2000 CHEVROLET SUBURBAN

11 recalls, 382 complaints - 549 TSBs

FUEL SYSTEM, GASOLINE

Defect Description

CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CE... Read more

Consequence

THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.

Remedy

HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).

88,303 vehicles affected

Manufacturer: HONEYWELL INTERNATIONAL, INC.

EXTERIOR LIGHTING

Defect Description

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE D... Read more

Consequence

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy

PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

61,944 vehicles affected

Manufacturer: PRO-A MOTORS, INC.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

Defect Description

CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES MAY EXPERIENCE UNWANTED ANTILOCK BRAKE SYSTEM (ABS) ACTIVATION. THIS CONDITION IS MORE LIKELY TO OCCUR IN ENVIRONMENTALLY CORROSIVE AREAS. THIS RECALL WILL BE LAUNCHED IN THE "SALT BELT" STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAR... Read more

Consequence

THIS CAN CAUSE INCREASED STOPPING DISTANCES DURING LOW-SPEED BRAKE APPLICATIONS, WHICH COULD RESULT IN A CRASH.

Remedy

DEALERS ARE TO REMOVE THE WHEEL SPEED SENSOR AND THOROUGHLY CLEAN THE WHEEL SPEED SENSOR MOUNTING SURFACE ON THE BEARING, APPLY RUST INHIBITOR TO THE CLEANED SURFACE, GREASE THE MOUNTING SURFACE, REINSTALL THE WHEEL SPEED SENSOR, AND CHECK THE PEAK-TO-PEAK OUTPUT VOLTAGE TO ENSURE THE WHEEL SPEED SI... Read more

1,353,718 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Defect Description

CERTAIN TRUCKS AND SPORT UTILITY VEHICLES WERE BUILT WITH FUEL MODULE RESERVOIR ASSEMBLIES THAT CONTAIN FUEL PUMP WIRES CONNECTORS MAY OVERHEAT UNDER CERTAIN OPERATING CONDITIONS.

Consequence

IF THE IGNITION CIRCUIT WIRE IS EXPOSED, THE FUEL PUMP FUSE WILL BLOW, DISABLING THE FUEL PUMP AND CAUSING AN ENGINE STALL OR NO-START CONDITION. IF SUFFICIENT HEAT IS CONDUCTED TO THE PASS-THROUGH CONNECTOR, A HOLE IN THE CONNECTOR MAY RESULT, WHICH MAY CAUSE A 'SERVICE ENGINE SOON' LIGHT TO BE I... Read more

Remedy

DEALERS WILL REMOVE THE FUEL TANK, AND REMOVE THE MODULE RESERVOIR ASSEMBLIES FROM THE TANK, AND INSTALL A NEW SERVICE KIT FREE OF CHARGE. AN INTERIM LETTER TO OWNERS WAS MAILED ON MAY 25, 2005. THE OWNERS WERE RE-NOTIFIED ON OCTOBER 19, 2005, SINCE PARTS ARE NOW AVAILABE. OWNERS MAY CONTACT CHE... Read more

316,508 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

POWER TRAIN:DRIVELINE:DRIVESHAFT

Defect Description

SOME PICKUP TRUCKS, VANS, AND SPORT UTILITY VEHICLES EQUIPPED WITH A HYDRAULIC PUMP DRIVESHAFT THAT CAN FRACTURE, RESULTING IN IMMEDIATE LOSS OF HYDRAULIC POWER STEERING ASSIST. ON CERTAIN VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, THE SAME CONDITION CAN RESULT IN LOSS OF POWER ASSIST FOR BRA... Read more

Consequence

AN INOPERATIVE PUMP CAN CAUSE INCREASED STEERING EFFORT, AND IN HYDRO-BOOST EQUIPPED VEHICLES ALSO INCREASED BRAKING EFFORT, BUT DOES NOT COMPLETELY ELIMINATE THE ABILITY TO STEER OR SLOW THE VEHICLE.

Remedy

DEALERS WILL REPLACE THE HYDRAULIC PUMP. THE CAMPAIGN BEGAN ON FEBRUARY 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.

98,221 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

STRUCTURE

Defect Description

CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EX... Read more

Consequence

THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.

Remedy

DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-60... Read more

3,674 vehicles affected

Manufacturer: SOUTHERN COMFORT CONVERSIONS

AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE

Defect Description

ON CERTAIN PICKUP AND UTILITY TRUCKS, SOME OF THESE VEHICLES HAVE AN AIR BAG SENSING DIAGNOSTIC MODULE (SDM) WHICH CONTAINS AN ANOMALY THAT COULD RESULT IN THE DRIVER AND PASSENGER'S AIR BAG FAILING TO DEPLOY DURING CERTAIN FRONTAL CRASHES.

Consequence

IN A VEHICLE CRASH, FRONT SEAT OCCUPANTS MAY RECEIVE MORE SEVERE INJURIES.

Remedy

DEALERS WILL RECALIBRATE THE SDM ON THE AFFECTED VEHICLES. OWNER NOTIFICATION BEGAN AUGUST 28, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC... Read more

525,254 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

TIRES:TREAD/BELT

Defect Description

TIRE DESCRIPTION: WILDERNESS LE TIRES (BOTH BLACK AND RAISED WHITE LETTER TIRES) PRODUCED DURING THE WEEK OF APRIL 24, 2000 (THE SEVENTEENTH WEEK OF 2000) AT THE CUERNAVACA, MEXICO PLANT WITH TIRE SERIAL NUMBERS V672WL11700 (BLACKWALL) AND V672WL21700 (RAISED WHITE LETTERS). THESE TIRES WERE USED ... Read more

Consequence

TREAD BELT SEPARATION MAY BE NOTICED BY IRREGULAR WEAR, NOISE, OR VIBRATION. WITH CONTINUED USE, IT MAY LEAD TO COMPLETE SEPARATION OF THE TREAD/BELT PACKAGE FROM THE TIRE CARCASS, POSSIBLY RESULTING IN A VEHICLE CRASH, PERSONAL INJURY, OR DEATH.

Remedy

ON JANUARY 2, 2001, FIRESTONE MADE A PUBLIC ANNOUNCEMENT OF THE DEFECT AND THAT REPLACEMENT TIRES ARE IMMEDIATELY AVAILABLE AT NO COST TO THE CUSTOMER. REPLACEMENT TIRES ARE AVAILABLE AT EITHER THEIR LOCAL GM OR CHEVROLET DEALER OR BY THEIR LOCAL AUTHORIZED PARTICIPATING FIRESTONE RETAILER. OWNER ... Read more

8,000 vehicles affected

Manufacturer: BRIDGESTONE/FIRESTONE, INC.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

Defect Description

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES. SOME OF THESE VEHICLES HAVE A CLEARANCE CONDITION BETWEEN THE FRONT RIGHT-HAND BRAKE PIPE AND THE BODY CROSS SILL THAT COULD DECREASE TO THE POINT OF ALLOWING CONTACT DURING THE LIFE OF THE VEHICLE. IF CONTACT OCCURS AND TH... Read more

Consequence

DURING BRAKING, THE PEDAL WILL BE LOWER THAN NORMAL AND STOPPING DISTANCES WILL BE LONGER. IF THIS OCCURS WHEN STOPPING DISTANCE IS LIMITED, A CRASH COULD OCCUR.

Remedy

DEALERS WILL INSPECT THE FRONT RIGHT-HAND BRAKE PIPE FOR WEAR. IF THERE ARE SIGNS OF WEAR, THIS SECTION OF THE BRAKE PIPE WILL BE REPLACED WITH A NEW DESIGNED BRAKE PIPE SECTION. IF THERE ARE NOT SIGNS OF WEAR ON THE BRAKE PIPE, THE DEALER WILL INSTALL A SPACER CLIP TO ENSURE SUFFICIENT CLEARANCE ... Read more

1,383,922 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

STRUCTURE:BODY

Defect Description

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES. SOME OF THESE VEHICLES HAVE LOOSE OR MISSING REAR WHEELHOUSE PLUGS. UNDER CERTAIN VEHICLE OPERATING CONDITIONS, EXHAUST GASES CAN FLOW FORWARD AND ACCUMULATE IN THE REAR WHEELHOUSE.

Consequence

THESE GASES COULD FLOW INTO THE PASSENGER COMPARTMENT IF THE PLUG IS MISSING OR LOOSE AND COULD CAUSE POSSIBLE ILLNESS, UNCONSCIOUSNESS, OR DEATH.

Remedy

DEALERS WILL INSPECT THE VEHICLE FOR LOOSE OR MISSING WHEELHOUSE PLUGS AND INSTALL NEW PLUGS IF NECESSARY.

35,659 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM

Defect Description

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH VACUUM POWER, 4-WHEEL DISC BRAKES. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC BRAKE SYSTEMS." THESE VEHICLES WERE BUILT WITH A KINKED BRAKE BOOSTER VACUUM SUPPLY HOSE.

Consequence

THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 105.

Remedy

DEALERS WILL RE-ROUTE THE BRAKE BOOSTER VACUUM SUPPLY HOSE.

3,758 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

Complaint Statistics

382 total complaints 30 crashes 8 fires 37 injuries 1 deaths

Top Reported Components

Component	Complaints
PARKING BRAKE	23
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP	23
TIRES:TREAD/BELT	22
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP	20
SERVICE BRAKES	20
TIRES	16
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS	16
SERVICE BRAKES, HYDRAULIC	13
STEERING	6
VEHICLE SPEED CONTROL	6

Incident date: May 10, 2014

While driving, the car abruptly became unable to access the operational battery or to operate the vehicle.

Incident date: May 10, 2014

The contact owns a 2013 Honda Odyssey. The contact stated that the front driver's side seat heater was malfunctioning. The contact stated that upon engaging the seat heater, the seat heater was intermittently inoperable. Additionally, the contact noticed a strong burning odor inside the cabin. The v... Read more

Incident date: Jan 1, 2004

Rear glass hatch hinge separation from glass, passenger side. Vehicle was passed to me after my father passed. Unknown when the hinge separated from glass. This is a safety issue for obvious reasons.

Incident date: Nov 3, 2019

I STARTED MY SUBURBAN LIKE ANY OTHER DAY, STEP ON BRAKES TO RELEASE THE SHIFTER, PUT INTO DRIVE WITH NO PROBLEM, I WENT ONTO THE HIGHWAY AKA FREEWAY WITH NO PROBLEM, I NEEDED TO MAKE A PANIC STOP, AND THE BRAKE PEDAL WENT STRAIGHT TO THE FLOOR, TRYING TO USE THE EMERGENCY BRAKE PEDAL, THAT ALS... Read more

Crash

Incident date: Nov 15, 2004

I HAD A FLAT TIRE. WHEN I WENT TO CHANGE IT, THE SPARE TIRE HOIST WITH LOWERS THE SPARE WAS INOPERABLE AND WOULD NOT LOWER THE SPARE. HAD TO TAKE TRUCK TO DEALER. I WAS TOLD BY DEALER THAT THE MECHANISM TO LOWER THE SPARE HAD RUSTED AND HAD SEIZED AND HAD TO BE REPLACED, WHICH II DID AND PAID FOR. I... Read more

Incident date: Jun 5, 2017

TL* THE CONTACT OWNS A 2000 CHEVROLET SUBURBAN. WHILE DRIVING 20 MPH, THE VEHICLE CAUGHT ON FIRE BETWEEN THE ACCELERATOR PEDAL AND ENGINE FIREWALL. THE FIRE DEPARTMENT WAS NOTIFIED AND WAS ABLE TO EXTINGUISH THE FIRE. A FIRE REPORT WAS FILED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE CON... Read more

Fire 1 injured

Incident date: Jun 5, 2017

Fire 1 injured

Incident date: Jul 22, 2016

TL* THE CONTACT OWNS A 2000 CHEVROLET SUBURBAN. THE CONTACT STARTED THE IGNITION AND THE BRAKE PEDAL EXTENDED TO THE FLOORBOARD WITHOUT WARNING WHEN IT WAS DEPRESSED. THE FAILURE RECURRED FOUR TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE BRAKE CABLE FAILED. THE MANUFACTUR... Read more

Incident date: Jul 1, 2016

IN THE PROCESS OF REPLACING THE FUEL PUMP FOR THE 3RD TIME.. FIRST ONE WAS UNDER WARRANTY BUT THE NEXT 2 ARE ON ME..NOW MY MECHANIC INFORMED ME OF A NEWER DESIGN ... SHOULD HAVE CAME OUT EARLIER.

Incident date: Jan 26, 2016

TL* THE CONTACT OWNS A 2000 CHEVROLET SUBURBAN. WHILE DRIVING APPROXIMATELY 4 MPH ON DRY ROAD SURFACES, THE ABS ENGAGED WHEN THE BRAKE PEDAL WAS DEPRESSED. THE FAILURE RECURRED WHENEVER COMING TO A STOP. IN 2005, THE VEHICLE WAS SERVICED UNDER NHTSA CAMPAIGN NUMBER: 05V379000 (SERVICE BRAKES, HYDRAU... Read more

Incident date: Aug 2, 2015

WHILE DRIVING AT 30 MILES PER HOUR APPLIED THE BRAKES AND BRAKE PEDAL BECAME SOFT AND WENT TO THE FLOOR. THE VEHICLE BARELY CAME TO A STOP BEFORE I HIT ANYTHING. NO WARNING LIGHTS OR MESSAGES APPEARED BEFORE THIS HAPPENED. FOUND BRAKE FLUID LEAKING FROM RUSTED METAL TUBING ON FRAME JUST BEHIND DR... Read more

Incident date: Jul 28, 2015

I HAVE BEEN WORKING IN THE 9100 KEYSTONE AVE. OFFICE BUILDING FOR THE PASSED TWO AND A HALF MONTHS. FOR OVER A MONTH NOW THERE HAS BEEN A BLACK CHEVROLET SUBURBAN PARKED IN THE SPOT NEXT TO MINE. IT HASN'T BEEN TOUCHED FOR OVER A MONTH. IF IT IS A STOLEN VEHICLE I WANT TO REPORT IT SO THAT IT CAN BE... Read more

Incident date: Nov 13, 2014

BRAKES FAILED, HAD TO DRIVE OFF THE ROAD IN FEAR OF HITTING CAR IN FRONT OF ME. CORRODED REAR BRAKE LINES, REAR BRAKE LINE BLEW OUT. *TR

Incident date: Aug 2, 2014

I WAS SITTING IN MY DRIVEWAY AND I PRESSED ON THE BRAKE TO ENGAGE REVERSE WHEN THE BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR. THIS IS NOT A NORMAL BRAKING FOR OUR SUBURBAN. BRAKE FLUID WAS ADDED TO THE BRAKE FLUID COMPARTMENT AND BRAKES WERE RE-TESTED; BRAKE PEDAL CONTINUED TO GO TO FLOOR. FURTHE... Read more

Incident date: Mar 12, 2012

TL* THE CONTACT OWNS A 2000 CHEVROLET SUBURBAN. THE CONTACT STATED A ROUTINE MAINTENANCE HE WAS NOTIFIED THAT THE BRAKE LINE WAS CORRODED. THE TECHINICIAN STATED THAT THE BRAKE LINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE ... Read more

Incident date: Mar 12, 2012

Incident date: Mar 3, 2014

2000 CHEVROLET SUBURBAN. CONSUMER WRITES IN REGARDS TO REIMBURSEMENT FOR RECALL CLAIM DENIED. *SMD THE CONSUMER STATED HE HAD THE HUB ASSEMBLIES AND SENSORS REPLACED BY A CERTIFIED MECHANIC DUE TO THE SPEED SENSORS BEING RUSTED. THE CONSUMER STATED HE HAD THEM REPLACED, FOR MUCH LESS THAN THE DEA... Read more

Incident date: Jul 11, 2011

MY FAMILY AND I (2 ADULTS AND 2 CHILDREN) ALONG WITH 2 OTHER BOYS (AGE 14) WERE DRIVING DOWN A HILL AND EXPERIENCED A COMPLETE BRAKE FAILURE. MY HUSBAND ATTEMPTED TO STOP AT A LIGHT AND DISCOVERED THAT THE BRAKES WERE INACTIVE. THE ROAD DECLINED STEEPLY FOR SOME TIME AND IT WAS A NIGHTMARE AS HE TRI... Read more

Crash

Incident date: Jun 6, 2012

REAR BRAKE LINES NEEDED TO BE REPLACE DUE TO CORROSION IN JUNE 2012. NOW THE FRONT BRAKE LINES NEED TO BE REPLACED DUE TO CORROSION JULY 2013. I PURCHASED THIS VEHICLE NEW IN 2000. *TR

Incident date: Feb 19, 2013

TL* THE CONTACT OWNS A 2000 CHEVROLET SUBURBAN. THE CONTACT STATED THAT WHILE ENTERING A PARKING SPOT AT AN UNKNOWN SPEED, SMOKE EMITTED FROM THE FRONT PASSENGER TIRE. THE CONTACT ALSO MENTIONED THAT THERE WAS A BRAKE FLUID LEAK. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS FOUND TH... Read more

Incident date: Dec 7, 2012

THE BRAKE PEDAL WENT ALL OF THE WAY TO THE FLOOR WHILE I WAS IN TRAFFIC GOING ABOUT 20 MPH. I WAS ABLE TO STOP MY SUBURBAN WITHOUT HITTING THE CAR IN FRONT OF ME BY PUTTING THE CAR IN 2ND GEAR AND USING THE EMERGENCY BRAKE. THERE WERE NO WARNINGS LIGHTS OR MESSAGES IN THE MESSAGE CENTER BEFORE OR AF... Read more

Incident date: Mar 15, 2012

I WAS DRIVING ON YORK ROAD IN MARYLAND GOING ABOUT 35 MILES PER HOUR WHEN THE CAR IN FRONT OF ME SUDDENLY STOPPED. I PRESSED ON THE BRAKE PEDAL BUT IT WENT STRAIGHT TO THE FLOOR. FORTUNATELY I HAD KEPT A GOOD DISTANCE BETWEEN MY CAR AND THE CAR IN FRONT OF ME. MY VEHICLE CAME TO A STOP ABOUT HALF AN... Read more

Incident date: Jun 8, 2012

STEEL BRAKE LINES ALONG REAR DIFFERENTIAL CORRODED AND FAILED RESULTING IN LOSS OF BRAKE FLUID AND BRAKING ACTIONS. *TR

Incident date: Nov 17, 2012

STEEL BRAKE LINE ALONG RIGHT REAR FRAME MEMBER CORRODED AND FAILED RESULTING IN LOSS OF BRAKE FLUID AND BRAKING ACTION. INSPECTION OF OTHER STEEL BRAKE LINES SHOW EXTENSIVE CORROSION, DRAWING REASONABLE CONCLUSION THAT OTHER LINES WILL FAIL. ALL STEEL BRAKE LINES NEED TO BE REPLACED TO MAKE VEHICL... Read more

Incident date: Jun 8, 2012

STEEL BRAKE LINES ALONG REAR DIFFERENTIAL CORRODED AND FAILED RESULTING IN LOSS OF BRAKE FLUID AND BRAKING ACTIONS. *TR

Incident date: Nov 11, 2012

WHEN APPROACHING AN INTERSECTION TODAY THE TRAFFIC LIGHT TURNED RED AND WHEN I DEPRESSED THE BRAKE PEDAL IT COLLAPSED TO THE FLOOR CAUSING ME TO RUN THE LIGHT AND PASS INTO THE INTERSECTION. I THANK MY LUCKY STARS THAT NOBODY WAS INJURED. MY WIFE AND CHILD WERE TERRIFIED, AS WAS I, BUT WE MANAGED TO... Read more

Incident date: Aug 22, 2012

I WAS TRAVELING DOWN A CITY STREET IN PHILADELPHIA TAKING MY YOUNG KIDS TO DAYCARE, WHEN I HAD TO COME TO AN ABRUPT STOP TO AVOID A VEHICLE MAKING AN ILLEGAL U-TURN. THE TRUCK WOULD NOT STOP THE BRAKE PEDAL WENT TO THE FLOOR THEN SLOWLY BROUGHT THE VEHICLE TO A STOP. I HAD THE TRUCK TOWED INTO A REP... Read more

Incident date: Aug 8, 2012

WAS SLOWING DOWN FOR A LIGHT AT AN INTERSECTION. WAS TRAVELING AROUND 15 MPH WHEN I STARTED TO BRAKE THEN THE PEDAL "POPPED" AND WENT TO THE FLOOR. IT DID COME TO A STOP ABOUT 20 FEET INTO THE INTERSECTION, LUCKY FOR THE 7 PASSENGERS THAT WHERE WITH ME NO ONE WAS COMING THROUGH THE INTERSECTION. I C... Read more

Incident date: Jul 26, 2012

TL* THE CONTACT OWNS A 2000 CHEVROLET SUBURBAN. THE CONTACT WAS DRIVING 70 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO PULL OVER TO THE SIDE OF THE ROAD BUT WAS UNABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC. THE MECHANIC STATED THAT THE FUEL PUMP ... Read more

Incident date: May 30, 2012

MY HUSBAND WAS BACKING OUR SUBURBAN DOWN THE DRIVEWAY (A HILL) WHEN HE COMPLETELY LOST BRAKING. PEDAL WENT TO THE FLOOR AND VEHICLE WASN'T SLOWING. EMERGENCY BRAKE WAS INEFFECTIVE. HE TURNED INTO A BUSH AT THE BOTTOM OF THE HILL AND RAN IT OVER, AND THAT PLUS LEVEL ROAD SLOWED HIM ENOUGH THAT HE WAS... Read more

Incident date: May 29, 2012

THE BRAKE LINE ON THE DRIVER SIDE HAS CORRODED AND CAUSED A LOSS OF BRAKE FLUID. AS A RESULT, THE VEHICLE HAS LOST SIGNIFICANT BRAKING ABILITY. UPON EXAMINATION OF THE OTHER LINES, IT IS APPARENT THAT CORROSION HAS AFFECTED ALL VISIBLE BRAKE LINES. THE METAL HAS BEGUN TO FLAKE OFF ON ALL THE LIN... Read more

Incident date: May 17, 2012

I WAS TRAVELING AT 40 MPH WHEN TRAFFIC STOPPED AHEAD. APPLIED BRAKES BUT BRAKE PEDAL DEPRESSED TO THE FLOOR WITH ONLY VERY MINOR BRAKING. AVOIDED ACCIDENT BY USING EMERGENCY BRAKE AND SWERVING ON TO THE RIGHT SHOULDER. THERE WAS NO WARNING ON THE INSTRUMENT PANEL OF LOW BRAKE FLUID, LACK OF BRAK... Read more

Incident date: May 13, 2009

BRAKE LINE BLEW. FRONT RIGHT. OTHER LINES LOOKED CORRODED. SUBSEQUENT LINE BLEW 11/13/11. THIS LINE WAS FROM MASTER CYLINDER AND RENDERED BRAKES UNUSABLE IMMEDIATELY. *TR

Incident date: Nov 1, 2011

I WAS HAVING BODY WORK DONE ON MY ABOVE VEHICLE AND DISCOVERED THE BRAKES LINES WERE RUSTED. I HAD A GM MECHANIC LOOK AT THEM. HE INFORMED ME THEY WERE RUSTED AND SHOULD BE REPLACED. I HAVE ORDERED STAINLESS STEEL BRAKE LINES AND WILL HAVE THEM INSTALLED PRIOR TO USING THE VEHICLE AGAIN . CERTAI... Read more

Incident date: Nov 1, 2011

Incident date: Dec 11, 2010

TL*THE CONTACT OWNS A 2000 CHEVROLET SUBURBAN. WHILE DRIVING APPROXIMATELY 10 MPH HE APPLIED THE BRAKES AND THE PEDAL DEPRESSED TO THE FLOOR. THE VEHICLE CONTINUED TO MOVE FORWARD MOMENTARILY BEFORE STOPPING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE HE WAS TOLD THAT THE BRAKE LINES RUPTU... Read more

Incident date: Oct 29, 2010

MY 2000 CHEVROLET SUBURBAN AT LOW SPEEDS (AROUND 10 MILES PER HOUR)THE ABS BRAKING SYSTEM WILL ENGAGE FOR NO REASON. THIS ACTION EXTENDS MY STOPPING DISTANCE AND ON SEVERAL OCCASIONS ALMOST CAUSES AN ACCIDENTS. I'M TOLD IT IS A PROBLEM WITH THE SPEED SENSORS ON THE FRONT WHEELS. *TR

Incident date: Oct 27, 2010

HAVE HAD ISSUES WITH ANTI LOCK BRAKES ON 2000 CHEVY SUBURBAN. TWICE HAVE HAD IT IN FOR SERVICE FOR LOW SPEED ANTILOCK BRAKE FAILURE. 10/27/2010 BRAKES FAILED AT 50 MPH AND RESULTED IN CRASH. INVESTIGATION THUS FAR SHOWS NO FAULTS ON SYSTEM COMPUTER AND MECHANIC HAS BEEN UNABLE TO DUPLICATE INCIDENT.... Read more

Incident date: Jun 30, 1999

FROM THE DAY I PICKED UP THIS TRUCK NEW I COMPLAINED ABOUT THE RUSTY CHASSIS. I WAS TOLD IT WAS SURFACE RUST AND THAT IT WOULD NOT CAUSE ANY PROBLEMS. NOW THE CHASSIS IS RUSTED TO THE POINT THAT I DO NOT THINK THE TRUCK IS SAFE. *TR

Incident date: Jun 30, 1999

Incident date: Jul 2, 2010

BRAKE PEDAL SUDDENLY AND RAPIDLY WENT TO THE FLOOR WITH LITTLE TO NO BRAKING EFFECTIVENESS. FRONT BRAKES RETAINED MINIMAL BRAKING WHILE REAR APPEARED TO HAVE NO BRAKING EFFECTIVENESS. WAS ABLE TO BRING VEHICLE TO STOP AND LOOKED UNDER VEHICLE AND OBSERVED BRAKE FLUID RUNNING ONTO THE GROUND FROM U... Read more

Incident date: Jul 2, 2010

Incident date: Sep 15, 2009

TL* THE CONTACT OWNS A 2000 CHEVROLET SUBURBAN. THE CONTACT STATED HE NOTICED AN UNKNOWN FLUID LEAKING FROM UNDERNEATH THE VEHICLE. THE DEALER CONFIRMED THERE WAS BRAKE FLUID LEAKING FROM THE FRONT DRIVER AND PASSENGERS SIDE BRAKE LINES. THE DEALER ADVISED THE BRAKE LINES WERE LEAKING DUE TO CORROSI... Read more

Incident date: Jul 7, 2007

TL*THE CONTACT OWNS A 2000 CHEVROLET SUBURBAN. WHILE DRIVING APPROXIMATELY 15 MPH, THE VEHICLE BEGAN TO PULSATE WHEN THE BRAKE PEDAL WAS DEPRESSED. PRIOR TO THE FAILURE, THE ABS WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, BUT THEY COULD NOT DE... Read more

Incident date: Jul 8, 2007

TL*THE CONTACT OWNS A 2000 CHEVROLET SUBURBAN. WHILE DRIVING APPROXIMATELY 15 MPH, THE ABS WARNING LIGHT ILLUMINATED WHEN THE CONTACT APPLIED PRESSURE TO THE BRAKE PEDAL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, BUT THEY WERE UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURE. ON A SEPARATE OCCAS... Read more

Incident date: Sep 15, 2007

TL*THE CONTACT OWNS A 2000 CHEVROLET SUBURBAN. WHILE DRIVING VARIOUS SPEEDS IN WET OR SLIPPERY CONDITIONS, THE BRAKES LOCKED. WHILE DRIVING AROUND A CURVE, ALL FOUR WHEELS LOCKED AND THE VEHICLE SLID FOR 20 OR 30 YARDS. THE SURFACE WAS WET AND THE CONTACT LOST CONTROL OF THE VEHICLE. THE VEHICLE... Read more

Showing 50 of 382 complaints.

Technical Service Bulletins, 2000 CHEVROLET SUBURBAN

549 manufacturer communications from 418 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
350000 EQUIPMENT	46
110000 ELECTRICAL SYSTEM	37
060000 ENGINE AND ENGINE COOLING	37
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL	27
060000 ENGINE (PWS)	25
353000 EQUIPMENT:ELECTRICAL	23
061000 ENGINE AND ENGINE COOLING:ENGINE	19
353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)	18

060000 ENGINE AND ENGINE COOLING

This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels shou

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.

100000 POWER TRAIN

This PI bulletin advises the technician on the proper way to install the pistons in an engine.

060000 ENGINE AND ENGINE COOLING

This PI bulletin advises the technician on the proper way to install the pistons in an engine.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Preliminary Information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. Technician will need to use Pico Oscilloscope Di

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.

350000 EQUIPMENT

This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.

200000 WHEELS

This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have hi

100000 POWER TRAIN

The service bulletin advises the tech of a normal transmission shift condition and the delay in throttle response when the throttle plate is opened rapidly and advises the customer that it is normal for the delay.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides graphics, information and guidelines for engine component wear to assist service personnel as a guideline to perform necessary engine repairs and prevent unnecessary engine replacement.

060000 ENGINE (PWS)

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

060000 ENGINE AND ENGINE COOLING

This service bulletin explains how to measure for oil consumption and possible reasons for loss of oil.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the

200000 WHEELS

This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.

061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

120000 EXTERIOR LIGHTING

This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.

353720 EQUIPMENT:ELECTRICAL:ACCESSORY GENERATOR:OUTLETS/RECEPTACLE

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

138220 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REAR WINDOW:ELECTRICAL HEATING ELEMENT

This Preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. To allow the ice to melt so that it can be drained from the related component

060000 ENGINE AND ENGINE COOLING

This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or P0455 Set.

060000 ENGINE AND ENGINE COOLING

110000 ELECTRICAL SYSTEM

This service bulletin provides information on Module Harvesting.

980000 UNKNOWN OR OTHER

This Preliminary Information communication provides information to the technician that General Motors and General Motors of Canada Company do not support cross border sales. The General Motors of Canada Customer Care Centre is the sole auth

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information on Handling Requests for Modifications to Permanently Import/Export Vehicles Between the U.S. and Canada.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

100000 POWER TRAIN

This Preliminary Information communication provides information to the technician to not remove the torque converter bolts and start the engine as this may cause damage to the torque converter of the crankshaft on vehicles equipped with an

100000 POWER TRAIN

This diagnostic tip advises the tech not to separate the flexplate from the torque convertor or damage my occur if the engine is started while diagnosing for noise from the engine or transmission.

060000 ENGINE AND ENGINE COOLING

This service bulletin explains how to measure for oil consumption and possible reasons for loss of oil.

060000 ENGINE AND ENGINE COOLING

This bulletin provides information on tools available to find an intake vacuum leak or exhaust leak to correct a condition of MIL Illuminated with Multiple Fuel Trim and/or Oxygen Sensor Codes Set.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

160000 STRUCTURE

060000 ENGINE AND ENGINE COOLING

This information bulletin explains how to measure for oil consumption and possible reasons for loss of oil.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

070000 FUEL SYSTEM, GASOLINE

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and

030000 SERVICE BRAKES, HYDRAULIC

061520 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:FILTER/SCREEN

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

060000 ENGINE AND ENGINE COOLING

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

350000 EQUIPMENT

This Preliminary Information communication provides information to the technician about installing General Motors Accessory parts/kits. Technicians should refer to Service Information for information regarding most accessories. Technician

356000 EQUIPMENT ADAPTIVE/MOBILITY

This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.

350000 EQUIPMENT

This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.

120000 EXTERIOR LIGHTING

This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.

071410 FUEL SYSTEM, GASOLINE:STORAGE:EVAPORATIVE EMISSIONS:CANISTER

This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or P0455 Set.

110000 ELECTRICAL SYSTEM

This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or P0455 Set.

350000 EQUIPMENT

160000 STRUCTURE

200000 WHEELS

350000 EQUIPMENT

This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.

070000 FUEL SYSTEM, GASOLINE

This Preliminary Information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blo

061560 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:PRESSURE/TEMPERATURE SENSOR

350000 EQUIPMENT

This Preliminary information communicates the use of Winter grade fuel during the warm months of 2020 and the potential rivability issues that it can cause. The ongoing Coronavirus (COVID-19) pandemic has caused significant reductions in

060000 ENGINE AND ENGINE COOLING

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.

060000 ENGINE (PWS)

This Preliminary Information communication provides information to the technician about finding needle bearings during an oil change. Technician will gain access to the roller rockers to inspect them. Only replace the roller rocker that is

350000 EQUIPMENT

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

355100 EQUIPMENT:OTHER:LABELS

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

060000 ENGINE (PWS)

This information bulletin explains how to measure for oil consumption and possible reasons for loss of oil.

060000 ENGINE (PWS)

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

070000 FUEL SYSTEM, GASOLINE

073000 FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM

356000 EQUIPMENT ADAPTIVE/MOBILITY

060000 ENGINE (PWS)

110000 ELECTRICAL SYSTEM

This Preliminary information communicates information to dealership on how to clear a B1001 DTC after replacing the BCM or SDM.

350000 EQUIPMENT

110000 ELECTRICAL SYSTEM

060000 ENGINE AND ENGINE COOLING

073000 FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM

This informational bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels

350000 EQUIPMENT

356000 EQUIPMENT ADAPTIVE/MOBILITY

353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock ce

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

350000 EQUIPMENT

This informational bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Replacement Guidelines.

356000 EQUIPMENT ADAPTIVE/MOBILITY

This informational bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Replacement Guidelines.

120000 LIGHTING (PWS)

This informational bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Replacement Guidelines.

060000 ENGINE (PWS)

110000 ELECTRICAL SYSTEM

350000 EQUIPMENT

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

118000 ELECTRICAL SYSTEM:SOFTWARE

This informational bulletin provides information for the GM of Canada OnStar Cellular Communication Upgrade to 3G/4G LTE for vehicles that may need an upgrade.

350000 EQUIPMENT

353000 EQUIPMENT:ELECTRICAL

350000 EQUIPMENT

063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

This informational bulletin advises of a new fuel injection kit used for decarbonizing the intake valves, and explains how toptier fuels should be used to reduce carbon build up.

060000 ENGINE (PWS)

350000 EQUIPMENT

060000 ENGINE (PWS)

110000 ELECTRICAL SYSTEM

This Preliminary information communicates the need to contact SPAC until GM CCA has sufficient stock.

110000 ELECTRICAL SYSTEM

This Preliminary information communicates the need to contact SPAC until GM CCA has sufficient stock.

020000 SUSPENSION

This Preliminary Information communication provides information to the technician about vehicles that have a lean to the left or right. Technician will need to measure fender wheel-opening heights, front and rear, to quantify vehicle lean.

060000 ENGINE AND ENGINE COOLING

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

350000 EQUIPMENT

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

120000 EXTERIOR LIGHTING

This informational bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Replacement Guidelines.

Showing 100 of 549 bulletins.

NHTSA Safety Investigations, CHEVROLET SUBURBAN

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

EA, Closed , Model Year: 2000

OVERHEATED FUEL PUMP WIRING

IN A LETTER DATED APRIL 14, 2005, GENERAL MOTORS (GM) NOTIFIED ODI THAT IT HAD IDENTIFIED A DEFECT RELATED TO MOTOR VEHICLE SAFETY IN APPROXIMATELY 316,508 MODEL YEAR (MY) 2000-01 1500 SERIES CHEVROLET SUBURBAN AND GMC YUKON XL VEHICLES (RECALL 05V-155).GM DETERMINED THAT SOME OF THESE VEHICLES WERE... EQUIPPED WITH FUEL MODULE RESERVOIR ASSEMBLIES (MRAS) THAT CONTAIN FUEL PUMP WIRES AND/OR CONNECTORS THAT MAY OVERHEAT UNDER CERTAIN OPERATING CONDITIONS.ACCORDING TO GM, FUEL PUMP WIRES THAT OVERHEAT MAY RESULT IN ONE OR MORE CONDITIONS THAT PRESENT RISKS TO MOTOR VEHICLE SAFETY:(1) FUEL LEAKAGE FROM THE MRA PASS-THROUGH CONNECTOR IF THE OVERHEATING PRODUCES A HOLE IN THE PLASTIC CONNECTOR; (2) ENGINE STALL IF WIRING EXPOSED BY THE OVERHEATING SHORTS TO GROUND AND CAUSES THE FUEL PUMP FUSE TO BLOW; OR (3) INACCURATE FUEL LEVEL READINGS IF OVERHEATED WIRING IS SHORTED TO THE FUEL LEVEL SENDER CARD.GM'S ANALYSIS IDENTIFIED THE CAUSE OF THE OVERHEATED WIRING AS A HIGH-RESISTANCE CONDITION IN THE MRA CONNECTOR CONTACTS DUE TO FRETTING CORROSION THAT MAY DEVELOP OVER TIME.GM DETERMINED THAT THE CORROSION IS CAUSED BY MOVEMENT BETWEEN THE CONTACT SURFACES AND THAT SUCH MOVEMENT IS PRIMARILY INFLUENCED BY CHASSIS AND FUEL TANK VIRBRATION CHARACTERISTICS.GM'S TESTING FOUND THAT THE FUEL TANK VIBRATION CHARACTERISTICS OF THE RECALLED MY 2000-01 1500-SERIES VEHICLES WERE SIGNIFICANTLY GREATER THAN IN OTHER GM VEHICLES EQUIPPED WITH THE SAME MRA CONNECTORS.THESE VEHICLES HAD THE HIGHEST RATE OF RELATED FUEL LEAK AND STALL COMPLAINTS; AND A RECENT SURVEY CONDUCTED BY GM FOUND EVIDENCE OF MRA WIRING OVER-HEATING IN ALMOST ONE-THIRD OF THE 1500-SERIES VEHICLES INSPECTED. OTHER VEHICLES EQUIPPED WITH THE SUBJECT MRA CONNECTOR AND EVALUATED DURING THIS INVESTIGATION INCLUDE APPROXIMATELY 33,000 MY 2000-01 2500-SERIES SUBUBRAN AND YUKON XL VEHICLES, WHICH FALL WITHIN THE SCOPE OF EA04-026, AND PEER POPULATIONS OF SHORT WHEELBASE YUKON AND TAHOE UTILITY VEHICLES AND FULL-SIZE SILVERADO AND SIERRA PICKUP TRUCKS. THESE VEHICLES ARE NOT INCLUDED IN RECALL 05V-155 FOR THE FOLLOWING REASONS:(1) THESE VEHICLES ARE EQUIPPED WITH FUEL TANKS WITH SIGNIFICANTLY LESS VIBRATION AT THE MRA INTERFACE THAN THE RECALLED VEHICLES; (2) THE POTENTIAL FOR FUEL LEAKAGE IS SUBSTANTIALLY LOWER IN THE PICKUP TRUCKS AND SHORT-WHEELBASE UTILITY VEHICLES DUE TO DIFFERENCES IN FUEL TANK CONFIGURATION AND NO INCIDENTS OF FUEL LEAKAGE DUE TO OVERHEATED WIRING WERE VERIFIED IN THESE VEHICLES; (3) THERE THERE HAVE BEEN ONLY THREE POTENTIALLY RELATED COMPLAINTS OF FUEL LEAKAGE ASSOCIATED WITH THE OVERHEATED WIRING CONDITION IN THE 2500-SERIES LONG-WHEELBASE UTILITY VEHICLES; AND (4) NO EVIDENCE OF OVERHEATED WIRING WAS FOUND IN THE 2500-SERIES SUBURBAN AND YUKON XL VEHICLES AND PICKUP TRUCKS INSPECTED BY GM IN ITS VEHICLE SURVEY EFFORTS AND THE RATE FOUND IN THE SHORT-WHEELBASE UTILITIES WAS LOWER THAN THE RECALLED VEHICLES BY AN ORDER OF MAGNITUDE. ODI WILL CONTINUE TO MONITOR THE EXPERIENCE IN THE 2500 SERIES MY 2000-01 LONG-WHEELBASE UTILITY VEHICLES.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS FOR THE 2500 SERIES VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY A CHANGE IN CIRCUMSTANCES.Read more

PE, Closed , Model Year: 2000

OVERHEATED FUEL PUMP WIRING

THE FUEL PUMP WIRING AND CONNECTOR MAY OVERHEAT AND MELT A HOLE IN THE TOP OF THE FUEL PUMP MODULE.POSSIBLE CONSEQUENCES INCLUDE FUEL TANK LEAKAGE AND ENGINE STALL WITH NO RESTART.FOURTEEN OF THE 20 COMPLAINTS TO ODI ALLEGE FUEL TANK LEAKAGE, INCLUDING ONE THAT REPORTED THAT A FIRE DEPARTMENT WAS CA... LLED TO THE SCENE AFTER A POOL OF GASOLINE WAS DISCOVERED BENEATH THE VEHICLE.MOST OF THE ODI COMPLAINTS REPORT INCIDENTS THAT OCCURRED WITHIN THE PAST YEAR. ACCORDING TO GM, FUEL LEAKAGE CAN OCCUR IN THE SUBJECT VEHICLES IF THE HEAT IS SUFFICIENT TO MELT A HOLE IN THE PLASTIC CONNECTOR LARGE ENOUGH FOR LIQUID FUEL TO FLOW THROUGH.ON-BOARD EMISSIONS DIAGNOSTICS MAY DETECT HOLES THAT ARE APPROXIMATELY 0.040 INCHES OR MORE AND SET A SERVICE ENGINE SOON WARNING LIGHT.THE CONNECTOR POSITION IN THE SUBJECT VEHICLES IS BELOW THE FUEL LEVEL WHEN THE TANK IS FULL.WHILE GM DOES NOT KNOW HOW MUCH FUEL COULD LEAK FROM A TANK WITH A MELTED FUEL PUMP CONNECTOR, SEVERAL CONSUMERS HAVE REPORTED SIGNIFICANT LEAK EVENTS.ENGINE STALL CAN OCCUR IF:(1) A SHORT OCCURS IN THE PUMP WIRING (BARE WIRE EXPOSED BY MELTED INSULATION SHORTS AGAINST A GROUND OR GROUND WIRE) AND THE FUEL PUMP RELAY FUSE IS BLOWN; OR (2) THE VEHICLE RUNS OUT OF FUEL DUE TO AN INACCURATE FUEL GAUGE READING RESULTING FROM AN ELECTRICAL SHORT BETWEEN THE FUEL PUMP WIRING AND THE LEVEL SENSOR WIRING. GM'S ANALYSIS OF FIVE ASSEMBLIES RETURNED FROM INCIDENT VEHICLES DETERMINED THAT THE CONDITION IS CAUSED BY ELEVATED RESISTANCE/ ARCING AT THE MRA UNDERCOVER B CAVITY TERMINAL OF THE FOUR-WAY 150 METRI-PAK CONNECTOR.GM ATTRIBUTES THE HIGH RESISTANCE AND ARCING TO A DEPRESSED CONTACT ARM AT THE 150 METRI-PAK B CAVITY FEMALE TERMINAL.GM IS CONTINUING ITS INVESTIGATION TO COMPLETE ITS ROOT CAUSE ANALYSIS. MODULAR RESERVOIR ASSEMBLIES USING THE 150 METRI-PAK CONNECTORS WERE USED BY GM IN SEVERAL MILLION C/K-SERIES SPORT UTILITY VEHICLES AND PICKUP TRUCKS FROM MY 1997 THROUGH 2002, WHEN GM RELEASED A METAL MRA COVER AND A 280 METRI-PAK CONNECTOR IN THE SUBJECT VEHICLES.DURING PE04-042, ODI COLLECTED INFORMATION FROM GM CONCERNING MY 2000-2002 C/K SUV'S AND PICKUP TRUCKS.THE SUBJECT VEHICLES COMPRISE APPROXIMATELY 9 PERCENT OF PRODUCTION FOR THOSE VEHICLES AND ABOUT 39 PERCENT OF COMPLAINTS TO GM. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT IN GM C/K-SERIES VEHICLES.Read more

EA, Closed , Model Year: 1995

BATTERY LEAKS ACID

There is no summary currently available

DP, Open , Model Year: 1993

OEM HITCH RECEIVER PLATFORM CRACKING

THE PETITION ALLEGES THAT CRACKS IN THE HITCH RECEIVER PLATFORM MAY LEAD TO SEPARATION OF THE TRAILER AND LOSS OF STEERING CONTROL

EA, Closed , Model Year: 1997

ERRATIC POWER STEERING ASSIST WHILE DRIV

THE OFFICE OF DEFECT INVESTIGATION (ODI) HAS INVESTIGATED ALLEGATIONS OF POWER STEERING ASSIST FLUCTUATIONS IN THE SUBJECT VEHICLES.FOR DETAILS AND A BASIS FOR THE INVESTIGATION CONCLUSIONS, PLEASE SEE THE CLOSING REPORT IN THE EA99-011 PUBLIC FILE.ODI HAS NOT IDENTIFIED A SAFETY-RELATED DEFECT TREN... Read more

PE, Closed , Model Year: 1994

DRIVERS SEAT FAILURE

THE COMPLAINANTS ALLEGE THE DRIVERS SEAT MOUNTING FAILS, ALLOWING THE SEAT TO MOVE OR TIP REARWARD INTO A RECLINED POSITION.

PE, Closed , Model Year: 1995

UNDERSEAT VEHICLE FIRES

ALLEGED SHORTING OF WIRE FOR POWER SEAT CAUSES UNDERSEAT FIRE.

EA, Closed , Model Year: 1992

POOR BRAKE PERFORMANCE

POOR PERFORMANCE OF ABS BRAKES

DP, Closed , Model Year: 1984

POOR BRAKING ON PANIC STOP

CHEVROLET SUBURBAN - All Years Overview

Complete safety history for the CHEVROLET SUBURBAN across all model years (1981, 2024).

178 Total Recalls

10,548 Total Complaints

9 Investigations

814 Reported Crashes

186 Reported Fires

21 Reported Deaths

CHEVROLET SUBURBAN - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2024	1	49	View
2023	3	141	View
2022	4	150	View
2021	12	242	View
2020	4	60	View
2019	3	92	View
2018	4	111	View
2017	5	184	View
2016	6	297	View
2015	11	588	View
2014	3	77	View
2013	4	170	View
2012	4	139	View
2011	3	193	View
2010	3	161	View
2009	5	133	View
2008	4	276	View
2007	4	358	View
2006	1	33	View
2005	7	161	View
2004	6	265	View
2003	7	361	View
2002	4	352	View
2001	8	543	View
2000 (current)	11	382
1999	2	861	View
1998	3	299	View
1997	3	556	View
1996	4	531	View
1995	7	587	View
1994	6	1,038	View
1993	2	616	View
1992	5	226	View
1991	4	65	View
1990	4	67	View
1989	4	68	View
1988	4	35	View
1987	1	21	View
1986	0	7	View
1985	0	12	View
1984	0	6	View
1983	0	4	View
1982	1	1	View
1981	1	1	View
1979	0	1	View
1978	0	3	View
1977	0	3	View

Other CHEVROLET Models

Model	Recalls	Complaints
TAHOE	240	12,622	View
MALIBU	216	29,080	View
SILVERADO 1500	200	22,534	View
CORVETTE	187	6,308	View
CAMARO	179	4,298	View
SILVERADO	159	10,964	View
SILVERADO 3500	152	1,409	View
EXPRESS	151	838	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2000 CHEVROLET SUBURBAN

Complaint Statistics

Top Reported Components

Technical Service Bulletins, 2000 CHEVROLET SUBURBAN

Most Affected Components

NHTSA Safety Investigations, CHEVROLET SUBURBAN

CHEVROLET SUBURBAN - All Years Overview

CHEVROLET SUBURBAN - Year by Year

Other CHEVROLET Models