2007 CHEVROLET MALIBU

6 recalls, 1,253 complaints - 1,169 TSBs

STEERING:ELECTRIC POWER ASSIST SYSTEM

Defect Description

General Motors LLC (GM) is recalling certain model year 2006-2007 Chevrolet Malibu and Malibu Maxx vehicles manufactured April 1, 2006, to June 30, 2006, and 2006-2007 Pontiac G6 vehicles manufactured April 18, 2006, to June 30, 2006. In the affected vehicles, there may be a sudden loss of electric... Read more

Consequence

If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.

Remedy

GM will notify owners, and dealers will replace the torque sensor assembly, free of charge. The recall began February 24, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14772. Note: This is an expa... Read more

69,633 vehicles affected

Manufacturer: General Motors LLC

STEERING

Defect Description

Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehi... Read more

Consequence

A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.

Remedy

Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.

7,304 vehicles affected

Manufacturer: Dorman Products, Inc.

ELECTRICAL SYSTEM:WIRING

Defect Description

General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January ... Read more

Consequence

Any of the above failure conditions increases the risk of a crash.

Remedy

GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim let... Read more

2,440,524 vehicles affected

Manufacturer: General Motors LLC

POWER TRAIN:AUTOMATIC TRANSMISSION

Defect Description

General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, thr... Read more

Consequence

If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the veh... Read more

Remedy

GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.

1,131,113 vehicles affected

Manufacturer: General Motors LLC

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Defect Description

TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.

Consequence

A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.

Remedy

TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.

4,887 vehicles affected

Manufacturer: TI GROUP AUTOMOTIVE SYSTEMS, LLC

EXTERIOR LIGHTING

Defect Description

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES... Read more

Consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

16,270 vehicles affected

Manufacturer: SABERSPORT

Complaint Statistics

1,253 total complaints 58 crashes 3 fires 57 injuries

Top Reported Components

Component	Complaints
STEERING	635
ELECTRICAL SYSTEM	108
AIR BAGS	77
FUEL SYSTEM, GASOLINE	48
POWER TRAIN	47
SERVICE BRAKES	35
FUEL/PROPULSION SYSTEM	34
ENGINE	34
VEHICLE SPEED CONTROL	31
ELECTRONIC STABILITY CONTROL (ESC)	22

Incident date: Jun 12, 2026

No power steering for 25min drive home. Next day it worked. Dealership said it had an expired recall for power steering fix. No work was done by dealership.

Incident date: Feb 4, 2026

The failed components are called "cam phasers." It is a known problem with the Ford 3.5 Ecoboost Engine (that even Ford is aware of). The cam phasers can fail, causing the timing chain to fail at any moment. They rattle upon startup of a cold engine. The failure of the original engineering is c... Read more

Incident date: Jan 21, 2026

I have a 2018 Ford escape and I have a coolant intrusion leaking into the cylinders.i can smell coolant inside the vehicle.i did some researched the problem.i noticed other people having the same problem.some of the while driving the motor stopped running.ford does have the knowledge of this and hav... Read more

Incident date: Apr 18, 2025

On [XXX] my family and I were on our way to Oklahoma. Luckily we were on a highway instead of interstate when our Kia motor blew. There were no oil warning lights illuminated, nothing. My husband luckily was able to steer the van to the side of the road safely. My vehicle had to be towed and when co... Read more

Incident date: Feb 1, 2025

I have had 2 rebuilt transmission and a manifold replacement and my vehicle still does not run at 100%

Incident date: Nov 11, 2022

While driving at 45mph, a bump in the road caused the steering shaft to uncouple from the spline shaft on the steering gearbox. Control of the vehicle was lost but an accident was avoided. This problem has been reported in a few forums by other people who also installed the same part on their vehicl... Read more

Incident date: Feb 4, 2025

I have contacted a local Honda dealer every few months since 03/30/2024 and have been told they still don't have the parts for the recall.

Incident date: Jan 27, 2025

I purchased the vehicle on January 27, 2025. The morning of Jan 29th, I had three error messages pop up. 1- Service High Voltage System 2- Service Vehicle Soon 3- Reduced Acceleration Drive With Cate The vehicle would not allow me to connect via Bluetooth. My phone was no longer paired. I took... Read more

Incident date: Jan 24, 2025

Clicking noise when turning

Incident date: Jul 9, 2024

Multiple systems failure simultaneously. Lane Keep assist system, adaptive cruise control, braking system failure and automatic emergency braking as well as forward collision warning. This appears to be due to some fault within the system that multiple owners experience — many mentions of this iss... Read more

Incident date: Aug 2, 2024

The negligent driver yielded to the flow of traffic without stopping. When he collided with us, the airbags (exploded) deployed so strongly that they damaged the windshield and our bodies: face, neck, etc. Our beloved Audi A4 2009 was totaled and after that we had several operations: 2 eye operation... Read more

Crash 2 injured

Incident date: Aug 2, 2024

See attached document for complaint

Incident date: Nov 15, 2023

WHAT HAPPENS IS MY CAR SHUT DOWN IN THE MIDDLE OF TRAFFIC AFTER ME GETTING GAS SOMETIMES AND ENGINE LIGHT APPEAR. WHEN SHUTTING DOWN A QUICK FLASH OF BATTERY LIGHT SHOWS UP, NOW ENGINE LIGHT IS ON LONGER AND THE CAR POWER JUST SHUT EVERYTHING DOWN AS IF THE BATTERY IS DEAD NOTHING WORK BUT WITH A JU... Read more

Incident date: Apr 10, 2019

The contact owns a 2014 Buick Enclave. The contact received notification of NHTSA Campaign Number: 23V334000 (Air Bags); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The deale... Read more

Incident date: Feb 22, 2024

The car looses power turbo has never worked it has a growing noise under the bonnet it has a loud noise when shifting

Incident date: Feb 13, 2024

The contact owns a 2018 Ford Focus. The contact stated while driving 55 MPH, the vehicle stalled and failed to accelerate while depressing the accelerator pedal. The check engine warning light was illuminated. The vehicle was taken to the dealer and the fuel injectors were replaced. The failure rec... Read more

Incident date: Feb 17, 2024

After just 2 months of use, the harness no longer stays tight. The straps can be easily loosened without pressing the Harness Release Button. It is impossible to secure my 13 month old in the seat. After tightening the harness on my daughter, I always pull on it to ensure a snug fit. Today when I p... Read more

Incident date: Feb 17, 2024

This was unintentional acceleration case: When I got into the parking space, the car was almost stopped and I was about to press the park button (gear) and the car suddenly accelerated and in a fraction of a second, climbed the curb, crashed into the fence, broke the fence and crushed on a tree. I... Read more

Crash 1 injured

Incident date: Mar 20, 2023

I take my car to kia dealership for my oil changes.they put the $45.00 oil,not sure if conventional or semi.apprx.4mos ago they told me kia no longer use the $45.00 oil so needed to upgrade to full synthetic oil.so i did,approx 2mos after,engine light came on flasing.with the oil light flashing asw... Read more

Incident date: Mar 20, 2023

Good evening, My name is [XXX] , I live in Boca Raton, FL, USA, and own a new car: Jeep 2022 Compass Lattitude VIN [XXX] . I report a serious safety hazard that can cause a crash injury or death that needs to be investigated and corrected. On Thursday, November 9 2023 I picked up my car from Arri... Read more

Incident date: Nov 6, 2023

The contact owns a 2023 Jeep Gladiator. The contact received notification of NHTSA Campaign Number: 23V116000 (Power Train) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The de... Read more

Incident date: Nov 2, 2023

Approximately mid May 2023, 5:15 PM +/_, while stopped at a red light while leaving the work parking structure, the engine revved up and wanted to move forward. Forcing the driver to apply heavy pressure on the brakes to avoid being forced into the intersection. An opening presented itself, the brak... Read more

Incident date: Jul 13, 2023

The contact owns a 2019 Chevrolet Silverado 2500. The contact stated while driving at various speeds, the vehicle lost motive power. The accelerator and brake pedals became inoperable. The check engine warning light was illuminated. Additionally, the engine power reduced message was displayed. The v... Read more

Incident date: Apr 12, 2023

July.2023: Check Engine Light On ; It came as we were driving on the highway. Acceleration was sluggish due to this issue. Error code indicated that 1 of the 4 engine had issues. Escalated the issue to Hyundai Customer Service. Issue was resolved during first week of Aug.2023. Sept.2023 We were dri... Read more

Incident date: Apr 12, 2023

Incident date: Mar 8, 2023

Leather dashboard is warping due to the water ingress issue which was addressed from previous recall.

Incident date: Mar 8, 2023

The contact owns a 2019 GMC Yukon. The contact stated that the third-row seats electrically controlled failed to function as needed. The contact stated that that the seats failed to move forward or backwards. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined ... Read more

Incident date: Mar 8, 2023

The contact owns a 2021 Mercedes-Benz S580. The contact received notification of NHTSA Campaign Number: 23V445000 (Fuel System, Gasoline) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair... Read more

Incident date: May 10, 2023

The vehicle throws a forward collision warning and then suddenly brakes to slow down while driving with no road hazard in front. This occurs about once every 10 days. This is a safety hazard because the forward collision warning has to be turned off every time the car is turned on. It will not stay... Read more

Incident date: May 10, 2023

Incident date: Apr 12, 2023

The contact owns a 2012 Volkswagen Tiguan. The contact stated that while driving at an undisclosed speed, the instrument panel display turned on and turned off intermittently. The contact continued driving at an unknown speed. The contact had since experienced failures related to the electrical syst... Read more

Incident date: Apr 12, 2023

My car, a 2020 Honda CR-V EX 1.5T AWD, was totaled in a fatal accident on a rainy night on an interstate highway. It spun on the highway a couple of turns, hit the highway barrier at all of its corners and sides, caused the airbags to all came out, and eventually deadly stopped in the middle of the ... Read more

Crash 1 injured

Incident date: Apr 12, 2023

Crash 1 injured

Incident date: Jul 7, 2023

3 Teenagers were able to break a window, enter the car, Start the car without use of a key, and drive the vehicle. Rear Windows breaking do not trigger anti-theft alarm. Car is able to be started with out use of the key. Car is able to be driven with out use of a key. Was able to catch the incident ... Read more

Incident date: Jul 7, 2023

At traffic light in drive position, shifting drags when accelerated and hard shift jerk , slipping gears or driving and not shifting at all

Incident date: Mar 1, 2023

I have problems with my Knox sensor on the dashboard of my car. It refuses to accept my Cataylic converter as part of my car and I have taken it to many repair shops to get fixed and it just keep messing up.

Incident date: Feb 5, 2016

WE PURCHASED THIS RV 0N 1-25-2022 FROM DAY BROS RV SALES 3054 SOUTH LAUREL RD LONDON KY 40744 WE TOOK THE RV ON OUR FIRST VACATION TO FL IN FEB 2023 ON OUR WAY HOME FROM VACATION IN NORTH CAROLINA BOTH WHEELS CAME OFF THE RV WE ALMOST JACK KNIFED, THE WHEEL STUDS ON BOTH WHEELS BROKE OFF WE WER... Read more

Incident date: Jan 1, 2023

In the past 6 months, the electrical system of my 2018 Outback has completely shut down on at least 4 occasions. I required several jump starts with the car parked in the garage, no doors left open, and no lights left on. I took it to the dealership where I was basically accused of lying because I ... Read more

Incident date: Feb 25, 2023

Today I started my RAV4 in my driveway to warm it up and went back in the house. Approximatly 5-10 minutes later someone knocked on the door to let me know the car was on fire. The fire department said it was likley that the fire started in the engine and spread to the rest of the vehicle.

Fire

Incident date: Sep 30, 2021

My vehicles computer systems have been hacked and who ever is doing it there destroying my vehicles brakes shocks transmission engines this needs to be looked into the police don’t believe me these people know where I’m going where I am I know who they are but I don’t want to get in trouble it... Read more

Crash 1 injured

Incident date: Sep 30, 2021

my car has stalled multiple times while in use, on the highway. VERY SCARRY!

Incident date: Sep 30, 2021

Air bags have stop working

Incident date: Jan 13, 2023

I purchase the car at the end of November of 2022 from drive time. I was driving on January 8th 2023 and the car speed reduced and the check engine light started flashing

Incident date: Mar 4, 2022

My vehicle is experiencing an issue with its power steering system that causes the wheel to shake uncontrollably and lock up sometimes when I am driving it. When I first got it inspected at a mechanic, they said that there was a recall for this exact issue for cars with my same make and model, so I ... Read more

Incident date: Oct 12, 2022

I can hear the U joint clicking like it wants to fail and suddenly randomly there is a loss of powersteering. This issue caused my father who is on oxygen to go to the hospital.

1 injured

Incident date: Oct 12, 2022

I can hear the U joint clicking like it wants to fail and suddenly randomly there is a loss of powersteering. This issue caused my father who is on oxygen to go to the hospital.

1 injured

Incident date: Oct 12, 2022

I can hear the U joint clicking like it wants to fail and suddenly randomly there is a loss of powersteering. This issue caused my father who is on oxygen to go to the hospital.

1 injured

Incident date: Jul 1, 2019

The contact owns a 2007 Chevrolet Malibu. The contact stated that once the temperature fell below 50 degrees Fahrenheit, the power steering assist would fail to operate as needed with the power steering warning light illuminated. The contact had taken the vehicle to the dealer and was informed that ... Read more

Incident date: Mar 29, 2022

Power steering failed. Available for inspection. Safety of myself and others were put at risk because my steering wheel became stiff and was extremely difficult to move while driving. Car is at an independent service center and the problem can be confirmed. The vehicle/component has not been inspect... Read more

Incident date: Mar 1, 2022

Intermittent power steering failure. For the second time in 3 years now the power steering is gone. I paid once, but I understand that there is a recall on certain models. It’s a documented issue , but they won’t help.

Showing 50 of 1,253 complaints.

EPA Fuel Economy, 2007 CHEVROLET MALIBU

Trim / Engine	City MPG	Highway MPG	Combined MPG	Fuel Type	Annual Fuel Cost
2.2L 4-cyl, Automatic 4-spd (Front-Wheel Drive)	21.0	31.0	25.0	Regular	$2,500
3.5L 6-cyl, Automatic 4-spd (Front-Wheel Drive)	19.0	30.0	23.0	Regular	$2,700
3.9L 6-cyl, Automatic (S4) (Front-Wheel Drive)	16.0	23.0	19.0	Regular	$3,300

CO2 Emissions: -1.0 g/mile (Midsize Cars)

Source: U.S. Environmental Protection Agency (EPA). Actual fuel economy may vary based on driving conditions.

Technical Service Bulletins, 2007 CHEVROLET MALIBU

1,169 manufacturer communications from 746 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
350000 EQUIPMENT	181
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL	137
110000 ELECTRICAL SYSTEM	99
060000 ENGINE AND ENGINE COOLING	78
356000 EQUIPMENT ADAPTIVE/MOBILITY	61
060000 ENGINE (PWS)	50
353000 EQUIPMENT:ELECTRICAL	44
100000 POWER TRAIN	40

200000 WHEELS

This service bulletin provides information for dealers/technicians on Tire Radial Force Variation (RFV).

110000 ELECTRICAL SYSTEM

This bulletin provides information for electrical ground repairs using new General Motors replacement fasteners with conductive finish.

060000 ENGINE AND ENGINE COOLING

This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels shou

350000 EQUIPMENT

This warranty administration bulletin provides policy information for GM courtesy transportation and roadside assistance programs.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.

100000 POWER TRAIN

This Warranty Admin service bulletin provides guidelines for Dealers Not Required and for Dealers Required to Contact the PQC for engine or transmission assembly replacement and explains the PQC process, GWM Transaction submission, vehicle

060000 ENGINE AND ENGINE COOLING

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.

100000 POWER TRAIN

This PI bulletin advises the technician on the proper way to install the pistons in an engine.

060000 ENGINE AND ENGINE COOLING

This PI bulletin advises the technician on the proper way to install the pistons in an engine.

120000 EXTERIOR LIGHTING

This informational bulletin provides information for dealers/technicians on Headlamp, Tail Lamp, License Lamp or Fog/Driving Lamp Damage.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Preliminary Information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. Technician will need to use Pico Oscilloscope Di

110000 ELECTRICAL SYSTEM

This preliminary information (PI) provides information om Service Programming System (SPS) Error Codes (E4398, E4399, E4403, M4404, M4413, M6954, M6955, E4414, E4423, E4491 or E6961).

350000 EQUIPMENT

This Preliminary Information communication provides information to the technician about the use of J-35616-64B terminal test probe, replacement terminals, and terminated leads. The J-35616-64B is the latest test probe released for checking

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.

350000 EQUIPMENT

This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.

200000 WHEELS

This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.

100000 POWER TRAIN

This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.

020000 SUSPENSION

This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.

010000 STEERING

This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides guidelines and diagnostic/repair information to technicians regarding vehicle engine oil consumption.

200000 WHEELS

This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have hi

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information for dealers/technicians on When and How to Submit a Field Product Report (FPR) (U.S. and Canada Dealers Only).

117100 ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER

This informational bulletin provides information for the IPC odometer programming method quick reference guide.

350000 EQUIPMENT

This informational bulletin provides information for the IPC odometer programming method quick reference guide.

110000 ELECTRICAL SYSTEM

This informational bulletin provides information for the IPC odometer programming method quick reference guide.

100000 POWER TRAIN

The service bulletin advises the tech of a normal transmission shift condition and the delay in throttle response when the throttle plate is opened rapidly and advises the customer that it is normal for the delay.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides graphics, information and guidelines for engine component wear to assist service personnel as a guideline to perform necessary engine repairs and prevent unnecessary engine replacement.

060000 ENGINE (PWS)

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

100000 POWER TRAIN

This service bulletin provides technicians with updated information to help identify the differences between what is considered a fluid leak, and what is considered fluid seepage.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides technicians with updated information to help identify the differences between what is considered a fluid leak, and what is considered fluid seepage.

020000 SUSPENSION

This service bulletin provides technicians with updated information to help identify the differences between what is considered a fluid leak, and what is considered fluid seepage.

010000 STEERING

This service bulletin provides technicians with updated information to help identify the differences between what is considered a fluid leak, and what is considered fluid seepage.

350000 EQUIPMENT

This service bulletin provides information on a guide to help reduce repeat visits for the same customer concern.

070000 FUEL SYSTEM, GASOLINE

This service bulletin provides information for maintenance cleaning of the fuel injectors and gasoline detergent additive.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides information for maintenance cleaning of the fuel injectors and gasoline detergent additive.

110000 ELECTRICAL SYSTEM

This bulletin provides information on identifying Non-GM Engine Calibrations for Gasoline Engines using the Tech 2 or GDS 2.

060000 ENGINE AND ENGINE COOLING

This bulletin provides information on identifying Non-GM Engine Calibrations for Gasoline Engines using the Tech 2 or GDS 2.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the

150000 SEAT BELTS

This service bulletin provides information on availability for a seat belt extender.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides guidelines and diagnostic/repair information to technicians regarding vehicle engine oil consumption.

110000 ELECTRICAL SYSTEM

The intent of this service bulletin is to identify aftermarket ALDL or DLC interface devices as potential sources for causing multiple customer concerns that do not have other diagnostic methods to identify them.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information for dealers/technicians on When and How to Submit a Field Product Report (FPR) (U.S. Dealers Only).

100000 POWER TRAIN

This service bulletin provides information on some vehicles that may rock or move slightly forward or rearward while in Park at start up after cold soak. This condition may be accompanied by a clunk noise. This is a slight movement that is

200000 WHEELS

This service bulletin provides information for dealers/technicians on Vibration Shortly After Tires are Mounted/Preventing Vibration from Wheel Slip (Tire Sliding on Wheel).

100000 POWER TRAIN

This Preliminary Information communication provides information to the technician about vehicles that have an intermittent no crank, no start, or start stall concern with the security light coming on. Technician may find Diagnostic Trouble

116000 ELECTRICAL SYSTEM:IGNITION

200000 WHEELS

This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.

061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

060000 ENGINE AND ENGINE COOLING

This diagnostic tip bulletin provides additional information on how to diagnose a possible valve, lifter or camshaft issue.

200000 WHEELS

This service bulletin provides information for dealers/technicians on Vibration Shortly After Tires are Mounted/Preventing Vibration from Wheel Slip (Tire Sliding on Wheel).

100000 POWER TRAIN

This bulletin provides information on the harmful effects of water or ethylene glycol in transmission fluid.

060000 ENGINE AND ENGINE COOLING

This diagnostic tip bulletin provides additional information on how to diagnose a possible valve, lifter or camshaft issue.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

120000 EXTERIOR LIGHTING

This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.

353720 EQUIPMENT:ELECTRICAL:ACCESSORY GENERATOR:OUTLETS/RECEPTACLE

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information for dealers/technicians on When and How to Submit a Field Product Report (FPR) (U.S. Dealers Only).

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Warranty Administration bulletin provides retail and wholesale service personnel with the policies/procedures and the warranty transaction submission procedures that support the Personal Property Damage process.

138220 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REAR WINDOW:ELECTRICAL HEATING ELEMENT

This Preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. To allow the ice to melt so that it can be drained from the related component

060000 ENGINE AND ENGINE COOLING

This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or P0455 Set.

060000 ENGINE AND ENGINE COOLING

100000 POWER TRAIN

190000 TIRES

This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo

200000 WHEELS

060000 ENGINE AND ENGINE COOLING

This bulletin provides information on Policies Applicable to All U.S. Dealers for Engine and Transmission Assembly Replacement Under Warranty, Policy or Customer Enthusiasm and information on Submission of Warranty Transaction in Global War

100000 POWER TRAIN

060000 ENGINE AND ENGINE COOLING

110000 ELECTRICAL SYSTEM

This service bulletin provides information on Module Harvesting.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).

980000 UNKNOWN OR OTHER

This Preliminary Information communication provides information to the technician that General Motors and General Motors of Canada Company do not support cross border sales. The General Motors of Canada Customer Care Centre is the sole auth

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information on Handling Requests for Modifications to Permanently Import/Export Vehicles Between the U.S. and Canada.

110000 ELECTRICAL SYSTEM

This preliminary information (PI) provides information om Service Programming System (SPS) Error Codes (E4398, E4399, E4403, M4404, M4413, M6954, M6955, E4414, E4423, E4491 or E6961).

010000 STEERING

This service bulletin provides technicians with updated information to help identify the differences between what is considered a fluid leak, and what is considered fluid seepage.

020000 SUSPENSION

This service bulletin provides technicians with updated information to help identify the differences between what is considered a fluid leak, and what is considered fluid seepage.

030000 SERVICE BRAKES, HYDRAULIC

This service bulletin provides technicians with updated information to help identify the differences between what is considered a fluid leak, and what is considered fluid seepage.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides technicians with updated information to help identify the differences between what is considered a fluid leak, and what is considered fluid seepage.

100000 POWER TRAIN

This service bulletin provides technicians with updated information to help identify the differences between what is considered a fluid leak, and what is considered fluid seepage.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides information on OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification.

100000 POWER TRAIN

This service bulletin provides information on OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification.

110000 ELECTRICAL SYSTEM

060000 ENGINE AND ENGINE COOLING

This bulletin provides information on identifying Non-GM Engine Calibrations for Gasoline Engines using the Tech 2 or GDS 2.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides the technician with additional information on fuels, fuel additives and fuel management.

070000 FUEL SYSTEM, GASOLINE

This service bulletin provides the technician with additional information on fuels, fuel additives and fuel management.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information on a guide to help reduce repeat visits for the same customer concern.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides guidelines and diagnostic/repair information to technicians regarding vehicle engine oil consumption.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides information for maintenance cleaning of the fuel injectors and gasoline detergent additive.

070000 FUEL SYSTEM, GASOLINE

This service bulletin provides information for maintenance cleaning of the fuel injectors and gasoline detergent additive.

100000 POWER TRAIN

This diagnostic tip advises the tech not to separate the flexplate from the torque convertor or damage my occur if the engine is started while diagnosing for noise from the engine or transmission.

100000 POWER TRAIN

This Preliminary Information communication provides information to the technician to not remove the torque converter bolts and start the engine as this may cause damage to the torque converter of the crankshaft on vehicles equipped with an

060000 ENGINE AND ENGINE COOLING

This bulletin provides information on tools available to find an intake vacuum leak or exhaust leak to correct a condition of MIL Illuminated with Multiple Fuel Trim and/or Oxygen Sensor Codes Set.

134000 VISIBILITY:SUN/MOON ROOF ASSEMBLY

This Preliminary Information communication advises the technician the steps on diagnosing the concern. Customer's sunroof operation intermittent, bind, noise, auto-reverse, and/or water leaks.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

160000 STRUCTURE

Showing 100 of 1,169 bulletins.

NHTSA Safety Investigations, CHEVROLET MALIBU

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

EA, Open , Model Year: 2020

DTN Air Bag Inflator Rupture

The Office of Defects Investigation (ODI) has become aware of eight vehicle crashes in which a rupture of a Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN) air bag inflator occurred during the deployment of the driver side air bag. All eight drivers in these crashes sustained serio... us or fatal injuries that appear linked to the ruptures. Six of those drivers sustained fatal injuries and two sustained severe injuries. In all eight incidents, the subject inflators had been installed as replacement equipment after the vehicle was involved in a previous crash. Information gathered during NHTSA’s initial analysis of these incidents indicates that the inflators were potentially imported illegally into the United States. In conjunction with this safety investigation, NHTSA is also working with appropriate authorities to address any illegal activities associated with the importation of these inflators. As a result of the significant safety concerns relating to these inflators, as well as extensive information already obtained by ODI relating to their field ruptures, ODI is moving directly to the Engineering Analysis (EA) stage of its investigative process rather than first opening a Preliminary Evaluation. NHTSA has taken a variety of actions to address the risks posed by the importation of substandard or counterfeit air bag components. However, until recently, these risks appeared spread across a variety of components and manufacturers. As part of ODI’s continuous monitoring of this issue, the agency has obtained information to suggest that at least eight incidents involve ruptures of inflators manufactured by DTN. In parallel with this dedicated investigation into DTN inflators, ODI will continue to monitor reports of field incidents to evaluate risks from other substandard imported air bag components. In 2012, ODI first became aware of substandard or counterfeit air bag modules sold through online marketplaces, such as auction sites. NHTSA obtained examples of these air bag modules and conducted testing. None of the inflators equipped in these modules were manufactured by DTN. This testing revealed that the inflators consistently malfunctioned during deployments, such as by failing to deploy the air bag or expelling metal shrapnel due to a rupture. This led NHTSA to release a consumer advisory in October 2012 to alert the public and repair professionals to the potential dangers of substandard or counterfeit air bag modules. ODI also worked with major vehicle manufacturers, who released advisories and notifications concerning the use of such air bag modules. Since then, NHTSA has continuously monitored for reports of malfunctioning air bags that may be associated with substandard or counterfeit components. These monitoring efforts have been supported by the increased visibility the advisories have brought to the issue, and by several standing general orders in place as part of separate investigations into Takata and ARC inflators, which require certain manufacturers to report any alleged or suspected inflator field ruptures to NHTSA. Until 2017, ODI was not aware of any field incidents involving an abnormal deployment of an imported substandard or counterfeit air bag module. In September 2017, ODI became aware of a crash involving a model year (MY) 2009 Honda Civic where the air bag ruptured during deployment, killing the driver. After inspecting the vehicle and air bag parts, ODI determined that the air bag inflator was not original equipment and that the air bag module was likely a substandard import. Insufficient information existed to determine the manufacturer of the inflator in this incident, however, it does not appear to resemble those manufactured by DTN. On June 16, 2023, ODI received a Vehicle Owner Questionnaire (VOQ #11527380) alleging that the rupture of a driver side air bag caused fatal injuries to the driver of a MY 2020 Chevrolet Malibu. ODI’s assessment of the rupture indicated that the air bag inflator was not original equipment but was instead manufactured by DTN, a Chinese company (also known as Yoshibayashi Toku theanol Automotive Safety Systems Co. Ltd.). From June 2023 to July 2024, ODI became aware of four additional ruptures involving substandard air bag modules equipped on Chevrolet Malibu vehicles. At the time, insufficient information existed for these crashes to determine who manufactured the ruptured inflators. As a result, NHTSA released a consumer advisory on July 10, 2024, alerting car buyers and owners to be aware of cheap, substandard replacement air bag inflators that can cause death or serious injury in a crash. The advisory urged consumers who own or are considering the purchase of a used vehicle to learn the vehicle’s history and ensure the vehicle has genuine air bag inflators. In March 2025, NHTSA learned about another rupture involving a suspected substandard, aftermarket inflator that was equipped in a MY 2017 Hyundai Sonata. The driver of this vehicle sustained fatal injuries that appeared related to the rupture. In August 2025, NHTSA received a similar report of a fatal air bag rupture in a MY 2019 Hyundai Sonata. Most recently, in October 2025, ODI received a report of a fatal air bag rupture in a MY 2020 Chevrolet Malibu. Photographs of the air bag components in these three crashes indicated that the ruptures all involved inflators manufactured by DTN. Further investigation of the inflator fragments in three of the prior incidents confirmed that they also involved DTN inflators. Photographs of the components involved in one of the other incidents also strongly suggest that the ruptured inflator was manufactured by DTN. This opening resume exceeded space limitations and is continued in an attachment uploaded to the investigation.Read more

EA, Closed , Model Year: 2004

Turn Signal Lamps

GM designed the MY 2004 and 2005 Chevrolet Malibu and Malibu Maxx vehicles with a daytime running lamp (DRL) system that uses the same filament (the high power filament of a dual filament bulb) as the front turn signals.The high power filament operates at full battery voltage when functioning as a D... RL.The DRL is illuminated whenever the headlamps are off, increasing the duty cycle of the front turn signal bulb.The MY 2003 and earlier Malibu vehicles (Malibu Maxx was not manufactured for sale in the U.S. prior to MY 2004) used a headlamp based design, operated at a reduced voltage, for the DRL function; GM reverted back to this design on the MY 2006 and later Malibu and Malibu Maxx vehicles. Filament based bulbs have a finite life (hours of illumination) for any given operating voltage.As a result, increasing the duty cycle of a bulb typically decreases the life span of the bulb.GM identified and addressed two front turn signal/DRL and rear turn signal bulb quality issues early in MY 2004 production, however vehicle warranty claims for failed bulbs continued to occur.To address the high warranty levels of bulb failures (90% of the warranty claims submitted to ODI by GM were bulb failures and 10% were socket failures), GM issued a technical service bulletin in March 2006 advising dealers to use a new specification of bulb when addressing service failures, and to also inspect the electrical sockets for thermal damage and replace if necessary.In June 2006 (after subject vehicle production ended) GM changed the turn signal bulb specification to that of the TSB bulb in vehicle production also.To date, ODI has not identified any allegations of crash, injury, or fire related to the alleged defect even though the subject vehicles have experienced 5 - 6 years of field exposure.ODI's analysis of consumer complaints, both VOQ and manufacturer, shows a declining trend.The warranty rate for turn signal bulb replacement is high however statistical analysis of the warranty data suggests that the majority of the original equipment bulbs have already been replaced.GM conducted a safety recall (06V-263) for MY 2004-2005 Cadillac XLR to replace the front turn signal/DRL bulbs and the electrical sockets.However GM advised that the turn signal/DRL bulbs/sockets on the subject vehicles differ from those on the recalled XLRs in several respects, including using bulb sockets with four electrical terminals as opposed to three, which improves the electrical connection, allows the bulb to operate at a lower temperature, and adds stability to the bulb in the socket; operating at a lower voltage, which increases vehicle bulb life; using vented headlamps, which allows bulbs to run cooler than those installed in a non-vented XLR headlamp; and using a clear bulb, which runs cooler than the amber bulbs installed on the XLR.Additionally, the warranty claim level related to subject vehicle sockets is unremarkable compared to other defect investigations into defective socket assemblies.A safety-related defect trend has not been identified at this time.Further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will take further action if warranted by the circumstances.See attached report for further information.Read more

PE, Closed , Model Year: 2004

TURN SIGNAL LAMPS

THE SUBJECT VEHICLES MAY EXPERIENCE LOSS OF FUNCTION OF ONE OR MORE OF THE PARK, TURN, STOP OR DAYTIME RUNNING LAMPS (DRL).FAILURE OF THE BULB MAY ALSO INCLUDE DISCOLORATION (HEAT DAMAGE) TO THE BULB SOCKET.GENERAL MOTORS (GM) TECHNICAL SERVICE BULLETIN (TSB) NUMBER 06-08-42-004C INSTRUCTS TECHNICIA... Read more

PE, Closed , Model Year: 2002

TURN SIGNAL FAILURES

IN DECEMBER 2004, GM ISSUED A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327. THE POLICY COVERED TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURRED FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD... Read more

RQ, Closed , Model Year: 1997

WINDSHIELD WIPER FAILURE

IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE W... Read more

EA, Closed , Model Year: 2004

LOSS OF ELECTRIC POWER STEERING

IN PERFORMING THIS ENGINEERING ANALYSIS, ODI DETERMINED THAT THE ELECTRIC POWER STEERING SYSTEM IN THE SUBJECT VEHICLES CAN MALFUNCTION OR FAIL, CAUSING THE DRIVER TO LOSE POWER STEERING ASSISTANCE; HOWEVER, DUE TO THE FOLLOWING REASONS, ODI HAS DECIDED THAT FURTHER EXPENDITURE OF AGENCY RESOURCES O... Read more

RQ, Closed , Model Year: 1999

TURN SIGNAL FAILURES

GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).OD... Read more

PE, Closed , Model Year: 2004

LOSS OF ELECTRIC POWER STEERING

ODI OPENED PE04-031 BASED ON EIGHT REPORTS OF ALLEGED POWER STEERING FAILURE IN THE SUBJECT VEHICLES.THE COMPLAINTS ALLEGE THAT THE DRIVER SUDDENLY LOST ALL ELECTRIC POWER STEERING ASSISTANCE WITHOUT WARNING MAKING THE VEHICLE DIFFICULT TO STEER. THE SUBJECT VEHICLE UTILIZES AN ELECTRIC POWER STEERI... Read more

EA, Closed , Model Year: 1999

FRONT SUSPENSION COIL SPRING FRACTURE

THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFO... Read more

PE, Closed , Model Year: 1999

FRONT SUSPENSION COIL SPRING FRACTURE

THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND... Read more

EA, Closed , Model Year: 2000

TURN SIGNAL FAILURES

BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1... Read more

DP, Closed , Model Year: 1999

ENGINE COOLANT BOILS OVER

There is no summary currently available

PE, Closed , Model Year: 2000

TURN SIGNAL FAILURE

ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.E... Read more

EA, Closed , Model Year: 1997

POWER RACK AND PINION STEERING FAILURE

THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.

PE, Closed , Model Year: 1997

STEERING RACK AND PINION

ODI HAS RECEIVED 200 COMPLAINTS FROMT CONSUMERS AND 1,238 FROM GM ALLEGING FAILURE OR LOCKUP OF THE STEERING RACK AND PINION UNIT (R&P).THIS ALLEGED CONDITION CAN RESULT IN THE LOSS OF STEERING CONTROL OF THE VEHICLE AND A CRASH CAN RESULT.GM HAS REPORTED SIX CRASHES IN WHICH EIGHT PEOPLE HAVE SUSTA... Read more

EA, Closed , Model Year: 1997

WINDSHIELD WIPER

ON FEBRUARY 22, 2000, THE OFFICE OF DEFECTS INVESTIGATION (ODI) INITIATED PE00-009 BASED ON SEVEN REPORTS OF WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 1997 & 1998 CHEVROLET MALIBU & OLDSMOBILE CUTLASS VEHICLES.THE INVESTIGATION WAS UPGRADED TO EA00-019 ON JULY 12, 2000.DURING THE COURSE OF... Read more

EA, Closed , Model Year: 1997

STOP LAMP ASSEMBLY OVERHEAT

There is no summary currently available

PE, Closed , Model Year: 1997

WINDSHIELD WIPER

There is no summary currently available

PE, Closed , Model Year: 1998

STOP LAMP

There is no summary currently available

CHEVROLET MALIBU - All Years Overview

Complete safety history for the CHEVROLET MALIBU across all model years (1973, 2025).

164 Total Recalls

29,324 Total Complaints

19 Investigations

1,247 Reported Crashes

277 Reported Fires

42 Reported Deaths

CHEVROLET MALIBU - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2025	1	9	View
2024	2	42	View
2023	2	84	View
2022	1	140	View
2021	2	118	View
2020	1	324	View
2019	1	307	View
2018	6	1,197	View
2017	4	1,173	View
2016	9	1,443	View
2015	3	395	View
2014	6	561	View
2013	10	1,382	View
2012	3	1,471	View
2011	4	1,526	View
2010	4	2,200	View
2009	6	2,356	View
2008	5	1,489	View
2007 (current)	6	1,253
2006	9	1,475	View
2005	6	1,386	View
2004	9	1,639	View
2003	3	773	View
2002	4	754	View
2001	4	1,005	View
2000	5	1,379	View
1999	3	1,227	View
1998	5	1,480	View
1997	6	693	View
1989	0	3	View
1986	0	1	View
1983	3	1	View
1982	3	3	View
1981	3	3	View
1980	6	6	View
1979	6	4	View
1978	8	2	View
1977	2	0	View
1975	1	2	View
1974	1	1	View
1973	1	0	View
1964	0	1	View

Other CHEVROLET Models

Model	Recalls	Complaints
SUBURBAN	246	10,458	View
TAHOE	240	12,622	View
SILVERADO 1500	200	22,534	View
CORVETTE	187	6,308	View
CAMARO	179	4,298	View
SILVERADO	159	10,964	View
SILVERADO 3500	152	1,409	View
EXPRESS	151	838	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2007 CHEVROLET MALIBU

Complaint Statistics

Top Reported Components

EPA Fuel Economy, 2007 CHEVROLET MALIBU

Technical Service Bulletins, 2007 CHEVROLET MALIBU

Most Affected Components

NHTSA Safety Investigations, CHEVROLET MALIBU

CHEVROLET MALIBU - All Years Overview

CHEVROLET MALIBU - Year by Year

Other CHEVROLET Models