2016 CHRYSLER PACIFICA

0 recalls, 6 complaints - 184 TSBs

No recalls found for this vehicle.

Complaint Statistics

6 total complaints

Top Reported Components

Component	Complaints
ELECTRONIC STABILITY CONTROL (ESC)	1
ENGINE	1
FUEL/PROPULSION SYSTEM	1
ELECTRICAL SYSTEM	1
POWER TRAIN	1
SUSPENSION	1

Incident date: Mar 1, 2019

THE FRONT AXLE BROKE WITH NO EVIDENCE OF IMPACT OR DAMAGE. THE AXLE BROKE WHILE OPERATING THE VEHICLE AT LESS THAN 30 MPH ON A RESIDENTIAL STREET. THE VEHICLE HAS APPROXIMATELY 12,700 MILES ON IT. THE DEALERSHIP CANNOT IDENTIFY A REASON FOR THE FRONT AXLE BREAKING. THIS CAUSED THE VEHICLE TO BE UNAB... Read more

Incident date: Mar 1, 2019

Incident date: Oct 6, 2017

CAR SHUTS OFF WHILE DRIVING. WARNINGS TO PUT THE CAR IN PARK AND ELECTRONIC STABILITY ISSUES MAY POP UP. THE ENGINE MAKES A WEIRD NOISE AND THE CAR WILL OFTEN NOT SHIFT TO PARK TO RESTART. THIS HAS OCCURRED THREE SEPARATE OCCASIONS FOR ME. EACH TIME I WAS LUCKILY DRIVING SLOWLY PRIOR TO A TURN. I ... Read more

Incident date: Oct 6, 2017

Technical Service Bulletins, 2016 CHRYSLER PACIFICA

184 manufacturer communications from 105 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
350000 EQUIPMENT	29
110000 ELECTRICAL SYSTEM	17
060000 ENGINE AND ENGINE COOLING	11
160000 STRUCTURE	11
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL	10
353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.	7
100000 POWER TRAIN	6
070000 FUEL SYSTEM, GASOLINE	6

111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On

020000 SUSPENSION

LIFTER, Hydraulic Roller Deactivating Please do not replace MDS lifters because the disconnecting pin is not lined up, this is normal and not a defect.

114000 ELECTRICAL SYSTEM:WIRING

Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. There is an error with the wiring diagrams in Service Library that is causing

110000 ELECTRICAL SYSTEM

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Warranty Bulletin D-16-03 - "Can / Am" Warranty Coverage - 594 / 595 / 596 WCC (Rev. B)

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

FCA Caribbean Warranty Bulletin ID-23-20 "Can / Am" Warranty Coverage - 594 / 595 / 596 WCC

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Lubrication and Maintenance Fluids If MOPAR fluids and chemicals are not readily available, please review Service Library for specifications so a suitable alternative can be used

060000 ENGINE AND ENGINE COOLING

Water Quality When Mixed With Engine Coolant

060000 ENGINE AND ENGINE COOLING

wiTECH Small Leak Verification Test (SLVT) - P0456-EVAP SYSTEM SMALL LEAK

350000 EQUIPMENT

wiTECH Small Leak Verification Test (SLVT) - P0456-EVAP SYSTEM SMALL LEAK

110000 ELECTRICAL SYSTEM

270000 LANE DEPARTURE

280000 BACK OVER PREVENTION

160000 STRUCTURE

Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when welding

980000 UNKNOWN OR OTHER

163200 STRUCTURE:INTERIOR PANELS:DOOR

160000 STRUCTURE

353600 EQUIPMENT:ELECTRICAL:INFOTAINMENT

Panasonic 8.4" CTP/FCTP Radio, Update Failure

220000 SEATS

Oil Filter If a Mopar Oil Filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils. Recommended Brands: Wix, Purolator, and NapaGold For concerns of V8 oil filter

060000 ENGINE AND ENGINE COOLING

If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils.

350000 EQUIPMENT

If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils.

092300 FUEL SYSTEM, OTHER:FUEL FILTER

110000 ELECTRICAL SYSTEM

No Start, Cannot Complete Module Replace, Proxi Or Module Proxi Configuration

110000 ELECTRICAL SYSTEM

No Start, Cannot Complete Module Replace, Proxi Or Module Proxi Configuration

060000 ENGINE AND ENGINE COOLING

Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement engine has been installed in the vehicle.

060000 ENGINE AND ENGINE COOLING

Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement engine has been installed in the vehicle.

114000 ELECTRICAL SYSTEM:WIRING

WIRING, Body Before replacing this harness, please contact FCA Redacted Content to see if a repair kit is available for your application. If no response in 15 minutes, proceed with repair. Please email pictures of harness defects to FCA Re

110000 ELECTRICAL SYSTEM

Battery Tester Warranty Code Procedures, Midtronics Charger Update Process

350000 EQUIPMENT

Battery Tester Warranty Code Procedures, Midtronics Charger Update Process

100000 POWER TRAIN

Gear Ratio DTC?s, Transmission Shift Concerns, Does Not Shift At Times, Shudders

110000 ELECTRICAL SYSTEM

Battery Tester Warranty Code Procedures, Medtronic Update Process

350000 EQUIPMENT

Battery Tester Warranty Code Procedures, Medtronic Update Process

010000 STEERING

Steering System Inspection After a Collision This bulletin documents the FCA US LLC position regarding conditions under which replacement or repair of steering system components are required.

356230 EQUIPMENT ADAPTIVE/MOBILITY:VEHICLE CONTROLS:STEERING

Steering System Inspection After a Collision This bulletin documents the FCA US LLC position regarding conditions under which replacement or repair of steering system components are required.

100000 POWER TRAIN

Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles. If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) are one-time usag

060000 ENGINE AND ENGINE COOLING

Customer complaint may include engine oil leak/consumption.

110000 ELECTRICAL SYSTEM

(Rev. A) Battery Tester Warranty Code Procedures, Medtronic Update Process

185000 VEHICLE SPEED CONTROL:CRUISE CONTROL

Cruise Control Inoperative.

350000 EQUIPMENT

Cruise Control Inoperative.

356000 EQUIPMENT ADAPTIVE/MOBILITY

Cruise Control Inoperative.

160000 STRUCTURE

Disinfectant Solution Recommended for COVID-19

350000 EQUIPMENT

Disinfectant Solution Recommended for COVID-19

110000 ELECTRICAL SYSTEM

Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are nece

350000 EQUIPMENT

070000 FUEL SYSTEM, GASOLINE

Possible Driveability Issues due to the Winter-Blend Fuel into the Warmer Season

010000 STEERING

Hands On Steering Wheel Message In EVIC

110000 ELECTRICAL SYSTEM

Key Programming, Security Pin Request, Pin Invalid

350000 EQUIPMENT

Key Programming, Security Pin Request, Pin Invalid

020000 SUSPENSION

Air Suspension Components Star Parts Catalog has been updated to show individual service parts for the compressor assembly. This will allow service technicians to repair the root cause without over repairing the system. Replace only the pa

160000 STRUCTURE

Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.

130000 VISIBILITY

Authentic Mopar? Glass Replacement This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the recommended usage of Authentic Mopar? Glass.

350000 EQUIPMENT

Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.

160000 STRUCTURE

Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.

350000 EQUIPMENT

Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.

130000 VISIBILITY

Authentic Mopar? Glass Replacement This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the recommended usage of Authentic Mopar? Glass.

160000 STRUCTURE

Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.

350000 EQUIPMENT

Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.

160000 STRUCTURE

Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.

160000 STRUCTURE

Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.

070000 FUEL SYSTEM, GASOLINE

wiTECH Small Leak Verification Test (SLVT) - P0456-EVAP SYSTEM SMALL LEAK

060000 ENGINE (PWS)

wiTECH Small Leak Verification Test (SLVT) - P0456-EVAP SYSTEM SMALL LEAK

060000 ENGINE AND ENGINE COOLING

wiTECH Small Leak Verification Test (SLVT) - P0456-EVAP SYSTEM SMALL LEAK

350000 EQUIPMENT

RADIO [RES] - New and/or Service Exchange For RES radio concerns. Use the wiTECH 2.0 and inspect the radio part number and serial number under the Radio/ECU Details tab. Please verify that the radio part number and/or serial number is not

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

120000 EXTERIOR LIGHTING

Cam Phasers, Oil Control Valve For Malfunction Indicator Light (MIL) issues related to 2012-2017 3.6L Pentastar engines, please note that there is a new diagnostic procedure available in DealerCONNECT for P-codes in relationship to cam p

061500 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION

353600 EQUIPMENT:ELECTRICAL:INFOTAINMENT

RES / RHA / REB Radios That Support Bluetooth and Hands-Free 1. For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands; DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). Th

353630 EQUIPMENT:ELECTRICAL:INFOTAINMENT:BLUETOOTH/WIFI

280000 BACK OVER PREVENTION

Valve Cover and Gasket, Left and Right Pertains to vehicles equipped with a 3.6L V6 V.V.T. Engine only: Oil leaking from the valve cover onto the O2 sensor causing faults codes P0140, P2096, P0137, P0157. Need to verify the leak source a

350000 EQUIPMENT

Restraints Information Sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use.

010000 STEERING

Rain light sensor Rain sense wipers do not operate: 1. Visual Inspection--> Check if the sensor is visually OK. (all the pins are OK) Check that the Connector is NOT loose (Sensor must get a voltage from 9V to 16V) 2. Functional Check

050000 PARKING BRAKE

110000 ELECTRICAL SYSTEM

140000 AIR BAGS

280000 BACK OVER PREVENTION

200000 WHEELS

Pentastar Oil Filter Adapter All vehicles equipped with a 3.2L or 3.6L engine; If replacing the Oil Filter Adapter (OFA) due to a leak detected between OFA and block. Ensure the torque on the 5 (OFA) bolts are torqued to 12nm.

061520 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:FILTER/SCREEN

060000 ENGINE AND ENGINE COOLING

Pentastar Oil Filter Adapter All vehicles equipped with a 3.2L or 3.6L engine; If replacing the Oil Filter Adapter (OFA) due to a leak detected between OFA and block, an O-ring kit (68191356AA) is now available to repair OFA/Block Interfac

181000 VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

Accelerator Pedal Before replacing accelerator pedal, be sure to follow fault code diagnostic procedures in service manual. Make sure to check wiring and connectors. P2122 and P2127 will set if accelerator pedal connector is disconnected d

181000 VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

136000 VISIBILITY:WINDSHIELD WIPER/WASHER

Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the dash and the washer fluid bottle is full, please perform this inspection: Check if float sensor is rotated off location from the bottl

136000 VISIBILITY:WINDSHIELD WIPER/WASHER

162300 STRUCTURE:BODY:DOOR

Door Hinge Assembly Side door hinge noisy. Only replace the door hinge with the integral check device. Do not replace the simple hinge if it is not damaged it is not the source of the noise. Replacing it unnecessary and is an over-repair.

162310 STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS

060000 ENGINE AND ENGINE COOLING

Oil Pump Assembly If error code P06DD present on any Pentastar V6 application, please inspect oil pump for relief valve failure. See photo attached. If valve is found out of place please call Bob Jackson (248) 944-0466 bob.jackson@fcagroup

070000 FUEL SYSTEM, GASOLINE

150000 SEAT BELTS

Restraints Remove I-Sheet from packaging. Correct information sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use.

150000 SEAT BELTS

Restraints Remove I-Sheet from packaging. Correct information sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use.

150000 SEAT BELTS

Restraints Information Sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use.

150000 SEAT BELTS

Restraints Information Sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Electronic Shift Module If DTC's U11C3, U0074 are present Stored or Active, please contact Pemi Sabageh at cell (519) 300-0629 or David Dysarz at (248) 944-0310. If you do not receive a call within 15 minutes please proceed with the repa

118000 ELECTRICAL SYSTEM:SOFTWARE

RES / RHA / REB Radios That Supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). The

130000 VISIBILITY/WIPER (PWS)

Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the dash and the washer fluid bottle is full, please perform the this inspection. Inspect the sensor for a fluid coating on the sensor pi

114000 ELECTRICAL SYSTEM:WIRING

Return: Wiring Assy - Engine You have been identified as either having stock, or have stock in transit to your dealership. Please return stock packaged before 2016/07/31 (31 July, 2016)of follow ing part numbers:68176457AF, 68176459AF. P

350000 EQUIPMENT

Inspect and Return: Trim Cover Assy - A-Pillar Rt/Lt You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part numbers: 1ZA04DX9AE, 1ZA05DX9AE. See attachments for id

350000 EQUIPMENT

05182535AD - Lamp Assy ?Tail Light LT You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 05182535AD . See attachments for identifying suspect stock. Pl

120000 LIGHTING (PWS)

Showing 100 of 184 bulletins.

NHTSA Safety Investigations, CHRYSLER PACIFICA

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Open , Model Year: 2017

Intermittent Loss of Electric Power Steering

The Office of Defects Investigation (ODI) is opening this Preliminary Evaluation to assess the scope, frequency, and potential safety consequences of alleged defects related to the electric power steering (EPS) system in model year (MY) 2017–2018 Chrysler Pacifica vehicles. ODI has received 94 Veh... Read more

RQ, Open , Model Year: 2018

Loss of motive power due to an internal wiring connector short.

On July 22, 2022, the Office of Defects Investigation (ODI) opened investigation PE22-008 regarding complaints alleging a loss of motive power condition potentially due to a transmission malfunction in Model Years 2019-2021 Chrysler Pacifica Plug-In Hybrid Electric Vehicles (PHEV). On January 17, ... 2023, Fiat Chrysler Automobiles (FCA) issued safety recall (NHTSA Recall 23V-010) involving 2017-2023 Model Years (MY) Pacifica Plug-In Hybrid Electric Vehicles (PHEV) produced between August 12, 2016, through January 9, 2023. The recall states that the loss of motive power condition in these vehicles is caused by an internal transmission wiring connector that may short circuit, resulting in an unexpected engine shutdown. An unexpected engine shutdown can cause a loss of drive power, increasing the risk of a crash. In discussions with FCA on Recall 23V-010, ODI confirmed the recall was related to investigation PE22-008. The remedy for 23V-010 is to update the Power Inverter module (PIM) and/or Instrument Panel Cluster (IPC) software to provide drivers a message stating “Stop Safely - Vehicle Will Shut Off Soon” followed by a chime and MIL, PRNDL blinking (on cluster and shifter knob), low SOC (State of Charge) warning and reduced power mode. The recall remedy does not replace the defective hardware that was described in Recall 23V-010, and the wiring connector short still exists on these vehicles. To date, ODI has received 132 reports for the population of vehicles subject to recall 23V-010. These reports allege a loss of motive power condition that reduces the vehicles speed, followed by dashboard warning lamps displaying messages associated with recall 23V-010. The presence of these warning lamps and messages indicates the vehicle likely had the recall remedy applied. Follow up discussions with FCA confirm their remedy does not prevent a loss of motive power, but instead limits torque to the engine and after an unspecified number of miles or period of time, the engine will shut down. When this occurs, FCA relies on the owner to transport the vehicle to a dealership after they experience a loss of motive power condition, at which time the defective hardware is replaced. Furthermore, the dashboard messages introduced in the recall remedy may cause the driver to pull over in an unsafe location. Pulling over in an unsafe location may expose the occupants to undue harm. The Office of Defects Investigation is opening this Recall Query (RQ) to assess the adequacy, frequency, and safety consequence of the remedy for recall 23V-010. To review the ODI reports cited in the opening resume ODI report identification number document, go to NHTSA.gov.Read more

RQ, Open , Model Year: 2017

Ignition-off high voltage battery fire (Remedy effectiveness of Recall 22V-077)

On February 11, 2022, Fiat Chrysler Automobiles (FCA) issued a safety recall (NHTSA Recall 22V-077) on all 2017-2018 Pacifica Plug-In Hybrid Electric Vehicles (PHEV) produced between August 12, 2016 through August 7, 2018. The recall addresses ignition “OFF’ fires that originate at the high volt... Read more

PE, Closed , Model Year: 2018

Transmission fault leading to loss of motive power

On July 22, 2022, the Office of Defects Investigation (ODI) opened PE22008 to investigate allegation of loss of motive power, potentially due to transmission malfunction, in certain Chrysler Pacifica vehicles. In a January 17, 2023 letter to NHTSA, Fiat Chrysler Automobiles (FCA) submitted recall no... Read more

DP, Closed , Model Year: 2017

Stall/Loss of Motive Power

By letter dated November 30, 2017, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration requesting it open an investigation into allegations of engine stalling in the model year (MY) 2017 Chrysler Pacifica, a new vehicle platform. In support of its petition,... CAS cited 57 NHTSA complaints alleging an engine stall in the subject Pacifica vehicles, in addition to other information it provided.On December 1, 2017, NHTSA's Office of Defects Investigation opened Defect Petition 17-003 as requested by CAS.ODI sent an information request letter to Fiat Chrysler Automobiles (FCA), the manufacturer of the subject Pacifica vehicles, on December 12, 2017 requesting information related to engine stalling in Pacificas.The letter requested FCA provide the information by January 23, 2018.On January 11, 2018, and after technical discussions with ODI, FCA filed a defect information report advising the agency that it would conduct a safety recall of certain MY2017 Chrysler Pacificas to address a condition resulting in engine stalling without warning.The recall would address nearly 154,000 MY2017 Pacificas manufactured with engine control software that did not contain a routine intended to address loss of crankshaft position information required to keep the engine from stalling.FCA noted the condition could lead to a stall without illuminating a Malfunction Indicator Lamp, and without setting any Diagnostic Trouble Code.Given these conditions, dealer technicians would be unable to properly diagnose, much less correct the cause of the stalling, which resulted in additional stalling events and significant consumer frustration.ODI reviewed consumer complaints it received through the date of FCA's recall filing and identified 88 alleging engine stalling.The ODI complaints generally describe stalling that occurs at low engine (RPM) and/or vehicle speeds, and are consistent in that regard with most of the 445 reports FCA provided.Also both the ODI and FCA reports note that the engine could be readily restarted after stalling.Both circumstances are consistent with the root cause FCA identified and is conducting a recall to address.Additionally, FCA was able to identify an older vehicle population that used the same engine as the MY2017 Pacifica, however the vehicles were manufactured with the remedy level software; according to FCA reports of stalling in this population were significantly lower.No crash or injury reports were identified in either the ODI or FCA reports.Certain MY2017 and all MY2018 Pacificas were manufactured with the remedy level software and are thus not included in the recall action.In view of the recall action FCA has announced, ODI considers the petition moot and is closing the action without a grant or deny decision.The closing of the petition does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by future circumstances.Reference (ODI) numbers for the above NHTSA complaints:11060960, 11060808, 11060711, 11057809, 11057520, 11057493, 11057171, 11057169, 11057025, 11055566, 11055031, 11054808, 11054746, 11054717, 11054274, 11054085, 11053669, 11053588, 11053553, 11053322, 11052905, 11052892, 11052654, 11052336, 11051390, 11051158, 11048832, 11048728, 11048720, 11048661, 11048626, 11048175, 11047936, 11047831, 11047793, 11047687, 11047684, 11047399, 11045061, 11042619, 11040610, 11040502, 11040294, 11039494, 11035468, 11034698, 11033417, 11032016, 11030729, 11029903, 11025266, 11025119, 11023691, 11023539, 11022835, 11022154, 11021223, 11019457, 11016083, 1101Read more

EA, Closed , Model Year: 2007

ENGINE COMPARTMENT FIRE

THE AGENCY HAS CLOSED THIS INVESTIGATION BASED ON ITS REVIEW OF CONSUMER COMPLAINTS, FIELD REPORTS, WARRANTY CLAIMS AND OTHER DATA REGARDING ENGINE COMPARTMENT FIRES AND POWER STEERING FLUID LEAKAGE IN MODEL YEAR (MY) 2007 CHRYSLER PACIFICA VEHICLES WITH 4.0L ENGINES.THE AVAILABLE EVIDENCE INDICATES... Read more

PE, Closed , Model Year: 2007

ENGINE COMPARTMENT FIRE

COMPLAINANTS ALLEGE THAT A FIRE ERUPTED UNDER THE HOOD, NEAR THE FRONT OF THE VEHICLE.IN CHRYSLER'S RESPONSE TO ODI'S NOVEMBER 2, 2007 INFORMATION REQUEST, CHRYSLER ASSERTS THAT THE ALLEGED DEFECT OCCURS ONLY IN THE 4.0L ENGINES AND THE CONSUMER WILL EXPERIENCE A LOSS OF POWER STEERING FLUID OR A NO... Read more

EA, Closed , Model Year: 2005

ENGINE STALLING

IN A NOVEMBER 8, 2006 LETTER, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING TWO SEPARATE DEFECT CONDITIONS THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2005-2006 CHRYSLER PACIFICA VEHICLES (NHTSA RECALL NO. 06V-432).MY 2005 VEHICLES... BUILT IN AUGUST AND SEPTEMBER OF 2004 ARE BEING RECALLED TO CORRECT A DEFECT IN THE SECONDARY FUEL PUMP MODULES, WHICH MAY HAVE AN IMPROPER PRESS FITTING ON THE INLET THAT CAN BECOME DISLODGED AND SHUT-OFF FUEL FLOW.ALL MY 2005-2006 VEHICLES BUILT BETWEEN JULY 8, 2004 AND NOVEMBER 11, 2005 ARE BEING RECALLED TO CORRECT A POWERTRAIN CONTROL MODULE (PCM) SOFTWARE ISSUE WITH THE EVAPORATIVE EMISSIONS SYSTEM WHICH CAN ALSO CAUSE STALLING.FOR BOTH CONDITIONS, ENGINE STALL INCIDENTS TEND TO OCCUR DURING LEFT TURNS. THERE WERE 17,375 VEHICLES BUILT DURING AUGUST AND SEPTEMBER 2004 THAT WERE AFFECTED BY BOTH THE FUEL PUMP MODULE AND PCM SOFTWARE CONDITIONS.THERE WERE 30 VOQS SUBMITTED TO ODI, 58 CONSUMER COMPLAINTS TO DCC AND 829 FIELD REPORTS RELATING TO VEHICLES PRODUCED DURING THIS PERIOD.WHILE THESE ARE MOSTLY RELATED TO THE FUEL PUMP CONDITION, SOME MAY HAVE BEEN CAUSED BY THE SOFTWARE FAULT.THE RESULTING STALL WHILE DRIVING FAILURE RATE FOR THIS PERIOD IS 5,278 INCIDENTS PER 100,000 VEHICLES.THERE WERE TWO CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 1,021 WARRANTY CLAIMS FOR FUEL PUMP MODULE REPLACEMENT THAT APPEAR RELATED TO ENGINE STALL (5.9% CLAIM RATE). THE POPULATION FOR THE REMAINING VEHICLES INCLUDED IN 06V-432 (I.E., THOSE ONLY AFFECTED BY THE SOFTWARE CONDITION) IS 114,523.THERE WERE 97 VOQS, 124 CONSUMER COMPLAINTS TO DCC AND 454 DCC FIELD REPORTS RELATING TO THESE VEHICLES.THE RESULTING STALL WHILE DRIVING FAILURE RATE IS 589 PER 100,000 VEHICLES.THERE WERE SEVEN CRASHES ALLEGED TO HAVE RESULTED FROM THESE INCIDENTS.THERE WERE 3,211 WARRANTY CLAIMS FOR PCM REFLASH THAT APPEAR RELATED TO ENGINE STALL IN THE TOTAL POPULATION OF 131,898 VEHICLES (2.4% CLAIM RATE). ALL CALCULATIONS ARE BASED ON UNIQUE VINS (MULTIPLE/REPEAT FAILURES NOT INCLUDED IN THESE CALCULATIONS) WITH NO DUPLICATION ACROSS CATEGORIES.DCC'S RECALL WILL REPROGRAM THE PCM SOFTWARE AND REPLACE THE FUEL PUMP MODULES IN ALL AFFECTED VEHICLES.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.Read more

EA, Closed , Model Year: 2004

FUEL TANK PUNCTURES

EA06-010 WAS OPENED BASED ON INFORMATION GATHERED IN PRELIMINARY EVALUATION PE06-009.PE06-009 WAS OPENED BASED ON INFORMATION OBTAINED IN A PEER INFORMATION REQUEST AS PART OF A PRELIMINARY EVALUATION (PE05-050) OF FUEL TANK PUNCTURE IN MODEL YEAR (MY) 2003 THROUGH 2006 NISSAN MURANO VEHICLES.IN JAN... UARY 2006, NISSAN SUBMITTED A DEFECT INFORMATION REPORT TO ODI THAT IDENTIFIED A DEFECT IN THE FUEL TANK SHIELDING IN APPROXIMATELY 209,000 MY 2003 THROUGH 2006 NISSAN MURANO VEHICLES.TO REMEDY THE PROBLEM, NISSAN INSTALLED SHIELDS ON THE EXPOSED FRONT SURFACES OF THE RECALLED VEHICLES.PEER DATA COLLECTED FOR MY 2004 THROUGH 2005 PACIFICA VEHICLES DURING PE05-050 INCLUDED 120 FIELD REPORTS DOCUMENTING TANK REPLACEMENTS DUE TO PUNCTURE OR DAMAGE BY ROAD DEBRIS AS PART OF A PARTS RESTRICTION PROGRAM CONDUCTED AT THE REQUEST OF THE TANK SUPPLIER (INERGY). ANALYSIS OF THE INFORMATION PROVIDED BY CHRYSLER DURING PE05-050, PE06-009 AND EA06-010 SHOW THAT THE FRONT SURFACE OF THE FUEL TANKS IN THE SUBJECT PACIFICA VEHICLES IS NOT COMPLETELY PROTECTED FROMROAD DEBRIS BY THE FLOOR PAN OR OTHER BODY STRUCTURE.THE TANKS WERE COMPARED WITH PEER VEHICLES, INCLUDING SEVERAL IDENTIFIED BY CHRYSLER AS SHARING SIMILAR DESIGN CHARACTERISTICS (UNSHIELDED HIGH-DENSITY POLYETHYLENE PLASTIC FUEL TANKS IN A SADDLEBAG CONFIGURATION).SOME OF THE PEER DESIGNS REVIEWED BY ODI PACKAGED THE TANKS IN RECESSED CAVITIES IN THE FLOOR PAN OR USED SHIELDS TO PROTECT EXPOSED SURFACES ON THE FRONT OF THE TANK.IN GENERAL, THESE TANKS HAD THE LOWEST COMPLAINT RATES FOR TANK PUNCTURE BY ROAD DEBRIS. HOWEVER, OTHER PEER DESIGNS REVIEWED BY ODI HAD PACKAGING SIMILAR TO THE SUBJECT VEHICLES AND SOME OF THESE ALSO HAD SOME COMPLAINTS OF TANK PUNCTURE.NONE OF THE PEER VEHICLES ANALYZED BY ODI HAD TANKS PUNCTURE DATA COMPARABLE TO CHRYSLER'S FIELD REPORTS FROM ITS PART RESTRICTION PROGRAMS, SO THAT DATA COULD NOT BE USED IN PEER COMPARISONS. ANALYSIS OF THE COMPLAINT DATA SHOWS THAT THE RATE FOR THE SUBJECT VEHICLES IS ABOUT HALF THAT OBSERVED IN THE RECALLED MURANO VEHICLES AND NOT SIGNIFICANTLY HIGHER THAN SOME OF THE PEER VEHICLES ANALYZED WITH SIMILAR DESIGN CHARACTERISTICS.TESTING BY THE NHTSA VEHICLE RESEARCH AND TESTING CENTER (VRTC) SHOWED DIFFERENCES BETWEEN THE MURANO AND PACIFICA FUEL TANK PACKAGING AND EXPOSURE TO ROAD DEBRIS THROWN BY THE FRONT TIRES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.Read more

RQ, Closed , Model Year: 2004

ENGINE STALLING

ON FEBRUARY 27, 2006 RQ06-002 WAS OPENED IN RESPONSE TO 60 COMPLAINTS OF ENGINE STALL, MOSTLY DURING LEFT-HAND TURNS, IN MODEL YEAR (MY) 2004 TO 2006 CHRYSLER PACIFICA VEHICLES THAT WERE OUTSIDE THE SCOPE OF RECALL 04V-113.IN MARCH 2004, DAIMLERCHRYSLER INITIATED RECALL 04V-113 ON 34,561 MY 2004 PAC... Read more

PE, Closed , Model Year: 2004

FUEL TANK PUNCTURES

ON FEBRUARY 22, 2006, ODI OPENED PE06-009 TO INVESTIGATE REPORTS THAT THE FUEL TANKS ON MODEL YEAR (MY) 2004 TO 2005 CHRYSLER PACIFICA VEHICLES MAY BE PUNCTURED BY CONTACT WITH ROAD DEBRIS.THE NUMBER OF REPORTS SUBMITTED BY CHRYSLER WAS SIGNIFICANTLY HIGHER THAN THOSE SUBMITTED BY OTHER MANUFACTURER... Read more

CHRYSLER PACIFICA - All Years Overview

Complete safety history for the CHRYSLER PACIFICA across all model years (2004, 2026).

92 Total Recalls

10,494 Total Complaints

11 Investigations

381 Reported Crashes

168 Reported Fires

15 Reported Deaths

CHRYSLER PACIFICA - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2026	3	11	View
2025	8	33	View
2024	11	59	View
2023	14	228	View
2022	10	333	View
2021	7	652	View
2020	5	257	View
2019	7	452	View
2018	12	1,311	View
2017	10	2,325	View
2016 (current)	0	6
2008	0	155	View
2007	0	481	View
2006	1	1,056	View
2005	2	1,802	View
2004	2	1,332	View
2003	0	1	View

Other CHRYSLER Models

Model	Recalls	Complaints
TOWN AND COUNTRY	209	19,029	View
SEBRING	114	4,101	View
300	112	6,460	View
VOYAGER	82	320	View
CIRRUS	53	1,232	View
LEBARON	48	837	View
200	47	6,930	View
NEW YORKER	44	1,035	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2016 CHRYSLER PACIFICA

Complaint Statistics

Top Reported Components

Technical Service Bulletins, 2016 CHRYSLER PACIFICA

Most Affected Components

NHTSA Safety Investigations, CHRYSLER PACIFICA

CHRYSLER PACIFICA - All Years Overview

CHRYSLER PACIFICA - Year by Year

Other CHRYSLER Models