2000 HYUNDAI SONATA Recalls, Complaints & Safety

Rt passenger side wheel clunks when turning, loud noise when moving took to dealer they found nothing wrong. I returned to dealer again a couple weeks later to confirm my a arm needs repairs, safety issues airbag’s light remaining lit told repairs not available for year and make iwas told to deal with it by dealer even if it was a safety issue, driving car doesn’t matter what speed my back end sounds like it is falling apart and my car will slam out or into gear I have reviewed recalls and safety issues and I have been told that they have been closed even if my car is currently having issues with the vehicle recalls ie..slamming in and out of gear, arm issues and clunky noises on turns and driving,rear end clunk sounds like no shocks or struts

STEERING AND STABILITY UNSTABLE. MECHANIC TELLS ME THAT THE REAR SUB FRAME IS RUSTY AND CRACKED. THE ENTIRE FRAME WAS REPLACED AROUND 2010 BECAUSE OF A RECALL. WHEN YOU HIT A BUMP LOSE TRACTION AND BECOMES UNSTABLE. WANT TO KNOW IF THE REPLACEMENT FRAME HAS A WARRANTY. WANT TO KEEP THE CAR STILL RUNS GREAT. 170,000 MILES

I UNDERSTAND THERE IS AN AIRBAG RECALL ON SOME MODEL CARS, I DRIVE A 2000 HYUNDAI SONATA GLS THAT HAS AN AIRBAG LIGHT ACTIVATED ON THE DASHBOARD. I DON'T KNOW IF THE AIRBAG IS DEFECTIVE, I SHOULD NOT DRIVE IT, OR WHAT TO DO, PLEASE ADVISE. THIS AIRBAG LITE ON THE DASHBOARD GOES ON AS SOON AS I START THE ENGINE, AND STAYS ON ALL THE TIME THE ENGINE IS RUNNING, THIS AIRBAG LIGHT DOES NOT GO OFF UNTIL I TURN THE ENGINE OFF.

TL* THE CONTACT OWNS A 2000 HYUNDAI SONATA. WHILE DRIVING 5 MPH, THE FRONT PASSENGER SIDE WHEEL DETACHED FROM THE VEHICLE. THE VEHICLE WAS TOWED TO AN AUTO SHOP WHERE THE FAILURE WAS DIAGNOSED AS A CONTROL ARM FAILURE AND RUSTED SUBFRAME. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000.

"TAKADA RECALL " TRANSMISSION DON'T SHIFT CHECK ENGINE LIGHT IS ON IT IS SUCK IN 3RD GEAR NEXT TIME START CAR NO CHECK ENGINE LIGHT CAR SHIFTS BUT BANGS HARD IN AND OUT OF NEXT GEAR THEN CHECK ENGINE LIGHT COMES ON AND CAR IS STUCK IN THIRD GEAR.ALSO AIR BAG LIGHT IS ON ALL TIME.

WHILE SLOWING DOWN TO MAKE A TURN ON SIDE ROAD, THE LOWER LEFT CONTROL ARM PULLED COMPLETELY OUT OF THE FRAME. INSPECTION AFTER FOUND LARGE HOLE RUSTED COMPLETELY THROUGH THE FRAME RAIL. INSPECTED RIGHT SIDE AND FRAME HAS SAME TYPE OF RUSTED AND MISSING FRAME SEGMENTS. THANKFULLY THIS HAPPENED AT LOW SPEED AND NOT ON THE INTERSTATE WHERE OUTCOME COULD HAVE BEEN VERY BAD. DOING SOME RESEARCH I HAVE FOUND THAT THIS APPEARS TO HAVE BEEN A KNOWN PROBLEM WITH THIS MODEL FOR SEVERAL YEARS BEGINNING WITH 1999 MODEL. *TR

2000 HYUNDAI SONATA. CONSUMER WRITES IN REGARDS TO VEHICLE RUSTED REAR CROSS MEMBER. *SMD THE CONSUMER STATED IN DECEMBER 2008, THE FRONT CROSS MEMBER BECAME RUSTED. THE DEALER REPLACED THE FRONT CROSS MEMBER AS IT WAS UNDER RECALL DUE TO RUST. THE CONSUMER STATED THE REAR CROSS MEMBER FRAME RUSTED AND ABOUT TO BREAK APART. WHEN THE CONSUMER WENT TO THE DEALER, HE WAS INFORMED THE REAR CROSS MEMBER WAS NOT UNDER RECALL. AND THE COST TO REPLACE IT, WAS $3,000. *JB

THE FUEL TANK ON 2000 HYUNDAI SONATA IS CRACKED AND LEAKING GASOLINE. THERE IS A STRONG GAS ODOR IN THE CABIN. THE FIRE DEPARTMENT AND HAZMAT TEAM RESPONDED. I COULD HAVE BEEN KILLED IN AN EXPLOSION IF THE GAS VAPORS IGNITED. THERE IS A RECALL FOR THE PREVIOUS MODEL YEAR HYUNDAI SONATA. THE FUEL TANK CAN CRACK AND LEAK GASOLINE. THAT IS WHAT HAPPENED TO MY 2000 SONATA. THE CAR IS NOW AT A DEALERSHIP WHERE THEY ARE REPLACING THE SUBRAME BECAUSE IT HAS A RECALL FOR SEVER RUST. THEY DO NOT WANT TO RECALL THE ISSUE WITH THE RUSTED, CRACKED FUEL TANK. *TR

AIR BAG LIGHT CAME ON AND STAYED ON. DEALER (TAYLOR HYUNDAI) DENIED THAT THERE WAS AN AIR BAG RECALL ON THIS MODEL. *TR

WHEN DRIVING TO WORK THE WHEEL START TO PULL. WHEN I GOT TO WORK I TOOK A LOOK AT THE FRAME THERE WAS A 2 INCH CRACK IN ONE SIDE AND A 1/4 INCH BY 20 INCH CRACK IN THE OTHER SIDE. WHEN I TOUCH IT THE FRAME WAS ROTTEN. *TR

WHEN I TRY TO FILL THE VEHICLE WITH GAS IT STOPS EVERY FEW CENTS, SIMULAR TO WHEN THE GAS TANK IS FULL, EVEN WHEN IT IS ON EMPTY. IT TAKES UPWARDS OF 30-45 MINUTES TO FILL THE GAS TANK. SOMETIMES THE GAS GAUGE IS ON LOW WHEN I TRY TO FILL IT UP BUT IT STOPS FILLING SO OFTEN THAT I HAVE TO CHANGE PUMPS TO BE ABLE TO FILL MY TANK TO FULL. I HAVE ALSO HAD THE GAS SPILL OUT THE TOP OF THE TANK JUST BY TRYING TO PUT ENOUGH GAS IN MY VEHICLE TO MAKE IT HOME. I HAVE DONE QUITE A BIT OF RESEARCH ON THE ISSUE AND HAVE FOUND IT TO BE A COMMON PROBLEM AMONG HYUNDAI VEHICLE. WE BOUGHT THIS CAR TO HAVE A GOOD, RELIABLE VEHICLE FOR OUR DAUGHTER TO DRIVE. I DO NOT FEEL SAFE ALLOWING HER TO GO ON A LONG ROAD TRIP WHEN SHE HAS TO SPEND SO LONG FILLING THE CAR WITH GAS. *TR

WHILE DRIVING MY 2000 HYUNDAI SONATA ON GOOD ROAD AND APPROACHING A TRAFFIC LIGHT IN THE LEFT THROUGH-LANE OF A MULTILANE STREET, I MADE A QUICK STOP (NOT AND EMERGENCY STOP) WHEN THE LIGHT TURNED YELLOW. THE ROAD WAS IN GOOD CONDITION AND DRY, AND THE OUTSIDE TEMPERATURE WAS ABOUT ABOUT 80 DEGREES F. UPON MAKING THIS STOP THE CAR PULLED UNUSUALLY SHARPLY TO THE RIGHT - IF THERE HAD BEEN A CAR IN THE RIGHT LANE, I WOULD HAVE HIT IT. AFTER THIS STOP, THE FRONT TIRE(S) MADE UNUSUAL SQUEELING NOISES UPON TURNING, AND THE STEERING FELT UNUSUAL AND SHAKEY. I DROVE THE CAR DIRECTLY (ABOUT A MILE) TO THE PLACE WE WERE VISITING IN LAS VEGAS AND THE NEXT MORNING TOOK THE CAR DIRECTLY TO A HYUNDAI DEALER. UPON INSPECTION THE DEALER FOUND THAT THE FRONT SUSPENSION FRAME CROSSMEMBER (FRONT SUBFRAME) HAD A CORROSION HOLE THROUGH THE FRONT SUBBFRAME AND THE FRONT SUBFRAME HAD FAILED, CAUSING THE RIGHT FRONT (PASSENGER) TIRE TO MOVE OUT OF POSITION AND SITTING AT AN ANGLE. THE DEALER'S ADVICE WAS THAT THIS WAS A SAFETY PROBLEM, AND IT COULD FURTHER FAIL AND RESULT IN LOSS OF STEERING CONTROL. THEY ADVISED THAT I DO NOT DRIVE THE CAR UNTIL THIS THIS FRONT SUBFRAME WAS REPLACED. THIS IS A REPLACEABLE PIECE - WHICH WAS ORDERED, AND REPLACEMENT PLANNED. THE CAR WAS LEFT WITH THE HYUNDAI DEALER, AND NOT DRIVEN FURTHER. THIS SITUATION IS ESSENTIALLY IDENTICAL TO NHTSA REFERENCE NUMBER 13V354000 FOR THE REAL SUSPENSION FOR SOME HYUNDAI VEHICLES THAT LED TO HYUNDAI RECALL CAMPAIGN 113 APPROVED IN SEPT 2013. HYUNDAI RECORDS SHOW THIS CAR WAS PURCHASED IN ILLINOIS (ONE OF THE APPROVED 113-RECALL STATES) AND IT WAS DRIVEN THERE FOR ABOUT 4 YEARS OR SO. I AM THE SECOND OWNER. HYUNDAI HAS ISSUED TECHNICAL SERVICE BULLETIN CAMPAIGN NUMBER 12-01-029 DATED OCTOBER 2012 (SUPERSEDES BULLETIN 09-01-020-2) WHICH ADDRESSES THIS FRONT SUBFRAME PROBLEM, BUT, I AM TOLD, IT IS NOT AN APPROVED RECALL. *TR

TL* THE CONTACT OWNS A 2000 HYUNDAI SONATA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 10 MPH, THE FRONT END OF THE VEHICLE COLLAPSED INTO THE PASSENGER'S SIDE WHEEL. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER 09V124000 (SUSPENSION) AND CONTACTED THE MANUFACTURER, WHO ADVISED THAT THE VIN WAS NOT INCLUDED IN THE RECALL CAMPAIGN. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000. RETURNED BY USPS ON 10-17-2013. SECOND ATTEMPT ON 10-31-2013 FAILED. *KB

TL* THE CONTACT OWNS A 2000 HYUNDAI SONATA. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO THE DEALER FOR ROUTINE SERVICE WHEN HE WAS INFORMED THAT THE DRIVER'S SIDE UPPER STRUT MOUNT HAD PENETRATED THROUGH THE MOUNTS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 25,000. *TR

RUST REAR CONTROL ARM BROKE FROM SUBFRAME, MADE NOISE ENOUGH TO TAKE TO MECHANIC WHO FOUND PROBLEM WHY IS IT THAT ONLY FRONT SUBFRAME & FRONT CONTROL ARMS WERE INCLUDED IN RECALL? THE REAR PARTS ARE ALSO RUSTING.... PARTS ARE MADE FROM SAME MATERIAL = SAME PROBLEM ... THE RECALL SHOULD INCLUDE BOTH THE FRONT AND THE BACK. WHY WOULD ONLY ONE SIDE OF THE CAR RUST AND NOT THE OTHER RIDICULOUS!! *TR

MY HYUNDAI DEALER HAS REFUSED TO HONOR THEIR 100,000MILES, 10 YEARS WARRANTY" MANY TIMES THAT I BRING THE CAR TO BE FIXED UNDER THE WARRANTY SINCE THE CAR WAS ONLY 8YEARS OLD AND 76,000 MILES SINCE 2008. THEY REFUSE TO FIX THE PROBLEMS THAT I EXPERIENCED BY SAYING MY CAR IS NOT LISTED IN ANY RECALL CAMPAIGN. UNFORTUNATELY THIS YEAR, ON 10/11/12, I TOOK MY CAR FOR AN ANNUAL STATE INSPECTION FOR 2000 HYUNDAI SONATA AND IT FAILS THE SAFETY INSPECTION. HERE IS WHAT IT SAYS: ***VEHICLE MEMO*** VEHICLE IS UNSAFE TO DRIVE...REAR SUB-FRAME HAS HOLE ROTTED THROUGH... DUE TO THE CURRENT FINANCIAL SITUATION, I DON'T KNOW HOW I WILL GET THIS CAR FIXED BECAUSE THE CAR IS NOW 115,000MILES AND 12 YEARS OLD AND I DON'T KNOW IF THEY WILL FIX IT. THEY HAVE CONTINUOUSLY REFUSED TO FIX MY CAR UNDER WARRANTY EVEN WHEN IT WAS CLEARLY WITHIN THE WARRANTY PERIOD AND I WAS LUCKY THEN THAT I HAVE BEEN ABLE TO PAY THE FIXES OUT OF POCKET BUT I DON'T HAVE THE LUXURY OF PAYING OUT OF POCKET THIS TIME. I AM IN NEED OF MIRACLES NOW. *TR

WHILE DRIVING OUR 2000 HYUNDAI SONATA MY HUSBAND'S SONATA CAME TO AN SCREECHING HALT IN WHICH HE ALMOST LOST COMPLETE CONTROL OF THE VEHICLE. FORTUNATELY, HE WAS ABLE TO PULL THE VEHICLE OVER TO THE SIDE OF THE ROAD. ONCE OUT OF THE VEHICLE, IT WAS VERY APPARENT THAT THE AXLE HAD BROKEN AND THE DRIVERS FRONT WHEEL HAD DETACHED FROM THE VEHICLE. THE VEHICLE WAS RELOCATED TO THE NEAREST HYUNDAI DEALER. IT WAS DETERMINED THAT THE DAMAGE WAS FROM HYUNDAI'S FRONT SUB FRAME CORROSION TREATMENT (CORROSION CLASS ACTION CC1) GROUP-CAMPAIGN, NUMBER 11-01-038 DATE-OCTOBER, 2011. THE DEALER COULD NOT FIND ANY RECORD THAT THIS RECALL NOTICE WAS SENT TO OUR HOME OF ADDRESS. *TR

TL* THE CONTACT OWNS A 2000 HYUNDAI SONATA. THE CONTACT STATED THAT WHILE THE VEHICLE WAS AT A LOCAL MECHANIC FOR TIRE MAINTENANCE, THE FRONT SUBFRAME LOWER CONTROL ARM WAS FOUND TO BE CORRODED. THE MANUFACTURER DENIED ASSISTANCE WITH THE REPAIR, BECAUSE THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 09V124000 (SUSPENSION). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 220,000.

GAS LIGHT DON'T WORK, THE ODOMETER DON'T WORK, WHEN IT RAINS THE CAR LIGHTS DIME AND THE CAR ALMOST DIES... *TR

I WAS HEADING EASTBOUND GOING ABOUT 40 MPH. AN SUV WAS HEADING WESTBOUND AND ABOUT TO MAKE A LEFT TURN. THE SUV STRUCK MY VEHICLE AND TOTALED THE ENTIRE FRONT OF THE VEHICLE. MY AIRBAGS DID NOT DEPLOY. I AM SUPPOSED TO HAVE SIDE AND FRONT AIRBAGS. I AM LUCKY I WAS WEARING A SEAT BELT BECAUSE OTHER THAN THAT, I HAD NO OTHER PROTECTION. THIS COULD HAVE BEEN FATAL. *TR

Crash 1 injured

TL* THE CONTACT OWNS A 2000 HYUNDAI SONATA. WHILE DRIVING APPROXIMATELY 10- 35 MPH, THE ENGINE STALLED WITH THE ILLUMINATION OF THE CHECK ENGINE WARNING INDICATOR. THE WARNING INDICATOR REMAINED ILLUMINATED UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE MASS AIR FLOW SENSOR WOULD NEED TO BE REPLACED. THE FAILURE RECURRED WHENEVER THE ENGINE WAS IN OPERATION. THERE WAS A RECALL RELATED TO THE DEFECT UNDER NHTSA CAMPAIGN ID NUMBER 00V259001 (ELECTRICAL SYSTEM: WIRING); HOWEVER THE RECALL EXPIRED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 120,000. UPDATED 03/14/12*LJ

CAR HAS BAD RUST OUT PROBLEMS. ON THE METAL FRAME AND SUSPENSION PARTS. TOTAL RUST OUT ON REAR FRAME, ALSO THE UPPER CONTROL ARMS. THE FRONT CRADLE FRAME WAS REPAIRED PREVIOUSLY. UPDATED 10/20/11 *BF

I HAVE A 2000 HYUNDAI SONATA. I HAVE HAD SEVERAL SENSORS REPLACED IN THIS CAR ALREADY. IT IS SOMETHING ELECTRICAL OR ANOTHER SENSOR, GO FIGURE. MY WIPERS STOPPED WORKING, AND MY WIPER FLUID PUMP ALSO WENT OUT. HAD LOCAL AUTO SHOP REPLACE WIPER FLUID PUMP, THEY TRIED WHATEVER THEY COULD, THEN THE WIPERS WOULD NOT STOP WORKING,SO THEY TOOK OUT THE RELAY SWITCH.THEN MY WIPERS START WORKING AND I CAN TURN THEM OFF/ON WITH OUT THE RELAY SWITCH IN. MY CAR POWER LOCKS ARE NOT WORKING EITHER, WHICH THEY DID BEFORE. THEN MY CAR WOULD NOT START FOR NEXT THREE/FOUR DAYS, HAD TO HAVE IT JUMPED EACH DAY. SO I THOUGHT IT WAS MY BATTERY OR ALTERNATOR, HAD THOSE TESTED, IT IS NOT EITHER OF THEM. THEN MY CAR THE NEXT COUPLE OF DAY STARTS A LITTLE BETTER, BUT STILL BARELY STARTING, AND SOMETIMES WHEN I START MY CAR, THE POWER LOCKS LOCK AUTOMATICALLY. MY RADIO HAS ALWAYS ACTED UP BY TURNING OFF AND ON WHEN IT WANTS AND NOT SAVING THE STATIONS I SAVE EVERYDAY, BUT NOW IT GOES FROM A STATION TO MY CD TURNING ON, JUST BY ITSELF. I HAVE SEEN OTHER COMPLAINTS ABOUT THIS ON THE INTERNET, THERE IS SERIOUSLY SOMETHING WRONG WITH THE ELECTRICAL WIRING OR THE SENSORS OF THIS CAR, THERE NEEDS TO BE A RECALL THIS COULD BE REAL DANGEROUS. YOU NEVER KNOW WHAT IS GOING TO HAPPEN. PLEASE HELP! *TR

NO SIGNS OF POSSIBLE PROBLEM PRIOR TO BEING UNABLE TO DRIVE THE VEHICLE. THE DRIVER LOST CONTROL OF THE VEHICLE WHEN DRIVING IN A PARKING LOT AND WAS ABLE TO AVOID ADDITIONAL DAMAGE AND INJURY. THE VEHICLE WAS THEN TOWED TO A LOCAL AUTO REPAIR SHOP THAT DIAGNOSED THE PROBLEM AS A SUBFRAME RUST ISSUE ON THE DRIVER'S SIDE, WHICH DID NOT ALLOW THE CONTROL ARMS TO FUNCTION. *TR

TL*THE CONTACT OWNS A 2000 HYUNDAI SONATA. THE CONTACT WAS DRIVING APPROXIMATELY BETWEEN 10-12 MPH ATTEMPTING TO MAKE A LEFT TURN, SUDDENLY THE VEHICLE STOPPED WITHOUT WARNING. THE CONTACT INSPECTED THE VEHICLE AND OBSERVED THAT THE FRONT DRIVER SIDE AXLE COMPLETELY SEPARATED. ALSO, THE SUB-FRAME EXHIBITED EXCESSIVE CORROSION. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER FOR DIAGNOSIS. THERE WAS A RECALL ASSOCIATED WITH THE NHTSA CAMPAIGN ID NUMBER 09V124000 (SUSPENSION). THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 193,165.

2000 HYUNDAI SONATA, VIN: [XXX]MFG DATE: 06/18/1999 SUB-FRAME FAILURE. CONDITION FOUND BY TIRE RETAILER DURING INSTALLATION AND ALIGNMENT. LOWER CONTROL ARM SEPARATED FROM SUB-FRAME. FORTUNATELY, CONDITION FOUND BEFORE CATASTROPHIC FAILURE OCCURRED WHILE DRIVING. LESS THAN 1 WEEK PRIOR TO DISCOVERY, EXPERIENCED DRIVE AXLE FAILURE. RIGHT DRIVE AXLE REPLACED BUT TECHNICIAN FAILED TO NOTICE OR MAKE ME AWARE FOR SEPARATION OF SUB-FRAME. THIS WAS THE APPARENT CAUSE OF THE DRIVE AXLE FAILURE. THE SUB-FRAME SEPARATION ALLOWED THE DRIVE AXLE TO SHIFT AND SLIP FROM TRANSMISSION CASE. LOWER CONNECTION FOR CONTROL ARM SEPARATED FROM SUB FRAME. THE CONDITION THAT OCCURRED IS IDENTICAL TO RECALL ON 2001-2004 HYUNDAI SONATA MODELS AND THE RECALL ISSUED FOR 1999 AND 2000 MODELS IN THE "SALT BELT" STATES. WE HAVE EXPERIENCED HEAVY WINTER WEATHER HERE IN VA OVER THE PAST 10 YEARS. LARGE AMOUNTS OF SALT HAVE BEEN USED ON OUR ROADS. THE RICHMOND AREA HAS EXCEEDED SALT USE SEVERAL TIMES SINCE I HAVE OWNED THIS VEHICLE! BUT SALT ISN'T A REQUIREMENT FOR A CONDITION SUCH AS THIS. THE BUILD UP OF WATER ALONE WILL CREATE THIS CONDITION! RUST OCCURS ANY TIME THAT WATER WITH NO DRAINAGE COMBINES WITH STEEL/IRON. MY VEHICLE IS CURRENTLY IN DEALER SERVICE HAVING THE SUB-FRAME REPLACED! HAD I BEEN NOTIFIED OF THIS POTENTIAL CONDITION, I WOULD HAVE TAKEN STEPS TO RESOLVE IT BEFORE IT THREATENED PERSONAL INJURY TO ME. I CAN ONLY THANK THE STAFF AT MERCHANT'S TIRE FOR FINDING IT BEFORE IT FAILED ON THE ROAD! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2000 HYUNDAI SONATA. THE CONTACT STATED WHILE DRIVING 5 MPH AND THE FRONT PASSENGER SIDE CONTROL ARM BROKE OFF THE SUB FRAME DUE TO CORROSION ON THE SUB FRAME, CAUSING THE VEHICLE TO COME TO A COMPLETE STOP. THE CONTACT HAD THE VEHICLE TOWED TO A DEALER TO HAVE THE SUB FRAME REPAIRED UNDER THE SUSPENSION RECALL (09V124000). PREVIOUSLY THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC TO HAVE THE SUB FRAME INSPECTED, AT THE TIME THE MECHANIC DID NOT FIND ANY RUST OR CORROSION ON THE FRAME. THE CONTACT STATED THE MANUFACTURER NEVER INFORMED HER ABOUT THE SUSPENSION RECALL. THE FAILURE MILEAGE WAS 140,000.

I AM WRITING IN REGARD TO MY 2000 HYUNDAI SONATA AND ITS SUB FRAME CORROSION AND THE FRUSTRATION I AM FEELING FROM THIS SITUATION. I WAS DRIVING TO WORK ON FRIDAY AUGUST 27TH AROUND 520 A.M. AND HAD BEEN ON THE I-10 FREEWAY ABOUT 5 MILES GOING AROUND 65 MILES AN HOUR, THE ROAD SOON HAS A SPEED LIMIT OF 75 MPH ' IT'S A 25 MILE STRETCH OF DESERT AND VERY HEAVILY TRAVELED BY 18 WHEELERS MAKING THE HAUL TO CALIFORNIA (LOS ANGELES). ANYWAY, I HAD JUST PASSED A SEMI AND WAS ABOUT TO PASS ANOTHER (WITH ONE BEHIND ME) WHEN I FELT SOMETHING LIKE METAL ON PAVEMENT AND THOUGHT SOMETHING WAS TERRIBLY WRONG WITH MY FRONT RIGHT TIRE... I DID ALL I COULD TO GET OFF THE FREEWAY (ON THE LEFT HAND SIDE) THE SEMI BEHIND ME ALMOST REAR ENDED ME ALONG WITH SEVERAL OTHER VEHICLES ON THEIR WAY TO WORK ' ALL I HEARD WAS HORNS, TIRES SQUEALING, AND SAW PEOPLE FLIPPING ME OFF ALL WHILE I WAS TRYING TO GET OFF THE FREEWAY. I WAS SOMEHOW ABLE TO GET THE CAR OFF THE ROAD (BARELY OVER THE YELLOW LINE). I TRIED TO LOOK AT THE FRONT RIGHT SIDE BUT THE CAR WAS SO CLOSE TO THE FREEWAY I WOULD HAVE GOTTEN HIT. I DIDN'T KNOW WHETHER TO STAY IN THE CAR OR STAND OUTSIDE (IF THE CAR WOULD HAVE BEEN HIT EITHER WAY WOULD HAVE BEEN DEADLY). A POLICE MAN CAME BY ABOUT 10 MINUTES LATER AND ASKED IF I WAS OKAY AND HAD ME TRY TO START THE CAR ' THE CAR WOULD NOT MOVE AS IF THE GEARS WERE GONE ' HE USED HIS PATROL CAR TO MOVE THE CAR FROM THE ROADWAY AND DOWN INTO THE DESERT MEDIAN. IT WAS AT THIS POINT THAT WE TOOK A LOOK AND COULD SEE THAT THE RIGHT FRONT TIRE WAS FACING OUT APPROXIMATELY 45 DEGREES WITH WHEEL HOUSING AND FENDER DAMAGE. I CALLED A FRIEND, AND A TOW TRUCK AND WENT TO WORK. THE CAR WAS TAKEN TO A MECHANIC'S HOUSE AND I WAS TOLD AFTER HIS INSPECTION THAT THE LOWER CONTROL ARM COMPLETELY SEPARATED/DETACHED FROM THE SUB FRAME, WITH CHUNKS OF THE FRAME STILL ATTACHED TO THE CONTROL ARM HARDWARE (NOTICEABLE SEVERE RUST/CORROSION) WHEN THE LOWER CONTROL ARM DETACHED FROM THE SUB FRAME. *TR

HYUNDAI 2000 SONATA SUBFRAME RUST CAUSED WHEEL FAILURE. *TR

TL* THE CONTACT OWNS A 2000 HYUNDAI SONATA. THE CONTACT STATED WHILE DRIVING AT APPROXIMATELY 10 MPH, HE HEARD A LOUD THUMP. THE VEHICLE BEGAN TO INDEPENDENTLY DECREASE IN SPEED BEFORE COMING TO A STOP. THE VEHICLE DID NOT STALL AND THE ENGINE CONTINUED TO RUN. THE VEHICLE WAS TOWED TO LOCAL REPAIR FACILITY WHERE THE CONTACT WAS INFORMED THAT THE SUB FRAME WAS CORRODED AND HAD FRACTURED FROM THE VEHICLE. THE VEHICLE WAS REPAIRED AT THE CONTACT'S EXPENSE. THE MANUFACTURER WAS NOT CONTACTED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 159,150 AND THE CURRENT MILEAGE WAS APPROXIMATELY 159,200.

TL*THE CONTACT OWNS A 2000 HYUNDAI SONATA. THE CONTACT STATED THAT THE FRONT SUB FRAME ON HIS VEHICLE WAS CORRODED, COVERED WITH RUST AND HAD A HOLE THE SIZE OF A BASEBALL IN IT. HE CONTACTED THE HYUNDAI SERVICE MANAGER AND STATED THAT HE WOULD CHECK WITH HYUNDAI USA AND FOLLOW UP WITH HIM REGARDING THE FAILURE. NHTSA RECALL CAMPAIGN ID NUMBER 09V124000, SUSPENSION IS RELATED TO HIS YEAR, MAKE, AND MODEL. THE CURRENT AND FAILURE MILEAGES WERE 116,491. THE VIN WAS UNKNOWN.

REAR CROSSMEMBER RUSTED OUT. PASSENGER REAR TIRE TURNED OUT TO RIGHT AND CAUSE ME TO VEER INTO THE RIGHT LANE, NEARLY CAUSING AN ACCIDENT. *TR

TL*THE CONTACT OWNS A 2000 HYUNDAI SONATA. THE CONTACT STATED THAT WHILE DRIVING AT ANY SPEED, THE BRAKES WOULD MAKE A GRINDING NOISE AND WHILE SHE ATTEMPTED TO SLOW DOWN, THE VEHICLE DID NOT RESPOND. THE VEHICLE WAS TAKEN TO AN AUTOMOTIVE CENTER FOR REPAIRS. THE FAILURE CONTINUED A SHORT WHILE LATER. THE BRAKES WERE REPLACED THREE TIMES INCLUDING REPLACEMENT OF PADS AND ROTORS BUT THE PROBLEM CONTINUED. THE VIN WAS UNAVAILABLE AT THE TIME OF THE COMPLAINT. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000. THE CURRENT MILEAGE WAS APPROXIMATELY 113,000.

Fire

2000 HYUNDAI SONATA WHEN I PURCHASED HE CAR JANUARY 30,2010 IT WAS RUNNING FINE NOW IT RUNS TERRIBLE. I'VE PURCHASED TWO NEW SETS OF TIRES BECAUSE SOMETHING KEEPS WEARING MY TIRES OUT. I SOUNDS LIKE SOMETHING UNDERNEATH IS SCRUBBING. NO PRESSURE OR SUSPENSION, ESPECIALLY ON THE HIGHWAY. *TR