2019 HYUNDAI SONATA

0 recalls, 213 complaints - 218 TSBs - 5/5 safety rating

No recalls found for this vehicle.

Complaint Statistics

213 total complaints 16 crashes 2 fires 8 injuries

Top Reported Components

Component	Complaints
ENGINE	31
UNKNOWN OR OTHER	28
POWER TRAIN	21
FUEL/PROPULSION SYSTEM	16
EXTERIOR LIGHTING	14
ELECTRICAL SYSTEM	14
STEERING	14
SERVICE BRAKES	11
AIR BAGS	11
ENGINE AND ENGINE COOLING	5

Incident date: Jul 1, 2026

The low-pressure fuel pump module assembly, located directly beneath the rear passenger seat cushion, experienced a plastic housing failure. A stress fracture on the upper plastic fuel outlet nipple caused raw liquid gasoline to actively weep and pool on top of the module inside the passenger cabin.... Read more

Incident date: Jul 7, 2026

The oil is low, went to get looked at by another mechanic besides Dealer cause they want to hit you over the head with prices. Was told car burning oil. Took to dealer for Oil Consumption Test. Had to pay for oil change. Came back a little before 1,000 miles and car failed. They charging me 900.00 ... Read more

Incident date: Jul 1, 2026

The contact owns a 2019 Hyundai Sonata. The contact stated that while driving at an undisclosed speed, the vehicle experienced severe overheating and excessive oil consumption. The contact also stated that there was a misfire in the engine even though the spark plugs and ignition coils were replaced... Read more

Incident date: Jan 26, 2026

On January 26, 2026, my 2019 Hyundai Sonata SEL suddenly became inoperable overnight. The vehicle had been operating normally with no warning signs—no check-engine or oil-pressure light, abnormal engine noise, overheating, loss of power, or other indication of an impending failure. The following m... Read more

Incident date: Jul 31, 2026

While driving a 2026 Tesla Model Y Premium on [XXX] at approximately [XXX] PM on [XXX] using Full Self-Driving (FSD) Supervised mode, the vehicle was traveling in the center lane (lane 2 of 3) when it ran over a large whole tire (commercial truck-sized) that was positioned in the center of the lane.... Read more

Crash

Incident date: Jul 16, 2026

High excessive oil consumption and premature piston ring failure leading to excessive oil consumption

Incident date: Jul 10, 2026

The contact owns a 2017 Ford Explorer. The contact received notification of NHTSA Campaign Number: 25V347000 (Structure). While driving approximately 60 MPH, the driver's side B-pillar trim detached and flew off the vehicle. The vehicle was taken to the residence, inspected, and confirmed that the d... Read more

Incident date: Jul 2, 2026

Vehicle is a 2019 Honda CR-V (1.5L Turbo) experiencing an active internal mechanical failure—suspected collapsing/sticking piston rings bypassing the combustion chamber, resulting in severe, unmeasured oil consumption. The dealership (Wesley Chapel Honda) filled the engine with new oil and refuse... Read more

Incident date: Apr 14, 2021

2026 Subaru Trailseeker, purchased new May 19, 2026. The 12V auxiliary battery failed completely after 3 days parked on June 17, 2026. Traction battery was at 65% charge at time of failure. All vehicle systems were unresponsive. Couldn't open doors, do anything. When the 12V drains fully on this pla... Read more

Incident date: Sep 22, 2025

Power steering and StabiliTrack warning pops-up randomly and cuts off power steering assistance while I'm driving on the highway or on country roads. The power steering is very hard to maneuver. However, when it's safe to do so, I have to pull over on a safe place and have to restart my truck twice,... Read more

Incident date: Jun 7, 2026

Failure of a $70 thermocouple sensor in the air conditioning unit requires replacement of the entire evaporative cooler, which requires removal and reinstallation of the entire dash from the vehicle. This should be a part serviceable without such extensive work.

Incident date: Mar 8, 2023

The complaint was filed on behalf of the customer. The contact stated while the customer was driving at an undisclosed speed, the steering wheel failed to turn in the intended direction. The vehicle was uncontrollable. The customer's vehicle drove on a sidewalk. The vehicle was towed to the independ... Read more

Incident date: Mar 8, 2023

Bought in Dec 2022, in February engine seized due to oil pressure issues, was told it needed a new engine. In communications with Ford, they were aware of issue, but it was not a recall issue at that time. I believe that if this issue occurred before recall, that they were replacing these parts with... Read more

Incident date: Mar 8, 2023

Rear main seal has blown three times since I purchased my vehicle from Carvana. I’ve pulled the engine out myself as I cannot afford another $3,500 at the shop. I’m a single income household that makes too much for financial assistance. The Chevy Equinox was the only vehicle in our price range. ... Read more

Incident date: Apr 29, 2026

In November of 2025 the vehicle displayed a "Check Eletrical System" error message. Shortly thereafter the vehicle decelerated to under 10mph as we were turning into traffic. We were able to drive it home (less than 1mi away) and then called the Dealership. The car was then towed to the dealer (but... Read more

Incident date: Apr 29, 2026

Incident date: Mar 9, 2026

Automatic Emergency Braking Blind Spot Warning/Blind Spot Detection Forward Collision Warning Antilock Brake System/ABS Lane Departure Warning Lane keeping Assistance I bought this vehicle last month from a dealer and two days later all the warning lights start popping up on the dashboard so I conta... Read more

Incident date: Mar 9, 2026

Incident date: Apr 17, 2026

Our vehicle has 79,500 miles and the transmission is slipping between 2nd and 3rd, and causing rpm surging. We had a diagnostic done and need the cdf drum replaced with the newly designed part as the current part has a defect. This is apparently a known issue and should be a recall so the defective... Read more

Incident date: Apr 17, 2026

The contact owns a 2016 Ford Fusion. The contact stated that the rear sensor for the camera was inoperable. The contact stated that unknown warning lights were illuminated. The contact received a notification letter of NHTSA Campaign Number: 25V695000 (Back Over Prevention). The local dealer was not... Read more

Incident date: Apr 14, 2026

I experienced repeated stalling, loss of drive power while on the highway, limp mode, and all dashboard warning lights over several years. I brought the vehicle to an authorized Honda dealership multiple times and specifically asked whether these symptoms were related to the known fuel pump recall. ... Read more

Incident date: Apr 14, 2026

MY VEHICLE HAS HAD A FUEL INJECTOR RECALL SINCE 07/2025. MY CAR HAS GRADUALLY STARTED TO IDLE AND DROP RPMS. IT STARTS WHEN THE VEHICLE WAS ONLY IN PARK AND NOW IT IS HAPPENING WHEN I AM IN DRIVE AND FOOT IS ON THE BRAKE. I AM NOT SURE WHAT TO DO BECAUSE OF THE OPEN RECALL WITH NO REPAIR OPTIONS IN ... Read more

Incident date: Apr 14, 2026

Incident date: Apr 5, 2026

Car started winding while driving and jerking for no reason.

Incident date: Apr 5, 2026

The Powershift for the transmission is the issue. Got two notices about a software update and followed through with updates. When done my Ford dealership said they couldn’t do anything else and that I was just going to be like it was. I never received any more recalls or even a Class Action letter... Read more

Incident date: Apr 1, 2026

In the 5 months I have owned this vehicle, the windshield has been chipped at least six time by debris while driving. As I am retired, I do not do a lot of freeway travel and 700 of the 3400 miles were from a trip to visit my mom. I had fewer windshield chips on my previous Honda CRV in 8 years and ... Read more

Incident date: Dec 1, 2025

The contact owns a 2019 GMC Yukon. The contact stated that while driving at slow speeds in a parking lot, the transmission unexpectedly downshifted and the vehicle jerked abnormally. The contact stated that when the gear shift lever was shifted to drive(D), the vehicle failed to function as designed... Read more

Incident date: Jan 14, 2026

A persistent humming/whining noise occurs at highway speeds (around 60–70 mph). The noise has been present for more than two years and has continued through multiple major repairs. The sound appears to come from the drivetrain area and raises concerns about a potential driveline or mechanical fail... Read more

Incident date: Jan 14, 2026

Incident date: Mar 18, 2026

camshaft failure cylinder 7

Incident date: Mar 18, 2026

While driving, the steering wheel suddenly became stiff and difficult to turn, making it hard to control the vehicle. This happened unexpectedly and created a serious safety risk, as I could have lost control and caused an accident. At the same time, the braking response did not feel normal, which ... Read more

Incident date: Feb 13, 2026

Shortly after a routine oil change performed at a Kia dealership, I discovered a significant oil leak underneath the vehicle the following day. Within a short period of time, the vehicle began experiencing engine-related issues including a cylinder misfire, noticeable shaking while driving, and loss... Read more

Incident date: Feb 21, 2026

While turning, the resistance = how heavy is steering, suddenly drop for few millisecond which causes unpredictable understeering , i almost hit the other car on opposite side it happens not every turn but randomly

Incident date: Feb 21, 2026

Throttle body replacement at only 23294 miles. Replaced under warranty . Did some searching and Honda is aware of coolant seeping into throttle body. This could cause failure while on road or hwy causing injury or death. This issue should have a priority permanent fix as my family is riding in this... Read more

Incident date: Feb 1, 2022

During acceleration it feels like the transmission is shifting hard and when slowing down something is shifting hard, you can feel it cause you cringe when it bangs into gear. One day my rear tires were skidding driving forward. The shop told me my rear end locked up. I couldn't get a new rear end c... Read more

Incident date: Sep 26, 2025

The contact rented a 2025 Hyundai Tucson. The contact stated that the vehicle would stop and would restart independently while driving. The contact stated that while attempting to reverse, the vehicle failed to respond on several occasions while the gear shifter was in reverse(R). The contact stated... Read more

Crash 2 injured

Incident date: Sep 26, 2025

I purchased a 2023 Chevy Tahoe in Oct 2025. Since then, I have been trying to figure out how to set up the myChevrolet app. The OnStar button doesn’t work so I called OnStar. After multiple calls, they told me that the account is linked to the previous owner and can’t be transferred because of a... Read more

Incident date: Jul 22, 2025

The vehicle experiences a Shift-to-Park malfunction in which it does not consistently recognize that it is in Park, despite being physically shifted into the Park position. When this occurs, the vehicle may fail to shut down properly or behaves as if it is not securely in Park. The condition is rep... Read more

Incident date: Jun 22, 2025

See attached document for complaint. I've got a 2015 Ford Explorer. A recall letter was sent to me over two years ago. The issue was the exterior a-pillar applique trim clip. I have been trying to get this taken care of over two years now. All the Ford Dealerships in my area tell me is we don't hav... Read more

Incident date: Nov 19, 2025

The car is experiencing the same problem reported on technical service bulletin SA187 (Blind spot detection (BSD) system logic improvement (SA 187)) BUT KIA states my VIN number is not listed under the service bulletin and therefore I have to pay $189 to get a software upgrade done. The "Check BSD ... Read more

Incident date: Aug 9, 2025

Check engine light was on after just sitting in the snow for two days. Dealer is saying that it is a fuel injector and something with the gas. I hope this fixes it.

Incident date: Nov 22, 2025

The contact owns a 2025 Nissan Sentra. The contact had stopped at a State Office to register the vehicle. While at the registration office, the contact was informed that there was an open recall associated with the vehicle. The contact checked the NHTSA website and found NHTSA Campaign Number: 25V80... Read more

Incident date: Jan 1, 2025

Yes had it inspected rear frame is rusting out affecting the sway bars which I will also need a new exhaust due to the rust. I did see honda has a recall but not in my state.

Incident date: Jun 1, 2024

Squeaky breaks Coolant leak Engine heating warning Check enginelight comes on after each gas visit Car sounded super load when engine is running due to constant coolant leaks Car doesn’t feel safe to drive with 4 young kids!

Incident date: Sep 24, 2025

Was driving with flow of traffic and the Engine lost power went to zero RPM check engine light came on. It’s a non hybrids motor. Wouldn’t turn over once pulled on side of road Check underneath engine bay for leaks of fluid nothing was leaking.

Incident date: Oct 17, 2025

I received a Uconnect update message on 10 -11–25 after doing that update my check engine light came on and my vehicle stalled out losing power multiple times on a highway with heavy traffic. I was asked to drive the vehicle to the Jeep dealership Heritage Jeep in Harrisburg, Pennsylvania they tol... Read more

Incident date: Sep 20, 2025

This vehicle was purchased from Audi Fort Lauderdale on July 31, 2025 and on the drive home, 9 safety systems were reported as not working. This has continued for 7 weeks and the dealer has attempted repair 5 times including software updates, front camera replacement, camera alignments and finally ... Read more

Incident date: Sep 23, 2025

I was driving northbound in on I15 in Salt Lake City when a Home Depot Bucket blew into my lane. I slowed down to change lanes when the Collision Mitigation Braking System (CMBS) deployed without warning, bringing my car to an almost stop causing a semi tractor trailer to hit me from behind.

Crash

Showing 50 of 213 complaints.

NHTSA Safety Ratings, 2019 HYUNDAI SONATA

2019 Hyundai Sonata 4 DR FWD

Category	Rating
Overall Rating	5 / 5 ★★★★★
Frontal Crash	5 / 5 ★★★★★
Frontal Crash, Driver	5 / 5 ★★★★★
Frontal Crash, Passenger	5 / 5 ★★★★★
Side Crash	5 / 5 ★★★★★
Side Crash, Driver	5 / 5 ★★★★★
Side Crash, Passenger	5 / 5 ★★★★★
Rollover	4 / 5 ★★★★☆
Rollover Risk	10.5%

Safety Technology

Feature	Status
Electronic Stability Control	Standard
Forward Collision Warning	No
Lane Departure Warning	Optional

Source: NHTSA 5-Star Safety Ratings Program. Ratings are based on crash tests conducted by the National Highway Traffic Safety Administration.

EPA Fuel Economy, 2019 HYUNDAI SONATA

Trim / Engine	City MPG	Highway MPG	Combined MPG	Fuel Type	Annual Fuel Cost
2.4L 4-cyl, Automatic (S6) (Front-Wheel Drive)	25.0	33.0	28.0	Regular	$2,200
2.0L 4-cyl, Automatic (S8) (Front-Wheel Drive)	23.0	32.0	26.0	Regular	$2,350
1.6L 4-cyl, Automatic (AM7) (Front-Wheel Drive)	28.0	37.0	31.0	Regular	$2,000

CO2 Emissions: 319.0 g/mile (Large Cars)

Source: U.S. Environmental Protection Agency (EPA). Actual fuel economy may vary based on driving conditions.

Technical Service Bulletins, 2019 HYUNDAI SONATA

218 manufacturer communications from 104 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
060000 ENGINE AND ENGINE COOLING	39
110000 ELECTRICAL SYSTEM	36
350000 EQUIPMENT	27
100000 POWER TRAIN	18
356000 EQUIPMENT ADAPTIVE/MOBILITY	16
060000 ENGINE (PWS)	10
010000 STEERING	9
118000 ELECTRICAL SYSTEM:SOFTWARE	9

100000 POWER TRAIN

This TSB provides a procedure to diagnose and replace, if necessary, an automatic transmission with Incorrect Ratio DTC (transmission clutch slip in gear above limit) listed on Page 2.

130000 VISIBILITY/WIPER (PWS)

This bulletin contains information about the proper removal of the windshield wiper blade protective cover on all models. If the protective cover is not removed correctly, there is a possibility of the rubber insert and rail spring becoming

130000 VISIBILITY

116300 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993), combined with an anti-theft steering wheel lock campaign (Campaign P32), and anti-theft ignition cylinder protector campaign (Campaign 9A5) in res

110000 ELECTRICAL SYSTEM

353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

110000 ELECTRICAL SYSTEM

353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

This bulletin provides the service procedure to: 1) Upgrade the IBU/BCM (Integrated Body Control Unit/Body Control Module) to revise the OEM Hyundai burglar alarm system operation and ignition start logic and 2) Install two anti-theft decal

110000 ELECTRICAL SYSTEM

116300 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993), combined with an anti-theft steering wheel lock campaign (Campaign P32), in response to an increase in thefts of certain 2011-2022MY Hyundai vehic

110000 ELECTRICAL SYSTEM

116320 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:SENSOR

Certain Hyundai vehicles may not be equipped with an immobilizer. This bulletin provides the service procedure to update the IBU/BCM (Integrated Body Control Unit/Body Control Module), to revise the OEM Hyundai burglar alarm system operati

110000 ELECTRICAL SYSTEM

116300 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

110000 ELECTRICAL SYSTEM

060000 ENGINE AND ENGINE COOLING

This bulletin provides important checkpoint guidelines when performing engine oil and filter change services.

100000 POWER TRAIN

If you are servicing an 8-speed vehicle with a a??Check Enginea?? light on and one or more of the DTC listed, follow the service procedure and replace the related solenoid and harness.

110000 ELECTRICAL SYSTEM

100000 POWER TRAIN

110000 ELECTRICAL SYSTEM

Some models from service campaign 993 (IBU/BCM Software Update and Decals Application) equipped with the Hyundai OEM remote start system may exhibit the horn honking when remote starting the vehicle after receiving the software update. Thi

353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

110000 ELECTRICAL SYSTEM

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

116320 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:SENSOR

110000 ELECTRICAL SYSTEM

061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)

Certain 2015-2019MY Sonata (LFA) vehicles may intermittently exhibit reduced engine power, a a??Crank/No Starta?? condition, and/or have DTC P1233 stored in the ECM due to an internally leaking fuel pump filter housing. For vehicles exhibit

060000 ENGINE AND ENGINE COOLING

116300 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

110000 ELECTRICAL SYSTEM

162000 STRUCTURE:BODY

Hyundai applies a Paint Protection Film (PPF) on new vehicles before delivery to dealerships. It provides a barrier between the paint and contaminants, such as rail dust, acid rain, and industrial fallout. In rare cases, the paint can becom

116320 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:SENSOR

110000 ELECTRICAL SYSTEM

116320 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:SENSOR

Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993) in response to an increase in thefts of certain Hyundai vehicles not equipped with engine immobilizers targeted through social media. In November 2

110000 ELECTRICAL SYSTEM

133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

110000 ELECTRICAL SYSTEM

060000 ENGINE AND ENGINE COOLING

If you are servicing an 8-speed vehicle with a a??Check Enginea?? light on and one or more of the DTC listed, follow the service procedure and replace the related solenoid and harness.

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

116320 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:SENSOR

110000 ELECTRICAL SYSTEM

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

110000 ELECTRICAL SYSTEM

061120 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER

Certain 2015-19MY Sonata (LFA) vehicles equipped with 2.0L Turbo GDI engines need the Electronic Control Module (ECM) software updated to revise the fuel injection control logic to compensate for oxygen sensor aging and control tailpipe emi

060000 ENGINE AND ENGINE COOLING

This bulletin provides information related to an Electronic Control Module (ECM) software update to revise the fuel injection control logic to compensate for O2 sensor aging and control tailpipe emissions within applicable standards.

110000 ELECTRICAL SYSTEM

130000 VISIBILITY

This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside th

060000 ENGINE AND ENGINE COOLING

Follow the guidelines outlined in this bulletin to inspect and clean or replace certain components of the engine intake system accordingly during engine short block or sub-assembly replacement.

190000 TIRES

Effective June 2, 2008, Federal Motor Vehicle Safety Standard 110 (FMVSS 110) established a threshold for correcting load carrying capacity information indicated on tire placards when vehicle weight has been increased before retail sale

010000 STEERING

Certain vehicles may develop a bearing noise within the Motor Driven Power Steering (MDPS) column worm shaft assembly. If bearing noise is heard, follow the procedure in this bulletin to replace the worm shaft bearing.

350000 EQUIPMENT

Certain vehicles (listed below) equipped with 7-speed Double Clutch Transmissions (DCT) may exhibit abnormal vibration at low speeds. This bulletin outlines the procedures for diagnosing clutch judder, updating the Transmission Control Unit

100000 POWER TRAIN

061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)

If you are servicing an applicable vehicle with a a??Check Enginea?? light on and one or more of the DTC listed below, follow the repair procedure and replace the related input/output speed sensor and harness.

100000 POWER TRAIN

If you are servicing an applicable vehicle with a a??Check Enginea?? light on and one or more of the DTC listed below, follow the repair procedure and replace the related solenoid and valve body harness.

060000 ENGINE AND ENGINE COOLING

The warranty coverage for engine long block repair or replacement regarding engine damage or malfunction from connecting rod bearing wear has been extended to 10 years or 120,000 miles from the date of original retail delivery or date of fi

060000 ENGINE AND ENGINE COOLING

The warranty coverage for engine long block repair or replacement regarding engine damage or malfunction from connecting rod bearing wear has been extended to a Limited Lifetime Warranty and is valid for original and subsequent owners.

060000 ENGINE AND ENGINE COOLING

Applicable vehicles with 2.0L T-GDI and 2.4L GDI engines may experience the Check Engine warning lamp illuminated with DTC P1326 and/or engine may exhibit Abnormal Noise or No Crank/No Start condition. Follow the procedure to inspect the ve

060000 ENGINE AND ENGINE COOLING

Certain vehicles with 2.0L T-GDI and 2.4L GDI engines may experience the Check Engine warning lamp illuminated with DTC P1326 and/or engine may exhibit abnormal noise or no crank/no start condition related to connecting rod bearing wear or

010000 STEERING

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This bulletin provides additional service diagnostic information and repair procedures related to Electric Waste Gate Actuator (EWGA) equipped vehicles listed below. Refer to the applicable Engine Control / Fuel System sections in the Shop

060000 ENGINE AND ENGINE COOLING

350000 EQUIPMENT

060000 ENGINE AND ENGINE COOLING

350000 EQUIPMENT

The warranty coverage for certain Theta II engine long block repair or replacement regarding engine damage or malfunction from connecting rod bearing wear has been extended to a Limited Lifetime Warranty and is valid for original and subseq

060000 ENGINE AND ENGINE COOLING

Hyundai has launched a Service Campaign for applicable vehicles with 2.0L Turbo and 2.4L GDI engines that may experience the Check Engine warning lamp illuminated with DTC P1326.

060000 ENGINE AND ENGINE COOLING

010000 STEERING

060000 ENGINE AND ENGINE COOLING

This bulletin provides additional service diagnostic information and repair procedures related to Variable Charge Motion Controllers (VCM) equipped in the applicable vehicles listed below. This bulletin also provides information on the use

110000 ELECTRICAL SYSTEM

Certain vehicles may experience 504 Time Out errors when using the Blue Link Mobile App. When asked to provide Modem Information (IMEI/USIM), the Head Unit (HU) displays all zeros. This bulletin describes the procedure to update the Head Un

350000 EQUIPMENT

This bulletin provides the service procedure for engine connecting rod bearing clearance testing. Perform the procedure outlined in this bulletin to fulfill the Bearing Clearance Test inspection requirements to determine next required steps

060000 ENGINE AND ENGINE COOLING

030000 BRAKES (PWS)

This bulletin provides best practice recommendations when performing brake service procedures.

350000 EQUIPMENT

This bulletin provides best practice recommendations when performing brake service procedures.

356000 EQUIPMENT ADAPTIVE/MOBILITY

This bulletin provides best practice recommendations when performing brake service procedures.

350000 EQUIPMENT

This bulletin provides the inspection procedure and repair guidelines for certain vehicles listed below.

060000 ENGINE AND ENGINE COOLING

This bulletin provides the inspection procedure and repair guidelines for certain vehicles listed below.

010000 STEERING

The rack-mounted dual pinion Motor Driven Power Steering (MDPS) system components can be replaced separately from the complete assembly. This bulletin provides information on the separate components and the replacement procedure of these co

100000 POWER TRAIN

This bulletin provides the procedure to update the TCU for a rough idle in Drive with Neutral Control enabled. The rough idle may occur only at a stop in Drive with the A/C off and the ATF temperature between 158~210A?F (70~99A?C). This upd

060000 ENGINE AND ENGINE COOLING

The warranty coverage for the engine long block for engine repairs or replacement related to connecting rod bearing damage as described in Campaign T3G (Seized and/or BCT No Pass Result Only) has been extended to 10 years or 120,000 miles f

118000 ELECTRICAL SYSTEM:SOFTWARE

Applicable vehicles with 2.0L Turbo and 2.4L GDI engines may experience the Check Engine warning lamp illuminated with DTC P1326. Follow the procedure to inspect the vehicle and replace the engine or update the engine ECU software based on

350000 EQUIPMENT

060000 ENGINE AND ENGINE COOLING

061120 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER

060000 ENGINE AND ENGINE COOLING

030000 BRAKES (PWS)

This bulletin describes the procedure to inspect and identify fluid which may appear around the brake caliper area.

200000 WHEELS

This bulletin provides tire vibration service procedures, including how to optimize vehicle vibration performance. For all wheel/tire balance claims, the a??Tire Balance Data Sheeta?? must be fully completed including imbalance and Road For

190000 TIRES

350000 EQUIPMENT

060000 ENGINE AND ENGINE COOLING

118000 ELECTRICAL SYSTEM:SOFTWARE

Showing 100 of 218 bulletins.

NHTSA Safety Investigations, HYUNDAI SONATA

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 2011

Air bags may be disabled during crash

The Office of Defects Investigation (ODI) opened PE18-003 on 3/16/18 to investigate incidents involving crashes, resulting in significant collision related damage, where the frontal airbags failed to deploy. ODI reviewed complaint data, available design, test, and field data on the model year (MY) 2... Read more

PE, Closed , Model Year: 2013

Front Passenger Seat Belt Anchor Failure

The Office of Defects Investigation (ODI) opened this investigation on December 27, 2016 based on two ODI consumer complaints reporting a failure of the front passenger seat belt to remain connected to the seat belt anchor and pre-tensioner during a crash.On March 8, 2017 Hyundai Motor America (Hyun... Read more

PE, Closed , Model Year: 2016

Electronic Parking Brake

The Office of Defects Investigation opened this investigation on September 3, 2016 based on four reports alleging the rear brakes locked or applied while driving without brake pedal application. One of the reports alleged a fire in the right rear wheel area.The vehicles subject to the investigation ... are equipped with an optional Electronic Parking Brake (EPB). In this system, an electric motor applies the parking brake by moving the rear brake pads (pads) against the brake rotors (rotors) when activated by the EPB control switch. The EPB is released by the control switch or by selecting a drive gear with the transmission shifter when the ignition is on.If the EPB has not been used within 1000 kilometers (621 miles) the system is designed to perform an Automatic Adjustment Function (AAF) of the pads to check for proper clearance. This function is a pad adjustment only and is preformed with the vehicle in park with the ignition off. It does not set the parking brake or turn the brake indicator light on. Hyundai has identified an error within the EPB control logic that can cause the pads to remain in contact with the rotors at various levels of force after the AAF is completed. This condition could cause the rear brakes to drag at the next drive cycle and may generate some levels of heat and smoke. The EPB control logic error affects model year 2016 vehicles produced from the start of production through March 16, 2016.Vehicles produced from March 17, 2016 incorporate an updated EPB control logic to prevent brake pad drag. On May 11, 2016 Hyundai notified its dealer network of Service Campaign TFF to update the EPB control logic in the affected vehicle population. Dealers will reflash the EPB software to prevent brake pad drag.There are no reports of accidents or injuries as a result of this issue. The incident that alleged fire could not be confirmed as there were no repairs to the vehicle other than replacement of the rear brake rotors and pads.ODI is closing this investigation based on the manufacturer's Service Campaign of the affected vehicles and in consideration that the the effect of brake drag in this instance does not appear to present an unreasonable risk to motor vehicle safety. The ODI reports cited above can be viewed at www-odi.nhtsa/complaints under the following identification (ODI)numbers: 10820359, 10854476, 10875764, 10892736, and 10928478Read more

PE, Closed , Model Year: 2006

Seat Belt Buckle Electrical Malfunction

On July 22, 2014 the Office of Defects Investigation (ODI) opened a preliminary evaluation to further analyze allegations of seat belt pretensioner malfunctions on model year (MY) 2006-2008 Hyundai Sonata vehicles.ODI received 131 unique reports alleging a failure within the seat belt pretensioner s... ystem, which was typically preceded by SRS light illumination.ODI requested more information from Hyundai in order to understand the nature of the failure and how the airbag deployment algorithm, the seat belt pretensioners, and/or the airbag function may be affected. In response to ODI?s information request (IR), Hyundai submitted 764 unique consumer and field reports and 19,847 warranty claims related to a failure in the front seat belt buckle assembly potentially causing a malfunction of the seat belt pretensioners.In it's response, Hyundai advised that if the resistance specifications for the seat belt buckle pretensioner circuit, located in the seat belt stalk, exceed the nominal range, a diagnostic trouble code will be set and the SRS warning indicator lamp will illuminate.The presence of this stored code will not affect the ability of the SRS Control Module (SRSCM) to detect a collision and command deployment of the pretensioners and airbags, if warranted.In fact, the wiring harness connector may be unplugged from the seat belt buckle pretensioner, and the signal to deploy the pretensioner will still be commanded and recorded.MY 2006-2008 Sonata?s utilize a dual pretensioner system by incorporating pretensioners into both the driver and front passenger seat belt retractor and the seat belt buckle assembly.The retractor pretensioner is located inside the B-pillar and winds (pretensions) the seat belt webbing back into the retractor housing during a collision, helping to remove seat belt slack and restrain the upper torso and hips.In contrast, the buckle pretensioner is located within the stalk of the seat belt assembly and acts to supplement lower limb protection.Both pretensioners are controlled by the SRSCM but utilize separate wiring and connectors.The seat belt retractor pretensioner circuitry and operation is independent of the seat belt buckle pretensioner connector and circuitry.Hyundai produced analysis indicating that increased resistance in the seat belt pretensioner which occurs in vehicle service does not result in a loss of buckle pretensioner.Hyundai further advised that in the unlikely event that a seat belt buckle pretensioner may not deploy due to increased resistance, the retractor pretensioner would still activate.Hyundai advised that the subject vehicles maintain their 5 STAR NHTSA safety rating using the retractor based pretensioner only.ODI notes that MY 2009-10 Sonatas reverted back to a single pretensioner system, and do not utilize seat belt buckle pretensioners. Hyundai advised its intention to initiate a warranty extension program to address concerns with the seat belt buckle prentensioner faults in MY 2006-2008 Hyundai Sonata vehicles.This action will extend the warranty coverage for this issue for 15 years or 250,000 miles, whichever occurs first.Given Hyundai's action and the minimal safety consequence this issue presents, further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor the issue and reserves the right to take further action if warranted by the circumstances. The ODI complaints cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, seRead more

PE, Closed , Model Year: 2011

Steering Shaft Separation

The Office of Defects Investigation (ODI) is aware of 7 complaints and field reports and 10 warranty claims on the subject vehicles that allege the intermediate steering shaft became loose or in some cases separated from the upper steering column and/or the steering gearbox, causing (or potentially ... Read more

PE, Closed , Model Year: 2002

INTERIOR DOOR HANDLE LACERATION HAZARD

THE MANUFACTURER HAS ISSUED A SAFETY RECALL NOTIFICATION AS A RESULT OF THIS INVESTIGATION.THE RECALL AFFECTS 91,202 MY 2002-2003 SUBJECT VEHICLES PRODUCED FROM JANUARY 28, 2002, THROUGH MARCH 22, 2003.THE VEHICLE RECALL POPULATION WAS DEFINED BY THE MANUFACTURER'S USE OF A NEW SUPPLIER FOR THE CHRO... Read more

PE, Closed , Model Year: 1999

FRONT SUB-FRAME CORROSION

THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION, PE08-029, ON APRIL 22, 2008, BASED ON 40 CONSUMER COMPLAINTS ALLEGING FRONT SUB-FRAME CORROSION IN MODEL YEAR (MY) 1999 THROUGH 2002 HYUNDAI SONATA VEHICLES.COMPLAINTS DESCRIBE SEVERE CORROSION OF THE VEHICLE SUB-FRAME IN THE A... REA WHERE THE RIGHT-FRONT LOWER CONTROL ARM IS ATTACHED.IN SOME VEHICLES, SUB-FRAME CORROSION HAS CAUSED COMPLETE OR PARTIAL DETACHMENT OF THE CONTROL ARM, RESULTING IN WHEEL COLLAPSE OR SEPARATION. IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER FOR PE08-029, HYUNDAI PROVIDED OWNER COMPLAINTS, FIELD REPORTS, AND WARRANTY CLAIM DATA FOR APPROXIMATELY 197,906 MY 1999 THROUGH 2002 SUBJECT VEHICLES SOLD OR LEASED IN THE UNITED STATES.THE BASE WARRANTY FOR THE SUBJECT VEHICLES IS 60 MONTHS OR 60,000 MILES, WHICHEVER OCCURS FIRST.ACCORDING TO HYUNDAI, PROLONGED EXPOSURE TO THE ROAD SALTS MAY RESULT IN CORROSIVE DAMAGE TO THE SUBFRAME.HYUNDAI REDESIGNED THE SUB-FRAME EARLY IN THE MY 2004 PRODUCTION (NOVEMBER 2003) TO ADDRESS PROBLEMS WITH PREMATURE CORROSION OF THE CROSSMEMBER NEAR THE RIGHT-FRONT SUSPENSION ATTACHMENT. ODI'S ANALYSIS OF BOTH COMPLAINT AND WARRANTY DATA FOR THE MY 1999 THROUGH 2002 SONATA VEHICLES SHOWS THAT THE FAILURE RATES ARE SIGNIFICANTLY HIGHER IN SALT BELT STATES, WHICH ACCOUNT FOR APPROXIMATELY 50 PERCENT OF VEHICLE SALES AND OVER 90 PERCENT OFCOMPLAINTS AND WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT (NOTE:FOR PURPOSES OF THIS INVESTIGATION THE SALT BELT INCLUDES CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN).ACCORDING TO HYUNDAI, THE ALLEGED DEFECT RESULTS IN A PROGRESSIVE LOSS OF STRUCTURAL INTEGRITY OF THE SUBFRAME AND THERE IS AMPLE OPPORTUNITY FOR THE PROBLEM TO BE DETECTED (BY INSPECTION, STEERING FEEL OR TIRE WEAR ANOMALIES) AND REPAIRED BEFORE IT REACHES A STATE WHERE A SAFETY RELATED INCIDENT MAY OCCUR.HYUNDAI IDENTIFIED 4 ALLEGATIONS OF VEHICLE DISABLEMENT AND 1 ALLEGATION OF A CRASH; WHERE THE LOWER CONTROL ARM BROKE FROM THE VEHICLE WHILE DRIVING AT 55 MPH AND THE DRIVER LOST CONTROL AND DROVE INTO A YARD.THERE WERE NO REPORTED INJURIES.ODI RECEIVED A SEPARATE ALLEGATION OF A CRASH, WHERE THE COMPLAINANT ALLEGED THAT WHILE DRIVING AROUND A SLIGHT CURVE AT 65 MPH ON A FREEWAY, THE VEHICLE SUB-FRAME FRACTURED AND THE DRIVER LOST CONTROL OF THE VEHICLE AND WENT OFF THE ROAD.AGAIN, NO INJURIES WERE REPORTED.APPROXIMATELY ONE-THIRD OF THE COMPLAINTS TO ODI ALLEGE THAT THE SUB-FRAME CORROSION RESULTED IN A LOSS OF CONTROL AND/OR A VEHICLE DISABLEMENT DUE TO WHEEL COLLAPSE OR SEPARATION.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-016) COVERING MY 1999 THROUGH EARLY-2004 HYUNDAI SONATA VEHICLES IN SALT-BELT STATES AND EQUIPPED WITH THE SUBJECT SUB-FRAME DESIGN TO FURTHER ASSESS THE FREQUENCY AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.Read more

PE, Closed , Model Year: 2002

TIRE VALVE STEM FAILURES

THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE), PE05-059, BASED ON NINE CONSUMER COMPLAINTS OF TIRE VALVE STEM FAILURES.THE ALLEGED VALVE STEM FAILURES OCCURRED ONLY AFTER TIRE REPLACEMENT FROM THE ORIGINAL EQUIPMENT (OE) TIRE (MICHELIN 205/65R15 ENERGY MXV4 PLUS) TO ... Read more

DP, Closed , Model Year: 1999

IMPROPER FRONTAL AIR BAG PERFORMANCE

HYUNDAI HAS RECEIVED 49 REPORTS FROM CUSTOMERS STATING THE FRONTAL AIR BAGS DID NOT DEPLOY IN A CRASH FOR THE SUBJECT VEHICLES.EXAMINATION OF SUPLIMENTAL INFORMATION PROVIDED TO ODI BY THE MANUFACTURER FOR THE REPORTED CASES IT APPEARED THAT THE NECESSARY AIR BAG DEPLOYMENT THRESHOLD WAS NOT MET.THE... Read more

PE, Closed , Model Year: 1989

PASS.RESTRAINT SYSTEM FAIL

There is no summary currently available

HYUNDAI SONATA - All Years Overview

Complete safety history for the HYUNDAI SONATA across all model years (1989, 2026).

141 Total Recalls

22,306 Total Complaints

10 Investigations

1,220 Reported Crashes

675 Reported Fires

28 Reported Deaths

HYUNDAI SONATA - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2026	1	2	View
2025	0	21	View
2024	1	74	View
2023	2	140	View
2022	3	142	View
2021	4	184	View
2020	4	275	View
2019 (current)	0	213
2018	1	553	View
2017	3	1,003	View
2016	6	998	View
2015	9	1,665	View
2014	7	1,081	View
2013	9	2,657	View
2012	8	2,280	View
2011	14	4,627	View
2010	2	415	View
2009	2	612	View
2008	5	554	View
2007	7	906	View
2006	11	1,422	View
2005	1	217	View
2004	1	288	View
2003	6	249	View
2002	7	407	View
2001	3	293	View
2000	4	378	View
1999	4	187	View
1998	1	68	View
1997	2	74	View
1996	1	37	View
1995	2	93	View
1994	1	7	View
1993	1	46	View
1992	1	43	View
1991	1	41	View
1990	3	25	View
1989	3	18	View
1987	0	4	View

Other HYUNDAI Models

Model	Recalls	Complaints
SANTA FE	153	9,962	View
ELANTRA	133	11,853	View
PALISADE	124	2,704	View
TUCSON	95	8,074	View
SONATA HYBRID	67	1,129	View
IONIQ 5	66	1,865	View
ACCENT	64	2,745	View
SANTA FE HYBRID	57	347	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2019 HYUNDAI SONATA

Complaint Statistics

Top Reported Components

NHTSA Safety Ratings, 2019 HYUNDAI SONATA

Safety Technology

EPA Fuel Economy, 2019 HYUNDAI SONATA

Technical Service Bulletins, 2019 HYUNDAI SONATA

Most Affected Components

NHTSA Safety Investigations, HYUNDAI SONATA

HYUNDAI SONATA - All Years Overview

HYUNDAI SONATA - Year by Year

Other HYUNDAI Models