2023 CHEVROLET SILVERADO 3500
1 recalls, 21 complaints - 613 TSBs
24V060000 Feb 1, 2024
LATCHES/LOCKS/LINKAGES:TAILGATE:LATCH
Defect Description
General Motors, LLC (GM) is recalling certain 2020-2024 Chevrolet Silverado 2500, 3500, GMC Sierra 2500 and 3500 vehicles equipped with power-unlatching tailgates. The tailgate's electronic gate-release switch may short circuit due to water intrusion, which can result in the tailgate inadvertently ... Read more
Consequence
An unlatched tailgate may open while driving and result in a loss of unsecured cargo, creating a road hazard and increasing the risk of a crash.
Remedy
Owners are advised to check that the tailgate is closed and latched before driving. Dealers will replace the exterior touchpad switch assemblies, free of charge. Owner notification letters were mailed May 17, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer se... Read more
Complaint Statistics
21 total complaints
1 fires
Top Reported Components
| Component | Complaints |
|---|---|
| UNKNOWN OR OTHER | 6 |
| POWER TRAIN | 5 |
| ELECTRICAL SYSTEM | 2 |
| FUEL/PROPULSION SYSTEM | 2 |
| ENGINE | 2 |
| TIRES | 1 |
| STEERING | 1 |
| BACK OVER PREVENTION | 1 |
| VEHICLE SPEED CONTROL | 1 |
VEHICLE SPEED CONTROL
Jul 8, 2026
Incident date: Jun 8, 2026
One day as I was turning at a green light the car completely stopped on me. I had to turn it off and then restart it and it worked fine. About a week later I had to drive to my cousin's house 45 minutes away and the car would not go, it acted like it was stalling and It didn't want to go over 2000RP... Read more
UNKNOWN OR OTHER
Jun 27, 2026
Incident date: Jun 4, 2026
First Failure occurred 7 months after purchase at 5,270 miles on August 1, 2024. The vehicle suddenly went into "Limp Mode" abruptly decelerating to 25 mph with a non-responsive gas pedal. A code reader displayed PO653 Sensor Reference: "Voltage B Circuit High". Dealer found corroded wire to batte... Read more
FUEL/PROPULSION SYSTEM
Jun 3, 2026
Incident date: May 19, 2026
This vehicle (VIN: [XXX] ) has suffered repeated catastrophic engine shutdowns and complete loss of propulsion power while in motion. The dashboard displayed "Engine off! Shift to P or N, then start engine." This has occurred so many times the owner lost count, requiring multiple tows to Kia of Beav... Read more
ENGINE
Jun 3, 2026
Incident date: May 19, 2026
This vehicle (VIN: [XXX] ) has suffered repeated catastrophic engine shutdowns and complete loss of propulsion power while in motion. The dashboard displayed "Engine off! Shift to P or N, then start engine." This has occurred so many times the owner lost count, requiring multiple tows to Kia of Beav... Read more
POWER TRAIN
Aug 10, 2025
Incident date: Jul 31, 2025
Fraudulently sold vehicle from Janovich Auto in Omaha, Ne. That does not have correct or proper documentation on vehicles history. Dealership purchased vehicle in New York. And sold it to me in Nebraska. With showing me history and suspect them bring it to Nebraska with proper legal documention.
ELECTRICAL SYSTEM
Jun 17, 2025
Incident date: Apr 12, 2025
I am the owner of a 2021 Ford Mustang Mach-E affected by Recall 25S65 involving a 12V battery discharge issue that creates a serious entrapment hazard. If the 12V battery fails, the front doors can remain locked—even if someone exits using the mechanical release. This puts me and my family at risk... Read more
UNKNOWN OR OTHER
Jun 17, 2025
Incident date: Apr 12, 2025
The tailgate keeps dropping while driving and while parked. The key fob is in a protected area or not near truck at all when this occurs
POWER TRAIN
Jun 17, 2025
Incident date: Apr 12, 2025
While driving down the highway suddenly loss of power with MIL light. Pulled over contacted dealer. Codes p200a and p200b. Set up appointment. Delivered vehicle to dealer. Inspection shows excessive soot buildup inside intake. Loss of power on road could cause vehicle accident and/or leave people st... Read more
ENGINE
Jun 11, 2025
Incident date: Feb 1, 2025
The contact owns a 2023 Kia Sportage. The contact stated while driving approximately 35 MPH, the instrument cluster went black, and the vehicle stalled. The contact stated that before being able to pull over, the vehicle restarted. The contact stated that the vehicle was taken to a local dealer who ... Read more
BACK OVER PREVENTION
Jun 2, 2025
Incident date: May 1, 2025
The contact owns a 2014 Ford Escape. The contact stated while reversing, the rearview camera failed to display an image of the rear of the vehicle. The vehicle returned to normal functionality, but the failure became a regular occurrence. The vehicle was taken to an independent mechanic, who diagnos... Read more
UNKNOWN OR OTHER
May 2, 2025
Incident date: Mar 31, 2025
My vehicle has 43K miles and I just got a p1098 code. I took it to a local mechanic and they have determined that the Engine coolant Control Valve Position Sensor is not functioning. This is causing the fan to run at 100% at all times. I am also getting a message on the dash stating that the vehicle... Read more
POWER TRAIN
May 2, 2025
Incident date: Mar 31, 2025
The contact owns a 2019 Jeep Cherokee. The contact received notification of NHTSA Campaign Number: 25V011000 (POWER TRAIN); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not available. The contact stated that the man... Read more
STEERING
May 1, 2025
Incident date: Mar 28, 2025
While driving power steering goes out. It is in an independent service center. Loss power steering while driving almost lost control of vehicle. Independent service center has confirmed it's the same as 2015 recall. Yes, an independent service center has the truck since April 25. Yes, power steering... Read more
UNKNOWN OR OTHER
May 1, 2025
Incident date: Mar 28, 2025
chevy Silverado shakes at 20, 40,65 and 70 mph chevy shake
UNKNOWN OR OTHER
Apr 26, 2025
Incident date: Apr 1, 2025
Drivers side front door hinge welds broken
FUEL/PROPULSION SYSTEM
Apr 26, 2025
Incident date: Apr 1, 2025
Suddenly when riding the motorcycle I discovered a massive fuel leak from the gas cap on to the front cylinder head. I immediately pulled over and inspected the gas cap for tightness. I found that the gasoline cap was sufficiently tight and the sealing surface of the o-ring was okay as well. The gas... Read more
POWER TRAIN
Apr 14, 2025
Incident date: Mar 5, 2025
Transfer case broken; no longer sending power to the rear wheels. Car loses traction when accelerating from a stop.
POWER TRAIN
Jan 23, 2025
Incident date: Jan 21, 2025
Lifter failure at 8629 miles. All warning lights went on at time of incident, truck would barely drive home and I had it towed into the dealership where they replaced the entire bank of lifters. This is on my repair order- "Checked and found dead mis on cylinder 4 and ticking noise from engine//pe... Read more
ELECTRICAL SYSTEM
Nov 1, 2024
Incident date: Oct 31, 2024
I was driving my 2024 CX90 PHEV when a warning about an electrical leakage in the hybrid system was detected. I brought it home and parked in my garage. I called the dealership and they told me to bring it in. When I started to leave, the car would not shift out of park and bricked up. A towing se... Read more
TIRES
Aug 29, 2024
Incident date: Oct 16, 2023
The contact owns a 2023 Chevrolet Malibu equipped with Continental Tires, Tire Line: Pro Contact, Tire Size: 245/40/R19, DOT Number: 6Y66WBR27. The contact stated that while his wife was driving at highway speeds, there was a blowout of the front driver's side tire. The cause of the failure was not ... Read more
UNKNOWN OR OTHER
Aug 7, 2024
Incident date: Jun 21, 2024
Our 2020 Chevy 1500 Trail Boss was waiting for an ordered instrument cluster at service department. The surveillance camera, film the vehicle catch on fire after being parked for 2 days. The smoke started from the inside, and the vehicle engulfed in flames until the fire department came. After t... Read more
Fire
Technical Service Bulletins, 2023 CHEVROLET SILVERADO 3500
613 manufacturer communications from 295 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 060000 ENGINE AND ENGINE COOLING | 120 |
| 110000 ELECTRICAL SYSTEM | 99 |
| 350000 EQUIPMENT | 87 |
| 100000 POWER TRAIN | 50 |
| 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL | 33 |
| 080000 FUEL SYSTEM, DIESEL | 30 |
| 160000 STRUCTURE | 18 |
| 200000 WHEELS | 17 |
23-NA-032
Apr 29, 2024
060000 ENGINE AND ENGINE COOLING
The informational bulletin advises the tech to use the glow plug bore cleaner to reduce the chance of soot building up on the glow plug causing a premature failure.
N232426401-01
Apr 25, 2024
170000 LATCHES/LOCKS/LINKAGES
Customer Satisfaction Program. As a remedy for Safety Recall N232426400, certain vehicles had the liftgate exterior release switch assembly disabled. This Customer Satisfaction Program provides the final repair to restore the function of
N232426401
Apr 24, 2024
170000 LATCHES/LOCKS/LINKAGES
Customer Satisfaction Program. As a remedy for Safety Recall N232426400, certain vehicles had the liftgate exterior release switch assembly disabled. This Customer Satisfaction Program provides the final repair to restore the function of
00-03-10-006P
Apr 18, 2024
200000 WHEELS
This service bulletin provides information for dealers/technicians on Tire Radial Force Variation (RFV).
23-NA-064
Apr 16, 2024
110000 ELECTRICAL SYSTEM
This service bulletin provides information on the Transport Mode Feature, also known as Logistics mode, which is used to increase the 12V Battery stand time of the vehicle during transit and or long period of stand time at the dealerships.
23-NA-064
Apr 16, 2024
350000 EQUIPMENT
This service bulletin provides information on the Transport Mode Feature, also known as Logistics mode, which is used to increase the 12V Battery stand time of the vehicle during transit and or long period of stand time at the dealerships.
20-NA-022
Apr 16, 2024
020000 SUSPENSION
This technical bulletin provides a procedure to re-torque the leaf spring u bolts to correct a condition of Clunking Noise from Rear of Vehicle (Re-torque Leaf Spring Bolts).
22-NA-038
Apr 12, 2024
980000 UNKNOWN OR OTHER
This warranty bulletin provides information on Customer Concern Not Duplicated (CCND) Labor Operation Numbers.
20-NA-132
Apr 10, 2024
350000 EQUIPMENT
This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.
20-NA-132
Apr 10, 2024
110000 ELECTRICAL SYSTEM
This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.
21-NA-155
Apr 8, 2024
350000 EQUIPMENT
This informational bulletin advises the technician to check for faults that may be caused by the trailer otherwise found by a possible faulty trailer connector.
21-NA-155
Apr 8, 2024
110000 ELECTRICAL SYSTEM
This informational bulletin advises the technician to check for faults that may be caused by the trailer otherwise found by a possible faulty trailer connector.
21-NA-155
Apr 8, 2024
030000 SERVICE BRAKES, HYDRAULIC
This informational bulletin advises the technician to check for faults that may be caused by the trailer otherwise found by a possible faulty trailer connector.
17-NA-052
Apr 8, 2024
350000 EQUIPMENT
This bulletin updates the position of General Motors on refinishing aluminum wheels. GM has determined that wheel refinishing under warranty will no longer be performed.
17-NA-052
Apr 8, 2024
200000 WHEELS
This bulletin updates the position of General Motors on refinishing aluminum wheels. GM has determined that wheel refinishing under warranty will no longer be performed.
10-08-45-001H
Mar 28, 2024
110000 ELECTRICAL SYSTEM
This bulletin provides information for electrical ground repairs using new General Motors replacement fasteners with conductive finish.
19-NA-255
Mar 27, 2024
160000 STRUCTURE
This preliminary informational bulletin provides frame coating repair information to correct a customer concern of wax coating on frame peeling, metal shows corrosion/rusting (U.S. and Canada Only).
20-NA-132
Mar 26, 2024
110000 ELECTRICAL SYSTEM
This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.
20-NA-132
Mar 26, 2024
111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.
20-NA-132
Mar 26, 2024
350000 EQUIPMENT
This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.
20-NA-132
Mar 26, 2024
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.
20-NA-132
Mar 26, 2024
118000 ELECTRICAL SYSTEM:SOFTWARE
This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.
19-NA-255
Mar 21, 2024
160000 STRUCTURE
This preliminary informational bulletin provides frame coating repair information to correct a customer concern of wax coating on frame peeling, metal shows corrosion/rusting (U.S. and Canada Only).
23-NA-103
Mar 21, 2024
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This service bulletin provides information on submitting quality Photos of Various Vehicle Concerns to the GM Technical Assistance Center (TAC).
24-NA-060
Mar 20, 2024
353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
This service bulletin provides repair information to correct a customer concerns of Radio Software issues.
24-NA-060
Mar 20, 2024
350000 EQUIPMENT
This service bulletin provides repair information to correct a customer concerns of Radio Software issues.
24-NA-060
Mar 20, 2024
110000 ELECTRICAL SYSTEM
This service bulletin provides repair information to correct a customer concerns of Radio Software issues.
17-NA-302
Mar 20, 2024
350000 EQUIPMENT
This informational bulletin provides information on availability for a locking gas cap for trucks are operated in high amount of dirt or dust which can migrate to the filler cap area.
17-NA-302
Mar 20, 2024
081100 FUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY
This informational bulletin provides information on availability for a locking gas cap for trucks are operated in high amount of dirt or dust which can migrate to the filler cap area.
16-NA-383
Mar 13, 2024
060000 ENGINE AND ENGINE COOLING
This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels shou
PIT6132
Mar 12, 2024
138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
This Preliminary information communicates an issues with the HVAC making a hum buzz noise when the blower is set to a higher speed. Engineering is working on a new HVAC door seal material to correct the noise.
23-NA-170
Mar 11, 2024
110000 ELECTRICAL SYSTEM
This bulletin advises the tech to inspect deeper into what may be the main cause of an engine failure.
23-NA-170
Mar 11, 2024
100000 POWER TRAIN
This bulletin advises the tech to inspect deeper into what may be the main cause of an engine failure.
23-NA-170
Mar 11, 2024
060000 ENGINE AND ENGINE COOLING
This bulletin advises the tech to inspect deeper into what may be the main cause of an engine failure.
07-00-89-037S
Mar 11, 2024
350000 EQUIPMENT
This warranty administration bulletin provides policy information for GM courtesy transportation and roadside assistance programs.
11-00-89-005X
Mar 10, 2024
350000 EQUIPMENT
This Warranty Administration bulletin provides information on Dealer Empowerment for Goodwill, Customer Enthusiasm and Policy (U.S. Only).
PIT5689G
Mar 7, 2024
110000 ELECTRICAL SYSTEM
This Preliminary information communicates that some customers may comment that after an auto-stop event the engine does not restart and to inspect the engine ground strap. Temporarily on hold while PIE0572 is active. PIE0572 has now ended
24-NA-046
Mar 7, 2024
132000 VISIBILITY:GLASS, SIDE/REAR
This technical bulletin provides a procedure to correct the condition of Suction Cup Marks on Window Glass.
24-NA-040
Mar 4, 2024
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This service bulletin provides information on All hazmat parts being returned to the Warranty Parts Center (WPC) must be shipped using Central Transport. Hazardous materials should never be sent by air transportation to the WPC.
17-NA-073
Mar 1, 2024
980000 UNKNOWN OR OTHER
This warranty administration bulletin provides information regarding the field action courtesy transportation policy.
22-NA-182
Feb 26, 2024
100000 POWER TRAIN
This service bulletin advises the technician to check if the transmission cooler lines are twisted to correct customer concerns of Harsh Shift, Shudder, Surge, Stall, Transmission Overheating and/or High Transmission Fluid Temperature.
23-NA-169
Feb 26, 2024
280000 BACK OVER PREVENTION
This service bulletin provides repair information to correct a customer concern of the rearview driver information camera intermittent in low light conditions - replace camera.
23-NA-169
Feb 26, 2024
110000 ELECTRICAL SYSTEM
This service bulletin provides repair information to correct a customer concern of the rearview driver information camera intermittent in low light conditions - replace camera.
23-NA-169
Feb 26, 2024
350000 EQUIPMENT
This service bulletin provides repair information to correct a customer concern of the rearview driver information camera intermittent in low light conditions - replace camera.
23-NA-073
Feb 26, 2024
060000 ENGINE AND ENGINE COOLING
This technical bulletin provides repair information to correct a customer concern of Evaporative DTCs P0442, P0446, P0455 or P0449, Caused by Dust Intrusion into the Evaporative Canister.
24-NA-020
Feb 23, 2024
060000 ENGINE AND ENGINE COOLING
This service bulletin provides a repair procedure to correct customer concerns of Service Emissions System Displayed on DIC, MIL Illuminated with DTC P249C and/or P20E8 Set.
PIT5689F
Feb 23, 2024
060000 ENGINE AND ENGINE COOLING
This Preliminary information communicates that some customers may comment that after an auto-stop event the engine does not restart and to inspect the engine ground strap. Temporarly on hold while PIE0572 is active. PIE0572 has now ended a
22-NA-074
Feb 22, 2024
060000 ENGINE AND ENGINE COOLING
This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.
PIT5551N
Feb 21, 2024
260000 FORWARD COLLISION AVOIDANCE
This Preliminary information communicates a "Forward Collision System Reduced" message displayed on the DIC when the Forward Automatic Braking has been set to the "Alert" setting. This is normal when the FAB has been set to "Alert".
PIT4322P
Feb 21, 2024
251000 ELECTRONIC STABILITY CONTROL:AUTOMATIC (ASC)
This Preliminary Information communication provides information to the technician about vehicles that have an unwanted Stability Activation and/or a Service Stability message on the Driver Information Center. Technician may find a Diagnosti
PIT5744D
Feb 21, 2024
273000 LANE DEPARTURE: BLIND SPOT DETECTION
This Preliminary information communicates information on how to disable the Side Blind Zone Detection and Park Assist systems when a customer removes the pickup box from the vehicle to install an aftermarket bed or body.
PIT5744D
Feb 21, 2024
118410 ELECTRICAL SYSTEM:ADAS:BLINDSPOT:SOFTWARE
This Preliminary information communicates information on how to disable the Side Blind Zone Detection and Park Assist systems when a customer removes the pickup box from the vehicle to install an aftermarket bed or body.
PIT5744D
Feb 21, 2024
118420 ELECTRICAL SYSTEM:ADAS:BLINDSPOT:SENSORS
This Preliminary information communicates information on how to disable the Side Blind Zone Detection and Park Assist systems when a customer removes the pickup box from the vehicle to install an aftermarket bed or body.
PIT5744D
Feb 21, 2024
118510 ELECTRICAL SYSTEM:ADAS:PARKING ASSIST:SOFTWARE
This Preliminary information communicates information on how to disable the Side Blind Zone Detection and Park Assist systems when a customer removes the pickup box from the vehicle to install an aftermarket bed or body.
PIT5744D
Feb 21, 2024
118520 ELECTRICAL SYSTEM:ADAS:PARKING ASSIST:SENSORS
This Preliminary information communicates information on how to disable the Side Blind Zone Detection and Park Assist systems when a customer removes the pickup box from the vehicle to install an aftermarket bed or body.
21-NA-238
Feb 20, 2024
100000 POWER TRAIN
This technical bulletin provides a procedure to inspect the front pump of the transmission for a possible leak.
PIT6054B
Feb 19, 2024
162500 STRUCTURE:BODY:TAILGATE
This Preliminary information communicates that the inner tailgate cannot be disabled if the vehicle is not equipped with passive entry.
23-NA-185
Feb 14, 2024
010000 STEERING
This service bulletin helps diagnose/reduce possible CCND issues on Transfer Cases - Service 4WD on DIC, Intermittent Failures, Noise Concerns, Driveline/Steering Vibration/Shudder, Intermittent DTCs/MIL Illuminated, Engagement/Disengagemen
23-NA-185
Feb 14, 2024
100000 POWER TRAIN
This service bulletin helps diagnose/reduce possible CCND issues on Transfer Cases - Service 4WD on DIC, Intermittent Failures, Noise Concerns, Driveline/Steering Vibration/Shudder, Intermittent DTCs/MIL Illuminated, Engagement/Disengagemen
23-NA-185
Feb 14, 2024
110000 ELECTRICAL SYSTEM
This service bulletin helps diagnose/reduce possible CCND issues on Transfer Cases - Service 4WD on DIC, Intermittent Failures, Noise Concerns, Driveline/Steering Vibration/Shudder, Intermittent DTCs/MIL Illuminated, Engagement/Disengagemen
23-NA-185
Feb 14, 2024
350000 EQUIPMENT
This service bulletin helps diagnose/reduce possible CCND issues on Transfer Cases - Service 4WD on DIC, Intermittent Failures, Noise Concerns, Driveline/Steering Vibration/Shudder, Intermittent DTCs/MIL Illuminated, Engagement/Disengagemen
24-NA-020
Feb 12, 2024
110000 ELECTRICAL SYSTEM
This service bulletin provides a repair procedure to correct customer concerns of Service Emissions System Displayed on DIC, MIL Illuminated with DTC P249C and/or P20E8 Set.
24-NA-020
Feb 12, 2024
060000 ENGINE AND ENGINE COOLING
This service bulletin provides a repair procedure to correct customer concerns of Service Emissions System Displayed on DIC, MIL Illuminated with DTC P249C and/or P20E8 Set.
PIC6486D
Feb 12, 2024
353600 EQUIPMENT:ELECTRICAL:INFOTAINMENT
This Preliminary information communicates to dealer that GM is aware of the issue and is working on a resolution.
PIC6486D
Feb 12, 2024
353610 EQUIPMENT:ELECTRICAL:INFOTAINMENT:SOFTWARE
This Preliminary information communicates to dealer that GM is aware of the issue and is working on a resolution.
PIT5895C
Feb 8, 2024
162500 STRUCTURE:BODY:TAILGATE
This Preliminary information communicates a new tailgate feature which allows the customer to enable or disable the inner tailgate.
16-NA-222
Feb 7, 2024
060000 ENGINE AND ENGINE COOLING
This bulletin provides information on Engine Concerns that could result from lack of scheduled maintenance, improper service or aftermarket calibrations.
19-NA-044
Feb 7, 2024
063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
This service bulletin provides information on the cold start control system in DI engines to reduce cold start emissions and improve fuel economy.
19-NA-044
Feb 7, 2024
070000 FUEL SYSTEM, GASOLINE
This service bulletin provides information on the cold start control system in DI engines to reduce cold start emissions and improve fuel economy.
PIT5479F
Feb 6, 2024
030000 BRAKES (PWS)
This Preliminary Information communication provides information to the technician about fluid leaking from the brake caliper piston area found during a service of the vehicle. The substance is actually excess assembly grease from the calipe
22-NA-150
Feb 5, 2024
110000 ELECTRICAL SYSTEM
This technical bulletin provides a procedure to program the Reductant Control Module and Setup and Perform the Reductant Fluid Tank Level Reset.
22-NA-150
Feb 5, 2024
060000 ENGINE AND ENGINE COOLING
This technical bulletin provides a procedure to program the Reductant Control Module and Setup and Perform the Reductant Fluid Tank Level Reset.
16-NA-338
Feb 2, 2024
100000 POWER TRAIN
This Warranty Admin service bulletin provides guidelines for Dealers Not Required and for Dealers Required to Contact the PQC for engine or transmission assembly replacement and explains the PQC process, GWM Transaction submission, vehicle
16-NA-338
Feb 2, 2024
060000 ENGINE AND ENGINE COOLING
This Warranty Admin service bulletin provides guidelines for Dealers Not Required and for Dealers Required to Contact the PQC for engine or transmission assembly replacement and explains the PQC process, GWM Transaction submission, vehicle
PIT4506G
Feb 2, 2024
190000 TIRES
This Preliminary Information communication provides information to the technician that some owners of Heavy Duty Trucks and Utilities may ask if they can lower their tire pressures. Tire pressures being set to the "Tire and Loading Label" w
PIT6097C
Jan 31, 2024
353000 EQUIPMENT:ELECTRICAL
This Preliminary information communicates an issue where the vehicles wireless charger no longer works with certain ISO updates on Apple 15 phones and advises customer to update their phone to the lastest ISO update.
23-NA-055
Jan 30, 2024
110000 ELECTRICAL SYSTEM
This service bulletin provides information on the EL-52800 Diagnostic & Charge Battery Station (DCBS) a?? FAQs.
PIT5702E
Jan 30, 2024
110000 ELECTRICAL SYSTEM
This Preliminary information communication provides information to the technician on installing Regular Production Option Code 9L7 Up-fitter Auxiliary Switches. Technician will need to reference the latest version of General Motors Up-fitte
PIT6119
Jan 30, 2024
162500 STRUCTURE:BODY:TAILGATE
This Preliminary information communicates an issue where the minor tailgate will not open due to an aftermarket device installed on the vehicle.
23-NA-055
Jan 30, 2024
350000 EQUIPMENT
This service bulletin provides information on the EL-52800 Diagnostic & Charge Battery Station (DCBS) a?? FAQs.
23-NA-189
Jan 29, 2024
350000 EQUIPMENT
This service bulletin assists technicians in setting up PicoScope hardware/software to monitor CAN bus traffic (voltage patterns) to aid Technical Assistance (TAC) and Field Service Engineers (FSEs) in diagnosing electrical issues present o
PIP5810B
Jan 29, 2024
100000 POWER TRAIN
This Preliminary information communicates that the tool for the HD transfer cases to install the input seal during a repair is incorrect and a new tool is in development.
23-NA-189
Jan 29, 2024
110000 ELECTRICAL SYSTEM
This service bulletin assists technicians in setting up PicoScope hardware/software to monitor CAN bus traffic (voltage patterns) to aid Technical Assistance (TAC) and Field Service Engineers (FSEs) in diagnosing electrical issues present o
21-NA-238
Jan 22, 2024
350000 EQUIPMENT
This technical bulletin provides a procedure to inspect the front pump of the transmission for a possible leak.
21-NA-238
Jan 22, 2024
100000 POWER TRAIN
This technical bulletin provides a procedure to inspect the front pump of the transmission for a possible leak.
PI0281K
Jan 18, 2024
160000 STRUCTURE
This preliminary informational (PI) bulletin provides information to dealership personnel which may be helpful when addressing underbody component corrosion with customers.
19-NA-255
Jan 18, 2024
160000 STRUCTURE
This preliminary informational bulletin provides frame coating repair information to correct a customer concern of wax coating on frame peeling, metal shows corrosion/rusting (U.S. and Canada Only).
21-NA-120
Jan 17, 2024
100000 POWER TRAIN
This service bulletin provides a Diagnostic Tip for Noise, Vibration, and/or Harshness Issues/Clunk Noise Heard During Coast Down Event after the transfer case was removed from the transmission and reinstalled during a recent repair.
21-NA-120
Jan 17, 2024
350000 EQUIPMENT
This service bulletin provides a Diagnostic Tip for Noise, Vibration, and/or Harshness Issues/Clunk Noise Heard During Coast Down Event after the transfer case was removed from the transmission and reinstalled during a recent repair.
23-NA-170
Jan 16, 2024
060000 ENGINE AND ENGINE COOLING
This bulletin advises the tech to inspect deeper into what may be to main cause of an engine failure.
18-NA-099
Jan 16, 2024
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.
02-08-42-001J
Jan 12, 2024
120000 EXTERIOR LIGHTING
This informational bulletin provides information for dealers/technicians on Headlamp, Tail Lamp, License Lamp or Fog/Driving Lamp Damage.
PIT6084A
Jan 12, 2024
353600 EQUIPMENT:ELECTRICAL:INFOTAINMENT
This PI states that a vehicle may exhibit a concern of the cross traffic alert indicators not displaying on the radio screen. While this is a customer dissatisfier, it does not pose a safety concern due to the fact that the customer will st
PI1394B
Jan 12, 2024
100000 POWER TRAIN
This PI bulletin advises the technician on the proper way to install the pistons in an engine.
PI1394B
Jan 12, 2024
060000 ENGINE AND ENGINE COOLING
This PI bulletin advises the technician on the proper way to install the pistons in an engine.
21-NA-155
Jan 11, 2024
350000 EQUIPMENT
This informational bulletin advises the technician to check for faults that may be caused by the trailer otherwise found by a possible faulty trailer connector.
21-NA-155
Jan 11, 2024
210000 TRAILER HITCHES
This informational bulletin advises the technician to check for faults that may be caused by the trailer otherwise found by a possible faulty trailer connector.
21-NA-155
Jan 11, 2024
110000 ELECTRICAL SYSTEM
This informational bulletin advises the technician to check for faults that may be caused by the trailer otherwise found by a possible faulty trailer connector.
PIT6109
Jan 10, 2024
162500 STRUCTURE:BODY:TAILGATE
This Preliminary information communicates an issue where the minor tailgate step link can contact the painted surface and chip the paint on the tailgate. Dealers are to adjust the step link bracket to provide clearance between the link and
PIT5161K
Jan 10, 2024
071000 FUEL SYSTEM, GASOLINE:STORAGE
This Preliminary Information communication provides information to the technician about vehicles that may have a bump feel or clunk noise at a stop or on launch. Dealer should communicate to the customer this condition is a normal operating
Showing 100 of 613 bulletins.
NHTSA Safety Investigations, CHEVROLET SILVERADO 3500
Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.
PE97001
Opened: Jan 17, 1997 , Closed: May 29, 1997
REAR AXLE SEPARATION FROM VEHICLE
THE SINGLE CONSUMER COMPLAINT RECEIVED BY NHTSA REPORTED AN INCIDENT IN WHICH APPLICATION OF THE SERVICE BRAKES OF THE SUBJECT VEHICLE PRECIPITATED AN UNFOREWARNED LOSS OF VEHICLE CONTROL AS THE LEFT REAR AXLE SEPARATED FROM THE VEHICLE.INSPECTION OF THE VEHICLE FOLLOWING THE INCIDENT DISCLOSED THAT... Read more
CHEVROLET SILVERADO 3500 - All Years Overview
Complete safety history for the CHEVROLET SILVERADO 3500 across all model years (1997, 2026).
104
Total Recalls
1,459
Total Complaints
1
Investigations
79
Reported Crashes
24
Reported Fires
4
Reported Deaths
CHEVROLET SILVERADO 3500 - Year by Year
Compare recalls and complaints across model years. Click any year to see full details.
| Year | Recalls | Complaints | |
|---|---|---|---|
| 2026 | 3 | 5 | View |
| 2025 | 1 | 19 | View |
| 2024 | 3 | 75 | View |
| 2023 (current) | 1 | 21 | |
| 2022 | 3 | 35 | View |
| 2021 | 5 | 56 | View |
| 2020 | 8 | 53 | View |
| 2019 | 7 | 34 | View |
| 2018 | 6 | 28 | View |
| 2017 | 6 | 14 | View |
| 2016 | 6 | 74 | View |
| 2015 | 7 | 78 | View |
| 2014 | 3 | 10 | View |
| 2013 | 4 | 36 | View |
| 2012 | 4 | 31 | View |
| 2011 | 5 | 42 | View |
| 2010 | 5 | 4 | View |
| 2009 | 6 | 10 | View |
| 2008 | 4 | 36 | View |
| 2007 | 5 | 42 | View |
| 2006 | 0 | 61 | View |
| 2005 | 1 | 60 | View |
| 2004 | 1 | 46 | View |
| 2003 | 1 | 60 | View |
| 2002 | 2 | 64 | View |
| 2001 | 2 | 97 | View |
| 2000 | 2 | 114 | View |
| 1999 | 1 | 73 | View |
| 1998 | 1 | 100 | View |
| 1997 | 1 | 78 | View |
| 1996 | 0 | 2 | View |
| 1994 | 0 | 1 | View |