ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY
Defect Description
Chrysler (FCA US, LLC) is recalling certain 2020-2025 Jeep Wrangler 4Xe and 2022-2026 Grand Cherokee 4Xe vehicles. The high voltage battery may fail internally and lead to a vehicle fire while parked or driving.
Consequence
A vehicle fire can increase the risk of injury.
Remedy
Owners are advised to park outside and away from structures and not to charge their vehicles until the remedy is completed. Dealers will update the high voltage battery software, and replace the high voltage battery, as necessary, free of charge. Some owner notification letters were mailed beginning
... December 17, 2025. The remaining owner notification letters will be mailed at a later date. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 68C. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning November 6, 2025. Vehicles that were previously recalled for the same issue under NHTSA Recalls 24V720 and 23V787 will need to have the new remedy performed.Read more320,068 vehicles affected
Manufacturer: Chrysler (FCA US, LLC)
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Defect Description
Chrysler (FCA US, LLC) is recalling certain 2018-2024 Jeep Wrangler vehicles. The wiring harness for the rearview camera and the center brake light may short circuit, which can disable the rearview camera image and center brake light. As such, these vehicles fail to comply with the requirements of
... Federal Motor Vehicle Safety Standard numbers 111, "Rear Visibility" and 108, "Lamps, Reflective Devices, and Associated Equipment."Read moreConsequence
A rearview camera image that does not display decreases the driver's visibility, increasing the risk of a crash. Additionally, a center brake light that fails to illuminate can fail to indicate to other drivers that the vehicle is slowing down, increasing the risk of a crash.
Remedy
Dealers replaced the harness for the center brake light and rearview camera and/or the spare tire carrier/harness assembly, as necessary, free of charge. All vehicles were repaired by January 15, 2024. Owner notification letters were mailed September 26, 2024. Owners may contact FCA US, LLC custo
... mer service at 1-800-853-1403. FCA US, LLC's number for this recall is 77B.Read more46 vehicles affected
Manufacturer: Chrysler (FCA US, LLC)
EXTERIOR LIGHTING:BRAKE LIGHTS
Defect Description
Chrysler (FCA US, LLC) is recalling certain 2018-2024 Jeep Wrangler vehicles. The wiring harness for the rearview camera and the center brake light may short circuit, which can disable the rearview camera image and center brake light. As such, these vehicles fail to comply with the requirements of
... Federal Motor Vehicle Safety Standard numbers 111, "Rear Visibility" and 108, "Lamps, Reflective Devices, and Associated Equipment."Read moreConsequence
A rearview camera image that does not display decreases the driver's visibility, increasing the risk of a crash. Additionally, a center brake light that fails to illuminate can fail to indicate to other drivers that the vehicle is slowing down, increasing the risk of a crash.
Remedy
Dealers replaced the harness for the center brake light and rearview camera and/or the spare tire carrier/harness assembly, as necessary, free of charge. All vehicles were repaired by January 15, 2024. Owner notification letters were mailed September 26, 2024. Owners may contact FCA US, LLC custo
... mer service at 1-800-853-1403. FCA US, LLC's number for this recall is 77B.Read more46 vehicles affected
Manufacturer: Chrysler (FCA US, LLC)
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
Defect Description
Chrysler (FCA US, LLC) is recalling certain 2020-2024 Jeep Gladiator and 2018-2024 Jeep Wrangler vehicles. The instrument panel cluster may experience an internal short circuit and fail. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 10
... 1, "Controls and Displays."Read moreConsequence
An instrument panel that fails to display critical safety information, such as the speedometer or warning lights, can increase the risk of a crash.
Remedy
Dealers will replace the instrument panel cluster, free of charge. Owner notification letters were mailed between October 3, 2024, and January 23, 2025. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is 30B.
32,863 vehicles affected
Manufacturer: Chrysler (FCA US, LLC)
STRUCTURE:FRAME AND MEMBERS
Defect Description
Chrysler (FCA US, LLC) is recalling certain 2020-2022 Jeep Wrangler vehicles. A stud on the frame assembly may puncture the fuel tank in a crash, which can result in a fuel leak.
Consequence
A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy
Dealers will inspect and, if necessary, remove the frame stud and apply paint, free of charge. Owner notification letters were mailed April 6, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 28A.
35,829 vehicles affected
Manufacturer: Chrysler (FCA US, LLC)
POWER TRAIN:CLUTCH ASSEMBLY
Defect Description
Chrysler (FCA US, LLC) is recalling certain 2018-2023 Jeep Wrangler, and 2020-2023 Jeep Gladiator vehicles equipped with manual transmissions. The clutch pressure plate may overheat and fracture.
Consequence
Overheated clutch components may increase the risk of a fire. Additionally, damage to other nearby components can result in debris falling onto the road or a loss of drive, increasing the risk of a crash.
Remedy
Dealers will replace the clutch assembly and update the software, free of charge. Owner notification letters were mailed from November 16, 2023 through July 25, 2024. Owners may contact (FCA US, LLC) customer service at 1-800-853-1403. FCA US LLC's number for this recall is 19A. This recall expa
... nds and replaces previous recall 21V-028. Vehicles previously repaired under recall 21V-028 will need to have the new remedy completed.Read more69,201 vehicles affected
Manufacturer: Chrysler (FCA US, LLC)
ENGINE
Defect Description
Chrysler (FCA US, LLC) is recalling certain 2020-2022 Jeep Wrangler, Ram 1500, and 2021-2022 Jeep Gladiator vehicles equipped with 3.0L diesel engines. The high pressure fuel pump (HPFP) may fail, causing an engine stall.
Consequence
An engine stall can increase the risk of a crash.
Remedy
Dealers will replace the HPFP and inspect and replace additional fuel system components, as necessary, free of charge. Owner notification letters were mailed October 17, 2023. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is Z96.
60,413 vehicles affected
Manufacturer: Chrysler (FCA US, LLC)
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Defect Description
Chrysler (FCA US, LLC) is recalling certain 2020-2022 Jeep Wrangler, Ram 1500, and 2021-2022 Jeep Gladiator vehicles equipped with 3.0L diesel engines. The high pressure fuel pump (HPFP) may fail, causing an engine stall.
Consequence
An engine stall can increase the risk of a crash.
Remedy
Dealers will replace the HPFP and inspect and replace additional fuel system components, as necessary, free of charge. Owner notification letters were mailed October 17, 2023. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is Z96.
60,413 vehicles affected
Manufacturer: Chrysler (FCA US, LLC)
BACK OVER PREVENTION:DISPLAY FUNCTION
Defect Description
Chrysler (FCA US, LLC) is recalling certain 2020-2021 Jeep Wrangler, RAM 1500 and 2021 Jeep Gladiator vehicles. A radio software error may prevent the rearview image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "
... Rear Visibility."Read moreConsequence
A rearview camera that does not display an image reduces the driver's rear view, increasing the risk of a crash.
Remedy
Dealers will update the radio software, free of charge. Owner notification letters were mailed October 6, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA, LLC's number for this recall is Z86.
7,895 vehicles affected
Manufacturer: Chrysler (FCA US, LLC)
BACK OVER PREVENTION:DISPLAY FUNCTION
Defect Description
Chrysler (FCA US, LLC) is recalling certain 2020-2021 Jeep Wrangler, RAM 1500 and 2021 Jeep Gladiator vehicles. A radio software error may prevent the rearview image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "
... Rear Visibility."Read moreConsequence
A rearview camera that does not display an image reduces the driver's rear view, increasing the risk of a crash.
Remedy
Dealers will update the radio software, free of charge. Owner notification letters were mailed October 6, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA, LLC's number for this recall is Z86.
7,895 vehicles affected
Manufacturer: Chrysler (FCA US, LLC)
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Defect Description
Chrysler (FCA US, LLC) is recalling certain 2020 Jeep Wrangler vehicles equipped with the 2.0 Liter engine. A cracked fuel supply line connector may leak fuel into the engine compartment.
Consequence
A fuel leak in the presence of an ignition source increases the risk of fire.
Remedy
Dealers will inspect and replace the fuel supply line as needed, free of charge. Owner notification letters were mailed on September 10, 2021. Owners may contact FCA US LLC customer service at 1-800-853-140. FCA US LLC's number for this recall is Y10.
14,410 vehicles affected
Manufacturer: Chrysler (FCA US, LLC)
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Defect Description
Chrysler (FCA US, LLC) is recalling certain 2020 Jeep Wrangler vehicles equipped with the 2.0 Liter engine. A cracked fuel supply line connector may leak fuel into the engine compartment.
Consequence
A fuel leak in the presence of an ignition source increases the risk of fire.
Remedy
Dealers will inspect and replace the fuel supply line as needed, free of charge. Owner notification letters were mailed on September 10, 2021. Owners may contact FCA US LLC customer service at 1-800-853-140. FCA US LLC's number for this recall is Y10.
14,410 vehicles affected
Manufacturer: Chrysler (FCA US, LLC)
POWER TRAIN:CLUTCH ASSEMBLY
Defect Description
Chrysler (FCA US, LLC) is recalling certain 2018-2021 Jeep Wrangler and 2020-2021 Jeep Gladiator vehicles equipped with manual transmissions. The clutch pressure plate may overheat and fracture.
Consequence
Overheated clutch components may increase the risk of a fire. Additionally, damage to other nearby components can result in debris falling onto the road or a loss of drive, increasing the risk of a crash.
Remedy
FCA US LLC will notify owners, and dealers will add software to reduce engine torque capability when clutch assembly temperatures rise to a level that may damage the inner pressure plate, free of charge." FCA has ordered a stop sale for the affected vehicles as of February 25, 2021. Owner notifica
... tion letters were mailed on March 4, 2021.Read more42,887 vehicles affected
Manufacturer: Chrysler (FCA US, LLC)
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Defect Description
Chrysler (FCA US LLC) is recalling certain 2020 Jeep Gladiator and Jeep Cherokee, 2019-2020 Ram 1500 Pickup, Ram 2500 Pickup, Ram 3500 Pickup, Chrysler Pacifica, Dodge Durango, Jeep Grand Cherokee, Jeep Wrangler, and Jeep Renegade and 2019 Dodge Challenger vehicles equipped with 8.4" or 12" radio di
... splays. A software error can cause the rearview camera image to remain displayed after the vehicle has been shifted out of reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."Read moreConsequence
The lingering rearview image can distract the driver, increasing the risk of a crash.
Remedy
Chrysler has notified owners, and dealers will update the radio display software, free of charge. Optionally, owners can choose to remotely update their software via an Over-The-Air (OTA) update available as of May 1, 2020. The recall began April 27, 2020. Owners may contact Chrysler customer ser
... vice at 1-800-853-1403. Chrysler's number for this recall is W30-W37.Read more319,610 vehicles affected
Manufacturer: Chrysler (FCA US LLC)
POWER TRAIN:CLUTCH ASSEMBLY
Defect Description
Chrysler (FCA US LLC) is recalling certain 2018-2020 Jeep Wrangler and 2020 Gladiator vehicles equipped with manual transmissions. The clutch pressure plate may overheat and fracture.
Consequence
The overheated clutch components may increase the risk of a fire. Additionally, damage to other nearby components can result in debris falling onto the road or a loss of drive, increasing the risk of a crash.
Remedy
Chrysler will notify owners, and dealers will reroute a wire harness and inspect the clutch system, and replace components as needed. The recall began April 30, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W12.
33,237 vehicles affected
Manufacturer: Chrysler (FCA US LLC)
SUSPENSION:FRONT:CONTROL ARM:LOWER ARM
Defect Description
Chrysler (FCA US LLC) is recalling certain 2020 Jeep Wrangler vehicles. The left side lower control arm bracket and weld may not be correctly positioned.
Consequence
The improper weld may allow the lower control arm to separate from the axle which can increase the risk of a crash.
Remedy
Chrysler will notify owners, and dealers will inspect the front axles, replacing them as necessary, free of charge. The recall began February 27, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W01.
3,005 vehicles affected
Manufacturer: Chrysler (FCA US LLC)
Complaint Statistics
748 total complaints
25 crashes 17 fires 10 injuries
Top Reported Components
| Component | Complaints |
|---|
| STEERING | 231 |
| ELECTRICAL SYSTEM | 150 |
| UNKNOWN OR OTHER | 57 |
| SUSPENSION | 49 |
| ENGINE | 47 |
| POWER TRAIN | 44 |
| VISIBILITY/WIPER | 33 |
| FUEL/PROPULSION SYSTEM | 27 |
| STRUCTURE:BODY | 14 |
| VEHICLE SPEED CONTROL | 12 |
Incident date: Mar 24, 2026
My daughter was driving the 2020 jeep wrangler we bought her & the instructor cluster panel went blank. We have had the vehicle less than 1yr & it has only 38,000 miles on it. There is a established recall (30B) for 2018-2024 jeep wranglers for the instrument cluster failing but for some reason our
... vin is not included? Can you help with coverage for this?Read more
Incident date: Feb 20, 2026
I am the original owner of a 2020 Jeep Wrangler. My instrument cluster has completely failed. I know that there is an active recall for this exact issue (30B) but my VIN number is not included. This is clearly a safety defect as my cluster is non-functional, I do not have a speedometer or warning in
... dicators.i have no idea how much or how little gas I have, if my tire pressure is low…I am the original owner, as stated ,and this is not normal wear. I am also aware that there is an open investigation into this recall and I believe my Jeep should be included in the recall. Prior to the cluster going out, there was not any warning. I started the jeep and it was working and as I was driving it went off. It never came back on. We checked connections and fuses, it’s not that. My husband has addressed it with two separate dealerships and was told there was nothing they could do and offered no suggestions. I went today and spoke with a new dealership and they put me in contact with Jeep Customer Care. I have begun the process but will most likely still be paying out of pocket with money, I frankly do not have. This is a safety issue and should be taken care of by Jeep, and is being covered for some by the recall.Read more
Incident date: Mar 21, 2026
WHILE DRIVING ON HWY AT HIGH RATE OF SPEED WHILE IN MODERATE TO HEAVY TRAFFIC- THE ENGINE FAILED, LOCKED UP AND STALLED IN THE FAST LANE- THERMOSTAT OVERHEATED WITHOUT WARNING OR LIGHTS- ENGINE LOST COMPRESSION- SHOULD BE RECALL AS THIS IS PREVALENT IN THIS MODEL ENGINE- 2020 JEEP WRANGLER SAHARA UN
... LIMITED 4 CYL 2.0 TURBORead more
Incident date: Mar 25, 2026
Steering gear box. Very sloppy while driving . not safe
Incident date: Nov 1, 2025
Instrument Panel Cluster Failure. Black screen. Can’t see MPH, Gas, mileage or any engine functionality. Consistent with NHTSA safety recall. My VIN is not in the recall despite being a 2020 Jeep Wrangler that is listed in the safety recall. Stellantis won’t cover repair and Jeep dealer in Mars
... hfield won’t cover. Potential 6 month fix with no replacement vehicle offered because part hasn’t been in stock.Read more
Incident date: Mar 10, 2026
The instrument panel has suddenly stopped working. Speedometer, Odometer, fuel, nothing displays. There is an active recall for this very issue 24V652000. However, my VIN is reportedly not included and the dealership says its not covered.
Incident date: Mar 5, 2026
Instrument cluster has gone blank. Unable to see digital speedometer, fuel level, engine temperature, current gear, 4WD status, and other items. Dealership said it was not part of recall 24V652000, they stated the only outstanding recall for this vehicle was 25V741000. Vehicle is scheduled to go
... in for that recall and further diagnosis of the instrument cluster issue.Read more
Incident date: Mar 8, 2026
The instrument cluster no longer displays any information, it is blank. My safety is at risk as I can not see how much gas I have, mileage, oil pressure or any other warnings that are used by the display. Prior to going completely blank intermittently it would show a greenish color. Other Jeep Wrang
... lers have had this problem, but my VIN was not part of the recall.Read more
Incident date: Feb 21, 2026
The contact owns a 2020 Jeep Wrangler. The contact stated that while operating the vehicle, the instrument panel became inoperable. The contact was unable to view the odometer, fuel level, or speedometer. The warning lights were inoperable. The contact referenced NHTSA Campaign Number: 24V652000 (EL
... ECTRICAL SYSTEM); as a possible cause for the failure, however the VIN was not included in the recall. The dealer was not notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 67,000.Read more
Incident date: Jan 16, 2026
The 3.5" screen on my jeep went out. Which prevented me from seeing speed, mileage and gas. They have recalled other jeeps from 2018-2024 but mine is not included because it has been in service for more then 24 months. We bought the jeep in 2023 with 20 some thousand miles on it. Why is there a time
... limit on a faulty part? Not everyone drives their cars 30,000+ a year, so problems with parts won't be known as early as 2 years. We replaced it and it cost $1600 plus a week of not having my car.Read more
Incident date: Jan 2, 2026
The instrument cluster has completely failed presenting a dangerous situation for driving. There are no warning lights, no speed indicator, no signal indicator, etc, etc. A simple Google search will show that this is a very widespread and well known issue with this vehicle, and a safety recall not
... ice should be issued and the replacement should be covered by the manufacturer. The vehicle was inspected by the dealership and they confirmed it is the instrument cluster.Read more
Incident date: Jan 2, 2026
The instrument cluster has completely failed presenting a dangerous situation for driving. There are no warning lights, no speed indicator, no signal indicator, etc, etc. A simple Google search will show that this is a very widespread and well known issue with this vehicle, and a safety recall not
... ice should be issued and the replacement should be covered by the manufacturer. The vehicle was inspected by the dealership and they confirmed it is the instrument cluster.Read more
Incident date: Dec 1, 2025
The instrument cluster is is not working. I am unable to see how much gas is in the vehicle nor am I able to see any critical warnings for the vehicle
Incident date: Feb 1, 2025
The attachment for the rear defrost failed. The wiring for the rear defrost was poorly attached (bad glue?) to the back window. With the lack of trunk, jeeps end up with lots of moisture spraying onto the back window and freezing. This poor design causes a hazard by limiting visibility to solely
... the side mirrors.Read more
Incident date: Feb 23, 2026
Wife’s 2020 Jeep Wrangler’s IPC above the steering wheel went blank. No speed, no fuel gauge, no odometer or warning lights, no turn signal indicators. Chrysler Safety Recall (30B) (NHTSA CAMPAIGN NUMBER: 24V652000) states there is a problem with these including our year Wrangler, 2020. Dealer s
... aid we are out of luck because when they type in our vin number into their database, no safety recalls are listed. This problem is all over the internet 2018-2024 Wrangler (JL) models. What gives???? Don’t even know how much gas we have! 6 year old car should NOT have the IPC shut off! If that’s not a safety concern, don’t know what is????Read more
Incident date: Feb 1, 2021
The driver and passenger side sunvisors have both failed. The piece that holds the visor in place is apparently plastic and breaks easily, causing the visor to malfunction. This sounds minor, but not in winter when the sun is low on the horizon and blinding to the driver. The first visor I replaced
... was in 2021 (on a 2020 jeep). You have to replace the entire assembly (not just the part). Both sides have failed repeatedly. After driving around for months with the visors bungee corded up, to keep them from hanging and flopping around, I have now had my mechanic install after market brackets. This is a well known problem among mechanics that work on newer Jeeps. This may sound minor, but I do feel its an accident waiting to happen when driving towards oncoming traffic when the sun is low. Note that this jeep is primarily driven on paved roads - it is not being driven repeatedly off road in crazy conditions.Read more
Incident date: Feb 20, 2026
The contact owned a 2020 Jeep Wrangler. The contact stated that there were strong fumes coming from the vehicle, causing the contact to sustain severe headaches and nausea. The contact had gone to the Doctor's Office, where blood work was completed. The contact was informed that no issues were found
... , and the Doctor inquired whether the contact had been exposed to any chemicals. The vehicle was taken to the dealer, where it was diagnosed and determined that fuel was leaking from a cracked quick connect and was entering the high fuel pump. The dealer determined that the high-pressure fuel pump lines needed to be replaced. The dealer related the failure to an unknown recall; however, the VIN was not included. The vehicle was not repaired due to the cost. The contact stated while driving approximately 10-20 MPH off a ramp, the contact noticed smoke in front of the vehicle. The contact looked at the instrument cluster, and upon looking up, the contact noticed fire coming from underneath the hood. The contact depressed the brake pedal and jumped out of the vehicle while the vehicle was still rolling. The contact had not pulled over. The contact did not sustain injuries from the fire. A nearby Police Officer notified the Fire Department and Emergency Services because the contact had jumped out of the moving vehicle without the cellphone. The fire was extinguished by the Fire Department. The front end and the hood of the vehicle were burned to the ground. It was unknown whether a Fire Department Report was filed. A Police Report was filed. The vehicle was towed and deemed a total loss by the Insurance Provider. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 134,959.Read more
Fire
1 injured
Incident date: Feb 19, 2026
The contact owns a 2020 Jeep Wrangler. The contact stated that while driving at an undisclosed speed, the instrument panel displayed a blank screen. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The dealer was made aware of the failure. The contact was informed that
... the repair was not covered under warranty or recall. The contact referenced an unknown recall with a similar failure; however, the VIN was not under recall. The contact stated that the vehicle was unsafe to drive with the instrument cluster being inoperable. The manufacturer was not made aware of the failure. The failure mileage was unknown.Read more
Incident date: Feb 17, 2026
My jeep steering wheel and entire vehicle shake violently at high speeds and after a bump.
Incident date: Aug 12, 2024
The contact owns a 2020 Jeep Wrangler. The contact stated that while driving approximately 50 MPH, the vehicle shuddered and was difficult to maneuver. No warning lights were illuminated. The failure had occurred on several occasions. The vehicle was taken to a dealer, where it was diagnosed, and de
... termined that the steering damper, inner tie rods, adjuster sleeve, outer tie rods, and the drag link assembly needed to be replaced. The vehicle was repaired; however, the failure persisted. The vehicle was taken to a different dealer, Vallejo Chrysler Dodge Jeep Ram (4325 Sonoma Blvd, Vallejo, CA 94589), where it was diagnosed and determined that the steering damper, inner tie rods, adjuster sleeve, outer tie rods, and the drag link assembly needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 45,500.Read more
Incident date: Feb 17, 2026
My jeep steering wheel and entire vehicle shake violently at high speeds and after a bump.
Incident date: Nov 4, 2024
The cluster instrument panel stopped working. It is a part that has been recalled. It was taken to the local jeep dealer and they confirmed the issue. Apparently, my jeep has not been added to the recall list yet. I also reported the issue directly to Chrysler back when it first happened.
Incident date: Feb 5, 2026
Shortly after leaving my house I glanced at the digital readout for my speed and noticed that the instrument cluster was blank. I pulled over, stopped my Jeep, then restarted it to see if that would correct it, which it did not. I took it to a reputable auto/electrical garage who at first noticed a
... master fuse block blown and replaced the fuse block. That didn't correct the instrument cluster however but they did find a recall 30B for 2020 Jeep Wrangler. I called Stellantis (1 800 334 9200) today, Feb 16th . I was told by 3 different people in 3 different departments that even though there is a safety recall on 2020 Jeeps my VIN# isn't included. I asked why not and was told that it depended where the Jeep was made. They also told me that the repair will be at my expense. This doesn't seem fair to me because the recall is a safety issue to replace the instrument panel cluster free of charge. Just because my Jeep VIN# wasn't included doesn't mean it wasn't going to fail like the others that were included!! I have no readouts on my dashboard and am sure it won't even pass inspection now because of that, let alone serious safety concerns without warning lights. I have to ask you, SHOULDN'T MY JEEP BE INCLUDED IN THIS SAFETY RECALL AND BE CORRECTED BY THE MANUFACTURER?!?! Thank you in advance for your consideration in this matter! [email protected] Laura CampbellRead more
Incident date: Feb 5, 2026
Shortly after leaving my house I glanced at the digital readout for my speed and noticed that the instrument cluster was blank. I pulled over, stopped my Jeep, then restarted it to see if that would correct it, which it did not. I took it to a reputable auto/electrical garage who at first noticed a
... master fuse block blown and replaced the fuse block. That didn't correct the instrument cluster however but they did find a recall 30B for 2020 Jeep Wrangler. I called Stellantis (1 800 334 9200) today, Feb 16th . I was told by 3 different people in 3 different departments that even though there is a safety recall on 2020 Jeeps my VIN# isn't included. I asked why not and was told that it depended where the Jeep was made. They also told me that the repair will be at my expense. This doesn't seem fair to me because the recall is a safety issue to replace the instrument panel cluster free of charge. Just because my Jeep VIN# wasn't included doesn't mean it wasn't going to fail like the others that were included!! I have no readouts on my dashboard and am sure it won't even pass inspection now because of that, let alone serious safety concerns without warning lights. I have to ask you, SHOULDN'T MY JEEP BE INCLUDED IN THIS SAFETY RECALL AND BE CORRECTED BY THE MANUFACTURER?!?! Thank you in advance for your consideration in this matter! [email protected] Laura CampbellRead more
Incident date: Feb 11, 2026
My speedometer/odometer screen went completely black. I have no idea how fast I’m going or how much gas I have. This is a know and very dangerous issue.
Incident date: Feb 5, 2026
The contact owns a 2020 Jeep Wrangler. The contact stated that while driving at an undisclosed speed, the instrument panel was blank. The contact pulled over and restarted the vehicle; however, the failure persisted. The contact associated the failure with NHTSA Campaign Number: 24V652000 (ELECTRICA
... L SYSTEM); however, the VIN was not included in the recall. The vehicle was driven to an independent mechanic and was diagnosed with instrument cluster failure. The vehicle was not repaired. The dealer was not notified of the failure. The manufacturer was not notified of the failure. The failure mileage was 52,000.Read more
Incident date: Feb 1, 2026
The IPC intermittently goes blank and I lose driver information like remaining fuel and speed limit and other safety information. The IPC also turns green and gets distortion.
Incident date: Feb 1, 2026
The IPC intermittently goes blank and I lose driver information like remaining fuel and speed limit and other safety information. The IPC also turns green and gets distortion.
Incident date: Feb 1, 2026
The IPC intermittently goes blank and I lose driver information like remaining fuel and speed limit and other safety information. The IPC also turns green and gets distortion.
Incident date: Dec 11, 2025
The instrument cluster has failed. I am unable to see critical warnings for my Jeep. I am unable to determine the milage. Fortunately, the speedometer is separate and I am able to see the speed. I see there is a recall for 2020 Wranglers but, for some reason my VIN is not included. I'm being told by
... the dealer that the repair will cost $1600. Reading online, this issues seems to be a problem with Wranglers.Read more
Incident date: Jan 13, 2026
The contact owns a 2020 Jeep Wrangler. The contact stated that upon starting the vehicle, the instrument cluster failed to operate as designed. The contact stated that the instrument cluster was black at start-up, preventing the gauges or safety features information from being displayed. The vehicle
... was not taken to a dealer or an independent mechanic to be diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 119,000.Read more
Incident date: Jan 19, 2026
My instrument cluster has failed. I can't see any vehicle information. No gas or oil gauges. No information what so ever. I can't see my speed or if may my be overheating. This is basic safety issues I should be able to see. There has been a recall for 2020 Jeep Wrangler's so other people hav
... e has the same issue. I can't drive without the basic safety instruments working. I don't even know how many miles are on my JeepRead more
Incident date: Dec 5, 2025
The instrument panel cluster went totally dark, I only have 53,000 miles on this vehicle. I can't see any warning lights, digital speed, and most dangerously how much gas I have in the vehicle. The dealer wants $2000.00 to replace it but this seems to be a common issue with Jeeps and the 7.0 clust
... er should be recalled along with the 3.5 cluster. I have the 7.0 that has not been recalled yet.Read more
Incident date: Dec 31, 1969
Instrument control panel does not function. It is a dark/blank screen not allowing driver to see vital functions and information about the vehicle. This vehicle had an alternator issue but could not be determined without extra tooling and labor to diagnose the problem. Safety is of paramount conce
... rn. Vehicle was taken into a dealership for inspection and determined that the "ICP" had failed and needed to be replaced for approximately $1600. This was before recall #30b had been initiated. The recall seemed to include this vehicle given the year and model listed in the recall order. Strangely, it is not included for this particular vehicle which is exhibiting the exact symptoms listed in the recall order.Read more
Incident date: Feb 1, 2026
The instrument panel, recently went dark on us while driving. We had seen previous recalls on this issue, but never received anything. Are we covered under this recall?
Incident date: Jun 4, 2025
I was driving on the highway with my daughter with dry normal conditions approximately 65-70mph when all of a sudden the jeep downshifts into 1st gear causing an extreme deceleration almost to a complete stop. I had a dead gas pedal and could not accelerate to get to a safe area or shoulder. The p
... roblem stopped after I came to a complete stop. My Jeep has been in the shop many times with unrelated issue. I did notify dealer they just brushed it off. It is in the dealership now with oil leak and mentioned transmission issue occured again and this time I made sure they wrote down exactly what happened and I feel extremely unsafe driving this car.Read more
Incident date: Jan 23, 2026
My instrument cluster failed on My 2020 Jeep Wrangler. I can't see any of my vehicle information. This makes safety a real concern for me. There is an existing recall for 2020 Jeep Wranglers. My vin is not included? Could it be evaluated please.
Incident date: Dec 13, 2025
Steering wheel electrical failure. Melted wiring inside steering wheel. Potential airbag and steering safety failure. Serious safety defect. Fire risk! While getting ready to leave a retail parking lot with heated steering wheel on, we became overwhelmed with fumes. Noticed the steering wheel was
... hot. Immediately shut off the car and opened the doors. When the fumes subsided, started the car and made sure the heated steering wheel was off. It no longer worked at all, when car was re-started. This could have been life threatening had we been traveling on the highway and not in a parking lot. Took vehicle to our dealer- Central Chrysler-Jeep-Dodge for repair. Dealer service advisor unable to diagnose exact cause due to extent of damage. Also commented shock that we didn’t experience a fire that could have caused the airbag to explode as well. Service advisor stated steering wheel heating element short and steering wheel wiring to clock spring melted due to excessive heat in circuit. I requested photos. I received one photo. I do not believe there were further inspections. Repairs were completed at my expense. Both dealership and Stellantis refuse to cover the cost of repairs citing I had no warranty coverage. I believe this goes beyond normal wear and tear. I did smell something mild, like sugar burning earlier in our errands yet it dissipated quickly and I assumed it was outside, in the air. It wasn’t until the overwhelm of fumes upon starting the car in a retail parking lot that we became aware there was a serious problem and immediately turned the car off.Read more
Incident date: Dec 13, 2025
Steering wheel electrical failure. Melted wiring inside steering wheel. Potential airbag and steering safety failure. Serious safety defect. Fire risk! While getting ready to leave a retail parking lot with heated steering wheel on, we became overwhelmed with fumes. Noticed the steering wheel was
... hot. Immediately shut off the car and opened the doors. When the fumes subsided, started the car and made sure the heated steering wheel was off. It no longer worked at all, when car was re-started. This could have been life threatening had we been traveling on the highway and not in a parking lot. Took vehicle to our dealer- Central Chrysler-Jeep-Dodge for repair. Dealer service advisor unable to diagnose exact cause due to extent of damage. Also commented shock that we didn’t experience a fire that could have caused the airbag to explode as well. Service advisor stated steering wheel heating element short and steering wheel wiring to clock spring melted due to excessive heat in circuit. I requested photos. I received one photo. I do not believe there were further inspections. Repairs were completed at my expense. Both dealership and Stellantis refuse to cover the cost of repairs citing I had no warranty coverage. I believe this goes beyond normal wear and tear. I did smell something mild, like sugar burning earlier in our errands yet it dissipated quickly and I assumed it was outside, in the air. It wasn’t until the overwhelm of fumes upon starting the car in a retail parking lot that we became aware there was a serious problem and immediately turned the car off.Read more
Incident date: Jan 16, 2026
The contact owns a 2020 Jeep Wrangler. The contact stated that while driving at an undisclosed speed, the instrument cluster displayed a black screen. The vehicle was taken to the independent mechanic, where it was diagnosed with instrument cluster failure. The contact was informed that the instrume
... nt cluster needed to be replaced. The vehicle was not repaired. The contact was advised to contact the dealer for assistance. The dealer was made aware of the failure; however, the contact was informed that the repair was not covered under a recall. The contact referenced an unknown recall howeve,r the VIN was not under recall. In addition, the contact was informed that most likely the failure was the result of rodents chewing on the wires, and that the repair was not covered under the recall. The manufacturer was made aware of the failure but provided no assistance. The contact was informed that the repair was not covered under a recall. The failure mileage was approximately 49,272.Read more
Incident date: Jan 16, 2026
The contact owns a 2020 Jeep Wrangler. The contact stated that while driving at an undisclosed speed, the instrument cluster displayed a black screen. The vehicle was taken to the independent mechanic, where it was diagnosed with instrument cluster failure. The contact was informed that the instrume
... nt cluster needed to be replaced. The vehicle was not repaired. The contact was advised to contact the dealer for assistance. The dealer was made aware of the failure; however, the contact was informed that the repair was not covered under a recall. The contact referenced an unknown recall howeve,r the VIN was not under recall. In addition, the contact was informed that most likely the failure was the result of rodents chewing on the wires, and that the repair was not covered under the recall. The manufacturer was made aware of the failure but provided no assistance. The contact was informed that the repair was not covered under a recall. The failure mileage was approximately 49,272.Read more
Incident date: Oct 20, 2025
The contact owns a 2020 Jeep Wrangler. The contact stated that while the vehicle was parked, the instrument panel became dark. The failure had occurred on several occasions. No warning lights were illuminated. The vehicle was taken to the dealer to be diagnosed; however, the cause of the failure was
... unknown. The vehicle was not repaired. The failure reoccurred and the vehicle was taken back to the dealer and was diagnosed and determined that the instrument panel needed to be replaced. The dealer stated that there was no recall associated with the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.Read more
Incident date: Dec 7, 2025
1. Instrument console screen or display has disabled. Cannot read speed, fuel level, etc. 2. Driver cannot discern status of vehicle. Speed, gear , and fuel data not readable which driver would need for safe driving. 3. This has not been reproduced by dealer. Confirmed by independent service center.
... 4. Vehicle has standard NYS safety inspection. 5. No prior warning or signs led to the outage of control panel.Read more
Incident date: Jan 8, 2026
Premature failure of right bank of intake camshaft and rocker arms/tappet valves requiring a $2000 repair on a 2020 Jeep Wrangler JLU with 64,596 miles.
Incident date: Jan 1, 2025
The contact owns a 2020 Jeep Wrangler. The contact stated that upon starting the vehicle, the instrument panel was blank before eventually returning to normal operation. The failure was intermittent at first before becoming a permanent failure. The contact was unable to see the speedometer, mileage,
... fuel gauge level, and other vital features of the vehicle. Upon investigation, the contact discovered NHTSA Campaign Number: 24V652000 (Electrical System); and associated the failure with the recall. Two dealers were notified of the failure and stated that the VIN was not under recall. A diagnostic test was performed, and the contact was provided with an estimate for the repair. The vehicle was not yet repaired. The contact sent an email to the manufacturer, but had not yet received a response. The failure mileage was unknown.Read more
Incident date: Jan 5, 2026
The contact owns a 2020 Jeep Wrangler. The contact stated that while driving at an undisclosed speed, the instrument cluster displayed a black screen. Due to the failure, the contact was unable to determine the speed of the vehicle. The vehicle was taken to the dealer, where it was determined that t
... he instrument cluster was inoperable and needed to be replaced. The vehicle was not repaired. The vehicle was then taken to an independent mechanic, where it was diagnosed with instrument cluster failure. The contact was informed that the instrument cluster needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 90,600.Read more
Incident date: Jan 11, 2026
Death wobble really bad
Incident date: Jan 11, 2026
Death wobble really bad
Incident date: Dec 15, 2025
The vehicle was running fine and then the cluster went out. It came back for a couple hours and now it’s been out for a couple weeks. It still lights up but does not show any writing. I know this is part of a recall but like the last time something happened to my jeep with the gas( huge safety vio
... lation) that costed $1400 to fix- Jeep obviously doesn’t care about safety. I’m over this Jeep if they don’t want to include the vehicle in the recall twice now.Read more
Incident date: Mar 15, 2025
The contact owns a 2020 Jeep Wrangler. The contact stated that while driving at 30 MPH, the instrument panel displayed a blank screen. No warning light was illuminated. A dealer was contacted. The vehicle was taken to the dealer to be diagnosed; however, the diagnostic result was unknown. The contac
... t related the failure to NHTSA Campaign Number: 24V652000 (ELECTRICAL SYSTEM); however, the VIN was not included in the recall. The manufacturer was not notified of the failure. The failure mileage was 110,000.Read more
Showing 50 of 748 complaints.
NHTSA Safety Investigations — JEEP WRANGLER
Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.
PE — Open
— Model Year: 2020
Instrument Panel Cluster (IPC) Failure
The Office of Defects Investigations (ODI) is opening a Preliminary Evaluation on 2020 Model Year Jeep Gladiators and Wranglers involving a malfunctioning Instrument Panel Clusters (IPC) resulting in the loss of important vehicle metrics and other status information. ODI has received 89 Vehicle
... Owner Questionnaires (VOQs) alleging a complete or partial loss of the IPC display while driving.  The subject vehicles' IPC display includes the speedometer, fuel gauge, engine temperature, turn signal indicators, warning light, and other gauges that are normally illuminated while the vehicle is in operation. Loss of the fuel gauge while driving may lead to an inability to determine the fuel level and result in a loss of motive power, and the loss of other safety-related information may impede a driverâs ability to take action to prevent a safety risk.  Furthermore, an IPC that is suddenly not visible to the driver may divert the driverâs attention from the driving task, potentially causing a vehicle crash. ODI is opening this Preliminary Evaluation to evaluate the scope, severity and frequency of the alleged IPC malfunctions and to assess potential safety-related consequences. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.govRead more
RQ — Open
— Model Year: 2024
Loss of Motive Power
The Office of Defects Investigation (ODI) has identified 68 Vehicle Owner Questionnaire (VOQ) reports for model years (MY) 2021 through 2024 Jeep Wrangler 4xe vehicles alleging a loss of motive power. Recall 22V-865 was issued by the manufacturer to address an engine shutdown condition in certain MY
... 2021-2023 Wrangler 4xe vehicles. The complaints noted here contain both post recall remedy failures and failures in vehicles not included within the scope of 22V-865. An analysis comparing complaints received before the issuance of recall 22V-865 and complaints outside the scope of the recall has been conducted. The results show the current complaint rate is higher in the out of scope vehicles than it was for vehicles that were later covered by the recall. ODI is opening this Recall Query (RQ) to assess the severity of the alleged defect in vehicles not included in recall 22V-865.ODI will also assess the scope and remedy effectiveness of the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.Read more
PE — Closed
— Model Year: 2019
Frame weld deficiencies
On September 16, 2019, the Office of Defects Investigation (ODI) granted Defect Petition DP18-004 and opened Preliminary Evaluation PE19-012 to investigate allegations of deficient frame welds and their potential safety related effects on 2018-2019 Jeep Wranglers. Due to a previous steering related
... recall that was caused by a misaligned weld on the front track bar (NHTSA Recall No. 18V-675), ODI decided to include reports of steering shimmy or wobble, loose steering, and steering stiction (loss of power steering) as part of this investigation and parent petition (DP18-004). ODI received information from the vehicle manufacturer Fiat Chrysler Automobiles (FCA) via information request letters dated March 8, 2019, and February 6, 2020. Supplemental requests for information occurred between July 2020 and July 2023. A review of the responsive manufacturer information showed that vehicles presenting an unexpected reduction in steering ability due to a welding tool misalignment were correctly addressed via recall 18V-675. General complaints concerning the weld appearance were not associated with a realized risk to motor vehicle safety. ODI identified a limited number of reports involving weld separation on vehicles that were out of scope of recall 18V-675. FCA identified various causes of weld quality issues in early production (build dates prior to March 2018) including improper welding techniques on galvanized frames and component part variation leading to off-seam welds. These issues were addressed in production for subject vehicles built after July 2018 and preceded a drop in weld failure reports. ODI reviewed manufacturer and agency reports of weld failures out of scope of recall 18V-675 and did not find any that resulted in a loss of vehicle control. There are no known crashes, injuries, or fatalities as a result of weld failures on vehicles not included in recall 18V-675. Due to the steering related consequence associated with Recall 18V-675, ODI opted to include a request for information regarding various steering issues experienced by vehicles included in this investigation. ODI reviewed manufacturer as well as agency data and determined these various steering issues were not related to any weld defect. Since the opening of this investigation, FCA has addressed the following steering concerns; a. Steering looseness due to material choice in the steering box internal components. FCA released an updated part with an internal component material less sensitive to temperature variances (TSB 08-003-21 REV. A).NHTSA will take further investigative action if justified. b. Steering wobble or shimmy due to a manufacturing and design deficiency in the steering damper. FCA released a part via Customer Satisfaction Notification (CSN) V41 in June 2019 which implemented supplier quality control improvements and design changes due to the presence of air in the base valve which degraded damping performance.NHTSA will take further investigative action if justified. c. Steering stiction, or loss of power steering, due to an underpowered steering pump calibration that occurred at highway speeds during cold weather. In December 2021, FCA released CSN Y95 which corrected this issue via software update. Due to the decreased number of consumer complaints, the service campaign appears to have addressed the issue related to an underpowered steering pump. NHTSA will take further investigative action if justified. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.Read more
PE — Closed
— Model Year: 2015
Seat belt buckle bracket failure
On July 17, 2019, NHTSA's Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE) 19-008 after receiving three Vehicle Owner Questionnaire (VOQ) reports alleging the driver's side seat belt buckle separated from the seat frame, rendering the seat belt non-functional. The VOQs involv
... ed model year (MY) 2015 and 2016 Jeep Wrangler (JK platform) that were configured for right-hand drive (RHD) use. On August 8, 2019, ODI issued an information request (IR) letter to FCA.The scope of the IR included all JK Wrangler produced for sale in the U.S. (both left- and right-hand drive), and amongst other things, requested any reports or allegations of driver's seat belt bracket failures on these vehicles. In its review of FCA's response, ODI determined that approximately 1.7 million JK Wrangler were produced from MY 2007 to 2018, about 16,000 of which were configured for RHD. ODI notes that the RHD Wrangler are typically used for rural postal delivery which often experience a more severe duty cycle. Also RHD JK was was not produced in MY 2007.As explained in the IR response, FCA identified three distinct populations of JK Wrangler concerning the driver's seat belt bucket bracket; specifically the MY 2007-2018 LHD (~1.7M units), the MY 2008-2010 RHD (4,563 units), and the MY 2011-2018 RHD (11,463 units) populations.FCA provided details on the designs used in each of these populations, identifying specific differences deemed pertinent to the strength and durability of each unique bracket design. FCA further reviewed its analysis of the complaint and warranty data identified under the IR, and noting that it had not identified any allegations of bracket failures on the LHD population, and only one allegation on the MY 2008-2010 RHD vehicles. By comparison, FCA identified 24 allegations of bracket failure for the MY 2011-2018 RHD JK, including two reports duplicative of the VOQs. Neither the FCA nor the VOQ reports allege an injury or fatality due to bracket failure. Based on this analysis, FCA decided to conduct a safety recall for the MY 2011-2018 RHD JK population. On September 30, 2019, FCA submitted a Defect Information Report initiating NHTSA Safety Recall 19V-680 (FCA No. VA6). Under the recall action, FCA will replace the driver's seat belt bracket on MY 2011-2018 RHD Jeep JK Wrangler. The repair will be conducted free of charge.In view of FCA's recall action, and its explanations of the scope of that action, ODI is closing PE19-008. ODI will continue to monitor the non-recalled RHD, and the LHD JK Wrangler for evidence of seat belt bracket failure and will take further action if warranted.The three VOQ reports cited above can be reviewed at NHTSA.gov under the following reference numbers:11190251, 11218472, 11231639.Read more
DP — Closed
— Model Year: 2019
Frame Weld Deficiencies
In a letter received on October 24, 2018, a citizen petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a safety defect investigation into frame weld deficiencies on model year (MY) 2018 'JL' Jeep Wrangler vehicles. The petitioner described a broad list of frame weld de
... ficiencies, including porous welds, excessive slag, lack of weld penetration, over penetration of welds, overweld or weld drip, and weld splash. The weld defects are allegedly located at a variety of locations on the frame assembly.On November 16, 2018, the Office of Defects Investigation (ODI) opened a Defect Petition (DP18-004) to evaluate whether to grant or deny the petition. On March 8, 2019, ODI sent an Information Request letter to Fiat Chrysler Automobiles (FCA) requesting information on frame weld related issues on all MY 2018-2019 Jeep Wrangler 'JL' vehicles. Due to a previous steering related recall that was caused by a misaligned weld on the front track bar (NHTSA Recall No. 18V-675), ODI opted to include a request for additional information concerning reports of steering shimmy or wobble, loose steering, and steering lockup in the March request letter. ODI has performed a preliminary analysis on the information obtained from FCA. Based on ODI's review of the applicable materials, NHTSA has decided to grant the petition. While reviewing the applicable materials obtained from the manufacturer, ODI identified various reports and references to frame welded component detachments that were outside of the scope of NHTSA Recall No. 18V-675. Additionally, the information that FCA provided did not adequately address whether frame weld quality deficiencies compromise the structural integrity of vehicles, and therefore may pose an unreasonable risk to motor vehicle safety. Finally, ODI needs to further evaluate the alleged steering-related defects reported through MY 2019 and the alleged defects' relation to weld quality.The petition was granted on September 16, 2019. Preliminary Evaluation PE19-012 has been opened to further assess the scope, frequency, and potential safety-related consequences of alleged weld quality deficiencies and steering related concerns on the MY 2018-2019 'JL' Jeep Wrangler vehicles.The ODI reports cited above can be viewed on NHTSA.gov under the following reference numbers:11234967, 11222390, 11219370, 11217080, 1204905, 11179954, 11171786, 11161243, 11155523, 11153044, 11143617, 11142722, 11142426, 11141336, 11141035, 11140637, 11140344, 11140262, 11140085, 11140057, 11139880, 11139866, 11139557, 11139467, 11139436, 11138974, 11138758, 11138757, 11132030, 11129738, 11129667, 11124312, 11120232, 11119676, 11119650, 11119454, 11119450, 11115658, 11115137, 11113029, 11112515, 11110583, 11109903, 11093172, 11088501, 11076098Read more
EA — Closed
— Model Year: 2008
Air Bag Clockspring Wiring Failure
On May 10, 2016, Fiat Chrysler America (FCA) submitted a Part 573 Defect Information Report announcing NHTSA recall 16V290 involving 394,258 model year (MY) 2007-2010 Jeep Wrangler vehicles.Under the recall FCA will replace the clockspring and install a steering wheel back cover and steering wheel c
... olumn shroud.This recall also includes approx. 4,524 MY2007-2010 right hand drive (RHD) Jeep Wrangler vehicles commonly used for rural postal delivery services.In addition 7,180 MY 2011-2016 right hand drive Jeep Wrangler vehicles were also recalled under 16V288, the same remedy repair will be used.Upon review of the 1,942 MY 2007-2010 Jeep Wrangler consumer complaints, 17,195 warranty reports and field returned parts assessment, FCA concluded that a defect exists in the driver side clockspring assembly, a device that both connects (electrically) the driver air bag to the control module and allows rotational movement between the steering wheel and fixed steering column.Clockspring failure may compromise the air bag circuit causing illumination of the air bag warning lamp, and may result in non-deployment of the driver air bag in a frontal crash.FCA identified a contributing factor in that the recalled vehicles may be subjected to off-road dusty environments and/or usage with the vehicle roof top/doors removed thus allowing dust and moisture to enter the clockspring assembly.FCA advised that the MY 2011 and later Wrangler vehicles had an improved steering column cover/shroud that may reduce the amount of dirt/moisture that can enter the clockspring assembly.During the investigation FCA and the Office of Defects Investigation (ODI) also reviewed 193 MY 2011-2012 Jeep Wrangler consumer complaints, 3,918 warranty reports and field returned parts along with reports from other FCA vehicles that use the same clockspring assembly.Based on this review, the rate of repair and the failure mode does not indicate a defect trend at this time in the later MY Wrangler or other FCA vehicles.During the field return parts review, FCA found a significant number of MY 2011-2012 Wrangler returned parts that operated normally, the so called ?no trouble found? or NTF parts where no fault could be identified through bench testing.On June 10, 2016, FCA informed ODI of its intention to conduct a 15-yr, 150k mile extended warranty program due to the NTF issue and the MY 2011 and later vehicles having a somewhat elevated level of warranty replacement.Consumers will be notified of the program in writing.FCA will collect clocksprings replaced under the warranty extension program to further examine and study the root cause failure.ODI will monitor FCA?s analysis to determine if any further field action is warranted.Based on the actions taken by FCA to recall the MY 2007-2010 Jeep Wrangler vehicles and the MY 2008-2016 right hand drive Wrangler vehicles, this investigation is closed.FCA has also agreed to conduct a warranty extension and further evaluation of the MY 2011-2016 Wrangler.At the time of FCA's field data submission in PE 15-025 (September 2015), ODI was aware of a total of 416 MY 2007-2010 and 23 MY 2011-2012 VOQs relevant to this issue.In addition, there have been an additional 90 and 16 VOQs (respectively) received since the recall announcement (i.e., thru May 2016).The reports noted above can be viewed at SaferCar.gov under the reference (ODI) numbers cited on the attached listing.Read more
PE — Closed
— Model Year: 2007
Air Bag Clockspring Wiring Failure
In it's response to ODI's PE15-025 Information Request letter, FCA identified 1,703 consumer complaints, field reports and legal claims responsive to the subject defect condition on the subject Wrangler vehicles.Six of these reports alleged an air bag non-deployment in a crash in which either the ai
... r bag warning light was allegedly on or came on afterward the crash, one of which also alleged injuries as a result of the non-deployment.FCA also provided data on other make, model and model year vehicles using the same clockspring.Additionally FCA provided 16,955 warranty claims related to the replacement of the air bag clockspring wiring assembly.It should be noted that FCA initiated an Extended Warranty Program on the left hand drive MY 2007 Wrangler in late calendar year 2011.6,777 of these claims are from the MY 2007 left hand drive Wrangler.FCA advises that some of the warranty claims involved clockspring failures that would not affect the air bag operation, for example due to noise, cruise control and/or radio operation issues.Many of these claims involved newer model year subject vehicles.FCA also noted that Wrangler's removable roof and door configuration may make it more susceptible to outdoor water/moisture and dust ingress.ODI investigated the right hand drive Wrangler in calender year 2011 for a similar clockspring issue under PE11-019.That investigation lead to NHTSA Safety Recall 11V258 on right hand drive model year (MY) 2008-2012 Wranglers.FCA redesigned the remedy clockspring to improve its durability and environmental protection and revised the design of the steering wheel to column shroud.Base on the data reviewed, this Preliminary Analysis (PE) is being upgraded to an Engineering Analysis (EA).The reports cited above are listed in the public investigative file available at SaferCar.gov under this investigation ID.Read more
PE — Closed
— Model Year: 2010
Skid plate debris fires
In a letter dated May 15, 2012, the Chrysler Group LLC (Chrysler) submitted a Defect Information Report to NHTSA identifying a safety defect regarding fires originating between the transmission skid plate and the exhaust catalyst in approximately 65,246 model year (MY) 2010 Jeep Wrangler 4x4 vehicle
... s with automatic transmissions (NHTSA Recall 12V-216).According to Chrysler, changes to the exhaust system for MY 2010 resulted in reduced clearances between the exhaust catalyst and the skid plate.If debris collects in the area of the skid plate and is not removed, there is an increased potential for underbody debris fires.ODI's analysis of skid plate area fires in the MY 2010 Wrangler vehicles with automatic transmissions found that the rate increased significantly from approximately 1.7 fires per 100,000 vehicle years in the MY 2007 through 2009 vehicles with the prior exhaust design to approximately 14.8 fires per 100,000 vehicle years in MY 2010 vehicles, a nearly 800 percent increase.In analysis of both Vehicle Owner Questionnaire (VOQ) data submitted to the Office of Defects Investigation (ODI) and Chrysler's consumer complaint data submitted to ODI, 35 unique reports were identified by Chrysler alleging fire in subject vehicles with origins near the engine compartment or in the underbody area directly beneath and to the rear of the engine compartment.Chrysler's assessments of the 35 reports of fire were categorized by likely causes.Eleven of the fires were determined to be caused by skid plate debris accumulation and 4 additional fires were found to have originated in the area of the skid plate, but debris ignition could not be confirmed.An additional skid plate debris fire was reported to ODI after the recall announcement, bringing the total known fire count to 36, including 12 caused by skid plate debris and 4 originating in the skid plate area from unknown causes.Chrysler identified a design change to the exhaust system in MY 2010 that increased the possibility of debris contact with an exhaust catalyst.Beginning in MY 2011, the skid plate was replaced with a skid bar for weight reduction purposes.The skid bar having a much smaller surface area than the skid plate reduces the potential for debris entrapment.The recall remedy for recall 12V-216 will involve replacement of the skid plate with the skid bar.As background, the MY 2010 subject vehicles are a part of the JK generation of Jeep Wrangler vehicles that began production in MY 2007.Chrysler conducted a prior recall (09V-436) of MY 2007 and 2008 Jeep Wranglers for a defect involving overheated transmission fluid expulsion that could contact the exhaust and cause an engine compartment fire.The recall remedy was to add audible (chime) and visual warnings (hot oil message in the instrument cluster) to alert the driver that the vehicle was being operated with elevated transmission fluid temperatures.Chrysler enhanced the audible warning with a service campaign (J31) for MY 2009 and a portion of the subject MY 2010 vehicles.Transmission fluid expulsion has not been identified as the cause of any of the 36 fire incidents in the subject vehicles. No indications of a common causal pattern were evident in the remaining 20 fire incidents in the subject vehicles.Six (6) of the incidents appear to be related to improper wiring of various added aftermarket equipment, 2 appear to be related to improper oil change, 1 was related to a damaged transfer case, 1 was related to an electrical short circuit and the remaining 10 were of unknown origin.Accordingly, this Preliminary Evaluation is closed.The ODI reports cited above can be reviewed at www-odi.Read more
PE — Closed
— Model Year: 2006
CLUTCH LINKAGE FAILURE
ON MAY 2, 2006 DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) A PART 573 REPORT ADVISING THAT CERTAIN MODEL YEAR 2006 JEEP WRANGLER VEHICLES WOULD BE VOLUNTARILY REC ALLED TO REPLACE A DEFECTIVE CLUTCH LINKAGE COMPONENT.THE RECALL ACTION IS
... IDENTIFIED BY NHTSA NO. 06V147 (DCC NO. F22).THE LINKAGE ROD BETWEEN THE CLUTCH PEDAL AND CLUTCH MASTER CYLINDER CAN BREAK WHEN THE CLUTCH PEDAL IS DEPRESSED; LINKAGE ROD FAILURE UNDER THESE CONDITIONS RESULTS IN IMMEDIATE ENGAGEMENT OF THE CLUTCH AND RENDERS THE CLUTCH PEDAL INEFFECTIVE THEREAFTER .THE 6,876 MANUAL TRANSMISSION VEHICLES INCLUDED IN THE RECALL ACTION WERE ALL MANUFACTURED BETWEEN 11/3/2005 AND 2/13/2006.DCC WILL REPLACE THE DEFECTIVE LINKAGE WITH A COMPONENT OF A PREVIOUS DESIGN LEVEL WHICH HAS NOT EXPERIENCED FIELD FAILURE.THE TIMING OF DCC'S ACTION HAS NOT BEEN DETERMINED.ACCORDINGLY, THIS PRELIMINARY EVALUATION IS CLOSED.Read more
EA — Closed
— Model Year: 1994
PARKING BRAKE RESULTING IN ROLLAWAY
There is no summary currently available
PE — Closed
— Model Year: 1994
PARKING BRAKE
ALLEGED THE THE PARKING BRAKE FAIL TO HOLD THE VEHICLE STATIONARY WHEN APPLIED, AND THE VEHICLE ROLLED AWAY
PE — Closed
— Model Year: 2000
AIR BAG MODULE DETACHMENT
ODI HAS RECEIVED A COMMPLAINT STATING THAT THE DRIVER-SIDE FRONTAL AIR BAG MODULE DETACHED FROM THE STEERING WHEEL WHILE ATTEMPTION TO USE THE HORN FOR THE FIRST TIME IN A BRAND NEW MODEL YEAR 2000 JEEP WRANGLE (PURCHASED I LATE MARCH 2000).THE AIR BAG MODULE FELL OFF THE STEERING WHEEL AND WAS HANG
... ING BY ITS WIRES.THE REPAIRING DELERSHIP STATED THAT THE TWO MOUNTING SCREWS, HOLDING THE INTEGTATED HORN/AIR BAG MODULE TO THE STEERING WHEEL, WERE MISSING.THIS INVESTIGATIONN IS OPENED TO DETERMINE THE SCOPE OF THE POTENTIAL PROBLEM OF MIS-ASSEMBLED AIR BAG MODULES IN TH EJEEP WRANGLE VEHICLES.Read more
RQ — Closed
— Model Year: 1999
INSTRUMENT PANEL GROUND SCREW
THE INSTRUMENT PANEL WIRING GROUND ATTACHMENT SCREWS CAN LOOSEN
RQ — Closed
— Model Year: 1992
FUEL LEAKAGE
ODI HAS RECEIVED 6 REPORTS ON FUEL LEAKAGE AND 3 REPORTS ON ALLEGED REMEDY FAILURE REPORTS
PE — Closed
— Model Year: 1990
SEAT BACK FAILURE
There is no summary currently available
EA — Closed
— Model Year: 1987
SEAT BELT BUCKLE FAILURE
There is no summary currently available
PE — Closed
— Model Year: 1988
SEAT BELT BUCKLE FAILURE
There is no summary currently available
EA — Closed
— Model Year: 1988
SENDING UNIT GASKET FAILS
There is no summary currently available
EA — Closed
— Model Year: 1989
DRIVESHAFT/UNIV.JOINT FAIL
There is no summary currently available
PE — Closed
— Model Year: 1990
SENDING UNIT GASKET FAILS
There is no summary currently available
PE — Closed
— Model Year: 1992
FUEL LINE LEAKAGE
There is no summary currently available
PE — Closed
— Model Year: 1988
EXHAUST SYSTEM FIRES
There is no summary currently available
EA — Closed
— Model Year: 1989
FUEL TANK/EXHAUST INTERFER
There is no summary currently available
PE — Closed
— Model Year: 1987
FUEL TANK/EXHAUST INTERFER
There is no summary currently available
PE — Closed
— Model Year: 1985
SAFETY BELT RETRACTOR
===
PE — Closed
— Model Year: 1987
WINDSHIELD WIPER FAILURE
There is no summary currently available