2007 MERCEDES-BENZ SPRINTER 3500
1 recalls — 0 complaints — 97 TSBs
10V655000
Dec 29, 2010
STRUCTURE
Defect Description
MERCEDES BENZ IS RECALLING CERTAIN MODEL YEAR 2007 AND 2010 2500 AND 3500 SPRINTER VEHICLES. THE CORRECT INTERIOR TRIM COVERING THE A-PILLARS MAY NOT HAVE BEEN INSTALLED. IF INCORRECT TRIM WAS INSTALLED ON A VEHICLE, THE VEHICLE WOULD FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE S... Read more
Consequence
IN THE EVENT OF A VEHICLE CRASH, THE VEHICLES MAY NOT PROVIDE THE PROTECTION REQUIRED BY THE STANDARD IF AN OCCUPANT STRIKES THE A-PILLAR TRIM.
Remedy
MERCEDES-BENZ WILL CHECK TO SEE IF THE CORRECT TRIM COVER WAS INSTALLED AND, IF NOT, REPLACE THAT TRIM COVER WITH THE CORRECT ONE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING FEBRUARY 2011. OWNERS MAY CONTACT MERCEDES-BENZ AT 843-695-5000.
No complaints found for this vehicle.
Technical Service Bulletins — 2007 MERCEDES-BENZ SPRINTER 3500
97 manufacturer communications from 60 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 350000 EQUIPMENT | 33 |
| 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL | 10 |
| 140000 AIR BAGS | 8 |
| 060000 ENGINE AND ENGINE COOLING | 6 |
| 356000 EQUIPMENT ADAPTIVE/MOBILITY | 4 |
| 060000 ENGINE (PWS) | 4 |
| 080000 FUEL SYSTEM, DIESEL | 3 |
| 110000 ELECTRICAL SYSTEM | 2 |
LI03.10-N-075843
Feb 13, 2023
060000 ENGINE AND ENGINE COOLING
Complaint Engine runs irregularly and it shakes. Indicator lamp lights up. Information: Fault codes for injectors and/or combustion misfires may be stored in the CDI control unit: a?? On engine 642 cylinder 6 is affected. a?? On engine
LI00.19-N-075749
Jan 13, 2023
110000 ELECTRICAL SYSTEM
Complaint Various issues including control unit programming procedure will not complete successfully/no newer software found, communication faults, or sporadic malfunction of systems. Cause Aftermarket CAN device could be installed into
NC3DABTKW2
Nov 10, 2022
140000 AIR BAGS
Replace Driver Airbag
LI01.00-N-074210
Jan 6, 2022
350000 EQUIPMENT
Complaint Oil loss from engine or visible traces of oil in the engine compartment. Cause To be determined in each possible situation Remedy Procedure for cause analysis: 1. Clean the engine if necessary. 2. Apply leak tracing powder.
LI01.00-N-074210
Jan 6, 2022
060000 ENGINE AND ENGINE COOLING
Complaint Oil loss from engine or visible traces of oil in the engine compartment. Cause To be determined in each possible situation Remedy Procedure for cause analysis: 1. Clean the engine if necessary. 2. Apply leak tracing powder.
LI54.22-N-074063
Dec 7, 2021
110000 ELECTRICAL SYSTEM
Various complaints due to aftermarket OBDII device installed
LI14.20-N-071638
Aug 21, 2020
060000 ENGINE AND ENGINE COOLING
Engine power output is reduced and/or engine indicator lamp lights up, various fault codes present in area of ex- haust gas recirculation (EGR system) or in charge air system
LI46.00-N-069137
Aug 3, 2020
070000 FUEL SYSTEM, GASOLINE
Power Steering Hose Updated Repair Method
LI46.00-N-069137
Aug 3, 2020
015200 STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
Power Steering Hose Updated Repair Method
LI91.40-N-062773
Dec 17, 2019
150000 SEAT BELTS
Seat belt does not roll up correctly
LI82.85-N-070617
Dec 4, 2019
350000 EQUIPMENT
MBUX multimedia system: Malfunction in Android Auto (Connect5)
LI82.85-N-070620
Dec 4, 2019
350000 EQUIPMENT
SOS display illuminates - poor radio and GPS reception or no reception at all (vehicle with code E4A)
LI82.85-N-069563
Dec 4, 2019
350000 EQUIPMENT
MBUX multimedia system: Central display goes dark temporarily (Connect5)
LI82.85-N-070619
Dec 3, 2019
350000 EQUIPMENT
MBUX multimedia system: Central display intermittently remains dark (NTG6)
LI82.85-N-070616
Dec 3, 2019
350000 EQUIPMENT
MBUX multimedia system: Commissioning problem - No PIN code available in VeDoc
LI82.85-N-070599
Dec 2, 2019
350000 EQUIPMENT
MBUX multimedia system: Incomplete playback of navigation announcements (NTG6)
LI32-25-N-069847
May 28, 2019
023000 SUSPENSION:MULTIPLE AXLE
Clunking/Rattle Noise from Rear Axle Area
LI31-00-N-069787
May 23, 2019
210000 TRAILER HITCHES
Information:907 Sprinter 15 Passenger Van Trailer Hitch
LI30 36-N-069739
Apr 29, 2019
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Instruction for the Removal of M20 Speed Limitation 65mph
LI82 85-N-069567
Apr 5, 2019
353000 EQUIPMENT:ELECTRICAL
MBUX multimedia system: Smartphone Integration (Apple CarPlay, Android Auto) not available (NTG6)
LI49 00-N-067929
Jul 23, 2018
100000 POWER TRAIN
Automatic Transmission Housing Cracked: Damage Resulting From Cracked Diesel Particulate Filter Bracket
LI49 00-N-067929
Jul 23, 2018
080000 FUEL SYSTEM, DIESEL
Automatic Transmission Housing Cracked: Damage Resulting From Cracked Diesel Particulate Filter Bracket
Sprinter Weekly
Jun 22, 2018
356000 EQUIPMENT ADAPTIVE/MOBILITY
Status of Parts Ordering - Sprinter
Sprinter Weekly
Jun 22, 2018
350000 EQUIPMENT
Status of Parts Ordering - Sprinter
Sprinter Weekly
Jun 15, 2018
356000 EQUIPMENT ADAPTIVE/MOBILITY
Status of Parts Ordering - Sprinter
Sprinter Weekly
Jun 15, 2018
350000 EQUIPMENT
Status of Parts Ordering - Sprinter
Sprinter Weekly
May 18, 2018
350000 EQUIPMENT
Status of Parts Ordering - Sprinter
Sprinter Weekly
Mar 16, 2018
356000 EQUIPMENT ADAPTIVE/MOBILITY
Status of Parts Ordering - Sprinter
Sprinter Weekly
Mar 16, 2018
350000 EQUIPMENT
Status of Parts Ordering - Sprinter
Sprinter Weekly
Dec 1, 2017
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Status of Parts Ordering - Sprinter
14CSA23
Oct 27, 2017
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
14CSA23 CSC Announces ?Tech Tips? ? DDCSN
Sprinter October
Oct 27, 2017
350000 EQUIPMENT
Status of Parts Ordering - Sprinter
LI33 00-N-066643
Oct 18, 2017
020000 SUSPENSION
Ball joint check on front axle
Sprinter Septemb
Sep 29, 2017
350000 EQUIPMENT
Status of Parts Ordering - Sprinter
Sprinter Septemb
Sep 22, 2017
350000 EQUIPMENT
Status of Parts Ordering - Sprinter
LI07 09-N-063338
Jul 11, 2017
060000 ENGINE (PWS)
Coolant / Vacuum / Temperature fault codes - Check Engine Light with DTCs P003313, P0299FA, P0299FB, P226100, P261F71, P012800, and P012809
2017010005
Apr 3, 2017
350000 EQUIPMENT
Recall Campaign bulletin
2017010005
Apr 3, 2017
140000 AIR BAGS
Recall Campaign bulletin
2017030013
Apr 3, 2017
140000 AIR BAGS
Recall Campaign bulletin
LI07.09-N-063338
Jan 10, 2017
060000 ENGINE AND ENGINE COOLING
Coolant / Vacuum / Temperature fault codes - Check Engine Light with DTCs P003313, P0299FA, P0299FB, P226100, P261F71, P012800, and P012809
Sprinter Weekly
Jan 5, 2017
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Status of Parts Ordering - Sprinter
LI0709N0633386
Nov 7, 2016
980000 UNKNOWN OR OTHER
Coolant, vacuum, temperature fault codes.
LI0709N0633386
Nov 7, 2016
033100 SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM
Coolant, vacuum, temperature fault codes.
Sprinter Weekly
Jul 8, 2016
350000 EQUIPMENT
Status of Parts Ordering - Sprinter
Sprinter Weekly
Jul 8, 2016
350000 EQUIPMENT
Status of Parts Ordering - Sprinter
Sprinter Weekly
Jul 1, 2016
350000 EQUIPMENT
Status of Parts Ordering - Sprinter
Sprinter Weekly
Jul 1, 2016
350000 EQUIPMENT
Status of Parts Ordering - Sprinter
Sprinter Weekly
Jun 24, 2016
350000 EQUIPMENT
Status of Parts Ordering - Sprinter
Sprinter Weekly
Jun 17, 2016
350000 EQUIPMENT
Status of Parts Ordering - Sprinter
Sprinter Weekly
Jun 17, 2016
350000 EQUIPMENT
Status of Parts Ordering - Sprinter
Sprinter Weekly
Jun 10, 2016
350000 EQUIPMENT
Status of Parts Ordering - Sprinter
Sprinter Weekly
Jun 10, 2016
350000 EQUIPMENT
Status of Parts Ordering - Sprinter
Sprinter Weekly
Jun 3, 2016
350000 EQUIPMENT
Status of Parts Ordering - Sprinter
Sprinter Weekly
Jun 3, 2016
350000 EQUIPMENT
Status of Parts Ordering - Sprinter
Sprinter Weekly
May 27, 2016
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Status of Parts Ordering - Sprinter
LI18.30-N-056338
May 27, 2016
060000 ENGINE (PWS)
Traces of oil in area of oil cooler (inner V) on engine 642
Sprinter Weekly
May 20, 2016
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Status of Parts Ordering - Sprinter
Sprinter Weekly
May 13, 2016
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Status of Parts Ordering - Sprinter
Sprinter Weekly
May 6, 2016
350000 EQUIPMENT
Status of Parts Ordering - Sprinter
LI35.00-N-060958
May 2, 2016
105000 POWER TRAIN:DRIVELINE
Humming, droning from the drivetrain on SPRINTER 2500 with all-wheel drive (4x4)
16TS7
Mar 28, 2016
080000 FUEL SYSTEM, DIESEL
16TS7 Reman Diesel Particulate Filter Serial Number
Airbag
Feb 26, 2016
140000 AIR BAGS
Additional information around the recent recall announcement affecting approximately 100,000 Mercedes-Benz and Freightliner vans involving Takata driver-side airbags containing SDI type inflators
PartsC
Feb 19, 2016
350000 EQUIPMENT
recall campaign announcement.
PartsC
Feb 19, 2016
131000 VISIBILITY:WINDSHIELD
recall campaign announcement.
PartsC
Feb 19, 2016
140000 AIR BAGS
recall campaign announcement.
2017030012
Feb 12, 2016
140000 AIR BAGS
Pursuant to Part 579.5, we have no Sprinter or Metris Service and Warranty Bulletins for the month of January, 2017.
Updates
Feb 12, 2016
140000 AIR BAGS
Additional information around the recent recall announcement affecting approximately 100,000 Mercedes-Benz and Freightliner vans involving Takata driver-side airbags containing SDI type inflators
2017030012
Feb 12, 2016
350000 EQUIPMENT
Pursuant to Part 579.5, we have no Sprinter or Metris Service and Warranty Bulletins for the month of January, 2017.
Update
Feb 11, 2016
140000 AIR BAGS
Takata airbag recall campaign announcement
V-B-58.20-04
Mar 6, 2015
356000 EQUIPMENT ADAPTIVE/MOBILITY
Special Tool Return Due to Interference Issue
14TL8
Oct 31, 2014
350000 EQUIPMENT
14TL8 TorcUP? Non-Impacting Torque Tool.
14CSA22
Oct 24, 2014
114000 ELECTRICAL SYSTEM:WIRING
14CSA22 DTNA Chassis Wiring Diagrams
14TL9
Oct 23, 2014
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
14TL9 Special Tool Warranty Program.
LI14.40-N-060049
Oct 20, 2014
063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
Fault relating to SCR AdBlue warning strategy
14TL7
Oct 15, 2014
354000 EQUIPMENT:MECHANICAL
14TL7 DD Platform Flywheel Housing Runout Tool W470589032100
14CSA21
Oct 14, 2014
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
14CSA21 Holiday Schedule for the Detroit Customer Support Center ?
LI68.30-N-059117
Oct 13, 2014
350000 EQUIPMENT
Cover of storage slot at front under roof liner (FF8) not fitting.
LI68.30-N-059117
Oct 13, 2014
162900 STRUCTURE:BODY:ROOF AND PILLARS
Cover of storage slot at front under roof liner (FF8) not fitting.
14CSA20
Oct 10, 2014
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
14CSA20 EGR Valve Actuator Kit P/N E23539699
LI07.04-N-056999
Oct 6, 2014
060000 ENGINE (PWS)
Engine power insufficient, engine diagnosis indicator lamp lights up and differential pressure sensor fault codes current and/or stored in CDI control unit
LI54.21-N-059919
Oct 6, 2014
116000 ELECTRICAL SYSTEM:IGNITION
Remote engine start via external starter switch sporadically not possible, fault code B150B
sb2080
Oct 1, 2014
062100 ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY
sb2080 Australian CST M1400 Isolated Radiator Retrofit
14TL2
Jul 29, 2014
060000 ENGINE (PWS)
14TL2 DD Platform Engine Stand Adapter W060589023100
14TL5
Jul 29, 2014
350000 EQUIPMENT
14TL5 ABS Power Line Carrier Converter Available Through PDC
14TS19
Jul 24, 2014
090000 FUEL SYSTEM, OTHER
14TS19 DD Platform High Pressure Fuel Lines
LI14.40-N-058284
Feb 7, 2014
060000 ENGINE AND ENGINE COOLING
AdBlue line leaking
LI8210N048712
Aug 21, 2013
121000 EXTERIOR LIGHTING:HEADLIGHTS
Headlamps and lamps fogged and/or leaking.
LI07.08-N-056829
Jul 18, 2013
060000 ENGINE AND ENGINE COOLING
Engine in limp-home mode, engine diagnosis indicator lamp lights up, fault code P213862, P213864, P211271, P225113, P019122 or P019185 stored in control unit.
SC-2013040002
May 1, 2013
350000 EQUIPMENT
MERCEDES: RADIO REMOTE RECEIVER FOR THE AUXILLIARY HEATER IS OPERATING ON AN UNAPPROVED RADIO FREQUENCY. RADIO REMOTE AND RECEIVER NEED TO BE REPLACED. MODEL 906 YEARS 2007-2011. *KB
SC-2013040002
May 1, 2013
353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
MERCEDES: RADIO REMOTE RECEIVER FOR THE AUXILLIARY HEATER IS OPERATING ON AN UNAPPROVED RADIO FREQUENCY. RADIO REMOTE AND RECEIVER NEED TO BE REPLACED. MODEL 906 YEARS 2007-2011. *KB
V-B-00.00/02A
Jan 27, 2012
118000 ELECTRICAL SYSTEM:SOFTWARE
MERCEDES (SPRINTER): SOFTWARE RETROFIT PROCESS. ALL MODEL YEARS. *KB
V-B-47.10/01A
Jan 24, 2012
080000 FUEL SYSTEM, DIESEL
MERCEDES (SPRINTER): PROCEDURE FOR WHEN DIESEL FUEL TANK IS FILLED WITH INCORRECT FUEL TYPE. ALL MODEL YEARS. *KB
V-B-41.10/02
Jan 10, 2012
105300 POWER TRAIN:DRIVELINE:DRIVESHAFT
MERCEDES (SPRINTER): REMOVAL AND INSTALLATION OF THE DRIVE SHAFT. ALL MODEL YEARS. *KB
SB-32-25-82
Nov 19, 2010
022400 SUSPENSION:REAR:SHOCK ABSORBER
MERCEDES-BENZ: SHOCK ABSORBER PROCEDURE. *RM
SB-32-25-82
Nov 19, 2010
021230 SUSPENSION:FRONT:SPRINGS:AIR SUSPENSION SYSTEM
MERCEDES-BENZ: SHOCK ABSORBER PROCEDURE. *RM
SB-32-25-82
Nov 19, 2010
022130 SUSPENSION:REAR:SPRINGS:AIR SUSPENSION SYSTEM
MERCEDES-BENZ: SHOCK ABSORBER PROCEDURE. *RM
SB-32-25-82
Nov 19, 2010
021300 SUSPENSION:FRONT:SHOCK ABSORBER
MERCEDES-BENZ: SHOCK ABSORBER PROCEDURE. *RM
NHTSA Safety Investigations — MERCEDES-BENZ SPRINTER 3500
Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.
PE20014
Opened: Sep 21, 2020 — Closed: Mar 30, 2021
Rear Wheel Speed Sensor Failure
The Office of Defects Investigation (ODI) analyzed complaint data provided by Daimler Vans USA, LLC (Daimler) as well as complaints submitted to ODI from consumers to identify incidents related to Rear Wheel Speed Sensors (RWSS) failures. ODI's analysis identified 6,710 incidents of RWSS failure (un... Read more
MERCEDES-BENZ SPRINTER 3500 — All Years Overview
Complete safety history for the MERCEDES-BENZ SPRINTER 3500 across all model years (2007–2024).
362
Total Recalls
470
Total Complaints
1
Investigations
20
Reported Crashes
8
Reported Fires
2
Reported Deaths
MERCEDES-BENZ SPRINTER 3500 — Year by Year
Compare recalls and complaints across model years. Click any year to see full details.
| Year | Recalls | Complaints | |
|---|---|---|---|
| 2024 | 3 | 4 | View |
| 2023 | 7 | 24 | View |
| 2022 | 16 | 12 | View |
| 2021 | 65 | 11 | View |
| 2020 | 74 | 22 | View |
| 2019 | 97 | 43 | View |
| 2018 | 14 | 17 | View |
| 2017 | 13 | 38 | View |
| 2016 | 20 | 95 | View |
| 2015 | 16 | 37 | View |
| 2014 | 10 | 83 | View |
| 2013 | 8 | 36 | View |
| 2012 | 7 | 31 | View |
| 2011 | 4 | 9 | View |
| 2010 | 6 | 4 | View |
| 2009 | 1 | 1 | View |
| 2008 | 0 | 3 | View |
| 2007 (current) | 1 | 0 |