2016 CHEVROLET SUBURBAN

6 recalls, 297 complaints - 2,358 TSBs

ELECTRONIC STABILITY CONTROL (ESC)

Defect Description

General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is tra... Read more

Consequence

Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.

Remedy

GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.

652,967 vehicles affected

Manufacturer: General Motors LLC

SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM

Defect Description

General Motors LLC (GM) is recalling certain 2015-2017 Cadillac Escalade, 2014-2018 Chevrolet Silverado, GMC Sierra, 2015-2018 Chevrolet Suburban, Tahoe, GMC Yukon vehicles. The amount of vacuum created by the vacuum pump may decrease over time.

Consequence

As the vacuum level drops, the brake assist decreases, increasing braking effort, extending the distance required to stop the vehicle, thereby increasing the risk of a crash.

Remedy

GM will notify owners, and dealers will reprogram the Electronic Brake Control Module, free of charge. The recall began October 8, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438, Cadillac customer service at 1-800-458-8006 or GMC customer service at 1-800-462-8782. GM's num... Read more

3,456,719 vehicles affected

Manufacturer: General Motors LLC

AIR BAGS:FRONTAL

Defect Description

General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Subur... Read more

Consequence

A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.

Remedy

GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadi... Read more

40,683 vehicles affected

Manufacturer: General Motors LLC

VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR

Defect Description

General Motors LLC (GM) is recalling certain 2016-2017 Chevrolet Suburban HD vehicles. These vehicles were assembled with a convex right-hand outside mirror, instead of with a non-convex (flat) right-hand outside mirror. As such, these vehicles fail to comply with the requirements of Federal Moto... Read more

Consequence

If equipped with the incorrect right-side rear-view mirror, the driver may misjudge the distance of other vehicles, increasing the risk of a crash.

Remedy

GM will notify owners, and dealers will replace the convex mirror with a non-convex mirror and provide a new page for the owner's manual with the customer notification letter, free of charge. The recall began February 7, 2017. Owners may contact GM customer service at 1-800-222-1020. GM's number ... Read more

214 vehicles affected

Manufacturer: General Motors LLC

AIR BAGS:FRONTAL

Defect Description

General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Poli... Read more

Consequence

A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.

Remedy

GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Ca... Read more

3,640,162 vehicles affected

Manufacturer: General Motors LLC

SUSPENSION:FRONT:CONTROL ARM

Defect Description

General Motors LLC (GM) is recalling certain model year 2016-2017 Chevrolet Silverado 1500 and 2016 Cadillac Escalade, Cadillac Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Sierra, GMC Yukon and GMC Yukon XL vehicles. The front upper control arms may have inadequate welds near the control... Read more

Consequence

Inadequate welds may allow the control arm to separate from the bushing, compromising steering and increasing the risk of a crash.

Remedy

GM will notify owners, and dealers will replace the left and right front upper control arms and realign the vehicle, free of charge. The recall began on May 18, 2016. Until the repairs have been made, owners are advised not to drive their vehicles. Owners may contact Chevrolet customer service at... Read more

3,738 vehicles affected

Manufacturer: General Motors LLC

Complaint Statistics

297 total complaints 16 crashes 13 injuries

Top Reported Components

Component	Complaints
SERVICE BRAKES	68
POWER TRAIN	39
ENGINE	33
UNKNOWN OR OTHER	29
ELECTRICAL SYSTEM	24
STEERING	17
STRUCTURE:BODY	10
SUSPENSION	8
AIR BAGS	8
VEHICLE SPEED CONTROL	7

Incident date: Jan 2, 2024

Hood and roof of Suburban has discolored and lost its shine coat. The door and panels are fine

Incident date: Jun 9, 2026

My wife took are jeep in for first inspection and the service technician found cracks between the tread on all 4 tires,the tires have 5600 miles,the service technician recommended new tires,I questioned why I should buy new tires when the nexen roadian HTX2 tires have a 70000 mile warranty,C Harper... Read more

Incident date: Jun 9, 2026

Out of the blue, the Travel Assist warning will start ringing. Sometimes it does it once, other times it can go nonstop for 10 minutes. It happens randomly and I can't make it come on. It has become a terrible distraction while I am driving. The dealer claims unless they observe it, they won't repai... Read more

Incident date: Jun 9, 2026

I was driving, suddenly my truck is dead. I got it tow to GM dealership for weeks. The technician diagnose and said I need a new engine replacement. My truck is only 148K.

Incident date: Mar 6, 2026

The contact owns a 2013 Toyota Prius V. The contact stated that while in reverse(R), the rear driver’s side tire became flat. Upon inspection, it was discovered that the rear axle had fractured due to rusting and corrosion, and had punctured the rear passenger’s side tire. The vehicle was towed ... Read more

Incident date: Mar 6, 2026

Vehicle was operating perfect then got alert indicating electrical system fault but vehicle still drove (was just 2 miles from home ) but then alarms sounded and just able to pull off road before vehicle died. Checked and see code DTC PIA9096 and car was inoperable after. Towed to dealer for replace... Read more

Incident date: Apr 4, 2026

Torque converter slipping. No one was injured during or after driving the vehicle. Ford dealership service center confirmed problem and made repairs. They was never any warning lights that turned on.

Incident date: Apr 4, 2026

Steering wheel is sticky during highway driving. While making minor turns or changing lanes the steering wheel intermittently has issues driving straight.

Incident date: Apr 4, 2026

The 12V battery in my 2025 Hyundai Ioniq 5 failed under normal use, causing repeated loss of vehicle function. Voltage measured ~12.3V at rest, dropping to ~12.0V when opening the door, and collapsing to ~11V then ~9V under light load (headlights), resulting in system shutdown. After a failed start... Read more

Incident date: Jan 26, 2026

The car material itself is very cheap meaning it poor quality, very flimsy, I hit a curb and the grill and cover just broke so easily even though it was now a serious hit but very small and slight to the point where you can’t feel it. Now it’s just hanging off and shaking badly because of the po... Read more

Crash

Incident date: Feb 23, 2026

While I was driving, my vehicle suddenly lost all power I encountered a misfire with the engine light flashing, and diagnostic codes P0353 and P0300 indicated a misfire on cylinder three. The coil pack and spark plugs for that cylinder were replaced, yet issues persist and problems continue. There ... Read more

Incident date: Feb 23, 2026

I have experienced two near-fatal incidents involving a sudden, uncommanded loss of motive power while traveling at highway speeds (approx. 70 MPH). On February 11, 2026, the vehicle entered "Limp Home Mode" without warning, dropping speed to 60 MPH and 2000 RPM in heavy traffic. This caused an imme... Read more

Incident date: Feb 23, 2026

Incident date: Feb 18, 2026

I was driving the car on a highway. About 2 hours into my trip the steering became very difficult when banking to the left. Felt like there was no power steering and I had to muscle the car through banking turns.

Incident date: Feb 4, 2026

while driving on an open road driver's side air bag suddenly deployed causing an unsafe driving condition

Incident date: Dec 31, 1969

The backup camera at night is very dark and unsafe. I can barely see anything. It’s a major safety issue even though sensors can warn you, I almost ran over my neighbor while backing out of the garage. My wife has a 2025 X5 that does not have this issue at all. I see online forums where tons... Read more

Incident date: Jan 21, 2026

The contact owns a 2020 Toyota Camry. The contact stated while driving 60 MPH, the sunroof rose up independently. The vehicle was taken to the dealer, where the contact was informed that the sunroof needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was not notifie... Read more

Incident date: Dec 31, 1969

Transmission failure due to CVT bearing failure

Incident date: Dec 31, 1969

September 2025; the fuel control module failed at 75 mph in the left lane of I-45 requiring me to pull over on the shoulder in heavy traffic. I eas towed to my dealership 170 miles. At that time the recall test was performed on my 6.2 L L87 engine and passed inspection. The oil was upgraded at that ... Read more

Incident date: Jun 14, 2024

My check engine light came on spring of 2025 and my Rogue was losing speed from 80mph to 50mph on the intersate with the RPM's shooting up to 5-6. On 5/30/2025, I paid $800 to get the intake manifold sensor replaced. A few months later in October of 2025, engine light came back on and was having the... Read more

Incident date: Jun 14, 2024

The contact owns a 2014 BMW X5. While the contact's daughter was attempting to start the vehicle, the vehicle failed to start. The vehicle was towed to an independent mechanic, who diagnosed the vehicle and determined that the 12-Volt battery and the auxiliary battery needed to be replaced. The vehi... Read more

Incident date: Aug 8, 2025

Purchased this vehicle at a big dealership and driving noticed glaring across the windshield try washing not helping took vehicle to glass shop that told me windshield damaged from rock chips and was pitted all the way through and could not be repaired has to be replaced dealership refuses to replac... Read more

Incident date: Oct 31, 2025

Due to a faulty PCV valve, the entire engine wiring harness needed to be replaced at 69,000 miles. The valve cover and camshafts were replaced, engine components were reassembled with mandatory bolts and gaskets. Lower timing cover was leaking on the passenger side due to the faulty PCV valve and th... Read more

Incident date: Oct 1, 2025

Sorento is not working properly due to transmission oil pump. This has been recalled by Kia but my car does not fall under the warranty.

Incident date: Oct 1, 2025

Sorento is not working properly due to transmission oil pump. This has been recalled by Kia but my car does not fall under the warranty.

Incident date: Oct 1, 2025

Sorento is not working properly due to transmission oil pump. This has been recalled by Kia but my car does not fall under the warranty.

Incident date: Aug 14, 2025

For the past couple of weeks, every time I drive the car, I get a number of error messages regarding problems with the advanced driver assistance features. These include: "Adaptive Cruise Control Problem", "Collision Mitigation System Problem", Lane Keeping Assist Problem", "Road Departure Mitigatio... Read more

Incident date: Jul 31, 2025

Wipers quite intermittently in rain or when using windshield washer Could not see clearly Problem intermittent dealer said wiper motor Yes No warning just quit Problem same as in recall NHTSA22v-142 on f150 2021 and 2022 and recall 22v842

Incident date: Jun 3, 2025

The power steering goes out and make it very hard to drive

Incident date: Jun 26, 2025

I SUBMITTED A COMPLAINT ABOUT THE SERVICE SHIFTER THAT I BEEN HAVING SINCE 2020 RIGHT AFTER I FINANCE THE CAR WITH DEALERSHIP. THE PROBLEM CONTINUED AND IT HASNT BEEN RESOLVED EVEN AFTER TAKING IT BACK FOR REPAIRING. RECENTLY ON 6/24/2025 MY CAR STOPPED ON THE EXPRESSWAY, THE SERVICE SHIFTER CAME ON... Read more

Incident date: Mar 20, 2025

The contact owns a 2014 Ford F-150. The contact stated that while in reverse(R), the screen was black or displayed a blue screen. The failure impeded the driver's visibility, preventing the driver from safely operating the vehicle. The message "Rearview Camera Unavailable" was displayed during the f... Read more

Incident date: May 7, 2025

225/60 R16 tire size valve leak and pushed in slow tire leak

Crash

Incident date: Apr 10, 2025

Safety Defect Complaint Vehicle Equipment: - Anti-lock Brakes - Full Front Air Bag - Passive Disabling Anti-theft Device Introduction: I am the registered owner and primary driver of a 2021 Chevrolet Suburban. I am filing this safety complaint regarding a serious system malfunction that occurred du... Read more

Crash

Incident date: Apr 10, 2025

Crash

Incident date: Apr 10, 2025

Crash

Incident date: Apr 17, 2025

While driving on the mass pike with my fiancé and 4 kids our motor suddenly died. We were using cruise control going 75mph and the vehicle shifted into neutral itself and the car died. I managed to make it to a break down lane and we had to sit there for 2.5 hours before a tow showed up to help. Th... Read more

Incident date: Apr 17, 2025

The engine did not start and had a burning smell coming out. The SUV was towed to a Ford dealer to find out the engine block has to be replace. The SUV has been well maintain through out the years of ownership. It has 84000.00 miles on it. After some research, my SUV is not the only one that this ha... Read more

Incident date: Apr 17, 2025

Incident date: Apr 8, 2025

The vehicle randomly stalls, goes dead and becomes unresponsive. This has happened numerous times at lights, stop signs and in the middle of the road.

Incident date: Nov 17, 2021

The contact owns a 2019 Kia Soul. The contact stated that while driving approximately 75 MPH and attempting to overtake a Commercial Semi-Truck, the vehicle suddenly lost automotive power and started to decelerate. The vehicle coasted to the side of the road and stalled. The vehicle was later towed ... Read more

Incident date: May 24, 2024

The contact owns a 2019 Ford Expedition. The contact stated that while driving at an undisclosed speed, the transmission unexpectedly downshifted with several unknown warning lights illuminated. The vehicle was able to be restarted. The vehicle was taken to the dealer, where it was diagnosed that th... Read more

Incident date: Feb 27, 2025

The CPO vehicle was purchased at 60k miles 11/5/2024. The vehicle started bogging down accelerating from a stop, while pulling into traffic, and decelerating randomly at 62k. The vehicle went in to the dealership at 64.5k on 2/20/2025 where they stated the transmission needed replacing due to a tran... Read more

Incident date: Sep 13, 2024

Randomly, my car will start throwing many warning signs when I crank my car. Then it magically disappears after 2 days. Also I drive my car past 40mph and the engine light came on and then I could no longer accelerate. My car was slowing down while I was on the freeway. I pulled over, turned my car... Read more

Incident date: Sep 13, 2024

Incident date: Sep 30, 2024

The head gasket leaks, full engine replacement is recommended. No accidents, only 79k miles on the engine.

Incident date: Oct 23, 2024

Engine started making noises. I had it towed to dealership to get it diagnosed. Dealership called me next morning to get information on what vehicle was doing. I called dealership that same evening and they informed me that the engine locked up on the tech diagnosing the issue, and I was going to ne... Read more

Incident date: Oct 19, 2024

Front CV axles. Front end shakes really bad at 30-50 mph. Dealer changed front passenger side CV axle but it still shakes really bad. I'll be bringing it back to the dealership, but warranty expires soon they need to have a recall and a better replacement part for this fix. I am not the only one wit... Read more

Incident date: Oct 19, 2024

Tranmission failed at 137k miles. Inspection revealed the tranmission was beyond repair and would have to be replaced. Last maintenance was tranmission fluid change at 95k miles by Ford dealer.

Incident date: Dec 21, 2024

The 12 volt battery keeps going dead or puts the car in to sleep mode. Ive been to the dealers 7 times and they have replaced the battery twice . I only have 14000 miles on it. this has been going on for most of the time i have had it. there is no safety issue at this time, it just wont start.

Showing 50 of 297 complaints.

Technical Service Bulletins, 2016 CHEVROLET SUBURBAN

2,358 manufacturer communications from 1405 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
350000 EQUIPMENT	301
110000 ELECTRICAL SYSTEM	239
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL	173
060000 ENGINE AND ENGINE COOLING	172
060000 ENGINE (PWS)	164
100000 POWER TRAIN	107
356000 EQUIPMENT ADAPTIVE/MOBILITY	98
353000 EQUIPMENT:ELECTRICAL	63

200000 WHEELS

This service bulletin provides information for dealers/technicians on Tire Radial Force Variation (RFV).

350000 EQUIPMENT

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

110000 ELECTRICAL SYSTEM

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

350000 EQUIPMENT

This bulletin updates the position of General Motors on refinishing aluminum wheels. GM has determined that wheel refinishing under warranty will no longer be performed.

200000 WHEELS

This bulletin updates the position of General Motors on refinishing aluminum wheels. GM has determined that wheel refinishing under warranty will no longer be performed.

110000 ELECTRICAL SYSTEM

This bulletin provides information for electrical ground repairs using new General Motors replacement fasteners with conductive finish.

160000 STRUCTURE

This preliminary informational bulletin provides frame coating repair information to correct a customer concern of wax coating on frame peeling, metal shows corrosion/rusting (U.S. and Canada Only).

118000 ELECTRICAL SYSTEM:SOFTWARE

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

350000 EQUIPMENT

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

110000 ELECTRICAL SYSTEM

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

160000 STRUCTURE

This preliminary informational bulletin provides frame coating repair information to correct a customer concern of wax coating on frame peeling, metal shows corrosion/rusting (U.S. and Canada Only).

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information on submitting quality Photos of Various Vehicle Concerns to the GM Technical Assistance Center (TAC).

060000 ENGINE AND ENGINE COOLING

This service bulletin advises the technician of possible coolant entering the areas of the engine, either through failed parts or defects in the castings, that may be the cause of the concerns related to the MIL or the engine running rough.

060000 ENGINE AND ENGINE COOLING

This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels shou

350000 EQUIPMENT

This warranty administration bulletin provides policy information for GM courtesy transportation and roadside assistance programs.

350000 EQUIPMENT

This Warranty Administration bulletin provides information on Dealer Empowerment for Goodwill, Customer Enthusiasm and Policy (U.S. Only).

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information on All hazmat parts being returned to the Warranty Parts Center (WPC) must be shipped using Central Transport. Hazardous materials should never be sent by air transportation to the WPC.

030000 BRAKES (PWS)

This Preliminary information communicates that when removing the fuel line jumper hose care should be taken to be sure the line is reinstalled correctly to avoid a no/low fuel pressure situation.

070000 FUEL SYSTEM, GASOLINE

This Preliminary information communicates that when removing the fuel line jumper hose care should be taken to be sure the line is reinstalled correctly to avoid a no/low fuel pressure situation.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Preliminary Information communication advises the technician with a tip when the vehicle stops running after it has been idling for 2.5 hours. This is normal operation of the vehicle built with regular production code BTM and without R

980000 UNKNOWN OR OTHER

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.

251000 ELECTRONIC STABILITY CONTROL:AUTOMATIC (ASC)

This Preliminary Information communication provides information to the technician about vehicles that have an unwanted Stability Activation and/or a Service Stability message on the Driver Information Center. Technician may find a Diagnosti

060000 ENGINE AND ENGINE COOLING

This bulletin provides information on Engine Concerns that could result from lack of scheduled maintenance, improper service or aftermarket calibrations.

070000 FUEL SYSTEM, GASOLINE

This service bulletin provides information on the cold start control system in DI engines to reduce cold start emissions and improve fuel economy.

063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

This service bulletin provides information on the cold start control system in DI engines to reduce cold start emissions and improve fuel economy.

030000 BRAKES (PWS)

This Preliminary Information communication provides information to the technician about fluid leaking from the brake caliper piston area found during a service of the vehicle. The substance is actually excess assembly grease from the calipe

190000 TIRES

This Preliminary Information communication provides information to the technician that some owners of Heavy Duty Trucks and Utilities may ask if they can lower their tire pressures. Tire pressures being set to the "Tire and Loading Label" w

100000 POWER TRAIN

This Warranty Admin service bulletin provides guidelines for Dealers Not Required and for Dealers Required to Contact the PQC for engine or transmission assembly replacement and explains the PQC process, GWM Transaction submission, vehicle

060000 ENGINE AND ENGINE COOLING

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

This Preliminary information communicates to dealers of a known issue with failed map update

070000 FUEL SYSTEM, GASOLINE

This Preliminary Information communication provides information to the technician on how to diagnose and repair vehicles that may have rattle or ticking noise that is louder inside the vehicle than outside. The noise may also sound like a l

160000 STRUCTURE

This preliminary informational bulletin provides frame coating repair information to correct a customer concern of wax coating on frame peeling, metal shows corrosion/rusting (U.S. and Canada Only).

160000 STRUCTURE

This preliminary informational (PI) bulletin provides information to dealership personnel which may be helpful when addressing underbody component corrosion with customers.

100000 POWER TRAIN

This service bulletin advises the technician that the possible cause may not be from a faulty clutch piston or extension housing and to perform testing on transmission for other possible issues, but it still may be possible on high mileage

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.

100000 POWER TRAIN

This PI bulletin advises the technician on the proper way to install the pistons in an engine.

060000 ENGINE AND ENGINE COOLING

This PI bulletin advises the technician on the proper way to install the pistons in an engine.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Preliminary Information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. Technician will need to use Pico Oscilloscope Di

120000 EXTERIOR LIGHTING

This informational bulletin provides information for dealers/technicians on Headlamp, Tail Lamp, License Lamp or Fog/Driving Lamp Damage.

110000 ELECTRICAL SYSTEM

This preliminary information (PI) provides information om Service Programming System (SPS) Error Codes (E4398, E4399, E4403, M4404, M4413, M6954, M6955, E4414, E4423, E4491 or E6961).

350000 EQUIPMENT

This Preliminary Information communication provides information to the technician about the use of J-35616-64B terminal test probe, replacement terminals, and terminated leads. The J-35616-64B is the latest test probe released for checking

110220 ELECTRICAL SYSTEM:HAND HEATER:WIRING HARNESS

This Preliminary information communicates a GM part number for reflective high temperature heat or insulating tape when repairing wiring harnesses.

980000 UNKNOWN OR OTHER

This Preliminary information communicates a GM part number for reflective high temperature heat or insulating tape when repairing wiring harnesses.

350000 EQUIPMENT

This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.

350000 EQUIPMENT

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

060000 ENGINE AND ENGINE COOLING

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

110000 ELECTRICAL SYSTEM

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

020000 SUSPENSION

This Preliminary Information communication provides information to the technician about vehicles that have had multiple repair attempts that are being performed on customer?s vehicles that exhibit vibration conditions without utilizing the

010000 STEERING

This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.

200000 WHEELS

This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.

100000 POWER TRAIN

This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.

020000 SUSPENSION

This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure when diagnosing vibration concerns.

200000 WHEELS

This Warranty Administration bulletin is for information on General Motors New Vehicle Tire Warranty Program (U.S. Dealers Only).

100000 POWER TRAIN

This information bulletin advises the technician the difference between a welch cap leak and the output seal of the t-case or transmission leaking ATF, causing the customer concern of a Red Fluid Leak from Center of Vehicle Located by Rear

350000 EQUIPMENT

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information on General Motors Dealership Critical Equipment Requirements and Recommendations.

200000 WHEELS

This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides guidelines and diagnostic/repair information to technicians regarding vehicle engine oil consumption.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Warranty Administration bulletin provides information on the Global Warranty Management (GWM) Warranty Parts Center (WPC) Parts Return Program.

190000 TIRES

This Warranty Administration bulletin is for information on General Motors New Vehicle Tire Warranty Program (U.S. Dealers Only).

200000 WHEELS

This Warranty Administration bulletin is for information on General Motors New Vehicle Tire Warranty Program (U.S. Dealers Only).

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have hi

110000 ELECTRICAL SYSTEM

This Preliminary information communicates additional information on how a LIN bus operates and diagnostic tips when working on a LIN bus.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information for dealers/technicians on When and How to Submit a Field Product Report (FPR) (U.S. and Canada Dealers Only).

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).

350000 EQUIPMENT

This bulletin provides information on Warranty Administration a?? Required Operating Procedures - 8 Points (U.S. Only).

110000 ELECTRICAL SYSTEM

This informational bulletin provides information for the IPC odometer programming method quick reference guide.

350000 EQUIPMENT

This informational bulletin provides information for the IPC odometer programming method quick reference guide.

117100 ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER

This informational bulletin provides information for the IPC odometer programming method quick reference guide.

100000 POWER TRAIN

This Technical bulletin provides a repair to correct a condition of Shudder/Surging While Driving.

060000 ENGINE AND ENGINE COOLING

This service bulletin explains the difference in oil filters for gas engines with new oil pump control systems and the possibilities of what may happen using the incorrect filter.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This bulletin provides information on Warranty Administration a?? Required Operating Procedures - 8 Points (U.S. Only).

100000 POWER TRAIN

This Preliminary Information communication provides information to the technician of a complaint of a sag or hesitation when accelerating. The concern is present when coasting at low speeds of less than 15 miles per hour and then aggressive

060000 ENGINE AND ENGINE COOLING

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Warranty Administration service bulletin provides information for dealers/Service advisors on when and how to submit a Pre-Repair Authorization (PRA).

060000 ENGINE AND ENGINE COOLING

The service bulletin advises the tech of a normal transmission shift condition and the delay in throttle response when the throttle plate is opened rapidly and advises the customer that it is normal for the delay.

100000 POWER TRAIN

This Preliminary information communicates to the dealer technician that TAC recommends the utilization of the GDS2 software to aid in diagnosing automatic transmission concerns. TAC is requesting the GDS2 session logs be sent in before the

060000 ENGINE AND ENGINE COOLING

This service bulletin provides graphics, information and guidelines for engine component wear to assist service personnel as a guideline to perform necessary engine repairs and prevent unnecessary engine replacement.

350000 EQUIPMENT

This Warranty Administration service bulletin provides information for dealers/Service advisors on when and how to submit a Pre-Repair Authorization (PRA).

350000 EQUIPMENT

This Warranty Administration bulletin provides information on the proper use of the labor operation 0600014.

060000 ENGINE (PWS)

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

060000 ENGINE AND ENGINE COOLING

This informational bulletin advised the technician that the engine and related parts will be debited if found that the tech didn't properly prepare the engine block from dirt and debris in bolt holes or if found that the block was damaged b

110000 ELECTRICAL SYSTEM

This bulletin provides information on Engine Concerns that could result from lack of scheduled maintenance, improper service or aftermarket calibrations.

060000 ENGINE AND ENGINE COOLING

This bulletin provides information on Engine Concerns that could result from lack of scheduled maintenance, improper service or aftermarket calibrations.

100000 POWER TRAIN

This service bulletin provides technicians with updated information to help identify the differences between what is considered a fluid leak, and what is considered fluid seepage.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides technicians with updated information to help identify the differences between what is considered a fluid leak, and what is considered fluid seepage.

010000 STEERING

This service bulletin provides technicians with updated information to help identify the differences between what is considered a fluid leak, and what is considered fluid seepage.

020000 SUSPENSION

This service bulletin provides technicians with updated information to help identify the differences between what is considered a fluid leak, and what is considered fluid seepage.

350000 EQUIPMENT

This service bulletin provides information on a guide to help reduce repeat visits for the same customer concern.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides information for maintenance cleaning of the fuel injectors and gasoline detergent additive.

070000 FUEL SYSTEM, GASOLINE

This service bulletin provides information for maintenance cleaning of the fuel injectors and gasoline detergent additive.

060000 ENGINE AND ENGINE COOLING

This bulletin provides information on identifying Non-GM Engine Calibrations for Gasoline Engines using the Tech 2 or GDS 2.

110000 ELECTRICAL SYSTEM

This bulletin provides information on identifying Non-GM Engine Calibrations for Gasoline Engines using the Tech 2 or GDS 2.

060000 ENGINE AND ENGINE COOLING

This service bulletin explains how to measure for oil consumption and possible reasons for loss of oil.

Showing 100 of 2,358 bulletins.

NHTSA Safety Investigations, CHEVROLET SUBURBAN

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

EA, Closed , Model Year: 2000

OVERHEATED FUEL PUMP WIRING

IN A LETTER DATED APRIL 14, 2005, GENERAL MOTORS (GM) NOTIFIED ODI THAT IT HAD IDENTIFIED A DEFECT RELATED TO MOTOR VEHICLE SAFETY IN APPROXIMATELY 316,508 MODEL YEAR (MY) 2000-01 1500 SERIES CHEVROLET SUBURBAN AND GMC YUKON XL VEHICLES (RECALL 05V-155).GM DETERMINED THAT SOME OF THESE VEHICLES WERE... EQUIPPED WITH FUEL MODULE RESERVOIR ASSEMBLIES (MRAS) THAT CONTAIN FUEL PUMP WIRES AND/OR CONNECTORS THAT MAY OVERHEAT UNDER CERTAIN OPERATING CONDITIONS.ACCORDING TO GM, FUEL PUMP WIRES THAT OVERHEAT MAY RESULT IN ONE OR MORE CONDITIONS THAT PRESENT RISKS TO MOTOR VEHICLE SAFETY:(1) FUEL LEAKAGE FROM THE MRA PASS-THROUGH CONNECTOR IF THE OVERHEATING PRODUCES A HOLE IN THE PLASTIC CONNECTOR; (2) ENGINE STALL IF WIRING EXPOSED BY THE OVERHEATING SHORTS TO GROUND AND CAUSES THE FUEL PUMP FUSE TO BLOW; OR (3) INACCURATE FUEL LEVEL READINGS IF OVERHEATED WIRING IS SHORTED TO THE FUEL LEVEL SENDER CARD.GM'S ANALYSIS IDENTIFIED THE CAUSE OF THE OVERHEATED WIRING AS A HIGH-RESISTANCE CONDITION IN THE MRA CONNECTOR CONTACTS DUE TO FRETTING CORROSION THAT MAY DEVELOP OVER TIME.GM DETERMINED THAT THE CORROSION IS CAUSED BY MOVEMENT BETWEEN THE CONTACT SURFACES AND THAT SUCH MOVEMENT IS PRIMARILY INFLUENCED BY CHASSIS AND FUEL TANK VIRBRATION CHARACTERISTICS.GM'S TESTING FOUND THAT THE FUEL TANK VIBRATION CHARACTERISTICS OF THE RECALLED MY 2000-01 1500-SERIES VEHICLES WERE SIGNIFICANTLY GREATER THAN IN OTHER GM VEHICLES EQUIPPED WITH THE SAME MRA CONNECTORS.THESE VEHICLES HAD THE HIGHEST RATE OF RELATED FUEL LEAK AND STALL COMPLAINTS; AND A RECENT SURVEY CONDUCTED BY GM FOUND EVIDENCE OF MRA WIRING OVER-HEATING IN ALMOST ONE-THIRD OF THE 1500-SERIES VEHICLES INSPECTED. OTHER VEHICLES EQUIPPED WITH THE SUBJECT MRA CONNECTOR AND EVALUATED DURING THIS INVESTIGATION INCLUDE APPROXIMATELY 33,000 MY 2000-01 2500-SERIES SUBUBRAN AND YUKON XL VEHICLES, WHICH FALL WITHIN THE SCOPE OF EA04-026, AND PEER POPULATIONS OF SHORT WHEELBASE YUKON AND TAHOE UTILITY VEHICLES AND FULL-SIZE SILVERADO AND SIERRA PICKUP TRUCKS. THESE VEHICLES ARE NOT INCLUDED IN RECALL 05V-155 FOR THE FOLLOWING REASONS:(1) THESE VEHICLES ARE EQUIPPED WITH FUEL TANKS WITH SIGNIFICANTLY LESS VIBRATION AT THE MRA INTERFACE THAN THE RECALLED VEHICLES; (2) THE POTENTIAL FOR FUEL LEAKAGE IS SUBSTANTIALLY LOWER IN THE PICKUP TRUCKS AND SHORT-WHEELBASE UTILITY VEHICLES DUE TO DIFFERENCES IN FUEL TANK CONFIGURATION AND NO INCIDENTS OF FUEL LEAKAGE DUE TO OVERHEATED WIRING WERE VERIFIED IN THESE VEHICLES; (3) THERE THERE HAVE BEEN ONLY THREE POTENTIALLY RELATED COMPLAINTS OF FUEL LEAKAGE ASSOCIATED WITH THE OVERHEATED WIRING CONDITION IN THE 2500-SERIES LONG-WHEELBASE UTILITY VEHICLES; AND (4) NO EVIDENCE OF OVERHEATED WIRING WAS FOUND IN THE 2500-SERIES SUBURBAN AND YUKON XL VEHICLES AND PICKUP TRUCKS INSPECTED BY GM IN ITS VEHICLE SURVEY EFFORTS AND THE RATE FOUND IN THE SHORT-WHEELBASE UTILITIES WAS LOWER THAN THE RECALLED VEHICLES BY AN ORDER OF MAGNITUDE. ODI WILL CONTINUE TO MONITOR THE EXPERIENCE IN THE 2500 SERIES MY 2000-01 LONG-WHEELBASE UTILITY VEHICLES.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS FOR THE 2500 SERIES VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY A CHANGE IN CIRCUMSTANCES.Read more

PE, Closed , Model Year: 2000

OVERHEATED FUEL PUMP WIRING

THE FUEL PUMP WIRING AND CONNECTOR MAY OVERHEAT AND MELT A HOLE IN THE TOP OF THE FUEL PUMP MODULE.POSSIBLE CONSEQUENCES INCLUDE FUEL TANK LEAKAGE AND ENGINE STALL WITH NO RESTART.FOURTEEN OF THE 20 COMPLAINTS TO ODI ALLEGE FUEL TANK LEAKAGE, INCLUDING ONE THAT REPORTED THAT A FIRE DEPARTMENT WAS CA... LLED TO THE SCENE AFTER A POOL OF GASOLINE WAS DISCOVERED BENEATH THE VEHICLE.MOST OF THE ODI COMPLAINTS REPORT INCIDENTS THAT OCCURRED WITHIN THE PAST YEAR. ACCORDING TO GM, FUEL LEAKAGE CAN OCCUR IN THE SUBJECT VEHICLES IF THE HEAT IS SUFFICIENT TO MELT A HOLE IN THE PLASTIC CONNECTOR LARGE ENOUGH FOR LIQUID FUEL TO FLOW THROUGH.ON-BOARD EMISSIONS DIAGNOSTICS MAY DETECT HOLES THAT ARE APPROXIMATELY 0.040 INCHES OR MORE AND SET A SERVICE ENGINE SOON WARNING LIGHT.THE CONNECTOR POSITION IN THE SUBJECT VEHICLES IS BELOW THE FUEL LEVEL WHEN THE TANK IS FULL.WHILE GM DOES NOT KNOW HOW MUCH FUEL COULD LEAK FROM A TANK WITH A MELTED FUEL PUMP CONNECTOR, SEVERAL CONSUMERS HAVE REPORTED SIGNIFICANT LEAK EVENTS.ENGINE STALL CAN OCCUR IF:(1) A SHORT OCCURS IN THE PUMP WIRING (BARE WIRE EXPOSED BY MELTED INSULATION SHORTS AGAINST A GROUND OR GROUND WIRE) AND THE FUEL PUMP RELAY FUSE IS BLOWN; OR (2) THE VEHICLE RUNS OUT OF FUEL DUE TO AN INACCURATE FUEL GAUGE READING RESULTING FROM AN ELECTRICAL SHORT BETWEEN THE FUEL PUMP WIRING AND THE LEVEL SENSOR WIRING. GM'S ANALYSIS OF FIVE ASSEMBLIES RETURNED FROM INCIDENT VEHICLES DETERMINED THAT THE CONDITION IS CAUSED BY ELEVATED RESISTANCE/ ARCING AT THE MRA UNDERCOVER B CAVITY TERMINAL OF THE FOUR-WAY 150 METRI-PAK CONNECTOR.GM ATTRIBUTES THE HIGH RESISTANCE AND ARCING TO A DEPRESSED CONTACT ARM AT THE 150 METRI-PAK B CAVITY FEMALE TERMINAL.GM IS CONTINUING ITS INVESTIGATION TO COMPLETE ITS ROOT CAUSE ANALYSIS. MODULAR RESERVOIR ASSEMBLIES USING THE 150 METRI-PAK CONNECTORS WERE USED BY GM IN SEVERAL MILLION C/K-SERIES SPORT UTILITY VEHICLES AND PICKUP TRUCKS FROM MY 1997 THROUGH 2002, WHEN GM RELEASED A METAL MRA COVER AND A 280 METRI-PAK CONNECTOR IN THE SUBJECT VEHICLES.DURING PE04-042, ODI COLLECTED INFORMATION FROM GM CONCERNING MY 2000-2002 C/K SUV'S AND PICKUP TRUCKS.THE SUBJECT VEHICLES COMPRISE APPROXIMATELY 9 PERCENT OF PRODUCTION FOR THOSE VEHICLES AND ABOUT 39 PERCENT OF COMPLAINTS TO GM. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT IN GM C/K-SERIES VEHICLES.Read more

EA, Closed , Model Year: 1995

BATTERY LEAKS ACID

There is no summary currently available

DP, Open , Model Year: 1993

OEM HITCH RECEIVER PLATFORM CRACKING

THE PETITION ALLEGES THAT CRACKS IN THE HITCH RECEIVER PLATFORM MAY LEAD TO SEPARATION OF THE TRAILER AND LOSS OF STEERING CONTROL

EA, Closed , Model Year: 1997

ERRATIC POWER STEERING ASSIST WHILE DRIV

THE OFFICE OF DEFECT INVESTIGATION (ODI) HAS INVESTIGATED ALLEGATIONS OF POWER STEERING ASSIST FLUCTUATIONS IN THE SUBJECT VEHICLES.FOR DETAILS AND A BASIS FOR THE INVESTIGATION CONCLUSIONS, PLEASE SEE THE CLOSING REPORT IN THE EA99-011 PUBLIC FILE.ODI HAS NOT IDENTIFIED A SAFETY-RELATED DEFECT TREN... Read more

PE, Closed , Model Year: 1994

DRIVERS SEAT FAILURE

THE COMPLAINANTS ALLEGE THE DRIVERS SEAT MOUNTING FAILS, ALLOWING THE SEAT TO MOVE OR TIP REARWARD INTO A RECLINED POSITION.

PE, Closed , Model Year: 1995

UNDERSEAT VEHICLE FIRES

ALLEGED SHORTING OF WIRE FOR POWER SEAT CAUSES UNDERSEAT FIRE.

EA, Closed , Model Year: 1992

POOR BRAKE PERFORMANCE

POOR PERFORMANCE OF ABS BRAKES

DP, Closed , Model Year: 1984

POOR BRAKING ON PANIC STOP

CHEVROLET SUBURBAN - All Years Overview

Complete safety history for the CHEVROLET SUBURBAN across all model years (1981, 2024).

178 Total Recalls

10,548 Total Complaints

9 Investigations

814 Reported Crashes

186 Reported Fires

21 Reported Deaths

CHEVROLET SUBURBAN - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2024	1	49	View
2023	3	141	View
2022	4	150	View
2021	12	242	View
2020	4	60	View
2019	3	92	View
2018	4	111	View
2017	5	184	View
2016 (current)	6	297
2015	11	588	View
2014	3	77	View
2013	4	170	View
2012	4	139	View
2011	3	193	View
2010	3	161	View
2009	5	133	View
2008	4	276	View
2007	4	358	View
2006	1	33	View
2005	7	161	View
2004	6	265	View
2003	7	361	View
2002	4	352	View
2001	8	543	View
2000	11	382	View
1999	2	861	View
1998	3	299	View
1997	3	556	View
1996	4	531	View
1995	7	587	View
1994	6	1,038	View
1993	2	616	View
1992	5	226	View
1991	4	65	View
1990	4	67	View
1989	4	68	View
1988	4	35	View
1987	1	21	View
1986	0	7	View
1985	0	12	View
1984	0	6	View
1983	0	4	View
1982	1	1	View
1981	1	1	View
1979	0	1	View
1978	0	3	View
1977	0	3	View

Other CHEVROLET Models

Model	Recalls	Complaints
TAHOE	240	12,622	View
MALIBU	216	29,080	View
SILVERADO 1500	200	22,534	View
CORVETTE	187	6,308	View
CAMARO	179	4,298	View
SILVERADO	159	10,964	View
SILVERADO 3500	152	1,409	View
EXPRESS	151	838	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2016 CHEVROLET SUBURBAN

Complaint Statistics

Top Reported Components

Technical Service Bulletins, 2016 CHEVROLET SUBURBAN

Most Affected Components

NHTSA Safety Investigations, CHEVROLET SUBURBAN

CHEVROLET SUBURBAN - All Years Overview

CHEVROLET SUBURBAN - Year by Year

Other CHEVROLET Models