2014 FORD F-250

0 recalls, 236 complaints - 29 TSBs

No recalls found for this vehicle.

Complaint Statistics

236 total complaints 3 crashes 2 injuries

Top Reported Components

Component	Complaints
SUSPENSION	64
STEERING	60
ENGINE	17
UNKNOWN OR OTHER	15
ELECTRICAL SYSTEM	15
FUEL/PROPULSION SYSTEM	9
POWER TRAIN	7
SERVICE BRAKES	7
WHEELS	5
EXTERIOR LIGHTING	5

Incident date: Apr 1, 2026

While driving the breaks faultered and I had to slam on the break. I had to press all the way down on the break pedal to slow down or stop. Also when stopped at a light the car turns off and puts itself in park. I had to turn the car off and back on again to fix it. My safety and the safety of oth... Read more

Incident date: Jan 30, 2026

The contact owns a 2022 Chevrolet Traverse. The contact stated that while driving 65 MPH on the highway, the low oil warning light illuminated. A dealer was contacted. The vehicle was towed to the dealer to be diagnosed, and it was determined that the engine needed to be replaced. The vehicle was no... Read more

Incident date: Jan 30, 2026

Odometer Fraud. The contact purchased a 2010 Chevrolet Suburban. The contact stated that while driving approximately 55 MPH, the vehicle suddenly stalled. The vehicle was restarted and driven; however, approximately one minute later, the failure reoccurred. The vehicle was restarted and driven to a ... Read more

Incident date: Feb 27, 2026

On January 31st, 2026, not long after starting a journey in my car, I got a “check electrical systems” warning. I was close to home so was able to turn around and drive home. Just before pulling into the driveway, the warning changed to a “power limited” warning. On Monday Feb 2nd, I had ... Read more

Incident date: Jun 5, 2015

2019 Ram Laramie 1500 instrument or cluster panel goes blank or speedometer goes blurry and unreadable.

Incident date: Oct 23, 2025

The contact owns a 2018 Cadillac XT5. The contact stated that while stopped at a stop light, the front driver's side seat independently moved forward and backward. The contact stated that the driver's side rearview mirror independently folded inwards. No warning lights were illuminated. The contact ... Read more

Incident date: Oct 23, 2025

The contact owns a 2016 Chevrolet Malibu. The contact stated that after driving and parking the vehicle, the contact entered the residence; however, upon returning to the vehicle, the vehicle failed to start. There were no warning lights illuminated. The vehicle was towed to the local dealer, and th... Read more

Incident date: Sep 9, 2025

The transmission failed. While driving, it shifts extremely hard and will suddenly downshift without warning. Autonation Ford of North Canton, Ohio, inspected the vehicle on August 13, 2025, and reported that the CDF drum clutches were likely worn. The truck is available for inspection upon request.... Read more

Incident date: Jun 13, 2025

The headlights burn out frequently the air conditioner does not work the ignition had to be replaced there's always a code of p0171 the start/stop feature does not work the brakes make the car shake. When does stuff takes place I have to pull the vehicle over cousin me to put others in danger by bei... Read more

Incident date: Mar 1, 2025

Recall 30B regarding the instrument panel cluster is affecting my jeep it only has 30k miles and is defective. Diagnosed 5/13/25 by Mitchell Auto Group service department in Avon, CT

Incident date: May 13, 2025

I own a 2023 Ford Maverick XLT Hybrid. I am having issues with the 12v battery. The battery drains unexpectedly making the truck go into Battery Saver Mode. I already took it to the Ford de leadership where it received a new 12v battery. Couple of months go by and now the replacement battery is havi... Read more

Incident date: Feb 16, 2025

Blind sport warning and forward collision warnings keep failing and the alarms are incessant. The alarms are a major distraction with all the flashing. These are items that have not worked since the car was delivered and Fisker, Heights, and the FOA have all failed to address this. Another car hand... Read more

Incident date: Jan 31, 2025

I bought Lincoln Aviator 2025 Model. After 2 weeks my car started showing all the faulty error sign. To be specific with sign I have the following sign on : BSM, Cross traffic system fault, front camera fault, pre-collision alert. Reverse camera malfunction sign. I have my other 3 friend that have ... Read more

Incident date: Dec 20, 2024

Rear brakes replaced twice on warranty. The car only has 24,000. Car remains with loud chattering brakes on all 4 brakes especially when brakes are cold. Especially loud chattering and squealing brakes still exist especially on rear brakes. Issue with a fuel valve needing to be replaced on warranty... Read more

Incident date: Dec 20, 2024

Incident date: Dec 3, 2024

Back up camera glitches. Causes driver assist to take control at times when not necessary. Have has this in for service at least 4 times since purchasing vehicle in 2020. Service states repaired each time bit eventually happens again. This last time is getting more severe cause multiple electrical ... Read more

Incident date: Dec 3, 2024

The big problem when I drive is that it is not safe, it jerks when I start to accelerate. I took it to the nearest dealer to have the problem fixed. And they do not want to fix the problem and now I just want to get this vehicle off the roads. I do not want to cause an accident and put my family at ... Read more

Incident date: Nov 26, 2024

Front upper control arm ball joint separated from socket.

Incident date: Oct 9, 2024

Footwell module is bad. My safety is at risk everyday that I drive the vehicle. The high beams don't work, turn signals don't work, inside dash lights don't work,windows don't roll down, side mirror's don't work,inside lights don't work, doors don't lock.My car was in the shop for another issue and ... Read more

Incident date: Oct 9, 2024

Engine maintenance required when AC is turned on. This is an issue with the coolant by pass valve, many rav4 owners have reported but a recall has not been established

Incident date: Aug 29, 2024

The ABS module has failed. There was a recall R61 issued previously for this issue of moisture causing ABS module failures. The original recall was completed on this vehicle [XXX]. There is no documentation that the ABS module itself was replaced at that time since this is a tiered recall. The ABS m... Read more

Incident date: Aug 29, 2024

The contact owns a 2011 Lincoln MKX. The contact stated that while attempting to stop the vehicle, the brake pedal was depressed; however, the vehicle failed to respond as needed. The vehicle was driven to the dealer to be diagnosed. The contact was informed that the ABS system needed to be replaced... Read more

Incident date: Sep 27, 2024

At highway speeds car steering gets stuck causing driver to correct steering, which causes car to bind. Extremely dangerous as in highway speeds can cause a hazard to driver as well as other drivers on the road.

Incident date: Sep 27, 2024

I am writing to complain that VW has not offered any assistance or solution to the electronic software failure noted in NHTSA Recall # 24V344. I have been experiencing software and electrical failures that affect the center and dashboard displays. I have no speedometer or rearview camera displa... Read more

Incident date: Sep 1, 2024

There is a recall on the Power Transfer Unit in my vehicle, a 2016 Jeep Cherokee which can cause rollaway or loss of control causing crash or injury.

Incident date: Aug 12, 2024

The contact owns a 2011 Ford Edge. The contact stated while driving 25 MPH and attempting to stop the vehicle, the brake pedal was depressed; however, the vehicle failed to respond, and the brake pedal traveled to the floorboard. The vehicle was taken to an independent mechanic where it was diagnose... Read more

Incident date: Jul 10, 2024

I bought this car for my daughter we bought used low miles in May 2023. She got her first oil change in August 2023, in November on her way back to college her car seized up and stop working on the highway. Dealership said missing oil plug. Had to replace with new engine. Insurance company drops us,... Read more

Incident date: Mar 15, 2023

The contact owns a 2013 Ford F-150. The contact stated that while driving at various speeds, the transmission was slipping between gear. While on a ramp, the vehicle failed to shift into gear. There were unknown warning lights illuminated. The vehicle was taken to an independent mechanic, who determ... Read more

Incident date: May 1, 2024

Engine failure. Car suddenly stop and engine light lit on.

Incident date: Sep 15, 2022

While driving the vehicle up a steep hill at 45mph, it began making a ticking noise, within seconds, the engine seized and the car died. There were no warning lights. The vehicle is available to be inspected, it has been towed to a Kia dealership and is currently awaiting inspection. Safety was ... Read more

Incident date: May 28, 2024

The contact owns a 2014 Nissan Pathfinder. The contact stated while driving 60 MPH and slowing down, the vehicle was vibrating and shaking while downshifting to a lower gear. The contact stated no warning light was illuminated. The contact stated that the vehicle was also hesitating and jerking into... Read more

Incident date: May 7, 2024

My drivers side quarter panel taillight has stopped working due to moisture in the light (no visible breakage on light), this was in January. This part is on continuous backorder with no ETA of coming back in stock. The light is an LED and therefore cannot replace just the bulb. I travel for work an... Read more

Incident date: May 7, 2024

Main center display becomes blank at random times. Sometimes this is accompanied by a loud squealing sound from car audio. When display blanks, all HVAC functions stop including defog, also all audio including turn signal indication sound. Sometimes display and functions self recover after approxima... Read more

Incident date: May 7, 2024

The contact owns a 2019 Ford Fusion Energi. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repa... Read more

Incident date: Apr 17, 2024

The ABS control module is not working. This turns off the anti-lock brakes and I have nearly hit someone when the brakes locked and skid across the intersection. The consistency beeping and vehicle message block the information screen. I have been waiting for over a year for the parts to be replaced... Read more

Incident date: Apr 17, 2024

Bullet 1: headlights defect Bullet 2: I am blinded at night because when I have low beams on there are 4 distinct shadows projected on the road. I can’t drive at night because it not only is very distracting but blocks my vision of the left side of the road. Bullet 3: yes, the problem has been re... Read more

Incident date: Jul 12, 2023

The contact owns a 2014 Hyundai Elantra. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. Th... Read more

Incident date: Jul 12, 2023

Experiencing stickiness in steering effort when travelling in straight line at highway speeds. Overcoming the stickiness sometimes causes vehicle to deviate in its lane.

Incident date: Dec 24, 2023

The contact owns a 2022 Ford Escape. The contact stated that while driving 25 MPH, there was an abnormal movement near the rear of the vehicle. The contact became aware that the rear window was detaching. The vehicle was taken to the dealer where the drip rail molding was replaced. The failure persi... Read more

Incident date: Dec 24, 2023

Knock Sensor and decreased internal battery No harm to me or others Yes No No, 12-23-2023 date of incident.

Incident date: Dec 24, 2023

Incident date: Nov 26, 2023

The contact owns a 2015 Ram 1500. The contact received notification of NHTSA Campaign Number: 22V406000 (Fuel System, Diesel) however, the part to do the recall repair was not yet available. The contact stated while driving approximately 60-80 MPH, the vehicle went into LIMP Mode and the speed was r... Read more

Incident date: Nov 2, 2023

there is currently a recall, U90, on my jeep. this recall causes high emissions. my vehicle will not pass department of motor vehicles with high emissions. there is a back order for the part that will fix the recall. the recall has also caused codes to come on, which can lead to other malfunctions. ... Read more

Incident date: Nov 2, 2023

The contact owns a 2011 Ford F-150. The contact stated while driving at various speeds, the vehicle shifted into first gear and became stuck in the first gear. The contact was able to pull to the side of the road and restart the vehicle after multiple attempts. The check engine and wrench warning li... Read more

Incident date: Nov 2, 2023

Incident date: Oct 18, 2023

All my warning lights came on my vehicle. Before I could get to service department, the car was making a weird sound underneath me. I knew something was wrong. I had it towed to dealer. They say my TURBO is out. The car is still in shop waiting on part, but the service man said the same make an... Read more

Incident date: Oct 18, 2023

I went to get a Virginia Inspection and found that the frame on both sides near the fuel tank was rusted completely through. The truck has no other rust spots anywhere.

Incident date: Sep 20, 2023

sudden failure of power steering,with out any prior warning or symptoms

Showing 50 of 236 complaints.

Technical Service Bulletins, 2014 FORD F-250

29 manufacturer communications from 9 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
062200 ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN	2
060000 ENGINE (PWS)	2
060000 ENGINE AND ENGINE COOLING	2
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER	1
034510 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER	1
045100 SERVICE BRAKES, AIR:DISC:CALIPER	1
133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS	1
061000 ENGINE AND ENGINE COOLING:ENGINE	1

060000 ENGINE AND ENGINE COOLING

Certain 2014-2016 Model Year F-250 ? F-550 and 2016 Model Year F-650 - F-750 Vehicles, With 6.7L Diesel Engine - Crankcase Ventilation Oil Separator Assembly

061200 ENGINE AND ENGINE COOLING:ENGINE:DIESEL

The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate

063140 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR

063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

063110 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)

063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

062300 ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS

062200 ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

062100 ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY

062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM

061320 ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER

061120 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER

061110 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

061000 ENGINE AND ENGINE COOLING:ENGINE

060000 ENGINE AND ENGINE COOLING

063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

060000 ENGINE (PWS)

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

Touchscreen navigation system - arabic language - blank screen

110000 ELECTRICAL SYSTEM

Some 2012-2016 vehicles equipped with a touchscreen navigation system and the language set to Arabic may exhibit a blank screen. This may be the result of the ribbon cables not being fully seated inside the front display interface module (F

350000 EQUIPMENT

Touchscreen navigation system - arabic language - blank screen

010000 STEERING

In monitoring our technical service inquiries and technical service bulletins from Ford, there is the potential for moderate to severe steering wheel oscillation (wobble) to occur. After extensive testing and outside feedback, the followi

060000 ENGINE (PWS)

FORD: 2011-2014 F-SUPER DUTY VEHICLES EQUIPPED WITH 6.7L DIESEL ENGINE MAY EXPERIENCE A RUNNING ROUGH OR MISFIRE DURING EXHAUST REGENERATION PROCESS *CN

133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

FORD: NO SERVICE ACTION IS RECOMMENDED FOR THIS CONDITION. PLEASE USE AT YOUR DISCRETION. VARIOUS 2010-2015 VEHICLES MAY EXPERIENCE A TURBULENCE NOISE, SIMILAR TO AN HELICOPTER NOISE, AT HIGHWAY SPEEDS WHEN THE REAR DOOR WINDOW(S) OR SUNROO

045100 SERVICE BRAKES, AIR:DISC:CALIPER

FORD: ON SOME TRUCKS, THE BINDING/STICKING OF FRONT/REAR BRAKE CALIPER AND WOULD NEED TO BE REMOVE AND REPLACE, EXCEPT BRAKE PADS ON CALIPER BRACKET ASSEMBLY, COMPLETE CALIPER ASSEMBLY (CALIPER BRACKET, BRAKE PADS, CLIPS) ON FRONT KNUCKLE/

034510 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

FORD: SOME MODEL VEHICLES MANUAL FOR POWERTRAIN CONTROL/EMISSION DIAGNOSTIC (PC/ED) HAS BEEN UPDATED REGARDING IMPROVED COOLING FAN CIRCUIT DUE TO A LACK OF AIR CONDITIONING, A MALFUNCTIONING INDICATOR LAMP (MIL) AND OVERHEATING.

062200 ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

NHTSA Safety Investigations, FORD F-250

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 2017

Power tailgate opens unintended

By letter dated December 4, 2019, Ford Motor Company (Ford) notified the Office of Defects Investigation (ODI) of a safety defect that may exist in model years (MY) 2017 through 2019 Ford Super Duty F-250, F-350, F-450 vehicles equipped with an electric tailgate. Following the receipt of five consum... er complaints alleging unintended tailgate opening without vehicle operator knowledge, while the vehicles were in motion, NHTSA opened this investigation to assess the manufacturer's data including warranty claims, field reports, design changes, etc.In vehicles equipped with an electric tailgate, water can enter the electrical wiring system and may cause a short circuit resulting in the unintended activation and release of the tailgate latch. This could allow unintended opening of the tailgate while the vehicle is in motion.Analysis of the data provided by Ford found that the frequency of a tailgate opening unintended was high in vehicles equipped with electric tailgates. Unintended tailgate opening without vehicle operator knowledge may result in loss of unrestrained cargo, increasing the risk of a crash. In response to this investigation, Ford decided to conduct recall 19V-864.Owners will be notified by mail and instructed to take their vehicle to a Ford dealer to modify the tailgate/frame wiring harnesses by adding jumper pigtails to isolate the tailgate release control circuits, and will install a new tailgate handle release switch. With recall action 19V-864 taken by Ford Motor Company this investigation is closed. Further use of agency resources does not appear to be warranted.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist on other model or MY vehicles outside of the recall scope. The agency reserves the right to take further action if warranted by the circumstances.The ODI reports cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID using the following complaint identification numbers: 10984283,11004227,11082643,11090089,11104638,11115381,11140680,11141071, 11141075,11141174,11141200,11141331,11141447,11141547,11141548,11142572, 11142618,11142657,11153541,11153959,11157225,11160936,11165124,11165590, 11166199,11166802,11170049,11171409,11171509,11171685,11180009,11182035, 11186146,11191151,11191353,11193045,11194958,11203615,11206443,11209199, 11229482,11230768,11233349,11233436,11255126,11265643.Read more

RQ, Closed , Model Year: 2011

Vehicle Commanded Engine Shutdown

The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engi... ne Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.Read more

PE, Closed , Model Year: 2008

Alleged Loss of Steering

The Office of DefectsInvestigation (ODI) opened PE13-014 after identifying five complaints alleging steering gear failure in model year (MY) 2008 Ford F-250 and F-350 Super Duty pick-up trucks and to evaluate the relationship between the design history of the steering gear assembly and the alleged d... efect.As background, ODI investigated steering gear sector shaft fractures in approximately 1.3 million MY 1999 - 2001 Ford Super Duty pick-up trucks and MY 2000 - 2001 Ford Excursion sport utility vehicles in Engineering Analysis EA01-009.The investigation determined that the sector shaft failures were the result of extraordinary, possibly multiple, impacts and not the result of fatigue.No defect in design, manufacturing or materials was identified in the sector shaft.EA01-009 was closed August 19, 2003 with 169 complaints, resulting in a rate of 12.9 incidents per 100,000 vehicles after approximately one year of service.Ford increased the diameter of the sector shaft from 1.375 inches to 1.625 inches at the start of MY 2005 production, increasing the resistance of the steering gear assembly to torsional overload by approximately 48% and changing the failure mode from sector shaft fracture to cracked or broken sector shaft gear teeth.The redesigned steering gear assembly was used in approximately 1.1 million MY 2005 through 2009 Ford Super Duty pick-up trucks, including the subject vehicles.Figure 1 shows the basic steering system design used in Ford Super Duty trucks investigated in EA01-009 and PE13-014. Figure 2 shows the locations of failures resulting from impact related torsional overloading of the sector shaft for the subject vehicles and the prior generation Ford Super Duty trucks investigated in EA01-009.Figure 3 shows an example of a failed sector shaft investigated in EA01-009 and comparisons of fracture surfaces of sector shafts failing from fatigue loading and from torsional overload.Ford provided field return part analysis of failed steering gears from MY 2005 through 2009 Super Duty trucks found evidence of broken sector shaft gear teeth and piston damage consistent with incidents of single event overload (Figure 4).Laboratory analysis found no evidence of fatigue or material property defects in any of the fractures.Analysis of complaint rates by vehicle build month showed no patterns indicating potential manufacturing quality issues and no difference before and after Ford introduced design changes to the input shaft and sector shaft seals in July 2007 to address potential leak concerns (Figure 5).Analysis of failures by time in service indicates a random failure pattern/distribution, consistent with incidents of impact induced overload (Figure 6). The complaint rate for the subject vehicles after approximately 5 to 6 years, 7.1 incidents per 100,000 vehicles, is lower than the rate observed in EA01-009. Furthermore, similar to the condition investigated in EA01-009, a number of incident records include evidence of impact loads (e.g., curb strikes) and several alleged crashes include incidents in which information suggests that the steering gear failure was most likely a result of crash forces, rather than the cause of the crash.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstances.The ODI complaints cited above can be reviewed at wwRead more

EA, Closed , Model Year: 2005

VIOLENT FRONT END OSCILLATION

THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEED... S ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.Read more

PE, Closed , Model Year: 2005

VIOLENT FRONT END OSCILLATION

ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEG... Read more

RQ, Closed , Model Year: 1999

PARKING BRAKE FAILURE

ON MAY 11, 1998, FORD MOTOR COMPANY FILED A DEFECT INFORMATION REPORT CONCERNING PARKING BRAKE FAILURE ON CERTAIN 1999 F-350 SUPER DUTY VEHICLES BUILT AT THE KENTUCKY TRUCK PLANT FROM JANUARY 26, 1998 THROUGH APRIL 24, 1998; RECALL 98V-101.THE REDUCTION IN PARKING BRAKE EFFECTIVENESS MAY OCCUR ON SO... Read more

PE, Closed , Model Year: 1999

STEERING SHAFT FRACTURE

ALLEGED THAT THE STEERING SHAFT MAY FRACTURE

PE, Closed , Model Year: 1994

SEPARATED FRONT SUSPENSION

CONSUMER COMPLAINTS REPORT THAT BOLTS WHICH RETAIN THE AXLE PIVOT BRACKET TO THE FRAME CROSS MEMBER CAN LOOSEN OR FAIL, CAUSING THE INBOARD END OR THE AXLE TO BECOME DETACHED FROM THE VEHICLE.OWNERS ALLEGE THAT THIS COULD RESULT IN LOSS OF STEERING CONTROL, HOWEVER THE COMPLAINT DATA SHOWS ONLY ONE ... INCIDENT WHERE THE VEHICLE LEFT THE ROADWAY FOLLOWING AXLE SEPARATION, WITH NO DAMAGE TO THE VEHICLE.IN ADDITION TO THE 225 CONSUMER COMPLAINTS, THERE WERE 4,315 WARRANTY CLAIMS RELATED TO THE FRONT SUSPENSION AND MEMBERS, AND 22 VEHICLES WERE REPLACED FOR GOODWILL.DOCUMENTS SUBMITTED BY FORD, UNDER REQUEST FOR CONFIDENTIAL TREATMENT INDICATE THAT THE BOLTS WERE INADEQUATE FOR THE DURABILITY REQUIREMENTS OF THE VEHICLE.ALSO, BOLTS WERE FOUND TO HAVE BEEN INADEQUATELY TORQUED AT ONE OR MORE ASSEMBLY PLANTS.OTHER FACTORS, SUCH AS WAX TREATMENT OF THE FRAME, CONTRIBUTED TO THE PROBLEM.INCREASED BOLT DIAMETER AND INCREASED TORQUE APPARENTLY CORRECTED THE PROBLEM.A SERVICE BULLETIN, 96-20-13, WAS ISSUED TO ADVISE DEALERS OF THIS CORRECTIVE ACTION.IN THESE DOCUMENTS, FORD ALSO REPORTED THAT A VEHICLE, EQUIPPED FOR SIMULTANEOUS CATASTROPHIC FAILURE OF ALL PIVOT BRACKET FASTENERS, WAS EVALUATED RESULTING IN A SLIGHT VEHICLE PULL TO ONE SIDE WITH NO LOSS OF VEHICLE CONTROL.ODI HAS NOT REPLICATED FORD'S VEHICLE TESTING, HOWEVER ANALYSIS OF THE DESIGN OF THE FRONT SUSPENSION INDICATES THAT EVEN IF THE INBOARD END OF THEAXLE BECAME DISCONNECTED FROM THE FRAME, THE OUTBOARD END WOULD REMAIN FIRMLY ATTACHED TO THE LEAF SPRING WITH TWO U-BOLTS.THIS WOULD RETAIN THE WHEEL IN ITS APPROXIMATE POSITION, ALTHOUGH THE WHEEL ALIGNMENT WOULD BE GREATLY IN ERROR.THEREFORE IT IS UNLIKELY THAT CONTROL OF THE VEHICLE WOULD BE LOST.OWNERS REPROT MANY SIGNIFICANT NOISES IN THE SUSPENSION, SUCH AS CREAKING, GROANING, CLUNKING, AND SQUEAKING, PRIOR TO NOTICING ANY SEPARATION OF THE AXLE.THIS PROVIDES WARNING OF THE LOOSENING OF THE BOLTS TO THE DRIVER, AND SHOULD NOT BE IGNORED.FORD HAS STATED THAT REPAIRS WILL BE COVERED UNDER THE VEHICLE'S BUMPER WARRANTY.COMPLAINTS ABOUT WARRANTY COVERAGE BY A FORD DEALER SHOULD BE ADDRESSED TO FORD, OR TO APPROPRIATE STATE AND LOCAL AGENCIES.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.Read more

PE, Closed , Model Year: 1992

ENGINE COMPARTMENT FIRES

There is no summary currently available

FORD F-250 - All Years Overview

Complete safety history for the FORD F-250 across all model years (1991, 2020).

152 Total Recalls

11,563 Total Complaints

9 Investigations

375 Reported Crashes

300 Reported Fires

19 Reported Deaths

FORD F-250 - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2022	0	156	View
2021	0	209	View
2020	1	352	View
2019	4	1,922	View
2018	1	616	View
2017	2	1,718	View
2016	0	430	View
2015	2	426	View
2014 (current)	0	236
2013	0	153	View
2012	1	423	View
2011	2	384	View
2010	0	109	View
2009	1	92	View
2008	6	255	View
2007	4	84	View
2006	3	332	View
2005	1	207	View
2004	7	201	View
2003	7	151	View
2002	7	189	View
2001	9	269	View
2000	10	417	View
1999	19	702	View
1998	9	76	View
1997	14	348	View
1996	5	212	View
1995	4	238	View
1994	10	156	View
1993	9	183	View
1992	7	149	View
1991	7	145	View
1990	0	5	View
1989	0	14	View
1979	0	1	View

Other FORD Models

Model	Recalls	Complaints
MUSTANG	1,104	11,600	View
RANGER	928	10,371	View
F-350 SD	776	2,363	View
F-450 SD	692	624	View
F-150	692	46,142	View
F-250 SD	638	3,635	View
EXPLORER	624	42,549	View
F-550 SD	578	603	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2014 FORD F-250

Complaint Statistics

Top Reported Components

Technical Service Bulletins, 2014 FORD F-250

Most Affected Components

NHTSA Safety Investigations, FORD F-250

FORD F-250 - All Years Overview

FORD F-250 - Year by Year

Other FORD Models