Complaint Statistics
41 total complaints
1 crashes
Top Reported Components
| Component | Complaints |
|---|
| ENGINE | 8 |
| SERVICE BRAKES | 7 |
| UNKNOWN OR OTHER | 4 |
| FUEL/PROPULSION SYSTEM | 4 |
| POWER TRAIN | 2 |
| SUSPENSION | 2 |
| ELECTRICAL SYSTEM | 2 |
| VISIBILITY/WIPER | 2 |
| FORWARD COLLISION AVOIDANCE: WARNINGS | 1 |
| FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING | 1 |
Incident date: Mar 12, 2026
While driving at approximately 20mph, the front passenger-side steering knuckle suffered a catastrophic structural failure, snapping completely in two. This resulted in an immediate loss of steering and suspension control. Inspection of the fractured part by a mechanic revealed significant orange ox
... idation (rust) inside the metal cross-section of the break. This internal corrosion on a 2-year-old vehicle indicates a manufacturing defect (casting porosity or inclusion) that allowed the part to weaken and fail prematurely under normal road stress.Read more
Incident date: Mar 12, 2026
While driving at approximately 20mph, the front passenger-side steering knuckle suffered a catastrophic structural failure, snapping completely in two. This resulted in an immediate loss of steering and suspension control. Inspection of the fractured part by a mechanic revealed significant orange ox
... idation (rust) inside the metal cross-section of the break. This internal corrosion on a 2-year-old vehicle indicates a manufacturing defect (casting porosity or inclusion) that allowed the part to weaken and fail prematurely under normal road stress.Read more
Incident date: Jan 20, 2026
Check engine light came on after attempting a remote start and failed. Upon using an OBD-II code reader, it gave the code: P2421 - EVAP Vent Valve stuck open. This part is not covered under the 8/80k federal emissions warranty but is still an issue and is affecting emissions. There were no othe
... r alerts or warnings issued before attempting the remote start that caused the issue.Read more
Incident date: Dec 19, 2025
Vehicle was parked in my driveway. My wife and I were about 10 feet from it working on another vehicle when we heard a loud pop. We looked over at the vehicle and the sunroof has exploded. It was bubbled upward and completely shattered. I contacted my VW dealer and we slowly drove the car to the sho
... p and left it. The dealer said it probably wasn't covered under dealer warranty because it was glass. It just shattered out of the blue, this should not be my fault or at my expense.Read more
Incident date: Aug 15, 2025
The contact owns a 2024 Volkswagen Jetta. The contact stated while driving approximately 35 MPH up an incline, the hill assist system engaged. The contact stated that while descending the incline, the hill assist was still engaged. The contact pulled over and turned off and restarted the vehicle to
... disengage the feature. There was no warning light illuminated. The contact stated that the failure was intermittent at first but had gradually become a recurring failure. The contact stated that the vehicle had additional failures with the transmission and the rear brakes due to the hill assist not disengaging as needed. The contact stated that the manual transmission was slipping out of gear and the rear brakes showed premature wear on the pads. The contact had taken the vehicle to several dealers. The contact stated that one dealer recommended that the transmission be replaced. The contact had taken the vehicle to another local dealer who was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 17,600.Read more
Incident date: Aug 15, 2025
The contact owns a 2024 Volkswagen Jetta. The contact stated while driving approximately 35 MPH up an incline, the hill assist system engaged. The contact stated that while descending the incline, the hill assist was still engaged. The contact pulled over and turned off and restarted the vehicle to
... disengage the feature. There was no warning light illuminated. The contact stated that the failure was intermittent at first but had gradually become a recurring failure. The contact stated that the vehicle had additional failures with the transmission and the rear brakes due to the hill assist not disengaging as needed. The contact stated that the manual transmission was slipping out of gear and the rear brakes showed premature wear on the pads. The contact had taken the vehicle to several dealers. The contact stated that one dealer recommended that the transmission be replaced. The contact had taken the vehicle to another local dealer who was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 17,600.Read more
Incident date: Aug 15, 2025
The contact owns a 2024 Volkswagen Jetta. The contact stated while driving approximately 35 MPH up an incline, the hill assist system engaged. The contact stated that while descending the incline, the hill assist was still engaged. The contact pulled over and turned off and restarted the vehicle to
... disengage the feature. There was no warning light illuminated. The contact stated that the failure was intermittent at first but had gradually become a recurring failure. The contact stated that the vehicle had additional failures with the transmission and the rear brakes due to the hill assist not disengaging as needed. The contact stated that the manual transmission was slipping out of gear and the rear brakes showed premature wear on the pads. The contact had taken the vehicle to several dealers. The contact stated that one dealer recommended that the transmission be replaced. The contact had taken the vehicle to another local dealer who was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 17,600.Read more
Incident date: Dec 11, 2025
The vehicle’s SOS/emergency call system has been inoperative since the vehicle was purchased. At delivery, the emergency call function did not work and displayed error messages. The vehicle was taken to an authorized Volkswagen dealer, and the OCU (online connectivity unit) module responsible for
... the SOS system was replaced under warranty on 3/17/2025 at approximately 6,294 miles. After the repair, the system functioned temporarily. In December 2025, the SOS system failed again and now displays an “Emergency Call Function Not Available / Please Service Vehicle” warning. The dealer has confirmed the same OCU module has failed again and must be replaced a second time. When the system is inoperative, the vehicle cannot automatically contact emergency services after a collision. This is a safety concern because the emergency call system is intended to function at all times in the event of a crash.Read more
Incident date: Sep 1, 2025
Front Windshield wipers randomly go on causing a distraction almost resulting in a accident. The vehicle was taken in for this problem to Colonial VW located at 200 W Street RD, Feasterville PA 19053. Service rep stated he knows of the issue but there is currently no fix for it. This problem fir
... st stared approximately 1 month ago. No warning lights or alerts are present on the vehicle. Issue seems to happen more in bright sunlight but can happen at anytime with multiple wipes at once. The issue will go away for a few mins to a day then reappear out of no where sometimes coming and going the whole trip A google search reveals this maybe a a more common problem than just my vehicle.Read more
Incident date: Sep 11, 2025
Sensitive sunroof glass. Sunroof glass shattered a section of the glass that has an open glass area now and will leak in inclement weather conditions.
Incident date: Sep 11, 2025
Sensitive sunroof glass. Sunroof glass shattered a section of the glass that has an open glass area now and will leak in inclement weather conditions.
Incident date: Aug 19, 2025
Driving on interstate 74 west bound entered rain storm. Did not see car that was slow or stopped until impact. Traveling at a speed of 78 mph. Airbag did not deploy. Is this normal? Rear ended car in front. Volkswagen was totaled with severe front end damage. Other car was a bigger suv. There is d
... ash cam footage that shows impact.Read more
Crash
Incident date: Aug 13, 2025
I just got this 2024 Jetta Sport 6 speed manual and tried getting up the drive that's slightly inclined and the brake assist would not disengage or the fuel was cut after it didn't progress then dies. It is possible to power through the brake assist but it will cause premature wear on the clutch, fl
... ywheel as well as the rear E brake with all this wireless tech on the brakes, throttle can't figure it out so take it back.Read more
Incident date: Aug 13, 2025
I just got this 2024 Jetta Sport 6 speed manual and tried getting up the drive that's slightly inclined and the brake assist would not disengage or the fuel was cut after it didn't progress then dies. It is possible to power through the brake assist but it will cause premature wear on the clutch, fl
... ywheel as well as the rear E brake with all this wireless tech on the brakes, throttle can't figure it out so take it back.Read more
Incident date: Aug 13, 2025
I just got this 2024 Jetta Sport 6 speed manual and tried getting up the drive that's slightly inclined and the brake assist would not disengage or the fuel was cut after it didn't progress then dies. It is possible to power through the brake assist but it will cause premature wear on the clutch, fl
... ywheel as well as the rear E brake with all this wireless tech on the brakes, throttle can't figure it out so take it back.Read more
Incident date: Aug 28, 2025
Brakes make loud noise when I come to stop when leaving highway. Rear pads are at 2mm as of 8/28/2025 when they were replaced in on 5/14/2025. Repairs were performed by dealership on 5/14/2025 but they did not replace the rotors, they only replaced the rear pads.
Incident date: Aug 30, 2025
The contact owns a 2024 Volkswagen Jetta. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the rear tires. No warning light was illuminated. The vehicle was taken to a local dealer, where it was diagnosed and determined that the rear rotors, and
... brake pads needed to be replaced. The vehicle was repaired at the consumer's expense. The manufacturer was made aware of the failure. The failure mileage was approximately 15,000.Read more
Incident date: Aug 30, 2025
The contact owns a 2024 Volkswagen Jetta. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the rear tires. No warning light was illuminated. The vehicle was taken to a local dealer, where it was diagnosed and determined that the rear rotors, and
... brake pads needed to be replaced. The vehicle was repaired at the consumer's expense. The manufacturer was made aware of the failure. The failure mileage was approximately 15,000.Read more
Incident date: Mar 13, 2024
The contact owns a 2024 Volkswagen Jetta. The contact stated that at start-up, there was an abnormal amount of white smoke coming from the exhaust pipes. There was no warning light illuminated. The vehicle was taken to a local dealer where it was diagnosed, and the contact was informed that a cause
... for the failure was not found. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 18,078.Read more
Incident date: May 12, 2025
The tire went flat as I was driving and when I had to change the tire I noticed that the tire had blown out on the sidewall on the inside of the rim of the car. The car only has 12,000 miles and I had a tire rotation done on my first oil change. I called the dealership to see if the tire was covered
... under warranty since I brought the car new for Steve White VW of Greenville, SC. They told me since I didn’t buy a warranty with the purchase of the car then it was nothing they could do about it. I brought a car thinking that the tires should be good until they wear out not blow out. Also I have TPMS light on as well as the check engine light is on in the vehicle. 205/55R17Read more
Incident date: May 12, 2025
The tire went flat as I was driving and when I had to change the tire I noticed that the tire had blown out on the sidewall on the inside of the rim of the car. The car only has 12,000 miles and I had a tire rotation done on my first oil change. I called the dealership to see if the tire was covered
... under warranty since I brought the car new for Steve White VW of Greenville, SC. They told me since I didn’t buy a warranty with the purchase of the car then it was nothing they could do about it. I brought a car thinking that the tires should be good until they wear out not blow out. Also I have TPMS light on as well as the check engine light is on in the vehicle. 205/55R17Read more
Incident date: May 28, 2024
my Volkswagen Jetta GLI 40th anniversary 6MT, has had multiple misfire check engine lights appear on dash since owning the car, multiple times has the car been to the dealership and multiple times they blamed me as the operator for the issue, i was told it was bad gas, then a software update was mad
... e available to fix the misfire issue and within 150 miles of getting the update the misfires happened again. the vehicle can be made ready for an inspection if needed. the misfire check engine light occurs during start up of the vehicle and i am stationary at this time. to my knowledge the components have been inspected by the dealership. the first misfire happened at around 4000 miles and the dealership claimed it was bad gas, then again at 6400 miles at which point the dealership performed the software update. since then i have had 2 additional misfire messages that I had not documented at the dealership.Read more
Incident date: Feb 1, 2025
[XXX] Invoice [XXX] vehicle was taken to HOY FAMILY AUTO DEALER in El Paso, Texas (1.)to inspect brakes noise and parking brake not engaging at all times, there has been times when the parking brake does not engage, and humming noise while braking and exiting freeway. Service personnel did not dismo
... unt wheels to have visual inspection on braking system they just checked for gap wear and tear. (2.)also told service advisor about Emergency braking system warning on dashboard warning system comes on sometimes while braking on empty roads at stop signs and while parking vehicle on a house driveway. (3.) suspension on front passenger side hard hit noise while driving on uneven pavements. (4.) passenger rear side view mirror sensor light most of times does not work on approaching moving vehicles. *Problem persists INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)Read more
Incident date: Feb 1, 2025
[XXX] Invoice [XXX] vehicle was taken to HOY FAMILY AUTO DEALER in El Paso, Texas (1.)to inspect brakes noise and parking brake not engaging at all times, there has been times when the parking brake does not engage, and humming noise while braking and exiting freeway. Service personnel did not dismo
... unt wheels to have visual inspection on braking system they just checked for gap wear and tear. (2.)also told service advisor about Emergency braking system warning on dashboard warning system comes on sometimes while braking on empty roads at stop signs and while parking vehicle on a house driveway. (3.) suspension on front passenger side hard hit noise while driving on uneven pavements. (4.) passenger rear side view mirror sensor light most of times does not work on approaching moving vehicles. *Problem persists INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)Read more
Incident date: Feb 1, 2025
[XXX] Invoice [XXX] vehicle was taken to HOY FAMILY AUTO DEALER in El Paso, Texas (1.)to inspect brakes noise and parking brake not engaging at all times, there has been times when the parking brake does not engage, and humming noise while braking and exiting freeway. Service personnel did not dismo
... unt wheels to have visual inspection on braking system they just checked for gap wear and tear. (2.)also told service advisor about Emergency braking system warning on dashboard warning system comes on sometimes while braking on empty roads at stop signs and while parking vehicle on a house driveway. (3.) suspension on front passenger side hard hit noise while driving on uneven pavements. (4.) passenger rear side view mirror sensor light most of times does not work on approaching moving vehicles. *Problem persists INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)Read more
Incident date: Mar 6, 2025
The contact owns a 2024 Volkswagen Jetta. The contact stated that while the vehicle was parked, the vehicle unintendedly accelerated without a warning light being illuminated. The contact depressed the brake pedal to stop the vehicle. The vehicle was able to be restarted. The vehicle was taken to th
... e dealer, where it was not diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 5,000.Read more
Incident date: Feb 20, 2025
The key pins on the VW flip keys fall our regularly and can leave motorists stranded in unsafe locations. It is however an excellent revenue generator when you consider the cost of replacement keys. I caught my pin in the process of falling our and saw it was a common problem that has not been r
... esolved in this flawed and unsafe key design that threatens the welfare of consumers and safety of use of their vehicle.Read more
Incident date: Jan 8, 2025
My 2024 Jetta with only 14,776 miles had rear brakes and rotors that were unsafe and worn out. They had to be replaced to avoid the possibility of brake failure and an accident. I paid $453.34 out of pocket. VW knows there is a defect with the rear brakes on this generation Jettas wearing out premat
... urely. They are covering these parts under only certain VIN and production dates but they admit ALL JETTAS ARE SUBJECT TO THIS WEARING OUT OF BRAKES BEGINNING WIITH THE 2022 MODEL YEAR.Read more
Incident date: Dec 11, 2024
My car was purchased in December 2023 it was new with approximately 4 miles on the car I’m retired I use the car mostly for doctors appointments personal use church in August 2024 I took my car in for 10,000 mile oil change at the time I was told that my brakes were in fair condition the rear brak
... es so in December 2024 I took my car to a Volkswagen service and another independent a car service center and was told basically that all the parts on my rear brakes needed to be replaced I thought this was highly unusual this is not the first new car I have owned and not the first Volkswagen I have owned I don’t drive every day I really wish you would answer me back quickly because spending between six and $700 for rear brakes on a new car is excessive I would appreciate it if you would respond quickly.Read more
Incident date: Nov 11, 2024
Vehicle is brand new currently has 13,000 miles, only highway driving, purchased car new in April 2024. Rear brakes wore down prematurely. Needed to replace rear brakes and rotors.
Incident date: Oct 23, 2024
The Hill Start Assist is overly aggressive in these cars. It doesn't release for 3 seconds after foot brake is not applied. Once it stalls the car and your panicked. Then you apply foot brake to restart the car you get to wait another 3 seconds or you stall again. It is inconsistent in pressure appl
... ied and dangerous. I have been driving manual transmission vehicles for near 40 years. Perhaps if I lived in San Francisco it might be of use but, with this activating at the slightest grade it is dangerous! Look around the VW forums I'm not the only person to think so.Read more
Incident date: Jul 28, 2024
I keep getting a cylinder 1 and 4 misfire on a 6MT on cold start. I previously had another 2024 jetta gli and it had the same exact problem as this one. the dealer confirmed the problem and bought the car back and now it is happening on the new car.
Incident date: Jul 28, 2024
I keep getting a cylinder 1 and 4 misfire on a 6MT on cold start. I previously had another 2024 jetta gli and it had the same exact problem as this one. the dealer confirmed the problem and bought the car back and now it is happening on the new car.
Incident date: Apr 9, 2024
I have gotten a multiple cylinder misfire since 800 miles and VW dealerships haven't been able to figure out why at first they said bad fuel then bad plugs and they have tried to treat both and it has not been fixed they will clear the light and it comes back almost immediately
Incident date: Jul 30, 2024
Codes read cylinder misfire. People say they cannot fix it.
Incident date: Jul 30, 2024
Codes read cylinder misfire. People say they cannot fix it.
Incident date: Jul 1, 2024
Purchased the car with around 70 miles. Dealer filled the car up full with gas when driven off the lot. Check engine light at 300 miles. Took into the dealer to deal with it. Dealer reported misfire on multiple cylinders on start up. Was told I put bad gas in the car when the dealer filled it up. Ad
... ded fuel additive and reset codes, sent me on my way and only have used 91 chevron since. Next around 600 miles check engine light came back one, same issue. They put my car in transport mode and back out. Reset codes and told me to not let the car idle on startup. For a brand new car????? 1300 mile mark check engine light again, same issue. Currently still in waiting to hear what they have to say. As of 8/19Read more
Incident date: Jun 10, 2024
This experience was with a rental vehicle - and I sent an email to the NHTSA address with additional details. Later, I saw this form. I am pasting the information here: Request #[XXX] 2024 VW Jetta Rental Vehicle - Unintended Acceleration / Braking The vehicle was rented from Fox Rent-a-Car in L
... as Vegas, NV for my short trip to California and back. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)Read more
Incident date: Jun 10, 2024
This experience was with a rental vehicle - and I sent an email to the NHTSA address with additional details. Later, I saw this form. I am pasting the information here: Request #[XXX] 2024 VW Jetta Rental Vehicle - Unintended Acceleration / Braking The vehicle was rented from Fox Rent-a-Car in L
... as Vegas, NV for my short trip to California and back. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)Read more
Incident date: Jun 10, 2024
This experience was with a rental vehicle - and I sent an email to the NHTSA address with additional details. Later, I saw this form. I am pasting the information here: Request #[XXX] 2024 VW Jetta Rental Vehicle - Unintended Acceleration / Braking The vehicle was rented from Fox Rent-a-Car in L
... as Vegas, NV for my short trip to California and back. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)Read more
Incident date: May 26, 2024
The small detached windshield above large windshield is defective and temperature sensitive. The vehicle was parked outside all day in hot Arizona ( extreme hot temps) and when we entered we put the ac on full blast. Within minutes with the car still in park. The glass exploded and shattered. Big
... pop sound almost like a gun shot. We looked outside and the upper windshield was cracked. I informed the dealership and manger said same thing happened to him while driving his Jetta. He thinks it was a rock. I disagree I think its defective and needs immediate action before injury occurs.Read more
NHTSA Safety Investigations — VOLKSWAGEN JETTA
Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.
PE — Closed
— Model Year: 2012
Diesel Fuel Injector Line Leakage
By letter dated October 3, 2011, Volkswagen Group of America, Inc. (VW) notified the National Highway Traffic Safety Administration (NHTSA) that it will conduct a safety recall to address a defect in approximately 168,275 model year (MY) 2009-2012 Volkswagen Jetta, Jetta Sportwagen, Golf, and Audi A
... 3 vehicles equipped with the 2.0L TDI Common Rail Clean Diesel engine (NHTSA Recall No. 11V-490).The recalled Jetta and Jetta Sportwagen vehicles were built from May 2008 through September 2011, the Golf vehicles were built from May 2009 through September 2011, and the Audi A3 vehicles were built from September 2009 through September 2011.According to Volkswagen, in U.S. applications of the above cited TDI vehicles including engine codes CJAA and CBEA, the fuel injection pulses could coincide with the natural frequency of the injector line #2 in specific load and RPM conditions.This resonance creates additional stress on the fuel line which a small number of parts (based on the statistic spread of line strength) cannot withstand over its lifetime.As a contributing factor, VW indicated that a supplier used tube material with scratch marks from a grinding process during certain production periods.Lines manufactured in these periods were installed in vehicles produced in the following 10 months:December 2008, January-February 2009, October 2009, March-April 2010 and September-December 2010.Injector lines using this material exhibit a significantly higher failure rate.Dealers will replace injector line #2 in all vehicles built in these months.In addition, as a precautionary measure, all recalled vehicles will have vibration dampers installed on all four fuel injector lines.Analysis of NHTSA complaints, VW complaints, VW field reports and warranty claims found allegations of injector line leakage in 443 subject vehicles.The leaking line was not identified in 62 of the vehicles.For the 381 that did provide information about which injector lines were leaking and/or replaced, 358 (94%) involved an injector line #2 leak/repair.Almost three-quarters of the injector line #2 leak/repair incident vehicles were built in the 10 months identified by VW, which accounted for approximately one-quarter of the recalled vehicles.The failure rate for injector line #2 in vehicles built in the 10 months affected by the supplier line scratching issue is 6.0 incidents per thousand vehicles (IPTV).The failure rate for injector line #2 in other production months of recalled vehicles is 0.8 IPTV.The leak/repair rates for the other injector lines are all well under 1 IPTV.The action taken by Volkswagen is sufficient to resolve the issues raised by this investigation. The agency will continue to monitor this issue and reserves the right to take further action if warranted by the circumstances. Accordingly, this investigation is closed.Read more
DP — Closed
— Model Year: 2000
ENGINE STALLING
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MU
... LTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.Read more
EA — Closed
— Model Year: 2002
DRIVER SIDE FRONT SEAT OVERHEATS
THIS INVESTIGATION CONCERNS THE ELECTRIC SEAT HEATER INSTALLED IN SOME MY 2002-2003 VOLKSWAGEN (VW) JETTA VEHICLES.CONSUMERS ALLEGE THAT THE SEAT HEATER MAY OVERHEAT, RESULTING IN BURN DAMAGE TO THE SEAT COVER AND TO THE DRIVER'S CLOTHING AND/OR SKIN.THIS EA ADDRESSES WHETHER SUCH FAILURES MAY POSE
... A RISK TO MOTOR VEHICLE SAFETY.ODI CONCLUDES THAT THE DRIVER-SIDE SEAT HEATER MAY FAIL OR MALFUNCTION DUE TO NORMAL VEHICLE USE, (I.E., DRIVER INGRESS AND EGRESS FROM THE VEHICLE).THE INVESTIGATION DISCLOSED THAT SUCH FAILURES DO NOT POSE A SIGNIFICANT RISK OF INJURY OR FIRE.ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND.THEREFORE, THIS EA HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.THE ATTACHED SUMMARY REPORT PROVIDES FURTHER DETAIL CONCERNING THIS EA.Read more
RQ — Closed
— Model Year: 1999
BRAKE LIGHT SWITCH
THE NUMBER OF DUPLICATES BETWEEN ODI AND MANUFACTURER FAILURE REPORTS CANNOT BE DETERMINED DUE TO MISSING AND OR INACCURATE INFORMATION.THE INJURY NOTED ABOVE WAS MINOR.ON FEBRUARY 26, 2004, VOLKSWAGEN OF AMERICA, INC. (VW) SUBMITTED A DEFECT NOTIFICATION (PER 49CFR573) TO THE NATIONAL HIGHWAY TRAFF
... IC SAFETY ADMINISTRATION (NHTSA) ADVISING THAT CERTAIN MODEL YEAR (MY) 1999 - 2002 VOLKSWAGEN JETTA VEHICLES MANUFACUTURED WITH THE SAME BRAKE LIGHT SWITCH AS RECALLED UNDER 03V-265 (MY 1998-2002 NEW BEETLE) ARE AFFECTED BY A SAFETY DEFECT.SPECIFICALLY, IF THE BRAKE LIGHT SWITCH MALFUNCTIONS, THE BRAKE LIGHTS COULD FAIL TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD STAY ILLUMINATED CONTINUALLY EVEN WHEN THE BRAKES ARE NOT APPLIED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING, THUS INCREASING THE RISK OF A REAR END COLLISION AND OCCUPANT INJURY.ACCORDINGLY, VOLKSWAGEN IS RECALLING JETTA VEHICLES MANUFACTURED FROM MAY 1998 TO NOVEMBER 2001 TO INSPECT AND REPLACE FREE OF CHARGE ANY AFFECTED BRAKE LIGHT SWITCHES.THE RECALL PROGRAM, VW CODE WX, WILL COMMENCE IN APRIL 2004.Read more
PE — Closed
— Model Year: 2003
DRIVER SEAT OVERHEATS/BURNS
THE SUBJECT VEHICLES ARE EQUIPPED WITH OPTIONAL ELECTRICALLY HEATED DRIVER AND FRONT PASSENGER SEATS.INFORMATION RECEIVED DURING PE03-052 DISCLOSED A SIGNIFICANT NUMBER OF INCIDENTS OF MALFUNCTIONING/OVERHEATING OF THE DRIVER SEAT HEATER IN THE SUBJECT VEHICLES.ADDITIONAL INCIDENTS MAY OCCUR DURING
... THE FINAL MONTHS OF THE WINTER SEASON.THIS MATTER IS ALSO CURRENTLY BEING INVESTIGATED BY TRANSPORT CANADA.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-010)IN ORDER TO FULLY INVESTIGATE THESE OCCURRENCES AND THEIR SAFETY IMPLICATIONS.Read more
EA — Closed
— Model Year: 1995
FUEL TANK PUNCTURE
PE — Closed
— Model Year: 1995
FUEL TANK PUNCTURE
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON AUGUST 10, 2000 BASED ON 9 REPORTS REGARDING PUNCTURED FUEL TANKS INVOLVING THE JETTA, PASSAT, AND CABRIO MODELS.THE REPORTS INDICATE ADDITIONAL REPORTS IN ITS RESPONSE TO THE PRELIMINARY EVALUATION.THIS INVESTIGATION HAS BEEN UPGRADED
... FOR FURTHER STUDY.Read more
EA — Closed
— Model Year: 1996
LIGHT AND /WINDSHIELD WIPERS
There is no summary currently available
PE — Closed
— Model Year: 1999
PASSENGER COMPARTMENT FIRE
IN ITS LETTER DATED FEBRUARY 4, 1999, VOLKSWAGEN STATED THAT IT WILL RECALL APPROXIMATELY 23,600 REDESIGNED 1999 JETTA AND GOLF 4-DOOR VEHICLES, OF WHICH APPROXIMATELY 11,000 HAVE BEEN SOLD TO CUSTOMERS, TO CORRECT A DEFECT THATMAY CAUSE A FIRE IN THE PASSENGEER COMPARTMENT AFTER A VEHICLE COLLISION
... .A SOUND INSULATION MATERIAL ATTACHED TO THE INSIDE OF THE B-PILLAR TRIM PANEL COULD HAVE BEEN IMPROPERLY INSTALLED.IN THE EVENT OF A COLLISION SEVERE ENOUGH TO ACTIVATE THE SEAT BELT PRETENSIONER, THE HOT EXHAUST GAS FROM THE PRETENSIONER COULD IGNITE THE INSULATION MATERIAL IF IT IS TOO CLOSE TO THE PRETENSIONER.VOLKSWAGEN DEALERS WILL REMOVE THE INSULATION MATERIAL FROM THE B-PILLARS.Read more
PE — Closed
— Model Year: 1991
REAR WHEEL SEPARATION
There is no summary currently available
DP — Closed
— Model Year: 1987
DEFECTIVE HEATER CORES
DEFECTIVE HEATER CORES
EA — Closed
— Model Year: 1988
HEATER CORE FAILURE
There is no summary currently available
PE — Closed
— Model Year: 1985
HEATER CORE FAILURE
There is no summary currently available
PE — Closed
— Model Year: 1990
UNSTABLE HIGH ENGINE IDLE
There is no summary currently available
PE — Closed
— Model Year: 1986
ENGINE MOUNT FAILURE
There is no summary currently available