2005 HYUNDAI ELANTRA

4 recalls, 180 complaints - 58 TSBs

EXTERIOR LIGHTING

Defect Description

HYUNDAI IS RECALLING 3,011 MODEL YEAR 2005-2007 ELANTRA, TUCSON, SONATA, AZERA AND ACCENT VEHICLES. A MALFUNCTIONING STOP LAMP SWITCH MAY CAUSE THE BRAKE LIGHTS TO FAIL TO ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED OR MAY CAUSE THE BRAKE LIGHTS TO REMAIN ILLUMINATED WHEN THE BRAKE PEDAL IS RELEAS... Read more

Consequence

ANY OF THESE MALFUNCTIONS COULD LEAD TO A CRASH.

Remedy

DEALERS WILL REPLACE THE STOP LAMP SWITCH FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 2, 2009. OWNERS MAY CONTACT HYUNDAI OF PUERTO RICO CUSTOMER SERVICE AT 1-787-999-4310.

3,011 vehicles affected

Manufacturer: HYUNDAI CARIBBEAN-PUERTO RICO

AIR BAGS

Defect Description

CERTAIN VEHICLES EQUIPPED WITH AN ADVANCED AIR BAG SYSTEM. THE OCCUPANT CLASSIFICATION SYSTEM (OCS) INSTALLED IN THE RIGHT FRONT SEAT OF THE VEHICLE MAY MISCLASSIFY A CHILD RESTRAINT SEAT (CRS) AS AN ADULT. THIS MAY OCCUR IF THE CRS IS INSTALLED AFTER AN ADULT HAS BEEN SEATED IN THE RIGHT FRONT... Read more

Consequence

THE POSSIBILITY OF MISCLASSIFICATION OF A CRS AS AN ADULT MAY ALLOW THE RIGHT FRONT AIRBAG OR SIDE IMPACT AIRBAG TO DEPLOY IN A CRASH AND COULD RESULT IN INJURY TO THE RIGHT FRONT OCCUPANT.

Remedy

DEALERS WILL REPROGRAM THE VEHICLE'S OCS ELECTRONIC CONTROL UNIT (ECU) TO REMOVE THE FEATURE THAT MAY CAUSE THE CRS TO BE RECOGNIZED AS AN ADULT. THE RECALL BEGAN ON NOVEMBER 15, 2005. OWNERS MAY CONTACT HYUNDAI OF PUERTO RICO AT 1-800-981-0188.

2,105 vehicles affected

Manufacturer: HYUNDAI CARIBBEAN-PUERTO RICO

AIR BAGS

Defect Description

Consequence

THE POSSIBILITY OF MISCLASSIFICATION OF A CRS AS AN ADULT MAY ALLOW THE RIGHT FRONT AIRBAG OR SIDE IMPACT AIRBAG TO DEPLOY IN A CRASH AND COULD RESULT IN INJURY TO THE RIGHT FRONT OCCUPANT.

Remedy

DEALERS WILL REPROGRAM THE VEHICLE'S OCS ELECTRONIC CONTROL UNIT (ECU) TO REMOVE THE FEATURE THAT MAY CAUSE THE CRS TO BE RECOGNIZED AS AN ADULT. THE RECALL BEGAN ON OCTOBER 31, 2005. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.

231,160 vehicles affected

Manufacturer: HYUNDAI MOTOR COMPANY

STEERING:LINKAGES:TIE ROD ASSEMBLY

Defect Description

CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH THREADED PORTIONS OF THE STEERING GEARBOX ASSEMBLY'S LEFT AND RIGHT INNER BALL JOINT ASSEMBLIES THAT CONTAIN INTERNAL CRACKS IN THE MATERIAL STRUCTURE.

Consequence

IF THE INNER BALL JOINT ASSEMBLY WAS TO BREAK AS A RESULT OF THE INTERNAL CRACK, THE TIE ROD END ASSEMBLY WOULD NOT LONGER BE ATTACHED TO THE STEERING GEAR BOX. THIS WOULD PREVENT STEERING CONTROL OF THAT FRONT WHEEL BY THE SEPARATED TIE ROD WHICH COULD RESULT IN A CRASH.

Remedy

DEALERS WILL REPLACE THE STEERING GEARBOX ASSEMBLIES ON THESE VEHICLES FREE OF CHARGE. OWNERS WERE CONTACTED BY TELEPHONE BEGINNING ON APRIL 8, 2005, AND INSTRUCTED NOT TO DRIVE THEIR VEHICLES. HYUNDAI WILL ARRANGE TO PICK UP AND RETURN THEIR VEHICLES AFTER REPAIR. OWNERS MAY CONTACT HYUNDAI AT 1... Read more

277 vehicles affected

Manufacturer: HYUNDAI MOTOR COMPANY

Complaint Statistics

180 total complaints 43 crashes 5 fires 41 injuries

Top Reported Components

Component	Complaints
AIR BAGS	49
VEHICLE SPEED CONTROL	12
AIR BAGS:FRONTAL	11
ELECTRICAL SYSTEM	10
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE	9
ENGINE	7
SERVICE BRAKES, HYDRAULIC	6
STRUCTURE:BODY	5
SEAT BELTS	4
UNKNOWN OR OTHER	4

Incident date: Jan 24, 2026

Abnormal inside tire wear leading to blow outs and flats. TSB 42M6 available for alignment, adjustment bolts and camber adjustments but it was not sent to my car and I've had to replace 2 sets of rear tires due to uneven wear. Mileage currently is at 35k. Dealer states no issues with suspension or a... Read more

Incident date: Jan 24, 2026

Incident date: Sep 24, 2025

CATASTROPHIC ENGINE FAILURE. With no prior indications, the engine seized while driving on side street at 25mph. Engine blew hole in block and dumped engine parts, including piston rod, piston and engine block remnants, and oil on street. Very dangerous as power steering stopped and was unable to tu... Read more

Incident date: Feb 21, 2025

The contact owns a 2018 Honda CR-V. The contact stated that while driving at various speeds, the Forward Collision Avoidance system activated independently, causing the vehicle to abruptly stop in the middle of the roadway. During each failure, there were no other vehicles or structures nearby to ca... Read more

Incident date: Feb 21, 2025

In July of 2023, my wife and kids were driving to San Diego from Phoenix. About 40 miles west of El Centro, CA, all the lights on the dash came on instructing her to pull over. When she pulled over and shut the car off, it would not come back on. Got towed back to a GM Dealership in El Centro. T... Read more

Incident date: Feb 21, 2025

Incident date: Oct 5, 2024

Two major complaints this Vechile #1 The current std operating control features are a flat out Safety Issue NO-ONE has taken into account the display of to name a few such as Fan-Speed Hi/Low, AC On/Off ,Heated Seat adjustment you cannot View while driving during daytime hours or late afternoon 1-2 ... Read more

Incident date: Oct 5, 2024

Incident date: Apr 7, 2023

The contact owns a 2017 Ford Escape. The contact stated that while driving at an undisclosed speed, the vehicle was running rough. The check engine warning light illuminated intermittently. The vehicle was taken to the local dealer where it was diagnosed that there was a crack in the short block. Ad... Read more

Incident date: Apr 7, 2023

The contact owns a 2021 Subaru Outback. The contact stated that on three separate occasions the windshield cracked without impact. The vehicle was taken to the same dealer after each failure and was informed each time that a rock chip might have caused the failure. The contact purchased a carbon ste... Read more

Incident date: Oct 1, 2021

The contact owns a 2005 Hyundai Elantra. The contact stated while driving at various speeds, the air bag warning light illuminated intermittently. The contact was made aware of various recalls for similar vehicles. The vehicle was taken to a local dealer where the contact was informed that the VIN w... Read more

Incident date: Jul 15, 2021

Passenger airbag sensor registers when someone sits down, but randomly turns off and displays “Passenger Airbag Off” light for a couple minutes before turning off again. Vehicle was inspected by an authorized Hyundai service center and no codes were produced. No indicated problems prior to the f... Read more

Incident date: Jul 15, 2021

Incident date: Mar 2, 2022

THE CLIP END WILL NOT RELEASE FROM THE RECEIVER BY PRESSING THE RED RELEASE BUTTON,,,,,,SAFETY PROBLEM...WHEN ALONE IN CAR I CAN PUT BELT CLIP IN PASSENGER RECEIVER

Incident date: Jun 30, 2020

AT INSPECTION, MECHANIC NOTED SEVERE AND DANGEROUS RUST TO SUBFRAME AND SUBFLOOR IN MULTIPLE AREAS OF VEHICLE. REAR PORTION OF SUBFRAME WAS ALMOST COMPLETED RUSTED THROUGH. ADDITIONALLY NOTED ISSUES WITH RP BRAKE LIGHT, PLATE LIGHT AND FP TURN SIGNAL. ONGOING ISSUE WITH FUSSES AND BULBS CONTINUALLY ... Read more

Incident date: Jun 30, 2020

Incident date: May 29, 2020

WHILE SLOWING DOWN AFTER DRIVING ON HIGHWAY OR STOPPING AT AN TRAFFIC LIGHT, THE CAR STALLS AND LOSES POWER STEERING. NEEDS TO BE PUT IN NEUTRAL TO RESTART BUT IF STOPPING AT ANOTHER LIGHT, IT DIES AGAIN. *TR

Incident date: May 29, 2020

Incident date: Apr 6, 2020

SUB FRAME IS ROTTING BROUGHT CAR TO MECHANIC FOR SERVICE NOT RELATED AND HE NOTICED THIS PROBLEM HE SAID IT COULD BE DANGEROUS IF NOT ADDRESSED. *TR

Incident date: Jul 11, 2019

HAS AN ISSUE WITH THE LOW BEAM LIGHT TURNING ON ONLY HIGH BEAMS WORK. AROUND 7:00 PM DRIVING HOME LIGHTS JUST COMPLETELY SHUT OFF ON ME DOWN THE FREEWAY. CHANGED OUT THE BULBS AND AGAIN WENT OUT AFTER 2 WEEKS AROUND 6 TRAFFIC HOUR WITCH ALMOST CAUSED A COLLISION WHEN OTHER DRIVER MERGED INTO MY LANE... Read more

Incident date: Oct 23, 2019

TL* THE CONTACT OWNS A 2005 HYUNDAI ELANTRA. WHILE THE VEHICLE WAS IN USE, THE AIR BAG WARNING INDICATOR ILLUMINATED. BEAVERTON HYUNDAI (13255 SW FARMINGTON RD, BEAVERTON, OR 97005, (877) 812-0866) WAS CONTACTED AND STATED THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE CONTACT PURCHASED A SCANNER AN... Read more

Incident date: Oct 23, 2019

Incident date: Jun 15, 2018

I CALL A DEALER LAST YEAR (LEE HYUNDAI) FLORENCE, SC. AND WAS TOLD THAT IF I WANT TO HAVE IT FIXED THAT IT WOULD COST ME ABOUT 500 DOLLARS, I ALSO THOUGHT THAT I HAD MADE A REPORT WITH NHTSA BEFORE AND THEN WHEN IT CAME ON TV, IT WAS SAID THAT HYUNDAI WAS LIABLE FOR FIXING IT.

Incident date: May 1, 2019

MY AIR BAG LIGHT WILL NOT GO AWAY

Incident date: May 3, 2019

TL* THE CONTACT OWNS A 2005 HYUNDAI ELANTRA. THE CONTACT STATED THAT THERE WAS AN INTERMITTENT FAILURE OF WHICH THE INSTRUMENT CLUSTER FAILED TO FUNCTION AS WELL AS THE SPEEDOMETER. THE VEHICLE WAS NOT DIAGNOSED BY AN AUTHORIZED DEALER YET TO DETERMINE THE CAUSE OF THE FAILURES. AN INDEPENDENT MECHA... Read more

Incident date: Sep 12, 2018

TALKED TO DEALER (HYUNDAI LEE), AND WAS TOLD RECALL WAS CLOSED AND I WOULD HAVE TO PAID TO HAVE FIXED. I BROUGHT THIS CAR FROM DEALER.

Incident date: Aug 17, 2018

JUST PURCHASED THIS VEHICLE USED AND THE AIR BAG DASHBOARD LIGHT WENT ON. THE DEALER CHARGED ME $140 TO DIAGNOSE INFORMING ME THAT THE SEAT SENSORS NEED REPLACEMENT ADDING THAT THE ENTIRE SEAT ASSEMBLY MAY NEED TO BE REPLACED. I FEEL THIS IS A FAILURE OF HYUNDAI'S RESEARCH AND DEVELOPMENT PLUS QUALI... Read more

Incident date: Mar 5, 2018

AIR BAG LIGHT HAS BEEN ON AND I NEED SAFETY IN THE CAR,WONDERING IF RECALL HAS BEEN REPORTED

Incident date: Aug 20, 2017

THE BOX METAL FRAME IS COMPLETED RUSTED THRU WITH A LOT OF THE FRAME RUSTED AWAY UNDER THE DRIVER AND PASSENGER SIDE BY FRONT DOOR AREA.I FOUND THIS OUT WHEN I WENT TO JACK UP THE CAR AT THE FRAME.

Incident date: Feb 1, 2018

TL* THE CONTACT OWNS A 2005 HYUNDAI ELANTRA. WHILE DRIVING 20 MPH, THE PASSENGER SIDE SUBFRAME FRACTURED ALONG THE WHEEL WELL. THE CONTACT STATED THAT THERE WAS SEVERE RUST TO THE VEHICLE'S SUBFRAME. THE VEHICLE WAS NOT TAKEN TO BE INSPECTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER AND LOCAL ... Read more

Incident date: Dec 1, 2017

COMPLETE LOST OF CONTROL NO STEERING ABILITIES

Crash Fire 3 injured

Incident date: Dec 1, 2017

COMPLETE LOST OF CONTROL NO STEERING ABILITIES

Crash Fire 3 injured

Incident date: Dec 1, 2017

COMPLETE LOST OF CONTROL NO STEERING ABILITIES

Crash Fire 3 injured

Incident date: Jan 25, 2016

PASSENGERS SEAT WAS CHECKED .FAULTY SENSOR IN SEAT .$1800. 00 TO FIX .CANT AFFORD TO FIX ON A FIXED INCOME

Incident date: Feb 2, 2015

TL* THE CONTACT OWNS A 2005 HYUNDAI ELANTRA. THE CONTACT STATED THAT THE METAL WHEEL RIMS PREMATURELY RUSTED WITH DETERIORATION CAUSING THE TIRES TO HAVE LOW PRESSURE, THEN SEVERAL TIMES THE CONTACT HAD TO REPLACE THE TIRES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT TIRE REPAIR TECHNICIAN TO INSPECT A... Read more

Incident date: Feb 2, 2015

Incident date: Jul 15, 2016

TL* THE CONTACT OWNS A 2005 HYUNDAI ELANTRA. UPON STARTING THE VEHICLE, THE AIR BAG INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE OCS MAT FAILED AND THE FRONT PASSENGER SEAT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BY THE CONTACT'S HUSBAND; HOW... Read more

Incident date: Jul 15, 2016

Incident date: Feb 6, 2017

23,000 ORIGINAL MILES. NEVER INVOLVED IN A CRASH. FRONT PASSENGER AIR BAG LIGHT INDICATES AIR BAG OFF EVEN WITH AN ADULT PASSENGER SEATED AND BELTED IN THE SEAT. INDICATOR LIGHT COMES ON AND OFF INTERMITTENTLY, FOR SEVERAL MINUTES AT A TIME, WHILE DRIVING VEHICLE CONTINUOUSLY. HAPPENS ON CITY STREET... Read more

Incident date: Sep 6, 2016

AIR BAG LIGHT KEEP ON COMING AND GOING OFF

Incident date: May 24, 2016

TL* TAKATA RECALL. THE CONTACT OWNS A 2005 HYUNDAI ELANTRA. WHILE DRIVING 30 MPH OR HIGHER, ANOTHER VEHICLE CRASHED INTO THE PASSENGER SIDE OF THE CONTACT'S VEHICLE. THE FRONT PASSENGER SIDE WINDOW SHATTERED AND THE DOOR FRACTURED ON THE CONTACT'S VEHICLE. THE DRIVER SUSTAINED NECK INJURIES, ARM PAI... Read more

Crash 3 injured

Incident date: Apr 5, 2016

WHILE TURNING LEFT OR RIGHT CLICKING SOUND. CLICKING SOUND STOPS WHEN STEERING WHEEL IS STRAIGHTEN.

Incident date: Mar 16, 2016

ENGINE ACCELERATED WHILE DRIVING STRAIGHT ON A CITY 4 LANE HWY & BRAKE PEDAL WOULDN'T STOP THE CAR. FINALLY WAS STOPPING AND I SHUT THE CAR OFF. HAD IT TOWED HOME WHERE IT HAS BEEN UNUSABLE SINCE OUT OF FEAR. I HAVE READ MANY REPORTS OF ACCIDENTS ON DIFFERENT HYUNDAI MODELS AND DIFFERENT YEARS BECAU... Read more

Incident date: Oct 20, 2015

I BOUGHT A NEW CABIN AIR FILTER TO REPLACE THE OLD CABIN AIR FILTER FOR 2005 HYUNDAI ELANTRA. WHEN I OPENED THE COMPARTMENT, TO MY SHOCK, THERE ISN'T AN AIR FILTER FOUND.....UPDATED 12/02/15 *BF *CN

Incident date: Jun 15, 2015

THE OCCUPANT CLASSIFICATION SYSTEM (OCS) INSTALLED IN THE RIGHT FRONT SEAT OF THE VEHICLE WILL NOT TURN OFF AND WILL NOT DETECT A PERSON IN THAT SEAT AND TURN THE "PASSENGER SEAT AIR BAG OFF" LIGHT OFF. THIS HAS BEEN A REOCCURRING PROBLEM IN OTHER HYUNDAI VEHICLES AND RECALLS HAVE BEEN ISSUED. FOR S... Read more

Incident date: Dec 10, 2014

TL* THE CONTACT OWNED A 2005 HYUNDAI ELANTRA. WHILE DRIVING 35 MPH, A VEHICLE IN FRONT STALLED CAUSING THE CONTACT TO REAR END THE VEHICLE. THE AIR BAGS DID NOT DEPLOY. THE CONTACT SUSTAINED CHEST INJURIES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE MAN... Read more

Crash 1 injured

Incident date: Mar 15, 2015

AIR BAG LIGHT STAYS ON AT ANY SPEED. *TR

Incident date: Feb 4, 2015

AUTOMOBILE DEVELOPED A THUMPING IN THE STEERING AND THE TIRE WAS FOUND TO HAVE A BROKEN TREAD BELT. IT COULD BE PLAINLY SEEN IN THE LATERAL RIPPLING OF THE TREAD. DEALER WOULD NOT REPLACE THE TIRE BUT WANTED TO SELL A NEW SET. NO CUTTING OR OTHER DAMAGE FOUND IN TREAD AT POINT OF BREAK. SUSPECT... Read more

Showing 50 of 180 complaints.

EPA Fuel Economy, 2005 HYUNDAI ELANTRA

Trim / Engine	City MPG	Highway MPG	Combined MPG	Fuel Type	Annual Fuel Cost
2.0L 4-cyl, Automatic 4-spd (Front-Wheel Drive)	21.0	29.0	24.0	Regular	$2,550
2.0L 4-cyl, Manual 5-spd (Front-Wheel Drive)	23.0	31.0	26.0	Regular	$2,350

CO2 Emissions: -1.0 g/mile (Midsize Cars)

Source: U.S. Environmental Protection Agency (EPA). Actual fuel economy may vary based on driving conditions.

Technical Service Bulletins, 2005 HYUNDAI ELANTRA

58 manufacturer communications from 39 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
350000 EQUIPMENT	6
356000 EQUIPMENT ADAPTIVE/MOBILITY	5
110000 ELECTRICAL SYSTEM	5
060000 ENGINE AND ENGINE COOLING	4
103000 POWER TRAIN:AUTOMATIC TRANSMISSION	4
103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)	4
140000 AIR BAGS	3
200000 WHEELS	3

130000 VISIBILITY/WIPER (PWS)

This bulletin contains information about the proper removal of the windshield wiper blade protective cover on all models. If the protective cover is not removed correctly, there is a possibility of the rubber insert and rail spring becoming

130000 VISIBILITY

060000 ENGINE AND ENGINE COOLING

This bulletin provides important checkpoint guidelines when performing engine oil and filter change services.

162000 STRUCTURE:BODY

Hyundai applies a Paint Protection Film (PPF) on new vehicles before delivery to dealerships. It provides a barrier between the paint and contaminants, such as rail dust, acid rain, and industrial fallout. In rare cases, the paint can becom

130000 VISIBILITY

This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside th

060000 ENGINE AND ENGINE COOLING

Follow the guidelines outlined in this bulletin to inspect and clean or replace certain components of the engine intake system accordingly during engine short block or sub-assembly replacement.

190000 TIRES

Effective June 2, 2008, Federal Motor Vehicle Safety Standard 110 (FMVSS 110) established a threshold for correcting load carrying capacity information indicated on tire placards when vehicle weight has been increased before retail sale

100000 POWER TRAIN

Hyundai approves only the ATF, DCT gear oil and IVT gear oil specified in the vehicle??A?A?s owner??A?A?s manual. ??A?A? Use of other ATF may result in improper shift quality or other drivability conditions. ??A?A? Use of other DCT and IV

350000 EQUIPMENT

This bulletin provides the service procedure for engine connecting rod bearing clearance testing. Perform the procedure outlined in this bulletin to fulfill the Bearing Clearance Test inspection requirements to determine next required steps

060000 ENGINE AND ENGINE COOLING

030000 BRAKES (PWS)

This bulletin provides best practice recommendations when performing brake service procedures.

356000 EQUIPMENT ADAPTIVE/MOBILITY

This bulletin provides best practice recommendations when performing brake service procedures.

350000 EQUIPMENT

This bulletin provides best practice recommendations when performing brake service procedures.

350000 EQUIPMENT

This bulletin provides the inspection procedure and repair guidelines for certain vehicles listed below.

060000 ENGINE AND ENGINE COOLING

This bulletin provides the inspection procedure and repair guidelines for certain vehicles listed below.

030000 BRAKES (PWS)

This bulletin describes the procedure to inspect and identify fluid which may appear around the brake caliper area.

200000 WHEELS

This bulletin provides tire vibration service procedures, including how to optimize vehicle vibration performance. For all wheel/tire balance claims, the a??Tire Balance Data Sheeta?? must be fully completed including imbalance and Road For

190000 TIRES

356000 EQUIPMENT ADAPTIVE/MOBILITY

This bulletin provides information regarding condensation related to moisture accumulation in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. The TSB illustrates the various causes of condensation inside the la

350000 EQUIPMENT

120000 EXTERIOR LIGHTING

200000 WHEELS

This bulletin provides information on tire maintenance best practices and procedures for dealers and customers to maximize tire life and performance.

190000 TIRES

This bulletin provides information on tire maintenance best practices and procedures for dealers and customers to maximize tire life and performance.

350000 EQUIPMENT

This bulletin describes the general guidelines to help disinfect and protect vehicle exterior/interior surfaces using recommended safe chemical products.

350000 EQUIPMENT

This bulletin provides information on identifying dealer stock vehicles with either: a?? A Battery SOC alert - low Battery State of Charge (SOC) at or below 50%. a?? A 30 Day alert - vehicle has not started and reported an SOC in 30 days.

110000 ELECTRICAL SYSTEM

100000 POWER TRAIN

The automatic transmission warranty repair policy authorizes in-dealership repairs of the following components for both OEM (new) and remanufactured automatic transmissions:

356000 EQUIPMENT ADAPTIVE/MOBILITY

The automatic transmission warranty repair policy authorizes in-dealership repairs of the following components for both OEM (new) and remanufactured automatic transmissions:

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

The automatic transmission warranty repair policy authorizes in-dealership repairs of the following components for both OEM (new) and remanufactured automatic transmissions:

356000 EQUIPMENT ADAPTIVE/MOBILITY

This bulletin describes the general guidelines to disinfect and protect vehicle interior surfaces using certain safe chemical products.

020000 SUSPENSION

This bulletin describes the requirements for all wheel alignment and/or vehicle tracking claims and best practices when diagnosing and conducting alignment-related repairs for all models and model years.

110000 ELECTRICAL SYSTEM

This bulletin provides guidelines to inspect the USB, head unit, and multi-box for common connection conditions. 2. This bulletin presents guidelines to inspect for common Android Auto and Apple CarPlay connection conditions. 3. This bullet

280000 BACK OVER PREVENTION

The Blind Spot Detection (BSD) or Blind-Spot Collision Warning (BCW) is a system that measures the speed of and distance from the following vehicles by using two magnetic wave radar sensors attached in the rear bumper. The BSD/BCW detects v

270000 LANE DEPARTURE

356000 EQUIPMENT ADAPTIVE/MOBILITY

This bulletin provides instruction detailing the proper methodology for scanning and uploading captured GDS data files to the Techline Repository. Compliance with this bulletin ensures that the GDS data files are correctly transferred and m

110000 ELECTRICAL SYSTEM

This bulletin provides the procedure to write the Vehicle Identification Number (VIN) during the replacement of the Engine Control Module (ECM) or Powertrain Control Module (PCM). Once the VIN has been programmed to the ECM/PCM, it cannot b

100000 POWER TRAIN

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

THIS BULLETIN PROVIDES INFORMATION ON COMPONENTS, ATTRIBUTES, AND PRECAUTIONS OF THE 7-SPEED DRY-TYPE DUAL CLUTCH TRANSMISSION (DCT).

106000 POWER TRAIN:AXLE ASSEMBLY

"THE PCM OR TCM CONTAINS LOGIC TO ADJUST SOLENOID DUTY AND LINE PRESSURE AS NEEDED TO COMPENSATE FOR NORMAL CLUTCH WEAR OVER THE LIFE OF THE TRANSAXLE. THIS BULLETIN PROVIDES THE PROCEDURES NECESSARY TO RESET (ERASE) AND RELEARN THE PCM/TCM

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

HYUNDAI: ATA SOLENOID DIAGNOSTIC TROUBLE CODES P0740, P0741, P0742, P0743, P0746, P0748, P0750, P0755, P0760, P0765, P0770. INCORRECT OPERATION OF THE TRANSAXLE SOLENOIDS MAY RESULT IN THE FOLLOWING SYMPTOMS-CHECK ENGINE LIGHT ILLUMINATED

061000 ENGINE AND ENGINE COOLING:ENGINE

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

HYUNDAI: AUTOMATIC TRANSAXLE RANGE SWITCH DIAGNOSTIC TROUBLE CODES P0705 (RANGE SWITCH SIGNAL PROBLEMS), P0707 (RANGE SWITCH OPEN CIRCUIT), AND P0708 (RANGE SWITCH SHORT CIRCUIT OR MULTIPLE INPUTS). AN IMPROPERLY ADJUSTED OR IMPROPERLY OP

061000 ENGINE AND ENGINE COOLING:ENGINE

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

AUTOMATIC TRANSAXLE HARSH AND/OR DELAYED UPSHIFT OR DOWNSHIFT - GDS ANALYSIS. *PE

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

AUTOMATIC TRANSAXLE HARSH AND/OR DELAYED ENGAGEMENT INTO DRIVE OR REVERSE. *KB

106000 POWER TRAIN:AXLE ASSEMBLY

AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES (DTC) LIST. *KB

110000 ELECTRICAL SYSTEM

OCCUPANT CLASSIFICATION SYSTEM (OCS) REPROGRAMMING. PASSENGER AIR BAG OFF INDICATOR LIGHT MAY NOT TURN OFF OR MAY SWITCH ON AND OFF WHEN SOME SMALLER STATURE ADULTS ARE SEATED IN THE RIGHT FRONT PASSENGER SEAT. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *SC

106000 POWER TRAIN:AXLE ASSEMBLY

REPROGRAMS ARE AVAILABLE FOR AUTOMATIC TRANSAXLE DRIVEABILITY ISSUES. TECHNET TIMES. HYUNDAI. *TT

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

REPROGRAMMING INSTRUCTIONS FOR DIAGNOSTIC TROUBLE CODE (DTC) P0736. CHECK ENGINE LIGHT ILLUMINATED AND DTC P0736 (REVERSE GEAR INCORRECT RATIO) STORED. *TT

110000 ELECTRICAL SYSTEM

AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *NM

140000 AIR BAGS

OCCUPANT CLASSIFICATION SYSTEM (OCS) REPROGRAMMING. FIX-IT-RIGHT. HYUNDAI TECHNET TIMES. *TT

102000 POWER TRAIN:MANUAL TRANSMISSION

TRANSMISSION GEARSHIFT KNOB CAP REPLACEMENT - SERVICE CAMPAIGN T14. *TT

140000 AIR BAGS

THE OCCUPANT CLASSIFICATION SYSTEM (OCS) PASSENGER AIR BAG OFF INDICATOR LIGHT MAY NOT TURN OFF OR MAY SWITCH ON AND OFF WHEN SOME SMALLER STATURE ADULTS ARE SEATED IN THE RIGHT FRONT PASSENGER SEAT. *TT FIT-IT-RIGHT OCCUPANT CLASSIFICAT

141100 AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE

AIR BAG CONTROL UNIT (ACU) REPROGRAMMING PROCEDURE (SERVICE CAMPAIGN 919). *TT

200000 WHEELS

WHEEL ALIGNMENT SPECIFICATIONS. *TT

140000 AIR BAGS

AIRBAG REPROGRAMMING GUIDE. *TT

NHTSA Safety Investigations, HYUNDAI ELANTRA

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

DP, Closed , Model Year: 2017

Loss of Motive Power

The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia Americ... a, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.Read more

EA, Closed , Model Year: 2013

Engine Fires

On March 29, 2019, the Office of Defects Investigation (ODI) opened two Preliminary Evaluations (PE19-003 on Hyundai and PE19-004 on Kia) to broadly investigate incidents of non-crash fires (regardless of origin or operational status of the vehicle) on various model year Hyundai and Kia vehicles. ... During the PE investigations, Hyundai and Kia issued several recalls to address vehicle fires, including those due to engine failures involving various engine types. The remedies for the engine failure recalls typically involve engine inspection (to detect existing damage), and if necessary, engine replacement. Additionally, both manufacturers have been installing an engine control software modification known as Knock Sensor Detection Software (KSDS) which is intended to detect impending engine failure, alert the driver, and limit engine power (to lessen likelihood of engine failure).KSDS is being installed under recalls and non-safety field actions, and both companies have extended limited engine warranties (see recall files). On December 22, 2021, ODI upgraded PE19-003 and PE19-004 to this Engineering Analysis (EA21-003, covering both Hyundai and Kia) to evaluate the scope of the prior recalls related to engine failures/fires and the efficacy of the recall remedies for the recalls, as well as the long-term viability of related programs and non-safety field actions being conducted by Hyundai and Kia. The former issue involved approximately 550,000 MY 2013 Hyundai Elantra, MY 2011 Kia Sorento, and MY 2012-2015 Kia Rio. The latter issue involved approximately 2.5 million recalled vehicles, which have been identified as displaying potential remedy concerns: Hyundai recalls 15V-568, 17V-226, 20V-746, and 21V-727; and Kia recalls 17V-224, 19V-120, 20V-750, and 21V-844. Regarding the recall scope issue, among all of the scope vehicles identified at EA opening, ODI found only the MY 2011 Kia Sorento vehicles equipped with both the Theta II 2.4L 4-cylinder Multi-Point Injection (MPI) and the Lambda II 3.5L 6-cylinder MPI engines experienced relatively high rates of reported fires. In December 2023, Kia issued recall 23V-877 that will cover about 80,000 MY 2011 Kia Sorento vehicles equipped with the Theta II 2.4L MPI engines. The remedy will involve an inspection, and if necessary, a replacement of the engine, as well as the installation of KSDS. It should be noted that in 2021 these vehicles were included in a KSDS product improvement campaign with warranty extension. For the MY 2011 Sorento vehicles equipped with the Lambda II 3.5L engines, ODI believes that future engine failures/fires involving these vehicles will likely be due to a lax in adhering to the proper or scheduled engine maintenance (regular engine oil changes), rather than a design or manufacturing engine issue. Regarding the issue of the efficacy of the recall remedies, ODI found the majority of the recalled Hyundai and Kia vehicles, by model, experienced lower reported fire rates after the remedies were applied. Furthermore, ODI found that for most vehicles that did not receive the recall remedies, by model, experienced relatively high fire rates. To address this problem, Hyundai informed ODI in December 2023, that it will renotify all of its owners covered by the Hyundai recalls of engine failures/fires every 8 months for the next 3 years. In December 2023, Kia stated that it will renotify the majority of its owners every 8 months for the next 3 years.Several previously recalled Kia models are excluded from the renotification due to their lower reported rates of engine fires. Overall, the renotification actions will help to increase the recall completion rates, thus reduce the frequency of engine fires in the future. In view of the recall action being taken by Kia and renotification actions being taken by both Kia and Hyundai, ODI is closing this Engineering Analysis. Also, both companies have been released from the 2020-iniated Consent Orders (Kia since November 2022 and Hyundai since November 2023). The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.Read more

DP, Closed , Model Year: 2007

Throttle control system vulnerabilities

The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening ... of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.Read more

EA, Closed , Model Year: 2011

Headliner Bracket Detachment

In March 2013, Hyundai issued a safety recall to reinforce the attachment of the metal support brackets to the headliner assembly in approximately 186,254 model year 2011-2013 Hyundai Elantra vehicles built in Korea and sold in the U.S. (see NHTSA recall 13V-115 for more information).The recall cove... Read more

PE, Closed , Model Year: 2012

Side Curtain Air Bag Improper Deployment

The Office of Defects Investigation (ODI) is aware of one incident of an improper deployment of the driver-side curtain air bag that deployed as a result of a crash involving a model year (MY) 2012 Hyundai Elantra.An inspection of this vehicle showed that a metal bracket (stiffener) in the headliner... Read more

PE, Closed , Model Year: 2001

FRONT LOWER CONTROL ARMS RUSTING

ON APRIL 14, 2009, HYUNDAI MOTOR CORPORATION SUBMITTED TO ODI A DEFECT INFORMATION REPORT INDICATING THAT IT WOULD RECALL A SALT-BELT POPULATION OF APPROXIMATELY 155,317 MODEL YEAR (MY) 2001 THROUGH 2003 HYUNDAI ELANTRA VEHICLES TO REMEDY A DEFECT THAT CAN RESULT IN LOSS OF VEHICLE CONTROL WITH AN I... NCREASED RISK OF A CRASH WHILE DRIVING (09V-125).THE AFFECTED VEHICLES COVER ALL MY 2001, MY 2002, AND MY 2003 THROUGH JANUARY 13, 2003 PRODUCTION.THESE INCLUDE ELANTRA VEHICLES THAT WERE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN.THE TOTAL THREE-YEAR PRODUCTION POPULATION FOR THE ELANTRA VEHICLES IS APPROXIMATELY 350,000. ACCORDING TO HYUNDAI, ROAD SALT CAN COLLECT IN THE OUTBOARD PORTION OF THE FRONT LOWER CONTROL ARM AND MAY RESULT IN INTERNAL CORROSION LEADING TO THINNING OF THE STEEL IN THE LOWER CONTROL ARMS.THE CORROSION MAY PROGRESS TO THE POINT WHERE THE LOWER CONTROL ARM UPPER AND LOWER PANELS BECOME PERFORATED.A PERFORATED FRONT LOWER CONTROL ARM MAY FRACTURE BETWEEN ITS BALL JOINT ATTACHMENT AND THE FORWARD AND REARWARD PIVOT ATTACHMENTS TO THE CHASSIS.THIS COULD AFFECT THE DRIVER'S CONTROL OVER THE TIRE AND WHEEL ASSEMBLY.HYUNDAI'S RECALL PROCEDURE INSTRUCTS DEALERS TO MEASURE THE THICKNESS OF THE STEEL IN THE FRONT LOWER CONTROL ARMS.IF SPECIFIED LEVELS OF CORROSION DAMAGE HAVE OCCURRED, THE FRONT LOWER CONTROL ARMS WILL BE REPLACED WITH NEW FRONT LOWER CONTROL ARMS WITH ADDITIONAL HOLES IN THE UPPER AND LOWER PANELS. ODI'S ANALYSIS OF FRONT LOWER CONTROL ARM COMPLAINT AND WARRANTY DATA SHOWS 220 COMPLAINTS AND 1,033 WARRANTY CLAIMS FOR THE TOTAL APPROXIMATELY 350,000 SUBJECT VEHICLES SOLD THROUGHOUT THE UNITED STATES, RESULTING IN A COMPLAINT RATE OF 62.82 PER 100,000 VEHICLES AND A CLAIM RATE OF 0.3 PERCENT.ODI'S ANALYSIS FOUND 7 COMPLAINTS AND 90 WARRANTY CLAIMS IN 132,475 VEHICLES SOLD IN NON-SALT BELT STATES, RESULTING IN A COMPLAINT RATE OF 5.3 PER 100,000 VEHICLES AND A CLAIM RATE OF 0.1 PERCENT. ODI'S ANALYSIS FURTHER FOUND 196 COMPLAINTS AND 943 WARRANTY CLAIMS IN 155,317 VEHICLES SOLD IN SALT BELT STATES, RESULTING IN A COMPLAINT RATE OF 126.2 PER 100,000 VEHICLES AND A CLAIM RATE OF 0.6 PERCENT.ODI IDENTIFIED 34 INCIDENTS OF LOWER CONTROL ARM FRACTURE RELATED TO CORROSION, ALL OF WHICH OCCURRED IN SALT BELT STATES.THE DATA DO NOT SHOW A DEFECT TREND IN VEHICLES OUTSIDE THE REGION COVERED BY HYUNDAI'S RECALL. THIS PRELIMINARY EVALUATION IS CLOSED.Read more

PE, Closed , Model Year: 2007

ENGINE STALLING - FUEL PUMP FAILURE

ON AUGUST 19, 2008, HYUNDAI SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING FUEL PUMP FAILURE RESULTING IN ENGINE STALL IN APPROXIMATELY 65,000 MODEL YEAR 2008 HYUNDAI ELANTRA VEHICLES WITH 2.0 LITER BETA ENGINES PRODUCED FROM NOVEMBER 5, 2007, THROUGH JUNE 28, 2008 (NHTSA RECALL NO. 08V-4... Read more

EA, Closed , Model Year: 2001

AIR BAG LIGHT ILLUMINATION

HYUNDAI IS CONDUCTING TWO SAFETY RECALLS TO CORRECT TWO SAFETY DEFECTS DESCRIBED BELOW.UNDER SAFETY RECALL 08V-532, HYUNDAI WILL INSTALL A VINYL PROTECTIVE SHIELD/COVER TO PREVENT SHORT CIRCUITS IN THE AIR BAG CONTROL MODULE CAUSE BY SPILLS OF LIQUIDS THAT SEEP INTO THE MODULE CONNECTOR. THIS ACTION... Read more

PE, Closed , Model Year: 2001

AIR BAG LIGHT ILLUMINATION

IN CERTAIN MODEL YEAR (MY) 2001 AND 2002 VEHICLES, THE AIR BAG SYSTEM IS SUSCEPTIBLE TO AIR BAG LIGHT ILLUMINATION AND AIR BAG NON-DEPLOYMENT OR INADVERTENT DEPLOYMENT FROM LIQUID CONTAMINATION OF THE AIR BAG CONTROL MODULE.THE CONTROL MODULE IS LOCATED BENEATH AND NEAR CENTER CONSOLE CUP HOLDERS.OD... Read more

PE, Closed , Model Year: 2004

POST-CRASH FUEL TANK LEAK

PE04-041 WAS OPENED TO INVESTIGATE A FUEL LEAK INCIDENT THAT OCCURRED DURING AN INSURANCE INSTITUTE FOR HIGHWAY SAFETY (IIHS) FRONTAL CRASH OFFSET TEST ON THE SUBJECT VEHICLE.THIS INVESTIGATION REVEALED THAT THE VAPOR TUBE HOSE CLAMP EAR WAS MISPOSITIONED AND FACING TOWARD THE FUEL TANK, WHICH ENABL... Read more

SQ, Open , Model Year: 1996

FUEL CAP REPLACEMENT CAMPAIGN 36

There is no summary currently available

PE, Closed , Model Year: 1996

WINDSHIELD WIPER FAILURE

IN ITS LETTER DATED FEBRUARY 14, 1997, HYUNDAI STATED THAT APPROXIMATELY 75,000 HYUNDAI VEHICLES (CERTAIN MODEL YEAR 1996-97 ELANTRA, ACCENT, SONATA AND TIBURON MODELS BUILT THROUGH OCTOBER 18, 1996 -- SEE NHTSA RECALL NO. 97V-026 FOR DETAILS) WILL BE RECALLED FOR A DEFECT IN THE WINDSHIELD WIPER MO... Read more

SQ, Open , Model Year: 1992

REAR SUSPENSION FAILURE

ODI HAS RECEIVED COMPLAINTS PERTAINING TO REAR SUSPENSION PROBLEMS.ADDITIONAL INFORMATION IS NEEDED TO FULLY UNDERSTAND THE NATURE AND CIRCUMSTANCES OF THE CANADIAN RECALL.FURTHERMORE, THIS INVESTIGATION IS OPENED TO EVALUATE HYUNDAI'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN TO INCLUDE ... Read more

PE, Closed , Model Year: 1990

SCISSOR JACK FAILURE

There is no summary currently available

HYUNDAI ELANTRA - All Years Overview

Complete safety history for the HYUNDAI ELANTRA across all model years (1994, 2026).

102 Total Recalls

12,126 Total Complaints

14 Investigations

1,279 Reported Crashes

273 Reported Fires

19 Reported Deaths

HYUNDAI ELANTRA - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2026	1	2	View
2025	0	31	View
2024	1	94	View
2023	2	159	View
2022	5	143	View
2021	6	214	View
2020	3	342	View
2019	1	334	View
2018	0	406	View
2017	4	1,077	View
2016	2	398	View
2015	3	356	View
2014	2	552	View
2013	4	1,863	View
2012	4	920	View
2011	5	589	View
2010	3	504	View
2009	4	321	View
2008	7	424	View
2007	6	365	View
2006	1	209	View
2005 (current)	4	180
2004	5	209	View
2003	5	310	View
2002	6	431	View
2001	6	445	View
2000	1	259	View
1999	2	183	View
1998	0	75	View
1997	3	196	View
1996	3	138	View
1995	1	179	View
1994	2	110	View
1993	0	39	View
1992	0	46	View

Other HYUNDAI Models

Model	Recalls	Complaints
SONATA	184	21,863	View
SANTA FE	153	9,962	View
PALISADE	124	2,704	View
TUCSON	95	8,074	View
SONATA HYBRID	67	1,129	View
IONIQ 5	66	1,865	View
ACCENT	64	2,745	View
SANTA FE HYBRID	57	347	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2005 HYUNDAI ELANTRA

Complaint Statistics

Top Reported Components

EPA Fuel Economy, 2005 HYUNDAI ELANTRA

Technical Service Bulletins, 2005 HYUNDAI ELANTRA

Most Affected Components

NHTSA Safety Investigations, HYUNDAI ELANTRA

HYUNDAI ELANTRA - All Years Overview

HYUNDAI ELANTRA - Year by Year

Other HYUNDAI Models