2015 CHEVROLET SUBURBAN

11 recalls, 589 complaints - 3,407 TSBs

POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)

Defect Description

General Motors, LLC (GM) is recalling certain 2026 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, and GMC Sierra 1500, Yukon, and Yukon XL vehicles with four-wheel (4WD) or all-wheel drive (AWD), and certain 2015-2020 Suburban, Escalade, Escalade ESV, Yukon, Yukon... Read more

Consequence

Front or rear wheel lockup increases the risk of a crash.

Remedy

Owners are advised not to drive their vehicle until the remedy is completed. Dealers will inspect and, if necessary, replace the transfer case assembly, free of charge. Owner notification letters were mailed May 18, 2026. Owners may contact GMC customer service at 1-800-462-8782, Chevrolet customer ... Read more

66 vehicles affected

Manufacturer: General Motors, LLC

ELECTRONIC STABILITY CONTROL (ESC)

Defect Description

General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is tra... Read more

Consequence

Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.

Remedy

GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.

652,967 vehicles affected

Manufacturer: General Motors LLC

SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM

Defect Description

General Motors LLC (GM) is recalling certain 2015-2017 Cadillac Escalade, 2014-2018 Chevrolet Silverado, GMC Sierra, 2015-2018 Chevrolet Suburban, Tahoe, GMC Yukon vehicles. The amount of vacuum created by the vacuum pump may decrease over time.

Consequence

As the vacuum level drops, the brake assist decreases, increasing braking effort, extending the distance required to stop the vehicle, thereby increasing the risk of a crash.

Remedy

GM will notify owners, and dealers will reprogram the Electronic Brake Control Module, free of charge. The recall began October 8, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438, Cadillac customer service at 1-800-458-8006 or GMC customer service at 1-800-462-8782. GM's num... Read more

3,456,719 vehicles affected

Manufacturer: General Motors LLC

STEERING:ELECTRIC POWER ASSIST SYSTEM

Defect Description

General Motors LLC (GM) is recalling certain 2015 Chevrolet Silverado 1500, Tahoe and Suburban, GMC Sierra 1500 and Yukon, and Cadillac Escalade vehicles. Electric power steering (EPS) assist may be lost momentarily, followed by a sudden return of EPS assist.

Consequence

If EPS assist is lost and then suddenly returns, the driver may have difficulty steering the vehicle, especially at low speeds, increasing the risk of a crash.

Remedy

GM will notify owners, and dealers will update the EPS module software, free of charge. The recall began October 12, 2018. Owners may contact Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020 and GMC customer service at 1-800-462-8782. GM's number for this ... Read more

1,015,918 vehicles affected

Manufacturer: General Motors LLC

AIR BAGS:FRONTAL

Defect Description

General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Subur... Read more

Consequence

A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.

Remedy

GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadi... Read more

40,683 vehicles affected

Manufacturer: General Motors LLC

AIR BAGS:FRONTAL

Defect Description

General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Poli... Read more

Consequence

A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.

Remedy

GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Ca... Read more

3,640,162 vehicles affected

Manufacturer: General Motors LLC

ELECTRICAL SYSTEM:IGNITION

Defect Description

General Motors LLC (GM) is recalling certain model year 2014-2015 Chevrolet Silverado and GMC Sierra trucks manufactured January 24, 2014, to February 26, 2014, 2015 Chevrolet Suburban vehicles manufactured February 12, 2014 and Chevrolet Tahoe vehicles manufactured February 6, 2014, to February 13,... Read more

Consequence

If stuck in the "Start" position, the ignition may suddenly snap back into the "Accessory" position, causing a loss of engine, steering, and braking power, increasing the risk of a vehicle crash. If the vehicle is in a crash, the air bags may not deploy, increasing the risk of occupant injury.

Remedy

GM will notify owners, and dealers will replace the ignition lock housing, free of charge. The recall began on November 20, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 15573.

3,073 vehicles affected

Manufacturer: General Motors LLC

STEERING:ELECTRIC POWER ASSIST SYSTEM

Defect Description

General Motors LLC (GM) is recalling certain model year 2015 Chevrolet Silverado, Suburban, Tahoe, GMC Sierra, and Yukon XL vehicles, equipped with electric power steering (EPS). Due to a problem with the EPS module, the affected vehicles may experience a sudden loss of power steering assist during... Read more

Consequence

An unexpected loss of power steering increases the risk of a crash.

Remedy

GM will notify owners, and dealers will replace the power steering assist motor kit, free of charge. The recall began on November 17, 2014. Owners may contact GM customer service at 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14743.

679 vehicles affected

Manufacturer: General Motors LLC

AIR BAGS:SIDE/WINDOW

Defect Description

General Motors LLC (GM) is recalling certain model year 2015 Chevrolet Suburban, Suburban LTZ, Tahoe, Tahoe LTZ, GMC Yukon, and Yukon XL Denali vehicles manufactured on May 13, 2014. The affected vehicles were assembled with a roof rail air bags (RRAB) that were not reinforced at the points were th... Read more

Consequence

During deployment, the RRAB may be punctured or torn by the roof carrier hardware, reducing its performance and increasing the risk of occupant injury in the event of a crash.

Remedy

GM will notify owners, and dealers will replace the roof carrier attaching hardware, free of charge. The recall is expected to begin in early September 2014. Owners may contact GM customer service at 1-800-222-1020 (Chevrolet) or 1-800-462-8782 (GMC). GM's number for this recall is 14359.

22 vehicles affected

Manufacturer: General Motors LLC

POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)

Defect Description

General Motors LLC (GM) is recalling certain model year 2014-2015 Chevrolet Silverado and GMC Sierra vehicles, and model year 2015 GMC Yukon and Chevrolet Suburban and Tahoe vehicles. In the affected vehicles, an electrical signal short may cause the transfer case to shift to neutral without the dr... Read more

Consequence

If the transfer case switches to neutral while the vehicle is parked and the parking brake is not in use, the vehicle may roll away increasing the risk of injury to bystanders. If the transfer case switches to neutral while the vehicle is being driven, the vehicle would lose drive power, increasing... Read more

Remedy

GM will notify owners, and dealers will re-program the software in the transfer case control module, free of charge. The recall began in early August 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 141... Read more

392,459 vehicles affected

Manufacturer: General Motors LLC

POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES

Defect Description

General Motors LLC (GM ) is recalling certain model year 2014 Chevrolet Silverado Light Duty Regular Cab, Double Cab, and Crew Cab 1500 series and model year 2015 Suburban and Tahoe; GMC model year 2014 Sierra Regular Cab, Double Cab, and Crew Cab 1500 Series and model year 2015 Yukon and Yukon XL v... Read more

Consequence

If the line is not securely seated and transmission oil leaks from the fitting, the oil could contact a hot surface and cause a vehicle fire.

Remedy

GM will notify owners, and dealers will inspect the transmission oil cooler line connection and repair the vehicles, as needed, free of charge. The recall began on May 19, 2014. Owners may contact Chevrolet at 1-866-694-6546 or GMC owners may contact GMC at 1-866-996-9463. GM's number for this re... Read more

489,936 vehicles affected

Manufacturer: General Motors LLC

Complaint Statistics

589 total complaints 34 crashes 13 fires 37 injuries 4 deaths

Top Reported Components

Component	Complaints
SERVICE BRAKES	137
ELECTRICAL SYSTEM	60
STEERING	57
UNKNOWN OR OTHER	57
ENGINE	39
POWER TRAIN	35
STRUCTURE:BODY	31
SUSPENSION	29
FUEL/PROPULSION SYSTEM	27
ELECTRONIC STABILITY CONTROL (ESC)	22

Incident date: Jul 18, 2026

Vehicle Component Affected: ELECTRICAL SYSTEM / FORWARD COLLISION AVOIDANCE / BACK OVER PREVENTION Description of the Safety Defect: The factory infotainment touchscreen in my 2015 Subaru Outback Limited (VIN: [XXX]) has suffered a severe manufacturing defect where the internal chemical gel adhesiv... Read more

Incident date: May 15, 2026

I was parked in front of my townhouse I have a witness who saw me at a stop. Next thing I know car accelerates and hits my townhouse. I did not accelerate I was not speeding and I have a witness who saw me stopped

Crash

Incident date: May 29, 2026

I’ve learned a while ago that the vehicle doesn’t have a working horn, I’ve replaced the fuse at least five times and it’s still not working. Yes the car was sold to me this way. Also I’ve been getting this warning to my ford app: “The Blind Spot Information System (BLIS)/Cross Traffic ... Read more

Incident date: Apr 20, 2026

I was traveling on the freeway at approximately 65 miles per hour. I slowed to approximately 50 miles per hour to pass a disabled vehicle and began accelerating again when the dash displayed a message that said "Stop Safely- Vehicle will Shut off soon" the check engine light, a red turtle light als... Read more

Incident date: Mar 23, 2026

The contact owns a 2024 Alliance Valor RV. The contact stated that the lithium 12-Volt battery failed to charge, and the battery warning light was flashing. The error codes 01 and 08 were displayed indicating a temperature overload. Upon inspection, the contact discovered that the 12-Volt Lithium ba... Read more

Incident date: Feb 21, 2026

I had my car to a reliable mechanic who informed me of open recalls on my vehicle. The next morning, while I was driving, the engine started making a noise and I called a local Kia dealership. I was making arrangements to bring the car in for them to look at when the car stalled, and I got to the si... Read more

Fire

Incident date: Jan 17, 2026

We turned the car on and got an ACC, LKAS, FCS, AHL errors due to the front sensor and the camera failing. This is an issue that many Honda owners are dealing with. The issue will not allow you to use cruise control and will disable 90% of the safety features we bought this vehicle for. The car driv... Read more

Incident date: Jan 17, 2026

Incident date: Mar 3, 2025

Refer to Mercedes Complaint letter dated August 21, 2025. Refer to EDR report of the crash Mercedes Benz is claiming no responsibility for the failure of Active Brake Assist (ABA) during a frontal impact collision that resulted in the car total loss. The sensors also didn't work resulting in no aler... Read more

Crash

Incident date: Mar 3, 2025

Crash

Incident date: Aug 21, 2025

The automatic braking system is activating automatically without any warning or any interference even though there is no vehicle or object in front it is happening all of a sudden and it a serious safety hazard and could cause major accident it is life threatening and I am very scared to drive it a ... Read more

Incident date: Dec 15, 2025

The start stop system has failed to restart at a busy traffic light more than half a dozen different times after a 1 hour drive. Short drives do not bring this issue out. This got me stuck at a light, drivers annoyed honking and confused as I try to get my vehicle to start again. Turning the van ... Read more

Incident date: Nov 28, 2025

Water erosion to the wiring harness to the front headlights led to an outage of the LEDs on glad of the vehicle.

Incident date: Nov 28, 2025

What component or system failed or malfunctioned, and is it available for inspection upon request? The Engine failed in a matter of seconds on the Interstate to where the vehicle was inoperable making a loud knocking sound and every system light on the dashboard turned on. We were able to take it t... Read more

Incident date: Nov 1, 2025

The contact owns a 2003 Volkswagen Passat. The contact stated while driving at an undisclosed speed, the vehicle stalled. There were no warning lights illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that the fuel pump needed to be replaced. The manufacturer wa... Read more

Incident date: Nov 15, 2025

Shortly after powering on the GHHM vehicle, driving a short distance, coming to a stop and depressing the accelerator the vehicle does not accelerate as though no power is getting to the drive train. This does not often happen but has always happened when the EV battery level is 3 bars or less and t... Read more

Incident date: Oct 19, 2025

The display screen for the back up camera, heating/cooling, radio, and all other settings has stopped functioning. The screen comes on, but with flashing static lines in the screen instead of the proper display. This makes it very hard to reverse at night, and downright dangerous... the screen can't... Read more

Incident date: Dec 31, 2023

The back up camera will randomly black out. The steering wheel motor is broke and the steering wheel does not adjust. Needed a new air conditioner motor, timing chain, had a transmission leak, wheel axel leak. This is a safety hazard and caused a huge financial strain.

Incident date: Mar 15, 2019

I’m reporting a safety issue with my 2019 Toyota RAV4 that has recently started and is getting worse. The problem seems related to the start-stop system or something in the powertrain. When I come to a stop—at a stop sign, red light, or roundabout—the car doesn’t always respond normally when... Read more

Incident date: Aug 6, 2025

drivers side second row captain seat makes ticking noise under the seat. if I put weight on seat it stops. it is intermittent. Im concerned it might be electrical. I have a video but unable to download. I can send if there is an email to send to.

Incident date: Jun 26, 2025

The check engine light came on in my car. I was waiting for the dealer to call me to fix it for the 3rd time. I was on my way home when every electrical option on the vehicle turned on- wipers, lights, dash lights, brake- which caused the car to brake- then it turned off and I had no brakes, the car... Read more

Crash

Incident date: Jun 26, 2025

The contact owns a 2013 Ford Edge. The contact stated while driving at an undisclosed speed, the ABS and traction control warning lights illuminated. The vehicle was taken to the dealer where it was diagnosed with ABS module failure. The contact was informed that the ABS module needed to be replaced... Read more

Incident date: May 17, 2025

Excessive oil consumption

Incident date: May 17, 2025

Engine blew a rod without warning or service light indication. The vehicle is available for inspection. My two children and I were put at risk due to the nature of the engine failure and being able to safely navigate the vehicle off of the highway. The vehicle was inspected by the mechanic of the sh... Read more

Incident date: May 12, 2025

The contact owns a 2015 Ford Flex. The contact stated while driving at an undisclosed speed, the back-over prevention camera did not function as intended. The contact stated that the back-over prevention camera displayed an upside-down image. In addition, the contact stated that the back-over preve... Read more

Incident date: Jan 15, 2022

Vehicle fail breaks malfunction. No response to the brakes. Push many times no break response vehicle hit vehicle in front of it could not be avoided That rotors are less than one year old there about six or 7000 miles on them. They are basically new new tires car will maintain no lights on dash no... Read more

Crash

Incident date: Jan 15, 2022

I was driving at freeway speeds on the interstate when I hit a divot in the pavement. My truck started shaking violently and I could barely control the steering and/or hold onto the steering wheel. When I applied the brakes, the issue worsened. I was finally able to find a spot to pull off. The shak... Read more

Incident date: Jan 15, 2022

I had the fuel pump recall (NHTSA ID 24V-113) performed on my 2019 Honda CBR600RR at a certified dealership. After the repair, I discovered multiple serious safety issues that made the motorcycle significantly more dangerous than it was before the recall: The fuel tank vent line was crushed und... Read more

Incident date: Apr 20, 2025

An independent service center confirmed that the water pump failed and fell apart. This water pump is a 4-groove pulley (part number 12685259) specific to my vehicle. Most other Silverados have a 6-groove pulley system. This 4-groove pulley water pump is unavailable from the dealer or any of the pa... Read more

Incident date: Feb 16, 2025

Unknown, Electric steering no longer works, ABS light, traction control light engine light air bag light and tool light are on the, brakes will be faulty at times mainly when ABS and traction control light turn on. There is Google fact that 2008 Mazda had recall for EPS, also faulty air bag and more... Read more

Incident date: Jan 21, 2025

noticed my engine sounded different, its a 2022 and i owned it for 1.5 years, i was taking it to the dealer for a oil change anyways, when i was there i asked them to through ears on it, they called me a hour later trying to explain it was due to the cold air (15-20 degrees) and the 6.2l uses 93 gas... Read more

Incident date: Dec 16, 2024

Driver side view mirror shakes while driving making it unsafe to use the mirror to make s lane change. Nissan corporate refusing to fix the issue, they say it's normal.

Incident date: Dec 17, 2024

The contact owns a 2024 Honda HR-V. The contact received notification of NHTSA Campaign Number: 24V744000 ( STEERING) however, the part to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aw... Read more

Incident date: Dec 17, 2024

The contact owns a 2018 Ford Escape. The contact stated while driving at approximately 10 MPH, the "Engine Overheated" message was displayed on the instrument panel, and the vehicle shut down. The vehicle failed to return to normal operation. No warning light was illuminated. The vehicle was towed t... Read more

Incident date: Dec 13, 2024

The contact owns a 2016 Acura TLX. The contact received notification of NHTSA Campaign Number: 23V751000 (Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. T... Read more

Incident date: Dec 8, 2024

When I attempt to fill my 2022 Ram 1500 (55,000 Miles) with gas the valve at the base of the tank (part of the evap system) prevents it from taking gas. The dealership told me it was a safety issue (no kidding) and I needed a new fuel tank. As it turns out this is a really common issue with these ... Read more

Incident date: Dec 8, 2024

The display which provides all vehicle information as well as guidance malfunctions (pixelates). Volkswagen acknowledges a faulty display chip is the cause. The dealer has updated software and even replaced the display with no success. I notified the dealer about the replaced display and he advis... Read more

Incident date: Jul 1, 2013

Flex Fuel Extended Crank when engine is cold. Have had into dealer multiple times and fix is temporary. Known issue with flex fuel Tundras that keeps returning

Incident date: Oct 19, 2024

The contact's wife owns 2022 Toyota Highlander Hybrid. The contact stated that while his wife was driving 70 MPH, the vehicle shut off with the "Maintenance Required Visit Your Dealer" message displayed. The contact’s wife restarted the vehicle and immediately pulled over to the shoulder. Despite ... Read more

Incident date: Oct 12, 2024

The 12v battery powering the electrical system failed. This caused the vehicle to stop unexpectedly in the middle of a busy street worth traffic on either side of the vehicle. All attempts to restart the vehicle resulted in an error stating the electrical system has failed. The problem was reprod... Read more

Incident date: Oct 12, 2024

Upper bumper flew off driving on the highway

Incident date: Aug 5, 2024

Vehicle purchased 10.31.2023 at Volkswagen Jackson (Ritchey Automotive) in Jackson, Mississippi. During the course of normal vehicle operation, multiple Travel Assist system failures and alerts as documented within Volkswagen Technical Service Bulletin 2070207/1 occur. Three repair attempts have pre... Read more

Incident date: Sep 11, 2024

Whenever I drive long distance like 1 or more hours, AC has problem. It worksd fine in short local distance. I see a lot of drivers have the same issue if you click the link below. During the hottest season, it can become very dangerous. I live in San Angelo, TX, and there is no Genesis dealership i... Read more

Incident date: Aug 29, 2024

I had a series of concerning incidents with my car. The trunk door was getting stuck halfway, but I was able to close it after turning on the engine. I also encountered a malfunction error on the backup camera, a Drive Train warning sign, and the car alarm going off by itself. The most alarming issu... Read more

Fire

Incident date: Aug 29, 2024

Fire

Incident date: Jul 2, 2024

Tire size P 235/45 R 18 Factory installed on 2024 Toyota Camry, failed catastrophically at 3415 (+/- 5) miles. Vehicle was traveling eastbound on I-40 in Knoxville, TN, when the tread separated completely after bilateral failure of the sidewalls about 2" from the beads. Car stability and control we... Read more

Incident date: Jun 7, 2022

The contact owns a 2015 Ford F-150. The contact stated that while his son was driving at an undisclosed speed, white smoke was coming from the base of the driver's seat belt clip. The contact stated that the air bags warning light illuminated with a message that the driver's side door was opened; ho... Read more

Incident date: Jun 30, 2024

The contact owns a 2017 Ford Fusion. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed with coolant intrusion into the engine. The contact was informed that the engine needed to be replace... Read more

Showing 50 of 589 complaints.

Technical Service Bulletins, 2015 CHEVROLET SUBURBAN

3,407 manufacturer communications from 1949 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
350000 EQUIPMENT	408
110000 ELECTRICAL SYSTEM	344
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL	253
060000 ENGINE (PWS)	208
060000 ENGINE AND ENGINE COOLING	208
356000 EQUIPMENT ADAPTIVE/MOBILITY	134
353000 EQUIPMENT:ELECTRICAL	125
353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.	123

200000 WHEELS

This service bulletin provides information for dealers/technicians on Tire Radial Force Variation (RFV).

350000 EQUIPMENT

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

110000 ELECTRICAL SYSTEM

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

350000 EQUIPMENT

This bulletin updates the position of General Motors on refinishing aluminum wheels. GM has determined that wheel refinishing under warranty will no longer be performed.

200000 WHEELS

This bulletin updates the position of General Motors on refinishing aluminum wheels. GM has determined that wheel refinishing under warranty will no longer be performed.

110000 ELECTRICAL SYSTEM

This bulletin provides information for electrical ground repairs using new General Motors replacement fasteners with conductive finish.

160000 STRUCTURE

This preliminary informational bulletin provides frame coating repair information to correct a customer concern of wax coating on frame peeling, metal shows corrosion/rusting (U.S. and Canada Only).

110000 ELECTRICAL SYSTEM

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

350000 EQUIPMENT

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

118000 ELECTRICAL SYSTEM:SOFTWARE

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

160000 STRUCTURE

This preliminary informational bulletin provides frame coating repair information to correct a customer concern of wax coating on frame peeling, metal shows corrosion/rusting (U.S. and Canada Only).

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information on submitting quality Photos of Various Vehicle Concerns to the GM Technical Assistance Center (TAC).

060000 ENGINE AND ENGINE COOLING

This service bulletin advises the technician of possible coolant entering the areas of the engine, either through failed parts or defects in the castings, that may be the cause of the concerns related to the MIL or the engine running rough.

060000 ENGINE AND ENGINE COOLING

This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels shou

350000 EQUIPMENT

This warranty administration bulletin provides policy information for GM courtesy transportation and roadside assistance programs.

350000 EQUIPMENT

This Warranty Administration bulletin provides information on Dealer Empowerment for Goodwill, Customer Enthusiasm and Policy (U.S. Only).

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information on All hazmat parts being returned to the Warranty Parts Center (WPC) must be shipped using Central Transport. Hazardous materials should never be sent by air transportation to the WPC.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Preliminary Information communication advises the technician with a tip when the vehicle stops running after it has been idling for 2.5 hours. This is normal operation of the vehicle built with regular production code BTM and without R

030000 BRAKES (PWS)

This Preliminary information communicates that when removing the fuel line jumper hose care should be taken to be sure the line is reinstalled correctly to avoid a no/low fuel pressure situation.

070000 FUEL SYSTEM, GASOLINE

This Preliminary information communicates that when removing the fuel line jumper hose care should be taken to be sure the line is reinstalled correctly to avoid a no/low fuel pressure situation.

980000 UNKNOWN OR OTHER

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.

251000 ELECTRONIC STABILITY CONTROL:AUTOMATIC (ASC)

This Preliminary Information communication provides information to the technician about vehicles that have an unwanted Stability Activation and/or a Service Stability message on the Driver Information Center. Technician may find a Diagnosti

060000 ENGINE AND ENGINE COOLING

This bulletin provides information on Engine Concerns that could result from lack of scheduled maintenance, improper service or aftermarket calibrations.

070000 FUEL SYSTEM, GASOLINE

This service bulletin provides information on the cold start control system in DI engines to reduce cold start emissions and improve fuel economy.

063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

This service bulletin provides information on the cold start control system in DI engines to reduce cold start emissions and improve fuel economy.

030000 BRAKES (PWS)

This Preliminary Information communication provides information to the technician about fluid leaking from the brake caliper piston area found during a service of the vehicle. The substance is actually excess assembly grease from the calipe

100000 POWER TRAIN

This Warranty Admin service bulletin provides guidelines for Dealers Not Required and for Dealers Required to Contact the PQC for engine or transmission assembly replacement and explains the PQC process, GWM Transaction submission, vehicle

060000 ENGINE AND ENGINE COOLING

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

This Preliminary information communicates to dealers of a known issue with failed map update

070000 FUEL SYSTEM, GASOLINE

This Preliminary Information communication provides information to the technician on how to diagnose and repair vehicles that may have rattle or ticking noise that is louder inside the vehicle than outside. The noise may also sound like a l

160000 STRUCTURE

This preliminary informational bulletin provides frame coating repair information to correct a customer concern of wax coating on frame peeling, metal shows corrosion/rusting (U.S. and Canada Only).

160000 STRUCTURE

This preliminary informational (PI) bulletin provides information to dealership personnel which may be helpful when addressing underbody component corrosion with customers.

100000 POWER TRAIN

This service bulletin advises the technician that the possible cause may not be from a faulty clutch piston or extension housing and to perform testing on transmission for other possible issues, but it still may be possible on high mileage

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.

100000 POWER TRAIN

This PI bulletin advises the technician on the proper way to install the pistons in an engine.

060000 ENGINE AND ENGINE COOLING

This PI bulletin advises the technician on the proper way to install the pistons in an engine.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Preliminary Information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. Technician will need to use Pico Oscilloscope Di

120000 EXTERIOR LIGHTING

This informational bulletin provides information for dealers/technicians on Headlamp, Tail Lamp, License Lamp or Fog/Driving Lamp Damage.

110000 ELECTRICAL SYSTEM

This preliminary information (PI) provides information om Service Programming System (SPS) Error Codes (E4398, E4399, E4403, M4404, M4413, M6954, M6955, E4414, E4423, E4491 or E6961).

350000 EQUIPMENT

This Preliminary Information communication provides information to the technician about the use of J-35616-64B terminal test probe, replacement terminals, and terminated leads. The J-35616-64B is the latest test probe released for checking

110220 ELECTRICAL SYSTEM:HAND HEATER:WIRING HARNESS

This Preliminary information communicates a GM part number for reflective high temperature heat or insulating tape when repairing wiring harnesses.

980000 UNKNOWN OR OTHER

This Preliminary information communicates a GM part number for reflective high temperature heat or insulating tape when repairing wiring harnesses.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.

350000 EQUIPMENT

This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.

350000 EQUIPMENT

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

110000 ELECTRICAL SYSTEM

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

060000 ENGINE AND ENGINE COOLING

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

020000 SUSPENSION

This Preliminary Information communication provides information to the technician about vehicles that have had multiple repair attempts that are being performed on customer?s vehicles that exhibit vibration conditions without utilizing the

010000 STEERING

This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.

020000 SUSPENSION

This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.

100000 POWER TRAIN

This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.

200000 WHEELS

This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.

200000 WHEELS

This Warranty Administration bulletin is for information on General Motors New Vehicle Tire Warranty Program (U.S. Dealers Only).

350000 EQUIPMENT

This information bulletin advises the technician the difference between a welch cap leak and the output seal of the t-case or transmission leaking ATF, causing the customer concern of a Red Fluid Leak from Center of Vehicle Located by Rear

100000 POWER TRAIN

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information on General Motors Dealership Critical Equipment Requirements and Recommendations.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides guidelines and diagnostic/repair information to technicians regarding vehicle engine oil consumption.

200000 WHEELS

This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Warranty Administration bulletin provides information on the Global Warranty Management (GWM) Warranty Parts Center (WPC) Parts Return Program.

200000 WHEELS

This Warranty Administration bulletin is for information on General Motors New Vehicle Tire Warranty Program (U.S. Dealers Only).

190000 TIRES

This Warranty Administration bulletin is for information on General Motors New Vehicle Tire Warranty Program (U.S. Dealers Only).

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information for dealers/technicians on When and How to Submit a Field Product Report (FPR) (U.S. and Canada Dealers Only).

110000 ELECTRICAL SYSTEM

This Preliminary information communicates additional information on how a LIN bus operates and diagnostic tips when working on a LIN bus.

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have hi

117100 ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER

This informational bulletin provides information for the IPC odometer programming method quick reference guide.

350000 EQUIPMENT

This informational bulletin provides information for the IPC odometer programming method quick reference guide.

110000 ELECTRICAL SYSTEM

This informational bulletin provides information for the IPC odometer programming method quick reference guide.

350000 EQUIPMENT

This bulletin provides information on Warranty Administration a?? Required Operating Procedures - 8 Points (U.S. Only).

100000 POWER TRAIN

This Technical bulletin provides a repair to correct a condition of Shudder/Surging While Driving.

060000 ENGINE AND ENGINE COOLING

This service bulletin explains the difference in oil filters for gas engines with new oil pump control systems and the possibilities of what may happen using the incorrect filter.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This bulletin provides information on Warranty Administration a?? Required Operating Procedures - 8 Points (U.S. Only).

100000 POWER TRAIN

The service bulletin advises the tech of a normal transmission shift condition and the delay in throttle response when the throttle plate is opened rapidly and advises the customer that it is normal for the delay.

060000 ENGINE AND ENGINE COOLING

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Warranty Administration service bulletin provides information for dealers/Service advisors on when and how to submit a Pre-Repair Authorization (PRA).

060000 ENGINE AND ENGINE COOLING

This Preliminary Information communication provides information to the technician of a complaint of a sag or hesitation when accelerating. The concern is present when coasting at low speeds of less than 15 miles per hour and then aggressive

100000 POWER TRAIN

This Preliminary information communicates to the dealer technician that TAC recommends the utilization of the GDS2 software to aid in diagnosing automatic transmission concerns. TAC is requesting the GDS2 session logs be sent in before the

060000 ENGINE AND ENGINE COOLING

This service bulletin provides graphics, information and guidelines for engine component wear to assist service personnel as a guideline to perform necessary engine repairs and prevent unnecessary engine replacement.

350000 EQUIPMENT

This Warranty Administration service bulletin provides information for dealers/Service advisors on when and how to submit a Pre-Repair Authorization (PRA).

350000 EQUIPMENT

This Warranty Administration bulletin provides information on the proper use of the labor operation 0600014.

060000 ENGINE (PWS)

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

060000 ENGINE AND ENGINE COOLING

This informational bulletin advised the technician that the engine and related parts will be debited if found that the tech didn't properly prepare the engine block from dirt and debris in bolt holes or if found that the block was damaged b

110000 ELECTRICAL SYSTEM

This bulletin provides information on Engine Concerns that could result from lack of scheduled maintenance, improper service or aftermarket calibrations.

060000 ENGINE AND ENGINE COOLING

This bulletin provides information on Engine Concerns that could result from lack of scheduled maintenance, improper service or aftermarket calibrations.

010000 STEERING

This service bulletin provides technicians with updated information to help identify the differences between what is considered a fluid leak, and what is considered fluid seepage.

020000 SUSPENSION

This service bulletin provides technicians with updated information to help identify the differences between what is considered a fluid leak, and what is considered fluid seepage.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides technicians with updated information to help identify the differences between what is considered a fluid leak, and what is considered fluid seepage.

100000 POWER TRAIN

This service bulletin provides technicians with updated information to help identify the differences between what is considered a fluid leak, and what is considered fluid seepage.

350000 EQUIPMENT

This service bulletin provides information on a guide to help reduce repeat visits for the same customer concern.

070000 FUEL SYSTEM, GASOLINE

This service bulletin provides information for maintenance cleaning of the fuel injectors and gasoline detergent additive.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides information for maintenance cleaning of the fuel injectors and gasoline detergent additive.

060000 ENGINE AND ENGINE COOLING

This bulletin provides information on identifying Non-GM Engine Calibrations for Gasoline Engines using the Tech 2 or GDS 2.

060000 ENGINE AND ENGINE COOLING

This service bulletin explains how to measure for oil consumption and possible reasons for loss of oil.

110000 ELECTRICAL SYSTEM

This bulletin provides information on identifying Non-GM Engine Calibrations for Gasoline Engines using the Tech 2 or GDS 2.

100000 POWER TRAIN

This Technical bulletin provides a repair to correct a condition of Shudder/Surging While Driving.

Showing 100 of 3,407 bulletins.

NHTSA Safety Investigations, CHEVROLET SUBURBAN

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

EA, Closed , Model Year: 2000

OVERHEATED FUEL PUMP WIRING

IN A LETTER DATED APRIL 14, 2005, GENERAL MOTORS (GM) NOTIFIED ODI THAT IT HAD IDENTIFIED A DEFECT RELATED TO MOTOR VEHICLE SAFETY IN APPROXIMATELY 316,508 MODEL YEAR (MY) 2000-01 1500 SERIES CHEVROLET SUBURBAN AND GMC YUKON XL VEHICLES (RECALL 05V-155).GM DETERMINED THAT SOME OF THESE VEHICLES WERE... EQUIPPED WITH FUEL MODULE RESERVOIR ASSEMBLIES (MRAS) THAT CONTAIN FUEL PUMP WIRES AND/OR CONNECTORS THAT MAY OVERHEAT UNDER CERTAIN OPERATING CONDITIONS.ACCORDING TO GM, FUEL PUMP WIRES THAT OVERHEAT MAY RESULT IN ONE OR MORE CONDITIONS THAT PRESENT RISKS TO MOTOR VEHICLE SAFETY:(1) FUEL LEAKAGE FROM THE MRA PASS-THROUGH CONNECTOR IF THE OVERHEATING PRODUCES A HOLE IN THE PLASTIC CONNECTOR; (2) ENGINE STALL IF WIRING EXPOSED BY THE OVERHEATING SHORTS TO GROUND AND CAUSES THE FUEL PUMP FUSE TO BLOW; OR (3) INACCURATE FUEL LEVEL READINGS IF OVERHEATED WIRING IS SHORTED TO THE FUEL LEVEL SENDER CARD.GM'S ANALYSIS IDENTIFIED THE CAUSE OF THE OVERHEATED WIRING AS A HIGH-RESISTANCE CONDITION IN THE MRA CONNECTOR CONTACTS DUE TO FRETTING CORROSION THAT MAY DEVELOP OVER TIME.GM DETERMINED THAT THE CORROSION IS CAUSED BY MOVEMENT BETWEEN THE CONTACT SURFACES AND THAT SUCH MOVEMENT IS PRIMARILY INFLUENCED BY CHASSIS AND FUEL TANK VIRBRATION CHARACTERISTICS.GM'S TESTING FOUND THAT THE FUEL TANK VIBRATION CHARACTERISTICS OF THE RECALLED MY 2000-01 1500-SERIES VEHICLES WERE SIGNIFICANTLY GREATER THAN IN OTHER GM VEHICLES EQUIPPED WITH THE SAME MRA CONNECTORS.THESE VEHICLES HAD THE HIGHEST RATE OF RELATED FUEL LEAK AND STALL COMPLAINTS; AND A RECENT SURVEY CONDUCTED BY GM FOUND EVIDENCE OF MRA WIRING OVER-HEATING IN ALMOST ONE-THIRD OF THE 1500-SERIES VEHICLES INSPECTED. OTHER VEHICLES EQUIPPED WITH THE SUBJECT MRA CONNECTOR AND EVALUATED DURING THIS INVESTIGATION INCLUDE APPROXIMATELY 33,000 MY 2000-01 2500-SERIES SUBUBRAN AND YUKON XL VEHICLES, WHICH FALL WITHIN THE SCOPE OF EA04-026, AND PEER POPULATIONS OF SHORT WHEELBASE YUKON AND TAHOE UTILITY VEHICLES AND FULL-SIZE SILVERADO AND SIERRA PICKUP TRUCKS. THESE VEHICLES ARE NOT INCLUDED IN RECALL 05V-155 FOR THE FOLLOWING REASONS:(1) THESE VEHICLES ARE EQUIPPED WITH FUEL TANKS WITH SIGNIFICANTLY LESS VIBRATION AT THE MRA INTERFACE THAN THE RECALLED VEHICLES; (2) THE POTENTIAL FOR FUEL LEAKAGE IS SUBSTANTIALLY LOWER IN THE PICKUP TRUCKS AND SHORT-WHEELBASE UTILITY VEHICLES DUE TO DIFFERENCES IN FUEL TANK CONFIGURATION AND NO INCIDENTS OF FUEL LEAKAGE DUE TO OVERHEATED WIRING WERE VERIFIED IN THESE VEHICLES; (3) THERE THERE HAVE BEEN ONLY THREE POTENTIALLY RELATED COMPLAINTS OF FUEL LEAKAGE ASSOCIATED WITH THE OVERHEATED WIRING CONDITION IN THE 2500-SERIES LONG-WHEELBASE UTILITY VEHICLES; AND (4) NO EVIDENCE OF OVERHEATED WIRING WAS FOUND IN THE 2500-SERIES SUBURBAN AND YUKON XL VEHICLES AND PICKUP TRUCKS INSPECTED BY GM IN ITS VEHICLE SURVEY EFFORTS AND THE RATE FOUND IN THE SHORT-WHEELBASE UTILITIES WAS LOWER THAN THE RECALLED VEHICLES BY AN ORDER OF MAGNITUDE. ODI WILL CONTINUE TO MONITOR THE EXPERIENCE IN THE 2500 SERIES MY 2000-01 LONG-WHEELBASE UTILITY VEHICLES.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS FOR THE 2500 SERIES VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY A CHANGE IN CIRCUMSTANCES.Read more

PE, Closed , Model Year: 2000

OVERHEATED FUEL PUMP WIRING

THE FUEL PUMP WIRING AND CONNECTOR MAY OVERHEAT AND MELT A HOLE IN THE TOP OF THE FUEL PUMP MODULE.POSSIBLE CONSEQUENCES INCLUDE FUEL TANK LEAKAGE AND ENGINE STALL WITH NO RESTART.FOURTEEN OF THE 20 COMPLAINTS TO ODI ALLEGE FUEL TANK LEAKAGE, INCLUDING ONE THAT REPORTED THAT A FIRE DEPARTMENT WAS CA... LLED TO THE SCENE AFTER A POOL OF GASOLINE WAS DISCOVERED BENEATH THE VEHICLE.MOST OF THE ODI COMPLAINTS REPORT INCIDENTS THAT OCCURRED WITHIN THE PAST YEAR. ACCORDING TO GM, FUEL LEAKAGE CAN OCCUR IN THE SUBJECT VEHICLES IF THE HEAT IS SUFFICIENT TO MELT A HOLE IN THE PLASTIC CONNECTOR LARGE ENOUGH FOR LIQUID FUEL TO FLOW THROUGH.ON-BOARD EMISSIONS DIAGNOSTICS MAY DETECT HOLES THAT ARE APPROXIMATELY 0.040 INCHES OR MORE AND SET A SERVICE ENGINE SOON WARNING LIGHT.THE CONNECTOR POSITION IN THE SUBJECT VEHICLES IS BELOW THE FUEL LEVEL WHEN THE TANK IS FULL.WHILE GM DOES NOT KNOW HOW MUCH FUEL COULD LEAK FROM A TANK WITH A MELTED FUEL PUMP CONNECTOR, SEVERAL CONSUMERS HAVE REPORTED SIGNIFICANT LEAK EVENTS.ENGINE STALL CAN OCCUR IF:(1) A SHORT OCCURS IN THE PUMP WIRING (BARE WIRE EXPOSED BY MELTED INSULATION SHORTS AGAINST A GROUND OR GROUND WIRE) AND THE FUEL PUMP RELAY FUSE IS BLOWN; OR (2) THE VEHICLE RUNS OUT OF FUEL DUE TO AN INACCURATE FUEL GAUGE READING RESULTING FROM AN ELECTRICAL SHORT BETWEEN THE FUEL PUMP WIRING AND THE LEVEL SENSOR WIRING. GM'S ANALYSIS OF FIVE ASSEMBLIES RETURNED FROM INCIDENT VEHICLES DETERMINED THAT THE CONDITION IS CAUSED BY ELEVATED RESISTANCE/ ARCING AT THE MRA UNDERCOVER B CAVITY TERMINAL OF THE FOUR-WAY 150 METRI-PAK CONNECTOR.GM ATTRIBUTES THE HIGH RESISTANCE AND ARCING TO A DEPRESSED CONTACT ARM AT THE 150 METRI-PAK B CAVITY FEMALE TERMINAL.GM IS CONTINUING ITS INVESTIGATION TO COMPLETE ITS ROOT CAUSE ANALYSIS. MODULAR RESERVOIR ASSEMBLIES USING THE 150 METRI-PAK CONNECTORS WERE USED BY GM IN SEVERAL MILLION C/K-SERIES SPORT UTILITY VEHICLES AND PICKUP TRUCKS FROM MY 1997 THROUGH 2002, WHEN GM RELEASED A METAL MRA COVER AND A 280 METRI-PAK CONNECTOR IN THE SUBJECT VEHICLES.DURING PE04-042, ODI COLLECTED INFORMATION FROM GM CONCERNING MY 2000-2002 C/K SUV'S AND PICKUP TRUCKS.THE SUBJECT VEHICLES COMPRISE APPROXIMATELY 9 PERCENT OF PRODUCTION FOR THOSE VEHICLES AND ABOUT 39 PERCENT OF COMPLAINTS TO GM. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT IN GM C/K-SERIES VEHICLES.Read more

EA, Closed , Model Year: 1995

BATTERY LEAKS ACID

There is no summary currently available

DP, Open , Model Year: 1993

OEM HITCH RECEIVER PLATFORM CRACKING

THE PETITION ALLEGES THAT CRACKS IN THE HITCH RECEIVER PLATFORM MAY LEAD TO SEPARATION OF THE TRAILER AND LOSS OF STEERING CONTROL

EA, Closed , Model Year: 1997

ERRATIC POWER STEERING ASSIST WHILE DRIV

THE OFFICE OF DEFECT INVESTIGATION (ODI) HAS INVESTIGATED ALLEGATIONS OF POWER STEERING ASSIST FLUCTUATIONS IN THE SUBJECT VEHICLES.FOR DETAILS AND A BASIS FOR THE INVESTIGATION CONCLUSIONS, PLEASE SEE THE CLOSING REPORT IN THE EA99-011 PUBLIC FILE.ODI HAS NOT IDENTIFIED A SAFETY-RELATED DEFECT TREN... Read more

PE, Closed , Model Year: 1994

DRIVERS SEAT FAILURE

THE COMPLAINANTS ALLEGE THE DRIVERS SEAT MOUNTING FAILS, ALLOWING THE SEAT TO MOVE OR TIP REARWARD INTO A RECLINED POSITION.

PE, Closed , Model Year: 1995

UNDERSEAT VEHICLE FIRES

ALLEGED SHORTING OF WIRE FOR POWER SEAT CAUSES UNDERSEAT FIRE.

EA, Closed , Model Year: 1992

POOR BRAKE PERFORMANCE

POOR PERFORMANCE OF ABS BRAKES

DP, Closed , Model Year: 1984

POOR BRAKING ON PANIC STOP

CHEVROLET SUBURBAN - All Years Overview

Complete safety history for the CHEVROLET SUBURBAN across all model years (1981, 2024).

178 Total Recalls

10,625 Total Complaints

9 Investigations

810 Reported Crashes

188 Reported Fires

20 Reported Deaths

CHEVROLET SUBURBAN - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2024	1	55	View
2023	3	159	View
2022	4	167	View
2021	12	256	View
2020	4	64	View
2019	3	102	View
2018	4	111	View
2017	5	186	View
2016	6	301	View
2015 (current)	11	589
2014	3	77	View
2013	4	170	View
2012	4	139	View
2011	3	193	View
2010	3	161	View
2009	5	133	View
2008	4	276	View
2007	4	359	View
2006	1	33	View
2005	7	161	View
2004	6	265	View
2003	7	361	View
2002	4	352	View
2001	8	543	View
2000	11	382	View
1999	2	861	View
1998	3	299	View
1997	3	556	View
1996	4	531	View
1995	7	587	View
1994	6	1,038	View
1993	2	616	View
1992	5	226	View
1991	4	65	View
1990	4	67	View
1989	4	68	View
1988	4	35	View
1987	1	21	View
1986	0	7	View
1985	0	12	View
1984	0	6	View
1983	0	4	View
1982	1	1	View
1981	1	1	View
1979	0	1	View
1978	0	3	View
1977	0	3	View

Other CHEVROLET Models

Model	Recalls	Complaints
TAHOE	240	12,622	View
MALIBU	216	29,080	View
SILVERADO 1500	200	22,534	View
CORVETTE	187	6,308	View
CAMARO	179	4,298	View
SILVERADO	159	10,964	View
SILVERADO 3500	152	1,409	View
EXPRESS	151	838	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2015 CHEVROLET SUBURBAN

Complaint Statistics

Top Reported Components

Technical Service Bulletins, 2015 CHEVROLET SUBURBAN

Most Affected Components

NHTSA Safety Investigations, CHEVROLET SUBURBAN

CHEVROLET SUBURBAN - All Years Overview

CHEVROLET SUBURBAN - Year by Year

Other CHEVROLET Models