1999 PLYMOUTH VOYAGER

10 recalls — 362 complaints — 109 TSBs

EQUIPMENT

Defect Description

CURT MFG IS RECALLING CERTAIN CLASS 3 RECEIVER HITCHES, P/N 13347, SOLD AS AFTERMARKET EQUIPMENT FOR USE ON 1997-2007 CHRYSLER TOWN AND COUNTRY VANS, 1996-2007 DODGE CARAVANS, AND 1996-2004 PLYMOUTH VOYAGER VANS. WHEN THE HITCH IS LOADED TO THE MAXIMUM RATING, THE HITCH MAY FRACTURE OR BREAK AT THE... Read more

Consequence

IF THE AREA IN QUESTION FRACTURES OR BREAKS, THIS COULD CAUSE AN UNSTABLE DRIVING CONDITION, POSSIBLY RESULTING IN A CRASH.

Remedy

CURT MFG WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE THE HITCH FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING AUGUST 2010. OWNERS MAY CONTACT CURT MFG AT 1-715-831-8713.

6,686 vehicles affected

Manufacturer: CURT MFG. INC.

VISIBILITY:GLASS, SIDE/REAR

Defect Description

CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDER... Read more

Consequence

IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.

Remedy

SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER... Read more

1,657 vehicles affected

Manufacturer: SAFELITE FULFILLMENT, INC.

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Defect Description

CERTAIN AIRTEX FUEL PUMP MODULES, P/NOS. E7089M, E7094M, E7113M, AND E7129M, MANUFACTURED BETWEEN JUNE 1 AND SEPTEMBER 24, 2006. THESE FUEL PUMP MODULES WERE SOLD AS AFTERMARKET FOR USE IN CERTAIN DAIMLERCHRYSLER VEHICLES LISTED ABOVE. SILICONE MATERIAL USED IN MANUFACTURE OF THE FLAPPER VALVE WAS... Read more

Consequence

FUEL RESTRICTION COULD RESULT IN LOSS OF POWER AND/OR ENGINE STALL, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy

AIRTEX WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMP MODULES FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT AIRTEX TOLL-FREE AT 1-866-867-3759.

24,358 vehicles affected

Manufacturer: AIRTEX PRODUCTS

SERVICE BRAKES, HYDRAULIC

Defect Description

CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE ... Read more

Consequence

LOSS OF BRAKE FLUID CAN LEAD TO A DECREASE IN BRAKE LINE PRESSURE AND AN INCREASE IN STOPPING DISTANCE, WHICH CAN RESULT IN A VEHICLE CRASH.

Remedy

AFFINIA (BRAKE PARTS, INC.) WILL REPLACE THE SUBJECT BRAKE HYDRAULIC MASTER CYLINDERS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS CAN CONTACT AFFINA GROUP CUSTOMER SERVICE AT 1-800-323-0354.

7,440 vehicles affected

Manufacturer: BRAKE PARTS, INC.

AIR BAGS

Defect Description

ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.

Consequence

THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.

Remedy

DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO... Read more

955,344 vehicles affected

Manufacturer: DAIMLERCHRYSLER CORPORATION

FUEL SYSTEM, GASOLINE

Defect Description

CERTAIN AFTERMARKET REPLACEMENT FUEL FILTERS, MODELS WIX FILTER PART NUMBERS 33576, 33577, 33734; NAPA FILTER PART NUMBERS 3576, 3577, 3734; AND CARQUEST FILTER PART NUMBERS 86576, 86577, 86734 USED ON 1996-2000 DAIMLERCHRYSLER TOWN & COUNTRY, DODGE CARAVAN, AND PLYMOUTH VOYAGER VEHICLES, CAN CAUSE ... Read more

Consequence

A POSSIBLE FIRE CAN OCCUR IN THE PRESENCE OF AN IGNITION SOURCE.

Remedy

WIX WILL NOTIFY ITS CUSTOMERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. NOTE: THIS DOES NOT INVOLVE ANY PRODUCTS MANUFACTURED BY THE DAIMLERCHRYSLER CORP. NOR ANY DAILMERCHRYSLER DEALERS. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY... Read more

68,563 vehicles affected

Manufacturer: WIX FILTERATION PRODUCTS DIVISION

EQUIPMENT

Defect Description

AFTERMARKET REPLACEMENT FUEL FILTERS MANUFACTURED BETWEEN SEPTEMBER 17, 2002, AND JANUARY 20, 2003, SOLD UNDER THE BRAND NAMES LISTED ABOVE. THE FILTER MAY EXPERIENCE MALFUNCTION OF THE QUICK CONNECTOR EITHER BLOCKING FUEL FLOW TO THE ENGINE OR CAUSING A FUEL LEAK. THIS DOES NOT INVOLVE ANY PRODU... Read more

Consequence

IF THIS CONDITION OCCURRED WHILE THE VEHICLE IS IN MOTION, THE ENGINE COULD STALL. ALSO, IN THE PRESENCE OF AN IGNITION SOURCE, THE FUEL LEAK COULD RESULT IN A VEHICLE FIRE.

Remedy

AFTERMARKET REPLACEMENT FUEL FILTERS FOR 1995-2000 SHORT WHEELBASE CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER AND DODGE CARAVAN MINIVANS PART NO. 18232 AND DATE CODE 0237, 0249, OR 0252. REPLACEMENT FUEL FILTERS FOR 1995-2000 LONG WHEELBASE CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER AND DODGE CARAV... Read more

45,870 vehicles affected

Manufacturer: INTERCONTINENTAL AUTO PARTS

SEAT BELTS:REAR/OTHER

Defect Description

ON CERTAIN MINIVANS, SOME TRIM MATERIAL CAN LOOSEN AND DROP INTO THE REAR OUTBOARD SEAT BELT ASSEMBLY, CAUSING THE SEAT BELT TO BECOME INOPERATIVE.

Consequence

IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.

Remedy

DEALERS WILL REPLACE THE TRIM WITH FOAM BLOCKERS AND INSPECT AND REPLACE ALL 3RD ROW SEAT BELT ASSEMBLIES. OWNER NOTIFICATION BEGAN JUNE 3, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOUL... Read more

545,311 vehicles affected

Manufacturer: DAIMLERCHRYSLER CORPORATION

FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM

Defect Description

VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.

Consequence

FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.

Remedy

DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOT... Read more

1,163,000 vehicles affected

Manufacturer: DAIMLERCHRYSLER CORPORATION

EXTERIOR LIGHTING:HEADLIGHTS

Defect Description

VEHICLE DESCRIPTION: MINI VANS BUILT FOR FLEET SALES ONLY. THE HEADLAMP MODULE DOES NOT IDENTIFY THE PARK LAMP AS "DRL" AS REQUIREMENT OF FMVSS 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Consequence

THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 108.

Remedy

ALL FLEET OWNERS/OPERATORS WILL BE MAILED NON-REMOVABLE DECALS WITH THE REQUIRED "DRL" LETTERS.

1,635 vehicles affected

Manufacturer: DAIMLERCHRYSLER CORPORATION

Complaint Statistics

362 total complaints 31 crashes 19 fires 22 injuries

Top Reported Components

Component	Complaints
AIR BAGS	39
POWER TRAIN:AUTOMATIC TRANSMISSION	28
ENGINE AND ENGINE COOLING:ENGINE	23
AIR BAGS:FRONTAL	15
ELECTRICAL SYSTEM:HORN	15
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE	15
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP	12
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE	10
VEHICLE SPEED CONTROL	8
ELECTRICAL SYSTEM:WIRING	8

Incident date: Mar 10, 2015

THERE ARE INSTANCES WHERE I AM OUT AND ABOUT AND AFTER RETURNING THE MY VEHICLE I GO IN AND WHEN I START THE VEHICLE IT WILL START AND SHUT ITSELF OFF. SEEMS TO HAPPENS WHEN I USE IT FREQUENTLY OR ON HOTTER DAYS. ALSO THE PANEL INSIDE THE CAR THAT TELLS YOU YOUR SPEED THE GAS YOU HAVE THE GEARS ALL ... Read more

Incident date: Oct 17, 2015

MY CAR TURNED OFF WHILE AT A STOP LIGHT TWICE, THEN ON ANOTHER OCCASSION WE WERE SLOWING DOWN TO MAKE A RIGHT HAND TURN INTO THE MALL PARKING LOT, IT WAS HARD TO CONTROL BUT WHEN IT CAME TO ASTOP I TURNED THE EGNITION ON AND IT STARTED AGAIN. I TOOK IT TO LITHIA DODGE HERE IN CORPUS CHRISTI,TEX OC... Read more

Incident date: May 28, 2015

TL* THE CONTACT OWNS A 1999 PLYMOUTH VOYAGER. THE CONTACT STATED THAT FUEL FUMES EMITTED INTO THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 92,200.

Incident date: Nov 12, 2013

I STARTED ENGINE PUT IT IN GEAR (DRIVE) STEPPED ON GAS WENT ABOUT 40MPH AND I NOTICED THE SPEEDOMETER WAS NOT WORKING AND THE NEEDLE WAS STILL AT 0. I HAD TO STOP THE VEHICLE PUT IT IN PARK TURN IT OFF TURN IT ON AGAIN PUT IT IN DRIVE AND THEN IT WOULD WORK AGAIN. EVERY NOW AND THEN THIS WOULD HAPPE... Read more

Incident date: Sep 17, 2013

TOOK A RIGHT TURN OUT OF PARKING LOT.HEARD A GROANING NOISE AND THE CAR WAVERED A LITTLE BIT.WHEN I GOT HOME,I NOTICED THE FRONT SPRING ON THE DRIVER SIDE WAS ONLY ABOUT 1 INCH AWAY FROM MAKING CONTACT WITH THE TIRE.I OPENED THE HOOD AND NOTED THAT WHERE THE STRUT IS CONNECTED TO THE WHEEL WELL........ Read more

Incident date: Nov 26, 2012

LOSING POWER STEERING FROM BUMPY ROADS AND DURING BAD WEATHER. THIS HAPPENED THREE TIMES WITHIN A 30 DAY PERIOD... ...FIRST, WHILE CHANGING LANES IN CITY I NOTICED THAT THE POWER STEERING WAS HARD WHEN I MADE A RIGHT TURN, HAD TO KEEP GOING WITH TRAFFIC, WHEN I MADE THE SECOND RIGHT TURN I REALIZED... Read more

Incident date: May 20, 2011

I HAVE SEEN ON CERTAIN CHRYSLER MODELS, ESPECIALLY MINIVANS, WITH THE 2-PIN FLOATING CALIPER DESIGN THAT THE SURFACE OF THE STEERING KNUCKLE WHERE THE BRAKE PADS RIDE WEARS AWAY AND CAN CAUSE THE AFFECTED WHEEL TO LOCK UP EITHER DURING A STOP OR AFTER THE BRAKE PEDAL IS RELEASED. THIS IS CAUSED BY T... Read more

Incident date: Mar 28, 2011

TL* THE CONTACT OWNS A 1999 PLYMOUTH VOYAGER. THE VEHICLE WAS PARKED WHEN THE CONTACT NOTICED THAT THE FRONT DRIVER SIDE STRUT TOWER WAS SEVERELY RUSTED AND CORRODED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHERE THE CONTACT WAS TOLD THAT THE FAILURE WAS COMMON. THE VEHICLE WAS NOT REPAI... Read more

Incident date: Jan 9, 2011

TL* THE CONTACT OWNS A 1999 PLYMOUTH VOYAGER. THE CONTACT STATED THAT THE STRUT MOUNT AROUND THE FRAME WAS COMPLETELY RUSTED. THE CONTACT STATED THAT IF THE STRUT FRACTURED WHILE DRIVING, THE VEHICLE COULD CAUSE A SERIOUS CRASH. THE CONTACT HAD NOT TAKEN THE VEHICLE TO THE DEALER FOR REPAIRS OR DIAG... Read more

Incident date: Mar 10, 2007

FAILURE OF DRIVERS SIDE STRUT TOWER ON 99 PLYMOUTH VOYAGER....STRUCTURAL FAILURE DUE TO RUST....MANUFACTURER RELEASE TECH SERVICE BULLETIN SUSPENSION/BODY - STRUT TOWER CORROSION NUMBER: 23-044-02 GROUP: BODY DATE: OCT. 14, 2002 SUBJECT: NS STRUT TOWER CORROSION THIS A STRUCTURAL ISSUE... Read more

Incident date: Apr 5, 2010

TL*THE CONTACT OWNS A 1999 CHRYSLER VOYAGER. UPON PICKING UP THE VEHICLE FROM BEING SERVICED FOR NON-RELATED ISSUES THE CONTACT WAS INFORMED THAT THE DRIVERS SIDE FRONT STRUT TOWER HAD SEVERELY RUSTED. THE VEHICLE HAD NOT BEEN SERVICED FOR THE FAILURE. THE FAILURE AND CURRENT MILEAGES WERE 97,160.

Incident date: Feb 26, 2010

I HAVE A 1999 PLYMOUTH VOYAGER WITH A 3.3 L ENGINE. EVERY TIME IT RAINS OR SNOW THE SERPENTINE BELT COMES OFF, MAKING IT IMPOSSIBLE TO STEER VEHICLE. I HAVE 5 CHILDREN THAT I TAKE FROM PLACE TO PLACE. THE ALTERNATOR STOPS CHARGING AS WELL. WHEN THIS HAPPENS I LOSE ALL CONTROL OF THE VEHICLE AND I... Read more

Incident date: Feb 26, 2010

Incident date: Nov 18, 2009

TL* THE CONTACT OWNS A 1999 PLYMOUTH VOYAGER. HE CONTACTED THE DEALER IN REFERENCE TO RECALL CAMPAIGN ID NUMBER: 04V480000 (AIR BAGS). HE WAS ADVISED THAT THE PARTS WERE ON BACKORDER. NO REPAIRS HAVE BEEN MADE. THE FAILURE MILEAGE WAS 96000. THE CURRENT MILEAGE WAS 97000. THE VEHICLE IDENTIFICATI... Read more

Incident date: Nov 13, 2009

DRIVING DOWN THE ROAD HIT A BUMP STOPPED THE CAR THEN AIR BAGS DEPLOYED. *TR

2 injured

Incident date: Sep 30, 2009

TL*THE CONTACT OWNS A 1999 PLYMOUTH VOYAGER. WHILE DRIVING APPROXIMATELY 60 MPH, HE ATTEMPTED TO ENGAGE THE BRAKE PEDAL AND NOTICED THAT THE BRAKE PEDAL WAS NON-RESPONSIVE. HE DROVE THE VEHICLE TO HIS RESIDENCE AND NOTIFIED A REPAIR SHOP. THE VEHICLE WAS TOWED TO THE REPAIR SHOP AND A MECHANIC STATE... Read more

Incident date: Aug 26, 2009

IGNITION IS LOCKED ON MY 1999 PLYMOUTH VOYAGER. CANNOT START THE CAR AT CALL. *TR

Incident date: Apr 6, 2009

TL*THE CONTACT OWN A 1999 PLYMOUTH VOYAGER. THE CLOCK SPRING CAUSED THE AIR BAGS, HORN AND CRUISE CONTROL TO FAIL. THE DEALER STATED THAT THE PARTS WERE ON BACK ORDER. THEY DON'T KNOW WHEN THEY WILL BE ABLE TO REPAIR THE VEHICLE. THE FAILURE MILEAGE WAS 146,520.

Incident date: Aug 10, 2008

TL*THE CONTACT OWNS A 1999 PLYMOUTH VOYAGER. THE CONTACT TOOK THE VEHICLE TO THE REPAIR GARAGE FOR ROUTINE SERVICE. HE WAS INFORMED THAT THE STRUT TOWER WAS CORRODED DUE TO DEFECTED METAL. THE FAILURE ALLOWED SALT TO PENETRATE AND CORRODE THE STRUTS. THE VEHICLE WILL BE REPAIRED. THE CURRENT AN... Read more

Incident date: May 8, 2008

TL*THE CONTACT OWNS A 1999 CHRYSLER VOYAGER. WHILE DRIVING BETWEEN 5-10 MPH, THE VEHICLE WOULD NOT STOP. THE FAILURE HAS BEEN OCCURRING EVERYDAY SINCE THE VEHICLE WAS PURCHASED. THE BRAKES HAVE BEEN INSPECTED EACH YEAR. THE CONTACT STATED THAT THE BRAKES ARE NOT GRABBING. THE CURRENT MILEAGE WA... Read more

Incident date: Feb 1, 2008

EVERY TIME IT'S REALLY WET OUT RAINING OR SNOW MY SERPENTINE BELT COMES OFF, THIS IS BECOMING A HUGE PROBLEM CAUSE NO ONE KNOWS HOW TO FIX THIS, WELL WHEN BELT COMES OFF YOU CANT STEER IT'S VERY HARD TO TURN WHEEL, NOTHING HAS BEEN DONE TO CORRECT FAILURE OTHER THEN KEEP SPENDING MONEY ON NEW BELT... Read more

Incident date: Feb 20, 2008

INSTRUMENT CLUSTER NOT WORKING (ALL GAUGES FLATLINED). APPARENTLY THIS IS A COMMON PROBLEM DUE TO POOR SOLDER ON THE BACK OF THE UNIT. THIS ALSO LED IN THE PAST TO UNCONTROLLED CYCLING OF THE DOOR LOCKS. *TR

Incident date: Jan 22, 2008

TL*THE CONTACT OWNS A 1999 PLYMOUTH VOYAGER. WHILE DRIVING 65 MPH, THE BRAKE LINE FAILED. THE DEALER STATED THAT THE ENTIRE BRAKE LINE WAS BADLY CORRODED. THE CONTACT STATED THAT IT WAS A CATASTROPHIC FAILURE THAT SHOULD HAVE NEVER OCCURRED. THE CURRENT AND FAILURE MILEAGES WERE 104,000. UPDA... Read more

Incident date: Jan 1, 2008

PURCHASED USED PLYMOUTH IN OCTOBER 2007 WITH 5393 MILES ON THE ODOMETER. REGISTERED AND DROVE IT FROM DECEMBER 3, 2007 TO JAN 2, 2008. NOTICED SIGNIFICANT AMOUNT OF TRANSMISSION FLUID UNDER THE VEHICLE AND FILM OF FLUID ON BACK WINDOW AND HATCH AREA. OBSERVED FLUID PUMPING OUT FROM UNDER THE CAR.... Read more

Incident date: Nov 5, 2007

TRANSMISSION IS SHIFTING TERRIBLE!THE BACK DOOR WILL NOT OPEN AT ALL,THE SIDE DOOR WILL NOT OPEN FROM INSIDE. MY LIGHTS FROM THE INSIDE OF VEHICLE GOES ON AND OFF. WHILE DRIVING DOWN THE ROAD THE VAN SHAKES TERRIBLE, IT FEELS LIKE THE MOTOR SHAKES. *TR

Incident date: Nov 5, 2007

Incident date: Nov 11, 2007

OBSERVED THAT THE DRIVER'S SIDE STRUT TOWER IS RUSTED THROUGH TWO LAYERS OF METAL AND PERFORATED OVER HALF THE WAY AROUND FRONT TOP OF THE STRUT TOWER. VEHICLE HAS LITTLE OTHER BODY RUST EXCEPT THIS SHOCK / STRUT TOWER AREA AND THERE NEEDS TO BE A SAFETY RECALL TO REPAIR THIS DEFECTIVE ITEM BEFORE F... Read more

Incident date: Nov 11, 2007

Incident date: Aug 29, 2007

OBSERVED THAT THE DRIVER'S SIDE STRUT TOWER IS RUSTED THROUGH TWO LAYERS OF METAL AND PERFORATED OVER HALF THE WAY AROUND FRONT TOP OF THE STRUT TOWER. VEHICLE HAS NO OTHER BODY RUST EXCEPT THIS SHOCK / STRUT TOWER AREA AND THERE NEEDS TO BE A SAFETY RECALL TO REPAIR THIS DEFECTIVE ITEM BEFORE FURT... Read more

Incident date: Aug 29, 2007

Incident date: Sep 1, 2007

TL*THE CONTACT OWNS A 1999 PLYMOUTH VOYAGER. THE CONTACT COULD NOT START HER VEHICLE AND IT WAS TOWED TO A MECHANIC. THE MECHANIC STATED THAT A CYLINDER IN THE TUMBLER, WHERE THE KEY IS PLACED IN THE IGNITION TO START THE VEHICLE, FAILED. THE FAILURE FIRST OCCURRED AT 60,000 MILES AND RECURRED ON... Read more

Incident date: Jul 31, 2007

1999 PLYMOUTH VOYAGER CAUGHT FIRE IN THE ENGINE COMPARTMENT. *KB OHIO TRAFFIC CRASH REPORT. *JB

Fire

Incident date: Aug 20, 2007

1999 PLYMOUTH GRAND VOYAGER THROWS SERPENTINE BELT WHEN DRIVING THROUGH A PUDDLE, RESULTING IN LOSS OF STEERING. *TR

Incident date: Jun 15, 2007

TL*THE CONTACT OWNS A 1999 PLYMOUTH VOYAGER. WHILE DRIVING 20 MPH, THE VEHICLE ACCELERATED AUTOMATICALLY TO 45 MPH. THE CONTACT ATTEMPTED TO APPLY THE BRAKES, BUT THE VEHICLE FAILED TO STOP. THE CONTACT CRASHED INTO THE REAR END OF ANOTHER VEHICLE. A POLICE REPORT WAS FILED. THE VIN, ENGINE SIZ... Read more

Crash

Incident date: Jun 8, 2007

TL*THE CONTACT OWNS A 1999 PLYMOUTH VOYAGER. THE CONTACT STATED THAT THE SHOCK TOWERS HAVE ALL RUSTED. IT IS THE ONLY AREA ON THE VEHICLE THAT HAS RUST DAMAGE. THE CONTACT STATED THAT THE AIR CONDITIONING SYSTEM IS NOT WORKING, EVEN THOUGH HE HAS SPENT $1,000 TO HAVE IT REPAIRED. THE PURCHASE DA... Read more

Incident date: Nov 24, 2003

TL*THE CONTACT OWNS A 1999 PLYMOUTH VOYAGER. THE CONTACT STATED THAT WHILE DRIVING THROUGH WET CONDITIONS THE SERPENTINE BELT WOULD DETACH FROM THE VEHICLE. THE VEHICLE WAS TOWED TO A DEALER FOUR TIMES. EACH TIME THE DEALER WOULD REATTACH THE BELT,THE SAME FAILURE WOULD OCCUR. THE DEALER WAS UNA... Read more

Incident date: Dec 7, 2006

TL* - THE CONTACT STATED THAT ON DECEMBER 7, 2006, WHILE DRIVING A 1999 GRAND VOYAGER SE AT 3 MPH SHE SAW FLAMES IN REARVIEW MIRROR. THE CONTACT STATED THAT THE STEREO SYSTEM'S SPEAKER WAS ON FIRE. HOWEVER, NO ONE WAS INJURED IN THE FIRE, BUT THAT FIRE SPREAD TO THE 3RD ROW SEAT, AND THE REAR DRI... Read more

Fire

Incident date: Aug 1, 2006

I BOUGHT KELLY/SPRINGFIELD NAVIGATOR GOLD TIRES P205/75R14 ON 6/21/05. THE BELTS ARE SHOWING THROUGH ON 2 OF THE TIRES, THE 3RD TIRE IS EXTREMELY WARN AND THE 4TH IS WARN ALL WITHIN 21,000 MILES. I HAVE NOTICED RECALLS ON SIMILAR TIRES WITH THE SAME PROBLEMS, ESPECIALLY P205/70R14. *JB

Incident date: Jul 4, 2006

I IMPORTED A CHRYSLER VOYAGER TO NEW ZEALAND VIN [XXX] WHICH NOT COMPLY FOR FRONTAL IMPACT. I EMAILED CHRYSLER TO GET A STATEMENT OF COMPLIANCE FOR THE VEHICLE BECAUSE I CAN'T REGISTER THE CAR IN THE COUNTRY DUE THE POOR SAFETY ACTION FOR FRONTAL IMPACT. WWW.LTSA.GOVT.NZ SAID THAT ALL CARS MANUFACTU... Read more

Incident date: Jul 27, 2006

DT*: THE CONTACT STATED, WHILE DRIVING DURING LIGHT RAIN, AT 50 MPH., THE POWER STEERING BELT DETACHED CAUSING THE STEERING TO BE DIFFICULT. THE INDEPENDENT SERVICE MECHANIC REPLACED THE COMPONENT. THE POWER STEERING BELT DETACHED AGAIN UNDER THE SAME CIRCUMSTANCES. THE INDEPENDENT SERVICE MECHANIC ... Read more

Incident date: Jul 7, 2006

FOUND BLISTERING STEEL ON LEFT STRUT TOWER. WAS CONCERNED BECAUSE STRUT TOP IS SUPPORTED BY THE TOWER. USED A SCREWDRIVER AND HAMMER TO KNOCK RUSTED METAL LOOSE. FOUND HOLES CLEAR THROUGH THE METAL INTO THE WHEEL WELL. TOOK THE VEHICLE TO THE DEALER. WAS TOLD THIS IS A COMMON PROBLEM WITH A BUL... Read more

Incident date: Jun 15, 2006

STRUT ON LEFT SIDE FRONT RUSTING ON TOP AROUND BOLTS. *JB

Incident date: Dec 3, 2005

ON 12/03/2005, MY 1999 PLYMOUTH GRAND VOYAGER MINI VAN'S TIE RODS FAILED AND MY WHEELS WENT WALL-EYED. MY CAR SLID INTO AN UNOCCUPIED PARKED VEHICLE CAUSING DAMAGE TO BOTH VEHICLES. MY SON-IN-LAW LOOKED UNDER THE VEHICLE AND TOLD ME THAT MY TIE RODS BROKE. I WAS DRIVING AT 25 MILES PER HOUR. TH... Read more

Crash

Incident date: Feb 23, 2006

DT*: THE CONTACT STATED WHILE DRIVING 30MPH, THE AIRBAG WARNING LIGHT ILLUMINATED WITHOUT ANY PRIOR WARNING. AFTERWARDS, THE DASH PANEL CLOCK, RADIO, AND HEATING DEFROSTER STOPPED WORKING. THE CONTACT PARKED THE VEHICLE AND ATTEMPTED TO TURN THE ENGINE OFF. THE KEY WOULD NOT RELEASE FROM THE IGN... Read more

Incident date: Feb 23, 2006

Incident date: Jan 28, 2006

DT*: THE CONTACT STATED WHILE DRIVING 50MPH BRAKE PRESSURE WAS APPLIED AND THE VEHICLE HAD AN INCREASED STOPPING DISTANCE. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT REPAIR SHOP. THE MECHANIC SUGGESTED REPLACING THE ANTILOCK BRAKE BOOSTER ASSEMBLY. ALTHOUGH THE PROBLEM PERSISTED, NO REPAIRS WER... Read more

Showing 50 of 362 complaints.

Technical Service Bulletins — 1999 PLYMOUTH VOYAGER

109 manufacturer communications from 102 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
162000 STRUCTURE:BODY	9
110000 ELECTRICAL SYSTEM	7
061000 ENGINE AND ENGINE COOLING:ENGINE	7
980000 UNKNOWN OR OTHER	6
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER	6
160000 STRUCTURE	5
350000 EQUIPMENT	5
162300 STRUCTURE:BODY:DOOR	4

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehi

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

110000 ELECTRICAL SYSTEM

Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are nece

350000 EQUIPMENT

160000 STRUCTURE

Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.

350000 EQUIPMENT

Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.

160000 STRUCTURE

Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.

350000 EQUIPMENT

Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.

160000 STRUCTURE

Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.

350000 EQUIPMENT

Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.

160000 STRUCTURE

Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.

160000 STRUCTURE

Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.

060000 ENGINE AND ENGINE COOLING

Valve Body. These may cause over drive cycling.

040000 SERVICE BRAKES, AIR

SNOW/WATER INGESTION INTO REAR BRAKE DRUM. *KB

034400 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM

SNOW/WATER INGESTION INTO REAR BRAKE DRUM. *TT

034400 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM

SNOW/WATER INGESTION INTO REAR BRAKE DRUM. *TT

010000 STEERING

POP/TICK SOUND IN STEERING WHEEL AREA. *TT

162000 STRUCTURE:BODY

COSMETIC CORROSION OR PERFORATION AT UPPER STRUT TOWER/S USUALLY BETWEEN THE STRUT AND UPPER LOAD PATH BEAM INNER PANEL (INNER FENDER). *TT

034400 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM

SNOW/WATER INGESTION INTO REAR BRAKE DRUM. *YD THIS BULLETIN SUPERSEDES 05-001-02 DATED MARCH 4, 2002. *TT

140000 AIR BAGS

CONCERNS WITH THE AIR BAG WARNING INDICATOR LAMP ON INTERMITTENTLY OR CONSTANTLY. *TT

980000 UNKNOWN OR OTHER

FLASH PROGRAMMING FAILURE RECOVERY. *SLC

135200 VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR

SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *SLC

011000 STEERING: STEERING WHEEL/HANDLE BAR

EXPERIENCING A POP/TICK SOUND HEARD COMING FROM THE STEERING WHEEL AREA WHILE THE VEHICLE IS IN MOTION. *TT

103600 POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES

SUBJECT REGARDING TRANSMISSION OIL COOLER LINE HOSE CLAMP SERVICE. *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

SUBJECT REGARDING CAMSHAFT / BEARING SERVICE. *TT

135200 VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR

SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *TT

021000 SUSPENSION:FRONT

EXPERIENCING A SQUAWK / CREAK / GROAN SOUND FROM FRONT SUSPENSION WHILE DRIVING OVER ROUGH / BUMPY ROADS. *TT

110000 ELECTRICAL SYSTEM

SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT

350000 EQUIPMENT

SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. *TT

034500 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC

A CONDITION MAY EXIST WHERE A LOW FREQUENCY HOWL / MOAN NOISE IS HEARD FROM THE REAR BRAKE AREA DURING LOW SPEED AND / OR LOW SPEED TURNS SUCH AS A PARKING LOT MANEUVER, WITH NO BRAKE PEDAL PRESSURE APPLIED. *TT

034430 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:DRUM

ON SOME VEHICLES, WHILE DRIVING THROUGH DEEP OR BLOWING SNOW / WATER, THE SNOW / WATER MAY ENTER THE REAR BRAKE DRUMS CAUSING RUST TO DEVELOP ON THE REAR BRAKE DRUM AND SHOE FRICTION SURFACES. THIS CONDITION CAN LEAD TO TEMPORARY FREEZI

110000 ELECTRICAL SYSTEM

SUBJECT REGARDING WIRE SPLICE REPAIRS. *SB

135000 VISIBILITY:REARVIEW MIRRORS/DEVICES

SUBJECT REGARDING OUTSIDE MIRROR GLASS REPLACEMENT. *TT

980000 UNKNOWN OR OTHER

INFORMATION ON SERVICE PUBLICATION UPDATES. *JB

220000 SEATS

SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT

162300 STRUCTURE:BODY:DOOR

EXPERIENCING A CHATTER SOUND COMING FROM THE SLIDING DOOR POWER LOCK ACTUATOR(S) WHEN THE POWER LOCK FEATURE IS REPEATEDLY ACTIVATED. *TT

070000 FUEL SYSTEM, GASOLINE

INFORMATION REGARDING UPDATES TO THE FUEL SYSTEM SERVICE PROCEDURES. *TT

140000 AIR BAGS

SUBJECT REGARDING NON-DEPLOYED AIRBAG HANDLING PROCEDURES. *TT

063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

SUBJECT REGARDING EGR MONITOR DIAGNOSTIC TEST DIFFICULT TO COMPLETE OR NOT READY AT HIGH ALTITUDES (ABOVE 4000 FEET). *TT

110000 ELECTRICAL SYSTEM

A CONDITION MAY EXIST WHERE THERE IS INTERMITTENT OPERATION / STATIC OCCURING IN THE FRONT INSTRUMENT PANEL SPEAKERS. *TT

162000 STRUCTURE:BODY

A CONDITION EXIST WHERE THE ROOF PANEL SURFACE EXHIBITS WAVINESS OR DEPRESSION(S) NEAR THE FRONT OF THE CHARACTER FEATURES OR SKID STRIP FOR ROOF RACK EQUIPPED VEHICLES. *TT

198000 TIRES:TEMPORARY/EMERGENCY SPARE TIRE

INFORMATION ON SPARE TIRE WINCHES. *TT

162000 STRUCTURE:BODY

THIS BULLETIN CONTAINS PROCECURES TO REMOVE WAVINESS OR DEPRESSIONS FROM THE ROOF PANEL SURFACE. *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

SUBJECT PERTAINS TO CHANGES TO THE TIMING BELT TENSIONER COMPONENTS. *TT

220000 SEATS

SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT

020000 SUSPENSION

EXPERIENCING A KNOCKING / CLUNKING SOUND COMING FROM THE FRONT SWAY BAR LINK HEARD INSIDE AND OUTSIDE THE VEHICLE WHEN DRIVING OVER ROUGH ROADS. *TT

114000 ELECTRICAL SYSTEM:WIRING

THIS BULLETIN PROVIDES A REVISED WIRE SPLICE PROCEDURE AND RELATED PARTS. *TT

010000 STEERING

A CONDITION WHERE A CLICK / RATTLE SOUND MAY BE HEARD COMING FROM THE AREA OF THE STEERING WHEEL WHILE THE VHICLE IS IN MOTION. *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

SUBJECT REGARDING MISDIAGNOSED LEAK DETECTION PUMP SYSTEMS WITH DIAGNOSTIC TROUBLE CODES P1494, P0442 P0455, OR P0456. *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

CONCERNS WITH THE PCV VALVE FREEZING UNDER EXTREMELY COLD CONDITIONS. *TT

034430 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:DRUM

INFORMATION REGARDING SNOW / WATER ENTERING THE REAR BRAKE DRUMS. *TT

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

VEHICLE OPERATOR MAY COMPLAIN OF POOR AM RADIO RECEPTION. *TT

145000 AIR BAGS:ON-OFF SWITCH ASSEMBLY

DAIMLERCHRYSLER CORPORATION IS NOW OFFERINB AIRBAG ON / OFF SWITCHES FOR SELECTED VEHICLES. *TT

051100 PARKING BRAKE:CONVENTIONAL:MECHANICAL

INFORMATION ON REAR WHEEL PARK BRAKE ACTUATOR / LEVER SERVICE. *TT

106000 POWER TRAIN:AXLE ASSEMBLY

SUBJECT ON TRANSAXLE SEEPAGE MIS-DIAGNOSIS- CASE POROSITY. *MJS

162000 STRUCTURE:BODY

SUBJECT ON THE CHILD SEAT TETHER ANCHORS. *MJS

061000 ENGINE AND ENGINE COOLING:ENGINE

TECHNICAL SERVICE BULLETIN REGARDING MULTI-LAYER STEEL (MLS) HEAD GASKET INSTALLATION PROCEDURES. *TT

980000 UNKNOWN OR OTHER

SOME VEHICLES MAY EXHIBIT INTERMITTENT MALFUNCTION INDICATOR LIGHT (MIL) ILLUMINATION WITH HEX CODE $1B (P0123) THROTTLE POSITION SENSOR (TPS) VOLTAGE HIGH. *TT

116100 ELECTRICAL SYSTEM:IGNITION:SWITCH

INFORMATION REGARDING THE IGNITION SWITCH HOUSING SERVICE. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

THIS BULLETIN ANNOUNCES THE AVAILABILITY AND INSTALLATION OF A RESUABLE AUTOMATIC TRANSMISSION OIL PAN GASKET. *TT

220000 SEATS

INFORMATION ON CHILD SEAT TETHER ANCHORS. *TT

180000 VEHICLE SPEED CONTROL

CONCERNS WITH SPEED CONTROL WHICH DOES NOT MAINTAIN SET SPEED WHILE CLIMBING A GRADE. *TT

181000 VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

EXPERIENCING VIBRATION / BUZZ IN THE ACCELERATOR PEDAL AT 2200 - 2500 RPM AND ABOVE 3500 RPM. *TT

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

VEHICLES MAY EXHIBIT AN INTERMITTENT CONDITION WHERE THE A/C SYSTEM BLOWS WARM AIR AFTER THE A/C SYSTEM HAD BEEN WORKING PROPERLY. *TT

162300 STRUCTURE:BODY:DOOR

CONCERNS WITH THE RIGHT SIDE SLIDING DOOR TRIM PANEL CONTACTING THE QUARTER PANEL WHEN THE DOOR IS OPENED. *TT

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

THIS BULLETIN EXPLAINS THE OPERATION AND APPLICATION OF THE LEAK DETECTION PUMP (LDP) MONITOR TEST. *TT

980000 UNKNOWN OR OTHER

CONDITIONS WITH INOPERATIVE OR INTERMITTENT REMOTE KEYLESS ENTRY (RKE) TRANSMITTER. *TT

162000 STRUCTURE:BODY

EXPERIENCING TICK TYPE NOISE AT TOP OF LEFT B-PILLAR. *TT

061110 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS

CONCERNS WITH SERPENTINE BELT SLIPPING OFF IDLER PULLEY. *TT

063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

EMISSIONS CALL FOR AN INCORRECT VEHICLE EMISSION CONTROL INFORMATION (VECHI) LABEL WHICH WAS INADVERTENTLY INSTALLED. *TT

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

SOME VEHICLES MAY EXHIBIT A CONDITION WHERE THE AIR CONDITIONER SYSTEM BLOWS WARM AIR INTERMITTENTLY. *TT

980000 UNKNOWN OR OTHER

CONDITIONS WITH INOPERATIVE OR INTERMITTENT REMOTE KEYLESS ENTRY (RKE) TRANSMITTER. *TT

106000 POWER TRAIN:AXLE ASSEMBLY

INFORMATION ON FAST FEEDBACK FLEET - INSTALLATION OF 2000 MODEL YEAR 41TE TRANSAXLES. *TT

120000 EXTERIOR LIGHTING

SERVICE ACTION REGARDING HEADLAMP AIM PROCEDURE CHANGE. *TT

190000 TIRES

SUBJECT PERTAINING TO SMOOTH ROAD HIGH-SPEED VIBRATION OR SHAKE CONDITION. *TT

190000 TIRES

CUSTOMER MAY COMPLAIN OF LOW SPEED TIRE WOBBLE. *TT

180000 VEHICLE SPEED CONTROL

CONDITIONS WITH INTERMITTENT LOSS OF SPEED CONTROL. *TT

355100 EQUIPMENT:OTHER:LABELS

SERVICE ACTION REGARDING AN INCORRECT VEHICLE EMISSIONS CONTROL INFORMATION (VECI) AND MONRONEY LABELS INSTALLED ON VEHICLES EQUIPPED WITH CALIFORNIA EMISSION. *TT

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

VEHICLES MAY EXPERIENCE FAULTS RELATED TO THE TRANSMISSION RANGE SENSOR (TRS). *TT

354300 EQUIPMENT:MECHANICAL:CARRIER/RACK

SERVICE ACTION REGARDING VEHICLES EQUIPPED WITH LUGGAGE RACK CROSSBAR INSTALLATION INFORMATION. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

SUBJECT REGARDING REUSABLE AUTOMATIC TRANSMISSION OIL PAN GASKET. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

SERVICE AND PARTS INFORMATION ON 1999 RUNNING CHANGES TO TRANSMISSION RANGE SENSOR (TRS) *TT

162300 STRUCTURE:BODY:DOOR

CONCERNS WITH FRONT AND / OR SLIDING DOOR POWER LOCK MOTORS MAKING A WHIRLING NOISE. *TT

162000 STRUCTURE:BODY

SUBJECT PERTAINING TO A TICKING TYPE NOISE AT TOP OF LEFT B-PILLAR. *TT

145000 AIR BAGS:ON-OFF SWITCH ASSEMBLY

SUBJECT REGARDING AIRBAG ON - OFF SWITCHES. *YC

061000 ENGINE AND ENGINE COOLING:ENGINE

SUBJECT REGARDING OIL SEEPAGE AT CAM POSITION SENSOR / MISINTERPRETED HEAD GASKET LEAK. *YC

131000 VISIBILITY:WINDSHIELD

WINDNOISE AROUND FRON DOOR GLASS, ESPECIALLY AT TOP OF THE B PILLAR. *AK

061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

VEHICLE EXPERIENCING A TICKING NOISE WHILE AT IDLE FROM ENGINE. *YC

061000 ENGINE AND ENGINE COOLING:ENGINE

A NEW MULTI-LAYER STEEL ( MLS ) HEAD GASKET HAS BEEN DEVELOPED AND IS BEING IMPLEMENTED INTO PRODUCTION VEHICLES. *YC

063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

SUBJECT REGARDING I/M ( INSPECTION MAINTENANCE ) TESTING - OBD II "CARB" READINESS MONITOR INFORMATION. *YC

980000 UNKNOWN OR OTHER

APPROVAL OF USING OF IN- TRANSIT PROTECTIVE FILM. ON ALL VEHICLES AT ALL ASSEMBLY PLANTS. *AK

110000 ELECTRICAL SYSTEM

INFORMATION ON ELECTRICAL FEATURE CHANGES. *YC

105000 POWER TRAIN:DRIVELINE

RIGHT SIDE HALF SHAFT CV BOOT IS MADE OF A SPECIAL HIGH TEMPERATURE RESISTANT MATERIAL THAT CAN SHOW HEAVY GREASE SEPAGE-ENOUGH TO FORM DROPLETS ON THE BOOT CONVOLUTES. *AK

105200 POWER TRAIN:DRIVELINE:CONSTANT VELOCITY JOINT

RIGHT SIDE HALF SHAFT CV BOOT IS MADE OF A SPECIAL HIGH TEMPERATURE RESISTANT MATERIAL THAT CAN SHOW HEAVY GREASE SEPAGE-ENOUGH TO FORM DROPLETS ON THE BOOT CONVOLUTES. *AK

020000 SUSPENSION

A SQUEAKING / CHIRPING NOISE IS HEARD ( INSIDE OR OUTSIDE THE VEHICLE ) FROM THE STRUT TOWER AREA( S ). *YC

110000 ELECTRICAL SYSTEM

SUBJECT REGARDING BODY CONTROL MODULE AUTO HEADLAMP SENSOR/ SIGNAL CIRCUIT DIAGNOSTIC TROUBLE CODE (DTC). *YC

162000 STRUCTURE:BODY

SUBJECT ON FLASH PROGRAMMING FAILURE RECOVERY. *YC

010000 STEERING

A "HONK" OR SQUEAL NOISE DURING PARKING LOT MANEUVERS. *YC

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

CONDITION WITH A/C COMPRESSOR LOCK-UP AT LOW MILEAGE. *YC

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

EXHIBITING A MOANING AND GROANING SOUND ACCOCIATED WITH A/C COMPRESSOR OPERATION. *YC

Showing 100 of 109 bulletins.

NHTSA Safety Investigations — PLYMOUTH VOYAGER

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE — Closed — Model Year: 1984

FRNT COIL SPRNG FRACTURE

There is no summary currently available

DP — Closed — Model Year: 1985

ENGINE FIRE

PLYMOUTH VOYAGER — All Years Overview

Complete safety history for the PLYMOUTH VOYAGER across all model years (1978–2000).

132 Total Recalls

6,868 Total Complaints

2 Investigations

502 Reported Crashes

190 Reported Fires

24 Reported Deaths

PLYMOUTH VOYAGER — Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2000	8	214	View
1999 (current)	10	362
1998	11	443	View
1997	11	474	View
1996	15	1,111	View
1995	4	476	View
1994	5	670	View
1993	10	749	View
1992	11	893	View
1991	10	624	View
1990	6	270	View
1989	5	204	View
1988	5	109	View
1987	3	99	View
1986	4	80	View
1985	6	38	View
1984	6	23	View
1983	1	7	View
1980	0	1	View
1978	1	1	View

Other PLYMOUTH Models

Model	Recalls	Complaints
GRAND VOYAGER	82	3,388	View
FURY	53	5	View
BREEZE	44	872	View
VALIANT	37	0	View
HORIZON	33	31	View
SATELLITE	28	1	View
PROWLER	24	69	View
RELIANT	22	67	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

1999 PLYMOUTH VOYAGER

Complaint Statistics

Top Reported Components

Technical Service Bulletins — 1999 PLYMOUTH VOYAGER

Most Affected Components

NHTSA Safety Investigations — PLYMOUTH VOYAGER

PLYMOUTH VOYAGER — All Years Overview

PLYMOUTH VOYAGER — Year by Year

Other PLYMOUTH Models