1999 TOYOTA RAV4 Recalls, Complaints & Safety

AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 1998-2000 RAV4, 1998-1999 RAV4 EV and Celica and 1997-1998 Supra vehicles. These vehicles were equipped with Non-Azide Driver air bag Inflators (NADI) and do not contain phase stabilized ammonium nitrate (PSAN) propellant. Due to a manufacturing issue, the NADI inflators may absorb moisture, causing the inflators to rupture or the air bag cushion to underinflate.

Remedy: Toyota will notify owners, and owners will have the option to self-inspect, or have a dealer inspect the steering wheel on their vehicle to determine if their vehicle may be equipped with an affected inflator. Potentially affected steering wheel serial numbers will be inspected by a dealer. Based on the inspection, dealers will replace the front driver air bag inflator with an alternate one, as necessary. These repairs will be performed free of charge. The recall began August 28, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's numbers for this recall is 20TB01 and 20TA01.

138,842 vehicles affected

AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

138,842 vehicles affected

POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH

VEHICLE DESCRIPTION: SPORT UTILITY ELECTRIC VEHICLES. IF THE SUBJECT VEHICLES ARE REPEATEDLY PARKED BY PLACING THE SHIFT LEVER INTO THE "P" POSITION WITHOUT APPLYING THE PARKING BRAKE, THE PARKING LOCK ROD, A COMPONENT OF THE TRANSMISSION PARKING LOCK SYSTEM, COULD BREAK.

Remedy: DEALERS WILL REPLACE THE PARKING LOCK ROD.

756 vehicles affected

SERVICE BRAKES, AIR:DISC:ROTOR

VEHICLE DESCRIPTION: SPORT UTILITY ELECTRIC VEHICLES. THE FRONT DISC BRAKE ROTOR, WHEN EQUIPPED WITH STEEL WHEELS, CAN DEVELOP STRESS FRACTURES IF THE LUG NUTS ARE TIGHTENED WITH EXCESSIVE TORQUE.

Remedy: DEALERS WILL REPLACE THE DISC BRAKE ROTORS. IF THE VEHICLE IS EQUIPPED WITH STEEL WHEELS, TOYOTA WILL REPLACE THE FRONT DISC BRAKE ROTORS AND STEEL WHEELS WITH NEW DISC BRAKE ROTORS AND NEW ALUMINUM WHEELS. IN ADDITION A CAUTION LABEL THAT READS, "USE NEW GENUINE TOYOTA ALUMINUM WHEELS." WILL BE AFFIXED. VEHICLES ALREADY EQUIPPED WITH ALUMINUM WHEELS WILL ONLY REQUIRE CAUTION LABEL INSTALLATION.

780 vehicles affected

ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

EQUIPMENT DESCRIPTION: AFTERMARKET THEFT DETERRENT SYSTEMS USED ON 1998-1998 TOYOTA RAV4, AVALON, AND SIENNA MODEL VEHICLES DISTRIBUTED BY SOUTHEAST TOYOTA DISTRIBUTORS, INC. IN THE STATES OF ALABAMA, FLORIDA, GEORGIA, NORTH AND SOUTH CAROLINA. THE ALARM WIRING HARNESS PLUGS INTO THE VEHICLE'S IGNITION SWITCH AND THE VEHICLE'S IGNITION SWITCH WIRING HARNESS PLUGS INTO THE ALARM HARNESS TO COMPLETE THE CIRCUIT. A PERCENTAGE OF THE FEMALE TERMINALS USED IN THE ALARM CONNECTOR WERE FOUND TO BE DEFECTIVE, CAUSING AN "OPEN CIRCUIT" CONDITION WHEN MATED TO THE MALE IGNITION SWITCH TERMINALS.

Remedy: DEALERS WILL INSPECT THE DATE CODE LABEL ON THE SECURITY SYSTEM HARNESS AND ANY DISPLAYING THE MANUFACTURING/FINAL DATE CODE WILL BE REPLACED WITH NEWLY PRODUCED HARNESSES. THE DATE CODES ARE: RAV4 - 6/24/98, 6/25/98, 6/26/98; SIENNA - 6/25/98, 6/26/98; AND AVALON - 6/30/98, 7/1/98, 8/31/98, 9/1/98, 9/2/98, AND 9/3/98.

1,960 vehicles affected

ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES, MINI VANS AND PASSENGER VEHICLES EQUIPPED WITH A THEFT DETERRENT SYSTEMS (TDS) SUPPLIED BY AUDIOVOX CORPORATION AND DISTRIBUTED BY SOUTHEAST TOYOTA DISTRIBUTORS, INC. IN THE STATES OF ALABAMA, FLORIDA, GEORGIA, NORTH AND SOUTH CAROLINA. THE ALARM WIRING HARNESS PLUGS INTO THE VEHICLE'S IGNITION SWITCH AND THE VEHICLE'S IGNITION SWITCH WIRING HARNESS PLUGS INTO THE ALARM HARNESS TO COMPLETE THE CIRCUIT. A PERCENTAGE OF THE FEMALE TERMINALS USED IN THE ALARM CONNECTOR WERE FOUND TO BE DEFECTIVE, CAUSING AN 'OPEN CIRCUIT' CONDITION WHEN MATED TO THE MALE IGNITION SWITCH TERMINALS.

1,960 vehicles affected

I lost control of the vehicle and I overcorrected causing the car to go airborne. I hit head on into an embankment then continued to roll 3or 4 times before stopping. There were no indications or warnings to make me think these parts were going to malfunction. My airbags never deployed and the seatbelt did not lockup.

Crash 1 injured

TL* TAKATA RECALL. THE CONTACT OWNS A 1999 TOYOTA RAV4. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V033000 (AIR BAGS) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT CALLED TOYOTA OF WALLINGFORD (859 N COLONY RD, WALLINGFORD, CT 06492, (888) 927-7559) WHERE IT WAS CONFIRMED THAT THE PART WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER HAD NOT BEEN MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

TL* THE CONTACT OWNS A 1999 TOYOTA RAV4. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V033000 (AIR BAGS) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. AN UNNAMED DEALER WAS CONTACTED AND CONFIRMED THAT PARTS WERE NOT YET AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* TAKATA RECALL. THE CONTACT OWNS A 1999 TOYOTA RAV4. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V03300 (AIR BAGS) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT CALLED STEVINSON TOYOTA EAST LOCATED AT 444 S. HAVANA ST, AURORA, CO 80012, AND IT WAS CONFIRMED THAT THE PART WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* TAKATA RECALL. THE CONTACT OWNS A 1999 TOYOTA RAV4. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V033000 (AIR BAGS) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT CONTACTED BERGLUND TOYOTA LOCATED AT 3000 WARDS RD, LYNCHBURG, VA 24502, (434) 509-0770, AND IT WAS CONFIRMED THAT THE PART WAS NOT AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. *JS *BF *JS

TL* THE CONTACT OWNS A 1999 TOYOTA RAV4. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V033000 (AIR BAGS) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. *BF *JS

WE TOOK THE RAV4 INTO THE MECHANIC FOR A BRAKE JOB & HE CALLED US TO SAY IT WASN'T ROAD WORTHY BECAUSE THE K-FRAME WAS ALMOST ENTIRELY RUSTED THROUGH AND WE SHOULDN'T PUT OUR CHILDREN IN IT. HE SAID WE SHOULDN'T EVEN DRIVE IT OFF HIS LOT THAT IT COULD HIT A POTHOLE AND BREAK IN TWO. WE CAME & TOOK PICTURES OF ALL THE RUST. HE SAID THE K-FRAME WOULD NEED TO BE REPLACED ALONG WITH THE ROCKER ARMS. WE CAME HOME & RESEARCHED TO FIND THIS IS A COMMON PROBLEM WITH THESE VEHICLES. I DON'T UNDERSTAND WHY A COMPANY LIKE TOYOTA WOULDN'T TAKE RESPONSIBILITY FOR A DEFECT LIKE THIS. IT'S CLEARLY A DESIGN FLAW. IMAGINE THE CATASTROPHIC DAMAGE AND INJURY THAT WOULD OCCUR IF I HAD MY CHILDREN IN THIS VEHICLE DRIVING 65MPH DOWN THE HIGHWAY (THAT I HAVE TO TAKE EVERYDAY TO GET ANYWHERE) AND THE FRAME ON THIS VEHICLE BREAKING! I HATE TO THINK WHAT WOULD HAPPEN TO ME OR MY CHILDREN. ALL BECAUSE TOYOTA DIDN'T MAKE SURE TO MAKE A FUNCTIONAL PART OF THE SUPPORT STRUCTURE OF THEIR VEHICLES.

TL* THE CONTACT OWNS A 1999 TOYOTA RAV. WHEN THE IGNITION WAS TURNED TO THE OFF POSITION IN THE EVENING, THE RADIO WAS ACTIVATED THE NEXT MORNING. ALSO, THE FAN IN THE ENGINE WAS RUNNING AND CAUSED THE BATTERY TO DRAIN. THE IGNITION WAS TURNED TO THE ON POSITION, BUT THE VEHICLE FAILED TO START. WHILE DRIVING AT AN UNKNOWN SPEED, THE ENGINE STALLED AND THE AIR BAG WARNING INDICATOR ILLUMINATED. THE VEHICLE RESTARTED ON SOME OCCASIONS, BUT THE FAILURES RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE THEFT DETERRENT SYSTEM FAILED AND NEEDED TO BE REMOVED. THE VEHICLE WAS REPAIRED, BUT THE FAILURES RECURRED AND RENDERED THE VEHICLE INOPERABLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 98V278000 (ELECTRICAL SYSTEM). THE FAILURE MILEAGE WAS APPROXIMATELY 110,000.

TL* THE CONTACT OWNS A 1999 TOYOTA RAV 4. THE CONTACT WAS NOTIFIED BY AN INDEPENDENT MECHANIC THAT THE FRONT CRADLE WAS COMPLETELY RUSTED AND THE ONLY THING KEEPING IT FROM FRACTURING WAS THE STEERING LINKAGE. THE VEHICLE WAS NOT ABLE TO BE REPAIRED. THE MANUFACTURER WAS NOT AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 220,000.

TL* THE CONTACT OWNS A 1999 TOYOTA RAV4. THE CONTACT NOTICED THAT THE FRONT SUB FRAME AND CONTROL ARMS WERE COMPLETELY RUSTED. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE ENGINE CRADLE AND CONTROL ARMS NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 120,000. UPDATED 10/8/14*CN THE CONSUMER STATED THE VEHICLE WAS REPAIRED AT THE OWNERS EXPENSE. UPDATED 3/23/2015*JS

Crash

TL* THE CONTACT OWNS A 1999 TOYOTA RAV4. THE CONTACT STATED THAT THE FRONT SUB FRAME AND CONTROL ARMS WERE COMPLETELY RUSTED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 163,000.

TODAY I WAS BACKING OUT OF A PARKING SPACE AND MY ENGINE SURGED. I WAS ABLE TO STOP THE CAR BY BRAKING AS HARD AS POSSIBLE, AND EVEN THEN IT WAS DIFFICULT TO STOP. THIS IS THE FIRST TIME IT HAS SURGED WHILE BACKING UP. ON NUMEROUS OCCASIONS OVER THE YEARS THE ENGINE HAS SURGED WHEN THE CAR IS SLOWING DOWN AT A STOPLIGHT OR STOP SIGN, AND USUALLY WHEN I'M GOING UNDER 10 MILES AN HOUR. VERY SCARY! THERE IS NO PROBLEM WITH MY FLOOR MAT, WHICH IS FASTENED SECURELY WELL BELOW THE BRAKE AND GAS PEDALS.ALSO, I'VE NEVER BEEN DISORIENTED AND UNABLE TO TELL WHERE MY FOOT IS. I DON'T DRINK OR SMOKE, AND HAVE A GOOD SAFETY RECORD WITH STATE FARM FOR OVER 40 YEARS. I'VE REPORTED THIS SURGING PROBLEM NUMEROUS TIMES TO TOYOTA AND THEY CAN'T SEE ANYTHING WRONG WHEN THEY TEST DRIVE. THAT'S BECAUSE THE SURGING PROBLEM OCCURS IRREGULARLY, ABOUT ONCE IN EVERY 50 TIMES I BRAKE. AT VARIOUS TIMES I'VE ASKED OTHER DRIVERS OF RAV 4 CARS IF THEY'VE HAD THIS PROBLEM, AND SEVERAL HAVE SAID YES. TOO BAD I NEVER TOOK DOWN THEIR NAMES. I'VE ALSO REPORTED THIS BEFORE TO THE NHTSA, AND NOTHING CAME OF IT. I HAVE FAITH THAT ONE DAY THE PROBLEM WILL BE ACKNOWLEDGED. I'M A RETIRED FEDERAL OFFICIAL, SO I HAVE TO THINK THAT WRITING THIS IS NOT A WASTE OF TIME. *TR

THERE IS RUST IN THE FRONT CROSS MEMBER PASSENGER SIDE. THERE IS A BIG HOLE BECAUSE OF RUST. IT IS NOT SAFE TO DRIVE IT. *TR

TL* THE CONTACT OWNS A 1999 TOYOTA RAV4. THE CONTACT STATED THAT WHILE SITTING AT A STOP WITH THE BRAKES APPLIED, THE VEHICLE ERRONEOUSLY ACCELERATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE COULD NOT BE DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE RECURRED SEVERAL TIMES. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 107,579.

WHILE DRIVING ON 2 LANE ROAD APPROACHING A STOP LIGHT, THE LIGHT TURNED RED AND CAR BRAKES FOR STOP, AT WHICH TIME THE THE LOWER A FRAME COLLAPSED, FORCING CAR TO THE LEFT AND INTO THE CURB, DRIVER SIDE TIRE WAS FORCED UP INTO THE WHEEL WELL. NO INJURIES OCCURED DUE TO LOW SPEED!! HOWEVER WHAT IF IT HAPPENED AT HIGHWAY SPEED??? CHECKED THE OTHER SIDE AND THE "STEEL" A FRAME "CRUMBLED IN MY HAND!!! CAR IS NOT DRIVABLE. HARD TO BELIEVE YOU HAVE FAITH THAT THIS CRITICAL MEMBER COULD FAIL SO VIOLENTLY?? HOPE THIS HELPS OTHERS, CHECK NOW!!!!! *TR

WHILE CHANGING THE CONVERTER ON MY 1999 RAV4, WE DISCOVERED HOLES AND EXTREME RUSTING ON THE FRONT CROSS MEMBER. IF THIS CROSS MEMBER BREAKS THE WHOLE SUSPENSION COULD DROP OUT FO THE CAR AND CAUSE SERIOUS INJURY. IT IS NO SECRET THAT TOYOTA HAS MANY PROBLEMS WITH FRAME ROT ON OTHER VEHICLES OCCURING ON SIMILAR YEARED MODELS. THE PROBLEM HAS NOT BEEN FIXED AND AFTER A LITTLE INVESTIGATING MYSELF, I HAVE DISCOVERED A DOZEN OTHER RAV4 OWNERS WITH THE SAME PROBLEM. I CONTACTED TOYOTA CORP. AND WAS TOLD MY CASE WAS THE ONLY OF ITS KIND BY THEM. AFTER TALKING TO DEALERS IN MY AREA I FOUND THAT THIS PROBLEM IS OCCURING AND BEING SEEN BY TOYOTA DEALERS AS WELL. *LN

S10 APPROPRIATE HANDLING RE TOYOTA BRAKING PROBLEM FM OWNER OF A 1999 TOYOTA RAV4. *KB THE CONSUMER STATED SHE WAS STOPPED AT A RED LIGHT, WITH HER FOOT ON THE BRAKE, WHEN SUDDENLY THE ENGINE REVVED AND THE VEHICLE LUNGED FORWARD. THE CONSUMER STATS SHE PUT ALL HER WEIGHT ON THE BRAKE, BUT IT ONLY STOPPED AFTER SHE TURNED THE ENGINE OFF. THE CONSUMER TOOK THE VEHICLE TO THE DEALER, BUT THEY WERE UNABLE TO FIND A PROBLEM. THE SECOND INCIDENT HAPPENED WITHIN A MONTHS TIME. THE CONSUMER STATED SHE WAS SLOWING DOWN BECAUSE SHE WAS APPROACHING A STOP LIGHT, AS SHE WAS BRAKING THE VEHICLE ACCELERATED. SHE WAS ABLE TO SLAM THE GEAR INTO NEUTRAL, SINCE IT WAS STILL MOVING AND IT STOPPED THE ACCELERATION.

AS I'VE SAID IN PREVIOUS CORRESPONDENCE TO YOUR OFFICE, AND TO TOYOTA, ALL UNANSWERED, MY 1999 RAV 4 HAS OFTEN SURGED WHILE MY FOOT IS ON THE BRAKE, ESPECIALLY WHEN I SLOW DOWN ON AN INCLINE (THE ENGINE RACES) AND I CAN BARELY BRAKE IT TO A FULL STOP. I KNOW THE PROBLEM IS ELECTRONIC, BUT THE TOYOTA DEALER IN BERKELEY, CA WHERE I BOUGHT IT STONE-WALLS, AND REFUSES TO BELIEVE IT UNLESS THEIR MECHANIC TAKES IT OUT FOR A RUN. OF COURSE, IT NEVER HAPPENS THEN, BECAUSE IT ONLY HAPPENS TO ME ABOUT ONCE IN A HUNDRED TIMES. *TR

AS VEHICLE ENTERED INTERED INTERSECTION, FRONT AIRBAG IMPLODED CAUSING DRIVER TO LOSE CONTROL AND HIT A PARKED TRUCK. BOTH VEHICLES WERE DAMAGED AND DRIVER'S INSURANCECOMPANY PAID THE CLAIM, CHARGING THE VIOLATION AGAINST THE DRIVER, AND RAISING DRIVER'S RATES EXORBITANTLY FOR THREE YEARS!! DUE TO THE FORCE OF THE IMPACT AGAINST THE DRIVER BY THE IMPLODING AIRBAG, THE DRIVER WAS VERY DAZED WHEN THE POLICE ARRIVED AND UNABLE TO ADEQUATELY EXPLAIN THE CAUSE OF THE ACCIDENT. *TR

Crash

I HAD A DEFECTIVE FUEL PUMP ON MY 1999 TOYOTA RAV4 WHICH GAVE ME PROBLEMS UP UNTIL IT STOPPED WORKING, WHICH I HAD TO TOW MY VEHICLE TO THE REPAIR SHOP AND HAVE IT DIAGNOSED AND THE FUEL PUMP REPLACED. *TR

TOYOTA 1999 RAV4 WHEN RELEASING GAS PEDAL TO SLOW DOWN, PEDAL STICKS AND CANNOT BE PUSHED DOWN TO FEED GAS WITHOUT STOMPING ON PEDAL 3 OR 4 TIMES. IT DOES NOT STICK ALL TIMES. USUALLY WHEN TEMPERATURE IS 30 DEGREES OR LOWER. HAVE BEEN STUCK IN MIDDLE OF HIGHWAY TRYING TO MAKE A TURN. VEHICLE IS NOT ON THE RECALL LIST. *TR

I SUBMIT THAT THE MOST RECENT RECALL (JAN. 2010) FOR STICKING GAS PEDALS EXTENDS TO OLDER YEAR MAKE/MODELS OF TOYOTA VEHICLES. MY 1999 TOYOTA RAV 4'S GAS PEDAL HAS BEEN STICKING NOW FOR ABOUT 3 YEARS, MOSTLY IN THE WINTER. I PRESS IT AND IT GETS STUCK AND I HAVE TO PUSH MY FOOT DOWN HARDER ON IT TO ACCELERATE. HOWEVER, THE PEDAL DOES SPRING BACK OKAY, AT LEAST AT THIS POINT. I'VE HAD IT LUBED RECENTLY AND THAT DIDN'T HELP AT ALL. *TR

TL* THE CONTACT OWNS A 1999 TOYOTA RAV4. WHILE ENTERING A PARKING SPACE, THE VEHICLE ACCELERATED WITHOUT INTENTION INTO SOME BUSHES. AFTER THE MINOR CRASH SHE WAS ABLE TO RESUME NORMAL VEHICLE OPERATION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED BECAUSE THE TECHNICIAN WAS UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE HAS NOT BEEN REPAIRED FOR THE MALFUNCTION. THE FAILURE MILEAGE WAS UNKNOWN. THE CURRENT MILEAGE WAS 109,000. THE VIN WAS UNAVAILABLE.

Crash

1999 TOYOTA RAV BEING DRIVEN BY MY 18 Y/O DAUGHTER. SHE COMPLAINED THAT THE CAR WOULD REV AND THEN JOLT WHEN IT WOULD FINALLY SHIFT INTO GEAR. WE BROUGHT IT TO A AAMCO DEALER TO HAVE DIAGNOSTICS DONE. THEY SAID IT WAS THE COMPUTER THAT NEEDED TO BE REPLACED. SINCE WE DIDN'T HAVE THE MONEY AT THE TIME WE DECIDED SHE SHOULD DRIVE IT HOME AND PARK IT. IT DIED ON THE WAY HOME WHILE SHE WAS ON THE FREEWAY. IT JUST WOULDN'T SHIFT INTO GEAR AND SLOWED DOWN TO A STOP IN THE MIDDLE OF PARLEYS CANYON (I-80) IN UTAH. NOT THE BEST SITUATION FOR A YOUNG GIRL TO BE IN! SHAME ON TOYOTA FOR NOT ADVISING THEIR CUSTOMERS OF THIS PROBLEM AND ADVISING US ON HOW TO PREVENT A WHOLE TRANSMISSION REPLACEMENT! *TR

TL*THE CONTACT OWNS A 1999 TOYOTA RAV4. THE CONTACT STATED THAT THE TIRE WAS WEARING AT AN ANGLE ON THE REAR DRIVER'S SIDE. THE TIRE PROTRUDES OUT TWO INCHES FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER AND THE CONTACT WAS INFORMED THAT THE BOLTS IN THE BACK WERE FROZEN. EVEN THOUGH THE BOLTS WERE ADJUSTABLE, THEY COULD NOT BE ADJUSTED. THE REPAIR WOULD COST OVER $1,200. THE CONTACT ALSO NOTICED THE DEFECT ON OTHER RAV4 VEHICLES. THE FAILURE MILEAGE WAS 155,915.

WE WERE IN A 1999 TOYOTA RAV4, AND HIT ANOTHER TRUCK IN THE REAR. AS A RESULT OF THE ACCIDENT THE AIR BAGS DID NOT OPERATE DEPLOY, AND THE RESTRAINT'S DID NOT WORK EITHER. RESULTING IN MY WIFE'S BROKEN LEFT ARM. *TR

Crash 2 injured

TL*- WHILE DRIVING A TOYOTA RAV 4 WITH 80000 MILES ON THE ODOMETER THE TRANSMISSION POPPED OUT OF FOURTH GEAR AND WOULD NOT ENGAGE . SHE TOOK THE VEHICLE TO THE DEALER, AND WHILE THEY WERE REPAIRING THE GEAR SHIFT, THEY ALSO DETERMINED THAT FIFTH GEAR NEEDED TO BE REPAIRED. AT 12,000 MILES THE VEHICLE EXPERIENCED THE SAME FAILURE WHILE IN 5TH GEAR. THE CONTACT DID NOT WANT THE SAME TECHNICIAN TO REPAIR THE VEHICLE BECAUSE SHE WAS CONCERNED THAT THE VEHICLE WILL NOT BE REPAIRED CORRECTLY. *AK UPDATED 03/19/07. 8JB

WITHOUT WARNING, CAR POPS INTO NEUTRAL FROM FIFTH GEAR. THIS INADVERTENT ACTION IS STARTLING, AND, IN MY OPINION, DANGEROUS. I DID NOT LOSE CONTROL OF CAR, BUT ONLY BECAUSE I WAS ALERT AT THE TIME. *NM

THE GAS TANK IN THE CONSUMER'S RAV 4 WAS INSTALLED WITH A HOLE IN IT. *TS THE CONSUMER STATED THE HOLE WAS HIDDEN BY THE CHASSIS AT THE TIME OF INSTALLATION. *JB THE HOLE CAUSED FUEL TO LEAK OUT OF THE TANK. *NM

JUST GET A NETWORK ERROR NOTICE WHEN I TRY TO GET THE TSBS FOR A 1999 TOYOTA RAV4. TRIED 2X GOT SAME ANSWER. BOB (PS WAS SUCCESSFUL WHEN I TRIED ANOTHER VEHICLE.*AK

1999 TOYOTA RAV4 CAUGHT ON FIRE UNDERNEATH THE HOOD.*MR THE FIRE OCCURRED WHILE THE CONSUMER'S SON WAS DRIVING. SMOKE BEGAN TO FILL THE CABIN AND THE DRIVER NOTICED FLAMES COMING FROM THE ENGINE. HE WAS ABLE TO PUT THE FIRE OUT WITH A TOWEL. AFTER THE FIRE THE TAILLIGHTS, DASH LIGHTS, INTERIOR LIGHTS NO LONGER WORKED. THE PASSENGERS SIDE FRONT HEADLIGHT AND WIRING WERE DESTROYED. THE CONSUMER CONTACTED THE MANUFACTURER BUT THEY REFUSED TO PROVIDE ANY ASSISTANCE BECAUSE OF THE AGE AND MILEAGE OF THE VEHICLE. *NM

Fire

COMPLAINT RECEIVED VIA E-MAIL. WHILE MY SON WAS DRIVING THE CAR CAUGHT ON FIRE UNDER THE HOOD FOR NO APPARENT REASON. I CONTACTED TOYOTA CORPORATION REGARDING THIS ISSUE, AND THEY HAD ME TAKE THE CAR TO A LOCAL DEALER. SO I TOOK IT TO MIDTOWN TOYOTA, WHERE I PURCHASED THE VEHICLE IN AUGUST OF 1999. I SPOKE WITH A JIM CHRISTENSEN ,773-622-6300 X 4911. HE IS IN THE SERVICE DEPARTMENT. AFTER A WEEK I WAS TOLD THAT BECAUSE MY CAR WAS 6 YEARS OLD AND HAD 64,000 MILES ON IT THAT IT WAS DETERMINED THAT THIS WAS NOT A MANUFACTURER'S DEFECT. BUT THEY COULD NOT EXPLAIN TO ME WHAT CAUSED THE FIRE, AND TOLD ME THAT THEY WERE NOT RESPONSIBLE FOR THE REPAIRS. THE CAR WAS PURCHASED BRAND NEW, AND DOES NOT HAVE ANY AFTER MARKET INSTALLATIONS OF ANY KIND. I HAVE PHOTOS OF THE DAMAGE THAT CAN MAILED UPON REQUEST. DAMAGE WAS CAUSED TO FRONT RIGHT SIDE, HEAD LIGHTS, WIRING BURNED AND WASHER RESERVOIR. THE BACK TAIL LIGHTS AND INTERIOR LIGHTS DON'T WORK ANY MORE. ALSO A FAN IN THE ENGINEER KEEPS RUNNING WHICH CAUSES MY BATTERY TO RUN DOWN. MY CAR WAS IN PREFECT RUNNING CONDITION UP UNTIL THIS HAPPENED. THE PERSON I SPOKE WITH @ TOYOTA REGARDING THIS INCIDENT IS TROY H. HIGA, 310-468-5638. I HAVE TRIED SEVERAL TIMES TO GO ABOUT TROY, BUT WAS TOLD THAT THERE WAS NO ONE ELSE I COULD SPEAK TO REGARDING THIS PROBLEM. I WOULD LIKE THIS INVESTIGATED. *AK

Fire

WITHOUT ANY DASH WARNING LIGHT COMING ON 1999 TOYOTA BLEW ITS ENGINE. *BF *TC

VALVE STEM SEALS NEED REPLACED $810.75 BY TOYOTA DEALER 80,000 MILES

BOTH OF THE FRONT SEAT BELT CONNECTIONS HAVE STOPPED LATCHING INTO AND LOCKING THE SEAT BELT. I HAD THE DRIVERS SIDE REPLACED ABOUT A YEAR AGO, IT WAS STILL UNDER WARRENTY. NOW THE PASSENGER SIDE IS NOT WORKING. IS THERE A PROBLEM WITH THE CONNECTIONS IF SO WHY AND WHAT IS NEEDED TO BE DONE. *AK

1999 TOYOTA RAV4 -- LOW FUEL INDICATOR LIGHT CAME ON WHEN INDICATOR NEEDLE WAS JUST BELOW 1/2 A TANK. CONSUMER HAD TOYOTA EXTRA CARE. DEALER SAID THE PROBLEM WAS A FUEL SENDER BRACKET, PART #77017-42020, AND WAS NOT COVERED UNDER THE EXTRA CARE.*AK

THE VEHICLE WAS INVOLVED IN A HEAD ON COLLISION WHILE DRIVING APPROXIMATELY 55 MPH. UPON IMPACT, THE AIR BAGS DID NOT DEPLOY. *AK *CB *JB

Crash 1 injured

I HAVE A 1999 RAV4. YESTERDAY I'M DRIVING HOME FROM WORK. I HEARD A LOUD NOISE, I THOUGHT A ROCK HIT MY CAR. I STOPPED AT THE STORE AND I GO TO GET MY KEYS OUT OF IGNITION AND THE CRUISE CONTROL SWITCH IS BROKE. THE BACK OF THE SWITCH WAS JUST HANGING. THAT WAS THE LAUD NOISE I HEARD. THE BACK POPPED OFF. CAN YOU TELL ME IF THERE IS A RECALL FOR THIS? THANK YOU

HEAD ON COLLISION -AIRBAGS FAILED TO DEPLOY-FRACTURING STERNUM,RIBS AND INJURING RIGHT SHOULDER. PRE-TENSIONER ON SEAT BELT FAILED ALSO. *NLM

Crash 1 injured

HEAD ON COLLISION -AIRBAGS FAILED TO DEPLOY-FRACTURING STERNUM,RIBS AND INJURING RIGHT SHOULDER. PRE-TENSIONER ON SEAT BELT FAILED ALSO. *NLM

Crash 1 injured

PRODUCT SAFETY DUE TO NON DEPLOYMENT OF THE AIR BAGS. DT

Crash 2 injured

WHILE TRAVELING ON HIGHWAY ANOTHER VEHICLE WAS IN FRONT OF CONSUMER'S VEHICLE. TO AVOID A COLLISON APPLIED BRAKES AND HIT VEHICLE IN FRONT. UPON IMPACT, DUAL AIRBAGS DIDN'T DEPLOY.*AK THIS VEHICLE WAS TOTALED. *JG

Crash 1 injured

DEALER PUT NEW BRAKE PADS ON TO STOP SQUEAKING, TO NO AVAIL.

AIRBAGS FAILED TO DEPLOY IN 45MPH (APPROX) HEAD-ON COLLISION. *AK

Crash 1 injured