2024 MERCEDES-BENZ SPRINTER 3500

3 recalls — 4 complaints — 11 TSBs

STRUCTURE:FRAME AND MEMBERS

Defect Description

Daimler Vans USA, LLC (DVUSA) is recalling certain 2024 Mercedes-Benz Sprinter 2500 and Sprinter 3500 vehicles. The longitudinal frame members may not be reinforced properly.

Consequence

Frame members with inadequate strength may reduce the vehicle's performance in a crash, increasing the risk of injury.

Remedy

Dealers will inspect and repair the frame, as necessary, free of charge. Owner notification letters were mailed December 18, 2025. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VVS3LAENGST. Vehicle Identification Numbers (VINs) involved in this recal... Read more

4 vehicles affected

Manufacturer: Daimler Vans USA, LLC

PARKING BRAKE

Defect Description

Daimler Vans USA, LLC (DVUSA) is recalling certain 2024 Mercedes-Benz Sprinter vehicles. The parking brake cable bracket welds may fail and disengage the parking brake. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and ... Read more

Consequence

Parking brake failure can result in a vehicle rollaway, increasing the risk of a crash.

Remedy

Dealers will inspect and repair the parking brake cable bracket as necessary, free of charge. Owner notification letters were mailed April 30, 2025. Owners may contact DVUSA customer service at 877-762-8267. DVUSA's number for this recall is VS3HALHAN.

88 vehicles affected

Manufacturer: Daimler Vans USA, LLC

SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY:U-BOLT, LEAF SPRING TO AXLE

Defect Description

Daimler Vans USA, LLC (DVUSA) is recalling certain 2023-2024 Mercedes-Benz Sprinter vehicles. The spring U-bolts for the rear axle may have reduced strength due to improper heat-treatment, which can cause the rear axle to shift out of position.

Consequence

An axle that moves out of position can cause a loss of vehicle control, increasing the risk of a crash.

Remedy

Dealers will replace the spring U-bolts, free of charge. Owner notification letters were mailed August 23, 2024. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3FEDERB.

1,232 vehicles affected

Manufacturer: Daimler Vans USA, LLC

Complaint Statistics

4 total complaints

Top Reported Components

Component	Complaints
FUEL/PROPULSION SYSTEM	1
WHEELS	1
UNKNOWN OR OTHER	1
TIRES	1

Incident date: Mar 27, 2026

The contact owns a 2024 Mercedes-Benz Sprinter 3500 equipped with Kumho Tires, Tire Line: Crugen Premium, Tire Size: 215/85/R16, DOT Number: 1H23PLDV9. The contact stated that while driving 65 MPH with his wife and dog inside the vehicle, the contact heard an abnormally loud sound coming from the fr... Read more

Incident date: Jun 11, 2025

We purchased a new 2025 Jayco Melbourne and afterwards discovered the MBZ 3500 Chassis was a 2024.(6/19/2024) A 2025 MBZ 3500 chassis has a TPMS -factory installed system; 2024 no TPMS. I started to install an aftermarket TPMS and noted the tire valve stems were rubber. I couldn’t install the end... Read more

Incident date: Jun 11, 2025

Incident date: Sep 2, 2024

Tried to drive over Wolf Creek Pass in Colorado. About halfway up, the vehicle started losing power and eventually lost all power. The engine was running but even with the pedal to the floor it was totally unresponsive. This put us in a dangerous situation as I had to park on the side of the road... Read more

Technical Service Bulletins — 2024 MERCEDES-BENZ SPRINTER 3500

11 manufacturer communications from 8 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
060000 ENGINE AND ENGINE COOLING	3
162300 STRUCTURE:BODY:DOOR	2
110000 ELECTRICAL SYSTEM	1
130000 VISIBILITY	1
138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM	1
080000 FUEL SYSTEM, DIESEL	1
160000 STRUCTURE	1
010000 STEERING	1

010000 STEERING

Various concerns in relation to electric power steering including Rattling/humming noise from electric power steering when steering fully turned (see video recordings 01 and 02).

060000 ENGINE AND ENGINE COOLING

Complaint Vehicles with SCR Generation 4: SCR/AdBlueA? warning message cannot be reset. Information: All fault codes in AdBlueA? (SCR) control unit have been processed and rectified; however fault code P13DF00 remains active and stored i

080000 FUEL SYSTEM, DIESEL

160000 STRUCTURE

Complaint Noise in front door from window regulator when driving. Cause Loosened nut of window lifter leads to screw connection at bottom of door breaking the mounting point in the door (see attached picture). Remedy Glue in repair pa

162300 STRUCTURE:BODY:DOOR

060000 ENGINE AND ENGINE COOLING

Complaint Engine runs irregularly and it shakes. Indicator lamp lights up. Information: Fault codes for injectors and/or combustion misfires may be stored in the CDI control unit: a?? On engine 642 cylinder 6 is affected. a?? On engine

060000 ENGINE AND ENGINE COOLING

Complaint Check engine warning light active. Fault code P300CA8 or P300CA9 "Hot film mass air flow sensor malfunction" is present in engine control unit. Cause a) In the case of fault P300CA8: a?? Due to incorrectly installed component

130000 VISIBILITY

Complaint Various customer concerns of Climate Control system operating inadequately. Cause Stepper motor linkage in the heater case may cause a mechanical fault during actuation during unfavorable environmental conditions. NOTE: If th

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

110000 ELECTRICAL SYSTEM

Complaint Distronic and/or Active Brake Assist inoperative after driving for an extended period Cause Blindness detection of the radar sensor. When driving for extended periods in areas with few or no objects for the radar sensor to det

162300 STRUCTURE:BODY:DOOR

(SC)Replace Front Door Check

NHTSA Safety Investigations — MERCEDES-BENZ SPRINTER 3500

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE — Closed — Model Year: 2013

Rear Wheel Speed Sensor Failure

The Office of Defects Investigation (ODI) analyzed complaint data provided by Daimler Vans USA, LLC (Daimler) as well as complaints submitted to ODI from consumers to identify incidents related to Rear Wheel Speed Sensors (RWSS) failures. ODI's analysis identified 6,710 incidents of RWSS failure (un... ique VINs) in MY 2012-2018 Mercedes- Benz and Freightliner Sprinter vehicles upfitted to campers or recreational vehicles (RVs) representing 81 percent of all Sprinter RWSS reports. Complaint and warranty analysis indicated that the majority of incidents (approximately 99%) were related to RWSS moisture intrusion condition in the Sprinter 3500 5-ton variant, which accounts for 98 percent of upfit campers, where moisture build-up and crystal dendrite formation develop in parked RVs and lead to sensor failures. According to the Daimler Information Request (IR) response, if the wheel speed information is detected as implausible by the Electronic Stability Program (ESP) control unit, the ESP system enters a failsafe mode where:-Driver torque requests are no longer accepted;-Cruise control, if used, would be deactivated; -The ESP/ABS system shuts off; and -Multiple warning lamps and messages advise the operator to take the vehicle to the workshop. While the majority of reports involved only ABS and/or ESP warning lights and messages on the instrument cluster due to faulty sensor signals triggering a failsafe mode, some reports cited intermittent sensor failures resulting in increased vehicle speed while in cruise control and degraded ABS or ESP. Degraded ESP functionality may impact driving stability of the 5-ton vehicle.On Feb 3, 2021, following discussion with ODI, Daimler submitted a Defect Information Report (DIR) to NHTSA describing a defect in the RWSS disabling the ESP control unit functions in approximately 48,667 MY 2012 through 2018 Mercedes-Benz and Freightliner Sprinter 3500 vehicles manufactured from Jan 4, 2012 through Oct 25, 2018 (Recall 21V-042). In its DIR, Daimler indicated that RWSS sensor failures are prevalent in camper vans due to sustained periods of non-use, during which time the moisture may not dry out, remaining inside the plastic housing package. If the moisture within the RWSS dries and the RWSS returns to normal operation, the failsafe mode and the warning lights will disappear at the next ignition cycle, but the sensor fault remains stored within the ESP control unit and can be accessed through a diagnostic evaluation. ODI will continue to monitor field experience in Sprinter non-RVs and Sprinter 2500 RVs 3-ton and 3.5-ton variants (approximately 626 vehicles).Daimler will notify owners of the recalled vehicles and advise them to take their vehicle to a Mercedes-Benz or Freightliner Sprinter dealer, who will replace the RWSS with a repackaged sensor with high robustness against moisture intrusion. Daimler began notifying dealers and owners in Feb 2021. This Preliminary Evaluation is closed.The ODI reports cited above can be reviewed at NHTSA.gov under the following ID numbers:11352380 11351299 11350521 11348969 11342776 11342464 11341988 11341151 11340388 11338230 11337921 11331832 11331829 11331476 11331427 11331066 11328671 11325768 11325693 11322814 11322346 11320295 11319376 11317336 11311647 11310621 11308318 11254223 11253828 11252220 11196530 11194330 11164250 11145019 11141273 11139000 11138785 11124129 11094122 11394837 11390889 11390039 11389262 11387883 11387713 11386418 11383887 11383866 11382947 11377384 11376615 11376973 11375781 11375403 11374997 11374151 11373892 11373111 11366293 11365920 11365594 11365355 11365194 11364253 11364346 11363990 11363787 11362948 113629Read more

MERCEDES-BENZ SPRINTER 3500 — All Years Overview

Complete safety history for the MERCEDES-BENZ SPRINTER 3500 across all model years (2007–2024).

362 Total Recalls

470 Total Complaints

1 Investigations

20 Reported Crashes

8 Reported Fires

2 Reported Deaths

MERCEDES-BENZ SPRINTER 3500 — Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2024 (current)	3	4
2023	7	24	View
2022	16	12	View
2021	65	11	View
2020	74	22	View
2019	97	43	View
2018	14	17	View
2017	13	38	View
2016	20	95	View
2015	16	37	View
2014	10	83	View
2013	8	36	View
2012	7	31	View
2011	4	9	View
2010	6	4	View
2009	1	1	View
2008	0	3	View
2007	1	0	View

Other MERCEDES-BENZ Models

Model	Recalls	Complaints
GLA 250	1,219	416	View
GLC 300	1,143	568	View
GLE 350	1,116	311	View
C 300	1,074	360	View
AMG GLS63	963	12	View
AMG C43	944	74	View
CLA 250	923	130	View
AMG GLC43	920	42	View