2006 TOYOTA PRIUS

6 recalls, 1,690 complaints - 267 TSBs

STEERING

Defect Description

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These... Read more

Consequence

Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.

Remedy

Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

669,705 vehicles affected

Manufacturer: Toyota Motor Engineering & Manufacturing

ENGINE AND ENGINE COOLING

Defect Description

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the... Read more

Consequence

The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.

Remedy

Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

350,662 vehicles affected

Manufacturer: Toyota Motor Engineering & Manufacturing

EQUIPMENT:OTHER:LABELS

Defect Description

SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Consequence

A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.

Remedy

DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.

153,418 vehicles affected

Manufacturer: SOUTHEAST TOYOTA DISTRIBUTORS, LLC

VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

Defect Description

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.

Consequence

A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.

Remedy

TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED A... Read more

4,445,056 vehicles affected

Manufacturer: TOYOTA MOTOR NORTH AMERICA, INC.

STEERING:ELECTRIC POWER ASSIST SYSTEM

Defect Description

THE INTERMEDIATE SHAFT AND SLIDING YOKE IN THE ELECTRIC POWER STEERING SYSTEM CAN CRACK WHEN LARGE FORCES ARE APPLIED AND THE CONNECTION MAY SEPARATE OR THE SLEEVE MAY FRACTURE.

Consequence

THIS COULD RESULT IN A LOSS OF STEERING CONTROL OF THE VEHICLE.

Remedy

TOYOTA WILL REPLACE THE STEERING INTERMEDIATE SHAFT AND INSPECT THE SLIDING YOKE AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON JUNE 9, 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

170,856 vehicles affected

Manufacturer: TOYOTA MOTOR NORTH AMERICA, INC.

AIR BAGS

Defect Description

ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDIT... Read more

Consequence

THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.

Remedy

DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.

133 vehicles affected

Manufacturer: TOYOTA MOTOR NORTH AMERICA, INC.

Complaint Statistics

1,690 total complaints 106 crashes 7 fires 65 injuries 1 deaths

Top Reported Components

Component	Complaints
EXTERIOR LIGHTING	820
ELECTRICAL SYSTEM	145
EXTERIOR LIGHTING:HEADLIGHTS	121
SERVICE BRAKES, HYDRAULIC	84
VEHICLE SPEED CONTROL	80
SERVICE BRAKES	66
SERVICE BRAKES, ELECTRIC	45
UNKNOWN OR OTHER	30
ENGINE	28
AIR BAGS	24

Incident date: Apr 20, 2026

The vehicle experiences major engine performance issues following a replacement engine installation (approximately 8,000 miles on the new engine). Additionally, the catalytic converter is malfunctioning, the steering exhibits significant pulsation during braking, and the suspension system is malfunc... Read more

Incident date: Feb 25, 2026

Failing front exhaust pipe mounting bracket. GM has a special coverage program (N212356540) for 2019-2020 Chevrolet Traverse which covers the repair for 15 years or 150,000 miles from the original service date. The coverage is VIN specific. My vehicle has been having this issue for two years now... Read more

Incident date: Sep 7, 2025

Please failure of windshield camera 36160 thr a11 has malfunctioned IDAS

Incident date: Dec 2, 2024

The contact owns a 2020 Ford F-250. The contact stated while driving 45 MPH, the vehicle sputtered and lost power. The vehicle was towed to the residence. The contact stated that a mobile mechanic diagnosed the vehicle and determined that the engine needed to be replaced. The manufacturer was notifi... Read more

Incident date: Dec 2, 2024

Subject: Safety Concern Regarding 2017 Genesis G80 Dear NHTSA, I am writing to report an ongoing issue with my 2017 Genesis G80. While driving, I have experienced a significant safety concern related to the vehicle's acceleration. Specifically, when accelerating at various speeds, the vehicle begins... Read more

Incident date: Dec 6, 2024

The contact owns a 2022 Chevrolet Silverado 1500 equipped with BFGoodrich Tires, Tire Line: KO3, Tire size: 275/65/R20, DOT Number: (N/A). The contact stated while driving at 55 MPH, the upper arm failed, and the tire detached from the vehicle. The contact stated he pulled over to the left side of ... Read more

Incident date: Dec 6, 2024

The contact owns a 2023 Volkswagen Tiguan. The contact stated that while driving 35-40 MPH, the engine warning light illuminated. The vehicle was leaking oil. The vehicle was taken to the local dealer, where it was diagnosed that the oil separator, PCV Positive Crankcase Ventilation valve, and gaske... Read more

Incident date: Dec 6, 2024

The contact owns a 2023 Ford F-150. The contact stated while driving 70 MPH, the transmission downshifted to second gear unexpectedly, causing the rear wheels to squeal. There was no warning light illuminated. The contact pulled to the side of the road temporarily. The contact stated resumed driving... Read more

Incident date: Aug 28, 2024

Car reading codes- Po56z-00 C0609-08 U0151-00 No A/C Front bumper clips do not stay tight Car reading low voltage Less than 14,000 miles with all these issues already, what a nightmare.

Incident date: Jun 1, 2024

Awning deployed while driving Vehicle causing canopy to detach and fly down road. Because of a switch in the storage compartment that had no safety Cover

Incident date: May 1, 2023

I have been driving this car for three years, and it performed exceptionally well until Friday, July 12, 2024. While driving on the highway, the "Engine Power Reduced" warning light activated. I pulled over, placed the car in park, waited a few seconds, and restarted the engine, but the issue persis... Read more

Incident date: May 1, 2023

Approximately 3 weeks ago had SVC 4WD light came on. I took it to my mechanic and was told they couldn't diagnose it because a special subscription has to be paid for to access what the Jeep code is. Was able to find a mechanic that could diagnose the Jeep code, turns out the PTU needs to be repla... Read more

Incident date: Jul 1, 2023

Touch screen has ghosting effects, and automatically starts disabling safety and alert systems, calling random people, playing music, muting calls, navigating to random places, etc. without any input from the user. Mazda has an existing service bulletin for this issue that includes the Mazda 6 (Mazd... Read more

Incident date: Jul 1, 2023

I have an infiniti qx60 that has a hairbag malfunctioning for a long time now. I've taken it to be serviced by infiniti many times. However, they could never fix it. At one point, I decided to leave it alone until the last time I took the car in to be serviced. The person who was helping me noticed ... Read more

Incident date: Jul 1, 2023

Incident date: Jun 15, 2023

My vehicle does not have a horn in the center. It is a button. Elon Musk told the public over and over they all had a center horn that just wasn’t activated yet, that would enable it in a future software update and that was a lie. This button horn on the right hand side never functions when needed... Read more

Incident date: Jun 15, 2023

I have a Toyota sienna 2022 Limited AWD, not been driving much recently. The last time I drove was 2 days ago but local around 2 miles. Today I tried opening my doors, and there is no response at all. At first I thought maybe my key fob is dead, so I grabbed my spare and tried, nothing. Pull both my... Read more

Incident date: Jun 3, 2023

I saw that 2012-2015 kia fortes had a recall for engines but mine was not a part of it. My car had a ticking/knocking sound and I took it to the mechanic and he said that I needed a new engine, he said the knocking could have started because of low oil which is impossible because I have kept up on m... Read more

Incident date: Jun 3, 2023

The vehicle had a safety recall performed on 3/28/23. The safety recall was to fix the problem of the vehicle shutting off while driving. On 4/23/23 while travelling on the highway at 70 the vehicle went into limp mode and started coasting. I had to drift to the side of the road. I was able to resta... Read more

Incident date: Mar 9, 2023

I tried to speak with Kia about a recall the engine on my making model I remember seeing it on your guises website this issue was never fixed and I’m currently having issues with my engine and they’re refusing to replace it. I’m trying to avoid a lawsuit and a serious accident because of the w... Read more

Incident date: Feb 28, 2023

I have a 2018 Honda odyssey 9 speed and I am well aware of the many issues people have been complaining of and I am experiencing many of those same issues. My number one issue is my acceleration. I need to step down all the way on the gas pedal to make the car move and once it does my rear tires spi... Read more

Incident date: Oct 5, 2022

The contact owns a 2006 Toyota Prius. The contact stated while she was sitting in the vehicle that was parked in the garage, the vehicle accelerated on its own and proceeded to move forward while the emergency brake was activated, and no warning light illuminated. The vehicle struck the contacts hom... Read more

Crash

Incident date: Sep 6, 2022

The contact owns a 2006 Toyota Prius. The contact stated while his wife was attempting to stop the engine and turn off the vehicle, the vehicle failed to turn off. There were no warning lights illuminated. The contact's wife was able to drive safely to the residence. The contact disconnected the ba... Read more

Incident date: Aug 13, 2022

Randomly the instrument panel (dashboard) does not turn on with the vehicle.

Incident date: Apr 1, 2022

The abs actuator is bad. Cant stop nor use the rechargeable braking. Very dangerous.

Incident date: Apr 1, 2022

The abs actuator is bad. Cant stop nor use the rechargeable braking. Very dangerous.

Incident date: Jul 15, 2017

Power braking goes out and ringing in car with brakes and abs light on. Have to press extra hard to brake car. Also anther time coming out of a parking lot in reverse and brakes just stopped car as if I had hit something but had not hit anything.

Incident date: Jan 10, 2022

The contact owns a 2006 Toyota Prius. The contact stated while getting into the vehicle, there was a loud buzzing sound coming from the brakes. The contact stated that the brake, anti-slip regulation, ABS, and vehicle stability control warning lights were illuminated on the instrument panel. The con... Read more

Incident date: Jan 10, 2022

Incident date: Jan 27, 2021

Headlights Malfunctioning. Red triangle light has been present since the week after purchase. 2006 Prius was inspected by Toyota and a private technician. Headlights and 2 Relay fuses have been replaced and is still malfunctioning. This is a safety risk having headlights not working properly can cau... Read more

Incident date: Jan 27, 2021

Incident date: Jun 15, 2013

When I brake and also go over a bump my 2006 Prius lurches forward. The traction control light illuminates. The faulty traction control system sent me into a 1-2 second lurch forward with zero brakes. Then the brake engage then I can stop. I told the dealer about it and they told me there is reprogr... Read more

Incident date: Sep 7, 2021

In June of 2018 My brake actuator failed on my 2006 Prius. At that time I had 169,689 miles on the vehicle. I had the part replaced at Autonation, a Toyota dealership for $2626 . Recently I had noticed that while sitting at a stoplight I was hearing a tapping noise at the brakes along with what they... Read more

Incident date: Mar 3, 2021

Discovered through failures repeated to dealers that certain items (Brakes, dashboard, et. al.) were recalled by Toyote. Never received recall notices. Contacted Toyota who demanded the vehicle be taken to dealer and now refuses to do anything. Have complete documentation to attach to this communica... Read more

Incident date: Mar 3, 2021

Incident date: Aug 18, 2021

Vehicle, upon turning on ignition/starting and putting in either drive or reverse gear, on level surface with brakes still applied will roll forward or backward. This has happened several times but usually at first start up for the day No warning lights(brake or other) are displayed Brake pedal is ... Read more

Incident date: Jul 24, 2021

The contact owns a 2006 Toyota Prius. The contact stated that while driving at an undisclosed speed, the vehicle lost power and immediately regained power. Approximately 24 hours later the check engine warning light illuminated. The vehicle was taken to an independent mechanic who diagnosed that the... Read more

Incident date: Jul 24, 2021

Incident date: May 31, 2021

The contact owns a 2006 Toyota Prius. The contact stated that the vehicle intermittently failed to shut-off as needed with several unknown warning lights illuminated. The contact had taken the vehicle to the dealer on three separate occasions and the mechanic was able to either disconnect the batter... Read more

Incident date: Jun 3, 2021

Hi, After being parked for about 1.5 hrs my back seat on the drivers side caught on fire. I understand this is where a battery is and that newer cars of this brand have had recalls for this problem.

Fire

Incident date: Jun 3, 2021

Hi, After being parked for about 1.5 hrs my back seat on the drivers side caught on fire. I understand this is where a battery is and that newer cars of this brand have had recalls for this problem.

Fire

Incident date: Jun 3, 2021

The contact owns a 2006 Toyota Prius. While receiving an oil change by an independent mechanic, the contact was informed that there was a large crack to the engine cradle located on the undercarriage. The contact was informed by the mechanic that the vehicle was unsafe to drive. The contact notified... Read more

Incident date: May 13, 2021

THE TOYOTA PRIUS 2006 WAS HIT FROM BEHIND (REAR ENDED) ON 05/13/2021 AND DRIVER'S SEAT COLLAPSED BACKWARDS, CAUSING A HEAD INJURY. THIS WAS NOT EXPECTED AND IS NOT ACCEPTABLE BY ANY SAFETY STANDARD. FORTUNATELY THERE WERE NO OTHER OCCUPANTS IN THE VEHICLE. THIS WAS A CHAIN COLLISION AND THE PRIUS... Read more

Crash 2 injured

Incident date: Jul 20, 2020

WHILE VEHICLE WAS IN MOTION ON A CITY STREET, AND ALSO UPON BACK ROADS, THE BRAKES IN MY 2006 TOYOTA PRIUS SEEMED TO GRAB. THERE WAS ALSO A LOUD NOISE UPON BRAKING. THIS ISSUE WORSENED AND THE DASH LIGHTS LIT UP. I TOOK TO LOCAL TOYOTA DEALERSHIP AND IT WAS DETERMINED THAT THE BRAKE ACTUATOR NEEDS T... Read more

Incident date: Aug 21, 2020

THE BRAKE BOOSTER IS MAKING LOTS OF CHIRPING NOISE WHEN THE BRAKE PEDAL IS DEPRESSED. WHILE I AM NOT GETTING ANY VISUAL INDICATORS OF FAILURE AT THIS MOMENT I BELIEVE (DUE TO MY OWN RESEARCH) THAT WHEN I DO THERE IS A HIGH CHANCE OF ME GETTING INTO A CAR ACCIDENT. I HAVE READ ON PRIUSCHAT.COM THAT ... Read more

Incident date: Feb 9, 2018

OWNER BEGAN NOTICING BRAKING PROBLEM IN NOVEMBER 2017. BRAKE PEDAL WOULD GO TO FLOOR WITH MINIMAL BRAKING. PROBLEM CONTINUED TO GET WORSE. OWNER TOOK VEHICLE TO TOYOTA DEALERSHIP AFTER HOLIDAY PERIOD ON 02/09/18 FOR DIAGNOSTICS. TOYOTA ADVISED OWNER OF FAILURE OF THE BRAKE ACTUATOR ASSEMBLY, $2500.0... Read more

Incident date: Jul 14, 2020

KNOWN PROBLEM WITH COMBINATION METER - FOUND IT SEARCHING ONLINE ONCE I REALIZED THIS WAS THE PROBLEM. I BOUGHT MY CAR USED AND SINCE IT IS NO LONGER COVERED BY TOYOTA, IT DIDN'T COME UP IN SEARCH. HAVING ISSUES WITH THERE BEING NO DISPLAY ON THE DASH AND VEHICLE NOT SHUTTING OFF FOR THE ENTIRE TIME... Read more

Incident date: Jul 14, 2020

Incident date: Dec 9, 2019

ACCORDING TO THE TOYOTA DEALERSHIP WHERE I HAVE MY CAR MAINTAINED, MY 2006 PRIUS IS IN NEED OF A NEW MOTHERBOARD. APPARENTLY THERE WAS A RECALL ON THIS PRIOR TO SO MANY MILES ON THE VEHICLE BUT I HAVE MISSED THIS DEADLINE AS MY CAR DID NOT SHOW THESE SYMPTOMS PRIOR TO THE CUTOFF.. MY PRIUS WHEN TUR... Read more

Showing 50 of 1,690 complaints.

EPA Fuel Economy, 2006 TOYOTA PRIUS

Trim / Engine	City MPG	Highway MPG	Combined MPG	Fuel Type	Annual Fuel Cost
1.5L 4-cyl, Automatic (variable gear ratios) (Front-Wheel Drive)	48.0	45.0	46.0	Regular	$1,350

CO2 Emissions: -1.0 g/mile (Midsize Cars)

Source: U.S. Environmental Protection Agency (EPA). Actual fuel economy may vary based on driving conditions.

Technical Service Bulletins, 2006 TOYOTA PRIUS

267 manufacturer communications from 138 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
350000 EQUIPMENT	36
110000 ELECTRICAL SYSTEM	28
111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY	20
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL	19
353000 EQUIPMENT:ELECTRICAL	17
060000 ENGINE (PWS)	11
118000 ELECTRICAL SYSTEM:SOFTWARE	10
140000 AIR BAGS	10

061500 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION

This is to advise of various price adjustments that will affect Toyota Genuine Motor Oil and Long Life Coolant, effective March 1, 2024. These products are ordered through the Toyota Complete Maintenance Care (TCMC) website.

060000 ENGINE AND ENGINE COOLING

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

OBSOLETE NOTICE January 22, 2024: This bulletin is now obsolete. Please see T-SB-0057-18.

350000 EQUIPMENT

TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2023 model year vehicles may be available provided the re

180000 VEHICLE SPEED CONTROL

140000 AIR BAGS

350000 EQUIPMENT

TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Follow the procedures in this bulletin to

110000 ELECTRICAL SYSTEM

140000 AIR BAGS

TSB: Some 2005 ? 2022 model year Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty smell is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The pur

350000 EQUIPMENT

DL: ZTN Expired on June 1, 2022

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

DL: ZTN Expired on June 1, 2022

119100 ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY

TSB: This bulletin includes basic procedures for performing a rescue charge on Ni-MH high voltage (HV) batteries. This bulletin should be used in conjunction with the applicable model and model year Repair Manual while performing a rescue c

350000 EQUIPMENT

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

280000 BACK OVER PREVENTION

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions

030000 SERVICE BRAKES, HYDRAULIC

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions

350000 EQUIPMENT

OBSOLETE NOTICE Month 09, 2022: This bulletin is now obsolete. Please see T-SB-0014-22.

050000 PARKING BRAKE

TSB: This Service Bulletin includes procedures to replace damaged or loose front carpet floor retainer(s) without replacing the carpet assembly. Follow the Repair Procedure in this bulletin to replace the loose or damaged carpet floor retai

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. This information must be kept near the point of vehicle sale and be available to any custom

200000 WHEELS

190000 TIRES

160000 STRUCTURE

353000 EQUIPMENT:ELECTRICAL

TT: Some customers may encounter Bluetooth? connectivity concerns such as: ?Difficulty to pair the phone. ?Intermittent Bluetooth? failure to connect to the vehicle when first turning on the vehicle. ?Various Bluetooth? Audio function

140000 AIR BAGS

Toyota Safety Recall and Service Campaign - Technician Certification Requirements

280000 BACK OVER PREVENTION

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.

030000 BRAKES (PWS)

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.

350000 EQUIPMENT

TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2021 model year vehicles may be available provided the re

280000 BACK OVER PREVENTION

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.

030000 BRAKES (PWS)

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.

030000 SERVICE BRAKES, HYDRAULIC

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.

353000 EQUIPMENT:ELECTRICAL

TSB: Some 2004 ? 2020 model year Hybrid vehicles may exhibit an excessive buildup of dust, lint, or debris in the HV battery intake filter or cooling fan. The condition could reduce the efficiency of the HV battery cooling system. Perform t

356000 EQUIPMENT ADAPTIVE/MOBILITY

350000 EQUIPMENT

110000 ELECTRICAL SYSTEM

010000 STEERING

060000 ENGINE (PWS)

TSB: OBSOLETE NOTICE August 11, 2020: This bulletin is no longer applicable and is now obsolete.

110000 ELECTRICAL SYSTEM

TSB: OBSOLETE NOTICE August 11, 2020: This bulletin is no longer applicable and is now obsolete.

060000 ENGINE (PWS)

TSB: OBSOLETE NOTICE August 11, 2020: This bulletin is no longer applicable and is now obsolete.

110000 ELECTRICAL SYSTEM

TSB: OBSOLETE NOTICE August 11, 2020: This bulletin is no longer applicable and is now obsolete.

060000 ENGINE (PWS)

TSB: OBSOLETE NOTICE August 08, 2020: This bulletin is no longer applicable and is now obsolete.

110000 ELECTRICAL SYSTEM

TSB: OBSOLETE NOTICE August 08, 2020: This bulletin is no longer applicable and is now obsolete.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

TSB: OBSOLETE NOTICE August 08, 2020: This bulletin is no longer applicable and is now obsolete.

350000 EQUIPMENT

TSB: Some 2003 ? 2020 model year Prius, Prius C, Prius V; 2006 ? 2019 model year Highlander Hybrid Vehicle; 2007 ? 2020 Camry Hybrid Vehicle; 2013 ? 2020 model year Avalon Hybrid Vehicle; 2016 ? 2020 model year Mirai and RAV4 Hybrid Vehic

110000 ELECTRICAL SYSTEM

062200 ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

062200 ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

200000 WHEELS

TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. ST005-01, SU001-08, and T-SB-0391-08. The aforementioned bulletins are obsolete, and any printed versions should be discarded. Be sure

020000 SUSPENSION

TSB: OBSOLETE NOTICE June 23, 2020: This bulletin is now obsolete. Please see T-SB-0063-20.

110000 ELECTRICAL SYSTEM

TT: This bulletin includes basic procedures for performing a rescue charge on Ni-MH high voltage (HV) batteries. This bulletin should be used in conjunction with the applicable model and model year Repair Manual while performing a rescue ch

350000 EQUIPMENT

TSB: OBSOLETE NOTICE April 07, 2020: This bulletin is now obsolete. Please see T-SB-0032-20. Replacement Certification Labels and VIN Plates

350000 EQUIPMENT

TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. PG021-88, PG015-89, PG0015-90, PG002-91, PG002-93, PG005-97, PG007-01, PG007-07, PG006-01, PG004-97, T-SB-0144-08, and T-SB-0304-17. The a

350000 EQUIPMENT

OBSOLETE NOTICE February 12, 2020: This bulletin is now obsolete. Please see T-SB-0010-20.

350000 EQUIPMENT

TSB: Some 2004 ? 2017 model year Toyota vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Although there is no way to eliminate these odors, follow the General Procedure in this bull

350000 EQUIPMENT

TSB: Vehicles may display evidence of a fluid leak or fluid seep from powertrain components. This bulletin explains how to determine the differences between a fluid leak versus a fluid seep. Cases that are determined to be a ?leak? should b

356000 EQUIPMENT ADAPTIVE/MOBILITY

TSB: REVISION NOTICE November 13, 2019 Rev2: ? The Warranty Information section has been updated. July 02, 2019 Rev1: ? The Applicable Warranty section has been updated. Any previous printed versions of this bulletin should be discarded. So

111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

350000 EQUIPMENT

010000 STEERING

TT: Some customers may encounter Bluetooth? connectivity concerns such as: ? Difficulty to pair the phone. ? Intermittent Bluetooth? failure to connect to the vehicle when first turning on the vehicle. ? Various Bluetooth? Audio functions a

111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

TSB: REVISION NOTICE July 02, 2019 Rev1: ? The Applicable Warranty section has been updated. Any previous printed versions of this bulletin should be discarded. Some 2004 ? 2009 model year Prius vehicles may exhibit a MIL ON condition with

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

100000 POWER TRAIN

TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections have been updated. October 30, 2017 Rev1: ? Applicability has be

110000 ELECTRICAL SYSTEM

060000 ENGINE (PWS)

110000 ELECTRICAL SYSTEM

TT: Some customers may encounter Bluetooth? connectivity concerns such as: ? Difficulty to pair the phone. ? Intermittent Bluetooth? failure to connect to the vehicle when first turning on the vehicle. ? Various Bluetooth? Audio functions a

350000 EQUIPMENT

TT: Some customers may encounter Bluetooth? connectivity concerns such as: ? Difficulty to pair the phone. ? Intermittent Bluetooth? failure to connect to the vehicle when first turning on the vehicle. ? Various Bluetooth? Audio functions a

353000 EQUIPMENT:ELECTRICAL

TT: Some customers may encounter Bluetooth? connectivity concerns such as: ? Difficulty to pair the phone. ? Intermittent Bluetooth? failure to connect to the vehicle when first turning on the vehicle. ? Various Bluetooth? Audio functions a

350000 EQUIPMENT

TT: Some customers may encounter Bluetooth? connectivity concerns such as: ? Difficulty to pair the phone. ? Intermittent Bluetooth? failure to connect to the vehicle when first turning on the vehicle. ? Various Bluetooth? Audio functions a

353000 EQUIPMENT:ELECTRICAL

TT: Some customers may encounter Bluetooth? connectivity concerns such as: ? Difficulty to pair the phone. ? Intermittent Bluetooth? failure to connect to the vehicle when first turning on the vehicle. ? Various Bluetooth? Audio functions a

110000 ELECTRICAL SYSTEM

Dealer Package: September 11, 2018 A watermark has been added to the Dealer Letter to indicate that ZTJ expired on September 10, 2018. Unlike halogen light bulbs which simply stop working at the end of their useful life, as the HID bulb ne

120000 EXTERIOR LIGHTING

350000 EQUIPMENT

Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17.

355100 EQUIPMENT:OTHER:LABELS

Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17.

350000 EQUIPMENT

Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17.

355100 EQUIPMENT:OTHER:LABELS

Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17.

350000 EQUIPMENT

TSB: REVISION NOTICE July 31, 2018 Rev2: ? The Supersession Notice has been updated. January 11, 2018 Rev1: ? The Supersession Notice has been updated. Any previous printed versions of this bulletin should be discarded. SUPERSESSION NOTICE

350000 EQUIPMENT

TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. T-SB-0043-14. ? Applicability has been updated to include 2017 ? 2018 model year Toyota vehicles. Service Bulletin No. T-SB-0043-14 is obso

030000 BRAKES (PWS)

Warranty Policy Bulletin: Toyota has received some reports where various brake system related warning lamps illuminate due to internal malfunctions of the Brake Actuator Assembly.

190000 TIRES

TSB: REVISION NOTICE February 12, 2018 Rev2: ? Applicability has been updated to include 2015 ? 2018 model year vehicles. January 23, 2014 Rev1: ? Applicability has been updated to include 2013 ? 2014 model year vehicles. Any previous print

190000 TIRES

350000 EQUIPMENT

TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. PG021-88, PG015-89, PG0015-90, PG002-91, PG002-93, PG005-97, PG007-01, PG007-07, and T-SB-0144-08. Service Bulletin Nos. PG021-88, PG015-89

110000 ELECTRICAL SYSTEM

TSB: REVISION NOTICE November 22, 2017 Rev1: ? Applicability has been updated to include 2014 ? 2018 model year vehicles. Any previous printed versions of this bulletin should be discarded. In the event that a Toyota vehicle becomes submerg

350000 EQUIPMENT

TSB: OBSOLETE NOTICE November 21, 2017: This bulletin is now obsolete. Please see T-SB-0304-17.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

TSB: REVISION NOTICE October 30, 2017 Rev1: * Applicability has been updated to include 2018 model year vehicles. SUPERSESSION NOTICE The information contained in this bulletin supersedes SB No. T-SB-0012-13. Flash reprogramming allows the

162300 STRUCTURE:BODY:DOOR

TSB: Vehicle replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) may be available from Toyota, provided the request meets one of the criteria lis

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

TSB: REVISION NOTICE July 20, 2017 Rev1: Applicability has been updated to exclude 2007 ? 2017 model year Avanza vehicles. Some hazardous material treatment and handling regulations at the state and local level define the pre-disposal deplo

140000 AIR BAGS

030000 BRAKES (PWS)

TSB: REVISION NOTICE: April 18, 2017 Rev1: G458The Parts Information and Required Tools and Equipment sections have been updated. Some 2004 ? 2009 model year Prius and 2006 ? 2007 model year Highlander HV vehicles may exhibit a condition wh

035000 SERVICE BRAKES, HYDRAULIC:FLUID

052310 PARKING BRAKE:DRIVELINE:HYDRAULIC:ACTUATOR

111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

TT: A vehicle may arrive to the dealer with a MIL ?ON? condition and P0A80 or P1AC000 stored in the memory. Some cases have been identified with internal modification done to the HV Battery. Modified or altered parts are not covered under

110000 ELECTRICAL SYSTEM

TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes SB No. T-SB-0101-11. Applicability has been updated to include 2016 ? 2017 model year vehicles. Service Bulletin No. T-SB-0101-11 is Obsolete and any printed

118000 ELECTRICAL SYSTEM:SOFTWARE

TSB: OBSOLETE NOTICE: September 14, 2016: This bulletin is now obsolete. Please see T-SB-0134-16.

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

TSB: REVISION NOTICE November 10, 2016 Rev2: ? Applicability has been updated to include 2016 ? 2017 model year Toyota vehicles. ? Parts Information section has been updated. Some 2004 ? 2017 model year Toyota vehicles may exhibit odor

350000 EQUIPMENT

TT: A vehicle may arrive to the dealer with a MIL ?ON? condition and P0A80 stored in the memory. Some cases have been identified with internal modification done to the HV Battery. Modified or altered parts are not covered under warranty.

060000 ENGINE (PWS)

TSB: Supersession Notice. Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service

110000 ELECTRICAL SYSTEM

353000 EQUIPMENT:ELECTRICAL

TT: Some customers may encounter Bluetooth? connectivity concerns such as: *Difficulty to pair the phone. *Intermittent Bluetooth? failure to connect to the vehicle when first turning on the vehicle. *Various Bluetooth? Audio functions a

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

Showing 100 of 267 bulletins.

NHTSA Safety Investigations, TOYOTA PRIUS

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

DP, Closed , Model Year: 2004

Intermediate Steering Shaft Separation

The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition... evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606Read more

PE, Closed , Model Year: 2010

Braking Performance, Hybrid Vehicle

The subject vehicles are the first model year of a new design generation of the Prius model line.The vehicles are powered by a hybrid drive system that uses both a regenerative braking system, which converts vehicle momentum into electrical energy to be stored in onboard batteries, and a hydraulic b... Read more

PE, Closed , Model Year: 2006

HEADLIGHT FAILURE

ODI OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS THAT BOTH HEADLIGHTS WOULD GO OUT, OR EXTINGUISH WHILE DRIVING.THE SUBJECT VEHICLES ARE EQUIPPED WITH HIGH INTENSITY DISCHARGE (HID) HEADLAMPS THAT OPERATE ON INDEPENDENT LAMPS AND ECU'S (ELECTRONIC CONTROL UNITS) FOR EACH HEADLIGHT, MEANING THAT... EACH HEADLIGHT RUNS INDEPENDENTLY OF THE OTHER, AND A FAILURE IN ONE LAMP OR ECU DOES NOT NECESSARILY RESULT IN A FAILURE OF THE OTHER.DURING THE INVESTIGATION, A RANDOM SAMPLE OF FORTY CONSUMERS WAS CONTACTED BY ODI IN A TELEPHONE SURVEY TO VERIFY THEIR EXPERIENCES.THE CONSUMERS STATED IN COMPLAINTS TO TOYOTA THAT BOTH HEADLIGHTS FAILED AT THE SAME TIME.ODI DISCOVERED THROUGH TALKING WITH THESE COMPLAINANTS THAT IN FACT ONE HEADLIGHT WOULD BEGIN TO FLICKER AND THEN CUT OFF.THE OTHER HEADLIGHT WOULD STILL BE OPERATIONAL.IN A FEW CASES WHERE NO ACTION WAS TAKEN, SOME COMPLAINANTS STATED THAT AFTER A FEW MONTHS BOTH HEADLAMPS WOULD BEGIN TO FAIL RESULTING IN NO HEADLIGHTS; HOWEVER NONE REPORTED THAT BOTH LAMPS FAILED SIMULTANEOUSLY.COMPLAINANTS ALSO STATED THAT THEY COULD TOGGLE THE HEADLAMP SWITCH ON AND OFF TO TEMPORARILY RESTORE LIGHTING WHEN THIS CONDITION OCCURRED, EVEN IN CASES WERE BOTH HEADLAMPS WERE EXTINGUISHED.THE RESULTS OF THIS SURVEY ARE LARGELY CONSISTENT WITH ODI'S ASSESSMENT OF THE REPORTS AND WARRANTY DATA.TOYOTA SUBMITTED IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER THAT, GENERALLY SPEAKING, ONLY ONE LAMP FAILED AT A TIME, AND THAT TOGGLING THE SWITCH RESTORED THE LAMP.TOYOTA REQUESTED A MEETING WITH ODI AND ON AUGUST 6, 2009, PRESENTED THEIR ASSESSMENT OF HEADLAMP FAILURE.TOYOTA CONFIRMED THAT A HEADLAMP COULD EXTINGUISH WHILE DRIVING DUE TO A BULB FAILURE, AND THAT IT COULD BE TEMPORARILY RESTORED BY TURNING THE HEADLIGHT SWITCH ON AND OFF, AND THAT SIMULTANEOUS FAILURE OF BOTH HEADLAMPS WAS RARE AND UNLIKELY.TOYOTA ALSO BRIEFLY DISCUSSED THEIR INTENTION TO CONDUCT A CUSTOMER SERVICE CAMPAIGN TO ADDRESS CONSUMER DISSATISFACTION WITH HID BULB FAILURES.SINCE THERE IS STILL ONE HEADLIGHT OPERATING WHEN THE OTHER ONE CUTS OFF, THERE IS STILL LIGHTING AVAILABLE TO GET THE VEHICLE TO A REPAIR FACILITY.THUS, A SAFETY DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.Read more

PE, Closed , Model Year: 2004

ENGINE STALLING

ODI OPENED PE05-029 BASED ON 33 REPORTS OF ALLEGED GASOLINE ENGINE STALLING ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES ARE GASOLINE/ ELECTRIC HYBRID VEHICLES THAT CAN BE OPERATED IN GASOLINE OR ELECTRIC MODES, OR A COMBINATION OF BOTH DEPENDING ON THE POWER DEMAND.ALL REPORTS ALLEGE THAT THE GASOL... INE ENGINE SHUT DOWN SUDDENLY WITHOUT WARNING.SOME OF THE COMPLAINANTS REPORTED THAT THE VEHICLE CONTINUED TO OPERATE USING THE ELECTRIC MODE FOR A PERIOD OF TIME AFTER THE GAS ENGINE STALLED AND SOME REPORTED THAT THE VEHICLE SHUT DOWN AT THE SAME TIME THAT THEY FELT THE GAS ENGINE STALLED.SOME CONSUMERS REPORTED THAT THEY WERE ABLE TO RESTART THE VEHICLE EITHER IMMEDIATELY OR AFTER ALLOWING THE VEHICLE SIT FOR A SHORT TIME, WHEREAS OTHERS REPORTED THAT THEY HAD THEIR VEHICLE TOWED.DURING PE05-029, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.THE COMPLAINT DATA REPRESENTS INCIDENTS WHERE ENGINE STALLING WAS ALLEGED OR WHERE THE VEHICLE WAS ALLEGED TO HAVE ONE OF THE VARIOUS CONDITIONS THAT CAUSES THE GAS ENGINE TO STALL.IN ITS AUGUST 26, 2005 RESPONSE TO ODI'S INFORMATION REQUEST, TOYOTA IDENTIFIED VARIOUS CONDITIONS THAT COULD CAUSE THE SUBJECT VEHICLES TO EXPERIENCE A GAS ENGINE STALL.IF THIS HAPPENS, THE DRIVER IS ALERTED BY AN AUDIBLE SOUND AND VARIOUS WARNING LIGHTS.THE VEHICLE WILL CONTINUE TO OPERATE IN THE ELECTRIC MODE AND THE ELECTRICALLY-POWERED BRAKE AND STEERING OPERATION WILL CONTINUE TO FUNCTION NORMALLY. ANALYSIS OF THE WARRANTY DATA INDICATED THAT OVER 97% OF VEHICLES EXPERIENCING A GAS ENGINE STALL RESULTED FROM AN ISSUE WITH THE PROGRAM LOGIC IN THE ELECTRONIC CONTROL MODULE (ECM) SYSTEM, WHICH MAY CAUSE THE ECM SYSTEM TO NOT START THE GAS ENGINE WHEN REQUIRED.AS A RESULT, THE VEHICLE WILL ENTER THE LIMITED OPERATION MODE DESCRIBED ABOVE.THE MAJORITY OF THE ODI COMPLAINTS ALSO INDICATED THAT THE DRIVER EXPERIENCED THIS CONDITION IN CONJUNCTION WITH THE ENGINE STALL. DURING OCTOBER 2005, TOYOTA INFORMED ODI THAT IT WOULD INITIATE A SPECIAL SERVICE CAMPAIGN (SSC) TO REPROGRAM THE ECM SOFTWARE ON APPROXIMATELY 75,000 MY 2004 AND EARLY 2005 SUBJECT VEHICLES TO ADDRESS THE GAS ENGINE STALLING CONDITION.DURING THIS SSC, DEALERS WILL ALSO APPLY SPECIAL DIELECTRIC GREASE TO A TRANSAXLE CONNECTOR TO PREVENT WATER INTRUSION WHICH MAY ALSO CAUSE SIMILAR LIMITED OPERATION CONDITIONS.BASED ON ODI'S ANALYSIS, THIS REMEDY SHOULD ADDRESS MOST OF THE INCIDENTS RESULTING IN A LIMITED OPERATION MODE.GIVEN THESE CIRCUMSTANCES, FURTHER USE OF THE AGENCY RESOURCES IN THIS MATTER DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.Read more

TOYOTA PRIUS - All Years Overview

Complete safety history for the TOYOTA PRIUS across all model years (2001, 2026).

91 Total Recalls

15,554 Total Complaints

4 Investigations

1,417 Reported Crashes

123 Reported Fires

32 Reported Deaths

TOYOTA PRIUS - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2026	1	5	View
2025	2	28	View
2024	4	31	View
2023	4	25	View
2022	1	31	View
2021	0	11	View
2020	0	23	View
2019	3	51	View
2018	1	45	View
2017	3	127	View
2016	5	215	View
2015	1	209	View
2014	3	276	View
2013	3	535	View
2012	6	541	View
2011	6	662	View
2010	10	3,482	View
2009	6	644	View
2008	4	1,894	View
2007	4	2,451	View
2006 (current)	6	1,690
2005	6	1,298	View
2004	6	737	View
2003	1	123	View
2002	2	201	View
2001	3	215	View
2000	0	4	View

Other TOYOTA Models

Model	Recalls	Complaints
TUNDRA	787	9,074	View
HIGHLANDER	677	6,756	View
RAV4	669	11,842	View
CROWN	548	141	View
TACOMA	406	10,562	View
VENZA	404	969	View
GRAND HIGHLANDER	388	332	View
HIGHLANDER HYBRID	355	1,103	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2006 TOYOTA PRIUS

Complaint Statistics

Top Reported Components

EPA Fuel Economy, 2006 TOYOTA PRIUS

Technical Service Bulletins, 2006 TOYOTA PRIUS

Most Affected Components

NHTSA Safety Investigations, TOYOTA PRIUS

TOYOTA PRIUS - All Years Overview

TOYOTA PRIUS - Year by Year

Other TOYOTA Models