2006 CHRYSLER PACIFICA
1 recalls, 1,056 complaints - 65 TSBs
06V432000 Nov 9, 2006
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
Defect Description
ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP MODULE AND THE POWER TRAIN CONTROL MODULE (PCM) SOFTWARE MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN OPERATING CONDITIONS.
Consequence
THIS COULD CAUSE A CRASH TO OCCUR WITHOUT PRIOR WARNING.
Remedy
DEALERS WILL REPROGRAM THE POWER TRAIN CONTROL MODULE. THE FUEL PUMP MODULE WILL ALSO BE REPLACED ON VEHICLES BUILT FROM AUGUST 1, 2004 THROUGH SEPTEMBER 30, 2004. THE RECALL BEGAN ON NOVEMBER 21, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Complaint Statistics
1,056 total complaints
32 crashes 14 fires 41 injuries 10 deaths
Top Reported Components
| Component | Complaints |
|---|---|
| ENGINE | 148 |
| STRUCTURE:BODY | 141 |
| POWER TRAIN | 91 |
| SUSPENSION | 81 |
| ENGINE AND ENGINE COOLING | 63 |
| UNKNOWN OR OTHER | 63 |
| FUEL/PROPULSION SYSTEM | 58 |
| ELECTRICAL SYSTEM | 53 |
| VEHICLE SPEED CONTROL | 39 |
| ENGINE AND ENGINE COOLING:ENGINE | 32 |
ENGINE
Aug 11, 2025
Incident date: Aug 11, 2025
Coolant intrusion into the cylinder block requiring new engine. Issue is known to manufacturer but Company no longer offers any support to customers. Dealership confirmed issue with scope showing Crack in cylinder. I maintained the vehicle and did regular fluid checks. Failure occurred with no warni... Read more
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Aug 11, 2025
Incident date: Aug 11, 2025
Front Camera Fault Service not available. Pre-Collision Assist Not Available. These faults have been showing up for over a year. I have taken my car to the dealer about 10 times, to no avail. Every time you hit a bump it happens. As I write this my car is in the shop again. The internet is rife ... Read more
ENGINE
Aug 11, 2025
Incident date: Aug 11, 2025
There's currently a coolant intrusion issue with my 2019 Ford escape and I see that there was a recall on this for all Ford escapes from the years of 2017 through 2019 and I wanted to see if this will be covered for repairs
ENGINE
Nov 14, 2023
Incident date: Nov 11, 2022
I had my 2019 Ford Ecosport serviced to have a new battery and brakes installed on it by my local Ford dealership. Approximately 5 days after I picked it up from the dealership, I was on my way to work and driving down I-75 (going approximately 70 mph). I received a sudden notification on my dash th... Read more
EQUIPMENT ADAPTIVE/MOBILITY:VEHICLE CONTROLS:SPEED CONTROL
Sep 21, 2022
Incident date: Mar 12, 2021
The contact owned a 2006 Chrysler Pacifica. The contact stated that while driving at 35 MPH, she lost control of the vehicle as it went through a guardrail and crashed into a tree where it came to a stop. The contact stated that she lost consciousness as she could not remember went occurred in detai... Read more
Crash
1 injured
UNKNOWN OR OTHER
Sep 19, 2022
Incident date: Sep 19, 2022
Bought this car 3 months ago from Ford dealership, took it to mechanic shop today for oil change and was told car is "unsafe to drive" from frame being so rusted
UNKNOWN OR OTHER
May 22, 2022
Incident date: Apr 11, 2022
Bought car from a private seller and wasn't informed of MASSIVE and UNSAFE DAMAGE TO ENGINE CRADLE. The engine cradle is nearly completely rotted out. Don't know if rust has eroded other parts until a mechanic can look extensively at the engine cradle. I have been trying salvage yards and 9 out of... Read more
POWER TRAIN
May 18, 2022
Incident date: May 1, 2022
I got in the car started it as usual, shifted it in (D), pulled out of my church parking lot, got about 5 miles away from my church stopped at a red light. The light turned green I accelerated as usual. At this light is a slight incline about 15% ways up the incline it just stopped pulling. I presse... Read more
POWER TRAIN
Apr 26, 2022
Incident date: Apr 1, 2022
Vehicle shut off WHILE DRIVING ON THE ROAD out of nowhere after running perfectly fine and since this incident the car won't start at all. Had the car diagnosed and it said it's the "Transmission control module"
UNKNOWN OR OTHER
Apr 26, 2022
Incident date: Apr 1, 2022
Vehicle shut off WHILE DRIVING ON THE ROAD out of nowhere after running perfectly fine and since this incident the car won't start at all. Had the car diagnosed and it said it's the "Transmission control module"
STRUCTURE:BODY
Sep 30, 2021
Incident date: Aug 4, 2021
A few weeks ago we took our car to a mechanic to have the brakes worked on as a part of routine maintenance. When we picked it up, he noted that when he had it up on the lift, he saw that the engine cradle was very badly rusted. He said that we shouldn't drive it anymore because of the risks involve... Read more
ELECTRICAL SYSTEM
Jul 22, 2021
Incident date: Jul 22, 2021
Key fob program
FUEL/PROPULSION SYSTEM
Jul 22, 2021
Incident date: Jul 22, 2021
Key fob program
UNKNOWN OR OTHER
Jul 22, 2021
Incident date: Jul 22, 2021
Key fob program
WHEELS
Jul 6, 2021
Incident date: Aug 18, 2020
I went on some errands before going out if town. I noticed I might need a wheel alignment soon and I parked the car in my garage to go out of town. When I returned to go have it checked out, I noticed my front driver side tire was flat and a closer inspection, it had a tear. Then I noticed my other ... Read more
UNKNOWN OR OTHER
Jul 6, 2021
Incident date: Aug 18, 2020
I went on some errands before going out if town. I noticed I might need a wheel alignment soon and I parked the car in my garage to go out of town. When I returned to go have it checked out, I noticed my front driver side tire was flat and a closer inspection, it had a tear. Then I noticed my other ... Read more
STEERING
Jul 6, 2021
Incident date: Aug 18, 2020
I went on some errands before going out if town. I noticed I might need a wheel alignment soon and I parked the car in my garage to go out of town. When I returned to go have it checked out, I noticed my front driver side tire was flat and a closer inspection, it had a tear. Then I noticed my other ... Read more
UNKNOWN OR OTHER
Jun 21, 2021
Incident date: Mar 20, 2020
My 2006 chrysler pacifica van has a corrosive chassis about break into, (meanimg) my engine is about to fall & hit the ground, this is my second chrysler, my first was a 2005 chrysler pacifica, when I bout the first one in 2014 they replace the chassis but I never thought to search Up under this on... Read more
ENGINE
Jun 21, 2021
Incident date: Mar 20, 2020
My 2006 chrysler pacifica van has a corrosive chassis about break into, (meanimg) my engine is about to fall & hit the ground, this is my second chrysler, my first was a 2005 chrysler pacifica, when I bout the first one in 2014 they replace the chassis but I never thought to search Up under this on... Read more
SUSPENSION
Mar 23, 2021
Incident date: Mar 23, 2021
PURCHASED THIS VEHICLE IN 2013, INQUIRED ABOUT DEFECTS AND RECALLS BUT WAS TOLD THERE WAS NONE. VEHICLE HAD 46,000 MILES ON IT AT TIME OF PURCHASE 104K PRESENTLY. GOOD RUNNING VEHICLE UP TO PAR ON MAINTENANCE, WHICH ALL GOES TO WASTE WITH A ROTTED SUBFRAME. RESEARCHED 100'S POSSIBLY 1000'S OF COMPLA... Read more
STRUCTURE:BODY
Mar 23, 2021
Incident date: Mar 23, 2021
PURCHASED THIS VEHICLE IN 2013, INQUIRED ABOUT DEFECTS AND RECALLS BUT WAS TOLD THERE WAS NONE. VEHICLE HAD 46,000 MILES ON IT AT TIME OF PURCHASE 104K PRESENTLY. GOOD RUNNING VEHICLE UP TO PAR ON MAINTENANCE, WHICH ALL GOES TO WASTE WITH A ROTTED SUBFRAME. RESEARCHED 100'S POSSIBLY 1000'S OF COMPLA... Read more
ENGINE
Mar 11, 2021
Incident date: Nov 3, 2020
I BOUGHT THE CAR AND 2 MONTHS LATER WHEN I WENT TO CHANGE THE OIL I NOTICED ABOUT HALD MY ENGINE CRADLE GONE DUE TO RUST
SUSPENSION
Mar 10, 2021
Incident date: Mar 4, 2021
NOTICED A LOT OF CLUNKING COMING FROM THE FRONT OF OUR 2006 PACIFICA. LOOKED UNDER VEHICLE AND NOTICED RUST AND HOLES IN THE ENGINE CRADLE. TOOK TO MY MECHANIC, HE CONFIRMED THE ENGINE CRADLE IS ABOUT TO FAIL. I CONTACTED BURGER CHRYSLER IN TERRE HAUTE IN. THEY STATED VEHICLE IS NOT UNDER ANY RECALL... Read more
UNKNOWN OR OTHER
Feb 14, 2021
Incident date: Feb 11, 2021
TRANSMISSION WENT OUT IN 3 MONTHS
UNKNOWN OR OTHER
Jan 15, 2021
Incident date: Jan 12, 2021
I BOUGHT THIS VEHICLE UNDER THE IMPRESSION IT NEEDED A MOTOR MOUNT TO FIND OUT THAT THE SUB FRAME IS ROTTEN TO THE POINT IT'S A SAFETY ISSUE TO DRIVE. THE REST OF THE DETAILS MAY NOT BE OF INTEREST TO YOU BUT I AM THE SURVIVING SPOUSE OF A DECEASED VETERAN AND MOTHER OF HIS TWO CHILDREN. I'VE BEEN S... Read more
ENGINE
Jan 15, 2021
Incident date: Jan 12, 2021
I BOUGHT THIS VEHICLE UNDER THE IMPRESSION IT NEEDED A MOTOR MOUNT TO FIND OUT THAT THE SUB FRAME IS ROTTEN TO THE POINT IT'S A SAFETY ISSUE TO DRIVE. THE REST OF THE DETAILS MAY NOT BE OF INTEREST TO YOU BUT I AM THE SURVIVING SPOUSE OF A DECEASED VETERAN AND MOTHER OF HIS TWO CHILDREN. I'VE BEEN S... Read more
POWER TRAIN
Nov 26, 2020
Incident date: Nov 23, 2020
WHILE DRIVE TURNING LEFT THOUGH A TRAFFIC LIGHT ON PILOT KNOB AND 160TH IN FARMINGTON MY CAR STALLED WHEEL LOCK UP PADDLE FELT LIKE IT HAD GOTTEN STUCK FOR A SECOND AND THERE IN THE MIDDLE OF THE INTERSECTION MY CAR HAD COMPLETELY STALLED OUT WITH MY CHILDREN IN THE VEHICLE TO WEAR I HAD TWO TRUCKS... Read more
VEHICLE SPEED CONTROL
Nov 26, 2020
Incident date: Nov 23, 2020
WHILE DRIVE TURNING LEFT THOUGH A TRAFFIC LIGHT ON PILOT KNOB AND 160TH IN FARMINGTON MY CAR STALLED WHEEL LOCK UP PADDLE FELT LIKE IT HAD GOTTEN STUCK FOR A SECOND AND THERE IN THE MIDDLE OF THE INTERSECTION MY CAR HAD COMPLETELY STALLED OUT WITH MY CHILDREN IN THE VEHICLE TO WEAR I HAD TWO TRUCKS... Read more
STEERING
Nov 26, 2020
Incident date: Nov 23, 2020
WHILE DRIVE TURNING LEFT THOUGH A TRAFFIC LIGHT ON PILOT KNOB AND 160TH IN FARMINGTON MY CAR STALLED WHEEL LOCK UP PADDLE FELT LIKE IT HAD GOTTEN STUCK FOR A SECOND AND THERE IN THE MIDDLE OF THE INTERSECTION MY CAR HAD COMPLETELY STALLED OUT WITH MY CHILDREN IN THE VEHICLE TO WEAR I HAD TWO TRUCKS... Read more
UNKNOWN OR OTHER
Nov 3, 2020
Incident date: Nov 3, 2020
I WAS DRIVE MY CAR AND ALL OF A SUDDEN GOING THROUGH A STREET INTERACTION ON 170TH STREET AND PILOT KNOB RD WHEN IT WENT DEAD ON ME THE CAR WHEEL LOCKED UP AND IT STALLED WE'RE I ALMOST COULD HAVE GOT HIT WITH MY FAMILY IN THE CAR I AND A FEW BYPASSERS HELP ME PUSH IT TO THE SIDE OF THE ROAD TO WE'R... Read more
STRUCTURE:BODY
Nov 2, 2020
Incident date: Oct 27, 2020
I BROUGHT MY CAR IN FOR INSPECTION. I ALSO WANTED THEM TO CHECK THE MUFFLER. I WAS CONTACTED BY THE GARAGE, THEY WERE NOT ABLE TO INSPECT THE VEHICLE BECAUSE THE SUBFRAME UNDER THE ENGINE IS COMPLETELY RUSTED AWAY. THEY SAID EVEN IF THEY COULD REPLACE THE MUFFLER THERE WOULD BE NOTHING TO ATTACH I... Read more
ENGINE
Sep 24, 2020
Incident date: Sep 24, 2020
I TOOK MY CAR IN TODAY TO HAVE SHOCKS PUT ON AND WAS INFORMED THE ENGINE CRADLE WAS SO SEVERELY RUSTED THE RACK AND PINION WAS ABOUT TO DROP OUT OF THE CAR ALONG WITH THE MOTOR. I DRIVE ON THE HIGHWAY EVERYDAY AND THIS WOULD HAVE BROKE IN THE NEXT WEEK OR SO AND I WOULD PROBABLY BE SEVERELY INJURED ... Read more
ELECTRONIC STABILITY CONTROL (ESC)
Sep 17, 2020
Incident date: Sep 13, 2020
ENTERED FREEWAY BATTERY LIGHT CAME ON AND LOST POWER. STARTING EXITING FREEWAY THEN CAR EXCELERATING ON ITS OWN. ENGINE WAS REVING AND HUMMING SO MUCH I THOUGHT THE ENGINE WOULD CATCH ON FIRE. CAR WOULD NOT SLOW DOWN. I HAD TO PUT IT IN NEUTRUAL AND HIT THE BRAKES AS I EXIT THE FREEWAY TO SAFELY PAR... Read more
ENGINE
Sep 17, 2020
Incident date: Sep 13, 2020
ENTERED FREEWAY BATTERY LIGHT CAME ON AND LOST POWER. STARTING EXITING FREEWAY THEN CAR EXCELERATING ON ITS OWN. ENGINE WAS REVING AND HUMMING SO MUCH I THOUGHT THE ENGINE WOULD CATCH ON FIRE. CAR WOULD NOT SLOW DOWN. I HAD TO PUT IT IN NEUTRUAL AND HIT THE BRAKES AS I EXIT THE FREEWAY TO SAFELY PAR... Read more
ELECTRICAL SYSTEM
Sep 17, 2020
Incident date: Sep 13, 2020
ENTERED FREEWAY BATTERY LIGHT CAME ON AND LOST POWER. STARTING EXITING FREEWAY THEN CAR EXCELERATING ON ITS OWN. ENGINE WAS REVING AND HUMMING SO MUCH I THOUGHT THE ENGINE WOULD CATCH ON FIRE. CAR WOULD NOT SLOW DOWN. I HAD TO PUT IT IN NEUTRUAL AND HIT THE BRAKES AS I EXIT THE FREEWAY TO SAFELY PAR... Read more
SUSPENSION
Sep 1, 2020
Incident date: Oct 24, 2019
THE ENGINE CRADLE ON MY 2006 CHRYSLER PACIFICA TOURING IS ALMOST COMPLETELY RUSTED AND CRACKED THROUGH. I TOOK IT TO THE MECHANIC BECAUSE IT WAS SHAKING AND BUCKING AND WAS TOLD TO STOP DRIVING IT BECAUSE ONE MORE BUMP COULD BREAK THE CRADLE CAUSING MY ENGINE TO DROP. IT WILL COST THOUSANDS OF DOLLA... Read more
STRUCTURE:BODY
Aug 5, 2020
Incident date: Jul 30, 2020
BOUGHT CAR 2018 FEB . NO MENTION OF WHOLE UNDER CARRIAGE RUSTED OUT - 2004-2008 CHRYSLER FORGOT TO SPRAY FOR RUST. WHEN WE GO WE BOUGHT IT LATER IN EVENING - WAS ASSURED THAT CAR HAD BEEN CHECKED OUT AND SOUND. WE HAVE DONE SOME REPAIRS ON OTHER THINGS - THERMOSTAT , RADIATOR , TIRES ABS SENSOR ISSU... Read more
ENGINE
Aug 5, 2020
Incident date: Jul 30, 2020
BOUGHT CAR 2018 FEB . NO MENTION OF WHOLE UNDER CARRIAGE RUSTED OUT - 2004-2008 CHRYSLER FORGOT TO SPRAY FOR RUST. WHEN WE GO WE BOUGHT IT LATER IN EVENING - WAS ASSURED THAT CAR HAD BEEN CHECKED OUT AND SOUND. WE HAVE DONE SOME REPAIRS ON OTHER THINGS - THERMOSTAT , RADIATOR , TIRES ABS SENSOR ISSU... Read more
STEERING
Aug 5, 2020
Incident date: Jul 30, 2020
BOUGHT CAR 2018 FEB . NO MENTION OF WHOLE UNDER CARRIAGE RUSTED OUT - 2004-2008 CHRYSLER FORGOT TO SPRAY FOR RUST. WHEN WE GO WE BOUGHT IT LATER IN EVENING - WAS ASSURED THAT CAR HAD BEEN CHECKED OUT AND SOUND. WE HAVE DONE SOME REPAIRS ON OTHER THINGS - THERMOSTAT , RADIATOR , TIRES ABS SENSOR ISSU... Read more
SUSPENSION
Jul 13, 2020
Incident date: Jul 12, 2020
TL* THE CONTACT OWNS A 2006 CHRYSLER PACIFICA. THE CONTACT STATED THAT UPON TAKING HER VEHICLE TO AN INDEPENDENT MECHANIC FOR SERVICE, SHE WAS INFORMED THAT THE ENGINE CRADLE WAS EXTREMELY CORRODED. THE CONTACT'S HUSBAND CALLED ED MARTIN CHRYSLER DODGE JEEP RAM (2109 E 53RD ST, ANDERSON, IN 46013) A... Read more
ENGINE
Jun 16, 2020
Incident date: Mar 23, 2020
TL* THE CONTACT OWNS A 2006 CHRYSLER PACIFICA. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT AND AN INDEPENDENT MECHANIC REPLACED THE FUEL PUMP, THE BATTERY, ALTERNATOR, THROTTLE BODY AND SEVERAL OTHER VARIOUS PARTS HOWEVER, THE FAILURE PER... Read more
POWER TRAIN
Jun 16, 2020
Incident date: Mar 23, 2020
TL* THE CONTACT OWNS A 2006 CHRYSLER PACIFICA. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT AND AN INDEPENDENT MECHANIC REPLACED THE FUEL PUMP, THE BATTERY, ALTERNATOR, THROTTLE BODY AND SEVERAL OTHER VARIOUS PARTS HOWEVER, THE FAILURE PER... Read more
ELECTRICAL SYSTEM
May 13, 2020
Incident date: May 12, 2020
AS IT WOULD SEEM IS A VERY COMMON PROBLEM, THE OIL PRESSURE SENDING UNIT HAS FAILED AND LEAKS OIL ON AND INTO THE HARNESS PLUG. UPON RESEARCHING THIS ISSUE THIS SEEMS TO BE A VERY COMMON ISSUE WITH THIS PARTICULAR VEHICLE AND CAN PRESENT BOTH A COSTLY FIX AND A FIRE HAZARD. WHILE DRIVING THE OIL PRE... Read more
ENGINE
May 13, 2020
Incident date: May 12, 2020
AS IT WOULD SEEM IS A VERY COMMON PROBLEM, THE OIL PRESSURE SENDING UNIT HAS FAILED AND LEAKS OIL ON AND INTO THE HARNESS PLUG. UPON RESEARCHING THIS ISSUE THIS SEEMS TO BE A VERY COMMON ISSUE WITH THIS PARTICULAR VEHICLE AND CAN PRESENT BOTH A COSTLY FIX AND A FIRE HAZARD. WHILE DRIVING THE OIL PRE... Read more
STRUCTURE:BODY
Apr 4, 2020
Incident date: Apr 2, 2020
SEVERE CRADLE RUST. MECHANIC HAS SAID THE ENGINE COULD FALL OUT OF THE VEHICLE WITHOUT WARNING.
SUSPENSION
Mar 3, 2020
Incident date: Feb 28, 2020
MY CAR WAS BUILT IN 2005 WHEN THE SUBFRAME RECALL WAS ISSUED, I CALLED THEM TO TRY AND GET SOME HELP, BASICALLY GET REIMBURSED FOR THE LABOR OF GETTING THE REPLACEMENT SUBFRAME INSTALLED. THE OLD SUBFRAME FINALLY BROKE WHILE I WAS DRIVING AT CITY SPEEDS AND I WAS LUCKY THAT THE SHOP I USED LET ME KN... Read more
STRUCTURE:BODY
Mar 3, 2020
Incident date: Feb 28, 2020
MY CAR WAS BUILT IN 2005 WHEN THE SUBFRAME RECALL WAS ISSUED, I CALLED THEM TO TRY AND GET SOME HELP, BASICALLY GET REIMBURSED FOR THE LABOR OF GETTING THE REPLACEMENT SUBFRAME INSTALLED. THE OLD SUBFRAME FINALLY BROKE WHILE I WAS DRIVING AT CITY SPEEDS AND I WAS LUCKY THAT THE SHOP I USED LET ME KN... Read more
SUSPENSION
Feb 2, 2020
Incident date: Mar 8, 2019
WHEN MOVING FROM THE HUMID EAST TO THE DESERT WEST ALL CONTROL ARM BUSHINGS AND MOTOR MOUNTS DRIED UP AND CRACKED CAUSING OVER THE COURSE OF A FEW WEEK TRACTIONS PROBLEMS MADE WORSE WHEN GETTING NEW TIRES AND AFTER FISHTAILING IN THE RAIN I BROUGHT IT TO A MECHANIC THAT FOUND THAT ALL RUBBER COMPONE... Read more
ENGINE
Jan 28, 2020
Incident date: Jan 2, 2020
ENGINE CRADLE ROTTING CAUSING INABILITY TO BE INSPECTED BY PERSONAL MECHANIC
FUEL/PROPULSION SYSTEM
Jan 12, 2020
Incident date: Nov 1, 2016
GAS CAP LIGHT ALWAYS REMAIN ON. MY RPM GAUGE IS JUMPING AN ALL OF MY INDICATOR LIGHTS ARE ON. THESE THINGS HAPPEN UPON STARTING THE VEHICLE. THERE IS A ROUGH IDLE AND I HAVE TO PUSH A PINK BUTTON TO SHIFT HERS. THE GEARS WILL NOT SHIFT. I SEE THAT THERE WAS A RECALL FOR VEHICLES OF MY BRAND BUT MY V... Read more
Showing 50 of 1,056 complaints.
Technical Service Bulletins, 2006 CHRYSLER PACIFICA
65 manufacturer communications from 48 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 350000 EQUIPMENT | 10 |
| 160000 STRUCTURE | 9 |
| 061000 ENGINE AND ENGINE COOLING:ENGINE | 7 |
| 060000 ENGINE AND ENGINE COOLING | 5 |
| 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL | 5 |
| 110000 ELECTRICAL SYSTEM | 4 |
| 103000 POWER TRAIN:AUTOMATIC TRANSMISSION | 2 |
| 199000 TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS | 2 |
9004009
Apr 7, 2021
100000 POWER TRAIN
Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles. If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) are one-time usag
9004275
Jul 22, 2020
116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehi
9004275
Jul 22, 2020
116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehi
23-015-20
Apr 30, 2020
160000 STRUCTURE
Disinfectant Solution Recommended for COVID-19
23-015-20
Apr 30, 2020
350000 EQUIPMENT
Disinfectant Solution Recommended for COVID-19
08-049-20
Apr 22, 2020
350000 EQUIPMENT
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are nece
08-049-20
Apr 22, 2020
110000 ELECTRICAL SYSTEM
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are nece
3100319
Nov 20, 2019
160000 STRUCTURE
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
3100619
Nov 20, 2019
160000 STRUCTURE
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
3100619
Nov 20, 2019
350000 EQUIPMENT
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
3100519
Nov 20, 2019
160000 STRUCTURE
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
31-005-19
Nov 20, 2019
350000 EQUIPMENT
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
31-005-19
Nov 20, 2019
160000 STRUCTURE
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
31-003-19
Nov 20, 2019
350000 EQUIPMENT
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
31-006-19
Nov 20, 2019
160000 STRUCTURE
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
9003623
Nov 16, 2016
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Wiper If Mopar OE wipers are unavailable, the below alternatives can be offered instead. 05066964A$ = WBRW0011A$ 05066973A$ = WB000019A$ or WBF00019A$ 05096134A$ = WB000027A$ or WBF00028A$ 55154762A$ = WB000013A$ 68001330A$ = WB000019
23027
Aug 23, 2016
114000 ELECTRICAL SYSTEM:WIRING
Return: Wiring Assy - Engine You have been identified as either having stock, or have stock in transit to your dealership. Please return stock packaged before 2016/07/31 (31 July, 2016)of follow ing part numbers:68176457AF, 68176459AF. P
23104
Aug 22, 2016
350000 EQUIPMENT
05182535AD - Lamp Assy ?Tail Light LT You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 05182535AD . See attachments for identifying suspect stock. Pl
23104
Aug 22, 2016
120000 LIGHTING (PWS)
05182535AD - Lamp Assy ?Tail Light LT You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 05182535AD . See attachments for identifying suspect stock. Pl
23137
Aug 22, 2016
350000 EQUIPMENT
Inspect and Return: Trim Cover Assy - A-Pillar Rt/Lt You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part numbers: 1ZA04DX9AE, 1ZA05DX9AE. See attachments for id
Volume 2, Issue
Aug 18, 2016
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Warranty Operations Newsletter Updates from Warranty Operations
20244
Aug 18, 2016
350000 EQUIPMENT
CBXDP361AA Return: Spacer Kit - Visor You have been identified as either having stock, or have stock in transit to your dealership. Please return stock of part number CBXDP361AA. Replacement part number is CBXDP361AB w hich is in stock a
22892
Aug 17, 2016
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Return: Lamp Assy - CHMSL& Cargo Light You have been identified as either having stock, or have stock in transit to your dealership. Please return all stock of follow ing part numbers:55372082AE, 55372082AD, 55372082AC, 55372082AB, 553720
22867
Aug 17, 2016
110000 ELECTRICAL SYSTEM
Inspect and Return: Solenoid Module - Transmission You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of follow ing part numbers:52120000AA, 52119435AF, 05078709AB. S
22958
Aug 17, 2016
117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
1NT30XDVAC - Inspect and Return: Panel - Instrument Panel You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 1N T30XDVAC. See attachments for identifyin
20616
Aug 12, 2016
110000 ELECTRICAL SYSTEM
P/N CBSZR068AA: Inspect & Return: Module Kit - Occupant Restraint You have been identified as either having stock, or have stock in transit to your dealership. Please return part number CBSZR068AA as per the QIR attached. Replacement par
Volume 2, Issue
Jun 2, 2016
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Warranty Operations Newsletter Updates from Warranty Operations
2301216
Mar 5, 2016
162600 STRUCTURE:BODY:HATCHBACK/LIFTGATE
Magnesium Inner Liftgate Repair And Appearance Characteristics
23-012-16
Mar 5, 2016
162600 STRUCTURE:BODY:HATCHBACK/LIFTGATE
Magnesium Inner Liftgate Repair And Appearance Characteristics This bulletin involves discussing magnesium inner liftgate repair warnings and appearance characteristics.
23-012-16
Mar 5, 2016
162610 STRUCTURE:BODY:HATCHBACK/LIFTGATE:HINGE AND ATTACHMENTS
Magnesium Inner Liftgate Repair And Appearance Characteristics
R2118796A
Feb 26, 2016
060000 ENGINE AND ENGINE COOLING
Valve Body. These may cause over drive cycling.
R2118796A
Feb 26, 2016
350000 EQUIPMENT
Valve Body. These may cause over drive cycling.
RL108213A$
Jan 26, 2016
060000 ENGINE AND ENGINE COOLING
NAG1 (5A580) Valve Body As per Warranty Bulletin D-13-22, please use R2108213A$ valve body for all Warranty (W), Mopar (M) and Mopar Vehicle Protection (F) claims.~ Assembly also includes Filter (52108325AA) and Gasket (52108332AA).~
9003215
Feb 12, 2015
060000 ENGINE AND ENGINE COOLING
Part Description: 5.7L Long Block Issue Description: This 5.7L Long Block Assembly is compatible with both EGR and Non-EGR applications. An EGR Block-Off Plate (53032739AA) must be ordered when installing this Long Block Assembly in a
9003215
Feb 12, 2015
060000 ENGINE AND ENGINE COOLING
Part Description: 5.7L Long Block Issue Description: This 5.7L Long Block Assembly is compatible with both EGR and Non-EGR applications. An EGR Block-Off Plate (53032739AA) must be ordered when installing this Long Block Assembly in a
9003215
Feb 12, 2015
350000 EQUIPMENT
Part Description: 5.7L Long Block Issue Description: This 5.7L Long Block Assembly is compatible with both EGR and Non-EGR applications. An EGR Block-Off Plate (53032739AA) must be ordered when installing this Long Block Assembly in a
9002887
Feb 11, 2015
160000 STRUCTURE
Part Description: Valve Body Assembly Issue Description: Valve body design was changed between 2010MY and 2011MY applications. To prevent mix matching valve bodies and solenoid packs the connectors are color coded.~ Valve bodies with
9002887
Feb 11, 2015
160000 STRUCTURE
Part Description: Valve Body Assembly Issue Description: Valve body design was changed between 2010MY and 2011MY applications. To prevent mix matching valve bodies and solenoid packs the connectors are color coded.~ Valve bodies with
9002887
Feb 11, 2015
060000 ENGINE AND ENGINE COOLING
Part Description: Valve Body Assembly Issue Description: Valve body design was changed between 2010MY and 2011MY applications. To prevent mix matching valve bodies and solenoid packs the connectors are color coded.~ Valve bodies with
9001329
Feb 12, 2014
050000 PARKING BRAKE
Part Description: Seat Belt - Retaining Button Kits. Issue Description: Do not replace the entire seat belt if the seat belt web stop button is missing or damaged.~Belt Web Button:~ 1D1 - Light Graystone - 05093280AB Belt Web Button~1D5 -
9001329
Feb 12, 2014
140000 AIR BAGS
Part Description: Seat Belt - Retaining Button Kits. Issue Description: Do not replace the entire seat belt if the seat belt web stop button is missing or damaged.~Belt Web Button:~ 1D1 - Light Graystone - 05093280AB Belt Web Button~1D5 -
9001329
Feb 12, 2014
200000 WHEELS
Part Description: Seat Belt - Retaining Button Kits. Issue Description: Do not replace the entire seat belt if the seat belt web stop button is missing or damaged.~Belt Web Button:~ 1D1 - Light Graystone - 05093280AB Belt Web Button~1D5 -
9002519
Mar 20, 2013
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
9002519
Mar 20, 2013
160000 STRUCTURE
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc
2304106
Aug 8, 2007
120000 EXTERIOR LIGHTING
EXTERIOR LAMP - LENS FOGGING. *NJ
0500307
Jun 13, 2007
046300 SERVICE BRAKES, AIR:ANTILOCK:WHEEL SPEED SENSOR
WHEEL SPEED SENSOR SERVICE. *KB
1400207
Apr 5, 2007
070000 FUEL SYSTEM, GASOLINE
CLEANING PROCEDURE FOR THE MECHANICAL THROTTLE BODY. *KB
2304706
Oct 21, 2006
131000 VISIBILITY:WINDSHIELD
CRACKED WINDSHIELD DUE TO BEING HIT BY A FOREIGN OBJECT LIKE A STONE. *KB
2200406
Oct 4, 2006
199000 TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS
TIRE PRESSURE MONITOR SYSTEM INFORMATION. *KB
0900505
Sep 16, 2006
061000 ENGINE AND ENGINE COOLING:ENGINE
MULTIPLE CYLINDER MISFIRE OR ROUGH IDLE. *TT
0803006
Aug 25, 2006
103000 POWER TRAIN:AUTOMATIC TRANSMISSION
POWERTRAIN CONTROL MODULE INITIALIZATION. *KB
35
Aug 1, 2006
061000 ENGINE AND ENGINE COOLING:ENGINE
ENGINE CONNECTING ROD BEARINGS MIGHT HAVE SAND LIKE DEBRIS. THIS COULD CAUSE EXCESSIVE WEAR ON THE ROD BEARINGS OR COULD RESULT IN ENGINE FAILURE. *KB
06025
Jul 10, 2006
061000 ENGINE AND ENGINE COOLING:ENGINE
3.5L #2 ROD BEARING AND CRANKSHAFT JOURNAL INSPECTION FOR CONTAMINATION. *TT
1801006
Mar 23, 2006
061000 ENGINE AND ENGINE COOLING:ENGINE
FLASH-I/M TESTING-REVISED ENGINE RPM LIMITS TO PERFORM A TWO SPEED IDLE (TSI) TEST. *AK
0803905
Mar 8, 2006
110000 ELECTRICAL SYSTEM
FRONT POWER AND/OR MEMORY SEAT INOPERATIVE. *TT
0803105
Mar 8, 2006
221700 SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER
FLASH: FRONT HEATED SEATS DO NOT GET WARM ENOUGH. *TT
1800406
Mar 1, 2006
061000 ENGINE AND ENGINE COOLING:ENGINE
FLASH-NO START OR HARD START. *AK
1400106
Jan 21, 2006
090000 FUEL SYSTEM, OTHER
LOOSE FUEL CAP MESSAGE OR MALFUNCTION INDICATOR LAMP ILLUMINATION FOR DIAGNOSTIC TROUBLE CODE P0457 - EVAP SYSTEM - LOOSE FUEL CAP. *TT
2200205
Dec 7, 2005
199000 TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS
TIRE PRESSURE MONITOR - SYSTEM INFORMATION. *TT
1803905
Dec 2, 2005
061000 ENGINE AND ENGINE COOLING:ENGINE
FLASH - ENGINE ROUGHNESS OR IDLE FLUCTUATION. *TT
1900805
Nov 2, 2005
010000 STEERING
REVISED POWER STEERING SYSTEM BLEEDING PROCEDURES. *SC
2100903
Oct 2, 2005
103000 POWER TRAIN:AUTOMATIC TRANSMISSION
AUTOMATIC TRANSMISSION DIAGNOSTIC TEARDOWN PROCEDURE. VARIOUS MODELS INCLUDING THE 2004 RAM TRUCK, DURANGO, SEBRING CONVERTIBLE, CHEROKEE, VISION, NEON, AND VOYAGER. *TT *SC
2401305
Aug 4, 2005
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
AIR CONDITIONING (A/C) COOLING COIL ODOR. *TT
01011901
Mar 13, 2007
061000 ENGINE AND ENGINE COOLING:ENGINE
FRONT END NOISE MAY BE HEARD. PRE-DELIVERY SHIFT QUALITY, TIRE PRESSURE SENSOR DIAGNOSTIC TOOL INFORMATION, AND GLASS REPLACEMENT. *KB
01011901
Mar 13, 2007
132000 VISIBILITY:GLASS, SIDE/REAR
FRONT END NOISE MAY BE HEARD. PRE-DELIVERY SHIFT QUALITY, TIRE PRESSURE SENSOR DIAGNOSTIC TOOL INFORMATION, AND GLASS REPLACEMENT. *KB
NHTSA Safety Investigations, CHRYSLER PACIFICA
Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.
PE25009
Opened: Sep 5, 2025
Intermittent Loss of Electric Power Steering
The Office of Defects Investigation (ODI) is opening this Preliminary Evaluation to assess the scope, frequency, and potential safety consequences of alleged defects related to the electric power steering (EPS) system in model year (MY) 2017–2018 Chrysler Pacifica vehicles. ODI has received 94 Veh... Read more
RQ24004
Opened: Feb 27, 2024
Loss of motive power due to an internal wiring connector short.
On July 22, 2022, the Office of Defects Investigation (ODI) opened investigation PE22-008 regarding complaints alleging a loss of motive power condition potentially due to a transmission malfunction in Model Years 2019-2021 Chrysler Pacifica Plug-In Hybrid Electric Vehicles (PHEV). On January 17, ... Read more
RQ24001
Opened: Jan 16, 2024
Ignition-off high voltage battery fire (Remedy effectiveness of Recall 22V-077)
On February 11, 2022, Fiat Chrysler Automobiles (FCA) issued a safety recall (NHTSA Recall 22V-077) on all 2017-2018 Pacifica Plug-In Hybrid Electric Vehicles (PHEV) produced between August 12, 2016 through August 7, 2018. The recall addresses ignition “OFF’ fires that originate at the high volt... Read more
PE22008
Opened: Jul 22, 2022 , Closed: Mar 27, 2024
Transmission fault leading to loss of motive power
On July 22, 2022, the Office of Defects Investigation (ODI) opened PE22008 to investigate allegation of loss of motive power, potentially due to transmission malfunction, in certain Chrysler Pacifica vehicles. In a January 17, 2023 letter to NHTSA, Fiat Chrysler Automobiles (FCA) submitted recall no... Read more
DP17003
Opened: Dec 1, 2017 , Closed: Mar 1, 2018
Stall/Loss of Motive Power
By letter dated November 30, 2017, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration requesting it open an investigation into allegations of engine stalling in the model year (MY) 2017 Chrysler Pacifica, a new vehicle platform. In support of its petition,... Read more
EA08006
Opened: Feb 21, 2008 , Closed: Apr 15, 2009
ENGINE COMPARTMENT FIRE
THE AGENCY HAS CLOSED THIS INVESTIGATION BASED ON ITS REVIEW OF CONSUMER COMPLAINTS, FIELD REPORTS, WARRANTY CLAIMS AND OTHER DATA REGARDING ENGINE COMPARTMENT FIRES AND POWER STEERING FLUID LEAKAGE IN MODEL YEAR (MY) 2007 CHRYSLER PACIFICA VEHICLES WITH 4.0L ENGINES.THE AVAILABLE EVIDENCE INDICATES... Read more
PE07052
Opened: Oct 19, 2007 , Closed: Feb 21, 2008
ENGINE COMPARTMENT FIRE
COMPLAINANTS ALLEGE THAT A FIRE ERUPTED UNDER THE HOOD, NEAR THE FRONT OF THE VEHICLE.IN CHRYSLER'S RESPONSE TO ODI'S NOVEMBER 2, 2007 INFORMATION REQUEST, CHRYSLER ASSERTS THAT THE ALLEGED DEFECT OCCURS ONLY IN THE 4.0L ENGINES AND THE CONSUMER WILL EXPERIENCE A LOSS OF POWER STEERING FLUID OR A NO... Read more
EA06013
Opened: Jun 22, 2006 , Closed: Nov 29, 2006
ENGINE STALLING
IN A NOVEMBER 8, 2006 LETTER, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING TWO SEPARATE DEFECT CONDITIONS THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2005-2006 CHRYSLER PACIFICA VEHICLES (NHTSA RECALL NO. 06V-432).MY 2005 VEHICLES... Read more
EA06010
Opened: Jun 15, 2006 , Closed: Oct 11, 2007
FUEL TANK PUNCTURES
EA06-010 WAS OPENED BASED ON INFORMATION GATHERED IN PRELIMINARY EVALUATION PE06-009.PE06-009 WAS OPENED BASED ON INFORMATION OBTAINED IN A PEER INFORMATION REQUEST AS PART OF A PRELIMINARY EVALUATION (PE05-050) OF FUEL TANK PUNCTURE IN MODEL YEAR (MY) 2003 THROUGH 2006 NISSAN MURANO VEHICLES.IN JAN... Read more
RQ06002
Opened: Feb 27, 2006 , Closed: Jun 22, 2006
ENGINE STALLING
ON FEBRUARY 27, 2006 RQ06-002 WAS OPENED IN RESPONSE TO 60 COMPLAINTS OF ENGINE STALL, MOSTLY DURING LEFT-HAND TURNS, IN MODEL YEAR (MY) 2004 TO 2006 CHRYSLER PACIFICA VEHICLES THAT WERE OUTSIDE THE SCOPE OF RECALL 04V-113.IN MARCH 2004, DAIMLERCHRYSLER INITIATED RECALL 04V-113 ON 34,561 MY 2004 PAC... Read more
PE06009
Opened: Feb 22, 2006 , Closed: Jun 15, 2006
FUEL TANK PUNCTURES
ON FEBRUARY 22, 2006, ODI OPENED PE06-009 TO INVESTIGATE REPORTS THAT THE FUEL TANKS ON MODEL YEAR (MY) 2004 TO 2005 CHRYSLER PACIFICA VEHICLES MAY BE PUNCTURED BY CONTACT WITH ROAD DEBRIS.THE NUMBER OF REPORTS SUBMITTED BY CHRYSLER WAS SIGNIFICANTLY HIGHER THAN THOSE SUBMITTED BY OTHER MANUFACTURER... Read more
CHRYSLER PACIFICA - All Years Overview
Complete safety history for the CHRYSLER PACIFICA across all model years (2004, 2026).
92
Total Recalls
10,494
Total Complaints
11
Investigations
381
Reported Crashes
168
Reported Fires
15
Reported Deaths
CHRYSLER PACIFICA - Year by Year
Compare recalls and complaints across model years. Click any year to see full details.
| Year | Recalls | Complaints | |
|---|---|---|---|
| 2026 | 3 | 11 | View |
| 2025 | 8 | 33 | View |
| 2024 | 11 | 59 | View |
| 2023 | 14 | 228 | View |
| 2022 | 10 | 333 | View |
| 2021 | 7 | 652 | View |
| 2020 | 5 | 257 | View |
| 2019 | 7 | 452 | View |
| 2018 | 12 | 1,311 | View |
| 2017 | 10 | 2,325 | View |
| 2016 | 0 | 6 | View |
| 2008 | 0 | 155 | View |
| 2007 | 0 | 481 | View |
| 2006 (current) | 1 | 1,056 | |
| 2005 | 2 | 1,802 | View |
| 2004 | 2 | 1,332 | View |
| 2003 | 0 | 1 | View |