2003 HYUNDAI ELANTRA

5 recalls, 310 complaints - 81 TSBs

SUSPENSION:FRONT:CONTROL ARM

Defect Description

HYUNDAI IS RECALLING 160,904 MY 2001-2003 ELANTRA AND MY 2003 TIBURON VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYL... Read more

Consequence

THE FRACTURING OF THE CONTROL ARM COULD AN OWNER'S CONTROL OVER THEIR VEHICLE THAT MAY INCREASE THE RISK OF A CRASH.

Remedy

DEALERS WILL INSPECT THE FRONT LOWER CONTROL ARMS FOR CORROSION DAMAGE. IF SPECIFIED LEVELS OF INTERNAL CORROSION DAMAGE ARE FOUND, THE FRONT LOWER CONTROL ARMS WILL BE REPLACED WITH NEW FRONT LOWER CONTROL ARMS INCORPORATING ADDITIONAL HOLES IN THE UPPER AND LOWER PANELS. IF THE FRONT LOWER CONTR... Read more

160,904 vehicles affected

Manufacturer: Hyundai Motor Company

FUEL SYSTEM, GASOLINE:STORAGE

Defect Description

CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY" A VALVE ON THE FUEL TANK ASSEMBLY MAY NOT CLOSE PROPERLY. IF A VEHICLE ROLLS OVER AND THE FUEL TANK ASSEMBLY VALVE IS NOT PROPERLY CLOSED, FUEL SPILLAGE MAY OCC... Read more

Consequence

FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.

Remedy

DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. THE RECALL BEGAN ON OCTOBER 5, 2004. OWNERS SHOULD CONTACT HYUNDAI DE PUERTO RICO AT 1-800-981-0188.

919 vehicles affected

Manufacturer: HYUNDAI CARIBBEAN-PUERTO RICO

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

Defect Description

SOME PASSENGER VEHICLES CONTAIN A FUEL TANK ASSEMBLY VALVE THAT MAY NOT CLOSE PROPERLY. IF A VEHICLE WITH A FUEL TANK ASSEMBLY VALVE THAT IS NOT PROPERLY CLOSED WERE TO ROLL OVER, FUEL SPILLAGE MAY OCCUR.

Consequence

FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.

Remedy

DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. OWNER NOTIFICATION BEGAN ON JUNE 30, 2004. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.

263,968 vehicles affected

Manufacturer: HYUNDAI MOTOR COMPANY

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

Defect Description

ON CERTAIN PASSENGER VEHICLES, THE BRAKE TUBES FOR THE REAR BRAKES CAN CONTACT THE STEERING GEARBOX MOUNTING BRACKETS.

Consequence

CONTACT BETWEEN THE REAR BRAKE TUBES AND THE STEERING GEARBOX MOUNTING BRACKETS MAY RESULT IN REAR BRAKE TUBE WEAR AND CORROSION, INCREASING THE RISK OF BRAKE FLUID LEAKAGE. BRAKE FLUID LEAKAGE COULD RESULT IN REDUCED BRAKING CAPABILITY, WHICH COULD RESULT IN A CRASH.

Remedy

DEALERS WILL REPOSITION THE REAR BRAKE TUBES, INSTALL BRAKE TUBE CLIPS, AND APPLY ANTI-CORROSION MATERIAL TO THE REAR BRAKE TUBES. OWNER NOTIFICATION BEGAN JANUARY 22, 2004. OWNERS SHOULD CONTACT HYUNDAI OF PUERTO RICO AT 1-800-633-5151.

1,993 vehicles affected

Manufacturer: HYUNDAI CARIBBEAN-PUERTO RICO

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

Defect Description

ON CERTAIN PASSENGER VEHICLES, THE REAR BRAKE TUBES PASS BEHIND THE FRONT SUSPENSION CROSSMEMBER. TWO STEERING GEARBOX MOUNTING BRACKETS ARE WELDED TO THE CROSSMEMBER. ON VEHICLES EQUIPPED WITH AN ANTILOCK BRAKE SYSTEM (ABS), THE REAR BRAKE TUBES COULD CONTACT BOTH STEERING GEARBOX MOUNTING BRACKE... Read more

Consequence

FLUID LEAKAGE COULD RESULT IN REDUCED BRAKING CAPABILITY INCREASING THE RISK OF A CRASH.

Remedy

DEALERS WILL REPOSITION THE REAR BRAKE TUBES SO THEY DO NOT CONTACT THE MOUNTING BRACKETS, INSTALL BRAKE TUBE CLIPS TO CONTROL THE LOCATION OF THE REAR BRAKE TUBES, AND APPLY ANTI-CORROSION MATERIAL TO THE TUBES IN THE AREAS WHERE CONTACT WITH THE MOUNTING BRACKETS MAY HAVE OCCURRED. OWNER NOTIFICA... Read more

312,292 vehicles affected

Manufacturer: HYUNDAI MOTOR COMPANY

Complaint Statistics

310 total complaints 59 crashes 1 fires 51 injuries

Top Reported Components

Component	Complaints
SUSPENSION	30
AIR BAGS	28
STEERING	15
AIR BAGS:FRONTAL	15
SUSPENSION:FRONT	13
SERVICE BRAKES, HYDRAULIC	12
SUSPENSION:FRONT:CONTROL ARM	12
STRUCTURE:BODY	11
EXTERIOR LIGHTING:HEADLIGHTS	9
ENGINE AND ENGINE COOLING:ENGINE	9

Incident date: Dec 12, 2023

The CVT seems to shudder uncontrollably when accelerating from zero and also when driving at 60mph on the interstate. The RPMs fluctuate erratically and spontaneously when traveling at 60mph or higher. Yes, the car can be inspected upon request-it does the shuddering every time it accelerates from... Read more

Incident date: Dec 12, 2023

Incident date: Oct 21, 2023

Outside temperature in the 70s had recently just rained and rear window was foggy. I turned on the rear defogger after about two minutes or so started smelling something burning thought it was car exhaust. I parked the car and the rear window shattered.There was a hole the size of a baseball, and wh... Read more

Incident date: Oct 21, 2023

Headrest saftey mechanism deployed due to the tension pin breaking internally while sitting in a driveway. Nothing caused deployment other than random device faliure

Incident date: Oct 21, 2023

Headrest saftey mechanism deployed due to the tension pin breaking internally while sitting in a driveway. Nothing caused deployment other than random device faliure

Incident date: May 15, 2023

Brake failure, turning into my parents driveway I had to swerve to miss a truck and drove in the yard because of it. It has been diagnosed a faulty brake vacuum pump that caused this failure. I am getting it looked at by a mechanic of Friday and hope that this issue didn't cause further problems wit... Read more

Incident date: May 15, 2023

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Numbers: 22V142000 (Visibility) and 23V163000 (Visibility) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a ... Read more

Incident date: Apr 1, 2021

Driver and front passenger inside plastic handles for doors broke apart from normal use. Drivers side outside plastic door handle also broke off. Getting out of the car requires power windows to be energized and lowered to access outside handles. The problem first appeared about a year ago.

Incident date: Apr 10, 2019

MY REAR SUBFRAME IS RUSTING SO BADLY THE REAR SUSPENSION IS FALLING APART.

Incident date: Apr 10, 2019

MY REAR SUBFRAME IS RUSTING SO BADLY THE REAR SUSPENSION IS FALLING APART.

Incident date: Jul 5, 2020

TL* THE CONTACT OWNS A 2003 HYUNDAI ELANTRA. THE CONTACT STATED THAT THE PASSENGER'S SIDE CONTROL ARM BECAME DEFECTIVE WHICH CAUSED DIFFICULTY TO STEER THE VEHICLE AT VARIOUS SPEEDS. THE CONTACT THEN CALLED SUPERIOR HYUNDAI SOUTH (238 W MITCHELL AVE, CINCINNATI, OH 45232) WHERE SHE MADE AN APPOINTME... Read more

Incident date: Jul 5, 2020

Incident date: Feb 15, 2020

DRIVING ON HIGHWAY AND TURNING RIGHT; A TIRE BLEW. ON INSPECTION BY A MECHANIC, THE FRONT PASSENGER CONTROL ARM WAS BENT WITH RUST ON THE EXPOSED METAL. THE BENT CONTROL ARM ALLOWED THE TIRE TO RUB AGAINST THE INTERIOR FENDER, EVENTUALLY LEADING TO THE TIRE FAILING. THE TIRE WAS IN GREAT CONDITION B... Read more

Incident date: Jan 7, 2020

WHEN PRESSING THE BRAKES IT SOUNDS LIKE IT'S METAL TO METAL, THE STEERING MAKES A FUNNY NOISE WHEN YOU TURN THE STEERING WHEEL. ALSO CAR KEEPS SAYING 02 SENSOR BUT THERE'S NOTHING WRONG WITH IT AND THE CHECK ENGINE LIGHT KEEPS COMING ON BECAUSE OF IT.*DT

Incident date: Jan 7, 2020

Incident date: Dec 9, 2019

TL* THE CONTACT OWNS A 2003 HYUNDAI ELANTRA. THE CONTACT TOOK THE VEHICLE TO FUCCILLO LINCOLN HYUNDAI (518-379-0680, LOCATED AT 4101 STATE ST, SCHENECTADY, NY 12304) TO BE REPAIRED PER NHTSA CAMPAIGN NUMBER: 09V125000 (SUSPENSION). THE CONTACT DIAGNOSED THAT THE REAR SUBFRAME WAS RUSTED. THE TECHNIC... Read more

Incident date: Jul 15, 2019

BRAKE LIGHTS WILL NOT GO OFF, EVEN WHEN IGNITION IS OFF. REPLACED BRAKE LIGHT SWITCH AND TGE PROBLEM REMAINS.

Incident date: Jun 17, 2019

MY LOWER CONTROL ARM BROKE IN TWO AWAY FROM THE BODY AND OTHER DRIVE COMPONENTS DUE TO RUST AND I'M NOT SURE WHAT ELSE. I WAS DRIVING AT A SLOW SPEED HEARD A POP NOISE GOT OUT LOOKED AND THE TIRE WAS ALL THE WAY AGAINST THE WHEEL WELL.

Incident date: Jun 17, 2019

Incident date: Jan 1, 2014

TL* THE CONTACT OWNS A 2003 HYUNDAI ELANTRA. THE CONTACT STATED THAT WHILE DRIVING AT 15 MPH, WHEN DEPRESSING THE ACCELERATOR PEDAL THE VEHICLE FAILED TO ACCELERATE AND WOULD TURN OFF AND ON. THE CONTACT CALLED THE LOCAL DEALER (SACRAMENTO HYUNDAI LOCATED AT 6250 FLORIN RD, SACRAMENTO, CA 95823, (9... Read more

Incident date: Feb 22, 2019

OUR 2003 HYUNDAI ELANTRA IS SUFFERING FROM SEVERE CORROSION ON THE SUBFRAME/UNIBODY, A PROBLEM FOR WHICH A CLASS ACTION SETTLEMENT WAS APPROVED (SEE THE FOLLOWING LINK HTTP://SALTBELTCORROSION.HYUNDAIUSA.COM/ FOR DETAILS REGARDING THE CIRULLI V. HYUNDAI MOTOR AMERICA SETTLEMENT, WHICH REACHED FINAL ... Read more

Incident date: Feb 22, 2019

Incident date: Jan 1, 2014

TL* THE CONTACT OWNS A 2003 HYUNDAI ELANTRA. WHILE DRIVING 20 MPH, THE FRONT DRIVER SIDE WHEEL DETACHED FROM THE VEHICLE. THE CONTACT LOST CONTROL OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE FRONT PASSENGER LOWER CONTROL ARM WAS RUSTED FROM THE INSIDE OUT AND... Read more

Incident date: Jun 3, 2018

I HAD A WRECK TODAY ON A HIGHWAY WHERE I WAS TRAVELING AT 40 MPH AND I SLAMMED ON MY BRAKES AND HIT THE CAR IN FRONT OF ME WHEN THE VEHICLE IN FRONT OF ME STOPPED SUDDENLY. MY CHEST RAMMED INTO THE STEERING WHEEL AND THE BAGS DID NOT DEPLOY.THE CAR WAS TOTALLY SMASHED IN THE FRONT AND THE DOOR HAD A... Read more

Crash 1 injured

Incident date: Jun 3, 2018

Crash 1 injured

Incident date: Nov 14, 2014

2003 HYUNDAI ELANTRA. CONSUMER WRITES IN REGARDS TO PASSENGER SIDE CONTROL ARM CORROSION RECALL REIMBURSEMENT. *SMD *TR

Incident date: Nov 14, 2014

2003 HYUNDAI ELANTRA. CONSUMER WRITES IN REGARDS TO PASSENGER SIDE CONTROL ARM CORROSION RECALL REIMBURSEMENT. *SMD *TR

Incident date: Nov 29, 2017

RECALL # 03V257000, 09V125000, 03V496000 SEVERE RUSTING AND CORROSION UNDER MY CAR WHICH THEY CLAIM WAS "FIXED" UNDER THE RECALLS. THEY DID NOT FIX THIS! THE FRONT DRIVER SIDE AXLE IS COMPLETELY CORRODED AND BREAKING - THEY CLAIM THEY SPRAYED IT WITH ANTI CORROSION COMPOUND BUT THIS DID NOT STOP FUR... Read more

Incident date: Nov 29, 2017

Incident date: Apr 1, 2017

TL* THE CONTACT OWNS A 2003 HYUNDAI ELANTRA. WHILE ACTIVATING THE TURN SIGNALS IN EITHER DIRECTION, THE SIGNAL LIGHTS WOULD EITHER WORK INTERMITTENTLY OR NOT WORK AT ALL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS NOT N... Read more

Incident date: Apr 1, 2017

Incident date: Dec 6, 2016

RIGHT FRONT LOWER CONTROL ARM AND RIGHT FRONT AXLE, BROKE WHILE DRIVING, CAUSING LOSS OF CONTROL. THIS WAS A PREVIOUS RECALL, WHICH WAS DONE AT THE DEALERSHIP. REPLACEMENT OF THE CONTROL ARMS WERE NOT REQUIRED AT THE TIME. INSPECTION, UNDERCOATING AND ,DRILLED DRAINAGE HOLES WERE THE FIX. WHILE STRA... Read more

Incident date: Dec 6, 2016

Incident date: Nov 29, 2016

THE WHOLE REAR METAL BEAM HOLDING THE REAR SUSPENSION RUSTED OUT AND FELL OFF WHILE DRIVING SENT CSRD INTO A SPIN BEFORE WE GOT IT STOPPED COULD HAVE BEEN KILLED DRIVING ON INTERSTATE 70 FROM WARRENTON TO WENTZVILLE MO YESTERDAY MOURNING AT 5:30 AM. *TR

Incident date: Nov 29, 2016

Incident date: Nov 10, 2016

AIR BAG SIGN ON, I TOOK DEALER MECHANIC SAID IT IS MANUFACTURING ISSUE.

Incident date: May 1, 2005

ISSUES WITH PUMPING FUEL, I DON'T KNOW WHAT TO CALL IT, BUT WHILE PUMPING GAS I CAN PUMP 15 +/- CENTS AND THE HANDLE CUTS OF ASS IF THE TANK IS FULL, TAKES FOREVER TO PUT $10 IN. 2ND ISSUE IS THE ELECTRICAL, EACH TIME I BUMP THE DASH AT THE RADIO AREA THE LIGHTS EITHER COMES ON OR GOES OUT AND 2 WE... Read more

Incident date: May 1, 2005

Incident date: Jul 13, 2016

REPLACED SENSORS BECAUSE THE CHECK ENGINE LIGHT CAME ON, NOW THE CAR WON'T PASS INSPECTION. THE DIAGNOSTIC TESTS WON'T READ ANY MALFUNCTION AND THE AIRBAG LIGHT WON'T GO OFF

Incident date: Jul 13, 2016

REPLACED SENSORS BECAUSE THE CHECK ENGINE LIGHT CAME ON, NOW THE CAR WON'T PASS INSPECTION. THE DIAGNOSTIC TESTS WON'T READ ANY MALFUNCTION AND THE AIRBAG LIGHT WON'T GO OFF

Incident date: Jun 10, 2016

STARTING ON 6/10/2016, EVERY TIME I FILL UP THE FUEL TANK, THE FILL TUBE BACKS UP AND THE PUMP NOZEL SHUTS OFF. MAKING IT TAKE LONGER TO FILL THE TANK. THE VEHICLE IS STATIONARY WITH ENGINE OFF, AT ALL SERVICE STATIONS.

Incident date: Feb 22, 2016

I HAD TO REPLACE STRUTS IN FRONT

Incident date: Feb 22, 2016

I HAD TO REPLACE STRUTS IN FRONT

Incident date: Feb 22, 2016

I HAD TO REPLACE STRUTS IN FRONT

Incident date: Nov 15, 2015

TL* THE CONTACT OWNS A 2003 HYUNDAI ELANTRA. THE CONTACT STATED THAT THERE WAS AN ABNORMAL NOISE COMING FROM THE FRONT DRIVER SIDE TIRE. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC BUT WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT WAS INFORMED OF NHTSA CAMPAIGN... Read more

Incident date: Sep 9, 2015

TL* THE CONTACT OWNED A 2003 HYUNDAI ELANTRA. WHILE DRIVING 30 MPH, THE BRAKE PEDAL WAS DEPRESSED AND TRAVELED TO THE FLOORBOARD. THE BRAKES FAILED TO RESPOND AND ANOTHER VEHICLE CRASHED INTO THE FRONT PASSENGER SIDE OF THE CONTACT'S VEHICLE. THE VEHICLE SPUN AROUND SEVERAL TIMES. ONLY THE PASSENGER... Read more

Crash 1 injured

Incident date: Sep 9, 2015

Crash 1 injured

Showing 50 of 310 complaints.

EPA Fuel Economy, 2003 HYUNDAI ELANTRA

Trim / Engine	City MPG	Highway MPG	Combined MPG	Fuel Type	Annual Fuel Cost
2.0L 4-cyl, Automatic 4-spd (Front-Wheel Drive)	22.0	30.0	25.0	Regular	$2,450
2.0L 4-cyl, Automatic 4-spd (Front-Wheel Drive)	21.0	30.0	25.0	Regular	$2,450
2.0L 4-cyl, Manual 5-spd (Front-Wheel Drive)	21.0	30.0	25.0	Regular	$2,450
2.0L 4-cyl, Automatic 4-spd (Front-Wheel Drive)	22.0	30.0	25.0	Regular	$2,450

CO2 Emissions: -1.0 g/mile (Compact Cars)

Source: U.S. Environmental Protection Agency (EPA). Actual fuel economy may vary based on driving conditions.

Technical Service Bulletins, 2003 HYUNDAI ELANTRA

81 manufacturer communications from 63 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
103000 POWER TRAIN:AUTOMATIC TRANSMISSION	8
110000 ELECTRICAL SYSTEM	7
061000 ENGINE AND ENGINE COOLING:ENGINE	7
350000 EQUIPMENT	6
356000 EQUIPMENT ADAPTIVE/MOBILITY	5
106000 POWER TRAIN:AXLE ASSEMBLY	4
060000 ENGINE AND ENGINE COOLING	4
100000 POWER TRAIN	3

130000 VISIBILITY/WIPER (PWS)

This bulletin contains information about the proper removal of the windshield wiper blade protective cover on all models. If the protective cover is not removed correctly, there is a possibility of the rubber insert and rail spring becoming

130000 VISIBILITY

060000 ENGINE AND ENGINE COOLING

This bulletin provides important checkpoint guidelines when performing engine oil and filter change services.

162000 STRUCTURE:BODY

Hyundai applies a Paint Protection Film (PPF) on new vehicles before delivery to dealerships. It provides a barrier between the paint and contaminants, such as rail dust, acid rain, and industrial fallout. In rare cases, the paint can becom

130000 VISIBILITY

This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside th

060000 ENGINE AND ENGINE COOLING

Follow the guidelines outlined in this bulletin to inspect and clean or replace certain components of the engine intake system accordingly during engine short block or sub-assembly replacement.

190000 TIRES

Effective June 2, 2008, Federal Motor Vehicle Safety Standard 110 (FMVSS 110) established a threshold for correcting load carrying capacity information indicated on tire placards when vehicle weight has been increased before retail sale

100000 POWER TRAIN

Hyundai approves only the ATF, DCT gear oil and IVT gear oil specified in the vehicle??A?A?s owner??A?A?s manual. ??A?A? Use of other ATF may result in improper shift quality or other drivability conditions. ??A?A? Use of other DCT and IV

060000 ENGINE AND ENGINE COOLING

This bulletin provides the service procedure for engine connecting rod bearing clearance testing. Perform the procedure outlined in this bulletin to fulfill the Bearing Clearance Test inspection requirements to determine next required steps

350000 EQUIPMENT

030000 BRAKES (PWS)

This bulletin provides best practice recommendations when performing brake service procedures.

356000 EQUIPMENT ADAPTIVE/MOBILITY

This bulletin provides best practice recommendations when performing brake service procedures.

350000 EQUIPMENT

This bulletin provides best practice recommendations when performing brake service procedures.

350000 EQUIPMENT

This bulletin provides the inspection procedure and repair guidelines for certain vehicles listed below.

060000 ENGINE AND ENGINE COOLING

This bulletin provides the inspection procedure and repair guidelines for certain vehicles listed below.

030000 BRAKES (PWS)

This bulletin describes the procedure to inspect and identify fluid which may appear around the brake caliper area.

200000 WHEELS

This bulletin provides tire vibration service procedures, including how to optimize vehicle vibration performance. For all wheel/tire balance claims, the a??Tire Balance Data Sheeta?? must be fully completed including imbalance and Road For

190000 TIRES

350000 EQUIPMENT

This bulletin provides information regarding condensation related to moisture accumulation in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. The TSB illustrates the various causes of condensation inside the la

120000 EXTERIOR LIGHTING

356000 EQUIPMENT ADAPTIVE/MOBILITY

200000 WHEELS

This bulletin provides information on tire maintenance best practices and procedures for dealers and customers to maximize tire life and performance.

190000 TIRES

This bulletin provides information on tire maintenance best practices and procedures for dealers and customers to maximize tire life and performance.

350000 EQUIPMENT

This bulletin describes the general guidelines to help disinfect and protect vehicle exterior/interior surfaces using recommended safe chemical products.

350000 EQUIPMENT

This bulletin provides information on identifying dealer stock vehicles with either: a?? A Battery SOC alert - low Battery State of Charge (SOC) at or below 50%. a?? A 30 Day alert - vehicle has not started and reported an SOC in 30 days.

110000 ELECTRICAL SYSTEM

356000 EQUIPMENT ADAPTIVE/MOBILITY

The automatic transmission warranty repair policy authorizes in-dealership repairs of the following components for both OEM (new) and remanufactured automatic transmissions:

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

The automatic transmission warranty repair policy authorizes in-dealership repairs of the following components for both OEM (new) and remanufactured automatic transmissions:

100000 POWER TRAIN

The automatic transmission warranty repair policy authorizes in-dealership repairs of the following components for both OEM (new) and remanufactured automatic transmissions:

356000 EQUIPMENT ADAPTIVE/MOBILITY

This bulletin describes the general guidelines to disinfect and protect vehicle interior surfaces using certain safe chemical products.

020000 SUSPENSION

This bulletin describes the requirements for all wheel alignment and/or vehicle tracking claims and best practices when diagnosing and conducting alignment-related repairs for all models and model years.

110000 ELECTRICAL SYSTEM

This bulletin provides guidelines to inspect the USB, head unit, and multi-box for common connection conditions. 2. This bulletin presents guidelines to inspect for common Android Auto and Apple CarPlay connection conditions. 3. This bullet

280000 BACK OVER PREVENTION

The Blind Spot Detection (BSD) or Blind-Spot Collision Warning (BCW) is a system that measures the speed of and distance from the following vehicles by using two magnetic wave radar sensors attached in the rear bumper. The BSD/BCW detects v

270000 LANE DEPARTURE

356000 EQUIPMENT ADAPTIVE/MOBILITY

This bulletin provides instruction detailing the proper methodology for scanning and uploading captured GDS data files to the Techline Repository. Compliance with this bulletin ensures that the GDS data files are correctly transferred and m

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

THIS BULLETIN PROVIDES INFORMATION ON COMPONENTS, ATTRIBUTES, AND PRECAUTIONS OF THE 7-SPEED DRY-TYPE DUAL CLUTCH TRANSMISSION (DCT).

106000 POWER TRAIN:AXLE ASSEMBLY

"THE PCM OR TCM CONTAINS LOGIC TO ADJUST SOLENOID DUTY AND LINE PRESSURE AS NEEDED TO COMPENSATE FOR NORMAL CLUTCH WEAR OVER THE LIFE OF THE TRANSAXLE. THIS BULLETIN PROVIDES THE PROCEDURES NECESSARY TO RESET (ERASE) AND RELEARN THE PCM/TCM

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

HYUNDAI: ATA SOLENOID DIAGNOSTIC TROUBLE CODES P0740, P0741, P0742, P0743, P0746, P0748, P0750, P0755, P0760, P0765, P0770. INCORRECT OPERATION OF THE TRANSAXLE SOLENOIDS MAY RESULT IN THE FOLLOWING SYMPTOMS-CHECK ENGINE LIGHT ILLUMINATED

061000 ENGINE AND ENGINE COOLING:ENGINE

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

HYUNDAI: AUTOMATIC TRANSAXLE RANGE SWITCH DIAGNOSTIC TROUBLE CODES P0705 (RANGE SWITCH SIGNAL PROBLEMS), P0707 (RANGE SWITCH OPEN CIRCUIT), AND P0708 (RANGE SWITCH SHORT CIRCUIT OR MULTIPLE INPUTS). AN IMPROPERLY ADJUSTED OR IMPROPERLY OP

061000 ENGINE AND ENGINE COOLING:ENGINE

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

AUTOMATIC TRANSAXLE HARSH AND/OR DELAYED UPSHIFT OR DOWNSHIFT - GDS ANALYSIS. *PE

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

AUTOMATIC TRANSAXLE HARSH AND/OR DELAYED ENGAGEMENT INTO DRIVE OR REVERSE. *KB

106000 POWER TRAIN:AXLE ASSEMBLY

AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES (DTC) LIST. *KB

106000 POWER TRAIN:AXLE ASSEMBLY

RESETTING AUTOMATIC TRANSAXLE ADAPTIVE VALUES. *SC AUTOMATIC TRANSAXLE CONTROL MODULE - RESET AND RELEARN ADAPTIVE VALUES. *TT

110000 ELECTRICAL SYSTEM

CORROSION IN THE FRONT DOOR WIRING CONNECTOR. THIS BULLETIN SUPERSEDES 01-90-004. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *SC

072100 FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

FUEL PUMP REPLACEMENT. *MR SERVICE CAMPAIGN T13. *TT

110000 ELECTRICAL SYSTEM

AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *NM

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

FD46XG PAG OIL SPECIFICATIONS FOR AIR CONDITIONING COMPONENT REPLACEMENT. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

AUTOMATIC TRANSAXLE HARSH AND/OR DELAYED SHIFTS. TO INCLUDE 2005 ELANTRA. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

AUTOMATIC TRANSAXLE HARSH AND/OR DELAYED ENGAGEMENT INTO DRIVE OR REVERSE. TO INCLUDE 2005 ELANTRA. *TT

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

FD46XG POLY ALKYLEN GLYCOL (PAG) OIL SPECIFICATIONS FOR AIR CONDITIONING COMPONENT REPLACEMENT. *NM

061000 ENGINE AND ENGINE COOLING:ENGINE

ENGINE CONTROL MODULE (ECM) REPROGRAMMING TO REDUCE THE DELAY IN RPM DROP BETWEEN SHIFTS WITH THE AIR CONDITIONER ON. *TT

133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

POWER WINDOW REGULATOR MOTOR.*MR

162000 STRUCTURE:BODY

REAR SPOILER FASTENER PART NUMBER INFORMATION. *MR

061000 ENGINE AND ENGINE COOLING:ENGINE

ECM (ENGINE CONTROL MODULE) REPROGRAMMING FOR WARM AMBIENT COLD START STUMBLE (WACSS) AND ENGINE HESITATION AT APPROXIMATELY 3800 RPM. *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

SERVICE INFORMATION FOR SULEAVE ELANTRA (ONLY APPLIED ON ELANTRA VEHICLES WITH CALIFORNIA EMISSIONS SPECIFICATION AND AUTOMATIC TRANSMISSION).*MR

180000 VEHICLE SPEED CONTROL

RESISTANCE VALUES FOR IDLE SPEED CONTROL ACTUATOR (ISCA). VARIOUS MODELS INCLUDING THE 2004 SONATA. *TT

063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

SERVICE INFORMATION FOR SULEV (SUPER ULTRA LOW EMISSION VEHICLE) ELANTRA (ONLY APPLIED ON ELANTRA VEHICLES WITH CALIFORNIA EMISSIONS SPECIFICATION AND AUTOMATIC TRANSMISSION). *TT

030000 SERVICE BRAKES, HYDRAULIC

CAMPAIGN 061 PROVIDES THE PROCEDURES FOR REPOSITIONING THE REAR BRAKE TUBES TO PREVENT CONTACT WITH THE FRONT SUSPENSION CROSSMEMBER'S STEERING GEAR BOX MOUNTING BRACKETS. *TT

112000 ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR

GENERATOR CHANGE FOR THE 2.0L ENGINE. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODE (DTC) P1723 ACCOMPANIED WITH MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED; TRANSAXLE HELD IN 2RD GEAR FAIL-SAFE; HARSH SHIFTS INTO REVERSE OR DRIVE. *TT

162300 STRUCTURE:BODY:DOOR

INTERIOR DOOR TRIM PANEL FABRIC REPAIR. *TT

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

KENWOOD RADIO RECEIVER INSTALLATION. *TT

072100 FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

FUEL PUMP INSTALLATION FOR A ROUGH RUNNING CONDITION. *TT

071110 FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP

THE SPRING-LOADED DOOR (FLAPPER VALVE) IN THE FUEL FILLER NECK HAS BEEN DELETED CERTAIN VEHICLES. *TT

162300 STRUCTURE:BODY:DOOR

DOOR FRAME BLACK TAPE REPLACEMENT PROCEDURE. *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

SERVICE INFORMATION FOR SULEV ELANTRA (ONLY APPLIED ON ELANTRA VEHICLES WITH CALIFORNIA EMISSIONS SPECIFICATION AND AUTOMATIC TRANSMISSION). *TT

100000 POWER TRAIN

ATA SOLENOID DIAGNOSTIC TROUBLE CODES P0740, P0741, P0742, P0743, P0750, P0755, P0760, P0765, P0770. *TT

110000 ELECTRICAL SYSTEM

2.0L ENGINE MFI CONTROL SYSTEM ETM REVISION (IGNITION COIL CONNECTOR CHANGE). *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

CONTINUOUSLY VARIABLE VALVE TIMING. *TT

980000 UNKNOWN OR OTHER

2003 SHOP MANUALS AND ETMS ON WEBTECH. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

THIRD GEAR FAIL-SAFE INFORMATION. *TT

110000 ELECTRICAL SYSTEM

FUSE #1 BLOWN - ELECTROCHROMIC (EC) MIRROR WIRE HARNESS SHORT. *TT

162000 STRUCTURE:BODY

HIGH PITCHED WIND NOISE RELATED TO FRONT DOOR WEATHERSTRIP. *TT

221200 SEATS:FRONT ASSEMBLY:RECLINER

PROCEDURE FOR REPLACEMENT OF THE FRONT SEAT TRACK RECLINER CABLE. *TT

112000 ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR

GENERATOR CHANGE FOR THE 2.0L ENGINE. *TT

110000 ELECTRICAL SYSTEM

POWER DOOR LOCK ACTUATOR CIRCUIT ETM/SHOP MANUAL CORRECTION. *TT

106000 POWER TRAIN:AXLE ASSEMBLY

ATA SOLENOID DIAGNOSTIC TROUBLE CODES P0740, P0743, P0750, P0755, P0760, P0765, P0770. *TT

NHTSA Safety Investigations, HYUNDAI ELANTRA

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

DP, Closed , Model Year: 2017

Loss of Motive Power

The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia Americ... a, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.Read more

EA, Closed , Model Year: 2013

Engine Fires

On March 29, 2019, the Office of Defects Investigation (ODI) opened two Preliminary Evaluations (PE19-003 on Hyundai and PE19-004 on Kia) to broadly investigate incidents of non-crash fires (regardless of origin or operational status of the vehicle) on various model year Hyundai and Kia vehicles. ... During the PE investigations, Hyundai and Kia issued several recalls to address vehicle fires, including those due to engine failures involving various engine types. The remedies for the engine failure recalls typically involve engine inspection (to detect existing damage), and if necessary, engine replacement. Additionally, both manufacturers have been installing an engine control software modification known as Knock Sensor Detection Software (KSDS) which is intended to detect impending engine failure, alert the driver, and limit engine power (to lessen likelihood of engine failure).KSDS is being installed under recalls and non-safety field actions, and both companies have extended limited engine warranties (see recall files). On December 22, 2021, ODI upgraded PE19-003 and PE19-004 to this Engineering Analysis (EA21-003, covering both Hyundai and Kia) to evaluate the scope of the prior recalls related to engine failures/fires and the efficacy of the recall remedies for the recalls, as well as the long-term viability of related programs and non-safety field actions being conducted by Hyundai and Kia. The former issue involved approximately 550,000 MY 2013 Hyundai Elantra, MY 2011 Kia Sorento, and MY 2012-2015 Kia Rio. The latter issue involved approximately 2.5 million recalled vehicles, which have been identified as displaying potential remedy concerns: Hyundai recalls 15V-568, 17V-226, 20V-746, and 21V-727; and Kia recalls 17V-224, 19V-120, 20V-750, and 21V-844. Regarding the recall scope issue, among all of the scope vehicles identified at EA opening, ODI found only the MY 2011 Kia Sorento vehicles equipped with both the Theta II 2.4L 4-cylinder Multi-Point Injection (MPI) and the Lambda II 3.5L 6-cylinder MPI engines experienced relatively high rates of reported fires. In December 2023, Kia issued recall 23V-877 that will cover about 80,000 MY 2011 Kia Sorento vehicles equipped with the Theta II 2.4L MPI engines. The remedy will involve an inspection, and if necessary, a replacement of the engine, as well as the installation of KSDS. It should be noted that in 2021 these vehicles were included in a KSDS product improvement campaign with warranty extension. For the MY 2011 Sorento vehicles equipped with the Lambda II 3.5L engines, ODI believes that future engine failures/fires involving these vehicles will likely be due to a lax in adhering to the proper or scheduled engine maintenance (regular engine oil changes), rather than a design or manufacturing engine issue. Regarding the issue of the efficacy of the recall remedies, ODI found the majority of the recalled Hyundai and Kia vehicles, by model, experienced lower reported fire rates after the remedies were applied. Furthermore, ODI found that for most vehicles that did not receive the recall remedies, by model, experienced relatively high fire rates. To address this problem, Hyundai informed ODI in December 2023, that it will renotify all of its owners covered by the Hyundai recalls of engine failures/fires every 8 months for the next 3 years. In December 2023, Kia stated that it will renotify the majority of its owners every 8 months for the next 3 years.Several previously recalled Kia models are excluded from the renotification due to their lower reported rates of engine fires. Overall, the renotification actions will help to increase the recall completion rates, thus reduce the frequency of engine fires in the future. In view of the recall action being taken by Kia and renotification actions being taken by both Kia and Hyundai, ODI is closing this Engineering Analysis. Also, both companies have been released from the 2020-iniated Consent Orders (Kia since November 2022 and Hyundai since November 2023). The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.Read more

DP, Closed , Model Year: 2007

Throttle control system vulnerabilities

The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening ... of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.Read more

EA, Closed , Model Year: 2011

Headliner Bracket Detachment

In March 2013, Hyundai issued a safety recall to reinforce the attachment of the metal support brackets to the headliner assembly in approximately 186,254 model year 2011-2013 Hyundai Elantra vehicles built in Korea and sold in the U.S. (see NHTSA recall 13V-115 for more information).The recall cove... Read more

PE, Closed , Model Year: 2012

Side Curtain Air Bag Improper Deployment

The Office of Defects Investigation (ODI) is aware of one incident of an improper deployment of the driver-side curtain air bag that deployed as a result of a crash involving a model year (MY) 2012 Hyundai Elantra.An inspection of this vehicle showed that a metal bracket (stiffener) in the headliner... Read more

PE, Closed , Model Year: 2001

FRONT LOWER CONTROL ARMS RUSTING

ON APRIL 14, 2009, HYUNDAI MOTOR CORPORATION SUBMITTED TO ODI A DEFECT INFORMATION REPORT INDICATING THAT IT WOULD RECALL A SALT-BELT POPULATION OF APPROXIMATELY 155,317 MODEL YEAR (MY) 2001 THROUGH 2003 HYUNDAI ELANTRA VEHICLES TO REMEDY A DEFECT THAT CAN RESULT IN LOSS OF VEHICLE CONTROL WITH AN I... NCREASED RISK OF A CRASH WHILE DRIVING (09V-125).THE AFFECTED VEHICLES COVER ALL MY 2001, MY 2002, AND MY 2003 THROUGH JANUARY 13, 2003 PRODUCTION.THESE INCLUDE ELANTRA VEHICLES THAT WERE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN.THE TOTAL THREE-YEAR PRODUCTION POPULATION FOR THE ELANTRA VEHICLES IS APPROXIMATELY 350,000. ACCORDING TO HYUNDAI, ROAD SALT CAN COLLECT IN THE OUTBOARD PORTION OF THE FRONT LOWER CONTROL ARM AND MAY RESULT IN INTERNAL CORROSION LEADING TO THINNING OF THE STEEL IN THE LOWER CONTROL ARMS.THE CORROSION MAY PROGRESS TO THE POINT WHERE THE LOWER CONTROL ARM UPPER AND LOWER PANELS BECOME PERFORATED.A PERFORATED FRONT LOWER CONTROL ARM MAY FRACTURE BETWEEN ITS BALL JOINT ATTACHMENT AND THE FORWARD AND REARWARD PIVOT ATTACHMENTS TO THE CHASSIS.THIS COULD AFFECT THE DRIVER'S CONTROL OVER THE TIRE AND WHEEL ASSEMBLY.HYUNDAI'S RECALL PROCEDURE INSTRUCTS DEALERS TO MEASURE THE THICKNESS OF THE STEEL IN THE FRONT LOWER CONTROL ARMS.IF SPECIFIED LEVELS OF CORROSION DAMAGE HAVE OCCURRED, THE FRONT LOWER CONTROL ARMS WILL BE REPLACED WITH NEW FRONT LOWER CONTROL ARMS WITH ADDITIONAL HOLES IN THE UPPER AND LOWER PANELS. ODI'S ANALYSIS OF FRONT LOWER CONTROL ARM COMPLAINT AND WARRANTY DATA SHOWS 220 COMPLAINTS AND 1,033 WARRANTY CLAIMS FOR THE TOTAL APPROXIMATELY 350,000 SUBJECT VEHICLES SOLD THROUGHOUT THE UNITED STATES, RESULTING IN A COMPLAINT RATE OF 62.82 PER 100,000 VEHICLES AND A CLAIM RATE OF 0.3 PERCENT.ODI'S ANALYSIS FOUND 7 COMPLAINTS AND 90 WARRANTY CLAIMS IN 132,475 VEHICLES SOLD IN NON-SALT BELT STATES, RESULTING IN A COMPLAINT RATE OF 5.3 PER 100,000 VEHICLES AND A CLAIM RATE OF 0.1 PERCENT. ODI'S ANALYSIS FURTHER FOUND 196 COMPLAINTS AND 943 WARRANTY CLAIMS IN 155,317 VEHICLES SOLD IN SALT BELT STATES, RESULTING IN A COMPLAINT RATE OF 126.2 PER 100,000 VEHICLES AND A CLAIM RATE OF 0.6 PERCENT.ODI IDENTIFIED 34 INCIDENTS OF LOWER CONTROL ARM FRACTURE RELATED TO CORROSION, ALL OF WHICH OCCURRED IN SALT BELT STATES.THE DATA DO NOT SHOW A DEFECT TREND IN VEHICLES OUTSIDE THE REGION COVERED BY HYUNDAI'S RECALL. THIS PRELIMINARY EVALUATION IS CLOSED.Read more

PE, Closed , Model Year: 2007

ENGINE STALLING - FUEL PUMP FAILURE

ON AUGUST 19, 2008, HYUNDAI SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING FUEL PUMP FAILURE RESULTING IN ENGINE STALL IN APPROXIMATELY 65,000 MODEL YEAR 2008 HYUNDAI ELANTRA VEHICLES WITH 2.0 LITER BETA ENGINES PRODUCED FROM NOVEMBER 5, 2007, THROUGH JUNE 28, 2008 (NHTSA RECALL NO. 08V-4... Read more

EA, Closed , Model Year: 2001

AIR BAG LIGHT ILLUMINATION

HYUNDAI IS CONDUCTING TWO SAFETY RECALLS TO CORRECT TWO SAFETY DEFECTS DESCRIBED BELOW.UNDER SAFETY RECALL 08V-532, HYUNDAI WILL INSTALL A VINYL PROTECTIVE SHIELD/COVER TO PREVENT SHORT CIRCUITS IN THE AIR BAG CONTROL MODULE CAUSE BY SPILLS OF LIQUIDS THAT SEEP INTO THE MODULE CONNECTOR. THIS ACTION... Read more

PE, Closed , Model Year: 2001

AIR BAG LIGHT ILLUMINATION

IN CERTAIN MODEL YEAR (MY) 2001 AND 2002 VEHICLES, THE AIR BAG SYSTEM IS SUSCEPTIBLE TO AIR BAG LIGHT ILLUMINATION AND AIR BAG NON-DEPLOYMENT OR INADVERTENT DEPLOYMENT FROM LIQUID CONTAMINATION OF THE AIR BAG CONTROL MODULE.THE CONTROL MODULE IS LOCATED BENEATH AND NEAR CENTER CONSOLE CUP HOLDERS.OD... Read more

PE, Closed , Model Year: 2004

POST-CRASH FUEL TANK LEAK

PE04-041 WAS OPENED TO INVESTIGATE A FUEL LEAK INCIDENT THAT OCCURRED DURING AN INSURANCE INSTITUTE FOR HIGHWAY SAFETY (IIHS) FRONTAL CRASH OFFSET TEST ON THE SUBJECT VEHICLE.THIS INVESTIGATION REVEALED THAT THE VAPOR TUBE HOSE CLAMP EAR WAS MISPOSITIONED AND FACING TOWARD THE FUEL TANK, WHICH ENABL... Read more

SQ, Open , Model Year: 1996

FUEL CAP REPLACEMENT CAMPAIGN 36

There is no summary currently available

PE, Closed , Model Year: 1996

WINDSHIELD WIPER FAILURE

IN ITS LETTER DATED FEBRUARY 14, 1997, HYUNDAI STATED THAT APPROXIMATELY 75,000 HYUNDAI VEHICLES (CERTAIN MODEL YEAR 1996-97 ELANTRA, ACCENT, SONATA AND TIBURON MODELS BUILT THROUGH OCTOBER 18, 1996 -- SEE NHTSA RECALL NO. 97V-026 FOR DETAILS) WILL BE RECALLED FOR A DEFECT IN THE WINDSHIELD WIPER MO... Read more

SQ, Open , Model Year: 1992

REAR SUSPENSION FAILURE

ODI HAS RECEIVED COMPLAINTS PERTAINING TO REAR SUSPENSION PROBLEMS.ADDITIONAL INFORMATION IS NEEDED TO FULLY UNDERSTAND THE NATURE AND CIRCUMSTANCES OF THE CANADIAN RECALL.FURTHERMORE, THIS INVESTIGATION IS OPENED TO EVALUATE HYUNDAI'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN TO INCLUDE ... Read more

PE, Closed , Model Year: 1990

SCISSOR JACK FAILURE

There is no summary currently available

HYUNDAI ELANTRA - All Years Overview

Complete safety history for the HYUNDAI ELANTRA across all model years (1994, 2026).

102 Total Recalls

12,126 Total Complaints

14 Investigations

1,279 Reported Crashes

273 Reported Fires

19 Reported Deaths

HYUNDAI ELANTRA - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2026	1	2	View
2025	0	31	View
2024	1	94	View
2023	2	159	View
2022	5	143	View
2021	6	214	View
2020	3	342	View
2019	1	334	View
2018	0	406	View
2017	4	1,077	View
2016	2	398	View
2015	3	356	View
2014	2	552	View
2013	4	1,863	View
2012	4	920	View
2011	5	589	View
2010	3	504	View
2009	4	321	View
2008	7	424	View
2007	6	365	View
2006	1	209	View
2005	4	180	View
2004	5	209	View
2003 (current)	5	310
2002	6	431	View
2001	6	445	View
2000	1	259	View
1999	2	183	View
1998	0	75	View
1997	3	196	View
1996	3	138	View
1995	1	179	View
1994	2	110	View
1993	0	39	View
1992	0	46	View

Other HYUNDAI Models

Model	Recalls	Complaints
SONATA	184	21,863	View
SANTA FE	153	9,962	View
PALISADE	124	2,704	View
TUCSON	95	8,074	View
SONATA HYBRID	67	1,129	View
IONIQ 5	66	1,865	View
ACCENT	64	2,745	View
SANTA FE HYBRID	57	347	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2003 HYUNDAI ELANTRA

Complaint Statistics

Top Reported Components

EPA Fuel Economy, 2003 HYUNDAI ELANTRA

Technical Service Bulletins, 2003 HYUNDAI ELANTRA

Most Affected Components

NHTSA Safety Investigations, HYUNDAI ELANTRA

HYUNDAI ELANTRA - All Years Overview

HYUNDAI ELANTRA - Year by Year

Other HYUNDAI Models