2026 CHEVROLET SILVERADO 3500

3 recalls, 5 complaints

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP:CONTROL/DRIVE MODULE

Defect Description

General Motors, LLC (GM) is recalling certain 2025-2026 Chevrolet Silverado 3500, and GMC Sierra 3500 vehicles with gasoline engines and dual fuel tanks (RPOs L8T and N2N). The rear fuel pump may not transfer adequate fuel to the front tank, causing an engine stall.

Consequence

An engine stall increases the risk of a crash.

Remedy

The vehicle's engine control module (ECM) will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed April 8, 2026. Owners may contact GMC customer service at 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number... Read more

11,807 vehicles affected

Manufacturer: General Motors, LLC

EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Defect Description

General Motors has decided that certain 2027 Chevrolet Bolt EV, 2025-2026 Cadillac OPTIQ, Chevrolet Colorado, Equinox EV, GMC Canyon, 2026 Buick Enclave, Envision, Cadillac CT5, Escalade, Escalade ESV, Escalade IQ, Escalade IQL, LYRIQ, VISTIQ, Chevrolet Blazer EV, Corvette Convertible, Corvette Coup... Read more

Consequence

Without an owner's manual to consult, owners may not know how to safely use and operate the vehicle, increasing the risk of injury in a crash.

Remedy

Dealers will reset the vehicle radio, which will facilitate automatic download of the electronic owner’s manual, free of charge. Owner notification letters were mailed April 16, 2026. Owners may contact GM customer service at 1-866-467-9700, Chevrolet customer service at 1-800-222-1020 or Cadillac... Read more

5,861 vehicles affected

Manufacturer: General Motors, LLC

EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Defect Description

General Motors, LLC (GM) is recalling certain 2026 Chevrolet Silverado 1500, 2500, and 3500 vehicles. These vehicles may not have received an owner's manual during production. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 225, “Child ... Read more

Consequence

Without an owner's manual to consult, owners may not know how to safely use and operate the vehicle, increasing the risk of injury in a crash.

Remedy

Dealers will provide the owner’s manual, free of charge. Owner notification letters were mailed December 30, 2025. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252532020. Vehicle Identification Numbers (VINs) involved in this recall became search... Read more

3,408 vehicles affected

Manufacturer: General Motors, LLC

Complaint Statistics

5 total complaints

Top Reported Components

Component	Complaints
STRUCTURE:BODY	1
ELECTRICAL SYSTEM	1
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL	1
ENGINE	1
POWER TRAIN	1

Incident date: Jun 13, 2026

THERE is a recall for the year, make and model for driver side airbag, also to do with transmission slipping and both of those I'm currently having issues with on my vehicle but with my vin its not coming up for any of the recalls but I want to request a Investigation on if my vehicle or any other o... Read more

Incident date: Jun 13, 2026

Incident date: May 15, 2026

chrome pillars came off on highway. the recall was sent in mail but upon visitation to kia for a different recall, I mentioned pillars and they did not have part to repair and there was a wait for part on their end is what they said. car was literally built with many defects I don't know how it pas... Read more

Incident date: May 15, 2026

When starting vehicle after leaving the grocery store, there were multiple fault messages displayed on the dash cluster. They were showing five fault areas, the Adaptive Cruise Control, Forward Collision Warning, Lane Departure Warning, Lane Keeping Assistance and Parking Collision Warning. When arr... Read more

Incident date: May 15, 2026

NHTSA Safety Investigations, CHEVROLET SILVERADO 3500

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 1997

REAR AXLE SEPARATION FROM VEHICLE

THE SINGLE CONSUMER COMPLAINT RECEIVED BY NHTSA REPORTED AN INCIDENT IN WHICH APPLICATION OF THE SERVICE BRAKES OF THE SUBJECT VEHICLE PRECIPITATED AN UNFOREWARNED LOSS OF VEHICLE CONTROL AS THE LEFT REAR AXLE SEPARATED FROM THE VEHICLE.INSPECTION OF THE VEHICLE FOLLOWING THE INCIDENT DISCLOSED THAT... THE LEFT REAR DUAL WHEELS HAD JAMMED INTO THE FENDER WELL AS THE AXLE SEPARATED FROM THE LEFT LEAF SPRING ASSEMBLY.THE NUTS WERE REPORTED MISSING FROM THE TWO U-BOLTS WHICH CLAMP THE REAR AXLE TO THE LEAF SPRINGS.THE INCIDENT OCCURRED ON A VEHICLE WITH A REPORTED ODOMETER READING OF 397 MILES.NO ADDITIONAL CONSUMER COMPLAINTS REGARDING THE ALLEGED DEFECT IN THE SUBJECT VEHICLES WERE RECEIVED BY THIS AGENCY SINCE THIS PE WAS INITIATED.INQUIRY TO THE MANUFACTURER DISCLOSED NO OTHER CONSUMER COMPLAINTS OR FIELD REPORTS OF SIMILAR NATURE, AND THREE WARRANTY CLAIMS WERE IDENTIFIED AS POTENTIALLY RELEVANT.THESE DATA APPLY TO THE 11,499 C/D 30-SERIES VEHICLES SOLD THROUGH MID-FEBRUARY, 1997, FROM THE TOTAL OF 27,385 BUILT AT GM'S FLINT ASSEMBLY PLANT.THE INQUIRY WAS LIMITED TO VEHICLES PRODUCED AT FLINT BECAUSE THE LOW MILEAGE OF THE COMPLAINANT VEHICLE SUGGESTED THAT ASSEMBLY/PRODUCTIION PROCEDURES MIGHT BE A SOURCE OF THE ISSUE.ODI ALSO CONTACTED THE GENERAL SERVICE ADMINISTRATION'S FLEET MANAGEMENT OFFICE AND DISCUSSED THE ISSUE.THEY SENT REQUESTS TO ALL OF THEIR REGIONAL FLEET MANAGERS ACROSS THE UNITED STATES, FOR ANY INFORMATION OR REPORTS OF FAILURES WITHIN THE GSA'S TOTAL FLEET OF SEVERAL HUNDRED TRUCKS. NO INCIDENT REPORTS WERE RECEIVED IN RESPONSE TO THESE INQUIRIES.THE APPLICATION OF PROPER TORQUES ON THE U-BOLT NUTS DURING VEHICLE ASSEMBLY IS ACCOMPLISHED BY AUTOMATED PNEUMATIC TOOLS THAT REQUIRE THE STATION OPERATOR TO ABSERVE AND MARK THE TORQUED ASSEMBLIES ACCORDING TO A COLOR CODE, AND TO NOTE ANY HIGH- OR LOW-TORQUE CONDITIONS ON AN INSPECTION TICKET.STATISTICAL REPORTS FOR THE ASSEMBLY FASTENING SYSTEM ARE PULLED TWICE PER SHIFT AND REVIEWED BY POWER TOOL PERSONNEL TO ENSURE THAT THE TOOL IS BEING USED AND THAT IT IS PERFORMING PROPERLY TO APPLY TORQUES WITHIN SPECIFIED ENGINEERING TOLERANCES.THE SINGLE CONSUMER COMPLAINT REPORTED FAILURE TO HAVE OCCURRED IN DECEMBER 1996. THE THREE WARRANTY CLAIMS WERE FILED IN NOVEMBER 1996, JANUARY 1997 AND FEBRUARY 1997.THIS TYPE OF FAILURE WOULD LIKELY BE DETECTED AND REPORTED VERY EARLY IN THE SERVICE LIFE OF THE VEHICLE, SO IT IS ALSO LIKELY THAT THE AFFECTED VEHICLES WERE PRODUCED OVER A PERIOD OF SEVERAL WEEKS AS OPPOSED TO A SINGLE PRODUCTION SHIFT, THE LATTER OF WHICH MIGHT INDICATE AN ASSEMBLY TOOL CALIBRATION OF OPERATOR PROBLEM DURING A SPECIFIC PERIOD OF TIME.THE SPREAD OF THE WARRANTY CLAIMS OVER SEVERAL WEEKS, TOGETHER WITH THE SINGLE INCIDENT REPORT, SUGGESTS THAT THESE INCIDENTS WERE OF A RANDOM NATURE, AS OPPOSED TO BEING INDICATORS OF A SYSTEMATIC ERROR IN THE PRODUCTION EQUIPMENT, THE ASSEMBLY PROCESS, OR THE QUALITY CONTROL MEASURES TAKEN.A SAFETY DEFECT TREND HAS NOT BEEN IDENTIFIED, AND THIS PE HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.Read more

CHEVROLET SILVERADO 3500 - All Years Overview

Complete safety history for the CHEVROLET SILVERADO 3500 across all model years (1997, 2026).

104 Total Recalls

1,459 Total Complaints

1 Investigations

79 Reported Crashes

24 Reported Fires

4 Reported Deaths

CHEVROLET SILVERADO 3500 - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2026 (current)	3	5
2025	1	19	View
2024	3	75	View
2023	1	21	View
2022	3	35	View
2021	5	56	View
2020	8	53	View
2019	7	34	View
2018	6	28	View
2017	6	14	View
2016	6	74	View
2015	7	78	View
2014	3	10	View
2013	4	36	View
2012	4	31	View
2011	5	42	View
2010	5	4	View
2009	6	10	View
2008	4	36	View
2007	5	42	View
2006	0	61	View
2005	1	60	View
2004	1	46	View
2003	1	60	View
2002	2	64	View
2001	2	97	View
2000	2	114	View
1999	1	73	View
1998	1	100	View
1997	1	78	View
1996	0	2	View
1994	0	1	View

Other CHEVROLET Models

Model	Recalls	Complaints
SUBURBAN	246	10,458	View
TAHOE	240	12,622	View
MALIBU	216	29,080	View
SILVERADO 1500	200	22,534	View
CORVETTE	187	6,308	View
CAMARO	179	4,298	View
SILVERADO	159	10,964	View
EXPRESS	151	838	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2026 CHEVROLET SILVERADO 3500

Complaint Statistics

Top Reported Components

NHTSA Safety Investigations, CHEVROLET SILVERADO 3500

CHEVROLET SILVERADO 3500 - All Years Overview

CHEVROLET SILVERADO 3500 - Year by Year

Other CHEVROLET Models