2000 PLYMOUTH VOYAGER
8 recalls, 214 complaints - 70 TSBs
10E034000 Aug 10, 2010
EQUIPMENT
Defect Description
CURT MFG IS RECALLING CERTAIN CLASS 3 RECEIVER HITCHES, P/N 13347, SOLD AS AFTERMARKET EQUIPMENT FOR USE ON 1997-2007 CHRYSLER TOWN AND COUNTRY VANS, 1996-2007 DODGE CARAVANS, AND 1996-2004 PLYMOUTH VOYAGER VANS. WHEN THE HITCH IS LOADED TO THE MAXIMUM RATING, THE HITCH MAY FRACTURE OR BREAK AT THE... Read more
Consequence
IF THE AREA IN QUESTION FRACTURES OR BREAKS, THIS COULD CAUSE AN UNSTABLE DRIVING CONDITION, POSSIBLY RESULTING IN A CRASH.
Remedy
CURT MFG WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE THE HITCH FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING AUGUST 2010. OWNERS MAY CONTACT CURT MFG AT 1-715-831-8713.
07E104000 Dec 11, 2007
VISIBILITY:GLASS, SIDE/REAR
Defect Description
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDER... Read more
Consequence
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.
Remedy
SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER... Read more
06E091000 Nov 2, 2006
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Defect Description
CERTAIN AIRTEX FUEL PUMP MODULES, P/NOS. E7089M, E7094M, E7113M, AND E7129M, MANUFACTURED BETWEEN JUNE 1 AND SEPTEMBER 24, 2006. THESE FUEL PUMP MODULES WERE SOLD AS AFTERMARKET FOR USE IN CERTAIN DAIMLERCHRYSLER VEHICLES LISTED ABOVE. SILICONE MATERIAL USED IN MANUFACTURE OF THE FLAPPER VALVE WAS... Read more
Consequence
FUEL RESTRICTION COULD RESULT IN LOSS OF POWER AND/OR ENGINE STALL, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy
AIRTEX WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMP MODULES FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT AIRTEX TOLL-FREE AT 1-866-867-3759.
06E022000 Mar 13, 2006
SERVICE BRAKES, HYDRAULIC
Defect Description
CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE ... Read more
Consequence
LOSS OF BRAKE FLUID CAN LEAD TO A DECREASE IN BRAKE LINE PRESSURE AND AN INCREASE IN STOPPING DISTANCE, WHICH CAN RESULT IN A VEHICLE CRASH.
Remedy
AFFINIA (BRAKE PARTS, INC.) WILL REPLACE THE SUBJECT BRAKE HYDRAULIC MASTER CYLINDERS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS CAN CONTACT AFFINA GROUP CUSTOMER SERVICE AT 1-800-323-0354.
04V480000 Oct 6, 2004
AIR BAGS
Defect Description
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence
THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy
DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO... Read more
03E053000 Oct 24, 2003
FUEL SYSTEM, GASOLINE
Defect Description
CERTAIN AFTERMARKET REPLACEMENT FUEL FILTERS, MODELS WIX FILTER PART NUMBERS 33576, 33577, 33734; NAPA FILTER PART NUMBERS 3576, 3577, 3734; AND CARQUEST FILTER PART NUMBERS 86576, 86577, 86734 USED ON 1996-2000 DAIMLERCHRYSLER TOWN & COUNTRY, DODGE CARAVAN, AND PLYMOUTH VOYAGER VEHICLES, CAN CAUSE ... Read more
Consequence
A POSSIBLE FIRE CAN OCCUR IN THE PRESENCE OF AN IGNITION SOURCE.
Remedy
WIX WILL NOTIFY ITS CUSTOMERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. NOTE: THIS DOES NOT INVOLVE ANY PRODUCTS MANUFACTURED BY THE DAIMLERCHRYSLER CORP. NOR ANY DAILMERCHRYSLER DEALERS. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY... Read more
03E045000 Sep 26, 2003
EQUIPMENT
Defect Description
AFTERMARKET REPLACEMENT FUEL FILTERS MANUFACTURED BETWEEN SEPTEMBER 17, 2002, AND JANUARY 20, 2003, SOLD UNDER THE BRAND NAMES LISTED ABOVE. THE FILTER MAY EXPERIENCE MALFUNCTION OF THE QUICK CONNECTOR EITHER BLOCKING FUEL FLOW TO THE ENGINE OR CAUSING A FUEL LEAK. THIS DOES NOT INVOLVE ANY PRODU... Read more
Consequence
IF THIS CONDITION OCCURRED WHILE THE VEHICLE IS IN MOTION, THE ENGINE COULD STALL. ALSO, IN THE PRESENCE OF AN IGNITION SOURCE, THE FUEL LEAK COULD RESULT IN A VEHICLE FIRE.
Remedy
AFTERMARKET REPLACEMENT FUEL FILTERS FOR 1995-2000 SHORT WHEELBASE CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER AND DODGE CARAVAN MINIVANS PART NO. 18232 AND DATE CODE 0237, 0249, OR 0252. REPLACEMENT FUEL FILTERS FOR 1995-2000 LONG WHEELBASE CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER AND DODGE CARAV... Read more
00V268000 Sep 13, 2000
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
Defect Description
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence
FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy
DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOT... Read more
Complaint Statistics
214 total complaints
23 crashes 6 fires 23 injuries 1 deaths
Top Reported Components
| Component | Complaints |
|---|---|
| POWER TRAIN:AUTOMATIC TRANSMISSION | 17 |
| POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH | 13 |
| ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS | 9 |
| AIR BAGS | 8 |
| ENGINE AND ENGINE COOLING:ENGINE:GASOLINE | 8 |
| AIR BAGS:FRONTAL | 8 |
| VEHICLE SPEED CONTROL | 7 |
| SEAT BELTS | 6 |
| TIRES | 6 |
| EQUIPMENT:APPLIANCE:AIR CONDITIONER | 6 |
ELECTRICAL SYSTEM
Mar 3, 2020
Incident date: Mar 20, 2001
THE SERPENTINE BELT COMES OFF CAUSING THE POWER STEERING TO FAIL, AND THE ALTERNATOR NOT TO WORK. THIS HAS OCCURRED OFF AND ON SINCE THE VEHICLE WAS NEW. THIS FAILURE OCCURS IN MOTION WHEN THE STREETS ARE WET AND A BIT BUMPY.
STEERING
Mar 3, 2020
Incident date: Mar 20, 2001
THE SERPENTINE BELT COMES OFF CAUSING THE POWER STEERING TO FAIL, AND THE ALTERNATOR NOT TO WORK. THIS HAS OCCURRED OFF AND ON SINCE THE VEHICLE WAS NEW. THIS FAILURE OCCURS IN MOTION WHEN THE STREETS ARE WET AND A BIT BUMPY.
AIR BAGS
Nov 25, 2014
Incident date: Apr 13, 2014
TL* THE CONTACT OWNED A 2000 PLYMOUTH VOYAGER. WHILE DRIVING 30 MPH, THE DRIVER CRASHED INTO A WALL AND THE AIR BAGS FAILED TO DEPLOY. THE DRIVER WAS FATALLY INJURED. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 120,0... Read more
Crash
1 injured
1 deaths
SUSPENSION
Mar 13, 2013
Incident date: Mar 13, 2013
MY MINIVAN HAS A BADLY CORRODED DRIVER SIDE STRUT TOWER THAT CHRYSLER KNOWS IS A PRODUCT FLOW YET WILL NOT AUTHORISE REPAIRS TO. THIS PLACES ALL OWNERS FAMILIES AND THE GENERAL PUBLIC AT GRAVE DANGER WHEN THIS TOWER. *TR COLLAPSES FOR THE VEHICLE LOOSES STEERING AND THE WHEEL FALLS OFF. I FEEL A ... Read more
STEERING
Mar 13, 2013
Incident date: Mar 13, 2013
MY MINIVAN HAS A BADLY CORRODED DRIVER SIDE STRUT TOWER THAT CHRYSLER KNOWS IS A PRODUCT FLOW YET WILL NOT AUTHORISE REPAIRS TO. THIS PLACES ALL OWNERS FAMILIES AND THE GENERAL PUBLIC AT GRAVE DANGER WHEN THIS TOWER. *TR COLLAPSES FOR THE VEHICLE LOOSES STEERING AND THE WHEEL FALLS OFF. I FEEL A ... Read more
SUSPENSION
Oct 4, 2011
Incident date: Oct 4, 2011
DRIVER'S SIDE UPPER STRUT TOWER SHEET METAL RUSTED THROUGH - PASSENGER SIDE STRUT TOWER, LIKE NEW(NO RUST AT ALL) MANY OTHER LIKE VEHICLE COMPLAINTS FOUND ON INTERNET SEARCH. *TR
STEERING
Oct 4, 2011
Incident date: Oct 4, 2011
DRIVER'S SIDE UPPER STRUT TOWER SHEET METAL RUSTED THROUGH - PASSENGER SIDE STRUT TOWER, LIKE NEW(NO RUST AT ALL) MANY OTHER LIKE VEHICLE COMPLAINTS FOUND ON INTERNET SEARCH. *TR
STRUCTURE:BODY
Oct 4, 2011
Incident date: Oct 4, 2011
DRIVER'S SIDE UPPER STRUT TOWER SHEET METAL RUSTED THROUGH - PASSENGER SIDE STRUT TOWER, LIKE NEW(NO RUST AT ALL) MANY OTHER LIKE VEHICLE COMPLAINTS FOUND ON INTERNET SEARCH. *TR
ENGINE AND ENGINE COOLING
Jun 26, 2011
Incident date: Jun 25, 2011
OVER THE PAST 5 YEARS - SINCE THE REPLACEMENT MY SERPENTINE BELT ON MY 2000 CHRYSLER VOYAGER HAS POPPED OFF 4 OR 5 TIMES. SINCE OUR LOCAL DEALER IS NO LONGER HERE I HAD TO PAY $93.21 TODAY TO HAVE THE BELT PUT BACK. THE MECHANIC CHECKED THE BELT AND TENSIONER AND FOUND BOTH IN PRACTICALLY BRAND NEW ... Read more
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
Aug 26, 2010
Incident date: Jul 1, 2009
TL* THE CONTACT OWNS A 2000 CHRYSLER VOYAGER. THE ENGINE SERPENTINE BELT WAS REPLACED JULY 2009 WHEN THE VEHICLE WAS TAKEN TO THE GARAGE FOR ROUTINE MAINTENANCE. LESS THAN ONE MONTH LATER, THE SERPENTINE BELT FAILED. ONE MONTH LATER, THE BELT COMPLETELY FRACTURED FROM THE VEHICLE WHILE DRIVING 25 MP... Read more
STRUCTURE
Aug 4, 2010
Incident date: May 5, 2010
I OWN A 2000 CHRYSLER VOYAGER SE 3.3L. THE DRIVER'S SIDE STRUT TOWER HAD SEVERE RUST ALMOST TO THE POINT OF RUSTING COMPLETELY THROUGH. VEHICLE HAS APPROX 146K MILES. I WAS FORCED TO PAY A LOCAL BODY SHOP TO REPAIR THE DAMAGE AND INSTALL A NEW STRUT TOWER CAP. *TR
ENGINE AND ENGINE COOLING:ENGINE
Nov 17, 2009
Incident date: Oct 23, 2009
DURING A VERY HEAVY RAIN, I HIT A BIG PUDDLE WHICH CAUSED THE SERPENTINE BELT TO COME OFF THE PULLEYS. MY MECHANIC SAID IT IS A COMMON PROBLEM WITH THIS VEHICLE. THE RESULT IS NO POWER STEERING, NO ALTERNATOR TO CHARGE THE BATTERY AND NO WATER PUMP TO COOL THE ENGINE. I DROVE IT UNTIL THE TEMP GAUGE... Read more
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
Oct 26, 2009
Incident date: Oct 24, 2009
TL*THE CONTACT OWNS A 2000 CHRYSLER VOYAGER. WHILE DRIVING IN EXCESSIVE RAINY CONDITIONS, HE NOTICED THAT THE BATTERY LIGHT APPEARED ON THE DASHBOARD AND THE VEHICLE NO LONGER HAD POWER STEERING. THERE WERE NO PRIOR WARNINGS AND THE CURRENT AND FAILURE MILEAGES WERE 89000. UPDATED 12/07/09 *BF ... Read more
STRUCTURE:FRAME AND MEMBERS
Oct 26, 2009
Incident date: Oct 26, 2009
THE STRUT TOWERS OF 2000 CHRYSLER VOYAGER ARE COMPLETELY RUSTED OUT. IF THEY BREAK APART IT WILL LIKELY BREAK THROUGH THE HOOD OR WINDSHIELD CAUSING SERIOUS ACCIDENT AND OR INJURIES WE WERE TOLD BY BLOOMINGTON CHRYSLER (THE DEALERSHIP WHERE WE PURCHASED THE VEHICLE) IT WOULD BE $1000.00 TO REPAIR.... Read more
STRUCTURE:BODY
Oct 26, 2009
Incident date: Oct 26, 2009
THE STRUT TOWERS OF 2000 CHRYSLER VOYAGER ARE COMPLETELY RUSTED OUT. IF THEY BREAK APART IT WILL LIKELY BREAK THROUGH THE HOOD OR WINDSHIELD CAUSING SERIOUS ACCIDENT AND OR INJURIES WE WERE TOLD BY BLOOMINGTON CHRYSLER (THE DEALERSHIP WHERE WE PURCHASED THE VEHICLE) IT WOULD BE $1000.00 TO REPAIR.... Read more
TIRES
May 30, 2009
Incident date: May 30, 2009
FOUR TIRES TREAD SEPARATION ALL SAME TREAD WEAR DOUGLAS TIRE 215/70R14 I HAVE PHOTOS AVAILABLE OF TODAY'S TIRE AND WILL PHOTOGRAPH THE REMAINING TWO SERIAL NUMBERS AND CHECK FOR THE FOURTH AT THE WAL MART THAT REPLACED IT. PROPERTY DAMAGE WAS NEGLIGIBLE BUT I WAS PREPARED FOR THE TIRE FAILURE I ROT... Read more
SUSPENSION:FRONT
May 27, 2009
Incident date: May 27, 2009
TSB #2304402 AND NHTSA #10000317: I HAVE THIS PROBLEM OF A RUSTED OUT STRUT TOWER. MY MECHANIC INFORMED ME THAT IT COULD BE DANGEROUS TO DRIVE. ALTHOUGH THIS IS A COMMON PROBLEM FOR 1996 - 2000 MINIVANS FOR ALL THREE CHRYSLER MODELS DURING THOSE YEARS, THERE IS NO RECALL BY THE MANUFACTURER, AND T... Read more
STRUCTURE:FRAME AND MEMBERS
May 27, 2009
Incident date: May 27, 2009
TSB #2304402 AND NHTSA #10000317: I HAVE THIS PROBLEM OF A RUSTED OUT STRUT TOWER. MY MECHANIC INFORMED ME THAT IT COULD BE DANGEROUS TO DRIVE. ALTHOUGH THIS IS A COMMON PROBLEM FOR 1996 - 2000 MINIVANS FOR ALL THREE CHRYSLER MODELS DURING THOSE YEARS, THERE IS NO RECALL BY THE MANUFACTURER, AND T... Read more
ENGINE AND ENGINE COOLING
Dec 28, 2008
Incident date: Dec 11, 2008
I HAVE A 2000 CHRYSLER MINI VAN AND MY SERPENTINE BELT KEEPS COMING OFF WHEN IT RAINS. THIS HAS HAPPENED 4 TIMES IN ONE YEAR. THEY HAVE REPLACED THE BELT AND FIXED THE TENSIONER ITS IN THE SHOP RIGHT NOW AND WAITING FOR A BELT KIT TO FIX THE PROBLEM (GATES SYSTEM KIT). WHY ISN'T THERE A RECALL O... Read more
TIRES
Nov 10, 2008
Incident date: Sep 1, 2008
MY MOTHER, BROTHER, AND I WERE ON AN EMERGENCY TRIP TO ARKANSAS IN THE MIDDLE OF THE NIGHT ON 09/01/08. WE HAD JUST GONE THROUGH KANSAS CITY, MO WHEN MY BROTHER (WHO WAS DRIVING AT THE TIME) LOST CONTROL OF MY 2000 PLYMOUTH VOYAGER VAN AND WAS ABLE TO GET THE VAN OFF TO THE SIDE OF THE INTERSTATE. ... Read more
WHEELS
Nov 3, 2008
Incident date: Nov 3, 2008
MY SON WAS DRIVING OUR MINIVAN 2000 VOYAGER AND THE FACTORY WHEEL OR RIM CRACKED INTO TWO HALVES DAMAGING THE TIRE BY CUTTING THE SIDE WALL. I AM NOT SURE THE OTHER THREE RIMS ARE SAFE. *TR
SUSPENSION:FRONT
Oct 30, 2008
Incident date: Oct 30, 2008
JUST INFORMED FROM MECHANIC THAT MY FRONT STRUT TOWERS ARE RUSTED THROUGH. DRIVER SIDE IS COMPLETED ROTTED AWAY AND PASSENGER SIDE SHOULD HAPPEN AFTER THIS WINTER. MY 2000 PLYMOUTH VOYAGER HAS UNDER 60,000MILE AND HAS ONLY 2 OWNERS. I HAVE RESEARCHED THAT THIS IS WAY TOO FREQUENT IN VOYAGERS FROM ... Read more
SUSPENSION:FRONT
Aug 27, 2008
Incident date: Jul 27, 2008
RUST HAS BEEN DEVELOPING ON TOP OF THE DRIVERS SIDE FRONT RUST TOWER FOR SEVERAL YEARS. HAVING JUST TAKEN AUTO CLASSES BECAME AWARE THAT THIS IS A PROBLEM THAT AFFECTS SAFETY. DEALERS HAVE NOT MENTIONED IT IN THE PAST (WHILE UNDER RUST PROTECTION WARRANTY). THE CAR IS RUNNING FINE PRESENTLY, BUT ... Read more
SERVICE BRAKES, HYDRAULIC
Aug 24, 2008
Incident date: Jul 1, 2008
ON 11/05 THE DEALER REPLACED THE MASTER CYLINDER BECAUSE IT WAS LEAKING. I NOW NOTICE IT IS LEAKING AGAIN. THE FIRE WALL IS ALL RUSTED, I DON'T KNOW WHAT DAMAGE IS BEING DONE FROM THE FLUID DRIPPING DOWN. *TR
AIR BAGS
Feb 27, 2008
Incident date: Feb 20, 2008
AIRBAG LIGHT STAYS ON HORN DOES NOT WORK BAD STRUTS, LOUD STRUTS SOUNDS. *TR
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
Jan 7, 2008
Incident date: May 17, 2003
SERPENTINE BELT COMES OFF WHILE DRIVING IN OR AFTER A RAIN OR AFTER SNOW MELTS, WET ROAD CONDITIONS. THIS BELT CONTROLS THE POWER STEERING AND IS ALMOST IMPOSSIBLE TO STEER, EXCEPT STRAIGHT. THE FEMALES IN MY FAMILY CAN NOT CONTROL THIS VEHICLE. *TR
ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
Nov 1, 2007
Incident date: Apr 1, 2007
TL*THE CONTACT OWNS A 2000 CHRYSLER VOYAGER. WHILE DRIVING 15 MPH, THE FAN BELT DISENGAGED WHEN DRIVING THROUGH A PUDDLE OF WATER. THE VEHICLE LOST POWER. THE DEALER REPLACED THE FAN BELT. THE FAILURE OCCURRED ON TWO OCCASIONS. THE DEALER STATED THAT THE WATER WOULD CAUSE THE FAN BELT TO HYDROP... Read more
AIR BAGS:FRONTAL
Oct 10, 2007
Incident date: Oct 9, 2007
TL*THE CONTACT OWNS A 2000 CHRYSLER VOYAGER. WHILE DRIVING 25 MPH, THE FRONT AIR BAGS DEPLOYED WITHOUT WARNING OR AN IMPACT. A POLICE REPORT WAS FILED. THE DRIVER WAS RUSHED TO THE EMERGENCY ROOM BECAUSE HIS EYES WERE BURNING AND HIS VISION WAS LIMITED. THE VEHICLE WAS TOWED TO HIS RESIDENCE. T... Read more
1 injured
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
Jul 20, 2007
Incident date: Jul 15, 2007
SERPENTINE BELT REPEATEDLY COMES OFF. REPLACING IDLER PULLEY, TENSIONER PULLEY, AND BELT REMEDIES THE SITUATION FOR 6 MONTHS OR SO. THE PROBLEM IS SO PROMINENT IN OTHER VEHICLES WITH THE SAME ENGINE THAT GATES AND GOODYEAR SELL A KIT THAT WILL PERMANENTLY FIX CHRYSLER'S GOOF UP. FAILURE RESULTS I... Read more
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
Apr 6, 2007
Incident date: Apr 7, 2003
TL*THE CONTACT OWNS A 2000 PLYMOUTH VOYAGER. WHEN THE ROADS WERE WET AND THE CONTRACT DROVE THROUGH STANDING WATER THE SERPENTINE BELT WOULD SLIP OFF THE VEHICLE. THE FAILURE MILEAGE WAS 39876. THE VEHICLE WAS TOWED TO A DEALER FOUR TIMES, AND THE DEALER REPLACED THE BELT. HOWEVER, HE COULD N... Read more
VEHICLE SPEED CONTROL
Feb 15, 2007
Incident date: Feb 15, 2007
TL*- THE CONTACT CALLED REGARDING THE 2000 PLYMOUTH VOYAGER. THE CONTACT STATED THAT THE VEHICLE WAS INVOLVED IN A RECALL FOR THE CLOCK SPRING. AFTER THE RECALL REPAIR WAS DONE THE HORN STOPPED WORKING, AND THE VEHICLE DID NOT HAVE POWER WHEN ACCELERATING. THE CONTACT TOOK THE VEHICLE BACK TO ... Read more
ELECTRICAL SYSTEM:HORN
Feb 15, 2007
Incident date: Feb 15, 2007
TL*- THE CONTACT CALLED REGARDING THE 2000 PLYMOUTH VOYAGER. THE CONTACT STATED THAT THE VEHICLE WAS INVOLVED IN A RECALL FOR THE CLOCK SPRING. AFTER THE RECALL REPAIR WAS DONE THE HORN STOPPED WORKING, AND THE VEHICLE DID NOT HAVE POWER WHEN ACCELERATING. THE CONTACT TOOK THE VEHICLE BACK TO ... Read more
AIR BAGS
Feb 15, 2007
Incident date: Feb 15, 2007
TL*- THE CONTACT CALLED REGARDING THE 2000 PLYMOUTH VOYAGER. THE CONTACT STATED THAT THE VEHICLE WAS INVOLVED IN A RECALL FOR THE CLOCK SPRING. AFTER THE RECALL REPAIR WAS DONE THE HORN STOPPED WORKING, AND THE VEHICLE DID NOT HAVE POWER WHEN ACCELERATING. THE CONTACT TOOK THE VEHICLE BACK TO ... Read more
SUSPENSION
Nov 6, 2006
Incident date: Oct 27, 2006
DT*: THE CONTACT STATED WHEN THE VEHICLE WAS TAKEN IN FOR A STATE INSPECTION; THE MECHANIC NOTICED THE DRIVER SIDE STRUT TOWER WAS BADLY CORRODED. THE MECHANIC EXPRESSED THAT THE VEHICLE WOULD PROBABLY NOT PASS INSPECTION THE NEXT TIME. THE VEHICLE WAS TAKEN TO THE DEALER, WHO CONTACTED THE MANUFA... Read more
STRUCTURE:FRAME AND MEMBERS
Nov 6, 2006
Incident date: Oct 27, 2006
DT*: THE CONTACT STATED WHEN THE VEHICLE WAS TAKEN IN FOR A STATE INSPECTION; THE MECHANIC NOTICED THE DRIVER SIDE STRUT TOWER WAS BADLY CORRODED. THE MECHANIC EXPRESSED THAT THE VEHICLE WOULD PROBABLY NOT PASS INSPECTION THE NEXT TIME. THE VEHICLE WAS TAKEN TO THE DEALER, WHO CONTACTED THE MANUFA... Read more
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
Jul 13, 2006
Incident date: Jul 2, 2006
FAILURE OF IDLER PULLEY ON MOTOR CAUSING MAJOR REPAIRS, DESTROYING NEW TIMING BELT,TENSIONER PULLEY DAMAGE TO TRANSMISSION, SPARK PLUGS AND OTHER DAMAGE AND A $500 TOWING BILL ACROSS STATE. VAN IS STILL IN SHOP AFTER 2 WEEKS AND MECHANIC SAYS NEW PART LOOKS DIFFERENT AS IF OLD DESIGN WAS BAD AND CHA... Read more
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
Jul 13, 2006
Incident date: Jul 12, 2006
DT*: THE CONTACT STATED WHILE DRIVING THROUGH A RESIDENTIAL AREA IN RAINY WEATHER, THERE WAS A LOSS OF STEERING WITHOUT WARNING. THE VEHICLE WAS PULLED OVER AND INSPECTED. THERE WAS EXTREME HEAT PRESENT UNDER THE HOOD AREA. IT WAS TOWED TO AN INDEPENDENT REPAIR SHOP FOR FURTHER INSPECTION. THE ... Read more
SEAT BELTS
Jun 12, 2006
Incident date: Nov 20, 2005
MY HUSBAND WAS INSTALLING MY SON'S CAR SEAT. WHEN HE GRABBED THE SHAFT OF THE SEAT BELT (THE PART ATTACHED TO THE FLOOR), IT CAME COMPLETELY OUT. APPARENTLY THE METAL PART THAT IS ATTACHED TO THE SEAT IS COMPLETELY GONE. THE DEALERSHIP IS TELLING ME I'M RESPONSIBLE FOR BUYING A NEW SEAT BECAUSE MY W... Read more
SUSPENSION:FRONT:MACPHERSON STRUT
Mar 3, 2006
Incident date: Feb 24, 2006
DT*: THE CONTACT STATED WHILE DRIVING, THERE WAS A NOISE IN THE FRONT END. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP AND IT WAS DETERMINED THE DRIVER SIDE STRUT TOWER RUSTED THROUGH. THE VEHICLE WAS THEN TAKEN TO AN AUTO BODY SHOP WERE THE STRUT TOWER WAS REWELDED. UPDATED 03/22/06. *... Read more
SUSPENSION:FRONT:MACPHERSON STRUT
Feb 10, 2006
Incident date: Feb 8, 2006
FRONT LEFT STRUT TOWER CORROSION, IT IS RUSTING BADLY AND COULD FAIL AT HIGH SPEEDS. THERE WAS A TSB A FEW YEARS AGO #23-044-02. I BELIEVE THAT BECAUSE OF THIS DEFECT THAT AFFECTS 1996-2000 MINI VANS MY FAMILY IS IN DANGER. *NM
SUSPENSION:FRONT:MACPHERSON STRUT
Jan 30, 2006
Incident date: Jan 27, 2006
LEFT STRUT TOWER HEAD IS RUSTING THROUGH AND REQUIRES REPAIR AT 89,000 MILES, 6 YEARS IN USE. I JUST NOTICED IT WHILE HOOD OPEN FOR OTHER SERVICE.*AK
EXTERIOR LIGHTING:HEADLIGHTS
Nov 9, 2005
Incident date: Nov 10, 2001
YEAR 2000 PLYMOUTH VOYAGER MINIVAN. EXTREMELY DIM/POOR HEADLIGHTS. DANGEROUS TO DRIVE AT NIGHT. NO REMEDY TO SITUATION. *NM
ELECTRICAL SYSTEM:WIRING
Sep 26, 2005
Incident date: Sep 22, 2005
PURCHASED 2000 CHRYSLER VOYAGER MINIVAN FROM DAVID STANLEY DODGE IN MIDWEST CITY, OK. ON SEPTEMBER 22, 2005, THE VEHICLE CAUGHT ON FIRE IN THE INSIDE OF THE VEHICLE, IN THE REAR NEAR THE SPEAKER COMPARTMENT. LUCKILY THE FIRE EXTINGUISHED ITSELF AND NO FURTHER DAMAGE TO THE VEHICLE OTHER THAN THE SPE... Read more
Fire
SEAT BELTS:REAR/OTHER
Sep 20, 2005
Incident date: Sep 20, 2005
REAR SEAT BELTS DO NOT CATCH (STOP LETTING OUT BELT) WHEN BRAKE APPLIED. THIS IS AN ISSUE CAUGHT AS PART OF A MASSACHUSETTS MANDATORY YEARLY INSPECTION WHICH CAUSE THE VEHICLE TO FAIL. CHRYSLER DEALERSHIP HAS INDICATED IT CAN BE FIXED FOR A CHARGE OF AT LEAST $82. *NM
ELECTRICAL SYSTEM
Sep 9, 2005
Incident date: Aug 5, 2005
MY VEHICLE HIT THE REAR OF A JEEP CHEROKEE AT APPROX. 10 MPH. I STOPPED AND EXITED THE VEHICLE TO LOOK AT THE DAMAGE AND FOUND PRACTICALLY NOTHING. THE ENGINE COMPARTMENT THEN BURST INTO FLAMES AND DESTROYED THE ENTIRE FRONT OF THE VAN. I DO NOT KNOW WHAT CAUSED THE FIRE, BUT I THOUGHT I SHOULD REP... Read more
Crash
Fire
POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES
Aug 5, 2005
Incident date: May 6, 2005
CHRYSLER/PLYMOUTH/DODGE DEALER REPLACED TRANSMISSION COOLING HOSES AND CLAMPS USING CLAMPS AS PER CHRYSLER SERVICE BULLETIN 07-006-1. NHTSA TECHNICAL SERVICE BULLETIN 632201 REFERS. CLAMP PART NUMBER 04596424AA CAME LOSE WHILE TRAVELING ON I-65 GOING THROUGH LOUISVILLE,KY CAUSING THE AUTO TO STAL... Read more
UNKNOWN OR OTHER
May 23, 2005
Incident date: May 20, 2005
I RETURNED TO THE VAN AFTER GROCERY SHOPPING, GOT IN AND BUCKLED MY SEAT BELT. I TURNED ON THE IGNITION AND PLACED THE VAN IN REVERSE TO BACK OUT OF THE HANDICAP PARKING SPOT CLOSEST TO THE STORE. BEFORE I COULD REACT, THE ENGINE BEGAN TO RACE AT HIGH SPEED SENDING ME AND THE VAN BACKWARDS! I WAS... Read more
Crash
1 injured
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
May 21, 2005
Incident date: May 19, 2005
I BOUGHT THE VAN USED IN LATE SEPT. 2002 WITH 22,000 MILES ON IT. DID NOT BUY EXT. WARRANTY. BY THE TIME I USED THE 1.AC IN THE SPRING IT DIDN'T WORK, WARRANTY WAS EXPIRED. REPLACED COMPRESSOR, NOT AT THE DEALER, THEN FOUND OUT EVAPORATOR WAS BAD TOO. NO MORE MONEY,STILL DRIVING WITH NO AC. 2. H... Read more
SERVICE BRAKES, AIR:ANTILOCK:ABS WARNING LIGHT
May 21, 2005
Incident date: May 19, 2005
I BOUGHT THE VAN USED IN LATE SEPT. 2002 WITH 22,000 MILES ON IT. DID NOT BUY EXT. WARRANTY. BY THE TIME I USED THE 1.AC IN THE SPRING IT DIDN'T WORK, WARRANTY WAS EXPIRED. REPLACED COMPRESSOR, NOT AT THE DEALER, THEN FOUND OUT EVAPORATOR WAS BAD TOO. NO MORE MONEY,STILL DRIVING WITH NO AC. 2. H... Read more
ELECTRICAL SYSTEM:HORN
May 21, 2005
Incident date: May 19, 2005
I BOUGHT THE VAN USED IN LATE SEPT. 2002 WITH 22,000 MILES ON IT. DID NOT BUY EXT. WARRANTY. BY THE TIME I USED THE 1.AC IN THE SPRING IT DIDN'T WORK, WARRANTY WAS EXPIRED. REPLACED COMPRESSOR, NOT AT THE DEALER, THEN FOUND OUT EVAPORATOR WAS BAD TOO. NO MORE MONEY,STILL DRIVING WITH NO AC. 2. H... Read more
Showing 50 of 214 complaints.
Technical Service Bulletins, 2000 PLYMOUTH VOYAGER
70 manufacturer communications from 66 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 061000 ENGINE AND ENGINE COOLING:ENGINE | 5 |
| 350000 EQUIPMENT | 5 |
| 160000 STRUCTURE | 5 |
| 110000 ELECTRICAL SYSTEM | 4 |
| 162000 STRUCTURE:BODY | 4 |
| 103000 POWER TRAIN:AUTOMATIC TRANSMISSION | 3 |
| 220000 SEATS | 3 |
| 034400 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM | 3 |
9004275
Jul 22, 2020
116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehi
9004275
Jul 22, 2020
116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehi
08-049-20
Apr 22, 2020
350000 EQUIPMENT
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are nece
08-049-20
Apr 22, 2020
110000 ELECTRICAL SYSTEM
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are nece
3100319
Nov 20, 2019
160000 STRUCTURE
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
3100519
Nov 20, 2019
160000 STRUCTURE
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
3100619
Nov 20, 2019
350000 EQUIPMENT
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
3100619
Nov 20, 2019
160000 STRUCTURE
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
31-005-19
Nov 20, 2019
350000 EQUIPMENT
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
31-005-19
Nov 20, 2019
160000 STRUCTURE
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
31-003-19
Nov 20, 2019
350000 EQUIPMENT
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
31-006-19
Nov 20, 2019
160000 STRUCTURE
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
R2118796A
Feb 26, 2016
060000 ENGINE AND ENGINE COOLING
Valve Body. These may cause over drive cycling.
9002519
Mar 20, 2013
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
0500106A
Sep 23, 2006
040000 SERVICE BRAKES, AIR
SNOW/WATER INGESTION INTO REAR BRAKE DRUM. *KB
0500305
Mar 9, 2006
034400 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM
SNOW/WATER INGESTION INTO REAR BRAKE DRUM. *TT
0500204
Jun 21, 2005
034400 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM
SNOW/WATER INGESTION INTO REAR BRAKE DRUM. *TT
1900303
Aug 29, 2003
010000 STEERING
POP/TICK SOUND IN STEERING WHEEL AREA. *TT
2304402
Oct 14, 2002
162000 STRUCTURE:BODY
COSMETIC CORROSION OR PERFORATION AT UPPER STRUT TOWER/S USUALLY BETWEEN THE STRUT AND UPPER LOAD PATH BEAM INNER PANEL (INNER FENDER). *TT
0500102A
Sep 23, 2002
034400 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM
SNOW/WATER INGESTION INTO REAR BRAKE DRUM. *YD THIS BULLETIN SUPERSEDES 05-001-02 DATED MARCH 4, 2002. *TT
0801102
Aug 19, 2002
140000 AIR BAGS
CONCERNS WITH THE AIR BAG WARNING INDICATOR LAMP ON INTERMITTENTLY OR CONSTANTLY. *TT
1802002
Jun 24, 2002
980000 UNKNOWN OR OTHER
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
2301502
Apr 1, 2002
135200 VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *SLC
1900801
Nov 23, 2001
011000 STEERING: STEERING WHEEL/HANDLE BAR
EXPERIENCING A POP/TICK SOUND HEARD COMING FROM THE STEERING WHEEL AREA WHILE THE VEHICLE IS IN MOTION. *TT
0700601
Nov 11, 2001
103600 POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES
SUBJECT REGARDING TRANSMISSION OIL COOLER LINE HOSE CLAMP SERVICE. *TT
0900801
Nov 2, 2001
061000 ENGINE AND ENGINE COOLING:ENGINE
SUBJECT REGARDING CAMSHAFT / BEARING SERVICE. *TT
2302701
Sep 21, 2001
135200 VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *TT
0200401
Jul 6, 2001
021000 SUSPENSION:FRONT
EXPERIENCING A SQUAWK / CREAK / GROAN SOUND FROM FRONT SUSPENSION WHILE DRIVING OVER ROUGH / BUMPY ROADS. *TT
1801201
May 25, 2001
350000 EQUIPMENT
SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. *TT
0801001
May 25, 2001
110000 ELECTRICAL SYSTEM
SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT
0500301
Apr 20, 2001
034500 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC
A CONDITION MAY EXIST WHERE A LOW FREQUENCY HOWL / MOAN NOISE IS HEARD FROM THE REAR BRAKE AREA DURING LOW SPEED AND / OR LOW SPEED TURNS SUCH AS A PARKING LOT MANEUVER, WITH NO BRAKE PEDAL PRESSURE APPLIED. *TT
2600401
Apr 1, 2001
980000 UNKNOWN OR OTHER
SUBJECT REGARDING SERVICE / DIAGNOSTIC MANUAL REVISIONS. *TT
2100601
Mar 16, 2001
103000 POWER TRAIN:AUTOMATIC TRANSMISSION
AUTOMATIC TRANSMISSION FLUID USAGE ATF+4. *TT *MJ
0500101
Feb 9, 2001
034430 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:DRUM
ON SOME VEHICLES, WHILE DRIVING THROUGH DEEP OR BLOWING SNOW / WATER, THE SNOW / WATER MAY ENTER THE REAR BRAKE DRUMS CAUSING RUST TO DEVELOP ON THE REAR BRAKE DRUM AND SHOE FRICTION SURFACES. THIS CONDITION CAN LEAD TO TEMPORARY FREEZI
0800600REV
Dec 29, 2000
110000 ELECTRICAL SYSTEM
SUBJECT REGARDING WIRE SPLICE REPAIRS. *SB
2303400A
Dec 15, 2000
135000 VISIBILITY:REARVIEW MIRRORS/DEVICES
SUBJECT REGARDING OUTSIDE MIRROR GLASS REPLACEMENT. *TT
2601200
Dec 1, 2000
980000 UNKNOWN OR OTHER
INFORMATION ON SERVICE PUBLICATION UPDATES. *JB
2300800B
Nov 24, 2000
220000 SEATS
SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT
2304200
Nov 3, 2000
162300 STRUCTURE:BODY:DOOR
EXPERIENCING A CHATTER SOUND COMING FROM THE SLIDING DOOR POWER LOCK ACTUATOR(S) WHEN THE POWER LOCK FEATURE IS REPEATEDLY ACTIVATED. *TT
2601000
Oct 1, 2000
070000 FUEL SYSTEM, GASOLINE
INFORMATION REGARDING UPDATES TO THE FUEL SYSTEM SERVICE PROCEDURES. *TT
082700
Sep 29, 2000
140000 AIR BAGS
SUBJECT REGARDING NON-DEPLOYED AIRBAG HANDLING PROCEDURES. *TT
180300
Jun 2, 2000
063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
SUBJECT REGARDING EGR MONITOR DIAGNOSTIC TEST DIFFICULT TO COMPLETE OR NOT READY AT HIGH ALTITUDES (ABOVE 4000 FEET). *TT
081500
Apr 21, 2000
110000 ELECTRICAL SYSTEM
A CONDITION MAY EXIST WHERE THERE IS INTERMITTENT OPERATION / STATIC OCCURING IN THE FRONT INSTRUMENT PANEL SPEAKERS. *TT
231100A
Apr 7, 2000
162000 STRUCTURE:BODY
A CONDITION EXIST WHERE THE ROOF PANEL SURFACE EXHIBITS WAVINESS OR DEPRESSION(S) NEAR THE FRONT OF THE CHARACTER FEATURES OR SKID STRIP FOR ROOF RACK EQUIPPED VEHICLES. *TT
0016
Apr 3, 2000
106000 POWER TRAIN:AXLE ASSEMBLY
SOME VEHICLES MAY EXPERIENCE DELAYED TRANSAXLE ENGAGEMENT ON A COLD START. *TT
220100
Mar 24, 2000
198000 TIRES:TEMPORARY/EMERGENCY SPARE TIRE
INFORMATION ON SPARE TIRE WINCHES. *TT
231100
Mar 24, 2000
162000 STRUCTURE:BODY
THIS BULLETIN CONTAINS PROCECURES TO REMOVE WAVINESS OR DEPRESSIONS FROM THE ROOF PANEL SURFACE. *TT
090600
Mar 10, 2000
061000 ENGINE AND ENGINE COOLING:ENGINE
SUBJECT PERTAINS TO CHANGES TO THE TIMING BELT TENSIONER COMPONENTS. *TT
230800
Mar 3, 2000
220000 SEATS
SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT
856
Mar 1, 2000
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
SUBJECT REGARDING THE OWNER'S MANUAL CONTAINS A STATEMENT THAT WAS INCLUDED INADVERTENTLY. THIS STATEMENT INDICATES THAT THE MENTIONED VEHICLES ARE EQUIPPED WITH A BRAKE / TRANSMISSION INTERLOCK. THIS IS INCORRECT. THE VEHICLE IS
080600
Feb 25, 2000
114000 ELECTRICAL SYSTEM:WIRING
THIS BULLETIN PROVIDES A REVISED WIRE SPLICE PROCEDURE AND RELATED PARTS. *TT
020300
Feb 25, 2000
020000 SUSPENSION
EXPERIENCING A KNOCKING / CLUNKING SOUND COMING FROM THE FRONT SWAY BAR LINK HEARD INSIDE AND OUTSIDE THE VEHICLE WHEN DRIVING OVER ROUGH ROADS. *TT
190999
Feb 11, 2000
010000 STEERING
A CONDITION WHERE A CLICK / RATTLE SOUND MAY BE HEARD COMING FROM THE AREA OF THE STEERING WHEEL WHILE THE VHICLE IS IN MOTION. *TT
180100
Feb 4, 2000
061000 ENGINE AND ENGINE COOLING:ENGINE
SUBJECT REGARDING MISDIAGNOSED LEAK DETECTION PUMP SYSTEMS WITH DIAGNOSTIC TROUBLE CODES P1494, P0442 P0455, OR P0456. *TT
180200
Feb 4, 2000
061000 ENGINE AND ENGINE COOLING:ENGINE
CONCERNS WITH THE PCV VALVE FREEZING UNDER EXTREMELY COLD CONDITIONS. *TT
051099
Jan 31, 2000
034430 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:DRUM
INFORMATION REGARDING SNOW / WATER ENTERING THE REAR BRAKE DRUMS. *TT
084599
Dec 31, 1999
353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
VEHICLE OPERATOR MAY COMPLAIN OF POOR AM RADIO RECEPTION. *TT
083799
Nov 12, 1999
145000 AIR BAGS:ON-OFF SWITCH ASSEMBLY
DAIMLERCHRYSLER CORPORATION IS NOW OFFERINB AIRBAG ON / OFF SWITCHES FOR SELECTED VEHICLES. *TT
050999
Nov 5, 1999
051100 PARKING BRAKE:CONVENTIONAL:MECHANICAL
INFORMATION ON REAR WHEEL PARK BRAKE ACTUATOR / LEVER SERVICE. *TT
211899
Nov 5, 1999
103700 POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER
INFORMATION REGARDING TORQUE CONVERTER BREAK IN IMPLEMENTED TO ELIMINATE EARLY MILEAGE SHUDDER CONCERNS. *TT
211699
Oct 22, 1999
103000 POWER TRAIN:AUTOMATIC TRANSMISSION
NEW AUTOMATIC TRANSMISSION FLUID USAGE (ATF +4 TYPE 9602). *MJS
847
Oct 1, 1999
355100 EQUIPMENT:OTHER:LABELS
SUBJECT REGARDING CANADIAN VEHICLE EMISSION CONTROL INFORMATION (VECI) LABEL INADVERTENTLY INSTALLED ON ABOUT 300 FEDERAL EMISSION CONTROL VEHICLES. *TT
233599REVA
Oct 1, 1999
162000 STRUCTURE:BODY
SUBJECT ON THE CHILD SEAT TETHER ANCHORS. *MJS
190699
Sep 17, 1999
116100 ELECTRICAL SYSTEM:IGNITION:SWITCH
INFORMATION REGARDING THE IGNITION SWITCH HOUSING SERVICE. *TT
090899
Sep 17, 1999
061000 ENGINE AND ENGINE COOLING:ENGINE
TECHNICAL SERVICE BULLETIN REGARDING MULTI-LAYER STEEL (MLS) HEAD GASKET INSTALLATION PROCEDURES. *TT
233599
Sep 3, 1999
220000 SEATS
INFORMATION ON CHILD SEAT TETHER ANCHORS. *TT
210599A
Sep 3, 1999
103000 POWER TRAIN:AUTOMATIC TRANSMISSION
THIS BULLETIN ANNOUNCES THE AVAILABILITY AND INSTALLATION OF A RESUABLE AUTOMATIC TRANSMISSION OIL PAN GASKET. *TT
082799
Aug 27, 1999
180000 VEHICLE SPEED CONTROL
CONCERNS WITH SPEED CONTROL WHICH DOES NOT MAINTAIN SET SPEED WHILE CLIMBING A GRADE. *TT
140399
Aug 27, 1999
181000 VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
EXPERIENCING VIBRATION / BUZZ IN THE ACCELERATOR PEDAL AT 2200 - 2500 RPM AND ABOVE 3500 RPM. *TT
233399
Aug 13, 1999
162300 STRUCTURE:BODY:DOOR
CONCERNS WITH THE RIGHT SIDE SLIDING DOOR TRIM PANEL CONTACTING THE QUARTER PANEL WHEN THE DOOR IS OPENED. *TT
NHTSA Safety Investigations, PLYMOUTH VOYAGER
Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.
PE88080
Opened: Jun 30, 1988 , Closed: Apr 5, 1989
FRNT COIL SPRNG FRACTURE
There is no summary currently available
DP87008
Opened: Dec 9, 1986 , Closed: Jan 5, 1987
ENGINE FIRE
ENGINE FIRE
PLYMOUTH VOYAGER - All Years Overview
Complete safety history for the PLYMOUTH VOYAGER across all model years (1978, 2000).
132
Total Recalls
6,868
Total Complaints
2
Investigations
502
Reported Crashes
190
Reported Fires
24
Reported Deaths
PLYMOUTH VOYAGER - Year by Year
Compare recalls and complaints across model years. Click any year to see full details.
| Year | Recalls | Complaints | |
|---|---|---|---|
| 2000 (current) | 8 | 214 | |
| 1999 | 10 | 362 | View |
| 1998 | 11 | 443 | View |
| 1997 | 11 | 474 | View |
| 1996 | 15 | 1,111 | View |
| 1995 | 4 | 476 | View |
| 1994 | 5 | 670 | View |
| 1993 | 10 | 749 | View |
| 1992 | 11 | 893 | View |
| 1991 | 10 | 624 | View |
| 1990 | 6 | 270 | View |
| 1989 | 5 | 204 | View |
| 1988 | 5 | 109 | View |
| 1987 | 3 | 99 | View |
| 1986 | 4 | 80 | View |
| 1985 | 6 | 38 | View |
| 1984 | 6 | 23 | View |
| 1983 | 1 | 7 | View |
| 1980 | 0 | 1 | View |
| 1978 | 1 | 1 | View |