2016 RAM 2500

14 recalls, 367 complaints - 646 TSBs

AIR BAGS:SIDE/WINDOW:CURTAIN:INFLATOR

Defect Description

Chrysler (FCA US, LLC) is recalling certain 2016-2019 Ram 3500, Ram 1500, 2016-2020 Ram 2500, and 2016 Ram 3500 Cab Chassis vehicles. The right and left side curtain air bag inflators may rupture due to a manufacturing defect.

Consequence

An inflator rupture may result in sharp metal fragments striking occupants, resulting in injury.

Remedy

Dealers will replace one or both side curtain air bags, as necessary, free of charge. Owner notification letters were mailed February 13, 2025. Owners may contact FCA customer service at 1-800-853-1403. FCA's numbers for this recall are 05C, 09C, and 10C.

6,066 vehicles affected

Manufacturer: Chrysler (FCA US, LLC)

AIR BAGS:SIDE/WINDOW:CURTAIN

Defect Description

Chrysler (FCA US, LLC) is recalling certain 2015-2020 Ram 1500 Classic, 2015-2016 Ram 3500, and Ram 2500 vehicles, and 2016 Ram 3500 Cab Chassis with a gross vehicle weight rating less than 10,000 lbs. The side air bag inflatable curtain (SABIC) inflator end cap may detach from the inflator, or the... Read more

Consequence

A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.

Remedy

Dealers will inspect and replace as necessary, the SABIC assemblies, free of charge. Interim owner notification letters were mailed on October 4, 2021. Owner notification letters were mailed on May 26, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number ... Read more

212,373 vehicles affected

Manufacturer: Chrysler (FCA US, LLC)

LATCHES/LOCKS/LINKAGES:TAILGATE:LATCH

Defect Description

Chrysler (FCA US LLC) is recalling certain 2015-2017 Ram 1500, 2500 and 3500 pickup trucks equipped with an 8 foot bed and a power locking tailgate. Chrysler is also recalling all 2013-2014 and 2018 Ram 1500, 2500 and 3500 pickup trucks built before April 1, 2018 with a 6 or 8 foot bed and a power ... Read more

Consequence

If the tailgate opens while the vehicle is being driven, cargo may fall out the vehicle and create a road hazard, increasing the risk of crash.

Remedy

Chrysler will notify owners, and dealers will repair the tailgate latch, free of charge. The recall began May 23, 2019. Chrysler is expected to notify owners of the expanded population on October 18, 2019. Owners may contact FCA US customer service at 1-800-853-1403. FCA US's number for this rec... Read more

1,103,209 vehicles affected

Manufacturer: Chrysler (FCA US LLC)

STEERING:LINKAGES:DRAG:LINK:CONNECTION

Defect Description

Chrysler (FCA US LLC) is recalling certain 2013-2018 Ram 3500 and 2014-2018 Ram 3500 Chassis Cab and Ram 2500 vehicles. The outboard steering linkage jam nut may loosen, allowing one end of the drag link to separate.

Consequence

A drag link separation can cause a loss of steering control, increasing the risk of crash.

Remedy

Chrysler will notify owners, and dealers will check the steering linkage jam nut tightness, replacing the drag link assembly or welding the nut to the adjuster sleeve, free of charge. The recall began March 22, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's numbe... Read more

795,575 vehicles affected

Manufacturer: Chrysler (FCA US LLC)

STEERING:LINKAGES

Defect Description

Streetcar ORV LLC (Streetcar) is recalling certain American Expedition Vehicles (AEV) 3" Dualsport aftermarket suspension kits, part numbers N0436000 and N0436001, sold for installation on 2013-2018 RAM 2500 and 3500HD trucks. Improper installation and machining of the original equipment steering k... Read more

Consequence

The weakened connection may result in a fractured steering drag link, causing a loss of steering and increasing the risk of a crash.

Remedy

Streetcar will notify owners and dealers will inspect and install a new steering knuckle, free of charge. The recall began December 3, 2018. Owners may contact AEV customer service at 1-248-926-0256, extension 500.

847 vehicles affected

Manufacturer: Streetcar ORV LLC

STRUCTURE:BODY:TAILGATE

Defect Description

Chrysler (FCA US LLC) is recalling certain 2015-2017 RAM 1500, 2500, and 3500 pickup trucks equipped with a power locking tailgate and either a 5 foot, 7 inch or 6 foot, 4 inch bed. The tailgate actuator limiter tab may fracture and cause the tailgate to unlatch and open while driving.

Consequence

If the tailgate latch releases and the tailgate opens while driving, cargo may fall out, creating a road hazard and increasing the risk of a crash.

Remedy

Chrysler will notify owners, and dealers will repair the vehicle, free of charge. The recall began September 17, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U74.

1,149,223 vehicles affected

Manufacturer: Chrysler (FCA US LLC)

ELECTRICAL SYSTEM:WIRING

Defect Description

Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler... Read more

Consequence

If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Remedy

Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise... Read more

4,815,661 vehicles affected

Manufacturer: Chrysler (FCA US LLC)

EQUIPMENT

Defect Description

Chrysler (FCA US LLC) is recalling various Dodge, Chrysler, and RAM vehicles equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V824-0103.pdf. These extinguishers ma... Read more

Consequence

If the fire extinguisher does not function properly, it can increase the risk of injury in the event of a fire.

Remedy

Chrysler will notify owners instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began February 14, 2018. Owners may contact Chrysler customer service at 1-800-853-1403 or Kidde customer service service toll-free at 1-855-262-3540, or online at www.kidd... Read more

61,791 vehicles affected

Manufacturer: Chrysler (FCA US LLC)

POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT

Defect Description

Chrysler (FCA US LLC) is recalling certain 2016-2017 Ram 3500 Cab Chassis with a Gross Vehicle Weight Rating (GVWR) of less than 10,000 lbs, 2011-2017 Ram 3500, 4500 and 5500 Cab Chassis vehicles, 2009-2017 Ram 1500 and 2010-2017 Ram 2500 and 3500 pickup trucks, all equipped with a column shifter. ... Read more

Consequence

Being able to shift the transmission without pushing the brake pedal and/or without a key in the ignition can increase the risk of an unintended vehicle rollaway that may result in personal injury or a crash.

Remedy

Chrysler will notify owners, and dealers will update the vehicle software, inspect the BTSI, and, as necessary, replace it, free of charge. The recall began February 26, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T79.

1,482,874 vehicles affected

Manufacturer: Chrysler (FCA US LLC)

ENGINE AND ENGINE COOLING:ENGINE:DIESEL

Defect Description

Chrysler (FCA US LLC) is recalling certain 2013-2017 RAM 2500, 3500, 3500 Cab Chassis, 4500 Cab Chassis, and 5500 Cab Chassis vehicles, equipped with Cummins 6.7L Turbo Diesel engines that have Concentric-brand water pumps without a vent hole. These water pumps may leak coolant.

Consequence

The leaking water pump can increase the risk of an engine compartment fire.

Remedy

Chrysler will notify owners, and dealers will replace the water pumps, free of charge. The recall began February 26, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T51.

443,874 vehicles affected

Manufacturer: Chrysler (FCA US LLC)

WHEELS

Defect Description

Streetcar ORV LLC, dba American Expedition Vehicles (AEV) is recalling certain 2013-2017 RAM 2500 and 3500 heavy duty trucks, modified by AEV to be equipped with cast aluminum Katla 8.5" road wheels. The outer surface of the wheel may fracture, resulting in rapid air loss.

Consequence

If the wheel fractures, a loss of vehicle control can occur, increasing the risk of a crash.

Remedy

AEV will notify owners, and dealers will replace the wheels with wheels of similar value, free of charge. The recall began on August 30, 2017. Owners may contact AEV customer service at 1-248-926-0256 extension 500.

1,765 vehicles affected

Manufacturer: Streetcar ORV LLC

AIR BAGS

Defect Description

Chrysler (FCA US LLC) is recalling certain model year 2013-2016 Ram 1500, Ram 2500, and 2014-2016 Ram 3500 vehicles. Certain driving conditions, such as driving off-road or debris striking the vehicle may cause the roll rate sensor to trigger a fault within the Occupant Restraint Controller (ORC). ... Read more

Consequence

If the rollover side curtain air bags and seat belt pretensioners are disabled, there is an increased risk of injury to the vehicle occupants in the event of a crash that necessitates activation of these safety systems.

Remedy

Chrysler will notify owners, and dealers will update the ORC software, free of charge. The recall began June 26, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T25.

1,021,279 vehicles affected

Manufacturer: Chrysler (FCA US LLC)

EQUIPMENT

Defect Description

Chrysler (FCA US LLC) is recalling aftermarket Mopar Canvas Seat Covers for certain 2012-2016 RAM 1500, 2500, and 3500 trucks. These Mopar canvas seat covers were sold through Chrysler dealerships beginning October 15, 2015. The seat covers can impede the deployment of the seat thorax airbags.

Consequence

If the seat cover impedes the air bag deployment, the seat thorax air bags may not provide adequate protection in the event of a crash, increasing the risk of a injury.

Remedy

Chrysler will notify owners to remove the front seat covers and return them for a full refund. The recall began on July 1, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S30.

345 vehicles affected

Manufacturer: Chrysler (FCA US LLC)

ENGINE AND ENGINE COOLING:ENGINE

Defect Description

Chrysler (FCA US LLC) is recalling certain model year 2016 Ram 2500, 3500, 3500 Cab Chassis and 4500/5500 Cab Chassis trucks manufactured July 31, 2015, to August 13, 2015 and equipped with a 6.7L Cummins Diesel engine. In the affected vehicles, the Engine Control Module (ECM) may short circuit, ca... Read more

Consequence

An engine that stalls without warning increases the risk of a crash.

Remedy

Chrysler will notify owners, and dealers will replace the ECM, free of charge. The recall began on December 21, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R52.

41 vehicles affected

Manufacturer: Chrysler (FCA US LLC)

Complaint Statistics

367 total complaints 24 crashes 5 fires 25 injuries 2 deaths

Top Reported Components

Component	Complaints
POWER TRAIN	59
ENGINE	53
ELECTRICAL SYSTEM	42
STEERING	39
UNKNOWN OR OTHER	34
SERVICE BRAKES	23
FUEL/PROPULSION SYSTEM	19
VEHICLE SPEED CONTROL	14
SUSPENSION	13
STRUCTURE:BODY	12

Incident date: Jun 18, 2025

It was necessary to stop at the end of an on-ramp to an expressway. As I proceeded to enter the expressway, my 2017 Ford Edge started vibrating and as I accelerated to go onto the expressway, the car stalled. I was able to restart the car and it vibrated and stalled again as I accelerated to pull ov... Read more

Incident date: Jun 11, 2024

turbo component defective fixed at my own cost last 2 yrs 9 m. afraid of fuel starvation

Incident date: Jun 11, 2024

turbo component defective fixed at my own cost last 2 yrs 9 m. afraid of fuel starvation

Incident date: Feb 5, 2026

The contact owns a 2015 Mercedes-Benz C300. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the vehicle. The vehicle was driven to the shoulder of the road. The contact inspected the exterior of the vehicle and became aware that the moon roof pa... Read more

Incident date: Feb 5, 2026

The head unit quit working around 98k. The head unit is the radio, and screen which includes the back up camera. From what we have been told and find online, this is a known problem with them and affects other models as well. For the most part the head unit doesn't work but once in a while, once a m... Read more

Incident date: Feb 17, 2026

While driving on the highway during a rainstorm, the high voltage fuse on my car's Internal Charge Control Unit blew and the ICCU itself failed. This rendered the vehicle inoperable as soon as I managed to get it to the shoulder. It took two weeks to repair, and I had to argue with Hyundai's corpora... Read more

Incident date: Feb 9, 2026

Acura EV app does not sync. Not only for those who purchased the car used, but those who updated the app.

Incident date: Feb 9, 2026

I was driving on the highway at about 65-70 MPH and the sunroof spontaneously shattered. It sounded like an explosion. No object hit the car. We were in Nevada and the outside temp was in the mid 60s. The inside air conditioning was set at 69. We pulled over to inspect and take a picture. I have rea... Read more

Incident date: Feb 9, 2026

The contact owns a 2018 Dodge Charger. The contact stated that while driving at slow speeds, there was an abnormal, repetitive thud sound coming from the vehicle. There was no warning light illuminated. The vehicle was taken to an independent mechanic, where the wheel bearings were replaced; however... Read more

Incident date: Jul 12, 2025

The vehicle experienced a sudden loss of motive power and became inoperable due to failure of the high-pressure fuel system. This VIN is subject to an active safety recall (NHTSA 24V957 / Ford 24S78) addressing high-pressure fuel pump failure that can result in loss of motive power while driving. P... Read more

Incident date: Oct 5, 2025

While driving cross country, my dash warning light came on and said " In 50 miles your vehicle will lose power and you won't be able to drive more than 5 mph. DEF problem". I spent $70,000 on this vehicle used with 50K miles on it. Recall from 2024, this is unacceptable. Now another recall for steer... Read more

Incident date: Dec 23, 2025

On 14th, 2026, while traveling at approximately 60 mph on the northbound 55 Freeway near the Katella exit, my vehicle suddenly began to shake violently without any prior warning. In response, I attempted to slow down by applying the brakes; however, the speedometer rapidly increased even as I mainta... Read more

Crash 1 injured

Incident date: Jul 1, 2025

In August 2025 my 2022 Kia Sorento S began having the Electronic Power Steering (EPS) Malfunction Indicator light flashing. It comes on, flashes for a while, then goes off again. Shortly after the first time this happened (a week or so), my steering began losing all power steering intermittently at ... Read more

Incident date: Nov 1, 2025

The infotainment system suffers from ghost touching. It has gotten out of control even after a “recall” fix at the dealership. Without being touched the volume changes, the stations change, the presets change, the car makes calls to my contacts. I am often unable to control the screen as it tur... Read more

Incident date: Nov 1, 2025

Upper grill trim panel broke off while on highway and went flying over the truck while at highway speeds. Same issue as existing recall for the 2022 model.

Incident date: Nov 10, 2025

The contact owns a 2018 Toyota Rav4. The contact received notice of NHTSA Campaign Number: 23V734000 (Electrical System). The contact stated that while changing the oil, he became aware that the battery was covered in corrosion and there was acid leaking from the battery tray. The vehicle was not di... Read more

Incident date: Oct 13, 2025

The forward crash detection detects objects on the side of the road that do not present a hazard. The vehicle then automatically, abruptly brakes causing temporary loss of control in the vehicle. In one instance the system detected the barriers in a construction zone causing me to almost lose contro... Read more

Incident date: Jul 30, 2025

I have major peeling paint issues on my 2019 Honda HR-V with white paint. The top of the car ( roof) and in the hatch area.

Incident date: Apr 24, 2025

Was driving in normal weather conditions, no rain, no hail, no snow, no inclement weather whatsoever. During daylight hours, plenty of visibility. Was driving with no other vehicles around and my windshield cracked. Nothing hit it, no spider webbing, no point of impact. It made a loud cracking sound... Read more

Incident date: Jun 18, 2025

The passenger side daytime running light vertical led strip in the passenger side headlight assembly has quit working as of 7/11/2025. I noticed that there seemed to be a reduction in the lighting on the passenger side of my vehicle that night. When I checked my vehicle lighting, I noticed that the ... Read more

Incident date: Mar 25, 2025

I am filing a complaint regarding ongoing and worsening issues with my Chevrolet vehicle, which appear to point to broader defects involving the engine and electrical systems. Months ago, while driving, the car suddenly lost power and displayed "Engine Power Reduced." I had to keep using it due to ... Read more

Incident date: May 23, 2025

Front drivers seat no longer capable of moving backwards and forwards. One of the rails will not move, causing the seat to rotate left and right and will not move back and forward. This is a hazard as it now no longer is safe for my Wife or I to drive. It is too far back for my wife and too far forw... Read more

Incident date: May 23, 2025

A large fuel leak occurred. The amount of diesel coming out of the top of the fuel filter area was so substantial that I could not drive the vehicle.

Incident date: Apr 10, 2023

I had catastrophic engine failure driving down the road to work. Check engine light started flashing the the oil light. The car then shut off. Got it towed and they found two pieces of the engine block in the cradle cover.

Incident date: Apr 10, 2023

Steering sticks and releases under pressure at 60/65+ mph on interstate. Very difficult to keep vehicle in lane consistently. Constantly correcting both right & left to maintain straight line is extremely fatiguing especially on long trips. Safe driving at highway speeds is compromised and present... Read more

Incident date: Apr 4, 2025

[XXX] Invoice [XXX] vehicle was taken to HOY FAMILY AUTO DEALER in El Paso, Texas (1.)to inspect brakes noise and parking brake not engaging at all times, there has been times when the parking brake does not engage, and humming noise while braking and exiting freeway. Service personnel did not dismo... Read more

Incident date: Apr 4, 2025

Today, as my wife was driving home, she heard a "crunch" noise while making a turn. Afterwards, the Airbag light came on, and her steering wheel botton functions are not working, including her car horn. This all relates to the clockspring. This will be the third time we have had the clockspring repl... Read more

Incident date: Apr 2, 2025

Driving on interstate at 70mph. Multiple, five or six, warnings pop up in rapid succession mostly dealing with the safety features such as distance to car in front, adaptive speed control, lane keeping. The last one was hybrid system - safely stop. The car then immediately lost all acceleration pow... Read more

Incident date: Apr 2, 2025

Incident date: Oct 16, 2019

My 2013 Honda Accord touring with 110,000 miles all of a sudden all the lights on the dash came on. I took it to the dealer. The dealer told me that the electronic control module or the vehicle stability control module was bad. At that time, the dealer could not get the part and at that time, the pa... Read more

Incident date: Oct 8, 2024

The car has now on three separate occasions lost power while driving. As I slow down coming to stop or reducing speed car will completely lose power and then struggle to restart. Both occasions were on busy roads. Additionally, when you put fuel in the car it does not turn on right away it smells li... Read more

Incident date: Oct 8, 2024

Dear NHTSA Recall Division, I am writing to bring to your attention a safety and performance issue related to a potential defect in the EVAP canister purge valve of my 2017 ford focus, which may be linked to the previously issued recall for this component. The EVAP canister purge valve in my vehic... Read more

Incident date: Oct 8, 2024

Incident date: Jun 18, 2024

While driving my car made a loud beep sound and Faulty Brake Booster appeared on the dash and the BRAKE light came on and the brakes would not work properly. I was almost rear ended because of this.

Incident date: Aug 30, 2024

Was driving to store got to store came out vehicle won't start just keeps turning over. From others that have the same vehicle ecodiesel I'm told it's the tone wheel/crankshaft position. And that the cheap plastic housing chips which causes the no start. Also recall for high pressure fuel pump. An... Read more

Incident date: May 2, 2024

The contact owns a 2018 Honda GL1800 Motorcycle. The contact received notification of NHTSA Campaign Number: 24V113000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the r... Read more

Incident date: May 2, 2024

While driving, as I turn the steering wheel to the left there is an additional sudden pull in the same direction.

Incident date: Jul 11, 2024

The contact owns a 2014 Hyundai Accent. The contact received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonabl... Read more

Incident date: Jun 11, 2024

I had the control arms replaced and now the steering assist/ steering gear assembly has stopped working. The vehicle is undrivable and it only has 29K miles. This happened while driving and I had to go straight through an intersection as I could not steer the car.

Incident date: Jun 11, 2024

The contact owns a 2017 Ford Edge. The contact stated while driving at an undisclosed speed, the vehicle began to drive in idle mode with the check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed as coolant leaking into the cylinders. The contact was info... Read more

Incident date: Feb 9, 2024

The rear axle broke for the second time on a Ford Windstar, after already breaking prior to a recall in 2010. It appears to have broken where a clamp was attached. This caused the rear wheels to fall into, and grind against the wheel well. This happened on a side street near my house. Had it happen... Read more

Incident date: Feb 9, 2024

The contact owns a 2023 Honda HR-V. The contact stated while driving 65 MPH with the rear windshield defroster engaged, the rear windshield exploded. The contact did not sustain any injuries and was able to continue driving. The vehicle was taken to the dealer to be diagnosed. The vehicle was not di... Read more

Incident date: May 1, 2024

The transmission down shifts by itself while driving down the road . You have to stop an change the gears to park then start again.I has happened 3 or 4 times .most of the time when you stop at a light or stop sign and take off when it drops to a lower gear it makes a sudden jerk. Some times tyhe tr... Read more

Incident date: May 21, 2024

Power steering failure. Everything was working properly when parked. When started the next day, a steering wheel warning light flashed repeatedly and there is no power steering. Vehicle can be steered manually but is incredibly difficult. The vehicle has not been to a shop or the dealer yet.

Incident date: Jul 28, 2023

While driving, the front collision warning activated, immediately followed by the automatic emergency brake system activating. This made my car break suddenly, attempting to stop in the middle of traffic without warning. There was nothing in front of me that could have activated the systems. This oc... Read more

Incident date: Jan 7, 2024

Rear window leaks

Incident date: Oct 4, 2023

I was hit by a large truck on the driver side as I was in the right lane catching up to a safe speed. The hit spun the car around at least 180 degrees. Due to the massive pain I couldn’t move. The car just shut off completely to include all functions. There were no prompts from the car’s emergen... Read more

Crash 2 injured

Incident date: Oct 4, 2023

Crash 2 injured

Incident date: Sep 1, 2023

The contact owns a 2017 Ford Focus. The contact stated that on several occasions while driving at various speeds the vehicle stalled. The vehicle was restarted on several occasions however, on other occasions the vehicle would not restart. Additionally, the contact stated that the coolant reservoir ... Read more

Showing 50 of 367 complaints.

NHTSA Safety Ratings, 2016 RAM 2500

2016 Ram 2500 Mega PU/EC 2WD

Category	Rating
Rollover	4 / 5 ★★★★☆
Rollover Risk	15.5%

Safety Technology

Feature	Status
Electronic Stability Control	Standard
Forward Collision Warning	No
Lane Departure Warning	No

Source: NHTSA 5-Star Safety Ratings Program. Ratings are based on crash tests conducted by the National Highway Traffic Safety Administration.

Technical Service Bulletins, 2016 RAM 2500

646 manufacturer communications from 346 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
350000 EQUIPMENT	104
110000 ELECTRICAL SYSTEM	62
100000 POWER TRAIN	50
060000 ENGINE AND ENGINE COOLING	37
130000 VISIBILITY	25
060000 ENGINE (PWS)	22
070000 FUEL SYSTEM, GASOLINE	19
353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.	17

063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

Emission Recall 67A D Truck Engine Calibration

111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On

063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

Emission Recall 67A - D Truck Engine Calibration

060000 ENGINE AND ENGINE COOLING

Emission Recall 67A - D Truck Engine Calibration

020000 SUSPENSION

Steering Drag Link If drag link had been welded due to V06 recall repair and there is an alignment concern, prior to drag link replacement ensure that the welded draglink toe setting procedure has been followed first. ~ ~ Service Library

010000 STEERING

020000 SUSPENSION

LIFTER, Hydraulic Roller Deactivating Please do not replace MDS lifters because the disconnecting pin is not lined up, this is normal and not a defect.

110000 ELECTRICAL SYSTEM

Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. There is an error with the wiring diagrams in Service Library that is causing

114000 ELECTRICAL SYSTEM:WIRING

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

FCA Caribbean Warranty Bulletin ID-23-20 "Can / Am" Warranty Coverage - 594 / 595 / 596 WCC

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Warranty Bulletin D-16-03 - "Can / Am" Warranty Coverage - 594 / 595 / 596 WCC (Rev. B)

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Lubrication and Maintenance Fluids If MOPAR fluids and chemicals are not readily available, please review Service Library for specifications so a suitable alternative can be used

060000 ENGINE AND ENGINE COOLING

6.7L New Oil Usage Information Incorrect oil used. This bulletin provides information regarding the correct oil grade to use on the 6.7L Cummins used in the 2023 to 2013 HD Trucks. The following information is intended to eliminate confusi

060000 ENGINE AND ENGINE COOLING

Water Quality When Mixed With Engine Coolant

110000 ELECTRICAL SYSTEM

Ambient Air Temperature Missing, Malfunction Indicator Lamp (MIL) Lamp On, Diagnostic Trouble Code (DTC) P0070-15 Ambient Air Temperature Sensor Circuit-Circuit Short to Battery or Open, P0073 Ambient Air Temperature Sensor Circuit High

110000 ELECTRICAL SYSTEM

Ambient Temperature Sensor Servicing.

350000 EQUIPMENT

wiTECH Small Leak Verification Test (SLVT) - P0456-EVAP SYSTEM SMALL LEAK

060000 ENGINE AND ENGINE COOLING

wiTECH Small Leak Verification Test (SLVT) - P0456-EVAP SYSTEM SMALL LEAK

110000 ELECTRICAL SYSTEM

280000 BACK OVER PREVENTION

Outside Power Fold Rearview Mirror Noise Or Loose At Pivot. Mirror Contacts Door Window Glass In The Folded Position.

180000 VEHICLE SPEED CONTROL

Outside Power Fold Rearview Mirror Noise Or Loose At Pivot. Mirror Contacts Door Window Glass In The Folded Position.

130000 VISIBILITY

Outside Power Fold Rearview Mirror Noise Or Loose At Pivot. Mirror Contacts Door Window Glass In The Folded Position.

100000 POWER TRAIN

Outside Power Fold Rearview Mirror Noise Or Loose At Pivot. Mirror Contacts Door Window Glass In The Folded Position.

050000 PARKING BRAKE

Outside Power Fold Rearview Mirror Noise Or Loose At Pivot. Mirror Contacts Door Window Glass In The Folded Position.

280000 BACK OVER PREVENTION

Malfunction Indicator Lamp (MIL) Illumination. NOx Sensor Diagnostic Trouble Codes (DTCs) Diagnosis Information.

120000 EXTERIOR LIGHTING

Malfunction Indicator Lamp (MIL) Illumination. NOx Sensor Diagnostic Trouble Codes (DTCs) Diagnosis Information.

080000 FUEL SYSTEM, DIESEL

Guidelines For The Use Of Alternative Diesel Fuels.

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

Ambient Temperature Sensor Servicing.

115000 ELECTRICAL SYSTEM:BODY CONTROL MODULE/BCM

Ambient Temperature Sensor Servicing.

114700 ELECTRICAL SYSTEM:WIRING:CONNECTORS/PLUGS/RECEPTACLES

CONNECTOR Trailer Tow,WIRING Trailer Tow,CONNECTOR 7 Way,WIRING Rear Bumper If the connector or wiring is physically damaged, burned, melted or corroded, prior to replacing the part, please contact FCA Redacted Content If no response in 1

210000 TRAILER HITCHES

162200 STRUCTURE:BODY:BUMPERS

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

Ambient Temperature Sensor Servicing.

353000 EQUIPMENT:ELECTRICAL

Ambient Temperature Sensor Servicing.

353000 EQUIPMENT:ELECTRICAL

Ambient Temperature Sensor Servicing.

160000 STRUCTURE

Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when welding

160000 STRUCTURE

980000 UNKNOWN OR OTHER

163200 STRUCTURE:INTERIOR PANELS:DOOR

061530 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:SEALS/GASKETS

COOLER - EGR

980000 UNKNOWN OR OTHER

COOLER - EGR

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module/Powertrain Control Module (ECM/PCM) with the latest available software. The customers may experience a Malfunction Indicator Lam

100000 POWER TRAIN

080000 FUEL SYSTEM, DIESEL

030000 SERVICE BRAKES, HYDRAULIC

070000 FUEL SYSTEM, GASOLINE

080000 FUEL SYSTEM, DIESEL

100000 POWER TRAIN

110000 ELECTRICAL SYSTEM

120000 EXTERIOR LIGHTING

280000 BACK OVER PREVENTION

110000 ELECTRICAL SYSTEM

100000 POWER TRAIN

110000 ELECTRICAL SYSTEM

210000 TRAILER HITCHES

CONNECTOR/WIRING, Trailer Tow If the connector or wiring is physically damaged, burned, melted or corroded, prior to replacing the part, please contact FCA Redacted Content If no response in 15 minutes, proceed with repair. Please send pic

114000 ELECTRICAL SYSTEM:WIRING

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Powertrain Control Module (PCM) with updatedsoftware. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investiga

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Powertrain Control Module (PCM) with updatedsoftware. The customer may describe extended cranking or starting times when the Compressed Natural Gas (C

114000 ELECTRICAL SYSTEM:WIRING

210000 TRAILER HITCHES

350000 EQUIPMENT

If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils.

060000 ENGINE AND ENGINE COOLING

If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils.

060000 ENGINE AND ENGINE COOLING

Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire. Upon investigation, it may be found that there is excessive camshaft lobe wear/lifter wear (roller failure) on one or more cam lobes and that camshaf

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

060000 ENGINE (PWS)

980000 UNKNOWN OR OTHER

061700 ENGINE AND ENGINE COOLING:ENGINE:CRANK/CAMSHAFT POSITION SENSOR

210000 TRAILER HITCHES

100000 POWER TRAIN

Transfer Case Shift Lever Design Change

130000 VISIBILITY

Left Hand Drivers Side Mirror Takes Longer to Defrost Or Clear Than Right Side Passenger

130000 VISIBILITY

Outside Power Fold Rearview Mirror Noise Or Loose At Pivot

120000 EXTERIOR LIGHTING

Diesel Injector Freezing This bulletin involves installing a insulator over the Diesel Exhaust Fluid (DEF) injector. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may f

130000 VISIBILITY

Outside Power Fold Rearview Mirror Noise Or Loose At Pivot

135200 VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR

Outside Power Fold Rearview Mirror Noise Or Loose At Pivot

070000 FUEL SYSTEM, GASOLINE

080000 FUEL SYSTEM, DIESEL

130000 VISIBILITY

Left Hand Drivers Side Mirror Takes Longer to Defrost Or Clear Than Right Side Passenger

130000 VISIBILITY

Left Hand Drivers Side Mirror Takes Longer to Defrost Or Clear Than Right Side Passenger

110000 ELECTRICAL SYSTEM

No Start, Cannot Complete Module Replace, Proxi Or Module Proxi Configuration

110000 ELECTRICAL SYSTEM

No Start, Cannot Complete Module Replace, Proxi Or Module Proxi Configuration

060000 ENGINE AND ENGINE COOLING

Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement engine has been installed in the vehicle.

060000 ENGINE AND ENGINE COOLING

Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement engine has been installed in the vehicle.

130000 VISIBILITY

Left Hand Drivers Side Mirror Takes Longer to Defrost Or Clear Than Right Side Passenger

130000 VISIBILITY

Left Hand Drivers Side Mirror Takes Longer to Defrost Or Clear Than Right Side Passenger

061500 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION

Customer Complaint May Include Engine Oil Leak Or Consumption

113000 ELECTRICAL SYSTEM:STARTER ASSEMBLY

No Start, No Crank

114000 ELECTRICAL SYSTEM:WIRING

WIRING, Body Before replacing this harness, please contact FCA Redacted Content to see if a repair kit is available for your application. If no response in 15 minutes, proceed with repair. Please email pictures of harness defects to FCA Re

110000 ELECTRICAL SYSTEM

Battery Tester Warranty Code Procedures, Midtronics Charger Update Process

350000 EQUIPMENT

Battery Tester Warranty Code Procedures, Midtronics Charger Update Process

110000 ELECTRICAL SYSTEM

No Start Intermittently, Vehicle Requires Multiple Keyless Push To Start Attempts To Start Vehicle, Intermittent Key Not Detected Message

100000 POWER TRAIN

No Start Intermittently, Vehicle Requires Multiple Keyless Push To Start Attempts To Start Vehicle, Intermittent Key Not Detected Message

100000 POWER TRAIN

Gear Ratio DTC?s, Transmission Shift Concerns, Does Not Shift At Times, Shudders

110000 ELECTRICAL SYSTEM

Battery Tester Warranty Code Procedures, Medtronic Update Process

350000 EQUIPMENT

Battery Tester Warranty Code Procedures, Medtronic Update Process

100000 POWER TRAIN

Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles. If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) are one-time usag

130000 VISIBILITY

Left Hand Drivers Side Mirror Takes Longer to Defrost Or Clear Than Right Side Passenger

130000 VISIBILITY

Left Hand Drivers Side Mirror Takes Longer to Defrost Or Clear Than Right Side Passenger

060000 ENGINE AND ENGINE COOLING

Customer complaint may include engine oil leak/consumption.

Showing 100 of 646 bulletins.

NHTSA Safety Investigations, RAM 2500

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 2017

Loss of Brake Performance

The Office of Defects Investigation (ODI) opened this investigation on November 28, 2022, after receiving 134 reports from consumers alleging an intermittent or permanent loss of braking performance in certain 2017-2018 Ram 2500-3500 pickup trucks manufactured by Fiat Chrysler Automobiles (FCA). The... alleged failures continued to occur at a steady rate across both models, at all speeds, with limited detectability. Consumers complained that the Anti-lock Braking System (ABS) warning light illuminated on their vehicles. The ABS module works in conjunction with the Hydraulic Control Unit (HCU), an electromechanical device that controls hydraulic pressure to the individual wheel brake assemblies, to manage braking forces during emergency stops. During this investigation, ODI received over 2,500 consumer complaints concerning ABS or HCU warning lights that illuminated on the dashboards of their vehicles. Many consumers described also having trouble with cruise control, traction control, or electronic stability control. Of the complaints received, over 50% mentioned that the ABS or HCU warning light was intermittent in nature. ODI learned that in January 2021, FCA was aware of a problem with the ABS pump motors on the subject vehicles. FCA had been working with the supplier, ZF, on an issue concerning swelling of the brushes inside the motor. According to a briefing given by ZF to FCA on January 15, 2021, the ABS, electronic stability control (ESC), traction control system (TSC) and other functions utilizing the motor would be disabled in the event of a problem with an ABS pump motor. ZF also informed FCA that Slip Control would be inhibited with the driver warning lamp illuminated, base braking would not be affected, and FMVSS stopping distance requirements would still be met. In order to better understand the potential consequences of the brushes swelling and the disablement of the ABS, ESC, TSC and other functions, ODI requested that NHTSA's Vehicle Research and Test Center (VRTC) conduct testing on a subject vehicle with a faulty pump motor installed. During the testing, VRTC found that as the brushes started to swell in the motor, the warning lamp could illuminate intermittently, causing confusion to drivers. Although the warning light illuminated intermittently, VRTC discovered that the pump was not working properly regardless of the warning light status. In this condition drivers might think that their vehicle is operating normally when the warning light is off, but instead, the ABS, ESC, TSC and other functions supported by the pump will not work. Following a series of meetings with FCA to demonstrate the findings ofVRTC's testing, FCA conducted an internal review and on November 27, 2024, FCA submitted safety recalls 24V-896 and 24E-100. In view of the recalls being conducted by FCA, ODI has closed this Preliminary Evaluation. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.Read more

PE, Closed , Model Year: 2019

High pressure fuel pump failure

The Office of Defects Investigation (ODI) opened PE21-021 on October 14, 2021 to investigate allegations of stall/loss of motive power as a result of high pressure fuel pump failures in certain model year (MY) 2019-2020 RAM 2500, 3500, 4500, and 5500 heavy duty trucks equipped with 6.7L Cummins turb... odiesel engines.On November 12, 2021, FCA filed vehicle recall 21V-880 and equipment recall 21E-094 on the subject population, identifying an `internally failed component? of the high pressure fuel pump equipped on the 6.7L Cummins Turbodiesel engine that introduced debris into the fuel system potentially causing fuel starvation and consequently an unexpected loss of motive power. Discussions with FCA identified the high pressure fuel pump equipped on these vehicles as the Bosch-supplied CP4. On December 16, 2021, Bosch filed recall 21E-101, stating the pump failure was a consequence of a manufacturer application-specific fuel system design.NHTSA subsequently identified recall 21V-586 involving loss of motive power due to failed CP4 fuel pumps on certain BMW vehicles.As a result of having received multiple recalls related to a common component, from two separate vehicle manufacturers, NHTSA?s focus shifted to determine if the related defect allegation was limited in scope to the recalled population. In early 2022, information request letters were sent to FCA and BMW to determine the root cause and consequentially identify the proper scope of potentially defective vehicles. After ODI received their information request response, FCA filed recalls 22V-406, 22E-048, 22V-767, and 22E-087. During review of information request response materials, NHTSA determined that sufficient information to identify a comprehensive recall population could not be produced by FCA or BMW. On March 17, 2023, this Preliminary Evaluation was upgraded to an Engineering Analysis (EA23-001), expanding the scope to include the Tier-one supplier and any manufacturer who equipped or installed similar high pressure fuel pumps subject to the failures observed in the recall population.The ODI reports cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID using the following complaint identification numbers: 11351441, 11361603, 11361616, 11365300, 11365426, 11365858, 11366401, 11372337, 11373793, 11374797, 11376793, 11378173, 11384377, 11386063, 11387018, 11399710, 11402550, 11415339, 11418868, 11418870, 11427075, 11434276, 11436807, 11437226, 11437249, 11437273, 11437292, 11437294, 11437394, 11437399, 11437403, 11437405, 11437423, 11437528, 11437565, 11437579, 11437580, 11437590, 11437679, 11437744, 11437781, 11437842, 11437993, 11438006, 11438008, 11438121, 11438138, 11438155, 11438392, 11438629, 11439359, 11439879, 11440397, 11443030, 11448163, 11458918, 11460558Read more

EA, Closed , Model Year: 2014

Steering loss due to linkage separation

On December 17, 2018, NHTSA's Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18016 to investigate alleged drag link failures in the steering system on model year (MY) 2015 and 2016 Ram 2500 trucks manufactured by FCA US, LLC (FCA). The drag link failures were found to be due... to a safety defect with the steering linkage where the drag link adjustable connector (used to adjust the steering system), held in position by two opposing jam nuts, can loosen. The loosening of this part can lead to wear and deterioration of the threads and eventual separation of the drag link, causing loss of steering. During the course of PE18016, it was found that two styles of drag link were used by FCA on the subject vehicles. The subject vehicles consist of two drivetrain types including four-wheel drive (4WD) and two-wheel drive (2WD). The 4WD and 2WD trucks used drag links of differing design but both incorporated the same threaded connector. In January 2019 FCA issued recall 19V-021 to address a potential loss of steering control in certain Model Year (MY) 2013-2018 4WD RAM 2500 and 3500 trucks. The trucks using the 2WD style drag link were not included in the scope of recall 19V-021. ODI upgraded PE18016 to an Engineering Analysis EA19004 on December 12, 2019. The purpose of EA19004 was to investigate if the root cause of the safety defect addressed by recall 19V-201 also affected the 2WD trucks and evaluate FCA’s rationale for not including them. ODI also monitored incoming consumer complaints regarding the remedy associated with 19V-021 and evaluated the suitability and long-term effectiveness of the prescribed repair. In the Defect Information Report submitted for recall 19V-021, FCA stated that the outboard jam nut could loosen and result in damage to the threading of the steering drag link connector. This could cause a separation in the drag link resulting in a loss of steering control. FCA determined that only the 4WD style drag link was affected and did not recall trucks with the 2WD style drag link due to design differences that made it unsusceptible to this failure mode. The repair remedy called for the steering coupler to be tightened to the proper torque prior to the jam nut being spot welded to the coupler body. If the coupler has already become detached or correct torque cannot be obtained, the drag link is to be replaced with an updated unit that went into production on the MY2019 RAM trucks.This updated unit uses a clamp to secure the coupler in place of the jam nuts used on original style components. In order to determine if the 2WD drag link was susceptible to the same defect found on the 4WD vehicles, ODI requested that our Vehicle Research and Test Center (VRTC) conduct testing on both RAM 2500 4WD and 2WD trucks. This testing was to determine operating conditions that might lead to loosened jam nuts of the recalled 4WD design and recreate these conditions on the 2WD vehicles to discover whether the 2WD design would also experience the loosening defect. Results from VRTC’s dynamic testing indicated that when the jam nuts are significantly under-torqued, they may loosen further from regular vehicle operation on the 4WD vehicles. Further, VRTC testing does not refute FCA’s assertion that the failure mechanism does not exist in the 2WD steering system. At the time of this closing resume, ODI has only received two allegations of drag link separation on 2WDvehicles.Neither could be validated as resulting from loose jam nuts. Since the release of recall 19V-021 ODI has received consumer complaints regarding the appearance of the spot weld applied to the defective drag link and the inability to have the steering properly aligned after welding of the jam nut. In September 2023, FCA provided owners with a supplemental Vehicle Alignment Clarification notification that provided information on an updated alignment procedure. Regarding the spot weld remedy used on the 4WD vehicles, ODI is concerned about the remedy in that during an alignment by a non-dealer repair facility, the spot weld might not be replaced after the alignment. To date there is no complaint trend of post alignment drag link separations, weld failures or other safety related incidents on remedied vehicles. This investigation is being closed with no further action. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances.Read more

PE, Closed , Model Year: 2013

Steering loss due to linkage separation

On December 17, 2018, NHTSA's Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE) 18-016 to investigate the steering system on model year (MY) 2015 and 2016 Ram 2500 manufactured by FCA US, LLC (FCA). Four complaints were received alleging separation of the drag link, a steering... linkage that connects between the right front steering knuckle and the pitman arm on the steering box output shaft. The failures were found to be at a threaded coupler within the drag link used for adjusting the length of the linkage during routine maintenance (alignment) of the steering system.Once separation occurs, turning the steering wheel has no effect, and there is no way for the driver to control or maintain the direction of the vehicle. During the investigation, it was determined that the same threaded coupler was used on two different drag link designs FCA manufactured on MY 2013-2018 Ram 2500 and 3500 pickups. FCA refers to the designs as either 4x2 or 4x4 style. In both designs, the coupler is prevented from turning on the drag link via two jam nuts that are tightened against the coupler. In its response to NHTSA's March 15, 2019, Information Request (IR) letter, FCA identified 48 incidents alleging separation of the steering linkage at the coupler resulting in a loss of steering control. Of those, 13 involved a crash, one of which resulted in an injury. All of the separations involved the 4x4 style drag link. Additionally, FCA's IR response refers to over 300 4x4 style equipped vehicles that experienced, or may have experienced loosening of one or more coupler jam nuts. On January 25, 2019, FCA submitted a Defect Information Report (DIR) initiating NHTSA Recall No. 19V-021. In its DIR, FCA stated that the outboard jam nut in certain MY 2013-2018 Ram 2500 and 3500 could loosen potentially resulting in damage to the coupler and/or drag link threading allowing one end of the drag link to separate. The DIR notes that drag link separation results in loss of steering control, which in turn can cause a crash without warning. FCA's DIR did not identify a root cause for the defect, however it posits that an improperly torqued outboard jam nut could loosen, and with long-term vehicle use, cause damage to the outer link bar and/or coupler threads due to relative motion between the two components. The scope of Recall 19V-021 included vehicles with the 4x4 style drag link only. Also discussed in its IR response, FCA noted that the 4x2 style drag link contains a design difference (the outboard portion of the drag link is straight while the 4x4 style contains a bend) which it suggests may result in differences in the mechanical (bending) loads presented at the coupler and jam nut interface. Moreover, the DIR states that While root cause of the 4x4 style defect has not been established, FCA US believes that bending loads on the drag link is, at least, a causal contributing factor. FCA notes it did not identify any reports alleging 4x2 style separation as well as only three reports of loosening of jam nuts, two of which resulted in loosening that provided obvious warning to the vehicle operator, indicating a different failure mode.NHTSA is upgrading this investigation to Engineering Analysis (EA) 19-004 in order to continue to monitor the subject 4x2 style vehicles for evidence of field failures. Additionally, in conjunction with NHTSA's Vehicle Research and Test Center, ODI intends to more thoroughly study potential root cause(s) of the 4x4 style defect mechanism, and if identified, will seek to determine if the 4x2 drag link is susceptible to the same mechanism(s). NHTSA will also evaluate the long-term suitability of the recallRead more

RAM 2500 - All Years Overview

Complete safety history for the RAM 2500 across all model years (2009, 2026).

155 Total Recalls

7,607 Total Complaints

4 Investigations

342 Reported Crashes

137 Reported Fires

5 Reported Deaths

RAM 2500 - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2026	6	31	View
2025	6	96	View
2024	5	76	View
2023	8	63	View
2022	12	264	View
2021	8	154	View
2020	10	229	View
2019	12	264	View
2018	10	3,699	View
2017	12	1,001	View
2016 (current)	14	367
2015	15	286	View
2014	16	483	View
2013	16	273	View
2010	4	309	View
2009	1	12	View

Other RAM Models

Model	Recalls	Complaints
3500	357	3,389	View
1500	324	16,135	View
PROMASTER	176	777	View
5500	163	198	View
4500	162	64	View
PROMASTER CITY	46	139	View
C/V TRADESMAN	5	14	View
3500 CAB CHASSIS	2	4	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2016 RAM 2500

Complaint Statistics

Top Reported Components

NHTSA Safety Ratings, 2016 RAM 2500

Safety Technology

Technical Service Bulletins, 2016 RAM 2500

Most Affected Components

NHTSA Safety Investigations, RAM 2500

RAM 2500 - All Years Overview

RAM 2500 - Year by Year

Other RAM Models