1993 HYUNDAI SONATA

1 recalls, 46 complaints - 18 TSBs

SEAT BELTS

Defect Description

THE MOTORIZED SHOULDER BELT CAN TRAVEL SLOWLY OR CHATTER IN THE TRACK AND MAY EVENTUALLY STOP TRACKING AND BECOME INOPERATIVE.

Consequence

SLOWING, CHATTERING, OR FAILURE OF THE MOTORIZED SHOULDERBELT MAY DISCOURAGE USE OF THE RESTRAINT SYSTEM, INCREASING THE RISK OF INJURYIN THE EVENT OF A SUDDEN STOP OR ACCIDENT.

Remedy

DEALERS WILL LUBRICATE THE TRACK ASSEMBLY AND, IF ANY SYSTEMS ARE FOUND INOPERATIVE, THE SYSTEM WILL BE REPAIRED OR REPLACED, AS REQUIRED.

100,000 vehicles affected

Manufacturer: HYUNDAI MOTOR AMERICA

Complaint Statistics

46 total complaints 1 crashes 1 injuries

Top Reported Components

Component	Complaints
POWER TRAIN:AUTOMATIC TRANSMISSION	7
ENGINE AND ENGINE COOLING:ENGINE	4
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE	4
ELECTRICAL SYSTEM:STARTER ASSEMBLY	3
UNKNOWN OR OTHER	2
STEERING:HYDRAULIC POWER ASSIST:PUMP	2
ELECTRICAL SYSTEM:HORN	2
ELECTRICAL SYSTEM:IGNITION:SWITCH	2
INTERIOR LIGHTING	2
POWER TRAIN:MANUAL TRANSMISSION	2

Incident date: Jun 20, 2005

DT: JUST BOUGHT THE VEHICLE USED AND IT STARTED SMOKING. ALSO, FLUID WAS COMING OUT OF IT, HAD VEHICLE TOWED TO BROTHER'S HOUSE. DEALER HASDNOT LOOKED AT VEHICLE. *AK

Incident date: Sep 2, 1994

THE ENGINE SMOKES ON START UP AND THE LIFTERS RATTLE AND KNOCK WAS IN AND OUT OF THE DEALERSHIP FOR MONTHS. EVERY 850+ MILES BURNS A QUART OF OIL WAS TOLD THAT THE WAY THAT ENGINE WORKS.THE CAR WAS KEPT FOR FOUR MONTHS AND CAME BACK THE SAME WAY.*AK

ACTUALLY A QUESTION RE A CURRENT RECALL: 93V196000. I'M GETTING A RUNAROUND FROM HYUNDAI. THEY SAY MY VIN IS FOR A CANADIAN VEHICLE (?) AND SO THEY CAN'T ASSIST WITH THE SEAT BELT TRACKING PROBLEM. I WONDER IF THAT'S LEGITIMATE, OR BOGUS. PLEASE ADVISE VIA EMAIL. *AK

BRAKE SYSTEM REPLACED AT PURCHASE BECAUSE OF SLOW REACTION AND NOISE, TRANSMISSION FAILURE ON HILL IN 5 O'CLOCK TRAFFIC, VALVE SEALS REPLACED AFTER CAR CONTINUALLY BLEW SMOKE FROM BURNING THE OIL, CATALYTIC CONVERTER REPLACED AFTER FAILING TO WORK, FRONT CAM, LIFTERS AND A ROCKER REPLACED (NO IDEA ... Read more

HAVE REPLACED TRANSMISSION, FRONT CAM, LIFTERS, ROCKER, TIMING BELT, CATALYTIC CONVERTER, POWER STEERING PUMP, VALVE SEALS, WATER PUMP, THERMOSTAT, BRAKES. TO BE REPAIRED ENGINE-WISE: REAR CAM, DRIVE AXLES, CYLINDER HEADS OR HEAD GASKETS

Incident date: Sep 2, 2000

TOOK THE AUTOMOBILE INTO DEALERSHIP TO HAVE A VEHICLE INSPECTION DONE. WHEN LEAVING DEALERSHIP NOTICED THAT THE DIRECTIONAL SIGNALS DID NOT WORK CIRCLED AROUND THE BLOCK AND DROVE THE CAR BACK TO THE DEALERSHIP. I EXPLAINED THAT THE DIRECTIONAL SIGNALS WERE WORKING FINE WHEN I BROUGHT THE VEHICLE IN... Read more

Incident date: Sep 2, 2000

Incident date: Aug 10, 1998

STARTER FAILED CAUSING DRIVER TO KEEP TURNING IGNITION KEY OFF AND ON TO GET VEHICLE TO START. NLM

NO SUMMARY

Incident date: Dec 25, 1998

PROBLEMS WITH CHANGING GEARS. WOULD GO 30MPH. WOULD GET NO SPEED. TRANSMISSION MADE GRINDING NOISE. BEEN TO DEALER & HAD MECHANIC CHANGE TRANSMISSION. THE 2ND TRANSMISSION WAS SAME AS FIRST. TOOK VEHICLE BACK & TRANSMISSION REPLACED ONCE AGAIN, 3 MONTHS LATER, TRANSMISSION STOPPED WORKING. HAD VEHIC... Read more

Incident date: Aug 10, 1998

AT DIFFERENT TIMES AND SPEEDS, THE CAR WILL SKIP AT TIMES. SOME TIMES IT SURGES VERY BAD AND CHECK ENGINE LIGHT WILL COME ON. OTHER TIMES THE CAR WILL MISS AND THE CHECK ENGINE LIGHT DOES NOT COME ON. TECHNICANS AT DEALERSHIP CAN NOT FIND TROUBLE CODE FROM CHECK ENGINE LIGHT TO SOLVE PROBLEM. YO... Read more

Incident date: Aug 10, 1998

VEHICLE EXPERIENCING STALLING. NLM

VEHICLE LEAKING OIL. NLM

Incident date: Jan 5, 1999

WHILE DRIVING AT 10 MPH, MAKING A RIGHT HAND TURN, ANOTHER VEHICLE REAR ENDED CONSUMER'S VEHICLE, AND BOTH FRONT BACK SEATS BROKE. DRIVER WAS INJURED. MANUFACTURER CONTACTED, BUT PROVIDED NO HELP. *AK *ML

Crash 1 injured

Incident date: Jun 26, 1996

WHEN DRIVING THE VEHICLE THE ENGINE CHECK LIGHT KEEPS COMING ON. CONSUMER HAS TAKEN THE VEHICLE TO THE DEALER, AND THEY CAN'T DETERMINE WHAT THE PROBLEM IS. *AK

ENGINE TIMING BELT MALFUNCTIONED FOUR TIMES, CAUSING THE VALVES TO BEND AND ENGINE TO COMPLETELY SHUT DOWN. PLEASE GIVE ANY FURTHER DETAILS. *AK

Incident date: Jun 1, 1997

GEARSHIFT INDICATOR LIGHT IN THE DASH, INDICATING THAT THE VEHICLE IS IN DRIVE, FAILED.

Incident date: Jun 1, 1997

GEARSHIFT INDICATOR LIGHT IN THE DASH, INDICATING THAT THE VEHICLE IS IN DRIVE, FAILED.

Incident date: Jun 1, 1997

WHEN TURNING RIGHT WITH THE LIGHTS ON, THE SWITCH APPARENTLY SHORTS OUT ALL LIGHTS ON THE VEHICLE, INTERIOR AND EXTERIOR. HEADLIGHTS ARE EXTINGUISHED WHEN TURN SIGNAL IS APPLIED.

Incident date: Jun 1, 1997

WHEN TURNING RIGHT WITH THE LIGHTS ON, THE SWITCH APPARENTLY SHORTS OUT ALL LIGHTS ON THE VEHICLE, INTERIOR AND EXTERIOR. HEADLIGHTS ARE EXTINGUISHED WHEN TURN SIGNAL IS APPLIED.

Incident date: Dec 1, 1998

TRANSMISSION/RADIATOR/STARTER FAILED.

Incident date: Dec 1, 1998

TRANSMISSION/RADIATOR/STARTER FAILED.

Incident date: Dec 1, 1998

TRANSMISSION/RADIATOR/STARTER FAILED.

Incident date: Jun 17, 1998

4-SPEED TRANSMISSION FAILURE.

Incident date: Oct 1, 1997

AUTOMATIC TRANSMISSION FAILED 3 TIMES. *AK

Incident date: Mar 28, 1997

WHILE DRIVING ON HIGHWAY VEHICLE STALLS IN THE FAST LANE. DEALER INSPECTED VEHICLE AND FOUND THAT THE CAUSE OF THE PROBLEM WAS A FAULTY COMPUTER CHIP. *AK

Incident date: Jan 1, 1997

CONSUMER SUSPECTS TOTAL BRAKE FAILURE. IF VEHICLE IS DRIVEN ON ROUGH SURFACE ROADS, BRAKES HAVE GIVEN AWAY A NUMBER OF TIMES. ON SMOOTH ROAD/RIDES BRAKES ARE FINE. VEHICLE WAS PURCHASED IN GUAM, WHERE PROBLEM BEGAN WHILE STILL UNDER WARRENTY. PROBLEM WAS RPORTED, BUTGAUM DEALERSHIP DID NOT KNOW ... Read more

Incident date: Feb 14, 1997

AUTOMATIC TRANSMISSION FAILURE; ALSO REPLACED HORN AND IGNITION SWITCH, *AK

Incident date: Feb 14, 1997

AUTOMATIC TRANSMISSION FAILURE; ALSO REPLACED HORN AND IGNITION SWITCH, *AK

Incident date: Feb 14, 1997

AUTOMATIC TRANSMISSION FAILURE; ALSO REPLACED HORN AND IGNITION SWITCH, *AK

Incident date: Feb 14, 1997

AUTOMATIC TRANSMISSION, HORN, AND IGNITION SWITCH FAILURE.

Incident date: Feb 14, 1997

AUTOMATIC TRANSMISSION, HORN, AND IGNITION SWITCH FAILURE.

Incident date: Feb 14, 1997

AUTOMATIC TRANSMISSION, HORN, AND IGNITION SWITCH FAILURE.

Incident date: Jan 8, 1997

WHILE DRIVING VEHICLE POWER STEERING PUMP WENT OUT, NOTICED STEERING FLUID HAD LEAKED OUT, CHECKED UNDER HOOD, NOTICED STEERING PUMP JUST DANGLING. *AK

Incident date: Sep 1, 1995

STARTER FAILED. *SD

Incident date: Sep 1, 1995

POWER WINDOWS INOPERATIVE. *SD

SUPERIOR HYUNDAI IN FAIRFIELD; RECALL FOR SLOW, CHATTERING OR NO MOVEMENT OF PASSIVE RESTRAINT. DEALER REFUSES TO PERFORM RECALL SAYS NOT PART OF RECALL. *AK

PURCHASED CAR USED, THE TIMING BELT BROKE, PLEASE DESCRIBE . *AK

EPA Fuel Economy, 1993 HYUNDAI SONATA

Trim / Engine	City MPG	Highway MPG	Combined MPG	Fuel Type	Annual Fuel Cost
2.0L 4-cyl, Automatic 4-spd (Front-Wheel Drive)	18.0	25.0	20.0	Regular	$3,100
2.0L 4-cyl, Manual 5-spd (Front-Wheel Drive)	18.0	24.0	20.0	Regular	$3,100
3.0L 6-cyl, Automatic 4-spd (Front-Wheel Drive)	16.0	22.0	18.0	Regular	$3,400

CO2 Emissions: -1.0 g/mile (Midsize Cars)

Source: U.S. Environmental Protection Agency (EPA). Actual fuel economy may vary based on driving conditions.

Technical Service Bulletins, 1993 HYUNDAI SONATA

18 manufacturer communications from 14 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
061000 ENGINE AND ENGINE COOLING:ENGINE	3
103000 POWER TRAIN:AUTOMATIC TRANSMISSION	2
350000 EQUIPMENT	2
062200 ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN	1
105300 POWER TRAIN:DRIVELINE:DRIVESHAFT	1
114000 ELECTRICAL SYSTEM:WIRING	1
270000 LANE DEPARTURE	1
280000 BACK OVER PREVENTION	1

130000 VISIBILITY

This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside th

350000 EQUIPMENT

This bulletin provides the inspection procedure and repair guidelines for certain vehicles listed below.

060000 ENGINE AND ENGINE COOLING

This bulletin provides the inspection procedure and repair guidelines for certain vehicles listed below.

030000 BRAKES (PWS)

This bulletin describes the procedure to inspect and identify fluid which may appear around the brake caliper area.

200000 WHEELS

This bulletin provides tire vibration service procedures, including how to optimize vehicle vibration performance. For all wheel/tire balance claims, the a??Tire Balance Data Sheeta?? must be fully completed including imbalance and Road For

190000 TIRES

350000 EQUIPMENT

This bulletin provides information on identifying dealer stock vehicles with either: a?? A Battery SOC alert - low Battery State of Charge (SOC) at or below 50%. a?? A 30 Day alert - vehicle has not started and reported an SOC in 30 days.

110000 ELECTRICAL SYSTEM

280000 BACK OVER PREVENTION

The Blind Spot Detection (BSD) or Blind-Spot Collision Warning (BCW) is a system that measures the speed of and distance from the following vehicles by using two magnetic wave radar sensors attached in the rear bumper. The BSD/BCW detects v

270000 LANE DEPARTURE

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

THIS BULLETIN PROVIDES INFORMATION ON COMPONENTS, ATTRIBUTES, AND PRECAUTIONS OF THE 7-SPEED DRY-TYPE DUAL CLUTCH TRANSMISSION (DCT).

114000 ELECTRICAL SYSTEM:WIRING

SHOP MANUAL ON DOHC SPARK PLUG WIRE ROUTING. *YC

061000 ENGINE AND ENGINE COOLING:ENGINE

PROVIDED PROCEDURES FOR THE INSTALLATION OF A BLOCK HEATER. *YC

061000 ENGINE AND ENGINE COOLING:ENGINE

SHOP MANUAL CORRECTION ON CYLINDER HEAD BOLT TORQUE SPECIFICATION. *YC

105300 POWER TRAIN:DRIVELINE:DRIVESHAFT

SHIFT CONDITION CAUSED BY SHORT CIRCUIT IN INHIBITOR SWITCH. *TW

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

VEHICLES EQUIPPED WITH AUTOMATIC TRANSAXLES MAY EXHIBIT A HIGH PITCH WHINE NOISE FROM THE TRANSAXLE. *TW

062200 ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

COOLING/CONDENSER FAN STAYS ON. *TW

061000 ENGINE AND ENGINE COOLING:ENGINE

VALVE TIMING BELT IMPROVEMENT. *TW

NHTSA Safety Investigations, HYUNDAI SONATA

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 2011

Air bags may be disabled during crash

The Office of Defects Investigation (ODI) opened PE18-003 on 3/16/18 to investigate incidents involving crashes, resulting in significant collision related damage, where the frontal airbags failed to deploy. ODI reviewed complaint data, available design, test, and field data on the model year (MY) 2... Read more

PE, Closed , Model Year: 2013

Front Passenger Seat Belt Anchor Failure

The Office of Defects Investigation (ODI) opened this investigation on December 27, 2016 based on two ODI consumer complaints reporting a failure of the front passenger seat belt to remain connected to the seat belt anchor and pre-tensioner during a crash.On March 8, 2017 Hyundai Motor America (Hyun... Read more

PE, Closed , Model Year: 2016

Electronic Parking Brake

The Office of Defects Investigation opened this investigation on September 3, 2016 based on four reports alleging the rear brakes locked or applied while driving without brake pedal application. One of the reports alleged a fire in the right rear wheel area.The vehicles subject to the investigation ... are equipped with an optional Electronic Parking Brake (EPB). In this system, an electric motor applies the parking brake by moving the rear brake pads (pads) against the brake rotors (rotors) when activated by the EPB control switch. The EPB is released by the control switch or by selecting a drive gear with the transmission shifter when the ignition is on.If the EPB has not been used within 1000 kilometers (621 miles) the system is designed to perform an Automatic Adjustment Function (AAF) of the pads to check for proper clearance. This function is a pad adjustment only and is preformed with the vehicle in park with the ignition off. It does not set the parking brake or turn the brake indicator light on. Hyundai has identified an error within the EPB control logic that can cause the pads to remain in contact with the rotors at various levels of force after the AAF is completed. This condition could cause the rear brakes to drag at the next drive cycle and may generate some levels of heat and smoke. The EPB control logic error affects model year 2016 vehicles produced from the start of production through March 16, 2016.Vehicles produced from March 17, 2016 incorporate an updated EPB control logic to prevent brake pad drag. On May 11, 2016 Hyundai notified its dealer network of Service Campaign TFF to update the EPB control logic in the affected vehicle population. Dealers will reflash the EPB software to prevent brake pad drag.There are no reports of accidents or injuries as a result of this issue. The incident that alleged fire could not be confirmed as there were no repairs to the vehicle other than replacement of the rear brake rotors and pads.ODI is closing this investigation based on the manufacturer's Service Campaign of the affected vehicles and in consideration that the the effect of brake drag in this instance does not appear to present an unreasonable risk to motor vehicle safety. The ODI reports cited above can be viewed at www-odi.nhtsa/complaints under the following identification (ODI)numbers: 10820359, 10854476, 10875764, 10892736, and 10928478Read more

PE, Closed , Model Year: 2006

Seat Belt Buckle Electrical Malfunction

On July 22, 2014 the Office of Defects Investigation (ODI) opened a preliminary evaluation to further analyze allegations of seat belt pretensioner malfunctions on model year (MY) 2006-2008 Hyundai Sonata vehicles.ODI received 131 unique reports alleging a failure within the seat belt pretensioner s... ystem, which was typically preceded by SRS light illumination.ODI requested more information from Hyundai in order to understand the nature of the failure and how the airbag deployment algorithm, the seat belt pretensioners, and/or the airbag function may be affected. In response to ODI?s information request (IR), Hyundai submitted 764 unique consumer and field reports and 19,847 warranty claims related to a failure in the front seat belt buckle assembly potentially causing a malfunction of the seat belt pretensioners.In it's response, Hyundai advised that if the resistance specifications for the seat belt buckle pretensioner circuit, located in the seat belt stalk, exceed the nominal range, a diagnostic trouble code will be set and the SRS warning indicator lamp will illuminate.The presence of this stored code will not affect the ability of the SRS Control Module (SRSCM) to detect a collision and command deployment of the pretensioners and airbags, if warranted.In fact, the wiring harness connector may be unplugged from the seat belt buckle pretensioner, and the signal to deploy the pretensioner will still be commanded and recorded.MY 2006-2008 Sonata?s utilize a dual pretensioner system by incorporating pretensioners into both the driver and front passenger seat belt retractor and the seat belt buckle assembly.The retractor pretensioner is located inside the B-pillar and winds (pretensions) the seat belt webbing back into the retractor housing during a collision, helping to remove seat belt slack and restrain the upper torso and hips.In contrast, the buckle pretensioner is located within the stalk of the seat belt assembly and acts to supplement lower limb protection.Both pretensioners are controlled by the SRSCM but utilize separate wiring and connectors.The seat belt retractor pretensioner circuitry and operation is independent of the seat belt buckle pretensioner connector and circuitry.Hyundai produced analysis indicating that increased resistance in the seat belt pretensioner which occurs in vehicle service does not result in a loss of buckle pretensioner.Hyundai further advised that in the unlikely event that a seat belt buckle pretensioner may not deploy due to increased resistance, the retractor pretensioner would still activate.Hyundai advised that the subject vehicles maintain their 5 STAR NHTSA safety rating using the retractor based pretensioner only.ODI notes that MY 2009-10 Sonatas reverted back to a single pretensioner system, and do not utilize seat belt buckle pretensioners. Hyundai advised its intention to initiate a warranty extension program to address concerns with the seat belt buckle prentensioner faults in MY 2006-2008 Hyundai Sonata vehicles.This action will extend the warranty coverage for this issue for 15 years or 250,000 miles, whichever occurs first.Given Hyundai's action and the minimal safety consequence this issue presents, further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor the issue and reserves the right to take further action if warranted by the circumstances. The ODI complaints cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, seRead more

PE, Closed , Model Year: 2011

Steering Shaft Separation

The Office of Defects Investigation (ODI) is aware of 7 complaints and field reports and 10 warranty claims on the subject vehicles that allege the intermediate steering shaft became loose or in some cases separated from the upper steering column and/or the steering gearbox, causing (or potentially ... Read more

PE, Closed , Model Year: 2002

INTERIOR DOOR HANDLE LACERATION HAZARD

THE MANUFACTURER HAS ISSUED A SAFETY RECALL NOTIFICATION AS A RESULT OF THIS INVESTIGATION.THE RECALL AFFECTS 91,202 MY 2002-2003 SUBJECT VEHICLES PRODUCED FROM JANUARY 28, 2002, THROUGH MARCH 22, 2003.THE VEHICLE RECALL POPULATION WAS DEFINED BY THE MANUFACTURER'S USE OF A NEW SUPPLIER FOR THE CHRO... Read more

PE, Closed , Model Year: 1999

FRONT SUB-FRAME CORROSION

THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION, PE08-029, ON APRIL 22, 2008, BASED ON 40 CONSUMER COMPLAINTS ALLEGING FRONT SUB-FRAME CORROSION IN MODEL YEAR (MY) 1999 THROUGH 2002 HYUNDAI SONATA VEHICLES.COMPLAINTS DESCRIBE SEVERE CORROSION OF THE VEHICLE SUB-FRAME IN THE A... REA WHERE THE RIGHT-FRONT LOWER CONTROL ARM IS ATTACHED.IN SOME VEHICLES, SUB-FRAME CORROSION HAS CAUSED COMPLETE OR PARTIAL DETACHMENT OF THE CONTROL ARM, RESULTING IN WHEEL COLLAPSE OR SEPARATION. IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER FOR PE08-029, HYUNDAI PROVIDED OWNER COMPLAINTS, FIELD REPORTS, AND WARRANTY CLAIM DATA FOR APPROXIMATELY 197,906 MY 1999 THROUGH 2002 SUBJECT VEHICLES SOLD OR LEASED IN THE UNITED STATES.THE BASE WARRANTY FOR THE SUBJECT VEHICLES IS 60 MONTHS OR 60,000 MILES, WHICHEVER OCCURS FIRST.ACCORDING TO HYUNDAI, PROLONGED EXPOSURE TO THE ROAD SALTS MAY RESULT IN CORROSIVE DAMAGE TO THE SUBFRAME.HYUNDAI REDESIGNED THE SUB-FRAME EARLY IN THE MY 2004 PRODUCTION (NOVEMBER 2003) TO ADDRESS PROBLEMS WITH PREMATURE CORROSION OF THE CROSSMEMBER NEAR THE RIGHT-FRONT SUSPENSION ATTACHMENT. ODI'S ANALYSIS OF BOTH COMPLAINT AND WARRANTY DATA FOR THE MY 1999 THROUGH 2002 SONATA VEHICLES SHOWS THAT THE FAILURE RATES ARE SIGNIFICANTLY HIGHER IN SALT BELT STATES, WHICH ACCOUNT FOR APPROXIMATELY 50 PERCENT OF VEHICLE SALES AND OVER 90 PERCENT OFCOMPLAINTS AND WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT (NOTE:FOR PURPOSES OF THIS INVESTIGATION THE SALT BELT INCLUDES CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN).ACCORDING TO HYUNDAI, THE ALLEGED DEFECT RESULTS IN A PROGRESSIVE LOSS OF STRUCTURAL INTEGRITY OF THE SUBFRAME AND THERE IS AMPLE OPPORTUNITY FOR THE PROBLEM TO BE DETECTED (BY INSPECTION, STEERING FEEL OR TIRE WEAR ANOMALIES) AND REPAIRED BEFORE IT REACHES A STATE WHERE A SAFETY RELATED INCIDENT MAY OCCUR.HYUNDAI IDENTIFIED 4 ALLEGATIONS OF VEHICLE DISABLEMENT AND 1 ALLEGATION OF A CRASH; WHERE THE LOWER CONTROL ARM BROKE FROM THE VEHICLE WHILE DRIVING AT 55 MPH AND THE DRIVER LOST CONTROL AND DROVE INTO A YARD.THERE WERE NO REPORTED INJURIES.ODI RECEIVED A SEPARATE ALLEGATION OF A CRASH, WHERE THE COMPLAINANT ALLEGED THAT WHILE DRIVING AROUND A SLIGHT CURVE AT 65 MPH ON A FREEWAY, THE VEHICLE SUB-FRAME FRACTURED AND THE DRIVER LOST CONTROL OF THE VEHICLE AND WENT OFF THE ROAD.AGAIN, NO INJURIES WERE REPORTED.APPROXIMATELY ONE-THIRD OF THE COMPLAINTS TO ODI ALLEGE THAT THE SUB-FRAME CORROSION RESULTED IN A LOSS OF CONTROL AND/OR A VEHICLE DISABLEMENT DUE TO WHEEL COLLAPSE OR SEPARATION.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-016) COVERING MY 1999 THROUGH EARLY-2004 HYUNDAI SONATA VEHICLES IN SALT-BELT STATES AND EQUIPPED WITH THE SUBJECT SUB-FRAME DESIGN TO FURTHER ASSESS THE FREQUENCY AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.Read more

PE, Closed , Model Year: 2002

TIRE VALVE STEM FAILURES

THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE), PE05-059, BASED ON NINE CONSUMER COMPLAINTS OF TIRE VALVE STEM FAILURES.THE ALLEGED VALVE STEM FAILURES OCCURRED ONLY AFTER TIRE REPLACEMENT FROM THE ORIGINAL EQUIPMENT (OE) TIRE (MICHELIN 205/65R15 ENERGY MXV4 PLUS) TO ... Read more

DP, Closed , Model Year: 1999

IMPROPER FRONTAL AIR BAG PERFORMANCE

HYUNDAI HAS RECEIVED 49 REPORTS FROM CUSTOMERS STATING THE FRONTAL AIR BAGS DID NOT DEPLOY IN A CRASH FOR THE SUBJECT VEHICLES.EXAMINATION OF SUPLIMENTAL INFORMATION PROVIDED TO ODI BY THE MANUFACTURER FOR THE REPORTED CASES IT APPEARED THAT THE NECESSARY AIR BAG DEPLOYMENT THRESHOLD WAS NOT MET.THE... Read more

PE, Closed , Model Year: 1989

PASS.RESTRAINT SYSTEM FAIL

There is no summary currently available

HYUNDAI SONATA - All Years Overview

Complete safety history for the HYUNDAI SONATA across all model years (1989, 2026).

141 Total Recalls

22,246 Total Complaints

10 Investigations

1,204 Reported Crashes

689 Reported Fires

27 Reported Deaths

HYUNDAI SONATA - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2026	1	2	View
2025	0	20	View
2024	1	72	View
2023	2	140	View
2022	3	142	View
2021	4	179	View
2020	4	262	View
2019	0	209	View
2018	1	546	View
2017	3	1,002	View
2016	6	996	View
2015	9	1,658	View
2014	7	1,079	View
2013	9	2,650	View
2012	8	2,280	View
2011	14	4,618	View
2010	2	415	View
2009	2	612	View
2008	5	554	View
2007	7	906	View
2006	11	1,422	View
2005	1	217	View
2004	1	288	View
2003	6	249	View
2002	7	407	View
2001	3	293	View
2000	4	378	View
1999	4	187	View
1998	1	68	View
1997	2	74	View
1996	1	37	View
1995	2	93	View
1994	1	7	View
1993 (current)	1	46
1992	1	43	View
1991	1	41	View
1990	3	25	View
1989	3	18	View
1987	0	4	View

Other HYUNDAI Models

Model	Recalls	Complaints
SANTA FE	153	9,962	View
ELANTRA	133	11,853	View
PALISADE	124	2,704	View
TUCSON	95	8,074	View
SONATA HYBRID	67	1,129	View
IONIQ 5	66	1,865	View
ACCENT	64	2,745	View
SANTA FE HYBRID	57	347	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

1993 HYUNDAI SONATA

Complaint Statistics

Top Reported Components

EPA Fuel Economy, 1993 HYUNDAI SONATA

Technical Service Bulletins, 1993 HYUNDAI SONATA

Most Affected Components

NHTSA Safety Investigations, HYUNDAI SONATA

HYUNDAI SONATA - All Years Overview

HYUNDAI SONATA - Year by Year

Other HYUNDAI Models