2025 CHEVROLET SILVERADO 3500

1 recalls, 19 complaints

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP:CONTROL/DRIVE MODULE

Defect Description

General Motors, LLC (GM) is recalling certain 2025-2026 Chevrolet Silverado 3500, and GMC Sierra 3500 vehicles with gasoline engines and dual fuel tanks (RPOs L8T and N2N). The rear fuel pump may not transfer adequate fuel to the front tank, causing an engine stall.

Consequence

An engine stall increases the risk of a crash.

Remedy

The vehicle's engine control module (ECM) will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed April 8, 2026. Owners may contact GMC customer service at 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number... Read more

11,807 vehicles affected

Manufacturer: General Motors, LLC

Complaint Statistics

19 total complaints

Top Reported Components

Component	Complaints
STEERING	5
ENGINE	4
POWER TRAIN	3
SUSPENSION	2
SERVICE BRAKES	1
FORWARD COLLISION AVOIDANCE: WARNINGS	1
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING	1
FUEL/PROPULSION SYSTEM	1
LANE DEPARTURE: BLIND SPOT DETECTION	1

Incident date: Jun 19, 2026

The vehicle's suspension system was improperly configured for its electric powertrain at the time of manufacture, resulting in an incorrect ride height that is incompatible with the vehicle's EV platform. This is not an isolated component failure but a fundamental design defect — the vehicle was d... Read more

Incident date: Jun 1, 2025

I was driving home from work late at night in December 2025. A Signal came on that said pull to safety or something like that and then I lost power steering and brake control and my entire dash in my vehicle went pitch black. I was in the middle lane on route 290 and I was very lucky not to hit an... Read more

Incident date: Jan 12, 2026

The blind spot system was a problem when I purchased the car, it spent 15 days in service in the first 30 days of ownership to address the issues. Now, I after another light came on I discovered 9 open recalls on the vehicle that were not disclosed prior to purchase.

Incident date: Jan 12, 2026

Incident date: Apr 13, 2026

Steering rack failure (wheel does not return to center, crunchy steering with increasingly more resistance over time).

Incident date: Apr 13, 2026

The same incident has occurred 4 times ( [XXX] While driving on the freeway in light traffic and no vehicles in front. The forward collision sensor triggered dropping the vehicle in speed approx 30 mph almost instantaneously. This is San Diego so no snow, rain or sleet and we were driving eastbound ... Read more

Incident date: Apr 13, 2026

Incident date: Jan 12, 2026

The vehicle has twice displayed a “Service High Voltage System” warning followed by “Reduced Acceleration – Drive With Care.” When this occurs, the vehicle enters a reduced-power (turtle) mode that severely limits acceleration. Cabin heat also stopped working, and the vehicle would not cha... Read more

Incident date: Jan 12, 2026

KIA/HYUNDAI INSPECTED AND FOUND CYLINDER 2 TO NOT FIRE ALONG WITH OIL LEAKING FROM LOWER 02 SENSOR. ENGINE BLOCK HAS HOLE, CYL 2 PISTON AND ROD ARE NO LONGER WITH/IN ENGINE. THIS OCCURED WHILE ACCELERATING ON THE FREEWAY ALL OF A SUDDEN VEHICLE STARTED SMOKING THEN LOST THE ABILITY TO ACCELERATE IT ... Read more

Incident date: Jan 12, 2026

Incident date: Oct 24, 2025

I am reporting a serious safety issue involving my 2025 Hyundai Palisade. The vehicle has repeatedly produced white smoke during cold start and has experienced loss of engine power while driving. Despite multiple repair visits (six times) to an authorized Hyundai dealership, the dealer repeatedly st... Read more

Incident date: May 26, 2025

In my 2013 Dodge Ram, after 12 years of running and driving practically perfectly, my Electrical Power Steering failed in June 2025 and lost power steering. My wife could have gotten into a collision. Even though this issues is part of a general recall issue for RAM during 2013-2016 models about, ... Read more

Incident date: May 26, 2025

My engine has started to burn excessive amounts of oil causing the oil light to flash. I took the car to the dealership and was told that it is a known defect in the engine and that if the car has over 100,000 miles they would recommend getting rid of the car because it could not be fixed and did no... Read more

Incident date: Jul 2, 2025

When slowing as I exited freeway the steering locked up and forced me into right lane. There were lots of warning lights, STOP when safe, steering assist problem, brake system problem, low speed braking problem. I had no power steering but was able to get car into a parking lot. I turned th... Read more

Incident date: Jul 2, 2025

My 2016 Kia Soul Plus (VIN: [XXX] ) showed a blinking check engine light and entered limp mode while driving. I had the code read and received P1326, which is a known issue in Kia vehicles related to the Knock Sensor Detection System (KSDS). This code indicates possible engine bearing wear or impen... Read more

Incident date: Apr 9, 2025

My 2020 Ford Expedition was repaired by Ford (under the power train warranty) in early 2024 for down shifting and loss of power when attempting to accelerate. That repair took multiple weeks. Last week (March 2025), while driving on the highway at 75mph, the vehicle lost all acceleration and the po... Read more

Incident date: Mar 7, 2025

The vehicle will lose power steering while driving. The lights come on for stabilitrak and traction control then it says power steering is gone. It randomly deactivates the power steering, while driving. It's extremely dangerous and have almost had accidents. They are telling me that it may not be u... Read more

Incident date: Mar 11, 2025

Car had an error message "drivetrain malfunction" car was drivable. Car has 87000 purchased in 2021. Car needs a new engine. Other Car owners having similar issues with the drivetrain malfunction

Incident date: Jan 13, 2025

had a recall on my truck to replace master brake master cylinder on October 2014, my truck lost braking power on [XXX] before I was able to leave my community almost resulted in me driving to a pond with toddler in the backseat. I was eventually able to bring truck to a full stop using extreme force... Read more

NHTSA Safety Investigations, CHEVROLET SILVERADO 3500

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 1997

REAR AXLE SEPARATION FROM VEHICLE

THE SINGLE CONSUMER COMPLAINT RECEIVED BY NHTSA REPORTED AN INCIDENT IN WHICH APPLICATION OF THE SERVICE BRAKES OF THE SUBJECT VEHICLE PRECIPITATED AN UNFOREWARNED LOSS OF VEHICLE CONTROL AS THE LEFT REAR AXLE SEPARATED FROM THE VEHICLE.INSPECTION OF THE VEHICLE FOLLOWING THE INCIDENT DISCLOSED THAT... THE LEFT REAR DUAL WHEELS HAD JAMMED INTO THE FENDER WELL AS THE AXLE SEPARATED FROM THE LEFT LEAF SPRING ASSEMBLY.THE NUTS WERE REPORTED MISSING FROM THE TWO U-BOLTS WHICH CLAMP THE REAR AXLE TO THE LEAF SPRINGS.THE INCIDENT OCCURRED ON A VEHICLE WITH A REPORTED ODOMETER READING OF 397 MILES.NO ADDITIONAL CONSUMER COMPLAINTS REGARDING THE ALLEGED DEFECT IN THE SUBJECT VEHICLES WERE RECEIVED BY THIS AGENCY SINCE THIS PE WAS INITIATED.INQUIRY TO THE MANUFACTURER DISCLOSED NO OTHER CONSUMER COMPLAINTS OR FIELD REPORTS OF SIMILAR NATURE, AND THREE WARRANTY CLAIMS WERE IDENTIFIED AS POTENTIALLY RELEVANT.THESE DATA APPLY TO THE 11,499 C/D 30-SERIES VEHICLES SOLD THROUGH MID-FEBRUARY, 1997, FROM THE TOTAL OF 27,385 BUILT AT GM'S FLINT ASSEMBLY PLANT.THE INQUIRY WAS LIMITED TO VEHICLES PRODUCED AT FLINT BECAUSE THE LOW MILEAGE OF THE COMPLAINANT VEHICLE SUGGESTED THAT ASSEMBLY/PRODUCTIION PROCEDURES MIGHT BE A SOURCE OF THE ISSUE.ODI ALSO CONTACTED THE GENERAL SERVICE ADMINISTRATION'S FLEET MANAGEMENT OFFICE AND DISCUSSED THE ISSUE.THEY SENT REQUESTS TO ALL OF THEIR REGIONAL FLEET MANAGERS ACROSS THE UNITED STATES, FOR ANY INFORMATION OR REPORTS OF FAILURES WITHIN THE GSA'S TOTAL FLEET OF SEVERAL HUNDRED TRUCKS. NO INCIDENT REPORTS WERE RECEIVED IN RESPONSE TO THESE INQUIRIES.THE APPLICATION OF PROPER TORQUES ON THE U-BOLT NUTS DURING VEHICLE ASSEMBLY IS ACCOMPLISHED BY AUTOMATED PNEUMATIC TOOLS THAT REQUIRE THE STATION OPERATOR TO ABSERVE AND MARK THE TORQUED ASSEMBLIES ACCORDING TO A COLOR CODE, AND TO NOTE ANY HIGH- OR LOW-TORQUE CONDITIONS ON AN INSPECTION TICKET.STATISTICAL REPORTS FOR THE ASSEMBLY FASTENING SYSTEM ARE PULLED TWICE PER SHIFT AND REVIEWED BY POWER TOOL PERSONNEL TO ENSURE THAT THE TOOL IS BEING USED AND THAT IT IS PERFORMING PROPERLY TO APPLY TORQUES WITHIN SPECIFIED ENGINEERING TOLERANCES.THE SINGLE CONSUMER COMPLAINT REPORTED FAILURE TO HAVE OCCURRED IN DECEMBER 1996. THE THREE WARRANTY CLAIMS WERE FILED IN NOVEMBER 1996, JANUARY 1997 AND FEBRUARY 1997.THIS TYPE OF FAILURE WOULD LIKELY BE DETECTED AND REPORTED VERY EARLY IN THE SERVICE LIFE OF THE VEHICLE, SO IT IS ALSO LIKELY THAT THE AFFECTED VEHICLES WERE PRODUCED OVER A PERIOD OF SEVERAL WEEKS AS OPPOSED TO A SINGLE PRODUCTION SHIFT, THE LATTER OF WHICH MIGHT INDICATE AN ASSEMBLY TOOL CALIBRATION OF OPERATOR PROBLEM DURING A SPECIFIC PERIOD OF TIME.THE SPREAD OF THE WARRANTY CLAIMS OVER SEVERAL WEEKS, TOGETHER WITH THE SINGLE INCIDENT REPORT, SUGGESTS THAT THESE INCIDENTS WERE OF A RANDOM NATURE, AS OPPOSED TO BEING INDICATORS OF A SYSTEMATIC ERROR IN THE PRODUCTION EQUIPMENT, THE ASSEMBLY PROCESS, OR THE QUALITY CONTROL MEASURES TAKEN.A SAFETY DEFECT TREND HAS NOT BEEN IDENTIFIED, AND THIS PE HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.Read more

CHEVROLET SILVERADO 3500 - All Years Overview

Complete safety history for the CHEVROLET SILVERADO 3500 across all model years (1997, 2026).

104 Total Recalls

1,459 Total Complaints

1 Investigations

79 Reported Crashes

24 Reported Fires

4 Reported Deaths

CHEVROLET SILVERADO 3500 - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2026	3	5	View
2025 (current)	1	19
2024	3	75	View
2023	1	21	View
2022	3	35	View
2021	5	56	View
2020	8	53	View
2019	7	34	View
2018	6	28	View
2017	6	14	View
2016	6	74	View
2015	7	78	View
2014	3	10	View
2013	4	36	View
2012	4	31	View
2011	5	42	View
2010	5	4	View
2009	6	10	View
2008	4	36	View
2007	5	42	View
2006	0	61	View
2005	1	60	View
2004	1	46	View
2003	1	60	View
2002	2	64	View
2001	2	97	View
2000	2	114	View
1999	1	73	View
1998	1	100	View
1997	1	78	View
1996	0	2	View
1994	0	1	View

Other CHEVROLET Models

Model	Recalls	Complaints
SUBURBAN	246	10,458	View
TAHOE	240	12,622	View
MALIBU	216	29,080	View
SILVERADO 1500	200	22,534	View
CORVETTE	187	6,308	View
CAMARO	179	4,298	View
SILVERADO	159	10,964	View
EXPRESS	151	838	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2025 CHEVROLET SILVERADO 3500

Complaint Statistics

Top Reported Components

NHTSA Safety Investigations, CHEVROLET SILVERADO 3500

CHEVROLET SILVERADO 3500 - All Years Overview

CHEVROLET SILVERADO 3500 - Year by Year

Other CHEVROLET Models