2007 FORD F-250

4 recalls, 84 complaints - 13 TSBs

SEATS

Defect Description

Vantage Mobility International, LLC (Vantage) is recalling certain 2015-2018 Ford Transit Van, Mercedes-Benz Sprinter, and 2007 Ford F-250-based shuttle vehicles equipped with Freedman GO-3S foldaway seats. When the back seat cushion is rotated from the stowed position to the upright position, the ... Read more

Consequence

In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.

Remedy

Vantage has notified owners, instructing them to contact Freedman for a repair kit, free of charge. The recall began March 25, 2019. Owners may contact Freedman customer service at 1-800-443-4540.

12 vehicles affected

Manufacturer: Vantage Mobility International, LLC

EXTERIOR LIGHTING:TAIL LIGHTS

Defect Description

FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 TH... Read more

Consequence

NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.

Remedy

DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.

26,715 vehicles affected

Manufacturer: FORD MOTOR COMPANY

EQUIPMENT:ELECTRICAL

Defect Description

CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.

Consequence

IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.

Remedy

ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.

175 vehicles affected

Manufacturer: CEQUENT ELECTRICAL PRODUCTS

SERVICE BRAKES, AIR

Defect Description

CERTAIN HARSCO WHEEL MODIFICATION GROUPS CONTAINING ACCURIDE STEEL RIMS, P/NOS. 203237 AND 203738; ACCURIDE ALUMINUM RIMS, P/N 203712; AND GKN STEEL RIMS, P/N 203688, SOLD AS MODIFICATION EQUIPMENT FOR CERTAIN 2005-2007 FORD F-250/F-350 4X4 PICKUP TRUCKS TO MODIFY TRACK WIDTH OF FRONT AND REAR AXLES... Read more

Consequence

BRAKE FAILURE CAN OCCUR, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy

HARSCO WILL NOTIFY OWNERS AND PROVIDE A REPAIR KIT ALONG WITH REPAIR INSTRUCTIONS FREE OF CHARGE. THE RECALL BEGAN IN SEPTEMBER 2006. OWNERS MAY CONTACT HARSCO AT 507-235-7112.

450 vehicles affected

Manufacturer: HARSCO TRACK TECHNOLOGIES

Complaint Statistics

84 total complaints 3 crashes 1 injuries

Top Reported Components

Component	Complaints
STEERING	22
SUSPENSION	15
SUSPENSION:FRONT	6
ENGINE	4
VEHICLE SPEED CONTROL	3
LATCHES/LOCKS/LINKAGES:DOORS:LATCH	2
FUEL/PROPULSION SYSTEM	2
SERVICE BRAKES, HYDRAULIC	2
ENGINE AND ENGINE COOLING	2
TIRES	2

Incident date: Oct 10, 2023

See attached document for complaint

Incident date: Oct 10, 2023

Cracked flexplate

Incident date: Oct 10, 2023

The Dealer did not reveal the unresolved recall on this used vehicle during sales lot inspection. After I pointed out the recall listed on the CarFax report, the dealer did not address the concern nor mention if the recall had been resolved in order to make the used truck ready for resale. The Deal... Read more

Incident date: May 1, 2023

The contact owns a 2014 Ford Fusion. The contact stated that while driving at an undisclosed speed, an unknown warning light illuminated. The contact inspected the vehicle and noticed there was no brake fluid in the reservoir. Additionally, the contact stated that while driving the vehicle was overh... Read more

Incident date: May 1, 2023

Incident date: Jun 23, 2022

Rear fuel tank strap broke on 6/20/2022. Fuel tank hit ground. Very dangerous cant believe i am only one and this hasnt been recalled.

Incident date: Mar 16, 2022

Truck randomly has the notorious death wobble when going over bumps. It shakes violently and i have to slow down or stop. Tried to have it diagnosed by mechanic several times with no outcome, this is when I researched and found out a lot of ford trucks have this issue. Is it a severe safety issue an... Read more

Incident date: Mar 16, 2022

Incident date: Sep 10, 2021

On our most recent trip, our Ford truck a 2007 F250 model experienced what is called the death wobble, where the front shakes violently. Which occurs in speeds of 70 or higher, when it hits a bump the front end shakes violently. It has happened in the past when we were on vacation. The dealer cou... Read more

Incident date: Aug 15, 2020

The contact owns a 2007 Ford F-250. The contact stated that the passenger’s and driver’s side rear door locking mechanisms were faulty and the doors could no longer be opened. The cause of the failure was not yet determined. The local dealer was contacted regarding the failure. The manufacturer ... Read more

Incident date: Jun 1, 2020

INSTRUMENT PANEL LOSES POWER. NO GUAGES WORK WHEN POWER IS LOST. NO TACH OR SPEEDOMETER, ELECTRIC WINDOWS ALSO DO NOT WORK. THIS IS A SAFETY ISSUE IF I CANT DETERMINE HOW FAST I AM GOING.

Incident date: Apr 21, 2017

TL* THE CONTACT OWNS A 2007 FORD F-250. THE CONTACT STATED WHILE DRIVING AND MAKING A LEFT TURN, THE STEERING WHEEL BECAME DIFFICULT TO TURN. THERE WAS NO WARNING LIGHT ILLUMINATED. THE CONTACT DROVE THE VEHICLE TO HIS RESIDENCE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THE POWER STEERIN... Read more

Incident date: Apr 21, 2017

Incident date: Jun 2, 2020

THE VEHICLE SHAKES VIOLENTLY ON THE ROAD WHEN I GO OVER A BUMP WHEN TRAVELING AT 65MPH OR HIGHER. I HAVE TO SLOW DOWN TO 50MPH OR BELOW TO GET IT TO SUBSIDE. *TR

Incident date: Jun 2, 2020

THE VEHICLE SHAKES VIOLENTLY ON THE ROAD WHEN I GO OVER A BUMP WHEN TRAVELING AT 65MPH OR HIGHER. I HAVE TO SLOW DOWN TO 50MPH OR BELOW TO GET IT TO SUBSIDE. *TR

Incident date: Nov 20, 2018

BRAKE BOOSTER FEED LINE CAME OFF AT INTAKE . I HAD NO POWER BRAKES JUST A HARD BRAKE PEDAL WHEN I WAS STOPPING TO PULL ON TO THE HIGHWAY. HAD TO PUSH PEDAL REAL HARD TO STOP. I FEEL IT SHOULD HAVE BEEN IN RECALL #08S05 THAT I READ WAS IN 2008 .

Incident date: Nov 5, 2018

TL* THE CONTACT OWNS A 2007 FORD F-250. THE CONTACT STATED THAT THE UNDERCARRIAGE OF THE VEHICLE BED WAS RUSTED AND PARTS WERE MISSING. THE CONTACT STATED THAT THE BED OF THE VEHICLE COULD UNEXPECTEDLY DETACH BECAUSE IT WAS LOOSE AND PARTS OF THE METAL WERE RUBBING OFF. THE CONTACT ALSO MENTIONED TH... Read more

Incident date: Jan 1, 2017

FRONT END SHIMMER WHEN CROSSING OVER BAD ROAD SPOTS. THE SHAKING CAN BE VERY BAD ALMOST LOSE CONTROL.

Incident date: Sep 20, 2012

1) FAULTY HEAD BOLTS REPAIR WAS OVER $6000 INVOLVED GASKETS, CRACKED HEADS, BOLTS, UPDATES AND UPGRADES. 2) DEATH WOBBLE FRONT END ISSUES (MINE ARE FORTUNATELY OCCURRING AT AT LOW SPEEDS) HOWEVER THE WOBBLE HAS CAUSED MANY FRONT END AND STEERING COMPONENTS TO WEAR OUT PREMATURELY. WOBBLE KICKS IN A... Read more

Incident date: Sep 20, 2012

Incident date: Jan 24, 2017

I HAD JUST WASHED MY TRUCK THE DAY BEFORE AND WHEN I CLEANED THE WHEELS THERE WERE NO ISSUES AND THEN THE FOLLOWING DAY AFTER DROPPING MY KIDS OFF AT SCHOOL I NOTICED A CRACK IN MY BACK DRIVER 20" CHROME OEM RIM THAT WENT FROM ONE SPOKE TO THE OTHER ABOUT A INCH FROM THE VALVE STEM THERE IS NO ROAD... Read more

Incident date: Dec 20, 2016

SPEEDOMETER STARTED MAL FUNCTION. CREATING A HYPER SPEED - INSTEAD OF 25 MPH - WAS READING 60 MPH.

Incident date: Jan 14, 2016

THIS VEHICLE WAS TOWED INTO OUR SHOP BECAUSE IT WOULD NOT START. WE INSTALLED A NEW STARTER AND LEFT IT OVER NIGHT IN THE STALL WHEN WE CAME BACK IN THE MORNING IT HAD ATTEMPTED TO START ITS SELF AND HAD DRIVEN THROUGH THE DOOR AND OUT ON TO THE LOT WEDGEING ITSELF IN THE NEW CARS. THIS TRUCK IS A ... Read more

Crash

Incident date: Feb 14, 2016

BOUCES ALL OVER ROAD SHOCKS ALSO LEAKING FLUID.

Incident date: Oct 1, 2015

TL* THE CONTACT OWNS A 2007 FORD F-250. WHILE DRIVING APPROXIMATELY 75 MPH, THE VEHICLE VEERED TO THE LEFT AND CRASHED INTO A GUARDRAIL WITHOUT WARNING. THE VEHICLE CROSSED THE HIGHWAY INTO ONCOMING TRAFFIC AND CRASHED INTO ANOTHER GUARDRAIL. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED AN... Read more

Crash

Incident date: Oct 1, 2015

Crash

Incident date: Aug 1, 2013

TL* THE CONTACT OWNS A 2007 FORD F-250. WHILE DRIVING AT 30 MPH, THE CONTACT LOST CONTROL OF THE VEHICLE AND IT VEERED TO THE LEFT AND RIGHT. THE VEHICLE WAS TOWED TO A DEALER WHO DIAGNOSED THAT THE STEERING BOX NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. HOWEVER, THE FAILURE RECURRED AND THE V... Read more

Incident date: Jan 12, 2015

I'M JUST A LITTLE UPSET THAT FORD WILL NOT STAND BEHIND THIS ISSUE WITH THE 06 AND 07 F250 FUELING ISSUE, I WENT TO ARVIN,CA AT LUNCH TODAY TO PUT GAS IN BECAUSE I TRY TO MAKE SURE WHEN IT GETS TO A HALF OF A TANK I FILL IT UP, IT TOOK ME 17 MINUTES TO PUT IN 13 GALLONS OF GAS, THAT IS SAD AND I HAV... Read more

Incident date: Jan 10, 2007

TL* THE CONTACT OWNS A 2007 FORD F-250. THE CONTACT STATED THAT ONLY AFTER THE VEHICLE WAS DRIVEN, THE VEHICLE FAILED TO RESTART IMMEDIATELY AFTER THE ENGINE WAS TURNED OFF. THE CONTACT WAITED TEN MINUTES OR MORE BEFORE THE VEHICLE RESUMED NORMAL FUNCTIONED. MOST RECENTLY, THE CONTACT TAPPED THE STA... Read more

Incident date: Jun 19, 2014

EGL COOLER FAILURE, WHITE SMOKE COMING OUT OF THE EXHAUST PIPE CAUSED BY COOLANT ENTERING INTO THE EMISSION SYSTEM. "ON ALL 6.0 ENGINES THE EGL COOLER WILL FAIL." THIS PROBLEM IS SO "MASSIVE" WITH SO MANY "MASSIVE COMPLAINTS FROM CUSTOMERS" THAT FORD HAS DONE TWO THINGS 1) DESIGNED A BY-PASS KIT... Read more

Incident date: Feb 4, 2014

TL* THE CONTACT OWNS A 2007 FORD F-250. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE VEHICLE SHOOK. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 42,000.

Incident date: Sep 12, 2012

PRONOUNCED AND SEVERE SHIMMY AND OSCILLATION IN THE STEERING WHEEL WHEN TRAVELING OVER SMALL BUMPS OR DIPS IN THE ROADWAY AND ON UNEVEN DRIVING SURFACES. FORD DEALER CONFIRMED THE PROBLEM AND REPLACED A TRACKING BAR AND THE STEERING DAMPER. THESE REPAIRS HELPED BUT DID NOT ELIMINATE THE ISSUE. NE... Read more

Incident date: Nov 19, 2013

TL* THE CONTACT OWNS A 2007 FORD F250. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, WHITE SMOKE EMITTED FROM THE EXHAUST AS THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TOWED TO A DEALER, WHO STATED THAT THE OIL COOLER WAS DEFECTIVE AND THE ERG VALVE WOULD NEED TO BE RE... Read more

Incident date: Nov 12, 2013

RECENTLY, WHILE DRIVING MY FORD F250 TRUCK, I HAVE EXPERIENCED THE FORD'S DEATH WOBBLE' ON THREE SEPARATE OCCASIONS. AFTER DRIVING OVER A BUMP IN THE ROADWAY, THE FRONT END STARTS WOBBLING TO THE POINT THAT I HAVE TO BRAKE AND PULL OVER JUST TO STAY IN CONTROL OF MY VEHICLE. WHEN THIS DEATH WOBBLE' ... Read more

Incident date: Nov 12, 2013

Incident date: Sep 16, 2011

TL* THE CONTACT OWNS A 2007 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE BATTERY WARNING LIGHT ILLUMINATED. THE CONTACT STATED THAT THE VEHICLE BECAME DIFFICULT TO STEER AND BRAKES ALSO FAILED. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE AIR COMPRES... Read more

Incident date: Sep 12, 2013

I HAVE A 2007 F 250 DIESEL AND EVERY TIME I AM DRIVING OVER SPEED BUMP AT 45MPH TO 65MPH MY TRUCK SHAKES LIKE CRAZY IT HAS BEEN TAKEN TO THE DEALER FOR A FIX BUT NOTHING IS DONE I AM AFRAID THAT ONE DAY THIS WILL COST AN ACCIDENT I HOPE THE THIS MATER IS TAKEN CARE SOON THANK YOU FOR YOUR HELP. *... Read more

Incident date: Sep 12, 2013

Incident date: Apr 23, 2013

GOING ALONG AROUND 55 TO 60 MPH AND RUN ACROSS VERY MILD BUMP AND THE FRONT WHEELS WILL BEGIN TO SHIMMY SO BAD IT JERKS THE STEERING WHEEL BACK AND FORTH. I HAVE TO HIT THE BRAKES AND SLOW WAY DOWN TO GET IT TO STOP SHAKING. IT IS VERY DANGEROUS FEELING AND IS NOT TIRE PRESSURE LIKE FORD CLAIMS. *T... Read more

Incident date: Apr 23, 2013

Incident date: Oct 22, 2012

TL* THE CONTACT OWNS A 2007 FORD F-250. THE CONTACT STATED THAT THE HEAD GASKET MALFUNCTIONED, CAUSING COOLANT TO SPRAY OVER THE ENGINE. THE CONTACT TOOK THE VEHICLE TO THE DEALER TO HAVE THE HEAD GASKET REPLACED. THE CONTACT CALLED THE MANUFACTURER REGARDING THE HEAD GASKET AND THE MANUFACTURER ADV... Read more

Incident date: Sep 12, 2012

HIGH SPEED WHEEL OSCILLATION OCCURRED WHILE DRIVING THE SPEED LIMIT OF INTERSTATE 275 AROUND CINCINNATI, OHIO. I HIT A BUMP ON THE EXIT OF THE INTERSTATES BRIDGE AND THE STEERING WHEEL SHOOK REALLY BAD LEFT AND RIGHT. I HAD RECEIVED A LETTER LAST YEAR WARNING ME ABOUT THIS CONDITION. I DID NOT THINK... Read more

Incident date: Sep 12, 2012

Incident date: May 29, 2012

I HAVE A 2007 FORD F-250SD 4X4 WITH A 6.0L DIESEL ENGINE. ON MAY 29, 2012 MY VEHICLE EXPERIENCED A NO START CONDITION AND HAD TO BE TOWED TO THE DEALER. UPON ARRIVAL I WAS ADVISED THAT I NEEDED A NEW STARTER AND POSSIBLY MORE BUT IT COULD NOT BE DETERMINED UNTIL THE VEHICLE WAS RUNNING AGAIN. START... Read more

Incident date: Jan 3, 2011

AFTER HITTING A BUMP IN THE ROAD, WHILE DRIVING APPROXIMATELY 55 MPH, THE FRONT END THE TRUCK STARTED SHAKING CAUSING A TEMPORARY LOSS OF CONTROL. THE TRUCK HAS DONE THIS ON NUMEROUS OCCASIONS AFTER HITTING BUMPS, POT HOLES OR UNEVEN SURFACES. *TR

Incident date: Jan 3, 2011

Incident date: Apr 9, 2011

RUNNING INTERSTATE GOING ON BRIDGE IN CURVE AN LITTLE CRACK IN ROAD MADE TRUCK START SHAKING VIOLENTLY. MAKING ME HAVE TO COME TO COMPLETE STOP BEFORE IT WOULD QUIT SHAKING THROWING STUFF ALL AROUND INSIDE TRUCK. *TR

Incident date: Apr 9, 2011

Showing 50 of 84 complaints.

Technical Service Bulletins, 2007 FORD F-250

13 manufacturer communications from 10 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
061000 ENGINE AND ENGINE COOLING:ENGINE	2
021600 SUSPENSION:FRONT:WHEEL BEARING	1
040000 SERVICE BRAKES, AIR	1
022000 SUSPENSION:REAR	1
071110 FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP	1
031000 SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES	1
063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM	1
070000 FUEL SYSTEM, GASOLINE	1

010000 STEERING

In monitoring our technical service inquiries and technical service bulletins from Ford, there is the potential for moderate to severe steering wheel oscillation (wobble) to occur. After extensive testing and outside feedback, the followi

061000 ENGINE AND ENGINE COOLING:ENGINE

FORD: 2005-2011 F250/F350. THE FUEL FILL NOZZLE MAY AUTOMATICALLY SHUT OFF TOO EARLY. *RM

046000 SERVICE BRAKES, AIR:ANTILOCK

FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM

061000 ENGINE AND ENGINE COOLING:ENGINE

FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM

100000 POWER TRAIN

FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM

118000 ELECTRICAL SYSTEM:SOFTWARE

FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM

070000 FUEL SYSTEM, GASOLINE

SLOW FUEL FILL--MIL ON WITH DTC P0191. *NJ

031000 SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES

CUSTOMER SATISFACTION PROGRAM. VEHICLES EQUIPPED WITH FIXED PEDALS ACCELERATOR PEDAL INSPECTION. EFFECTIVE UNTIL JUNE 30, 2007. *KB THIS PROGRAM IS BEING EXTENDED UNTIL JUNE 30, 2008. UPDATED ON 09/25/07. *NJ

022000 SUSPENSION:REAR

REAR WHEEL BEARING LUBRICATION UPGRADE PRIOR TO SALE. *KB

040000 SERVICE BRAKES, AIR

BRAKE LINE MODIFICATION NEEDED DUE TO FRONT WHEELS COMING INTO CONTACT WITH THE BRAKE LINES. *KB

021600 SUSPENSION:FRONT:WHEEL BEARING

FRONT WHEEL BEARINGS - NOISE. *TT UPDATED ON 02-27-07. *KB

071110 FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP

SLOW FUEL FILL. *KB

063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

VEHICLES EQUIPPED WITH A 5.4L 3V OR 6.8L 3V ENGINE BUILT ON OR BEFORE 09/08/06 MAY EXHIBIT AN EXHAUST SYSTEM NOISE OFTEN DESCRIBED AS A SNAP/POP/TICK/PING NOISE. *NJ

NHTSA Safety Investigations, FORD F-250

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 2017

Power tailgate opens unintended

By letter dated December 4, 2019, Ford Motor Company (Ford) notified the Office of Defects Investigation (ODI) of a safety defect that may exist in model years (MY) 2017 through 2019 Ford Super Duty F-250, F-350, F-450 vehicles equipped with an electric tailgate. Following the receipt of five consum... er complaints alleging unintended tailgate opening without vehicle operator knowledge, while the vehicles were in motion, NHTSA opened this investigation to assess the manufacturer's data including warranty claims, field reports, design changes, etc.In vehicles equipped with an electric tailgate, water can enter the electrical wiring system and may cause a short circuit resulting in the unintended activation and release of the tailgate latch. This could allow unintended opening of the tailgate while the vehicle is in motion.Analysis of the data provided by Ford found that the frequency of a tailgate opening unintended was high in vehicles equipped with electric tailgates. Unintended tailgate opening without vehicle operator knowledge may result in loss of unrestrained cargo, increasing the risk of a crash. In response to this investigation, Ford decided to conduct recall 19V-864.Owners will be notified by mail and instructed to take their vehicle to a Ford dealer to modify the tailgate/frame wiring harnesses by adding jumper pigtails to isolate the tailgate release control circuits, and will install a new tailgate handle release switch. With recall action 19V-864 taken by Ford Motor Company this investigation is closed. Further use of agency resources does not appear to be warranted.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist on other model or MY vehicles outside of the recall scope. The agency reserves the right to take further action if warranted by the circumstances.The ODI reports cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID using the following complaint identification numbers: 10984283,11004227,11082643,11090089,11104638,11115381,11140680,11141071, 11141075,11141174,11141200,11141331,11141447,11141547,11141548,11142572, 11142618,11142657,11153541,11153959,11157225,11160936,11165124,11165590, 11166199,11166802,11170049,11171409,11171509,11171685,11180009,11182035, 11186146,11191151,11191353,11193045,11194958,11203615,11206443,11209199, 11229482,11230768,11233349,11233436,11255126,11265643.Read more

RQ, Closed , Model Year: 2011

Vehicle Commanded Engine Shutdown

The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engi... ne Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.Read more

PE, Closed , Model Year: 2008

Alleged Loss of Steering

The Office of DefectsInvestigation (ODI) opened PE13-014 after identifying five complaints alleging steering gear failure in model year (MY) 2008 Ford F-250 and F-350 Super Duty pick-up trucks and to evaluate the relationship between the design history of the steering gear assembly and the alleged d... efect.As background, ODI investigated steering gear sector shaft fractures in approximately 1.3 million MY 1999 - 2001 Ford Super Duty pick-up trucks and MY 2000 - 2001 Ford Excursion sport utility vehicles in Engineering Analysis EA01-009.The investigation determined that the sector shaft failures were the result of extraordinary, possibly multiple, impacts and not the result of fatigue.No defect in design, manufacturing or materials was identified in the sector shaft.EA01-009 was closed August 19, 2003 with 169 complaints, resulting in a rate of 12.9 incidents per 100,000 vehicles after approximately one year of service.Ford increased the diameter of the sector shaft from 1.375 inches to 1.625 inches at the start of MY 2005 production, increasing the resistance of the steering gear assembly to torsional overload by approximately 48% and changing the failure mode from sector shaft fracture to cracked or broken sector shaft gear teeth.The redesigned steering gear assembly was used in approximately 1.1 million MY 2005 through 2009 Ford Super Duty pick-up trucks, including the subject vehicles.Figure 1 shows the basic steering system design used in Ford Super Duty trucks investigated in EA01-009 and PE13-014. Figure 2 shows the locations of failures resulting from impact related torsional overloading of the sector shaft for the subject vehicles and the prior generation Ford Super Duty trucks investigated in EA01-009.Figure 3 shows an example of a failed sector shaft investigated in EA01-009 and comparisons of fracture surfaces of sector shafts failing from fatigue loading and from torsional overload.Ford provided field return part analysis of failed steering gears from MY 2005 through 2009 Super Duty trucks found evidence of broken sector shaft gear teeth and piston damage consistent with incidents of single event overload (Figure 4).Laboratory analysis found no evidence of fatigue or material property defects in any of the fractures.Analysis of complaint rates by vehicle build month showed no patterns indicating potential manufacturing quality issues and no difference before and after Ford introduced design changes to the input shaft and sector shaft seals in July 2007 to address potential leak concerns (Figure 5).Analysis of failures by time in service indicates a random failure pattern/distribution, consistent with incidents of impact induced overload (Figure 6). The complaint rate for the subject vehicles after approximately 5 to 6 years, 7.1 incidents per 100,000 vehicles, is lower than the rate observed in EA01-009. Furthermore, similar to the condition investigated in EA01-009, a number of incident records include evidence of impact loads (e.g., curb strikes) and several alleged crashes include incidents in which information suggests that the steering gear failure was most likely a result of crash forces, rather than the cause of the crash.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstances.The ODI complaints cited above can be reviewed at wwRead more

EA, Closed , Model Year: 2005

VIOLENT FRONT END OSCILLATION

THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEED... S ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.Read more

PE, Closed , Model Year: 2005

VIOLENT FRONT END OSCILLATION

ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEG... Read more

RQ, Closed , Model Year: 1999

PARKING BRAKE FAILURE

ON MAY 11, 1998, FORD MOTOR COMPANY FILED A DEFECT INFORMATION REPORT CONCERNING PARKING BRAKE FAILURE ON CERTAIN 1999 F-350 SUPER DUTY VEHICLES BUILT AT THE KENTUCKY TRUCK PLANT FROM JANUARY 26, 1998 THROUGH APRIL 24, 1998; RECALL 98V-101.THE REDUCTION IN PARKING BRAKE EFFECTIVENESS MAY OCCUR ON SO... Read more

PE, Closed , Model Year: 1999

STEERING SHAFT FRACTURE

ALLEGED THAT THE STEERING SHAFT MAY FRACTURE

PE, Closed , Model Year: 1994

SEPARATED FRONT SUSPENSION

CONSUMER COMPLAINTS REPORT THAT BOLTS WHICH RETAIN THE AXLE PIVOT BRACKET TO THE FRAME CROSS MEMBER CAN LOOSEN OR FAIL, CAUSING THE INBOARD END OR THE AXLE TO BECOME DETACHED FROM THE VEHICLE.OWNERS ALLEGE THAT THIS COULD RESULT IN LOSS OF STEERING CONTROL, HOWEVER THE COMPLAINT DATA SHOWS ONLY ONE ... INCIDENT WHERE THE VEHICLE LEFT THE ROADWAY FOLLOWING AXLE SEPARATION, WITH NO DAMAGE TO THE VEHICLE.IN ADDITION TO THE 225 CONSUMER COMPLAINTS, THERE WERE 4,315 WARRANTY CLAIMS RELATED TO THE FRONT SUSPENSION AND MEMBERS, AND 22 VEHICLES WERE REPLACED FOR GOODWILL.DOCUMENTS SUBMITTED BY FORD, UNDER REQUEST FOR CONFIDENTIAL TREATMENT INDICATE THAT THE BOLTS WERE INADEQUATE FOR THE DURABILITY REQUIREMENTS OF THE VEHICLE.ALSO, BOLTS WERE FOUND TO HAVE BEEN INADEQUATELY TORQUED AT ONE OR MORE ASSEMBLY PLANTS.OTHER FACTORS, SUCH AS WAX TREATMENT OF THE FRAME, CONTRIBUTED TO THE PROBLEM.INCREASED BOLT DIAMETER AND INCREASED TORQUE APPARENTLY CORRECTED THE PROBLEM.A SERVICE BULLETIN, 96-20-13, WAS ISSUED TO ADVISE DEALERS OF THIS CORRECTIVE ACTION.IN THESE DOCUMENTS, FORD ALSO REPORTED THAT A VEHICLE, EQUIPPED FOR SIMULTANEOUS CATASTROPHIC FAILURE OF ALL PIVOT BRACKET FASTENERS, WAS EVALUATED RESULTING IN A SLIGHT VEHICLE PULL TO ONE SIDE WITH NO LOSS OF VEHICLE CONTROL.ODI HAS NOT REPLICATED FORD'S VEHICLE TESTING, HOWEVER ANALYSIS OF THE DESIGN OF THE FRONT SUSPENSION INDICATES THAT EVEN IF THE INBOARD END OF THEAXLE BECAME DISCONNECTED FROM THE FRAME, THE OUTBOARD END WOULD REMAIN FIRMLY ATTACHED TO THE LEAF SPRING WITH TWO U-BOLTS.THIS WOULD RETAIN THE WHEEL IN ITS APPROXIMATE POSITION, ALTHOUGH THE WHEEL ALIGNMENT WOULD BE GREATLY IN ERROR.THEREFORE IT IS UNLIKELY THAT CONTROL OF THE VEHICLE WOULD BE LOST.OWNERS REPROT MANY SIGNIFICANT NOISES IN THE SUSPENSION, SUCH AS CREAKING, GROANING, CLUNKING, AND SQUEAKING, PRIOR TO NOTICING ANY SEPARATION OF THE AXLE.THIS PROVIDES WARNING OF THE LOOSENING OF THE BOLTS TO THE DRIVER, AND SHOULD NOT BE IGNORED.FORD HAS STATED THAT REPAIRS WILL BE COVERED UNDER THE VEHICLE'S BUMPER WARRANTY.COMPLAINTS ABOUT WARRANTY COVERAGE BY A FORD DEALER SHOULD BE ADDRESSED TO FORD, OR TO APPROPRIATE STATE AND LOCAL AGENCIES.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.Read more

PE, Closed , Model Year: 1992

ENGINE COMPARTMENT FIRES

There is no summary currently available

FORD F-250 - All Years Overview

Complete safety history for the FORD F-250 across all model years (1991, 2020).

152 Total Recalls

11,563 Total Complaints

9 Investigations

375 Reported Crashes

300 Reported Fires

19 Reported Deaths

FORD F-250 - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2022	0	156	View
2021	0	209	View
2020	1	352	View
2019	4	1,922	View
2018	1	616	View
2017	2	1,718	View
2016	0	430	View
2015	2	426	View
2014	0	236	View
2013	0	153	View
2012	1	423	View
2011	2	384	View
2010	0	109	View
2009	1	92	View
2008	6	255	View
2007 (current)	4	84
2006	3	332	View
2005	1	207	View
2004	7	201	View
2003	7	151	View
2002	7	189	View
2001	9	269	View
2000	10	417	View
1999	19	702	View
1998	9	76	View
1997	14	348	View
1996	5	212	View
1995	4	238	View
1994	10	156	View
1993	9	183	View
1992	7	149	View
1991	7	145	View
1990	0	5	View
1989	0	14	View
1979	0	1	View

Other FORD Models

Model	Recalls	Complaints
MUSTANG	1,104	11,600	View
RANGER	928	10,371	View
F-350 SD	776	2,363	View
F-450 SD	692	624	View
F-150	692	46,142	View
F-250 SD	638	3,635	View
EXPLORER	624	42,549	View
F-550 SD	578	603	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2007 FORD F-250

Complaint Statistics

Top Reported Components

Technical Service Bulletins, 2007 FORD F-250

Most Affected Components

NHTSA Safety Investigations, FORD F-250

FORD F-250 - All Years Overview

FORD F-250 - Year by Year

Other FORD Models