2023 CHEVROLET TAHOE

5 recalls, 312 complaints - 856 TSBs - 4/5 safety rating

FUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY

Defect Description

General Motors, LLC (GM) is recalling certain 2021 Cadillac Escalade, 2021, 2023-2024 Chevrolet Tahoe, and 2022 and 2024 GMC Yukon vehicles equipped with a 6-cylinder diesel engine. The original fuel tank may have been replaced with an incorrect fuel tank, which can allow fuel to leak in a rollover ... Read more

Consequence

A fuel leak in the presence of an ignition source increases the risk of a vehicle fire.

Remedy

Dealers will inspect for the correct fuel tank and replace it, if necessary, free of charge. Owner notification letters were mailed November 5, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-878... Read more

12 vehicles affected

Manufacturer: General Motors, LLC

ENGINE AND ENGINE COOLING:ENGINE:HARD PARTS INTERNAL/MECHANICAL

Defect Description

General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing d... Read more

Consequence

Engine failure increases the risk of a crash.

Remedy

Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification le... Read more

597,571 vehicles affected

Manufacturer: General Motors, LLC

SERVICE BRAKES, HYDRAULIC:BRAKE FLUID LOW WARNING: LAMP

Defect Description

General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake... Read more

Consequence

Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.

Remedy

The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020,... Read more

449,671 vehicles affected

Manufacturer: General Motors, LLC

SUSPENSION:REAR

Defect Description

General Motors, LLC (GM) is recalling certain 2023 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Yukon, and Yukon XL vehicles. The rear suspension outer control arm bolts may not have been properly heat-treated, which can cause the bolts to break.

Consequence

A broken suspension bolt can result in misalignment of the rear wheel, increasing the risk of a crash.

Remedy

Dealers will replace both rear suspension outer control arm bolts, free of charge. Owner notification letters were mailed November 14, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM... Read more

189 vehicles affected

Manufacturer: General Motors, LLC

EXTERIOR LIGHTING:LIGHTING CONTROL MODULE:SOFTWARE

Defect Description

General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate wh... Read more

Consequence

DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.

Remedy

The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac custo... Read more

740,108 vehicles affected

Manufacturer: General Motors, LLC

Complaint Statistics

312 total complaints 9 crashes 6 fires 7 injuries 2 deaths

Top Reported Components

Component	Complaints
ENGINE	58
POWER TRAIN	43
ELECTRICAL SYSTEM	36
UNKNOWN OR OTHER	35
STEERING	19
FUEL/PROPULSION SYSTEM	15
AIR BAGS	7
EXTERIOR LIGHTING	7
SERVICE BRAKES	6
SUSPENSION	6

Incident date: Sep 7, 2026

1 week and 1 day later we are stranded again on the side of highway going full speed in our Tahoe. We took it to two different certified Chevy dealerships and they gave us a vague resolution and this issusr is not fixed at all. Our engine is locking up on us at full speed on the highway. This vehicl... Read more

Incident date: Aug 29, 2026

We were driving full speed down the highway and the vehicle completely shut down steering wheel locked and we were stranded for six hours. Turns out the dealer said it was just the battery and they fixed the grounding of the battery. I’m sorry but I’m not satisfied with this response. I’m scar... Read more

Incident date: Aug 29, 2026

Incident date: Aug 27, 2026

A couple weeks ago, the truck suddenly started running rough and the front collision avoidance system failure message displayed. Immediately took it to the dealership. Computer read out showed #7 fuel injector failed. Repaired and was fine. Yesterday, 8/27/26, same thing happened again. Immediately... Read more

Incident date: Aug 27, 2026

Incident date: Aug 28, 2026

The contact owns a 2023 Chevrolet Tahoe. The contact stated that the vehicle was taken to a dealer, where the NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling) remedy was completed with an oil change and oil cap replacement. Approximately three months later, while the contact's wife was d... Read more

Incident date: Oct 1, 2025

I am writing to express my disappointment with how the L87 engine recall was handled on my 2023 Chevrolet Tahoe. I purchased this vehicle for approximately $82,000 and brought it to Kunes Chevrolet in Lake Geneva multiple times for scheduled maintenance. During my first visit after learning of the ... Read more

Incident date: Jan 1, 2026

ONSTAR module does not work. GM dealership claims the hardworking malfunctions and needs replacement for $800. Onstar is advertised as a safety feature that is now unable to be used.

Incident date: Apr 12, 2026

My 2023 Chevrolet Tahoe (VIN: [XXX]) suffered a catastrophic failure of the 6.2L V8 L87 engine assembly — specifically the connecting rod and crankshaft components — at freeway speeds on [XXX], just 9 days after purchase. The original failed engine is no longer available for inspection as it was... Read more

Incident date: Aug 9, 2026

The contact owns a 2015 Chevrolet Silverado 1500. The contact stated that the vehicle was taken to a dealer for an undisclosed repair. The vehicle was picked up and driven for seven minutes down the road, and the vehicle lost power steering functionality. The vehicle was taken back to the dealer, an... Read more

Incident date: Aug 9, 2026

I was driving my 2019 Chevy Silverado TrailBoss with 81,000 miles at 65MPH on I-80 East in Omaha, NE, when 3 warning lights came on. The first was the Service Parking Brake. The second was Service ESC. The final was a flashing Check Engine light. My truck started backfiring/misfiring, making a lo... Read more

Incident date: Jul 7, 2026

The contact owns a 2026 Toyota 4Runner. The contact stated that on several occasions while driving at various speeds, after disconnecting the trailer wiring harness, the message Tow/Haul Mode or a Trailer Coverage Indicator appeared even though the vehicle was no longer hauling the trailer. The mess... Read more

Incident date: Jul 7, 2026

The TCM is faulty. There is a tsb so Toyota is well aware of the issue. They will not take care of it under the power train warranty. The TCM doesn't shift the vehicle correctly. This lag and funny shifting almost caused an accident.

Incident date: Aug 5, 2026

adaptive cruise disengaging alert on dash- no cars or weather conditions to induce this. loss of power and bucking on highway( near accident caused) catostostrophic sudden loss of power engine/transmission failure while mechanic driving resulting in car towed back to dealer. loss of power multiple t... Read more

Incident date: Jan 20, 2026

Backing my truck out of my garage the power steering needs service came on and immediately I had no power steering. The truck was very difficult to steer and had I been driving on the road this would have been a major oroblem. I only have 42000 miles on the truck.

Incident date: May 1, 2026

Front windshield is extremely fragile. The smallest rock will create a chip which will spider across the windshield within a couple days. I have an older Land Rover and there have been more rocks with only a few small chips and no spider. Cheap glass installed on the new Land Rovers.

Incident date: May 1, 2026

The vehicle has suffered a catastrophic failure of the hybrid drive motor rotor, transmission, and engine clutch, resulting in a $14,993 repair quote. This is a direct consequence of a failed remedy for NHTSA Recall 18V260 (Hyundai Campaign 176).In February 2020, a dealer performed an 'inspection/ca... Read more

Incident date: Jul 2, 2026

My 2017 Hyundai Santa Fe (VIN: [XXX]) was brought to Herb Chambers Hyundai of [XXX], in December 2023 to address the Underbody Corrosion Recall/Campaign (9A0). The dealer performed the preventative service. However, the remedy completely failed because the frame was already severely structurally com... Read more

Incident date: May 21, 2026

Cylinder 3 misfire code and rough idle/driving car tries to stall out, engine is consuming a quart of oil every 500 miles and has 30psi compression in cylinder 3. Car only has 129k miles

Incident date: Jul 13, 2026

When vehicles comes to a stop, sometimes there is a hesitation in vehicle acceleration. Vehicle will jerk, then accelerate 3-4 seconds after pressing down throttle. Car does not provide or show error codes. There is currently a Toyota Service Bulletin for the exact same issue for the Toyota highland... Read more

Incident date: Jul 13, 2026

Incident date: Jun 9, 2026

Front seats Cause back and hip pain and fatigue on trips over 30 mins- head rest don’t adjust to help compensate putting in awkward positioning. The automatic braking or whatever signifies your close to objects in the front has randomly breaked hard with nothing near me almost resulting in being ... Read more

Incident date: Jun 9, 2026

Incident date: Jul 27, 2023

System/Component Malfunction: High-voltage hybrid powertrain system failure. Code P0DAF-00 (Hybrid EV Battery Cell Balancing Circuit) is present and locked in the Hybrid Control Processor (HCP). Vehicle is available for inspection. Safety Risk: Operating a vehicle with an unresolved high-voltage hy... Read more

Incident date: Jul 27, 2023

Incident date: May 18, 2026

My vehicle is affected by Recall 93C / (NHTSA 25V-586 )for a fuel pump defect that can cause the engine to stall while driving. This safety issue has already occurred — my vehicle stalled while in motion, creating a dangerous situation. The car is currently unsafe to drive. Description of the Inc... Read more

Incident date: Jun 9, 2026

I recently got my transmission replaced for my 2006 Ford Freestyle in December 2025. Yet, I am having transmission issues on my car now. Bates Ford was the dealership who replaced my transmission, but I feel as if where they got my replaced transmission from was not honest about the product it sold ... Read more

Incident date: Jun 9, 2026

We were trying to drive home and the middle seat belt, where my youngest child was sitting, would not latch. it would 'click' in, but if you pulled on it, it would pop out. This was terrifying because we had to drive home on a 2-lane highway with oncoming traffic. I checked online and found that m... Read more

Incident date: Jun 9, 2026

Incident date: Jun 7, 2026

I am writing to formally lodge a complaint regarding a recurring issue I have experienced with the head gasket in my vehicle. I have owned several vehicles of this make and model, and I have observed a troubling pattern of blown head gaskets that has not been adequately addressed. Specifically, my ... Read more

Incident date: May 20, 2026

Im constantly having to put coolant in. My car won’t let me update. I have to pay at a dealership which is too expensive . Also, the two plug in to charge your phone doesn’t work.

Incident date: May 25, 2026

The second row captain's chair seatbelt buckle stalks on the 2027 Kia Telluride are abnormally tall and rigid, with an angle causing the seatbelt webbing to kink and compress at a sharp angle around any forward-facing car seat base. This compromises the seatbelt's ability to lock and distribute cras... Read more

Incident date: Apr 27, 2026

The contact owns a 2019 Ford Flex. The contact received notifications of NHTSA Campaign Numbers: 25V695000 (Back Over Prevention) and 25V732000 (Structure); however, parts to do the recall repairs were not yet available. The contact stated that while in reverse(R), the rearview camera image would in... Read more

Incident date: Apr 11, 2026

The vehicle experienced repeated catastrophic engine failures, including failure of a replacement engine. Approximately six months after purchase and at around 80,000 miles, the engine failed and required a complete engine replacement through Volkswagen and the MaxCare service contract. Approximate... Read more

Incident date: Apr 1, 2025

The contact owns a 2018 ALFA ROMEO Stelvio. The contact stated that while driving at an undisclosed speed, the vehicle randomly shuts off and comes to a complete stop before restarting on its own. Additionally, the vehicle tends to stall randomly after fueling, and the contact noted flickering withi... Read more

Incident date: Apr 1, 2025

My 2020 Toyota Highlander hybrid sometimes has a brake slipping or surging sensation when I apply my brakes while stopping. It happens periodically and not every time. I have not taken it to a Toyota service station for this specific reason but I mentioned it while in for a recent oil change. They c... Read more

Incident date: Apr 6, 2026

Mileage (~124k) * RPM behavior * Loss of power uphill * Can cause a crash on highway with the cvt promblems nissian sentras sv has been cause of loss of power out of no where needs to be addressed as a recall maintenance has been don great on vechile it has history and need to be addressed. It goes ... Read more

Incident date: Dec 31, 1969

While driving in hot environments the entire electrical interface would turn off. Some times the engine would stall as well. Nothing electrical works in the car and the motor would cut off while driving.

Incident date: Apr 29, 2026

Engine stopped while driving 70 mph down the highway and the car shifted into neutral. Had to cost to side of the road. Took car into dealership and even though the car was certified safe drive and the engine had no issues 5 months ago, I was told the engine was now locking up. The engine failed de... Read more

Incident date: Apr 29, 2026

Incident date: Apr 24, 2026

The contact owns a 2022 Hyundai Tucson. The contact stated that while maneuvering into a handicap parking space, the vehicle suddenly accelerated on its own while the brake pedal was depressed. The vehicle climbed over a concrete parking bollard and struck a handicap sign, resulting in unintended ac... Read more

Crash

Incident date: Apr 24, 2026

I purchased a new Ram RHO Dec 31 2025, on Saturday, January 17th 2026 1:03 AM, I received an email, a triggered alert 1) Driver Assistance Blind Spot Monitoring System Triggered Allert, Schedule your Service Appointment. I made an appointment for a shake in wheels and blind spot monitoring I brought... Read more

Crash

Incident date: Apr 24, 2026

2018 Kia Optima LX, 2.4L GDI Theta II engine. Approximately 128,000 miles. Reporting severe internal oil consumption that has progressed to engine misfire and shaking, consistent with late-stage Theta II connecting rod bearing failure. The vehicle is now unsafe to drive and has been parked. Timelin... Read more

Incident date: Jan 23, 2026

When the running lights and headlights are set to Auto, moving the lever to High Beam causes the lights to go out. I have been asking the dealer and trying to find a solution since buying the car new, but no recall had been issued for my VIN and the dealer will not correct the problem with a recall ... Read more

Incident date: Apr 17, 2026

I was driving west bound on I40 with the adaptive cruise control, and lane assist on at 75 MPH. It was around 8:30 PM when I seen the instrument panel flash, just drop for less than half a second, and then come back up but dimmer, like when the headlights come on, except they already were on. At tha... Read more

Incident date: Apr 17, 2026

On [XXX] about [XXX] I was driving North on the [XXX] about a quarter mile north of the [XXX] exit and [XXX] 4 of a mile south of the [XXX] exit. The transmission in my 2019 Toyota Camry started to slip and failed to transfer power to the wheels. The engine reved to about 2800 RPM. Thankful... Read more

Incident date: Apr 17, 2026

Showing 50 of 312 complaints.

NHTSA Safety Ratings, 2023 CHEVROLET TAHOE

2023 Chevrolet Tahoe SUV 4WD

Category	Rating
Overall Rating	4 / 5 ★★★★☆
Frontal Crash	4 / 5 ★★★★☆
Frontal Crash, Driver	5 / 5 ★★★★★
Frontal Crash, Passenger	4 / 5 ★★★★☆
Side Crash	5 / 5 ★★★★★
Side Crash, Driver	5 / 5 ★★★★★
Side Crash, Passenger	5 / 5 ★★★★★
Rollover	3 / 5 ★★★☆☆
Rollover Risk	0.0%

Safety Technology

Feature	Status
Electronic Stability Control	Standard
Forward Collision Warning	Standard & Optional
Lane Departure Warning	Standard & Optional

Source: NHTSA 5-Star Safety Ratings Program. Ratings are based on crash tests conducted by the National Highway Traffic Safety Administration.

Technical Service Bulletins, 2023 CHEVROLET TAHOE

856 manufacturer communications from 395 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
110000 ELECTRICAL SYSTEM	176
060000 ENGINE AND ENGINE COOLING	131
350000 EQUIPMENT	118
100000 POWER TRAIN	75
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL	38
160000 STRUCTURE	35
080000 FUEL SYSTEM, DIESEL	23
353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.	18

110000 ELECTRICAL SYSTEM

This bulletin provides a procedure to program the ECM if the DTC is set and/or the start/stop doesn't restart after a stop.

060000 ENGINE AND ENGINE COOLING

This bulletin provides a procedure to program the ECM if the DTC is set and/or the start/stop doesn't restart after a stop.

350000 EQUIPMENT

This informational bulletin provides information for dealers/technicians on Customer Education Bulletin for Google Built-in Radio.

060000 ENGINE AND ENGINE COOLING

Customer Satisfaction Program - Certain vehicles may have a condition in which the engine lifter bores may be oversized. Dealers are to replace the engine.

200000 WHEELS

This service bulletin provides information for dealers/technicians on Tire Radial Force Variation (RFV).

030000 BRAKES (PWS)

This bulletin provides a replacement procedure for brake pads due to squealing Noise at Low Speeds for Tahoe PPVs.

110000 ELECTRICAL SYSTEM

This service bulletin provides information on the Transport Mode Feature, also known as Logistics mode, which is used to increase the 12V Battery stand time of the vehicle during transit and or long period of stand time at the dealerships.

350000 EQUIPMENT

980000 UNKNOWN OR OTHER

This warranty bulletin provides information on Customer Concern Not Duplicated (CCND) Labor Operation Numbers.

350000 EQUIPMENT

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

110000 ELECTRICAL SYSTEM

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

060000 ENGINE AND ENGINE COOLING

This bulletin provides a procedure to program the ECM if the DTC is set and/or the start/stop doesn't restart after a stop.

110000 ELECTRICAL SYSTEM

This bulletin provides a procedure to program the ECM if the DTC is set and/or the start/stop doesn't restart after a stop.

350000 EQUIPMENT

This bulletin provides a procedure to program the ECM if the DTC is set and/or the start/stop doesn't restart after a stop.

350000 EQUIPMENT

This informational bulletin advises the technician to check for faults that may be caused by the trailer otherwise found by a possible faulty trailer connector.

110000 ELECTRICAL SYSTEM

This informational bulletin advises the technician to check for faults that may be caused by the trailer otherwise found by a possible faulty trailer connector.

030000 SERVICE BRAKES, HYDRAULIC

This informational bulletin advises the technician to check for faults that may be caused by the trailer otherwise found by a possible faulty trailer connector.

350000 EQUIPMENT

This bulletin updates the position of General Motors on refinishing aluminum wheels. GM has determined that wheel refinishing under warranty will no longer be performed.

200000 WHEELS

This bulletin updates the position of General Motors on refinishing aluminum wheels. GM has determined that wheel refinishing under warranty will no longer be performed.

030000 BRAKES (PWS)

This bulletin provides a replacement procedure for brake pads due to squealing Noise at Low Speeds.

350000 EQUIPMENT

This technical bulletin provides repair information to correct a customer concern of a Service Drivers Assist Message Illuminated in DIC with DTC B2BA1 Set.

110000 ELECTRICAL SYSTEM

This technical bulletin provides repair information to correct a customer concern of a Service Drivers Assist Message Illuminated in DIC with DTC B2BA1 Set.

350000 EQUIPMENT

This technical bulletin provides repair information to correct a customer concern of the E88 Front Floor Console Bin Lamp Inoperative.

110000 ELECTRICAL SYSTEM

This technical bulletin provides repair information to correct a customer concern of the E88 Front Floor Console Bin Lamp Inoperative.

350000 EQUIPMENT

This Preliminary information communicates Engineering is investigating a no audio issue.

353640 EQUIPMENT:ELECTRICAL:AUX AUDIO JACK/PLUG

This Preliminary information communicates Engineering is investigating a no audio issue.

020000 SUSPENSION

This Preliminary information communicates A diagnostic tip from root causing DTC: C1197 caused by a pinched air inlet hose to the suspension compressor air leveling system.

251000 ELECTRONIC STABILITY CONTROL:AUTOMATIC (ASC)

This Preliminary information communicates A diagnostic tip from root causing DTC: C1197 caused by a pinched air inlet hose to the suspension compressor air leveling system.

110000 ELECTRICAL SYSTEM

This bulletin provides information for electrical ground repairs using new General Motors replacement fasteners with conductive finish.

160000 STRUCTURE

This preliminary informational bulletin provides frame coating repair information to correct a customer concern of wax coating on frame peeling, metal shows corrosion/rusting (U.S. and Canada Only).

356000 EQUIPMENT ADAPTIVE/MOBILITY

This technical bulletin provides repair information to correct a customer concern of a Service Drivers Assist Message Illuminated in DIC with DTC B2BA1 Set.

110000 ELECTRICAL SYSTEM

This technical bulletin provides repair information to correct a customer concern of a Service Drivers Assist Message Illuminated in DIC with DTC B2BA1 Set.

110000 ELECTRICAL SYSTEM

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

350000 EQUIPMENT

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

118000 ELECTRICAL SYSTEM:SOFTWARE

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

110000 ELECTRICAL SYSTEM

This Preliminary information communicates a vehicle may come to the dealer with a complaint of no start, stalling, rough idle, no acceleration, loss of power, erratic shifting, fuel gauge inoperative, MIL illuminated with various codes stor

100000 POWER TRAIN

This service bulletin provides diagnostic information for technicians in cases of an ETRS system fault or a no start condition - If the vehicle needs to be moved, it is recommended to use wheel dollies, tire skates or the NEW Manual Park Re

110000 ELECTRICAL SYSTEM

This technical bulletin provides repair information to correct a customer concern of the E88 Front Floor Console Bin Lamp Inoperative.

350000 EQUIPMENT

This technical bulletin provides repair information to correct a customer concern of the E88 Front Floor Console Bin Lamp Inoperative.

353000 EQUIPMENT:ELECTRICAL

This Preliminary information communicates and issue with the LED right above the wireless charging pad being inoperative and how to resolve the concern with the LED.

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

This Preliminary information communicates Diagnostic Tips When Having Difficulties Programming Or Adding Key Fobs / Transmitters.

160000 STRUCTURE

This preliminary informational bulletin provides frame coating repair information to correct a customer concern of wax coating on frame peeling, metal shows corrosion/rusting (U.S. and Canada Only).

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information on submitting quality Photos of Various Vehicle Concerns to the GM Technical Assistance Center (TAC).

110000 ELECTRICAL SYSTEM

060000 ENGINE AND ENGINE COOLING

This service bulletin advises the technician of possible coolant entering the areas of the engine, either through failed parts or defects in the castings, that may be the cause of the concerns related to the MIL or the engine running rough.

030000 SERVICE BRAKES, HYDRAULIC

This bulletin provides a replacement procedure for brake pads due to squealing Noise at Low Speeds.

110000 ELECTRICAL SYSTEM

This technical bulletin provides a procedure to program the TCM and replace the control valve body if the conditions are found to be the cause of the failure you the valve body.

100000 POWER TRAIN

This technical bulletin provides a procedure to program the TCM and replace the control valve body if the conditions are found to be the cause of the failure you the valve body.

353000 EQUIPMENT:ELECTRICAL

This Preliminary information communicates and issue with customers misunderstanding weather they need to bluetooth pair the factory provided headphones.

081100 FUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY

This technical bulletin provides a procedure replace the tappet that is located on the fuel door.

350000 EQUIPMENT

This technical bulletin provides a procedure replace the tappet that is located on the fuel door.

045200 SERVICE BRAKES, AIR:DISC:PADS

This Preliminary information communicates an issue with premature brake pad life and engineering is working on release new pad lining material.

100000 POWER TRAIN

Customer Satisfaction Program: Certain vehicles may have pinion gears that have low core and surface hardness. Dealers are to replace the transmission.

060000 ENGINE AND ENGINE COOLING

This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels shou

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

This Preliminary information communicates an issues with the HVAC making a hum buzz noise when the blower is set to a higher speed. Engineering is working on a new HVAC door seal material to correct the noise.

110000 ELECTRICAL SYSTEM

This bulletin advises the tech to inspect deeper into what may be the main cause of an engine failure.

100000 POWER TRAIN

This bulletin advises the tech to inspect deeper into what may be the main cause of an engine failure.

060000 ENGINE AND ENGINE COOLING

This bulletin advises the tech to inspect deeper into what may be the main cause of an engine failure.

350000 EQUIPMENT

This warranty administration bulletin provides policy information for GM courtesy transportation and roadside assistance programs.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Preliminary information communicates a diagnostic tip on how to resolve a issue if the serial data authentication configuration did not complete correctly.

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

This Preliminary information communicates where to find the back antenna for learning new key fobs.

350000 EQUIPMENT

This Warranty Administration bulletin provides information on Dealer Empowerment for Goodwill, Customer Enthusiasm and Policy (U.S. Only).

080000 FUEL SYSTEM, DIESEL

This bulletin advises the tech that there are extra characters on the fuel injector and to ignore the last numbers when identifying flow rate.

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

This Preliminary information communicates Engineering is investigating a no audio issue.

110000 ELECTRICAL SYSTEM

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

This Preliminary information communicates Engineering is investigating a no audio issue.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Preliminary Information communication advises the technician with a tip when the vehicle stops running after it has been idling for 2.5 hours. This is normal operation of the vehicle built with regular production code BTM and without R

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This service bulletin provides information on All hazmat parts being returned to the Warranty Parts Center (WPC) must be shipped using Central Transport. Hazardous materials should never be sent by air transportation to the WPC.

980000 UNKNOWN OR OTHER

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

118000 ELECTRICAL SYSTEM:SOFTWARE

This Preliminary information communicates to technicians that a calibration to correct a P138C is forthcoming and to not attempt repairs.

120000 EXTERIOR LIGHTING

This Preliminary information communicates a issue where the Can bus 1 data line is being corrupted by a aftermarket lighting module or poor connection installed by a Police Upfitter.

110000 ELECTRICAL SYSTEM

This Preliminary information communicates a issue where the Can bus 1 data line is being corrupted by a aftermarket lighting module or poor connection installed by a Police Upfitter.

162600 STRUCTURE:BODY:HATCHBACK/LIFTGATE

This technical bulletin offers a procedure to correct the condition of Dead Battery and / or Unwanted Liftgate Opening.

170000 LATCHES/LOCKS/LINKAGES

This technical bulletin offers a procedure to correct the condition of Dead Battery and / or Unwanted Liftgate Opening.

160000 STRUCTURE

This technical bulletin offers a procedure to correct the condition of Dead Battery and / or Unwanted Liftgate Opening.

110000 ELECTRICAL SYSTEM

This technical bulletin offers a procedure to correct the condition of Dead Battery and / or Unwanted Liftgate Opening.

020000 SUSPENSION

This Preliminary information communicates a tip when diagnosing an inoperative air leveling suspension system and to repair any loss of comm DTC's with the power window motors first.

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

This Preliminary information communicates Engineering is investigating a no audio issue.

100000 POWER TRAIN

This service bulletin advises the technician to check if the transmission cooler lines are twisted to correct customer concerns of Harsh Shift, Shudder, Surge, Stall, Transmission Overheating and/or High Transmission Fluid Temperature.

110000 ELECTRICAL SYSTEM

This technical bulletin provides repair information to correct a customer concern of DTC U3000 Setting in Automated Map Module (HDLM) - SuperCruise Unavailable.

110000 ELECTRICAL SYSTEM

This Preliminary information communicates that you may notice a black screen on their radio display. This can happen for a period of a couple seconds or the entire ignition cycle. Engineering is aware of the issue and investigating.

356000 EQUIPMENT ADAPTIVE/MOBILITY

This technical bulletin provides repair information to correct a customer concern of DTC U3000 Setting in Automated Map Module (HDLM) - SuperCruise Unavailable.

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

060000 ENGINE AND ENGINE COOLING

This service bulletin provides a repair procedure to correct customer concerns of Service Emissions System Displayed on DIC, MIL Illuminated with DTC P249C and/or P20E8 Set.

110000 ELECTRICAL SYSTEM

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.

110000 ELECTRICAL SYSTEM

This Preliminary information communicates information on to verify if the correct Rear Short Range Radar brackets are heat staked to the rear fascia. If brackets are installed in incorrect location U3000 SYM76 can set.

251000 ELECTRONIC STABILITY CONTROL:AUTOMATIC (ASC)

This Preliminary Information communication provides information to the technician about vehicles that have an unwanted Stability Activation and/or a Service Stability message on the Driver Information Center. Technician may find a Diagnosti

260000 FORWARD COLLISION AVOIDANCE

This Preliminary information communicates a "Forward Collision System Reduced" message displayed on the DIC when the Forward Automatic Braking has been set to the "Alert" setting. This is normal when the FAB has been set to "Alert".

284300 BACK OVER PREVENTION: SENSING SYSTEM: RADAR

275300 LANE DEPARTURE: SENSING SYSTEM: RADAR

264300 FORWARD COLLISION AVOIDANCE: SENSING SYSTEM: RADAR

070000 FUEL SYSTEM, GASOLINE

Emission Recall - General Motors has decided to conduct a Voluntary Emission Recall on certain vehicles. During servicing of these vehicles, an incorrect catalytic converter part that may not meet all emission system requirements may have

063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

170000 LATCHES/LOCKS/LINKAGES

This Preliminary information communicates where to find the back antenna for learning new key fobs.

116340 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER

This Preliminary information communicates where to find the back antenna for learning new key fobs.

350000 EQUIPMENT

This engineering information (EI) closure ends the need for gathering further information from technicians in regard to windshield wipers intermittently inoperative when on low setting.

110000 ELECTRICAL SYSTEM

This engineering information (EI) closure ends the need for gathering further information from technicians in regard to windshield wipers intermittently inoperative when on low setting.

Showing 100 of 856 bulletins.

NHTSA Safety Investigations, CHEVROLET TAHOE

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

DP, Closed , Model Year: 2010

Rollover Side Curtain Air Bags

In June 2015, the Office of Defects Investigation (ODI) opened this Defect Petition in response to a petition (see ODI 10568388) requesting a defect investigation of several alleged defects that can cause occupant ejections during rollover crashes in certain General Motors vehicles.The petition focu... Read more

EA, Closed , Model Year: 2007

Interior Door Handle Laceration Risk

The investigated concern involved chrome plating on interior door handles that could peel or separate from the plastic base material.This de-lamination could result in a sharp edge and pose a risk of laceration.In some cases, consumers reported minor hand/skin lacerations.Of these reported injuries,... the vast majority of injuries were to adults.Ninety percent of claims associated with interior door handle de-lamination were related to the front doors.In addition to the above Tahoe/Yukon vehicles, other GMT 900 series C/K vehicles (Avalanche, Escalade, Sierra, Silverado, and Suburban) have a trim level that utilizes the chrome plated interior door handles and were included in the analysis.The resultant population group had a total of 746 complaint reports with 309 injury incidents and 43,619 unique VIN regular warranty claims over a combined 451,745 vehicle population.The door handle supplier was changed in September 2006 with new tooling and process in place by October 2006.The base population prior to the September 2006 vendor change accounted for the bulk (or 89%) of all complaints and comparable injury reports and warranty claims.Due to the nature of the failure (thin chrome plating peeling off the door handle), only minor hand/skin laceration injuries similar to a paper cut were recorded.All but a few did not require professional medical treatment such as surgical or liquid sutures (i.e. stitches).Less than 10% of injury reports had specifically involved a 3-10 year old child.This was due to the fact that 90% of the claims were associated with door handles located in the front seating area (where the window glass panels usually have less solar tinting than rear window glass panels) where children are not normally seated. In July 2010, GM issued a Special Coverage Policy (SCP 09239) on the base vehicles to extend the warranty coverage to 10 years/100k miles.Recent data indicate that the base population complaint and injury reporting have subsided since the implementation of the SCP campaign.In June 2011, GM added the remaining interim population (Sep-Oct 2006) to the SCP.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstances.Read more

PE, Closed , Model Year: 2007

Interior Door Handle Laceration Risk

The statistical data regarding problem experience in the table above are net counts for unique vehicles.Review of information in this PE discloses that while accounting for approximately two-thirds of the total population, MY 2007 subject vehicles are cited in more than 90 percent of the consumer co... Read more

PE, Closed , Model Year: 1995

SEAT BELT ANCHORAGE SEPARATION

ODI HAS RECEIVED ONE (1) COMPLAINT ALLEGING THAT THE 2ND ROW PASSENGER-SIDE SEAT BELT RELEASE BUCKLE ANCHOR DETACHED FROM SEAT FRAME DURING A SIDE IMPACT CRASH.DURING THE CRASH, THE OCCUPANT WAS THROWN FROM HIS SEAT, PARTIALLY EJECTED THROUGH THE REAR QUARTER WINDOW OF THE VEHICLE.OCCUPANT SUSTAINED... Read more

PE, Closed , Model Year: 1995

HEADLIGHT

BASED ON THE REPORTS RECEIVED BY ODI FROM CONSUMERS, FAILURE OF THE HEADLIGHT ELECTRICAL CIRCUIT MAY OCCUR IN THE SUBJECT VEHICLES, AND MAY RESULT FROM REPEATED ADJUSTMENT OFTHE TILT STEERING WHEEL IN THE SUBJECT VEHICLES.REPEATED ADJUSTMENT OF THE STEERING WHEEL POSITION MAY STRAIN THE WIRING IN TH... Read more

PE, Closed , Model Year: 1995

BATTERY LEAKS ACID

ODI HAS RECEIVED 21 COMPLAINTS WHERE OWNERS ALLEGE THAT THE STANDARD GM FACTORY SUPPLIED AC DELCO BATTERY CASE FAILED, RESULTING IN THE LEAKAGE OF SULFURIC ACID.OF THE 21 COMPLAINT VEHICLES, SIX SUBURBAN, THREE TAHOES, AND ONE YUKON OWNER(S) COMPLAINED ABOUT A LOSS OF BRAKE FLUID FROM DETERIORATION ... Read more

CHEVROLET TAHOE - All Years Overview

Complete safety history for the CHEVROLET TAHOE across all model years (1994, 2026).

169 Total Recalls

12,966 Total Complaints

6 Investigations

622 Reported Crashes

195 Reported Fires

43 Reported Deaths

CHEVROLET TAHOE - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2026	3	31	View
2025	1	77	View
2024	3	100	View
2023 (current)	5	312
2022	4	254	View
2021	16	635	View
2020	3	68	View
2019	2	166	View
2018	3	142	View
2017	4	233	View
2016	8	353	View
2015	14	893	View
2014	3	118	View
2013	4	309	View
2012	3	253	View
2011	5	571	View
2010	4	405	View
2009	5	391	View
2008	4	687	View
2007	4	1,533	View
2006	4	144	View
2005	7	381	View
2004	5	548	View
2003	7	628	View
2002	6	543	View
2001	8	607	View
2000	10	341	View
1999	3	677	View
1998	4	315	View
1997	2	515	View
1996	5	390	View
1995	8	296	View
1994	2	20	View
1993	0	12	View
1992	0	8	View
1991	0	5	View
1988	0	1	View

Other CHEVROLET Models

Model	Recalls	Complaints
SUBURBAN	246	10,458	View
MALIBU	216	29,080	View
SILVERADO 1500	200	22,534	View
CORVETTE	187	6,308	View
CAMARO	179	4,298	View
SILVERADO	159	10,964	View
SILVERADO 3500	152	1,409	View
EXPRESS	151	838	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2023 CHEVROLET TAHOE

Complaint Statistics

Top Reported Components

NHTSA Safety Ratings, 2023 CHEVROLET TAHOE

Safety Technology

Technical Service Bulletins, 2023 CHEVROLET TAHOE

Most Affected Components

NHTSA Safety Investigations, CHEVROLET TAHOE

CHEVROLET TAHOE - All Years Overview

CHEVROLET TAHOE - Year by Year

Other CHEVROLET Models