2022 FORD F-250

0 recalls, 156 complaints - 1 TSBs

No recalls found for this vehicle.

Complaint Statistics

156 total complaints 3 crashes 3 fires 2 injuries

Top Reported Components

Component	Complaints
ENGINE	26
POWER TRAIN	18
ELECTRICAL SYSTEM	17
UNKNOWN OR OTHER	10
SERVICE BRAKES	8
STEERING	8
FUEL/PROPULSION SYSTEM	7
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING	5
LANE DEPARTURE: ASSIST	4
ENGINE AND ENGINE COOLING	4

Incident date: Jul 2, 2026

The contact owns a 2020 Hyundai Palisade. The contact received notification of NHTSA Campaign Number: 25V607000 (Seat Belts). The contact stated that while parked on several occasions, the second-row driver-side and passenger-side seat belts buckles failed to latch and required three to four attempt... Read more

Incident date: Jul 3, 2026

A week prior to the engine light going on, I noticed the car running rough when stopped at a traffic light. I thought it was due to the extreme heat and the A/C running high. The check engine light went on in my 2018 Ford Edge on XXX. I took it to the dealer where I purchased it and they ran a diagn... Read more

Incident date: May 17, 2026

On May 10 a lighted wrench appeared on the instrument panel. The car felt as if I was loosing power. May 12 I got in the car, the wrench and check engine lights were both on. Called the dealer service department. They told me the car is not safe to drive as it cannot accelerator and will go into "li... Read more

Incident date: Feb 1, 2026

1) Rear subframe supports differential, axels, suspension, brakes, wheels and tires 2) If rear suspension fails , above noted assemblies will fall out of the car 3) Yes, dealer and independent garage have inspected and condemned 4) Manufacturer is aware of the problem, 5) No warnings or messages... Read more

Incident date: Apr 6, 2026

Yesterday evening, my wife and I had friends over to our house, and we were excited to show them our new Tesla. We offered to take them on a short drive around town using the Full Self-Driving (Supervised) feature. At approximately 8:00 PM, we entered the address of our local Sam's Club as the desti... Read more

Incident date: Apr 6, 2026

The contact owns a 2018 Mercedes-Benz S560 4MATIC. The contact stated that the vehicle had experienced failures associated with NHTSA Campaign Number: 26V216000 (Power Train). The vehicle was taken to a dealer, and the contact was informed that the part to do the recall repair was not yet available.... Read more

Incident date: Apr 6, 2026

I bought the vehicle used with 40,000 miles it’s has 100,856 now the engine shot off while I was driving and brought it to the GMC dealer that GM instructed me to the dealer had me pay 284.95 for inspection and then try to charge me 1284.95 for a complete tar down of the engine because of misfiri... Read more

Incident date: May 24, 2026

The tire separated after only 20k miles. Mechanic stated that I still had half of the tires life left. Was advised not to drive more than a mile on it as it could blow out and cause harm to myself and 2 young children. I had two new tires put on the vehicle. My mechanic will be checking the two rema... Read more

Incident date: Jul 5, 2024

The factory touchscreen infotainment system is experiencing severe screen delamination (internal adhesive failure). This defect causes uncontrollable 'ghost touching,' where the screen registers phantom inputs. The system cycles through radio stations, changes audio sources, and changes navigation ... Read more

Incident date: Jul 5, 2024

Our transmission is whining during acceleration.

Incident date: May 17, 2026

On May 6, 2026, while operating the vehicle on a neighborhood street, the vehicle experienced a sudden, violent, and dangerous failure. After accelerating away from a stop sign, the vehicle was traveling at approximately 20-25 mph when, simultaneous with a warning message, it came to an immediate a... Read more

Incident date: May 15, 2026

Dear NHTSA Office of Defects Investigation, I am filing this formal safety defect complaint regarding the complete failure of the airbag system to deploy during a serious motor vehicle collision on [XXX], involving a 2025 Jeep Grand Cherokee L Altitude (VIN: [XXX] ). This failure occurred in direct... Read more

Crash 1 injured

Incident date: Jul 20, 2025

While driving my 2023 Nissan Rogue on Interstate xxx from [XXX] to [XXX] with my xxx daughter in the vehicle, the vehicle suddenly displayed multiple warnings including collision assist/sensor malfunction warnings, start/stop system failure warnings, and “check owner’s manual” messages. Imme... Read more

Incident date: May 1, 2026

The contact owns a 2004 Cadillac Deville. The contact stated while driving at 35 MPH, the vehicle jerked. No warning lights were illuminated. The contact stated that the failure occurred during the warm weather season. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. ... Read more

Incident date: Apr 22, 2026

UNKNOWN - engine developed knock that could potentially lead to catastrophic engine failure during normal driving conditions, causing loss of control or inability to stop. NTB19-057a is a technical service bulletin issued by manufacturer - cylinder 7 scuffing with a short block or complete engine re... Read more

Incident date: Apr 20, 2026

We have had multiple incidents when the car is at a stop light with the idle stop not active, the vehicle engine will just die. The light turns green and the vehicle is not running, it will take multiple times pushing the start button for it to start back up. This has resulted in multiple almost r... Read more

Incident date: Apr 10, 2026

The front passenger side door is unable to open from inside or outside the vehicle. The door actuator failed, and this has been confirmed by the dealer. This is an obvious safety issue as it prevents egress in an emergency. According to Internet forums, this seems to be a known issue across BMW ... Read more

Incident date: Mar 11, 2026

Having issues with transmission at 68000 miles. Shuddering and cutting out. Shift to park comes on and also replaced alternator twice already. Replaced 1st alternator at less than 20,000 miles at 2 years old.

Incident date: Mar 27, 2026

Driving at 75mph upgrade westbound out of Denver, Co. Engine failed, shut down at speed, had to emergency move to right shoulder through 3 lanes of traffic. The last 10 mph it locked wheels to a screeching halt. Towed to Foundation Chevrolet. Confirmed engine failed, needs replacement. Ev... Read more

Incident date: Mar 14, 2026

My car has been stalling at stops and I am unable to fill my car as it will not start so I have to put increments of 10-15.00 at a time they have told me now for over three months that parts were on back order and the recall that can catch my entire car on fire while driving cannot be fixed as their... Read more

Incident date: Oct 1, 2025

The contact's mother owns a 2015 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 24V031000 (STRUCTURE) and 25V695000 (BACK OVER PREVENTION); however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reaso... Read more

Incident date: Jun 8, 2025

The warning light for the airbags is on on my dashboard with no airbags ever been deployed.

Incident date: Sep 4, 2025

I have a Hybrid version of the 2023 Corolla in the SE trim. Everytime the car is cold (engine just started), and I'm pressing the brake, I can hear some clicking noises similar to a CV Axle noise when they are bad. That braking noise goes away as the car heat up. The noise is sensitive to speed, it ... Read more

Incident date: Feb 10, 2026

The contact owns a 2015 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 24V031000 (Structure) and 25V695000 (Back Over Prevention); however, the parts to do the recall repairs were not yet available. The contact stated while driving approximately 65 MPH, the front driver... Read more

Incident date: Feb 10, 2026

Incident date: Feb 1, 2026

The rear portion of the panoramic moonroof shattered spontaneously while the vehicle was being operated, without any impact or external cause.

Incident date: Jan 12, 2026

While driving at highway speeds (approximately 50–55 mph) on a highly curving road, the steering intermittently became difficult to control. The steering wheel felt locked or stuck in a turned position and required excessive force to return to center. This condition occurred repeatedly over a 14-m... Read more

Incident date: Jan 12, 2026

6.2l motor blew up set at dealership for 4 months no motor to fix it. finally got it back with in 10 days the torque converter need replaced in the transmission. out of service out f service for motor june 19 2025 got it back october 20 2025. transmission went out 10mdays later

Incident date: Jan 12, 2026

Incident date: Jul 1, 2025

The Day Time Running light on the left side of the car just stopped working. The DRL is not damage. I checked for impact marks.

Incident date: Nov 26, 2025

Odometer Fraud. The contact was interested in purchasing a 2001 Ford Excursion at the dealer who advertised the mileage on the vehicle as 120,000 on Saturday, December 6th, 2025; however, the odometer showed a mileage of 116,000. While noticing the difference, the contact decided to research the VIN... Read more

Incident date: Nov 26, 2025

My vehicle experienced a sudden and immediate loss of motive power due to a catastrophic internal engine failure, creating a severe road safety hazard. While driving and attempting to accelerate or merge, the vehicle exhibits extreme hesitation, severe misfiring on cylinder #2, and rough, unstable ... Read more

Incident date: Jul 15, 2025

Vehicle: 2024 Jeep Wrangler 4xe Safety Recall IDs: 78C and 68C Issue: No available remedy for serious safety defects. Summary: My 2024 Jeep Wrangler 4xe has two active safety recalls. Recall 78C involves engine casting contamination leading to fire risk and sudden loss of propulsion. Recall 68C invo... Read more

Incident date: Oct 11, 2024

On numerous occasions (over 20) the forward collision system just slams on the brakes to a full stop, there was nothing close enough to vehicle to cause this issue. Sometimes it’s caused by rain or wind, sometimes for no apparent reasons. One time it caused a no damage accident as person behind me... Read more

Crash

Incident date: Nov 7, 2025

The contact owns a 2017 Volkswagen Jetta. The contact stated while the vehicle was parked, the infotainment system touch screen failed to operate as an intended. No warning light was illuminated. An independent mechanic was contacted, and the vehicle was taken to the independent mechanic to be diagn... Read more

Incident date: Oct 10, 2025

I was driving to work and when I turned into my job the steering wheel became hard. I parked my truck turned it off and turned it back on and all of my dashboard lights came on and didn’t go away. The truck would not go into any gear. Initially, we thought it was a battery problem so they changed ... Read more

Incident date: Oct 27, 2025

In 2022, my 2019 Acura TLX A-Spec received a warranty engine replacement due to a spun bearing. At that time, recall 23V-751 (connecting rod bearing defect) did not yet exist. Recently, the replacement engine developed a pronounced knocking/ticking noise at idle and during light acceleration. Multip... Read more

Incident date: Dec 31, 1969

Back passenger seatbelt won't work. Mirror sensors go off randomly when no cars are around when I'm in reverse. Backup camera malfunctions and the screen turns black.

Incident date: Oct 9, 2025

Put the truck in reverse [from park] and when I braked the pedal went to the floor and took many seconds to stop the vehicle. Checked the brake fluid, very low, filled it, pumped the brakes until it was no longer to the floor, checked the fluid again and filled it again. Parked it then tested it 20 ... Read more

Incident date: Oct 20, 2025

While pulling a 38ft 5th wheel camper on an incline with the cruise control set at random the vehicle completely dies. It experiences a total shutdown of the engine, which in return causes a complete loss of power steering, brakes etc. The truck will not restart until you push the off button and ope... Read more

Incident date: Oct 20, 2025

Everytime I fill the car up with gas it does this thing where I lose power when I stop or when I turn the wheel. So I have to stop and start the car. Its very dangerous because it has cut off while I was making a turn. We have tried to fix it several times. We replaced the fuel pump and that helpe... Read more

Incident date: Sep 20, 2025

While in park, when vehicle switches from electric idle to engine idle the car lurches forward. This has happened on multiple occasions

Incident date: Oct 16, 2025

The contact owns a 2021 Kia Soul. The contact stated that the engine was making a grinding sound while the vehicle was being started. Additionally, the contact stated that the engine oil had to be changed every week. While receiving an oil change, the contact was informed that the engine seemed to b... Read more

Incident date: Dec 6, 2024

The OEM Hankook Dynapro HP2 tires (size 225/60R17 99H, DOT 15MJF BU HA 2523) installed on a 2024 Chevrolet Trax developed premature tread wear and sidewall weakness well before half of their rated 65,000-mile life. At approximately 33,900 miles, one tire suffered a nail puncture in the sidewall and ... Read more

Incident date: Dec 6, 2024

Incident date: Sep 8, 2025

On or about 2022 I was given notice of recall which told me to go to any BMW dealer for repair. I went to Niello BMW in Sacramento. I was getting car processed and then told to summarily leave. They refused to repair my car per recall notice

Incident date: Sep 4, 2025

Note: Searching for similar complaints I found them under "Engine", "Electrical", and "Fuel". There are many such complaints! My 2020 Nissan Leaf has been under a recall notice since September of 2024 (12 months ago). Nissan warned the battery may catch fire during level 3 (rapid) charging. Nissan ... Read more

Incident date: Sep 4, 2025

My 2020 Mercedes-Benz GLE 350 experienced a complete engine seizure at approximately 60,000 miles without any warning signs. The vehicle shut down and would not restart. The engine is completely inoperable. I am aware of recalls involving engine stalling and fuel system issues in this model, and I b... Read more

Incident date: Sep 4, 2025

The contact owns a 2014 Ford F-150. The contact stated that while reversing, the back over prevention camera screen was solid black, and there was no rear image displayed. Occasionally, the image was distorted and undistinguishable. The contact stated that the failure was intermittent. The cause of ... Read more

Showing 50 of 156 complaints.

Technical Service Bulletins, 2022 FORD F-250

1 manufacturer communications from 1 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL	1

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

The Service Awareness Newsletter is an informal communication that contains information that may not be presently available in a TSB, SSM, GSB, or other electronic communication. This article includes information on warranty, technical serv

NHTSA Safety Investigations, FORD F-250

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 2017

Power tailgate opens unintended

By letter dated December 4, 2019, Ford Motor Company (Ford) notified the Office of Defects Investigation (ODI) of a safety defect that may exist in model years (MY) 2017 through 2019 Ford Super Duty F-250, F-350, F-450 vehicles equipped with an electric tailgate. Following the receipt of five consum... er complaints alleging unintended tailgate opening without vehicle operator knowledge, while the vehicles were in motion, NHTSA opened this investigation to assess the manufacturer's data including warranty claims, field reports, design changes, etc.In vehicles equipped with an electric tailgate, water can enter the electrical wiring system and may cause a short circuit resulting in the unintended activation and release of the tailgate latch. This could allow unintended opening of the tailgate while the vehicle is in motion.Analysis of the data provided by Ford found that the frequency of a tailgate opening unintended was high in vehicles equipped with electric tailgates. Unintended tailgate opening without vehicle operator knowledge may result in loss of unrestrained cargo, increasing the risk of a crash. In response to this investigation, Ford decided to conduct recall 19V-864.Owners will be notified by mail and instructed to take their vehicle to a Ford dealer to modify the tailgate/frame wiring harnesses by adding jumper pigtails to isolate the tailgate release control circuits, and will install a new tailgate handle release switch. With recall action 19V-864 taken by Ford Motor Company this investigation is closed. Further use of agency resources does not appear to be warranted.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist on other model or MY vehicles outside of the recall scope. The agency reserves the right to take further action if warranted by the circumstances.The ODI reports cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID using the following complaint identification numbers: 10984283,11004227,11082643,11090089,11104638,11115381,11140680,11141071, 11141075,11141174,11141200,11141331,11141447,11141547,11141548,11142572, 11142618,11142657,11153541,11153959,11157225,11160936,11165124,11165590, 11166199,11166802,11170049,11171409,11171509,11171685,11180009,11182035, 11186146,11191151,11191353,11193045,11194958,11203615,11206443,11209199, 11229482,11230768,11233349,11233436,11255126,11265643.Read more

RQ, Closed , Model Year: 2011

Vehicle Commanded Engine Shutdown

The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engi... ne Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.Read more

PE, Closed , Model Year: 2008

Alleged Loss of Steering

The Office of DefectsInvestigation (ODI) opened PE13-014 after identifying five complaints alleging steering gear failure in model year (MY) 2008 Ford F-250 and F-350 Super Duty pick-up trucks and to evaluate the relationship between the design history of the steering gear assembly and the alleged d... efect.As background, ODI investigated steering gear sector shaft fractures in approximately 1.3 million MY 1999 - 2001 Ford Super Duty pick-up trucks and MY 2000 - 2001 Ford Excursion sport utility vehicles in Engineering Analysis EA01-009.The investigation determined that the sector shaft failures were the result of extraordinary, possibly multiple, impacts and not the result of fatigue.No defect in design, manufacturing or materials was identified in the sector shaft.EA01-009 was closed August 19, 2003 with 169 complaints, resulting in a rate of 12.9 incidents per 100,000 vehicles after approximately one year of service.Ford increased the diameter of the sector shaft from 1.375 inches to 1.625 inches at the start of MY 2005 production, increasing the resistance of the steering gear assembly to torsional overload by approximately 48% and changing the failure mode from sector shaft fracture to cracked or broken sector shaft gear teeth.The redesigned steering gear assembly was used in approximately 1.1 million MY 2005 through 2009 Ford Super Duty pick-up trucks, including the subject vehicles.Figure 1 shows the basic steering system design used in Ford Super Duty trucks investigated in EA01-009 and PE13-014. Figure 2 shows the locations of failures resulting from impact related torsional overloading of the sector shaft for the subject vehicles and the prior generation Ford Super Duty trucks investigated in EA01-009.Figure 3 shows an example of a failed sector shaft investigated in EA01-009 and comparisons of fracture surfaces of sector shafts failing from fatigue loading and from torsional overload.Ford provided field return part analysis of failed steering gears from MY 2005 through 2009 Super Duty trucks found evidence of broken sector shaft gear teeth and piston damage consistent with incidents of single event overload (Figure 4).Laboratory analysis found no evidence of fatigue or material property defects in any of the fractures.Analysis of complaint rates by vehicle build month showed no patterns indicating potential manufacturing quality issues and no difference before and after Ford introduced design changes to the input shaft and sector shaft seals in July 2007 to address potential leak concerns (Figure 5).Analysis of failures by time in service indicates a random failure pattern/distribution, consistent with incidents of impact induced overload (Figure 6). The complaint rate for the subject vehicles after approximately 5 to 6 years, 7.1 incidents per 100,000 vehicles, is lower than the rate observed in EA01-009. Furthermore, similar to the condition investigated in EA01-009, a number of incident records include evidence of impact loads (e.g., curb strikes) and several alleged crashes include incidents in which information suggests that the steering gear failure was most likely a result of crash forces, rather than the cause of the crash.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstances.The ODI complaints cited above can be reviewed at wwRead more

EA, Closed , Model Year: 2005

VIOLENT FRONT END OSCILLATION

THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEED... S ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.Read more

PE, Closed , Model Year: 2005

VIOLENT FRONT END OSCILLATION

ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEG... Read more

RQ, Closed , Model Year: 1999

PARKING BRAKE FAILURE

ON MAY 11, 1998, FORD MOTOR COMPANY FILED A DEFECT INFORMATION REPORT CONCERNING PARKING BRAKE FAILURE ON CERTAIN 1999 F-350 SUPER DUTY VEHICLES BUILT AT THE KENTUCKY TRUCK PLANT FROM JANUARY 26, 1998 THROUGH APRIL 24, 1998; RECALL 98V-101.THE REDUCTION IN PARKING BRAKE EFFECTIVENESS MAY OCCUR ON SO... Read more

PE, Closed , Model Year: 1999

STEERING SHAFT FRACTURE

ALLEGED THAT THE STEERING SHAFT MAY FRACTURE

PE, Closed , Model Year: 1994

SEPARATED FRONT SUSPENSION

CONSUMER COMPLAINTS REPORT THAT BOLTS WHICH RETAIN THE AXLE PIVOT BRACKET TO THE FRAME CROSS MEMBER CAN LOOSEN OR FAIL, CAUSING THE INBOARD END OR THE AXLE TO BECOME DETACHED FROM THE VEHICLE.OWNERS ALLEGE THAT THIS COULD RESULT IN LOSS OF STEERING CONTROL, HOWEVER THE COMPLAINT DATA SHOWS ONLY ONE ... INCIDENT WHERE THE VEHICLE LEFT THE ROADWAY FOLLOWING AXLE SEPARATION, WITH NO DAMAGE TO THE VEHICLE.IN ADDITION TO THE 225 CONSUMER COMPLAINTS, THERE WERE 4,315 WARRANTY CLAIMS RELATED TO THE FRONT SUSPENSION AND MEMBERS, AND 22 VEHICLES WERE REPLACED FOR GOODWILL.DOCUMENTS SUBMITTED BY FORD, UNDER REQUEST FOR CONFIDENTIAL TREATMENT INDICATE THAT THE BOLTS WERE INADEQUATE FOR THE DURABILITY REQUIREMENTS OF THE VEHICLE.ALSO, BOLTS WERE FOUND TO HAVE BEEN INADEQUATELY TORQUED AT ONE OR MORE ASSEMBLY PLANTS.OTHER FACTORS, SUCH AS WAX TREATMENT OF THE FRAME, CONTRIBUTED TO THE PROBLEM.INCREASED BOLT DIAMETER AND INCREASED TORQUE APPARENTLY CORRECTED THE PROBLEM.A SERVICE BULLETIN, 96-20-13, WAS ISSUED TO ADVISE DEALERS OF THIS CORRECTIVE ACTION.IN THESE DOCUMENTS, FORD ALSO REPORTED THAT A VEHICLE, EQUIPPED FOR SIMULTANEOUS CATASTROPHIC FAILURE OF ALL PIVOT BRACKET FASTENERS, WAS EVALUATED RESULTING IN A SLIGHT VEHICLE PULL TO ONE SIDE WITH NO LOSS OF VEHICLE CONTROL.ODI HAS NOT REPLICATED FORD'S VEHICLE TESTING, HOWEVER ANALYSIS OF THE DESIGN OF THE FRONT SUSPENSION INDICATES THAT EVEN IF THE INBOARD END OF THEAXLE BECAME DISCONNECTED FROM THE FRAME, THE OUTBOARD END WOULD REMAIN FIRMLY ATTACHED TO THE LEAF SPRING WITH TWO U-BOLTS.THIS WOULD RETAIN THE WHEEL IN ITS APPROXIMATE POSITION, ALTHOUGH THE WHEEL ALIGNMENT WOULD BE GREATLY IN ERROR.THEREFORE IT IS UNLIKELY THAT CONTROL OF THE VEHICLE WOULD BE LOST.OWNERS REPROT MANY SIGNIFICANT NOISES IN THE SUSPENSION, SUCH AS CREAKING, GROANING, CLUNKING, AND SQUEAKING, PRIOR TO NOTICING ANY SEPARATION OF THE AXLE.THIS PROVIDES WARNING OF THE LOOSENING OF THE BOLTS TO THE DRIVER, AND SHOULD NOT BE IGNORED.FORD HAS STATED THAT REPAIRS WILL BE COVERED UNDER THE VEHICLE'S BUMPER WARRANTY.COMPLAINTS ABOUT WARRANTY COVERAGE BY A FORD DEALER SHOULD BE ADDRESSED TO FORD, OR TO APPROPRIATE STATE AND LOCAL AGENCIES.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.Read more

PE, Closed , Model Year: 1992

ENGINE COMPARTMENT FIRES

There is no summary currently available

FORD F-250 - All Years Overview

Complete safety history for the FORD F-250 across all model years (1991, 2020).

152 Total Recalls

11,563 Total Complaints

9 Investigations

375 Reported Crashes

300 Reported Fires

19 Reported Deaths

FORD F-250 - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2022 (current)	0	156
2021	0	209	View
2020	1	352	View
2019	4	1,922	View
2018	1	616	View
2017	2	1,718	View
2016	0	430	View
2015	2	426	View
2014	0	236	View
2013	0	153	View
2012	1	423	View
2011	2	384	View
2010	0	109	View
2009	1	92	View
2008	6	255	View
2007	4	84	View
2006	3	332	View
2005	1	207	View
2004	7	201	View
2003	7	151	View
2002	7	189	View
2001	9	269	View
2000	10	417	View
1999	19	702	View
1998	9	76	View
1997	14	348	View
1996	5	212	View
1995	4	238	View
1994	10	156	View
1993	9	183	View
1992	7	149	View
1991	7	145	View
1990	0	5	View
1989	0	14	View
1979	0	1	View

Other FORD Models

Model	Recalls	Complaints
MUSTANG	1,104	11,600	View
RANGER	928	10,371	View
F-350 SD	776	2,363	View
F-450 SD	692	624	View
F-150	692	46,142	View
F-250 SD	638	3,635	View
EXPLORER	624	42,549	View
F-550 SD	578	603	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2022 FORD F-250

Complaint Statistics

Top Reported Components

Technical Service Bulletins, 2022 FORD F-250

Most Affected Components

NHTSA Safety Investigations, FORD F-250

FORD F-250 - All Years Overview

FORD F-250 - Year by Year

Other FORD Models