2006 TOYOTA RAV4

11 recalls, 880 complaints - 358 TSBs

SUSPENSION:REAR

Defect Description

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear t... Read more

Consequence

Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.

Remedy

Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are G0V for Toyota vehicles and GLK for... Read more

337,449 vehicles affected

Manufacturer: Toyota Motor Engineering & Manufacturing

SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER

Defect Description

Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Priu... Read more

Consequence

If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.

Remedy

SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.

7,749 vehicles affected

Manufacturer: Southeast Toyota Distributors, LLC

SEAT BELTS:REAR/OTHER

Defect Description

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the... Read more

Consequence

A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.

Remedy

Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0F.

1,123,752 vehicles affected

Manufacturer: Toyota Motor Engineering & Manufacturing

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

Defect Description

Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vib... Read more

Consequence

If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.

Remedy

Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-... Read more

1,814,284 vehicles affected

Manufacturer: Toyota Motor Engineering & Manufacturing

AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

Defect Description

Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module ... Read more

Consequence

If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.

Remedy

Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac V... Read more

1,486,413 vehicles affected

Manufacturer: Toyota Motor Engineering & Manufacturing

SUSPENSION:REAR

Defect Description

Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develo... Read more

Consequence

Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.

Remedy

Toyota will notify owners, and dealers will inspect the tie rods and replace any that have rust or corrosion on the alignment adjustment threads. All of the rear tie rods will then be encased in an epoxy to prevent future environmental damage. Due to limitations in parts, the recall remedy will be... Read more

780,584 vehicles affected

Manufacturer: Toyota Motor Engineering & Manufacturing

SUSPENSION:REAR

Defect Description

Consequence

Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.

Remedy

Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on November 30, 2012. Owners may contact Toyota ... Read more

780,584 vehicles affected

Manufacturer: Toyota Motor Engineering & Manufacturing

VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

Defect Description

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.

Consequence

A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.

Remedy

THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.

1,363,244 vehicles affected

Manufacturer: TOYOTA MOTOR NORTH AMERICA, INC.

EQUIPMENT:OTHER:LABELS

Defect Description

SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Consequence

A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.

Remedy

DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.

153,418 vehicles affected

Manufacturer: SOUTHEAST TOYOTA DISTRIBUTORS, LLC

EQUIPMENT:OTHER:LABELS

Defect Description

GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPA... Read more

Consequence

THIS DOES NOT MEET THE STANDARD REQUIREMENTS.

Remedy

DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.

271,417 vehicles affected

Manufacturer: GULF STATES TOYOTA, INC.

EQUIPMENT:OTHER:LABELS

Defect Description

TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE S... Read more

Consequence

INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.

Remedy

TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.

27,080 vehicles affected

Manufacturer: TOYOTA MOTOR NORTH AMERICA, INC.

Complaint Statistics

880 total complaints 38 crashes 9 fires 11 injuries 1 deaths

Top Reported Components

Component	Complaints
STEERING	222
ENGINE	110
VEHICLE SPEED CONTROL	69
SUSPENSION	66
AIR BAGS	51
ELECTRICAL SYSTEM	34
POWER TRAIN	30
ENGINE AND ENGINE COOLING	22
UNKNOWN OR OTHER	21
POWER TRAIN:AUTOMATIC TRANSMISSION	20

Incident date: Mar 13, 2026

The moonroof spontaneously shattered when I was driving on the freeway which sounded like a gunshot. There were no external factors such as debris from other vehicles and the temperature outside was relevantly constant at about 78F. No other cars were close to me or in front of me. For almost the en... Read more

Incident date: Dec 31, 1969

6 weeks since purchase and only 2000 miles-engine suddenly made a horrible rattling noise and stalled. Towed to dealership and was told engine was dead and needed replacement.

Incident date: Jul 2, 2025

Blind spot towing mirrors very unsafe cars motorcycles and people disappear behind mirrors especially the right side have had many close calls. Ram needs to go back to old style mirrors.

Incident date: Mar 28, 2025

"high voltage system failure" and inability to charge - co cooling and limited acceleration - took 7 1/2 weeks to repair - Tech found p1c0100 ac compressor motor underspend, recharged ac system nd found excessive freon

Incident date: Nov 18, 2024

Two Front Tires 235/55R18 100V wore down to completely unsafe condiotion and had to be replaced. Tires were on vehicle less than 8 months and had less than 10K miles on them.

Incident date: Aug 17, 2020

When driving on the highway, almost all warning lights came on. I was in the middle lane and decided it best to get off the highway asap. I stepped on the gas as I looked to accelerate when changing lanes. The car did not speed up. I was able to make it off the highway at the next exit. As I was tr... Read more

Incident date: Jul 23, 2023

The contact owns a 2016 Audi A6. The contact stated while having routine maintenance on the vehicle, the independent mechanic became aware that the water pump was leaking. The contact was informed that the water pump, the thermostat assembly, and the upper coolant pipe needed to be replaced. The veh... Read more

Incident date: Feb 21, 2023

My lane departure and collision warning did not work when I crashed into a car head on and totallled my vehicle. I had not yet received my recall maintenance, nor did I know about both recalls. Only the first. Not only that but lane assist did not work and the airbag did not go off. Despite totali... Read more

Crash 1 injured

Incident date: Mar 29, 2022

2006 Toyota Rav4 with 2.4 liter engine burning oil rapidly. Burning approximately 4 quarts of oil in 3,000 miles. Vehicle currently has 100,000 miles. Issue persists even though I maintain routine maintenance on the vehicle. Luckily no safety hazards have occurred yet, but there is a high risk for ... Read more

Incident date: Jul 25, 2022

The contact owns a 2006 Toyota Rav4. The contact stated that while making a right or left turn, there was a loud popping sound coming from the steering wheel. There was no warning light illuminated. Additionally, the contact stated that the popping noise was progressively louder while steering to ma... Read more

Incident date: May 9, 2022

While my son was driving me the vehicles steering wheel locked and he was unable to steer the vehicle. It caused us to go off the road down a steep hill and wreck. I’ve never had any problems with this vehicle so it was completely unexpected. If there had been anyone in our path we wouldn’t of b... Read more

Crash

Incident date: Feb 3, 2022

Clunking noise when turning steering wheel right or left. Numerous complaints from 006 RAV 4 owners. Fear that my steering will fail and cause an accident or Death. The issue is a defective intermediate steering shaft. Toyota will not issue a recall and will only repair if vehicle is still under wa... Read more

Incident date: Oct 31, 2021

My Toyota RAV4 started smoking by the headlights last night while I was driving on the highway. I pulled over and opened the hood to see what was happening and it burst into flames. The car completely burned. Nothing left! I see on the internet that other people have had this happen. Please investig... Read more

Fire

Incident date: Sep 27, 2021

excessive oil consumption 1 1/2 quart oil every 600 miles

Incident date: Sep 1, 2021

The rear subframe in my '06 Toyota RAV4 has rusted through. This is a key structural part of the vehicle, all of the rear suspension components attach to this subframe, so it's concerning to see the integrity of the subframe completely compromised. The component has not been inspected by the manuf... Read more

Incident date: Apr 28, 2021

This 2006 Rav4 engine is known for its massive oil consumption due to the faulty piston rings. Always kept oil in it and had regular changes because of this issue. Checked the oil 2 days prior to the engine failure, and all was well. Driving down the hwy going around 70mph, the engine started to los... Read more

Incident date: Nov 23, 2018

THIS COMPLAINT IS RELATED TO DISCOVERY SRX P215/70R16 COOPER TIRES WHICH WERE BOUGHT ON OCTOBER 23 2018. THESE TIRES ARE IDENTICAL TO RECALL 'NHTSA RECALL NO. - 19T-005 AFFECTING COOPER DISCOVERER' AND COOPER EVOLUTION' TIRES' ONLY THEY ARE THE 16 INCH TIRES. WE BELIEVE THAT THE 16 INCH TIRES SHOULD... Read more

Crash

Incident date: Apr 2, 2021

FOR SOME TIME THERE HAS BEEN AN INTERMITTENT PROBLEM WITH THE DASHBOARD LIGHTS COMING ON AND LOSS OF POWER STEERING. THE CAR HAS BEEN CHECKED BY MECHANICS, INCLUDING ONE AT A TOYOTA DEALERSHIP, BUT THE PROBLEM WAS NOT FOUND. I HAVE EXPERIENCED THE PROBLEM WITH THE CAR STATIONARY, BUT I BELIEVE MY SO... Read more

Incident date: Apr 2, 2021

Incident date: Sep 1, 2020

TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. THE CONTACT STATED THAT THE VEHICLE WAS CONSUMING OIL AT AN EXCESSIVE RATE. THE CONTACT TOOK THE VEHICLE TO A CERTIFIED MECHANIC WHO STATED THAT THE OIL WAS LEAKING AND EXCESSIVELY BURNING TO THE EXTENT THAT IT COULD CAUSE A POSSIBLE ENGINE FAILURE. THE VEHIC... Read more

Incident date: Nov 27, 2020

I BOUGHT A USED 2006 RAV4 3.5 L V-6, AFTER A MONTH A BOUGHT IT. I NOTICED WHEN I TURN LEFT OR RIGHT I HEARD A CLUNK SOUND. I FOUND OUT THAT THE INTERMEDIATE STEERING SHAFT IS THE PROBLEM. THIS COMMON TO MOST RAV4, DEALERSHIP IT'S NORMAL BUT TO ME IT DOESN'T FELL NORMAL WHEN I'M DRIVING, IT FEELS LIK... Read more

Incident date: Oct 1, 2020

THE ENGINE IS BURNING OIL DUE TO BAD PISTON RINGS. I DID SOME DIGGING FOUND THAT THAT IT WAS MANUFACTURED THIS WAY.

Incident date: Jul 21, 2020

AS A RESULT OF HAVING RECALL 16V596000 PERFORMED, REAR TOE ARMS ARE NO LONGER ADJUSTABLE FOR ALIGNMENTS. CONTACTED TOYOTA CUSTOMER EXPERIENCE AND WAS TOLD THEY WOULD NOT REPAIR AT THEIR COST THE MANUFACTURING DEFECT THAT CAUSES PREMATURE RUST, OFFERED NO SOLUTIONS. CAUSES PREMATURE TIRE WEAR, LOSS O... Read more

Incident date: May 1, 2019

THERE WAS A RECALL REGARDING OIL CONSUMPTION. I TOOK MY VEHICLE TO THE DEALER. THEY FILLED UP THE OIL AND TOLD ME TO COME BACK AFTER 3000 MILES BUT TO NOT FILL THE OIL. HALFWAY IN, THE OIL WAS COMPLETELY EXHAUSTED. BECAUSE IT HAD NOT BEEN 3000 MILES, I COULD NOT TAKE IT BACK FOR A FIX. I HAD NO C... Read more

Incident date: May 1, 2019

Incident date: Feb 19, 2020

HAD MY 2006 TOYOTA RAV 4 IN THE DEALERSHIP FOR RECALL SERVICES. I ALSO HAD RECOMMENDED MAINTENANCE TUNEUP AND BRAKE FLUID DRAIN AND REFILL. WHEN I LEFT THE PARKING LOT OF THE DEALERSHIP, I CROSSED 2 LANES OF TRAFFIC, BRAKED, WAITED FOR ALTERNATE TRAFFIC TO PASS BEFORE TURNING ONTO THE CITY STREET WI... Read more

Incident date: Feb 19, 2020

Incident date: Feb 27, 2020

THE ENGINE IS BURNING OIL LIKE MAD. I PURCHASED IT THREE WEEKS AGO AND THERE WERE NO ISSUES WHEN I LOOKED AT IT. I HOOKED MY OBD II SCANNER AND NO CODES POPPED, WHICH MADE ME GO AHEAD AND PURCHASE IT. I HEARD ABOUT THE TOYOTA 2AZ-FE ENGINES HAVING OIL ISSUES, BUT THIS IS GETTING OUT OF HAND. MY MEC... Read more

Incident date: May 14, 2019

TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. THE CONTACT STATED THAT EACH TIME THE VEHICLE WAS DRIVEN, IT SHOOK INTERMITTENTLY. NO WARNING INDICATOR LIGHTS ILLUMINATED. THE CONTACT STATED THAT THE FAILURE HAS PROGRESSIVELY WORSENED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR A ... Read more

Incident date: Aug 8, 2019

TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. THE CONTACT STATED THAT BOTH REAR WHEELS WERE WEARING OUT THE TIRES DUE TO NHTSA CAMPAIGN NUMBER: 16V596000 (SUSPENSION) REGARDING THE REAR SUSPENSION ARM. THE VEHICLE WAS TAKEN TO NAGUABO AUTO SALES (272 NAGUABO PR 00718), BUT AN ALIGNMENT COULD NOT BE COMPL... Read more

Incident date: Dec 3, 2019

TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V596000 (SUSPENSION), HOWEVER THE PARTS FOR THE RECALL REMEDY WERE NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME TO REPAIR THE VEHICLE. HERITAGE TOYOT... Read more

Incident date: Jun 14, 2019

MY CAR HAS BEEN CONSUMING LOTS OF OIL HOWEVER I WAS NEVER ABLE TO IDENTIFY WHERE THE LEAK WAS COMING FROM. I CONTACTED TOYOTA CERTIFIED REPAIR SERVICE WHEN I WENT TO GET OIL CHANGED THEY INDICATED THEY DID NOT IDENTIFY ANY LEAKS AND THE VEHICLE WAS OPERATING CORRECTLY ALTHOUGH I RETURNED TO TOYOTA... Read more

Incident date: Apr 1, 2019

WE PURCHASED A 2006 RAV4 LIMITED THE FIRST WEEK OF MARCH 2019. A REAR DIFFERENTIAL COUPLING GROWL NOISE WAS NOTICEABLE A MONTH AFTER WE PURCHASED THE VEHICLE. WHILE DRIVING THE REAR END STARTED MAKING A GROWLING NOISE. IN EARLY JANUARY 2015 TOYOTA ISSUED A WARRANTY ENHANCEMENT PROGRAM (ZF4) FOR YEAR... Read more

Incident date: May 9, 2019

2.4 ENGINE BURNS EXCESSIVE OIL. APPARENTLY, OTHER TOYOTA MODELS WITH THE SAME 2.4 ENGINE HAVE HAD FREE REPAIRS. I BELIEVE TOYOTA SHOULD REPAIR THE 2.4 ENGINE IN MY 2006 RAV4 TO STOP THE EXCESSIVE OIL BURNING. IT NOW BURNS ONE QUART FOR EVERY 500-600 MILES.

Incident date: Apr 2, 2019

LOSING OIL ENGINE MAKING NOISE NO POWER

Incident date: Apr 5, 2019

TAMARA RECALL ENGINE FAILURE ALMOST CAUSED A MAJOR ACCIDENT. DEALERSHIP TELLS ME THE IT'S AN RECALL BUT, IT HAS NOW EXPIRED. I DON'T UNDERSTAND HOW A SAFETY RECALL CAN EXPIRE. I NEED HELP FROM AN ATTORNEY ON THIS MATTER. BECAUSE THIS ISN'T RIGHT. CAN YOU RECOMMEND AN ATTORNEY? THEY SAID THEY COULD O... Read more

Incident date: Apr 5, 2019

Incident date: Apr 2, 2019

LOSING OIL ENGINE MAKING NOISE NO POWER

Incident date: Apr 2, 2019

LOSING OIL ENGINE MAKING NOISE NO POWER

Incident date: Apr 7, 2018

TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. THE CONTACT STATED THAT THE REAR AND FRONT AXLES WERE RUSTED OUT AND RUST COVERED THE BOTTOM OF THE VEHICLE. THE VEHICLE WAS TAKEN TO CURRY WATER TOWN TOYOTA (832 STRAITS TURNPIKE, WATERTOWN, CT 06795, (203) 758-8261), BUT THE MECHANICS REFUSED TO REPAIR THE ... Read more

Incident date: Apr 7, 2018

Incident date: Apr 8, 2019

HAVING AN ISSUE WITH MY REAR RIGHT WHEEL SPEED SENSOR - SO THEREFOR IF I DON'T COUGH UP THE $1200 THAT TOYOTA IS ASKING, I WON'T HAVE THE SAFETY FEATURES OF ABS OR TRACTION CONTROL ON MY CAR. I WAS DRIVING ON THE HIGHWAY WHEN THE ABS, BRAKE AND TRACTION CONTROL WARNING LIGHTS CAME ON... THEY'V... Read more

Incident date: Apr 8, 2019

Incident date: Aug 24, 2016

TL* THE CONTACT OWNS A 2006 TOYOTA RAV4. WHILE DEPRESSING THE BRAKE PEDAL, THE VEHICLE SHOOK. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V596000 (SUSPENSION). THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE VEHICLE WAS TAKEN... Read more

Incident date: Apr 6, 2019

OIL LIGHT CAME ON SECONDS BEFORE CHECK ENGINE LIGHT. CAR WOULD NOT ACCELERATE AND I HAD TO PULL OFF ROAD. ENGINE REQUIRED FOUR (4) QUARTS OF OIL. NO WARNING OF LOW OIL!! I WAS DRIVING ON AN INTERSTATE HIGHWAY AT THIS TIME!

Incident date: Mar 5, 2019

MY RAV4--VIN: [XXX]--HAS A PROBLEM WITH THE DRIVER SIDE AIRBAG CONNECTOR. WHEN THE WARNING LIGHT IS ON, IT DEACTIVATES ALL OF THE AIRBAGS. IT HAS BECOME PERMANENTLY ON IN RECENT DAYS. IT HAS BECOME A SAFETY HAZARD. WHEN I START MY VEHICLE AND THE AUTOMATIC CHECK UP, THE AIRBAG LIGHT KEEPS LIGHTI... Read more

Incident date: Mar 5, 2019

Incident date: Feb 12, 2018

THE SIDE AIRBAG CONNECTOR FAILED TO WORK SPORADICALLY. WHEN IT FAILED TO PASS THE ONBOARD TEST, THE WHOLE AIRBAG SYSTEM STOPS WORKING, WHICH BECOMES A SAFETY HAZARD.

Incident date: Feb 1, 2019

VEHICLE DID HAVE AN OFFICIAL RECALL(STEERING SHAFT ASSEMBLY) VEHICLE WAS REPAIRED 2X'S. VEHICLE IS EXPERIENCING SAME PROBLEM. STEERING GETS TIGHT AND KNOCKS. SENT LETTER TO TOYOTA IN CALIFORNIA CREATED CASE #[XXX] DEALER REFUSES TO REPAIR *TT CONSUMER STATED THERE ARE 2 ODI NUMBERS #352270 AND... Read more

Showing 50 of 880 complaints.

Technical Service Bulletins, 2006 TOYOTA RAV4

358 manufacturer communications from 196 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
350000 EQUIPMENT	50
060000 ENGINE AND ENGINE COOLING	50
060000 ENGINE (PWS)	48
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL	22
110000 ELECTRICAL SYSTEM	18
100000 POWER TRAIN	14
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER	11
140000 AIR BAGS	10

061500 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION

This is to advise of various price adjustments that will affect Toyota Genuine Motor Oil and Long Life Coolant, effective March 1, 2024. These products are ordered through the Toyota Complete Maintenance Care (TCMC) website.

060000 ENGINE AND ENGINE COOLING

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

OBSOLETE NOTICE January 22, 2024: This bulletin is now obsolete. Please see T-SB-0057-18.

350000 EQUIPMENT

TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2023 model year vehicles may be available provided the re

180000 VEHICLE SPEED CONTROL

140000 AIR BAGS

350000 EQUIPMENT

TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Follow the procedures in this bulletin to

110000 ELECTRICAL SYSTEM

140000 AIR BAGS

TSB: Some 2005 ? 2022 model year Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty smell is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The pur

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

280000 BACK OVER PREVENTION

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions

030000 SERVICE BRAKES, HYDRAULIC

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions

050000 PARKING BRAKE

TSB: This Service Bulletin includes procedures to replace damaged or loose front carpet floor retainer(s) without replacing the carpet assembly. Follow the Repair Procedure in this bulletin to replace the loose or damaged carpet floor retai

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. This information must be kept near the point of vehicle sale and be available to any custom

200000 WHEELS

190000 TIRES

160000 STRUCTURE

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

TSB: Some 2006 ? 2022 model year Toyota vehicles in particular geographic areas may exhibit a condition where the HVAC evaporator drain hose has become obstructed with an insect nest. An insect repellent drain hose tip (ARINIX? Tip) is avai

140000 AIR BAGS

Toyota Safety Recall and Service Campaign - Technician Certification Requirements

280000 BACK OVER PREVENTION

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.

030000 BRAKES (PWS)

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.

350000 EQUIPMENT

TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2021 model year vehicles may be available provided the re

280000 BACK OVER PREVENTION

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.

030000 BRAKES (PWS)

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.

030000 SERVICE BRAKES, HYDRAULIC

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.

020000 SUSPENSION

TSB: OBSOLETE NOTICE June 23, 2020: This bulletin is now obsolete. Please see T-SB-0063-20.

200000 WHEELS

TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. ST005-01, SU001-08, and T-SB-0391-08. The aforementioned bulletins are obsolete, and any printed versions should be discarded. Be sure

063140 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR

These SKUs are Exhaust Manifolds with Catalytic Converters. The customer communication requested return of unsold inventory due to a loss of CARB certification. These SKUs can no longer be sold as they do not meet CARB standards, but part

063140 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR

350000 EQUIPMENT

TSB: OBSOLETE NOTICE April 07, 2020: This bulletin is now obsolete. Please see T-SB-0032-20. Replacement Certification Labels and VIN Plates

350000 EQUIPMENT

TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. PG021-88, PG015-89, PG0015-90, PG002-91, PG002-93, PG005-97, PG007-01, PG007-07, PG006-01, PG004-97, T-SB-0144-08, and T-SB-0304-17. The a

350000 EQUIPMENT

OBSOLETE NOTICE February 12, 2020: This bulletin is now obsolete. Please see T-SB-0010-20.

350000 EQUIPMENT

TSB: Some 2004 ? 2017 model year Toyota vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Although there is no way to eliminate these odors, follow the General Procedure in this bull

350000 EQUIPMENT

TSB: Vehicles may display evidence of a fluid leak or fluid seep from powertrain components. This bulletin explains how to determine the differences between a fluid leak versus a fluid seep. Cases that are determined to be a ?leak? should b

350000 EQUIPMENT

Dealer Package: Toyota will be sending Safety Recall/Special Service Campaign Follow-Up Notices to owners whose vehicles have not yet had the following Safety Recall/Special Service Campaign repairs completed. Please note the following info

350000 EQUIPMENT

Dealer Email: Toyota will be sending Safety Recall/Special Service Campaign Follow-Up Notices to owners whose vehicles have not yet had the following Safety Recall/Special Service Campaign repairs completed. Please note the following inform

350000 EQUIPMENT

Region Letter: Toyota will be sending Safety Recall/Special Service Campaign Follow-Up Notices to owners whose vehicles have not yet had the following Safety Recall/Special Service Campaign repairs completed. Please note the following infor

350000 EQUIPMENT

Region Email: Toyota will be sending Safety Recall/Special Service Campaign Follow-Up Notices to owners whose vehicles have not yet had the following Safety Recall/Special Service Campaign repairs completed. Please note the following inform

356000 EQUIPMENT ADAPTIVE/MOBILITY

TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. T-SB-0033-14. ? Applicability has been updated to include 2019 model year Toyota vehicles. Service Bulletin No. T-SB-0033-14 is obsolete and

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

060000 ENGINE (PWS)

TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections have been updated. October 30, 2017 Rev1: ? Applicability has be

110000 ELECTRICAL SYSTEM

100000 POWER TRAIN

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

TSB: Some vehicles in particular geographic areas may exhibit a condition where the HVAC evaporator drain hose has become obstructed with an insect nest. An insect repellent drain hose tip (ARINIX? Tip) is now available to help minimize fut

350000 EQUIPMENT

Region Email: Toyota will be sending Safety Recall and Special Service Campaign follow-up notices to owners whose vehicles have not yet had the following Safety Recall or Special Service Campaign repairs completed. Please note the following

350000 EQUIPMENT

Dealer Email: Safety Recall and Special Service Campaign completion is an integral part of our commitment to meet customer expectations of Toyota products. Toyota will be sending Follow-Up Notices to remind owners whose vehicles have not ye

350000 EQUIPMENT

Region Letter: Toyota will be conducting Safety Recall and Special Service Campaign follow-up notifications to owners whose vehicles have not yet had the following Safety Recall or Special Service Campaign repairs completed. Please note the

350000 EQUIPMENT

Dealer Packet: Safety Recall and Special Service Campaign completion is an integral part of our commitment to meet customer expectations of Toyota products. Toyota will be sending Follow-Up Notices to remind owners whose vehicles have not y

350000 EQUIPMENT

Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17.

355100 EQUIPMENT:OTHER:LABELS

Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17.

350000 EQUIPMENT

Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17.

355100 EQUIPMENT:OTHER:LABELS

Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17.

350000 EQUIPMENT

TSB: REVISION NOTICE July 31, 2018 Rev2: ? The Supersession Notice has been updated. January 11, 2018 Rev1: ? The Supersession Notice has been updated. Any previous printed versions of this bulletin should be discarded. SUPERSESSION NOTICE

350000 EQUIPMENT

TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. T-SB-0043-14. ? Applicability has been updated to include 2017 ? 2018 model year Toyota vehicles. Service Bulletin No. T-SB-0043-14 is obso

190000 TIRES

TSB: REVISION NOTICE February 12, 2018 Rev2: ? Applicability has been updated to include 2015 ? 2018 model year vehicles. January 23, 2014 Rev1: ? Applicability has been updated to include 2013 ? 2014 model year vehicles. Any previous print

190000 TIRES

350000 EQUIPMENT

TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. PG021-88, PG015-89, PG0015-90, PG002-91, PG002-93, PG005-97, PG007-01, PG007-07, and T-SB-0144-08. Service Bulletin Nos. PG021-88, PG015-89

110000 ELECTRICAL SYSTEM

TSB: REVISION NOTICE November 22, 2017 Rev1: ? Applicability has been updated to include 2014 ? 2018 model year vehicles. Any previous printed versions of this bulletin should be discarded. In the event that a Toyota vehicle becomes submerg

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

TSB: REVISION NOTICE October 30, 2017 Rev1: * Applicability has been updated to include 2018 model year vehicles. SUPERSESSION NOTICE The information contained in this bulletin supersedes SB No. T-SB-0012-13. Flash reprogramming allows the

162300 STRUCTURE:BODY:DOOR

TSB: Vehicle replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) may be available from Toyota, provided the request meets one of the criteria lis

140000 AIR BAGS

TSB: REVISION NOTICE July 20, 2017 Rev1: Applicability has been updated to exclude 2007 ? 2017 model year Avanza vehicles. Some hazardous material treatment and handling regulations at the state and local level define the pre-disposal deplo

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

TSB: REVISION NOTICE March 08, 2017 Rev1: ? Applicability has been updated to include 2015 - 2017 model year Toyota vehicles. ? The Parts Information section has been updated. Some vehicles in particular geographic areas may exhibit a c

140000 AIR BAGS

Dealer Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed.

140000 AIR BAGS

Region Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed.

063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

Technical Instructions: Toyota has received reports that certain 2006 through 2008 Model Year RAV4 vehicles (equipped with a V6 (2GR) engine) operated in specific cold climate areas where high amounts of road salt are used (?Cold Climate S

063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

Dealer Package: Toyota has received reports that certain 2006 through 2008 Model Year RAV4 vehicles (equipped with a V6 (2GR) engine) operated in specific cold climate areas where high amounts of road salt are used (?Cold Climate States?)

063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

Dealer Daily: An additional inspection-only opcode for aftermarket mufflers has been added.

060000 ENGINE AND ENGINE COOLING

Dealer Package Email: Toyota has received reports that certain 2006 through 2008 Model Year RAV4 vehicles (equipped with a V6 (2GR) engine) operated in specific cold climate areas where high amounts of road salt are used (?Cold Climate Sta

060000 ENGINE AND ENGINE COOLING

Region Letter Email: Toyota has received reports that certain 2006 through 2008 Model Year RAV4 vehicles (equipped with a V6 (2GR) engine) operated in specific cold climate areas where high amounts of road salt are used (Cold Climate State

350000 EQUIPMENT

Dealer Daily: Special Service Campaign G0Y dealer letter and technical instructions now available on TIS.

060000 ENGINE AND ENGINE COOLING

Warranty Policy Bulletin: Toyota has received some reports where vehicles may exhibit excessive engine oil consumption. Toyota is now announcing the part replacement phase of Warranty Enhancement Program ZE7 for vehicles exhibiting excess

110000 ELECTRICAL SYSTEM

TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes SB No. T-SB-0101-11. Applicability has been updated to include 2016 ? 2017 model year vehicles. Service Bulletin No. T-SB-0101-11 is Obsolete and any printed

118000 ELECTRICAL SYSTEM:SOFTWARE

TSB: OBSOLETE NOTICE: September 14, 2016: This bulletin is now obsolete. Please see T-SB-0134-16.

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

TSB: REVISION NOTICE November 10, 2016 Rev2: ? Applicability has been updated to include 2016 ? 2017 model year Toyota vehicles. ? Parts Information section has been updated. Some 2004 ? 2017 model year Toyota vehicles may exhibit odor

060000 ENGINE (PWS)

TSB: Supersession Notice. Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service

110000 ELECTRICAL SYSTEM

Dealer Package email: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Smart

350000 EQUIPMENT

353000 EQUIPMENT:ELECTRICAL

110000 ELECTRICAL SYSTEM

Dealer Package: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Smart Stop

350000 EQUIPMENT

353000 EQUIPMENT:ELECTRICAL

110000 ELECTRICAL SYSTEM

Technical Instructions: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Sma

350000 EQUIPMENT

353000 EQUIPMENT:ELECTRICAL

060000 ENGINE (PWS)

Region Letter email: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Smart

060000 ENGINE (PWS)

Region Letter: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Smart Stop T

060000 ENGINE (PWS)

110000 ELECTRICAL SYSTEM

350000 EQUIPMENT

353000 EQUIPMENT:ELECTRICAL

110000 ELECTRICAL SYSTEM

350000 EQUIPMENT

353000 EQUIPMENT:ELECTRICAL

060000 ENGINE (PWS)

Showing 100 of 358 bulletins.

NHTSA Safety Investigations, TOYOTA RAV4

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 2013

Battery Hold Down Bracket Thermal Events

The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) to understand the contributing factors and frequency of vehicle fires originating from the battery region of the engine compartment in Model Year (MY) 2013-2018 Toyota RAV4 vehicles on 25 February 2021. At the time of ope... ning, ODI attributed eleven allegations and additional EWR events to this PE. PE21005 focused on replacement batteries installed in the subject vehicles. No reported fire event identified in PE21005 involved the originally supplied 12V battery. The reported fires took place in vehicles known to contain aftermarket batteries or whose age exceeded the expected life of the original equipment battery. ODI identified battery dimensioning as it relates to the battery retention system (hold down bracket, radiator support bolt, J-hook, and battery tray) as the main factor set in the contact between the battery hold down bracket contacting the positive terminal of the 12V battery. The subject vehicles carried over the same battery tray and retention system from the prior generation (MY2006 – MY2012) of RAV4 vehicles. However, the subject vehicles were equipped with a dimensionally smaller battery (Group 35) than the prior generation (Group 24F). The smaller- length measurement in the Group 35 battery size in a battery tray originally designed to fit a Group 24F battery contributed to increased potential for battery movement which was exacerbated by the diversity in aftermarket battery configuration and irregularities intrinsic to battery replacement procedures. Battery movement coupled with the proximity of the B+ terminal on the battery and the grounded electrically conductive hold down bracket set the stage for a short to ground leading to an engine stall (if in operation) followed by a vehicle fire. This investigation was not able to classify the installation status, battery size, or cause of every allegation due to the fire event causing damage to the area, inaccessible vehicle, modification to the battery retention system after the event, and/or inconclusive photographic evidence. Toyota's investigation of the issue identified aftermarket battery catalogs that listed an improper battery replacement size (Group 26R) that would nevertheless fit into the subject vehicles whose battery retention system is incapable of reliably restraining a Group 26R battery. On 18 November 2021, Toyota initiated a consumer advisory campaign (21TG01) to the subject vehicle owners, notifying them of the correct size battery and offering a free inspection of the battery and retention hardware, a caution label to affix to the hold down bracket, and a discounted replacement 12V battery. This investigation with Toyota established three broad categories to characterize the battery retention system state of a given vehicle: "correct", "minor mis-installation", and "major mis-installation". - The "correct" terminology references the front bolt, bracket, and J-hook installed in a position not in contact with the positive battery terminal and the front bolt torqued to 17 Nm and the J-hook engaged with the tray hole and torqued to 4.9 Nm. - A "minor mis-installation" would describe the three retention components installed in the prescribed location, however not to the correct torque values. - The "major mis-installation" condition would constitute a retention component missing or disconnected from the system. Toyota's own testing used five exemplar batteries installed on a subject vehicle in each battery categorization resulted in: - Contact between the B+ terminal and hold down bracket in "major mis-installations" - Movement of the battery in "minor mis-installations" - No observable motion in "correct" installations. ODI conducted its own evaluation of the Toyota- specified replacement battery and 5 aftermarket Group 35 batteries. The six batteries tested conformed to the Group 35 Battery Council International (BCI) standard on overall dimensional tolerance and terminal location. That standard does not define the edge shape or material of battery casing. Physical interaction between the hold down bracket and the battery case and the friction between the casing material and the battery tray resulted in a large variability in movement forces required to incite movement when the battery was installed in the "correct" condition. Resulting in movement at an induced lateral load between 0.6 G and 1.91 G equivalent force across each battery. This force is higher than a typical vehicle could exert in a steady state turn and would only experience loads through brief shock or impulses. Multiple shock or impulse loads across time would contribute to a delay between the replacement battery installation and the fire event. Likelihood of a fire event increases as the installation method degraded from the "correct", to "minor mis-installation", and then to "major mis-installation". Protruding vent caps atop some of the batteries tested aided in restricting battery movement relative to the hold down. An absence of vent caps permitted additional movement. Following several discussions and vehicle inspections with ODI during this investigation, on 01 November 2023, Toyota filed a safety recall (NHTSA 23V-734) of 1,853,568 MY 2013 through MY 2018 Toyota RAV4 vehicles to reduce the risk of a vehicle fire with redesigned battery retention components. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.Read more

PE, Closed , Model Year: 2006

Rear Suspension Arm Assembly Failure

In a letter dated August 1, 2012 Toyota Motor Engineering & Manufacturing North America, Inc. (Toyota) submitted a Defect Information Report (NHTSA Recall No. 12V-373) to the NHTSA identifying a safety defect regarding possible separation of the Rear Suspension Arm No. 1 Assembly (arm) at the thread... ed portion (shaft and turn buckle) of the component in MY 2006 through MY 2011 Toyota RAV4 vehicles built from October 2005 through September 2010 and in MY 2010 Lexus HS250h vehicles manufactured from July 2009 through August 2010.According to Toyota, if the adjustment nuts for the rear wheel alignment are improperly tightened when alignment is performed in service, backlash may develop at the threaded portion of the arm, followed by rust formation.The threads may then wear causing the arm to separate, which may result in a loss of vehicle control.In analysis of both Vehicle Owner Questionnaire (VOQ) data submitted to the Office of Defects Investigation (ODI) and consumer complaint data submitted to Toyota, ODI identified 131 non-duplicative reports alleging failure of the subject rear suspension arm (Note:some of the complaints and related service records refer to the arm as a rear tie rod).Six of the complainants allege the failure resulted in some loss of vehicle control.For purposes of this analysis, loss of control events involve alleged complete or partial departure from the intended lane of travel.An additional four complaints reported difficulty maintaining control of the vehicle when the arm failed.Recalled vehicles will be inspected for proper torque of the adjustment nuts and replaced as necessary.In addition, Toyota will take several actions to reduce the potential for improper torque in future alignment procedures.This includes:(1) providing proper tightening sequence and torque specification information to two major wheel alignment equipment manufacturers, who would disseminate the information to alignment shops using their equipment; (2) installation of a clip on each arm with an instructional label showing proper tightening sequence and torque specification (the clip must be removed to perform a wheel alignment); (3) installation of additional labels on the front and back vertical surfaces of the Rear Suspension Arm No. 2 assemblies; and (4) providing an instruction booklet to owners to place in the glove box.This investigation is closed.Read more

TOYOTA RAV4 - All Years Overview

Complete safety history for the TOYOTA RAV4 across all model years (1996, 2025).

149 Total Recalls

12,082 Total Complaints

2 Investigations

1,060 Reported Crashes

359 Reported Fires

11 Reported Deaths

TOYOTA RAV4 - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2025	3	104	View
2024	3	251	View
2023	3	247	View
2022	1	209	View
2021	1	506	View
2020	6	795	View
2019	7	1,172	View
2018	3	439	View
2017	3	408	View
2016	3	291	View
2015	4	399	View
2014	4	275	View
2013	2	330	View
2012	5	357	View
2011	11	402	View
2010	14	498	View
2009	15	397	View
2008	14	708	View
2007	14	1,240	View
2006 (current)	11	880
2005	5	168	View
2004	2	182	View
2003	0	392	View
2002	0	682	View
2001	0	418	View
2000	3	34	View
1999	5	75	View
1998	5	92	View
1997	1	61	View
1996	1	54	View
1995	0	1	View
1994	0	4	View

Other TOYOTA Models

Model	Recalls	Complaints
TUNDRA	787	9,074	View
HIGHLANDER	677	6,756	View
CROWN	548	141	View
TACOMA	406	10,562	View
VENZA	404	969	View
GRAND HIGHLANDER	388	332	View
PRIUS	365	15,456	View
HIGHLANDER HYBRID	355	1,103	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2006 TOYOTA RAV4

Complaint Statistics

Top Reported Components

Technical Service Bulletins, 2006 TOYOTA RAV4

Most Affected Components

NHTSA Safety Investigations, TOYOTA RAV4

TOYOTA RAV4 - All Years Overview

TOYOTA RAV4 - Year by Year

Other TOYOTA Models