2020 FORD EDGE

4 recalls, 432 complaints - 195 TSBs - 5/5 safety rating

BACK OVER PREVENTION:SOFTWARE

Defect Description

Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2... Read more

Consequence

A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.

Remedy

Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.

200,237 vehicles affected

Manufacturer: Ford Motor Company

POWER TRAIN:DRIVELINE:DRIVESHAFT

Defect Description

Ford Motor Company (Ford) is recalling certain 2020-2021 Edge, 2020 Lincoln Nautilus and Ford Escape and 2021 Lincoln Corsair and Ford Bronco Sport vehicles. An inadequate amount of lubricant in the rear drive unit may cause seizure of the rear drive axle.

Consequence

If the rear drive unit seizes, there may be a loss of drive and/or a loss of vehicle control, increasing the risk of a crash.

Remedy

Ford will notify owners, and dealers will check the rear drive unit lubricant level. Axles found to have lubricant at the minimum level will be filled to the full level. Axles found to be below the minimum lubricant fill level will be replaced, free of charge. This recall began March 12, 2021. O... Read more

147 vehicles affected

Manufacturer: Ford Motor Company

BACK OVER PREVENTION: SENSING SYSTEM: CAMERA

Defect Description

Ford Motor Company (Ford) is recalling certain 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or dist... Read more

Consequence

Reduced rearward visibility can increase the risk of a crash.

Remedy

Ford will notify owners, and dealers will replace the rearview camera, free of charge. The recall began November 17, 2020. Remedy became available on February 1, 2021. Owner notification letters were mailed on February 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's ... Read more

620,246 vehicles affected

Manufacturer: Ford Motor Company

POWER TRAIN:AUTOMATIC TRANSMISSION

Defect Description

Ford Motor Company (Ford) is recalling certain 2019-2020 Edge, Transit Connect and Lincoln MKX and 2020 Escape and Lincoln Corsair vehicles. The start/stop accumulator endcap may have missing or loose bolts.

Consequence

Missing or loose bolts on the start stop accumulator endcap could result in a transmission fluid leak and may progress to a loss of transmission function. A transmission fluid leak in the presence of an ignition source may increase the risk of fire.

Remedy

Ford will notify owners, and dealers will replace the start/stop accumulator, free of charge. The recall began September 23, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S49.

97 vehicles affected

Manufacturer: Ford Motor Company

Complaint Statistics

432 total complaints 35 crashes 9 fires 30 injuries

Top Reported Components

Component	Complaints
ENGINE	64
POWER TRAIN	59
ELECTRICAL SYSTEM	59
UNKNOWN OR OTHER	37
STEERING	26
SERVICE BRAKES	19
AIR BAGS	15
FUEL/PROPULSION SYSTEM	14
EXTERIOR LIGHTING	12
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING	11

Incident date: Jul 1, 2026

My 2020 Ford Edge Titanium was shuddering between 10 - 40 mph. I took my car to a Ford dealership to diagnose the problem. They said it's the torque converter and they needed to replace the transmission. It would be a rebuild/repair at a cost of 8,991.00. This car has only 49,500 miles and points to... Read more

Incident date: Aug 28, 2026

The vehicle has been shuddering/jerking when accelerating. This problem is present at highway speeds, as well as lower speeds. A Ford Service Center on 8-28-26 has diagnosed it as a failing torque converter. The safety or both me and others is at risk if this part fails while driving. It is also dan... Read more

Incident date: Aug 1, 2026

I bought my Edge new in 2020. 3 years into owning the car had the transmission replaced on 8/23 due to mechanical/component failures. This was replaced under the original warranty of the car. The new transmission carried a 2 year unlimited warranty. I started having trouble again with the transmissi... Read more

Incident date: Jun 20, 2026

The contact owns a 2020 Ford Edge. The contact stated that while driving at an undisclosed speed, the vehicle shuddered, and there was an abnormal sound coming from underneath the vehicle, and the vehicle failed to exceed 30 MPH while the accelerator pedal was depressed. The contact stated that the ... Read more

Incident date: Jun 11, 2026

VIn number:[XXX] case number:XXX， My [XXX] car just 6 years old car and just run around 69000 miles，Coolant leaked into the engine, causing it to fail. Ford is demanding we pay ＄6,000 for a replacement.We cant accept we need Pay ＄6000 for replace engine，because Thats problem should don'... Read more

Incident date: Jun 11, 2026

Incident date: Aug 11, 2026

Transmission failure. No warning lights or messages.

Incident date: Jul 31, 2026

About a month ago, July 2026, i started to notice shaking bumping when car shifted out of first gear. Brought to local garage and they said needs new transmission.

Incident date: Jul 19, 2026

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V455000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was not yet available. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact st... Read more

Incident date: Jul 21, 2026

On the 26th of April 2026, the transfer Case on my 2020 Grand Cherokee (with less 114,000 miles) failed during highway travel. This resulted in a sudden downshift and temporary deceleration followed by illumination of “Service 4wd” display. A short time after, the “Service Electronic Stabi... Read more

Incident date: Aug 5, 2026

The contact owns a 2023 Ford Bronco Sport. The contact stated that while driving at various speeds, the vehicle pulled to the right with the tire pressure warning light illuminated. The driver was forced to steer the vehicle to the left to center the vehicle. The vehicle had been taken to two separa... Read more

Crash 1 injured

Incident date: Jul 1, 2026

2023 Cadillac Escalade, 6.2L V8 (RPO L87). Subject of Recall 25V-274 and NHTSA investigation RQ26-001. Over the past year, this vehicle has been out of the shop only about 90 days total. The rest of the year it has been in dealer service at GM/Cadillac dealerships for a recurring, undiagnosed loss-... Read more

Incident date: Jul 1, 2026

The Power Transfer Unit (PTU) failed on my 2020 Jeep Cherokee. Started hearing grinding and roaring noises coming from the front wheels and was having trouble stopping. There is a recall already going for the same make and model but for other specific vin numbers, mine not included. The problem was ... Read more

Incident date: Jun 20, 2026

The contact owns a 2014 Dodge Dart. The contact received notification of NHTSA Campaign Number: 25V674000 (POWER TRAIN); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacture... Read more

Incident date: May 11, 2026

On two separate occasions, once in 2025 and again in July 2026, while pulling a travel trailer an emissions control fault in the EGR system caused the Cummins turbo diesel engine in the truck to lose power. At this reduced power, highway speeds could not be maintained, and even small hills were diff... Read more

Incident date: May 11, 2026

The contact owns a 2019 Ford Expedition. The contact stated that while stopping at a red light, there was a big explosion coming from the seat belt pretensioner that shook the vehicle. Additionally, the seat belt seized, and the air bag warning light was illuminated. The contact sustained whiplash a... Read more

1 injured

Incident date: May 11, 2026

The contact owns a 2014 Ford F-150. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the transmission unexpectedly downshifted. The RPM's increased and the powertrain war... Read more

Incident date: Mar 20, 2026

The contact owns a 2013 Chevrolet Malibu. The contact stated that while driving 55 MPH, the electrical system failed inside the vehicle, causing the air conditioning system to fail to operate, and the window control buttons failed to roll the window down. The battery saver active warning light was i... Read more

Incident date: Jul 9, 2026

When going up my 5% grade driveway the truck has slammed into “park” while moving two times. The car turns off as it slams into park and a “ service transmission” warning is on the dash. It leaves small skid marks from doing this while moving. It has 1790 miles on it. Dealer has had it a... Read more

Incident date: Jun 9, 2026

The contact's daughter owns a 2026 Mazda CX-50. The contact stated that while his daughter was driving 40 MPH and decelerating to turn into a parking lot, the front passenger’s side wheel detached and fell in underneath the vehicle. The vehicle was towed to a tow yard and was then towed to the dea... Read more

Incident date: Jan 1, 2026

During an accident the driver side airbags did not deploy. The vehicle was rammed on the rear passenger wheel area. The impact was significant enough to have the curtain airbags on the passenger side go off, but the only person in the vehicle was myself, the driver.

Crash 1 injured

Incident date: Jul 7, 2026

The high pressure fuel pump seized, shattering the camshaft, dropping metal fragments into the cylinders causing total engine failure. GM issued a safety recall for certain 2021-2022 Chevy equinox due to a defective fuel pump modules but it was not accurate. GM is currently facing major class action... Read more

Incident date: Jul 1, 2026

At about 6:50am July 7th 2026, I was getting in the exit lane of interstate 50 to exit. I merge into the lane and being applying my breaks since I was going about 55-60mph. However, my vehicle did not slow down. I began to press harder, it still did not slow down, so I pressed as hard as I could bec... Read more

1 injured

Incident date: Jul 4, 2026

While driving, a “Service ESC” warning message appeared and the vehicle suddenly lost power steering assist, causing the steering to become extremely difficult and creating a serious safety risk while the vehicle was in motion. The vehicle was taken to a service center, where technicians found m... Read more

Incident date: Jul 15, 2026

My vehicle starts displaying traction control on the dash then says reduced engine power and looses power starting until u stop turn it off and crank it back up. Sometimes it runs really rough and you have to crank it back up. The ac goes in and out on it, sometimes it jerks while driving, after hav... Read more

Incident date: Jun 26, 2026

Following a software update by Ford in the past 6-8 months, upon start-up my vehicle asks me which drive mode I wish to be in but then after 15-45 seconds "forgets" my answer and changes drive modes. This results in regenerative braking being disabled, at random, in the middle of a drive. This is a ... Read more

Incident date: May 19, 2026

2016 Honda Pilot EXL. At 100,100 miles, an engine rod bearing went bad. Honda told me my VIN was not covered and it would be $8000 to replace the engine with a used engine. I sold them my car

Incident date: Jul 6, 2026

A month or so ago my car had a rough idle and the mechanic couldn't figure out why. Then last week my car lost power on the interstate, during rush hour. I'm lucky I didn't cause an accident as the loss of power was so sudden and all the traffic around me. Somehow I was able to safely pull over on t... Read more

Incident date: Jul 2, 2026

The contact owns a 2017 Hyundai Santa Fe. The contact stated that while driving approximately 15 MPH on the interstate, the contact heard an abnormal tumbling sound coming from underneath the vehicle. The contact noticed an unknown object had detached from the vehicle. Upon inspection, the contact d... Read more

Incident date: Jul 2, 2026

The windshield wipers intermittently stop working. This has been occurring for 2 years and the 5dealership cannot find an issue because they always work when the car is in for service. They also now want to charge a diagnostic fee each time it's in since the car is no longer under warranty

Incident date: Jul 6, 2026

The contact owned a 2010 Ford Ranger. The contact stated that while the son was driving uphill at approximately 65 MPH, the vehicle crashed into the rear passenger side of a boat trailer, causing the vehicle to roll over and slide approximately 20 ft. During the crash, the front of the vehicle was ... Read more

Crash 1 injured

Incident date: Jul 6, 2026

The contact owns a 2005 Dodge Ram 1500. The contact received notification of NTHSA Campaign Number: 16V352000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the dealer had exceeded a reasonable amount of time for... Read more

Incident date: Jun 15, 2026

The wiring in my trunk harness was severed due to the repeated opening and closing of my trunk. This caused my reverse lights to fail and my trunk latch to stop working. This issue is part of a known recall: Campaign 21V-00D. Tesla attempted to fix the issue in 2023 but the poor repair did not work.... Read more

Incident date: Apr 1, 2026

When turning left the steering wheel catches and sticks. It is also causing a stationary chassis shift at full lock.

Incident date: Apr 1, 2026

When turning left the steering wheel catches and sticks. It is also causing a stationary chassis shift at full lock.

Incident date: Apr 1, 2026

Since the first weeks of ownership, my 2024 Volkswagen Taos has exhibited a persistent brake system defect: loud metallic grinding/scraping/squealing noise when braking, vibration when braking, and sensation that brakes are not engaging properly. The defect affects both front and rear brakes. At app... Read more

Incident date: Apr 6, 2026

After driving the vehicle around all day, I parked it and turned it off and then it set on fire.

Fire

Incident date: Apr 6, 2026

The contact owns a 2024 Lincoln Corsair. The contact received notification of NHTSA Campaign Number: 26V091000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the vehicle was experiencing an abnormally high voltage battery rapid discharge... Read more

Incident date: Jun 5, 2026

What component or system failed or malfunctioned, and is it available for inspection upon request? Jeep started on fire and is still at a tow yard in Belchertown, MA How was your safety or the safety of others put at risk? The Jeep started on fire while I was driving. I pulled over as the engine was... Read more

Fire

Incident date: Apr 6, 2026

The contact owns a 2024 Nissan Kicks. The contact stated that while the vehicle was parked, the rear glass shattered without impact. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 30,... Read more

Incident date: May 4, 2026

The contact owns a 2016 Jeep Cherokee. The contact stated that while driving 25 MPH, the vehicle went into LIMP Mode. Several unknown warning lights were illuminated. A dealer was contacted. The contact pulled over into a parking lot, turned off and restarted the vehicle, and the vehicle operated as... Read more

Incident date: May 23, 2026

The driver-side front door and related body fit/sealing system appear to be defective. The door is visibly uneven and misaligned with the surrounding body panels, resulting in excessive door gaps and significant air intrusion into the cabin while driving. The condition is available for inspection up... Read more

Incident date: Jun 26, 2025

As I was driving 75 mph down the highway my collision alert flashed all my lights turned off, including my headlights and all interior lights as it was dark time and they flashed back on a couple of times until they finally stayed on. I pulled over and as I came to zero, speed, the vehicle completel... Read more

Incident date: Jun 9, 2026

The passenger seat occupancy sensor, an electrocapacitive mat (ecm), is defective on a large number of cars on the g30/fop platform including mine. This leads to intermittent sensor faults which cause an airbag warning.

Incident date: Jun 9, 2026

Incident date: Jun 5, 2026

Driving and everything on my dashboard goes black. Also issues with false blind spot detections.

Incident date: Jun 5, 2026

Apr 11,2025 Manufacturer Recall Number25S37 NHTSA Recall Number25V236 Recall StatusRecall Incomplete The manufacturer has failed or is unable to remedy this safety recall for my vehicle in a timely manner: April 2025: Safety Recall notice received from Ford, parts not available. September 2025: ... Read more

Incident date: May 29, 2026

Bolts for front lower lateral links in suspension backed themselves out over time, eventually causing the suspension to suffer a total collapse and trigger a complete loss of steering authority.

Incident date: May 21, 2026

On 05/08/2026 the brakes failed while in a queue at a drive-up restaurant. The car was steered away to a flat part of the parking lot. After a restart the brakes returned to operation and the car was taken to the dealership where the brake line were flushed and the brake fluid replaced. On 05/25/202... Read more

Crash

Incident date: May 26, 2026

This morning, around 9 AM, I was stopped on [XXX] in traffic, just south of [XXX] . [XXX] ) Foot on break, waiting for traffic to start moving. Engine suddenly revved to about 4k RPM. Car started to lurch a bit, I had to put increased pressure on the brake to hold it. I wasn’t sure the b... Read more

Showing 50 of 432 complaints.

NHTSA Safety Ratings, 2020 FORD EDGE

2020 Ford Edge SUV AWD

Category	Rating
Overall Rating	5 / 5 ★★★★★
Frontal Crash	5 / 5 ★★★★★
Frontal Crash, Driver	5 / 5 ★★★★★
Frontal Crash, Passenger	5 / 5 ★★★★★
Side Crash	5 / 5 ★★★★★
Side Crash, Driver	5 / 5 ★★★★★
Side Crash, Passenger	5 / 5 ★★★★★
Rollover	4 / 5 ★★★★☆
Rollover Risk	15.5%

Safety Technology

Feature	Status
Electronic Stability Control	Standard
Forward Collision Warning	Standard
Lane Departure Warning	Standard

Source: NHTSA 5-Star Safety Ratings Program. Ratings are based on crash tests conducted by the National Highway Traffic Safety Administration.

Technical Service Bulletins, 2020 FORD EDGE

195 manufacturer communications from 125 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
110000 ELECTRICAL SYSTEM	47
350000 EQUIPMENT	29
060000 ENGINE AND ENGINE COOLING	16
100000 POWER TRAIN	15
118000 ELECTRICAL SYSTEM:SOFTWARE	12
980000 UNKNOWN OR OTHER	6
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL	6
353000 EQUIPMENT:ELECTRICAL	5

350000 EQUIPMENT

All accessory stick-on keyless entry keypads come with a wallet card containing the master code. If the accessory keypad was factory installed, this card will be placed in the glove box and should be handed to the vehicles owner during ini

980000 UNKNOWN OR OTHER

Various vehicles have had pinpoint tests, guided routines and the Warranty and Policy Manual recentlyupdated for diagnostics and repairs on SYNC generation 3 and later applications. When performingdiagnostics and repairs on SYNC Gen 3 or la

060000 ENGINE AND ENGINE COOLING

For 2015-2024 Ford and Lincoln vehicles equipped with turbocharged engines and customer concern of an engine oil leak, refer to Workshop Manual (WSM), Section 303-00 for oil leak inspection and testing methods. Ford has evaluated turbocharg

100000 POWER TRAIN

During service and repair requiring removal and replacement of a crankshaft bolt and/or crankshaft damper, achieving proper torque of the crankshaft pulley bolt is critical. Incorrect torque may allow the bolt to loosen resulting in the tim

110000 ELECTRICAL SYSTEM

Some 2020-2023 Ford and Lincoln SYNC3 equipped vehicles may experience an inaccurate notification in the FordPass??A?/LincolnWay??A? app indicating Vehicle Has Entered Deep Sleep Mode. Vehicle Has Entered Deep Sleep Mode message is expected

060000 ENGINE AND ENGINE COOLING

This TSB supersedes TSB 23-2049 to update the parts list. Some 2019-2023 Edge/Nautilus vehicles equipped with a 2.7L EcoBoost engine may exhibit a ticking/tapping or rattle type noise from the top front cover area of the engine on initial s

104000 POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)

Some 2019-2021 Edge/Nautilus vehicles equipped with all wheel drive (AWD) may exhibit a noise from the rear of the vehicle while approaching the vehicle or prior to starting engine. This may be due to the rear drive unit (RDU) actuator lear

118000 ELECTRICAL SYSTEM:SOFTWARE

104000 POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)

Some 2019-2021 Edge/Nautilus vehicles equipped with all-wheel drive (AWD) may exhibit a noise/vibration/chatter/shudder/grind/bind from the rear of the vehicle during low speed turning events. To correct the condition, reprogram the AWD mod

100000 POWER TRAIN

Some 2019-2023 Edge/Nautilus and 2022-2023 Maverick vehicles equipped with all wheel drive (AWD) may exhibit chatter/shudder during low speed turning events. This may be due to fluid contamination in the rear drive unit (RDU). Drain and ref

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

Some 2019-2020 Edge/F-150/Fusion/Continental/MKZ/Nautilus, 2019-2021 Mustang/Ranger/Transit Connect, 2020-2021 EcoSport/Escape/Expedition/Explorer/F-Super Duty/Aviator/Corsair/Navigator, 2021 Bronco Sport and 2020-2022 Explorer/Aviator vehi

980000 UNKNOWN OR OTHER

118000 ELECTRICAL SYSTEM:SOFTWARE

353610 EQUIPMENT:ELECTRICAL:INFOTAINMENT:SOFTWARE

110000 ELECTRICAL SYSTEM

In various 2017-2023 Ford and Lincoln vehicles, customers may receive a message in the FordPass or LincolnWay App stating Feature Unavailable. Since this is a fleet vehicle, it cannot access the (SYNC Connect) FordPass or LincolnWay app thr

100000 POWER TRAIN

Some 2019-2023 Edge/Nautilus, 2020-2023 Escape/Corsair, 2021-2023 Bronco Sport, 2022-2023 Maverick vehicles equipped with all wheel drive (AWD) may exhibit chatter/shudder during low speed turning events. This may be due to fluid contaminat

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

980000 UNKNOWN OR OTHER

280100 BACK OVER PREVENTION:SOFTWARE

Some 2020-2021 Escape built on/before 23-Nov-2021, 2021 F-150 built on/before 08-Oct-2021, 2021 Mustang Mach-E built on/before 29-Mar-2021, 2021 Expedition built on/before 05-Aug-2021, 2021 Explorer built on/before 27-Sep-2021 and 2020-2022

357500 EQUIPMENT:APPLIANCE:TV/RADIO/SPEAKERS

110000 ELECTRICAL SYSTEM

Some 2020-2023 Ford and Lincoln SYNC3 equipped vehicles may experience an inaccurate notification in the FordPassA?/LincolnWayA? app indicating Vehicle Has Entered Deep Sleep Mode. Vehicle Has Entered Deep Sleep Mode message is expected if

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

The Service Awareness Newsletter is an informal communication that contains information that may not be presently available in a TSB, SSM, GSB, or other electronic communication. This article includes information on warranty, technical serv

060000 ENGINE AND ENGINE COOLING

Some 2021-2023 Ford and Lincoln vehicles equipped with a 2.7L or 3.0L engine may exhibit an upper engine thump/knock noise coming from the left cylinder head. This condition is most noticeable at idle and may lessen at higher engine speed o

160000 STRUCTURE

For 2000-2024 Ford and Lincoln vehicles, swapping a module from a vehicle for diagnosis purposes is likely to cause errors and is not recommended. It is also not recommended to order a replacement module using a vehicle identification numbe

060000 ENGINE AND ENGINE COOLING

Some 2019-2023 Edge/Nautilus vehicles equipped with a 2.7L EcoBoost engine may exhibit a ticking/tapping or rattle type noise from the top front cover area of the engine on initial start-up after a cold soak of 6 hours or more that may last

353000 EQUIPMENT:ELECTRICAL

060000 ENGINE AND ENGINE COOLING

Some 2019-2023 Edge/Nautilus vehicles equipped with a 2.0L engine may exhibit a repeat block heater failure. This may be caused by air in the engine cooling system. The WSM replacement procedure has been updated to include the Engine Coolin

030000 BRAKES (PWS)

Some Ford and Lincoln vehicles may exhibit noise when the brakes are applied. When diagnosing and repairing brake noise conditions, use the Workshop Manual (WSM) and the appropriate pinpoint test in section 206-00. The brake rotors should o

280100 BACK OVER PREVENTION:SOFTWARE

Some 2015-2020 Edge, 2016-2018 MKX, 2019-2020 Nautilus, 2018-2021 Expedition/Navigator, and 2020-2021 Escape/Corsair/Explorer/Aviator vehicles may exhibit an inoperative power liftgate. This may be due to the rear gate trunk module (RGTM) s

060000 ENGINE AND ENGINE COOLING

Some 2019-2022 Edge/Nautilus vehicles equipped with a 2.7L EcoBoost engine may exhibit a ticking/tapping or rattle type noise from the top front cover area of the engine on initial start-up after a cold soak of 6 hours or more that may last

030000 SERVICE BRAKES, HYDRAULIC

100000 POWER TRAIN

Some 2021-2022 Bronco Sport 1.5L, 2019-2022 Edge/Nautilus, 2020-2022 Escape/Corsair, and 2022 Maverick vehicles may exhibit an illuminated AWD warning indicator or fault message with diagnostic trouble code (DTC) C0095:71/:19 stored in the

100000 POWER TRAIN

Some 2018-2022 Ford and Lincoln vehicles equipped with the 8F35 transmission built on or before 16-Mar-2022 may exhibit transmission slip during acceleration from a stop when hot. This may be due damaged internal case half pump seals (7N265

353000 EQUIPMENT:ELECTRICAL

Some 2018-2022 Ford/Lincoln vehicles equipped with a wireless charging pad may exhibit one of the following if the customer is using a Magsafe iPhone (iPhone 12 or 13): slow charging, inoperative, notification that the phone has been mispos

110000 ELECTRICAL SYSTEM

Some 2017-2022 Ford/Lincoln customers may experience a notification in the FordPass??A???A???A???A?/LincolnWay??A???A???A???A? app indicating Vehicle Has Entered Deep Sleep Mode. This occurs when the vehicle has not been started for 14 cons

353000 EQUIPMENT:ELECTRICAL

Some 2019-2022 Edge/Nautilus, 2018-2022 Expedition/Navigator, 2020-2022 Explorer/Aviator vehicles equipped with a family entertainment system may experience the audio is not synchronized with the video display when using the vehicle speaker

280100 BACK OVER PREVENTION:SOFTWARE

110000 ELECTRICAL SYSTEM

Some 2017-2022 Ford and Lincoln vehicle owners may experience a condition of missing authorization, command and control, battery charging details or phone-as-a-key setup buttons/selections in their FordPass or LincolnWay App. This condition

118000 ELECTRICAL SYSTEM:SOFTWARE

110000 ELECTRICAL SYSTEM

Some 2013-2023 Ford or Lincoln vehicles with modems activated through FordPass or LincolnWay may experience 12 volt battery drain symptoms when the customer uses non-Ford/Lincoln phone applications as an alternate channel to access vehicle

346000 COMMUNICATION:MANUFACTURER TELEMATICS

Some 2017-2021 Ford and Lincoln vehicles equipped with a TCU may exhibit inoperative remote features via Ford Pass/Lincoln Way mobile app, incomplete user authorization and/or no modem electronic serial number (ESN) displayed. To correct th

350000 EQUIPMENT

In various 2017-2022 Ford and Lincoln vehicles, customers may receive a message in the FordPass or LincolnWay App stating "Feature Unavailable. Since this is a fleet vehicle, it cannot access the (SYNC Connect) FordPass or LincolnWay app th

346000 COMMUNICATION:MANUFACTURER TELEMATICS

220000 SEATS

This article supersedes TSB 21-2236 to update the models and year affected. Some 2013-2018 C-Max, 2013-2020 Fusion/MKZ, 2013-2022 Escape, 2015-2018 Focus, 2015-2019 MKC, 2015-2022 Edge/F150/Mustang, 2016-2018 MKX, 2016-2019 Explorer, 2017-2

350000 EQUIPMENT

354000 EQUIPMENT:MECHANICAL

100000 POWER TRAIN

Some 2020-2022 Edge ST and Nautilus vehicles equipped with an 8F57 transmission built on or before 18-Mar-2022 may exhibit a return to park when shifting to drive or reverse with an illuminated malfunction indicator lamp (MIL) and diagnosti

220000 SEATS

Some 2017-2018 Focus/MKX/C-MAX, 2017-2019 MKC/Taurus/Flex/MKT, 2017-2020 Fusion/MKZ/Continental, 2017-2022 Mustang/Edge/Explorer/Police Interceptor Utility/Escape/F-150/F-Super Duty, 2018-2022 Expedition/Navigator, 2019-2022 Ranger/Nautilus

060000 ENGINE AND ENGINE COOLING

Some 2019-2022 Edge/Nautilus, 2020-2022 Escape/Corsair, and 2021-2022 Bronco Sport vehicles equipped with a 2.0L EcoBoost or 2.3L EcoBoost may exhibit a lack of power with an illuminated malfunction indicator lamp (MIL) with diagnostic trou

110000 ELECTRICAL SYSTEM

162600 STRUCTURE:BODY:HATCHBACK/LIFTGATE

Some 2019-2020 Edge/Nautilus vehicles built on or before 03-Dec-2020 may exhibit a power liftgate unable to unlatch from both switches after a second unlatch attempt with or without diagnostic trouble code (DTC) U3000:49 stored in the rear

350000 EQUIPMENT

118000 ELECTRICAL SYSTEM:SOFTWARE

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

Some 2016-2021 Ford and Lincoln vehicles equipped with SYNC 3 may exhibit a condition where the navigation voice prompts are inoperative after a SYNC map update. This may be due to an incomplete installation of the SYNC map software. If pos

118000 ELECTRICAL SYSTEM:SOFTWARE

353000 EQUIPMENT:ELECTRICAL

Some 2018-2021 Ford and Lincoln vehicles may exhibit inoperative remote features via the Ford Pass/Lincoln Way mobile app, incomplete user authorization, no modem electronic serial number (ESN) displayed or DTCs U2100 and/or B156D in the te

110000 ELECTRICAL SYSTEM

This article supersedes TSB 21-2342 to update the Issue, Action, and Service Procedure. Some 2019-2020 Edge/F-150/Fusion/Continental/MKZ/Nautilus, 2019-2021 Mustang/Ranger/Transit Connect, 2020-2021 EcoSport/Escape/Expedition/Explorer/F-Sup

350000 EQUIPMENT

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

Some 2019-2021 Edge/Nautilus vehicles built on or before 11-Mar-2021 and equipped with a 8F35 transmission may exhibit a shudder/buck/jerk while driving up to 35 mph (57 km/h). This may be due to the software in the powertrain control modul

350000 EQUIPMENT

980000 UNKNOWN OR OTHER

Some 2017-2020 Ford and Lincoln vehicles equipped with a TCU may exhibit inoperative remote features via Ford Pass/Lincoln Way mobile app, incomplete user authorization and/or no modem electronic serial number (ESN) displayed. To correct th

346000 COMMUNICATION:MANUFACTURER TELEMATICS

060000 ENGINE AND ENGINE COOLING

Some 2019-2020 Edge/Nautilus vehicles equipped with 2.0L EcoBoost engine and built on or before 14-Oct-2020 may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTCs) P0137, P0141 and/or P2096. This may

110000 ELECTRICAL SYSTEM

Some 2019-2020 Edge/F-150/Fusion/Continental/MKZ/Nautilus, 2019-2021 Mustang/Ranger/Transit Connect, 2020-2021 EcoSport/Escape/Expedition/Explorer/F-Super Duty/Aviator/Corsair/Navigator and 2021 Bronco Sport vehicles with SYNC 3 may experie

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Some 2019-2020 Edge/F-150/Fusion/Continental/MKZ/Nautilus, 2019-2021 Mustang/Ranger/Transit Connect, 2020-2021 EcoSport/Escape/Expedition/Explorer/F-Super Duty/Aviator/Corsair/Navigator and 2021 Bronco Sport vehicles with SYNC 3 may experie

110000 ELECTRICAL SYSTEM

Some 2015-2021 Edge, 2016-2018 MKX, and 2019-2021 Nautilus vehicles may exhibit the parking lamps stay on and/or the trailer lights flicker with vehicle turned off when a trailer is connected to the vehicle. This may be due to the software

120000 EXTERIOR LIGHTING

110600 ELECTRICAL SYSTEM:INTERIOR LAMPS/BULBS

120110 EXTERIOR LIGHTING:LIGHTING CONTROL MODULE:SOFTWARE

060000 ENGINE AND ENGINE COOLING

Some 2019-2021 Edge/Nautilus/Ranger, 2020-2021 Escape/Corsair/Explorer, and 2021 Bronco Sport vehicles equipped with a 2.0L/2.3L EcoBoost may exhibit a lack of power with an illuminated malfunction indicator lamp (MIL) with diagnostic troub

061400 ENGINE AND ENGINE COOLING:ENGINE:HARD PARTS INTERNAL/MECHANICAL

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

Some 2019-2020 Edge/F-150/Fusion/Continental/MKZ/Nautilus, 2019-2021 Mustang/Ranger/Transit Connect, 2020-2021 EcoSport/Escape/Expedition/Explorer/F-Super Duty/Aviator/Corsair/Navigator and 2021 Bronco Sport vehicles with SYNC 3 may experie

102640 POWER TRAIN:MANUAL TRANSMISSION:INTERNAL:DOGS/SYNCHROS

Some 2019-2020 Edge/F-150/Fusion/Continental/MKZ/Nautilus, 2019-2021 Mustang/Ranger/Transit Connect, 2020-2021 EcoSport/Escape/Expedition/Explorer/F-Super Duty/Aviator/Corsair/Navigator and 2021 Bronco Sport vehicles with SYNC 3 may experie

110000 ELECTRICAL SYSTEM

Some 2019-2021 Edge/Nautilus vehicles may exhibit an inoperative power liftgate with or without diagnostic trouble code U3000:49 stored in the rear gate trunk module (RGTM). This may be due to the software in the RGTM. To correct the condit

350000 EQUIPMENT

110000 ELECTRICAL SYSTEM

Some 2015-2021 Ford and Lincoln vehicles may exhibit an illuminated MIL with diagnostic trouble codes (DTC) P0011, P0012, P0014, P0015, P0016, P0017, P0018, P0019, P0021, P0022, P0024 and/or P0025. This may be due to small debris causing th

031110 SERVICE BRAKES, ELECTRIC:SOFTWARE/PROGRAMMING

Some 2013-2021 Ford and Lincoln vehicles may exhibit noise when the brakes are applied. When diagnosing and repairing brake noise conditions, use the Workshop Manual (WSM) and the appropriate pinpoint test in section 206-00. The brake rotor

110000 ELECTRICAL SYSTEM

Some 2018-2021 Ford/Lincoln vehicles equipped with a wireless charging pad may exhibit an inoperative charging pad, slow charging, a notification that the phone has been mispositioned on the charging pad and/or the phone charging icon in th

102640 POWER TRAIN:MANUAL TRANSMISSION:INTERNAL:DOGS/SYNCHROS

Some 2017-2021 Ford and Lincoln vehicle customers may receive a message in their FordPass or Lincoln Way App stating Feature Unavailable. Since this is a fleet vehicle, it cannot access the SYNC Connect or FordPass Connect feature or Lincol

110000 ELECTRICAL SYSTEM

Some 2016-2021 Ford or Lincoln vehicles equipped with SYNC 3 or SYNC 4 may exhibit a blank screen or other various SYNC symptoms only when the vehicle is in transport mode. This is considered normal due to the power saving features enabled

100000 POWER TRAIN

Some 2019-2021 Edge/Nautilus/Transit Connect, 2020-2021 Escape/Corsair and 2021 Bronco Sport vehicles equipped with a 8F35 transmission may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P0766 sto

110000 ELECTRICAL SYSTEM

Some 2019-2020 Edge/F-150/Fusion/Continental/MKZ/Nautilus, 2019-2021 Mustang/Ranger/Transit Connect, 2020-2021 EcoSport/Escape/Expedition/Explorer/F-Super Duty/Aviator/Corsair/Navigator and 2021 Bronco Sport vehicles with SYNC 3 may experie

350000 EQUIPMENT

Some 2019-2020 Edge/F-150/Fusion/Continental/MKZ/Nautilus, 2019-2021 Mustang/Ranger/Transit Connect, 2020-2021 EcoSport/Escape/Expedition/Explorer/F-Super Duty/Aviator/Corsair/Navigator and 2021 Bronco Sport vehicles with SYNC 3 may experie

110000 ELECTRICAL SYSTEM

Some 2019-2021 Edge/Nautilus vehicles equipped with all wheel drive (AWD) may exhibit a noise from the rear of the vehicle while approaching the vehicle or prior to starting engine, which is associated with rear drive unit (RDU) actuator le

220000 SEATS

Some 2013-2018 C-Max, 2013-2020 Fusion/MKZ, 2013-2021 Escape, 2015-2018 Focus, 2015-2019 MKC, 2015-2021 Edge/F150/Mustang, 2016-2018 MKX, 2016-2019 Explorer, 2017-2021 F-Super Duty, 2018-2021 EcoSport/Expedition, 2019-2021 Ranger/Nautilus,

162200 STRUCTURE:BODY:BUMPERS

Some 2015-2021 Edge, 2016-2018 MKX and 2019-2021 Nautilus vehicles may exhibit a hood bounce or flutter condition at high speeds. This may be due to an incorrect adjustment of the rubber bump stops. To correct this condition, make sure the

060000 ENGINE AND ENGINE COOLING

Some 2019 MKC, 2019-2021 Edge/Nautilus/Escape/Ranger/Explorer, 2020-2021 Corsair, and 2021 Bronco Sport vehicles equipped with 2.0L and 2.3L EcoBoost engines may exhibit a light to moderate ticking type noise at idle (600-700 RPM). The nois

072100 FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

110000 ELECTRICAL SYSTEM

Some 2015-2021 Edge, 2016-2018 MKX, 2019-2021 Nautilus, 2018-2021 Expedition/Navigator, and 2020-2021 Escape/Corsair/Explorer/Aviator vehicles may exhibit an inoperative power liftgate. This may be due to the rear gate trunk module (RGTM) s

350000 EQUIPMENT

Some 2019-2021 Ford and Lincoln vehicles may exhibit an intermittent audio echo/robotic voice heard during a bluetooth phone call by the person that is not in the vehicle. Using Apple CarPlay and Android Auto instead of Bluetooth can help a

110000 ELECTRICAL SYSTEM

Some 2017-2021 Ford and Lincoln vehicle owners may experience a condition of missing Authorization, Command and Control, Battery Charging Details or Phone-as-a-Key setup buttons/selections in their FordPass or LincolnWay App. This condition

350000 EQUIPMENT

060000 ENGINE AND ENGINE COOLING

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

110000 ELECTRICAL SYSTEM

Some 2018-2020 Ford and Lincoln vehicles may exhibit inoperative remote features via the Ford Pass/Lincoln Way mobile app, incomplete user authorization, no modem electronic serial number (ESN) displayed or DTCs U2100 and/or B156D in the te

350000 EQUIPMENT

356000 EQUIPMENT ADAPTIVE/MOBILITY

110000 ELECTRICAL SYSTEM

Some 2019-2020 Edge/F-150/Fusion/Continental/MKZ/Nautilus, 2019-2021 Mustang/Ranger/Transit Connect, 2020-2021 EcoSport/Escape/Expedition/Explorer/F-Super Duty/Aviator/Corsair/Navigator and 2021 Bronco Sport vehicles with SYNC 3 may experie

Showing 100 of 195 bulletins.

NHTSA Safety Investigations, FORD EDGE

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

DP, Open , Model Year: 2015

Loss of Motive Power

The Office of Defects Investigation (ODI) received a petition on August 5, 2026, requesting a defect investigation into the 2.0 Liter EcoBoost engine on model year 2015-2018 Ford Edge vehicles. The petition alleges that engine coolant intrusion results in a significant loss of engine power, accompan... Read more

PE, Closed , Model Year: 2015

Loss of braking caused by rear brake hose failure

On October 3, 2024, NHTSA’s Office of Defects Investigation (ODI) opened this Preliminary Evaluation to investigate instances of rear brake hose ruptures causing a sudden and unexpected loss of braking in model year (MY) 2015-2017 Ford Edge vehicles manufactured by Ford Motor Company. The complain... ts allege that, without warning, the vehicle lost its ability to brake causing an unanticipated increase in the vehicle’s stopping distance. The complaints also allege that, prior to the rear brake hose rupture event, the vehicle had been serviced under recall 20V-469. Recall 20V469 involved MY 2015-2018 Ford Edge and MY 2016-2018 Lincoln MKX vehicles which may experience front brake hose ruptures causing increased brake pedal travel and a reduction in the rate of deceleration. Ford identified the cause of this safety defect as a consistent localized failure of the internal reinforcement braid of the brake hose due to cyclic fatigue via tensile/bending and torsional inputs during suspension and steering articulations. Ford also identified that only 88% of suspension articulation was utilized on the front brake hose test rig during life cycle testing. These findings, along with ODI’s identification of an emerging trend involving rear brake hose ruptures, prompted the opening of this investigation. ODI identified 64 Vehicle Owners Questionnaires related to this investigation, 2 involving a crash. These consumers were interviewed and reported experiencing sudden loss of braking ability while traveling at low and highway speeds without any prior warning such as a “low brake fluid” warning indicator. Consumers reported that, as they tried to stop their vehicle, the brake pedal traveling to the floorboard and the vehicle required more stopping distance than anticipated or considered normal. Consumers also observed brake fluid present on the rear tires and roadway near the rear tires immediately after the incident. Some consumers provided photographs of the rear brake hose ruptures which depicted a similar rupture pattern and location (near the crimp on the dynamic section of the brake hose). 1 photograph showed an installation alignment mark pulled out near the crimp suggesting exposure to unanticipated tensile forces pulling the hose away from the crimp. During this investigation, Ford responded to Information Request Letters detailing information such as warranty claim data, brake hose specifications and engineering drawings, production part changes logs, and Ford’s assessments of potential root cause. Ford reported that the front and rear brake jounce hoses equipped on the subject vehicle population utilized the same construction and material. Therefore, Ford’s analysis consisted of a comparison between the front and rear hoses demonstrating that the rear hose bend radii in full jounce and full rebound were larger than the front hose. Ford also described that the two hoses are exposed to different loading environments as the rear brake hose is exposed to suspension inputs only, while the front hose is exposed to both suspension and steering inputs; thus, the rear hose is subjected to lower tension and fatigue loads. However, it is important to point out that larger bend radii alone do not necessarily mean a brake hose can withstand the dynamic loading requirements of a brake hose (as discussed earlier, the defect identified in the front brake hoses were attributed to the hose material). Rear brake hose failures were identified through exemplar vehicle and parts inspections conducted by NHTSA’s Vehicle Research and Testing Center. Ford stated that its investigation did not identify any specific or common root cause for this safety defect, and that brake hoses can fail for many reasons including contact with road debris, improper vehicle servicing, and fatigue, as well as vehicle age and miles in service. Based on its assessment of failure rates and warranty claims, Ford concluded that the rear brake hose ruptures did not present an unreasonable risk to motor vehicle safety because consumers would experience a progressive leak accompanied by a red brake warning indicator within the instrument panel and would not experience a total loss of braking due to the diagonally split brake system. Note that these assessments are contrary to the consumer experiences described above. As previously described, consumers described a sudden, unexpected loss of braking ability with no prior warning in their instrument cluster (not a progressive leak) and an increase in anticipated vehicle stopping distance (presenting an unreasonable risk to motor vehicle safety). ODI conveyed these perspectives and investigative findings to Ford during a technical discussion on July 23, 2025. On August 22, 2025, Ford submittedrecall 25V-544 which included MY 2015-2018 Ford Edge and MY 2016-2018 Lincoln MKX vehicles, for a total recall population of 499,129 vehicles. As described in the Part 573, in September 2024, Ford concluded that this concern did not present an unreasonable risk to motor vehicle safety and closed its investigation into allegations involving rear brake jounce hose ruptures within this vehicle population. Ford reopened this investigation in July 2025 following the technical discussion with ODI referenced above. Ford identified the safety defect as a rupture of the rear brake jounce hose resulting in an increase in pedal travel and increase in vehicle stopping distance elevating the risk of a crash. To date, Ford has not fully determined the root cause of this safety defect and is currently working to develop a remedy program. In view of the recall action taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identiﬁcation Number document, go to NHTSA.gov.Read more

RQ, Open , Model Year: 2020

Rearview Camera FMVSS 111 Noncompliance

On September 23, 2020, Ford Motor Company (Ford) filed a noncompliance recall report under 49 CFR Part 573 (NHTSA Recall No. 20V-575), recalling 620,246 Model Year (MY) 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus ... Read more

PE, Closed , Model Year: 2011

Door Ajar Warning Light Always On

The Office of Defects Investigation (ODI) opened this investigation on September 28, 2016 based on allegations that the door ajar light located on the instrument cluster stays on all of the time even when all doors are closed and fully latched on 2011-2013 model year Ford Edge vehicles.When the ligh... t is illuminated continuously, vehicle occupants cannot be certain if any of the doors are properly latched.Reported safety consequences as a result of this issue include doors opening while driving (because doors were initially not latched properly), doors cannot be locked while driving, and the interior dome lights staying on continuously. Ford data received from the Information Request letter corresponding to this investigation indicates the failures were caused by contamination of the electrical contacts on the switch located within each door latch that tells the vehicle if the door is open or closed.All four doors contain the same latch design and switch.According to Ford, the Body Control Module (BCM) monitors the position of the switch and continuously samples it to detect a state of change.After a closed door state is detected, a continuous wetting current designed to keep the electrical contacts clean is sent from the BCM to the switches as long as the BCM is active.Beginning with the 2011 model year Edge vehicles, a change in BCM strategy resulted in a reduction of the wetting current sent out to clean the switch contacts by more than 75%.Over time, this low level of current is not sufficient to keep the switch contacts clean and contamination build up causes them to fail as described above.During the course of this investigation, ODI has identified a total of 1,983 complaints related to the door ajar light.Of these complaints, 14 indicated that a door opened while driving.Twelve of the 14 door opening events were situations where an occupant of the vehicle (often a child) opened a passenger door because the doors were not locked.The remaining two complaints involved a door opening on its own because the driver was unaware that the door was unlatched.There were no accidents but one complainant reported that a shoulder injury was caused by the driver having to repeatedly slam the door in an effort to get the door ajar light to turn off.After reviewing all available data, an unreasonable risk to motor vehicle safety has not been identified.The door latches themselves continue to function properly, remaining securely latched until acted upon by a driver or passenger.Child safety locks on the rear doors continue to function properly and can be used to prevent the rear doors from opening via the inside door handles.Vehicle crashworthiness is not affected by the lock condition of the doors and all active safety systems continue to function normally even if the vehicle BCM believes one or more doors is open.In addition, no accidents or accident related injuries have been reported.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.ODI numbers for the reports cited above are shown in the attached document.Read more

PE, Closed , Model Year: 2014

Wheel Separation

On November 29, 2014, ODI received a complaint reporting the complete separation of an original equipment 22-inch alloy wheel rim mounted on the right front position of a model year 2014 Ford Edge vehicle (VOQ 10661278).The driver indicated that the right-front corner of the vehicle suddenly dropped... Read more

PE, Closed , Model Year: 2007

FRONT SUSPENSION LOWER BALL JOINT

ON JULY 13, 2009, THE OFFICE OF DEFECTS INVESTIGATIONS (ODI) OPENED PRELIMINARY EVALUATION PE09-031 TO INVESTIGATE ALLEGATIONS OF FRONT LOWER BALL JOINT SEPARATION IN MODEL YEAR (MY) 2007 AND 2008 FORD EDGE AND LINCOLN MKX VEHICLES.THE INVESTIGATION WAS BASED ON THREE OWNER COMPLAINTS ALLEGING THAT ... THE FRONT LOWER BALL JOINT SEPARATED AND CAUSED THE FRONT SUSPENSION TO COLLAPSE WHILE DRIVING.ODI ALSO IDENTIFIED INFORMATION RELATED TO THE ALLEGED DEFECT IN EARLY WARNING DATA SUBMITTED BY FORD.PRELIMINARY ANALYSIS INDICATED THAT THE FAILURES WERE RELATED TO THE PINCH BOLT USED TO SECURE THE FRONT LOWER BALL JOINT STUD TO THE STEERING KNUCKLE.ONE COMPLAINT ALLEGED THAT A CRASH OCCURRED WHICH RESULTED IN A MINOR INJURY.HOWEVER, NO ADDITIONAL INFORMATION COULD BE OBTAINED TO SUPPORT THIS CLAIM.INFORMATION PROVIDED BY FORD IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER FOR PE09-031 INDICATE THAT IN EARLY MY 2007 PRODUCTION THERE WERE SOME ISSUES WITH THE FRONT LOWER CONTROL ARM BALL JOINT ASSEMBLY PROCESS.THE PINCH BOLTS USED WERE HAND STARTED AND HAD THE POTENTIAL TO CROSS THREAD AND NOT ACHIEVE PROPER CLAMP LOAD, POTENTIALLY RESULTING IN A LOOSE JOINT.IN NOVEMBER 2007, CHANGES WERE IMPLEMENTED TO CHASE AND CLEAN THE FIRST SIX THREADS OF THE BOLT TO PROVIDE EASIER HAND STARTING OF THE NUT AND ENSURE GOOD THREAD ENGAGEMENT BEFORE TIGHTENING. FORD ALSO IDENTIFIED ONGOING CONCERNS WITH THE POWER TRANSMISSION UNIT (PTU) SEALS AND FRONT SUSPENSION HYDRO-BUSHINGS ON THE SUBJECT VEHICLES, WHICH BOTH REQUIRE DISASSEMBLY OF THE FRONT LOWER BALL JOINT TO REPAIR.IF THE BALL JOINT IS NOT PROPERLY REASSEMBLED FOLLOWING SUCH SERVICE, THE JOINT MAY SEPARATE IN LATER SERVICE.FORD HAS PROVIDED ADDITIONAL INSTRUCTIONS AND NEW PINCH BOLTS TO THE PTU REPAIR KIT TO IMPROVE THE JOINT REASSEMBLY PROCESS. ODI'S ANALYSIS OF FAILURE DATA IDENTIFIED 31 INCIDENTS OF JOINT SEPARATION (WITH 12 SPECIFICALLY STATING THAT THEY OCCURRED WHILE DRIVING).REPAIR RECORDS FOR THESE 31 VEHICLES SHOWS THAT 28 INVOLVE SEPARATION OF THE JOINT ON THE PASSENGER (RIGHT) SIDE, WHICH IS THE SIDE THAT MUST BE DISASSEMBLED FOR PTU SERVICE.TWENTY-THREE OF THESE WERE FOUND TO HAVE BEEN PREVIOUSLY DISASSEMBLED FOR CONTROL ARM BUSHING SERVICE, PTU SERVICE OR OTHER TRANSMISSION REPAIR. THE EIGHT CLAIMS THAT DID NOT INVOLVE PRIOR SERVICE REPAIRS REQUIRING JOINT DISASSEMBLY ALL OCCURRED VERY EARLY IN VEHICLE LIFE, INDICATING THAT IT IS UNLIKELY THAT ANY JOINTS MANUFACTURED WITH LOOSE PINCH BOLTS ARE STILL IN SERVICE.ALL OF THESE JOINTS FAILED WITHIN 6 MONTHS IN SERVICE AND 10,000 MILES (THE MAXIMUM FAILURE MILEAGE IS 8,097 MILES).THERE HAVEN'T BEEN ANY SUCH FAILURES (I.E., NOT INVOLVING PRIOR SERVICE/DISASSEMBLY) SINCE DECEMBER 2008.THE RATE FOR INCIDENTS THAT DID NOT OCCUR FOLLOWING SERVICE AND, THUS, MAY BE RELATED TO THE MANUFACTURING PROCESS ISSUES IDENTIFIED BY FORD IS VERY LOW (2.5 PER 100,000 VEHICLES) AND THESE INCIDENTS OCCURRED VERY EARLY IN THE LIFE OF THE VEHICLES AND ARE NOT SHOWING A CONTINUING FAILURE TREND.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.Read more

FORD EDGE - All Years Overview

Complete safety history for the FORD EDGE across all model years (2007, 2024).

92 Total Recalls

18,058 Total Complaints

6 Investigations

506 Reported Crashes

185 Reported Fires

4 Reported Deaths

FORD EDGE - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2024	2	50	View
2023	4	34	View
2022	5	163	View
2021	7	147	View
2020 (current)	4	432
2019	3	937	View
2018	7	984	View
2017	8	1,647	View
2016	7	1,112	View
2015	7	967	View
2014	3	519	View
2013	2	3,247	View
2012	3	1,482	View
2011	3	2,538	View
2010	7	778	View
2009	7	307	View
2008	7	1,467	View
2007	6	1,242	View
2004	0	5	View

Other FORD Models

Model	Recalls	Complaints
MUSTANG	1,104	11,600	View
RANGER	928	10,371	View
F-350 SD	776	2,363	View
F-150	692	46,142	View
F-450 SD	692	624	View
F-250 SD	638	3,635	View
EXPLORER	624	42,549	View
F-550 SD	578	603	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2020 FORD EDGE

Complaint Statistics

Top Reported Components

NHTSA Safety Ratings, 2020 FORD EDGE

Safety Technology

Technical Service Bulletins, 2020 FORD EDGE

Most Affected Components

NHTSA Safety Investigations, FORD EDGE

FORD EDGE - All Years Overview

FORD EDGE - Year by Year

Other FORD Models