1985 HONDA ACCORD

1 recalls, 19 complaints

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP

Defect Description

IF THE PLASTIC COATING OF THE FUEL FILLER AND/OR BREATHER PIPE IS DAMAGED, SALT WATER MAY ACCUMULATE BETWEEN THE PLASTIC COATING AND THE STEEL PIPES, AND THE ACCUMULATION COULD CAUSE CORROSSION WHICH WOULD EVENTUALLY RUST THROUGH THE AFFECTED PIPES, ALLOWING GASOLINE FUMES AND FUEL TO LEAK.

Consequence

GASOLINE FUMES AND/OR FUEL LEAKAGE THROUGH THE FILLER ORBREATHER PIPES COULD RESULT IN A FIRE WHEN EXPOSED TO A SOURCE OF IGNITION.

Remedy

CORRODED FILLER OR BREATHER PIPES WILL BE CLEANED AND RECOATED OR REPLACED AS NEEDED.

903,219 vehicles affected

Manufacturer: AMERICAN HONDA MOTOR CO.

Complaint Statistics

19 total complaints 5 crashes 2 fires 6 injuries 2 deaths

Top Reported Components

Component	Complaints
SUSPENSION:FRONT	2
FUEL SYSTEM, GASOLINE	1
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP	1
FUEL SYSTEM, GASOLINE:DELIVERY	1
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM	1
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR	1
VEHICLE SPEED CONTROL	1
SEAT BELTS:FRONT:ANCHORAGE	1
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS	1
STRUCTURE:BODY:DOOR	1

Incident date: Aug 9, 2001

HONDA ACCORD GOING 45 MPH WAS STRUCK ON LEFT REAR BY ANOTHER CAR GOING ALSO FORTY 45 MPH HITTING GAS TANK LOCATED BEHIND LEFT BACK PASSENGER DOOR. CAR INGNITED UNDER CAR AS CAR WAS SPINNING FOR AT LEAST ONE MINUTE. FIRE BURNED THOURGH BACKSEAT IGNITING SEAT AND SEATBELT TENNSIONIERS.CAR DOORS DID NO... Read more

Crash Fire 3 injured

Incident date: Aug 9, 2001

Crash Fire 3 injured

Incident date: Oct 26, 2002

CONSUMER STATES WHILE DRIVING THE FRONT SUSPENSION CRADLE BOLTS SNAP, AND CAUSES LOSS OF STEERING CONTROL. DEALER NOTIFIED. MR PHOTOS ATTACHED. *TT

Incident date: Jun 28, 2001

TIRE TREAD SEPARATION ON TWO JUPITER YP-701 TIRE MADE BY WOOSUNG. 3/14/01, REAR PASSENGER SIDE, TIRE DID NOT DEFLATE WHEN THE TREAD SEPARATION OCCURRED, TIRE WAS NOT BALD BUT STILL HAD AN ESTIMATED 10,000 OR MORE TREADLIFE. 6/28/01, REAR DRIVERS SIDE,TREAD SEPARATION, 37,000 MILES ON TIRE, TRAVELIN... Read more

Incident date: Jul 15, 1998

MULTIFUNCTION SWITCH FAILED. NLM

Incident date: Jul 15, 1998

CLUTCH FAILED. NLM

WHILE DRIVING OIL LIGHT CAME ON DUE TO THE ENGINE LEAKING OIL ALSO, DEALER REPLACED SEALS AND BELTS. *AK

Incident date: Mar 13, 1990

18-YEAR OLD SON DROWNED BECAUSE THE VEHICLE WENT INTO A CANAL AND THE POWER WINDOWS/POWER LOCKS WERE INOPERABLE. *AK

Crash 1 deaths

Incident date: Mar 13, 1990

18-YEAR OLD SON DROWNED BECAUSE THE VEHICLE WENT INTO A CANAL AND THE POWER WINDOWS/POWER LOCKS WERE INOPERABLE. *AK

Crash 1 deaths

Incident date: May 13, 1997

SEAT BELTS IN REAR DID NOT WORK PROPERLY. PARKED VEHICLE, TOOK TIRE OFF & NOTICED THAT REAR SEAT BELT CAME DETACHED FROM ANCHOR ATTACHMENT. WILL BE TAKEN VEHICLE TO DEALER. *AK

Incident date: Apr 9, 1997

HIGH SPEED INVOLUNTARY EXCELLERATION, RESULTING IN CRASH. *AK

Crash

Incident date: Oct 1, 1996

REPLACEMENT ROTORS BECAME WARPED AFTER SIX MONTHS AND LESS THAN 6000 MPH; ALSO, FRONT OF VEHICLE MAKES NOISE AFTER FRONT BUSHINGS WERE REPLACED. *AK

Incident date: Oct 1, 1996

REPLACEMENT ROTORS BECAME WARPED AFTER SIX MONTHS AND LESS THAN 6000 MPH; ALSO, FRONT OF VEHICLE MAKES NOISE AFTER FRONT BUSHINGS WERE REPLACED. *AK

IN THE MORNING WHEN OPENING UP THE TRUNK THERE'S OVER CONDENSATION OF WATER BECAUSE THERE MAY NOT BE ANY AIR CIRCULATION. PLEASE DESCRIBE DETAIL. *AK

Incident date: Apr 16, 1995

FUEL LEAKAGE DUE TO RUSTING OF THE GAS LINE. PLEASE DESCRIBE IN MORE DETAIL. *AK

SUN WEST HONDA IN COLORADO SPRINGS REFUSED TO PERFORM RECALL FOR FILLER NECK DUE TO OWNER NOT BEING IN SERVICE AREA. PLEASE DESCRIBE DETAILS. TT

Incident date: Jul 10, 1995

RUSTED FUEL TANK FILLER PIPE RECALL REPAIRS REFUSED DUE TO WRONG ADDRESS (92V-028). *AK

EPA Fuel Economy, 1985 HONDA ACCORD

Trim / Engine	City MPG	Highway MPG	Combined MPG	Fuel Type	Annual Fuel Cost
1.8L 4-cyl, Automatic 4-spd (Front-Wheel Drive)	22.0	27.0	24.0	Regular	$2,600
1.8L 4-cyl, Automatic 4-spd (Front-Wheel Drive)	22.0	27.0	24.0	Regular	$2,600
1.8L 4-cyl, Manual 5-spd (Front-Wheel Drive)	22.0	27.0	24.0	Regular	$2,600
1.8L 4-cyl, Manual 5-spd (Front-Wheel Drive)	22.0	29.0	25.0	Regular	$2,500
1.8L 4-cyl, Automatic 4-spd (Front-Wheel Drive)	21.0	24.0	22.0	Regular	$2,850
1.8L 4-cyl, Automatic 4-spd (Front-Wheel Drive)	21.0	28.0	24.0	Regular	$2,600
1.8L 4-cyl, Manual 5-spd (Front-Wheel Drive)	23.0	30.0	26.0	Regular	$2,400
1.8L 4-cyl, Automatic 4-spd (Front-Wheel Drive)	20.0	25.0	22.0	Regular	$2,850
1.8L 4-cyl, Manual 5-spd (Front-Wheel Drive)	21.0	26.0	23.0	Regular	$2,700

CO2 Emissions: -1.0 g/mile (Subcompact Cars)

Source: U.S. Environmental Protection Agency (EPA). Actual fuel economy may vary based on driving conditions.

NHTSA Safety Investigations, HONDA ACCORD

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

EA, Open , Model Year: 2018

Inadvertent Automatic Emergency Braking

On February 21, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE22003) to assess reports of inadvertent activation of the Collision Mitigation Braking System (CMBS), an automatic emergency braking (AEB) system, in model year 2017-2019 Honda CR-V and 2018-2019 Honda A... Read more

RQ, Closed , Model Year: 2023

Front Seat Belt Assemblies may be Missing the Rivet that Secures the Quick Connector and Wire Plate

On April 4, 2024, the Office of Defects Investigations (ODI) opened RQ24006 to investigate American Honda Motor Co.’s (Honda’s) proposed remedy for recall 23V-782 as well as scope of the vehicles involved. Honda issued recall 23V-782 on November 21, 2023, which concerns certain model year (MY) 2... Read more

PE, Closed , Model Year: 2018

Inadvertent Automatic Emergency Braking

EA, Closed , Model Year: 2013

Loss of Direction Control

On May 6, 2021, the Office of Defects Investigation (ODI) opened Engineering Analysis (EA21-001) to assess a sudden loss of steering control, in Model Year (MY) 2013-2015 Honda Accord vehicles. Consumers alleged while driving the steering wheel would pull to the left or the right independently. Stee... ring pull may pose a risk of loss of directional control. Honda stated that they believed the inadvertent steering input was caused by a loose magnet located within the electronic power steering (EPS) system. Due to poor formulation of the adhesive, this magnet can become loose and move up to 2 degrees around the steering column. When the magnet moves, the torque sensor generates a signal that results in unwanted steering in either direction. Honda stated the steering force required to maintain directional control with a loose magnet is a maximum of 3-pound feet. The maximum force of the unwanted steering input can be overcome by the driver and is similar to driving on grooved pavement.The Vehicle Research Test Center (VRTC) sent over 4,000 questionnaires to 2013-2015 Honda Accord vehicle owners. Of the 637 responses, 58 consumers experienced unwanted steering. Consumers experiencing unwanted steering did not report difficulties maintaining directional control. There were no crashes or injuries reported to VRTC. Testing done by VRTC was not able to reproduce the allegations. Analysis of all relevant data indicates that the subject condition has a relatively low failure rate. The poor adhesive formulation was addressed by the supplier with three (3) counter measures in the manufacturing process.There has been a declining trend in consumer complaints to NHTSA which indicates possible exhaustion of parts prone to failure. In view of the low rate, declining complaint trend, the nature of failure, and resolution of the adhesive formulation, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11538714, 11528538, 11528008, 11522953, 11496557, 11495837, 11494328, 11478680, 11477167, 11476758, 11476263, 11471198, 11470001, 11467026, 11466561, 11466016, 11465626, 11464143, 11463558, 11462759, 11461500, 11460777, 11460191, 11455540, 11454334, 11452198, 11448114, 11447666, 11444888, 11444823, 11444172, 11443324, 11443243, 11443105, 11441374, 11439520, 11438345, 11437261, 11436824, 11436350, 11435994, 11435079, 11434969, 11434545, 11434442, 11434381, 11433824, 11433745, 11433555, 11433368, 11433176, 11431206, 11430465, 11430253, 11430009, 11429253, 11428301, 11427449, 11426841, 11426340, 11425928, 11425261, 11425230, 11423611, 11423245, 11422445, 11422395, 11422351, 11422220, 11422138, 11422069, 11421683, 11421589, 11421540, 11420573, 11419338, 11419270, 11418147, 11418143, 11417768, 11417742, 11417570, 11417437, 11416804, 11416699, 11416401, 11416378, 11416375, 11416155, 11416117, 11416084, 11416051, 11416032, 11416028, 11416024, 11416000, 11415933, 11415915, 11414105, 11406220, 11398736 ,11387075, 11387049, 11375580, 11364698, 11361125, 11351660, 11349961, 11327909, 11327170, 11301957, 11289067, 11282525, 11277659, 11258017, 11256914, 11218752, 11208077, 11196050, 11194358, 11189901, 11165075, 11163481, 11154891Read more

DP, Closed , Model Year: 2013

Loss of Direction Control

The Office of Defects Investigation (ODI) received a petition dated October 19, 2020 requesting an investigation of an alleged defect in the steering system in Model Year (MY) 2013 Honda Accord vehicles. The petitioner alleges that MY2013 Honda accord vehicles are experiencing a sudden loss of steer... Read more

PE, Closed , Model Year: 2008

SRS Control Module Failure

As discussed further below, and by letter dated January 22, 2016, Honda is recalling certain model year (MY) 2008 through 2010 Honda Accords to replace a defective air bag/SRS control module that can result in the Supplemental Restraint System (SRS) becoming fully inoperative (disabled).See NHTSA Sa... fety Recall 16V056 at SaferCar.gov for further details.Honda's response to an agency Information Request letter indicated that the SRS module was manufactured by tier-one supplier Continental and contained a power supply ASIC manufactured by tier-two supplier Atmel. The original ASIC was susceptible to a moisture ingress issue due to inadequate ASIC passivation layer.Water ingress could result in moisture reaching the Titanium Nitride (TiN) layer in the ASIC causing corrosion and breakage of electrical circuits.The damaged ASIC then causes failures of the SRS module resulting in 1) incomplete boot-up when power is supplied to the module or 2) the inability of the module to establish either internal or external bus communications.In either case the air bag readiness indicator light on the instrument cluster is illuminated and all air bags and seat belt pretensioners are disabled.During the investigation, ODI obtained the SRS module from a complainant crash vehicle where the air bags did not deploy despite a significant frontal impact.An inspection of the module was performed at a Continental facility.The inspection confirmed that the module had the ASIC fault thus preventing the SRS module from completing the boot-up process.An attempt was made to recover stored EDR data from the module however none was present; this outcome is consistent with an Atmel ASIC failure.A second SRS module alleged to have the ASIC problem was inspected during the same visit.This second module was unable to communicate with the test equipment.The ASIC was replaced on this module and full function was restored to the module confirming the ASIC as the cause of the SRS module fault.According to Honda, tier-two Atmel implemented three different corrective actions in early 2008.Implementation of the corrective actions into module production by tier-one Continental, and into vehicle production by Honda resulted in three distinct vehicle populations.The first population consists of certain non-consecutively built MY 2008 to 2010 Accords with modules that did not contain any of the corrective actions.This population of 341,444 vehicles exhibited a significant level of module failure in service and is thus being recalled.The second population of 382,693 non-consecutively built MY 2008 to 2010 Accords contained two of the three corrective actions.This population exhibited a significantly lower level of SRS module failure, compared to the first population, but a marginally higher level compared to the third population.Honda is conducting a 15 year unlimited mileage extended warranty program for this second population.Under the program Honda will replace the SRS module free of charge for vehicles that experience an SRS module malfunction due to ASIC failure.Owners eligible for the extended warranty will be notified by Honda in writing.The third population consists of vehicles containing all three corrective actions, this population exhibits a normal level of SRS module failure.Based on the safety recall and extended warranty this investigation is closed.The VOQ reports cited above can be reviewed at SaferCar.gov under the following identification numbers: 10871612, 10869953, 10810554, 10788238, 10781994, 10778712, 10765025, 10761583, 10759019, 10758622, 10747850, 10735806, 10734761, 10733519, 10715339, 10703521, 10676517, 1065Read more

PE, Closed , Model Year: 2013

Electric Power Steering Failure

The Office of Defects Investigation (ODI) opened PE14-033 to investigate 24 complaints alleging loss of power steering while driving in model year (MY) 2013 Honda Accord vehicles equipped with electric power steering (EPS).Analysis of service data for the original 24 complaints and 33 additional com... Read more

AQ, Closed , Model Year: 2001

Honda EWR Reporting

In a Consent Order executed on December 29, 2014, American Honda Motor Co. (Honda) admitted that it violated the Safety Act by failing to report certain death and injury incidents that were required to be reported to NHTSA under 49 C.F.R. ? 579.21(b), and by failing to report certain customer satisf... Read more

EA, Closed , Model Year: 2008

Inadvertent Side Air Bag Deployment

Honda is conducting a safety recall of approximately 303,900 model year 2008-2009 Honda Accord sedans to address inadvertent deployment of the side air bags (see NHTSA recall 15V-665 for more information).It should be noted that almost all of the recalled vehicles are the 2008 Accords (built from st... Read more

PE, Closed , Model Year: 2008

Inadvertent Side Air Bag Deployment

ODI has identified 293 incidents of alleged inadvertent deployment of the side air bags in model year (MY) 2008 Honda Accord 4-door vehicles.This total represents all incidents reported to both ODI and Honda including those from Honda's warranty system (note: the total shown above eliminates all dup... Read more

DP, Closed , Model Year: 2005

Braking Performance

The Office of Defects Investigation (ODI) received a defect petition requesting that it open an investigation and recall MY 2005 Honda Accord Hybrid vehicles for a possible safety defect related to braking performance.The petitioner in a defect petition letter and in a complaint filed with ODI under... Read more

EA, Closed , Model Year: 2003

Ignition Shift Interlock

On August 4, 2010, American Honda Motor Co. (Honda) submitted a Defect Information Report (DIR) to NHTSA regarding a ignition interlock defect in approximately 384,220 model year (MY) 2003 Honda Accord and Civic and MY 2003 and 2004 Honda Element vehicles with automatic transmissions (Recall 10V-364... Read more

RQ, Closed , Model Year: 2002

IGNITION PARK-SHIFT INTERLOCK

ODI HAS RECEIVED 16 COMPLAINTS ALLEGING FAILURES OF THE IGNITION PARK-SHIFT INTERLOCK THAT ALLOWED THE IGNITION KEY TO BE REMOVED FROM THE IGNITION SWITCH WITHOUT THE TRANSMISSION BEING SHIFTED TO PARK IN MODEL YEAR (MY) 2002 AND 2003 HONDA ACCORD VEHICLES WITH AUTOMATIC TRANSMISSIONS.ELEVEN OF THE ... Read more

PE, Closed , Model Year: 2000

SRS READINESS INDICATOR ILLUMINATION

THE SUBJECT VEHICLES ARE DESIGNED WITH AN OCCUPANT POSITION DETECTION SYSTEM (OPDS) FOR THE PASSENGER SEAT TO SUPPRESS THE SIDE AIRBAG IN THE EVENT OF AN OUT-OF-POSITION OCCUPANT.ON SOME VEHICLES, THE OPDS UNIT AND SENSOR GRID MAY BE SUSCEPTIBLE TO HIGH MOISTURE CONTENT AND/OR TO SPORADIC ELECTRICAL... Read more

DP, Closed , Model Year: 1999

IGNITION-PARK INTERLOCK

THE OFFICE OF DEFECTS INVESTIGATION (ODI) PRODUCED AN INFORMATION REQUEST (IR) LETTER DATED OCTOBER 14, 2004 WHICH DEFINED THE SUBJECT VEHICLES AS MODEL YEAR 1999 - 2001 HONDA ACCORD VEHICLES WHICH WERE NOT WITHIN THE SCOPE OF PRIOR RECALL ACTION (03V423) HONDA CONDUCTED TO RESOLVE AN INTERLOCK DEFE... Read more

PE, Closed , Model Year: 2004

FRONTAL DRIVER AIR BAG

DURING TWO OF 13 NHTSA RESEARCH & DEVELOPMENT COMPATIBILITY CRASH TESTS, THE DRIVER-SIDE FRONTAL AIRBAG FAILED TO PROPERLY DEPLOY DUE TO A LARGE TEAR IN THE AIRBAG FABRIC.BOTH R&D TEST VEHICLES THAT CONTAINED A FAILED AIR BAG WERE 4-DOOR, 4-CYLINDER (L4) VEHICLES.SUBSEQUENT STATIC AND DYNAMIC TESTS ... Read more

EA, Closed , Model Year: 1998

IGNITION-PARK INTERLOCK

SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF HONDA COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE ONE INJURY OCCURRED WHEN A ROLLAWAY VEHICLE STRUCK THE EXITING OPERATOR WHO HAD INADVERTENTLY PARKED THE VEHICLE IN AN UNSECURED STATE (NOT IN PARK, BRAKE NOT ENGAGED).HONDA IDENTIFIED THE WARRANTY CLAI... Read more

PE, Closed , Model Year: 1998

IGNITION-PARK INTERLOCK SYSTEM

SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF THE MANUFACTURER COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE NOTED INJURY OCCURRED WHEN A ROLLAWAY VEHICLE THAT HAD BEEN INADVERTENTLY PARKED IN NEUTRAL STRUCK THE EXITING OPERATOR.THE WARRANTY CLAIM COUNT SHOWN FOR OTHER REPRESENTS INCIDENTS WHERE HON... Read more

PE, Closed , Model Year: 1998

SEAT FRAME BRACKET FAILURE

THIS PE WAS OPENED BASED ON 10 CONSUMER COMPLAINTS IN THE ODI DATABASE ALLEGING THAT THE POWER ASSISTED SEATS WERE FAILING IN CERTAIN 1998-2002 HONDA ACCORD VEHICLES.FAILURES ARE CONCENTRATED IN THE 1998-99 MODEL YEAR VEHICLES.THE BRACKET THAT ATTACHES THE SEAT BOTTOM TO THE SEAT BASE IS FRACTURING ... Read more

DP, Closed , Model Year: 1995

ABS

SQ, Open

HEADLAMP WIRING

HONDA HAS APPARENTLY ISSUED A REPAIR KIT FOR HEADLAMP WIRING FOR THE HONDA ACCORD WHICH DOES NOT INCLUDE A SET OF INSTRUCTIONS FOR HOW THE WORK IS TO BE COMPLETED.THE PRODUCT NUMBER FOR THIS REPAIR KIT IS 06200-SEO-306 WITH COMPONENT PART NUMBERS 32119-SEO-3050 0060-1 AND 32109-SEO-3050 006002.THE A... Read more

PE, Closed , Model Year: 1995

OVERSENSITIVE AIR BAG DEPLOYMENT