1995 FORD F-150

7 recalls, 788 complaints - 125 TSBs

EXTERIOR LIGHTING:HEADLIGHTS

Defect Description

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES... Read more

Consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy

DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

42,540 vehicles affected

Manufacturer: DOPE, INC.

EXTERIOR LIGHTING

Defect Description

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES... Read more

Consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

16,270 vehicles affected

Manufacturer: SABERSPORT

EXTERIOR LIGHTING

Defect Description

CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. ... Read more

Consequence

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy

CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.

27,176 vehicles affected

Manufacturer: CK MOTORSPORT, INC.

EXTERIOR LIGHTING

Defect Description

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE D... Read more

Consequence

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy

PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

61,944 vehicles affected

Manufacturer: PRO-A MOTORS, INC.

VEHICLE SPEED CONTROL

Defect Description

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.

Consequence

A FIRE AT THE SWITCH COULD OCCUR.

Remedy

BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO ... Read more

4,500,000 vehicles affected

Manufacturer: FORD MOTOR COMPANY

SEATS

Defect Description

THE WIRE HARNESS FOR THE POWER LUMBAR FEATURE ON THE SEAT IS UNDERNEATH THE FRONT SEAT CUSHION SUPPORT WIRES. THE SUPPORT WIRES ON THE DRIVER SEAT CAN CONTACT AND DAMAGE THE INSULATION HARNESS RESULTING IN A HIGH RESISTANCE ELECTRICAL SHORT THROUGH THE SUPPORT WIRES.

Consequence

CONSEQUENCE OF DEFECT: OVER HEATING OF THE SUPPORT WIRES COULD RESULT, AND MELTING, SMOKE, OR POSSIBLE IGNTION OF THE SURROUNDING MATERIALS COULD OCCUR.

Remedy

DEALERS WILL INSPECT THE SEATS ON THE AFFECTED VEHICLES. IF NO DAMAGE IS FOUND, THE DRIVER SEAT WIRE HARNESS WILL BE COVERED WITH A PROTECTIVE CONVOLUTE TUBING, WRAPPED WITH ELECTRICAL TAPE AND THE HARNESS WILL BE REROUTED. IF DAMAGE IS FOUND, THE WIRE HARNESS WILL BE REPLACED.

31,000 vehicles affected

Manufacturer: FORD MOTOR COMPANY

SEATS

Defect Description

THE SEAT RECLINER TO SEAT FRAME ATTACHING BOLTS ON THESE VEHICLES COULD LOOSEN, FATIGUE AND FRACTURE, ALLOWING THE SEAT BACK TO SUDDENLY RECLINE.

Consequence

IF THIS WERE TO OCCUR TO THE DRIVER'S SEAT, THIS COULD RESULT IN A SUDDEN LOSS OF VEHICLE CONTROL INCREASING THE RISK OF A VEHICLE ACCIDENT.

Remedy

DEALERS WILL REMOVE ALL FOAM AND/OR FABRIC SANDWICHED BETWEEN THE RECLINER ASSEMBLY AND THE SEAT FRAME, INSTALL WASHERS BETWEEN THE SEAT RECLINER AND THE SEAT FRAME AT EACH ATTACHMENT POINT, AND INSTALL NEW ATTACHING BOLTS TORQUED TO A HIGHER SPECIFICATION. THESE CORRECTIONS WILL BE MADE TO BOTH THE... Read more

2,400 vehicles affected

Manufacturer: VEHICLE SAFETY SYSTEMS

Complaint Statistics

788 total complaints 61 crashes 124 fires 52 injuries 2 deaths

Top Reported Components

Component	Complaints
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP	81
VEHICLE SPEED CONTROL:CRUISE CONTROL	46
ENGINE AND ENGINE COOLING:ENGINE	41
AIR BAGS:FRONTAL	29
VEHICLE SPEED CONTROL	28
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY	28
TIRES	27
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS	24
SUSPENSION:FRONT	24
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR	21

Incident date: Jul 25, 2021

The contact owns a 1995 Ford F-150 equipped with a Clutch Max Clutch Kit sold by Clutch America. The part and serial numbers were unknown. The contact stated that while making a right turn into a parking lot, the clutch pedal was depressed and went to the floor and seized. The contact stated that th... Read more

Incident date: Jun 4, 2021

My vehicle has 2 fuel tanks. In the last month I have been noticing that the rest tank is pushing gas to the front tank. I have also noticed a strong fuel smell if I select the rear tank first after filling both tanks. Looking on line there is a NHTSA recall on 1990-1993 models. NHTSA # 93v125000. T... Read more

Incident date: Sep 1, 2016

MY TRUCK HAS DUAL FUEL TANKS. FUEL FROM THE FRONT TANK IS DIVERTED INTO THE REAR TANK. THIS CAUSES THE REAR TANK TO OVERFLOW GASOLINE OUT OF THE GAS CAP. THIS HAPPENS WHEN THE TRUCK'S ENGINE IS RUNNING AND IT IS STATIONARY OR IN MOTION. I HAVE TO MAKE SURE THE REAR TANK IS NEVER MORE THAN HALF FULL ... Read more

Incident date: Oct 20, 2020

WHILE DRIVING MY DUAL TANK 1995 FORD F-150, USING THE REAR TANK, I NOTICED FUEL BEING FORCED OUT OF MY FRONT FUEL FILLER CAP. NOT SURE HOW MUCH FUEL WAS PUMPED OUT PRIOR TO MY NOTICING. I HAD TO LET THE TRUCK SIT WHILE THE FUEL VAPOR DISSIPATED. I FINALLY GOT IT HOME USING THE FRONT TANK. NOT SURE W... Read more

Incident date: Apr 15, 2020

TL* THE CONTACT OWNS A 1995 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS AT STAND STILL ON THE OUTSIDE OF THE GARAGE, WHEN HE NOTICED FIRE EXITING FROM THE ENGINE. THE CONTACT STATED HE HAD A FIRE EXTINGUISHER AND WATER HOSE AND WAS TRYING TO EXTINGUISHED THE FIRE BUT WAS UNABLE TO. THE FIRE ... Read more

Fire

Incident date: Mar 1, 2019

TL* THE CONTACT OWNS A 1995 FORD F-150. WHILE DRIVING 15 MPH, THE CONTACT HEARD AN ABNORMAL NOISE AND SAW SMOKE COMING FROM THE PASSENGER SIDE VENT. THE CONTACT OPENED THE WINDOWS AND CONTINUED TO DRIVE TO HIS DESTINATION. THE CONTACT WAS ABLE TO PARK THE VEHICLE SAFELY. WHEN THE CONTACT ATTEMPTED T... Read more

Incident date: Oct 12, 2017

1995 FORD F150. CONSUMER WRITES IN REGARDS TO VEHICLE HEADLIGHTS. *LD THE CONSUMER STATED THE HEADLIGHTS OF VEHICLES ARE SO BRIGHT THAT THEY CAUSE VISIBILITY ISSUES. UPDATED 11/07/2017*JS

Incident date: Mar 22, 2017

SPEED CONTROL SWITCH ON BRAKE MASTER CYLINDER CAUGHT ON FIRE. DAMAGE LIMITED TO SWITCH WHICH WAS UNPLUGGED AFTER FAILURE. SUBSEQUENTLY, BRAKE FLUID HAS LEAKED OUT OF MASTER CYLINDER AT SWITCH PLUG RESULTING IN CORROSION OF BRAKE PARTS INCLUDING BRAKE MASTER CYLINDER AND BRAKE BOOSTER. BRAKES ARE ... Read more

Fire

Incident date: Mar 22, 2017

Fire

Incident date: Mar 22, 2017

Fire

Incident date: Dec 20, 2016

TL* THE CONTACT OWNS A 1995 FORD F-150. THE CONTACT STATED THAT FUEL FUMES EMITTED INTO THE VEHICLE. THE CONTACT FOUND A LEAK AND NOTICED FUEL SPEWING OUT OF THE CATALYTIC CONVERTER. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIM... Read more

Incident date: Oct 29, 2016

TL* THE CONTACT OWNED A 1995 FORD F-150. WHILE THE VEHICLE WAS PARKED FOR APPROXIMATELY THIRTY MINUTES, IT CAUGHT FIRE WITHOUT WARNING. THE FIRE WAS EXTINGUISHED BY THE FIRE MARSHALL. POLICE AND FIRE REPORTS WERE FILED. THE VEHICLE WAS DESTROYED, BUT NOT TOWED. THERE WERE NO INJURIES. THE FAILURE MI... Read more

Fire

Incident date: Jul 28, 2016

TL* THE CONTACT OWNED A 1995 FORD F-150. WHILE THE VEHICLE WAS PARKED IN THE DRIVEWAY, IT CAUGHT FIRE WITHOUT WARNING. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V017000 (VEHICLE SPEED CONTROL). A FIRE REPORT WAS FILED. THE CONTACT EXTINGUISHED MOST OF THE FIRE BEFORE THE FIRE DEPARTMENT A... Read more

Fire

Incident date: Feb 13, 2016

TL* THE CONTACT OWNS A 1995 FORD F-150. AFTER INSPECTING THE VEHICLE, THE CONTACT DISCOVERED THAT THE FRONT AND REAR FUEL TANKS WERE LEAKING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE REAR FUEL TANK WAS DISCONNECTED AND THE FRONT TANK WAS REPLACED. THE FAILURE RECURRED. THE MANUFACT... Read more

Incident date: Nov 3, 2014

TL* THE CONTACT OWNED A 1995 FORD F-150. THE CONTACT STATED THAT THE VEHICLE CAUGHT FIRE. THE FIRE DEPARTMENT WAS ABLE TO EXTINGUISH THE FIRE. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

Fire

Incident date: Oct 31, 2014

THE REAR SHACKLE'S WERE REPLACED IN 2004,WHEN THE REAR SPRINGS CRACKED FOR NO APPARENT REASON,AND UPON SPRING REMOVAL THE SHACKLE THAT HOLDS THE SPRING HAD HOLES'S AND VERY DETTERIATED. SINCE THE SPRINGS WERE REPLACED THE TRUCK HAS APPRX.65000 MORE MILES,AND WITH NOTHING IN THE TRUCK BOX THE FRONT S... Read more

Incident date: Jul 30, 2014

TL* THE CONTACT OWNS A 1995 FORD F-150. THE CONTACT STATED THAT THE CRUISE CONTROL AND HORN FAILED TO OPERATE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 75,860.

Incident date: Jul 30, 2014

Incident date: Jul 25, 2014

TL* THE CONTACT OWNS A 1995 FORD F-150. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED AND UNOCCUPIED. THERE WAS A LOUD EXPLOSION AND THE VEHICLE BECAME ENGULFED IN FLAMES. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILE... Read more

Fire

Incident date: Jul 10, 2012

TL* THE CONTACT OWNS A 1995 FORD F-150 EQUIPPED WITH GOOD YEAR TRACKER 2 TIRES, SIZE: 31X10.50R15LT. THE CONTACT WAS DRIVING APPROXIMATELY 45 MPH WHEN THE VEHICLE BEGAN PULLING TO THE RIGHT. THE CONTACT STOPPED THE VEHICLE TO CHECK THE FRONT WHEELS AND DISCOVERED THAT THE RIGHT PASSENGER'S SIDE TIRE... Read more

Incident date: Jan 7, 2013

TL* THE CONTACT OWNS A 1995 FORD F-150. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 15 MPH THE CLUTCH FELL TO THE FLOOR BOARD. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO STATED THE BUSHING THAT DETAINS THE ROD TO THE MASTER CYLINDER CLUTCH ASSEMBLY DISINTEGRATED AND HAD TO BE REPLACED. ... Read more

Incident date: Jan 7, 2013

Incident date: Jul 13, 2013

TL* THE CONTACT OWNS A 1995 FORD F150. THE CONTACT STATED THAT GAS WAS LEAKING FROM THE FUEL NOZZLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE IT WAS STATED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAI... Read more

Incident date: Jul 9, 2013

THE PASSENGER SEAT SUDDENLY RECLINED AND WILL NOT LOCK INTO PLACE. THE LOCAL DEALER STATED THERE IS NO RECALL FOR THIS DESPITE (96E010000). I HAVE EXPRESSED CONCERNS WITH THEM IN CASE THE DRIVER SEAT HAS THE SAME MALFUNCTION AND THEY STILL REFUSE TO ACKNOWLEDGE THAT FORD SHOULD TAKE RESPONSIBILITY F... Read more

Incident date: May 21, 2012

TRUCK WAS PARKED, TURNED OFF, AND PARKED IN MY DRIVEWAY. APPROXIMATELY 3:45AM I HEARD GLASS BREAK AND LOOKED OUT THE WINDOW TO SEE THE INSIDE OF THE TRUCK ON FIRE. I RAN AND GRABBED 2 FIRE EXTINGUISHERS AND A WATER HOSE; AND I PUT THE FIRE OUT. THE TRUCK IS TOTALLED NOW. FORD ASKED ME TO TOW IT ... Read more

Fire

Incident date: May 21, 2012

Fire

Incident date: Nov 25, 2011

AFTER GETTING HOME FROM A TRIP, I SMELLED SOMETHING BURNING ABOUT 2 HOURS AFTER WE'D BEEN HOME. I WALKED AROUND TRYING TO FIGURE OUT WHAT IT WAS AND WHEN I WALKED OUTSIDE, I SAW FLAMES COMING FROM THE DRIVER'S SIDE HOOD OF OUR 1995 F-150. MY HUSBAND WENT OVER TO THE DRIVERS SIDE DOOR TO OPEN IT SO H... Read more

Fire

Incident date: Aug 17, 2011

TL* THE CONTACT OWNS A 1995 FORD F150 EQUIPPED WITH COOPER COBRA RADIAL GT TIRES, TIRE SIZE 255/70/15. THE DOT NUMBER WAS 3DM2C280907. WHILE DRIVING APPROXIMATELY 70 MPH, THE CONTACT LOST SLIGHT CONTROL OF THE VEHICLE DUE TO THE REAR DRIVER SIDE TIRE EXPLODING. THE VEHICLE WAS DRIVEN TO THE SIDE OF ... Read more

Incident date: Jul 24, 2011

MY 1995 FORD F-150 HAS DUEL GAS TANKS AND THE REAR TANK STRAPS HAVE CORRODED CAUSING THE TANK TO LOOSE ALL FUEL(1/2 TANK) LEAKING OVER THE SPARE TIRE AND UNDERSIDE OF THE TANK. THIS STARTED WITH THE SMELL OF RAW FUEL IN JULY BUT COULD NOT FIND THE LEAK UNTIL 3 DAYS AGO WHEN I FOUND A LARGE GAS SPOT ... Read more

Incident date: Jun 10, 2009

DRIVER SEATBELT JAMS UP AND MAKES IT UNSAFE TO UNBUCKLE. *KB

Incident date: Nov 28, 2010

TL*THE CONTACT OWNS A 1995 FORD F150. THE CONTACT STATED THAT HE HEARD A LOUD NOISE AND THEN NOTICED THAT THE ENGINE WAS ON FIRE WHICH SPREAD TO THE REAR END OF THE VEHICLE. THE MANUFACTURER TOOK REPORT NUMBER 1373833330 AND ADVISED THE CONTACT THAT HE WOULD RECEIVE A CALL BACK FROM COUNSEL. THE F... Read more

Fire

Incident date: Aug 8, 2010

THIS MORNING OUR FORD F-150 BURST INTO FLAMES IN THE ENGINE COMPARTMENT. THE TRUCK HAD NOT BEEN DRIVEN SINCE THE NIGHT BEFORE AND THE TRUCK WAS JUST SITTING IN THE DRIVEWAY. WE CALLED THE FIRE DEPARTMENT AND THEY PUT OUT THE FIRE BUT THE TRUCK WAS DESTROYED. *TR

Fire

Incident date: Jun 12, 2010

95 FORD 150 CAUGHT FIRE WHILE PARKED. TRUCK WAS DAMAGED AND IT IS A LOSS. FIRE DEPARTMENT AND INSPECTOR FOUND THAT IT WAS DUE TO A RECALL FROM FORD MOTORS OF CRUISE CONTROL. *TR

Fire

Incident date: Jun 12, 2010

TL* THE CONTACT OWNS A 1995 FORD F150 XLT. THE CONTACT STATED HE NOTICED THE VEHICLE WAS LEAKING BRAKE FLUID AND THE BRAKES WOULD FALL FARTHER INTO THE FLOORBOARD THAN USUAL WHEN DEPRESSED. THE CONTACT HAD RECEIVED PRIOR NOTICE OF NHTSA RECALL CAMPAIGN ID NUMBER 05V388000 (VEHICLE SPEED CONTROL). TH... Read more

Incident date: Apr 5, 2010

TL* THE CONTACT OWNS A 1995 FORD F150. WHILE DRIVING AT SPEEDS OF 50 MPH, THE LEAF SPRING BRACKET RUSTED AND FRACTURED FROM THE VEHICLE. THE VEHICLE WAS THEN TAKEN TO AN INDEPENDENT MECHANIC FOR REPAIRS AT THE OWNERS EXPENSE. THE DEALER WAS CONTACTED AND THEY STATED THERE WERE NO RECALLS FOR HIS VEH... Read more

Incident date: Apr 5, 2010

Incident date: Oct 30, 2009

ON OCTOBER 30TH, 2009 I WAS TRAVELING ON ROUTE 113 TOWARDS PORTLAND, ME. AFTER I WENT BY A GAS STATION IN BROWNFIELD, ME I STARTED TO PASS A VEHICLE. I PUSHED THE GAS PEDAL AND SHORTLY AFTER I UNDERSTOOD THAT I CANNOT CONTROL MY CAR. THE GAS PEDAL STUCK AND BRAKES WERE WORKING ONLY FOR A SHORT WHILE... Read more

Crash 1 injured

Incident date: Jan 10, 2010

1995 FORD F150 ENGINE CAUGHT FIRE WHILE ON THE OHIO TURNPIKE. *KBOHIO TRAFFIC CRASH REPORT # 10-0027-91 UPDATED LETTER 04/29/10 *BF

Fire

Incident date: Nov 23, 2009

THIS COMPLAINT CONCERNS THE DRIVER'S SIDE SEAT BELT. WHEN THE SEAT BELT TONGUE IS INSERTED INTO THE BUCKLE THERE IS THE REASSURING "CLICK" AND IT FEELS SECURE AND ENGAGED. HOWEVER, WHEN LEANING FORWARD THE SEAT BELT COMES UNLATCHED. PREVIOUSLY THIS WAS AN OCCASIONAL FAILURE, NOW IT FAILS WHENEVER... Read more

Incident date: Nov 9, 2009

VEHICLE CAUGHT FIRE WHILE PARKED INFRONT OF THE HOUSE. FIRE DEPARTMENT SAID IT WAS RELATED TO THE CRUISE CONTROL SWITCH THAT HAS BEEN RECALLED. *TR

Fire

Incident date: Oct 19, 2009

VIOLENT SHAKE IN F-150 DUE TO FRONT END. NOT THE FIRST TIME IT'S HAPPENED. I REPLACED ROTORS AND BREAKS 2 TIMES AND TOOK IT TO GET THE FRONT END TIGHTENED UP AND ALIGNED TO NO AVAIL. VERY DANGEROUS. HTTP://WWW.TOPIX.COM/FORUM/AUTOS/FORD-F-250-SUPER-DUTY/TOHP1M75VBFBFT9IL/P4. *TR

Incident date: Aug 8, 2009

TL*THE CONTACT OWNS A 1995 FORD F-150. WHILE THE VEHICLE WAS PARKED, IT BURST INTO FLAMES. THE FIRE ORIGINATED FROM THE DRIVER'S SIDE OF THE VEHICLE WHERE THE BRAKE FLUID AND STEERING COLUMN WERE LOCATED. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND FILED A REPORT. THERE WERE NO INJURIES. THE ... Read more

Fire

Incident date: Aug 8, 2009

TL*THE CONTACT OWNS A 1995 FORD F-150. WHILE THE VEHICLE WAS PARKED IN FRONT OF THE CONTACT'S RESIDENCE, IT CAUGHT FIRE WITHOUT NOTICE. UPON INSPECTION, THE CONTACT NOTICED THAT THE FLAMES ORIGINATED FROM UNDER THE STEERING COLUMN. THE VEHICLE HAD NOT BEEN DRIVEN DAYS PRIOR TO THE FAILURE. THE F... Read more

Fire

Incident date: Jun 24, 2009

1995 FORD F150 STARTED ON FIRE PARKED ON THE STREET IN FRONT OF MY HOUSE. *TR

Fire

Incident date: Jan 1, 2002

REFERENCE TO RECALL #05V388000. APPROX 7 YEARS AGO THE HARNESS SHORTED OUT. THE VEHICLE WAS PARKED AND WHEN STARTING UP SAW SMOKE AND SMELLED ELECTRICAL SHORT. OBSERVE ELECTRICAL COMPONENT SHORTENING OUT OF THE CRUISE CONTROL WIRE HARNESS. THIS CAUSED THE CRUISE CONTROL (I.E. HORN, SPEED SETTING... Read more

Fire

Incident date: Dec 21, 2008

NO WARNING WHEN I SHAFTED INTO 2ND GEAR THE 1 INCH SHAFT @ THE REAR OF THE TRANNY SNAPPED THE DRIVE SHAFT FELL FROM THE FRONT & HIT THE PAVEMENT. *TR

Incident date: Dec 3, 2008

I HAVE A 1995 FORD F150 AND WAS NOT TAGGED DUE TO THE AMOUNT OF GAS IT USED AND TAG WAS REMOVED AND COULD NOT BE DRIVEN ON THE ROAD. SO I COULD NOT TAKE TO DEALER TO HAVE RECALL DONE DUE TO NO TAG OR INSURANCE. I PUT NEW BATTERY IN IT AND DROVE AROUND MY PROPERTY AND PARKED IT AND WENT INSIDE MY HOU... Read more

Fire

Incident date: Nov 7, 2008

MY 1995 FORD F 150 CAUGHT FIRE DUE TO THE SPEED CONTROL DEACTIVATION SWITCH. FIRE WAS CONTAINED TO THE MASTER CYLINDER AREA UNDER THE HOOD. (PUT IT OUT MYSELF). *TR

Fire

Incident date: Nov 12, 2008

VEHICLE CAUGHT ON FIRE SITTING IN DRIVEWAY; HAD NOT BEEN STARTED IN 24 HOURS. *TR

Fire

Incident date: Nov 12, 2008

VEHICLE CAUGHT ON FIRE SITTING IN DRIVEWAY; HAD NOT BEEN STARTED IN 24 HOURS. *TR

Fire

Showing 50 of 788 complaints.

Technical Service Bulletins, 1995 FORD F-150

125 manufacturer communications from 115 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
103000 POWER TRAIN:AUTOMATIC TRANSMISSION	15
061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE	9
138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM	5
061000 ENGINE AND ENGINE COOLING:ENGINE	5
034000 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS	5
102000 POWER TRAIN:MANUAL TRANSMISSION	5
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER	4
063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM	4

114000 ELECTRICAL SYSTEM:WIRING

AFTERMARKET WIRING ALTERATIONS - SERVICE TIP. *TT

103600 POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES

NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT

125100 EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH

LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT

103800 POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH

BRAKE SHIFT INTERLOCK.*JB

138600 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:HEATER CORE

SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC

980000 UNKNOWN OR OTHER

INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC

110000 ELECTRICAL SYSTEM

A CONDITION MAY EXIST WITH POSSIBLE ELECTRONC DAMAGE OCCURING TO THE COMPUVALVE FROM VOLTAGE SPIKES BETWEEN THE COMPUVALVE CONNECTIONS WHEN CONNECTING OR DISCONNECTING THE MAIN COMPUVALVE HARNESS C4025. *TT

103600 POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES

SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

TRANSMISSION- E40D/4R100-1989-99-MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART. YD

103600 POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES

VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM IS NOT PROPERLY FLUSHED, FLUID IN-LINE FILTER KIT. *MJS

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS

100000 POWER TRAIN

SOME VEHICLES MAY EXPERIENCE A CONDITION OF NO 4 X 4 LOW RANGE ENGAGEMENT OR A STUCK IN 4 X 4 LOW RANGE. *MJS

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC TROUBLE CODES STORED IN THE GEM MODULE. *TT

103400 POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT

ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. *TT

114000 ELECTRICAL SYSTEM:WIRING

SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO (DTC) DIAGNOSTIC TROUBLE CODE STORED IN THE GEM. *TT

034000 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS

INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT

125000 EXTERIOR LIGHTING:BRAKE LIGHTS

CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT

980000 UNKNOWN OR OTHER

INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT

106000 POWER TRAIN:AXLE ASSEMBLY

SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY REMANUFACTURED (FQR) 4R70W TRANSMISSION EXCHANGE UNITS WITH JULIAN BUILD BETWEEN 062-97 AND 040-99. *TT

162300 STRUCTURE:BODY:DOOR

SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT

110000 ELECTRICAL SYSTEM

FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC

063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC

190000 TIRES

INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC

063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT

034530 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR

HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC

034000 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS

SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC

354600 EQUIPMENT:MECHANICAL:WRECKER AND WHEEL LIFT DEVICES

RECOMMENDED GUIDELINES FOR TOWING BEHIND RECREATIONAL VEHICLES. *TT

034500 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC

THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE. *YC

034000 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS

A COMPREHENSIVE PULL AND DRIFT DIAGNOSTIC PROCEDURE HAS BEEN DEVELOPED TO ASSIST TECHNICIANS IN RESOLVING BRAKE PULL OR DRIFT CONCERNS. *AK

044100 SERVICE BRAKES, AIR:DRUM:SHOES/LININGS

A SHUDDER / VIBRATION AND / OR SQUEALING HEARD WHILE BRAKING - REVISED FRONT BRAKE LINING. *TT

034000 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS

SUBJECT REGARDING ON-VEHICLE CALIPER-MOUNT LATHE MACHINING SETUP PROCEDURES. *TT

020000 SUSPENSION

SOME VEHICLES MAY EXHIBIT A DRIFT OR PULL TO THE LEFT WHILE BRAKING. *TT

045300 SERVICE BRAKES, AIR:DISC:ROTOR

AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC

980000 UNKNOWN OR OTHER

SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,628, AND/OR 1728. *YC

106000 POWER TRAIN:AXLE ASSEMBLY

CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS. *TT

034530 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR

SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

INFORMATION ON THE DEFROSTER PERFORMANCE ENHANCEMENT.

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

PERFORMANCE ENHANCEMENT FOR DEFROSTER. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62, 628, AND / OR 1728 MAY BE STORED IN MEMORY. *TT

500000 CHILD SEAT

PART NUMBER INFORMATION FOR THE USE OF A CHILD SEAT TETHER. *TW

102000 POWER TRAIN:MANUAL TRANSMISSION

NEW CLUTCH SLAVE CYLINDER WITH A REDESIGNED LIP SEAL. *TW

121000 EXTERIOR LIGHTING:HEADLIGHTS

HEADLAMP- HEADLAMP HOUSING MELTS- AMBULANCE AND EMERGENCY VEHICLES ONLY. *JD

114100 ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD

WIRING- AFTERMARKET WIRING ALTERATIONS- SERVICE TIP. *JD

980000 UNKNOWN OR OTHER

FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD

021700 SUSPENSION:FRONT:HUB

NOISE- "RATCHETING"- FRONT AXLE- 4X4- SELF-ENGAGEMENT OF AUTOMATIC HUB LOCKS- BRONCO, F-150 AND F-250 UNDER 8500# GVW. *JD

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD

160000 STRUCTURE

FRAME- RIVET REPLACEMENT WITH BOLTS- SERVICE TIPS. *JD

061110 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS

ACCESSORY DRIVE BELTS- FEAD BELT COMES OFF- VEHICLES WITH 4.9L ENGINE. *JD

116200 ELECTRICAL SYSTEM:IGNITION:MODULE

GEM CONCERN - CHECK FOR MORE THAN ONE GEM CONTROLLED COMPONENT THAT IS INOPERATIVE OR FOR A STRING OF FALSE GEM DTC'S RECEIVED IN MEMORY. *TW

101100 POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)

THE CLUTCH MAY BE HARD TO DEPRESS DUE TO DUST/CONTAMINATION ENTERING THE SLAVE CYLINDER. *TW

021242 SUSPENSION:FRONT:SPRINGS:LEAF SPRING ASSEMBLY:HANGER,BRACKET

NOISE- "POPPING/CREAKING"- FRONT FRAME OR SUSPENSION BRACKETS- FRAME- "POPPING/CREAKING"- FASTENER REPLACEMENT. *JD

104000 POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)

SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD

141100 AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE

AIR BAG LAMP FLASH-OUT CODE 33 ON VEHICLES EQUIPED WITH A PASSENGER SIDE AIR BAG. *JD

116200 ELECTRICAL SYSTEM:IGNITION:MODULE

THE NGS DISPLAYS INCORRECT DATE FOR THE ING GEM PID ON THE VEHICLES. *JD

102000 POWER TRAIN:MANUAL TRANSMISSION

HIGH SHIFT EFFORTS ON MANUAL TRANSMISSION. *JD

102000 POWER TRAIN:MANUAL TRANSMISSION

HIGH SHIFT EFFORTS ON MANUAL TRANSMISSION. *JD

116200 ELECTRICAL SYSTEM:IGNITION:MODULE

THE NGS DISPLAYS INCORRECT DATA FOR THE IGN GEM PID ON THE VEHICLES. *JD

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E40D TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD

061000 ENGINE AND ENGINE COOLING:ENGINE

ENGINE COMPARTMENT NOISE-"BUZZING OR KNOCKING"- RIGHT FRONT OF ENGINE-AFTER STARTING. *JD

103700 POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER

TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW

107000 POWER TRAIN:AXLE HUBS

NOISE - RATCHETING - FRONT AXLE - 4X4 - SELF ENGAGEMENT OF AUTOMATIC HUB LOCKS. *TW

116200 ELECTRICAL SYSTEM:IGNITION:MODULE

POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW

141000 AIR BAGS:FRONTAL

WHEN DIAGNOSING AN AIR BAG LAMP FLASH-OUT CODE 33 (PASSENGER SIDE AIR BAG HIGH RESISTANCE OR OPEN) ON A 1994-1996 F150 OR BRONCO THAT IS NOT EQUIPPED WITH A PASSENGER SIDE AIR BAG, CHECK FOR PROPER GROUND FROM PIN 7, CIRCUIT 629, AT THE AIR

114000 ELECTRICAL SYSTEM:WIRING

WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW

103700 POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER

TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW

105300 POWER TRAIN:DRIVELINE:DRIVESHAFT

VIBRATION - DRIVELINE VIBRATION AND/OR DRIVELINE NOISE - REGULAR CAB 4X4 VEHICLES EQUIPPED WITH 7.5L ENGINE AND MANUAL TRANSMISSION. *TW

141000 AIR BAGS:FRONTAL

DIAGNOSING AN AIR BAG LAMP FLASH-OUT CODE 33 (PASSENGER SIDE AIR BAG HIGH RESISTANCE OR OPEN)

102000 POWER TRAIN:MANUAL TRANSMISSION

INFORMATION ON AODE/4R7W TRANSMISSION MAIN CONTROL & CASE REPLACEMENT. *TT

131000 VISIBILITY:WINDSHIELD

WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW

034000 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS

BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW

185000 VEHICLE SPEED CONTROL:CRUISE CONTROL

LONG CRANK - STICKING IDLE AIR CONTROL (IAC) VALVE - VEHICLES BUILT FROM 11/1/94 THROUGH 3/30/96 -STALL - AFTER STARTING WHEN ENGINE ALLOWED TO SOAK FROM 1-4 HOURS - STICKING IDLE AIR CONTROL (IAC) VALVE. *TW

075000 FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM

MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

AIR CONDITIONING - COMPRESSOR FAILURE - INSUFFICIENT AMOUNT OF REFRIGERANT OIL. *TW

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

ENGINE COMPARTMENT NOISE - BUZZING OR KNOCKING - RIGHT FRONT OF ENGINE - AFTER STARTING - 4.9L ENGINES - F SERIES BUILT FROM 8/1/94 THROUGH 10/15/95 - ECONOLINES BUILT FROM 8/15/94 THROUGH 10/15/95. *TW

102000 POWER TRAIN:MANUAL TRANSMISSION

E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM. *TT

063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

VEHICLES MAY EXHIBIT AN EXHAUST LEAK &/OR NOISE DUE TO WARPED EXHAUST MANIFOLDS. *TT

100000 POWER TRAIN

SUBJECT REGARDING A NEW TRANSMISSION CASE AND MAIN CONTROL RELEASED FOR SERVICE ON AODE / 4R70W TRANSMISSIONS. *TT

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

EXPERIENCING A KNOCKING NOISE WHEN THE ENGINE IS COLD AND UNDER ACCELERATION. *TT

101000 POWER TRAIN:CLUTCH ASSEMBLY

SERVICE TIP INFORMATION REGARDING THE REVERSE CLUTCH PISTON AND PISTON SEAL USAGE. *TT

106000 POWER TRAIN:AXLE ASSEMBLY

4X4 FRONT AXLES MUST USE HYPOID 4X4 GEAR OIL P/N F1TZ-19580-A & HIGH TEMP 4X4 FRONT AXLE & WHEEL BEARING GREASE WHEN SERVICING. IT IS NOT RECOMMENDED TO USE HEAVIER WEIGHT LUBES IN THESE FRONT AXLES.

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

BULLETIN APPLIES TO VEHICLES EQUIPPED W/ A 31TH TRANSAXLE. TRANSAXLE SLIPS MOMENTARILY (ENGINE RPM INCREASES/FLARES) DURING LIGHT THROTTLE 2-3 UPSHIFTS.

105300 POWER TRAIN:DRIVELINE:DRIVESHAFT

BULLETIN APPLIES TO VEHICLES EQUIPPED W/ A 31TH TRANSAXLE. TRANSAXLE SLIPS MOMENTARILY (ENGINE RPM INCREASES/FLARES) DURING LIGHT THROTTLE 2-3 UPSHIFTS.

036000 SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE BECAUSE IT MAY BE INCOMPATIBLE WITH THE RUBBER MATERIAL USED IN THE DISC BRAKE SYSTEM. IF PETROLEUM-BASED GREASE IS USED TO LUBRICATE ANY PAR

107000 POWER TRAIN:AXLE HUBS

CONCERN OF AUTOMATIC HUBLOCKS SELF-ENGAGING. *TW

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

SOME E4OD TRANSMISSIONS W/ BUILD DATES 5B03 (FEB. 3, 1995) AND 5E31 (MAY 31, 1995) MAY HAVE A VALVE, IN THE PUMP, THAT RESTRICTS FLUID FLOW (FIG 1). THIS VALVE MAY BECOME STUCK IN THE VALVE BORE AND RESTRICT LUBRICATION. SYMPTOMS MAY INCLU

112000 ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR

GENERATOR-MOTORCRAFT 95AMP-FRONT BEARING CONCERN-FD1060/1460 ENGINES- VEHICLES BUILT BEFORE 7/3/95. *SD

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

ENGINE- 'KNOCKING' NOISE - WHEN OPERATING ENGINE AT 200-2300 RPM - FD1460 ENGINE

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

REVISED DESIGN TRANSMISSION REAR CASE BUSHING. *TW

011000 STEERING: STEERING WHEEL/HANDLE BAR

LIGHT CLICKING SENSATION OR LOOSENESS AS THE STEERING WHEEL IS TURNED. *TW

021000 SUSPENSION:FRONT

UNKNOWN

111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

UNKNOWN

034100 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

BRAKES - HYDRAULIC - HYDROMAX BRAKE RESEREVOIR MOUNTING BRACKET SEPARATION. *TW

Showing 100 of 125 bulletins.

NHTSA Safety Investigations, FORD F-150

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

EA, Open , Model Year: 2015

Unintended Transmission Downshift and Rear Wheel Lock-up

On March 21, 2025, NHTSA’s Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE25002) to investigate instances of unexpected transmission downshifting without driver input in model year (MY) 2015-2017 Ford F-150 vehicles (subject vehicles) manufactured by Ford Motor Company (F... ord). The complaints allege that, without warning or driver input, the subject vehicles experienced a sudden and rapid deceleration often accompanied by temporary rear wheel lockup, seizure, or skidding, resulting in a loss of vehicle control that increases the risk of crash and injury to all motorists, including those not within the subject vehicles. The MY 2015 and MY 2016 F-150 vehicles were equipped with the “6R80” transmission, while the MY 2017 vehicles were equipped with either the “6R80” transmission or the “10R80” transmission. This investigation was limited to MY 2015-2017 Ford F-150 with the “6R80” transmission. ODI identified 329 Vehicle Owners Questionnaires (VOQs) related to this investigation and sixty percent of these consumers were interviewed to confirm the details of their allegations. Consumers reported that their vehicles’ transmission suddenly downshifted to a lower gear, often to 1st or 2nd gear, without driver input or advance warning. Consumers described the downshift events to be regular and repeated occurrences, with some consumers stating that they no longer drive the vehicle due to safety concerns. Forty-three percent of consumers reported experiencing at least one wheel lockup event, during which the rear tires locked, screeched, or skidded during the transmission downshift. ODI also found that 114 of the 329 consumers reported having their vehicle’s molded lead frame or valve body assembly (which comes with a molded lead frame) replaced, 80 of which were confirmed through consumer submitted repair invoices. In its response to ODI’s Information Request, Ford provided an assessment of potential root cause of failure for the subject vehicles and how this failure is different from the failure associated with MY 2011-2014 Ford F-150 vehicles that was addressed by four safety recalls (16V-248, 19V-075, 19V-433, and 24V-444). Ford has identified that the defect in the recalled vehicle population involved lead frame supplier production issues resulting in signal loss from the Output Shaft Speed (OSS) sensor. Ford has identified that the alleged defect in the subject vehicle population involved degradation of electrical connections within the lead frame due to thermal cycling and vibration over extended time in service resulting in signal loss from the Transmission Range Sensor (TRS). Signal loss from the TRS can result in an unintended shift to neutral, unintended upshift, or unintended downshift which are regulated by a gear “shift map” based on the vehicle’s speed at the time of signal loss. According to Ford’s “shift map”, at speeds between 35-64 mph, the maximum allowable downshift would be to 2nd gear (i.e. a 6th to 2nd gear downshift event) which Ford has designated to represent the worst-case scenario for subject vehicles. Ford has also acknowledged that the worst-case scenario may also involve temporary wheel lockup. However, Ford has stated that the failure mechanism in the MY 2011-2014 F-150 vehicles—previously addressed through recalls—primarily involved OSS sensor signal loss that could result in 6th to 1st gear downshift events. This OSS-related failure mode is distinct from the TRS-related signal loss identified in the subject vehicle population. ODI has identified an additional potential safety defect associated with the alleged defect in the subject vehicles. Preliminary testing performed by NHTSA’s Vehicle Research Test Center (VRTC) showed that when the TRS experiences an intermittent signal loss, one possible outcome is a change in vehicle direction. Specifically, if a vehicle is operating in reverse up an incline when the TRS signal loss occurs, then the vehicle may shift into neutral causing the vehicle to change directions and roll forward. ODI is opening this Engineering Analysis (EA) to, among other things, perform component-level testing and vehicle testing, as well as review additional technical information to better understand the alleged defect that has been identified. To review the reports cited in the Opening Resume ODI Report Identiﬁcation Number document, go to NHTSA.gov.Read more

PE, Closed , Model Year: 2015

Unintended Transmission Downshift and Rear Wheel Lock-up

On March 21, 2025, NHTSA’s Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE25002) to investigate instances of unexpected transmission downshifting without driver input in model year (MY) 2015-2017 Ford F-150 vehicles (subject vehicles) manufactured by Ford Motor Company... (Ford). The complaints allege that, without warning or driver input, the subject vehicles experienced a sudden and rapid deceleration often accompanied by temporary rear wheel lockup, seizure, or skidding, resulting in a loss of vehicle control that increases the risk of crash and injury to all motorists, including those not within the subject vehicles. The MY 2015 and MY 2016 F-150 vehicles were equipped with the “6R80” transmission, while the MY 2017 vehicles were equipped with either the “6R80” transmission or the “10R80” transmission. This investigation was limited to MY 2015-2017 Ford F-150 with the “6R80” transmission. ODI identified 329 Vehicle Owners Questionnaires (VOQs) related to this investigation and sixty percent of these consumers were interviewed to confirm the details of their allegations. Consumers reported that their vehicles’ transmission suddenly downshifted to a lower gear, often to 1st or 2nd gear, without driver input or advance warning. Consumers described the downshift events to be regular and repeated occurrences, with some consumers stating that they no longer drive the vehicle due to safety concerns. Forty-three percent of consumers reported experiencing at least one wheel lockup event, during which the rear tires locked, screeched, or skidded during the transmission downshift. ODI also found that 114 of the 329 consumers reported having their vehicle’s molded lead frame or valve body assembly (which comes with a molded lead frame) replaced, 80 of which were confirmed through consumer submitted repair invoices. In its response to ODI’s Information Request, Ford provided an assessment of potential root cause of failure for the subject vehicles and how this failure is different from the failure associated with MY 2011-2014 Ford F-150 vehicles that was addressed by four safety recalls (16V-248, 19V-075, 19V-433, and 24V-444). Ford has identified that the defect in the recalled vehicle population involved lead frame supplier production issues resulting in signal loss from the Output Shaft Speed (OSS) sensor. Ford has identified that the alleged defect in the subject vehicle population involved degradation of electrical connections within the lead frame due to thermal cycling and vibration over extended time in service resulting in signal loss from the Transmission Range Sensor (TRS). Signal loss from the TRS can result in an unintended shift to neutral, unintended upshift, or unintended downshift which are regulated by a gear “shift map” based on the vehicle’s speed at the time of signal loss. According to Ford’s “shift map”, at speeds between 35-64 mph, the maximum allowable downshift would be to 2nd gear (i.e. a 6th to 2nd gear downshift event) which Ford has designated to represent the worst-case scenario for subject vehicles. Ford has also acknowledged that the worst-case scenario may also involve temporary wheel lockup. However, Ford has stated that the failure mechanism in the MY 2011-2014 F-150 vehicles—previously addressed through recalls—primarily involved OSS sensor signal loss that could result in 6th to 1st gear downshift events. This OSS-related failure mode is distinct from the TRS-related signal loss identified in the subject vehicle population. ODI has identified an additional potential safety defect associated with the alleged defect in the subject vehicles. Preliminary testing performed by NHTSA’s Vehicle Research Test Center (VRTC) showed that when the TRS experiences an intermittent signal loss, one possible outcome is a change in vehicle direction. Specifically, if a vehicle is operating in reverse up an incline when the TRS signal loss occurs, then the vehicle may shift into neutral causing the vehicle to change directions and roll forward. Based on NHTSA’s analysis of consumer data, information provided by Ford, and preliminary testing conducted by NHTSA’s VRTC, this Preliminary Evaluation is being upgraded to an Engineering Analysis (EA26001). During this Engineering Analysis, the agency plans to, among other things, perform component-level testing and vehicle testing, as well as review additional technical information to better understand the alleged defect that has been identified from this Preliminary Evaluation. To review the reports cited in the Closing Resume ODI Report Identiﬁcation Number document, go to NHTSA.gov.Read more

RQ, Closed , Model Year: 2014

Unintended Transmission Downshift

In September 2016, Ford Motor Company (Ford) issued safety recall 16V-248 which included certain model year (MY) 2011-2012 Ford F-150 vehicles equipped with 6-speed (6R80) automatic transmissions. This recall was in response to allegations of unintended, unexpected vehicle transmission downshifting ... to a lower gear without warning, often accompanied by temporary rear wheel lock-up, increasing the risk of a crash and/or injury, and included approximately 153,581 vehicles. Ford identified the root cause of the unintended, unexpected vehicle transmission downshifting to a lower gear to be intermittent signal loss from the transmission’s Output Shaft Speed (OSS) sensor due to solder joint cracks on the OSS circuit board as a result of manufacturing process issues. The OSS sensor is mounted onto the molded lead frame and transmits changes in transmission shaft speed to the Powertrain Control Module (PCM). The remedy program described in safety recall 16V-248 involved reprogramming of the PCM to prevent unintended vehicle transmission downshifting from occurring. In December 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-010) to assess the scope and remedy effectiveness of safety recall 16V-248. As a result of this ODI investigation, Ford issued safety recall 19V-075 to expand the scope of 16V-248 to include MY 2011-2013 Ford F-150 vehicles equipped with 6-speed (6R80) automatic transmissions and included approximately 1,263,051 vehicles. The remedy program described in safety recall 19V-075 involved reprogramming of the PCM to prevent unintended vehicle transmission downshifting from occurring. In June 2019, Ford issued safety recall 19V-433 as the remedy program used to service MY 2013 Ford F-150 5.0L and 6.2L vehicles in accordance with safety recall 19V-075 did not contain the necessary updates to prevent unintended vehicle transmission downshifting from occurring and included approximately 107,857 vehicles. On March 27, 2024, ODI opened this Recall Query (RQ24-005) to investigate the scope of the above-described safety recalls. At the time that this investigation was opened, ODI had received 86 Vehicle Owner Questionnaires (VOQs) reporting allegations of unintended, unexpected vehicle transmission downshifting to a lower gear without warning, often accompanied by temporary rear wheel lock-up, in MY 2014 Ford F-150 vehicles. As a result of this Recall Query, Ford filled safety recall 24V-444 on June 14, 2024, to include MY 2014 Ford F-150 vehicles and expand the scope of safety recalls 16V-248, 19V-075 and 19V-433. The remedy program described in safety recall 24V-444 involved reprogramming of the PCM to prevent unintended vehicle transmission downshifting from occurring and included approximately 552,188 vehicles. In its May 2024 response to ODI’s information request, Ford concluded that a predominant root cause for the intermittent OSS signal loss has not been identified outside of the original safety recall (16V-248). Ford’s investigation also concluded that the primary causes of the defect in MY 2014 F-150 vehicles were related to the molded lead frame and the control assembly transmission main. In the May 2024 response, Ford identified 2,184 total reports that described unintended vehicle transmission downshifting and rear wheel lock-up events; 1,441 warranty claims and 743 reports from consumer complaints, field reports, consumer surveys, and lawsuits/legal claims. Note that the values presented here and in the table above represent the total number of reports which can include a single consumer with multiple reports of the same event as well as a consumer with reports of multiple distinct events. Of the 1,441 warranty claims, 551 warranty claims involved repair of the molded lead frame (38%) and 509 warranty claims involved repair of the control assembly transmission main (35%). Ford has also stated that the PCM programming used to prevent unintended vehicle transmission downshifting was implemented starting with MY 2015 vehicle #1 production and onward. In view of the safety recall action being taken by Ford, ODI is closing this Recall Query (RQ24-005). The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.Read more

PE, Closed , Model Year: 2015

Seatbelt Pretensioner Fire

On June 18, 2018, the Office of Defects Investigations (ODI) opened a Preliminary Evaluation (PE18-008) to investigate complaints alleging post-crash fires at the B pillar in the area of the seat belt pretensioners on MY 2014-2018 Ford F-150 Regular Cab, and Super Crew Cab Vehicles. On August 24, 20... Read more

AQ, Closed , Model Year: 2015

Champion Ford Edinboro / Steering Shaft

NHTSA opened AQ17-001 to determine whether Champion Ford Edinboro, Inc. (Champion Ford), of Edinboro, Pennsylvania, complied with the requirements of the National Traffic and Motor Vehicle Safety Act, 49 U.S.C. Chapter 301 (Safety Act) and its implementing regulations. The Safety Act requires, among... Read more

RQ, Closed , Model Year: 2015

Brake Master Cylinder Failure

On June 8, 2020, Ford Motor Company issued a safety recall (NHTSA Recall No. 20V-332) of 292,311 model year (MY) 2014-2017 Ford F-150 vehicles equipped with 3.5L Ecoboost engines and built from 9/1/2014 to 8/1/2016. Ford stated that the causes of brake fluid loss in the master cylinder are brake flu... id contamination that can interfere with rear cup seal function, and rolling of the rearmost cup seal.Prior to total loss of the front brakes, depending on the amount of brake fluid loss in the master cylinder, the driver may receive an audible chime, message center alert and red brake warning indicator in the instrument cluster, and may experience a change in brake pedal travel and increased pedal effort. It should be noted that a small number of late-built MY 2014 and early-built MY 2017 F-150 vehicles are included in the recall along with the subject vehicles (MY 2015-2016).This Recall Query is closed based on the safety recall issued by Ford. The ODI reports cited above can be viewed at NHTSA.gov under the following ID numbers:10734951 10839988 10862418 10872737 10873438 10876359 10881590 10883442 10885352 10888026 10888524 10891826 10891829 10891886 10893632 10894688 10894844 10896122 10896446 10898079 10899093 10899198 10902944 10903776 10904695 10908281 10910101 10913678 10913867 10914016 10914164 10914288 10914361 10914382 10914483 10914507 10915027 10915894 10916302 10916346 10916578 10920258 10925699 10926076 10926148 10926179 10927388 10927402 10927459 10927578 10928457 10928906 10930128 10936207 10940199 10943902 10948941 10950413 10954419 10956798 10969452 10969971 10984389 10985533 10991033 10993430 10993826 10994249 11000331 11000746 11001283 11001291 11001403 11001550 11002014 11002827 11003801 11004795 11005551 11010248 11010341 11011291 11011502 11012944 11013023 11013826 11014954 11015390 11018677 11018771 11020059 11021249 11021632 11022034 11022116 11022243 11023791 11025448 11030416 11030852 11039991 11082190 11082307 11083373 11083998 11089076 11091017 11092142 11093509 11096406 11096501 11097550 11097885 11099405 11099859 11100723 11101189 11101357 11101515 11101631 11102242 11102281 11102299 11102326 11102360 11102481 11104187 11104212 11104877 11109739 11110958 11111028 11111445 11111776 11112143 11112145 11112331 11112445 11112504 11112969 11112970 11114501 11115336 11115612 11118050 11118324 11119688 11119741 11120003 11120625 11120839 11121496 11122946 11123817 11124180 11124313 11124735 11129689 11129763 11129799 11130736 11131008 11132384 11139389 11139955 11154079 11163050 11183075 11189767 11192325 11193564 11195772 11196715 11205224 11205725 11208030 11208558 11209657 11210390 11217868 11218183 11218476 11218533 11218548 11218703 11218773 11219228 11219556 11220778 11221408 11221528 11221888 11222322 11222604 11222909 11228582 11228780 11229191 11229412 11229541 11229673 11230311 11230525 11230553 11230595 11230606 11230664 11231440 11231744 11231985 11232226 11232462 11233423 11233425 11233557 11233595 11233614 11233857 11233864 11234025 11234577 11234715 11234752 11240161 11240184 11240219 11240344 11241143 11241328 11241565 11241737 11241755 11241979 11242032 11242096 11242101 11242222 11242430 11242723 11243775 11244070 11244092 11244223 11244613 11244872 11245199 11245233 11245259 11245846 11246001 11251825 11252130 11252506 11252570 11252595 11252809 11254026 11254116 11254385 11254816 11255210 11255273 11255487 11256470 11257328 11257549 11258458 11258978 11265268 11267540 11269887 11279423 11281670 11287382 11291824 11297512 11298972 11301103 11306644 11310503 11315450 11316153 11318273 11319339 11319344 11319751Read more

PE, Closed , Model Year: 2013

Master Cylinder External Leak

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and b... uilt at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107Read more

EA, Closed , Model Year: 2011

Brake Vacuum Pump Failure

On February 15, 2016, Ford Motor Company initiated Customer Satisfaction Program 15N05 to extend warranty coverage for the electric vacuum pump in certain model year (MY) 2011 through 2012 Ford F-150 pickup trucks equipped with 3.5L GTDI engines.The program extends coverage for up to 10 years of ser... vice or 150,000 miles from the warranty start date of the vehicle, all vehicles are eligible for the program through July 30, 2016 regardless of mileage.Ford's program covers all repairs related to electric vacuum pump (EVP) malfunctions including excessive noise, vibration, or change in brake pedal feel while applying the brakes at cold start. Ford states that the engine intake manifold is the primary source of vacuum for the brake booster and is fully compliant to motor vehicle safety standards without the supplemental vacuum supplied by the EVP.The company also contends that failure modes related to the EVP are progressive and provide warning to operators by way of noise and vibration before an operator to experience any temporary change in brake pedal feel.ODI's analysis of warranty data found that the majority of claims involved consumer concerns with EVP noise or vibration from the left front fender area when the vehicle is first started. Continued operation in this mode with pump motor noise will eventually result in the EVP seizing or becoming non-functional.Component failure analysis indicated that Ford and its supplier, Continental, identified a pump crank drive corrosion condition due to moisture entry through the vacuum intake.Corrosion damage to EVP internal components may eventually result in a blown fuse in the power distribution box and total loss of EVP function.Analysis of consumer complaints, field reports, and warranty data related to EVP failures found thatincidents predominantly occurred in driveways and parking lots in the periods immediately after cold engine starts.Many consumers operated their vehicle for some period of time with a blown EVP fuse without realizing that the pump had failed or that the vehicle had a brake system malfunction.Consumers who did experience braking performance issues reporteda temporary hard brake pedal condition at start-up followed by more consistent normal pedal feel after few seconds.On June 22, 2015, Ford developed a remedy procedure and issued TSB 15-0105 instructing dealers to replace the vacuum pump and install a new vacuum pump harness kit. In addition to reviewing test data submitted by Ford, ODI assessed safety risks associated with the alleged defect under various operating conditions, including: 1) baseline system performance with full engine and EVP vacuum available using exemplar parts, 2) disabled EVP and booster vacuum regulated to simulate worst case conditions for engine intake manifold vacuum supply to the brake booster (approximately 300 mbar); and 3) all source vacuum to the brake booster removed and Optimized Hydraulic Braking (OHB) mode active to represent complete loss of brake booster function (note: this condition is a more severe brake boost system failure mode than the alleged defect).ODI also analyzed all complaints and warranty claims to identify incidents alleging brake system performance concerns related to EVP failures.These analyses identified no brake performance issues or resulting changes in stopping distances either on highway or city traffic conditions.Two complaints alleging EVP malfunctions caused or contributed to rear-end collisions during attempted decelerations from road speeds are not believed to be related to the alleged defect.The EVP provides supplemental vacuum during initial start-up and idleRead more

PE, Closed , Model Year: 2011

Brake Vacuum Pump Failure

On June 22, 2015, the Office of Defects Investigations (ODI) opened Preliminary Evaluation PE15-026 to investigate incidents of increased brake pedal effort at cold start and extended stopping distance while driving in traffic, resulting from failures of the electric brake vacuum assist pump in mode... l year (MY) 2011-2012 Ford F-150 pickup trucks equipped with 3.5L GTDI engines. In response to ODI's Information Request (IR) for PE15-026, Ford provided ODI with 396 complaints and field reports relating to incidents of increased brake pedal effort or malfunctions in the electric vacuum pump (EVP). ODI's analysis of the data provided by Ford identified 7 crashes and 1,851 warranty claims related to either a hard brake pedal condition or reduced brake effectiveness. Additionally, ODI identified one report in its database alleging an injury to an occupant of a vehicle struck in the rear by a subject F-150 vehicle with a failed EVP as documented in the police accident report referencing a dealer assessment of the pump.According to Ford, the subject vehicles utilize a traditional brake vacuum booster to provide power assist for braking and the EVP is intended to operate to maintain consistent brake pedal feel. The engine intake manifold is the primary source of vacuum for the booster and is fully compliant to motor vehicle safety standards without the EVP. Ford described the conditions related to a change in brake pedal feel as limited and temporary and provided component failure analysis showing evidence of water entry into the EVP which caused internal pump corrosion. Ford indicated that the EVP failure mode is progressive and provides warning to operators by way of noise and vibration before an operator is likely to experience any temporary change in brake pedal feel. Damage to the EVP motor bearing may eventually result in a blown EVP fuse and total loss of EVP function. Ford provided test data showing the brake pedal forces and pedal travel curves over time for 0.3g decelerations to a stop from 80kph (50mph) for: 1) normal system (full engine and EVP vacuum available); 2) Ford's approximation of worst case booster performance with EVP failure (EVP disabled and booster vacuum regulated to 300mbar to simulate cold start, all accessory loads on, and starting at 0 vacuum); and 3) with all source vacuum to the brake booster removed and Hydraulic Boost Compensation (HBC) active to represent complete loss of brake booster function. The Ford tests showed that the brake pedal forces required for achieving the 0.3g decelerations were relatively low for the normal condition, 35-40 N (8-9 lbf), increased by approximately 2-3 times normal when the EVP is disabled, 75-115 N (17-26 lbf), and increased by about 5-6 times normal for the complete brake booster failure condition, 205-215 N (46-48 lbf). This Preliminary Evaluation has been upgraded to Engineering Analysis (EA15-006) to test for EVP malfunctions under other vehicle operating conditions (e.g., low-speed driveway braking after cold-start with failed EVP), potential human factors contributions and to further assess the scope, frequency, and safety-related consequences of the alleged defect.The VOQs associated with the opening of this investigation are:10565994, 10575987, 10598351, 10604687, 10605701, 10607811, 10610491, 10615536, 10617828, 10619545, 10643075, 10650578, 10662151, 10664415, 10666988, 10668069, 10678844, 10695537, 10700874, 10706217, 10706271, 10712465, 10723033, 10723792, 10726960, 10730549, 10730721, 10730735, 10730837, 10730909, 10731008, 10731135, 10731157, 10731165, 10731395, 10731758, 10732609, 10732878, 10733375, 10733804, 10734558, 10734613, 10743859, 10744214, 10Read more

PE, Closed , Model Year: 2011

Reduced power during hard acceleration

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford... for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing ofRead more

EA, Closed , Model Year: 1997

Fuel Tank Strap Failure Due to Corrosion

One or both of the steel straps holding up the fuel tank and attaching it to the truck frame can corrode and fail (break or separate).If one strap fails, the tank may tilt and drop and possibly contact the road surface.If both straps break, the entire tank may drop to the road.If either failure occu... rs while the vehicle is being driven, contact with the road can abrade the tank and create a hole from which gasoline can spill.When the tank drops, it remains attached to the vehicle only by the fuel filler hose and/or supply lines, or in rare instances, by the skid plate, if present.In some cases the weight of the tank sufficiently strained the hoses and fittings and caused separation and subsequent fuel leaks from those connections.The fire hazard created by leaking gasoline is increased by the possible presence of sparks created by the metal tank being dragged along the road.Corrosion of the straps appears to be caused by prolonged exposure to road deicers, frequently road salt, used to treat snow or ice covered roads.States in which large quantities of deicers are applied to roads during the winter season (salt belt states) account for the predominant portion of strap failures.Vehicles in these salt belt states are prone to experience corrosion related failures more frequently and earlier in a vehicle?s life cycle.Ford reports approximately 97 percent of reports it received relating to strap failure involve vehicles that were operated in these high corrosion areas, and 95 percent of the reports to NHTSA involved such vehicles.Approximately one-third of F-150 U.S. production was sold in salt belt states.ODI has included in the above counts reports it has received from consumers and reports it has received from Ford in which either the complaint involved confirmed strap corrosion or ODI's assessment of available information suggests corrosion caused the reported problem.Among the incidents reported to NHTSA, 441 involved one or both straps failing due to corrosion, 353 involved the fuel tank dropping and/or dragging on the ground, and 180 involved fuel leakage.ODI has received four reports of strap failure in which the leaking fuel ignited but self-extinguished, and one incident in which fire destroyed the vehicle and injured its driver.Ford reported the same injury incident and three other unique fire incidents, including two in which the leaking fuel ignited and fire destroyed the vehicle.There were no injuries associated with the three unique Ford incidents.Ford has agreed to conduct a recall to repair the subject vehicles.The recall will cover vehicles that were originally sold or are currently registered in salt belt states (regardless of vehicle age).The vehiclesincluded in the recall are those subject vehicles that are, or have ever been, registered in Connecticut, Delaware, Iowa, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, or the District of Columbia.Ford's recall action appears to adequately address the problem at this time.The above vehicle population (1,340,349) includes subject vehicles originally delivered or sold in salt belt states.ODI does not know the current or historical locations of all subject vehicles.According to Ford approximately 73% of the recall population is currently registered (a 27% attrition rate).Ford is also recalling certain MY 1997-1999 F-250 vehicles (under 8,500 GVWR), and MY2002-2003 Lincoln Blackwood vehicles for the same condition, resulting in an estimated 1.1 million total vehiclesRead more

PE, Closed , Model Year: 1997

Fuel Tank Strap Corrosion/Rust

One or both of the steel straps holding up the fuel tank and attaching it to the truck frame can corrode and break.If one strap breaks, the tank may tilt and drop and possibly contact the road surface.If both straps break, the entire tank may drop to the road.If either failure occurs while the vehic... Read more

EA, Closed , Model Year: 2004

Inadvertent airbag deployment

ODI opened this investigation based on reports of inadvertent airbag deployment.Data provided by Ford indicated that the airbag clockspring jumper wire, which is situated inside the steering wheel assembly, was installed in a manner that would allow it to rub (abrade) against a sharp metal edge on t... Read more

PE, Closed , Model Year: 2005

INADVERTENT AIRBAG DEPLOYMENT

FORD REPORTS THAT THE INADVERTENT AIRBAG DEPLOYMENTS ARE MOST LIKELY CAUSED BY THE AIRBAG HORN MOUNTING PLATE'S SHARP METAL EDGE THAT EVENTUALLY CAN CHAFE/CUT THE AIRBAG CLOCKSPRING JUMPER WIRE LEADING TO A SHORT-TO-GROUND CONDITION.ONE HUNDRED EIGHTY TWO (182) OF THE 230 REPORTS WERE FOR AIRBAG DEP... Read more

PE, Closed , Model Year: 2003

CNG REGULATOR LEAK

THE AGENCY HAS CLOSED THIS INVESTIGATION BASED ON ITS REVIEW OF COMPLAINT REPORTS, DISCUSSIONS WITH COMPLAINANTS AND FIELD AND TECHNICAL DATA PROVIDED BY FORD.THE SUBJECT VEHICLES ARE 1/2 TON PICKUP TRUCKS AND ARE NATURAL GAS VEHICLES (NGV) THAT ARE FUELED BY GASOLINE OR COMPRESSED NATURAL GAS.THE A... Read more

PE, Closed , Model Year: 2005

LOSS OF BRAKE POWER-ASSIST

BY LETTER DATED MAY 5, 2008, FORD MOTOR COMPANY (FORD) NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-208) TO ADDRESS A MANUFACTURING DEFECT IN APPROXIMATELY 605,684 MODEL YEAR (MY) 2005 AND 2006 FORD F-150 AND LINCOLN MARK LT VEHICLES ORIGINALLY EQUIPPED WITH THE ... 5.4L DISPLACEMENT, 3-VALVE PER CYLINDER, V-8 ENGINE.THE RECALLED VEHICLES WERE BUILT FROM JULY 18, 2004 THROUGH MAY 31, 2006 AT THE DEARBORN TRUCK PLANT; FROM MAY 4, 2004 THROUGH MAY 31, 2006 AT THE KANSAS CITY ASSEMBLY PLANT; AND FROM APRIL 19, 2004 THROUGH MAY 31, 2006 AT THE NORFOLK TRUCK PLANT.THE VEHICLES WERE MANUFACTURED WITH THE SAME DEFECTIVE BRAKE BOOSTER VACUUM SUPPLY HOSE ASSEMBLY UNIQUE TO THE 5.4L V-8 ENGINE.FORD F-150 VEHICLES EQUIPPED WITH OPTIONALLY AVAILABLE 4.2L V6 AND 4.6L V-8 ENGINES ARE NOT INCLUDED IN THIS RECALL ACTION BECAUSE THEY UTILIZE A DIFFERENT, ONE-PIECE BRAKE BOOSTER VACUUM SUPPLY HOSE ASSEMBLY THAT DOES NOT EXHIBIT AN APPARENT DEFECT TREND. THE RECALLED VEHICLES UTILIZE A TWO-PIECE BRAKE BOOSTER VACUUM SUPPLY HOSE ASSEMBLY COMPRISED OF A STANDPIPE ASSEMBLY AND VACUUM HOSE.THE STANDPIPE ASSEMBLY ATTACHES TO A FITTING ON THE ENGINE AIR INTAKE MANIFOLD UTILIZING A FLEXIBLE RUBBER HOSE AND PLASTIC ELBOW.THE VACUUM HOSE ATTACHES TO THE OPPOSITE END OF THE STANDPIPE ASSEMBLY AND CONNECTS TO A CHECK VALVE FITTING AT THE BRAKE BOOSTER ASSEMBLY.ACCORDING TO FORD, THE PORTION OF THE BRAKE BOOSTER VACUUM SUPPLY HOSE ASSEMBLY ATTACHED TO THE INTAKE MANIFOLD MAY SWELL OVER TIME AND LOSE RETENTION FORCE, WHICH MAY ALLOW THE HOSE TO BECOME DETACHED FROM THE INTAKE MANIFOLD.SHOULD THE BRAKE BOOSTER VACUUM SUPPLY HOSE ASSEMBLY BE DISRUPTED, APPLICATION OF THE BRAKE PEDAL MAY DEPLETE THE VACUUM RESERVE AND CONSEQUENTLY RESULT IN LOSS OF BRAKE POWER-ASSIST. TO CORRECT THE SAFETY DEFECT, FORD WILL INSTALL AN IMPROVED DESIGN BRAKE BOOSTER VACUUM SUPPLY HOSE ASSEMBLY THAT UTILIZES A HOSE CLAMP AT THE INTAKE MANIFOLD ATTACHMENT. THIS REMEDY WILL BE PROVIDED FREE OF CHARGE FOR ALL RECALLED VEHICLES.LATER PRODUCTION FORD F-150 AND LINCOLN MARK LT VEHICLES BUILT AFTER MAY 2006 WERE MANUFACTURED WITH A HOSE CLAMP AT THE BRAKE BOOSTER VACUUM SUPPLY HOSE/INTAKE MANIFOLD ATTACHMENT AND ARE NOT AFFECTED. TO DATE, THE OFFICE OF DEFECTS INVESTIGATION (ODI) IS AWARE OF 324 NON-DUPLICATIVE COMPLAINTS AND 14 NON-INJURY CRASHES RELATED TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF 4,465 SUBJECT VEHICLES THAT EXPERIENCED ONE OR MORE WARRANTY CLAIMS TO REPAIR OR REPLACE THE SUBJECT BRAKE BOOSTER VACUUM SUPPLY HOSE ASSEMBLY. THE ACTION TAKEN BY FORD IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.Read more

PE, Closed , Model Year: 1997

STEERING COLUMN

PE, Closed , Model Year: 1998

SPARE TIRE WEAR

DP, Closed , Model Year: 1998

SPARE TIRE MOUNTING

THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION WAS PETITIONED TO COMMENCE A DEFECT INVESTIGATION OF THE SUBJECT VEHICLES BY A LETTER SIGNED BY WILLIAM F. ALLARD AND DATED 15-FEB-98.THE PETITION ALLEGES THAT THE SPARE TIRE MOUNTING PLACES THE TIRE SIDEWALL DIRECTLY IN CONTACT WITH THE METAL UNDER... Read more

RQ, Open , Model Year: 1997

REAR SUSPENSION SPRING BREAKAGE

IN JULY 1998, FORD SUBMITTED A PART 573 NOTIFICATION TO NHTSA CONCERNING BROKEN REAR SPRINGS ON CERTAIN 1997-98 FORD F150 TRUCKS, WITH FOUR-WHEEL DRIVE.FORD STATED THAT FATIGUE FRACTURE OF THE REAR SPRINGS MAY OCCUR IF THE SPRING ARE OVER STRESSES(SIC) BY VEHICLE OVERLOADING.THE BROKEN PIECE OF THE ... Read more

EA, Closed , Model Year: 1997

ALLEGED LOSS OF THROTTLE CONTROL

THE DETAILS OF INFORMATION AND DATA EVALUATED DURING THIS INVESTIGATION ARE STATED IN THE ENGINEERING ANALYSIS CLOSING REPORT, DATED SEPTEMBER 30, 1999.A SAFETY-RELATED DEFECT TREND RESULTING FROM INTERFERENCE BY THE FLOOR MAT WITH PROPER OPERATION OF THE THROTTLE IN THE SUBJECT VEHICLES WAS NOT IDE... Read more

PE, Closed , Model Year: 1997

LOSS OF THROTTLE CONTROL

There is no summary currently available

RQ, Closed , Model Year: 1994

INADVERTENT AIR BAG DEPLOYMENT

There is no summary currently available

RQ, Closed , Model Year: 1997

AUTOMATIC TRANSMISSION CONTROL

ON SEPTEMBER 4, 1997, FORD FILED A DEFECT INFORMATION REPORT CONCERNING APPROXIMATELY 15,000 1997 MODEL YEAR F-150 TRUCKS, MANUFACTURED FROM FEBRUARY 16 THROUGH MARCH 4, 1996, AND BUILT AT THE NORFOLK OR KANSAS CITY ASSEMBLY PLANTS.THESE VEHICLES COULD HAVE INCORRECTLY MANUFACTURED AUTOMATIC TRANSMI... Read more

RQ, Closed , Model Year: 1997

ICE FORMATION IN THE THROTTLE BODY

There is no summary currently available

EA, Closed , Model Year: 1997

WHEEL SEPARATION

BY LETTER DATED MAY 6, 1998, THE MANUFACTURER ADVISED NHTSA OF ITS DECISION TO INITIATE A SAFETY RECALL OF APPROXIMATELY 1,520,000 OF THE SUBJECT VEHICLES, INCLUDING F-250 LIGHT DUTY TRUCKS, AND NAVIGATOR VEHICLES BUILT AT THE NORFOLK, MICHIGAN TRUCK, KANSAS CITY, AND ONTARIO TRUCK ASSEMBLY PLANTS B... Read more

PE, Closed , Model Year: 1997

WHEEL SEPARATION FROM VEHICLE

IN ADDITION TO THE A FAILURE REPORT TABULATIONS GIVEN ABOVE, THE MANUFACTURER REPORTED THAT AN ADDITIONAL 33 OWNER AND FIELD REPORTS HAVE BEEN FILED WHICH REFER TO PROBLEMS (LUG NOT TORQUE LOSS, LUG BOLT FRACTURE) THAT DID NOT INVOLVE ACTUAL WHEEL SEPARATION, BUT WHICH MAY BE POTENTIALLY RELEVANT EV... Read more

PE, Closed , Model Year: 1997

FAILURE TRANSMISSION PARK ENGAGEMENT/LOC

BY LETTER DATED SEPTEMBER 4, 1997, THE MANUFACTURER ADVISED NHTSA THAT A SAFETY-RELATED RECALL ACTION WOULD BE INITIATED TO CORRECT A POTENTIAL FAILURE OF THE TRANSMISSION SHIFT CABLE IN APPROXIMATELY 15,000 OF THE SUBJECT VEHICLES.THE SUSPECT CABLES WERE SUPPLIED TO FORD BY TELEFLEX AUTOMOTIVE AND ... Read more

EA, Closed , Model Year: 1997

SEAT BELT ANCHORAGE SEPARATION

FORD NOTIFIED ODI THAT THEY ARE CONDUCTING A RECALL TO INSPECT AND, AS NECESSARY, REPAIR THE SEAT BELT ANCHORAGE ATTACHMENTS ON 1997 FORD F150 VEHICLES BUILT FROM THE BEGINNING OF PRODUCTION THROUGH APRIL OF 1996.ODI'S DATABASE CONTAINS ONE COMPLAINT ALLEGING THE CENTER FRONT SEAT BELT ANCHORAGE WAS... Read more

PE, Closed , Model Year: 1997

SEAT BELT ANCHORAGE SEPARATION

ODI'S DATABASE CONTAINS ONE COMPLAINT ALLEGING THE CENTER FRONT SEAT BELT ANCHORAGE WAS NOT BOLTED TO THE FLOOR.FORD SUBMITTED 28 ADDITIONAL FIELD REPORTS AND WARRANT CLAIMS ALLEGING THAT A SEAT BELT WAS NOT BOLTED TO THE FLOOR, NOT ATTACHED, NOT HOOKED UP, OR THE OWNER COMPLAINTED THAT THE SEAT BEL... Read more

FORD F-150 - All Years Overview

Complete safety history for the FORD F-150 across all model years (1991, 2026).

419 Total Recalls

47,330 Total Complaints

30 Investigations

2,343 Reported Crashes

2,348 Reported Fires

87 Reported Deaths

FORD F-150 - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2026	1	3	View
2025	12	167	View
2024	10	257	View
2023	11	564	View
2022	22	775	View
2021	28	1,256	View
2020	11	859	View
2019	9	1,647	View
2018	19	2,778	View
2017	18	1,749	View
2016	14	2,508	View
2015	14	2,150	View
2014	8	1,905	View
2013	3	3,930	View
2012	4	2,434	View
2011	6	2,966	View
2010	1	1,134	View
2009	2	400	View
2008	1	455	View
2007	7	623	View
2006	14	741	View
2005	14	1,364	View
2004	16	2,431	View
2003	11	523	View
2002	10	964	View
2001	19	1,451	View
2000	17	1,274	View
1999	18	1,323	View
1998	18	1,624	View
1997	26	3,285	View
1996	7	383	View
1995 (current)	7	788
1994	13	908	View
1993	13	753	View
1992	9	553	View
1991	6	357	View
1990	0	25	View
1989	0	19	View
1987	0	2	View
1984	0	2	View

Other FORD Models

Model	Recalls	Complaints
MUSTANG	1,104	11,600	View
RANGER	928	10,371	View
F-350 SD	776	2,363	View
F-450 SD	692	624	View
F-250 SD	638	3,635	View
EXPLORER	624	42,549	View
F-550 SD	578	603	View
EXPEDITION	555	11,534	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

1995 FORD F-150

Complaint Statistics

Top Reported Components

Technical Service Bulletins, 1995 FORD F-150

Most Affected Components

NHTSA Safety Investigations, FORD F-150

FORD F-150 - All Years Overview

FORD F-150 - Year by Year

Other FORD Models