2001 HYUNDAI SONATA

3 recalls, 293 complaints - 105 TSBs

SUSPENSION

Defect Description

HYUNDAI IS RECALLING 188,282 MY 2001-2004 SONATA AND MY 2001-2004 XG300 AND XG350 VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, O... Read more

Consequence

IF THAT HAPPENS, THE VEHICLE MAY LOSE DRIVE POWER TO THE WHEELS, AND THE FRONT WHEEL MAY MAKE CONTACT WITH THE FENDER OR WHEEL WELL, THEREBY INCREASING THE RISK OF A CRASH.

Remedy

DEALERS WILL MEASURE THE THICKNESS OF THE FRONT SUB-FRAME AND INSPECT THE FRONT SUB-FRAME FOR CORROSION DAMAGE AND, IF NECESSARY, THE FRONT SUB-FRAME WILL BE REPLACED WITH A NEW SUB-FRAME THAT INCORPORATES ADDITIONAL HOLES IN THE UPPER AND LOWER PANELS. IF THE FRONT SUB-FRAME DOES NOT REQUIRE REPLA... Read more

188,282 vehicles affected

Manufacturer: Hyundai Motor Company

AIR BAGS:SIDE/WINDOW

Defect Description

ON CERTAIN PASSENGER VEHICLES, AN INTERMITTENT CONDITION THAT LEADS TO THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG WARNING LIGHT ILLUMINATION COULD RESULT FROM MOTION OF THE SIDE IMPACT AIR BAG WIRING HARNESS AND SIDE IMPACT AIR BAG WIRING HARNESS CONNECTOR WHICH MOUNT TO THE ADJUSTABLE SEAT CUS... Read more

Consequence

NON-DEPLOYMENT OF THE SRS SIDE IMPACT AIR BAG COULD INCREASE THE RISK OF INJURY DURING A SIDE IMPACT CRASH.

Remedy

DEALERS WILL MORE SECURELY FASTEN THE SIDE IMPACT AIR BAG WIRING HARNESSES AND CONNECTORS TO THE VEHICLE'S FRONT SEAT CUSHION FRAMES. OWNER NOTIFICATION BEGAN MAY 28, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WI... Read more

145,355 vehicles affected

Manufacturer: HYUNDAI MOTOR COMPANY

AIR BAGS

Defect Description

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG WARNING LIGHT COULD ILLUMINATE DUE TO MOTION OF THE SIDE IMPACT AIR BAG WIRING HARNESS AND SIDE IMPACT AIR BAG WIRING HARNESS CONNECTOR THAT MOUNT TO THE ADJUSTABLE SEAT CUSHION ASSEMBLY. THIS CONDITION ONLY... Read more

Consequence

THIS CONDITION COULD PREVENT SEAT MOUNTED SIDE IMPACT AIR BAG DEPLOYMENT DURING AN ACCIDENT WHERE SUCH DEPLOYMENT SHOULD OCCUR. NON-DEPLOYMENT OF THE SRS SIDE IMPACT AIR BAGS COULD INCREASE THE RISK OF INJURY DURING AN ACCIDENT WHERE SIDE IMPACT AIR BAG DEPLOYMENT IS INTENDED.

Remedy

DEALERS WILL MORE SECURELY FASTEN THE FRONT SEAT SIDE IMPACT AIR BAG WIRING HARNESS AND CONNECTORS TO THE VEHICLE'S FRONT SEAT CUSHION FRAMES. OWNER NOTIFICATION WILL OCCUR IN SIX MAILINGS ON MAY 27, JUNE 3, JUNE 10, JUNE 17, JUNE 24, AND JULY 1, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZ... Read more

86,513 vehicles affected

Manufacturer: HYUNDAI MOTOR COMPANY

Complaint Statistics

293 total complaints 34 crashes 30 injuries

Top Reported Components

Component	Complaints
STRUCTURE:FRAME AND MEMBERS	51
AIR BAGS	27
SUSPENSION	22
VEHICLE SPEED CONTROL	11
STEERING	9
POWER TRAIN:AUTOMATIC TRANSMISSION	9
STRUCTURE:BODY	9
AIR BAGS:FRONTAL	9
ENGINE AND ENGINE COOLING:ENGINE	9
ENGINE AND ENGINE COOLING	7

Incident date: Oct 1, 2021

Upper rear control arm is connected to the subframe of the car and it’s rotted/ rusted out where the bushing goes to hold the control arm in place. Where am I supposed to mount the bushing now since it’s no longer there.

Incident date: Oct 1, 2021

Incident date: Jan 30, 2019

RECENTLY I HAD A SITUATION WHERE I WAS DRIVING ON COUNTY ROAD WAY AND MY CAR SUDDENLY COLLAPSED AND CAME TO AN IMMEDIATE STOP. TO SAY THE LEAST, I WAS A LITTLE SHOOK UP. I GOT OUT THE CAR AND NOTICED THAT THE DRIVER SIDE WHEEL HAD LODGED AGAINST THE WHEEL WELL. THE CAR WOULD GO INTO GEAR BUT IT WAS ... Read more

Incident date: Jan 30, 2019

Incident date: Sep 25, 2018

I WAS DRIVING DOWN MY STREET WHEN THE DRIVERS CV AXLE POPPED OUT OF THE TRANSMISSION. I GOT THE VEHICLE TOWED HOME AND REMOVED THE WHEEL TO FIND THAT THE SUBFRAME WAS CORRODED COMPLETELY INTO. I KNOW THERE ARE RECALLS PERTAINING TO THIS EXACT ISSUE ON THIS TYPE OF CAR

Incident date: Sep 25, 2018

Incident date: Jul 22, 2018

CONTROL ARM COMPLETELY SEPARATED/ BROKE FROM THE SUBFRAME. CALLED HYUNDAI AS MECHANIC SAID THIS SHOULD HAVE BEEN INCLUDED UNDER A RECALL THAT CAME OUT SEVERAL YEARS AGO FOR "BECAUSE OF A POTENTIAL CORROSION RISK INVOLVING THE FRONT SUB-FRAME...CORROSION MAY PROGRESS AND THE FORWARD MOUNTING OF THE L... Read more

Incident date: Jul 22, 2018

Incident date: Jul 8, 2008

AIRBAG RED LIGHT COMES ON WHEN STARTING THE ENGINE. RESTRAINING STRAP IN REAR-LEFT SEAT DOES NOT ENGAGE.

Incident date: Jul 8, 2008

AIRBAG RED LIGHT COMES ON WHEN STARTING THE ENGINE. RESTRAINING STRAP IN REAR-LEFT SEAT DOES NOT ENGAGE.

Incident date: Jul 8, 2008

AIRBAG RED LIGHT COMES ON WHEN STARTING THE ENGINE. RESTRAINING STRAP IN REAR-LEFT SEAT DOES NOT ENGAGE.

Incident date: Feb 24, 2018

TL* THE CONTACT OWNS A 2001 HYUNDAI SONATA. WHILE THE VEHICLE WAS PARKED AND UNOCCUPIED, THE DRIVER'S SIDE AIR BAG DEPLOYED WITHOUT WARNING OR IMPACT. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACT... Read more

Incident date: Sep 4, 2017

TL* THE CONTACT OWNS A 2001 HYUNDAI SONATA. WHILE MAKING A RIGHT TURN, THERE WAS AN ABNORMAL NOISE COMING FROM THE FRONT PASSENGER SIDE TIRE. IT WAS DISCOVERED THAT THE CONTROL ARM HAD FRACTURED FROM THE FRAME, WHICH WAS CRUMBLING DUE TO RUST AND CORROSION. THE VEHICLE WAS TOWED TO AN INDEPENDENT ME... Read more

Incident date: Sep 4, 2017

Incident date: Feb 7, 2017

PASSENGER SENSOR RIGHT FRONT,SENSOR FOUND IT FAULTY,THIS SENSOR IS UNDER THE FABRIC OF SEAT.LIGHT IS ALL WAYS ON.

Incident date: Feb 7, 2017

PASSENGER SENSOR RIGHT FRONT,SENSOR FOUND IT FAULTY,THIS SENSOR IS UNDER THE FABRIC OF SEAT.LIGHT IS ALL WAYS ON.

Incident date: Jul 29, 2016

BAD FUEL VAPOR SMELL IN CABIN, NO CHECK ENG LIGHT ON. CHECKED ENG LIGHT AT AUTO ZONE ANYWAY, CODE SAID VAPOR VALVE GOING TO CANISTER/DUMP AFTER WARM UP. HYUNDAI BY PHONE SAID CANISTER NEEDED REPLACED($400+). I LIVE ON DISABILITY SSI, TOO EXPENSIVE. TOOK TO SMALL GARAGE, AFTER LIFTING, BOTTOM OF GAS ... Read more

Incident date: Aug 15, 2016

WAS INFORMED APPROXIMATELY 2006-2007 BY GOOD SAMARITAN, BILL OSTERHAGE, THAT HIS DAUGHTER'S 2002 HYUNDAI FRONT TIRE ROD AXIAL BROKE D/T MAJOR CORROSIVE ISSUES WITH FRAME DEFECTS. HE CONTACTED AN ATTORNEY FOR CLASS ACTION LAW SUIT TO BE STARTED D/T SAFETY ISSUES TO PREVENT DEATH TO OTHERS & REPAIR FR... Read more

Incident date: Aug 15, 2016

Incident date: May 31, 2016

MY SON WAS IN AN ACCIDENT IN WHICH SOMEONE PULLED OUT OF A SIDE ROAD INTO HIS PATH OF TRAVEL. THE FRONT OF THE HYUNDAI FROM JUST PAST THE GRILL ON DRIVER'S SIDE TO ENTIRE PASSENGER SIDE HIT THE FRONT DRIVER WHEEL FORWARD ON THE OTHER CAR. NEITHER THE STEERING WHEEL NOR THE PASSENGER SIDE AIRBAG DEPL... Read more

Crash

Incident date: Apr 26, 2016

MY CAR HAS A REAR RUST PROBLEM THAT HAS LEFT THE CAR UNDRIVEABLE. THE SUPPORT FOR THE WHEEL HAS RUSTED THROUGH AND THE REAR WHEELS ARE TILTING IN. I DID LOSE CONTROL OF THE CAR AS IT SWAYED FOR ONE SIDE OF THE ROAD TO THE OTHER LANE AND BACK. MY SPEED WAS ABOUT 45 MPH ON A TWO LANE ROAD WITH A SPEAD... Read more

Incident date: Aug 12, 2015

WHILE BACKING OUT OF MY DRIVEWAY BRAKE PEDDLE WENT TO THE FLOOR AND LEAKED OUT FLUID THROUGH A STEEL RUSTED BRAKE LINE ON DRIVER SIDE , I HAD THE STEEL LINE REPLACED, A MONTH LATER SAME INCIDENT THANK GOD IT HAPPENED AGAIN ONLY THE OPPOSITE SIDE THE BRAKE LINE LEAKED . IF THIS HAPPENED IN AN EMER... Read more

Incident date: Mar 19, 2015

TL* THE CONTACT OWNED A 2001 HYUNDAI SONATA. WHILE DRIVING AT 55 MPH, THE CONTACT LOST CONTROL OF THE VEHICLE AND CRASHED INTO A BRIDGE. THE CONTACT STATED THAT THE FRONT DRIVER SIDE AIR BAG FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT SUFFERED INJURIES TO THE HEAD, THUMB, KNEES, NECK, A... Read more

Crash 1 injured

Incident date: Jan 13, 2015

TL* THE CONTACT OWNS A 2001 HYUNDAI SONATA. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 09V124000 (SUSPENSION). THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER THE RECALL BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT... Read more

Incident date: Dec 13, 2014

MY CARS FRONT SUBFRAME BROKE DUE TO CORROSION AND AXLE FELL APART WHILE DRIVING. *TR

Incident date: Dec 13, 2014

MY CARS FRONT SUBFRAME BROKE DUE TO CORROSION AND AXLE FELL APART WHILE DRIVING. *TR

Incident date: Dec 13, 2014

MY CARS FRONT SUBFRAME BROKE DUE TO CORROSION AND AXLE FELL APART WHILE DRIVING. *TR

Incident date: Oct 1, 2014

TL* THE CONTACT OWNS A 2001 HYUNDAI SONATA. WHILE DRIVING APPROXIMATELY 30 MPH AND MAKING A LEFT TURN, ANOTHER VEHICLE CRASHED INTO THE FRONT OF THE CONTACT'S VEHICLE. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES REPORTED. THE VEHICLE WAS TOWED TO THE CONTACT'S... Read more

Crash

Incident date: Oct 20, 2014

TL* THE CONTACT OWNS A 2001 HYUNDAI SONATA. WHILE DRIVING APPROXIMATELY 35 MPH, AN ABNORMAL NOISE EMITTED FROM THE FRONT PASSENGER SIDE OF THE VEHICLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE FRONT AXLE AND THE FRONT SUBFRAME NEEDED TO BE REPLACED. THE VEH... Read more

Incident date: Oct 20, 2014

Incident date: Aug 20, 2014

TL* THE CONTACT OWNS A 2001 HYUNDAI SONATA. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO A DEALER AND WAS REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 02V105000 (AIR BAGS) BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE... Read more

Incident date: Jan 10, 2014

WHILE DRIVING THE CAR THE WHEEL AND ASSEMBLY BROKE FREE FROM THE FRAME OF THE CAR WHICH WAS COMPLETELY RUSTED AND DROPPED THE CAR TO THE GROUND PUSHED THE WHEEL ASSEMBLY WHEEL WELL. AFTER RESEARCHING THE MAKE AND MODEL THEIR IS A RECALL PERTAINING TO THIS ISSUE BUT ONLY APPLIES TO THE SALT BELT. MY ... Read more

Incident date: Jan 10, 2014

Incident date: Jul 5, 2011

AS I WAS DRIVING DOWN THE ROAD AT APPRX 30 MPH. THE CAR WOULD DE CELERATE. I WOULD HAVE TO TAKE MY FOOT OFF THE GAS AND THEN PUT BACK ON TO GET THE CAR TO MOVE. ALSO AT THE SAME TIME THE CAR WOULD BANG INTO GEAR FROM PARK AND INTO REVERSE. I WAS TOLD IT NEEDED A NEW TRANSMISSION. THE CAR WAS ... Read more

Incident date: Jul 5, 2011

Incident date: Nov 30, 2013

HYUNDAI SONATA 2011 PUSH BUTTON START. I AM THE ORIGINAL OWNER OF THE VEHICLE. YESTERDAY I WENT INTO MY CAR AND PROCEEDED TO START MY CAR. I HAD TO PUSH THE START BUTTON THREE TIMES BEFORE ACTUALLY STARTED UP. THIS HAPPENED TWICE WITHIN 2 HOURS. 5 DAYS PRIOR MY VEHICLE HAD BEEN TO THE HYUNDAI DEALE... Read more

Incident date: Nov 30, 2013

Incident date: Sep 21, 2013

I WAS TRYING TO AVOID AN ACCIDENT, AS I SWERVED THE CAR FISH TAILED. THE DRIVER SIDE REAR TIRE HIT THE CURB, AT WHICH POINT THE TIRE ACTUALLY BUCKLED UNDER THE CAR. I HAD TO HAVE THE CAR TOWED TO A SHOP. WHEN THE MECHANIC LOOKED AT THE CAR AT FIRST WE BELIEVED WE ONLY NEEDED THE REAR TIRE ASSEMBLY. ... Read more

Incident date: Sep 21, 2013

Incident date: Aug 30, 2013

I TOOK MY 2001 HYUNDAI SONATA GLS IN TO THE DEALERSHIP FOR A ROUTINE OIL CHANGE. THEY CALLED ME TO THE SERVICE DEPARTMENT TO TELL ME THAT THE CROSS MEMBER ON THE DRIVERS SIDE WAS RUSTED BADLY AND MAY BE CRACKED. THEY TOOK PICTURES AND CONTACTED HYUNDAI TO SEE IF THERE WERE ANY RECALLS FOR THIS PRO... Read more

Incident date: Aug 30, 2013

Incident date: Aug 7, 2013

I WAS DRIVING AND WITHIN 15 MINUTES MY HYUNDAI RIPPED THROUGH 2 TIRES. LUCKILY I FIGURED SOMETHING WAS UP AND WAS TAKING BACK ROADS WHEN THE SECOND TIME IT HAPPENED PARTS OF THE RUBBER FROM THE TIRES WERE IN THE ROAD. I HAD TO HAVE IT TOWED AND APPARENTLY THE CRADLE SUB FRAME WAS COMPLETELY RUSTE... Read more

Incident date: Aug 7, 2013

Showing 50 of 293 complaints.

EPA Fuel Economy, 2001 HYUNDAI SONATA

Trim / Engine	City MPG	Highway MPG	Combined MPG	Fuel Type	Annual Fuel Cost
2.4L 4-cyl, Automatic 4-spd (Front-Wheel Drive)	18.0	26.0	21.0	Regular	$2,950
2.4L 4-cyl, Manual 5-spd (Front-Wheel Drive)	19.0	27.0	22.0	Regular	$2,850
2.5L 6-cyl, Automatic 4-spd (Front-Wheel Drive)	18.0	25.0	20.0	Regular	$3,100
2.5L 6-cyl, Manual 5-spd (Front-Wheel Drive)	18.0	26.0	21.0	Regular	$2,950

CO2 Emissions: -1.0 g/mile (Midsize Cars)

Source: U.S. Environmental Protection Agency (EPA). Actual fuel economy may vary based on driving conditions.

Technical Service Bulletins, 2001 HYUNDAI SONATA

105 manufacturer communications from 82 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
103000 POWER TRAIN:AUTOMATIC TRANSMISSION	10
061000 ENGINE AND ENGINE COOLING:ENGINE	8
350000 EQUIPMENT	7
100000 POWER TRAIN	7
110000 ELECTRICAL SYSTEM	6
106000 POWER TRAIN:AXLE ASSEMBLY	5
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER	5
356000 EQUIPMENT ADAPTIVE/MOBILITY	5

130000 VISIBILITY

This bulletin contains information about the proper removal of the windshield wiper blade protective cover on all models. If the protective cover is not removed correctly, there is a possibility of the rubber insert and rail spring becoming

130000 VISIBILITY/WIPER (PWS)

060000 ENGINE AND ENGINE COOLING

This bulletin provides important checkpoint guidelines when performing engine oil and filter change services.

162000 STRUCTURE:BODY

Hyundai applies a Paint Protection Film (PPF) on new vehicles before delivery to dealerships. It provides a barrier between the paint and contaminants, such as rail dust, acid rain, and industrial fallout. In rare cases, the paint can becom

130000 VISIBILITY

This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside th

060000 ENGINE AND ENGINE COOLING

Follow the guidelines outlined in this bulletin to inspect and clean or replace certain components of the engine intake system accordingly during engine short block or sub-assembly replacement.

190000 TIRES

Effective June 2, 2008, Federal Motor Vehicle Safety Standard 110 (FMVSS 110) established a threshold for correcting load carrying capacity information indicated on tire placards when vehicle weight has been increased before retail sale

100000 POWER TRAIN

Hyundai approves only the ATF, DCT gear oil and IVT gear oil specified in the vehicle??A?A?s owner??A?A?s manual. ??A?A? Use of other ATF may result in improper shift quality or other drivability conditions. ??A?A? Use of other DCT and IV

060000 ENGINE AND ENGINE COOLING

This bulletin provides the service procedure for engine connecting rod bearing clearance testing. Perform the procedure outlined in this bulletin to fulfill the Bearing Clearance Test inspection requirements to determine next required steps

350000 EQUIPMENT

This bulletin provides best practice recommendations when performing brake service procedures.

356000 EQUIPMENT ADAPTIVE/MOBILITY

This bulletin provides best practice recommendations when performing brake service procedures.

030000 BRAKES (PWS)

This bulletin provides best practice recommendations when performing brake service procedures.

060000 ENGINE AND ENGINE COOLING

This bulletin provides the inspection procedure and repair guidelines for certain vehicles listed below.

350000 EQUIPMENT

This bulletin provides the inspection procedure and repair guidelines for certain vehicles listed below.

030000 BRAKES (PWS)

This bulletin describes the procedure to inspect and identify fluid which may appear around the brake caliper area.

190000 TIRES

This bulletin provides tire vibration service procedures, including how to optimize vehicle vibration performance. For all wheel/tire balance claims, the a??Tire Balance Data Sheeta?? must be fully completed including imbalance and Road For

200000 WHEELS

120000 EXTERIOR LIGHTING

This bulletin provides information regarding condensation related to moisture accumulation in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. The TSB illustrates the various causes of condensation inside the la

350000 EQUIPMENT

356000 EQUIPMENT ADAPTIVE/MOBILITY

190000 TIRES

This bulletin provides information on tire maintenance best practices and procedures for dealers and customers to maximize tire life and performance.

200000 WHEELS

This bulletin provides information on tire maintenance best practices and procedures for dealers and customers to maximize tire life and performance.

350000 EQUIPMENT

This bulletin describes the general guidelines to help disinfect and protect vehicle exterior/interior surfaces using recommended safe chemical products.

110000 ELECTRICAL SYSTEM

This bulletin provides information on identifying dealer stock vehicles with either: a?? A Battery SOC alert - low Battery State of Charge (SOC) at or below 50%. a?? A 30 Day alert - vehicle has not started and reported an SOC in 30 days.

350000 EQUIPMENT

100000 POWER TRAIN

The automatic transmission warranty repair policy authorizes in-dealership repairs of the following components for both OEM (new) and remanufactured automatic transmissions:

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

The automatic transmission warranty repair policy authorizes in-dealership repairs of the following components for both OEM (new) and remanufactured automatic transmissions:

356000 EQUIPMENT ADAPTIVE/MOBILITY

The automatic transmission warranty repair policy authorizes in-dealership repairs of the following components for both OEM (new) and remanufactured automatic transmissions:

356000 EQUIPMENT ADAPTIVE/MOBILITY

This bulletin describes the general guidelines to disinfect and protect vehicle interior surfaces using certain safe chemical products.

020000 SUSPENSION

This bulletin describes the requirements for all wheel alignment and/or vehicle tracking claims and best practices when diagnosing and conducting alignment-related repairs for all models and model years.

110000 ELECTRICAL SYSTEM

This bulletin provides guidelines to inspect the USB, head unit, and multi-box for common connection conditions. 2. This bulletin presents guidelines to inspect for common Android Auto and Apple CarPlay connection conditions. 3. This bullet

270000 LANE DEPARTURE

The Blind Spot Detection (BSD) or Blind-Spot Collision Warning (BCW) is a system that measures the speed of and distance from the following vehicles by using two magnetic wave radar sensors attached in the rear bumper. The BSD/BCW detects v

280000 BACK OVER PREVENTION

356000 EQUIPMENT ADAPTIVE/MOBILITY

This bulletin provides instruction detailing the proper methodology for scanning and uploading captured GDS data files to the Techline Repository. Compliance with this bulletin ensures that the GDS data files are correctly transferred and m

100000 POWER TRAIN

This SKU is an Air Conditioning Bypass Pulley. The Customer communication requested return of unsold inventory to inspect for potential bracket cracking. Bracket cracks may cause the engine drive belt to slip or jump off the pulley causin

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

100000 POWER TRAIN

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

100000 POWER TRAIN

110000 ELECTRICAL SYSTEM

100000 POWER TRAIN

110000 ELECTRICAL SYSTEM

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

THIS BULLETIN PROVIDES INFORMATION ON COMPONENTS, ATTRIBUTES, AND PRECAUTIONS OF THE 7-SPEED DRY-TYPE DUAL CLUTCH TRANSMISSION (DCT).

046000 SERVICE BRAKES, AIR:ANTILOCK

HYUNDAI: ALL SONATA HYBRIDS. BRAKE BLEEDING PROCEDURE. *RM

061000 ENGINE AND ENGINE COOLING:ENGINE

HYUNDAI: ATA SOLENOID DIAGNOSTIC TROUBLE CODES P0740, P0741, P0742, P0743, P0746, P0748, P0750, P0755, P0760, P0765, P0770. INCORRECT OPERATION OF THE TRANSAXLE SOLENOIDS MAY RESULT IN THE FOLLOWING SYMPTOMS-CHECK ENGINE LIGHT ILLUMINATED

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

061000 ENGINE AND ENGINE COOLING:ENGINE

HYUNDAI: AUTOMATIC TRANSAXLE RANGE SWITCH DIAGNOSTIC TROUBLE CODES P0705 (RANGE SWITCH SIGNAL PROBLEMS), P0707 (RANGE SWITCH OPEN CIRCUIT), AND P0708 (RANGE SWITCH SHORT CIRCUIT OR MULTIPLE INPUTS). AN IMPROPERLY ADJUSTED OR IMPROPERLY OP

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

EXHAUST GAS RECIRCULATION (EGR) SYSTEM DIAGNOSIS. *KB

106000 POWER TRAIN:AXLE ASSEMBLY

AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES (DTC) LIST. *KB

036000 SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

ABS PUMP SELF-CHECK NOISE. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *SC

110000 ELECTRICAL SYSTEM

AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *NM

036000 SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

ABS PUMP SELF CHECK NOISE. ALSO INCLUDED: 2003-2005 MODEL XG AND 1999, 2000, 2001, 2003, 2004 AND 2005 MODEL SANTA FE. *SC

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

FD46XG PAG OIL SPECIFICATIONS FOR AIR CONDITIONING COMPONENT REPLACEMENT. *TT

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

FD46XG POLY ALKYLEN GLYCOL (PAG) OIL SPECIFICATIONS FOR AIR CONDITIONING COMPONENT REPLACEMENT. *NM

061000 ENGINE AND ENGINE COOLING:ENGINE

UNSTABLE IDLE (SIMPLE DIAGNOSIS PROCEDURE FOR INTERMITTENTLY STUCK CLOSED EGR SOLENOID VALVE). *TT

036400 SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:ABS WARNING LIGHT

ANTI-LOCK BRAKING SYSTEM (ABS)TCS ACTIVATION MAY RESULT FROM UNDERINFLATED COMPACT SPARE TIRE. *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

2.5/2.7L V6 ENGINE TITANIUM O2 SENSORS (CAMPAIGN V01) - REVISED TSB VERSION 2. *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

2.5/2.7L V6 ENGINE TITANIUM O2 SENSORS (CAMPAIGN V01) - REVISED TSB. *TT

180000 VEHICLE SPEED CONTROL

RESISTANCE VALUES FOR IDLE SPEED CONTROL ACTUATOR (ISCA). VARIOUS MODELS INCLUDING THE 2004 SONATA. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODE (DTC) P1723 ACCOMPANIED WITH MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED; TRANSAXLE HELD IN 2RD GEAR FAIL-SAFE; HARSH SHIFTS INTO REVERSE OR DRIVE. *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

ECM (ENGINE CONTROL MODULE) REPROGRAMMING FOR ENGINE HESITATION IN THE MORNING AND DIAGNOSTIC TROUBLE CODE P0139. *TT

100000 POWER TRAIN

ATA SOLENOID DIAGNOSTIC TROUBLE CODES P0740, P0741, P0742, P0743, P0750, P0755, P0760, P0765, P0770. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

THIRD GEAR FAIL-SAFE INFORMATION. *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

VEHICLES MAY EXPERIENCE ENGINE RPM FLUCTUATION - CRUISE CONTROL CABLE ADJUSTMENT PROCEDURE. *TT

106000 POWER TRAIN:AXLE ASSEMBLY

ATA SOLENOID DIAGNOSTIC TROUBLE CODES P0740, P0743, P0750, P0755, P0760, P0765, P0770. *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

ECM (ENGINE CONTROL MODULE) REPROGRAMMING FOR ENGINE HESITATION IN THE MORNING AND DIAGNOSTIC TROUBLE CODE P0139. *TT

101000 POWER TRAIN:CLUTCH ASSEMBLY

IMPROVED CLUTCH RELEASE SHAFT UPPER AND LOWER BUSHING. *TT

121000 EXTERIOR LIGHTING:HEADLIGHTS

VERY BRIEF, SLIGHT HEADLAMP DIMMING CONDITION. *TT

131000 VISIBILITY:WINDSHIELD

A CONDITION MAY EXIST WHERE THE FRONT DOOR GLASS DOES NOT RAISE PROPERLY OR WILL NOT STAY FULLY CLOSED AND / OR DOES NOT LOWER PROPERLY. *TT

034400 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM

THIS BULLETIN INVOLVES INFORMATION RELATING TO A CHANGE IN THE REAR DRUM BRAKES TO REDUCE BRAKE SQUEAL/SQUEAK NOISE. *JG

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SUBJECT REGARDING ENGINE RPM FLUCTUATION - CRUISE CONTROL CABLE ADJUSTMENT PROCEDURE. *JG

106000 POWER TRAIN:AXLE ASSEMBLY

SUBJECT REGARDING AUTOMATIC TRANSAXLE HARSH AND/OR DELAYED SHIFTS. *JG

980000 UNKNOWN OR OTHER

SUBJECT REGARDING DIAGNOSTIC GUIDE FOR CLIFFORD AND DEI SECURITY SYSTEM. *JG

140000 AIR BAGS

SUBJECT REGARDING SIDE IMPACT AIR BAG WIRE HARNESS ROUTING. *JG

110000 ELECTRICAL SYSTEM

SUBJECT REGARDING SIDE IMPACT AIR BAG WIRE HARNESS ROUTING CAMPAIGN. *JG

021100 SUSPENSION:FRONT:STABILIZER BAR

SUBJECT REGARDING REAR STABILIZER BAR BUSHING REPLACEMENT-NOISE REPAIR PROCEDURE. *JG

980000 UNKNOWN OR OTHER

SOME VEHICLES MAY EXPERIENCE CHECK ENGINE LIGHT ILLUMINATION OR DIAGNOSTIC TROUBLE CODES P0133, P0134, P1134, P0153, P0154, OR P1154. *SLC

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

INFORMATION REGARDING AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *YH

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

SUBJECT REGARDING AUTOMATIC TRANSAXLE HARSH OR DELAYED PARK-REVERSE OR PARK-DRIVE ENGAGEMENT. *SLC

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

VEHICLES MAY EXPERIENCE A HARSH OR DELAYED PARK-REVERSE OR PARK-DRIVE ENGAGEMENT IN VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS. *SLC

980000 UNKNOWN OR OTHER

SUBJECT REGARDING V6 NITROGEN OXIDE NOX DIAGNOSIS. *JG

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SUBJECT REGARDING ENGINE RUNS ROUGH, IDLES ROUGH, DTC P0335. *YD

106000 POWER TRAIN:AXLE ASSEMBLY

SUBJECT REGARDING SHIFTLOCK AND KEY LOCK CABLE ADJUSTMENT FOR VEHICLES WITH SPORT SHIFT. *SLC

063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

INFORMATION ON EXHAUST GAS RECIRCULATION. *SLC

171100 LATCHES/LOCKS/LINKAGES:DOORS:LATCH

INFORMATION REGARDING SECURITY UPGRADE: DOOR LOCK LEARN PROCEDURE. *YD

050000 PARKING BRAKE

INFORMATION REGARDING NOISE FROM REAR WHEELSD ,PARKING BRAKE ADJUSTMENT. *YD

063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

SUBJECT REGARDING EXHAUST GAS RECIRCULATION (EGR) SYSTEM DIAGNOSIS. *TT

185000 VEHICLE SPEED CONTROL:CRUISE CONTROL

SUBJECT REGARDING SHOP MANUAL CORRECTION FOR IDLE SPEED ACTUATOR RESISTANCE CHECK. *YH

116200 ELECTRICAL SYSTEM:IGNITION:MODULE

SUBJECT REGARDING ECM NON-INTERCHANGEABILITY. *YH

185000 VEHICLE SPEED CONTROL:CRUISE CONTROL

INFORMATION REGARDING SHOP MANUAL CORRECTION FOR IDLE SPEED ACTUATOR RESISTANCE CHECK. *YH

116300 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

INFORMATION REGARDING SECURITY SYSTEM UPGRADE. *YH

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

SUBJECT REGARDING FINAL DRIVE GEAR WHINE NOISE. *YH

200000 WHEELS

SUBJECT REGARDING NOISE FROM REAR WHEELS. *YH

116300 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

SUBJECT REGARDING SECURITY UPGRADE DOOR LOCK LEARN PROCEDURE. *YH

114400 ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS

INFORMATION REGARDING MISSING 5 AMP FUSE FROM SECURITY UPGRADE KITS. *YH

350000 EQUIPMENT

INFORMATION ON THE ACUOSTIC WARNING SYSTEM. *TT

Showing 100 of 105 bulletins.

NHTSA Safety Investigations, HYUNDAI SONATA

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 2011

Air bags may be disabled during crash

The Office of Defects Investigation (ODI) opened PE18-003 on 3/16/18 to investigate incidents involving crashes, resulting in significant collision related damage, where the frontal airbags failed to deploy. ODI reviewed complaint data, available design, test, and field data on the model year (MY) 2... Read more

PE, Closed , Model Year: 2013

Front Passenger Seat Belt Anchor Failure

The Office of Defects Investigation (ODI) opened this investigation on December 27, 2016 based on two ODI consumer complaints reporting a failure of the front passenger seat belt to remain connected to the seat belt anchor and pre-tensioner during a crash.On March 8, 2017 Hyundai Motor America (Hyun... Read more

PE, Closed , Model Year: 2016

Electronic Parking Brake

The Office of Defects Investigation opened this investigation on September 3, 2016 based on four reports alleging the rear brakes locked or applied while driving without brake pedal application. One of the reports alleged a fire in the right rear wheel area.The vehicles subject to the investigation ... are equipped with an optional Electronic Parking Brake (EPB). In this system, an electric motor applies the parking brake by moving the rear brake pads (pads) against the brake rotors (rotors) when activated by the EPB control switch. The EPB is released by the control switch or by selecting a drive gear with the transmission shifter when the ignition is on.If the EPB has not been used within 1000 kilometers (621 miles) the system is designed to perform an Automatic Adjustment Function (AAF) of the pads to check for proper clearance. This function is a pad adjustment only and is preformed with the vehicle in park with the ignition off. It does not set the parking brake or turn the brake indicator light on. Hyundai has identified an error within the EPB control logic that can cause the pads to remain in contact with the rotors at various levels of force after the AAF is completed. This condition could cause the rear brakes to drag at the next drive cycle and may generate some levels of heat and smoke. The EPB control logic error affects model year 2016 vehicles produced from the start of production through March 16, 2016.Vehicles produced from March 17, 2016 incorporate an updated EPB control logic to prevent brake pad drag. On May 11, 2016 Hyundai notified its dealer network of Service Campaign TFF to update the EPB control logic in the affected vehicle population. Dealers will reflash the EPB software to prevent brake pad drag.There are no reports of accidents or injuries as a result of this issue. The incident that alleged fire could not be confirmed as there were no repairs to the vehicle other than replacement of the rear brake rotors and pads.ODI is closing this investigation based on the manufacturer's Service Campaign of the affected vehicles and in consideration that the the effect of brake drag in this instance does not appear to present an unreasonable risk to motor vehicle safety. The ODI reports cited above can be viewed at www-odi.nhtsa/complaints under the following identification (ODI)numbers: 10820359, 10854476, 10875764, 10892736, and 10928478Read more

PE, Closed , Model Year: 2006

Seat Belt Buckle Electrical Malfunction

On July 22, 2014 the Office of Defects Investigation (ODI) opened a preliminary evaluation to further analyze allegations of seat belt pretensioner malfunctions on model year (MY) 2006-2008 Hyundai Sonata vehicles.ODI received 131 unique reports alleging a failure within the seat belt pretensioner s... ystem, which was typically preceded by SRS light illumination.ODI requested more information from Hyundai in order to understand the nature of the failure and how the airbag deployment algorithm, the seat belt pretensioners, and/or the airbag function may be affected. In response to ODI?s information request (IR), Hyundai submitted 764 unique consumer and field reports and 19,847 warranty claims related to a failure in the front seat belt buckle assembly potentially causing a malfunction of the seat belt pretensioners.In it's response, Hyundai advised that if the resistance specifications for the seat belt buckle pretensioner circuit, located in the seat belt stalk, exceed the nominal range, a diagnostic trouble code will be set and the SRS warning indicator lamp will illuminate.The presence of this stored code will not affect the ability of the SRS Control Module (SRSCM) to detect a collision and command deployment of the pretensioners and airbags, if warranted.In fact, the wiring harness connector may be unplugged from the seat belt buckle pretensioner, and the signal to deploy the pretensioner will still be commanded and recorded.MY 2006-2008 Sonata?s utilize a dual pretensioner system by incorporating pretensioners into both the driver and front passenger seat belt retractor and the seat belt buckle assembly.The retractor pretensioner is located inside the B-pillar and winds (pretensions) the seat belt webbing back into the retractor housing during a collision, helping to remove seat belt slack and restrain the upper torso and hips.In contrast, the buckle pretensioner is located within the stalk of the seat belt assembly and acts to supplement lower limb protection.Both pretensioners are controlled by the SRSCM but utilize separate wiring and connectors.The seat belt retractor pretensioner circuitry and operation is independent of the seat belt buckle pretensioner connector and circuitry.Hyundai produced analysis indicating that increased resistance in the seat belt pretensioner which occurs in vehicle service does not result in a loss of buckle pretensioner.Hyundai further advised that in the unlikely event that a seat belt buckle pretensioner may not deploy due to increased resistance, the retractor pretensioner would still activate.Hyundai advised that the subject vehicles maintain their 5 STAR NHTSA safety rating using the retractor based pretensioner only.ODI notes that MY 2009-10 Sonatas reverted back to a single pretensioner system, and do not utilize seat belt buckle pretensioners. Hyundai advised its intention to initiate a warranty extension program to address concerns with the seat belt buckle prentensioner faults in MY 2006-2008 Hyundai Sonata vehicles.This action will extend the warranty coverage for this issue for 15 years or 250,000 miles, whichever occurs first.Given Hyundai's action and the minimal safety consequence this issue presents, further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor the issue and reserves the right to take further action if warranted by the circumstances. The ODI complaints cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, seRead more

PE, Closed , Model Year: 2011

Steering Shaft Separation

The Office of Defects Investigation (ODI) is aware of 7 complaints and field reports and 10 warranty claims on the subject vehicles that allege the intermediate steering shaft became loose or in some cases separated from the upper steering column and/or the steering gearbox, causing (or potentially ... Read more

PE, Closed , Model Year: 2002

INTERIOR DOOR HANDLE LACERATION HAZARD

THE MANUFACTURER HAS ISSUED A SAFETY RECALL NOTIFICATION AS A RESULT OF THIS INVESTIGATION.THE RECALL AFFECTS 91,202 MY 2002-2003 SUBJECT VEHICLES PRODUCED FROM JANUARY 28, 2002, THROUGH MARCH 22, 2003.THE VEHICLE RECALL POPULATION WAS DEFINED BY THE MANUFACTURER'S USE OF A NEW SUPPLIER FOR THE CHRO... Read more

PE, Closed , Model Year: 1999

FRONT SUB-FRAME CORROSION

THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION, PE08-029, ON APRIL 22, 2008, BASED ON 40 CONSUMER COMPLAINTS ALLEGING FRONT SUB-FRAME CORROSION IN MODEL YEAR (MY) 1999 THROUGH 2002 HYUNDAI SONATA VEHICLES.COMPLAINTS DESCRIBE SEVERE CORROSION OF THE VEHICLE SUB-FRAME IN THE A... REA WHERE THE RIGHT-FRONT LOWER CONTROL ARM IS ATTACHED.IN SOME VEHICLES, SUB-FRAME CORROSION HAS CAUSED COMPLETE OR PARTIAL DETACHMENT OF THE CONTROL ARM, RESULTING IN WHEEL COLLAPSE OR SEPARATION. IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER FOR PE08-029, HYUNDAI PROVIDED OWNER COMPLAINTS, FIELD REPORTS, AND WARRANTY CLAIM DATA FOR APPROXIMATELY 197,906 MY 1999 THROUGH 2002 SUBJECT VEHICLES SOLD OR LEASED IN THE UNITED STATES.THE BASE WARRANTY FOR THE SUBJECT VEHICLES IS 60 MONTHS OR 60,000 MILES, WHICHEVER OCCURS FIRST.ACCORDING TO HYUNDAI, PROLONGED EXPOSURE TO THE ROAD SALTS MAY RESULT IN CORROSIVE DAMAGE TO THE SUBFRAME.HYUNDAI REDESIGNED THE SUB-FRAME EARLY IN THE MY 2004 PRODUCTION (NOVEMBER 2003) TO ADDRESS PROBLEMS WITH PREMATURE CORROSION OF THE CROSSMEMBER NEAR THE RIGHT-FRONT SUSPENSION ATTACHMENT. ODI'S ANALYSIS OF BOTH COMPLAINT AND WARRANTY DATA FOR THE MY 1999 THROUGH 2002 SONATA VEHICLES SHOWS THAT THE FAILURE RATES ARE SIGNIFICANTLY HIGHER IN SALT BELT STATES, WHICH ACCOUNT FOR APPROXIMATELY 50 PERCENT OF VEHICLE SALES AND OVER 90 PERCENT OFCOMPLAINTS AND WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT (NOTE:FOR PURPOSES OF THIS INVESTIGATION THE SALT BELT INCLUDES CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN).ACCORDING TO HYUNDAI, THE ALLEGED DEFECT RESULTS IN A PROGRESSIVE LOSS OF STRUCTURAL INTEGRITY OF THE SUBFRAME AND THERE IS AMPLE OPPORTUNITY FOR THE PROBLEM TO BE DETECTED (BY INSPECTION, STEERING FEEL OR TIRE WEAR ANOMALIES) AND REPAIRED BEFORE IT REACHES A STATE WHERE A SAFETY RELATED INCIDENT MAY OCCUR.HYUNDAI IDENTIFIED 4 ALLEGATIONS OF VEHICLE DISABLEMENT AND 1 ALLEGATION OF A CRASH; WHERE THE LOWER CONTROL ARM BROKE FROM THE VEHICLE WHILE DRIVING AT 55 MPH AND THE DRIVER LOST CONTROL AND DROVE INTO A YARD.THERE WERE NO REPORTED INJURIES.ODI RECEIVED A SEPARATE ALLEGATION OF A CRASH, WHERE THE COMPLAINANT ALLEGED THAT WHILE DRIVING AROUND A SLIGHT CURVE AT 65 MPH ON A FREEWAY, THE VEHICLE SUB-FRAME FRACTURED AND THE DRIVER LOST CONTROL OF THE VEHICLE AND WENT OFF THE ROAD.AGAIN, NO INJURIES WERE REPORTED.APPROXIMATELY ONE-THIRD OF THE COMPLAINTS TO ODI ALLEGE THAT THE SUB-FRAME CORROSION RESULTED IN A LOSS OF CONTROL AND/OR A VEHICLE DISABLEMENT DUE TO WHEEL COLLAPSE OR SEPARATION.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-016) COVERING MY 1999 THROUGH EARLY-2004 HYUNDAI SONATA VEHICLES IN SALT-BELT STATES AND EQUIPPED WITH THE SUBJECT SUB-FRAME DESIGN TO FURTHER ASSESS THE FREQUENCY AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.Read more

PE, Closed , Model Year: 2002

TIRE VALVE STEM FAILURES

THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE), PE05-059, BASED ON NINE CONSUMER COMPLAINTS OF TIRE VALVE STEM FAILURES.THE ALLEGED VALVE STEM FAILURES OCCURRED ONLY AFTER TIRE REPLACEMENT FROM THE ORIGINAL EQUIPMENT (OE) TIRE (MICHELIN 205/65R15 ENERGY MXV4 PLUS) TO ... Read more

DP, Closed , Model Year: 1999

IMPROPER FRONTAL AIR BAG PERFORMANCE

HYUNDAI HAS RECEIVED 49 REPORTS FROM CUSTOMERS STATING THE FRONTAL AIR BAGS DID NOT DEPLOY IN A CRASH FOR THE SUBJECT VEHICLES.EXAMINATION OF SUPLIMENTAL INFORMATION PROVIDED TO ODI BY THE MANUFACTURER FOR THE REPORTED CASES IT APPEARED THAT THE NECESSARY AIR BAG DEPLOYMENT THRESHOLD WAS NOT MET.THE... Read more

PE, Closed , Model Year: 1989

PASS.RESTRAINT SYSTEM FAIL

There is no summary currently available

HYUNDAI SONATA - All Years Overview

Complete safety history for the HYUNDAI SONATA across all model years (1989, 2026).

141 Total Recalls

22,165 Total Complaints

10 Investigations

1,201 Reported Crashes

681 Reported Fires

27 Reported Deaths

HYUNDAI SONATA - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2026	1	2	View
2025	0	20	View
2024	1	71	View
2023	2	136	View
2022	3	139	View
2021	4	170	View
2020	4	258	View
2019	0	206	View
2018	1	544	View
2017	3	995	View
2016	6	992	View
2015	9	1,642	View
2014	7	1,077	View
2013	9	2,641	View
2012	8	2,272	View
2011	14	4,609	View
2010	2	415	View
2009	2	612	View
2008	5	554	View
2007	7	906	View
2006	11	1,422	View
2005	1	217	View
2004	1	288	View
2003	6	249	View
2002	7	407	View
2001 (current)	3	293
2000	4	378	View
1999	4	187	View
1998	1	68	View
1997	2	74	View
1996	1	37	View
1995	2	93	View
1994	1	7	View
1993	1	46	View
1992	1	43	View
1991	1	41	View
1990	3	25	View
1989	3	18	View
1987	0	4	View

Other HYUNDAI Models

Model	Recalls	Complaints
SANTA FE	153	9,962	View
ELANTRA	133	11,853	View
PALISADE	124	2,704	View
TUCSON	95	8,074	View
SONATA HYBRID	67	1,129	View
IONIQ 5	66	1,865	View
ACCENT	64	2,745	View
SANTA FE HYBRID	57	347	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2001 HYUNDAI SONATA

Complaint Statistics

Top Reported Components

EPA Fuel Economy, 2001 HYUNDAI SONATA

Technical Service Bulletins, 2001 HYUNDAI SONATA

Most Affected Components

NHTSA Safety Investigations, HYUNDAI SONATA

HYUNDAI SONATA - All Years Overview

HYUNDAI SONATA - Year by Year

Other HYUNDAI Models