the strut towers. This problem started happening approximately when it was just 10 years old or less and got worse and worse over the years. I have not driven it for many years because it seems very unsafe.Read more
Incident date: Jun 1, 2018
Strut mounts are very rusty, the Chrysler recommended repair could not be done, due to extensive rust around the strut tower. This is confirmed by many other owners of this year and generation of vehicle. The vehicle is is good shape except for this and the problem was caused by a manufacturing defe
... ct which allowed rusting in the strut towers. This problem started happening approximately when it was just 10 years old or less and got worse and worse over the years. I have not driven it for many years because it seems very unsafe.Read more
Incident date: Nov 2, 2019
THE HEATED SEAT ON THE DRIVER SIDE WAS HEATING UP SO HOT THAT IT WOULD BURN YOUR BOTTOM. NOW IT HAS SEIZES TO WORK EVEN WITH REPAIRS.
Incident date: Sep 16, 2019
AIR BAG LIGHT CONSTANTLY ON, NO HORN NO CRUISE CONTROL NO RADIO CONTROL. WENT TO DEALER FOR RECALL ON AIRBAG STEERING WHEEL CLOCK SPRING AND WAS TOLD I WOULD HAVE TO PAY FOR DIAGNOSTIC AND ALSO PAY FOR PART " IN CASE IT WAS NOT COVERED. THIS IS NOT HOW A SAFETY RECALL SHOULD BE PERFORMED TO MY UNDER
... STANDINGRead more
Incident date: Sep 16, 2019
AIR BAG LIGHT CONSTANTLY ON, NO HORN NO CRUISE CONTROL NO RADIO CONTROL. WENT TO DEALER FOR RECALL ON AIRBAG STEERING WHEEL CLOCK SPRING AND WAS TOLD I WOULD HAVE TO PAY FOR DIAGNOSTIC AND ALSO PAY FOR PART " IN CASE IT WAS NOT COVERED. THIS IS NOT HOW A SAFETY RECALL SHOULD BE PERFORMED TO MY UNDER
... STANDINGRead more
Incident date: Jul 6, 2019
THERE IS AN KNOWN ISSUE WITH TOWN&COUNTRY VAN B/T CERTAIN YEARS. I HAVE A 1999. WHEN WATER SPLASHES FROM THE ROAD OR RUNS OFF THE VEHICLE, THE WATER LANDS ON THE SERPENTINE BELT, AND CAUSES THE BELT TO SLIDE OFF. WHEN THE BELT SLIDES OFF, THE POWER STEERING FAILS TO SUCH A DEGREE THAT IT MAKES THE V
... EHICLE DIFFICULT TO MAINTAIN CONTROL. THERE IS A PATCH THAT CHRYSLER ISSUED, BUT NOT DID NOT DEEM IT A RECALL. I BELIEVE THIS ISSUE IS BAD ENOUGH THAT IT COULD CAUSE SIGNIFICANT PROBLEMS. I'VE HAD THIS HAPPEN SEVERAL TIMES. NOT DRIVING THROUGH PUDDLES, BUT JUST HAVING A WET ROAD CAN CAUSE (AND HAS CAUSED) AN ISSUE. THE FIX IS 400+$, WHICH IS RIDICULOUS CONSIDERING THAT THIS IS A KNOWN ISSUE THAT CHRYSLER CREATED A FIX FOR, BUT WON'T RECALL. I'VE REPLACED EVERY BELT, TENSIONER, PULLEY ETC, AND THE MECHANIC FRANKLY SAID ITS A KNOWN PROBLEM WITH CERTAIN YEARS OF TOWN & COUNTY.Read more
Incident date: Oct 1, 2016
MY PROBLEM IS IN THE IGNITION SWITCH, WHICH IS AFFECTING THE AIR CONDITIONER AND BLINKERS , AT THE SAME TIME , I TESTED THE VAN WHILE IT WAS RUNNING I MOVED THE IGNITION KEY AND THE AIR CONDITIONING AND BLINKERS WOULD WORK. STARTED WELL VAN WAS STATIONARY IN MY DRIVEWAY 10/1/2016.
Incident date: Sep 7, 2016
FUEL INJECTOR RAIL FAILURE. WOULD LIKE TO KNOW IF THERE WAS A RECALL ON THIS AND IF THE REPAIR IS COVERED UNDER A RECALL. GAS IS LEAKING FROM THE FUEL INJECTOR RAIL, AND VAN WAS CHUGGING. THANK YOU IN ADVANCE. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5
... U.S.C. 552(B)(6). *TRRead more
Incident date: Jul 12, 2016
WHEN I WENT TO VISIT MY WIFE AT THE NURSING HOME WHERE SHE IS, AFTER I GOT IN MY VAN TO GO HOME I ONLY MADE IT A COUPLE MILES THE GAUGES WENT GOOFY THEN THE MOTOR QUIT, I HAD NO CLUE A RELATIVE OWNS A WRECKER SERVICE SO HE CAME AND TOWED ME HOME. THE NEXT DAY I TRIED TO START IT BUT NO LUCK, WHEN I
... FIRST GOT THE VAN IT DID SOMETHING JUST LIKE THIS SO I FIGURED IT COULD BE THE BRAIN SO I GOT ONE AND PUT IT IN, NOTHING SO WHILE TURNING THE ENGINE OVER I DIDN'T HEAR THE FUEL PUMP SO I BOUGHT A REPLACEMENT. AFTER GOING THROUGH ALL OF THAT IT STILL WOULD TURN BUT NOT START A MECHANIC CAME OUT TO LOOK AT IT AND SEE IF HE COULD FIGURE OUT WHY IT DIDN'T START AFTER LOOKING AT IT HE SAID THAT IT WAS PROBABLY THE FUEL SHUT OFF RELAY, THAT'S WHERE IT IS,I NEED TO FIND WHERE THE CUTOFF RELAY IS LOCATED SO I CAN RESET IT.Read more
Incident date: Jul 6, 2015
I WAS DRIVING ON STREET AND BRAKES WENT OUT. DID NOT HIT ANYONE BUT HAD TO DRIVE TO SHOP DO TO NO BRAKES VERY SLOW. BRAKES LINE RUSTED OUT AND HAD TO REPLACE BRAKE LINES USED EMERGENCY BRAKE TO STOP AND GO. ALL PARTS OF VAN IS RUSTING FRAME THAT HOLDS MOTOR IN RUSTED AND CAN NOT TRADE IN DO TO DEALE
... R SAID IT IS A SAFETY FACTOR AND IT CAN NOT BE REPAIRED DO TO RUST.Read more
Incident date: Jul 6, 2015
I WAS DRIVING ON STREET AND BRAKES WENT OUT. DID NOT HIT ANYONE BUT HAD TO DRIVE TO SHOP DO TO NO BRAKES VERY SLOW. BRAKES LINE RUSTED OUT AND HAD TO REPLACE BRAKE LINES USED EMERGENCY BRAKE TO STOP AND GO. ALL PARTS OF VAN IS RUSTING FRAME THAT HOLDS MOTOR IN RUSTED AND CAN NOT TRADE IN DO TO DEALE
... R SAID IT IS A SAFETY FACTOR AND IT CAN NOT BE REPAIRED DO TO RUST.Read more
Incident date: Jul 6, 2015
I WAS DRIVING ON STREET AND BRAKES WENT OUT. DID NOT HIT ANYONE BUT HAD TO DRIVE TO SHOP DO TO NO BRAKES VERY SLOW. BRAKES LINE RUSTED OUT AND HAD TO REPLACE BRAKE LINES USED EMERGENCY BRAKE TO STOP AND GO. ALL PARTS OF VAN IS RUSTING FRAME THAT HOLDS MOTOR IN RUSTED AND CAN NOT TRADE IN DO TO DEALE
... R SAID IT IS A SAFETY FACTOR AND IT CAN NOT BE REPAIRED DO TO RUST.Read more
Incident date: Jul 20, 2016
WANTED TO TRADE VAN IN AND THEY TOLD ME DO TO SAFETY FACTORS COULD NOT TAKE IN ON A TRADE. SAID THAT THE RUST ON VAN UNDER CARRIAGE WAS SO BAD THAT MOTOR COULD FALL OUT AND IT WAS NOT WORTH TAKING IN ON A TRADE DO TO THIS PROBLEM
Incident date: Jul 20, 2016
WANTED TO TRADE VAN IN AND THEY TOLD ME DO TO SAFETY FACTORS COULD NOT TAKE IN ON A TRADE. SAID THAT THE RUST ON VAN UNDER CARRIAGE WAS SO BAD THAT MOTOR COULD FALL OUT AND IT WAS NOT WORTH TAKING IN ON A TRADE DO TO THIS PROBLEM
Incident date: Nov 23, 2015
TL* THE CONTACT OWNS A 1999 CHRYSLER TOWN AND COUNTRY. ON SEVERAL OCCASIONS, THE INSTRUMENT PANEL FAILED TO REMAIN ILLUMINATED. THE VEHICLE WAS NOT DAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 148,000.
Incident date: Jul 3, 2015
INSTRUMENT CLUSTER AND SPEDOMETER HAVE FAILED. WHILE DRIVING MY ENTIRE DASH WOULD TURN OFF. NO SPEDOMETER, NO TACHOMETER, NO FUEL, NOTHING. AFTER A MONTH OR TWO OF THIS HAPPENING ON AND OFF, MY SPEDOMETER STARTED GETTING INACCURATE. IT'S NOW AT ABOUT 37MPH OFF. WHEN I TURN MY CAR OFF, THE SPEDO
... METER GOES TO 0 (OR BELOW 0). WHEN I TURN MY KEY TO THE RIGHT, IT GOES TO 37MPH. WHILE I'M DRIVING 20, IT SHOWS 57MPH. IF I'M DRIVING 60MPH, IT SHOWS 97MPH. AFTER PERFORMING A GOOGLE SEARCH AND READING THROUGH SOME TECH BLOGS, WE'VE FOUND THIS IS A VERY COMMON PROBLEM WITH THE INSTRUMENT CLUSTER AND A BROKEN CIRCUIT THAT NEEDS TO BE SOLDERED. WE DID THAT AND HAVE NOT HAD THE PROBLEM WITH MY DASH INSTRUMENTS TURNING OFF SINCE THEN, BUT THE SPEDOMETER IS STILL NOT ACCURATE. WE TRIED DOING A SPEDOMETER RESET WHICH DID NOT RESOLVE THE ISSUE. I FEEL LIKE THERE ARE SO MANY PEOPLE THAT HAVE REPORTED THIS PROBLEM, AND IT IS UNSAFE FOR YOUR INSTRUMENT CLUSTER TO NOT BE FULLY FUNCTIONAL - THAT THIS SHOULD BE A RECALL. I KNOW PEOPLE WITH JEEPS AND DODGE VEHICLES THAT HAVE THE SAME PROBLEM. I AM SHOCKED THAT THIS IS NOT A RECALLED ISSUE AND CAN'T WAIT TO SELL THIS. I DEFINITELY WON'T MAKE THE MISTAKE OF PURCHASING JEEP/DODGE/CRYSLER AGAIN IF YOU'RE UNWILLING TO REPAIR THIS DEFECT FOR YOUR CUSTOMERS AT NO COST. AFTER A BRIEF SEARCH, I SEE NHTSA ID NUMBERS: 10253857, 10469302, 10192636, 10093722, 10195148, 10203097, 10093722, 10137954, AND 10062117 FILED WITH SAME OR SIMILAR PROBLEMS AS WELL AS ALL THE INFO I'VE FOUND ONLINE.Read more
Incident date: Jun 8, 2015
TL* THE CONTACT OWNS A 2009 CHRYSLER TOWN AND COUNTRY. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V373000 (AIR BAGS, ELECTRICAL SYSTEM); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL
... REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE VIN WAS UNKNOWN. THE CONTACT HAD NOT EXPERIENCED A FAILURE.Read more
Incident date: Jun 8, 2015
TL* THE CONTACT OWNS A 2009 CHRYSLER TOWN AND COUNTRY. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V373000 (AIR BAGS, ELECTRICAL SYSTEM); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL
... REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE VIN WAS UNKNOWN. THE CONTACT HAD NOT EXPERIENCED A FAILURE.Read more
Incident date: Oct 1, 2005
TL* THE CONTACT OWNS A 1999 CHRYSLER TOWN AND COUNTRY. ON OCCASION, THE VEHICLE WOULD NOT START. ALSO, WHILE DRIVING, THE HEADLIGHTS WOULD SUDDENLY SHUT OFF. FOR EACH FAILURE, THE CONTACT INDICATED THAT BANGING ON THE DASHBOARD WOULD RESOLVE THE ISSUES. THE VEHICLE WAS TAKEN TO THE DEALER ON MULTIPL
... E OCCASIONS AND THE BATTERY, STARTER, AND COMPUTER WERE REPLACED; HOWEVER, THE FAILURES CONTINUED. THE MANUFACTURER WAS NOTIFIED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 65,000.Read more
Incident date: Oct 1, 2005
TL* THE CONTACT OWNS A 1999 CHRYSLER TOWN AND COUNTRY. ON OCCASION, THE VEHICLE WOULD NOT START. ALSO, WHILE DRIVING, THE HEADLIGHTS WOULD SUDDENLY SHUT OFF. FOR EACH FAILURE, THE CONTACT INDICATED THAT BANGING ON THE DASHBOARD WOULD RESOLVE THE ISSUES. THE VEHICLE WAS TAKEN TO THE DEALER ON MULTIPL
... E OCCASIONS AND THE BATTERY, STARTER, AND COMPUTER WERE REPLACED; HOWEVER, THE FAILURES CONTINUED. THE MANUFACTURER WAS NOTIFIED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 65,000.Read more
Incident date: Jan 14, 2015
TL* THE CONTACT OWNED A 1999 CHRYSLER TOWN AND COUNTRY. THE CONTACT STATED THAT SMOKE EMITTED UNDER THE HOOD. WITHIN MINUTES, THE HOOD CAUGHT FIRE. THE FIRE DEPARTMENT WAS NOTIFIED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 34,000.
Fire
Incident date: Feb 16, 2015
LEAKING FUEL FROM FUEL RAIL IN FRONT OF MANIFOLD. THERE IS A VALID RECALL, YET CHRYSLER WOULD NOT COVER TOWING VEHICLE EVEN THOUGH THERE IS A DANGEROUS SITUATION WITH FUEL LEAKING ONTO THE ENGINE. I VERY MUCH BELIEVE THAT CHRYSLER SHOULD COVER TOWING. *TR
Incident date: Jan 20, 2015
THERE WAS NO INCIDENT YET. THE DRIVER'S SIDE UPPER STRUT BRACKET IS RUSTED ABOUT A 1/4 OF THE TOP SIDE. DON'T KNOW WHERE THE MOISTURE COULD HAVE COME FROM? THE SEALS ABOVE THAT AREA SEEM OK. COULDN'T FIND ANY PAST RECALLS FOR THIS ISSUE BUT, THE PASSENGER'S SIDE IS JUST FINE. AT THIS POINT THE INSU
... RANCE COMPANY WON'T COVER FIXING IT. AND AM NOT SURE WHAT COULD BE DONE? THIS IS MY MOM'S CAR AND THE INFORMATION BELOW IS MINE. *TRRead more
Incident date: Nov 16, 2014
I WAS DRIVING DOWN THE ROAD DOWN THE ROAD ON 11/16/14 AND THE SERPENTINE BELT CAM OFF GOING DOWN THE ROAD AND THE HEAD LIGHTS WENT DIM AND THE ENGINE WAS GOING TO OVER HEAT AND THE STEERING WHEEL WAS VERY HARD TO TURN SO I HAD TO PULL OVER AND PUT THE BELT BACK ON AND EVERY TIME I GO DOWN THE ROAD
... AND THE SERPENTINE BELT GETS WET IT COME OFF AND I HAVE TO FIX IT EVERY TIME I HIT A LITTLE WATER PUDDLE IT COME OFF AND I PUT ALL NEW PARTS AND I LOOKED ONLINE TO SEE IF ANY ONE HAD THE SAME PROBLEM LIKE I HAVE AND I SEEN MORE THEN 9,000 COMPLAINTS AND IM TIRED OF THE PROBLEM IT CAME OFF 10 TIMES THIS YEAR AND THE DEALER SAID THAT IS MISSED ALIGN EVEN THE MECHANICS SAID IT IS A COMMON PROBLEM. SO IF ANY ONE CAN DO SOME THING ABOUT IT PLEASE DO SOME THING BEFORE SOME ONE GETS VERY BAD HURT. *TRRead more
Incident date: Sep 26, 2012
TL* THE CONTACT OWNS A 1999 CHRYSLER TOWN AND COUNTRY. WHEN THE CONTACT ATTEMPTED TO START THE VEHICLE, THE ENGINE STALLED. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THE CAUSE OF THE FAILURE COULD NOT BE DIAGNOSED. THE VEHICLE WAS NOT REPAIRED.
... THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.Read more
Incident date: Feb 1, 2014
OUR VEHICLE HAS FAILED TO START ON 3 OCCASIONS. THE FIRST TIME WE HAD IT TOWED TO THE CHRYSLER DEALERSHIP. IT STARTED RIGHT UP FOR THEM AND THEY COULD FIND ANYTHING WRONG. IF YOU GOOGLE 1999 CHRYSLER TOWN & COUNTRY YOU WILL FIND MANY COMPLAINTS AND FEW SOLUTIONS. ONE PARTY HAS SPENT OVER $3000 A
... T THE DEALERSHIP AND STILL HAS THE PROBLEM. I AM NOT A MECHANIC BUT MY GUESS WOULD BE THERE IS A LOOSE SOLDERING JOINT ON ONE OF THE BOARDS. IT HAS TO DO WITH THE ALARM. THE CAR THINKS ITS BEING STOLEN SO IT CUTS THE ENGINE OFF. WHAT HAS WORKED FOR US (BELIEVE IT OR NOT) IS A GOOD HARD BANG ON THE TOP OF THE DASH. I AM FEARFUL OF DRIVING. I DON'T WANT TO GET STRANDED. THIS SHOULD DEFINITELY BE A RECALL AND CHRYSLER NEEDS TO ADDRESS THIS ISSUE. THE ALARM SET LIGHT COMES ON EACH TIME, SOMETIMES EVEN WHILE DRIVING! WE SHOULDN'T HAVE TO CROSS OUR FINGERS EVERY TIME WE GET IN THE VAN! CAN YOU TELL US HOW TO DISCONNECT THE ALARM SYSTEM? I THINK THAT WOULD BE A BAND-AIDE FIX TO THE PROBLEM BUT WE HAVE NOT BEEN ABLE TO FIND ANY INSTRUCTIONS. THE PROBLEM FIRST STARTED WITH THE HORN BLOWING FOR THE ALARM SPORADICALLY AND FOR NO REASON. WE TOOK OUT THE HORN FUSE TO PREVENT FURTHER INSTANCES WHICH POSES A SAFETY HAZARD. ITS OLD BUT LOW MILES AND SHOULD NOT HAVE THESE ISSUES. *TRRead more
Incident date: Aug 28, 2013
WHILE DRIVING VEHICLE TO AN APPT MY DAUGHTER STARTED COMPLAINING OF HER FEET BECOMING VERY HOT. SHE WAS SITTING IN THE PASSENGER FRONT SEAT, THERE WAS A BURNING ODOR. I PULLED OVER AND LOOKED UNDERNEATH THE VEHICLE, THE EXHAUST WAS CHERRY RED AND THERE WERE FLAMES NEAR CATALYTIC CONVERTER AREA. I
... HAD TO HAVE THE VAN TOWED HOME. *TRRead more
Fire
Incident date: Aug 28, 2013
I PURCHASED THIS VEHICLE IN AUGUST OF 2013 AND HAVE BEEN HAVING ONGOING PROBLEMS WITH THE ALARM SYSTEM. IT SHUTS THE VEHICLE DOWN AND WON'T LET IT START AGAIN FOR ANYWHERE FROM DAYS TO WEEKS LATER. I HAVE HAD A NEW COMPUTER PUT IN AND FLASHED BY THE CHRYSLER GARAGE BUT NOTHING AND NOONE SEEMS TO B
... E ABLE TO FIX THIS PROBLEM. IT MAKES THE VEHICLE TOTALLY UNRELIABLE AND A SAFETY HAZARD TO GET STRANDED ANYTIME. I HAVE BEEN DUMPING MONEY INTO THE VEHICLE FOR OVER A YEAR TRYING TO GET IT FIXED WITH NO LUCK. THIS SHOULD BE A RECALL ITEM THAT IS ADDRESSED AT THE EXPENSE OF THE COMPANY. THEY KNOW THIS PROBLEM EXISTS. *TRRead more
Incident date: May 26, 2014
DRIVING VAN IN THE RAIN, NOTICED THE STEERING BECAME EXTREMELY DIFFICULT. I ALSO NOTICED THAT THE LIGHTS AD POWER STARTED TO DIM. IN THAT CASE, I PULLED OVER TO SEE WHAT THE ISSUE WAS. I NOTICED THAT THE SERPENTINE BELT HAD COME OFF THE PULLEYS. I HAVE HAD OTHER MINI-VANS ESPECIALLY DODGES AND H
... AVE NOTICED THEY ALL SEEM TO DO THE SAME THING WHEN IT COMES TO RAIN, SNOW, ICE. YOU WOULD THINK THEY WOULD RESOLVE THIS ISSUE AS IT IS A SAFETY ISSUE. I'VE LEARNED FROM MY PREVIOUS DODGE CARAVANS HOW TO PUT THE SERPENTINE BELT BACK ON, BUT IT REALLY IS A SAFETY ISSUE AS THIS COULD LEAVE YOU STRANDED AND VERY COSTLY (MONEY AND TIME WISE) IF YOU DON'T KNOW HOW TO PUT IT BACK ON. AS A CONSUMER, I WILL NOT BE PURCHASING ANOTHER DODGE OR CHRYSLER MINIVAN AGAIN DUE TO THIS ISSUE! *TRRead more
Incident date: May 26, 2014
DRIVING VAN IN THE RAIN, NOTICED THE STEERING BECAME EXTREMELY DIFFICULT. I ALSO NOTICED THAT THE LIGHTS AD POWER STARTED TO DIM. IN THAT CASE, I PULLED OVER TO SEE WHAT THE ISSUE WAS. I NOTICED THAT THE SERPENTINE BELT HAD COME OFF THE PULLEYS. I HAVE HAD OTHER MINI-VANS ESPECIALLY DODGES AND H
... AVE NOTICED THEY ALL SEEM TO DO THE SAME THING WHEN IT COMES TO RAIN, SNOW, ICE. YOU WOULD THINK THEY WOULD RESOLVE THIS ISSUE AS IT IS A SAFETY ISSUE. I'VE LEARNED FROM MY PREVIOUS DODGE CARAVANS HOW TO PUT THE SERPENTINE BELT BACK ON, BUT IT REALLY IS A SAFETY ISSUE AS THIS COULD LEAVE YOU STRANDED AND VERY COSTLY (MONEY AND TIME WISE) IF YOU DON'T KNOW HOW TO PUT IT BACK ON. AS A CONSUMER, I WILL NOT BE PURCHASING ANOTHER DODGE OR CHRYSLER MINIVAN AGAIN DUE TO THIS ISSUE! *TRRead more
Incident date: Dec 9, 2013
TL* THE CONTACT OWNS A 1999 TOWN AND COUNTRY. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE BELT BECAME DETACHED FROM THE PULLEY SYSTEM, CAUSING THE POWER STEERING AND BRAKES TO FAIL. THE CONTACT STATED HE WOULD HAVE TO RECONNECT THE BELT WHENEVER IT BECAME DETACHED. THE FAILURE
... WAS RECURRING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE TENSION PULLEY SYSTEM NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 135,000. *TRRead more
Incident date: Aug 8, 2012
TL* THE CONTACT OWNS A 1999 CHRYSLER TOWN AND COUNTRY. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD STALL WITHOUT WARNING. THE CONTACT MENTIONED THAT THE VEHICLE WOULD IMMEDIATELY RESTART AFTER THE FAILURE BUT ALL THE GAUGES ON THE INSTRUMENT PANEL WOULD REMAIN OFF. THE
... VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 119,000 AND THE CURRENT MILEAGE WAS 178,000.Read more
Incident date: Jul 20, 2013
TL* THE CONTACT OWNS A 1999 CHRYSLER TOWN AND COUNTRY. THE CONTACT WAS DRIVING IN RAINY WEATHER AT APPROXIMATELY 55 MPH WHEN SHE TRAVELED OVER A PUDDLE OF WATER AND THE STEERING WHEEL SEIZED. THE BATTERY WARNING LIGHT AND THE KEY ICON ILLUMINATED. THE STEERING WHEEL BECAME EXTREMELY DIFFICULT TO TUR
... N AND THE CONTACT MOVED TO THE SIDE OF THE ROAD WHERE THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NEITHER DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 99,000.Read more
Incident date: Apr 29, 2013
WHEN I STARTED THE CAR THE ENGINE WAS COLD FROM SITTING IN THE DRIVEWAY ALL NIGHT. I SMELLED GASOLINE. I OPENED THE HOOD TO FIND GASOLINE SHOOTING OUT OF THE FUEL HOSE RIGHT WHERE IT FITS INTO THE PRESSED CRIMPED METAL CONNECTION. IT WAS SPRAYING GASOLINE ALL OVER THE ENGINE. I TURNED OF THE ENGINE
... BEFORE IT BECAME HOT. IF THIS LEAK HAD OCCURRED WHILE DRIVING, THE MOTOR WOULD HAVE BEEN HOT, AND CAUGHT FIRE. THE GARAGE REPLACED THE PLENUM GASKET SET, FUEL INJECTION, O RING, AND THE FUEL RAIL. NOTE: THE RECALL #RQ00008 DC MINIVAN FUEL INJECTOR RAIL LEAK WAS DONE. *TRRead more
Incident date: Nov 2, 2007
MY VEHICLE HAS BEEN GOING HAYWIRE. SOMETIMES THE LOCKS GOES UP AND DOWN BY ITSELF AND YOU CAN HEAR SOMETHING SORT OF LIKE A TAZER. THE ODOMETER BLINKS WHILE ALL OF THIS IS GOING ON. ALSO, I TOOK MY VAN TO THE SHOP AT SEARS BECAUSE WHEN I TURN THE SWITCH FOR AIR, IT ONLY WORKS ON HIGH AND NOT ALL
... THE TIME. THEY TOLD ME THAT SEEMS TO BE THE CASE WITH MANY OF THE TOWN AND COUNTRY VANS THAT COME IN THERE. ALSO THE PIPE THAT RUNS COOLANT TO THE BACK VENTS RUSTED OUT. AGAIN, AFTER RESEARCHING WITH MANY SHOPS, WAS TOLD THAT IT APPEARS THE SAME ISSUES ARE TAKING PLACE WITH THIS MODEL VAN. ALSO THERE IS A LOT OF RUST UNDERNEATH. NOT SURE AS TO HOW IT IS HAPPENING. I HAVE HAD TO REPLACE MY RADIATOR TWICE WITH THE LAST 6 YEARS AS IF SOMETHING IS RUSTING PARTS UNDERNEATH. I WILL BE VISITING MANY SHOPS AND HAVING THE OWNERS SIGN A PETITION AS TO WHAT ARE THE ONGOING ISSUES WITH THESE VEHICLES. I HAVE STARTED A BLOG AND I AM NOT THE ONLY PERSON WITH ISSUES WITH THIS VEHICLE. *TRRead more
Incident date: Nov 2, 2007
MY VEHICLE HAS BEEN GOING HAYWIRE. SOMETIMES THE LOCKS GOES UP AND DOWN BY ITSELF AND YOU CAN HEAR SOMETHING SORT OF LIKE A TAZER. THE ODOMETER BLINKS WHILE ALL OF THIS IS GOING ON. ALSO, I TOOK MY VAN TO THE SHOP AT SEARS BECAUSE WHEN I TURN THE SWITCH FOR AIR, IT ONLY WORKS ON HIGH AND NOT ALL
... THE TIME. THEY TOLD ME THAT SEEMS TO BE THE CASE WITH MANY OF THE TOWN AND COUNTRY VANS THAT COME IN THERE. ALSO THE PIPE THAT RUNS COOLANT TO THE BACK VENTS RUSTED OUT. AGAIN, AFTER RESEARCHING WITH MANY SHOPS, WAS TOLD THAT IT APPEARS THE SAME ISSUES ARE TAKING PLACE WITH THIS MODEL VAN. ALSO THERE IS A LOT OF RUST UNDERNEATH. NOT SURE AS TO HOW IT IS HAPPENING. I HAVE HAD TO REPLACE MY RADIATOR TWICE WITH THE LAST 6 YEARS AS IF SOMETHING IS RUSTING PARTS UNDERNEATH. I WILL BE VISITING MANY SHOPS AND HAVING THE OWNERS SIGN A PETITION AS TO WHAT ARE THE ONGOING ISSUES WITH THESE VEHICLES. I HAVE STARTED A BLOG AND I AM NOT THE ONLY PERSON WITH ISSUES WITH THIS VEHICLE. *TRRead more
Incident date: Jun 1, 2012
TL* THE CONTACT OWNS A 1999 CHRYSLER TOWN AND COUNTRY. THE CONTACT STATED THAT ONCE THE VEHICLE WAS STARTED, THE GEARS COULD BE SHIFTED WITHOUT THE CONTACT DEPRESSING THE BRAKES. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE THEY ADVISED HIM THAT THE BRAKE SHIFT INTERLOCK WAS NOT PLACED IN
... THAT PARTICULAR YEAR, MAKE AND MODEL VEHICLE. THEREFORE, THE FAILURE WAS CONSIDERED A NORMAL CHARACTERISTIC OF THE PARTICULAR VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 110,000. THE CURRENT MILEAGE WAS APPROXIMATELY 185,000.Read more
Incident date: Sep 8, 2012
MY 17 YEAR OLD SON WAS DRIVING THE CAR; HE APPLIED THE BRAKES WHILE APPROACHING A RED LIGHT AND THE PEDAL WENT TO THE FLOOR. HE WAS DRIVING SLOW ENOUGH AND STARTED BRAKING SOON ENOUGH THAT HE WAS ABLE TO STOP THE CAR PRIOR TO THE INTERSECTION BY PUMPING THE BRAKE PEDAL VIGOROUSLY. BOTH OF THE SOLI
... D FRONT BRAKE LINES HAD RUSTED OUT AT THE CONNECTION POINTS WITH THE FLEXIBLE HOSES... I HAD PREVIOUSLY REPLACED THE REAR BRAKE LINES DUE TO SIMILAR RUSTING PROBLEMS (3 YEARS AGO), AND DID ASK THE DEALER TO INSPECT THE FRONT BRAKE LINES ABOUT A YEAR AGO PRIOR TO LETTING MY SON DRIVE THE 'OLD' MINIVAN; THE BRAKE LINES WERE GIVEN A CLEAN BILL OF HEALTH... *TRRead more
Incident date: Apr 6, 2012
TL* THE CONTACT OWNS A 1999 CHRYSLER TOWN AND COUNTRY. THE CONTACT STATED THAT THE CLUSTER CIRCUIT BOARD ON THE INSTRUMENT PANEL FAILED. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THERE WAS AN OPEN CIRCUIT BOARD THAT CAUSED THE VEHICLE TO NOT START, WHICH NEEDED TO BE REPLACED. THE VEHICLE WAS N
... OT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 129,000.Read more
Incident date: Jul 28, 2012
THIS IS THE 2ND INCIDENT FOR THE SAME PROBLEM. FIRST COMPLAINT #10468365. I WAS STOPPED AT AN INTERSECTION. I CROSSED THE STREET AND MY TIRES SPLASHED WATER THAT WAS RUNNING DOWN THE STREET GUTTER. THE WATER WAS 2-4" DEEP. I ONCE AGAIN IMMEDIATELY LOST STEERING AND THE ENGINE BEGAN TO OVERHEA
... T. I WAS ABLE TO MUSCLE THE STEERING WHEEL ENOUGH TO PULL IT OFF TO THE SIDE OF THE ROAD. I LOOKED UNDER THE HOOD AND FOUND THE BELT HAD SLIPPED OFF AGAIN. I HAD TO HAVE IT TOWED TO THE GARAGE. THE MECHANIC CHECKED OUT THE BELT AND THE TENSIONER AND SAID THEY WERE OK, AND THEY REINSTALLED THE BELT. THE FIRST TIME THIS HAPPENED I WAS TURNING A CORNER, AND THE VAN WENT INTO THE OPPOSITE LANE. I GUESS I CAN BE THANKFUL FOR THE DRAUGHT THESE PAST FEW MONTHS. THIS IS A SERIOUS PROBLEM. IT MAKES ME AFRAID OF DRIVING WHEN IT IS RAINING OR WITH ANY WATER ON THE ROAD. I CAN'T IMAGINE WHAT WOULD HAPPEN ON THE INTERSTATE AT 70MPH, PASSING SOMEONE, OR TAKING A CURVE IN THE ROAD. I CONTACTED THE CHRYSLER DEALERSHIP. A BULLETIN #07-0299 WAS ISSUED IN 7.14.99. THE DEALERSHIP SAID I WOULD HAVE TO PURCHASE ANY FIXES AS IT WASN'T A RECALLED PROBLEM. THE DEALERSHIP TOLD MY MECHANIC THEY OFFERED A $400 KIT TO FIX THE PROBLEM, OR I COULD PURCHASE A "SNOW" SHIELD AND HAVE IT INSTALLED. WHY WOULD I NEED A "SNOW" SHIELD IN LOUISIANA? *TRRead more
Incident date: Mar 21, 2012
IT HAD BEEN RAINING BUT HAD STOPPED. I WAS MAKING A RIGHT HAND TURN WHEN MY RIGHT TIRE WENT THROUGH APPROXIMATELY 2-4" OF WATER IN THE GUTTER. I IMMEDIATELY LOST CONTROL OF THE STEERING AND VEERED INTO THE OPPOSITE LANE. FORTUNATELY THERE WERE NO CARS IN THAT LANE. I HAD DIFFICULTY STEERING AND
... THE ENGINE BEGAN TO OVERHEAT. I WAS FORTUNATE THE GARAGE WAS AROUND THE CORNER. THE BELT HAD SLIPPED OFF THE PULLEYS. THE BELT HAD NOT BROKEN, ONLY SLIPPED OFF. THEY SAID I WAS THE 3RD TOWN AND COUNTRY THAT DAY THAT HAD TO HAVE THE BELT PUT BACK ON DUE TO THE WET WEATHER, AND THAT IT WAS A PROBLEM WITH MODEL FOR MANY YEARS. THIS IS THE 3RD TIME TO SEND THIS REPORT. WHEN I HIT "VERIFY" EVERYTHING GOES BLANK. *TRRead more
Incident date: Jul 28, 2012
THIS IS THE 2ND INCIDENT FOR THE SAME PROBLEM. FIRST COMPLAINT #10468365. I WAS STOPPED AT AN INTERSECTION. I CROSSED THE STREET AND MY TIRES SPLASHED WATER THAT WAS RUNNING DOWN THE STREET GUTTER. THE WATER WAS 2-4" DEEP. I ONCE AGAIN IMMEDIATELY LOST STEERING AND THE ENGINE BEGAN TO OVERHEA
... T. I WAS ABLE TO MUSCLE THE STEERING WHEEL ENOUGH TO PULL IT OFF TO THE SIDE OF THE ROAD. I LOOKED UNDER THE HOOD AND FOUND THE BELT HAD SLIPPED OFF AGAIN. I HAD TO HAVE IT TOWED TO THE GARAGE. THE MECHANIC CHECKED OUT THE BELT AND THE TENSIONER AND SAID THEY WERE OK, AND THEY REINSTALLED THE BELT. THE FIRST TIME THIS HAPPENED I WAS TURNING A CORNER, AND THE VAN WENT INTO THE OPPOSITE LANE. I GUESS I CAN BE THANKFUL FOR THE DRAUGHT THESE PAST FEW MONTHS. THIS IS A SERIOUS PROBLEM. IT MAKES ME AFRAID OF DRIVING WHEN IT IS RAINING OR WITH ANY WATER ON THE ROAD. I CAN'T IMAGINE WHAT WOULD HAPPEN ON THE INTERSTATE AT 70MPH, PASSING SOMEONE, OR TAKING A CURVE IN THE ROAD. I CONTACTED THE CHRYSLER DEALERSHIP. A BULLETIN #07-0299 WAS ISSUED IN 7.14.99. THE DEALERSHIP SAID I WOULD HAVE TO PURCHASE ANY FIXES AS IT WASN'T A RECALLED PROBLEM. THE DEALERSHIP TOLD MY MECHANIC THEY OFFERED A $400 KIT TO FIX THE PROBLEM, OR I COULD PURCHASE A "SNOW" SHIELD AND HAVE IT INSTALLED. WHY WOULD I NEED A "SNOW" SHIELD IN LOUISIANA? *TRRead more
Incident date: Jul 28, 2012
THIS IS THE 2ND INCIDENT FOR THE SAME PROBLEM. FIRST COMPLAINT #10468365. I WAS STOPPED AT AN INTERSECTION. I CROSSED THE STREET AND MY TIRES SPLASHED WATER THAT WAS RUNNING DOWN THE STREET GUTTER. THE WATER WAS 2-4" DEEP. I ONCE AGAIN IMMEDIATELY LOST STEERING AND THE ENGINE BEGAN TO OVERHEA
... T. I WAS ABLE TO MUSCLE THE STEERING WHEEL ENOUGH TO PULL IT OFF TO THE SIDE OF THE ROAD. I LOOKED UNDER THE HOOD AND FOUND THE BELT HAD SLIPPED OFF AGAIN. I HAD TO HAVE IT TOWED TO THE GARAGE. THE MECHANIC CHECKED OUT THE BELT AND THE TENSIONER AND SAID THEY WERE OK, AND THEY REINSTALLED THE BELT. THE FIRST TIME THIS HAPPENED I WAS TURNING A CORNER, AND THE VAN WENT INTO THE OPPOSITE LANE. I GUESS I CAN BE THANKFUL FOR THE DRAUGHT THESE PAST FEW MONTHS. THIS IS A SERIOUS PROBLEM. IT MAKES ME AFRAID OF DRIVING WHEN IT IS RAINING OR WITH ANY WATER ON THE ROAD. I CAN'T IMAGINE WHAT WOULD HAPPEN ON THE INTERSTATE AT 70MPH, PASSING SOMEONE, OR TAKING A CURVE IN THE ROAD. I CONTACTED THE CHRYSLER DEALERSHIP. A BULLETIN #07-0299 WAS ISSUED IN 7.14.99. THE DEALERSHIP SAID I WOULD HAVE TO PURCHASE ANY FIXES AS IT WASN'T A RECALLED PROBLEM. THE DEALERSHIP TOLD MY MECHANIC THEY OFFERED A $400 KIT TO FIX THE PROBLEM, OR I COULD PURCHASE A "SNOW" SHIELD AND HAVE IT INSTALLED. WHY WOULD I NEED A "SNOW" SHIELD IN LOUISIANA? *TRRead more
Incident date: Mar 21, 2012
IT HAD BEEN RAINING BUT HAD STOPPED. I WAS MAKING A RIGHT HAND TURN WHEN MY RIGHT TIRE WENT THROUGH APPROXIMATELY 2-4" OF WATER IN THE GUTTER. I IMMEDIATELY LOST CONTROL OF THE STEERING AND VEERED INTO THE OPPOSITE LANE. FORTUNATELY THERE WERE NO CARS IN THAT LANE. I HAD DIFFICULTY STEERING AND
... THE ENGINE BEGAN TO OVERHEAT. I WAS FORTUNATE THE GARAGE WAS AROUND THE CORNER. THE BELT HAD SLIPPED OFF THE PULLEYS. THE BELT HAD NOT BROKEN, ONLY SLIPPED OFF. THEY SAID I WAS THE 3RD TOWN AND COUNTRY THAT DAY THAT HAD TO HAVE THE BELT PUT BACK ON DUE TO THE WET WEATHER, AND THAT IT WAS A PROBLEM WITH MODEL FOR MANY YEARS. THIS IS THE 3RD TIME TO SEND THIS REPORT. WHEN I HIT "VERIFY" EVERYTHING GOES BLANK. *TRRead more
Incident date: Mar 21, 2012
IT HAD BEEN RAINING BUT HAD STOPPED. I WAS MAKING A RIGHT HAND TURN WHEN MY RIGHT TIRE WENT THROUGH APPROXIMATELY 2-4" OF WATER IN THE GUTTER. I IMMEDIATELY LOST CONTROL OF THE STEERING AND VEERED INTO THE OPPOSITE LANE. FORTUNATELY THERE WERE NO CARS IN THAT LANE. I HAD DIFFICULTY STEERING AND
... THE ENGINE BEGAN TO OVERHEAT. I WAS FORTUNATE THE GARAGE WAS AROUND THE CORNER. THE BELT HAD SLIPPED OFF THE PULLEYS. THE BELT HAD NOT BROKEN, ONLY SLIPPED OFF. THEY SAID I WAS THE 3RD TOWN AND COUNTRY THAT DAY THAT HAD TO HAVE THE BELT PUT BACK ON DUE TO THE WET WEATHER, AND THAT IT WAS A PROBLEM WITH MODEL FOR MANY YEARS. THIS IS THE 3RD TIME TO SEND THIS REPORT. WHEN I HIT "VERIFY" EVERYTHING GOES BLANK. *TRRead more
Incident date: Mar 21, 2012
IT HAD BEEN RAINING BUT HAD STOPPED. I WAS MAKING A RIGHT HAND TURN WHEN MY RIGHT TIRE WENT THROUGH APPROXIMATELY 2-4" OF WATER IN THE GUTTER. I IMMEDIATELY LOST CONTROL OF THE STEERING AND VEERED INTO THE OPPOSITE LANE. FORTUNATELY THERE WERE NO CARS IN THAT LANE. I HAD DIFFICULTY STEERING AND
... THE ENGINE BEGAN TO OVERHEAT. I WAS FORTUNATE THE GARAGE WAS AROUND THE CORNER. THE BELT HAD SLIPPED OFF THE PULLEYS. THE BELT HAD NOT BROKEN, ONLY SLIPPED OFF. THEY SAID I WAS THE 3RD TOWN AND COUNTRY THAT DAY THAT HAD TO HAVE THE BELT PUT BACK ON DUE TO THE WET WEATHER, AND THAT IT WAS A PROBLEM WITH MODEL FOR MANY YEARS. THIS IS THE 3RD TIME TO SEND THIS REPORT. WHEN I HIT "VERIFY" EVERYTHING GOES BLANK. *TRRead more
Incident date: Nov 21, 2011
ON THIS DAY I WAS SITING IN MY VAN WITH THE IGNITION IN THE ON POSITION RESETTING MY CLOCKS IN THE VEHICLE I RESTED MY HAND ON THE SHIFTER WHEN IT RELEASED FROM PARK INTO REVERSE GEAR WITHOUT THE ENGINE RUNNING THERE ARE NO BRAKES BECAUSE OF POWER BRAKING YOU CANT STOP ON A DIME SO I QUICKLY ENGAGED
... THE PARKING BRAKE TO STOP THE VEHICLE FROM ROLLING DOWN MY DRIVE. I IMMEDIATELY CONTACTED CHRYSLER WHO CLAIMS THEY ARE NOT RESPONSIBLE FOR THIS ISSUE SINCE THEY DID NOT INSTALL THIS SAFTEY FEATURE ON ANY CHRYSLER TOWN AND COUNTRY VAN TO DATE ALSO I HAVE AN ISSUE WITH WHEN IT RAINS THE SERPENTINE BELT FALLS OFF THE PULLEYS IF WATER SPLASHES UP ONTO THE BELT ITSELF CAUSING LOSS OF BRAKES AND STEERING DUE TO THIS DEFECT CHRYSLER IS AWARE OF THIS ISSUE BUT AGAIN REFUSES TO RECALL THE VEHICLES FOR A SAFER FIX SOMETHING NEEDS TO BE DONE BEOFE THEY KILL SOMEONE. *TRRead more
Incident date: Nov 21, 2011
ON THIS DAY I WAS SITING IN MY VAN WITH THE IGNITION IN THE ON POSITION RESETTING MY CLOCKS IN THE VEHICLE I RESTED MY HAND ON THE SHIFTER WHEN IT RELEASED FROM PARK INTO REVERSE GEAR WITHOUT THE ENGINE RUNNING THERE ARE NO BRAKES BECAUSE OF POWER BRAKING YOU CANT STOP ON A DIME SO I QUICKLY ENGAGED
... THE PARKING BRAKE TO STOP THE VEHICLE FROM ROLLING DOWN MY DRIVE. I IMMEDIATELY CONTACTED CHRYSLER WHO CLAIMS THEY ARE NOT RESPONSIBLE FOR THIS ISSUE SINCE THEY DID NOT INSTALL THIS SAFTEY FEATURE ON ANY CHRYSLER TOWN AND COUNTRY VAN TO DATE ALSO I HAVE AN ISSUE WITH WHEN IT RAINS THE SERPENTINE BELT FALLS OFF THE PULLEYS IF WATER SPLASHES UP ONTO THE BELT ITSELF CAUSING LOSS OF BRAKES AND STEERING DUE TO THIS DEFECT CHRYSLER IS AWARE OF THIS ISSUE BUT AGAIN REFUSES TO RECALL THE VEHICLES FOR A SAFER FIX SOMETHING NEEDS TO BE DONE BEOFE THEY KILL SOMEONE. *TRRead more
Incident date: Nov 21, 2011
ON THIS DAY I WAS SITING IN MY VAN WITH THE IGNITION IN THE ON POSITION RESETTING MY CLOCKS IN THE VEHICLE I RESTED MY HAND ON THE SHIFTER WHEN IT RELEASED FROM PARK INTO REVERSE GEAR WITHOUT THE ENGINE RUNNING THERE ARE NO BRAKES BECAUSE OF POWER BRAKING YOU CANT STOP ON A DIME SO I QUICKLY ENGAGED
... THE PARKING BRAKE TO STOP THE VEHICLE FROM ROLLING DOWN MY DRIVE. I IMMEDIATELY CONTACTED CHRYSLER WHO CLAIMS THEY ARE NOT RESPONSIBLE FOR THIS ISSUE SINCE THEY DID NOT INSTALL THIS SAFTEY FEATURE ON ANY CHRYSLER TOWN AND COUNTRY VAN TO DATE ALSO I HAVE AN ISSUE WITH WHEN IT RAINS THE SERPENTINE BELT FALLS OFF THE PULLEYS IF WATER SPLASHES UP ONTO THE BELT ITSELF CAUSING LOSS OF BRAKES AND STEERING DUE TO THIS DEFECT CHRYSLER IS AWARE OF THIS ISSUE BUT AGAIN REFUSES TO RECALL THE VEHICLES FOR A SAFER FIX SOMETHING NEEDS TO BE DONE BEOFE THEY KILL SOMEONE. *TRRead more
Incident date: Jan 20, 2012
I OWN A 1999 CHRYSLER TOWN & COUNTRY VAN. MAJOR PROBLEM IS SERPENTINE BELT COMING OFF AND CAUSING A LOSS OF STEERING. EVERY TIME IT RAINS MY SERPENTINE BELT COMES OFF WHICH CAUSES EXTREMELY HARD STEERING. I HAVE REPLACED TENSIONERS TWICE IN THE AND BELT 4 TIMES. THANK GOD I WAS NOT ON THE FREE WAY
... OR A STREET WITH ALOT OF TRAFFIC OR THIS COULD KILL ME OR AN OTHER PERSON. I HAVE LOOKED ON THE INTERNET AND THIS HAS HAPPENED TO 100S OF PEOPLE. ON THE INTERNET IT STATE THAT THE FACTORY RECOMMENDED REPAIR ( THE REPLACEMENT OF THE IDLER PULLEY AND THE PULLEYS RETAINING BRACKET.) IN THE TSB I READ, CHRYSLER'S ENGINEERS HAVE DECIDED THAT ON SOME MODELS THE IDLER PULLEY IS MISALIGNED BY .08 INCHES. CHRYSLER SHOULD RECALL THIS AND FIX THERE PROBLEM BEFORE SOMEONE GETS KILLED. GET INVOLVED AND MAKE CHRYSLER FIX THIS PROBLEM. *TRRead more
Showing 50 of 485 complaints.
NHTSA Safety Investigations — CHRYSLER TOWN AND COUNTRY
Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.
PE — Closed
— Model Year: 2016
Sliding Doors Inoperative
The Office of Defects Investigation (ODI) opened PE21-016 on July 7, 2021, to investigate 364 complaints alleging that one or both sliding doors on 2016 Model Year (MY) Grand Caravan or Town and Country vehicles could not be opened. The door(s) could not be opened using the mechanical handle or elec
... tronic remote switches. Many of the complaints described having to remove passengers seated in the rear of vehicles through the front doors, the second sliding door (if it was operational), the window, or the car?s rear hatch. The complainants have expressed concerns that if the sliding door(s) cannot be opened in the event of an emergency or crash, it could trap passengers or delay their egress.On June 4, FCA published TSB# 23-017-20 instructing dealers to replace the door lock actuator instead of the entire door latch assembly on the subject vehicles when consumers complained about either one or both of the sliding door locks not functioning and/or emitting a loud buzzing noise during lock/unlock operation. On June 16, 2021, FCA approved a Quality Warranty Extension for fifteen years/150,000 miles from the vehicle's in-service date for sliding door lock actuators on vehicles built between May 1, 2015, through January 9, 2017. FCA has started notifying owners about the new program. FCA will provide reimbursement for owners who previously paid for sliding door repairs.Consumers whose sliding doors are inoperative will have the opportunity to have their vehicle diagnosed, and if a fault is identified, have the sliding door actuator repaired at no charge.Analysis of the FCA IR response and ODI complaint data found that the majority (96%) of sliding door failures occurred prior to the calendar year 2020 when the subject vehicles had approximately 4 years in service. At the time of the closing of this investigation, 99% of the subject vehicles are passed the age where failures typically occur. The number of new reports has been decreasing since 2020 and further reduced following the FCA Warranty Extension program. ODI found that prior to a failure of the sliding door(s) there is normally a loud buzzing noise/sound generated that alerts the operator to the actuator starting to wear out.ODI has not identified any crashes or injury allegations due to the sliding door being inoperable on the subject vehicles following nearly six years of exposure. ODI will continue to monitor complaints received for the incidence of sliding doors becoming inoperative.Accordingly, the investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.For a complete summary of this investigation and related consumer complaints, please see attached closing resume document.Read more
PE — Closed
— Model Year: 2014
Interior Vehicle Fire
On August 6th, 2020, the Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE20-012) to investigate alleged thermal events, and/or vehicle fires originating at the charge hub in 2014 Chrysler Town and Country minivans manufactured by Fiat Chrysler Automobiles (FCA). While the
... investigation was focused on the 2014 Chrysler Town and Country vehicles, the scope of the investigation was expanded to include the 2013-2020 Chrysler Town and Country, and Dodge Grand Caravan vehicles (the RT Platform).During the investigation ODI sent two separate Information Request letters to the manufacturer. One on August 17th, 2020 and one on March 31st, 2021.ODI identified a subject 2014 Chrysler Town and Country van on a vehicle salvage website that appeared to have experienced a thermal event where the charge hub is located. With the help of the NHTSA's Vehicle Research and Test Center (VRTC), ODI purchased the vehicle from the salvage company to inspect the damage and determine if more information about the failure could be obtained. A joint inspection with the manufacturer was conducted. Following this comprehensive inspection, a cause of the fire could not be determined.FCA initiated a parts collection initiative to obtain parts from the field for testing. The test results from the FCA field parts collection were inconclusive as they could not identify a common cause for the alleged thermal events. FCA looked at multiple liquid solutions that could have entered the charge hub circuit and caused it to short out, potentially leading to a fire. FCA also performed testing where the charge hub circuit was shorted out using a wire to observe if a flame or fire was produced. FCA provided their assessment to ODI concluding that none of the testing methods performed lead to a flame or fire being propagated.Given the low rate of thermal incidents at the subject vehicle charge hub, no reports of serious injury, zero reports of crash or death, and a lack of common failure mode, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves the right to take further action if warranted by the circumstances.Read more
RQ — Closed
— Model Year: 2010
Air Bag Non-Deployment/Engine Stall
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The repor
... t identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972Read more
PE — Closed
— Model Year: 2005
FRONT AIR BAG CRASH SENSOR FAILURE
THE MODEL YEAR (MY) 2005 DAIMLERCHRYSLER (DC) MINIVANS HAVE THE NEW ADVANCED FRONTAL AIR BAG SYSTEMS WITH TWO FRONT CRASH SENSORS MOUNTED ON THE FRAME RAILS BEHIND THE FRONT BUMPER AND A MAIN CRASH SENSOR INSIDE THE AIR BAG CONTROL MODULE MOUNTED IN THE PASSENGER COMPARTMENT.ACCORDING TO DC, THE FRO
... NT CRASH SENSORS ARE DESIGNED TO OPTIMIZE DETECTION OF FRONTAL OFFSET AND ANGULAR CRASHES.THE ADVANCED AIR BAG SYSTEM OFFERS DIFFERENT LEVELS OF AIR BAG INFLATION BASED ON INPUT FROM THE CRASH SENSORS.THIS INVESTIGATION REVEALED THAT THE FRONT CRASH SENSORS CAN CORRODE FROM WATER ENTERING THE SENSOR ASSEMBLY.DC IS STILL INVESTIGATING ALL POTENTIAL ROOT CAUSES OF SENSOR FAILURES.A CORRODED SENSOR CAN SET A FAULT CODE, ILLUMINATE THE AIR BAG WARNING LAMP, AND BECOME DISABLED.IT APPEARS THAT FAILURE OF ONE OR BOTH FRONT CRASH SENSORS CAN POTENTIALLY RESULT IN NO/LATE DEPLOYMENT OF FRONTAL AIR BAGS AND NON-DEPLOYMENT OF DRIVER'S HIGHER INFLATION LEVELS IN CERTAIN FRONTAL CRASHES.IT SHOULD BE NOTED THAT OCCUPANTS OF VEHICLES INVOLVED IN A CRASH MAY NOT BE AWARE OF LATE OR IMPROPERLY REDUCED LEVEL OF AIR BAG INFLATION AND THUS FIELD REPORTING OF SUCH EVENTS MAY BE SUPPRESSED.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-003) FOR FURTHER INVESTIGATION OF MY 2005 (AND 2006) DC MINIVANS.NOTE: TOTAL NUMBER OF ODI AND MANUFACTURER COMPLAINTS INCLUDES SOME DUPLICATE REPORTS.Read more
EA — Closed
— Model Year: 2001
POWER LIFTGATE LATCH
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL
... 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.Read more
PE — Closed
— Model Year: 2003
POWER LIFTGATE LATCH
THIS INVESTIGATION WAS OPENED ON JULY 30, 2004, BASED ON ODI CONSUMER COMPLAINTS ALLEGING UNWANTED OPENING OF THE VEHICLE'S POWER LIFTGATE (PLG) WHILE DRIVING.IN DAIMLERCHRYSLER CORPORATION (DCC)'S SEPTEMBER 17, 2004 RESPONSE TO ODI' S INFORMATION REQUEST LETTER, IT PROVIDED ADDITIONAL CONSUMER COMP
... LAINTS AND LAWSUITS.DCC STATES IN PART, ...THE PLG LATCH BECOMES STUCK IN A SEMI-CLOSED STATE NOT ALLOWING THE PLG LATCH TO ENGAGE THE STRIKER, THUS NOT CLOSING THE LIFTGATE COMPLETELY.IN THIS CONDITION THE PLG AJAR WARNING LIGHT WILL NOT BE ILLUMINATED AND THE PLG CAN RISE (NOT A POWERED OPEN) WHILE DRIVING. THIS INVESTIGATION HAS BEEN UPGRADED TO EA04-031 FOR FURTHER ANALYSIS.Read more
PE — Closed
— Model Year: 1999
OVERHEATING OF SEAT HEATERS
ODI OPENED THIS INVESTIGATION BASED ON 24 COMPLAINTS ALLEGING THAT THE ELECTRICALLY HEATED DRIVER OR PASSENGER SEAT SPARKS/OVERHEATS.DAIMLERCHRYSLER BELIEVES THE FAILURE IS DUE TO ONE OF TWO FACTORS:THE STITCHING OPERATION ON THE SEAT COVER MAY CAUSE THE SEWING NEEDLE TO SEVER SOME STRANDS OF THE WI
... RE HEATING GRID IN THE SEAT, OR A POOR SOLDER JOINT/WIRE CONNECTOR FAILS DUE TO IMPROPER PROCESSING OR LONG TERM OVERSTRESSING.THE IGNITION SWITCH AND THE SEAT HEATER SWITCH MUST BOTH BE TURNED ON TO POWER THE SEAT HEATER.COMPLAINANTS REPORT THAT WHEN OVERHEATING OCCURS, SWITCHING THE HEATER OFF ALSO STOPS THE OVERHEATING.THE FAILURE CANNOT OCCUR IN AN UNATTENDED VEHICLE WITH THE IGNITION SWITCH OFF.ODI FINDS THAT THE 33 FIRE ALLEGATIONS ARE REPORTING VERY LOCALIZED OVERHEATING(PHOTOS OF DAMAGED SEATS SHOW HOLES THE SIZE OF A PENCIL OR LESS).THERE ARE NO REPORTS OF SUSTAINED COMBUSTION AND NO REPORTS OF OTHER FIRE DAMAGE TO THE VEHICLE.THE INJURY ALLEGATIONS ARE REPORTING MINOR INJURY.NO CONSUMERS REQUIRED MEDICAL TREATMENT (PHYSICIAN CARE).THERE ARE NO ALLEGATIONS OF LOSS OF VEHICLE CONTROL DUE TO FAILURE OF A HEATED SEAT.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.Read more
PE — Closed
— Model Year: 1999
OVERHEATING OF FRONT SEAT HEATERS
ALLEGE THAT THE FRONT SEATS OVER HEAT AND SMOKE OR CATCH FIRE
EA — Closed
— Model Year: 1998
POST COLLISION FUEL SYSTEM
EA — Closed
— Model Year: 1994
INADVERTENT AIR BAG DEPLOYMENTS
COMPLAINTS ALLEGE THAT THE FRONT AIR BAG (S) DEPLOYED INADVERTENTLY--IN MOST CASES WHILE STARTING THE VEHICLE.
PE — Closed
— Model Year: 1994
INADVERTENT AIR BAG DEPLOYMENTS
COMPLAINTS ALLEGE THAT THE SUBJECT VEHICLES' AIR BAGS DEPLOYED INADVERTENTLY (IN MOST CASES WHEN STARTING THE VEHICLE).
EA — Closed
— Model Year: 1992
SAFETY BELT ANCHORAGE FAILURES
There is no summary currently available
PE — Closed
— Model Year: 1992
WINDSHIELD WIPER FAILURE
ALLEGED WINDSHIELD WIPERS FAIL WHILE IN USE
DP — Closed
— Model Year: 1992
WINDSHIELD WIPER FAILURE
CFAS PETITIONED THE AGENCY TO CONDUCT A DEFECT INVESTIGATION ON WINDSHIELD WIPER FAILURE ON 1989 AND LATER CHRYSLER MODELS WHICH SHOULD INCLUDE, BUT NOT LIMITED TO SPIRIT/ACCLAIM: DYNASTY/NEW YORKER/LANDAU; LANCE/LEBARON; SHADOW/SUNDANCE; CARAVAN/VOYAGER.HOWEVER, BASED ON ODI'S COMPLAINT RECORDS, ON
... LY CERTAIN MINIVANS WILL BE INVESTIGATEDRead more
EA — Closed
— Model Year: 1997
INTEGRATED CHILD SEAT BELT LOCKUP
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
PE — Closed
— Model Year: 1996
SLIDING DOOR LATCH FAILURE
CHRYSLER MAINTAINS THAT THE COMMON FACTOR CONTRIBUTING TO KNOWN SLIDING DOOR OPENING INCIDENTS IS PRIOR INCORRECT DEALER LATCH ADJUSTMENT.CHRYSLER ATTRIBUTES THIS PROBLEM TO AN INACCURATE SERVICE MANUAL PROCEDURE - SLIDING DOOR LATCH/LOCK CONTROL, REMOVAL AND INSTALLATION.CHRYSLER FURNISHED INFORMAT
... ION SHOWING THAT SIX OF ITS COMPLAINTS, AND TWO OF ODI'S, INVOLVED VEHICLES THAT HAD UNDERGONE PRIOR REPAIRS TO THE AFFECTED SLIDING DOOR.CHRYSLER HAS ADDRESSED THE PROBLEM BY ISSUING TWO TECHNICAL SERVICE BULLETINS.TSB 26-06-96, SERVICE MANUAL REVISIONS, WAS ISSUED IN JUNE 1996 AND INCLUDES A SERVICE REVISION (#81-370-6105A) CORRECTING SERVICE MANUAL SLIDING DOOR REPAIR PROCEDURES.TSB 23-39-96, SLIDING DOOR(S) DIFFICULT TO OPEN FROM THE OUTSIDE AND/OR INSIDE, WAS ISSUED JUNE 28, 1996.CHRYSLER IDENTIFIED THREE DESIGN CHANGES INVOLVING THE SUBJECT COMPONENTS: (1)SLIDING DOOR LATCH PAWL SPRING FORCE INCREASED FROM 5.4 NEWTONS TO 8.0 NEWTONS IN SEPTEMBER 1995 TO ENHANCE PAWL ROTATION RETURN TO NEUTRAL POSITION; (2)ADJUSTABLE SLIDING DOOR HINGE IMPLEMENTED IN NOVEMBER 1995 TO REDUCE VARIATION IN SLIDING DOOR FIT; AND(3)SLIDING DOOR STRIKER ATTACHMENT HOLES REVISED IN JANUARY 1996 TO ELIMINATE UP/DOWN ADJUSTMENT OF STRIKER TO IMPROVE INSTALLATION PROCESS AND REDUCE VARIABILITY OF ALIGNMENT BETWEEN LATCH AND STRIKER.AT PRESENT, ODI IS NOT AWARE OF ANY INCIDENTS INVOLVING VEHICLES BUILT IN OR AFTER JANUARY 1996.ODI HAS CONTINUED TO RECEIVE COMPLAINTS OF SLIDING DOORS OPENING WHILE THE VEHICLES ARE IN MOTION, INCLUDING VEHICLES WITH NO PRIOR SERVICE HISTORY TO THE AFFECTED SLIDING DOOR ASSEMBLY.OWNERS ALLEGE THAT THE DOORS OPEN ANYWHERE FROM A FEW INCHES TO FULLY OPEN, AT SPEEDS RANGING FROM 15 TO 60 MPH.ODI HAS ALSO RECEIVED NUMBEROUS COMPLAINTS ALLEGING DIFFICULTY IN LATCHING THE SUBJECT SLIDING DOORS AND/OR DIFFICULTY IN OPENING ONE OR BOTH SLIDING DOORS.Read more
PE — Closed
— Model Year: 1996
FUEL LEAKEAGE FROM ROLLOVER VALVE
There is no summary currently available