2016 FORD F-150

14 recalls, 2,581 complaints - 434 TSBs

POWER TRAIN:AUTOMATIC TRANSMISSION

Defect Description

Ford Motor Company (Ford) is recalling certain 2015-2017 F-150 vehicles. A loss of signal between the transmission range sensor and the powertrain control module can cause the transmission to unexpectedly downshift into second gear.

Consequence

Unexpectedly downshifting into second gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy

Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed July 24, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S28. Vehicle Identification Numbers (VINs) involved in this recall became s... Read more

1,392,935 vehicles affected

Manufacturer: Ford Motor Company

SERVICE BRAKES, HYDRAULIC:POWER ASSIST

Defect Description

Ford Motor Company (Ford) is recalling certain 2016-2017 Ford Expedition, Lincoln Navigator, and 2016-2018 F-150 vehicles equipped with 3.5L Ecoboost engines. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.

Consequence

A loss of brake fluid may result in a change in brake pedal travel, increased pedal effort and reduced front brake function, requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.

Remedy

Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. An interim owner notification letter notifying customers of the safety defect were mailed on April 29, 2022. Owner notification le... Read more

195,864 vehicles affected

Manufacturer: Ford Motor Company

SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT

Defect Description

Tenneco Automotive (DRiV) is recalling certain MOOG K500359 ball joints, for aftermarket installation on 2015-2018 Ford F-150 trucks. The ball joint may have a misaligned dust boot and may be missing alignment hole and installation warning tag, which may lead to improper alignment of the ball joint... Read more

Consequence

An incorrectly installed ball joint may cause the ball joint stud to break, which can compromise front wheel control, increasing the risk of a crash.

Remedy

DRiV will notify owners, and dealers will inspect, and if necessary replace the ball joint, free of charge. Owner letters were mailed May 5, 2021. Owners may contact Tenneco Automotive customer service at 1-877-489-6659.

2,394 vehicles affected

Manufacturer: Tenneco Automotive

SERVICE BRAKES, HYDRAULIC:POWER ASSIST

Defect Description

Ford Motor Company (Ford) is recalling certain 2014-2017 F-150 pickup trucks equipped with 3.5L Ecoboost engines. The brake master cylinder may leak brake fluid into the brake booster.

Consequence

A loss of brake fluid may result in a change in brake pedal travel and feel, increased pedal effort and reduced front brake function, possibly requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.

Remedy

Ford will notify owners, and dealers will replace the brake master cylinder and inspect the brake booster, replacing it as necessary, free of charge. Ford issued owners an interim notification on June 30, 2020. The recall began on October 28, 2020. Owners may contact Ford customer service at 1-86... Read more

292,311 vehicles affected

Manufacturer: Ford Motor Company

EQUIPMENT:ELECTRICAL

Defect Description

Ford Motor Company (Ford) is recalling certain 2015-2016 F-150 pick-up trucks equipped with 3.5L GTDI engines and block immersion heaters that were potentially relocated from their originally installed location. The incorrect location could put the heater too close to hot engine components, possibl... Read more

Consequence

A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.

Remedy

Ford will notify owners, and dealers will inspect the block heater's location and its cable, replacing components as necessary, free of charge. If the replacement parts are not available, dealers will disable the existing block heater cable from being used until parts become available. The recall ... Read more

13,854 vehicles affected

Manufacturer: Ford Motor Company

EQUIPMENT:ELECTRICAL

Defect Description

Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block h... Read more

Consequence

A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.

Remedy

Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford custome... Read more

131,068 vehicles affected

Manufacturer: Ford Motor Company

ENGINE

Defect Description

Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater. Water and contaminants may get into the block heater cable's splice connector causi... Read more

Consequence

When the heater is plugged in, prolonged corrosion could cause a resistive short, increasing the risk of overheated or melted wiring which can increase the risk of a fire.

Remedy

Ford will notify owners, and dealers will disable the block heater cable, free of charge. Once parts are available, Dealers will replace the engine block heater cable, free of charge. The recall began June 3, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for thi... Read more

410,289 vehicles affected

Manufacturer: Ford Motor Company

STRUCTURE:BODY:ROOF AND PILLARS

Defect Description

Ford Motor Company (Ford) is recalling certain 2015-2018 Ford F-150 Regular Cab and SuperCrew Cab vehicles. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.

Consequence

A vehicle fire could result if materials ignite inside the vehicle.

Remedy

Ford will notify owners, and dealers will remove the B-pillar insulation material and wiring harness tape, and install heat resistant tape, free of charge. The recall began September 28, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S27.

1,619,112 vehicles affected

Manufacturer: Ford Motor Company

SEATS

Defect Description

Ford Motor Company (Ford) is recalling certain 2016 F-150 and Explorer vehicles. Loose power seat adjuster pivot bolts may cause the front seat cushions to detach and not properly restrain the seat occupant in the event of a crash.

Consequence

In the event of a crash, a seat occupant that is not properly restrained has an increased risk of injury.

Remedy

Ford will notify owners, and dealers will inspect the tightness of the power seat track upper pivot link bolt, either applying threadlocker or replacing the lift link and hardware, free of charge. Interim letters are expected to go out January 15, 2018. Owners will receive a second notice when the... Read more

177,264 vehicles affected

Manufacturer: Ford Motor Company

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Defect Description

Ford Motor Company (Ford) is recalling certain 2015-2017 Ford F-150, and 2017 F-250, F-350, F-450, and F-550 Super Duty trucks. The doors on these vehicles may have a bent or kinked actuation cable or the door latches may freeze after water gets into the latch. Either condition can result in the d... Read more

Consequence

A door that opens while driving can increase the risk of injury.

Remedy

Ford will notify owners, and dealers will inspect the door latch actuation cables and repair if necessary, and install water shields over the door latches, free of charge. The recall began October 12, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall ... Read more

1,101,107 vehicles affected

Manufacturer: Ford Motor Company

SEAT BELTS:REAR/OTHER

Defect Description

Ford Motor Company (Ford) is recalling certain 2015-2017 F-150, and 2017 F-250 and F-350 trucks equipped with a crew cab. The left rear inflatable seat belt buckle assembly may be inadequately attached to its mounting bracket. As such, these vehicles fail to comply with the requirements of Federal... Read more

Consequence

If the left rear inflatable seat belt buckle separates from it's mounting bracket, the seat occupant may not be adequately restrained, increasing their risk of injury.

Remedy

Ford will notify owners, and dealers will inspect the seat belt assembly, replacing the attaching rivet as necessary, free of charge. Interim notices informing owners of the safety risk were mailed October 18, 2017. Owners will receive a second notice when the remedy becomes available. Owners may... Read more

117,423 vehicles affected

Manufacturer: Ford Motor Company

STRUCTURE:BODY:DOOR

Defect Description

Ford Motor Company (Ford) is recalling certain 2015-2017 F-150, and 2017 F-250, F-350, F-450, and F-550 vehicles originally produced with black or body colored exterior door handles that may have been subsequently equipped with a chrome exterior door handle cover accessory kit purchased from a Ford ... Read more

Consequence

If the doors unlatch and open in a side impact collision, the occupants have an increased risk of injury.

Remedy

Ford will notify owners, and dealers will remove the accessory covers and refund the purchase price. The recall began July 13, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for the recall is 17C09.

14,410 vehicles affected

Manufacturer: Ford Motor Company

SEATS:FRONT ASSEMBLY:RECLINER

Defect Description

Ford Motor Company (Ford) is recalling certain model year 2016 Ford Explorer and F-150 vehicles equipped with a manual recline driver's seat. The seat back frame may have insufficient welds which may not meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restr... Read more

Consequence

The seat back may not adequately restrain the occupant during a crash, increasing the risk of injury.

Remedy

Ford will notify owners, and dealers will inspect and, if necessary, replace the seat back frame, free of charge. The recall begin on August 18, 2016. Owners may contact Ford at 1-800-392-3673. Ford's number for this recall is 16C11.

5,280 vehicles affected

Manufacturer: Ford Motor Company

AIR BAGS:SENSOR:OCCUPANT CLASSIFICATION

Defect Description

Ford Motor Company (Ford) is recalling certain model year 2016 F-150 trucks manufactured April 27, 2015, to November 22, 2015, and equipped with Multi-Contour Seats (MCS). The front passenger seat Occupant Classification System (OCS) that calibrates the air bag deployment level may incorrectly clas... Read more

Consequence

If an adult is incorrectly classified as a child, the passenger frontal air bag will not deploy during a crash, increasing the risk of injury.

Remedy

Ford will notify owners, and dealers will update the Occupant Classification System Module (OCSM) with new software, free of charge. The recall began on March 11, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S05.

2,894 vehicles affected

Manufacturer: Ford Motor Company

Complaint Statistics

2,581 total complaints 102 crashes 45 fires 97 injuries

Top Reported Components

Component	Complaints
SERVICE BRAKES	335
ENGINE	327
UNKNOWN OR OTHER	269
POWER TRAIN	268
ELECTRICAL SYSTEM	236
STRUCTURE:BODY	190
FUEL/PROPULSION SYSTEM	106
STEERING	101
VISIBILITY/WIPER	97
VEHICLE SPEED CONTROL	79

Incident date: Aug 15, 2026

The contact owns a 2016 Ford F-150. The contact stated that while attempting to depress the horn pad on the steering wheel, the horn failed to provide an audible sound as intended. The air bag warning light illuminated. The vehicle was taken to a local dealer where it was diagnosed and determined th... Read more

Incident date: Sep 8, 2026

The contact owns a 2016 Ford F-150. The contact stated that while driving 70 MPH, the transmission unexpectedly downshifted to 3rd gear. The contact received notification of NHTSA Campaign Number: 26V237000 (Power Train); however, the dealer and manufacturer stated that the VIN was not included in t... Read more

Incident date: May 21, 2026

In April of this year my 2016 F150 began having issues related to the automatic transmission. Symptoms included unexpected and irregular downshifting from 6th gear into 4th gear while traveling on the highway, random and irregular shifting from gear to gear, and not gearing down below 3rd gear when ... Read more

Incident date: Aug 24, 2026

The contact owns a 2016 Ford F-150. The contact received an unknown recall notification. The dealer was contacted by phone and scheduled an appointment for a technician to pick up the vehicle. The technician drove the vehicle to the dealer. The unknown recall repair was completed. The contact receiv... Read more

Incident date: Aug 26, 2026

The contact owns a 2016 Ford F-150. The contact stated that the vehicle was repaired under an undisclosed recall; however, the recall repair failed to prevent a failure. The contact stated that while driving at an undisclosed speed, the vehicle hesitated while upshifting or downshifting between 4th ... Read more

Incident date: Aug 26, 2026

The contact owns a 2016 Ford F-150. The contact stated that vehicle was taken to the local dealer for a recall repair associated with the PCM reprogramming. Upon retrieval, the vehicle went into LIMP Mode while driving. The contact stated that while driving at an undisclosed speed, the transmission... Read more

Incident date: Aug 26, 2026

Incident date: Sep 2, 2026

I would like to file complaint against Ford for their latest recall (26N041) and how they are not doing replacing the defective Lead Frame in customers vehicles. It's a big scam and a waste of time. I brought my 2016 Ford F-150 in for Ford’s latest recall (26N04) affecting 2015–2017 models due... Read more

Incident date: Sep 2, 2026

Incident date: Apr 4, 2026

Truck downshifts into low gear, yellow wrench and engine light come on and the truck goes into limp mode, no warnings or anything. These symptoms first started about 5 months ago and I have stopped driving the truck for that time. I took it to the dealer after looking it up and seeing there was a re... Read more

Incident date: Jun 16, 2026

XXX, my Ford F-150 began experiencing serious and unpredictable transmission shifting problems. The truck would downshift unexpectedly while traveling at various speeds. At times, it would not downshift properly when coming to a complete stop, and it would sometimes shift back up into third gear fro... Read more

Incident date: Apr 15, 2026

The contact owns a 2016 Ford F-150. The contact stated that while driving at approximately 30 MPH, the vehicle hesitated to maintain acceleration while the accelerator pedal was depressed, which caused the vehicle to jerk forward into the rear bumper of another vehicle in traffic. The front bumper s... Read more

Crash

Incident date: Aug 21, 2026

On August 21, 2026, my 2016 Ford F-150 was serviced at Five Star Ford to perform safety recall 26S28 (Powertrain Control Module software update). Immediately following this software flash, the transmission's shifting logic became severely corrupted and unsafe to drive. The vehicle currently acts as ... Read more

Incident date: Jul 27, 2026

The contact owns a 2016 Ford F-150. The contact had received notification of NHTSA Campaign Number : 26V237000 (POWER TRAIN) and the vehicle was taken to a local dealer where it was remedied. The contact contact continued to drive the vehicle when the failure occurred while driving at 60 MPH the tra... Read more

Incident date: Aug 19, 2026

The contact owns a 2016 Ford F-150. The contact stated that the vehicle was taken to a dealer to be serviced under NHTSA Campaign Number: 26V237000 (Power Train). The vehicle was not experiencing any failure prior to the recall repair; however, after the recall repair was completed, the transmission... Read more

Incident date: Aug 15, 2026

Vehicle transmission downshift to a lower gear while traveling at city and highway speeds without any prior warning or driver input. Diagnostic showed codes P0715 and P0717. The following day we received notification from Ford of the recall "Transmission molded leadframe replacement" (Campaign 26N04... Read more

Incident date: Jan 16, 2025

"While operating my 2016 Ford F-150, the vehicle lost power-steering assist. Ray Skillman Ford diagnosed an internal failure of the power steering control module and replaced the steering gear assembly. The vehicle had approximately 94,620 miles. Sudden loss of steering assist significantly increase... Read more

Incident date: Mar 23, 2026

The contact owns a 2016 Ford F-150. The contact stated that while operating the vehicle, the vehicle lunged forward. Additionally, while attempting to slow down to stop the vehicle, the transmission unexpectedly downshifted while driving. The vehicle was taken to the local dealer and serviced under ... Read more

Incident date: Jul 24, 2026

My truck at 45 mph suddenly downshifted to first gear. It locked my tires causing me to fish tail. Luckily I lost control beside a shoulder and not into a ditch or another vehicle. I was near my home and turned onto a country road and was able to drive 20 mph or less to get it home. It is due to a r... Read more

Incident date: Aug 19, 2026

This vehicle 2016 ford F150 is known to have shorting issues. From literally all wiring harnesses. I had a small fire in my truck due to this issue, caused melting of the ribbon cable in my seat heater control module, which is a known issue from Ford. I have shorting in my turn signal switch (no wip... Read more

Fire

Incident date: Aug 19, 2026

Fire

Incident date: Jul 22, 2026

I made an appointment for July 22,2026 with Purvis Ford in Fredericksburg to have the 28S26 recall for a transmission issue outlined in the recall. The process was estimated to be 4-6 hours. Purvis Ford called said the software upgrade was completed and i could get my truck. The truck would not s... Read more

Incident date: Aug 19, 2026

Fire

Incident date: Aug 12, 2026

Ford Motor sent notice 26s28 to me regarding a possible problem with my transmission/powertrain. On August 12 they reprogrammed my Powertrain Control Module. In the letter regarding this upgrade they also stated, and I quote: " If your dashboard displays a Malfunction Indicator Lamp(MIL)or Powertrai... Read more

Incident date: Aug 8, 2026

The contact owns a 2016 Ford F-150. The contact stated that the vehicle was repaired under NHTSA Campaign Number: 26V237000 (Power Train); but the failure occurred. The dealer was contacted and stated that there was no result on the diagnostic test associated with the transmission failure, and the r... Read more

Incident date: Apr 8, 2026

The contact owns a 2016 Ford F-150. The contact stated that while driving at an undisclosed speed, the transmission unexpectedly downshifted. The powertrain warning light illuminated; however, the warning light was intermittent. The vehicle was taken to the dealer where the contact was informed of a... Read more

Incident date: Feb 1, 2023

Constant "rumble strip" noise and vibration while driving. I have spoken to many F150 owners and they are experiencing same problem

Incident date: Oct 6, 2025

On XXX, I took my truck to Wynn Odom Ford, [XXX]. The concern was the wrench light comes on at times. The correction according to the dealer is PO722 pass replaced lead frame to valve body. The total payment I had to pay out of pocket was $1,875.73. In XXX I received a letter from Ford Motor C... Read more

Incident date: Jul 21, 2026

The contact owns a 2016 Ford F-150. The contact stated that while driving 60 MPH, the vehicle lost automotive power. The contact stated that several unknown warning lights were illuminated. The vehicle was towed to a local dealer and was repaired under NHTSA Campaign Number: 26V237000 (POWER TRAIN).... Read more

Incident date: Jun 1, 2026

The faulty panoramic sunroof is a known issue by Ford Motor Company. Yet they have done nothing to resolve it. The panoramic sunroof on the 2016 Ford F-150 is known to develop operational and structural problems, including sticking, binding, excessive wind noise, water leaks, and failure of the glas... Read more

Incident date: Aug 4, 2026

The contact owns a 2016 Ford F-150. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 26V237000 (Power Train); however, the failure occurred after the recall repair. While driving at an undisclosed speed, the accelerator pedal was depressed, but the vehicle hes... Read more

Incident date: Jul 28, 2026

Was involved in a head on collision involving 2 cars; one which was hit in the front driver wheel panel and the other was directly head on and the air bags did not deploy. Resulting in major seatbelt bruising and knee injury.

Crash 1 injured

Incident date: Aug 8, 2026

Push on accelerator truck barely would go, shifted hard, codes check engine lights flashing, engine sounded bad

Incident date: Feb 20, 2026

Vehicle caused a SEVERE drivability condition while at highway speeds by sputtering, losing power and auxiliary driver's systems becoming degraded. We were able to drive the vehicle in limp mode to a near service station. They ran diagnostics and determined that there were multiple secondary events ... Read more

Incident date: Feb 20, 2026

Excessive oil consumption. I lose 3 qt of oil every 1200 miles. I have had the required maintenance on the car and still having excessive oil consumption.

Incident date: Feb 20, 2026

Incident date: Aug 10, 2026

Twice within 3 days the car drove when was in electronic park. FIRST August 1 2026 instance got in car parked in a lot. Started it (foot on brake, push start). Spent ≈ 15 min checking iPad. When car in front of me backed out of parking space, car dinged, lit up that car in front is leaving like ... Read more

Crash

Incident date: Aug 10, 2026

Crash

Incident date: Aug 10, 2026

CONTEMPORANEOUS NOTE 2024 ACURA ZDX – AWD - NHTSA Recall No. 26V306000 Date: XXX Time: 12:25 PM On XXX at approximately 12:25 PM, I contacted Miami Acura Service at [XXX] to schedule the recently issued rear-view camera safety recall 26V306000 for my 2024 Acura ZDX. I was advised by the dealership... Read more

Incident date: Jul 20, 2026

The car has a blown head gasket at 72k miles the odometer. This seems to be a major problem with 2018-2022 honda accords with the 1.5 turbo engine. it also has a bad fuel pump.

Incident date: Nov 1, 2020

The contact owns a 2015 Dodge Dart. The contact stated that while the vehicle was parked, the gear shifter was shifted to neutral(N); however, the transmission failed to shift as intended. The contact inspected under the hood of the vehicle and became aware that the transmission shifter cable had de... Read more

Incident date: Feb 6, 2026

Component/system that failed: The audio/infotainment system (radio), rear DVD entertainment system, and backup camera all fail together while driving. The vehicle is available for inspection upon request. Description of the problem: While driving, the radio works normally for approximately 10-30 mi... Read more

Incident date: Feb 6, 2026

Incident date: Aug 6, 2025

The dashboard (instrument panel) on this 2012 Lexus IS 250 has degraded and deteriorated, developing a shiny, reflective surface. In daylight and bright conditions, this degraded surface reflects onto the windshield and produces a significant glare that obstructs the driver's view of the road. The g... Read more

Incident date: Aug 5, 2026

When I put my 2013 Ford edge in reverse the backup camera goes out for about 5 to 10 seconds or it just doesn’t work at all. And also I just paid $672 to have the drivers side door latch replaced because the recall had expired in November of 2025 the door ajar light would stay on and the dash woul... Read more

Incident date: Mar 6, 2026

Recall on parts not available tried several times to get appointment no parts. This I and 1 car family must use daily to work and and cannot get fixed per dealership no parts available 2+ years or so. Need help for this severe issue as a consumer. Who is responsible if collision or death from this.

Incident date: Aug 5, 2026

Vehicle total power loss while driving on the freeway, UNKNOWN cause. Vehicle will not turn off or turn on, shift gear locked. Seem to be a system communication between battery, transmission, ecu. Major safety risk while driving on the 3rd lane on the freeway driving 65mph with other vehicles aroun... Read more

Incident date: May 10, 2026

On XXX, while driving on Interstate XXX with my family near [XXX], the engine shut off and the vehicle lost all power. The event was preceded by a "Reduced Power" error displayed on the dashboard. Traffic was moderate and I was able to pull over to the right shoulder. The engine shutting off while o... Read more

Incident date: Apr 4, 2026

Backup camera only works sometimes which is a safety risk when backing up. Other year models have had a recall for this same reason. It has been doing it for at least 6 months now.

Incident date: Jun 15, 2024

Electronic Throttle Control warning light comes on upon starting vehicle while extended crank occurs. When starting car, the push to start feature will not turn over and continuously cranks multiple times. Issue is intermittent- never know when it will happen which makes it difficult to replicate at... Read more

Showing 50 of 2,581 complaints.

Technical Service Bulletins, 2016 FORD F-150

434 manufacturer communications from 258 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
350000 EQUIPMENT	67
110000 ELECTRICAL SYSTEM	58
060000 ENGINE AND ENGINE COOLING	34
060000 ENGINE (PWS)	18
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER	18
160000 STRUCTURE	18
100000 POWER TRAIN	13
356000 EQUIPMENT ADAPTIVE/MOBILITY	12

350000 EQUIPMENT

All accessory stick-on keyless entry keypads come with a wallet card containing the master code. If the accessory keypad was factory installed, this card will be placed in the glove box and should be handed to the vehicles owner during ini

060000 ENGINE AND ENGINE COOLING

This article supersedes TSB 23-2330 to update the Parts List. Some 2015-2017 F-150 vehicles equipped with a 2.7L EcoBoost engine may exhibit an oil leak from the oil pan RTV seal. This may be due to various concerns with the oil pan. To cor

060000 ENGINE AND ENGINE COOLING

Some 2011-2024 Mustang and F-150 vehicles equipped with a 5.0L engine may exhibit a tick tap and/or typewriter ticking noise at idle after an engine oil change. It is often referred to as typewriter noise because of its similarity to the so

060000 ENGINE AND ENGINE COOLING

For 2015-2024 Ford and Lincoln vehicles equipped with turbocharged engines and customer concern of an engine oil leak, refer to Workshop Manual (WSM), Section 303-00 for oil leak inspection and testing methods. Ford has evaluated turbocharg

100000 POWER TRAIN

During service and repair requiring removal and replacement of a crankshaft bolt and/or crankshaft damper, achieving proper torque of the crankshaft pulley bolt is critical. Incorrect torque may allow the bolt to loosen resulting in the tim

060000 ENGINE AND ENGINE COOLING

This article supersedes TSB 23-2083 to update the Service Procedure and the Part List. Some 2015-2017 F-150 vehicles equipped with a 2.7L EcoBoost engine may exhibit an oil leak from the oil pan RTV seal. This may be due to various concerns

030000 BRAKES (PWS)

Some 2016-2018 F-150 and 2016-2017 Expedition/Navigator vehicles may require pressure bleeding of the brake system. The brake system pressure bleeding procedure in the Workshop Manual (WSM), Section 206-00, has been updated to add a warning

350000 EQUIPMENT

Some 2015-2019 F-Super Duty and 2015-2020 F-150/Mustang vehicles may require replacement of the powertrain control module (PCM) for various reasons. While performing a programmable module installation (PMI) using the Integrated Diagnostic S

110000 ELECTRICAL SYSTEM

350000 EQUIPMENT

Some vehicles equipped with power folding mirrors may exhibit power folding mirrors that are inoperative or exhibit a clicking sound. This may be due to the mirrors being manually folded in, during transportation, going through a car wash,

350000 EQUIPMENT

Some 2015-2020 F-150 and 2017-2022 F-Super Duty vehicles may exhibit a lack of heat or cooling from the cabin vents when the climate control settings are adjusted between hot and cold. This may be due to a stuck/binding temperature door wit

160000 STRUCTURE

For 2000-2024 Ford and Lincoln vehicles, swapping a module from a vehicle for diagnosis purposes is likely to cause errors and is not recommended. It is also not recommended to order a replacement module using a vehicle identification numbe

060000 ENGINE AND ENGINE COOLING

Some 2015-2017 F-150 vehicles equipped with a 2.7L EcoBoost engine may exhibit an oil leak from the oil pan RTV seal. This may be due to various concerns with the oil pan. To correct the condition, follow the Service Procedure to replace th

350000 EQUIPMENT

Some vehicles equipped with a 2.7L, 3.0L,3.5L or 5.0L engine may require replacement of the long block engine assembly. New service kits have been released which include all the one-time-use components required in the service procedure for

060000 ENGINE AND ENGINE COOLING

Some 2015-2020 F-150 vehicles equipped with a 2.7L, 3.5L or 5.0L engine may require replacement of the long block engine assembly. New service kits have been released which include all the one-time-use components required in the service pro

350000 EQUIPMENT

135200 VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR

280000 BACK OVER PREVENTION

Some 2015-2023 F-150, 2017-2022 F-Super Duty, and 2019-2023 Ranger vehicles may exhibit dust ingress into the cabin through the doors or air extractors. This may be due to the climate control system being in recirculation mode as a result o

162300 STRUCTURE:BODY:DOOR

030000 BRAKES (PWS)

Some Ford and Lincoln vehicles may exhibit noise when the brakes are applied. When diagnosing and repairing brake noise conditions, use the Workshop Manual (WSM) and the appropriate pinpoint test in section 206-00. The brake rotors should o

177100 LATCHES/LOCKS/LINKAGES:FUELING/CHARGING DOOR/HATCH/PORT:LATCH/LOCK RELEASE SYSTEM

Certain 2015-2020 Model Year F-150 Vehicles Equipped with a Power Release Tailgate - Unintended Tailgate Opening REASON FOR THIS SUPPLEMENT Parts ordering information and full repair instructions are now available to support completion of

980000 UNKNOWN OR OTHER

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

162500 STRUCTURE:BODY:TAILGATE

Some 2015-2022 F-150 and 2017-2022 F-Super Duty vehicles may experience issues with the tailgate center step moulding. If there is an issue with the center molding (warped, damaged condition, loose, or if the molding is missing), the trim c

113000 ELECTRICAL SYSTEM:STARTER ASSEMBLY

Some 2017-2022 F-250-F-550, 2015-2020 F-150 and 2018-2022 Expedition vehicles without push button start and passive entry may exhibit a condition where it is difficult to insert the ignition key and/or turn it to the accessory position when

030000 SERVICE BRAKES, HYDRAULIC

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

Some 2015-2022 F-150, 2017-2022 F-Super Duty and 2018-2022 Expedition/Navigator vehicles may exhibit poor air conditioning (A/C) performance. Workshop Manual (WSM) diagnostic procedures have been updated to more accurately diagnose A/C perf

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

100000 POWER TRAIN

Some 2003-2020 Expedition/Navigator and 2006-2020 F-150 (non-Raptor) vehicles equipped with 4WD may exhibit grinding/clicking/ratcheting noise from the front wheel area. This may be due to partial engagement of the integrated wheel ends (IW

173100 LATCHES/LOCKS/LINKAGES:TAILGATE:LATCH

In the affected vehicles, some customers report experiencing an unintended tailgate opening and may have previously serviced their vehicle for this concern. Ford has developed an enhanced remedy for customers who may want this enhanced repa

170000 LATCHES/LOCKS/LINKAGES

110000 ELECTRICAL SYSTEM

Some 2013-2023 Ford or Lincoln vehicles with modems activated through FordPass or LincolnWay may experience 12 volt battery drain symptoms when the customer uses non-Ford/Lincoln phone applications as an alternate channel to access vehicle

173200 LATCHES/LOCKS/LINKAGES:TAILGATE:LOCK

Certain 2015-2020 Model Year F-150 Vehicles Equipped with a Power Release Tailgate - Unintended Tailgate Opening - In the affected vehicles, some customers report experiencing an unintended tailgate opening and may have previously serviced

980000 UNKNOWN OR OTHER

140000 AIR BAGS

Some 2015-2020 F-150, 2017-2022 Super Duty and 2018-2021 Expedition vehicles may experience a cracked or splitting driver air bag cover. This may be due to the air bag cover tear seam design. An updated driver air bag assembly has been rele

354000 EQUIPMENT:MECHANICAL

This article supersedes TSB 21-2236 to update the models and year affected. Some 2013-2018 C-Max, 2013-2020 Fusion/MKZ, 2013-2022 Escape, 2015-2018 Focus, 2015-2019 MKC, 2015-2022 Edge/F150/Mustang, 2016-2018 MKX, 2016-2019 Explorer, 2017-2

350000 EQUIPMENT

220000 SEATS

980000 UNKNOWN OR OTHER

Some 2015-2022 F-150, 2017-2022 F-Super Duty and 2018-2022 Expedition/Navigator vehicles may exhibit poor air conditioning (A/C) performance, loss of airflow and/or engine cooling fans running continuously from high A/C pressures. This conc

062200 ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

350000 EQUIPMENT

Some 2015-2020 F-150 vehicles may experience a cracked or splitting driver air bag cover. This may be due to the air bag cover tear seam design. An updated driver air bag assembly has been released with a more robust air bag cover design. R

140000 AIR BAGS

060000 ENGINE (PWS)

Some 2015-2021 F-150, 2017-2021 Super Duty and 2018-2021 Expedition/Navigator vehicles may exhibit poor air conditioning (A/C) performance, loss of airflow and/or engine cooling fans running continuously from high A/C pressures. This concer

060000 ENGINE AND ENGINE COOLING

118000 ELECTRICAL SYSTEM:SOFTWARE

Some 2016-2021 Ford and Lincoln vehicles equipped with SYNC 3 may exhibit a condition where the navigation voice prompts are inoperative after a SYNC map update. This may be due to an incomplete installation of the SYNC map software. If pos

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

356000 EQUIPMENT ADAPTIVE/MOBILITY

Some 2018-2020 Expedition/Navigator, 2015-2020 F150 and 2017-2020 F-Super Duty vehicles equipped with power running boards (PRB) may exhibit a condition where the PRBs are disabled, changing the feature menu setting from Auto to Off mode in

350000 EQUIPMENT

110000 ELECTRICAL SYSTEM

115000 ELECTRICAL SYSTEM:BODY CONTROL MODULE/BCM

Some 2016-2017 Ford and Lincoln vehicles with a new body control module (BCM) installed may exhibit a programming error when using IDS versions 122.03 through 123.01 stating 'Data Corrupt' or 'Configuration Failed, would you like to retry?'

110000 ELECTRICAL SYSTEM

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Some 2015-2021 F-150, 2017-2021 F-Super Duty and 2018-2021 Expedition/Navigator vehicles equipped with a vista roof opening panel may exhibit a binding/sticking, glass stuck open or closed, noisy operation including chatter, rattling, or gr

162900 STRUCTURE:BODY:ROOF AND PILLARS

134000 VISIBILITY:SUN/MOON ROOF ASSEMBLY

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

Some 2015-2020 F-150, 2017-2020 Super Duty and 2018-2020 Expedition/Navigator vehicles may exhibit poor air conditioning (A/C) performance, loss of airflow and/or engine cooling fans running continuously from high A/C pressures. This concer

062200 ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

110000 ELECTRICAL SYSTEM

Some 2015-2021 Ford and Lincoln vehicles may exhibit an illuminated MIL with diagnostic trouble codes (DTC) P0011, P0012, P0014, P0015, P0016, P0017, P0018, P0019, P0021, P0022, P0024 and/or P0025. This may be due to small debris causing th

031110 SERVICE BRAKES, ELECTRIC:SOFTWARE/PROGRAMMING

Some 2013-2021 Ford and Lincoln vehicles may exhibit noise when the brakes are applied. When diagnosing and repairing brake noise conditions, use the Workshop Manual (WSM) and the appropriate pinpoint test in section 206-00. The brake rotor

119430 ELECTRICAL SYSTEM:PROPULSION SYSTEM:CHARGING:MODULE:ONBOARD (OBCM)

Some 2016-2017 Ford and Lincoln vehicles with a new Body Control Module (BCM) installed may exhibit a programming error using IDS v122.03 and newer stating "Data Corrupt" or Configuration Failed, would you like to retry?. A temporary work

115000 ELECTRICAL SYSTEM:BODY CONTROL MODULE/BCM

110000 ELECTRICAL SYSTEM

Some 2016-2021 Ford or Lincoln vehicles equipped with SYNC 3 or SYNC 4 may exhibit a blank screen or other various SYNC symptoms only when the vehicle is in transport mode. This is considered normal due to the power saving features enabled

220000 SEATS

Some 2013-2018 C-Max, 2013-2020 Fusion/MKZ, 2013-2021 Escape, 2015-2018 Focus, 2015-2019 MKC, 2015-2021 Edge/F150/Mustang, 2016-2018 MKX, 2016-2019 Explorer, 2017-2021 F-Super Duty, 2018-2021 EcoSport/Expedition, 2019-2021 Ranger/Nautilus,

170000 LATCHES/LOCKS/LINKAGES

On your vehicle, moisture and water entering a power door lock actuator housing could cause the actuator motor to momentarily freeze in cold temperatures and may also cause actuator motor corrosion over time. Frozen water within a power doo

170000 LATCHES/LOCKS/LINKAGES

In some of the affected vehicles, moisture and water entering a power door lock actuator housing can cause the actuator motor to momentarily freeze in cold temperatures and may also cause actuator motor corrosion over time. Frozen water wit

350000 EQUIPMENT

This article supersedes TSB 21-2144 to update the vehicle model years affected and the Part List. Some 2015-2020 F-150 and 2017-2021 F-Super Duty vehicles may exhibit a lack of heat or cooling from the cabin vents when the climate control s

110000 ELECTRICAL SYSTEM

Some 2016 MKS, 2016-2017 Navigator, 2016-2018 F-150/Focus/C-MAX/Edge/Fiesta/MKX/Transit Connect/Mustang, 2017-2018 Continental/Fusion/MKZ, 2017-2019 Explorer, 2016-2019 Escape/MKC/Flex/MKT/Taurus/Transit/Expedition/F-Super Duty, and 2018-20

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

060000 ENGINE AND ENGINE COOLING

350000 EQUIPMENT

Some 2015-2020 F-150 XL/XLT vehicles may exhibit warping/separation of the instrument panel at the defrost vents. To correct the condition, follow the Service Procedure to replace the instrument panel upper section.

350000 EQUIPMENT

Some 2015-2021 F-150 and 2017-2021 F-Super Duty vehicles may exhibit a lack of heat or cooling from the cabin vents when the climate control settings are adjusted between hot and cold. This may be due to a stuck/binding temperature door wit

060000 ENGINE AND ENGINE COOLING

Some 2011-2021 Mustang and F-150 vehicles equipped with a 5.0L engine may exhibit a ticking noise at idle after an engine oil change. It is often referred to as typewriter noise because of its similarity to the sound of a mechanical typewri

100000 POWER TRAIN

Some 2013-2018 F-150 vehicles equipped with electronic shift on-the-fly (ESOF) 4-wheel drive (4WD) may exhibit an intermittent grinding noise while driving in 2-wheel drive (2WD) mode most commonly on acceleration. ESOF can be identified as

350000 EQUIPMENT

Some 2015-2021 F-150, 2016-2018 MKX, 2019-2021 Nautilus, 2015-2021 Edge, 2017-2019 Fusion, 2017-2020 MKZ And 2017-2020 Continental vehicles equipped with a 2.7L/3.0L EcoBoost engine may appear to have a low engine oil level if the proper pr

350000 EQUIPMENT

Some 2015-2020 F-150 and 2018-2020 Expedition/Navigator vehicles equipped with a 3.5L/2.7L EcoBoost engine and four-wheel drive (4WD) may exhibit an intermittent grinding type noise while driving in two-wheel drive (2WD), most commonly on a

060000 ENGINE AND ENGINE COOLING

350000 EQUIPMENT

For 2011-2020 F-150/Mustang vehicles equipped with a 5.0L engine when installing a replacement secondary timing chain tensioner (6K254) or secondary timing chain guide (6K297), it is necessary to replace both components as a pair, using the

350000 EQUIPMENT

Some 2003-2020 Expedition/Navigator and 2006-2020 F-150 vehicles equipped with TOD transfer cases may exhibit grinding/clicking/ratcheting noise from the front wheel area. This may be due to partial engagement of the integrated wheel ends (

200000 WHEELS

110000 ELECTRICAL SYSTEM

118000 ELECTRICAL SYSTEM:SOFTWARE

Some 2013-2018 F-150 vehicles equipped with Electronic Shift On-The-Fly (ESOF) 4-wheel drive (4WD) may exhibit an intermittent grinding noise while driving in 2-wheel drive (2WD) mode most commonly on acceleration. This may be due to a loss

350000 EQUIPMENT

100000 POWER TRAIN

356000 EQUIPMENT ADAPTIVE/MOBILITY

When installing a replacement short block in 2015-2017 vehicles equipped with a 2.7L or 3.0L EcoBoost engine, the engine must be converted to use a belt driven oil pump with the following parts: left exhaust camshaft JT4Z-6250-B, left inta

350000 EQUIPMENT

060000 ENGINE AND ENGINE COOLING

118410 ELECTRICAL SYSTEM:ADAS:BLINDSPOT:SOFTWARE

Some 2015-2020 F-150/Mustang, 2016-2020 Edge, 2016-2018 MKX and 2019-2020 Nautilus vehicles built on or before 18-Jan-2020 may exhibit a mirror click and/or ratcheting noise when using memory functions or easy entry/exit function. This may

356000 EQUIPMENT ADAPTIVE/MOBILITY

060000 ENGINE AND ENGINE COOLING

Some 2009-2020 Ford and Lincoln vehicles equipped with turbochargers may exhibit an oil leak from the turbocharger oil supply or return tubes, O-rings or 6.7L pedestal gasket. Although oil may collect on the turbocharger, it is very rare fo

118320 ELECTRICAL SYSTEM:ADAS:DRIVER MONITORING:CAMERA/SENSOR

Some 2015-2020 F-150 except Raptor, 2017-2020 F-Super Duty, 2018-2020 Expedition vehicles equipped with a front camera washer may exhibit a washer fluid leak at the front camera washer jet when not in use. This may be due to the rubber seal

356000 EQUIPMENT ADAPTIVE/MOBILITY

061500 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION

Some 2015-2020 F-150, 2016-2018 MKX, 2019-2020 Nautilus, 2015-2020 Edge, 2017-2019 Fusion, 2017-2020 MKZ And 2017-2020 Continental vehicles equipped with a 2.7L/3.0L EcoBoost engine may appear to have a low engine oil level if the proper pr

350000 EQUIPMENT

118000 ELECTRICAL SYSTEM:SOFTWARE

Some 2016 MKS, 2016-2017 Navigator, 2016-2018 F150/Focus/CMAX/Edge/Fiesta/MKX/ Transit Connect/Mustang, 2017-2018 Continental/Fusion/MKZ, 2017-2019 Explorer, 2016-2019 Escape/MKC/Flex/MKT/Taurus/Transit/Expedition/F-Super Duty, and 2018-201

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

Some 2015-2019 F-150, 2017-2019 F-Super Duty vehicles may exhibit a lack of heat or cooling from the cabin vents when the climate settings are adjusted between hot and cold. This may be due to a stuck/binding temperature door within the cli

160000 STRUCTURE

Some 2015-2020 F-150, 2017-2020 F-Super Duty vehicles may exhibit one or more noisy doors when opening and closing. This may be due to dirt and debris on the door check arm(s). To correct this condition, follow the Service Procedure to clea

160000 STRUCTURE

This article supersedes TSB 19-2026 to update the vehicle model years affected. Some 2000 and newer Ford/Lincoln/Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint wi

060000 ENGINE AND ENGINE COOLING

Some 2015-2020 F150/Edge/Fusion, 2016-2018 MKX, 2019-2020 Nautilus, and 2017-2020 Continental vehicles equipped with 2.7L EcoBoost engines may exhibit an illuminated malfunction indicator lamp (MIL) and/or Engine Coolant Over Temperature wa

350000 EQUIPMENT

Some 2016-2020 Ford and Lincoln vehicles equipped with a SYNC 3 Touchscreen may experience the volume control unresponsive from the Front Control Interface Module (FCIM) and steering volume controls when using Apple Car Play. When the Apple

110000 ELECTRICAL SYSTEM

Showing 100 of 434 bulletins.

NHTSA Safety Investigations, FORD F-150

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

EA, Open , Model Year: 2015

Unintended Transmission Downshift and Rear Wheel Lock-up

On March 21, 2025, NHTSA’s Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE25002) to investigate instances of unexpected transmission downshifting without driver input in model year (MY) 2015-2017 Ford F-150 vehicles (subject vehicles) manufactured by Ford Motor Company (F... ord). The complaints allege that, without warning or driver input, the subject vehicles experienced a sudden and rapid deceleration often accompanied by temporary rear wheel lockup, seizure, or skidding, resulting in a loss of vehicle control that increases the risk of crash and injury to all motorists, including those not within the subject vehicles. The MY 2015 and MY 2016 F-150 vehicles were equipped with the “6R80” transmission, while the MY 2017 vehicles were equipped with either the “6R80” transmission or the “10R80” transmission. This investigation was limited to MY 2015-2017 Ford F-150 with the “6R80” transmission. ODI identified 329 Vehicle Owners Questionnaires (VOQs) related to this investigation and sixty percent of these consumers were interviewed to confirm the details of their allegations. Consumers reported that their vehicles’ transmission suddenly downshifted to a lower gear, often to 1st or 2nd gear, without driver input or advance warning. Consumers described the downshift events to be regular and repeated occurrences, with some consumers stating that they no longer drive the vehicle due to safety concerns. Forty-three percent of consumers reported experiencing at least one wheel lockup event, during which the rear tires locked, screeched, or skidded during the transmission downshift. ODI also found that 114 of the 329 consumers reported having their vehicle’s molded lead frame or valve body assembly (which comes with a molded lead frame) replaced, 80 of which were confirmed through consumer submitted repair invoices. In its response to ODI’s Information Request, Ford provided an assessment of potential root cause of failure for the subject vehicles and how this failure is different from the failure associated with MY 2011-2014 Ford F-150 vehicles that was addressed by four safety recalls (16V-248, 19V-075, 19V-433, and 24V-444). Ford has identified that the defect in the recalled vehicle population involved lead frame supplier production issues resulting in signal loss from the Output Shaft Speed (OSS) sensor. Ford has identified that the alleged defect in the subject vehicle population involved degradation of electrical connections within the lead frame due to thermal cycling and vibration over extended time in service resulting in signal loss from the Transmission Range Sensor (TRS). Signal loss from the TRS can result in an unintended shift to neutral, unintended upshift, or unintended downshift which are regulated by a gear “shift map” based on the vehicle’s speed at the time of signal loss. According to Ford’s “shift map”, at speeds between 35-64 mph, the maximum allowable downshift would be to 2nd gear (i.e. a 6th to 2nd gear downshift event) which Ford has designated to represent the worst-case scenario for subject vehicles. Ford has also acknowledged that the worst-case scenario may also involve temporary wheel lockup. However, Ford has stated that the failure mechanism in the MY 2011-2014 F-150 vehicles—previously addressed through recalls—primarily involved OSS sensor signal loss that could result in 6th to 1st gear downshift events. This OSS-related failure mode is distinct from the TRS-related signal loss identified in the subject vehicle population. ODI has identified an additional potential safety defect associated with the alleged defect in the subject vehicles. Preliminary testing performed by NHTSA’s Vehicle Research Test Center (VRTC) showed that when the TRS experiences an intermittent signal loss, one possible outcome is a change in vehicle direction. Specifically, if a vehicle is operating in reverse up an incline when the TRS signal loss occurs, then the vehicle may shift into neutral causing the vehicle to change directions and roll forward. ODI is opening this Engineering Analysis (EA) to, among other things, perform component-level testing and vehicle testing, as well as review additional technical information to better understand the alleged defect that has been identified. To review the reports cited in the Opening Resume ODI Report Identiﬁcation Number document, go to NHTSA.gov.Read more

PE, Closed , Model Year: 2015

Unintended Transmission Downshift and Rear Wheel Lock-up

On March 21, 2025, NHTSA’s Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE25002) to investigate instances of unexpected transmission downshifting without driver input in model year (MY) 2015-2017 Ford F-150 vehicles (subject vehicles) manufactured by Ford Motor Company... (Ford). The complaints allege that, without warning or driver input, the subject vehicles experienced a sudden and rapid deceleration often accompanied by temporary rear wheel lockup, seizure, or skidding, resulting in a loss of vehicle control that increases the risk of crash and injury to all motorists, including those not within the subject vehicles. The MY 2015 and MY 2016 F-150 vehicles were equipped with the “6R80” transmission, while the MY 2017 vehicles were equipped with either the “6R80” transmission or the “10R80” transmission. This investigation was limited to MY 2015-2017 Ford F-150 with the “6R80” transmission. ODI identified 329 Vehicle Owners Questionnaires (VOQs) related to this investigation and sixty percent of these consumers were interviewed to confirm the details of their allegations. Consumers reported that their vehicles’ transmission suddenly downshifted to a lower gear, often to 1st or 2nd gear, without driver input or advance warning. Consumers described the downshift events to be regular and repeated occurrences, with some consumers stating that they no longer drive the vehicle due to safety concerns. Forty-three percent of consumers reported experiencing at least one wheel lockup event, during which the rear tires locked, screeched, or skidded during the transmission downshift. ODI also found that 114 of the 329 consumers reported having their vehicle’s molded lead frame or valve body assembly (which comes with a molded lead frame) replaced, 80 of which were confirmed through consumer submitted repair invoices. In its response to ODI’s Information Request, Ford provided an assessment of potential root cause of failure for the subject vehicles and how this failure is different from the failure associated with MY 2011-2014 Ford F-150 vehicles that was addressed by four safety recalls (16V-248, 19V-075, 19V-433, and 24V-444). Ford has identified that the defect in the recalled vehicle population involved lead frame supplier production issues resulting in signal loss from the Output Shaft Speed (OSS) sensor. Ford has identified that the alleged defect in the subject vehicle population involved degradation of electrical connections within the lead frame due to thermal cycling and vibration over extended time in service resulting in signal loss from the Transmission Range Sensor (TRS). Signal loss from the TRS can result in an unintended shift to neutral, unintended upshift, or unintended downshift which are regulated by a gear “shift map” based on the vehicle’s speed at the time of signal loss. According to Ford’s “shift map”, at speeds between 35-64 mph, the maximum allowable downshift would be to 2nd gear (i.e. a 6th to 2nd gear downshift event) which Ford has designated to represent the worst-case scenario for subject vehicles. Ford has also acknowledged that the worst-case scenario may also involve temporary wheel lockup. However, Ford has stated that the failure mechanism in the MY 2011-2014 F-150 vehicles—previously addressed through recalls—primarily involved OSS sensor signal loss that could result in 6th to 1st gear downshift events. This OSS-related failure mode is distinct from the TRS-related signal loss identified in the subject vehicle population. ODI has identified an additional potential safety defect associated with the alleged defect in the subject vehicles. Preliminary testing performed by NHTSA’s Vehicle Research Test Center (VRTC) showed that when the TRS experiences an intermittent signal loss, one possible outcome is a change in vehicle direction. Specifically, if a vehicle is operating in reverse up an incline when the TRS signal loss occurs, then the vehicle may shift into neutral causing the vehicle to change directions and roll forward. Based on NHTSA’s analysis of consumer data, information provided by Ford, and preliminary testing conducted by NHTSA’s VRTC, this Preliminary Evaluation is being upgraded to an Engineering Analysis (EA26001). During this Engineering Analysis, the agency plans to, among other things, perform component-level testing and vehicle testing, as well as review additional technical information to better understand the alleged defect that has been identified from this Preliminary Evaluation. To review the reports cited in the Closing Resume ODI Report Identiﬁcation Number document, go to NHTSA.gov.Read more

RQ, Closed , Model Year: 2014

Unintended Transmission Downshift

In September 2016, Ford Motor Company (Ford) issued safety recall 16V-248 which included certain model year (MY) 2011-2012 Ford F-150 vehicles equipped with 6-speed (6R80) automatic transmissions. This recall was in response to allegations of unintended, unexpected vehicle transmission downshifting ... to a lower gear without warning, often accompanied by temporary rear wheel lock-up, increasing the risk of a crash and/or injury, and included approximately 153,581 vehicles. Ford identified the root cause of the unintended, unexpected vehicle transmission downshifting to a lower gear to be intermittent signal loss from the transmission’s Output Shaft Speed (OSS) sensor due to solder joint cracks on the OSS circuit board as a result of manufacturing process issues. The OSS sensor is mounted onto the molded lead frame and transmits changes in transmission shaft speed to the Powertrain Control Module (PCM). The remedy program described in safety recall 16V-248 involved reprogramming of the PCM to prevent unintended vehicle transmission downshifting from occurring. In December 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-010) to assess the scope and remedy effectiveness of safety recall 16V-248. As a result of this ODI investigation, Ford issued safety recall 19V-075 to expand the scope of 16V-248 to include MY 2011-2013 Ford F-150 vehicles equipped with 6-speed (6R80) automatic transmissions and included approximately 1,263,051 vehicles. The remedy program described in safety recall 19V-075 involved reprogramming of the PCM to prevent unintended vehicle transmission downshifting from occurring. In June 2019, Ford issued safety recall 19V-433 as the remedy program used to service MY 2013 Ford F-150 5.0L and 6.2L vehicles in accordance with safety recall 19V-075 did not contain the necessary updates to prevent unintended vehicle transmission downshifting from occurring and included approximately 107,857 vehicles. On March 27, 2024, ODI opened this Recall Query (RQ24-005) to investigate the scope of the above-described safety recalls. At the time that this investigation was opened, ODI had received 86 Vehicle Owner Questionnaires (VOQs) reporting allegations of unintended, unexpected vehicle transmission downshifting to a lower gear without warning, often accompanied by temporary rear wheel lock-up, in MY 2014 Ford F-150 vehicles. As a result of this Recall Query, Ford filled safety recall 24V-444 on June 14, 2024, to include MY 2014 Ford F-150 vehicles and expand the scope of safety recalls 16V-248, 19V-075 and 19V-433. The remedy program described in safety recall 24V-444 involved reprogramming of the PCM to prevent unintended vehicle transmission downshifting from occurring and included approximately 552,188 vehicles. In its May 2024 response to ODI’s information request, Ford concluded that a predominant root cause for the intermittent OSS signal loss has not been identified outside of the original safety recall (16V-248). Ford’s investigation also concluded that the primary causes of the defect in MY 2014 F-150 vehicles were related to the molded lead frame and the control assembly transmission main. In the May 2024 response, Ford identified 2,184 total reports that described unintended vehicle transmission downshifting and rear wheel lock-up events; 1,441 warranty claims and 743 reports from consumer complaints, field reports, consumer surveys, and lawsuits/legal claims. Note that the values presented here and in the table above represent the total number of reports which can include a single consumer with multiple reports of the same event as well as a consumer with reports of multiple distinct events. Of the 1,441 warranty claims, 551 warranty claims involved repair of the molded lead frame (38%) and 509 warranty claims involved repair of the control assembly transmission main (35%). Ford has also stated that the PCM programming used to prevent unintended vehicle transmission downshifting was implemented starting with MY 2015 vehicle #1 production and onward. In view of the safety recall action being taken by Ford, ODI is closing this Recall Query (RQ24-005). The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.Read more

PE, Closed , Model Year: 2015

Seatbelt Pretensioner Fire

On June 18, 2018, the Office of Defects Investigations (ODI) opened a Preliminary Evaluation (PE18-008) to investigate complaints alleging post-crash fires at the B pillar in the area of the seat belt pretensioners on MY 2014-2018 Ford F-150 Regular Cab, and Super Crew Cab Vehicles. On August 24, 20... Read more

AQ, Closed , Model Year: 2015

Champion Ford Edinboro / Steering Shaft

NHTSA opened AQ17-001 to determine whether Champion Ford Edinboro, Inc. (Champion Ford), of Edinboro, Pennsylvania, complied with the requirements of the National Traffic and Motor Vehicle Safety Act, 49 U.S.C. Chapter 301 (Safety Act) and its implementing regulations. The Safety Act requires, among... Read more

RQ, Closed , Model Year: 2015

Brake Master Cylinder Failure

On June 8, 2020, Ford Motor Company issued a safety recall (NHTSA Recall No. 20V-332) of 292,311 model year (MY) 2014-2017 Ford F-150 vehicles equipped with 3.5L Ecoboost engines and built from 9/1/2014 to 8/1/2016. Ford stated that the causes of brake fluid loss in the master cylinder are brake flu... id contamination that can interfere with rear cup seal function, and rolling of the rearmost cup seal.Prior to total loss of the front brakes, depending on the amount of brake fluid loss in the master cylinder, the driver may receive an audible chime, message center alert and red brake warning indicator in the instrument cluster, and may experience a change in brake pedal travel and increased pedal effort. It should be noted that a small number of late-built MY 2014 and early-built MY 2017 F-150 vehicles are included in the recall along with the subject vehicles (MY 2015-2016).This Recall Query is closed based on the safety recall issued by Ford. The ODI reports cited above can be viewed at NHTSA.gov under the following ID numbers:10734951 10839988 10862418 10872737 10873438 10876359 10881590 10883442 10885352 10888026 10888524 10891826 10891829 10891886 10893632 10894688 10894844 10896122 10896446 10898079 10899093 10899198 10902944 10903776 10904695 10908281 10910101 10913678 10913867 10914016 10914164 10914288 10914361 10914382 10914483 10914507 10915027 10915894 10916302 10916346 10916578 10920258 10925699 10926076 10926148 10926179 10927388 10927402 10927459 10927578 10928457 10928906 10930128 10936207 10940199 10943902 10948941 10950413 10954419 10956798 10969452 10969971 10984389 10985533 10991033 10993430 10993826 10994249 11000331 11000746 11001283 11001291 11001403 11001550 11002014 11002827 11003801 11004795 11005551 11010248 11010341 11011291 11011502 11012944 11013023 11013826 11014954 11015390 11018677 11018771 11020059 11021249 11021632 11022034 11022116 11022243 11023791 11025448 11030416 11030852 11039991 11082190 11082307 11083373 11083998 11089076 11091017 11092142 11093509 11096406 11096501 11097550 11097885 11099405 11099859 11100723 11101189 11101357 11101515 11101631 11102242 11102281 11102299 11102326 11102360 11102481 11104187 11104212 11104877 11109739 11110958 11111028 11111445 11111776 11112143 11112145 11112331 11112445 11112504 11112969 11112970 11114501 11115336 11115612 11118050 11118324 11119688 11119741 11120003 11120625 11120839 11121496 11122946 11123817 11124180 11124313 11124735 11129689 11129763 11129799 11130736 11131008 11132384 11139389 11139955 11154079 11163050 11183075 11189767 11192325 11193564 11195772 11196715 11205224 11205725 11208030 11208558 11209657 11210390 11217868 11218183 11218476 11218533 11218548 11218703 11218773 11219228 11219556 11220778 11221408 11221528 11221888 11222322 11222604 11222909 11228582 11228780 11229191 11229412 11229541 11229673 11230311 11230525 11230553 11230595 11230606 11230664 11231440 11231744 11231985 11232226 11232462 11233423 11233425 11233557 11233595 11233614 11233857 11233864 11234025 11234577 11234715 11234752 11240161 11240184 11240219 11240344 11241143 11241328 11241565 11241737 11241755 11241979 11242032 11242096 11242101 11242222 11242430 11242723 11243775 11244070 11244092 11244223 11244613 11244872 11245199 11245233 11245259 11245846 11246001 11251825 11252130 11252506 11252570 11252595 11252809 11254026 11254116 11254385 11254816 11255210 11255273 11255487 11256470 11257328 11257549 11258458 11258978 11265268 11267540 11269887 11279423 11281670 11287382 11291824 11297512 11298972 11301103 11306644 11310503 11315450 11316153 11318273 11319339 11319344 11319751Read more

PE, Closed , Model Year: 2013

Master Cylinder External Leak

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and b... uilt at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107Read more

EA, Closed , Model Year: 2011

Brake Vacuum Pump Failure

On February 15, 2016, Ford Motor Company initiated Customer Satisfaction Program 15N05 to extend warranty coverage for the electric vacuum pump in certain model year (MY) 2011 through 2012 Ford F-150 pickup trucks equipped with 3.5L GTDI engines.The program extends coverage for up to 10 years of ser... vice or 150,000 miles from the warranty start date of the vehicle, all vehicles are eligible for the program through July 30, 2016 regardless of mileage.Ford's program covers all repairs related to electric vacuum pump (EVP) malfunctions including excessive noise, vibration, or change in brake pedal feel while applying the brakes at cold start. Ford states that the engine intake manifold is the primary source of vacuum for the brake booster and is fully compliant to motor vehicle safety standards without the supplemental vacuum supplied by the EVP.The company also contends that failure modes related to the EVP are progressive and provide warning to operators by way of noise and vibration before an operator to experience any temporary change in brake pedal feel.ODI's analysis of warranty data found that the majority of claims involved consumer concerns with EVP noise or vibration from the left front fender area when the vehicle is first started. Continued operation in this mode with pump motor noise will eventually result in the EVP seizing or becoming non-functional.Component failure analysis indicated that Ford and its supplier, Continental, identified a pump crank drive corrosion condition due to moisture entry through the vacuum intake.Corrosion damage to EVP internal components may eventually result in a blown fuse in the power distribution box and total loss of EVP function.Analysis of consumer complaints, field reports, and warranty data related to EVP failures found thatincidents predominantly occurred in driveways and parking lots in the periods immediately after cold engine starts.Many consumers operated their vehicle for some period of time with a blown EVP fuse without realizing that the pump had failed or that the vehicle had a brake system malfunction.Consumers who did experience braking performance issues reporteda temporary hard brake pedal condition at start-up followed by more consistent normal pedal feel after few seconds.On June 22, 2015, Ford developed a remedy procedure and issued TSB 15-0105 instructing dealers to replace the vacuum pump and install a new vacuum pump harness kit. In addition to reviewing test data submitted by Ford, ODI assessed safety risks associated with the alleged defect under various operating conditions, including: 1) baseline system performance with full engine and EVP vacuum available using exemplar parts, 2) disabled EVP and booster vacuum regulated to simulate worst case conditions for engine intake manifold vacuum supply to the brake booster (approximately 300 mbar); and 3) all source vacuum to the brake booster removed and Optimized Hydraulic Braking (OHB) mode active to represent complete loss of brake booster function (note: this condition is a more severe brake boost system failure mode than the alleged defect).ODI also analyzed all complaints and warranty claims to identify incidents alleging brake system performance concerns related to EVP failures.These analyses identified no brake performance issues or resulting changes in stopping distances either on highway or city traffic conditions.Two complaints alleging EVP malfunctions caused or contributed to rear-end collisions during attempted decelerations from road speeds are not believed to be related to the alleged defect.The EVP provides supplemental vacuum during initial start-up and idleRead more

PE, Closed , Model Year: 2011

Brake Vacuum Pump Failure

On June 22, 2015, the Office of Defects Investigations (ODI) opened Preliminary Evaluation PE15-026 to investigate incidents of increased brake pedal effort at cold start and extended stopping distance while driving in traffic, resulting from failures of the electric brake vacuum assist pump in mode... l year (MY) 2011-2012 Ford F-150 pickup trucks equipped with 3.5L GTDI engines. In response to ODI's Information Request (IR) for PE15-026, Ford provided ODI with 396 complaints and field reports relating to incidents of increased brake pedal effort or malfunctions in the electric vacuum pump (EVP). ODI's analysis of the data provided by Ford identified 7 crashes and 1,851 warranty claims related to either a hard brake pedal condition or reduced brake effectiveness. Additionally, ODI identified one report in its database alleging an injury to an occupant of a vehicle struck in the rear by a subject F-150 vehicle with a failed EVP as documented in the police accident report referencing a dealer assessment of the pump.According to Ford, the subject vehicles utilize a traditional brake vacuum booster to provide power assist for braking and the EVP is intended to operate to maintain consistent brake pedal feel. The engine intake manifold is the primary source of vacuum for the booster and is fully compliant to motor vehicle safety standards without the EVP. Ford described the conditions related to a change in brake pedal feel as limited and temporary and provided component failure analysis showing evidence of water entry into the EVP which caused internal pump corrosion. Ford indicated that the EVP failure mode is progressive and provides warning to operators by way of noise and vibration before an operator is likely to experience any temporary change in brake pedal feel. Damage to the EVP motor bearing may eventually result in a blown EVP fuse and total loss of EVP function. Ford provided test data showing the brake pedal forces and pedal travel curves over time for 0.3g decelerations to a stop from 80kph (50mph) for: 1) normal system (full engine and EVP vacuum available); 2) Ford's approximation of worst case booster performance with EVP failure (EVP disabled and booster vacuum regulated to 300mbar to simulate cold start, all accessory loads on, and starting at 0 vacuum); and 3) with all source vacuum to the brake booster removed and Hydraulic Boost Compensation (HBC) active to represent complete loss of brake booster function. The Ford tests showed that the brake pedal forces required for achieving the 0.3g decelerations were relatively low for the normal condition, 35-40 N (8-9 lbf), increased by approximately 2-3 times normal when the EVP is disabled, 75-115 N (17-26 lbf), and increased by about 5-6 times normal for the complete brake booster failure condition, 205-215 N (46-48 lbf). This Preliminary Evaluation has been upgraded to Engineering Analysis (EA15-006) to test for EVP malfunctions under other vehicle operating conditions (e.g., low-speed driveway braking after cold-start with failed EVP), potential human factors contributions and to further assess the scope, frequency, and safety-related consequences of the alleged defect.The VOQs associated with the opening of this investigation are:10565994, 10575987, 10598351, 10604687, 10605701, 10607811, 10610491, 10615536, 10617828, 10619545, 10643075, 10650578, 10662151, 10664415, 10666988, 10668069, 10678844, 10695537, 10700874, 10706217, 10706271, 10712465, 10723033, 10723792, 10726960, 10730549, 10730721, 10730735, 10730837, 10730909, 10731008, 10731135, 10731157, 10731165, 10731395, 10731758, 10732609, 10732878, 10733375, 10733804, 10734558, 10734613, 10743859, 10744214, 10Read more

PE, Closed , Model Year: 2011

Reduced power during hard acceleration

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford... for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing ofRead more

EA, Closed , Model Year: 1997

Fuel Tank Strap Failure Due to Corrosion

One or both of the steel straps holding up the fuel tank and attaching it to the truck frame can corrode and fail (break or separate).If one strap fails, the tank may tilt and drop and possibly contact the road surface.If both straps break, the entire tank may drop to the road.If either failure occu... rs while the vehicle is being driven, contact with the road can abrade the tank and create a hole from which gasoline can spill.When the tank drops, it remains attached to the vehicle only by the fuel filler hose and/or supply lines, or in rare instances, by the skid plate, if present.In some cases the weight of the tank sufficiently strained the hoses and fittings and caused separation and subsequent fuel leaks from those connections.The fire hazard created by leaking gasoline is increased by the possible presence of sparks created by the metal tank being dragged along the road.Corrosion of the straps appears to be caused by prolonged exposure to road deicers, frequently road salt, used to treat snow or ice covered roads.States in which large quantities of deicers are applied to roads during the winter season (salt belt states) account for the predominant portion of strap failures.Vehicles in these salt belt states are prone to experience corrosion related failures more frequently and earlier in a vehicle?s life cycle.Ford reports approximately 97 percent of reports it received relating to strap failure involve vehicles that were operated in these high corrosion areas, and 95 percent of the reports to NHTSA involved such vehicles.Approximately one-third of F-150 U.S. production was sold in salt belt states.ODI has included in the above counts reports it has received from consumers and reports it has received from Ford in which either the complaint involved confirmed strap corrosion or ODI's assessment of available information suggests corrosion caused the reported problem.Among the incidents reported to NHTSA, 441 involved one or both straps failing due to corrosion, 353 involved the fuel tank dropping and/or dragging on the ground, and 180 involved fuel leakage.ODI has received four reports of strap failure in which the leaking fuel ignited but self-extinguished, and one incident in which fire destroyed the vehicle and injured its driver.Ford reported the same injury incident and three other unique fire incidents, including two in which the leaking fuel ignited and fire destroyed the vehicle.There were no injuries associated with the three unique Ford incidents.Ford has agreed to conduct a recall to repair the subject vehicles.The recall will cover vehicles that were originally sold or are currently registered in salt belt states (regardless of vehicle age).The vehiclesincluded in the recall are those subject vehicles that are, or have ever been, registered in Connecticut, Delaware, Iowa, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, or the District of Columbia.Ford's recall action appears to adequately address the problem at this time.The above vehicle population (1,340,349) includes subject vehicles originally delivered or sold in salt belt states.ODI does not know the current or historical locations of all subject vehicles.According to Ford approximately 73% of the recall population is currently registered (a 27% attrition rate).Ford is also recalling certain MY 1997-1999 F-250 vehicles (under 8,500 GVWR), and MY2002-2003 Lincoln Blackwood vehicles for the same condition, resulting in an estimated 1.1 million total vehiclesRead more

PE, Closed , Model Year: 1997

Fuel Tank Strap Corrosion/Rust

One or both of the steel straps holding up the fuel tank and attaching it to the truck frame can corrode and break.If one strap breaks, the tank may tilt and drop and possibly contact the road surface.If both straps break, the entire tank may drop to the road.If either failure occurs while the vehic... Read more

EA, Closed , Model Year: 2004

Inadvertent airbag deployment

ODI opened this investigation based on reports of inadvertent airbag deployment.Data provided by Ford indicated that the airbag clockspring jumper wire, which is situated inside the steering wheel assembly, was installed in a manner that would allow it to rub (abrade) against a sharp metal edge on t... Read more

PE, Closed , Model Year: 2005

INADVERTENT AIRBAG DEPLOYMENT

FORD REPORTS THAT THE INADVERTENT AIRBAG DEPLOYMENTS ARE MOST LIKELY CAUSED BY THE AIRBAG HORN MOUNTING PLATE'S SHARP METAL EDGE THAT EVENTUALLY CAN CHAFE/CUT THE AIRBAG CLOCKSPRING JUMPER WIRE LEADING TO A SHORT-TO-GROUND CONDITION.ONE HUNDRED EIGHTY TWO (182) OF THE 230 REPORTS WERE FOR AIRBAG DEP... Read more

PE, Closed , Model Year: 2003

CNG REGULATOR LEAK

THE AGENCY HAS CLOSED THIS INVESTIGATION BASED ON ITS REVIEW OF COMPLAINT REPORTS, DISCUSSIONS WITH COMPLAINANTS AND FIELD AND TECHNICAL DATA PROVIDED BY FORD.THE SUBJECT VEHICLES ARE 1/2 TON PICKUP TRUCKS AND ARE NATURAL GAS VEHICLES (NGV) THAT ARE FUELED BY GASOLINE OR COMPRESSED NATURAL GAS.THE A... Read more

PE, Closed , Model Year: 2005

LOSS OF BRAKE POWER-ASSIST

BY LETTER DATED MAY 5, 2008, FORD MOTOR COMPANY (FORD) NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-208) TO ADDRESS A MANUFACTURING DEFECT IN APPROXIMATELY 605,684 MODEL YEAR (MY) 2005 AND 2006 FORD F-150 AND LINCOLN MARK LT VEHICLES ORIGINALLY EQUIPPED WITH THE ... 5.4L DISPLACEMENT, 3-VALVE PER CYLINDER, V-8 ENGINE.THE RECALLED VEHICLES WERE BUILT FROM JULY 18, 2004 THROUGH MAY 31, 2006 AT THE DEARBORN TRUCK PLANT; FROM MAY 4, 2004 THROUGH MAY 31, 2006 AT THE KANSAS CITY ASSEMBLY PLANT; AND FROM APRIL 19, 2004 THROUGH MAY 31, 2006 AT THE NORFOLK TRUCK PLANT.THE VEHICLES WERE MANUFACTURED WITH THE SAME DEFECTIVE BRAKE BOOSTER VACUUM SUPPLY HOSE ASSEMBLY UNIQUE TO THE 5.4L V-8 ENGINE.FORD F-150 VEHICLES EQUIPPED WITH OPTIONALLY AVAILABLE 4.2L V6 AND 4.6L V-8 ENGINES ARE NOT INCLUDED IN THIS RECALL ACTION BECAUSE THEY UTILIZE A DIFFERENT, ONE-PIECE BRAKE BOOSTER VACUUM SUPPLY HOSE ASSEMBLY THAT DOES NOT EXHIBIT AN APPARENT DEFECT TREND. THE RECALLED VEHICLES UTILIZE A TWO-PIECE BRAKE BOOSTER VACUUM SUPPLY HOSE ASSEMBLY COMPRISED OF A STANDPIPE ASSEMBLY AND VACUUM HOSE.THE STANDPIPE ASSEMBLY ATTACHES TO A FITTING ON THE ENGINE AIR INTAKE MANIFOLD UTILIZING A FLEXIBLE RUBBER HOSE AND PLASTIC ELBOW.THE VACUUM HOSE ATTACHES TO THE OPPOSITE END OF THE STANDPIPE ASSEMBLY AND CONNECTS TO A CHECK VALVE FITTING AT THE BRAKE BOOSTER ASSEMBLY.ACCORDING TO FORD, THE PORTION OF THE BRAKE BOOSTER VACUUM SUPPLY HOSE ASSEMBLY ATTACHED TO THE INTAKE MANIFOLD MAY SWELL OVER TIME AND LOSE RETENTION FORCE, WHICH MAY ALLOW THE HOSE TO BECOME DETACHED FROM THE INTAKE MANIFOLD.SHOULD THE BRAKE BOOSTER VACUUM SUPPLY HOSE ASSEMBLY BE DISRUPTED, APPLICATION OF THE BRAKE PEDAL MAY DEPLETE THE VACUUM RESERVE AND CONSEQUENTLY RESULT IN LOSS OF BRAKE POWER-ASSIST. TO CORRECT THE SAFETY DEFECT, FORD WILL INSTALL AN IMPROVED DESIGN BRAKE BOOSTER VACUUM SUPPLY HOSE ASSEMBLY THAT UTILIZES A HOSE CLAMP AT THE INTAKE MANIFOLD ATTACHMENT. THIS REMEDY WILL BE PROVIDED FREE OF CHARGE FOR ALL RECALLED VEHICLES.LATER PRODUCTION FORD F-150 AND LINCOLN MARK LT VEHICLES BUILT AFTER MAY 2006 WERE MANUFACTURED WITH A HOSE CLAMP AT THE BRAKE BOOSTER VACUUM SUPPLY HOSE/INTAKE MANIFOLD ATTACHMENT AND ARE NOT AFFECTED. TO DATE, THE OFFICE OF DEFECTS INVESTIGATION (ODI) IS AWARE OF 324 NON-DUPLICATIVE COMPLAINTS AND 14 NON-INJURY CRASHES RELATED TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF 4,465 SUBJECT VEHICLES THAT EXPERIENCED ONE OR MORE WARRANTY CLAIMS TO REPAIR OR REPLACE THE SUBJECT BRAKE BOOSTER VACUUM SUPPLY HOSE ASSEMBLY. THE ACTION TAKEN BY FORD IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.Read more

PE, Closed , Model Year: 1997

STEERING COLUMN

PE, Closed , Model Year: 1998

SPARE TIRE WEAR

DP, Closed , Model Year: 1998

SPARE TIRE MOUNTING

THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION WAS PETITIONED TO COMMENCE A DEFECT INVESTIGATION OF THE SUBJECT VEHICLES BY A LETTER SIGNED BY WILLIAM F. ALLARD AND DATED 15-FEB-98.THE PETITION ALLEGES THAT THE SPARE TIRE MOUNTING PLACES THE TIRE SIDEWALL DIRECTLY IN CONTACT WITH THE METAL UNDER... Read more

RQ, Open , Model Year: 1997

REAR SUSPENSION SPRING BREAKAGE

IN JULY 1998, FORD SUBMITTED A PART 573 NOTIFICATION TO NHTSA CONCERNING BROKEN REAR SPRINGS ON CERTAIN 1997-98 FORD F150 TRUCKS, WITH FOUR-WHEEL DRIVE.FORD STATED THAT FATIGUE FRACTURE OF THE REAR SPRINGS MAY OCCUR IF THE SPRING ARE OVER STRESSES(SIC) BY VEHICLE OVERLOADING.THE BROKEN PIECE OF THE ... Read more

EA, Closed , Model Year: 1997

ALLEGED LOSS OF THROTTLE CONTROL

THE DETAILS OF INFORMATION AND DATA EVALUATED DURING THIS INVESTIGATION ARE STATED IN THE ENGINEERING ANALYSIS CLOSING REPORT, DATED SEPTEMBER 30, 1999.A SAFETY-RELATED DEFECT TREND RESULTING FROM INTERFERENCE BY THE FLOOR MAT WITH PROPER OPERATION OF THE THROTTLE IN THE SUBJECT VEHICLES WAS NOT IDE... Read more

PE, Closed , Model Year: 1997

LOSS OF THROTTLE CONTROL

There is no summary currently available

RQ, Closed , Model Year: 1994

INADVERTENT AIR BAG DEPLOYMENT

There is no summary currently available

RQ, Closed , Model Year: 1997

AUTOMATIC TRANSMISSION CONTROL

ON SEPTEMBER 4, 1997, FORD FILED A DEFECT INFORMATION REPORT CONCERNING APPROXIMATELY 15,000 1997 MODEL YEAR F-150 TRUCKS, MANUFACTURED FROM FEBRUARY 16 THROUGH MARCH 4, 1996, AND BUILT AT THE NORFOLK OR KANSAS CITY ASSEMBLY PLANTS.THESE VEHICLES COULD HAVE INCORRECTLY MANUFACTURED AUTOMATIC TRANSMI... Read more

RQ, Closed , Model Year: 1997

ICE FORMATION IN THE THROTTLE BODY

There is no summary currently available

EA, Closed , Model Year: 1997

WHEEL SEPARATION

BY LETTER DATED MAY 6, 1998, THE MANUFACTURER ADVISED NHTSA OF ITS DECISION TO INITIATE A SAFETY RECALL OF APPROXIMATELY 1,520,000 OF THE SUBJECT VEHICLES, INCLUDING F-250 LIGHT DUTY TRUCKS, AND NAVIGATOR VEHICLES BUILT AT THE NORFOLK, MICHIGAN TRUCK, KANSAS CITY, AND ONTARIO TRUCK ASSEMBLY PLANTS B... Read more

PE, Closed , Model Year: 1997

WHEEL SEPARATION FROM VEHICLE

IN ADDITION TO THE A FAILURE REPORT TABULATIONS GIVEN ABOVE, THE MANUFACTURER REPORTED THAT AN ADDITIONAL 33 OWNER AND FIELD REPORTS HAVE BEEN FILED WHICH REFER TO PROBLEMS (LUG NOT TORQUE LOSS, LUG BOLT FRACTURE) THAT DID NOT INVOLVE ACTUAL WHEEL SEPARATION, BUT WHICH MAY BE POTENTIALLY RELEVANT EV... Read more

PE, Closed , Model Year: 1997

FAILURE TRANSMISSION PARK ENGAGEMENT/LOC

BY LETTER DATED SEPTEMBER 4, 1997, THE MANUFACTURER ADVISED NHTSA THAT A SAFETY-RELATED RECALL ACTION WOULD BE INITIATED TO CORRECT A POTENTIAL FAILURE OF THE TRANSMISSION SHIFT CABLE IN APPROXIMATELY 15,000 OF THE SUBJECT VEHICLES.THE SUSPECT CABLES WERE SUPPLIED TO FORD BY TELEFLEX AUTOMOTIVE AND ... Read more

EA, Closed , Model Year: 1997

SEAT BELT ANCHORAGE SEPARATION

FORD NOTIFIED ODI THAT THEY ARE CONDUCTING A RECALL TO INSPECT AND, AS NECESSARY, REPAIR THE SEAT BELT ANCHORAGE ATTACHMENTS ON 1997 FORD F150 VEHICLES BUILT FROM THE BEGINNING OF PRODUCTION THROUGH APRIL OF 1996.ODI'S DATABASE CONTAINS ONE COMPLAINT ALLEGING THE CENTER FRONT SEAT BELT ANCHORAGE WAS... Read more

PE, Closed , Model Year: 1997

SEAT BELT ANCHORAGE SEPARATION

ODI'S DATABASE CONTAINS ONE COMPLAINT ALLEGING THE CENTER FRONT SEAT BELT ANCHORAGE WAS NOT BOLTED TO THE FLOOR.FORD SUBMITTED 28 ADDITIONAL FIELD REPORTS AND WARRANT CLAIMS ALLEGING THAT A SEAT BELT WAS NOT BOLTED TO THE FLOOR, NOT ATTACHED, NOT HOOKED UP, OR THE OWNER COMPLAINTED THAT THE SEAT BEL... Read more

FORD F-150 - All Years Overview

Complete safety history for the FORD F-150 across all model years (1991, 2026).

422 Total Recalls

48,023 Total Complaints

30 Investigations

2,379 Reported Crashes

2,374 Reported Fires

86 Reported Deaths

FORD F-150 - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2026	1	15	View
2025	12	169	View
2024	10	269	View
2023	12	591	View
2022	23	824	View
2021	29	1,329	View
2020	11	909	View
2019	9	1,704	View
2018	19	2,864	View
2017	18	1,822	View
2016 (current)	14	2,581
2015	14	2,227	View
2014	8	1,943	View
2013	3	3,960	View
2012	4	2,444	View
2011	6	2,979	View
2010	1	1,136	View
2009	2	400	View
2008	1	456	View
2007	7	625	View
2006	14	742	View
2005	14	1,364	View
2004	16	2,431	View
2003	11	527	View
2002	10	965	View
2001	19	1,451	View
2000	17	1,274	View
1999	18	1,323	View
1998	18	1,624	View
1997	26	3,285	View
1996	7	383	View
1995	7	788	View
1994	13	908	View
1993	13	753	View
1992	9	553	View
1991	6	357	View
1990	0	25	View
1989	0	19	View
1987	0	2	View
1984	0	2	View

Other FORD Models

Model	Recalls	Complaints
MUSTANG	1,104	11,600	View
RANGER	928	10,371	View
F-350 SD	776	2,363	View
F-450 SD	692	624	View
F-250 SD	638	3,635	View
EXPLORER	624	42,549	View
F-550 SD	578	603	View
EXPEDITION	555	11,534	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2016 FORD F-150

Complaint Statistics

Top Reported Components

Technical Service Bulletins, 2016 FORD F-150

Most Affected Components

NHTSA Safety Investigations, FORD F-150

FORD F-150 - All Years Overview

FORD F-150 - Year by Year

Other FORD Models