2017 HYUNDAI SONATA

3 recalls, 995 complaints - 303 TSBs - 5/5 safety rating

EXTERIOR LIGHTING:TURN SIGNAL

Defect Description

Hyundai Motor America (Hyundai) is recalling certain 2015-2017 Sonata, 2016-2017 Sonata Hybrid, and Sonata Plug-In Hybrid vehicles. The Smart Junction Box (SJB) software logic may not properly interpret the signals received from the multifunction switch, which could cause the turn signal to activat... Read more

Consequence

A turn signal that activates in the opposite direction of what was intended by the driver increases the risk of a crash.

Remedy

Dealers will update the SJB software, free of charge. Owner notification letters were mailed November 19, 2021. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 210.

469,377 vehicles affected

Manufacturer: Hyundai Motor America

LATCHES/LOCKS/LINKAGES:TRUNK LID:LATCH

Defect Description

Hyundai Motor America (Hyundai) is recalling certain 2017-2018 Sonata, 2016-2018 Sonata Hybrid, 2018-2020 Accent, and 2016-2017 Azera vehicles. The trunk latch may become damaged, preventing the opening of the trunk from the inside. As such, these vehicles fail to comply with the requirements of F... Read more

Consequence

A person inside the trunk compartment may become trapped, increasing their risk of injury.

Remedy

Dealers will replace the trunk latch base, free of charge. Owner notification letters were mailed December 4, 2021. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 208.

348,158 vehicles affected

Manufacturer: Hyundai Motor America

AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

Defect Description

Hyundai Motor Company (Hyundai) is recalling certain model year 2017 Hyundai Elantra vehicles manufactured April 15, 2016, to September 13, 2016, and Sonata vehicles manufactured May 27, 2016 to September 16, 2016. In these vehicles, the end seal for the driver's frontal air bag inflator may not ha... Read more

Consequence

In the event of a crash, an air bag that does not inflate fully increases the risk of injury.

Remedy

Hyundai will notify owners, and dealers will replace the driver's frontal air bag module, free of charge. The recall began February 13, 2017. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 156.

110 vehicles affected

Manufacturer: Hyundai Motor America

Complaint Statistics

995 total complaints 49 crashes 14 fires 30 injuries

Top Reported Components

Component	Complaints
ENGINE	212
STEERING	145
UNKNOWN OR OTHER	101
ELECTRICAL SYSTEM	90
POWER TRAIN	73
SERVICE BRAKES	46
STRUCTURE:BODY	33
AIR BAGS	29
EXTERIOR LIGHTING	27
FUEL/PROPULSION SYSTEM	24

Incident date: Jun 25, 2026

My engine seemed to be consuming oil way to much I had to do a oil change at 61,000 recommend by tire plus but at 58,000 is when I had to change my oil I also noticed there is a buring smell and its also been leaking oil at times I went to get it checked out by a mechanic at tireplus but they also t... Read more

Incident date: Jun 25, 2026

Incident date: Jun 19, 2026

Driving home from work on [XXX] (not a safe location)when my car lost power and engine light began to flash. I pulled off to the side of road and called my dad. He came with a code reader and said there was a code P1326. He cleared the code and car drove normally again. 2 days later it began to run ... Read more

Incident date: Aug 29, 2025

High oil consumption, burning a quart of oil or more every 500 miles since bought used at Hyundai dealership.

Incident date: Sep 26, 2021

My 2017 Hyundai Sonata SE, equipped with the Theta II 2.4L GDI engine, is experiencing severe powertrain failures including rhythmic metallic engine knocking, catastrophic oil consumption, and un-commanded surges/jumping in speed while driving. These symptoms manifested following an unauthorized eng... Read more

Incident date: Sep 26, 2021

Incident date: May 11, 2026

The RED light is lit on the dashboard for the airbag. Unable to use steering wheel electronic features which helps with and was designed for hands free controls. I am unable to cycle through the electronic features or engage the cruise control due to the steering wheel electronics are in-op. Please ... Read more

Incident date: May 11, 2026

The horn isn’t making any noise at all. There were no warning lamps or messages, I didn’t know until I needed to use my horn.

Incident date: May 11, 2026

The contact owns a 2022 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair... Read more

Incident date: May 27, 2026

Rough idle started at 11,400 miles. Took to GMC dealer near me and had thrust bearing clearance measured. Measured .0054"(within spec). They released truck back to me. 19,400 mile oil change found large metal(non magnetic) slivers in the filter media. I cut filters to check for issues due to known ... Read more

Incident date: May 27, 2026

Car was charging normally and all of a sudden it stopped charging both level 2 and DC. No warning nothing and seems like a common occurrence in this car and after warranty is over. Have ready many have this happen to them. Shop says that it’s the OBC needs to be replaced which isn’t a cheap repl... Read more

Incident date: Apr 11, 2026

Supplemental Information to Existing NHTSA Complaint involving a 2017 Hyundai Sonata Plug-in Hybrid (VIN: [XXX] ) While traveling at approximately 70 MPH on a heavily traveled highway, the vehicle suddenly and completely lost propulsion without warning. The vehicle rapidly decelerated in traffic, c... Read more

Incident date: Apr 11, 2026

Vehicle stalled during routine driving. Code P129F. I was stranded in 95 degree weather with three small children. Please correct and advise ASAP. Had to be towed home. Vehicle inoperable.

Incident date: Apr 11, 2026

There is a recall for the HAVOC system foe the years 2021-2023, 25V649 recall. My car is a 2019 kia sorento and I m having the same issues, I have already replaced blower motor, resistor, air filter replaced, fuses, air compressor clutch relays, 3 times. Coolant is fine. After reading this recall m... Read more

Incident date: May 14, 2026

High voltage battery pack, Power Inverter Module (PIM), and HV charging system. PIM replaced twice (p/n 68381781AD, 8/4/25 and 8/18/25) after being found melted with arcing damage at HV connections. Battery pack has active BPCM fault codes and a recorded cell voltage excursion. Vehicle available for... Read more

Incident date: May 14, 2026

Incident date: Apr 27, 2026

While driving the stereo went off, the ac, the car stopped in middle of the road and I lost all electrical. I tried turning back on and the emergency brake light was on and the dash said "Steering Assist is Reduced, Drive with Care.” I was able to put it in neutral and get it out of the way. Ba... Read more

Incident date: May 5, 2026

I have a Hyundai Sonata 2017 one year after I bought the car I started having acceleration problems. I have had the throttle changed and the valve gasket cover repaired. On April 15, 2026 the check engine light came on. On April 29th I got theta 2 emissions update installed at Hyundai Auburn, Al. I ... Read more

Incident date: May 5, 2026

The contact owns a 2013 Kia Sorento. The contact stated that while driving, a sound of an explosion was heard and the sunroof shattered, the slider of the sunroof was closed so the glass did not enter the vehicle. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the ... Read more

Incident date: Apr 5, 2026

My car has been in and out of the shop since 2024 due to the power train system. As this is an active recall case my car was repaired 5 times. Recently, with the recall part replaced in January 2026, I got my car back and in May 2026 while driving, my car once again loss power. Going from 50 to coas... Read more

Incident date: May 4, 2026

I Purchased a 2022 Nissan Altima from Drive Time with 90,000 miles on it. I would have had this car for 2 years this month in May. The Car Currently has about 122,587 Miles on it and has Transmission CVT Failure. I notice pulling, not being able to Accelerate while car was in motion, and while car... Read more

Incident date: Apr 24, 2026

[XXX] [XXX] [XXX] [XXX] VIA CERTIFIED MAIL – RETURN RECEIPT REQUESTED U.S. Department of Transportation National Highway Traffic Safety Administration (NHTSA) Vehicle Safety Compliance Division (NVS-210) 1200 New Jersey Avenue SE Washington, DC 20590 Wednesday, May 6, 2026 RE: SAFETY DEFECT CO... Read more

Incident date: May 2, 2026

NHTSA Complaint SummaryVehicle: 2017 Ford Escape SEEngine: 1.5L EcoBoostVIN: [XXX] Defect: Engine Block Design Flaw / Coolant IntrusionTechnical Description of the Issue:My vehicle is experiencing a well-documented manufacturing defect specific to the 1.5L EcoBoost engine. The engine block was desi... Read more

Incident date: Dec 30, 2025

Factory window tint of the back window & the driver/passenger side(s) windows are bubbling and peeling causing visual impairment while operating motor vehicle. Examples of impairment are backing the vehicle and changing lanes & these affected areas are blurry. Panaramic Sunroof does not seal proper... Read more

Incident date: Mar 17, 2026

2024 Mercedes-Benz Sprinter 2500 experienced unusually rapid brake, tire, and battery wear at low mileage. Front brakes required replacement at approximately 29,000 miles. Rear brakes were already worn low by approximately 37,000 miles. Rear tires required replacement by approximately 37,000 miles. ... Read more

Incident date: Apr 17, 2026

When using the cruise control or self driving function the car will, unprovoked, brake suddenly and severely. Hitting the acceleration pedal will disengage the cruise control or self driving and will stop the deceleration. The error happens about 1-2 times per 20 miles. I do not use these features o... Read more

Incident date: Jul 23, 2022

We have replaced the battery twice and likely will need a third battery soon. I have learned that there is a known issue with the DCM trying to connect using 3G. This is causing a parasitic drain on the battery. The vehicle will fail to start. This has occurred many times over the last few years. W... Read more

Incident date: Mar 19, 2022

Cracked windshield out of nowhere, starts from the bottom passenger side.

Incident date: Mar 20, 2026

I currently have a complaint 11709255 regarding the electric thermostat. I just had that part replaced in November of 2025 for the 3rd time. Last week, again I had a warning of engine problem. The next day there was cold air blowing when the heat was on. The dash thermostat immediately began to mov... Read more

Incident date: Oct 1, 2023

The contact owns a 2024 Kenworth T680. The contact stated that while operating the vehicle and pressing the wiper fluid button, the wiper fluid did not immediately spray, and the contact was unable to immediately clean the front windshield. The contact stated that after several attempts, the wiper f... Read more

Incident date: Dec 1, 2025

Issue type: 1.) Electrical system / hybrid battery 2.) Safety recall with no remedy My 2024 Jeep Wrangler 4xe currently has open safety recalls (78C and A7C) with no available remedy. These recalls have been open for several months. I have been advised that the vehicle may pose a safety risk, yet I... Read more

Incident date: Feb 22, 2026

1. My car began to produce white smoke after a burning smell. Then caught fire under the hood in engine area. The car is buried in snow/ice, not available to access. 2. The car caught fire. 3. The problem has not been reproduced nor confirmed by anyone (dealer/independent service center) 4. No, ... Read more

Fire

Incident date: Mar 13, 2024

Experiencing a failed Electronic Steering Lock (ESL). Car won’t crank or start even after verifying battery health and key fob. Symptoms point to a failed ESL, left stranded

Incident date: Feb 17, 2026

The contact owns a 2021 Chevrolet Tahoe. The contact stated that while driving approximately 25 MPH, the accelerator pedal was depressed, and the vehicle started losing motive power. There was no warning light illuminated. The vehicle stalled and was unable to be restarted. The vehicle was towed to ... Read more

Incident date: Feb 17, 2026

While driving at night all error light showed up. I slowed down to the side of the road and while I was slowing down the engine died. I tried to start the car which worked but when I pressed the gas the engine died again. Tried it two more times with the same results. Then turned the car and waited ... Read more

Incident date: Feb 11, 2026

Safety Complaint – Sudden Oil Loss and Engine Failure – 2014 Chevy Equinox Hello, I am reporting a serious safety issue involving my 2014 Chevrolet Equinox with the 2.4L Ecotec engine. My vehicle began consuming oil at an abnormal rate without any dashboard warnings in early 2025. The oil le... Read more

Incident date: Feb 8, 2026

Incident date: Feb 6, 2026

The vehicle was returned to me after a manufacturer-authorized high-voltage battery replacement that was completed on December 10, 2025. Immediately after pickup, the vehicle began exhibiting safety-related issues. I experienced abnormal and hard steering operation, repeated low coolant warnings, a... Read more

Incident date: Feb 6, 2026

The contact owns a 2018 Honda Odyssey. The contact stated that while reversing, the back over prevention camera screen failed to display an image. The contact stated that the screen occasionally shut off unintendedly, and frequently disconnected from connected Bluetooth devices. The dealer was notif... Read more

Incident date: Nov 30, 2024

The vehicle often displays a code related to Electrical system failure, automatic emergency braking failure, and brake failure. The brakes have failed during low-speed backing The dealership has not diagnosed the issue

Incident date: Feb 6, 2026

Incident date: Jan 2, 2025

While driving, multiple safety systems suddenly failed at the same time including Adaptive Cruise Control, Lane Keeping Assist, Collision Mitigation Braking System, Road Departure Mitigation, and Auto High Beam. All warning lights appeared simultaneously. The vehicle became unsafe to drive relying o... Read more

Incident date: Feb 3, 2026

Rear latch unlocks while vehicle is running or not running up to 30 times at once. Rear latch unlocks without key being in vehicle. This has been reported to Hyundai Motor America since August 2025. The front collision warning goes off at random times, left side departure goes off at random times.

Incident date: Aug 19, 2025

Rear Window exploded while vehicle parked.

Incident date: Jan 15, 2026

Component that failed: The valve train system failed due to collapsed lifters in the GM 5.3L L84 engine. The lifter failure caused internal camshaft damage requiring major repair. The failed components were removed by the Chevrolet dealership and should be available through the repair facility if in... Read more

Incident date: Jan 15, 2026

2017 2.7L F150 6 speed transmission. After an hour of drive time transmission vehicle got stuck between 3rd and 5th. If continued to drive it would go into “limp mode” stuck in 3rd gear and unable to accelerate. On my way home this occurred at 70mph on the highway and the truck downshifted and c... Read more

Showing 50 of 995 complaints.

NHTSA Safety Ratings, 2017 HYUNDAI SONATA

2017 Hyundai Sonata 4 DR FWD

Category	Rating
Overall Rating	5 / 5 ★★★★★
Frontal Crash	5 / 5 ★★★★★
Frontal Crash, Driver	5 / 5 ★★★★★
Frontal Crash, Passenger	5 / 5 ★★★★★
Side Crash	5 / 5 ★★★★★
Side Crash, Driver	5 / 5 ★★★★★
Side Crash, Passenger	5 / 5 ★★★★★
Rollover	4 / 5 ★★★★☆
Rollover Risk	10.5%

Safety Technology

Feature	Status
Electronic Stability Control	Standard
Forward Collision Warning	Optional
Lane Departure Warning	Optional

Source: NHTSA 5-Star Safety Ratings Program. Ratings are based on crash tests conducted by the National Highway Traffic Safety Administration.

EPA Fuel Economy, 2017 HYUNDAI SONATA

Trim / Engine	City MPG	Highway MPG	Combined MPG	Fuel Type	Annual Fuel Cost
2.4L 4-cyl, Automatic (S6) (Front-Wheel Drive)	25.0	36.0	29.0	Regular	$2,150
1.6L 4-cyl, Automatic (AM7) (Front-Wheel Drive)	28.0	36.0	31.0	Regular	$2,000
2.0L 4-cyl, Automatic (S6) (Front-Wheel Drive)	22.0	31.0	26.0	Regular	$2,400

CO2 Emissions: 307.0 g/mile (Large Cars)

Source: U.S. Environmental Protection Agency (EPA). Actual fuel economy may vary based on driving conditions.

Technical Service Bulletins, 2017 HYUNDAI SONATA

303 manufacturer communications from 165 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
060000 ENGINE AND ENGINE COOLING	39
110000 ELECTRICAL SYSTEM	37
350000 EQUIPMENT	35
100000 POWER TRAIN	21
060000 ENGINE (PWS)	20
356000 EQUIPMENT ADAPTIVE/MOBILITY	20
118000 ELECTRICAL SYSTEM:SOFTWARE	18
010000 STEERING	13

100000 POWER TRAIN

This TSB provides a procedure to diagnose and replace, if necessary, an automatic transmission with Incorrect Ratio DTC (transmission clutch slip in gear above limit) listed on Page 2.

130000 VISIBILITY/WIPER (PWS)

This bulletin contains information about the proper removal of the windshield wiper blade protective cover on all models. If the protective cover is not removed correctly, there is a possibility of the rubber insert and rail spring becoming

130000 VISIBILITY

116300 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993), combined with an anti-theft steering wheel lock campaign (Campaign P32), and anti-theft ignition cylinder protector campaign (Campaign 9A5) in res

110000 ELECTRICAL SYSTEM

353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

110000 ELECTRICAL SYSTEM

353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

This bulletin provides the service procedure to: 1) Upgrade the IBU/BCM (Integrated Body Control Unit/Body Control Module) to revise the OEM Hyundai burglar alarm system operation and ignition start logic and 2) Install two anti-theft decal

110000 ELECTRICAL SYSTEM

116300 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993), combined with an anti-theft steering wheel lock campaign (Campaign P32), in response to an increase in thefts of certain 2011-2022MY Hyundai vehic

110000 ELECTRICAL SYSTEM

116320 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:SENSOR

Certain Hyundai vehicles may not be equipped with an immobilizer. This bulletin provides the service procedure to update the IBU/BCM (Integrated Body Control Unit/Body Control Module), to revise the OEM Hyundai burglar alarm system operati

110000 ELECTRICAL SYSTEM

116300 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

110000 ELECTRICAL SYSTEM

060000 ENGINE AND ENGINE COOLING

This bulletin provides important checkpoint guidelines when performing engine oil and filter change services.

110000 ELECTRICAL SYSTEM

100000 POWER TRAIN

110000 ELECTRICAL SYSTEM

Some models from service campaign 993 (IBU/BCM Software Update and Decals Application) equipped with the Hyundai OEM remote start system may exhibit the horn honking when remote starting the vehicle after receiving the software update. Thi

353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

110000 ELECTRICAL SYSTEM

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

116320 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:SENSOR

110000 ELECTRICAL SYSTEM

061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)

Certain 2015-2019MY Sonata (LFA) vehicles may intermittently exhibit reduced engine power, a a??Crank/No Starta?? condition, and/or have DTC P1233 stored in the ECM due to an internally leaking fuel pump filter housing. For vehicles exhibit

060000 ENGINE AND ENGINE COOLING

116300 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

110000 ELECTRICAL SYSTEM

162000 STRUCTURE:BODY

Hyundai applies a Paint Protection Film (PPF) on new vehicles before delivery to dealerships. It provides a barrier between the paint and contaminants, such as rail dust, acid rain, and industrial fallout. In rare cases, the paint can becom

116320 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:SENSOR

110000 ELECTRICAL SYSTEM

116320 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:SENSOR

Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993) in response to an increase in thefts of certain Hyundai vehicles not equipped with engine immobilizers targeted through social media. In November 2

110000 ELECTRICAL SYSTEM

010000 STEERING

The warranty coverage for certain 2015-2017MY Sonata (LFa) and Sonata Hybrid/Plug-in (LF HEV/PHEV) vehicles exhibiting reduced power steering assist and/or motor driven power steering (MDPS) warning lamp has been extended to 15 years or 150

010000 STEERING

The warranty coverage for certain 2015-2017MY Sonata (LFa) and Sonata HEV/PHEV (LF HEV/PHEV) vehicles exhibiting reduced power steering assist and/or motor driven power steering (MDPS) warning lamp has been extended to 15 years or 150,000 m

133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

110000 ELECTRICAL SYSTEM

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

116320 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:SENSOR

110000 ELECTRICAL SYSTEM

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

110000 ELECTRICAL SYSTEM

061120 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER

Certain 2015-19MY Sonata (LFA) vehicles equipped with 2.0L Turbo GDI engines need the Electronic Control Module (ECM) software updated to revise the fuel injection control logic to compensate for oxygen sensor aging and control tailpipe emi

060000 ENGINE AND ENGINE COOLING

This bulletin provides information related to an Electronic Control Module (ECM) software update to revise the fuel injection control logic to compensate for O2 sensor aging and control tailpipe emissions within applicable standards.

110000 ELECTRICAL SYSTEM

130000 VISIBILITY

This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside th

160000 STRUCTURE

Certain 2017-2018MY Elantra (ADa), Sonata (LFa), and Santa Fe Sport (AN) vehicles manufactured by Hyundai Motor Manufacturing Alabama (a??HMMAa??) may exhibit peeling or bubbling of the white paint in various areas of the vehicle, most comm

160000 STRUCTURE

060000 ENGINE AND ENGINE COOLING

Follow the guidelines outlined in this bulletin to inspect and clean or replace certain components of the engine intake system accordingly during engine short block or sub-assembly replacement.

190000 TIRES

Effective June 2, 2008, Federal Motor Vehicle Safety Standard 110 (FMVSS 110) established a threshold for correcting load carrying capacity information indicated on tire placards when vehicle weight has been increased before retail sale

010000 STEERING

Certain vehicles may develop a bearing noise within the Motor Driven Power Steering (MDPS) column worm shaft assembly. If bearing noise is heard, follow the procedure in this bulletin to replace the worm shaft bearing.

350000 EQUIPMENT

Certain vehicles (listed below) equipped with 7-speed Double Clutch Transmissions (DCT) may exhibit abnormal vibration at low speeds. This bulletin outlines the procedures for diagnosing clutch judder, updating the Transmission Control Unit

100000 POWER TRAIN

060000 ENGINE AND ENGINE COOLING

The warranty coverage for engine long block repair or replacement regarding engine damage or malfunction from connecting rod bearing wear has been extended to 10 years or 120,000 miles from the date of original retail delivery or date of fi

060000 ENGINE AND ENGINE COOLING

The warranty coverage for engine long block repair or replacement regarding engine damage or malfunction from connecting rod bearing wear has been extended to a Limited Lifetime Warranty and is valid for original and subsequent owners.

060000 ENGINE AND ENGINE COOLING

Applicable vehicles with 2.0L T-GDI and 2.4L GDI engines may experience the Check Engine warning lamp illuminated with DTC P1326 and/or engine may exhibit Abnormal Noise or No Crank/No Start condition. Follow the procedure to inspect the ve

060000 ENGINE AND ENGINE COOLING

Certain vehicles with 2.0L T-GDI and 2.4L GDI engines may experience the Check Engine warning lamp illuminated with DTC P1326 and/or engine may exhibit abnormal noise or no crank/no start condition related to connecting rod bearing wear or

010000 STEERING

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This bulletin provides additional service diagnostic information and repair procedures related to Electric Waste Gate Actuator (EWGA) equipped vehicles listed below. Refer to the applicable Engine Control / Fuel System sections in the Shop

060000 ENGINE AND ENGINE COOLING

350000 EQUIPMENT

060000 ENGINE AND ENGINE COOLING

The warranty coverage for certain Theta II engine long block repair or replacement regarding engine damage or malfunction from connecting rod bearing wear has been extended to a Limited Lifetime Warranty and is valid for original and subseq

350000 EQUIPMENT

060000 ENGINE AND ENGINE COOLING

015000 STEERING:HYDRAULIC POWER ASSIST SYSTEM

010000 STEERING

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

118000 ELECTRICAL SYSTEM:SOFTWARE

When asked to provide the Modem Information, the Universal Subscriber Identity Module (USIM) may not be available. This TSB# 21-01-080H describes the 3-part software to correct this condition and activate Blue Link Services.

110000 ELECTRICAL SYSTEM

When asked to provide the Modem Information, the Universal Subscriber Identity Module (USIM) information is not available. This bulletin describes the 3-part Software to correct this condition and activate Blue Link Services.

060000 ENGINE AND ENGINE COOLING

Hyundai has launched a Service Campaign for applicable vehicles with 2.0L Turbo and 2.4L GDI engines that may experience the Check Engine warning lamp illuminated with DTC P1326.

060000 ENGINE AND ENGINE COOLING

010000 STEERING

103110 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE:SOFTWARE

100000 POWER TRAIN

060000 ENGINE AND ENGINE COOLING

This bulletin provides additional service diagnostic information and repair procedures related to Variable Charge Motion Controllers (VCM) equipped in the applicable vehicles listed below. This bulletin also provides information on the use

350000 EQUIPMENT

This bulletin provides the service procedure for engine connecting rod bearing clearance testing. Perform the procedure outlined in this bulletin to fulfill the Bearing Clearance Test inspection requirements to determine next required steps

060000 ENGINE AND ENGINE COOLING

030000 BRAKES (PWS)

This bulletin provides best practice recommendations when performing brake service procedures.

356000 EQUIPMENT ADAPTIVE/MOBILITY

This bulletin provides best practice recommendations when performing brake service procedures.

350000 EQUIPMENT

This bulletin provides best practice recommendations when performing brake service procedures.

060000 ENGINE AND ENGINE COOLING

This bulletin provides the inspection procedure and repair guidelines for certain vehicles listed below.

350000 EQUIPMENT

This bulletin provides the inspection procedure and repair guidelines for certain vehicles listed below.

010000 STEERING

The rack-mounted dual pinion Motor Driven Power Steering (MDPS) system components can be replaced separately from the complete assembly. This bulletin provides information on the separate components and the replacement procedure of these co

060000 ENGINE AND ENGINE COOLING

The warranty coverage for the engine long block for engine repairs or replacement related to connecting rod bearing damage as described in Campaign T3G (Seized and/or BCT No Pass Result Only) has been extended to 10 years or 120,000 miles f

060000 ENGINE AND ENGINE COOLING

Applicable vehicles with 2.0L Turbo and 2.4L GDI engines may experience the Check Engine warning lamp illuminated with DTC P1326. Follow the procedure to inspect the vehicle and replace the engine or update the engine ECU software based on

061120 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER

060000 ENGINE AND ENGINE COOLING

350000 EQUIPMENT

118000 ELECTRICAL SYSTEM:SOFTWARE

030000 BRAKES (PWS)

This bulletin describes the procedure to inspect and identify fluid which may appear around the brake caliper area.

Showing 100 of 303 bulletins.

NHTSA Safety Investigations, HYUNDAI SONATA

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 2011

Air bags may be disabled during crash

The Office of Defects Investigation (ODI) opened PE18-003 on 3/16/18 to investigate incidents involving crashes, resulting in significant collision related damage, where the frontal airbags failed to deploy. ODI reviewed complaint data, available design, test, and field data on the model year (MY) 2... Read more

PE, Closed , Model Year: 2013

Front Passenger Seat Belt Anchor Failure

The Office of Defects Investigation (ODI) opened this investigation on December 27, 2016 based on two ODI consumer complaints reporting a failure of the front passenger seat belt to remain connected to the seat belt anchor and pre-tensioner during a crash.On March 8, 2017 Hyundai Motor America (Hyun... Read more

PE, Closed , Model Year: 2016

Electronic Parking Brake

The Office of Defects Investigation opened this investigation on September 3, 2016 based on four reports alleging the rear brakes locked or applied while driving without brake pedal application. One of the reports alleged a fire in the right rear wheel area.The vehicles subject to the investigation ... are equipped with an optional Electronic Parking Brake (EPB). In this system, an electric motor applies the parking brake by moving the rear brake pads (pads) against the brake rotors (rotors) when activated by the EPB control switch. The EPB is released by the control switch or by selecting a drive gear with the transmission shifter when the ignition is on.If the EPB has not been used within 1000 kilometers (621 miles) the system is designed to perform an Automatic Adjustment Function (AAF) of the pads to check for proper clearance. This function is a pad adjustment only and is preformed with the vehicle in park with the ignition off. It does not set the parking brake or turn the brake indicator light on. Hyundai has identified an error within the EPB control logic that can cause the pads to remain in contact with the rotors at various levels of force after the AAF is completed. This condition could cause the rear brakes to drag at the next drive cycle and may generate some levels of heat and smoke. The EPB control logic error affects model year 2016 vehicles produced from the start of production through March 16, 2016.Vehicles produced from March 17, 2016 incorporate an updated EPB control logic to prevent brake pad drag. On May 11, 2016 Hyundai notified its dealer network of Service Campaign TFF to update the EPB control logic in the affected vehicle population. Dealers will reflash the EPB software to prevent brake pad drag.There are no reports of accidents or injuries as a result of this issue. The incident that alleged fire could not be confirmed as there were no repairs to the vehicle other than replacement of the rear brake rotors and pads.ODI is closing this investigation based on the manufacturer's Service Campaign of the affected vehicles and in consideration that the the effect of brake drag in this instance does not appear to present an unreasonable risk to motor vehicle safety. The ODI reports cited above can be viewed at www-odi.nhtsa/complaints under the following identification (ODI)numbers: 10820359, 10854476, 10875764, 10892736, and 10928478Read more

PE, Closed , Model Year: 2006

Seat Belt Buckle Electrical Malfunction

On July 22, 2014 the Office of Defects Investigation (ODI) opened a preliminary evaluation to further analyze allegations of seat belt pretensioner malfunctions on model year (MY) 2006-2008 Hyundai Sonata vehicles.ODI received 131 unique reports alleging a failure within the seat belt pretensioner s... ystem, which was typically preceded by SRS light illumination.ODI requested more information from Hyundai in order to understand the nature of the failure and how the airbag deployment algorithm, the seat belt pretensioners, and/or the airbag function may be affected. In response to ODI?s information request (IR), Hyundai submitted 764 unique consumer and field reports and 19,847 warranty claims related to a failure in the front seat belt buckle assembly potentially causing a malfunction of the seat belt pretensioners.In it's response, Hyundai advised that if the resistance specifications for the seat belt buckle pretensioner circuit, located in the seat belt stalk, exceed the nominal range, a diagnostic trouble code will be set and the SRS warning indicator lamp will illuminate.The presence of this stored code will not affect the ability of the SRS Control Module (SRSCM) to detect a collision and command deployment of the pretensioners and airbags, if warranted.In fact, the wiring harness connector may be unplugged from the seat belt buckle pretensioner, and the signal to deploy the pretensioner will still be commanded and recorded.MY 2006-2008 Sonata?s utilize a dual pretensioner system by incorporating pretensioners into both the driver and front passenger seat belt retractor and the seat belt buckle assembly.The retractor pretensioner is located inside the B-pillar and winds (pretensions) the seat belt webbing back into the retractor housing during a collision, helping to remove seat belt slack and restrain the upper torso and hips.In contrast, the buckle pretensioner is located within the stalk of the seat belt assembly and acts to supplement lower limb protection.Both pretensioners are controlled by the SRSCM but utilize separate wiring and connectors.The seat belt retractor pretensioner circuitry and operation is independent of the seat belt buckle pretensioner connector and circuitry.Hyundai produced analysis indicating that increased resistance in the seat belt pretensioner which occurs in vehicle service does not result in a loss of buckle pretensioner.Hyundai further advised that in the unlikely event that a seat belt buckle pretensioner may not deploy due to increased resistance, the retractor pretensioner would still activate.Hyundai advised that the subject vehicles maintain their 5 STAR NHTSA safety rating using the retractor based pretensioner only.ODI notes that MY 2009-10 Sonatas reverted back to a single pretensioner system, and do not utilize seat belt buckle pretensioners. Hyundai advised its intention to initiate a warranty extension program to address concerns with the seat belt buckle prentensioner faults in MY 2006-2008 Hyundai Sonata vehicles.This action will extend the warranty coverage for this issue for 15 years or 250,000 miles, whichever occurs first.Given Hyundai's action and the minimal safety consequence this issue presents, further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor the issue and reserves the right to take further action if warranted by the circumstances. The ODI complaints cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, seRead more

PE, Closed , Model Year: 2011

Steering Shaft Separation

The Office of Defects Investigation (ODI) is aware of 7 complaints and field reports and 10 warranty claims on the subject vehicles that allege the intermediate steering shaft became loose or in some cases separated from the upper steering column and/or the steering gearbox, causing (or potentially ... Read more

PE, Closed , Model Year: 2002

INTERIOR DOOR HANDLE LACERATION HAZARD

THE MANUFACTURER HAS ISSUED A SAFETY RECALL NOTIFICATION AS A RESULT OF THIS INVESTIGATION.THE RECALL AFFECTS 91,202 MY 2002-2003 SUBJECT VEHICLES PRODUCED FROM JANUARY 28, 2002, THROUGH MARCH 22, 2003.THE VEHICLE RECALL POPULATION WAS DEFINED BY THE MANUFACTURER'S USE OF A NEW SUPPLIER FOR THE CHRO... Read more

PE, Closed , Model Year: 1999

FRONT SUB-FRAME CORROSION

THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION, PE08-029, ON APRIL 22, 2008, BASED ON 40 CONSUMER COMPLAINTS ALLEGING FRONT SUB-FRAME CORROSION IN MODEL YEAR (MY) 1999 THROUGH 2002 HYUNDAI SONATA VEHICLES.COMPLAINTS DESCRIBE SEVERE CORROSION OF THE VEHICLE SUB-FRAME IN THE A... REA WHERE THE RIGHT-FRONT LOWER CONTROL ARM IS ATTACHED.IN SOME VEHICLES, SUB-FRAME CORROSION HAS CAUSED COMPLETE OR PARTIAL DETACHMENT OF THE CONTROL ARM, RESULTING IN WHEEL COLLAPSE OR SEPARATION. IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER FOR PE08-029, HYUNDAI PROVIDED OWNER COMPLAINTS, FIELD REPORTS, AND WARRANTY CLAIM DATA FOR APPROXIMATELY 197,906 MY 1999 THROUGH 2002 SUBJECT VEHICLES SOLD OR LEASED IN THE UNITED STATES.THE BASE WARRANTY FOR THE SUBJECT VEHICLES IS 60 MONTHS OR 60,000 MILES, WHICHEVER OCCURS FIRST.ACCORDING TO HYUNDAI, PROLONGED EXPOSURE TO THE ROAD SALTS MAY RESULT IN CORROSIVE DAMAGE TO THE SUBFRAME.HYUNDAI REDESIGNED THE SUB-FRAME EARLY IN THE MY 2004 PRODUCTION (NOVEMBER 2003) TO ADDRESS PROBLEMS WITH PREMATURE CORROSION OF THE CROSSMEMBER NEAR THE RIGHT-FRONT SUSPENSION ATTACHMENT. ODI'S ANALYSIS OF BOTH COMPLAINT AND WARRANTY DATA FOR THE MY 1999 THROUGH 2002 SONATA VEHICLES SHOWS THAT THE FAILURE RATES ARE SIGNIFICANTLY HIGHER IN SALT BELT STATES, WHICH ACCOUNT FOR APPROXIMATELY 50 PERCENT OF VEHICLE SALES AND OVER 90 PERCENT OFCOMPLAINTS AND WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT (NOTE:FOR PURPOSES OF THIS INVESTIGATION THE SALT BELT INCLUDES CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN).ACCORDING TO HYUNDAI, THE ALLEGED DEFECT RESULTS IN A PROGRESSIVE LOSS OF STRUCTURAL INTEGRITY OF THE SUBFRAME AND THERE IS AMPLE OPPORTUNITY FOR THE PROBLEM TO BE DETECTED (BY INSPECTION, STEERING FEEL OR TIRE WEAR ANOMALIES) AND REPAIRED BEFORE IT REACHES A STATE WHERE A SAFETY RELATED INCIDENT MAY OCCUR.HYUNDAI IDENTIFIED 4 ALLEGATIONS OF VEHICLE DISABLEMENT AND 1 ALLEGATION OF A CRASH; WHERE THE LOWER CONTROL ARM BROKE FROM THE VEHICLE WHILE DRIVING AT 55 MPH AND THE DRIVER LOST CONTROL AND DROVE INTO A YARD.THERE WERE NO REPORTED INJURIES.ODI RECEIVED A SEPARATE ALLEGATION OF A CRASH, WHERE THE COMPLAINANT ALLEGED THAT WHILE DRIVING AROUND A SLIGHT CURVE AT 65 MPH ON A FREEWAY, THE VEHICLE SUB-FRAME FRACTURED AND THE DRIVER LOST CONTROL OF THE VEHICLE AND WENT OFF THE ROAD.AGAIN, NO INJURIES WERE REPORTED.APPROXIMATELY ONE-THIRD OF THE COMPLAINTS TO ODI ALLEGE THAT THE SUB-FRAME CORROSION RESULTED IN A LOSS OF CONTROL AND/OR A VEHICLE DISABLEMENT DUE TO WHEEL COLLAPSE OR SEPARATION.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-016) COVERING MY 1999 THROUGH EARLY-2004 HYUNDAI SONATA VEHICLES IN SALT-BELT STATES AND EQUIPPED WITH THE SUBJECT SUB-FRAME DESIGN TO FURTHER ASSESS THE FREQUENCY AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.Read more

PE, Closed , Model Year: 2002

TIRE VALVE STEM FAILURES

THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE), PE05-059, BASED ON NINE CONSUMER COMPLAINTS OF TIRE VALVE STEM FAILURES.THE ALLEGED VALVE STEM FAILURES OCCURRED ONLY AFTER TIRE REPLACEMENT FROM THE ORIGINAL EQUIPMENT (OE) TIRE (MICHELIN 205/65R15 ENERGY MXV4 PLUS) TO ... Read more

DP, Closed , Model Year: 1999

IMPROPER FRONTAL AIR BAG PERFORMANCE

HYUNDAI HAS RECEIVED 49 REPORTS FROM CUSTOMERS STATING THE FRONTAL AIR BAGS DID NOT DEPLOY IN A CRASH FOR THE SUBJECT VEHICLES.EXAMINATION OF SUPLIMENTAL INFORMATION PROVIDED TO ODI BY THE MANUFACTURER FOR THE REPORTED CASES IT APPEARED THAT THE NECESSARY AIR BAG DEPLOYMENT THRESHOLD WAS NOT MET.THE... Read more

PE, Closed , Model Year: 1989

PASS.RESTRAINT SYSTEM FAIL

There is no summary currently available

HYUNDAI SONATA - All Years Overview

Complete safety history for the HYUNDAI SONATA across all model years (1989, 2026).

141 Total Recalls

22,165 Total Complaints

10 Investigations

1,201 Reported Crashes

681 Reported Fires

27 Reported Deaths

HYUNDAI SONATA - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2026	1	2	View
2025	0	20	View
2024	1	71	View
2023	2	136	View
2022	3	139	View
2021	4	170	View
2020	4	258	View
2019	0	206	View
2018	1	544	View
2017 (current)	3	995
2016	6	992	View
2015	9	1,642	View
2014	7	1,077	View
2013	9	2,641	View
2012	8	2,272	View
2011	14	4,609	View
2010	2	415	View
2009	2	612	View
2008	5	554	View
2007	7	906	View
2006	11	1,422	View
2005	1	217	View
2004	1	288	View
2003	6	249	View
2002	7	407	View
2001	3	293	View
2000	4	378	View
1999	4	187	View
1998	1	68	View
1997	2	74	View
1996	1	37	View
1995	2	93	View
1994	1	7	View
1993	1	46	View
1992	1	43	View
1991	1	41	View
1990	3	25	View
1989	3	18	View
1987	0	4	View

Other HYUNDAI Models

Model	Recalls	Complaints
SANTA FE	153	9,962	View
ELANTRA	133	11,853	View
PALISADE	124	2,704	View
TUCSON	95	8,074	View
SONATA HYBRID	67	1,129	View
IONIQ 5	66	1,865	View
ACCENT	64	2,745	View
SANTA FE HYBRID	57	347	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2017 HYUNDAI SONATA

Complaint Statistics

Top Reported Components

NHTSA Safety Ratings, 2017 HYUNDAI SONATA

Safety Technology

EPA Fuel Economy, 2017 HYUNDAI SONATA

Technical Service Bulletins, 2017 HYUNDAI SONATA

Most Affected Components

NHTSA Safety Investigations, HYUNDAI SONATA

HYUNDAI SONATA - All Years Overview

HYUNDAI SONATA - Year by Year

Other HYUNDAI Models