1987 JEEP CHEROKEE

9 recalls, 72 complaints - 4 TSBs

EXTERIOR LIGHTING:HEADLIGHTS

Defect Description

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES... Read more

Consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy

DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

42,540 vehicles affected

Manufacturer: DOPE, INC.

EXTERIOR LIGHTING

Defect Description

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES... Read more

Consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Remedy

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

16,270 vehicles affected

Manufacturer: SABERSPORT

EXTERIOR LIGHTING

Defect Description

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE D... Read more

Consequence

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy

PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

61,944 vehicles affected

Manufacturer: PRO-A MOTORS, INC.

VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

Defect Description

VEHICLE DESCRIPTION: MULTIPURPOSE PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS. THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH FEDERAL REGULATION 573. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. DRIVERS CAN MISTAKENLY STEP ON THE ACCELERATOR PEDAL WHEN THEY INT... Read more

Consequence

PEDAL MISAPPLICATION BY A DRIVER CAN CAUSE UNINTENDED ACCELERATION.

Remedy

DEALERS WILL INSTALL A SHIFT INTERLOCK ON THE AUTOMATIC TRANSMISSION OF THESE VEHICLES.

1,010,400 vehicles affected

Manufacturer: CHRYSLER CORPORATION

SERVICE BRAKES, HYDRAULIC:POWER ASSIST:HYDRAULIC

Defect Description

BRAKE BOOSTER VACUUM RESERVOIR CANISTERS MAY DEVELOP LEAKS DUE TO BUMPER IMPACT.

Consequence

THIS WOULD RESULT IN LOSS OF POWER BRAKE ASSIST AND ANINCREASE IN STOPPING DISTANCE.

Remedy

REPLACE BRAKE BOOSTER VACUUM CANNISTERS WITH NEW TYPE CANNISTERS; ALSO, INSTALL A RESTRICTION ORIFICE TO ENSURE SUFFICIENT VACUUM IN EVENT CANNISTER LEAKAGE OCCURS.

1,600 vehicles affected

Manufacturer: CHRYSLER CORPORATION

VEHICLE SPEED CONTROL:LINKAGES

Defect Description

VEHICLE MAY CONTAIN AN OUT OF TOLERANCE THROTTLE BODY.

Consequence

THIS COULD PREVENT THE ACCELERATOR FROM RETURNING TOIDLE WHEN RELEASED.

Remedy

REPLACE SUSPECT THROTTLE BODIES.

20,439 vehicles affected

Manufacturer: CHRYSLER CORPORATION

VEHICLE SPEED CONTROL

Defect Description

CRUISE CONTROL MODULE COULD HAVE INCONSISTENT CRUISE CONTROL OPERATION.

Consequence

INCONSISTENT CRUISE CONTROL OPERATION COULD RESULT INLOSS OF CONTROL AND AN ACCIDENT.

Remedy

REPLACE MODULE, AS NECESSARY.

3,996 vehicles affected

Manufacturer: CHRYSLER CORPORATION

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

Defect Description

A STUD MAY HAVE BEEN INSTALLED ON TOP OF THE INTAKE MANIFOLD OF ENGINE THAT COULD CONTACT THE FUEL SUPPLY HOSE. CONSEQUENCE OF DEFECT: CHAFING OF THE FUEL HOSE COULD OCCUR WHICH COULD RESULT ... Read more

Remedy

REMOVE STUD AND REPLACE FUEL SUPPLY HOSE AND LINE ASSEMBLY ON VEHICLES WITH ACCUMULATED MILEAGE.

635 vehicles affected

Manufacturer: CHRYSLER CORPORATION

STEERING:LINKAGES

Defect Description

STEERING LINKAGE COUPLERS REMAINED IN ACID ETCHING BATH TOO LONG. CONSEQUENCE OF DEFECT: COUPLERS COULD BE OUT OF TOLERANCE RESULTING IN STEERING ... Read more

Remedy

REPLACE OUT OF TOLERANCE STEERING LINKAGE COUPLERS.

6,958 vehicles affected

Manufacturer: CHRYSLER CORPORATION

Complaint Statistics

72 total complaints 4 crashes 7 fires 8 injuries 1 deaths

Top Reported Components

Component	Complaints
VEHICLE SPEED CONTROL	12
SEAT BELTS:FRONT:BUCKLE ASSEMBLY	5
ENGINE AND ENGINE COOLING:ENGINE	5
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL	4
VEHICLE SPEED CONTROL:LINKAGES	3
ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD	3
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE	3
POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)	2
VEHICLE SPEED CONTROL:CRUISE CONTROL	2
VEHICLE SPEED CONTROL:CABLES	2

Incident date: Mar 15, 2003

DT*: THE CONTACT STATED THERE IS A PROBLEM WITH THE STEERING IN THE VEHICLE. THE VEHICLE IS AT THE DEALERSHIP AT THIS TIME FOR DIAGNOSTICS TEST. THERE IS A NHTSA RECALL, # 86V159000 REGARDING THE STEERING LINKAGES. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL; HOWEVER IT IS NOT INC... Read more

Incident date: Oct 5, 2005

DT: THE CONTACT STATED THIS VEHICLE HAD THE SAME PROBLEMS AS INDICATED IN THE RECALLS; 97I002000 CONCERNING THE ACCELERATOR PEDAL , RECALL 88V106000 CONCERNING THE POWER ASSIST HYDRAULIC SERVICE BRAKES/RECALL 87V035000 CONCERNING VEHICLE SPEED CONTROL LINKAGES/ 86V159000 CONCERNING THE ST... Read more

Incident date: Oct 5, 2005

Incident date: May 20, 2000

THE CONSUMER NOTICED PINK FLUID ON THE GARAGE FLOOR. THE VEHICLE WAS TAKEN TO DEALERSHIP. THE GASKET AND SEALS WERE REPLACED ON THE TRANSFER CASE. HOWEVER THE LEAK CONTINUED. AFTER PARTS WERE REPLACED AND TRANSMISSION WAS PUT ON DEALERSHIP FOUND A POROUS LEAK IN WHICH A SMALL PIN HOLE WAS IN TH... Read more

Incident date: Jun 15, 2003

THIS JEEP IS UNPREDICTABLE BECAUSE IT ACCELERATES FOR NO EXPECTED REASON IT SEEMS TO GET STUCK ON A HIGH THROTTLE IDLE SPEED WHEN I FIRST TURN IT ON. I WOULD TURN IT ON AND IT WILL ACCELERATE AT VERY HIGH REVOLUTIONS , IT SOUNDS LIKE ITS GOING TO EXPLODE, SO I TURN IT OFF THEN ON AGAIN AND IT WILL ... Read more

Incident date: Mar 16, 2004

STEERING COLUMN SNAPPED. AS A RESULT, STEERING FAILED. *AK

Incident date: Sep 25, 2003

WHEN BRAKING AFTER DRIVING AT HIGHWAY SPEEDS, THE VEHICLE SUDDENLY ACCELERATED. AS A RESULT, THE VEHICLE EXPERIENCED EXTENDED STOPPING DISTANCE. RECALL 87V03500 WAS ISSUED, BUT THIS VEHICLE WAS NOT INCLUDED DUE TO VIN. *AK THE VEHICLE WOULD NOT STOP UNTIL THE KEY WAS TURNED OFF. THE ENGINE ... Read more

Incident date: Apr 17, 2003

STEERING COLUMN WOBBLES AT TILT JOINT . ON LEFT TURNS, STEERING COLUMN LOCKS IN POSITION MAKING CAR UNDRIVEABLE. *NLM

Incident date: Feb 5, 2003

THE CONSUMER WAS SITTING IN THE VEHICLE WITH THE ENGINE IDLING IN FRONT OF A HOSPITAL ENTRANCE, WHEN ALL OF A SUDDEN THE VEHICLE SUDDENLY ACCELERATED WITHOUT WARNING AND CRASHED INTO A BUILDING. SIX PEOPLE WERE INJURED. *JB

Crash 6 injured

Incident date: Dec 2, 2002

WHILE TRAVELING ON THE HIGHWAY WITHOUT PRIOR WARNING. THE THROTTLE WAS STUCK AND THE VEHICLE ACCELERATE AND HIT AN EMBANKMENT. AND ROLL THREE OR MORE TIMES. PLEASE FILL IN ADDITIONAL INFORMATION DEALER IS AWARE OF THE PROBLEM. TS

WHILE DRIVING VEHICLE NOTICED THERE WAS SMOKE SEEPING FROM UNDER THE HOOD. WAS ABLE TO OPEN THE HOOD AND NOTICED THAT VEHICLE CAUGHT ON FIRE. *AK

Fire

Incident date: May 3, 2002

WHEN TURNING VEHICLE ON ON FULL THROTTLE CANNOT STOP VEHICLE IF PUT IT IN GEAR. CONTACTED MECHANIC. THROTTLE BODY PROBLEM.*AK

Incident date: May 5, 2002

ENGINE CAUGHT ON FIRE AFTER VEHICLE WAS PARKED. *AK

Fire

Incident date: Oct 29, 2000

WITH THE ENGINE RUNNING AT IDLE SPEED, THE IDLER PULLEY SEPARATED FROM THE ENGINE AND ALMOST HIT THE CONSUMERS HEAD, IT BOUNCED OFF THE CONSUMERS GARAGE WALL AND IMPACTED THE GARAGE CONCRETE FLOOR, THE BEARINGS WITHIN THE IDLER PULLEY FAILED, CAUSING THE PULLEY BOLT THREADS TO BACK OUT OF THE HOUSIN... Read more

Incident date: Oct 29, 2000

THE BEARINGS WITHIN THE IDLER PULLEY (NUMBER 53002905) FAILED CAUSING THE PULLEY BOLT THREADS TO BACK OUT OF THE HOUSING, THE ENGINE WAS RUNNING WITH THE HOOD UP SLIGHTLY ABOVE ENGINE IDLE SPEED WHEN IDLER PULLEY SEPARATED FROM THE ENGINE AND BECAME AIRBORN. NLM

Incident date: May 1, 2001

THE ACCESSORIES WIRE [BROWN IN COLOR] OVERHEATS AND MELTS CAUSING THE SOCKET ASSEMBLY AND THE IGNITION SWITCH TO ALMOST CATCH ON FIRE. THAT ONE WIRE ON 1987 AND EARLY MODELS HAPPENS ALOT. I RESEARCHED A NUMBER OF JEEPS IN SALVAGE YARDS LOCALLY. JEEP MUST HAVE DISCOVERED THE DEFECT LATER MODELS HAVE... Read more

THE VEHICLE SLIPPED INTO A DIFFERENT GEAR. NLM

Incident date: Oct 29, 2000

WHILE THE ENGINE WAS RUNNING, BEARING WITHIN THE IDLER PULLEY FAILED, THE PULLEY BOLT THREADS BACK OUT OF THE HOUSING, THE IDLER PULLEY SEPARATED FROM THE ENGINE AND TORPEDOED PASS OWNER'S HEAD, PULLEY COULD HAVE SERIOUSLY INJURED OR KILLED ANYONE IN ITS PATH. *CJ

Incident date: Oct 1, 1996

CRUISE CONTROL FAILED.*ET

Incident date: Oct 1, 1996

CRUISE CONTROL FAILED.*ET

Incident date: Sep 20, 2000

BOTH REAR BUMPER BRACKETS COMPLETLY RUSTED OUT & REAR BUMPER DISCONNECTED FROM RIGHT BRACKET & HANGING ONLY BY ONE BRACKET & DRAGGING ON GROUND BEHIND VEHICLE AS IT WAS MOVING AT HIGHWAY SPEED. THE BUMPER COULD HAVE FALLEN OFF AND PRESENTED A SERIOUS ROAD HAZARD TO FOLLOWING VEHICLES.

Incident date: Aug 10, 2000

CONSUMERS SON WAS DRIVING DOWN HIGHWAY AND SUDDENLY FRONT RIGHT TIRES TREAD COMPLETELY PEELED OFF, CONSUMERS SON BRIEFLY LOST CONTROL OF AUTO, NO INJURY WAS SUSTAINED, TIRES ONLY HAD 8-10000 MILES- THEY WERE FIRESTONE TIRES SIZE P205R/7515 FR360.*AK *SLC

BOUGHT FULL SET OF TIRES 2 YEARS AGO. OVER ONE YEAR I HAD 6 FLAT TIRES FROM PUNCTURES, ONE OF WHICH PUNCTURED THE TIRE SO BAD AS TO MAKE IT UNREPAIRABLE. FOUR OF THESE INCIDENTS WERE DRIVING ON NORMAL ROADS, THE OTHER TWO ON GRAVEL ROADS. SO CALLED 'ALL TERRAIN' TIRES SHOULD NOT BE SO PRONE TO PUNCT... Read more

Incident date: Jul 12, 1994

BALL BEARING BUSHINGS RESTRAINED BY METAL BAND IN STEERING COLUMN BOTH SEPARATED AS WELL AS ELONGATE ALLOWING BALL BEARINGS TO FALL OUT, RESULTING IN STEERING LOCKING, POPPING NOISES AND LOOSENESS IN THE STEERING COLUMN. CAN BE EASILY DETECTED BY JIGGLING THE STEERING WHEEL, STEERING WHEEL WITH MOV... Read more

POSSIBELE ENGINE FAILURE, THE VEHICLE LOST SPEED AND OVER HEATED, CATCHING FIRE AND RSULTING IN TOTAL DAMAGE. YH

Fire

Incident date: Mar 5, 2000

1. ACCELERATOR STICKS INTERMITTENTLY, HAVE TO RESTART JEEP SEVERAL TIMES TO GET IT TO IDLE DOWN. IF I AM TRAVELING DOWN THE ROAD IT WILL ACCELERATE BY ITSELF UP TO 3500 RPM MAKING BRAKING DIFFICULT. HAVE TO PULL OVER AND RESTART JEEP UNTIL IT UNSTICKS ITSELF. 2. HAVE NOTICED REALLY LOOSE FR... Read more

Incident date: Mar 5, 2000

Incident date: Nov 24, 1998

STEERING COLUMN BOLT LOOSENED, CAUSING STEERING COLUMN TO COME APART.

Incident date: Nov 15, 1998

SPEED CONTROL WOULD ENGAGE BY ITSELF WHENEVER VEHICLE REACHED 50-55 MPH, AND ACCELERATOR WOULD NOT RELEASE UNTIL VEHICLE WAS TURNED OFF. MANUFACTURER NOTIFIED OF NHTSA RCALLS # 87V-022 000, EQUIPMENT/SPEED CONTROL; AND 87V-035 000 : THROTTLE LINKAGES & ACCELERATOR. MANUFACTURER INFORMED CONSUMER T... Read more

Incident date: Jun 21, 1987

WHILE DRIVING AT 35 MPH TOOK FOOT OFF OF THE GAS PEDAL AND THE THROTTLE STAYED OPEN, CAUSING VEHICLE TO ACCELERATE. *AK

Incident date: May 12, 1999

EACH TIME THE ENGINE COOLANT RESERVOIR BEGAN LEAKING AT THE SEAM WHERE IT IS PUT TOGETHER, CAUSING THE ENGINE TO OVERHEAT AT THE DEALERSHIP THE MAN AT THE PARTS DEPT. SAID THAT THIS HAPPENED ALOT AND SOMETHING SHOULD BE DONE. *AK

VEHICLE WAS NOT INCLUDED IN TWO RECALLS ALTHOUGH EXPERIENCEING THE SAME EXACT PROBLEMS. RECALLS 87V035000, THROTTLE AND 88V106000, BRAKES. *AK THE DEALER STATED THAT VIN NUMBER FOR THE VEHICLE WAS NOT IN THE RECALL. *YH

NO SUMMARY

Incident date: Jan 1, 1999

REPLACED IDLE SPEED UNIT AND THROTTLE POSITION SENSOR (TPS).

Incident date: Jan 1, 1999

REPLACED IDLE SPEED UNIT AND THROTTLE POSITION SENSOR (TPS).

IDLE CONTROL ON THE VEHICLE HAS PROBLEM, FOR NO APPARENT REASON, VEHICLE IDLES BETWEEN 2,000 TO 3,000RPMS.

VEHICLE'S STABILITY IS VERY POOR, CAUSING VEHICLE TO ROLLOVER DURING A COLLISION.

2 injured

VEHICLE STALLS AT STOP SIGNS AND SOMETIMES WHEN TURNING CORNERS INTERMITTENTLY, TESTED EEC, REPLACE VALVE ASY, SENSOR ASSY-EXH GAS, REPLACE EGR AND EVP OPEN AT ALL TIMES ROAD TEST.

Incident date: Jan 1, 1994

REAR BRAKES FAILED FIVE TIMES.

Incident date: Aug 6, 1996

VEHICLE EXPERIENCES SUDDEN ACCELERATION. *AK

Incident date: Jan 7, 1997

WHILE WIFE DRIVING AT SLOW SPEED VEHICLE SHE WAS REAR ENDED. THE GAS TANK, LOCATED IN THE REAR RUPTURED, CAUSING A FIRE AND SUFFERED A FATALITY WHEN THE FIRE BLEW OUT ONE OF HER DAUGHTERS THAT WAS SITTING IN REAR SEAT. CLAIMS THAT PLACEMENT OF TANK IN REAR OF VEHICLE IS A SERIOUS DANGER TO THE PUBLI... Read more

Crash Fire 1 deaths

VEHICLE STALLS AT IDLE SPEEDS OF 2000-3000 RPMS.

VEHICLE HAS UNWANTED ACCELERATION WITH OUT ACCELERATOR PEDAL APPLICATION, THE CAR WILL RUN BY ITSELF. *AK

THE DRIVER 'S SIDE SEAT BELT BUCKLE BROKE, UNBLE TO UNLOC K SEAT BELT TO REMOVE IT. *AK

Showing 50 of 72 complaints.

Technical Service Bulletins, 1987 JEEP CHEROKEE

4 manufacturer communications from 4 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
105000 POWER TRAIN:DRIVELINE	1
171100 LATCHES/LOCKS/LINKAGES:DOORS:LATCH	1
103800 POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH	1
162000 STRUCTURE:BODY	1

162000 STRUCTURE:BODY

SUBJECT REGARDING FLOOR PAN CORROSION. *SLC

103800 POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH

SUBJECT ON CUSTOMER SATISFACTION NOTIFICATION #733--BRAKE PEDAL SHIFT INTERLOCK. *YC

105000 POWER TRAIN:DRIVELINE

NEW FRONT OUTPUT SEAL AND OIL SLINGER FOR TRANSFER CASE. *TW

171100 LATCHES/LOCKS/LINKAGES:DOORS:LATCH

REDESIGNED LIFTGATE LATCH. *TW

NHTSA Safety Investigations, JEEP CHEROKEE

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 2014

Electronic Parking Brake Water Ingress

The Office of Defects Investigation (ODI) opened investigation PE22-009 after having received 80 complaints on model years 2014-2020 Jeep Cherokees alleging the Electronic Parking Brake (EPB) inadvertently activated while the vehicle was in motion.During this investigation, the subject vehicles were... updated to include only Model Years (MY) 2014-2016, while MY 2017-2020 were considered peers.Based on related repair invoices, ODI believed the EPB module was damaged by water leaking into the vehicle. When the EPB inadvertently activates, it can cause a stalling condition bringing the vehicle to a stop. ODI was aware of recall 15V-393 that addresses water ingress affecting the power liftgate module on nearly the same population of vehicles subject of this investigation. The liftgate module can potentially catch fire as a result of the water damage. Both the liftgate and EPB modules are located in a similar area of the vehicle. On May 11, 2016, the manufacturer released a Technical Service Bulleting (ODI #10191415, FCA #08-060-16) that instructs dealers on replacing the EPB module and inspecting the electrical connector for corrosion if a customer describes having the EPB not releasing. This Preliminary Evaluation was opened to assess the scope, frequency, and safety-related consequences of the alleged defect. On September 8th, 2022, ODI sent an information request letter to Fiat Chrysler US LLC (FCA) requesting pertinent information on the subject 2014-2016 Jeep Cherokee and Peer 2017-2020 Jeep Cherokee vehicles. FCA Provided its full response on October 27th, 2022 after ODI granted a one-week extension. ODI has reviewed the information FCA provided as well as new reports submitted to NHTSA’s Vehicle Owner Questionnaire database. Based on a review of all available information, ODI has identified evidence supporting a total of 1,655 subject vehicles that likely experienced a failure of the subject EPB. Within the subject vehicle complaints, ODI identified the 2014 Model Year (MY) Jeep Cherokee as having the highest rate of failure, while also being the oldest group of vehicles in this investigation. The 2014 Jeep Cherokees that likely experienced a failure of the subject EPB represent an incident rate of approximately 0.58%. The average Time In Service (TIS) at failure was 2.6 years and the oldest failure occurred at 8.5 years in service. The 2014 population of vehicles is at 9 years in service. All other MY Jeep Cherokee vehicles (both subject and peer) within this investigation had significantly lower failure rates than the 2014 MY Jeep Cherokee. ODI has reviewed all the information available at this time, and identified four allegations of a crash, three allegations of injuries, and one allegation of a fire.Two of the crash allegations alleged injuries, and the alleged injuries were minor severity.All of the alleged injuries appeared to be consistent with hard braking and did not need medical attention. There was no supporting information that demonstrated a fire had occurred on the vehicle. In its response to ODI, FCA provided its assessment of the alleged defect in the subject vehicles, stating that it does not believe the alleged defect poses an unreasonable risk to motor vehicle safety. FCA states the majority of incidents involving the EPB inadvertently activating occurred while the vehicle was stationary and that a small number of incidents occurred while the vehicle was backing up or at low speeds. This is consistent with ODI’s observations. Based on the analysis conducted by ODI, this investigation will be closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. NHTSA reserves the right take additional actions if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.Read more

PE, Closed , Model Year: 2015

Engine compartment fire

On October 15, 2015, Fiat Chrysler Automobiles, US LLC, (FCA), submitted a Defect Information Report (DIR) to NHTSA regarding an air-conditioning suction/discharge combo line routing condition that may result in engine compartment fire in approximately 75,574 model year (MY) 2015 Jeep Cherokee vehic... les equipped with 2.4L engines and built from October 1, 2014 through June 18, 2015 (NHTSA Recall 15V-676, FCA Recall R57).According to FCA's DIR, a misrouted A/C combo line can be pinched and cut or thermally degraded by the exhaust manifold heat shield, potentially resulting in loss of air conditioning, smoke and/or fire from ignition of leaked A/C refrigerant oil onto a hot exhaust manifold.The recalled vehicles will be inspected for misrouted A/C combo lines and those found to be misrouted will be replaced.FCA estimates that one percent of the recalled population may be affected by the A/C combo line routing defect.ODI?s analysis of warranty data provided by FCA in response to the information request letter for PE15-003 identified a spike in claims related to the A/C combo line leakage in vehicles equipped with 2.4L engines built after October 1, 2014.FCA implemented its final process corrective action for the hose routing concern on June 18, 2015.The 113,034 MY 2015 Jeep Cherokee vehicles equipped with 3.2L engines have different A/C line routing configurations and are not affected by the A/C combo line routing defect.FCA provided a total of 220 warranty claims potentially related to the A/C combo line in vehicles equipped with 2.4L engines.Ninety-five percent of the claims (210) involved the 74,574 Jeep Cherokee 2.4L vehicles built during the recall period.Only 10 A/C combo line claims and no related fires were identified in the 28,250 Jeep Cherokee 2.4L vehicles that were built before or after the period with the hose routing concern.Analysis of engine compartment fires reported to ODI and FCA identified a total of 10 fires in MY 2015 Jeep Cherokee vehicles.Nine (9) of the fires involved vehicles equipped with 2.4L engines and 8 of these involved vehicles built during the production range subject to Recall 15V-676.These include 5 fires that FCA's investigations determined were most likely caused by the A/C combo line and 3 fires of unknown cause originating in the area of the exhaust manifold heat shield, resulting in fire incident rates in the recall population of 6.6 per 100,000 vehicles for the A/C combo line condition and 10.6 per 100,000 vehicles for fire incidents for which the A/C combo line could not be excluded as the cause.The other 2 engine compartment fires involved a low-mileage fire of unknown cause in a vehicle equipped with a 3.2L engine and a minor self-extinguished fire that FCA?s investigation attributed to a lower transmission oil cooler (TOC) line connection seepage condition in a rental vehicle equipped with a 2.4L engine and built prior to the recall production range. This preliminary evaluation is closed based on FCA?s recall.The following VOQ numbers are associated with the issues discussed in this closing resume: A/C combo line failure:10786287 Unknown cause:10712350, 10678215, 10672201Read more

EA, Closed , Model Year: 1993

Crash Related Fuel Tank Fires

ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fataliti... es and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen byRead more

DP, Closed , Model Year: 1991

SUDDEN ACCELERATION