1992 CHEVROLET IMPALA

1 recalls, 0 complaints - 1 TSBs

EXTERIOR LIGHTING

Defect Description

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE D... Read more

Consequence

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy

PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

61,944 vehicles affected

Manufacturer: PRO-A MOTORS, INC.

No complaints found for this vehicle.

Technical Service Bulletins, 1992 CHEVROLET IMPALA

1 manufacturer communications from 1 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)	1

061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)

Expanded Availability for Remanufacture and Return (R&R) Electronic Control Modules

NHTSA Safety Investigations, CHEVROLET IMPALA

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

AQ, Closed , Model Year: 2014

BiCal Chevrolet/Loss of Power Steering

NHTSA opened AQ17-002 to determine whether BiCal Chevrolet of Valley Stream, New York (BiCal) has complied with the requirements of the National Traffic and Motor Vehicle Safety Act, 49 U.S.C. Chapter 301 (Safety Act) and its implementing regulations. The Safety Act requires, among other things, tha... Read more

DP, Closed , Model Year: 2008

Passenger Air Bag OCS Algorithm

The Agency received a petition on November 14, 2013 requesting an investigation into the operation of the passenger air bag Occupant Classification System (OCS) software logic and algorithm.The petitioner states that due to this alleged defect, the passenger air bag may be suppressed at point of imp... Read more

PE, Closed , Model Year: 2014

Active Safety System Malfunction

On April 15, 2014, the Office of Defects Investigations (ODI) opened Preliminary Evaluation PE14-010 based on two complaints alleging incidents of sudden/severe uncommanded braking resulting in rear impact collisions in model year (MY) 2014 Chevrolet Impala vehicles.ODI analyzed all complaints relat... ed to allegations of unwanted brake activations while driving that were provided by GM or submitted to ODI from consumers and has not identified any additional incidents involving sudden, extended (greater than 1 second) autonomous braking.The two crash complaints that were the basis of PE14-010 involved rental vehicles equipped with an Electric Park Brake (EPB) system.Neither vehicle was equipped with Full Speed Range Adaptive Cruise Control (FSRACC) or Forward Collision Alert (FCA) systems. According to GM, brake lights will be illuminated if the service brakes are applied or the EPB system is activated while the vehicle is moving (dynamic EPB brake apply).In a dynamic EPB brake apply, the Electric Brake Control Module (EBCM) initiates a controlled deceleration while activating a chime and a telltale light.If the service brake is applied at any time during dynamic EPB brake apply, the system provides a substantially greater deceleration.Witness statements and analysis of crash data from the two incidents are consistent with inadvertent dynamic EPB brake applications.Both reports alleged beeping noise immediately before the accidents and one pre-crash data report shows a moderate initial vehicle deceleration followed by in increase in deceleration to approximately 0.6g just prior to the vehicle stopping and being struck from the rear.During this investigation, General Motors LLC (GM) inspected the two crash incident vehicles and examined each of the EPB switches to assess potential mechanical and electrical fault conditions.The testing and part examination did not find any evidence of mechanical or electrical failure of the EPB switches and GM did not identify any faults in the subject components or systems that could have caused or contributed to autonomous brake applications in the incident vehicles.According to GM, the evidence indicates the events were caused by inadvertent driver actuation of the EPB switch. Additionally, during this investigation, GM identified a defect condition in the EPB software in approximately 132,921 model year (MY) 2014 through 2015 Chevrolet Impala and MY 2013 through 2015 Cadillac XTS vehicles (Recall No. 14V-541) that could result in failure of the EPB to release after vehicle start-up.In this condition, the electronic parking brake piston actuation arm may not fully retract when the driver disengages the EPB, which may cause the brake pads to stay partially engaged with the rotor.According to GM, the parking brake indicator may not illuminate when the EPB is engaged and the driver may experience poor vehicle acceleration, undesired deceleration during idle coast-down, excessive brake heat, and premature wear to some brake components. If the vehicle is operated for an extended period of time in this condition, there is a potential for the rear brakes to generate significant heat, smoke, and sparks.GM and its supplier, Mando Pyeongtaek, upgraded the EPB software to address brake drag conditions and issued a recall bulletin on September 4, 2014 instructing dealers to reprogram the electronic parking brake control module on all affected vehicles. This preliminary evaluation is closed.The closing of this investigation does not constitute a finding that a safety-related defect does not exist.For additional information regarding this investigation, see Attachment A to this cRead more

PE, Closed , Model Year: 2006

POWER STEERING FLUID LEAKS - FIRES

GENERAL MOTORS (GM) INITIATED A CUSTOMER SATISFACTION CAMPAIGN IN OCTOBER OF 2006 TO ADDRESS A FAILURE OF THE POWER STEERING HOSE AND/OR CLAMPS THAT COULD OCCUR WHEN THE ENGINE IS STARTED IN VEHICLES PRIMARILY OPERATED IN THE FOLLOWING STATES THAT EXPERIENCE EXTREMELY COLD TEMPERATURES:ALASKA, MAINE... , MINNESOTA, MONTANA, NEW HAMPSHIRE, NORTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN AND WYOMING.AT THE TIME THIS PRELIMINARY EVALUATION (PE) WAS OPENED, ONLY 1 OF THE 33 COMPLAINTS RECEIVED BY THE OFFICE OF DEFECTS INVESTIGATION (ODI) WAS FROM A STATE COVERED BY THE CUSTOMER SATISFACTION CAMPAIGN.IN RESPONSE TO AN INFORMATION REQUEST SENT BY THE ODI, GM PROVIDED INFORMATION THAT INCLUDED 6 ALLEGED FIRES AND 1 ALLEGED MINOR CRASH POTENTIALLY RELATED TO THE ALLEGED DEFECT. ONE OF THE ALLEGED FIRES IS A DUPLICATE OF A REPORT RECEIVED BY ODI.OF THE FIRE INCIDENTS, 2 OF THE 6 ALLEGED FIRE INCIDENTS OCCURRED AFTER THE REMEDY DETAILED IN THE CUSTOMER SATISFACTION PROGRAM WAS PERFORMED.ONE OF THE VEHICLES WAS TOTALED AS A RESULT OF THE INCIDENT.IT IS UNDETERMINED WHETHER THE INCIDENTS WERE RELATED TO THE ALLEGED DEFECT OR WERE A BY PRODUCT OF THE REPAIR.OF THE OTHER FOUR ALLEGED FIRE INCIDENTS, 1 INCIDENT INVOLVED SMOKE ONLY AND NO VISIBLE FLAMES.BASED ON THE INFORMATION PROVIDED, THE REMAINING 3 FIRE INCIDENTS WERE LOCALIZED EVENTS THAT PRIMARILY INVOLVED DAMAGE TO THE POWER STEERING COMPONENTS AND SURROUNDING WIRING.ALL 3 OF THESE VEHICLES WERE SUBSEQUENTLY REPAIRED.NONE OF THE ALLEGED FIRE INCIDENTS OCCURRED WHILE THE VEHICLE WAS UNATTENDED.ODI IS AWARE OF 1 ADDITIONAL ALLEGED FIRE INCIDENT THAT WAS NOT INCLUDED IN GM'S INFORMATION REQUEST RESPONSE.BASED ON THE CONSUMER'S DESCRIPTION OF THE INCIDENT, THE FIRE WAS QUICKLY EXTINGUISHED BY A FRIEND AND THE VEHICLE WAS SUBSEQUENTLY REPAIRED AT A DEALERSHIP.IN TOTAL ODI IS AWARE OF 6 ALLEGED FIRE INCIDENTS WHERE THE CONSUMER ALLEGED FLAMES WERE VISIBLE.ALL OF THE ALLEGED FIRE INCIDENTS OCCURRED WHILE THE VEHICLE WAS STILL ATTENDED. ODI IS AWARE 1 MINOR CRASH ALLEGED TO BE RELATED TO A POWER STEERING FLUID LEAK.THE CONSUMER ALLEGED A MINOR CRASH OCCURRED AS THE CONSUMER WAS ATTEMPTING TO PULL INTO A DRIVEWAY AND HAD DIFFICULTY NEGOTIATING THE TURN DUE TO EXPERIENCING HIGH POWER STEERING EFFORTS AND STRUCK A SNOW BANK.IN A LETTER DATED SEPTEMBER 21, 2009, GM INFORMED ODI THAT A CUSTOMER SATISFACTION PROGRAM WILL COMMENCE IN DECEMBER OF 2009 FOR THE ENTIRE US. AS A REMEDY THE POWER STEERING HOSE ASSEMBLY FOR VEHICLES WITH V8 ENGINES AND THE POWER STEERING RETURN HOSE AND CLAMPS FOR VEHICLES WITH V6 ENGINES WILL BE REPLACED WITH UPGRADED COMPONENTS.BASED ON THE LOW FREQUENCIES AND MINOR SEVERITIES OF THE ALLEGED FIRE INCIDENTS AND CRASH,NO SAFETY RELATED DEFECT TREND HAS BEEN IDENTIFIED IN THE SUBJECT VEHICLES.GM'S EXPANDED CUSTOMER SATISFACTION PROGRAM WILL PROVIDE FREE REPAIRS TO VEHICLES EXCLUDED FROM THE ORIGINAL CAMPAIGN.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.Read more

PE, Closed , Model Year: 2001

ALLEGED HEADLIGHT FAILURE

A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGAT... Read more

PE, Closed , Model Year: 2000

INADVERTENT ENGINE STALLING

There is no summary currently available

DP, Closed , Model Year: 1977

SEAT BELTS DON'T UNLOCK

CHEVROLET IMPALA - All Years Overview

Complete safety history for the CHEVROLET IMPALA across all model years (1965, 2019).

135 Total Recalls

15,237 Total Complaints

7 Investigations

921 Reported Crashes

468 Reported Fires

10 Reported Deaths

CHEVROLET IMPALA - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2020	0	25	View
2019	1	41	View
2018	1	88	View
2017	0	138	View
2016	0	177	View
2015	3	434	View
2014	12	1,018	View
2013	1	466	View
2012	3	422	View
2011	2	844	View
2010	4	737	View
2009	5	1,368	View
2008	2	1,203	View
2007	3	932	View
2006	2	803	View
2005	4	811	View
2004	7	1,375	View
2003	8	935	View
2002	7	1,077	View
2001	10	959	View
2000	10	1,128	View
1999	0	4	View
1998	0	4	View
1997	0	2	View
1996	1	120	View
1995	1	64	View
1994	1	19	View
1993	1	6	View
1992 (current)	1	0
1991	1	0	View
1987	0	1	View
1985	1	1	View
1983	2	3	View
1982	3	2	View
1981	2	2	View
1980	3	0	View
1979	3	2	View
1978	3	0	View
1977	3	1	View
1976	1	0	View
1974	3	0	View
1973	1	0	View
1972	2	0	View
1971	4	0	View
1969	4	5	View
1968	2	0	View
1967	2	2	View
1966	2	4	View
1965	3	0	View
1963	0	1	View
1958	0	1	View

Other CHEVROLET Models

Model	Recalls	Complaints
SUBURBAN	246	10,458	View
TAHOE	240	12,622	View
MALIBU	216	29,080	View
SILVERADO 1500	200	22,534	View
CORVETTE	187	6,308	View
CAMARO	179	4,298	View
SILVERADO	159	10,964	View
SILVERADO 3500	152	1,409	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health