1998 PLYMOUTH VOYAGER

11 recalls, 443 complaints - 123 TSBs

EQUIPMENT

Defect Description

CURT MFG IS RECALLING CERTAIN CLASS 3 RECEIVER HITCHES, P/N 13347, SOLD AS AFTERMARKET EQUIPMENT FOR USE ON 1997-2007 CHRYSLER TOWN AND COUNTRY VANS, 1996-2007 DODGE CARAVANS, AND 1996-2004 PLYMOUTH VOYAGER VANS. WHEN THE HITCH IS LOADED TO THE MAXIMUM RATING, THE HITCH MAY FRACTURE OR BREAK AT THE... Read more

Consequence

IF THE AREA IN QUESTION FRACTURES OR BREAKS, THIS COULD CAUSE AN UNSTABLE DRIVING CONDITION, POSSIBLY RESULTING IN A CRASH.

Remedy

CURT MFG WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE THE HITCH FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING AUGUST 2010. OWNERS MAY CONTACT CURT MFG AT 1-715-831-8713.

6,686 vehicles affected

Manufacturer: CURT MFG. INC.

VISIBILITY:GLASS, SIDE/REAR

Defect Description

CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDER... Read more

Consequence

IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.

Remedy

SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER... Read more

1,657 vehicles affected

Manufacturer: SAFELITE FULFILLMENT, INC.

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Defect Description

CERTAIN AIRTEX FUEL PUMP MODULES, P/NOS. E7089M, E7094M, E7113M, AND E7129M, MANUFACTURED BETWEEN JUNE 1 AND SEPTEMBER 24, 2006. THESE FUEL PUMP MODULES WERE SOLD AS AFTERMARKET FOR USE IN CERTAIN DAIMLERCHRYSLER VEHICLES LISTED ABOVE. SILICONE MATERIAL USED IN MANUFACTURE OF THE FLAPPER VALVE WAS... Read more

Consequence

FUEL RESTRICTION COULD RESULT IN LOSS OF POWER AND/OR ENGINE STALL, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy

AIRTEX WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMP MODULES FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT AIRTEX TOLL-FREE AT 1-866-867-3759.

24,358 vehicles affected

Manufacturer: AIRTEX PRODUCTS

SERVICE BRAKES, HYDRAULIC

Defect Description

CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE ... Read more

Consequence

LOSS OF BRAKE FLUID CAN LEAD TO A DECREASE IN BRAKE LINE PRESSURE AND AN INCREASE IN STOPPING DISTANCE, WHICH CAN RESULT IN A VEHICLE CRASH.

Remedy

AFFINIA (BRAKE PARTS, INC.) WILL REPLACE THE SUBJECT BRAKE HYDRAULIC MASTER CYLINDERS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS CAN CONTACT AFFINA GROUP CUSTOMER SERVICE AT 1-800-323-0354.

7,440 vehicles affected

Manufacturer: BRAKE PARTS, INC.

AIR BAGS

Defect Description

ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.

Consequence

THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.

Remedy

DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO... Read more

955,344 vehicles affected

Manufacturer: DAIMLERCHRYSLER CORPORATION

FUEL SYSTEM, GASOLINE

Defect Description

CERTAIN AFTERMARKET REPLACEMENT FUEL FILTERS, MODELS WIX FILTER PART NUMBERS 33576, 33577, 33734; NAPA FILTER PART NUMBERS 3576, 3577, 3734; AND CARQUEST FILTER PART NUMBERS 86576, 86577, 86734 USED ON 1996-2000 DAIMLERCHRYSLER TOWN & COUNTRY, DODGE CARAVAN, AND PLYMOUTH VOYAGER VEHICLES, CAN CAUSE ... Read more

Consequence

A POSSIBLE FIRE CAN OCCUR IN THE PRESENCE OF AN IGNITION SOURCE.

Remedy

WIX WILL NOTIFY ITS CUSTOMERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. NOTE: THIS DOES NOT INVOLVE ANY PRODUCTS MANUFACTURED BY THE DAIMLERCHRYSLER CORP. NOR ANY DAILMERCHRYSLER DEALERS. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY... Read more

68,563 vehicles affected

Manufacturer: WIX FILTERATION PRODUCTS DIVISION

EQUIPMENT

Defect Description

AFTERMARKET REPLACEMENT FUEL FILTERS MANUFACTURED BETWEEN SEPTEMBER 17, 2002, AND JANUARY 20, 2003, SOLD UNDER THE BRAND NAMES LISTED ABOVE. THE FILTER MAY EXPERIENCE MALFUNCTION OF THE QUICK CONNECTOR EITHER BLOCKING FUEL FLOW TO THE ENGINE OR CAUSING A FUEL LEAK. THIS DOES NOT INVOLVE ANY PRODU... Read more

Consequence

IF THIS CONDITION OCCURRED WHILE THE VEHICLE IS IN MOTION, THE ENGINE COULD STALL. ALSO, IN THE PRESENCE OF AN IGNITION SOURCE, THE FUEL LEAK COULD RESULT IN A VEHICLE FIRE.

Remedy

AFTERMARKET REPLACEMENT FUEL FILTERS FOR 1995-2000 SHORT WHEELBASE CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER AND DODGE CARAVAN MINIVANS PART NO. 18232 AND DATE CODE 0237, 0249, OR 0252. REPLACEMENT FUEL FILTERS FOR 1995-2000 LONG WHEELBASE CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER AND DODGE CARAV... Read more

45,870 vehicles affected

Manufacturer: INTERCONTINENTAL AUTO PARTS

AIR BAGS:FRONTAL

Defect Description

ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.

Consequence

Remedy

DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED O... Read more

1,500,521 vehicles affected

Manufacturer: DAIMLERCHRYSLER CORPORATION

SEAT BELTS:REAR/OTHER

Defect Description

ON CERTAIN MINIVANS, SOME TRIM MATERIAL CAN LOOSEN AND DROP INTO THE REAR OUTBOARD SEAT BELT ASSEMBLY, CAUSING THE SEAT BELT TO BECOME INOPERATIVE.

Consequence

IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.

Remedy

DEALERS WILL REPLACE THE TRIM WITH FOAM BLOCKERS AND INSPECT AND REPLACE ALL 3RD ROW SEAT BELT ASSEMBLIES. OWNER NOTIFICATION BEGAN JUNE 3, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOUL... Read more

545,311 vehicles affected

Manufacturer: DAIMLERCHRYSLER CORPORATION

FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM

Defect Description

VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.

Consequence

FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.

Remedy

DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOT... Read more

1,163,000 vehicles affected

Manufacturer: DAIMLERCHRYSLER CORPORATION

CHILD SEAT

Defect Description

VEHICLE DESCRIPTION: PASSENGER MINIVANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT WEBBING WAS INCORRECTLY ROUTED AROUND THE METAL REINFORCEMENT BAR ON THESE SEATS.

Consequence

THE CHILD SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED IN THE EVENT OF A COLLISION.

Remedy

DEALERS WILL INSPECT THE ROUTING OF THE SHOULDER BELT WEBBING AND ANY FOUND INCORRECT WILL BE PROPERLY ROUTED.

900 vehicles affected

Manufacturer: CHRYSLER CORPORATION

Complaint Statistics

443 total complaints 23 crashes 18 fires 21 injuries

Top Reported Components

Component	Complaints
POWER TRAIN:AUTOMATIC TRANSMISSION	40
AIR BAGS	35
ENGINE AND ENGINE COOLING:ENGINE	26
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS	20
AIR BAGS:FRONTAL	18
UNKNOWN OR OTHER	16
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE	16
ELECTRICAL SYSTEM:HORN	13
ENGINE AND ENGINE COOLING	12
ELECTRICAL SYSTEM	11

Incident date: Jan 6, 2016

THE 1998 PLYMOUTH VOYAGER PASSENGER VAN WAS INVOLVED IN A TWO VEHICLE COLLISION ON A PUBLIC HIGHWAY. CAUSE OF THE COLLISION WAS DUE TO THE OTHER INVOLVED VEHICLE, THAT BEING A 2011 KIA SOUL, FAILING TO STAY WITHIN ITS TRAVEL LANE. THE KIA CROSSED OVER INTO THE PATH OF THE PLYMOUTH VOYAGER, WITH BOTH... Read more

Crash 2 injured

Incident date: Jun 15, 2013

TL* THE CONTACT OWNS A 1998 PLYMOUTH VOYAGER. WHILE DRIVING AT 45 MPH, THE AIR BAG WARNING LIGHT ILLUMINATED AND THE CRUISE CONTROL FAILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE FAILURE MILEAGE WAS 140,000. THE VIN WAS NOT AVAILABLE.

Incident date: Jan 30, 2015

1998 PLYMOUTH VOYAGER LEFT AND RIGHT FRONT TOWERS ARE CONSUMED BY CORROSION EXPOSING THE STRUT ASSEMBLIES AND SEVERELY WEAKENING THE LOAD BEARING STRUCTURE CAUSING SERIOUS RISK OF STRUT TOWER FAILURE AS ON OR BOTH STRUTS WILL PENETRATE INTO THE ENGINE COMPARTMENT CAUSING THE FRONT OF THE VEHICLE TO ... Read more

Incident date: Mar 6, 2012

TL* THE CONTACT OWNS A 1998 PLYMOUTH VOYAGER. THE CONTACT STATED THAT WHILE DRIVING 45 MPH DURING INCLEMENT WEATHER, THE SERPENTINE BELT SLIPPED OFF THE PULLEY, CAUSING THE BATTERY WARNING LIGHT TO ILLUMINATE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BU... Read more

Incident date: Jul 31, 2009

I OWN A 1998 PLYMOUTH VOYAGER. AT THE TIME OF THE FIRST INCIDENT THE VEHICLE HAD APPROXIMATELY 80,000 MILES ON IT. WHILE DRIVING I NOTICED THAT A NUMBER OF WARNING LIGHTS SUDDENLY APPEARED AND THAT ALL OF THE GAUGES WERE NOT OPERATING ON THE DASH. THE VEHICLE WAS BROUGHT TO SCAP JEEP/PLYMOUTH... Read more

Incident date: Jul 2, 2010

DROVE THROUGH A PUDDLE. SERPENTINE BELT FELL OFF, CAUSING LOSS OF POWER STEERING. COMPLETED REPAIR AS PER TSB 07-02-99. DID NOT CORRECT ISSUE. A KNOWN ISSUE WITH 1996 - 2000 PLYMOUTH/DODGE CARAVANS 3.3L AND 3.8L. VERY DANGEROUS, HAPPENS ON WET/SNOW CONDITIONS. BOTTOM THIRD OF HARMNIC BALANCER ... Read more

Incident date: Mar 16, 2011

THE BELT SLIPS OFF IN THE RAIN CAUSING POWER FAILURE TO EVERYTHING RUNNING OFF THE BELT. NO POWER STEERING, NO COOLING SYSTEM, NO ELECTRICAL CHARGING, NO A/C, AND I BELIEVE THE BRAKES DIDN'T WORK RIGHT. *TR

Incident date: May 19, 2011

1989 PLYMOUTH VOYAGER LEFT AND RIGHT FRONT TOWERS ARE CONSUMED BY CORROSION EXPOSING THE MCPHERSON STRUT ASSEMBLIES AND SEVERELY WEAKENING THE LOAD BEARING STRUCTURE CAUSING SERIOUS RISK OF STRUT TOWER FAILURE AS ON OR BOTH STRUTS WILL PENETRATE INTO THE ENGINE COMPARTMENT CAUSING THE FRONT OF THE V... Read more

Incident date: May 19, 2011

Incident date: Aug 8, 2010

ANOTHER 1998 PLYMOUTH VOYAGER VAN WITH THE REAR BRAKE LINES BROKEN. HAPPENED ON THE ROAD, BRAKES WORKED AND LESS THAN 3 MILES DOWN THE ROAD WHEN DRIVER ATTEMPTED A TURN, BRAKES WENT TO THE FLOOR. DRIVER WAS ABLE TO PARK THE VEHICLE. VEHICLE WAS DRIVEN HOME BY HUSBAND USING FRONT BRAKES ONLY WHERE TH... Read more

Incident date: Apr 22, 2005

98 VOYAGER EXPRESSO 3.3 ENGINE. DOORS LOCK AT RANDOM, WHEN PUT IN GEAR, WHEN PUT IN PARK, WHILE KEYS IN CAR, WITH CAR RUNNING, THE 15MPH IS TOTALLY IRRELEVENT IN THIS VAN. IT ALSO OVER HEATS EVEN IN WINTER, AND ALL THE LIGHTS BLINK ON THE INSTRUMENT CLUSTER AS WELL AS THE HOUSING FOR AC, DEFROST, R... Read more

Incident date: Apr 22, 2005

Incident date: Jun 1, 2010

TL*THE CONTACT OWNS A 1998 PLYMOUTH VOYAGER. WHILE THE VEHICLE WAS BEING SERVICED BY A LOCAL MECHANIC WHO STATED THAT THE UNDER CARRIAGE HAD DETERIORATED DUE TO RUST. AN AUTHORIZED DEALER CONFIRMED THE DIAGNOSIS. THE CONTACT CALLED THE MANUFACTURER AND WAS UNABLE TO SPEAK WITH ANYONE. THE APPROXI... Read more

Incident date: Oct 10, 2009

THE HEAT CHANGES FROM HOT TO A/C BY ITSELF, THE REAR DEFROST DON'T WORK ALL THE TIME, THE BACK WIPERS GO ON BY THEN SELF WITH DIFFERENT DELAYS,,, , STAYS ON DEFROST, AND THE STRUT TOWER ARE VERY POOR SHAPE, NEVER SAW STRUT TOWERS RUST LIKE THIS ON ANY OTHER VAN OR CAR BUT THIS ONE..1998 PL... Read more

1 injured

Incident date: Oct 10, 2009

1 injured

Incident date: Oct 10, 2009

1 injured

Incident date: Mar 30, 2010

TL*THE CONTACT OWNS A 1998 PLYMOUTH VOYAGER. WHILE DRIVING APPROXIMATELY 45 MPH, THE CONTACT STATED THAT THE HEADLIGHTS, MARKER LIGHTS, SPEEDOMETER, FUEL GAUGE, ODOMETER, TEMPERATURE GAUGE, WIPERS, HORN AND POWER LOCKS ALL STOPPED WORKING. THE CONTACT HAD TO DRIVE AT NIGHT WITH NO LIGHTS FOR THREE ... Read more

Incident date: Jan 15, 2010

INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) THE CHRYSLER DEALER HAS NOT BEEN ABLE TO FIX THE CLOCKSPRING ON MY MINIVAN BECAUSE THE PART THAT CHRYSLER WILL PAY FOR IS NOT IN STOCK. [XXX]. I HAVE HAD MY MINIVAN IN THE DEALER MULTIPLE TIMES SINCE JAN 1... Read more

Incident date: Nov 18, 2009

TL*THE CONTACT OWNS A 1998 PLYMOUTH VOYAGER WHICH WAS PURCHASED IN 2000. HE RECEIVED A RECALL LETTER FROM CHRYSLER AND DID NOT HAVE ANY FAILURES ON THE VEHICLE AT THAT TIME. NHTSA CAMPAIGN ID NUMBER: 02V293000, AIR BAGS FRONTAL. AFTER THE CONTACT RECEIVED THE LETTER, THE AIRBAG WARNING LIGHT ILLUMIN... Read more

Incident date: Oct 1, 2006

WE HAVE PAID NUMEROUS TIMES TO HAVE THESE SAME ISSUES LOOKED AT PARTS REPLACED. NEW BRAIN AS THEY SAID FOR THE CAR, NEW COMPUTER MODULES. THIS OVER THE YEARS HAS COST ME UNTOLD AMOUNTS OF TIME AND MONEY. THE DASH SHUTS OFF COMPLETELY WHILE DRIVING, EVEN THOUGH WE HAVE HAD EVERYTHING REPLACED. WIPERS... Read more

Incident date: Oct 13, 2009

FRONT DRIVER SIDE STRUT TOWER RUSTED OUT AND FRONT TIRE FALLING OFF CAR. *TR

Incident date: Oct 13, 2009

FRONT DRIVER SIDE STRUT TOWER RUSTED OUT AND FRONT TIRE FALLING OFF CAR. *TR

Incident date: Sep 2, 2009

AS AN INVESTIGATOR ASSIGNED TO THE CALIFORNIA HIGHWAY PATROL, MULTIDISCIPLINARY ACCIDENT INVESTIGATION TEAM (MAIT) IN SACRAMENTO, AND AS DIRECTED BY THE MAIT OPERATIONS MANUAL, THIS IS TO NOTIFY NHTSA/ODI OF THE VERIFIED FAILURE OF A SAFETY RESTRAINT SYSTEM IN A VEHICLE INVOLVED IN A SEVERE-INJURY T... Read more

Crash 2 injured

Incident date: Oct 2, 2008

OWN A 98 PLYMOUTH VOYAGER EXPRESSO THAT INTERMITTENTLY WILL NOT CRANK OR WILL CRANK AND IMMEDIATELY GO DEAD. ALL DASH LIGHTS FLICKER OR GO OUT, NO FUEL INDICATOR, NO SPEEDOMETER. HAS DIED WHILE DRIVING IT ONCE WHICH WAS VERY DANGEROUS AND SCARY. FAILURE OCCURS PERIODICALLY AND IS DANGEROUS AND VEH... Read more

Incident date: Jul 1, 2009

RECEIVED RECALL NOTICE FROM CHRYSLER DEALERSHIP WITH CORPORATE PROGRAM HEADQUARTERS POSTMARK NOTIFICATION # CJD62709 FOR 1998 PLYMOUTH VOYAGER BUT NEITHER CUSTOMER SERVICE AT NUMBER INDICATED OR MANUFACTURER HAS ANY INFORMATION REGARDING PROBLEM. DRIVER(S) OF THIS VEHICLE LEFT CLUELESS AND IS NOW SA... Read more

Incident date: Aug 4, 2008

FAILURE TO PASS INSPECTION W/O REPAIR AS A SAFETY ISSUE 1998 PLYMOUTH VOYAGER DRIVER'S SIDE STRUT TOWER CAP RUST THROUGH. *TR

Incident date: Sep 22, 2002

THE STRUT TOWER IS RUSTING VERY BAD AND ABOUT TO BREAK OFF. THIS IS A VERY BIG DANGER FOR MY WIFE AND FOUR KIDS.. I FIRST NOTICE THE RUST 2 WEEKS AFTER WE BOUGHT THIS 1998 PLYMOUTH VOYAGER, AND THE DEALER WOULD NOT FIX IT. IT BEEN 3.5 YEARS KNOW AND THERE ARE HOLES WE CAN SEE THOUGH. NOT VERY ... Read more

Incident date: May 20, 2008

VAN BOUGHT NEW WITH DEFECTIVE MOTORS FOR POWER WINDOWS, FROM CHRYSLER. *TR

Incident date: May 9, 2008

1998 PLYMOUTH GRAND VAN 3.3 MOTOR. AFTER GOING THREW A RAIN PUDDLE OR GOING THREW SNOW THE BELT WILL COME OFF. IT WILL LEAVE YOU STUCK ON THE SIDE OF THE ROAD!. HAVE TRIED TO HAVE IT REPAIRED 3 OR 4 TIMES AND IT STILL DOES IT. IT IS A KNOWN PROBLEM BY PLYMOUTH. THEY NEED TO FIX THIS!!!! *TR

Incident date: Apr 15, 2008

TL*THE CONTACT OWNS A 1998 PLYMOUTH VOYAGER. WHEN THE VEHICLE IS TURNED OFF, THE HEADLIGHTS REMAIN ILLUMINATED AND OCCASIONALLY ACTIVATE AUTOMATICALLY. THE FAILURE WAS NOTICED WHILE DRIVING 15 MPH AND IT DRAINS THE BATTERY. THE DEALER STATED THAT THERE WERE NO RECALLS AVAILABLE AND THE REPAIR WAS... Read more

Incident date: Jul 20, 2007

WHILE STARTING FROM STOPPED POSITION AT TRAFFIC LIGHT, MY FRONT LEFT AXEL SNAPPED IN THE MIDDLE. IT SEEMS THERE WAS A MANUFACTURING DEFECT IN THE AXEL ROD. *TR

Incident date: May 1, 2006

DT*: THE CONTACT STATED THERE WERE SEVERAL PROBLEMS WITH THE VEHICLE THAT WOULD BE CONSIDERED A MANUFACTURER DEFECT. THE FIRST COMPONENT OF CONCERN WAS THE BELT TENSIONER WHICH HAD TO BE REPLACED BY THE DEALER BECAUSE IT WAS OBSERVED TO BE DISMANTLED. THE SECOND COMPONENT WAS IDENTIFIED WHEN THE VEH... Read more

Incident date: May 1, 2006

Incident date: Jun 22, 2006

DT*: THE CONTACT STATED THAT THE LEFT FRONT STRUT TOWER OF THE VEHICLE APPEARED TO HAVE AN UNUSUAL AMOUNT OF RUST ON TOP. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP ON 12/28/04 WHO DETERMINED IT WOULD HAVE TO BE REPLACED AND THAT IT WAS A COMMON PROBLEM ON THIS MODEL. THE VEHICLE WAS TAKEN ... Read more

Incident date: Jun 15, 2005

DT*: THE CONTACT STATED, WHILE TRAVELING 30MPH, PANIC BRAKING WAS ATTEMPTED TO AVOID A VEHICLE STOPPED AT A RED LIGHT. THE ABS ACTIVATED AND THE VEHICLE SLID INTO THE REAR OF THE VEHICLE STOPPED AT THE LIGHT. THE CONTACT WAS WEARING A SEAT BELT; SUSTAINED NO INJURIES AND THE POLICE TOOK A REPORT ... Read more

Crash

Incident date: Jan 19, 2006

1998 PLYMOUTH MINIVAN. STRUCTURE RUSTED THROUGH ON LEFT FRONT STRUT TOWER. THE PROBLEM WAS CAUGHT WHEN THERE WAS APPROX. 90% RUST THROUGH. A POTHOLE HIT OR JUST SEVERE BRAKING COULD HAVE HAD CATASTROPHIC RESULTS. CHRYSLER ADVISES THAT THEY WILL DO NOTHING BUT SAY SORRY. IS THIS A CHRONIC PROBLEM... Read more

Incident date: Jan 24, 2006

DT*: THE CONTACT STATED A LEAK WAS NOTICED UNDER THE TRANSMISSION WHEN THE VEHICLE WAS PARKED. A LOCAL INDEPENDENT REPAIR MECHANIC REPLACED A SHAFT SEAL IN THE TRANSMISSION. HOWEVER, THAT DID NOT REMEDY THE LEAK. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR TRANSMISSION SHOP WERE IT WAS DETERM... Read more

Incident date: Jan 24, 2006

Incident date: Dec 13, 2005

WHEN ATTEMPTING TO TURN ON THE HEADLIGHTS, THE HEADLIGHTS WILL FLICKER ON FOR ONLY A SPLIT SECOND THEN GO OFF. THE DRIVER MUST TURN THE HEADLIGHT SWITCH ONLY TO A CERTAIN POINT SO THAT THE LIGHTS WILL STAY ON. IF THE LIGHTS FLICKER, THE DRIVER HAS TO TURN THE LIGHTS OFF, THEN TRY AGAIN. TWICE, WH... Read more

Incident date: Oct 6, 2005

THERE WAS A RECALL MANY YEARS AGO IN GERMANY ON THE STARTER,ALSO HAVE A LETTER FROM THE CHRYSLER SHOP THE PART GET REPLACED ON WARRANTY THAT WAS MANY YEARS AGO,THERE NEVER HAD THE PART TO REPLACE IT. NOW I AM IN THE STATES ,IN WASHINGTON, AND THE RECALL PART FAILED ME. SECOND: MY HEADLIGHT HAVE A ... Read more

Incident date: Oct 6, 2005

Incident date: Oct 17, 2005

THE SERPENTINE BELT ON MY 1998 PLYMOUTH VOYAGER WAS REPLACED BY THE DEALER IN AUGUST 2004. IT HAS GONE BACK TO THE DEALER TWICE AFTER THAT MAINTENANCE BECAUSE THE BELT SLIPS WHEN DRIVING IN RAIN. THE DEALER REPLACED A MOUNT WHICH IS IN THE RECOMMENDED TSB BY CHRYSLER BUT TO NO AVAIL. TO THIS DATE... Read more

Incident date: Oct 4, 2005

WHILE HAVING A NEW BATTERY INSTALLED ON OUR 1998 PLYMOUTH VOYAGER, WE WERE SHOWN THAT THE STRUT TOWER IS RUSTING AND CRACKED ON THE TOP. SUBSEQUENT EXAMINATION BY OTHER MECHANICS SHOWS THAT THE RUSTING STARTED IN THE TOP PLATE AND WORKED ITS WAY DOWN TO THE SECOND PLATE, WHICH IS NOT AS BAD. THE COM... Read more

Incident date: Oct 2, 2005

1998 PLYMOUTH VOYAGER - STRUT IS PUSHING THROUGH THE STRUT TOWER ON THE DRIVER'S SIDE. EXCESSIVE RUST. HASN'T FAILED YET, BUT FAILURE IS IMMINENT AND WOULD BE VERY DANGEROUS. *JB

Incident date: Oct 2, 2005

1998 PLYMOUTH VOYAGER - STRUT IS PUSHING THROUGH THE STRUT TOWER ON THE DRIVER'S SIDE. EXCESSIVE RUST. HASN'T FAILED YET, BUT FAILURE IS IMMINENT AND WOULD BE VERY DANGEROUS. *JB

Incident date: Aug 8, 2005

DT: CALLER GOT RECALL WORK DONE ON CLOCK SPRING, BUT IT DID NOT FIX THE PROBLEM. THE AIR BAG LIGHT WAS ON BEFORE IT WAS FIXED, AND NOW THE AIR BAG LIGHT WAS OFF , AND THE ABS LIGHT AND ENGINE LIGHT WERE ON, AND NONE OF GAUGES WORKED. DEALER SAID THERE WAS NOTHING ELSE THEY COULD DO. DEALER SA... Read more

Incident date: Aug 8, 2005

Showing 50 of 443 complaints.

Technical Service Bulletins, 1998 PLYMOUTH VOYAGER

123 manufacturer communications from 118 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
162000 STRUCTURE:BODY	12
061000 ENGINE AND ENGINE COOLING:ENGINE	9
110000 ELECTRICAL SYSTEM	7
350000 EQUIPMENT	5
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER	5
160000 STRUCTURE	5
010000 STEERING	4
061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE	4

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehi

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

110000 ELECTRICAL SYSTEM

Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are nece

350000 EQUIPMENT

160000 STRUCTURE

Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.

350000 EQUIPMENT

Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.

160000 STRUCTURE

Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.

350000 EQUIPMENT

Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.

160000 STRUCTURE

Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.

350000 EQUIPMENT

Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.

160000 STRUCTURE

Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.

160000 STRUCTURE

Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.

060000 ENGINE AND ENGINE COOLING

Valve Body. These may cause over drive cycling.

040000 SERVICE BRAKES, AIR

SNOW/WATER INGESTION INTO REAR BRAKE DRUM. *KB

034400 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM

SNOW/WATER INGESTION INTO REAR BRAKE DRUM. *TT

034400 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM

SNOW/WATER INGESTION INTO REAR BRAKE DRUM. *TT

010000 STEERING

POP/TICK SOUND IN STEERING WHEEL AREA. *TT

162000 STRUCTURE:BODY

COSMETIC CORROSION OR PERFORATION AT UPPER STRUT TOWER/S USUALLY BETWEEN THE STRUT AND UPPER LOAD PATH BEAM INNER PANEL (INNER FENDER). *TT

034400 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM

SNOW/WATER INGESTION INTO REAR BRAKE DRUM. *YD THIS BULLETIN SUPERSEDES 05-001-02 DATED MARCH 4, 2002. *TT

140000 AIR BAGS

CONCERNS WITH THE AIR BAG WARNING INDICATOR LAMP ON INTERMITTENTLY OR CONSTANTLY. *TT

980000 UNKNOWN OR OTHER

FLASH PROGRAMMING FAILURE RECOVERY. *SLC

135200 VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR

SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *SLC

011000 STEERING: STEERING WHEEL/HANDLE BAR

EXPERIENCING A POP/TICK SOUND HEARD COMING FROM THE STEERING WHEEL AREA WHILE THE VEHICLE IS IN MOTION. *TT

103600 POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES

SUBJECT REGARDING TRANSMISSION OIL COOLER LINE HOSE CLAMP SERVICE. *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

SUBJECT REGARDING CAMSHAFT / BEARING SERVICE. *TT

135200 VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR

SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *TT

021000 SUSPENSION:FRONT

EXPERIENCING A SQUAWK / CREAK / GROAN SOUND FROM FRONT SUSPENSION WHILE DRIVING OVER ROUGH / BUMPY ROADS. *TT

110000 ELECTRICAL SYSTEM

SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT

350000 EQUIPMENT

SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. *TT

034500 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC

A CONDITION MAY EXIST WHERE A LOW FREQUENCY HOWL / MOAN NOISE IS HEARD FROM THE REAR BRAKE AREA DURING LOW SPEED AND / OR LOW SPEED TURNS SUCH AS A PARKING LOT MANEUVER, WITH NO BRAKE PEDAL PRESSURE APPLIED. *TT

034430 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:DRUM

ON SOME VEHICLES, WHILE DRIVING THROUGH DEEP OR BLOWING SNOW / WATER, THE SNOW / WATER MAY ENTER THE REAR BRAKE DRUMS CAUSING RUST TO DEVELOP ON THE REAR BRAKE DRUM AND SHOE FRICTION SURFACES. THIS CONDITION CAN LEAD TO TEMPORARY FREEZI

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

THIS BULLETIN INVOLVES INSTALLATION OF A NEW COMPONENT TO ASSIST CAM SEAL RETENTION. *JB

110000 ELECTRICAL SYSTEM

SUBJECT REGARDING WIRE SPLICE REPAIRS. *SB

135000 VISIBILITY:REARVIEW MIRRORS/DEVICES

SUBJECT REGARDING OUTSIDE MIRROR GLASS REPLACEMENT. *TT

220000 SEATS

SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT

162300 STRUCTURE:BODY:DOOR

EXPERIENCING A CHATTER SOUND COMING FROM THE SLIDING DOOR POWER LOCK ACTUATOR(S) WHEN THE POWER LOCK FEATURE IS REPEATEDLY ACTIVATED. *TT

070000 FUEL SYSTEM, GASOLINE

INFORMATION REGARDING UPDATES TO THE FUEL SYSTEM SERVICE PROCEDURES. *TT

140000 AIR BAGS

SUBJECT REGARDING NON-DEPLOYED AIRBAG HANDLING PROCEDURES. *TT

162000 STRUCTURE:BODY

A CONDITION EXIST WHERE THE ROOF PANEL SURFACE EXHIBITS WAVINESS OR DEPRESSION(S) NEAR THE FRONT OF THE CHARACTER FEATURES OR SKID STRIP FOR ROOF RACK EQUIPPED VEHICLES. *TT

162000 STRUCTURE:BODY

THIS BULLETIN CONTAINS PROCECURES TO REMOVE WAVINESS OR DEPRESSIONS FROM THE ROOF PANEL SURFACE. *TT

220000 SEATS

SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT

114000 ELECTRICAL SYSTEM:WIRING

THIS BULLETIN PROVIDES A REVISED WIRE SPLICE PROCEDURE AND RELATED PARTS. *TT

010000 STEERING

A CONDITION WHERE A CLICK / RATTLE SOUND MAY BE HEARD COMING FROM THE AREA OF THE STEERING WHEEL WHILE THE VHICLE IS IN MOTION. *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

SUBJECT REGARDING MISDIAGNOSED LEAK DETECTION PUMP SYSTEMS WITH DIAGNOSTIC TROUBLE CODES P1494, P0442 P0455, OR P0456. *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

CONCERNS WITH THE PCV VALVE FREEZING UNDER EXTREMELY COLD CONDITIONS. *TT

034430 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:DRUM

INFORMATION REGARDING SNOW / WATER ENTERING THE REAR BRAKE DRUMS. *TT

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

VEHICLE OPERATOR MAY COMPLAIN OF POOR AM RADIO RECEPTION. *TT

145000 AIR BAGS:ON-OFF SWITCH ASSEMBLY

DAIMLERCHRYSLER CORPORATION IS NOW OFFERINB AIRBAG ON / OFF SWITCHES FOR SELECTED VEHICLES. *TT

051100 PARKING BRAKE:CONVENTIONAL:MECHANICAL

INFORMATION ON REAR WHEEL PARK BRAKE ACTUATOR / LEVER SERVICE. *TT

162000 STRUCTURE:BODY

SUBJECT ON THE CHILD SEAT TETHER ANCHORS. *MJS

061000 ENGINE AND ENGINE COOLING:ENGINE

TECHNICAL SERVICE BULLETIN REGARDING MULTI-LAYER STEEL (MLS) HEAD GASKET INSTALLATION PROCEDURES. *TT

980000 UNKNOWN OR OTHER

SOME VEHICLES MAY EXHIBIT INTERMITTENT MALFUNCTION INDICATOR LIGHT (MIL) ILLUMINATION WITH HEX CODE $1B (P0123) THROTTLE POSITION SENSOR (TPS) VOLTAGE HIGH. *TT

116100 ELECTRICAL SYSTEM:IGNITION:SWITCH

INFORMATION REGARDING THE IGNITION SWITCH HOUSING SERVICE. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

THIS BULLETIN ANNOUNCES THE AVAILABILITY AND INSTALLATION OF A RESUABLE AUTOMATIC TRANSMISSION OIL PAN GASKET. *TT

220000 SEATS

INFORMATION ON CHILD SEAT TETHER ANCHORS. *TT

180000 VEHICLE SPEED CONTROL

CONCERNS WITH SPEED CONTROL WHICH DOES NOT MAINTAIN SET SPEED WHILE CLIMBING A GRADE. *TT

181000 VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

EXPERIENCING VIBRATION / BUZZ IN THE ACCELERATOR PEDAL AT 2200 - 2500 RPM AND ABOVE 3500 RPM. *TT

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

THIS BULLETIN EXPLAINS THE OPERATION AND APPLICATION OF THE LEAK DETECTION PUMP (LDP) MONITOR TEST. *TT

162000 STRUCTURE:BODY

EXPERIENCING TICK TYPE NOISE AT TOP OF LEFT B-PILLAR. *TT

061110 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS

CONCERNS WITH SERPENTINE BELT SLIPPING OFF IDLER PULLEY. *TT

190000 TIRES

SUBJECT PERTAINING TO SMOOTH ROAD HIGH-SPEED VIBRATION OR SHAKE CONDITION. *TT

190000 TIRES

CUSTOMER MAY COMPLAIN OF LOW SPEED TIRE WOBBLE. *TT

180000 VEHICLE SPEED CONTROL

CONDITIONS WITH INTERMITTENT LOSS OF SPEED CONTROL. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

SUBJECT REGARDING REUSABLE AUTOMATIC TRANSMISSION OIL PAN GASKET. *TT

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

CONCERNS WITH SAGS / HESITATION / STUMBLE / START & STALL, A/C BUMP IMPROVEMENTS, ADDITION OF LEAK DETECTION PUMP (LDP) MONITOR TEST. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

SERVICE AND PARTS INFORMATION ON 1999 RUNNING CHANGES TO TRANSMISSION RANGE SENSOR (TRS) *TT

162300 STRUCTURE:BODY:DOOR

CONCERNS WITH FRONT AND / OR SLIDING DOOR POWER LOCK MOTORS MAKING A WHIRLING NOISE. *TT

063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

EMISSIONS RECALL -- VEHICLE EMISSION CONTROL INFORMATION (VECI) LABEL REPLACEMENT. *TT

162000 STRUCTURE:BODY

SUBJECT PERTAINING TO A TICKING TYPE NOISE AT TOP OF LEFT B-PILLAR. *TT

145000 AIR BAGS:ON-OFF SWITCH ASSEMBLY

SUBJECT REGARDING AIRBAG ON - OFF SWITCHES. *YC

061000 ENGINE AND ENGINE COOLING:ENGINE

SUBJECT REGARDING OIL SEEPAGE AT CAM POSITION SENSOR / MISINTERPRETED HEAD GASKET LEAK. *YC

131000 VISIBILITY:WINDSHIELD

WINDNOISE AROUND FRON DOOR GLASS, ESPECIALLY AT TOP OF THE B PILLAR. *AK

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

VEHICLE EXPERIENCING A TICKING NOISE WHILE AT IDLE FROM ENGINE. *YC

061000 ENGINE AND ENGINE COOLING:ENGINE

A NEW MULTI-LAYER STEEL ( MLS ) HEAD GASKET HAS BEEN DEVELOPED AND IS BEING IMPLEMENTED INTO PRODUCTION VEHICLES. *YC

063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

SUBJECT REGARDING I/M ( INSPECTION MAINTENANCE ) TESTING - OBD II "CARB" READINESS MONITOR INFORMATION. *YC

020000 SUSPENSION

A SQUEAKING / CHIRPING NOISE IS HEARD ( INSIDE OR OUTSIDE THE VEHICLE ) FROM THE STRUT TOWER AREA( S ). *YC

110000 ELECTRICAL SYSTEM

SUBJECT REGARDING BODY CONTROL MODULE AUTO HEADLAMP SENSOR/ SIGNAL CIRCUIT DIAGNOSTIC TROUBLE CODE (DTC). *YC

162000 STRUCTURE:BODY

SUBJECT ON FLASH PROGRAMMING FAILURE RECOVERY. *YC

145000 AIR BAGS:ON-OFF SWITCH ASSEMBLY

SUBJECT REGARDING THE AIRBAG ON-OFF SWITCHES. *YC

010000 STEERING

A "HONK" OR SQUEAL NOISE DURING PARKING LOT MANEUVERS. *YC

022000 SUSPENSION:REAR

RATTLE NOISE FROM REAR OF THE VEHICLE WHEN DRIVING OVER ROAD BUMPS. *AK

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

CONDITION WITH A/C COMPRESSOR LOCK-UP AT LOW MILEAGE. *YC

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

EXHIBITING A MOANING AND GROANING SOUND ACCOCIATED WITH A/C COMPRESSOR OPERATION. *YC

162300 STRUCTURE:BODY:DOOR

THE FRONT DOOR BODY MOUNTED WEATERSTRIP FALLS OFF MOUNTING FLANGE, USUALLY ALONG THE TOP OF THE DOOR OPENING. *YC

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

SUBJECT REGARDING A/C SUCTION AND / OR DISCHARGE LINE REQUIRES REPLACEMENT DUE TO CRACKING AT OR NEAR COMPRESSOR. *AK

162000 STRUCTURE:BODY

SYMPTOMS WITH ROOF RACK RATTLES AT HIGHWAY SPEEDS. *YC

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

PERCEIVED LOSS OR CAHNGE OF RADIO STATION PRESETS. *AK

061000 ENGINE AND ENGINE COOLING:ENGINE

SUBJECT ON LABOR OPERATION TIME CHANGE FOR DOMESTIC 2.OL DOHC AND 2.4L HEAD GASKET REPLACEMENT. *YC

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

CONDITIONS WITH A/C COMPRESSOR LOCK-UP AT LOW MILEAGE. *YC

162000 STRUCTURE:BODY

INFORMATION ON BODY CONTROL MODULE (BCM) REPLACEMENT. *YC

020000 SUSPENSION

*DURING LOW SPEED VEHICLE EXPERIENCES SIDE TO SIDE OSCILLATION/WOBBLE WHILE DRIVING BETWEEN 10-45MPH. *AK

106000 POWER TRAIN:AXLE ASSEMBLY

SUBJECT ON DELAYED TRANSAXLE ENGAGEMENT. *AK

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

INFORMATION ON INSTALLATION OF RADIO TRANSMITTING EQUIPMENT. *AK

180000 VEHICLE SPEED CONTROL

SOME VEHICLES MAY PRODUCE A HIGH PITCHED WHISTLE NOISE DURING WIDE OPEN THROTTLE ACCELERATION. *YC

061000 ENGINE AND ENGINE COOLING:ENGINE

SOME VEHICLES MAY EXPERIENCE A CONDITION WHERE THE VALVE TRAIN MAKES A TAPPING NOISE. *YC

063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

INFORMATION ON REMOVAL OF THE EXHAUST DRONE. *YC

061000 ENGINE AND ENGINE COOLING:ENGINE

SUBJECT ON TIP-IN SAGS/HESITATIONS OR ROUGH IDLE AFTER A HOT SOAK RESTART. *YC

116200 ELECTRICAL SYSTEM:IGNITION:MODULE

CONDITION WITH THE SOFTWARE WITHIN THE POWERTRAIN (PCM) MAY NOT OPERATE THE SOLID STATE RELAY FOR THE RADIATOR FAN CORRECTLY. *YC

200000 WHEELS

INFORMATION ON VEHICLE ALUMINUM WHEELS HAVING A UNIQUE BALANCE WEIGHT RETENTION FLANGE. *YC

102000 POWER TRAIN:MANUAL TRANSMISSION

SUBJECT ON TRANSAXLE DESENSITIZATION TO INTERMITTENT FAULTS / DRIVEABILITY IMPROVEMENTS. *YC

Showing 100 of 123 bulletins.

NHTSA Safety Investigations, PLYMOUTH VOYAGER

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 1984

FRNT COIL SPRNG FRACTURE

There is no summary currently available

DP, Closed , Model Year: 1985

ENGINE FIRE

PLYMOUTH VOYAGER - All Years Overview

Complete safety history for the PLYMOUTH VOYAGER across all model years (1978, 2000).

132 Total Recalls

6,868 Total Complaints

2 Investigations

502 Reported Crashes

190 Reported Fires

24 Reported Deaths

PLYMOUTH VOYAGER - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2000	8	214	View
1999	10	362	View
1998 (current)	11	443
1997	11	474	View
1996	15	1,111	View
1995	4	476	View
1994	5	670	View
1993	10	749	View
1992	11	893	View
1991	10	624	View
1990	6	270	View
1989	5	204	View
1988	5	109	View
1987	3	99	View
1986	4	80	View
1985	6	38	View
1984	6	23	View
1983	1	7	View
1980	0	1	View
1978	1	1	View

Other PLYMOUTH Models

Model	Recalls	Complaints
GRAND VOYAGER	82	3,388	View
FURY	53	5	View
BREEZE	44	872	View
VALIANT	37	0	View
HORIZON	33	31	View
SATELLITE	28	1	View
PROWLER	24	69	View
RELIANT	22	67	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

1998 PLYMOUTH VOYAGER

Complaint Statistics

Top Reported Components

Technical Service Bulletins, 1998 PLYMOUTH VOYAGER

Most Affected Components

NHTSA Safety Investigations, PLYMOUTH VOYAGER

PLYMOUTH VOYAGER - All Years Overview

PLYMOUTH VOYAGER - Year by Year

Other PLYMOUTH Models