1999 FORD F-250

19 recalls, 702 complaints - 255 TSBs

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING

Defect Description

FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, OR... Read more

Consequence

AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.

Remedy

FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STR... Read more

1,100,000 vehicles affected

Manufacturer: FORD MOTOR COMPANY

EXTERIOR LIGHTING:HEADLIGHTS

Defect Description

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES... Read more

Consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy

DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

42,540 vehicles affected

Manufacturer: DOPE, INC.

EQUIPMENT:ELECTRICAL

Defect Description

CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.

Consequence

IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.

Remedy

ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.

175 vehicles affected

Manufacturer: CEQUENT ELECTRICAL PRODUCTS

EXTERIOR LIGHTING:HEADLIGHTS

Defect Description

CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIV... Read more

Consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy

MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.

19,413 vehicles affected

Manufacturer: MAXZONE AUTO PARTS CORPORATION

VEHICLE SPEED CONTROL

Defect Description

ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.

Consequence

OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE.

Remedy

DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388)

1,200,000 vehicles affected

Manufacturer: FORD MOTOR COMPANY

EXTERIOR LIGHTING:HEADLIGHTS

Defect Description

CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLEC... Read more

Consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy

SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.

14,616 vehicles affected

Manufacturer: SABRY LEE, INC.

EXTERIOR LIGHTING

Defect Description

CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. ... Read more

Consequence

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy

CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.

27,176 vehicles affected

Manufacturer: CK MOTORSPORT, INC.

VEHICLE SPEED CONTROL

Defect Description

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.

Consequence

A FIRE AT THE SWITCH COULD OCCUR.

Remedy

BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO ... Read more

4,500,000 vehicles affected

Manufacturer: FORD MOTOR COMPANY

PARKING BRAKE:CONVENTIONAL:MECHANICAL:LINKAGE AND CABLE

Defect Description

ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS, FAILURE OF THE FRONT PARKING BRAKE CABLE INPUT BUTTON COULD RESULT IN FAILURE OF THE PARKING BRAKE SYSTEM TO HOLD THE VEHICLE STATIONARY.

Consequence

THIS COULD RESULT IN UNINTENDED VEHICLE MOVEMENT AND A VEHICLE CRASH.

Remedy

DEALERS WILL REPLACE THE FRONT PARKING BRAKE CABLE AND THE CONTROLLER AND VERIFY THE PERFORMANCE OF THE PARKING BRAKE SYSTEM. OWNER NOTIFICATION BEGAN APRIL 5, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A ... Read more

51,846 vehicles affected

Manufacturer: FORD MOTOR COMPANY

EQUIPMENT:OTHER:LABELS

Defect Description

VEHICLE DESCRIPTION: BI-FUEL CNG PICKUP TRUCKS AND BI-FUEL CNG VANS, MODIFIED BY CFI CONTROL SYSTEMS, INC., FAIL TO CONFORM TO THE REQUIREMENTS OF FMVSS NO. 303, "FUEL SYSTEM INTEGRITY OF COMPRESSED NATURAL GAS VEHICLES." THE LABEL AFFIXED TO THE FUEL FILLER DOOR BY THE VEHICLE MODIFIER CONTAINS T... Read more

Consequence

THESE VEHICLES DO NOT COMPLY WITH THE REQUIREMENTS.

Remedy

OWNERS WILL BE PROVIDED A LABEL WITH THE REQUIRED STATEMENT, ALONG WITH INSTRUCTIONS FOR AFFIXING THE LABEL AT THE FUEL FILLER DOOR. OWNER NOTIFICATION BEGAN NOVEMBER 2, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY W... Read more

4,500 vehicles affected

Manufacturer: FORD MOTOR COMPANY

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

Defect Description

VEHICLE DESCRIPTION: PICKUP TRUCKS EQUIPPED WITH GASOLINE ENGINES AND 8 FOOT BOXES, MAY NOT FULLY SATISFY THE REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." IN A 30 MPH FRONTAL BARRIER CRASH TEST, A FUEL TANK VAPOR RECOVERY VALVE SEPARATED INTERNALLY. DURING THE SUBSEQUENT STATIC ROLLOVE... Read more

Consequence

FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy

DEALERS WILL INSTALL A STOP PLATE ASSEMBLY ON THE VEHICLE FRAME TO PREVENT RECOVERY VALVE CONTACT WITH A FRAME CROSSMEMBER DURING THE IMPACT SEQUENCE.

107,540 vehicles affected

Manufacturer: FORD MOTOR COMPANY

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

Defect Description

VEHICLE DESCRIPTION: GASOLINE AND DIESEL ENGINE PICKUP TRUCKS EQUIPPED WITH 8 FOOT BEDS, DO NOT FULLY SATISFY THE REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." THE FUEL TANK FRONT STRAP ISOLATOR MAY NOT BE PROPERLY POSITIONED WHICH COULD RESULT IN THE STRAP CUTTING THE TANK DURING A 30 M... Read more

Consequence

DURING THE SUBSEQUENT STATIC ROLLOVER TEST, FUEL SPILLAGE EXCEEDED THE SPECIFIED RATE, INCREASING THE RISK OF A FIRE.

Remedy

DEALERS WILL REPOSITION THE FRONT STRAP ISOLATOR.

245,300 vehicles affected

Manufacturer: FORD MOTOR COMPANY

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING

Defect Description

VEHICLE DESCRIPTION: PICKUP TRUCKS EQUIPPED WITH 6" BEDS MANUFACTURED FROM JANUARY 5, 1998 THROUGH JUNE 4, 1999, DO NOT NOT FULLY SATISFY THE POST CRASH TEST STATIC ROLLOVER REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." CONTACT BETWEEN THE FUEL TANK AND A FUEL TANK LOCATOR BRACKET DU... Read more

Consequence

FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy

DEALERS WILL REPLACE THE FUEL TANK LOCATOR BRACKET WITH A SIMILAR BRACKET WHOSE DESIGN HAS BEEN REVISED TO INCORPORATE MORE ROUNDED SURFACES WHERE CONTACT WITH THE TANK OCCURS.

102,700 vehicles affected

Manufacturer: FORD MOTOR COMPANY

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

Defect Description

VEHICLE DESCRIPTION: GASOLINE AND DIESEL ENGINE PICKUP TRUCKS EQUIPPED WITH 6" AND 8" BEDS MANUFACTURED FROM JANUARY 5, 1998 THROUGH MARCH 21, 1999, DO NOT NOT FULLY SATISFY THE POST CRASH TEST STATIC ROLLOVER REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." SIX ATTACHMENT BOLTS (M12 BOL... Read more

Consequence

FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy

DEALERS WILL AUGMENT THE BOX-TO-CHASSIS ATTACHMENT BY INSTALLING BOX-TO-CHASSIS RETAINING CABLES.

293,650 vehicles affected

Manufacturer: FORD MOTOR COMPANY

VEHICLE SPEED CONTROL

Defect Description

VEHICLE DESCRIPTION: CERTAIN 1997-1999 RHD EXPLORER EQUIPPED WITH 4.0L OHV/SOHC ENGINES AND CRUISE CONTROL BUILT FROM MAY 29, 1996 THROUGH MARCH 4, 1999; 1998-1999 EXPLORER/MOUNTAINEERS EQUIPPED WITH 4.0L OHV/SOHC OR 5.0L ENGINES OR 1998-1999 RANGERS EQUIPPED WITH 2.5L, 3.0L FFV/EFI OR 4.0L ENGINES... Read more

Consequence

IF THE CRUISE CONTROL IS USED AND THIS CONDITION IS PRESENT, A STUCK THROTTLE COULD RESULT, WHICH COULD POTENTIALLY RESULT IN A CRASH.

Remedy

DEALERS WILL REPLACE THE CRUISE CONTROL CABLES. AT THE PRESENT TIME, THE REPLACEMENT CABLES ARE NOT AVAILABLE. CUSTOMERS ARE BEING ADVISED NOT TO USE THE CRUISE CONTROL SYSTEM UNTIL A REPLACEMENT CAN BE MADE.

898,739 vehicles affected

Manufacturer: FORD MOTOR COMPANY

AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE

Defect Description

VEHICLE DESCRIPTION: LIGHT DUTY TRUCKS. THE CAST TOW HOOKS CHANGES THE CRASH PULSE OF THE VEHICLE IN FRONTAL BARRIER IMPACTS AND THE AIR BAG SENSOR WAS NOT CALIBRATED TO THIS NEW CRASH PULSE WHICH MAY CAUSE THE AIR BAGS TO DEPLOY IN LOWER SPEED IMPACTS THAN DESIGN INTENT.

Consequence

UNEXPECTED AIR BAG DEPLOYMENT CAN RESULT IN PERSONAL INJURY.

Remedy

DEALERS WILL REPLACE THE CAST TOW HOOKS WITH FORGED HOOKS.

20 vehicles affected

Manufacturer: FORD MOTOR COMPANY

VEHICLE SPEED CONTROL:CABLES

Defect Description

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS. A SPEED CONTROL CABLE MAY NOT HAVE FULLY SEATED INTO THE ACCELERATOR BRACKET AT TIME OF INSTALLATION. IF THE CABLE IS NOT FULLY SEATED INTO THIS BRACKET, THE CABLE COULD SEPARATE FROM THE BRACKET.

Consequence

A LOOSE CABLE CAN RESULT IN THE THROTTLE NOT FULLY RETURNING TO IDLE AND CAUSE AN INCREASE IN STOPPING DISTANCE.

Remedy

DEALERS WILL ADD A RETAINING CLIP TO THE SPEED CONTROL CABLE FITTING AT THE ACCELERATOR BRACKET.

1,500 vehicles affected

Manufacturer: FORD MOTOR COMPANY

FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM

Defect Description

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS. THE FUEL PRESSURE REGULATOR O-RING MAY HAVE BEEN DAMAGED WHEN THE FUEL PRESSURE REGULATOR WAS INSTALLED IN THE ENGINE FUEL RAIL. IF THE O-RING IS DAMAGED, FUEL VAPOR OR LEAKAGE COULD OCCUR.

Consequence

IF AN IGNITION SOURCE IS PRESENT, A FIRE COULD RESULT.

Remedy

DEALERS WILL REPLACE THE FUEL PRESSURE REGULATOR.

1,700 vehicles affected

Manufacturer: FORD MOTOR COMPANY

STEERING:GEAR BOX (OTHER THAN RACK AND PINION)

Defect Description

VEHICLE DESCRIPTION: MEDIUM DUTY TRUCKS AND CHASSIS-CABS. ONE OR MORE OF THE FOUR RIVETS ON THE LOWER STEERING SHAFT FLEX COUPLING MAY NOT HAVE BEEN CRIMPED DURING THE SUB-ASSEMBLY PROCESS.

Consequence

IF A RIVET IS NOT CRIMPED, THE FLEX JOINT CAN ROTATE ON THE SHAFT AND THERE WOULD BE A REDUCTION IN OR LOSS OF STEERING CONTROL.

Remedy

DEALERS WILL INSPECT THE LOWER STEERING SHAFT RIVETS AND REPLACE ANY SHAFTS WITH UNCRIMPED RIVETS.

90,000 vehicles affected

Manufacturer: FORD MOTOR COMPANY

Complaint Statistics

702 total complaints 60 crashes 17 fires 42 injuries 2 deaths

Top Reported Components

Component	Complaints
TIRES	54
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP	47
TIRES:TREAD/BELT	34
AIR BAGS:FRONTAL	29
ENGINE AND ENGINE COOLING:ENGINE	25
POWER TRAIN:AUTOMATIC TRANSMISSION	23
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE	23
TIRES:SIDEWALL	21
VEHICLE SPEED CONTROL	20
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC	18

Incident date: Sep 28, 2023

the anti lock button does not work, kia will not fix it, they stated that there recall on it was for locks that can move the car forward and backwards. I've never used my anti lock button its down beside the gear shift so the only way I can drive my suv to put my car in drive, reverse etc to use the... Read more

Incident date: Oct 20, 2022

The Belt in the tire separated while driving. This caused a "Bubble" to form causing my truck to shake violently and required changing to the spare tire. If this happened on the highway I could have lost control and caused an accident. I took my truck to a tire installer who documented the above... Read more

Incident date: Feb 27, 2022

My fiancé & I were driving down a 35mph road & I told her my steering wheel was a little crooked & I don't remember hitting anything to knock out of alignment. We got to my friends house to move a car trailer for him up his steep driveway. I hooked up to the trailer pulled it out, moved it around... Read more

Incident date: Dec 1, 2020

The contact owns a 1999 Ford F-250. The contact stated that the vehicle stalled while driving at various speeds. The contact stated that the check engine light illuminated for approximately 30 seconds. The contact would turn off and restart the vehicle and the vehicle would return to normal operatio... Read more

Incident date: Jun 30, 2021

I was driving on the interstate going highway speed of 65 mph and the accelerator was stuck open and I could not slow down. The engine stayed at a high rpm. I had to press with a lot of force to slow down and come to a stop with the engine still at high rpm and had trouble stopping. Luckily, wher... Read more

Incident date: Jul 8, 2020

TL THE CONTACT OWNS A 1999 FORD F-250 EQUIPPED TRAILERED TO 2019 FOREST RIVER EAST TO WEST TRAVEL TRAILER EQUIPPED WITH TBC BRAND LLC TIRES, TIRE LINE: TRAILER KING, TIRE SIZE: ST225/75R15, DOT NUMBER: 1ADB4HFT1). THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE PASSENGER'S SIDE FRO... Read more

Incident date: Aug 11, 2019

TL* THE CONTACT OWNS A 1999 FORD F-250. WHILE DRIVING 5 MPH, THE CONTACT HEARD SOMETHING SNAP ON HIS VEHICLE. THE CONTACT PULLED THE VEHICLE OVER AND DISCOVERED THAT THE REAR STRAP CONNECTED TO THE FUEL TANK DETACHED FROM THE VEHICLE. THE CONTACT WIRED THE TANK BACK INTO PLACE AND DROVE HOME. THE CO... Read more

Incident date: Jul 20, 2019

TL* THE CONTACT OWNS A 1999 FORD F-250. WHILE DRIVING 55 MPH, THE FUEL TANK DROPPED OUT OF PLACE WITHOUT WARNING. THE CONTACT HEARD A DRAGGING, SCRAPING SOUND UNDERNEATH THE VEHICLE. THE CONTACT PULLED OVER INTO A PARKING LOT AND DISCOVERED THE FAILURE. BRAD HOWELL FORD (2170 E BLVD ST, KOKOMO, IN 4... Read more

Incident date: May 19, 2019

TL* THE CONTACT OWNS A 1999 FORD F-250. WHILE OPERATING THE VEHICLE AT HIGHWAY SPEEDS, BOTH FUEL STRAPS FRACTURED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE); AL... Read more

Incident date: Apr 25, 2019

TL* THE CONTACT OWNS A 1999 FORD F-250. WHEN THE CONTACT EXITED AND RETURNED TO THE VEHICLE, IT MADE AN ABNORMAL SOUND WHEN IT WAS RESTARTED. SUDDENLY, A FIRE ERUPTED UNDER THE HOOD, WHICH SPREAD TO THE CABIN OF THE VEHICLE. THE DRIVER FELL AND HURT HER KNEE WHILE ATTEMPTING TO EXIT THE VEHICLE QUIC... Read more

Fire 1 injured

Incident date: Apr 25, 2019

Fire 1 injured

Incident date: Mar 13, 2019

TL* THE CONTACT OWNS A 1999 FORD F-250. THE CONTACT STATED THAT THE VEHICLE CAUGHT FIRE UNDER THE HOOD WHILE PARKED ON THE SIDE OF THE ROAD. THE FAILURE OCCURRED WITHOUT WARNING. THE CONTACT EXTINGUISHED THE FIRE WITH SNOW. A POLICE REPORT WAS NOT FILED. THERE WERE NO INJURIES. THE DEALER AND MANUFA... Read more

Fire

Incident date: Feb 6, 2019

FILLED THE GAS TANK FULL THE DROVE DOWN THE STREET AT 45 MPH. ABOUT 1 MILE INTO THE DRIVE THE REAR FUEL TANK STRAP BROKE IN HALF AND THE REAR END OF THE FUEL TANK FELL TO THE GROUND SPILLING MOST OF THE FUEL. THE STRAP LOOK CORRODED.

Incident date: Mar 25, 2018

BLOWS SPARK PLUGS OUT & BREAKS COIL PACKS FROM SITTING STILL AT INITIAL TAKE OFF. HAS HAPPENED 4 PREVIOUS TIMES

Incident date: Oct 23, 2017

I WAS GOING DOWN THE FREEWAY @ 65MPH AND I NOTICED MY STEERING WAS NOT RESPONDING IN THE NORMAL WAY. I HAD MADE IT TO A EXIT AND STOPPED AT LIGHT TRIED TO MAKE RIGHT TURN TRUCK CONTINUED STRAIGHT, AND I WAS STOPPED IN RUSH HOUR TRAFFIC IN CA. GOT OUT AND SAW MY SECTOR SHAFT HAD BROKEN OFF MY S... Read more

Incident date: Aug 17, 2016

RUSTED THREW FUEL TANK STRAPS NO CRUISE CONTROL NO AIR CONDITIONING

Incident date: Aug 17, 2016

RUSTED THREW FUEL TANK STRAPS NO CRUISE CONTROL NO AIR CONDITIONING

Incident date: Aug 17, 2016

RUSTED THREW FUEL TANK STRAPS NO CRUISE CONTROL NO AIR CONDITIONING

Incident date: Dec 18, 2014

I WAS DRIVING DOWN INTERSTATE 75 AND SUDDENLY I LOST POWER AND HAD A EXTREMELY LOUD PIPING NOISE COMING FROM UNDER THE HOOD . I STOPPED IMMEDIATELY AND CHECKED UNDER THE HOOD I COULD NOT TELL WITH THE ENGINE OFF SO I RESTARTED IT AND INSPECTED IT AND FOUND THAT MY NUMBER 2 SPARK PLUG HAD BLOWN OUT O... Read more

Incident date: Nov 27, 2016

I WAS HEADING BACK TO COLLEGE IN BROOKINGS SD, WHEN I WAS STOPPED WAITING FOR A TRAIN TO PASS. AFTER THE TRAIN PASSES I PUT IT FROM PARK INTO DRIVE AND RIGHT WHEN I STARTED MOVING I HEAR A LOUD POP. AFTER I DRIVE ANOTHER BLOCK TO A GAS STATION TO LOOK UNDER THE HOOD I CAME TO THE CONCLUSION THAT I ... Read more

Incident date: Apr 15, 2016

TL* THE CONTACT OWNS A 1999 FORD F-250. WHILE DRIVING APPROXIMATELY 55 MPH, THE SPARE TIRE DETACHED AND WENT UNDER THE TRAILER THAT WAS BEING HAULED. THE CONTACT LOST CONTROL OF THE VEHICLE AND CRASHED INTO THE MEDIAN. A POLICE REPORT WAS NOT FILED. THE CONTACT WENT TO THE HOSPITAL, BUT THERE WERE N... Read more

Crash

Incident date: Apr 15, 2016

Crash

Incident date: Jan 15, 2016

TL* THE CONTACT OWNS A 1999 FORD F-250. AFTER THE VEHICLE WAS PLACED INTO THE PARK POSITION, IT INDEPENDENTLY ROLLED BACKWARDS WITHOUT WARNING. THE PASSENGER WAS ABLE TO STOP THE VEHICLE. THE CONTACT DISCOVERED THAT THE VEHICLE INADVERTENTLY SWITCHED INTO THE REVERSE POSITION. AS A RESULT, THE CONTA... Read more

1 injured

Incident date: Apr 30, 2016

REAR FUEL TANK STRAP FAILED, CAUSING FUEL TANK TO DRAG ON GROUND WHILE VEHICLE WAS IN MOTION. SEE SAFETY RECALL 11S21 WHICH RECALLED FUEL TANK STRAPS ON OTHER 1999 FORD TRUCKS INCLUDING F-150 AND F-250 LIGHT DUTY BUT NOT F-250 SUPER DUTY. RECALL SHOULD BE EXTENDED TO 1999 F-250 SUPER DUTY.

Incident date: Mar 18, 2016

TL* THE CONTACT OWNS A 1999 FORD F-250. THE CONTACT STATED THAT THE EMERGENCY BRAKE FAILED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 160,000. UPDATED 05/24/16*LJ UPDATED 12/12/2017*JS

Incident date: Feb 26, 2016

THIS IS MY 2ND REPLACEMENT OF A THROTTLE POSITION SENSOR. VERY EXPENSIVE REPAIR! $500-600 (BASICALLY A NEW PEDAL ASSEMBLY.) WHAT IS DISTURBINGLY UNSAFE IS THE DRIVER WILL LOSE ALL THROTTLE RESPONSE ANYTIME AND UNKNOWINGLY RANDOM TIMING. COULD BE ON THE FREEWAY (WITH TRAFFIC ON YOUR BUTT! COULD B... Read more

Incident date: Feb 26, 2016

Incident date: Jan 14, 2015

THIS ENGINE WITH ALUMINUM HEADS BLEW OUT SPARK PLUG NUMBERS 2 AND 7. FIRST OCCURRENCE ON AUG 11 2015 AND THE NEXT JAN 14, 2016. THE FIRST INCIDENT OCCURRED DRIVING DOWN A HIGHWAY AND THE NEXT OCCURRED STARTING FROM A STOP LIGHT. THERE WAS A LAG IN POWER AND THEN A LOUD BANGING NOISE AND A STRONG ... Read more

Incident date: Jan 14, 2016

SPARK PLUG NUMBERS 2 AND 7 BLEW OUT OF THE CYLINDER HEAD. NUMBER 2 BLEW OUT WHILE DRIVING DOWN THE HIGHWAY AND NUMBER 7 BLEW OUT STARTING OFF AT A GREEN LIGHT ON A MAIN STREET. THERE WAS A STRONG ODOR OF GAS WHEN THIS OCCURRED AND SERIOUS VIBRATION FROM THE ENGINE MISFIRING. THIS CREATED A POTENT... Read more

Incident date: Nov 25, 2015

MY V-10 EJECTED A SPARK PLUG.

Incident date: Oct 23, 2015

SPARK PLUG BLEW OUT OF HEAD WHILE DRIVING. ENGINE HAS 92000 MILES AND ORIGINAL SPARK PLUGS.

Incident date: Sep 10, 2015

TL* THE CONTACT OWNS A 1999 FORD F-250. WHILE ATTEMPTING TO STOP THE VEHICLE, THE BRAKE PEDAL EXTENDED TO THE FLOORBOARD AND THE VEHICLE FAILED TO STOP. THE CONTACT DISCOVERED BRAKE FLUID WAS LEAKING UNDER THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE BRAKE LINES WERE CORRO... Read more

Incident date: Sep 10, 2015

TL* THE CONTACT OWNS A 1999 FORD F 250. WHILE DRIVING APPROXIMATELY 5 MPH AND MAKING A LEFT TURN, THE BRAKE PEDAL WAS DEPRESSED BUT THE VEHICLE FAILED TO DECELERATE WITHOUT WARNING. THE CONTACT OBSERVED THAT THERE WAS FUEL LEAKING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TOWED TO A DEALER WHERE... Read more

Incident date: Jun 28, 2015

#6 SPARK PLUG BLEW OUT OF THE HEAD. I HAD IT REPAIRED TWO DAYS LATER. TWO DAYS AFTER THAT, THE #3 SPARK PLUG BLEW OUT OF THE HEAD WHILE I WAS DRIVING AT 25MPH. DURING BOTH INCIDENTS GASOLINE FUMES AND EXHAUST FILLED BOTH THE ENGINE COMPARTMENT AND THE PASSENGER COMPARTMENT.

Incident date: Dec 16, 2014

TL* THE CONTACT OWNS A 1999 FORD F-250. WHILE THE VEHICLE WAS ON A SERVICE LIFT UNDERGOING A ROUTINE OIL CHANGE, THE INDEPENDENT MECHANIC STATED THAT THE FUEL STRAP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS ... Read more

Incident date: Sep 15, 2014

A MAJOR LOSS OF POWER WHILE TOWING A LOAD. THE LOSS WAS SIGNIFICANT ENOUGH THE FIRST TIME THAT THE TRUCK COULD NOT SHIFT INTO HIGHER GEARS. COULD ONLY MANAGE 55 MPH MAX. WHEN I ARRIVED HOME, TOOK IT TO MY LOCAL DEALER TO HAVE IT REPAIRED. THEY HAD IT FOR 10 DAYS AND WERE UNABLE TO LOCATE ANY PROBLEM... Read more

Incident date: Sep 20, 2014

TL* THE CONTACT OWNS A 1999 FORD F-250. THE CONTACT STATED THAT THE FUEL TANK STRAPS WERE RUSTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING AND THE MECHANIC STATED THAT THE FUEL LINE STRAP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIE... Read more

Incident date: Jul 19, 2013

TIRE BLEW OUT ON INTERESTATE. TIRES ONLY 1-2 MONTHS OLD AT THE TIME OF BLOW OUT. CAUSED THE TRUCK TO FLIP ACROSS LANES OF TRAFFIC AND LAND ON ITS SIDE IN THE MEDIAN. PASSENGER WAS INJURED. TIRES WERE FEDERAL COURAGIA M/T. *TR

Crash 1 injured

Incident date: Jul 11, 2013

GAS TANK STRAP BROKE ALLOWING THE GAS TANK TO FALL OUT OF PLACE ALMOST TOUCHING THE ROAD. HAD TO HAVE TRUCK TOWED IN. WOULD APPRECIATE YOUR HELP IN GETTING COSTS COVERED FOR THE REPAIRS FROM ANY RECALL ON THIS SAFETY HAZARD SINCE THE GAS TANK COULD HAVE EXPLODED. ANY HELP IN THIS MATTER WOULD BE G... Read more

Incident date: Jan 2, 2014

TL* THE CONTACT OWNS A 1999 FORD F-250. THE CONTACT STATED THAT THE BOLT THAT HELD THE FUEL TANK FAILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE FILLER NECK AND THE FAILED BOLT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURE WAS MADE AWARE OF THE... Read more

Incident date: Aug 9, 2013

I FILED A CLAIM WITH MICHELIN NORTH AMERICA, INC (MICHELIN), THAT WAS DENIED, FOR DAMAGES IN EXCESS OF $3,000.00 INCURRED BY MY PERSONAL VEHICLE RESULTING FROM THE COMPLETE TREAD DETACHMENT OF A UNIROYAL LAREDO TIRE (DOT# BFW8FEUU4107), AFTER 13,586 MILES. DETACHMENT OCCURRED AT HIGHWAY SPEED (65MP... Read more

Incident date: Sep 12, 2013

HEARD A LOUD POP FROM UNDER THE HOOD WHILE DRIVING AT HIGHWAY SPEED. SOUNDED LIKE IT WAS RIGHT IN FRONT OF THE GLOBE BOX AREA. THE ENGINE EJECTED A SPARK PLUG WHICH IS A VERY COMMON FAILURE FOR TRITON ENGINES WITH ALUMINUM HEADS - THREADS FAILED THAT HOLD THE SPARK PLUG IN PLACE. I DID NOT HEAR A... Read more

Incident date: Apr 16, 2013

MY TRUCK WAS PARKED AT WORK. WHEN I GOT IN THE TRUCK TO LEAVE I WENT TO START IT AND I HAD HEARD A LOUD BANG FROM UNDER THE HOOD FOLLOWED BY A CLATTERING SOUND. I OPENED THE HOOD AND FOUND THAT I HAD BLOWN A PLUG. THIS IS A KNOWN ISSUE FOR FORD 4.6L 5.4L 6.8L ENGINES. I KNOW THIS IS NOT THE FIRST TI... Read more

Incident date: Apr 9, 2013

TL* THE CONTACT OWNS A 1999 FORD F-250. THE CONTACT STATED THAT WHILE ATTEMPTING TO MERGE INTO TRAFFIC WITH THE BRAKES ENGAGED, THE VEHICLE SUDDENLY ACCELERATED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND... Read more

Incident date: Nov 15, 2012

TL* THE CONTACT OWNS A 1999 FORD F-250. THE CONTACT STATED WHILE PARKED THE REAR DRIVER AND PASSENGER SIDE DOORS WOULD NOT OPEN WHEN THE LATCH WAS PULLED FROM THE INTERIOR OR EXTERIOR OF THE VEHICLE. AN INDEPENDENT MECHANIC PERFORMED A DIAGNOSTIC TEST AND STATED THE LOCK AND CABLE ASSEMBLY HAD TO BE... Read more

Incident date: Jul 13, 2001

ON JULY 18TH 2012 I WAS TAKING HOLLYWOOD BLVD TO GO TO THE STORES AND ALL THE SUDDEN THE TRUCK JUST SHUT OFF I WAS ABLE TO PUT THE EMERGENCY BRAKE AND DINT' HIT ANYBODY. I HAD IT TOWED TO MY HOME. THEN A FEW DATES LATER WE TOOK THE TRUCK TO A FORD DEALER WERE THEY CHARGE US FOR CHECKING THE TRUCK AN... Read more

Incident date: Jun 19, 2012

TL* THE CONTACT OWNS A 1999 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, SHE HEARD A LOUD NOISE COMING FROM THE REAR OF THE VEHICLE. THE CONTACT MANEUVERED TO THE SHOULDER AND NOTICED THAT THE FUEL TANK WAS DETACHING FROM THE VEHICLE. THE VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP. THE DE... Read more

Incident date: May 24, 2012

TL* THE CONTACT OWNS A 1999 FORD F250 EQUIPPED WITH GOODYEAR WRANGLER LT TIRES, SIZE: 265/75R16. THE CONTACT WAS DRIVING 65 MPH WHEN THE FRONT PASSENGER SIDE TIRE EXPLODED. THE FAILURE CAUSED DAMAGE TO THE FRONT PASSENGER SIDE DOOR AND FENDER. THE CONTACT REMOVED THE FAILED TIRE AND INSTALLED THE ... Read more

Incident date: Apr 2, 2012

SPARK PLUG "BLEW OUT"OF ITS HOLE CAUSING LOSS OF POWER AND SUDDEN CONSTERNATION. WAS PULLING AN LIGHT EMPTY TRAILER AND FORTUNATELY DRIVING WITH NO OTHER TRAFFIC AROUND. 5.4L TRITON V8 ENGINE, MANUAL TRANSMISSION. FACTORY TUNE-UP AND PLUG REPLACEMENT DONE ABOUT 20K MILES EARLIER, 5 YEARS AGO. *TR

Incident date: Nov 16, 2011

TL* THE CONTACT OWN A 1999 FORD F-250. THE CONTACT STATED THAT THE FUEL TANK STRAPS CORRODED AND CREATED A HOLE IN THE FUEL TANK. FUEL BEGAN TO LEAK AS A RESULT OF THE FAILURE. THE CONTACT RECEIVED A RECALL NOTICE ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 99V093001 (FUEL SYSTEM, GASOLINE:STORAGE:TANK... Read more

Showing 50 of 702 complaints.

Technical Service Bulletins, 1999 FORD F-250

255 manufacturer communications from 240 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE	21
980000 UNKNOWN OR OTHER	16
100000 POWER TRAIN	14
103000 POWER TRAIN:AUTOMATIC TRANSMISSION	12
110000 ELECTRICAL SYSTEM	10
103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)	9
061000 ENGINE AND ENGINE COOLING:ENGINE	8
036000 SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP	7

070000 FUEL SYSTEM, GASOLINE

Safety recall 11S21 - Fuel tank strap fracture - requests for recall service action

070000 FUEL SYSTEM, GASOLINE

For 1997-2003 F-150, 2004 F-150 Heritage, 1997-1999 F-250 Light Duty, or 2002-2003 Blackwood vehicles Safety Recall 11S21 has been issued for vehicles that are operated in high corrosion areas for an extended period, where one or both fuel

350000 EQUIPMENT

FORD/LINCOLN: SAFETY RECALL REGARDING HIGH CORROSION AREAS FOR OPERATING, FOR AN EXTENDED TIME, VEHICLES WHERE BOTH OR ONE STRAP OF FUEL TANK CAN FRACTURE, AFTER CONTACTING GROUND. MODEL 1997-99 F250 LD, 1997-03 F150, 2004 F150 HERITAGE,

071100 FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

091120 FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:MOUNTING

FORD/LINCOLN: SAFETY RECALL ISSUED DUE TO ONE OR BOTH FUEL TANK STRAPS FRACTURING DUE TO BEING IN HIGH CORROSION AREAS FOR AN EXTENDED PERIOD AND DISLODGING FUEL TANK. MODEL 1997-99 F250, 1997-03 F150, 2004 F150 HERITAGE, 2002-2003 BLACKW

071120 FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING

071100 FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

061000 ENGINE AND ENGINE COOLING:ENGINE

SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE

063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR (EXHAUST GAS RECIRCULATION VALVE) FLOW. *TT

162000 STRUCTURE:BODY

SERVICE TIPS BEFORE ARC WELDING ON THE FRAME OR BODY OF A UNIT. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

A COLD WEATHER REVERSE ENGAGEMENT STALL. *TT

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT

020000 SUSPENSION

VEHICLE LEAN SAG WHEN OBSERVED FROM REAR OF VEHICLE. *EH

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT

033100 SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM

VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY - CLIMATE CONTROL DEFAULTS TO DEFROST. OASIS. TO ALSO INCLUDE 2005 SUPER DUTY F-SERIES, EXCURSION, AND F650/750. *TT

017500 STEERING:LINKAGES:TIE ROD ASSEMBLY

CUSTOMER MAINTENANCE REMINDER - LITERATURE PROGRAM 04L19 - TIE ROD INSPECTION PROCEDURE. *TT

100000 POWER TRAIN

EXCESSIVE DRIVE-AWAY SHUDDER OR VIBRATION UNDER MODERATE TO HEAVY ACCELERATION FROM A STOP. *TT

141100 AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE

AIR BAG LIGHT ON WITH DIAGNOSTIC TROUBLE CODE (DTC) B1871 OR B1935 FOLLOWING ECS/RCM REPLACEMENT. *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

OIL/DUST FILM AT CAC CONNECTIONS. *MJ

010000 STEERING

OIL LEAK AT HIGH PRESSURE PUMP FITTINGS AND/OR PLUG. THIS INCLUDES SUPER DUTY F-SERIES. OASIS. *TT

162300 STRUCTURE:BODY:DOOR

SQUEAKING NOISE COMING FROM THE UPPER DOOR SEAL WHEN DRIVING OVER BUMPS. F250 MODEL INCLUDES 1999-2004 SUPER DUTY F-SERIES. *TT

110000 ELECTRICAL SYSTEM

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH NO HARD FAULT. *TT

103600 POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES

NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

BI-FUEL LPG VEHICLES (WITH COOLANT LOCK OFF) MAY EXHIBIT A NO START CONDITION. *TT

090000 FUEL SYSTEM, OTHER

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT

090000 FUEL SYSTEM, OTHER

POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE, ON SOME DEDICATED CNG VEHICLES. *TT *JB

090000 FUEL SYSTEM, OTHER

ON SOME DEDICATED CNG VEHICLES, A POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE. REVISED SERVICE PARTS. *TT

061200 ENGINE AND ENGINE COOLING:ENGINE:DIESEL

GRADUAL LOSS OF POWER AT CRUISE. USE FUEL ADDITIVE TO PREVENT HIS CONDITION. ALL SUPER DUTY F-SERIES 1999-2003 INCLUDED. OASIS *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

ENGINE-CYLINDER HEAD DECK LEAK-4.6 AND 5.4L ENGINES-NEW SERVICE-ONLY GASKET AND CYLINDER HEAD KITS AVAILABILITY. *MJ

061000 ENGINE AND ENGINE COOLING:ENGINE

ENGINE-LIGHT TICK OR RATTLE TYPE NOISE FROM ENGINE AFTER COLD START. *MJ

180000 VEHICLE SPEED CONTROL

DRIVEABILITY-IDLE-HIGH IDLE SPEEDS-THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES-VEHICLES BUILT THROUGH 12/31/01 EQUIPPED WITH 4.6L ENGINE. *MJ

073000 FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM

DRIVEABILITY-IDLE-HIGH IDLE SPEEDS-THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES-VEHICLES BUILT THROUGH 12/31/01 EQUIPPED WITH 4.6L ENGINE. *MJ

125100 EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH

LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SOME BI-FUEL LPG VEHICLES (WITH COOLANT LOCK OFF) MAY EXHIBIT A NO START CONDITION. *TT

070000 FUEL SYSTEM, GASOLINE

INFORMATION ON VEHICLES EXHIBITING A PERCEIVED POOR FUEL RANGE / ECONOMY, AND OR A FAULTY FUEL GAUGE. *TT

102000 POWER TRAIN:MANUAL TRANSMISSION

SOME VEHICLES EQUIPPED WITH A 5-SPEED MAZDA R2 MANUAL TRANSMISSION MAY EXHIBIT A HIGH EFFORT CONDITION WHEN SHIFTING ANY GEAR. *TT

072200 FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

SUBJECT REGARDING HEATER HOSE TO FUEL RAIL FLEX LINE INSPECTION. *JG

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SOME VEHICLES MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS INCLUDING LACKS POWER, HESITATES, HARD TO START, AND/OR MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED AND PRODUCE POSSIBLE DIAGNOSTIC TROUBLE CODES P0103, P0172 AND P0175. *TT

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SOME VEHICLES EQUIPPED WITH THE ROMEO BUILT 4.6L 2V ENGINE MAY EXHIBIT AN ENGINE OIL LEAK OR OIL WEEPAGE FROM THE CYLINDER HEAD GASKET AT THE RIGHT HAND REAR OR THE LEFT HAND FRONT OF THE ENGINE. *TT

116100 ELECTRICAL SYSTEM:IGNITION:SWITCH

SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN CONTROL

180000 VEHICLE SPEED CONTROL

A CONDITION MAY EXIST, WHERE THROTTLE STICKING MAY OCCUR ON A FEW VEHICLES IN VERY COLD AMBIENT TEMPERATURES AFTE OPERATING AT STEADY SPEED OR EXTENDED IDLE FOR A PERIOD OF TIME. *TT

010000 STEERING

SUBJECT REGARDING 198196 BOLT-ON STEERING STOPS SERVICE GROUP, ALL MODELS 0307, HR0307A AND HR1000A. *SLC

100000 POWER TRAIN

SOME SUPER DUTY F SERIES EQUIPPED WITH PTO CAPABLE TRANSMISSIONS MAY EXHIBIT A FAILURE TO GO T HIGH IDLE UPON PTO ENGAGEMENT. *TT

103800 POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH

BRAKE SHIFT INTERLOCK.*JB

113000 ELECTRICAL SYSTEM:STARTER ASSEMBLY

CONCERNS WITH CORRODED POSITIVE STARTER CABLE. *TT

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

SOME VEHICLES EQUIPPED WITH A 4.6L ENGINE AND M5OD 5 SPEED MANUAL TRANSMISSIONS MAY EXHIBIT HESITATION ON ACCELERATION AND A CHECK ENGINE LIGHT ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES 90172 AND 90175. *SLC

091100 FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY

SOME VEHICLES MAY EXHIBIT A FUEL FILL VALVE SEALING CONDITION. *YD

021100 SUSPENSION:FRONT:STABILIZER BAR

SOME VEHICLES MAY EXHIBIT REPEAT NOISE CONCERNS WITH THE FRONT STABILITY BAR END LINKS. *YH

104000 POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)

SOME VEHICLES MAY EXHIBIT INADVERTENT 4X4 HI OR LOW SHIFT EVENTS, 4X4 AND / OR LOW RANGE INDICATOR FLASHING OR SOLID OR VEHICLE STUCK IN 4L AFTER UNCOMMANDED SHIFT. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

SOME VEHICLES EQUIPPED WITH A 4R70W AUTOMATIC TRANSMISSION MAY EXHIBIT A CLUNK NOISE DURING THE 2-1 DOWNSHIFT EVENT. *TT

070000 FUEL SYSTEM, GASOLINE

SUBJECT REGARDING OVERVIEW OF BI-FUEL CNG VEHICLE PARAMETER IDENTIFICATION DATA (PID), INPUTS AND OUTPUTS AS A DIAGNOSTIC AID FOR BI-FUEL VEHICLES. *TT

100000 POWER TRAIN

SOME VEHICLES EQUIPPED WITH A 4.6L ENGINE A 5 SPEED MANUAL TRANSMISSION MAY EXHIBIT A SLIGHT HESITATION ON LIGHT TIP-IN ACCELERATION AND A MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P0172 AND P0175. *TT

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

VEHICLES EQUIPPED WITH A 4.6L ENGINE AND 5 SPEED MANUAL TRANSMISSION MAY EXHIBIT A SLIGHT HESITATION ON LIGHT TIP-IN ACCELERATION AND A MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODES P0172 AND P0175. *TT

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

ON SOME VEHICLES THERE MAY BE AN OIL LEAK FROM THE RIGHT HAND HEAD GASKET AT THE REAR OF THE BLOCK / HEAD JOINT. *TT

162300 STRUCTURE:BODY:DOOR

CONCERNS THAT SOME TRUCKS MAY EXHIBIT A LOOSE / DETACHED REAR WINDOW HALO TRIM GIMP MOULDING. *TT

106100 POWER TRAIN:AXLE ASSEMBLY:BANJO HOUSING

A CONDITION MAY EXIST WHERE A DRIVELINE VIBRATION AND / OR A TRANSMISSION FLUID LEAK FROM THE EXTENSION HOUSING SEAL AREA MAY OCCUR ON SOME VEHICLES. THIS MAY BE CAUSED BY THE EXTENSION HOUSING BUSHING OR SEAL WALKING / SPINNING OUT DUE T

980000 UNKNOWN OR OTHER

SOME VEHILCES EQUIPPED WITH 4.6L ROMEO ENGINE AND MANUAL TRANSMISSION ONLY, MAY EXHIBIT A CHECK ENGINE LIGHT ON AND DIAGNOSTIC TROUBLE COE P0172 / P0175 STORED IN MEMORY WITH POSSIBLE DRIVEABLTILITY CONDITIONS SUCH AS HESITATION / STUMBLE.

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

THIS BULLETIN STATES THAT ON SOME VEHICLES (INCLUDING 2002 BLACKWOOD) A BATTERY DISCONNECT OR PARAMETER RESET IS REQUIRED DURING POWERTRAIN CONTROL MODULE (PCM) OR INSTRUMENT CLUSTER (VIC / HEC / ICM) REPLACEMENT. *TT

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SOME BI-FUEL VEHICLES MAY EXHIBIT A NO START CONDITION. *TT

116300 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) MAY NOT START OR CRANK. *TT

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT

980000 UNKNOWN OR OTHER

A CONDITION MAY EXIST WHERE THE MALFUNCTION INDICATOR LAMP IS ON WITH DIAGNOSTIC TROUBLE CODE P0340 (CAMSHAFT POSITION (CMP) SENSOR A CIRCUIT) STORED, ACCOMPANIED WITH A DRIVEABILITY CONCERN. *TT

100000 POWER TRAIN

INOPERATIVE OR INACCURATE SPEEDOMETER AS WELL AS 4X4 LIGHT INOPERATIVE AND / OR DIAGNOSTIC TROUBLE CODE P1635 AND / OR P1639 AFTER A POWERTRAIN CONTROL MODULE (PCM) HAS BEEN REPLACED. *TT

160000 STRUCTURE

SOME VEHICLES MAY EXHIBIT A WATER LEAK AROUND THE REAR (SLIDING) WINDOW. *TT

185000 VEHICLE SPEED CONTROL:CRUISE CONTROL

SOME VEHICLES EQUIPPED WITH A 4.6L, 5.4L, OR 6.8L ENGINE MAY EXHIBIT A ROUGH IDLE / MISS AFTER START-UP IN COLD AMBIENT TEMPERATURES. *TT

103600 POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES

SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT

110000 ELECTRICAL SYSTEM

A CONDITION MAY EXIST WITH POSSIBLE ELECTRONC DAMAGE OCCURING TO THE COMPUVALVE FROM VOLTAGE SPIKES BETWEEN THE COMPUVALVE CONNECTIONS WHEN CONNECTING OR DISCONNECTING THE MAIN COMPUVALVE HARNESS C4025. *TT

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SOME VEHICLES MAY EXHIBIT A NO CRANK / NO START CONDITION IN TEMPERATURES BELOW 12 DEGREES C (10 DEGREES F). *TT

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SOME VEHICLES MAY EXHIBIT AN INTERMITTENT HESITATION OR BUCK WHILE DRIVING IN ANY FUEL MODE (LPG, CNG OR GASOLINE). *TT

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

EMMISSION RECALL ON CERTAIN VEHICLES EQUIPPED WITH 7.3L DIESEL AND CALIFORNIA WARM WEATHER CALIBRATION - PCM REPROGRAM. *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

OIL LEAK FROM THE FRONT OR REAR CYLINDER HEAD OIL SUPPLY RAIL END PLUGS. *TT

355100 EQUIPMENT:OTHER:LABELS

THIS BULLETIN INVOLVES FUEL DOOR LABEL APPLICATION / REPLACEMENT. *JB

110000 ELECTRICAL SYSTEM

SOME VEHICLES MAY EXHIBIT AN INOPERATIVE COURTESY, GLOVE COMPARTMENT, UNDERHOOD, RUNNING BOARD LAMPS, POWER WINDOWS, RADIO AND REAR WIPER IN THE MORNING OR AFTER VEHICLE IS LEFT UNATTENDED FOR 45 MINUTES. *JB

135000 VISIBILITY:REARVIEW MIRRORS/DEVICES

CONCERNS WITH THE SIGNAL MIRROR REFLECTIVE SURFACE DETERIORATING OVER TIME, DEVELOPING DARK SPOTS DUE TO CHROME PLATING DELAMINATION. *JB

061110 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS

THIS BULLETIN ADDRESSES CONCERNS A NOISE AT INTIAL ENGINE STARTUP WHEN COLD FROM THE ACCESSORY DRIVE BELT. *JB

034000 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS

CONCERNS WITH REAR BRAKE NOISE. *JB

100000 POWER TRAIN

INOPERATIVE OR INACCURATE SPEEDOMETER, 4X4 LAMP ILLUMINATED AND / OR DIAGNOSTIC TROUBLE CODES (DTCS) P1635 OR P1639 PRESENT AFTER A POWERTRAIN CONTROL MODULE (PCM) OR INSTRUMENT CLUSTER REPLACEMENT. *JB

100000 POWER TRAIN

SOME VEHICLES EQUIPPED WITH A MANUAL TRANSFER CASE MAY EXHBIT AN INOPERATIVE SPEEDOMETER. *TT

110000 ELECTRICAL SYSTEM

CONCERNS WITH COURTESY, GLOVE COMPARTMENT, UNDERHOOD, RUNNING BOARD LAMPS; POWER WINDOWS; RADIO; AND REAR WIPER ALL INOPERATIVE IN THE MORNING OR AFTER VEHICLE IS LEFT UNATTENDED FOR 45 MINUTES. *MR

063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

EXHIBITING A CRACKLING / POPPING NOISE FROM THE EXHAUST. **MR

980000 UNKNOWN OR OTHER

INFORMATION REGARDING ERRACTIC REMOTE ENTRY FUNCTIONS-NEW GEM RELEASED. **MR

114200 ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH

SOME VEHICLES MAY EXHIBIT A DELAYED OPERATION / INOPERATIVE INSTRUMENT CLUSTER WITH KOEO OR KOER. **MR

114200 ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH

EXHIBITING A DELAYED OPERATION / INOPERATIVE INSTRUMENT CLUSTER WITH KOEO OR KOER. *TT

104000 POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)

INFORMATION REGARDING TRANSFER CASE HALL EFFECT ENCODER TIPS. **MR

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

SOME BI-FUEL VEHICLES MAY REQUIRE POWERTRAIN CONTROL MODULE (PCM) REPLACEMENT DURING SERVICE AND MAY NOT RUN ON CNG OR LPG., RECALIBRATION OF THE PCM/REPLACEMENT. *MJS

980000 UNKNOWN OR OTHER

CONCERNS WITH ERRATIC REMOTE ENTRY FUNCTIONS. *TT

103600 POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES

VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM IS NOT PROPERLY FLUSHED, FLUID IN-LINE FILTER KIT. *MJS

131000 VISIBILITY:WINDSHIELD

CONCERNS WITH VEHICLES EXHIBITING A WINDSHIELD CREAK / SQUEAK. *TT

106200 POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT

SOME VEHICLES EQUIPPED WITH 10.50-INCH RING GEAR, FULL-FLOATING REAR AXLES MAY EXHIBIT A LEAK AT THE OUTBOARD END OF THE AXLE SHAFT(S). *TT

133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

SOME VEHICLES MAY EXHIBIT INTERIOR LIGHTS, POWER WINDOWS AND / OR INOPERATIVE RUNNING BOARD LIGHTS FOR A SHORT PERIOD OF TIME IN THE MORNING. *TT

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SOME VEHICLES WITH 4.6L, OR 6.8L ENGINES MAY EXHIBIT A ROLLER FINGER FOLLOWER COMING OFF DURING ENGINE CRANKING IN COLD TEMPERATURES BELOW ZERO DEGREES F. A ONE-TIME NOISE FROM THE ENGINE MAY BE HEARD, FOLLOWED BY ROUGH RUNNING / MISSES

161000 STRUCTURE:FRAME AND MEMBERS

VEHICLES MAY EXPERIENCE INNER FENDER WELL- DENTED OR DINGED FROM STONES BEING THROWN INTO WHEELWELL. *MJS

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS

100000 POWER TRAIN

SOME VEHICLES MAY EXPERIENCE A CONDITION OF NO 4 X 4 LOW RANGE ENGAGEMENT OR A STUCK IN 4 X 4 LOW RANGE. *MJS

980000 UNKNOWN OR OTHER

ALL VEHICLES MAY EXHIBIT AN INOPERATIVE OR INACCURATE SPEEDOMETER, 4X4 LIGHT INOPERATIVE AND/OR DTC P1635 AFTER A PCM HAS BEEN REPLACED. *MJS

063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

SOME VEHICLES MAY EXHIBIT A CRACKLING/POPPING NOISE FROM THE EXHAUST, VEHICLES BUILT BETWEEN 11/1/97 AND 12/8/99. *MJS

162700 STRUCTURE:BODY:TRUNK LID

CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING.

034520 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS

SOME SUPER DUTY F SERIES VEHICLES MAY EXHIBIT A BRAKE SQUEAL / SQUEAK FROM THE REAR BRAKES. *TT

063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

SOME VEHICLES BUILT BETWEEN 11/1/97 AND 12/8/99 MAY EXHIBIT A CRACKLING/POPPING NOISE FROM THE EXHAUST. *MJS

126200 EXTERIOR LIGHTING:TURN SIGNAL:SWITCH

ON SOME VEHICLES, THE FRONT WINDSHIELD WIPERS MAY OPERATE WHILE THE MULTIFUNCTION SWITCH IS IN THE OFF POSITION. *TT

Showing 100 of 255 bulletins.

NHTSA Safety Investigations, FORD F-250

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 2017

Power tailgate opens unintended

By letter dated December 4, 2019, Ford Motor Company (Ford) notified the Office of Defects Investigation (ODI) of a safety defect that may exist in model years (MY) 2017 through 2019 Ford Super Duty F-250, F-350, F-450 vehicles equipped with an electric tailgate. Following the receipt of five consum... er complaints alleging unintended tailgate opening without vehicle operator knowledge, while the vehicles were in motion, NHTSA opened this investigation to assess the manufacturer's data including warranty claims, field reports, design changes, etc.In vehicles equipped with an electric tailgate, water can enter the electrical wiring system and may cause a short circuit resulting in the unintended activation and release of the tailgate latch. This could allow unintended opening of the tailgate while the vehicle is in motion.Analysis of the data provided by Ford found that the frequency of a tailgate opening unintended was high in vehicles equipped with electric tailgates. Unintended tailgate opening without vehicle operator knowledge may result in loss of unrestrained cargo, increasing the risk of a crash. In response to this investigation, Ford decided to conduct recall 19V-864.Owners will be notified by mail and instructed to take their vehicle to a Ford dealer to modify the tailgate/frame wiring harnesses by adding jumper pigtails to isolate the tailgate release control circuits, and will install a new tailgate handle release switch. With recall action 19V-864 taken by Ford Motor Company this investigation is closed. Further use of agency resources does not appear to be warranted.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist on other model or MY vehicles outside of the recall scope. The agency reserves the right to take further action if warranted by the circumstances.The ODI reports cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID using the following complaint identification numbers: 10984283,11004227,11082643,11090089,11104638,11115381,11140680,11141071, 11141075,11141174,11141200,11141331,11141447,11141547,11141548,11142572, 11142618,11142657,11153541,11153959,11157225,11160936,11165124,11165590, 11166199,11166802,11170049,11171409,11171509,11171685,11180009,11182035, 11186146,11191151,11191353,11193045,11194958,11203615,11206443,11209199, 11229482,11230768,11233349,11233436,11255126,11265643.Read more

RQ, Closed , Model Year: 2011

Vehicle Commanded Engine Shutdown

The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engi... ne Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.Read more

PE, Closed , Model Year: 2008

Alleged Loss of Steering

The Office of DefectsInvestigation (ODI) opened PE13-014 after identifying five complaints alleging steering gear failure in model year (MY) 2008 Ford F-250 and F-350 Super Duty pick-up trucks and to evaluate the relationship between the design history of the steering gear assembly and the alleged d... efect.As background, ODI investigated steering gear sector shaft fractures in approximately 1.3 million MY 1999 - 2001 Ford Super Duty pick-up trucks and MY 2000 - 2001 Ford Excursion sport utility vehicles in Engineering Analysis EA01-009.The investigation determined that the sector shaft failures were the result of extraordinary, possibly multiple, impacts and not the result of fatigue.No defect in design, manufacturing or materials was identified in the sector shaft.EA01-009 was closed August 19, 2003 with 169 complaints, resulting in a rate of 12.9 incidents per 100,000 vehicles after approximately one year of service.Ford increased the diameter of the sector shaft from 1.375 inches to 1.625 inches at the start of MY 2005 production, increasing the resistance of the steering gear assembly to torsional overload by approximately 48% and changing the failure mode from sector shaft fracture to cracked or broken sector shaft gear teeth.The redesigned steering gear assembly was used in approximately 1.1 million MY 2005 through 2009 Ford Super Duty pick-up trucks, including the subject vehicles.Figure 1 shows the basic steering system design used in Ford Super Duty trucks investigated in EA01-009 and PE13-014. Figure 2 shows the locations of failures resulting from impact related torsional overloading of the sector shaft for the subject vehicles and the prior generation Ford Super Duty trucks investigated in EA01-009.Figure 3 shows an example of a failed sector shaft investigated in EA01-009 and comparisons of fracture surfaces of sector shafts failing from fatigue loading and from torsional overload.Ford provided field return part analysis of failed steering gears from MY 2005 through 2009 Super Duty trucks found evidence of broken sector shaft gear teeth and piston damage consistent with incidents of single event overload (Figure 4).Laboratory analysis found no evidence of fatigue or material property defects in any of the fractures.Analysis of complaint rates by vehicle build month showed no patterns indicating potential manufacturing quality issues and no difference before and after Ford introduced design changes to the input shaft and sector shaft seals in July 2007 to address potential leak concerns (Figure 5).Analysis of failures by time in service indicates a random failure pattern/distribution, consistent with incidents of impact induced overload (Figure 6). The complaint rate for the subject vehicles after approximately 5 to 6 years, 7.1 incidents per 100,000 vehicles, is lower than the rate observed in EA01-009. Furthermore, similar to the condition investigated in EA01-009, a number of incident records include evidence of impact loads (e.g., curb strikes) and several alleged crashes include incidents in which information suggests that the steering gear failure was most likely a result of crash forces, rather than the cause of the crash.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstances.The ODI complaints cited above can be reviewed at wwRead more

EA, Closed , Model Year: 2005

VIOLENT FRONT END OSCILLATION

THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEED... S ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.Read more

PE, Closed , Model Year: 2005

VIOLENT FRONT END OSCILLATION

ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEG... Read more

RQ, Closed , Model Year: 1999

PARKING BRAKE FAILURE

ON MAY 11, 1998, FORD MOTOR COMPANY FILED A DEFECT INFORMATION REPORT CONCERNING PARKING BRAKE FAILURE ON CERTAIN 1999 F-350 SUPER DUTY VEHICLES BUILT AT THE KENTUCKY TRUCK PLANT FROM JANUARY 26, 1998 THROUGH APRIL 24, 1998; RECALL 98V-101.THE REDUCTION IN PARKING BRAKE EFFECTIVENESS MAY OCCUR ON SO... Read more

PE, Closed , Model Year: 1999

STEERING SHAFT FRACTURE

ALLEGED THAT THE STEERING SHAFT MAY FRACTURE

PE, Closed , Model Year: 1994

SEPARATED FRONT SUSPENSION

CONSUMER COMPLAINTS REPORT THAT BOLTS WHICH RETAIN THE AXLE PIVOT BRACKET TO THE FRAME CROSS MEMBER CAN LOOSEN OR FAIL, CAUSING THE INBOARD END OR THE AXLE TO BECOME DETACHED FROM THE VEHICLE.OWNERS ALLEGE THAT THIS COULD RESULT IN LOSS OF STEERING CONTROL, HOWEVER THE COMPLAINT DATA SHOWS ONLY ONE ... INCIDENT WHERE THE VEHICLE LEFT THE ROADWAY FOLLOWING AXLE SEPARATION, WITH NO DAMAGE TO THE VEHICLE.IN ADDITION TO THE 225 CONSUMER COMPLAINTS, THERE WERE 4,315 WARRANTY CLAIMS RELATED TO THE FRONT SUSPENSION AND MEMBERS, AND 22 VEHICLES WERE REPLACED FOR GOODWILL.DOCUMENTS SUBMITTED BY FORD, UNDER REQUEST FOR CONFIDENTIAL TREATMENT INDICATE THAT THE BOLTS WERE INADEQUATE FOR THE DURABILITY REQUIREMENTS OF THE VEHICLE.ALSO, BOLTS WERE FOUND TO HAVE BEEN INADEQUATELY TORQUED AT ONE OR MORE ASSEMBLY PLANTS.OTHER FACTORS, SUCH AS WAX TREATMENT OF THE FRAME, CONTRIBUTED TO THE PROBLEM.INCREASED BOLT DIAMETER AND INCREASED TORQUE APPARENTLY CORRECTED THE PROBLEM.A SERVICE BULLETIN, 96-20-13, WAS ISSUED TO ADVISE DEALERS OF THIS CORRECTIVE ACTION.IN THESE DOCUMENTS, FORD ALSO REPORTED THAT A VEHICLE, EQUIPPED FOR SIMULTANEOUS CATASTROPHIC FAILURE OF ALL PIVOT BRACKET FASTENERS, WAS EVALUATED RESULTING IN A SLIGHT VEHICLE PULL TO ONE SIDE WITH NO LOSS OF VEHICLE CONTROL.ODI HAS NOT REPLICATED FORD'S VEHICLE TESTING, HOWEVER ANALYSIS OF THE DESIGN OF THE FRONT SUSPENSION INDICATES THAT EVEN IF THE INBOARD END OF THEAXLE BECAME DISCONNECTED FROM THE FRAME, THE OUTBOARD END WOULD REMAIN FIRMLY ATTACHED TO THE LEAF SPRING WITH TWO U-BOLTS.THIS WOULD RETAIN THE WHEEL IN ITS APPROXIMATE POSITION, ALTHOUGH THE WHEEL ALIGNMENT WOULD BE GREATLY IN ERROR.THEREFORE IT IS UNLIKELY THAT CONTROL OF THE VEHICLE WOULD BE LOST.OWNERS REPROT MANY SIGNIFICANT NOISES IN THE SUSPENSION, SUCH AS CREAKING, GROANING, CLUNKING, AND SQUEAKING, PRIOR TO NOTICING ANY SEPARATION OF THE AXLE.THIS PROVIDES WARNING OF THE LOOSENING OF THE BOLTS TO THE DRIVER, AND SHOULD NOT BE IGNORED.FORD HAS STATED THAT REPAIRS WILL BE COVERED UNDER THE VEHICLE'S BUMPER WARRANTY.COMPLAINTS ABOUT WARRANTY COVERAGE BY A FORD DEALER SHOULD BE ADDRESSED TO FORD, OR TO APPROPRIATE STATE AND LOCAL AGENCIES.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.Read more

PE, Closed , Model Year: 1992

ENGINE COMPARTMENT FIRES

There is no summary currently available

FORD F-250 - All Years Overview

Complete safety history for the FORD F-250 across all model years (1991, 2020).

152 Total Recalls

11,563 Total Complaints

9 Investigations

375 Reported Crashes

300 Reported Fires

19 Reported Deaths

FORD F-250 - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2022	0	156	View
2021	0	209	View
2020	1	352	View
2019	4	1,922	View
2018	1	616	View
2017	2	1,718	View
2016	0	430	View
2015	2	426	View
2014	0	236	View
2013	0	153	View
2012	1	423	View
2011	2	384	View
2010	0	109	View
2009	1	92	View
2008	6	255	View
2007	4	84	View
2006	3	332	View
2005	1	207	View
2004	7	201	View
2003	7	151	View
2002	7	189	View
2001	9	269	View
2000	10	417	View
1999 (current)	19	702
1998	9	76	View
1997	14	348	View
1996	5	212	View
1995	4	238	View
1994	10	156	View
1993	9	183	View
1992	7	149	View
1991	7	145	View
1990	0	5	View
1989	0	14	View
1979	0	1	View

Other FORD Models

Model	Recalls	Complaints
MUSTANG	1,104	11,600	View
RANGER	928	10,371	View
F-350 SD	776	2,363	View
F-450 SD	692	624	View
F-150	692	46,142	View
F-250 SD	638	3,635	View
EXPLORER	624	42,549	View
F-550 SD	578	603	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

1999 FORD F-250

Complaint Statistics

Top Reported Components

Technical Service Bulletins, 1999 FORD F-250

Most Affected Components

NHTSA Safety Investigations, FORD F-250

FORD F-250 - All Years Overview

FORD F-250 - Year by Year

Other FORD Models