2023 CHEVROLET MALIBU

2 recalls, 84 complaints - 332 TSBs - 5/5 safety rating

BACK OVER PREVENTION: SENSING SYSTEM: CAMERA

Defect Description

General Motors, LLC (GM) is recalling certain 2023-2025 Chevrolet Malibu vehicles. The rearview camera screen may display a distorted or blank image.

Consequence

A rearview image that does not display correctly reduces the driver's view behind the vehicle, increasing the risk of a crash.

Remedy

Dealers will inspect, and if necessary, replace the rearview camera, free of charge. Owner notification letters were mailed May 20, 2026. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N262551720. Vehicle Identification Numbers (VINs) involved in this... Read more

276,879 vehicles affected

Manufacturer: General Motors, LLC

STRUCTURE:FRAME AND MEMBERS

Defect Description

General Motors, LLC (GM) is recalling certain 2022-2023 Chevrolet Malibu vehicles. The front impact bar, a structural portion of the vehicle frame, may not be properly welded to the front frame rail.

Consequence

An improperly welded front impact bar may result in the front crash sensors not performing correctly, increasing the risk of injury in a crash.

Remedy

Dealers will inspect the right-hand and left-hand side of the vehicle's motor rail for an incomplete weld. If the condition is found, the vehicle will be repurchased by GM. Owner notification letters were mailed January 20, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020.

2,108 vehicles affected

Manufacturer: General Motors, LLC

Complaint Statistics

84 total complaints 2 crashes 1 fires 2 injuries

Top Reported Components

Component	Complaints
ENGINE	17
UNKNOWN OR OTHER	11
ELECTRICAL SYSTEM	8
POWER TRAIN	5
FUEL/PROPULSION SYSTEM	3
STEERING	3
BACK OVER PREVENTION	3
VISIBILITY/WIPER	3
SERVICE BRAKES	3
SERVICE BRAKES, HYDRAULIC	2

Incident date: Feb 1, 2026

The contact owns a 2023 Chevrolet Malibu. The contact stated that while reversing, the rearview camera intermittently flickered and later displayed a blank image. The message "Service Vision System" was displayed. The contact later received notification of NHTSA Campaign Number: 26V212000 (Back Over... Read more

Incident date: Jan 1, 2026

Most of the time, the car will not unlock when the unlock button is pressed on the key fobs. Most of the time, when the key fob is on the console and the start button is depressed, the car will not start. It can take multiple minutes and attempts before the car will finally start. Changing the ba... Read more

Incident date: Jun 15, 2026

The contact owns a 2023 Chevrolet Malibu. The contact stated that the vehicle hesitated after starting the vehicle, and while accelerating on several occasions from a stoplight. The failure occasionally occurred while driving on the freeway, causing the vehicle to decelerate unexpectedly. The vehicl... Read more

Incident date: Jun 29, 2026

The contact owns a 2023 Chevrolet Malibu. The contact stated that while reversing, the rear-view camera malfunctioned and displayed a black screen with the message "Backup Camera Unavailable" displayed. The contact stated that the failure created a hazard while reversing. The cause of the failure wa... Read more

Incident date: Mar 18, 2026

The rearview camera started acting funny around March 2026 and completely stopped working in April 2026. When I put the car in reverse it says “service vision system” I have been frequently checking the recall website and it says they are aware of the recall but do not have a fix. I have even ca... Read more

Incident date: Jun 1, 2026

Back up camera is under recall with no fix and not working period. Goes to black screen with a message “ Service Vision System” Dealership - Dan Cummins- refuses to repair due to no fix available.

Incident date: Apr 8, 2026

To Whom It May Concern, I am the owner of a 2023 Chevrolet Malibu that is affected by the ongoing backup camera safety recall. I am submitting this complaint because this defect is not a minor inconvenience—it is a serious safety issue that places me, my family, pedestrians, and other motorists at... Read more

Incident date: Apr 8, 2026

Incident date: Mar 18, 2026

Subject: Safety Complaint and Request for Assistance – 2023 Chevrolet Malibu Backup Camera Recall To Whom It May Concern, I am the owner of a 2023 Chevrolet Malibu that has been affected by the backup camera recall. The malfunctioning backup camera creates a serious safety hazard for me, my pass... Read more

Incident date: Jun 18, 2026

The contact owns a 2023 Chevrolet Malibu. The contact received notification of NHTSA Campaign Number: 26V212000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable ... Read more

Incident date: Mar 18, 2026

Incident date: Jun 10, 2026

Back up camera stopped working, there is a recall that was not completed before buying the car

Incident date: May 12, 2026

The contact owns a 2023 Chevrolet Malibu. The contact stated that while driving at an undisclosed speed, the vehicle intermittently entered LIMP mode. The message "Turn off to Reduce Power Failure" was displayed, and the vehicle failed to exceed 40 MPH. The Check Engine warning light was illuminate... Read more

Incident date: May 25, 2026

Windshield cracks- I got two windshield cracks from a very small rocks, going at very low speeds. The glass does NOT seem thick/resistant enough. the two crack occurred on the SEPARATE occasions. There are multiple complains about his known issue with GV80 and other Genesis vehicles. After getting ... Read more

Incident date: Jan 30, 2026

We were driving on highway, approximately 2 miles from home, when we suddenly lost power to the drive train. Eventually it started moving again but after a short distance we again lost power to the drive train. It appeared that whenever it transferred from gasoline to hybrid or electric, we would ... Read more

Incident date: Jan 30, 2026

My 2020 Kia Soul had its engine replaced under safety recall SC209 (NHTSA Campaign 21V259). At 136,202 miles, this replacement engine suffered a secondary catastrophic failure, dropping heavy metal shavings into the oil lubrication system and causing the engine to stall. Kia of Orange Park (Repair O... Read more

Incident date: Jan 15, 2026

ABS / VSA module failed at 90k miles causing spongy brakes. Acura quoted me $3500 for a new module which is more than the value of the car.

Incident date: Apr 4, 2026

Check engine light came on. Next day had a diagnostic run on it and found the coolant intrusion into cylinder 2. A new TSB 19-2208 was recommended. Talked with dealership and they advised to contact Ford Customer Care, who had Roadside Assistance come and pick up the 2018 Lincoln MKC and take ... Read more

Incident date: May 21, 2026

I am filing a safety complaint regarding my 2023 Nissan Ariya involving an apparent failure of the 12-volt battery and/or electrical system. While parked overnight in my driveway, powered off, and not plugged in nor charging, the front battery/engine compartment began sizzling, overheating, and prod... Read more

Incident date: Apr 2, 2026

The contact owns a 2026 Mazda CX-5. The contact stated while driving at an undisclosed speed, the instrument cluster displayed a black screen. The contact stated that several warning lights were illuminated. The dealer was made aware of the failure. In addition, the contact was informed that the fai... Read more

Incident date: May 13, 2026

On Sunday, April 12, 2026, at approximately 5:00 PM, I experienced a sudden and complete engine failure while driving my 2019 Chevy Silverado equipped with the 6.2L V8 engine. Without warning, the vehicle lost all ability to accelerate, creating an immediate and dangerous situation for myself, my fa... Read more

Incident date: Mar 1, 2026

Seatbelt unlatched. Buckle was broken. I was told it was a “mechanical issue”

Incident date: Mar 1, 2026

I have had an issue with my brakes for a couple years. I have taken my van to a couple of different mechanics to express my concerns and they have changed brakes but the issues continue. The brakes do not always work effectively. They make a hissing sound. When my foot is on the brake, sometimes... Read more

Incident date: Mar 1, 2026

Incident date: Apr 23, 2026

Check engine light illuminated on my 2021 Chevrolet Tahoe. Upon diagnostic scan, the following emissions-related fault codes were present: P11D5 (NOx sensor), P14D9 (NOx sensor), P2383 (EGR pressure sensor), and P2C7A (NOx catalytic converter efficiency). All components are available for inspection ... Read more

Incident date: Apr 23, 2026

Incident date: Apr 29, 2026

Carnival was working fine then, without warning, I was unable to accelerate. Had entered highway and reached a maximum speed around 30 mph in a 55 mph zone. Pedal fully depressed and zero acceleration, dashboard read "check hybrid system, stop safely". Tried changing driving modes to no effect. Lots... Read more

Incident date: Jan 10, 2026

fuel pump cut off intermeeting mager loss off power tech at subaru refuse to repair car has 72000 miles on well manetane

Incident date: Jan 10, 2026

The engine oil system failed due to a persistent oil leak that was present from the time of purchase on December 16th 2024. The vehicle is available for inspection upon request and is currently immobile due to a completely seized engine. My safety was put at serious risk because the vehicle has no f... Read more

Incident date: Jan 7, 2026

ABS- TRACTION CONTROL- BRAKE- POWERSTEERING ALARM APPEARS STATING TO DRIVE WITH CAUTION- HAVE TAKEN THE VECHICLE IN FOR SERVICE AND THEY STATE THEY CAN NOT REPAIR THE ALARM- I ASKED IF THIS WOULD NOT BE CONSIDERED A RECALL ISSUE DUE TO SAFTEY ISSUE. AS THE CAR STATES IT IS NOT SAFE TO BE DRIVEN- A... Read more

Incident date: Mar 22, 2026

Incident Overview: A Continental Control Contact Sport SRS+ tire (DOT 5323) experienced a catastrophic internal structural failure during normal driving on a wet roadway. The tire had approximately 50% tread remaining and was 1–1.5 years old. Failure Description: Inspection indicates internal belt... Read more

Crash 1 injured

Incident date: Mar 27, 2026

The contact owns a 2016 Acura ILX. The contact received notification of NHTSA Campaign Number: 25V859000 (Service Brakes, Hydraulic). The contact stated that the brake pedal was depressed to the floorboard. No warning light was illuminated. The local dealer was contacted and confirmed that parts wer... Read more

Incident date: Mar 27, 2026

On June 17th, 2025 while driving from [XXX] back to my home state of [XXX] , I experienced an engine malfunction in Chester, Va where the 6.2 L87 engine was shaking and had severe hesitation. It was diagnosed by the Chevrolet dealership in Chester, VA as suffering severe failure of ALL 8 fuel injec... Read more

Incident date: Apr 2, 2026

Began with a misfire on cylinder 5 code P0305. Replaced spark plugs, wires, and coil pack. Misfire still existed. Fuel injector on cylinder 5 was stuck open and had to be replaced. Misfire still existed. No spark from new coil pack on cylinder 5, replaced coil pack connector. Misfire still existed, ... Read more

Incident date: Oct 10, 2025

The contact owns a 2022 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V455000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated ... Read more

Incident date: Oct 10, 2025

Incident date: Feb 9, 2026

Constant camera issues. The rear camera only works half the time and when it does go it, it'll just cut off while driving in reverse. It's completely unreliable and dangerous. New update has affected the cars acceleration. Now when its below a certain degrees outside they changed it so the car can ... Read more

Incident date: Feb 9, 2026

The contact owns a 2008 Pontiac G6. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 14V252000 (ELECTRICAL SYSTEM, EXTERIOR LIGHTING, VEHICLE SPEED CONTROL, ELECTRONIC STABILITY CONTROL (ESC); however, the failure recurred after the recall repair. The vehicle ... Read more

Incident date: Dec 13, 2025

My Chevy Silverado was repaired by 3 different certified Chevy dealers about 10 times for a variety of issues. The last time I brought my truck to Bridgewater Chevy I was told I need an engine replacement. The certified dealers failed to identify the root cause to all the issues. All the symptoms po... Read more

Incident date: Dec 24, 2025

With this 2025 Lexus NX350 Premium AWD, the front windshield glass is BADLY distorted. Looking at the road ahead while seated behind the steering wheel, objects aren't clear, they tend to be wobbly as there is a MAJOR safety issue here with the glass itself. My dealer told me that the other 2025 Lex... Read more

Incident date: Dec 24, 2025

We were driving and had the circulation on to make sure that no outside air was being circulated in so that condensation does not build up on the inside of the cabin. The circulation button auto turned off without us knowing. We then had all four windows, and our windshield and back window completel... Read more

Incident date: Dec 24, 2025

At approximately 10:30 a.m. on 12/28/2025, while traveling on the highway, the panoramic sunroof of my 2019 Ford Edge SEL spontaneously exploded without warning. The failure was accompanied by a sound similar to a gunshot. The weather was clear and sunny, with an ambient outdoor temperature of appro... Read more

Incident date: Apr 8, 2023

A recent computer upgrade was requested via the jeep computer system and initiated. The next day, while driving, the jeep kept losing power and the engine shut off multiple times. The check engine light went on after the loss of power but not before. There were no symptoms prior to the malfunctio... Read more

Incident date: Apr 8, 2023

Incident date: Sep 25, 2025

Engine failure in October of 2023. Had vehicle towed to dealership and was told truck was not under warranty because of mileage and was going to be months before they can get to it because of parts on backorder or shortage of parts. Had truck towed to another shop and had the repairs done there, at ... Read more

Showing 50 of 84 complaints.

NHTSA Safety Ratings, 2023 CHEVROLET MALIBU

2023 Chevrolet Malibu 4 DR FWD

Category	Rating
Overall Rating	5 / 5 ★★★★★
Frontal Crash	5 / 5 ★★★★★
Frontal Crash, Driver	5 / 5 ★★★★★
Frontal Crash, Passenger	5 / 5 ★★★★★
Side Crash	5 / 5 ★★★★★
Side Crash, Driver	5 / 5 ★★★★★
Side Crash, Passenger	5 / 5 ★★★★★
Rollover	4 / 5 ★★★★☆
Rollover Risk	10.3%

Safety Technology

Feature	Status
Electronic Stability Control	Standard
Forward Collision Warning	Standard & Optional
Lane Departure Warning	Standard & Optional

Source: NHTSA 5-Star Safety Ratings Program. Ratings are based on crash tests conducted by the National Highway Traffic Safety Administration.

EPA Fuel Economy, 2023 CHEVROLET MALIBU

Trim / Engine	City MPG	Highway MPG	Combined MPG	Fuel Type	Annual Fuel Cost
1.5L 4-cyl, Automatic (variable gear ratios) (Front-Wheel Drive)	27.0	35.0	30.0	Regular	$2,100

CO2 Emissions: 292.0 g/mile (Midsize Cars)

Source: U.S. Environmental Protection Agency (EPA). Actual fuel economy may vary based on driving conditions.

Technical Service Bulletins, 2023 CHEVROLET MALIBU

332 manufacturer communications from 157 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
110000 ELECTRICAL SYSTEM	75
350000 EQUIPMENT	62
060000 ENGINE AND ENGINE COOLING	42
100000 POWER TRAIN	30
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL	27
200000 WHEELS	15
260000 FORWARD COLLISION AVOIDANCE	6
980000 UNKNOWN OR OTHER	6

200000 WHEELS

This service bulletin provides information for dealers/technicians on Tire Radial Force Variation (RFV).

350000 EQUIPMENT

This service bulletin provides information on the Transport Mode Feature, also known as Logistics mode, which is used to increase the 12V Battery stand time of the vehicle during transit and or long period of stand time at the dealerships.

110000 ELECTRICAL SYSTEM

980000 UNKNOWN OR OTHER

This warranty bulletin provides information on Customer Concern Not Duplicated (CCND) Labor Operation Numbers.

350000 EQUIPMENT

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

110000 ELECTRICAL SYSTEM

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

110000 ELECTRICAL SYSTEM

This service bulletin provides service procedure information to correct a customer concern of Shift to Park Displayed on DIC When Vehicle is in- Park, No Start - DTC B000A Set.

100000 POWER TRAIN

This service bulletin provides service procedure information to correct a customer concern of Shift to Park Displayed on DIC When Vehicle is in- Park, No Start - DTC B000A Set.

350000 EQUIPMENT

This bulletin updates the position of General Motors on refinishing aluminum wheels. GM has determined that wheel refinishing under warranty will no longer be performed.

200000 WHEELS

This bulletin updates the position of General Motors on refinishing aluminum wheels. GM has determined that wheel refinishing under warranty will no longer be performed.

110000 ELECTRICAL SYSTEM

This bulletin provides information for electrical ground repairs using new General Motors replacement fasteners with conductive finish.

118000 ELECTRICAL SYSTEM:SOFTWARE

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

350000 EQUIPMENT

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

110000 ELECTRICAL SYSTEM

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

110000 ELECTRICAL SYSTEM

This Preliminary information communicates a vehicle may come to the dealer with a complaint of no start, stalling, rough idle, no acceleration, loss of power, erratic shifting, fuel gauge inoperative, MIL illuminated with various codes stor

110000 ELECTRICAL SYSTEM

This service bulletin advises the technician to replace valve body first to determine if that is the issue for and if not, to inspect internal parts of transmission for any signs of abnormal wear to correct customer concerns of Loss of Forw

100000 POWER TRAIN

117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

This service bulletin provides repair information to correct various functional concerns of the Instrument Cluster and DTC U0155.

350000 EQUIPMENT

This service bulletin provides repair information to correct various functional concerns of the Instrument Cluster and DTC U0155.

110000 ELECTRICAL SYSTEM

This service bulletin provides repair information to correct various functional concerns of the Instrument Cluster and DTC U0155.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Preliminary information communicates to dealer that GM is aware of the issue and is working on a resolution.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information on submitting quality Photos of Various Vehicle Concerns to the GM Technical Assistance Center (TAC).

110000 ELECTRICAL SYSTEM

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

This service bulletin provides repair information to correct a customer concerns of Radio Software issues.

350000 EQUIPMENT

This service bulletin provides repair information to correct a customer concerns of Radio Software issues.

110000 ELECTRICAL SYSTEM

This service bulletin provides repair information to correct a customer concerns of Radio Software issues.

220000 SEATS

This engineering information (EI) closure ends the need for gathering further information from technicians in regard to Melted Burn Marks and/or Smoke Smell Coming from the Height Adjuster Motor Under the Front Row Seat.

110000 ELECTRICAL SYSTEM

060000 ENGINE AND ENGINE COOLING

This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels shou

350000 EQUIPMENT

This warranty administration bulletin provides policy information for GM courtesy transportation and roadside assistance programs.

350000 EQUIPMENT

This Warranty Administration bulletin provides information on Dealer Empowerment for Goodwill, Customer Enthusiasm and Policy (U.S. Only).

110000 ELECTRICAL SYSTEM

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information on All hazmat parts being returned to the Warranty Parts Center (WPC) must be shipped using Central Transport. Hazardous materials should never be sent by air transportation to the WPC.

980000 UNKNOWN OR OTHER

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

110000 ELECTRICAL SYSTEM

This service bulletin provides service procedure information to correct a customer concern of Shift to Park Displayed on DIC When Vehicle is in- Park, No Start - DTC B000A Set.

100000 POWER TRAIN

This service bulletin provides service procedure information to correct a customer concern of Shift to Park Displayed on DIC When Vehicle is in- Park, No Start - DTC B000A Set.

110000 ELECTRICAL SYSTEM

This service bulletin provides repair information to correct a customer concern of Service Engine Soon Illuminated in DIC and/or a Malfunctioning Fuel Gauge with DTC U0076/U18A2/P1001/P1434 or Other Message Counter Incorrect Codes Set.

081100 FUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY

060000 ENGINE AND ENGINE COOLING

350000 EQUIPMENT

This service bulletin provides repair information to correct a customer concern of the rearview driver information camera intermittent in low light conditions - replace camera.

110000 ELECTRICAL SYSTEM

This service bulletin provides repair information to correct a customer concern of the rearview driver information camera intermittent in low light conditions - replace camera.

280000 BACK OVER PREVENTION

This service bulletin provides repair information to correct a customer concern of the rearview driver information camera intermittent in low light conditions - replace camera.

110000 ELECTRICAL SYSTEM

This service bulletin provides a repair procedure to correct a customer concern of Loss of and/or Reduced Propulsion.

100000 POWER TRAIN

This service bulletin provides a repair procedure to correct a customer concern of Loss of and/or Reduced Propulsion.

110000 ELECTRICAL SYSTEM

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.

260000 FORWARD COLLISION AVOIDANCE

This Preliminary information communicates a "Forward Collision System Reduced" message displayed on the DIC when the Forward Automatic Braking has been set to the "Alert" setting. This is normal when the FAB has been set to "Alert".

353610 EQUIPMENT:ELECTRICAL:INFOTAINMENT:SOFTWARE

This Preliminary information communicates to dealer that GM is aware of the issue and is working on a resolution.

353600 EQUIPMENT:ELECTRICAL:INFOTAINMENT

This Preliminary information communicates to dealer that GM is aware of the issue and is working on a resolution.

060000 ENGINE AND ENGINE COOLING

This bulletin provides information on Engine Concerns that could result from lack of scheduled maintenance, improper service or aftermarket calibrations.

070000 FUEL SYSTEM, GASOLINE

This service bulletin provides information on the cold start control system in DI engines to reduce cold start emissions and improve fuel economy.

063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

This service bulletin provides information on the cold start control system in DI engines to reduce cold start emissions and improve fuel economy.

100000 POWER TRAIN

This Warranty Admin service bulletin provides guidelines for Dealers Not Required and for Dealers Required to Contact the PQC for engine or transmission assembly replacement and explains the PQC process, GWM Transaction submission, vehicle

060000 ENGINE AND ENGINE COOLING

353000 EQUIPMENT:ELECTRICAL

This Preliminary information communicates an issue where the vehicles wireless charger no longer works with certain ISO updates on Apple 15 phones and advises customer to update their phone to the lastest ISO update.

350000 EQUIPMENT

This service bulletin provides information on the EL-52800 Diagnostic & Charge Battery Station (DCBS) a?? FAQs.

110000 ELECTRICAL SYSTEM

This service bulletin provides information on the EL-52800 Diagnostic & Charge Battery Station (DCBS) a?? FAQs.

350000 EQUIPMENT

This service bulletin assists technicians in setting up PicoScope hardware/software to monitor CAN bus traffic (voltage patterns) to aid Technical Assistance (TAC) and Field Service Engineers (FSEs) in diagnosing electrical issues present o

110000 ELECTRICAL SYSTEM

160000 STRUCTURE

This preliminary informational (PI) bulletin provides information to dealership personnel which may be helpful when addressing underbody component corrosion with customers.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.

350000 EQUIPMENT

This engineering information (EI) s requesting information from technicians to perform the check list provided and contact the engineer listed in regard to Melted Burn Marks and/or Smoke Smell Coming from the Height Adjuster Motor Under the

220000 SEATS

110000 ELECTRICAL SYSTEM

100000 POWER TRAIN

This Preliminary information communicates the process for recording transmission noises using the PicoScope For review

100000 POWER TRAIN

This PI bulletin advises the technician on the proper way to install the pistons in an engine.

060000 ENGINE AND ENGINE COOLING

This PI bulletin advises the technician on the proper way to install the pistons in an engine.

353600 EQUIPMENT:ELECTRICAL:INFOTAINMENT

This PI states that a vehicle may exhibit a concern of the cross traffic alert indicators not displaying on the radio screen. While this is a customer dissatisfier, it does not pose a safety concern due to the fact that the customer will st

120000 EXTERIOR LIGHTING

This informational bulletin provides information for dealers/technicians on Headlamp, Tail Lamp, License Lamp or Fog/Driving Lamp Damage.

100000 POWER TRAIN

This Preliminary information communicates inspection and/or needed repairs for DTC P2714 on a VT40 CVT transmission

110000 ELECTRICAL SYSTEM

This preliminary information (PI) provides information om Service Programming System (SPS) Error Codes (E4398, E4399, E4403, M4404, M4413, M6954, M6955, E4414, E4423, E4491 or E6961).

110000 ELECTRICAL SYSTEM

This engineering information (EI) is requesting information from technicians to perform the check list provided and contact the engineer listed in regard to Melted Burn Marks and/or Smoke Smell Coming from the Height Adjuster Motor Under th

220000 SEATS

350000 EQUIPMENT

This service bulletin provides service procedure information to correct a customer concern of Shift to Park Displayed on DIC When Vehicle is in- Park, No Start - DTC B000A Set.

110000 ELECTRICAL SYSTEM

This service bulletin provides service procedure information to correct a customer concern of Shift to Park Displayed on DIC When Vehicle is in- Park, No Start - DTC B000A Set.

100000 POWER TRAIN

This service bulletin provides service procedure information to correct a customer concern of Shift to Park Displayed on DIC When Vehicle is in- Park, No Start - DTC B000A Set.

110220 ELECTRICAL SYSTEM:HAND HEATER:WIRING HARNESS

This Preliminary information communicates a GM part number for reflective high temperature heat or insulating tape when repairing wiring harnesses.

980000 UNKNOWN OR OTHER

This Preliminary information communicates a GM part number for reflective high temperature heat or insulating tape when repairing wiring harnesses.

353650 EQUIPMENT:ELECTRICAL:WIRELESS CHARGER/CRADLE

This Preliminary information communicates an issue where the vehicles wireless charger no longer works with the latest ISO update on Apple 15 phones.

353000 EQUIPMENT:ELECTRICAL

This Preliminary information communicates an issue where the vehicles wireless charger no longer works with the latest ISO update on Apple 15 phones.

350000 EQUIPMENT

This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.

353650 EQUIPMENT:ELECTRICAL:WIRELESS CHARGER/CRADLE

This Preliminary information communicates an issue where the vehicles wireless charger no longer works with the lastest ISO update on Apple 15 phones.

060000 ENGINE AND ENGINE COOLING

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

110000 ELECTRICAL SYSTEM

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

350000 EQUIPMENT

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

353610 EQUIPMENT:ELECTRICAL:INFOTAINMENT:SOFTWARE

This Preliminary information communicates an issue where the vehicles wireless charger no longer works with the lastest ISO update on Apple 15 phones.

353600 EQUIPMENT:ELECTRICAL:INFOTAINMENT

This Preliminary information communicates an issue where the vehicles wireless charger no longer works with the lastest ISO update on Apple 15 phones.

100000 POWER TRAIN

This technical bulletin provides a procedure to replace the shifter if the park switch has been found with bad pins, causing the customers concern.

110000 ELECTRICAL SYSTEM

This technical bulletin provides a procedure to replace the shifter if the park switch has been found with bad pins, causing the customers concern.

160000 STRUCTURE

Service Update. On certain vehicles, a structure plug may be missing on the passengera??s side of the dash panel. Dealers are to inspect, and if necessary, install the structure plug.

350000 EQUIPMENT

This service bulletin provides repair information to correct a customer concern of the rearview driver information camera intermittent in low light conditions - replace camera.

110000 ELECTRICAL SYSTEM

This service bulletin provides repair information to correct a customer concern of the rearview driver information camera intermittent in low light conditions - replace camera.

110000 ELECTRICAL SYSTEM

This service bulletin provides information to inform dealership personnel about Law Enforcement and Government vehicles that request to disable or enable content.

120000 EXTERIOR LIGHTING

This service bulletin provides information to inform dealership personnel about Law Enforcement and Government vehicles that request to disable or enable content.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides information to inform dealership personnel about Law Enforcement and Government vehicles that request to disable or enable content.

Showing 100 of 332 bulletins.

NHTSA Safety Investigations, CHEVROLET MALIBU

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

EA, Open , Model Year: 2020

DTN Air Bag Inflator Rupture

The Office of Defects Investigation (ODI) has become aware of eight vehicle crashes in which a rupture of a Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN) air bag inflator occurred during the deployment of the driver side air bag. All eight drivers in these crashes sustained serio... us or fatal injuries that appear linked to the ruptures. Six of those drivers sustained fatal injuries and two sustained severe injuries. In all eight incidents, the subject inflators had been installed as replacement equipment after the vehicle was involved in a previous crash. Information gathered during NHTSA’s initial analysis of these incidents indicates that the inflators were potentially imported illegally into the United States. In conjunction with this safety investigation, NHTSA is also working with appropriate authorities to address any illegal activities associated with the importation of these inflators. As a result of the significant safety concerns relating to these inflators, as well as extensive information already obtained by ODI relating to their field ruptures, ODI is moving directly to the Engineering Analysis (EA) stage of its investigative process rather than first opening a Preliminary Evaluation. NHTSA has taken a variety of actions to address the risks posed by the importation of substandard or counterfeit air bag components. However, until recently, these risks appeared spread across a variety of components and manufacturers. As part of ODI’s continuous monitoring of this issue, the agency has obtained information to suggest that at least eight incidents involve ruptures of inflators manufactured by DTN. In parallel with this dedicated investigation into DTN inflators, ODI will continue to monitor reports of field incidents to evaluate risks from other substandard imported air bag components. In 2012, ODI first became aware of substandard or counterfeit air bag modules sold through online marketplaces, such as auction sites. NHTSA obtained examples of these air bag modules and conducted testing. None of the inflators equipped in these modules were manufactured by DTN. This testing revealed that the inflators consistently malfunctioned during deployments, such as by failing to deploy the air bag or expelling metal shrapnel due to a rupture. This led NHTSA to release a consumer advisory in October 2012 to alert the public and repair professionals to the potential dangers of substandard or counterfeit air bag modules. ODI also worked with major vehicle manufacturers, who released advisories and notifications concerning the use of such air bag modules. Since then, NHTSA has continuously monitored for reports of malfunctioning air bags that may be associated with substandard or counterfeit components. These monitoring efforts have been supported by the increased visibility the advisories have brought to the issue, and by several standing general orders in place as part of separate investigations into Takata and ARC inflators, which require certain manufacturers to report any alleged or suspected inflator field ruptures to NHTSA. Until 2017, ODI was not aware of any field incidents involving an abnormal deployment of an imported substandard or counterfeit air bag module. In September 2017, ODI became aware of a crash involving a model year (MY) 2009 Honda Civic where the air bag ruptured during deployment, killing the driver. After inspecting the vehicle and air bag parts, ODI determined that the air bag inflator was not original equipment and that the air bag module was likely a substandard import. Insufficient information existed to determine the manufacturer of the inflator in this incident, however, it does not appear to resemble those manufactured by DTN. On June 16, 2023, ODI received a Vehicle Owner Questionnaire (VOQ #11527380) alleging that the rupture of a driver side air bag caused fatal injuries to the driver of a MY 2020 Chevrolet Malibu. ODI’s assessment of the rupture indicated that the air bag inflator was not original equipment but was instead manufactured by DTN, a Chinese company (also known as Yoshibayashi Toku theanol Automotive Safety Systems Co. Ltd.). From June 2023 to July 2024, ODI became aware of four additional ruptures involving substandard air bag modules equipped on Chevrolet Malibu vehicles. At the time, insufficient information existed for these crashes to determine who manufactured the ruptured inflators. As a result, NHTSA released a consumer advisory on July 10, 2024, alerting car buyers and owners to be aware of cheap, substandard replacement air bag inflators that can cause death or serious injury in a crash. The advisory urged consumers who own or are considering the purchase of a used vehicle to learn the vehicle’s history and ensure the vehicle has genuine air bag inflators. In March 2025, NHTSA learned about another rupture involving a suspected substandard, aftermarket inflator that was equipped in a MY 2017 Hyundai Sonata. The driver of this vehicle sustained fatal injuries that appeared related to the rupture. In August 2025, NHTSA received a similar report of a fatal air bag rupture in a MY 2019 Hyundai Sonata. Most recently, in October 2025, ODI received a report of a fatal air bag rupture in a MY 2020 Chevrolet Malibu. Photographs of the air bag components in these three crashes indicated that the ruptures all involved inflators manufactured by DTN. Further investigation of the inflator fragments in three of the prior incidents confirmed that they also involved DTN inflators. Photographs of the components involved in one of the other incidents also strongly suggest that the ruptured inflator was manufactured by DTN. This opening resume exceeded space limitations and is continued in an attachment uploaded to the investigation.Read more

EA, Closed , Model Year: 2004

Turn Signal Lamps

GM designed the MY 2004 and 2005 Chevrolet Malibu and Malibu Maxx vehicles with a daytime running lamp (DRL) system that uses the same filament (the high power filament of a dual filament bulb) as the front turn signals.The high power filament operates at full battery voltage when functioning as a D... RL.The DRL is illuminated whenever the headlamps are off, increasing the duty cycle of the front turn signal bulb.The MY 2003 and earlier Malibu vehicles (Malibu Maxx was not manufactured for sale in the U.S. prior to MY 2004) used a headlamp based design, operated at a reduced voltage, for the DRL function; GM reverted back to this design on the MY 2006 and later Malibu and Malibu Maxx vehicles. Filament based bulbs have a finite life (hours of illumination) for any given operating voltage.As a result, increasing the duty cycle of a bulb typically decreases the life span of the bulb.GM identified and addressed two front turn signal/DRL and rear turn signal bulb quality issues early in MY 2004 production, however vehicle warranty claims for failed bulbs continued to occur.To address the high warranty levels of bulb failures (90% of the warranty claims submitted to ODI by GM were bulb failures and 10% were socket failures), GM issued a technical service bulletin in March 2006 advising dealers to use a new specification of bulb when addressing service failures, and to also inspect the electrical sockets for thermal damage and replace if necessary.In June 2006 (after subject vehicle production ended) GM changed the turn signal bulb specification to that of the TSB bulb in vehicle production also.To date, ODI has not identified any allegations of crash, injury, or fire related to the alleged defect even though the subject vehicles have experienced 5 - 6 years of field exposure.ODI's analysis of consumer complaints, both VOQ and manufacturer, shows a declining trend.The warranty rate for turn signal bulb replacement is high however statistical analysis of the warranty data suggests that the majority of the original equipment bulbs have already been replaced.GM conducted a safety recall (06V-263) for MY 2004-2005 Cadillac XLR to replace the front turn signal/DRL bulbs and the electrical sockets.However GM advised that the turn signal/DRL bulbs/sockets on the subject vehicles differ from those on the recalled XLRs in several respects, including using bulb sockets with four electrical terminals as opposed to three, which improves the electrical connection, allows the bulb to operate at a lower temperature, and adds stability to the bulb in the socket; operating at a lower voltage, which increases vehicle bulb life; using vented headlamps, which allows bulbs to run cooler than those installed in a non-vented XLR headlamp; and using a clear bulb, which runs cooler than the amber bulbs installed on the XLR.Additionally, the warranty claim level related to subject vehicle sockets is unremarkable compared to other defect investigations into defective socket assemblies.A safety-related defect trend has not been identified at this time.Further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will take further action if warranted by the circumstances.See attached report for further information.Read more

PE, Closed , Model Year: 2004

TURN SIGNAL LAMPS

THE SUBJECT VEHICLES MAY EXPERIENCE LOSS OF FUNCTION OF ONE OR MORE OF THE PARK, TURN, STOP OR DAYTIME RUNNING LAMPS (DRL).FAILURE OF THE BULB MAY ALSO INCLUDE DISCOLORATION (HEAT DAMAGE) TO THE BULB SOCKET.GENERAL MOTORS (GM) TECHNICAL SERVICE BULLETIN (TSB) NUMBER 06-08-42-004C INSTRUCTS TECHNICIA... Read more

PE, Closed , Model Year: 2002

TURN SIGNAL FAILURES

IN DECEMBER 2004, GM ISSUED A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327. THE POLICY COVERED TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURRED FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD... Read more

RQ, Closed , Model Year: 1997

WINDSHIELD WIPER FAILURE

IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE W... Read more

EA, Closed , Model Year: 2004

LOSS OF ELECTRIC POWER STEERING

IN PERFORMING THIS ENGINEERING ANALYSIS, ODI DETERMINED THAT THE ELECTRIC POWER STEERING SYSTEM IN THE SUBJECT VEHICLES CAN MALFUNCTION OR FAIL, CAUSING THE DRIVER TO LOSE POWER STEERING ASSISTANCE; HOWEVER, DUE TO THE FOLLOWING REASONS, ODI HAS DECIDED THAT FURTHER EXPENDITURE OF AGENCY RESOURCES O... Read more

RQ, Closed , Model Year: 1999

TURN SIGNAL FAILURES

GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).OD... Read more

PE, Closed , Model Year: 2004

LOSS OF ELECTRIC POWER STEERING

ODI OPENED PE04-031 BASED ON EIGHT REPORTS OF ALLEGED POWER STEERING FAILURE IN THE SUBJECT VEHICLES.THE COMPLAINTS ALLEGE THAT THE DRIVER SUDDENLY LOST ALL ELECTRIC POWER STEERING ASSISTANCE WITHOUT WARNING MAKING THE VEHICLE DIFFICULT TO STEER. THE SUBJECT VEHICLE UTILIZES AN ELECTRIC POWER STEERI... Read more

EA, Closed , Model Year: 1999

FRONT SUSPENSION COIL SPRING FRACTURE

THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFO... Read more

PE, Closed , Model Year: 1999

FRONT SUSPENSION COIL SPRING FRACTURE

THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND... Read more

EA, Closed , Model Year: 2000

TURN SIGNAL FAILURES

BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1... Read more

DP, Closed , Model Year: 1999

ENGINE COOLANT BOILS OVER

There is no summary currently available

PE, Closed , Model Year: 2000

TURN SIGNAL FAILURE

ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.E... Read more

EA, Closed , Model Year: 1997

POWER RACK AND PINION STEERING FAILURE

THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.

PE, Closed , Model Year: 1997

STEERING RACK AND PINION

ODI HAS RECEIVED 200 COMPLAINTS FROMT CONSUMERS AND 1,238 FROM GM ALLEGING FAILURE OR LOCKUP OF THE STEERING RACK AND PINION UNIT (R&P).THIS ALLEGED CONDITION CAN RESULT IN THE LOSS OF STEERING CONTROL OF THE VEHICLE AND A CRASH CAN RESULT.GM HAS REPORTED SIX CRASHES IN WHICH EIGHT PEOPLE HAVE SUSTA... Read more

EA, Closed , Model Year: 1997

WINDSHIELD WIPER

ON FEBRUARY 22, 2000, THE OFFICE OF DEFECTS INVESTIGATION (ODI) INITIATED PE00-009 BASED ON SEVEN REPORTS OF WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 1997 & 1998 CHEVROLET MALIBU & OLDSMOBILE CUTLASS VEHICLES.THE INVESTIGATION WAS UPGRADED TO EA00-019 ON JULY 12, 2000.DURING THE COURSE OF... Read more

EA, Closed , Model Year: 1997

STOP LAMP ASSEMBLY OVERHEAT

There is no summary currently available

PE, Closed , Model Year: 1997

WINDSHIELD WIPER

There is no summary currently available

PE, Closed , Model Year: 1998

STOP LAMP

There is no summary currently available

CHEVROLET MALIBU - All Years Overview

Complete safety history for the CHEVROLET MALIBU across all model years (1973, 2025).

164 Total Recalls

29,324 Total Complaints

19 Investigations

1,247 Reported Crashes

277 Reported Fires

42 Reported Deaths

CHEVROLET MALIBU - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2025	1	9	View
2024	2	42	View
2023 (current)	2	84
2022	1	140	View
2021	2	118	View
2020	1	324	View
2019	1	307	View
2018	6	1,197	View
2017	4	1,173	View
2016	9	1,443	View
2015	3	395	View
2014	6	561	View
2013	10	1,382	View
2012	3	1,471	View
2011	4	1,526	View
2010	4	2,200	View
2009	6	2,356	View
2008	5	1,489	View
2007	6	1,253	View
2006	9	1,475	View
2005	6	1,386	View
2004	9	1,639	View
2003	3	773	View
2002	4	754	View
2001	4	1,005	View
2000	5	1,379	View
1999	3	1,227	View
1998	5	1,480	View
1997	6	693	View
1989	0	3	View
1986	0	1	View
1983	3	1	View
1982	3	3	View
1981	3	3	View
1980	6	6	View
1979	6	4	View
1978	8	2	View
1977	2	0	View
1975	1	2	View
1974	1	1	View
1973	1	0	View
1964	0	1	View

Other CHEVROLET Models

Model	Recalls	Complaints
SUBURBAN	246	10,458	View
TAHOE	240	12,622	View
SILVERADO 1500	200	22,534	View
CORVETTE	187	6,308	View
CAMARO	179	4,298	View
SILVERADO	159	10,964	View
SILVERADO 3500	152	1,409	View
EXPRESS	151	838	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2023 CHEVROLET MALIBU

Complaint Statistics

Top Reported Components

NHTSA Safety Ratings, 2023 CHEVROLET MALIBU

Safety Technology

EPA Fuel Economy, 2023 CHEVROLET MALIBU

Technical Service Bulletins, 2023 CHEVROLET MALIBU

Most Affected Components

NHTSA Safety Investigations, CHEVROLET MALIBU

CHEVROLET MALIBU - All Years Overview

CHEVROLET MALIBU - Year by Year

Other CHEVROLET Models