1997 CHEVROLET SUBURBAN

3 recalls, 556 complaints - 51 TSBs

FUEL SYSTEM, GASOLINE

Defect Description

CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CE... Read more

Consequence

THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.

Remedy

HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).

88,303 vehicles affected

Manufacturer: HONEYWELL INTERNATIONAL, INC.

VISIBILITY:WINDSHIELD WIPER/WASHER

Defect Description

ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.

Consequence

IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.

Remedy

DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, G... Read more

1,755,876 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR

Defect Description

CERTAIN SPORT UTILITY VEHICLES, MINI VANS, AND PICKUP TRUCKS MAY DEVELOP A SHORT CIRCUIT IN THE ELECTRIC OUTSIDE REARVIEW MIRROR SWITCH.

Consequence

IF THIS WERE TO HAPPEN, IT COULD RESULT IN AN INOPERATIVE SWITCH, HEAT DAMAGE TO THE DRIVER'S DOOR, AND/OR IGNITION OF COMPONENTS IN THE DRIVER'S DOOR AND A SUBSEQUENT VEHICLE FIRE WITHOUT PRIOR WARNING.

Remedy

DEALERS WILL INSTALL A FUSED JUMPER HARNESS TO THE ELECTRIC OUTSIDE REARVIEW MIRROR SWITCH. OWNER NOTIFICATION BEGAN ON APRIL 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTAC... Read more

507,171 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

Complaint Statistics

556 total complaints 27 crashes 15 fires 20 injuries

Top Reported Components

Component	Complaints
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP	64
STEERING	46
STEERING:HYDRAULIC POWER ASSIST SYSTEM	44
POWER TRAIN:AUTOMATIC TRANSMISSION	36
ELECTRICAL SYSTEM:12V/24V/48V BATTERY	27
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP	20
VISIBILITY:WINDSHIELD WIPER/WASHER	14
TIRES	14
VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR	14
STEERING: STEERING WHEEL/HANDLE BAR	13

Incident date: Oct 5, 2020

THE PREVIOUS OWNER SAID THE BRAKES WORE QUICKLY BUT WE DIDN'T REALIZE HOW QUICKLY UNTIL WE HAD ISSUES AND GOT THE REPAIR INFORMATION. NEW BRAKES ABOUT EVERY 4 MONTHS ARE NEEDED. ONCE THEY START WEARING THE PADS AND ROTORS ARE GONE WITHIN A DAY. THIS TIME I NEARLY RAN INTO SOMEONE THEY DETERIORATE... Read more

Incident date: Nov 28, 2019

I STOPPED TO GET GAS ANC CUT MY TRUCK OFF. I GOT BACK IN IT AND CUT IT ON AN DROVE ABOUT 30 YARDS I NOTICED A SMELL LIKE BURNING WIRES. SO I CUT IT OFF GOT OUT CHECKED THE OUTSIDE THE SMELL IS ONLY ON THE INSIDE. THEN I POPPED THE HOOD AN SMELLED THE SAME SMELL. I PUSHED IT AND PARKED IT. MY CLICKER... Read more

Incident date: Oct 2, 2014

MY 1997 CHEVROLET SUBURBAN C-2500 IS LEAKING OIL FROM UNDERNEATH THE ENGINE AND MAKING ENGINE VERY "HOT". THIS HAPPENS WHEN I'M DRIVING THIS VEHICLE.I TOUCH THE ENGINE HOOD AND FEEL THAT IT'S VERY, VERY HOT. I JUST WENT HOME TO PREVENT ANY FIRE OR ACCIDENT. MY MECHANIC SAID IT'S NOT ORDINARY FOR THI... Read more

Incident date: Jul 15, 2012

DECEMBER 2009, REPLACED RUPTURED BRAKE LINES ABOVE THE REAR DIFFERENTIAL. SEVERELY RUSTED. JULY 15, 2012, RUPTURED BRAKE LINE BY THE DRIVER SIDE FLOOR BOARD AND FIRE WALL. SEVERELY RUSTED. FUEL LINES UNDER THE VEHICLE IS ALSO SEVERELY RUSTED. LEAK CAN CAUSE FIRE. BRAKE FAILURE OCCURRED DURING DRI... Read more

Incident date: Jul 15, 2012

Incident date: Nov 21, 2011

THE AIRBAG DIDN'T DEPLOYED AM VEER DISAPPOINTED MY SON WAS INJURED. *TR

Crash 1 injured

Incident date: Sep 23, 2011

TL* THE CONTACT OWNS A 1997 CHEVROLET SUBURBAN. THE CONTACT STATED THAT THE WINDSHIELD WIPERS AND WASHERS FAILED. THE VEHICLE WAS TAKEN TO THE DEALER. THE MANUFACTURER WAS CONTACT AND CONFIRMED THAT REMEDY REPAIRS WERE PERFORMED UNDER NHTSA CAMPAIGN ID NUMBER:03V159000(VISIBILITY:WINDSHIELD WIPER/WA... Read more

Incident date: Aug 9, 2009

ERRATIC POWER STEERING ASSIST WHILE DRIVING RESULTING IN ERRATIC CONTROL AT HIGHWAY SPEEDS. STARTED IN 2006 AND ENDED IN 2009. VEHICLE WAS TAKEN TO DEALER NUMEROUS TIMES TO NO AVAIL. *TR

Fire

Incident date: Jun 22, 1998

TL*THE CONTACT OWNS A 1997 CHEVROLET SUBURBAN. WHEN THE VEHICLE IS FULLY LOADED, THE CONTACT NOTICES THAT THE VEHICLE BECOMES DIFFICULT TO STEER. HE HAS TAKEN THE VEHICLE TO A MECHANIC 15 TIMES AND THEY HAVE MADE NUMEROUS REPAIRS, INCLUDING VARIOUS COMPONENTS OF THE STEERING UNIT, STEERING SENSORS... Read more

Incident date: Jun 22, 1998

Incident date: Aug 16, 2008

HOOD LATCH ON 1997 CHEVY SUBURBAN KEEP FAILING, HOOD FLIES UP WHILE DRIVING. HAS HAPPENED 3 TIMES IN TWO YEARS. *TR

Incident date: Jul 11, 2008

THE CAR WAS PARKED IN THE DRIVEWAY. IN THE MIDDLE OF THE NIGHT IT BURST INTO FLAMES. OUR DOGS WOKE US UP. THE FIRE STARTED IN THE FRONT PASSENGER COMPARTMENT. BY THE TIME THE FIRE DEPARTMENT ARRIVED 7 MINUTES LATER THERE WAS NOTHING LEFT TO THE INTERIOR OF THE CAR. THE ENGINE AND UNDERSIDE OF THE C... Read more

Fire

Incident date: Jul 20, 2007

WINDSHIELD WIPER FAILURE ON RAINY INTERSTATE HIGHWAY. 1997 CHEVROLET SUBURBAN. *TR

Incident date: Dec 1, 2007

TL*THE CONTACT OWNS A 1997 CHEVROLET SUBURBAN. THE CONTACT STATED THAT THE DELAY FEATURE ON THE WINDSHIELD WIPERS WORKED SPORADICALLY. SHE RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 03V159000 (VISIBILITY:WINDSHIELD WIPER/WASHER) AND GM RECALL NUMBER 03023 IN FEBRUARY OF 2002. THE RECAL... Read more

Incident date: Jul 15, 2007

TL*THE CONTACT OWNS A 1997 CHEVROLET SUBURBAN. WHILE DRIVING AT AN UNKNOWN SPEED IN THE RAIN, THE WINDSHIELD WIPERS WOULD NOT ACTIVATE. THE CONTACT TOOK HER VEHICLE TO THE DEALER AND THEY STATED THAT HER VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 03V159000 (VISIBILITY:WINDSHIELD WIPER/WA... Read more

Incident date: Jul 15, 2007

TL*THE CONTACT OWNS A 1997 CHEVROLET SUBURBAN. WHILE DRIVING 65 MPH, THE CONTACT HEARD A LOUD NOISE AND LOST CONTROL OF THE VEHICLE. HE CRASHED THE VEHICLE INTO A WALL. THE DRIVER SIDE REAR B.F. GOODRICH TIRE TREAD SEPARATED AND CAUSED THE FAILURE. THE ROAD CONDITIONS WERE DRY. THE FRONT END OF... Read more

Crash

Incident date: Mar 4, 2006

I HAVE LOST STEERING AND BRAKING ON 1996 6.5 TURBO DIESEL SUBURBAN THREE TIMES NOW I DRIVE NORMALLY. I AM 42 AND HAVE A FAMILY OF SEVEN. WHEN BRAKING THE POWER BOOSTER HAS ZERO PRESSURE AND IT IS VERY HARD TO STOP AND AT THE VERY SAME TIME ALL POWER STEERING IS LOST. I THOUGHT THE POWER STEERING P... Read more

Incident date: Mar 4, 2006

Incident date: May 30, 2004

1997 CHEVEROLET C1500 SUBURBAN INTERMITTENT WIPER MOTOR FAILURE TO WORK PROPERLY. CAUSES LACK OF VISIBILITY DURING INCLEMENT WEATHER CONDITIONS OR DURING WINDSHIELD CLEANING OPERATIONS. WIPERS WILL CEASE TO WORK CONTINUOUS AND PROBLEM IS SPORADIC. *JB

Incident date: Mar 24, 2006

I HAVE A 1997 CHEVY SUBURBAN WITH A 7.4 ENGINE. FOR THE MOST PART ITS BEEN A GOOD VEHICLE, BUT THE BRAKES ARE ANOTHER STORY. THE SUBURBAN HAS BEEN THROUGH 2 SETS OF FRONT BRAKES, AND NONE IN THE REAR. BEING CONCERNED, THE 3RD MECHANIC TO REALLY SPEND TIME FIGURING OUT THE PROBLEM, FOUND OUT THE BRAK... Read more

Incident date: Aug 31, 2005

1997 CHEVY SUBURBAN IN-TANK FUEL SENDING UNIT FIRE: BOUGHT VEHICLE USED WITH 88000 MILES. EVENTS LEADING UP TO THE FAILURE / BURN UP OF THE UNIT INCLUDED INTERMITTENT FUEL PUMP AND FUEL GAUGE FAILURE, HAD PUMP REPLACED BY PATRICK GMC, PROBLEM PERSISTED, HAD DEALER WOLF CHEVROLET CHECK FUEL PRESSURE... Read more

Fire

Incident date: Jan 1, 2006

DT*: THE CONTACT STATED THE VEHICLE WAS HAVING ABS PROBLEMS. WHILE APPLYING THE BRAKE PEDAL TO STOP AT SLOWER SPEEDS THE ABS ACTIVATED CAUSING GREATER STOPPING DISTANCES. THERE IS A NHTSA RECALL, # 05V379000, REGARDING THE ABS. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL; HOWEVER... Read more

Incident date: Jan 1, 1901

CONSUMER COMPLAINT REGARDING 1997 SUBURBAN BRAKING MALFUNCTIONS. *TS THE VEHICLE WAS TAKEN TO THE DEALER WHO DETERMINED THAT TWO SENSORS WERE NEEDED BECAUSE THE CURRENT ONES WERE CORRODED. THE CONSUMER EXPERIENCED THE SAME SYMPTOM AS DESCRIBED IN THE RECALL FOR THE 1998-2002 VEHICLES. *NM

Incident date: Jul 15, 2005

IN JULY/AUGUST 2005 I BEGAN EXPERIENCING ACTIVATION OF THE ABS AT VERY LOW SPEEDS OF 5-10 MPH IN 1997 CHEVROLET SUBURBAN. I TOOK THE CAR TO REPAIR SHOP AND FOUND OUT THAT THE FRONT BRAKE UNITS, CALIPERS, ETC., WERE CORRODED AND NEEDED TO BE REPLACED. I DID THIS. ALSO ,FOUND OUT THAT THE ABS U... Read more

Incident date: Jul 15, 2005

Incident date: Dec 15, 2005

DT: THE CONTACT STATES THERE IS A NHTSA RECALL CAMPAIGN 03V159000 CONCERNING THE WINDSHIELD WIPERS. THIS VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL, BUT IT IS NOT INCLUDED IN THE RECALL DUE TO VIN. THE CONTACT WAS HAVING THE VEHICLE REPAIRED AT HER OWN EXPENSE.*AK

Incident date: Nov 18, 2002

DT: THE CONTACT STATES THERE IS NHTSA RECALL CAMPAIGN 05V379000 CONCERNING THE ANTI- LOCK BRAKES. THIS VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL, BUT IT IS NOT INCLUDED IN THE RECALL DUE TO VIN. THE CONTACT REPAIRED THE VEHICLE AT HIS OWN EXPENSE. *AK THE CONSUMER STATED DUE ... Read more

Crash

Incident date: Sep 8, 2005

DT: THE CONTACT STATES THERE IS A NHTSA RECALL CAMPAIGN 03V159000 CONCERNING THE WINDSHIELD WIPER/WASHER MOTOR. THIS VEHICLE EXPERIENCED THE SAME PROBLEMS AS INDICATED IN THE RECALL, BUT IT IS NOT INCLUDED IN THE RECALL DUE TO VIN. NO REPAIRS WERE DONE . *AK

Incident date: Oct 1, 2003

DT: THE CONTACT OWNS A 1997 CHEVROLET SUBURBAN. SHE RECEIVED RECALL 05V379000 NOTICE FOR A 2001 CHEVROLET SILVERADO REGARDING THE ABS SYSTEM. THE CONTACT STATED THAT THE 1997 CHEVROLET SUBURBAN IS EXPERIENCED THE SAME ABS BRAKE PROBLEM AS INDICATED IN THE RECALL. WHEN THE BRAKES WERE APP... Read more

Incident date: Jan 23, 2003

DT: THE CONTACT WAS DRIVING AT A LOW SPEED AND APPLIED BRAKE PRESSURE AND THE ABS PULSATED. THERE WAS EXTENDED STOPPING DISTANCE AS INDICATED IN A CURRENT RECALL ON THE ANTI LOCK BRAKES. THE VEHICLE WAS TAKEN TO A DEALER WHO REPLACED BOTH WHEEL SPEED SENSORS ON THE FRONT BRAKES. THAT CORRECTED ... Read more

Incident date: Jan 20, 1997

ABS BRAKES PROBLEMS ON MY 1997 CHEVY TAHOE 4DR 4-WHEEL DRIVE. THE BRAKES HAVE BEEN TERRIBLE SINCE I OBTAINED THIS VEHICLE WHEN IT WAS BRAND NEW. THEY WOULD GRUNT & GROAN, SKIP AND ACT ERRATIC. ON ICE AND SNOW, I WOULD ACTUALLY GO FASTER WHEN I WOULD APPLY THE BRAKES AND SLIDE MUCH FASTER THAN A CAR ... Read more

Incident date: Jul 2, 2005

DT: THE CONSUMER STATES 1997 CHEVROLET SUBURBAN HAS BRAKE PROBLEMS. THIS RESULTED IN A CRASH, AND THERE WERE ONLY MINOR INJURIES. THE BRAKES JUST STARTED HAVING PROBLEMS FOR A COUPLE OF WEEKS. BEFORE THE CONSUMER COULD GET A CHANCE TO HAVE THE BRAKES CHECKED, HAD AN ACCIDENT. THE BRAKES WERE C... Read more

Crash 1 injured

Incident date: Apr 24, 2005

DT: THE CONSUMER STATED THE RIGHT REAR TIRE CAME APART ON THE INTERSTATE. THE CONSUMER HAS WRITTEN TO BRIDGESTONE. THEY WOULD NEED THE TIRE TO BE SENT TO THEM TO DETERMINE THE CAUSE OF THE TIRE SEPARATION. CONSUMER REFUSED TO SEND THE TIRE TO THE MANUFACTURER. *AK THERE WAS DAMAGE TO THE V... Read more

Incident date: Jun 18, 2005

DT: CONSUMER RECEIVED A RECALL ON SIDE MIRROR SWITCH ,AND HAD REPAIR WORK DONE. BUT, FELT THERE WERE STILL HOT WIRES ON DRIVER'S SIDE. THIS MAY BE A FIRE HAZARD. CONTACTED DEALER AND MANUFACTURER ABOUT IT, AND THEY WOULD NOT REMEDY THIS PROBLEM. *AK

Incident date: Jun 16, 2005

DT: THIS MORNING HIT THE BRAKES COMING DOWN THE HILL AND ENGINE SHUT DOWN, COULD NOT CONTROL STEERING AND BRAKES DIDN'T WORK EITHER. THE ELECTRIC AND POWER FAILURE, COULDN'T DO ANYTHING WITH THE VEHICLE. IT HASN'T BE CHECKED BY DEALER YET.*AK

Incident date: Jun 16, 2005

Incident date: Jun 5, 2005

NHTSA COMPLAINT # 03V159000 - CHEVROLET HAS RECALLED CERTIAN VEHICLES WITH AN INTERMITTENT WINDSHIEL WIPER PROBLEM. MY 1997 2WD SUBURBAN IS NOT NCLUDED. 1996 ALL SUBURBANS ARE AND 1997 4WD SUBURBANS ARE. I HAVE THE SAME SYMPTOMS AS THE 1996 AND 1997 4WD.

Incident date: Jun 7, 2005

WINDSHIELD WIPERS WORK INTERMITTENTLY AND OCCASIONALLY FAIL. DANGEROUS DURING RAINSTORMS. THIS 1997 SUBURBAN VIN# [XXX] DOES NOT SHOW UP ON RECALL NHTSA CAMPAIGN # 03V159000. *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident date: May 16, 2005

I BOUGHT A USED SUBURBAN AND SINCE I HAVE OWNED IT I HAVE BEEN HAVING TROUBLE WITH THE STEERING. WHILE DRIVING DOWN THE ROAD THE STEERING WHEEL JERKS SUDDENLY TO THE RIGHT. I REALLY HAVE TO KEEP A TIGHT GRIP ON THE STEERING WHEEL WHILE DRIVING, ESPECIALLY WHEN ON A ROAD WITH ALOT OF TWISTS AND TUR... Read more

Incident date: Feb 10, 2005

WHEN I APPLY THE BRAKES TO MY 1997 CHEVY SUBURBAN, THE ABS KICKS ON AND PULSATES EXTENDING THE STOPPING DISTANCE TREMENDOUSLY. THERE HAS BEEN A RECALL ON THIS FOR RECENT YEAR SUBURBANS, BUT NOT AS FAR BACK AS THE 1997 MODEL.

Incident date: May 7, 2005

I HAVE A 1997 CHEVROLET SUBURBAN AND IT BLEW THE COUPLING ON THE HEATER HOSE WHILE DRIVING THIS PAST SATURDAY. THE VEHICLE HAD TO BE TOWED AND THE REPAIR WAS 93.00. I HAVE SPOKEN TO SEVERAL PEOPLE WITH THE SAME MOTOR THAT ALL HAD THE SAME PROBLEM. THE CHEVROLET DEALER SAID THAT THERE PROBABLY SHO... Read more

Incident date: Mar 4, 2005

WHILE DRIVING IN THE RAIN THE WINDSHIELD WIPERS WOULD COME ON AND OFF ON THEIR OWN. DRIVER TOOK VEHICLE TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT WINDSHIELD WIPER MOTOR NEEDED TO BE REPLACED. DRIVER INFORMED THE MECHANIC THAT RECALL 03V159000 FOR THE WINDSHIELD WIPER MOTOR WAS... Read more

Incident date: Nov 20, 2004

NHTSA RECALL CAMPAIGN 03V159000 CONCERNING WINDSHIELD WIPER MOTOR FAILURE. VEHICLE WAS TAKEN TO THE DEALER FOR THE RECALL, AND MECHANIC STATED THAT RECALL REPAIRS HAD BEEN PERFORMED PREVIOUSLY. HOWEVER, THE OWNER OF THE VEHICLE HAD NEVER TAKEN THE VEHICLE TO ANY DEALER FOR RECALL REPAIRS. ... Read more

Incident date: Nov 8, 2004

THE BRAKES VIBRATE EXCESSIVELY AND HESITATE WHEN THEY ARE APPLIED, MAKING IT DIFFICULT TO STOP VEHICLE. MANUFACTURER WAS CONTACTED BY OWNER.*AK

Incident date: Feb 3, 2005

THE WINDSHIELD WIPER MOTOR FAILED AND THE WINDSHIELD WIPERS QUIT WORKING WHILE ENGAGED. THE MANUFACTURER IS CHARGING THE CONSUMER FOR THE WINDSHIELD WIPER MOTOR RECALL 03V159000 BECAUSE THEIR RECORDS INDICATED THAT THE RECALL WAS CLOSED OUT IN 98. THIS RECALL WAS ISSUED IN 2003. THE DEALERSHIP INSP... Read more

Incident date: Dec 2, 2002

ABS FAILURE, ELECTRICAL FAILURE AND FRONT AND REAR BRAKE FAILURE. THIS CORRESPONDENCE IS NOT AVAILABLE VIA .I BELIEVE THE LETTER MAY HAVE BEEN MISPLACED WHILE IN TRANSITION FROM DIMMS TO ARTEMIS VIA TRAN TECH EMPLOYEES. THE POWER WINDOWS AND AIR CONDITION FAILED. THERE WAS A VIOLENT GEAR CHANGE BE... Read more

Incident date: Dec 2, 2002

Showing 50 of 556 complaints.

Technical Service Bulletins, 1997 CHEVROLET SUBURBAN

51 manufacturer communications from 38 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
350000 EQUIPMENT	7
110000 ELECTRICAL SYSTEM	5
353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.	4
034000 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS	3
070000 FUEL SYSTEM, GASOLINE	3
353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES	3
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL	3
118000 ELECTRICAL SYSTEM:SOFTWARE	2

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

070000 FUEL SYSTEM, GASOLINE

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and

030000 SERVICE BRAKES, HYDRAULIC

110000 ELECTRICAL SYSTEM

350000 EQUIPMENT

This informational bulletin provides information for dealers/technicians on Procedures to Unlock Delco Radio with Theftlock.

110000 ELECTRICAL SYSTEM

This informational bulletin provides information for dealers/technicians on Procedures to Unlock Delco Radio with Theftlock.

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock ce

353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

350000 EQUIPMENT

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

350000 EQUIPMENT

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

350000 EQUIPMENT

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco Theft Lock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock c

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco Theft Lock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock c

356000 EQUIPMENT ADAPTIVE/MOBILITY

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco Theft Lock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock c

350000 EQUIPMENT

070000 FUEL SYSTEM, GASOLINE

199000 TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

118000 ELECTRICAL SYSTEM:SOFTWARE

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This warranty administration bulletin provides policy information with the field action courtesy transportation policy.

118000 ELECTRICAL SYSTEM:SOFTWARE

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

THIS TECHNICAL BULLETIN PROVIDES A PROCEDURE TO REPROGRAM THE MEDIA DISC PLAYER WITH THE LATEST CALIBRATIONS TO CORRECT A CONDITION OF THE REAR ENTERTAINMENT SYSTEM NOT OPERATING AS INTENDED IN COLDER AMBIENT TEMPERATURE AREAS DUE TO CALIBR

353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Vehicle Recalls

070000 FUEL SYSTEM, GASOLINE

This informational bulletin provides the technician with information on what E85 fuel may due to a non E85 vehicle.

061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)

Expanded Availability for Remanufacture and Return (R&R) Electronic Control Modules

060000 ENGINE AND ENGINE COOLING

This preliminary informational bulletin provides information on High Oil Pressure on Startup After Engine Replacement Concern.

350000 EQUIPMENT

This preliminary informational bulletin provides information on High Oil Pressure on Startup After Engine Replacement Concern.

021244 SUSPENSION:FRONT:SPRINGS:LEAF SPRING ASSEMBLY:U-BOLT, LEAF SPRING TO AXLE

LEFT FRONT AXLE SHAFT DIFFICULT TO REMOVE. AXLE DIFFERENTIAL LEAK SEAL SHAFT. *KB

036000 SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

ANTILOCK BRAKE (ABS) ACTIVATION AT LOW SPEEDS. *TT

103400 POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT

DIAGNOSIS OF CRACKED OR BROKEN TRANSMISSION CASE. *TT 2006 AND PRIOR CARS AND LIGHT DUTY TRUCKS. *TT

060000 ENGINE AND ENGINE COOLING

REPLACEMENT OF CONNECTOR WHEN REPLACING FUEL TANK MODULE/FUEL PUMP MODULE. *TT

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

93-00 FULL SIZE UTILITIES (GMT 400 OLD STYLE ONLY) AC BLOWS WARM AND THE HIGH SIDE PRESSURE IS TOO HIGH. *MJ

110000 ELECTRICAL SYSTEM

MALFUNCTION INDICATOR LAMP ON WITH A P0300 SET AND A MISFIRE. VARIOUS MODELS INCLUDING 1996 - 1999 P32 MODELS. SIT BULLETIN 1416475. *TT

110000 ELECTRICAL SYSTEM

MALFUNCTION INDICATOR LAMP ON WITH A P0300 SET AND A MISFIRE. VARIOUS MODELS INCLUDING THE 1996-1999 P32 AND THE 1996-2002 GMC C/K TRUCK. *TT

093000 FUEL SYSTEM, OTHER:FUEL INJECTION SYSTEM

6.5L L49 L56 L57 L65 DIESEL ENGINE REQUIRING FUEL INJECTION PUMP REPLACEMENT. MODELS P32/P42 1994-1999 INCLUDED. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

4L60-E AUTOMATIC TRANSMISSION OIL PUMP FIRST AND SECOND DESIGN IDENTIFICATION. *TT

110000 ELECTRICAL SYSTEM

ELECTRIC OUTSIDE REARVIEW MIRROR SWITCH SHORT CIRCUIT. *TT

135200 VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR

INSTALLING A FUSE JUMPER HARNESS TO CORRECT A SHORT CIRCUIT IN THE ELECTRIC OUTSIDE REARVIEW MIRROR SWITCH. *TT *JB

136000 VISIBILITY:WINDSHIELD WIPER/WASHER

WINDSHIELD WIPER FAILURE DUE TO CRACKED BOULDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THIS SPECIAL POLICY COVERS THE CONDITION FOR A PERIOD OF SEVEN YEARS OR 70,000 MILES, WHICHEVER OCCURS FIRST FROM THE DATE THE VEHICLE WAS ORIGINALLY P

136200 VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR

SPECIAL POLICY ADJUSTMENT - WINDSHIELD WIPER MOTOR FAILURES. *TT

046000 SERVICE BRAKES, AIR:ANTILOCK

ANTILOCK BRAKE (ABS) ACTIVATION AT LOW SPEEDS ON VARIOUS MODELS INCLUDING THE 1995 AND 1996 ENVOY. *TT

100000 POWER TRAIN

DIAGNOSTIC INFORMATION FOR INTERMITTENT TRANSMISSION DOWNSHIFT, SLIP, BUSY/CYCLING TCC OR NOISY COOLING FAN. *TT

034000 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS

BRAKE LEAD/PULL AND FRONT BRAKE WEAR. *MJS

034000 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS

SOME CAB CHASSIS, CREW CAB, AND PICKUP MODELS MAY EXHIBIT A BRAKE LEAD / PULL AND FRONT BRAKE WEAR. *TT

030000 SERVICE BRAKES, HYDRAULIC

VEHICLES LEADING OR PULLING TO EITHER SIDE WHILE APPLYING THE BRAKES, AND PREMATURE FRONT BRAKE WEAR, ESPECIALLY VEHICLES THAT HAVE BEEN USED TO TOW A HEAVY LOAD. *YC

034000 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS

VEHICLE LEADING OR PULLING TO EITHER SIDE WHILE APPLYING THE BRAKES OR FRONT BRAKE WEAR NOT MEETING EXPECTATIONS. *YC

162310 STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS

BROKEN REAR CARGO DOOR HINGE (INSTALL REPLACEMENT HINGE). *TW

061000 ENGINE AND ENGINE COOLING:ENGINE

SERVICE ENGINE SOON LIGHT AND P0300 WHEN TOWING, CRUISING UPHILL OR ON HARD ACCELERATION. *TT

100000 POWER TRAIN

4L80E OUTPUT CARRIER THRUST WASHER CHANGES. *TT

NHTSA Safety Investigations, CHEVROLET SUBURBAN

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

EA, Closed , Model Year: 2000

OVERHEATED FUEL PUMP WIRING

IN A LETTER DATED APRIL 14, 2005, GENERAL MOTORS (GM) NOTIFIED ODI THAT IT HAD IDENTIFIED A DEFECT RELATED TO MOTOR VEHICLE SAFETY IN APPROXIMATELY 316,508 MODEL YEAR (MY) 2000-01 1500 SERIES CHEVROLET SUBURBAN AND GMC YUKON XL VEHICLES (RECALL 05V-155).GM DETERMINED THAT SOME OF THESE VEHICLES WERE... EQUIPPED WITH FUEL MODULE RESERVOIR ASSEMBLIES (MRAS) THAT CONTAIN FUEL PUMP WIRES AND/OR CONNECTORS THAT MAY OVERHEAT UNDER CERTAIN OPERATING CONDITIONS.ACCORDING TO GM, FUEL PUMP WIRES THAT OVERHEAT MAY RESULT IN ONE OR MORE CONDITIONS THAT PRESENT RISKS TO MOTOR VEHICLE SAFETY:(1) FUEL LEAKAGE FROM THE MRA PASS-THROUGH CONNECTOR IF THE OVERHEATING PRODUCES A HOLE IN THE PLASTIC CONNECTOR; (2) ENGINE STALL IF WIRING EXPOSED BY THE OVERHEATING SHORTS TO GROUND AND CAUSES THE FUEL PUMP FUSE TO BLOW; OR (3) INACCURATE FUEL LEVEL READINGS IF OVERHEATED WIRING IS SHORTED TO THE FUEL LEVEL SENDER CARD.GM'S ANALYSIS IDENTIFIED THE CAUSE OF THE OVERHEATED WIRING AS A HIGH-RESISTANCE CONDITION IN THE MRA CONNECTOR CONTACTS DUE TO FRETTING CORROSION THAT MAY DEVELOP OVER TIME.GM DETERMINED THAT THE CORROSION IS CAUSED BY MOVEMENT BETWEEN THE CONTACT SURFACES AND THAT SUCH MOVEMENT IS PRIMARILY INFLUENCED BY CHASSIS AND FUEL TANK VIRBRATION CHARACTERISTICS.GM'S TESTING FOUND THAT THE FUEL TANK VIBRATION CHARACTERISTICS OF THE RECALLED MY 2000-01 1500-SERIES VEHICLES WERE SIGNIFICANTLY GREATER THAN IN OTHER GM VEHICLES EQUIPPED WITH THE SAME MRA CONNECTORS.THESE VEHICLES HAD THE HIGHEST RATE OF RELATED FUEL LEAK AND STALL COMPLAINTS; AND A RECENT SURVEY CONDUCTED BY GM FOUND EVIDENCE OF MRA WIRING OVER-HEATING IN ALMOST ONE-THIRD OF THE 1500-SERIES VEHICLES INSPECTED. OTHER VEHICLES EQUIPPED WITH THE SUBJECT MRA CONNECTOR AND EVALUATED DURING THIS INVESTIGATION INCLUDE APPROXIMATELY 33,000 MY 2000-01 2500-SERIES SUBUBRAN AND YUKON XL VEHICLES, WHICH FALL WITHIN THE SCOPE OF EA04-026, AND PEER POPULATIONS OF SHORT WHEELBASE YUKON AND TAHOE UTILITY VEHICLES AND FULL-SIZE SILVERADO AND SIERRA PICKUP TRUCKS. THESE VEHICLES ARE NOT INCLUDED IN RECALL 05V-155 FOR THE FOLLOWING REASONS:(1) THESE VEHICLES ARE EQUIPPED WITH FUEL TANKS WITH SIGNIFICANTLY LESS VIBRATION AT THE MRA INTERFACE THAN THE RECALLED VEHICLES; (2) THE POTENTIAL FOR FUEL LEAKAGE IS SUBSTANTIALLY LOWER IN THE PICKUP TRUCKS AND SHORT-WHEELBASE UTILITY VEHICLES DUE TO DIFFERENCES IN FUEL TANK CONFIGURATION AND NO INCIDENTS OF FUEL LEAKAGE DUE TO OVERHEATED WIRING WERE VERIFIED IN THESE VEHICLES; (3) THERE THERE HAVE BEEN ONLY THREE POTENTIALLY RELATED COMPLAINTS OF FUEL LEAKAGE ASSOCIATED WITH THE OVERHEATED WIRING CONDITION IN THE 2500-SERIES LONG-WHEELBASE UTILITY VEHICLES; AND (4) NO EVIDENCE OF OVERHEATED WIRING WAS FOUND IN THE 2500-SERIES SUBURBAN AND YUKON XL VEHICLES AND PICKUP TRUCKS INSPECTED BY GM IN ITS VEHICLE SURVEY EFFORTS AND THE RATE FOUND IN THE SHORT-WHEELBASE UTILITIES WAS LOWER THAN THE RECALLED VEHICLES BY AN ORDER OF MAGNITUDE. ODI WILL CONTINUE TO MONITOR THE EXPERIENCE IN THE 2500 SERIES MY 2000-01 LONG-WHEELBASE UTILITY VEHICLES.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS FOR THE 2500 SERIES VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY A CHANGE IN CIRCUMSTANCES.Read more

PE, Closed , Model Year: 2000

OVERHEATED FUEL PUMP WIRING

THE FUEL PUMP WIRING AND CONNECTOR MAY OVERHEAT AND MELT A HOLE IN THE TOP OF THE FUEL PUMP MODULE.POSSIBLE CONSEQUENCES INCLUDE FUEL TANK LEAKAGE AND ENGINE STALL WITH NO RESTART.FOURTEEN OF THE 20 COMPLAINTS TO ODI ALLEGE FUEL TANK LEAKAGE, INCLUDING ONE THAT REPORTED THAT A FIRE DEPARTMENT WAS CA... LLED TO THE SCENE AFTER A POOL OF GASOLINE WAS DISCOVERED BENEATH THE VEHICLE.MOST OF THE ODI COMPLAINTS REPORT INCIDENTS THAT OCCURRED WITHIN THE PAST YEAR. ACCORDING TO GM, FUEL LEAKAGE CAN OCCUR IN THE SUBJECT VEHICLES IF THE HEAT IS SUFFICIENT TO MELT A HOLE IN THE PLASTIC CONNECTOR LARGE ENOUGH FOR LIQUID FUEL TO FLOW THROUGH.ON-BOARD EMISSIONS DIAGNOSTICS MAY DETECT HOLES THAT ARE APPROXIMATELY 0.040 INCHES OR MORE AND SET A SERVICE ENGINE SOON WARNING LIGHT.THE CONNECTOR POSITION IN THE SUBJECT VEHICLES IS BELOW THE FUEL LEVEL WHEN THE TANK IS FULL.WHILE GM DOES NOT KNOW HOW MUCH FUEL COULD LEAK FROM A TANK WITH A MELTED FUEL PUMP CONNECTOR, SEVERAL CONSUMERS HAVE REPORTED SIGNIFICANT LEAK EVENTS.ENGINE STALL CAN OCCUR IF:(1) A SHORT OCCURS IN THE PUMP WIRING (BARE WIRE EXPOSED BY MELTED INSULATION SHORTS AGAINST A GROUND OR GROUND WIRE) AND THE FUEL PUMP RELAY FUSE IS BLOWN; OR (2) THE VEHICLE RUNS OUT OF FUEL DUE TO AN INACCURATE FUEL GAUGE READING RESULTING FROM AN ELECTRICAL SHORT BETWEEN THE FUEL PUMP WIRING AND THE LEVEL SENSOR WIRING. GM'S ANALYSIS OF FIVE ASSEMBLIES RETURNED FROM INCIDENT VEHICLES DETERMINED THAT THE CONDITION IS CAUSED BY ELEVATED RESISTANCE/ ARCING AT THE MRA UNDERCOVER B CAVITY TERMINAL OF THE FOUR-WAY 150 METRI-PAK CONNECTOR.GM ATTRIBUTES THE HIGH RESISTANCE AND ARCING TO A DEPRESSED CONTACT ARM AT THE 150 METRI-PAK B CAVITY FEMALE TERMINAL.GM IS CONTINUING ITS INVESTIGATION TO COMPLETE ITS ROOT CAUSE ANALYSIS. MODULAR RESERVOIR ASSEMBLIES USING THE 150 METRI-PAK CONNECTORS WERE USED BY GM IN SEVERAL MILLION C/K-SERIES SPORT UTILITY VEHICLES AND PICKUP TRUCKS FROM MY 1997 THROUGH 2002, WHEN GM RELEASED A METAL MRA COVER AND A 280 METRI-PAK CONNECTOR IN THE SUBJECT VEHICLES.DURING PE04-042, ODI COLLECTED INFORMATION FROM GM CONCERNING MY 2000-2002 C/K SUV'S AND PICKUP TRUCKS.THE SUBJECT VEHICLES COMPRISE APPROXIMATELY 9 PERCENT OF PRODUCTION FOR THOSE VEHICLES AND ABOUT 39 PERCENT OF COMPLAINTS TO GM. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT IN GM C/K-SERIES VEHICLES.Read more

EA, Closed , Model Year: 1995

BATTERY LEAKS ACID

There is no summary currently available

DP, Open , Model Year: 1993

OEM HITCH RECEIVER PLATFORM CRACKING

THE PETITION ALLEGES THAT CRACKS IN THE HITCH RECEIVER PLATFORM MAY LEAD TO SEPARATION OF THE TRAILER AND LOSS OF STEERING CONTROL

EA, Closed , Model Year: 1997

ERRATIC POWER STEERING ASSIST WHILE DRIV

THE OFFICE OF DEFECT INVESTIGATION (ODI) HAS INVESTIGATED ALLEGATIONS OF POWER STEERING ASSIST FLUCTUATIONS IN THE SUBJECT VEHICLES.FOR DETAILS AND A BASIS FOR THE INVESTIGATION CONCLUSIONS, PLEASE SEE THE CLOSING REPORT IN THE EA99-011 PUBLIC FILE.ODI HAS NOT IDENTIFIED A SAFETY-RELATED DEFECT TREN... Read more

PE, Closed , Model Year: 1994

DRIVERS SEAT FAILURE

THE COMPLAINANTS ALLEGE THE DRIVERS SEAT MOUNTING FAILS, ALLOWING THE SEAT TO MOVE OR TIP REARWARD INTO A RECLINED POSITION.

PE, Closed , Model Year: 1995

UNDERSEAT VEHICLE FIRES

ALLEGED SHORTING OF WIRE FOR POWER SEAT CAUSES UNDERSEAT FIRE.

EA, Closed , Model Year: 1992

POOR BRAKE PERFORMANCE

POOR PERFORMANCE OF ABS BRAKES

DP, Closed , Model Year: 1984

POOR BRAKING ON PANIC STOP

CHEVROLET SUBURBAN - All Years Overview

Complete safety history for the CHEVROLET SUBURBAN across all model years (1981, 2024).

178 Total Recalls

10,625 Total Complaints

9 Investigations

810 Reported Crashes

188 Reported Fires

20 Reported Deaths

CHEVROLET SUBURBAN - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2024	1	55	View
2023	3	159	View
2022	4	167	View
2021	12	256	View
2020	4	64	View
2019	3	102	View
2018	4	111	View
2017	5	186	View
2016	6	301	View
2015	11	589	View
2014	3	77	View
2013	4	170	View
2012	4	139	View
2011	3	193	View
2010	3	161	View
2009	5	133	View
2008	4	276	View
2007	4	359	View
2006	1	33	View
2005	7	161	View
2004	6	265	View
2003	7	361	View
2002	4	352	View
2001	8	543	View
2000	11	382	View
1999	2	861	View
1998	3	299	View
1997 (current)	3	556
1996	4	531	View
1995	7	587	View
1994	6	1,038	View
1993	2	616	View
1992	5	226	View
1991	4	65	View
1990	4	67	View
1989	4	68	View
1988	4	35	View
1987	1	21	View
1986	0	7	View
1985	0	12	View
1984	0	6	View
1983	0	4	View
1982	1	1	View
1981	1	1	View
1979	0	1	View
1978	0	3	View
1977	0	3	View

Other CHEVROLET Models

Model	Recalls	Complaints
TAHOE	240	12,622	View
MALIBU	216	29,080	View
SILVERADO 1500	200	22,534	View
CORVETTE	187	6,308	View
CAMARO	179	4,298	View
SILVERADO	159	10,964	View
SILVERADO 3500	152	1,409	View
EXPRESS	151	838	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

1997 CHEVROLET SUBURBAN

Complaint Statistics

Top Reported Components

Technical Service Bulletins, 1997 CHEVROLET SUBURBAN

Most Affected Components

NHTSA Safety Investigations, CHEVROLET SUBURBAN

CHEVROLET SUBURBAN - All Years Overview

CHEVROLET SUBURBAN - Year by Year

Other CHEVROLET Models