2003 CHEVROLET SILVERADO 3500
1 recalls, 60 complaints - 204 TSBs
06E043000 May 19, 2006
FUEL SYSTEM, GASOLINE
Defect Description
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CE... Read more
Consequence
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Remedy
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Complaint Statistics
60 total complaints
2 fires
Top Reported Components
| Component | Complaints |
|---|---|
| SERVICE BRAKES, HYDRAULIC | 13 |
| SERVICE BRAKES | 10 |
| ELECTRICAL SYSTEM | 5 |
| FUEL SYSTEM, DIESEL | 3 |
| FUEL/PROPULSION SYSTEM | 2 |
| ENGINE | 2 |
| POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE) | 2 |
| ENGINE AND ENGINE COOLING:ENGINE:DIESEL | 2 |
| EXTERIOR LIGHTING | 2 |
| TIRES | 2 |
SERVICE BRAKES
Jul 28, 2016
Incident date: Oct 22, 2014
DRIVING THROUGH A RURAL TOWN GOING ABOUT 45 MILES AN HOUR, I APPLIED THE BRAKES AND THEY WERE VERY SOFT, BRAKE PEDAL WENT NEAR THE FLOOR, EASED IT HOME ON FRONT BRAKES (AS REAR LINE HAD RUPTURED). UPON INSPECTION BRAKE LINE HAD RUSTED IN TWO JUST BEHIND THE FUEL TANK (LONG SECTION HAD RUSTED AWAY).... Read more
POWER TRAIN
Jun 3, 2016
Incident date: May 17, 2016
TL* THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 3500. WHILE DRIVING APPROXIMATELY 4 MPH, THE CLUTCH PANEL ASSEMBLY FRACTURED INTO THE FLOORBOARD WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND A DEALER ON TWO SEPARATE OCCASIONS WHERE IT WAS DIAGNOSED THAT THE CLUTCH PANEL FAILE... Read more
FUEL/PROPULSION SYSTEM
Oct 29, 2015
Incident date: Oct 17, 2015
TL* THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 3500. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE ENGINE STALLED AND THERE WAS AN ABNORMAL NOISE. THE CONTACT WAS A CERTIFIED MECHANIC AND DIAGNOSED THAT THE FUEL INJECTOR FAILED. THE VEHICLE WAS RESTARTED AND THE FAILURE RECURRED. THE MANUFACTUR... Read more
ENGINE
Oct 29, 2015
Incident date: Oct 17, 2015
TL* THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 3500. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE ENGINE STALLED AND THERE WAS AN ABNORMAL NOISE. THE CONTACT WAS A CERTIFIED MECHANIC AND DIAGNOSED THAT THE FUEL INJECTOR FAILED. THE VEHICLE WAS RESTARTED AND THE FAILURE RECURRED. THE MANUFACTUR... Read more
SERVICE BRAKES
Dec 27, 2014
Incident date: Dec 27, 2014
WAS DRIVING ALONG AT APPROXIMATELY 40 MILES AN HOUR WHEN TO APPLY THE BRAKES THE BRAKE LINE RUPTURED AND I HAD TO STEER OFF THE ROAD INTO DITCH. *TR
SERVICE BRAKES
Sep 29, 2014
Incident date: Sep 23, 2014
I WAS DRIVING TO WORK IN THE MORNING ON 9/23/14 AND WENT TO APPLY THE BRAKES TO SLOW DOWN, WHEN THE BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR. I WAS ABLE TO SLOW DOWN WHILE DOWN SHIFTING THE TRANSMISSION AND NARROWLY MISSING HITTING THE VEHICLE IN FRONT OF ME. I PULLED OVER AND NOTICED BRAKE FLUID... Read more
SERVICE BRAKES
Aug 19, 2014
Incident date: Aug 12, 2014
THANK GOD MY HUSBAND WAS WITH ME AND KNEW WHAT TO DO. I WAS DRIVING. AS WE WERE GOING DOWN THE INTERSTATE AT 65 MPH WE HEAR A NOISE NOT HAVING A CLUE IN THE WORLD. HE SAID WE NEED TO FIND A PULL OFF AND SEE WHAT THAT COULD BE. AS I WENT TO EXIT OFF I DISCOVERED I HAD NO BRAKES. NONE WHATSOEVER. AS M... Read more
SERVICE BRAKES
Jun 4, 2014
Incident date: Jun 1, 2014
TL* THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 3500. THE CONTACT STATED THAT THE BRAKES FAILED WITH NO WARNING. THE CONTACT ATTEMPTED TO DRIVE THE VEHICLE ON A RESIDENTIAL ROAD AND UPON APPLYING THE BRAKES, THE PEDAL EXTENDED TO THE FLOORBOARD. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE ONTO THE EM... Read more
PARKING BRAKE:DRIVELINE:HYDRAULIC:HOSES, LINES/PIPING, AND FITTINGS
Jun 4, 2014
Incident date: Jun 1, 2014
TL* THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 3500. THE CONTACT STATED THAT THE BRAKES FAILED WITH NO WARNING. THE CONTACT ATTEMPTED TO DRIVE THE VEHICLE ON A RESIDENTIAL ROAD AND UPON APPLYING THE BRAKES, THE PEDAL EXTENDED TO THE FLOORBOARD. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE ONTO THE EM... Read more
EXTERIOR LIGHTING
Apr 28, 2014
Incident date: Apr 25, 2014
FIRST COMPLAINT FOR THIS PROBLEM WAS REPORTED ON 10/21/10. COMPLAINT #10361641. SAME PROBLEM AGAIN DTR LIGHT ON RIGHT SIDE OUT,SMELLED BURNING WIRE SAW THAT THE SAME THING HAPPENED AGAIN. WIRES LEADING TO LIGHT ASSEMBLY MELTED AND ALSO MELTED THE SOCKET AGAIN. I THINK THIS COULD POSSIBLY LEAD TO SO... Read more
Fire
ELECTRICAL SYSTEM
Apr 28, 2014
Incident date: Apr 25, 2014
FIRST COMPLAINT FOR THIS PROBLEM WAS REPORTED ON 10/21/10. COMPLAINT #10361641. SAME PROBLEM AGAIN DTR LIGHT ON RIGHT SIDE OUT,SMELLED BURNING WIRE SAW THAT THE SAME THING HAPPENED AGAIN. WIRES LEADING TO LIGHT ASSEMBLY MELTED AND ALSO MELTED THE SOCKET AGAIN. I THINK THIS COULD POSSIBLY LEAD TO SO... Read more
Fire
FUEL/PROPULSION SYSTEM
Apr 24, 2014
Incident date: Feb 3, 2014
TL*THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 3500. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHO RESET THE COMPUTER AND REPLACED THE FUEL TANK ALONG WITH THE FUEL TRANSFER PUMP. THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFI... Read more
FUEL SYSTEM, GASOLINE
Mar 21, 2014
Incident date: Jun 20, 2012
FIRST FAILURE WAS THE DUAL BRAKING SYSTEM I WAS HOOKED UP TO A TRAILER AND STARTED DOWN THE DRIVEWAY (ABOUT 0.4MILE LONG) AND STEPPED ON THE BRAKE PEDAL WHICH WENT TO THE FLOOR BOARDS. THERE WAS NO STOPPING EFFORT FROM THE BRAKES. I USED THE MANUAL CONTROL OF THE TRAILER BRAKES TO STOP THE VEHICLE. ... Read more
SERVICE BRAKES, HYDRAULIC
Mar 21, 2014
Incident date: Jun 20, 2012
FIRST FAILURE WAS THE DUAL BRAKING SYSTEM I WAS HOOKED UP TO A TRAILER AND STARTED DOWN THE DRIVEWAY (ABOUT 0.4MILE LONG) AND STEPPED ON THE BRAKE PEDAL WHICH WENT TO THE FLOOR BOARDS. THERE WAS NO STOPPING EFFORT FROM THE BRAKES. I USED THE MANUAL CONTROL OF THE TRAILER BRAKES TO STOP THE VEHICLE. ... Read more
SERVICE BRAKES
Feb 10, 2014
Incident date: Feb 7, 2014
TL-THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 3500. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH, THE BRAKE PEDAL WAS APPLIED NUMEROUS TIMES BEFORE THE VEHICLE WOULD STOP. THE CONTACT WAS ABLE TO RESUME WITH CAUTION. HE ALSO NOTICED THAT THE BRAKE LINE WAS RUPTURED AND CAUSED BRAKE FL... Read more
FUEL SYSTEM, DIESEL
Jan 2, 2014
Incident date: Jan 24, 2013
DRIVING DOWN THE ROAD AND TRUCK JUST STARTS STALLING OUT. GOT IT TO THE FORD DEALERSHIP WHO SAYS THERE IS RUST IN THE TANK AND THE FUEL FILTER IS FULL OF IT. THIS IS A SAFETY ISSUE AS I WAS BARELY ABLE TO GET OFF OF THE ROAD. THESE TRUCKS NEED TO BE RECALLED FOR THE FUEL TANKS. I'VE HAD VEHICLES... Read more
FUEL SYSTEM, DIESEL
Jul 23, 2013
Incident date: Sep 27, 2006
GM HAD A INJECTOR PROBLEM (RECALL ) IN 2006. THEY REPLACED MINE ON SEPT,27 2006. ON MAY 21 20013 I HAD THE SAME PROBLEM IN WHICH GM CONVEYS THEY CAN'T FIX IT AGAIN. THE MILEAGE ON MAY, 21 WAS 84362, JUST ABOUT HOW LONG THE OTHERS LASTED. I WAS TOLD FROM MY LOCAL GM DEALER THAT THEY ARE SEVERAL OT... Read more
ENGINE
Jul 23, 2013
Incident date: Sep 27, 2006
GM HAD A INJECTOR PROBLEM (RECALL ) IN 2006. THEY REPLACED MINE ON SEPT,27 2006. ON MAY 21 20013 I HAD THE SAME PROBLEM IN WHICH GM CONVEYS THEY CAN'T FIX IT AGAIN. THE MILEAGE ON MAY, 21 WAS 84362, JUST ABOUT HOW LONG THE OTHERS LASTED. I WAS TOLD FROM MY LOCAL GM DEALER THAT THEY ARE SEVERAL OT... Read more
SERVICE BRAKES
Nov 24, 2012
Incident date: Nov 15, 2012
WHEN BACKING OUT OF DRIVEWAY WENT TO STOP AND PEDDLE WENT TO FLOOR,BLOWING BRAKE FLUID ALL OVER ROAD.I HAVE READ MANY ARTICLES ON THIS PROBLEM,WITH CHEVY PRODUCTS.THANK HEAVENS I WAS NOT DRIVING ON THE HIGHWAY AND THIS HAPPENED. ENOUGH SAID SHOULD BE A RECALL,OR REIMBURSEMENT FOR REPAIRS ALL READY F... Read more
SERVICE BRAKES
Nov 21, 2012
Incident date: Nov 8, 2012
BRAKE LINES HAD EXCESSIVE AMOUNT OF CORROSION/RUSTED CAUSING A LEAK(S). LINES GOING FROM THE ABS MODULE TO THE FRONT BRAKES WERE FOUND TO BE LEAKING. LINES GOING FROM THE ABS SYSTEM TO THE RESERVOIR WERE ALSO RUSTED AND REQUIRED REPLACEMENT. LINES FROM THE ABS SYSTEM TO THE REAR BRAKES BEGAN LEAK... Read more
SERVICE BRAKES
Oct 29, 2012
Incident date: Oct 29, 2012
BRAKE LINES ARE ALL RUSTED AS ARE FUEL LINES, BRAKE LINE DEVELOPED LEAK AFTER HARD STOP, PEDAL WENT TO FLOOR, REPAIR SHOP IS NOW REPLACING BRAKE LINES. *TR
SERVICE BRAKES
Jul 8, 2012
Incident date: Nov 15, 2011
HAD CORRODED FUEL LINES REPLACED. MECHANIC STATED THAT BRAKE LINES LOOKED IN BAD SHAPE AND SUGGESTED THEY BE REPLACED ALSO. HAD LIMITED USAGE OF MY TRUCK WHILE I LOOKED INTO HAVING THEM REPLACED. ON ONE OCCASION I WAS APPROACHING A STOP SIGN WITH MY WIFE IN TRUCK, AS I WENT TO STOP, LINE RUPTURED, P... Read more
SERVICE BRAKES, HYDRAULIC
Nov 8, 2011
Incident date: Oct 27, 2011
WIFE WAS COMING HOME FROM WORK AT NIGHT WENT TO STOP AND LOST BRAKES. I GOT IT BACK HOME AND INSPECTED IT AND FOUND THAT IT BLEW A REAR AND FRONT BRAKE LINE. THE BRAKE LINES WERE ROTTED SO BAD WE REPLACED THEM ALL. UPON REPLACING BRAKE LINES I NOTICED THAT FUEL LINES WERE ALSO ROTTED SEVERELY AND ON... Read more
SERVICE BRAKES, HYDRAULIC
Nov 4, 2011
Incident date: Nov 4, 2011
TL* THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 3500. THE CONTACT STATED THAT WHILE BRAKING TO A STOP, THE BRAKE PEDAL WENT TO THE FLOORBOARD ABNORMALLY AND HE WAS UNABLE TO ENGAGE THE BRAKES. THE CONTACT STATED THAT HE HAD TO SHIFT INTO NEUTRAL IN ORDER TO STOP THE VEHICLE. HE ALSO MENTIONED THAT A... Read more
SERVICE BRAKES, HYDRAULIC
Oct 20, 2011
Incident date: Oct 20, 2011
ON THE ABOVE LISTED DATE THE BRAKES ON MY TRUCK FAILED WHILE GOING DOWN HILL NOT FAR FROM MY HOUSE, THIS WAS NOT A COMPLETE FAILURE AS I WAS ABLE TO STOP, GET TURNED AROUND AND GO HOME. UPON FURTHER INVESTIGATION I FOUND A BRAKE LINE THAT RUSTED THROUGH. WHILE LOOKING ON LINE FOR PARTS AND GUIDANCE ... Read more
SERVICE BRAKES, HYDRAULIC
Oct 19, 2011
Incident date: Oct 19, 2011
2003 CHEVY SILVERADO LAST YEAR BRAKE LINES BROKE WHILE ON ROAD DUE TO SEVERE CORROSION LINES . WE WERE LUCKY NOT TO HAVE HAD AN ACCIDENT REPLACED ALL LINES ON VEHICLE. NOW ALL ROTORS HAD TO BE REPLACED DUE TO SEVERE CORROSION ON THEM . POOR QUALITY OF ROTORS AND CALIBERS ON VEHICLE . WE ONLY HAVE 38... Read more
SERVICE BRAKES, HYDRAULIC
Aug 19, 2011
Incident date: Aug 17, 2011
FULL BRAKE SYSTEM FAILURE. DURING A PANIC STOP TO AVOID A MULTI-CAR ACCIDENT ALL THE METAL BRAKE LINES BETWEEN THE ABS MODULE AND THE WHEEL ENDS BURST DUE TO RUST AND CORROSION BUILD UP. ALL THE METAL LINES MUST BE REPLACED WITH NEW. *TR
FUEL SYSTEM, OTHER
Aug 19, 2011
Incident date: Feb 2, 2010
WHILE DRIVING HOME AROUND 10 PM WITH SMALL CHILDREN; MY TRUCK STARTED TO SURGE, BECAME DIFFICULT TO CONTROL, AND THE GAUGES DID NOT REGISTER ANYTHING ( ALL AT 0). THIS ROAD WAS IN THE MIDDLE OF NOWHERE AND OUTSIDE A BAD AREA, SO I CALLED MY HUSBAND TO COME FOLLOW ME HOME AND I DROVE HOME SLOWLY ALL ... Read more
ELECTRICAL SYSTEM
Aug 19, 2011
Incident date: Feb 2, 2010
WHILE DRIVING HOME AROUND 10 PM WITH SMALL CHILDREN; MY TRUCK STARTED TO SURGE, BECAME DIFFICULT TO CONTROL, AND THE GAUGES DID NOT REGISTER ANYTHING ( ALL AT 0). THIS ROAD WAS IN THE MIDDLE OF NOWHERE AND OUTSIDE A BAD AREA, SO I CALLED MY HUSBAND TO COME FOLLOW ME HOME AND I DROVE HOME SLOWLY ALL ... Read more
EQUIPMENT
Aug 19, 2011
Incident date: Feb 2, 2010
WHILE DRIVING HOME AROUND 10 PM WITH SMALL CHILDREN; MY TRUCK STARTED TO SURGE, BECAME DIFFICULT TO CONTROL, AND THE GAUGES DID NOT REGISTER ANYTHING ( ALL AT 0). THIS ROAD WAS IN THE MIDDLE OF NOWHERE AND OUTSIDE A BAD AREA, SO I CALLED MY HUSBAND TO COME FOLLOW ME HOME AND I DROVE HOME SLOWLY ALL ... Read more
SERVICE BRAKES, HYDRAULIC
Aug 19, 2011
Incident date: May 10, 2007
VEHICLE IS A CHEVY 2003 4X4 3500 DUALLY WITH APPROXIMATELY 87,000 MILES. SUDDEN AND COMPLETE BRAKE FAILURE WHILE DRIVING DUE TO CORRODED BRAKE LINE LEAK I SINCE HAD FIXED. WHILE BRAKING AT SLOW SPEEDS THE BRAKE PEDAL SLAMS TO THE FLOOR AND IN REVERSE THERE IS ALSO A LOUD CLUNK THAT SHAKES THE TRUCK.... Read more
ELECTRICAL SYSTEM
Jun 26, 2011
Incident date: Jun 10, 2010
GM PASSLOCK THEFT DETERRENT SYSTEM IS LEAVING THOUSANDS OF PEOPLE STRANDED . THIS PROBLEM IS WIDESPREAD AND NEEDS TO BE ADDRESSED. *TR
SERVICE BRAKES, HYDRAULIC
Mar 23, 2011
Incident date: Jan 28, 2011
BRAKE LINES RUST THROUGH WITH NO ADVANCE WARNING. IN MY CASE IT WAS AT HIGHWAY SPEEDS WHILE THE TRUCK WAS LOADED WITH APPROX. 1000 LBS OF MATERIAL. FORTUNATELY IT WAS JUST THE REAR LINES SO I STILL HAD FRONT BRAKES TO BRING THE VEHICLE TO A COMPLETE STOP. WHEN RESEARCHING THIS EVENT I FOUND CASES TH... Read more
SERVICE BRAKES, HYDRAULIC
Jan 9, 2011
Incident date: Jul 15, 2006
I HAVE A 2003 CHEVY K3500 SILVERADO TRUCK, WITH ABOUT 60,000 MILES. AS OF DECEMBER 2010, I HAVE SUFFERED TWO BRAKE LINE FAILURES DUE TO CORROSION, WHEREIN A STEEL RIGID BRAKE LINE RUSTED COMPLETELY THROUGH, RESULTING IN BRAKE LOSS. I LIVE IN OHIO, AND SALT IS USED ON ROADS, HOWEVER, IN MY 30 YEARS... Read more
ELECTRICAL SYSTEM
Oct 21, 2010
Incident date: Oct 18, 2010
DAY TIME RUNNING LIGHTS STOPPED WORKING.WHEN REPLACING BULBS FOUND SOCKETS BURNED TO BULB BASE AND WIRES TO SOCKETS BURNT. HAD TO REPLACE SECTION OF WIRES AND BREAK BULB BASE TO REMOVE. CONDITION CAN POSSIBLY CAUSE A FIRE IN ELECTRICAL SYSTEM. *TR
EXTERIOR LIGHTING
Oct 21, 2010
Incident date: Oct 18, 2010
DAY TIME RUNNING LIGHTS STOPPED WORKING.WHEN REPLACING BULBS FOUND SOCKETS BURNED TO BULB BASE AND WIRES TO SOCKETS BURNT. HAD TO REPLACE SECTION OF WIRES AND BREAK BULB BASE TO REMOVE. CONDITION CAN POSSIBLY CAUSE A FIRE IN ELECTRICAL SYSTEM. *TR
SERVICE BRAKES, HYDRAULIC
Aug 16, 2010
Incident date: Aug 16, 2003
SUDDEN COMPLETE BRAKE FAILURE WHILE DRIVING DUE TO CORRODED BRAKE LINE LEAK . VEHICLE IS A CHEVY 2003 4X4 3500 DUALLY WITH APPROXIMATELY 82,000 MILES. VEHICLE IS CURRENTLY AT REPAIR SHOP. ALL BRAKE LINES ARE SEVERELY RUSTED AND WILL HAVE TO BE REPLACED. *TR
SERVICE BRAKES, HYDRAULIC
Aug 14, 2010
Incident date: May 10, 2010
ABS AT LOW SPEED ACTIVATES, BRAKING PEDAL LOW. *TR
SERVICE BRAKES, HYDRAULIC
Jul 28, 2010
Incident date: Nov 18, 2004
THIS CLAIM IS ON A CHEVY SILVERADO 3500 DIESEL TRUCK THAT I BOUGHT NEW. AROUND 30,000 MILES THIS VEHICLE WAS TAKEN IN FOR CLUTCH PROBLEMS 3 TIMES, BRAKES GOING TO THE FLOOR, THE WINDSHIELD COMING LOOSE, RADIO PROBLEMS, STEERING PROBLEMS AND TIRE WEAR. GENERAL MOTORS, THE BETTER BUSINESS BUREAU AN... Read more
POWER TRAIN:DRIVELINE
Jul 28, 2010
Incident date: Nov 18, 2004
THIS CLAIM IS ON A CHEVY SILVERADO 3500 DIESEL TRUCK THAT I BOUGHT NEW. AROUND 30,000 MILES THIS VEHICLE WAS TAKEN IN FOR CLUTCH PROBLEMS 3 TIMES, BRAKES GOING TO THE FLOOR, THE WINDSHIELD COMING LOOSE, RADIO PROBLEMS, STEERING PROBLEMS AND TIRE WEAR. GENERAL MOTORS, THE BETTER BUSINESS BUREAU AN... Read more
EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
Jul 28, 2010
Incident date: Nov 18, 2004
THIS CLAIM IS ON A CHEVY SILVERADO 3500 DIESEL TRUCK THAT I BOUGHT NEW. AROUND 30,000 MILES THIS VEHICLE WAS TAKEN IN FOR CLUTCH PROBLEMS 3 TIMES, BRAKES GOING TO THE FLOOR, THE WINDSHIELD COMING LOOSE, RADIO PROBLEMS, STEERING PROBLEMS AND TIRE WEAR. GENERAL MOTORS, THE BETTER BUSINESS BUREAU AN... Read more
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Jul 28, 2010
Incident date: Nov 18, 2004
THIS CLAIM IS ON A CHEVY SILVERADO 3500 DIESEL TRUCK THAT I BOUGHT NEW. AROUND 30,000 MILES THIS VEHICLE WAS TAKEN IN FOR CLUTCH PROBLEMS 3 TIMES, BRAKES GOING TO THE FLOOR, THE WINDSHIELD COMING LOOSE, RADIO PROBLEMS, STEERING PROBLEMS AND TIRE WEAR. GENERAL MOTORS, THE BETTER BUSINESS BUREAU AN... Read more
TIRES
Jul 28, 2010
Incident date: Nov 18, 2004
THIS CLAIM IS ON A CHEVY SILVERADO 3500 DIESEL TRUCK THAT I BOUGHT NEW. AROUND 30,000 MILES THIS VEHICLE WAS TAKEN IN FOR CLUTCH PROBLEMS 3 TIMES, BRAKES GOING TO THE FLOOR, THE WINDSHIELD COMING LOOSE, RADIO PROBLEMS, STEERING PROBLEMS AND TIRE WEAR. GENERAL MOTORS, THE BETTER BUSINESS BUREAU AN... Read more
SUSPENSION
Jul 28, 2010
Incident date: Nov 18, 2004
THIS CLAIM IS ON A CHEVY SILVERADO 3500 DIESEL TRUCK THAT I BOUGHT NEW. AROUND 30,000 MILES THIS VEHICLE WAS TAKEN IN FOR CLUTCH PROBLEMS 3 TIMES, BRAKES GOING TO THE FLOOR, THE WINDSHIELD COMING LOOSE, RADIO PROBLEMS, STEERING PROBLEMS AND TIRE WEAR. GENERAL MOTORS, THE BETTER BUSINESS BUREAU AN... Read more
STEERING
Jul 28, 2010
Incident date: Nov 18, 2004
THIS CLAIM IS ON A CHEVY SILVERADO 3500 DIESEL TRUCK THAT I BOUGHT NEW. AROUND 30,000 MILES THIS VEHICLE WAS TAKEN IN FOR CLUTCH PROBLEMS 3 TIMES, BRAKES GOING TO THE FLOOR, THE WINDSHIELD COMING LOOSE, RADIO PROBLEMS, STEERING PROBLEMS AND TIRE WEAR. GENERAL MOTORS, THE BETTER BUSINESS BUREAU AN... Read more
STRUCTURE
Jul 28, 2010
Incident date: Nov 18, 2004
THIS CLAIM IS ON A CHEVY SILVERADO 3500 DIESEL TRUCK THAT I BOUGHT NEW. AROUND 30,000 MILES THIS VEHICLE WAS TAKEN IN FOR CLUTCH PROBLEMS 3 TIMES, BRAKES GOING TO THE FLOOR, THE WINDSHIELD COMING LOOSE, RADIO PROBLEMS, STEERING PROBLEMS AND TIRE WEAR. GENERAL MOTORS, THE BETTER BUSINESS BUREAU AN... Read more
ENGINE AND ENGINE COOLING:ENGINE
Jul 28, 2010
Incident date: Nov 18, 2004
THIS CLAIM IS ON A CHEVY SILVERADO 3500 DIESEL TRUCK THAT I BOUGHT NEW. AROUND 30,000 MILES THIS VEHICLE WAS TAKEN IN FOR CLUTCH PROBLEMS 3 TIMES, BRAKES GOING TO THE FLOOR, THE WINDSHIELD COMING LOOSE, RADIO PROBLEMS, STEERING PROBLEMS AND TIRE WEAR. GENERAL MOTORS, THE BETTER BUSINESS BUREAU AN... Read more
SERVICE BRAKES, HYDRAULIC
Jul 13, 2010
Incident date: Jul 12, 2010
TL* THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 3500. THE CONTACT STATED WHILE BRAKING FROM 15 MPH. THE BRAKE PEDAL FELL TO THE FLOORBOARD AND THE BRAKES DID NOT ENGAGE. THE CONTACT WAS ABLE TO STOP THE VEHICLE BY USING THE EMERGENCY BRAKE. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND HAD NO... Read more
ELECTRICAL SYSTEM
Feb 9, 2010
Incident date: Jan 7, 2010
SPEEDOMETER FAILURE AT 92,000 MILES. SPEEDOMETER SWINGS OVER ACTUAL SPEED. THIS IS A PROBLEM ON SEVERAL CHEVROLET MODELS TAHOES AND PICKUPS. I HAVE A NEIGHBOR AND HIS WENT OUT AT 82, 000 MILES. *TR
TIRES
Sep 16, 2009
Incident date: Aug 10, 2009
TL*THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 3500. THE CONTACT STATED THAT THE FRONT AND REAR OUTER DRIVER SIDE COOPER TIRES BEGAN LOSING RUBBER WHICH CAUSED TREAD SEPARATION. WHILE DRIVING 50 MPH ON THE HIGHWAY, THE TIRE TREAD HAS CONTINUOUSLY SEPARATED FROM THE TIRES. THE COOPER DEALER AND MANU... Read more
Showing 50 of 60 complaints.
Technical Service Bulletins, 2003 CHEVROLET SILVERADO 3500
204 manufacturer communications from 133 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 060000 ENGINE AND ENGINE COOLING | 35 |
| 350000 EQUIPMENT | 22 |
| 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL | 18 |
| 110000 ELECTRICAL SYSTEM | 18 |
| 356000 EQUIPMENT ADAPTIVE/MOBILITY | 9 |
| 060000 ENGINE (PWS) | 8 |
| 030000 BRAKES (PWS) | 7 |
| 353000 EQUIPMENT:ELECTRICAL | 7 |
10-08-45-001H
Mar 28, 2024
110000 ELECTRICAL SYSTEM
This bulletin provides information for electrical ground repairs using new General Motors replacement fasteners with conductive finish.
06-06-01-019C
Mar 14, 2024
060000 ENGINE AND ENGINE COOLING
This bulletin advises the technician of possible location of an internal coolant leak from a specific cylinder head and location.
16-NA-383
Mar 13, 2024
060000 ENGINE AND ENGINE COOLING
This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels shou
22-NA-074
Feb 22, 2024
060000 ENGINE AND ENGINE COOLING
This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.
18-NA-099
Jan 16, 2024
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.
PI1394B
Jan 12, 2024
100000 POWER TRAIN
This PI bulletin advises the technician on the proper way to install the pistons in an engine.
PI1394B
Jan 12, 2024
060000 ENGINE AND ENGINE COOLING
This PI bulletin advises the technician on the proper way to install the pistons in an engine.
02-08-42-001J
Jan 12, 2024
120000 EXTERIOR LIGHTING
This informational bulletin provides information for dealers/technicians on Headlamp, Tail Lamp, License Lamp or Fog/Driving Lamp Damage.
PIP5601B
Jan 12, 2024
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This Preliminary Information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. Technician will need to use Pico Oscilloscope Di
23-NA-219
Dec 12, 2023
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.
23-NA-219
Dec 12, 2023
350000 EQUIPMENT
This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.
17-NA-170
Oct 6, 2023
200000 WHEELS
This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.
PIT5099G
Sep 26, 2023
138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have hi
10-00-89-006J
Sep 26, 2023
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).
07-08-49-020R
Sep 21, 2023
117100 ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER
This informational bulletin provides information for the IPC odometer programming method quick reference guide.
07-08-49-020R
Sep 21, 2023
350000 EQUIPMENT
This informational bulletin provides information for the IPC odometer programming method quick reference guide.
07-08-49-020R
Sep 21, 2023
110000 ELECTRICAL SYSTEM
This informational bulletin provides information for the IPC odometer programming method quick reference guide.
23-NA-153
Sep 1, 2023
060000 ENGINE AND ENGINE COOLING
The service bulletin advises the tech of a normal transmission shift condition and the delay in throttle response when the throttle plate is opened rapidly and advises the customer that it is normal for the delay.
23-NA-153
Sep 1, 2023
100000 POWER TRAIN
The service bulletin advises the tech of a normal transmission shift condition and the delay in throttle response when the throttle plate is opened rapidly and advises the customer that it is normal for the delay.
18-NA-073
Aug 24, 2023
060000 ENGINE AND ENGINE COOLING
This service bulletin provides graphics, information and guidelines for engine component wear to assist service personnel as a guideline to perform necessary engine repairs and prevent unnecessary engine replacement.
23-NA-144
Aug 18, 2023
030000 BRAKES (PWS)
This technical bulletin provides information and a solution to a condition of Brake Pedal Moves or Self Applies at Full Turns.
03-06-01-023G
Jul 31, 2023
060000 ENGINE AND ENGINE COOLING
This service bulletin explains how to measure for oil consumption and possible reasons for loss of oil.
17-NA-170
Apr 27, 2023
200000 WHEELS
This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.
PIP5628F
Apr 24, 2023
061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)
This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D
19-NA-219
Apr 24, 2023
060000 ENGINE AND ENGINE COOLING
This diagnostic tip bulletin provides additional information on how to diagnose a possible valve, lifter or camshaft issue.
19-NA-219
Mar 23, 2023
060000 ENGINE AND ENGINE COOLING
This diagnostic tip bulletin provides additional information on how to diagnose a possible valve, lifter or camshaft issue.
22-NA-009
Mar 17, 2023
060000 ENGINE AND ENGINE COOLING
This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.
17-NA-073
Feb 21, 2023
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This warranty administration bulletin provides information regarding the field action courtesy transportation policy.
01-08-42-001O
Feb 15, 2023
120000 EXTERIOR LIGHTING
This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.
23-NA-001
Feb 15, 2023
350000 EQUIPMENT
This service bulletin provides information for dealers/technicians on OnStar Module 2G Sunset Information.
23-NA-001
Jan 6, 2023
110000 ELECTRICAL SYSTEM
This service bulletin provides information for dealers/technicians on OnStar Module 2G Sunset Information.
23-NA-001
Jan 6, 2023
350000 EQUIPMENT
This service bulletin provides information for dealers/technicians on OnStar Module 2G Sunset Information.
09-00-89-008F
Dec 21, 2022
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This Warranty Administration bulletin provides retail and wholesale service personnel with the policies/procedures and the warranty transaction submission procedures that support the Personal Property Damage process.
PIP5540J
Dec 15, 2022
138220 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REAR WINDOW:ELECTRICAL HEATING ELEMENT
This Preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. To allow the ice to melt so that it can be drained from the related component
21-NA-124
Dec 14, 2022
060000 ENGINE AND ENGINE COOLING
This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or P0455 Set.
PIT3271N
Nov 29, 2022
200000 WHEELS
This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo
PIT3271N
Nov 29, 2022
190000 TIRES
This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo
22-NA-074
Nov 9, 2022
060000 ENGINE AND ENGINE COOLING
This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.
22-NA-205
Oct 19, 2022
110000 ELECTRICAL SYSTEM
This service bulletin provides information on Module Harvesting.
PIT3665L
Oct 18, 2022
030000 BRAKES (PWS)
This Preliminary Information communication advises the technician that the Hydro-Boost is not serviceable and will need to be replaced if the brake pedal moves or applies on its own at a full turn.
10-00-89-006I
Oct 7, 2022
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).
22-NA-195
Sep 28, 2022
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This service bulletin provides information on Handling Requests for Modifications to Permanently Import/Export Vehicles Between the U.S. and Canada.
06-00-89-031H
Sep 16, 2022
100000 POWER TRAIN
This service bulletin provides information on OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification.
06-00-89-031H
Sep 16, 2022
060000 ENGINE AND ENGINE COOLING
This service bulletin provides information on OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification.
22-NA-009
Sep 14, 2022
060000 ENGINE AND ENGINE COOLING
This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.
22-NA-181
Sep 1, 2022
100000 POWER TRAIN
This diagnostic tip advises the tech not to separate the flexplate from the torque convertor or damage my occur if the engine is started while diagnosing for noise from the engine or transmission.
20-NA-065
Aug 15, 2022
060000 ENGINE AND ENGINE COOLING
This bulletin provides information on tools available to find an intake vacuum leak or exhaust leak to correct a condition of MIL Illuminated with Multiple Fuel Trim and/or Oxygen Sensor Codes Set.
22-NA-009
Jun 15, 2022
060000 ENGINE AND ENGINE COOLING
This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.
PIT5099F
Jun 13, 2022
138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have hi
18-NA-099
May 16, 2022
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.
12-00-89-003B
May 2, 2022
060000 ENGINE (PWS)
This service bulletin provides policy information on warranty administration guidelines for multiple repairs with independent causes (GM Canada Dealers Only).
12-00-89-003B
May 2, 2022
353000 EQUIPMENT:ELECTRICAL
This service bulletin provides policy information on warranty administration guidelines for multiple repairs with independent causes (GM Canada Dealers Only).
03-06-01-023E
Apr 27, 2022
060000 ENGINE AND ENGINE COOLING
This information bulletin explains how to measure for oil consumption and possible reasons for loss of oil.
22-NA-074
Mar 31, 2022
060000 ENGINE AND ENGINE COOLING
This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.
22-NA-009
Mar 22, 2022
060000 ENGINE AND ENGINE COOLING
This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.
05-00-89-072E
Mar 22, 2022
070000 FUEL SYSTEM, GASOLINE
This service bulletin provides the technician with additional information on fuels, fuel additives and fuel management.
05-00-89-072E
Mar 22, 2022
060000 ENGINE AND ENGINE COOLING
This service bulletin provides the technician with additional information on fuels, fuel additives and fuel management.
04-06-04-051F
Mar 22, 2022
354000 EQUIPMENT:MECHANICAL
This service bulletin provides information for maintenance cleaning of the fuel injectors and gasoline detergent additive.
04-06-04-051F
Mar 22, 2022
073000 FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
This service bulletin provides information for maintenance cleaning of the fuel injectors and gasoline detergent additive.
PIT3271M
Mar 7, 2022
200000 WHEELS
This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo
PIT3271M
Mar 7, 2022
190000 TIRES
This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo
22NA009
Jan 11, 2022
061520 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:FILTER/SCREEN
This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.
PIP5628E
Dec 14, 2021
060000 ENGINE AND ENGINE COOLING
This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D
PIT3099U
Aug 11, 2021
350000 EQUIPMENT
This Preliminary Information communication provides information to the technician about installing General Motors Accessory parts/kits. Technicians should refer to Service Information for information regarding most accessories. Technician
PIT3271K
Nov 11, 2020
200000 WHEELS
This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo
PIT3271K
Nov 11, 2020
190000 TIRES
This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo
16NA383
May 8, 2020
060000 ENGINE (PWS)
This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels shou
16NA383
May 8, 2020
356000 EQUIPMENT ADAPTIVE/MOBILITY
This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels shou
16NA383
May 8, 2020
073000 FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels shou
PIT5195F
Apr 27, 2020
110000 ELECTRICAL SYSTEM
This Preliminary Information communication provides information to the technician about vehicles that the speedometer needle appears to be inaccurate. Dealer should advise the customer the specification for speedometer needle accuracy is +/
16NA383
Jan 2, 2020
356000 EQUIPMENT ADAPTIVE/MOBILITY
This informational bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels
16NA383
Jan 2, 2020
350000 EQUIPMENT
This informational bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels
16NA383
Jan 2, 2020
073000 FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
This informational bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels
060309004N
Oct 31, 2019
021240 SUSPENSION:FRONT:SPRINGS:LEAF SPRING ASSEMBLY
This technical bulletin provides a procedure to apply grease to the leaf springs to correct a condition of a squeak noise from the metals making contact.
100089006G
Oct 16, 2019
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This informational bulletin provides information for dealers how to submit a product information report (PIR) (Canada Only).
100089009C
Oct 9, 2019
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This informational bulletin provides information on key code security and information on GM key code look up applications.
DOR-K2S2K-10
Jul 26, 2019
350000 EQUIPMENT
This SKU is a Pitman Arm. The customer communication requested return of unsold inventory to inspect for the spline size. If the spline size is incorrect it will not have a tight fit with the mating component, and would lead to detectabl
PIT3665H
Jun 24, 2019
030000 BRAKES (PWS)
This Preliminary Information communication advises the technician that the Hydro-Boost is not serviceable and will need to be replaced if the brake pedal moves or applies on its own at a full turn.
PIP5540D
Feb 19, 2019
060000 ENGINE AND ENGINE COOLING
This Preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. To allow the ice to melt so that it can be drained from the related component
PIT3227P
Dec 17, 2018
162500 STRUCTURE:BODY:TAILGATE
This Preliminary Information communication provides information to the technician about vehicles that may have slack in one of the tailgate cables. Technician should not replace any parts for this concern. Please communicate to the customer
PIP5540B
Dec 6, 2018
060000 ENGINE AND ENGINE COOLING
This Preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. To allow the ice to melt so that it can be drained from the related component
PIP4925B
Dec 3, 2018
063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
This preliminary information document communicates a tip on the way to diagnose possible induction or exhaust air leaks using the evaporative emission cart smoke machine and ultrasonic leak detector tools.
150089004B
Oct 1, 2017
021400 SUSPENSION:FRONT:MACPHERSON STRUT
Information Regarding the Differences Between Fluid Leakage and Seepage This bulletin is intended to help identify the differences between what is considered a fluid leak and what is considered seepage. Improper diagnosis may lead to un
150089004B
Oct 1, 2017
022400 SUSPENSION:REAR:SHOCK ABSORBER
Information Regarding the Differences Between Fluid Leakage and Seepage This bulletin is intended to help identify the differences between what is considered a fluid leak and what is considered seepage. Improper diagnosis may lead to un
150089004B
Oct 1, 2017
021300 SUSPENSION:FRONT:SHOCK ABSORBER
Information Regarding the Differences Between Fluid Leakage and Seepage This bulletin is intended to help identify the differences between what is considered a fluid leak and what is considered seepage. Improper diagnosis may lead to un
070849020M
Oct 1, 2017
117110 ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER:SENSOR/SENDING UNIT
IPC Odometer Programming Method Quick Reference Guide
070849020M
Oct 1, 2017
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
IPC Odometer Programming Method Quick Reference Guide
15-08-73-001A
Mar 21, 2017
118000 ELECTRICAL SYSTEM:SOFTWARE
This informational bulletin explains how to update the older Onstar module software to new software over GSA.
17-NA-073
Mar 15, 2017
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This warranty administration bulletin provides policy information with the field action courtesy transportation policy.
PI1394A
Aug 29, 2016
060000 ENGINE (PWS)
THIS INFORMATIONAL BULLETIN PROVIDES ADDITIONAL INFORMATION ON HOW TO INSTALL PISTONS AND SUGGEST WHAT TOOLS TO USE.
16NA260
Aug 26, 2016
353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
THIS TECHNICAL BULLETIN PROVIDES A PROCEDURE TO REPROGRAM THE MEDIA DISC PLAYER WITH THE LATEST CALIBRATIONS TO CORRECT A CONDITION OF THE REAR ENTERTAINMENT SYSTEM NOT OPERATING AS INTENDED IN COLDER AMBIENT TEMPERATURE AREAS DUE TO CALIBR
000601012F
Aug 2, 2016
060000 ENGINE (PWS)
THIS INFORMATIONAL BULLETIN PROVIDES INFORMATION TO GM DEALERS ON THE CORRECT CLEANING METHODS WHEN CLEANING ENGINE GASKET SEALING SURFACES.
PIT5485B
Apr 27, 2016
110000 ELECTRICAL SYSTEM
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN IF UNABLE TO PLACE AN ONSTAR CALL IN THE IGNITION ON MODE AFTER THE ONSTAR CANADA UPGRADE, TO CONTACT THE GM TECHNICAL ASSISTANCE CENTER ONSTAR GROUP FOR FURTHER ASSISTANCE.
PIT5485B
Apr 27, 2016
353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN IF UNABLE TO PLACE AN ONSTAR CALL IN THE IGNITION ON MODE AFTER THE ONSTAR CANADA UPGRADE, TO CONTACT THE GM TECHNICAL ASSISTANCE CENTER ONSTAR GROUP FOR FURTHER ASSISTANCE.
PIC5088F
Apr 21, 2016
353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN ON THE STEPS TO DIAGNOSE AND REPAIR THE CONCERN. THE VEHICLE'S XM RADIO ONLY HAS XM PREVEIW CHANNELS.
PIC5050A
Apr 19, 2016
353000 EQUIPMENT:ELECTRICAL
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON REPAIRING THE CONCERN. A CUSTOMER MAY IDENTIFY A CONCERN OF UNABLE TO REACTIVATE A VEHICLE'S ONSTAR THAT HAS BEEN PREVIOUSLY DISABLED BY ONSTAR. DEALER IS TO CA
PIC4935E
Apr 19, 2016
110000 ELECTRICAL SYSTEM
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO HELP THE DEALERSHIP TECHNICIANS PERFORM A PARASITIC DRAIN TEST FOR THE ONSTAR MODULE. WHEN PERFORMING BATTERY PARASITIC DRAIN TEST, THERE MAY BE SOME CONFUSION AS TO WHAT TH
PIC-4935-E
Apr 19, 2016
111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO HELP THE DEALERSHIP TECHNICIANS PERFORM A PARASITIC DRAIN TEST FOR THE ONSTAR MODULE. WHEN PERFORMING BATTERY PARASITIC DRAIN TEST, THERE MAY BE SOME CONFUSION AS TO WHAT TH
PIC-4935-E
Apr 19, 2016
110000 ELECTRICAL SYSTEM
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO HELP THE DEALERSHIP TECHNICIANS PERFORM A PARASITIC DRAIN TEST FOR THE ONSTAR MODULE. WHEN PERFORMING BATTERY PARASITIC DRAIN TEST, THERE MAY BE SOME CONFUSION AS TO WHAT TH
PIT5389A
Apr 19, 2016
353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN ON THE STEPS FOR DIAGNOSING THE CONCERN. THE VEHICLE MAY BE UNABLE TO CONNECT TO ONSTAR USING THE WHITE, BLUE OR RED ONSTAR BUTTONS.
Showing 100 of 204 bulletins.
NHTSA Safety Investigations, CHEVROLET SILVERADO 3500
Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.
PE97001
Opened: Jan 17, 1997 , Closed: May 29, 1997
REAR AXLE SEPARATION FROM VEHICLE
THE SINGLE CONSUMER COMPLAINT RECEIVED BY NHTSA REPORTED AN INCIDENT IN WHICH APPLICATION OF THE SERVICE BRAKES OF THE SUBJECT VEHICLE PRECIPITATED AN UNFOREWARNED LOSS OF VEHICLE CONTROL AS THE LEFT REAR AXLE SEPARATED FROM THE VEHICLE.INSPECTION OF THE VEHICLE FOLLOWING THE INCIDENT DISCLOSED THAT... Read more
CHEVROLET SILVERADO 3500 - All Years Overview
Complete safety history for the CHEVROLET SILVERADO 3500 across all model years (1997, 2026).
104
Total Recalls
1,459
Total Complaints
1
Investigations
79
Reported Crashes
24
Reported Fires
4
Reported Deaths
CHEVROLET SILVERADO 3500 - Year by Year
Compare recalls and complaints across model years. Click any year to see full details.
| Year | Recalls | Complaints | |
|---|---|---|---|
| 2026 | 3 | 5 | View |
| 2025 | 1 | 19 | View |
| 2024 | 3 | 75 | View |
| 2023 | 1 | 21 | View |
| 2022 | 3 | 35 | View |
| 2021 | 5 | 56 | View |
| 2020 | 8 | 53 | View |
| 2019 | 7 | 34 | View |
| 2018 | 6 | 28 | View |
| 2017 | 6 | 14 | View |
| 2016 | 6 | 74 | View |
| 2015 | 7 | 78 | View |
| 2014 | 3 | 10 | View |
| 2013 | 4 | 36 | View |
| 2012 | 4 | 31 | View |
| 2011 | 5 | 42 | View |
| 2010 | 5 | 4 | View |
| 2009 | 6 | 10 | View |
| 2008 | 4 | 36 | View |
| 2007 | 5 | 42 | View |
| 2006 | 0 | 61 | View |
| 2005 | 1 | 60 | View |
| 2004 | 1 | 46 | View |
| 2003 (current) | 1 | 60 | |
| 2002 | 2 | 64 | View |
| 2001 | 2 | 97 | View |
| 2000 | 2 | 114 | View |
| 1999 | 1 | 73 | View |
| 1998 | 1 | 100 | View |
| 1997 | 1 | 78 | View |
| 1996 | 0 | 2 | View |
| 1994 | 0 | 1 | View |