2004 FORD MUSTANG

6 recalls, 130 complaints - 50 TSBs

EXTERIOR LIGHTING:HEADLIGHTS

Defect Description

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES... Read more

Consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy

DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

42,540 vehicles affected

Manufacturer: DOPE, INC.

EXTERIOR LIGHTING

Defect Description

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES... Read more

Consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

16,270 vehicles affected

Manufacturer: SABERSPORT

EXTERIOR LIGHTING:HEADLIGHTS

Defect Description

K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND A... Read more

Consequence

WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy

K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.

1,921 vehicles affected

Manufacturer: K2 MOTOR CORPORATION

FUEL SYSTEM, GASOLINE

Defect Description

CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE... Read more

Consequence

FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.

Remedy

UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.

58,640 vehicles affected

Manufacturer: UFI FILTERS USA

EXTERIOR LIGHTING

Defect Description

CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. ... Read more

Consequence

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy

CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.

27,176 vehicles affected

Manufacturer: CK MOTORSPORT, INC.

VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

Defect Description

ON CERTAIN MUSTANG COBRA PASSENGER VEHICLES, THE REAR SURFACE OF THE ACCELERATOR PEDAL MAY COME INTO CONTACT WITH FLOOR CARPETING DURING HEAVY THROTTLE APPLICATION. THE UNIQUE SURFACE PROFILE OF THE ACCELERATOR PEDAL MAY CATCH IN THE CUTOUT ON THE FLOOR CARPETING BEHIND THE ACCELERATOR PEDAL.

Consequence

THIS COULD INTERFERE WITH THE PEDAL'S ABILITY TO RETURN TO AN IDLE POSITION. UNEXPECTED, CONTINUED THROTTLE APPLICATION AND/OR INCREASED STOPPING DISTANCES MAY OCCUR WHICH COULD RESULT IN A CRASH.

Remedy

DEALERS WILL INSTALL A SHIELD OVER THE CUTOUT IN THE CARPET BEHIND THE ACCELERATOR PEDAL. THE RECALL BEGAN ON APRIL 26, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

19,140 vehicles affected

Manufacturer: FORD MOTOR COMPANY

Complaint Statistics

130 total complaints 21 crashes 8 injuries

Top Reported Components

Component	Complaints
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL	26
UNKNOWN OR OTHER	15
VEHICLE SPEED CONTROL	5
TIRES	5
AIR BAGS	5
AIR BAGS:FRONTAL	4
SUSPENSION	4
ENGINE	3
EQUIPMENT	3
ELECTRICAL SYSTEM	3

Incident date: Jul 3, 2026

Po442 Evaporative Emmison system leak. Heat catalyst egr set malfunctions. Primary and secondary a/c system deficiencies.

Incident date: Jul 3, 2026

Po442 Evaporative Emmison system leak. Heat catalyst egr set malfunctions. Primary and secondary a/c system deficiencies.

Incident date: Jul 3, 2026

Po442 Evaporative Emmison system leak. Heat catalyst egr set malfunctions. Primary and secondary a/c system deficiencies.

Incident date: Jan 13, 2024

2013 Chevy Malibu LS Headlight found shorted and was causing other electrical issues. I found out the 8pin plug one of its pins showing burnt and its male mate same You can see this issue is not just one owner incident and it’s a public complaint in this public forum link [XXX] INFORMATION REDACT... Read more

Incident date: Jan 13, 2024

Incident date: Jul 31, 2013

CASUAL DRIVER. NOTICED ACCELERATION AND COASTING/ROLLING WERE SLUGGISH. MECHANIC NOTED BRAKE AREA TEMP ON FRONT DRIVER'S SIDE WAS OVER 400 DEGREES. THE BRAKES ON THAT WHEEL WOULD NOT RELEASE COMPLETELY AND CAUSED CONTINUOUS FRICTION PRODUCING OVERHEATING. (I NOTICED I AM NOT THE ONLY ONE TO SUBMIT... Read more

Incident date: Mar 3, 2020

NEVER KNOW WHEN CAR IS FULLY GAS UP ALWAYS PUT GAS IN AT 1/4 TO 1/2 TANK, WILL OVERFILL IF NOT VERY CAREFULLY SO REALLY JUST PUT NO MORE THAN 10 TO 15 DALLAS NEVER SHOWS FULL. DO NOT WANT TO OVERFLOW ON ME FOR ONE TWO IT'S BAD FOR MY BABY #1 MUSTANG

Incident date: Mar 1, 2016

BACK ON MARCH 1, 2016 I BELIEVE I WAS COMING TO A STOP LIGHT I APPLIED MY FOOT ON THE BREAK AND THE CAR SEEM TO WANNA KEEP INCHING FORWARD INCHING FORWARD I HAD AT THIS TIME CONTINUED TO PRESS DOWN ON THE BREAK AS SOON AS I KNEW IT I WAS IN THE MIDDLE OF THE STREET PRACTICALLY DURING A RED LIGHT AND... Read more

Crash

Incident date: Mar 1, 2017

GAS PEDAL GOT CAUGHT ON A PIECE OF CARPET WHICH CAUSED MY CAR TO ENTER INTO AN INTERSECTION ON A RED LIGHT AND CAUSED ME TO HAVE AN ACCIDENT. WHICH THEN MADE MY INSURANCE JUMP. I REMEMBER THIS DAY VERY WELL IT WAS THE DAY BEFORE MY BIRTHDAY I CAME UP TO THE RED LIGHT AND STOPPED THE CAR SEEM TO WANT... Read more

Crash

Incident date: Apr 13, 2019

ABS BRAKE LIGHT IS ON THIS IS UNSAFE IN WET OR SNOWY CONDITIONS

Incident date: Nov 22, 2018

TL* THE CONTACT OWNS A 2004 FORD MUSTANG. WHILE DRIVING 25 MPH, THE ACCELERATOR PEDAL BECAME CAUGHT IN THE FLOORMAT AND CAUSED THE VEHICLE TO ACCELERATE. THE CONTACT HAD TO SHIFT INTO NEUTRAL TO STOP THE VEHICLE. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS 169,865.

Incident date: Mar 1, 2017

BACK IN 2016 I WAS INVOLVED IN AN ACCIDENT IN WHICH MY GAS PEDAL SEEMED TO HAVE GOT HUNG UP ON THE CARPET WHICH CAUSED MY GAS PEDAL TO ACCELERATE A LITTLE WHEN I WAS AT A RED LIGHT CAUSING ME TO HAVE AN ACCIDENT.. I WAS COMING TO A STOP AT A RED LIGHT WHEN THE PEDAL SEEMED TO HAVE GOT STUCK. I HAD M... Read more

Crash

Incident date: Sep 1, 2018

TL* THE CONTACT OWNS A 2004 FORD MUSTANG. WHILE ATTEMPTING TO DRIVE OFF FROM A PARKING SPACE, THE VEHICLE ACCELERATED FROM 0 TO APPROXIMATELY 40 MPH. AS A RESULT, THE VEHICLE CRASHED INTO THE FRONT DRIVER'S SIDE OF ANOTHER VEHICLE THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THERE WERE NO... Read more

Crash

Incident date: Jul 16, 2017

THE SPARK PLUGS HAVE A TENDENCY TO BLOW OUT. AN EXPLOSION MAKES THE PLUG STRIP THE THREADS AND DO DAMAGE TO THE HEAD. THERE IS ALSO POTENTIAL FOR FIRE AS FUEL VAPOR IS THEN RELEASE DIRECTLY INTO THE ENGINE COMPARTMENT.

Incident date: Nov 29, 2015

TL* THE CONTACT OWNED A 2004 FORD MUSTANG. WHILE DRIVING APPROXIMATELY 15 MPH, A VEHICLE RAN A RED LIGHT AND CRASHED HEAD ON INTO THE CONTACT'S VEHICLE. THE CONTACT'S VEHICLE WAS TURNED SIDEWAYS AND CRASHED INTO A POLE. THE FRONTAL AIR BAGS FAILED TO DEPLOY. THE CONTACT WAS PINNED INSIDE THE VEHICLE... Read more

Crash

Incident date: Feb 28, 2016

WE WERE IN AN ACCIDENT ON 2-28-2016 AND WAS HIT FROM THE SIDE AND PUSHED INTO A DITCH WHILE PASSING A FORD 250 HE TURNED INTO US WHILE DRIVING 50 MPH. THE AIRBAGS DID NOT GO OFF.

Crash 1 injured

Incident date: Jul 5, 2015

TL* THE CONTACT OWNS A 2004 FORD MUSTANG. THE CONTACT STATED THAT HEADLAMPS FAILED TO RESPOND INTERMITTENTLY. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 110,000. THE VIN ... Read more

Incident date: Jan 3, 2011

FOR AT LEAST 5 YEARS THE CONVERTIBLE TOP LEAKS WATER INTO THE BACK OF THE CAR WHEN THE TOP FOLDS DOWN INTO THE BACK OF THE CAR, THEN THIS WATER LEAKS ONTO THE BACK FLOOR BOARDS. AFRAID IT IS GOING TO ROT OUT THE FLOOR BOARDS. THIS NEEDS TO BE TAKEN CARE OF. I KNOW OF MANY FORD MUSTANGS THAT DO TH... Read more

Incident date: Jul 21, 2014

PASSENGER SIDE FRONT SEAT BELT RETRACTS ONLY AND WILL NOT EXTEND, SO THEREFORE IS NON-FUNCTIONAL. THIS IS NOT A CASE OF TWISTED BELT, AS WE HAVE ACCESSED THE PART AND ENSURED "FLAT" WIND. MY SON JUST BOUGHT CAR. PRIOR OWNER SAYS IT NEVER WORKED FOR SEVERAL YEARS. DRIVER'S SIDE SEAT BELT IS AL... Read more

Incident date: Jan 1, 2007

TL* THE CONTACT OWNS A 2004 FORD MUSTANG. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE COULD NOT BE REPLICATED HOWEVER, THE DEALER MADE REPAIRS TO THE VEHICLE. THE CONTACT WAS UNSURE OF WHAT REPAIRS WERE PERFORMED. THE FAILURE RECURRED S... Read more

Incident date: May 8, 2012

TL* THE CONTACT OWNS A 2004 FORD MUSTANG. THE CONTACT STATED THAT WHILE DRIVING, A LOUD NOISE WAS HEARD COMING FROM UNDER THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO A REPAIR SHOP WHERE THEY ADVISED THAT THE AIR COMPRESSOR CONDENSATION DRIPPED ONTO THE EXHAUST PIPE AND THE EXHAUST PIPED NEEDED TO ... Read more

Incident date: Nov 8, 2011

TL* THE CONTACT OWNS A 2004 FORD MUSTANG. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS AND ENGAGING THE ACCELERATOR PEDAL, THE PEDAL WOULD BECOME STUCK. AS A RESULT, THERE WAS AN INCREASE IN ENGINE RPMS.THE CONTACT MENTIONED THAT SHE WOULD HAVE TO KICK AT THE PEDAL OR ENGAGE THE BRAKES IN... Read more

Incident date: Nov 8, 2011

Incident date: May 19, 2012

TL* THE CONTACT OWNS A 2004 FORD MUSTANG. THE CONTACT HAS A COOPER MASTER-CRAFT SENSYS01 TIRE, SIZE 205/65R15, DOT #2402 THAT FAILED. WHILE DRIVING 70 MPH THE DRIVERS SIDE FRONT TIRE TREAD SEPARATED CAUSING DAMAGE TO THE WHEEL WELL, THE FRONT BUMPER AND LOOSENED THE ROCKER PANEL. THE VEHICLE MERGED ... Read more

Incident date: Jun 1, 2011

EVERY TIME IT RAINS, UNDERNEATH THE PASSENGER SEAT INTO THE BACK PASSENGER SIDE FLOORBOARD IS FLOODED WITH WATER. *TR

Incident date: Sep 18, 2011

SEPTEMBER 18, 2011: WHILE EXITING AN INTERSTATE, I BEGAN TO GO AROUND THE CLOVERLEAF OF MY EXIT, LESS THAN 15 MPH, AND THE BACK END OF MY MUSTANG VERY QUICKLY FISHTAILED SPINNING ME ALL THE WAY AROUND. I ENDED UP FACING THE PEOPLE BEHIND ME, WHO FORTUNATELY WERE GOING AS SLOWLY AS I WAS. FORTUNATE... Read more

Incident date: Mar 18, 2009

TL* THE CONTACT OWNS A 2004 FORD MUSTANG. THE CONTACT STATED THE HEADLIGHTS WERE VERY DIM AND THE HIGH BEAMS HAD TO BE USED IN ORDER TO SEE AT NIGHT. THE CONTACT REPLACED THE LENS AND ADDED HIGH INTENSITY LIGHT BULBS, BUT THE FAILURE WAS NOT CORRECTED. THE CONTACT SPOKE WITH THE MANUFACTURER AND STA... Read more

Incident date: Apr 13, 2010

TL*THE CONTACT OWNS A 2004 FORD MUSTANG. THE REAR AXLE HOUSING WAS CORRODED AND RUSTED WHICH THE CONTACT NOTICED AFTER A ROUTINE MAINTENANCE. THE CONTACT CALLED THE DEALER WHO STATED THERE WERE NO RECALLS. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 15,000. UPDATED 04/08/11

Incident date: Sep 6, 2004

IN 2004 MY MOM BOUGHT A NEW 2004 FORD MUSTANG WITH THE 3.9 V-6 MOTOR AND WITHIN A COUPLE OF MONTHS IT STARTED TICKING REAL LOUD WHEN YOU FIRST START IT UP. COME TO FIND OUT IT WAS A PASSENGER SIDE EXHAUST LEAK THAT JUST GOT WORSE, AND AT THE SAME TIME HER ENGINE STARTED MAKING LOUD CHIRPING AND CRA... Read more

Incident date: Sep 6, 2004

Incident date: Nov 10, 2009

CAR STALLING WHILE IDLING AND DECELERATING. *TR

Incident date: Sep 7, 2009

IF YOU RECLINE THE SEAT BACK, AND THE SEATBELT IS THROUGH THE PLASTIC LOOP ATTACHED TO SEAT, IT LOOSES TENSION AND FAILS TO RESTRAIN YOU. THIS CAN CAUSE SERIOUS INJURY DURING AN ACCIDENT. *TR

Incident date: Aug 16, 2009

TL*THE CONTACT OWNS A 2004 FORD MUSTANG. WHILE DRIVING 10MPH, A VEHICLE PROCEEDED THROUGH A TRAFFIC LIGHT AND CRASHED INTO THE FRONT PASSENGER SIDE OF HER VEHICLE. THERE WERE NO INJURIES SUSTAINED; HOWEVER, SHE STATED THAT THE AIR BAGS ARE DEFECTIVE SINCE THE IMPACT FROM THE CRASH SHOULD HAVE CAUSE... Read more

Crash

Incident date: Jun 1, 2009

A FEW WEEKS AGO, I HAD TO DRIVE ACROSS TOWN TO PICK UP MY SISTER FROM WORK (IRONICALLY, SHE WAS HAVING A CAR PROBLEM.) I STOPPED FOR AN ACCIDENT, AND I NOTICED THE HEADLIGHTS GETTING DIMMER AND DIMMER. I LOOKED AT THE BATTERY GAUGE AND SAW THAT THE CAR WAS DYING. SINCE I WAS IN THE MIDDLE LANE, I KI... Read more

Incident date: Dec 25, 2008

EAGLE LS BACK SIDE RIGHT TIRE BLEW OUT SEPARATED FROM THREAD AROUND WHOLE TIRE 4 HOLES IN TIRE SPEED WAS 40MPH THANKS GOD NO RAIN DIDN'T RUN OVER ANYTHING THE THREAD SEPARATED FROM AROUND THE WHOLE TIRE WITH 4 HOLES NO WARNING TIRES IN GREAT SHAPE. *TR

Incident date: Oct 13, 2008

1. FRONT DRIVER SIDE TIRE FLATTENED ON THE WAY TO WORK...I FILLED IT UP AND PROCEEDED TO WORK AND HAD HELP CHANGING TIRE IN PARKING LOT. 2. ALL 4 VALVE STEMS WERE LEAKING ON MY TIRES 3. REPLACED 2 BACK TIRES AND FIXED VALVES ON 2 FRONT TIRES. *TR

Incident date: Mar 7, 2008

2004 FORD MUSTANG REAR BRAKE CALIPER/PISTON FAILURE. THE FAILURE RESULTED IN A NEAR FIRE ON THE RIGHT REAR OF THE VEHICLE. END RESULTS IN REPLACEMENT OF THE ROTOR, CALIPER, AND BRAKE PADS. THE LEFT REAR BRAKE SYSTEM WAS UNAFFECTED. *TR

Incident date: Jan 3, 2008

TL*THE CONTACT OWNS A 2004 FORD MUSTANG. THE VEHICLE HAS GOODYEAR EAGLE LS, SIZE P225/55/R16 (NA) TIRES. WHILE DRIVING APPROXIMATELY 55 MPH, THE SIDEWALL OF THE PASSENGER REAR TIRE BLEW OUT WITHOUT WARNING. THE CONTACT PULLED OFF THE ROAD AND AAA REPLACED THE TIRE. THE TIRE PRESSURE WAS NORMAL. ... Read more

Incident date: Dec 12, 2007

CAR WAS PARKED ON HILL WHILE IDLING WITH PARKING BRAKE ON, WHEN THE CAR ROLLED DOWN THE HILL, RESULTING IN OVER $5,000.00 IN DAMAGES. THE BREAK HANDLE WAS STILL IN THE UP POSITION. *TR

Crash

Incident date: Dec 12, 2007

CAR WAS PARKED ON HILL WHILE IDLING WITH PARKING BRAKE ON, WHEN THE CAR ROLLED DOWN THE HILL, RESULTING IN OVER $5,000.00 IN DAMAGES. THE BREAK HANDLE WAS STILL IN THE UP POSITION. *TR

Crash

Incident date: Aug 7, 2005

TL*THE CONTACT OWNS A 2004 FORD MUSTANG. THE CONTACT STATED THAT THE TAIL PIPE WAS PROTRUDING TOO FAR FROM THE VEHICLE, WHICH CAUSED A MASSIVE INJURY TO HIS SON'S ARM. THE TAIL PIPE IS CUT IN A 2.9 INCH EDGE INSTEAD OF BEING ROUNDED. HE BELIEVED THAT IT SHOULD BE FURTHER BACK (APPROXIMATELY ONE I... Read more

1 injured

Incident date: Sep 9, 2007

TL*THE CONTACT'S DAUGHTER OWNS A 2004 FORD MUSTANG COBRA. WHILE DRIVING 25 MPH, THE CONTACT REMOVED HIS FOOT FROM THE ACCELERATOR PEDAL AND THE VEHICLE CONTINUED TO DRIVE FORWARD. HE STATED THAT THE PEDAL WAS STUCK TO THE FLOOR. THE VEHICLE DROVE OVER A CURB AND, CRASHED INTO A FENCE AND A POLE, ... Read more

Crash

Incident date: Mar 19, 2007

POWER STEERING UNIT WAS EXCESSIVELY NOISY AND DISTRACTING... LOCKS UP ON HARD TURN. DEALER SAYS NATURE OF THE BEAST, WON'T REPLACE IT. COMPLAINED 3 TIMES, CAR JUST WENT OUT OF WARRANTY... SEVERAL HUNDRED LOCAL POLICE CRUISERS HAVE HAD THEIR POWER STEERING REPLACED, BY DEALER AFTER "NEGATIVE PUBLICI... Read more

Incident date: Jan 12, 2007

FOLLOWING A FRONTAL ACCIDENT AT 40 MPH NEITHER FROM AIR BAG DEPLOYED FROM MY 2004 FORD MUSTANG, VIN [XXX]. *NM UPDATED 07/11/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Crash

Incident date: Dec 25, 2006

A FEW DAYS PRIOR MY CAR MADE A SQUEALING NOISE WHEN I STOPPED. ON DEC 25, 2006 I WAS TRAVELING DOWN A RESIDENTIAL STREET WHEN MY AXLES SHIFT AND MY CAR TIRES LOCKED UP, IT WAS APPROXIMATELY 1/8 MILE FROM MY HOME. THE STEERING WHEEL WAS SHIFTED APPROXIMATELY 90 DEGREES. *JB

Incident date: Dec 25, 2006

Incident date: Jun 8, 2006

DT*: THE CONTACT STATED THERE WERE TWO SEPARATE BLOWOUTS ON SAME TYPE OF TIRE WHILE DRIVING AT 80 AND 50 MPH. THE WEATHER CONDITIONS WERE DRY AND NO DEBRIS WAS ON THE ROAD. THERE WERE NO REPORTS FILED OR PICTURES TAKEN. UPDATED 7/25/2006 - GOODYEAR EAGLE ZR TIRES. *NM

Incident date: Jun 8, 2006

Incident date: Apr 16, 2006

FRONT IMPACT 35-40 MPH AIRBAGS NEVER DEPLOYED. *JB

Crash 1 injured

Incident date: Feb 20, 2006

MY ACCELERATOR PEDAL GOT STUCK UNDER MY CARPET AND ALMOST CAUSED ME TO WRECK!! *NM

Showing 50 of 130 complaints.

EPA Fuel Economy, 2004 FORD MUSTANG

Trim / Engine	City MPG	Highway MPG	Combined MPG	Fuel Type	Annual Fuel Cost
3.8L 6-cyl, Automatic 4-spd (Rear-Wheel Drive)	17.0	25.0	20.0	Regular	$3,100
3.8L 6-cyl, Manual 5-spd (Rear-Wheel Drive)	18.0	27.0	21.0	Regular	$2,950
3.9L 6-cyl, Automatic 4-spd (Rear-Wheel Drive)	17.0	24.0	20.0	Regular	$3,100
3.9L 6-cyl, Manual 5-spd (Rear-Wheel Drive)	18.0	27.0	21.0	Regular	$2,950
4.6L 8-cyl, Automatic 4-spd (Rear-Wheel Drive)	16.0	21.0	18.0	Regular	$3,450
4.6L 8-cyl, Automatic 4-spd (Rear-Wheel Drive)	15.0	21.0	17.0	Regular	$3,650
4.6L 8-cyl, Manual 5-spd (Rear-Wheel Drive)	15.0	23.0	18.0	Regular	$3,450
4.6L 8-cyl, Manual 5-spd (Rear-Wheel Drive)	15.0	23.0	18.0	Regular	$3,450
4.6L 8-cyl, Manual 6-spd (Rear-Wheel Drive)	15.0	22.0	17.0	Regular	$3,650

CO2 Emissions: -1.0 g/mile (Subcompact Cars)

Source: U.S. Environmental Protection Agency (EPA). Actual fuel economy may vary based on driving conditions.

Technical Service Bulletins, 2004 FORD MUSTANG

50 manufacturer communications from 33 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
061000 ENGINE AND ENGINE COOLING:ENGINE	7
102000 POWER TRAIN:MANUAL TRANSMISSION	5
110000 ELECTRICAL SYSTEM	3
063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM	3
060000 ENGINE AND ENGINE COOLING	2
062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM	2
138120 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:WINDSHIELD:ELECTRICAL HEATING ELEMENT	2
105500 POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT	1

060000 ENGINE (PWS)

The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate

060000 ENGINE AND ENGINE COOLING

061000 ENGINE AND ENGINE COOLING:ENGINE

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

061110 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS

061120 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER

061200 ENGINE AND ENGINE COOLING:ENGINE:DIESEL

061320 ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER

062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM

062100 ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY

062200 ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

062300 ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS

063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

063110 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)

063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

063140 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR

063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

061000 ENGINE AND ENGINE COOLING:ENGINE

SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE

061000 ENGINE AND ENGINE COOLING:ENGINE

ENGINE MISFIRE WITH DIAGNOSTIC TROUBLE CODE (DTC) PEWEE, P0302, P0303, P0304, P0305, P0306, P0307, P0308, AND P0316. *TT

106000 POWER TRAIN:AXLE ASSEMBLY

LIMITED SLIP AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNING MANEUVERS. *TT

060000 ENGINE AND ENGINE COOLING

WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT

151300 SEAT BELTS:FRONT:RETRACTOR

SAFETY BELT RETRACTION SPEED. *TT

150000 SEAT BELTS

SAFETY BELT WEB STOP BUTTON SERVICE. *EH

102000 POWER TRAIN:MANUAL TRANSMISSION

1-2 SHIFT CLASH, GRIND OR HARD TO SHIFT - TR3650 5 SPEED MANUAL TRANSMISSION. *TT

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT

014000 STEERING:RACK AND PINION

STEERING RACK NOISE. *TT SQUEAK/CREAK NOISE FROM STEERING RACK WHEN TURNING. *SC

138200 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REAR WINDOW

REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT

063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

EXHAUST LEAK - CRACKED OR SEPARATED RIGHT SIDE EXHAUST PIPE - 3.8L AND 3.9L ENGINES. *TT

102000 POWER TRAIN:MANUAL TRANSMISSION

MANUAL TRANSMISSION HARD TO SHIFT INTO FIRST/REVERSE FROM A STOP. *TT

010000 STEERING

POP/CLUNK OR SQUEALING NOISE FROM THE STEERING GEAR WHEN TURNING, DRIVING OVER BUMPS, OR BRAKING. OASIS. *TT

110000 ELECTRICAL SYSTEM

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04.

138120 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:WINDSHIELD:ELECTRICAL HEATING ELEMENT

REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT

138120 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:WINDSHIELD:ELECTRICAL HEATING ELEMENT

INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS. *TT

102000 POWER TRAIN:MANUAL TRANSMISSION

TRANSMISSION RATTLE NOISE OR DIFFICULT TO SHIFT CONDITION ON VEHICLES EQUIPPED WITH A TREMEC T56 6 SPEED MANUAL TRANSMISSION. *TT

102000 POWER TRAIN:MANUAL TRANSMISSION

HARD TO SHIFT. *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

ENGINE TICKING NOISE. *TT

110000 ELECTRICAL SYSTEM

INTERMITTENT LOSS OF POWER OR CRANK NO START - POSSIBLE PATS LAMP FLASHING AND DIAGNOSTIC TROUBLE CODES (DTCS) U1147 AND/OR U1262. *TT

063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

EXHAUST LEAK. RIGHT SIDE EXHAUST PIPE ON 3.8L OR 3.9L ENGINE. *TT

102000 POWER TRAIN:MANUAL TRANSMISSION

GEAR WHINE IN 1ST, 3RD AND REVERSE GEARS. *TT

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

THUMP NOISE WHEN A/C CLUTCH ENGAGES. *MJ

061000 ENGINE AND ENGINE COOLING:ENGINE

4.6L SUPERCHARGED ENGINE MAY EXHIBIT A LACK OF POWER AND NO BOOST WHEN THE VEHICLE IS INITIALLY DELIVERED TO THE DEALERSHIP. *TT

105000 POWER TRAIN:DRIVELINE

DRIVELINE CLUNK DURING GEAR CHANGES AND/OR QUICK ACCELERATION AFTER COAST (TIP-IN) CLUNK. *TT

062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM

OVERHEATING CONDITION - COOLING SYSTEM FILL/BLEED PROCEDURE. *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

ENGINE-ROMEO BUILT 4.6L 2V-TICK NOISE FROM ENGINE-ENGINES BUILT BEFORE 9/17/2003. *MJ

110000 ELECTRICAL SYSTEM

REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT

162900 STRUCTURE:BODY:ROOF AND PILLARS

CONVERTIBLE TOP LIFTING UNEVENLY. *TT

021000 SUSPENSION:FRONT

SQUEAKING OR CRUNCHING NOISE FROM THE FRONT SUSPENSION WHILE DRIVING OVER BUMPS OR BRAKING. *TT

105500 POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT

SOME COBRAS MAY EXHIBIT A CLUNK NOISE FROM THE DRIVELINE DURING A QUICK ACCLERATION JUST AFTER COAST (TIP-IN CLUNK). *TT

NHTSA Safety Investigations, FORD MUSTANG

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 2011

Inability to shift gears on acceleration

The Office of Defects Investigations (ODI) analyzed complaint data provided by Ford as well as complaints submitted to ODI from consumers.In total, there were 364 unique reports indicating various shift quality issues while driving.Ford identified several factors that may contribute to shift quality... concerns in the subject vehicles, including cold transmission, clutch stay-out at high engine speeds, gear clash or grinding, and gradual loosening of clutch plate bolts in some early production vehicles.The largest percentage of complaints indicated higher than expected shift efforts in cold ambient temperatures.These complaints were related to transmission fluid viscosity and the higher shift efforts resolved themselves with the drivetrain warming.Ford published technical service bulletin TSB 11-3-18 to inform technicians that a lower viscosity fluid was available for use to address the cold shift issues.The clutch stay-out condition typically occurs at engine speeds greater than 4000 rpm.It does not prevent the selection of any gear, but may delay clutch re-engagement depending on how long the driver maintains the higher engine speed.Ford identified rotating inertia of the clutch components as the root cause and replacement clutch pedal parts were made available under Ford TSB 10-19-4.A number of reports alleged increasing difficulty selecting gears along with gear clash or grinding.Grinding or notchy gear shifts may be caused by gradual loosening of clutch plate fasteners, which is promoted by certain aggressive shifting.This condition is progressive in nature and initially results in symptoms related to shift quality/feel.Clutch plate bolt loosening will not result in inability to select any gear unless the progressive symptoms are ignored until complete clutch failure occurs.ODI?s analysis identified only five complaints alleging an inability to shift into gear due to loose clutch plate bolts.None of these resulted in a stall and gear shifting could occur before engine start.A revised fastener was designed and implemented in production and is available for service through a special service message.There is no indication of loss of motive power or unreasonable safety risk associated with the alleged defect in the subject vehicles.This preliminary evaluation is closed.Read more

EA, Closed , Model Year: 2003

ACCELERATOR PEDAL INTERFERENCE

ON APRIL 3, 2006, FORD MOTOR COMPANY SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING A DEFECT CONDITION THAT COULD RESULT IN INTERFERENCE BETWEEN THE ACCELERATOR PEDAL AND FLOOR CARPETING IN APPROXIMATELY 19,140 MODEL YEAR 2003 AND 2004 MUSTANG COBRA VEHICLES (FORD RECALL NO. 06S43/NHTSA R... Read more

PE, Closed , Model Year: 2003

ACCELERATOR PEDAL INTERFERENCE

PE05-038 WAS OPENED ON JULY 7, 2005, WITH 11 CONSUMER COMPLAINTS TO ODI ALLEGING INCIDENTS OF THROTTLE STICKING DUE TO ACCELERATOR PEDAL INTERFERENCE WITH THE CARPET.ODI HAS RECEIVED AN ADDITIONAL 24 COMPLAINTS SINCE THE PE WAS OPENED.DURING PE05-038, FORD SUPPLIED COMPLAINT AND WARRANTY INFORMATION... Read more

PE, Closed , Model Year: 1998

FIRES IN THE CENTER CONSOLE