1999 HYUNDAI ELANTRA

2 recalls, 183 complaints - 74 TSBs

ELECTRICAL SYSTEM:WIRING

Defect Description

VEHICLE DESCRIPTION: SOME SONATA VEHICLES EQUIPPED WITH 2.5 LITER V-6 ENGINES AND ALL ELANTRA MODEL VEHICLES MAY HAVE EXPERIENCED INTERMITTENT LOW-SPEED ENGINE STALLING, WHICH COULD OCCUR IF THE MAF (MASS AIR FLOW) SENSOR ELECTRICAL SIGNAL IS INTERRUPTED AS A RESULT OF ENGINE VIBRATION TRANSMITTED ... Read more

Consequence

THIS CONDITION CAN CAUSE THE ENGINE TO STALL, INCREASING THE RISK OF A CRASH.

Remedy

DEALERS WILL RE-ROUTE THE MAF SENSOR CONNECTOR WIRING HARNESS.

165,977 vehicles affected

Manufacturer: HYUNDAI MOTOR COMPANY

POWER TRAIN:AUTOMATIC TRANSMISSION

Defect Description

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS. THE AUTOMATIC TRANSMISSION PRESSURE CONTROL SOLENOID VALVE SEALS DO NOT REMAIN SUFFICIENTLY ELASTIC, RESULTING IN TRANSMISSION FLUID LEAKAGE. THIS LEAKAGE CAN RESULT IN REDUCED PRESSURE APPLICATION TO THE CLUTCHES, B... Read more

Consequence

SUCH SLIPPAGE CAN CAUSE PREMATURE DETERIORATION OF THE FRICTION ELEMENT SURFACES AND COULD CAUSE THE VEHICLE NOT TO ACCELERATE, OR NOT ACCELERATE AS EXPECTED, WHEN THE DRIVER PRESSES THE ACCELERATOR PEDAL.

Remedy

DEALERS WILL REPLACE THE PRESSURE CONTROL SOLENOID VALVE.

11,530 vehicles affected

Manufacturer: HYUNDAI MOTOR COMPANY

Complaint Statistics

183 total complaints 24 crashes 4 fires 26 injuries

Top Reported Components

Component	Complaints
POWER TRAIN:AUTOMATIC TRANSMISSION	34
AIR BAGS:FRONTAL	16
ELECTRICAL SYSTEM	11
ENGINE AND ENGINE COOLING	8
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE	7
POWER TRAIN	6
EQUIPMENT:APPLIANCE:AIR CONDITIONER	5
ELECTRICAL SYSTEM:WIRING	5
ENGINE AND ENGINE COOLING:ENGINE	4
VEHICLE SPEED CONTROL	4

Incident date: Nov 1, 2017

WHEN ACCELERATING THE CAR DOES NOT SHIFT PROPERLY CAUSING THE VEHICLE TO SLOW MAKING IT VERY DANGEROUS ON THE FREEWAY

Incident date: Apr 15, 2000

TL* THE CONTACT OWNS A 1999 HYUNDAI ELANTRA. WHILE THE VEHICLE WAS STOPPED, THE GEAR SHIFTER SEIZED AND THE VEHICLE COULD NOT BE SHIFTED INTO GEAR. THE DEALER WAS UNABLE TO REPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE RECURRED AND THE VEHICLE WAS TAKEN TO THE DEALER AGAIN WHERE I... Read more

Incident date: Aug 6, 2016

TL* THE CONTACT OWNS A 1999 HYUNDAI ELANTRA. THE CONTACT STATED THAT THE VEHICLE JERKED, LUNGED, AND LOST POWER. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE TECHNICIAN DIAGNOSED THE ISSUE AS AN ELECTRICAL FAILURE. THE VEHICLE WAS REPAIRED; HOWEVER... Read more

Incident date: Nov 15, 2016

TL* THE CONTACT OWNS A 1999 HYUNDAI ELANTRA. THE CONTACT STATED THAT THE VEHICLE LOST POWER AND WAS UNABLE TO ACCELERATE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 99V178000 (... Read more

Incident date: Sep 27, 2016

I HAVE A 99 HYUNDAI ELANTRA 4 DOOR. LAST WEEK THE STEERING COLUMN CAUGHT ON FIRE WHILE IT WAS BEING DRIVEN. MORE SPECIFICALLY, I WAS AT THE TIME IN THE HARDEE'S DRIVE THRU WHEN THE SMOKE AND FLAMES STARTED. I WAS ABLE TO GET MY CAR TO ROLL OUT OF THE DRIVE THRU AND INTO THE PARKING LOT. I HAVE SPOK... Read more

Fire

Incident date: Sep 27, 2016

Fire

Incident date: Sep 27, 2016

Fire

Incident date: Jul 17, 2001

TL* THE CONTACT OWNS A 1999 HYUNDAI ELANTRA. THE CONTACT STATED THAT THE VEHICLE FAILED TO MOVE WHEN THE GEAR SHIFTER WAS PLACED IN THE REVERSE POSITION. IN ADDITION, THE VEHICLE FAILED TO ACCELERATE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE FAILURE RECURRED WHENEVER THE VEHICLE WAS OPERATED. TH... Read more

Incident date: Dec 2, 2014

12/2/2014 MULTI-CAR/SEMI ACCIDENT. FRONT END COLLISION WITH REAR END DAMAGE. TOTAL LOSS, AIR BAGS DID NOT DEPLOY. 465 S @ MM 41 NEAR PENDLETON PIKE EXIT. AT FAULT DRIVER SPUN ON ICE, CAME INTO MY LANE THAT I WAS TRAVELING SOUTH IN SO SHE WAS TRAVELING NORTH. HIT DRIVERS SIDE TO DRIVERS SIDE, SEMI TR... Read more

Crash 1 injured

Incident date: Dec 1, 2014

TL* THE CONTACT OWNS A 1999 HYUNDAI ELANTRA. WHILE DRIVING AT 40 MPH AFTER THE TRANSMISSION WAS REPLACED BY AN INDEPENDENT MECHANIC, THE CONTACT NOTICED A STRONG TRANSMISSION FLUID ODOR. THE CONTACT NOTICED THAT THE TRANSMISSION FLUID LEVEL WAS LOW. IN ADDITION, WHILE DRIVING AT 40 MPH, THE ACCELERA... Read more

Incident date: Dec 1, 2014

Incident date: Mar 26, 2015

MY VEHICLE HAS BEEN STALLING FOR MORE THAN A YEAR. THE MASS AIRFLOW SENSOR READ AS BAD AND I HAVE REPLACED IT TWICE. I JUST FOUND OUT THAT THERE WAS A RECALL SEP 11, 2000. NHTSA CAMPAIGN ID NUMBER: 00V259001 . I PURCHASED THE VEHICLE USED SEVERAL YEARS AFTER THE RECALL WAS IN EFFECT. WHEN I E-MAI... Read more

Incident date: Dec 1, 2014

TL* THE CONTACT OWNS A 1999 HYUNDAI ELANTRA. THE CONTACT STATED THAT THE REAR PASSENGER SIDE SUBFRAME RUSTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE REAR PASSENGER SUBFRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF... Read more

Incident date: May 7, 2004

I HAVE READ MANY OF THE COMPLAINTS ABOUT THE HYUNDAI. I'VE ELIMINATED PRACTICALLY ALL THE SAME COMPLAINTS ABOUT THE ENGINE PERFORMANCE BY TUNING THE ENGINE EVERY 30 TO 35 THOUSAND MILES. THE GAS MILEAGE AND PERFORMANCE HAS BEEN VERY ACCEPTABLE. YES I TOO HAVE HAD TO REPLACE THE MANIFOLD, MAS AIR SEN... Read more

Incident date: May 7, 2004

Incident date: May 2, 2012

I HAVE A 1999 HYUNDAI ELANTRA WITH 128,750 MI. AT. THE EVAPORATIVE EMISSIONS CANISTER HAS BECOME DISCONNECTED FROM THE BODY OF THE CAR WHERE IT IS BOLTED WHICH IS UNDERNEATH THE TRUNK BEHIND THE LEFT REAR WHEEL DUE TO THE BRACKET RUSTING AND BREAKING DUE TO INADEQUATE STEEL USED WHICH DOES NOT RES... Read more

Incident date: Apr 30, 2012

THE REAR FRAME CROSSMEMBER HAS RUSTED THROUGH AND HOLDS THE OTHER SUSPENSION COMPONENTS IN PLACE. THE WHOLE CAR IS SEVERELY RUSTED. HYUNDAI RUSTING IN THE SALT BELT STATES IS DOCUMENTED. I WOULD LIKE HYUNDAI TO REPLACE ALL RUSTED OUT FRAME SUSPENSION MEMBERS. *JS

Incident date: Nov 1, 2009

TL*THE CONTACT OWNS A 1999 HYUNDAI ELANTRA. WHILE DRIVING 30 MPH, THE CONTACT STATED THAT THE VEHICLE STALLED. THE CONTACT STATED THAT THE FAILURE WAS SIMILAR TO RECALL 00V259001 (ELECTRICAL SYSTEM: WIRING). THE CONTACT CALLED THE DEALER AND THE MANUFACTURER WHO BOTH STATED THAT THE VEHICLE WAS NOT ... Read more

Incident date: Apr 5, 2010

TL*THE CONTACT OWNS A 1999 HYUNDAI ELANTRA. WHILE ACCELERATING FROM A STOP SIGN AT 5 MPH, THE VEHICLE MOMENTARILY HESITATED BEFORE CONTINUING TO ACCELERATE. THE FAILURE OCCURRED INTERMITTENTLY. THE VEHICLE HAD NOT BEEN INSPECTED AT THE TIME OF THE COMPLAINT. THE CURRENT AND FAILURE MILEAGES WERE APP... Read more

Incident date: Apr 5, 2010

Incident date: Aug 11, 2009

MY 1999 HYUNDAI ELANTRA GL SEDAN HAS BEEN EXPERIENCING INTERMITTENT (BUT WITH INCREASING FREQUENCY) LOW/"IDLE" SPEED ENGINE STALLING. THIS PRESENTS A DANGEROUS SITUATION WHEN THE CAR STALLS AT A STOPLIGHT OR WHEN SLOWING TO TURN IN A RESIDENTIAL NEIGHBORHOOD. MOST STALLS ARE OCCURRING AT LESS THAN 2... Read more

Incident date: Aug 11, 2009

Incident date: Feb 9, 2009

COMPAIGN ID 00V259001 IS FOR LOW SPEED STALLING ON 1999 HYUNDAI ELANTRA MODELS WITH CERTAIN VIN NUMBERS AND RELATES TO THE WIRING WITH THE MASS AIR FLOW CENSOR. I HAVE A 1999 HYUNDAI ELANTRA THAT IS HAVING THE EXACT SAME PROBLEM BUT DOES NOT FIT WITHIN THE VIN RANGE SO THEY ARE NOT COVERING IT. I FE... Read more

Incident date: Feb 9, 2009

Incident date: Dec 2, 2008

TL*THE CONTACT OWNS A 1999 HYUNDAI ELANTRA. WHEN THE ACCELERATOR PEDAL WAS DEPRESSED, THE VEHICLE HESITATED. THE VEHICLE ALSO STALLED WHILE DRIVING LESS THAN 50 MPH. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBERS 99V178000 (POWER TRAIN:AUTOMATIC TRANSMISSION) AND 00V259001 (ELECTRICAL SYST... Read more

Incident date: Apr 24, 2008

PURCHASED 1999 HYUNDAI ELANTRA IN APRIL OF 1999. ON 1/15/2001 VEHICLE DIED AND WAS TOWED TO DEALERSHIP. TRANSMISSION REPLACED. MILEAGE AT THE TIME-33,663. ON APRIL 24, 2008, I WAS ADVISED BY MECHANIC THAT THE TRANSMISSION WAS SLIPPING. VEHICLE DOES NOT PROPERLY SHIFT INTO GEAR. ENTIRE CAR SHAK... Read more

Incident date: May 5, 2005

TL*THE CONTACT OWNS A 1999 HYUNDAI ELANTRA. THE CONTACT STATED THAT THE TRANSMISSION WAS FAILING AND THE VEHICLE WAS NOT ACCELERATING PROPERLY WHEN THE PEDAL WAS DEPRESSED. INSTEAD OF GAINING SPEED, THE VEHICLE HESITATED WHILE DRIVING 15 MPH. THROUGH ONLINE RESEARCH, HE DISCOVERED NHTSA CAMPAIGN ... Read more

Incident date: Jun 15, 2007

TL*THE CONTACT OWNS A 1999 HYUNDAI ELANTRA GL. THE CONTACT STATED THAT THE CHECK ENGINE LIGHT ILLUMINATED AND THE VEHICLE WOULD SHIFT HARD WHEN GOING FROM FIRST TO SECOND GEAR. IN ADDITION, THE VEHICLE WOULD NOT SHIFT INTO REVERSE OR OVER DRIVE. THE DEALER STATED THAT THE TRANSMISSION CAUSED THE ... Read more

Incident date: Oct 19, 2007

TL*THE CONTACT OWNS A 1999 HYUNDAI ELANTRA. THE CONTACT STATED THAT THE FRONT HEADLIGHTS LENS WERE DISCOLORED AND VISIBILITY AT NIGHT WAS VERY LIMITED. THE HYUNDAI CORPORATE OFFICE WAS NOTIFIED AND THEY STATED THAT THE HEADLIGHTS WERE ONLY COVERED UNDER A FIVE YEAR WARRANTY. THE CURRENT AND FAILU... Read more

Incident date: Jul 2, 2007

TL*THE CONTACT OWNS A 1999 HYUNDAI ELANTRA. WHILE IDLING, THE VEHICLE STALLED AND THE SERVICE ENGINE WARNING LIGHT ILLUMINATED. THE FAILURE HAS OCCURRED FIFTY TIMES, BUT THE VEHICLE WAS ABLE TO BE RESTARTED AFTER EACH ONE. THE DEALER REPLACED THE MAF SENSOR. THE MANUFACTURER STATED THAT HIS VIN ... Read more

Incident date: Jun 25, 2007

TL*THE CONTACT OWNS A 1999 HYUNDAI ELANTRA. THE CONTACT STATED THAT THE VEHICLE STALLS AND FEELS AS IF IT WILL SHUT OFF WHEN IDLING. THE VEHICLE OPERATES NORMALLY WHEN IN MOTION. THE IDLING AND STALLING HAVE WORSENED OVER TIME. THE VIN, PURCHASE DATE, AND ENGINE SIZE WERE UNKNOWN. THE CURRENT A... Read more

Incident date: Mar 3, 2007

TL*THE CONTACT OWNS A 1999 HYUNDAI ELANTRA. THE VEHICLE STALLED WHILE DRIVING 15 MPH. THE MECHANIC STATED THAT A NEW TRANSMISSION WAS NEEDED. THE CURRENT MILEAGE IS 138,000 AND FAILURE MILEAGE WAS 135,000.

Incident date: Mar 14, 2007

I TOOK MY 1999 HYUNDAI ELANTRA IN TO OBRIEN AUTO PARK IN FORT MYERS SERVICE CENTER TO GET LOOKED AT AND FIXED. I HAD TROUBLE CODES THAT I HAD CHECKED PRIOR GOING THERE AT AUTOZONE THAT WERE CODES PO747, PO743, PO442. THE FIRST TO ARE CODES INVOLVING MY AUTOMATIC TRANSMISSION. I VIEWED ON YOUR WEBSIT... Read more

Incident date: Sep 21, 2006

1999 ELANTRA HOOD FLEW UP AND STRUCK THE WINDSHIELD WHILE DRIVING. *TS *NM UPDATED 01/09/07. *JB

Incident date: Jun 9, 2006

WHILE DRIVING ON THE FREEWAY, THE HOOD ON MY VEHICLE FLEW OPEN, WITHOUT WARNING, AND SMASHED INTO MY WINDSHIELD. THE LAST TIME THE HOOD WAS POPPED OPEN WAS SEVERAL MONTHS AGO FOR AN OIL CHANGE. I HAD, IN ALL OF THAT TIME, NEVER NOTICED THAT THE HOOD WAS SLIGHTLY OPEN. I HAVE ATTEMPTED TO CONTACT ... Read more

Incident date: Sep 14, 2005

SUNDAY SEPT 11, 2005- MY CAR WOULD NOT ACCELERATE ON I-285 WEST BOUND I HAD TO COAST OVER TO THE SIDE OF THE ROAD AMIDST SUNDAY TRAFFIC,THEY CONFIRMED THAT MY TIMING BELT HAD POPPED CAR TOWED TO MIDAS GAVE ME A TSB REPORT STATING THAT THE TIMING BELT COVERED HAD CRACKED AND THAT IS WHAT MADE THE TIM... Read more

Incident date: Sep 14, 2005

Incident date: Sep 3, 2005

DT: THE VEHICLE IS LEAKING TRANSMISSION FLUID. RIGHT NOW IT WILL NOT SHIFT GEARS AT ALL. WHEN DRIVING WILL BE IN SECOND OR THIRD GEAR AND THE VEHICLE WILL SHIFT DOWN ON ITS OWN. RECALL ID 99V178000 CONCERNING AUTOMATIC TRANSMISSION WAS ISSUED. THIS HAPPENED ON SEPTEMBER 3, 2005. IT MADE A REVVIN... Read more

Incident date: Jul 22, 2005

DT: THE TRANSMISSION WOULD JUMP OUT OF GEAR OR DOWN SHIFT AND THE CHECK ENGINE LIGHT ILLUMINATED AFTERWARDS WHILE DRIVING AFTER THE VEHICLE WAS PARKED OVERNIGHT. THE CHECK ENGINE LIGHT REMAINED ON. BASICALLY THIS ONLY OCCURRED IN THE MORNING. SOMETIMES HOWEVER, IT WOULD FEEL AS THOUGH IT WAS NOT... Read more

Incident date: May 1, 2005

MASS AIR FLOW SENSOR WAS REPLACED AT DEALERSHIP. I JUST FOUND OUT ON THE WEB THAT THE PART WAS RECALLED IN SEPT 2000. CAN I BE REIMBERSSED?

Incident date: Sep 22, 2004

WHEN DRIVING 35 MPH, THE TRANSMISSION SLIPS GEARS. THE VEHICLE IS STILL DRIVABLE. THE DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. THE CAUSE WAS NOT DETERMINED. PLEASE PROVIDE MORE INFORMATION. *NM

Incident date: Dec 20, 2004

(1) ON DECEMBER 20,2004, THE FIRST COLD DAY OF THE YEAR, MY 1999 ELANTRA WOULD NOT START. (2) THE NEXT DAY, DECEMBER 21, 2004, THE CAR STARTED, BUT AS I WOULD COME TO A STOP AT A TRAFFIC LIGHT, THE ENGINE WOULD BEGIN TO SHAKE VIOLENTLY AND THE CAR WOULD STALL OUT. THIS ALSO OCCURRED WHILE TRAVEL... Read more

Incident date: Nov 1, 2004

AT 23,000 MILES A/C BURNED OUT, REPLACED AUTO TRANSMISSION, SPARK PLUG WIRING AND MANY LEAKS. FRONT END VIBRATING, TIRES AND BRAKE LINING FAILED. *BF THE CONSUMER STATED THAT THE BRAKE SHOES FOR THE FRONT AND BACK DO NOT MATCH. *TC

Incident date: Nov 1, 2004

Incident date: Jun 27, 2003

NAR 9-8-03. THE CONSUMER FELT THAT THE VEHICLE'S TRANSMISSION WAS SLIPPING. THE VEHICLE WAS TAKEN TO THE DEALER . THE DEALER FIGURED THE PROBLEM MIGHT BE FUEL DELIVERY RELATED AND ASKED PERMISSION TO PURSUE A REMEDY. THE DEALER REMOVED THE FUEL TANK AND FLUSHED THE FUEL LINES AND INJECTORS AND ... Read more

Incident date: Aug 1, 2002

THE "AIR BAG" AND "CHECK ENGINE" LIGHTS STAYS ON ALL THE TIME. BOTH DRIVER AND REAR PASSENGER WINDOWS WILL NOT WORK, BOTH MUST BE TAPED UP. CAR HAS HAD A "ELECTRIAL BURNING" SMELL OFF AND ON FOR A YEAR. THE HEADLIGHTS GOES BRIGHT WHILE DRIVING. GETTING LESS THAN 20 MPG GAS. BATTERIES FREQUENTLY ... Read more

Incident date: Aug 1, 2002

Incident date: Jul 1, 2004

VEHICLE STALLED INTERMITTENTLY WHILE DRIVING AT 10-15 MPH AND/OR 55 MPH. VEHICLE WAS TO THE DEALER ON SEVERAL SEPARATE OCCASIONS. *AK

Showing 50 of 183 complaints.

EPA Fuel Economy, 1999 HYUNDAI ELANTRA

Trim / Engine	City MPG	Highway MPG	Combined MPG	Fuel Type	Annual Fuel Cost
2.0L 4-cyl, Automatic 4-spd (Front-Wheel Drive)	19.0	28.0	22.0	Regular	$2,800
2.0L 4-cyl, Manual 5-spd (Front-Wheel Drive)	21.0	30.0	24.0	Regular	$2,550

CO2 Emissions: -1.0 g/mile (Compact Cars)

Source: U.S. Environmental Protection Agency (EPA). Actual fuel economy may vary based on driving conditions.

Technical Service Bulletins, 1999 HYUNDAI ELANTRA

74 manufacturer communications from 60 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
106000 POWER TRAIN:AXLE ASSEMBLY	14
350000 EQUIPMENT	6
103000 POWER TRAIN:AUTOMATIC TRANSMISSION	6
356000 EQUIPMENT ADAPTIVE/MOBILITY	5
110000 ELECTRICAL SYSTEM	4
060000 ENGINE AND ENGINE COOLING	4
190000 TIRES	3
061000 ENGINE AND ENGINE COOLING:ENGINE	3

060000 ENGINE AND ENGINE COOLING

This bulletin provides important checkpoint guidelines when performing engine oil and filter change services.

162000 STRUCTURE:BODY

Hyundai applies a Paint Protection Film (PPF) on new vehicles before delivery to dealerships. It provides a barrier between the paint and contaminants, such as rail dust, acid rain, and industrial fallout. In rare cases, the paint can becom

130000 VISIBILITY

This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside th

060000 ENGINE AND ENGINE COOLING

Follow the guidelines outlined in this bulletin to inspect and clean or replace certain components of the engine intake system accordingly during engine short block or sub-assembly replacement.

190000 TIRES

Effective June 2, 2008, Federal Motor Vehicle Safety Standard 110 (FMVSS 110) established a threshold for correcting load carrying capacity information indicated on tire placards when vehicle weight has been increased before retail sale

100000 POWER TRAIN

Hyundai approves only the ATF, DCT gear oil and IVT gear oil specified in the vehicle??A?A?s owner??A?A?s manual. ??A?A? Use of other ATF may result in improper shift quality or other drivability conditions. ??A?A? Use of other DCT and IV

350000 EQUIPMENT

This bulletin provides the service procedure for engine connecting rod bearing clearance testing. Perform the procedure outlined in this bulletin to fulfill the Bearing Clearance Test inspection requirements to determine next required steps

060000 ENGINE AND ENGINE COOLING

030000 BRAKES (PWS)

This bulletin provides best practice recommendations when performing brake service procedures.

350000 EQUIPMENT

This bulletin provides best practice recommendations when performing brake service procedures.

356000 EQUIPMENT ADAPTIVE/MOBILITY

This bulletin provides best practice recommendations when performing brake service procedures.

350000 EQUIPMENT

This bulletin provides the inspection procedure and repair guidelines for certain vehicles listed below.

060000 ENGINE AND ENGINE COOLING

This bulletin provides the inspection procedure and repair guidelines for certain vehicles listed below.

030000 BRAKES (PWS)

This bulletin describes the procedure to inspect and identify fluid which may appear around the brake caliper area.

200000 WHEELS

This bulletin provides tire vibration service procedures, including how to optimize vehicle vibration performance. For all wheel/tire balance claims, the a??Tire Balance Data Sheeta?? must be fully completed including imbalance and Road For

190000 TIRES

350000 EQUIPMENT

This bulletin provides information regarding condensation related to moisture accumulation in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. The TSB illustrates the various causes of condensation inside the la

120000 EXTERIOR LIGHTING

356000 EQUIPMENT ADAPTIVE/MOBILITY

200000 WHEELS

This bulletin provides information on tire maintenance best practices and procedures for dealers and customers to maximize tire life and performance.

190000 TIRES

This bulletin provides information on tire maintenance best practices and procedures for dealers and customers to maximize tire life and performance.

350000 EQUIPMENT

This bulletin describes the general guidelines to help disinfect and protect vehicle exterior/interior surfaces using recommended safe chemical products.

350000 EQUIPMENT

This bulletin provides information on identifying dealer stock vehicles with either: a?? A Battery SOC alert - low Battery State of Charge (SOC) at or below 50%. a?? A 30 Day alert - vehicle has not started and reported an SOC in 30 days.

110000 ELECTRICAL SYSTEM

100000 POWER TRAIN

The automatic transmission warranty repair policy authorizes in-dealership repairs of the following components for both OEM (new) and remanufactured automatic transmissions:

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

The automatic transmission warranty repair policy authorizes in-dealership repairs of the following components for both OEM (new) and remanufactured automatic transmissions:

356000 EQUIPMENT ADAPTIVE/MOBILITY

The automatic transmission warranty repair policy authorizes in-dealership repairs of the following components for both OEM (new) and remanufactured automatic transmissions:

356000 EQUIPMENT ADAPTIVE/MOBILITY

This bulletin describes the general guidelines to disinfect and protect vehicle interior surfaces using certain safe chemical products.

020000 SUSPENSION

This bulletin describes the requirements for all wheel alignment and/or vehicle tracking claims and best practices when diagnosing and conducting alignment-related repairs for all models and model years.

110000 ELECTRICAL SYSTEM

This bulletin provides guidelines to inspect the USB, head unit, and multi-box for common connection conditions. 2. This bulletin presents guidelines to inspect for common Android Auto and Apple CarPlay connection conditions. 3. This bullet

280000 BACK OVER PREVENTION

The Blind Spot Detection (BSD) or Blind-Spot Collision Warning (BCW) is a system that measures the speed of and distance from the following vehicles by using two magnetic wave radar sensors attached in the rear bumper. The BSD/BCW detects v

270000 LANE DEPARTURE

356000 EQUIPMENT ADAPTIVE/MOBILITY

This bulletin provides instruction detailing the proper methodology for scanning and uploading captured GDS data files to the Techline Repository. Compliance with this bulletin ensures that the GDS data files are correctly transferred and m

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

THIS BULLETIN PROVIDES INFORMATION ON COMPONENTS, ATTRIBUTES, AND PRECAUTIONS OF THE 7-SPEED DRY-TYPE DUAL CLUTCH TRANSMISSION (DCT).

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

HYUNDAI: AUTOMATIC TRANSAXLE RANGE SWITCH DIAGNOSTIC TROUBLE CODES P0705 (RANGE SWITCH SIGNAL PROBLEMS), P0707 (RANGE SWITCH OPEN CIRCUIT), AND P0708 (RANGE SWITCH SHORT CIRCUIT OR MULTIPLE INPUTS). AN IMPROPERLY ADJUSTED OR IMPROPERLY OP

061000 ENGINE AND ENGINE COOLING:ENGINE

106000 POWER TRAIN:AXLE ASSEMBLY

AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *TT

063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

EXHAUST MANIFOLD ASSEMBLY INSPECTION AND REPLACEMENT CAMPAIGN - V04. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *TT

063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

EXHAUST NOISE COMING FROM THE ENGINE COMPARTMENT. VOLUNTARY SERVICE CAMPAIGN V04 INVOLVES INSPECTING AND, IF NECESSARY, REPLACING THE EXHAUST MANIFOLD. *TT

063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

EXHAUST MANIFOLD ASSEMBLY INSPECTION AND REPLACEMENT CAMPAIGN. *EH

106000 POWER TRAIN:AXLE ASSEMBLY

ATA SOLENOID DIAGNOSTIC TROUBLE CODES P0740, P0741, P0742, P0743, P0745, P0747, P0748, P0750, P0752, P0753, P0755, P0757, P0758, P0760, P0765. *TT *MJ

106000 POWER TRAIN:AXLE ASSEMBLY

AUTOMATIC TRANSAXLE PULSE GENERATOR DIAGNOSTIC TROUBLE CODES P0717 & P0722. 2004 ACCENT INCLUDED. *TT

162300 STRUCTURE:BODY:DOOR

INTERIOR DOOR TRIM PANEL FABRIC REPAIR. *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

OBD-II READINESS TEST DRIVE CYCLE. *TT

101000 POWER TRAIN:CLUTCH ASSEMBLY

IMPROVED CLUTCH RELEASE SHAFT UPPER AND LOWER BUSHING. *TT

106000 POWER TRAIN:AXLE ASSEMBLY

SUBJECT REGARDING AUTOMATIC TRANSAXLE OIL LEAKING FROM OIL PAN GASKET. *JG

980000 UNKNOWN OR OTHER

SUBJECT REGARDING DIAGNOSTIC GUIDE FOR CLIFFORD AND DEI SECURITY SYSTEM. *JG

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

SUBJECT ON AUTOMATIC TRANSAXLE HARSH OR DELAYED PARK REVERSE OR PARK DRIVE ENGAGEMENT. *YH

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

SUBJECT REGARDING AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *YH

034510 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER

SUBJECT REGARDING FRONT BRAKE CALIPER RATTLE NOISE REPAIR KIT. *TT

106000 POWER TRAIN:AXLE ASSEMBLY

AUTOMATIC TRANSAXLE PULSE GENERATOR DIAGNOSTIC TROUBLE CODES P0717 AND P0722 - REVISED. *JG

106000 POWER TRAIN:AXLE ASSEMBLY

INFORMATION ON PERFORMING A TEST DRIVE FOR TRANSAXLE SHIFT QUALITY. *TT

106000 POWER TRAIN:AXLE ASSEMBLY

SUBJECT REGARDING TRANSAXLE DIAGNOSTIC TROUBLE CODES. *TT

063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

SUBJECT REGARDING A VOLUNTARY CUSTOMER NOTIFICATION (MASS AIR FLOW SENSOR CONNECTION RECALL CAMPAIGN) ON CERTAIN VEHICLES MANUFACTURED BETWEEN JUNE 1, 1999 AND JUNE 16, 2000. *TT

063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

SUBJECT REGARDING CAMPAIGN 040 - MASS AIR FLOW SENSOR CONNECTION RECALL CAMPAIGN. *TT

063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

SUBJECT REGARDING MASS AIR FLOW SENSOR CONNECTOR REPLACEMENT CAMPAIGN. *TT

106000 POWER TRAIN:AXLE ASSEMBLY

SUBJECT REGARDING AUTOMATIC TRANSAXLES - NOT INTERCHANGEABLE. *TT

106000 POWER TRAIN:AXLE ASSEMBLY

SUBJECT REGARDING THE AUTOMATIC TRANSAXLE TESTER I DESIGNED TO TROUBLESHOOT THE NEW GENERATION TRANSAXLE FOR ALL 2000 MODELS. *TT

106000 POWER TRAIN:AXLE ASSEMBLY

SOME TRANSAXLES PRODUCED PRIOR TO 05/15/99 MAY EXPERIENCE AN OIL LEAK IN THE BELLHOUSING BEHIND THE TORQUE CONVERTER. *TT

106000 POWER TRAIN:AXLE ASSEMBLY

SUBJECT REGARDING AUTOMATIC TRANSAXLES - NOT INTERCHANGEABLE. *TT

070000 FUEL SYSTEM, GASOLINE

THIS BULLETIN PROVIDES FUEL PUMP CHECK CONNECTOR LOCATIONS FOR VARIOUS VEHICLES. *TT

106000 POWER TRAIN:AXLE ASSEMBLY

SUBJECT REGARDING AUTOMATIC TRANSAXLE MODIFICATIONS. *TT

063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

SOME VEHICLES WITH FEDERAL SPECIFICATION EMISSION SYSTEMS AND ON SOME VEHICLES MAY EXHIBIT AN EXHAUST DRONE OR EXHIBIT A BUZZING NOISE AT IDLE OR AT ENGINE SPEEDS UP TO 2500 RPM. *TT

106000 POWER TRAIN:AXLE ASSEMBLY

INFORMATION REGARDING 1998 - 1999 AUTOMATIC TRANSAXLES - NOT INTERCHANGEABLE. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

SOME VEHICLES EQUPPED WITH AUTOMATIC TRANSAXLES MAY SLIP DURING DOWNSHIFT FROM 4TH - 2ND GEAR, SLIP DURING AN UPSHIFT FROM 2ND - 3RD OR 3RD - 4TH GEAR, SLIP WHEN ACCELERATING FROM A STOP AND SLIP CAUSING THE VEHICLE TO NOT ACCELERATE OR NOT

110000 ELECTRICAL SYSTEM

INFORMATION PERTAINING TO THE IDLE POSITION SWITCH ON ATM EQUIPPED VEHICLES. *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

SUBJECT REGARDING CRANKSHAFT POSITION SENSOR REPLACEMENT PROCEDURE. *TT

103700 POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER

SOME VEHICLES MAY EXPERIENCE AN OIL LEAK BEHIND THE TORQUE CONVERTER. *TT

110000 ELECTRICAL SYSTEM

THIS TSB PROVIDES DIAGNOSTIC TROUBLE CODES, A WIRING SCHEMATIC WHICH INCLUDES THE PRETENSIONER CIRCUITS AND A COMPONENT LOCATION INDEX FOR VEHICLES EQUIPPED WITH AN AIR BAG SYSTEM (SRS) AND SEAT BELT PRETENSIONERS. *TT

106000 POWER TRAIN:AXLE ASSEMBLY

SUBJECT REGARDING AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODE P1613/1614. *TT

121000 EXTERIOR LIGHTING:HEADLIGHTS

SHOP MANUAL CORRECTION ON HEADLIGHT AIMING INSTRUCTIONS. *TT

020000 SUSPENSION

INFORMATION ON ALIGNMENT SPECIFICATIONS. *TT

160000 STRUCTURE

PROCEDURES ON REPLACING DAMAGED DRIP RAIL WEATHERSTRIP. *TT

NHTSA Safety Investigations, HYUNDAI ELANTRA

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

DP, Closed , Model Year: 2017

Loss of Motive Power

The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia Americ... a, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.Read more

EA, Closed , Model Year: 2013

Engine Fires

On March 29, 2019, the Office of Defects Investigation (ODI) opened two Preliminary Evaluations (PE19-003 on Hyundai and PE19-004 on Kia) to broadly investigate incidents of non-crash fires (regardless of origin or operational status of the vehicle) on various model year Hyundai and Kia vehicles. ... During the PE investigations, Hyundai and Kia issued several recalls to address vehicle fires, including those due to engine failures involving various engine types. The remedies for the engine failure recalls typically involve engine inspection (to detect existing damage), and if necessary, engine replacement. Additionally, both manufacturers have been installing an engine control software modification known as Knock Sensor Detection Software (KSDS) which is intended to detect impending engine failure, alert the driver, and limit engine power (to lessen likelihood of engine failure).KSDS is being installed under recalls and non-safety field actions, and both companies have extended limited engine warranties (see recall files). On December 22, 2021, ODI upgraded PE19-003 and PE19-004 to this Engineering Analysis (EA21-003, covering both Hyundai and Kia) to evaluate the scope of the prior recalls related to engine failures/fires and the efficacy of the recall remedies for the recalls, as well as the long-term viability of related programs and non-safety field actions being conducted by Hyundai and Kia. The former issue involved approximately 550,000 MY 2013 Hyundai Elantra, MY 2011 Kia Sorento, and MY 2012-2015 Kia Rio. The latter issue involved approximately 2.5 million recalled vehicles, which have been identified as displaying potential remedy concerns: Hyundai recalls 15V-568, 17V-226, 20V-746, and 21V-727; and Kia recalls 17V-224, 19V-120, 20V-750, and 21V-844. Regarding the recall scope issue, among all of the scope vehicles identified at EA opening, ODI found only the MY 2011 Kia Sorento vehicles equipped with both the Theta II 2.4L 4-cylinder Multi-Point Injection (MPI) and the Lambda II 3.5L 6-cylinder MPI engines experienced relatively high rates of reported fires. In December 2023, Kia issued recall 23V-877 that will cover about 80,000 MY 2011 Kia Sorento vehicles equipped with the Theta II 2.4L MPI engines. The remedy will involve an inspection, and if necessary, a replacement of the engine, as well as the installation of KSDS. It should be noted that in 2021 these vehicles were included in a KSDS product improvement campaign with warranty extension. For the MY 2011 Sorento vehicles equipped with the Lambda II 3.5L engines, ODI believes that future engine failures/fires involving these vehicles will likely be due to a lax in adhering to the proper or scheduled engine maintenance (regular engine oil changes), rather than a design or manufacturing engine issue. Regarding the issue of the efficacy of the recall remedies, ODI found the majority of the recalled Hyundai and Kia vehicles, by model, experienced lower reported fire rates after the remedies were applied. Furthermore, ODI found that for most vehicles that did not receive the recall remedies, by model, experienced relatively high fire rates. To address this problem, Hyundai informed ODI in December 2023, that it will renotify all of its owners covered by the Hyundai recalls of engine failures/fires every 8 months for the next 3 years. In December 2023, Kia stated that it will renotify the majority of its owners every 8 months for the next 3 years.Several previously recalled Kia models are excluded from the renotification due to their lower reported rates of engine fires. Overall, the renotification actions will help to increase the recall completion rates, thus reduce the frequency of engine fires in the future. In view of the recall action being taken by Kia and renotification actions being taken by both Kia and Hyundai, ODI is closing this Engineering Analysis. Also, both companies have been released from the 2020-iniated Consent Orders (Kia since November 2022 and Hyundai since November 2023). The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.Read more

DP, Closed , Model Year: 2007

Throttle control system vulnerabilities

The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening ... of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.Read more

EA, Closed , Model Year: 2011

Headliner Bracket Detachment

In March 2013, Hyundai issued a safety recall to reinforce the attachment of the metal support brackets to the headliner assembly in approximately 186,254 model year 2011-2013 Hyundai Elantra vehicles built in Korea and sold in the U.S. (see NHTSA recall 13V-115 for more information).The recall cove... Read more

PE, Closed , Model Year: 2012

Side Curtain Air Bag Improper Deployment

The Office of Defects Investigation (ODI) is aware of one incident of an improper deployment of the driver-side curtain air bag that deployed as a result of a crash involving a model year (MY) 2012 Hyundai Elantra.An inspection of this vehicle showed that a metal bracket (stiffener) in the headliner... Read more

PE, Closed , Model Year: 2001

FRONT LOWER CONTROL ARMS RUSTING

ON APRIL 14, 2009, HYUNDAI MOTOR CORPORATION SUBMITTED TO ODI A DEFECT INFORMATION REPORT INDICATING THAT IT WOULD RECALL A SALT-BELT POPULATION OF APPROXIMATELY 155,317 MODEL YEAR (MY) 2001 THROUGH 2003 HYUNDAI ELANTRA VEHICLES TO REMEDY A DEFECT THAT CAN RESULT IN LOSS OF VEHICLE CONTROL WITH AN I... NCREASED RISK OF A CRASH WHILE DRIVING (09V-125).THE AFFECTED VEHICLES COVER ALL MY 2001, MY 2002, AND MY 2003 THROUGH JANUARY 13, 2003 PRODUCTION.THESE INCLUDE ELANTRA VEHICLES THAT WERE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA AND WISCONSIN.THE TOTAL THREE-YEAR PRODUCTION POPULATION FOR THE ELANTRA VEHICLES IS APPROXIMATELY 350,000. ACCORDING TO HYUNDAI, ROAD SALT CAN COLLECT IN THE OUTBOARD PORTION OF THE FRONT LOWER CONTROL ARM AND MAY RESULT IN INTERNAL CORROSION LEADING TO THINNING OF THE STEEL IN THE LOWER CONTROL ARMS.THE CORROSION MAY PROGRESS TO THE POINT WHERE THE LOWER CONTROL ARM UPPER AND LOWER PANELS BECOME PERFORATED.A PERFORATED FRONT LOWER CONTROL ARM MAY FRACTURE BETWEEN ITS BALL JOINT ATTACHMENT AND THE FORWARD AND REARWARD PIVOT ATTACHMENTS TO THE CHASSIS.THIS COULD AFFECT THE DRIVER'S CONTROL OVER THE TIRE AND WHEEL ASSEMBLY.HYUNDAI'S RECALL PROCEDURE INSTRUCTS DEALERS TO MEASURE THE THICKNESS OF THE STEEL IN THE FRONT LOWER CONTROL ARMS.IF SPECIFIED LEVELS OF CORROSION DAMAGE HAVE OCCURRED, THE FRONT LOWER CONTROL ARMS WILL BE REPLACED WITH NEW FRONT LOWER CONTROL ARMS WITH ADDITIONAL HOLES IN THE UPPER AND LOWER PANELS. ODI'S ANALYSIS OF FRONT LOWER CONTROL ARM COMPLAINT AND WARRANTY DATA SHOWS 220 COMPLAINTS AND 1,033 WARRANTY CLAIMS FOR THE TOTAL APPROXIMATELY 350,000 SUBJECT VEHICLES SOLD THROUGHOUT THE UNITED STATES, RESULTING IN A COMPLAINT RATE OF 62.82 PER 100,000 VEHICLES AND A CLAIM RATE OF 0.3 PERCENT.ODI'S ANALYSIS FOUND 7 COMPLAINTS AND 90 WARRANTY CLAIMS IN 132,475 VEHICLES SOLD IN NON-SALT BELT STATES, RESULTING IN A COMPLAINT RATE OF 5.3 PER 100,000 VEHICLES AND A CLAIM RATE OF 0.1 PERCENT. ODI'S ANALYSIS FURTHER FOUND 196 COMPLAINTS AND 943 WARRANTY CLAIMS IN 155,317 VEHICLES SOLD IN SALT BELT STATES, RESULTING IN A COMPLAINT RATE OF 126.2 PER 100,000 VEHICLES AND A CLAIM RATE OF 0.6 PERCENT.ODI IDENTIFIED 34 INCIDENTS OF LOWER CONTROL ARM FRACTURE RELATED TO CORROSION, ALL OF WHICH OCCURRED IN SALT BELT STATES.THE DATA DO NOT SHOW A DEFECT TREND IN VEHICLES OUTSIDE THE REGION COVERED BY HYUNDAI'S RECALL. THIS PRELIMINARY EVALUATION IS CLOSED.Read more

PE, Closed , Model Year: 2007

ENGINE STALLING - FUEL PUMP FAILURE

ON AUGUST 19, 2008, HYUNDAI SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING FUEL PUMP FAILURE RESULTING IN ENGINE STALL IN APPROXIMATELY 65,000 MODEL YEAR 2008 HYUNDAI ELANTRA VEHICLES WITH 2.0 LITER BETA ENGINES PRODUCED FROM NOVEMBER 5, 2007, THROUGH JUNE 28, 2008 (NHTSA RECALL NO. 08V-4... Read more

EA, Closed , Model Year: 2001

AIR BAG LIGHT ILLUMINATION

HYUNDAI IS CONDUCTING TWO SAFETY RECALLS TO CORRECT TWO SAFETY DEFECTS DESCRIBED BELOW.UNDER SAFETY RECALL 08V-532, HYUNDAI WILL INSTALL A VINYL PROTECTIVE SHIELD/COVER TO PREVENT SHORT CIRCUITS IN THE AIR BAG CONTROL MODULE CAUSE BY SPILLS OF LIQUIDS THAT SEEP INTO THE MODULE CONNECTOR. THIS ACTION... Read more

PE, Closed , Model Year: 2001

AIR BAG LIGHT ILLUMINATION

IN CERTAIN MODEL YEAR (MY) 2001 AND 2002 VEHICLES, THE AIR BAG SYSTEM IS SUSCEPTIBLE TO AIR BAG LIGHT ILLUMINATION AND AIR BAG NON-DEPLOYMENT OR INADVERTENT DEPLOYMENT FROM LIQUID CONTAMINATION OF THE AIR BAG CONTROL MODULE.THE CONTROL MODULE IS LOCATED BENEATH AND NEAR CENTER CONSOLE CUP HOLDERS.OD... Read more

PE, Closed , Model Year: 2004

POST-CRASH FUEL TANK LEAK

PE04-041 WAS OPENED TO INVESTIGATE A FUEL LEAK INCIDENT THAT OCCURRED DURING AN INSURANCE INSTITUTE FOR HIGHWAY SAFETY (IIHS) FRONTAL CRASH OFFSET TEST ON THE SUBJECT VEHICLE.THIS INVESTIGATION REVEALED THAT THE VAPOR TUBE HOSE CLAMP EAR WAS MISPOSITIONED AND FACING TOWARD THE FUEL TANK, WHICH ENABL... Read more

SQ, Open , Model Year: 1996

FUEL CAP REPLACEMENT CAMPAIGN 36

There is no summary currently available

PE, Closed , Model Year: 1996

WINDSHIELD WIPER FAILURE

IN ITS LETTER DATED FEBRUARY 14, 1997, HYUNDAI STATED THAT APPROXIMATELY 75,000 HYUNDAI VEHICLES (CERTAIN MODEL YEAR 1996-97 ELANTRA, ACCENT, SONATA AND TIBURON MODELS BUILT THROUGH OCTOBER 18, 1996 -- SEE NHTSA RECALL NO. 97V-026 FOR DETAILS) WILL BE RECALLED FOR A DEFECT IN THE WINDSHIELD WIPER MO... Read more

SQ, Open , Model Year: 1992

REAR SUSPENSION FAILURE

ODI HAS RECEIVED COMPLAINTS PERTAINING TO REAR SUSPENSION PROBLEMS.ADDITIONAL INFORMATION IS NEEDED TO FULLY UNDERSTAND THE NATURE AND CIRCUMSTANCES OF THE CANADIAN RECALL.FURTHERMORE, THIS INVESTIGATION IS OPENED TO EVALUATE HYUNDAI'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN TO INCLUDE ... Read more

PE, Closed , Model Year: 1990

SCISSOR JACK FAILURE

There is no summary currently available

HYUNDAI ELANTRA - All Years Overview

Complete safety history for the HYUNDAI ELANTRA across all model years (1994, 2026).

102 Total Recalls

12,126 Total Complaints

14 Investigations

1,279 Reported Crashes

273 Reported Fires

19 Reported Deaths

HYUNDAI ELANTRA - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2026	1	2	View
2025	0	31	View
2024	1	94	View
2023	2	159	View
2022	5	143	View
2021	6	214	View
2020	3	342	View
2019	1	334	View
2018	0	406	View
2017	4	1,077	View
2016	2	398	View
2015	3	356	View
2014	2	552	View
2013	4	1,863	View
2012	4	920	View
2011	5	589	View
2010	3	504	View
2009	4	321	View
2008	7	424	View
2007	6	365	View
2006	1	209	View
2005	4	180	View
2004	5	209	View
2003	5	310	View
2002	6	431	View
2001	6	445	View
2000	1	259	View
1999 (current)	2	183
1998	0	75	View
1997	3	196	View
1996	3	138	View
1995	1	179	View
1994	2	110	View
1993	0	39	View
1992	0	46	View

Other HYUNDAI Models

Model	Recalls	Complaints
SONATA	184	21,863	View
SANTA FE	153	9,962	View
PALISADE	124	2,704	View
TUCSON	95	8,074	View
SONATA HYBRID	67	1,129	View
IONIQ 5	66	1,865	View
ACCENT	64	2,745	View
SANTA FE HYBRID	57	347	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

1999 HYUNDAI ELANTRA

Complaint Statistics

Top Reported Components

EPA Fuel Economy, 1999 HYUNDAI ELANTRA

Technical Service Bulletins, 1999 HYUNDAI ELANTRA

Most Affected Components

NHTSA Safety Investigations, HYUNDAI ELANTRA

HYUNDAI ELANTRA - All Years Overview

HYUNDAI ELANTRA - Year by Year

Other HYUNDAI Models