1996 CHEVROLET TAHOE

5 recalls, 390 complaints - 43 TSBs

EQUIPMENT

Defect Description

CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AN... Read more

Consequence

THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.

Remedy

HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.

121,680 vehicles affected

Manufacturer: HONEYWELL INTERNATIONAL, INC.

FUEL SYSTEM, GASOLINE

Defect Description

CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CE... Read more

Consequence

THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.

Remedy

HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).

88,303 vehicles affected

Manufacturer: HONEYWELL INTERNATIONAL, INC.

VISIBILITY:WINDSHIELD WIPER/WASHER

Defect Description

ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.

Consequence

IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.

Remedy

DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, G... Read more

1,755,876 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

VISIBILITY:WINDSHIELD WIPER/WASHER

Defect Description

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.

Consequence

THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.

Remedy

DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.

1,557,585 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

VEHICLE SPEED CONTROL

Defect Description

THESE VEHICLES WERE ASSEMBLED WITH THE THROTTLE CABLE CONTACTING THE DASH MAT WHICH COULD BIND THE THROTTLE. THIS DOES NOT MEET WITH THE MAXIMUM RETURN TIMES REQUIRED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, "ACCELERATOR CONTROL SYSTEMS."

Consequence

CONSEQUENCE OF NON-COMPLIANCE: THE ENGINE SPEED MAY NOT RETURN TO IDLE INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.

Remedy

DEALERS WILL INSPECT FOR ADEQUATE THROTTLE CABLE TO DASH MAT CLEARANCE, AND IF THERE IS INSUFFICIENT CLEARANCE, CUT OUT A PORTION OF THE DASH MAT TO PROVIDE PROPER CLEARANCE.

379,004 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

Complaint Statistics

390 total complaints 31 crashes 5 fires 35 injuries 3 deaths

Top Reported Components

Component	Complaints
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP	39
POWER TRAIN:AUTOMATIC TRANSMISSION	20
VISIBILITY:WINDSHIELD WIPER/WASHER	18
VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR	18
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS	11
ELECTRICAL SYSTEM:12V/24V/48V BATTERY	10
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE	9
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP	9
AIR BAGS	8
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER	8

Incident date: Aug 29, 2020

TL* THE CONTACT OWNS A 1996 CHEVROLET TAHOE EQUIP WITH DEXTEERO DHT2 TIRES, SIZED: P265/75R/16, DOT 01BTHBAC00420, AND LINE: NOT AVAILABLE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH AND MAKING A LEFT TURN THE FRONT DRIVERS SIDE TIRE SUDDENLY EXPERIENCED A BLOW OUT CAUSING THE DRIVER... Read more

Crash

Incident date: Mar 30, 2020

I HAVE A 1996 CHEVY TAHOE WHICH I HAVE BEEN THE ORIGINAL OWNER SINCE NEW. I RECENTLY HAD MAINTENANCE PERFORMED ON THE VEHICLE AND HAD THE SHOP CHECK THE DRIVERS SIDE AIR BAG BECAUSE THE CHECK AIR BAG INDICATOR LIGHT WAS COMING ON DURING THE OPERATION OF THE VEHICLE. THE REPAIR SHOP INDICATED TO ... Read more

Incident date: Aug 13, 2013

TL* THE CONTACT OWNS A 1996 CHEVROLET TAHOE. WHILE DRIVING APPROXIMATELY 5 MPH AND PUSHING ANOTHER VEHICLE, THE BRAKES FAILED WHEN THE BRAKE PEDAL WAS DEPRESSED. AS A RESULT, BOTH VEHICLES CRASHED INTO A WALL. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES. THE... Read more

Crash

Incident date: Mar 20, 2013

MY HUSBAND WAS DRIVING OUR 1996 TAHOE WHEN IT JUST STOPPED! WE FOUND THAT THE KEY HAD SHUT OFF WHILE DRIVING. WE WERE IN THE MIDDLE OF A THRUWAY WHEN EVERYONE WAS DRIVING 60 MPH. A VERY DANGEROUS SITUATION INDEED. THIS HAS HAPPENED 3 TIMES IN THE YEAR I'VE OWNED THE VEHICLE. WE ARE ALSO HAVING... Read more

Incident date: Mar 20, 2013

Incident date: May 17, 2013

VEHICLE STOP SHUT DOWN COMPLETE WITH JERKING BEFORE SHUTTING DOWN STOP PULLING AND LOST ALL POWER NOW SERVICE ENGINE LIGHT IS ON AND ANTI-LOCK BRAKE LIGHT IS ON AND WANT SHIFT INTO SECOND GEAR AS IF SOMETHING IS WRONG WITH TRANSMISSION. *TR

Incident date: Aug 5, 2009

PAINT STARTED CHIPPING/PEELING OFF FROM DRIVERS FRONT FINDER AND HOOD IN APPROX. 2009 TO TODAYS DATE (08/21/2013). PS WE ARE THE ORIGINAL OWNERS AND OUR TAHOE HAS BEEN KEPT UP IN TOP CONDITION. *TR

Incident date: Aug 1, 2011

UNWANTED ANTILOCK BRAKE ACTIVATION AT LOW SPEED STARTED INTERMITTENT NOW CONSISTENT IN UNWANTED ACTIVATION RESULTING IN INCREASED STOPPING DISTANCE. THERE IS A CURRENT CAMPAIGN FOR 1999-2002 THAT SHOULD BE EXPANDED TO INCLUDE 1996 VEHICLES. CAMPAIGN NO. 05V379000. *TR

Incident date: Apr 16, 2005

DRIVER POWER SEAT WILL NOT OPERATE . I HAVE READ SIMILAR COMPLAINTS ON THE WEB ABOUT THE FAILURE OF SEAT WORKING PROPERLY AND HAS THERE BEEN A RECALL? I HAVE OWNED THE VEHICLE NEW AND THE ONLY DRIVER. I ONLY WEIGHT 90LBS. *TR

Incident date: Dec 16, 2010

TL*THE CONTACT OWNS A 1996 CHEVROLET TAHOE. WHILE DRIVING APPROXIMATELY 25 MPH THE BRAKES WERE APPLIED AND THE PEDAL EXTENDED TO THE FLOOR. THE VEHICLE WAS TAKEN TO HIS RESIDENCE AND THE CONTACT COULD SEE BRAKE FLUID LEAKING FROM THE BRAKE LINES. THE FAILURE WAS NOT DIAGNOSED AND THE VEHICLE WAS NO... Read more

Incident date: Nov 11, 2010

TL*THE CONTACT OWNS A 1996 CHEVROLET TAHOE. WHILE THE VEHICLE WAS PARKED, THE CONTACT STATED THAT THE FRONT RIGHT AND LEFT FRAME RAILS FOR THE AIR BAG SENSOR WERE SEPARATING AND ROTTING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THAT THE PARTS FOR REPAIR WERE NO LONGER MANUFACTURED. T... Read more

Incident date: May 30, 2008

MY '96 CHEVROLET TAHOE 2-DOOR SUFFERED COMPLETE BRAKE SYSTEM LOSS WHEN A BRAKE LINE BURST WHILE IN-SERVICE. THE TAHOE, USED PRIMARILY IN ILLINOIS IN THE WINTER, SUFFERED THE FAILURE IN MAY OF 2008 WITH ABOUT 102,000 MILES ACCUMULATED AND WITH NO WITH NO PRIOR INDICATIONS OF A PROBLEM PRIOR TO THE... Read more

Incident date: Mar 6, 2010

1996 CHEVROLET TAHOE. THE LEFT WINDSHIELD WIPER WORKS AND THE RIGHT WINDSHIELD WIPER DOES NOT. THIS BEGAN WHILE MY HUSBAND WAS DRIVING IN THE RAIN AND RESULTED IN VERY LIMITED VISIBILITY. HE WENT TO AUTO ZONE TO REPLACE THE WIPERS AND WHEN THEY REPLACED THE RIGHT WIPER, IT DID NOT CORRECT THE PROBLE... Read more

Incident date: Jul 22, 2004

I HAD A 1996 TAHOE THAT OCCASIONALLY SPED UP WHILE ON CRUISE CONTROL. I SOL THIS VEHICLE ABOUT FOUR Y EARS AGO. *TR

Incident date: Dec 13, 2008

TL*THE CONTACT OWNS A 1996 CHEVROLET TAHOE. WHILE DRIVING 55 MPH, THE FOUR WHEEL DRIVE LIGHT ILLUMINATED AND BEGAN FLASHING. THERE WAS SMOKE UNDERNEATH THE HOOD AND THE VEHICLE STALLED. AFTER OPENING THE HOOD, THE SMOKE CONTINUED TO MULTIPY; HOWEVER, THERE WAS NO FIRE PRESENT. A POLICE REPORT WAS FI... Read more

Fire

Incident date: Aug 5, 2008

TL*THE CONTACT'S MOTHER OWNS A 1996 CHEVROLET TAHOE. THE WINDSHIELD WIPERS WERE NOT OPERATING NORMALLY. THEY WERE REPAIRED IN 2001. RECALL 03V159000 COMPONENT: VISIBILITY:WINDSHIELD WIPER/WASHER IS RELATED TO THE FAILURE. THE DEALER CONFIRMED THAT THE VIN IS NOT RELATED TO THE RECALL. THE DEALER AL... Read more

Incident date: Aug 5, 2008

Incident date: Apr 2, 2008

I PURCHASED 5 TOYO PROXIES 285/60/18 AND HAVE HAD A BLOW OUT ON THE SIDE WALL OF TWO WITHIN THE LAST YEAR WITH PREMATURE CRACKING ON ALL OF THE TIRES. THE FIRST TIRE THAT BLEW OUT I THOUGHT WAS JUST AN ACCIDENT. BUT AFTER PURCHASING THE 5TH TIRE AND THEN HAVING A BLOW OUT ON 4/2/2008, WITHIN 6 MOS O... Read more

Incident date: Jan 30, 2007

OCCASIONALLY WHEN STARTING THE TRUCK THERE IS A MISFIRE/BACKFIRE FROM THE ENGINE WHERE GREY SMOKE PERMEATES THROUGH THE DASHBOARD INTO THE CABIN OF THE TRUCK. SMOKE ALSO COMES FROM UNDER THE HOOD OF THE TRUCK. DEALERSHIP COULD NOT DUPLICATE MISFIRE/BACKFIRE. THIS HAPPENS A FEW TIMES A MONTH. *... Read more

Incident date: Oct 21, 2006

1996 TAHOE HEADLIGHT FAILURE. WHEN FLIPPING THE SWITCH TO TURN O HEADLIGHTS THEY DO NOT TURN ON. SPENT ALMOST $200 IN DIAGNOSTIC TIME. THE REPAIR SHOP SAYS THE WIRING IN THE STEERING COLUMN IS FATIGUED AND FRAYED MOST LIKELY DUE TO REPEATED ADJUSTMENTS WITH THE TILT STEERING WHEEL. VERY EXPENSIVE TO... Read more

Incident date: Nov 20, 2006

DT*: THE CONTACT STATED THE HEADLIGHTS WOULD NOT ILLUMINATE. THE CONTACT HAD REPLACED THE HEADLIGHTS AND THE HEADLIGHT SWITCH BUT THAT HAD NOT RESOLVED THE ISSUE. THE VEHICLE HAD NOT BEEN TO A SERVICE DEALER.

Incident date: May 20, 2006

LET ME START BY SAYING THAT I AM A ASE CERTIFIED MASTER TRUCK TECHNICIAN WITH 16 YEARS OF EXPERIENCE. AFTER LEARNING OF THE SAFETY RECALL ON THE 285/75/16 DICK CEPEK RADIAL FCII, I INSPECTED ALL 5 OF MY TIRES. FOUR OF THE TIRES HAD MATCHING DOT CODES AND LOOKED FINE. THE FIFTH TIRE WAS BOUGHT AT A L... Read more

Incident date: Mar 5, 2006

DRIVER DOOR LATCH FAILURE. *JB

Incident date: Sep 1, 2005

ANTI-LOCK BRAKES ARE COMING ON FREQUENTLY. *JB

Incident date: Sep 21, 2005

MY 3 YEAR OLD DAUGHTER WAS ABLE TO SHIFT THE VEHICLE FROM PARK INTO NEUTRAL WITHOUT THE KEY IN THE IGNITION AND WITHOUT DEPRESSING THE BRAKE CAUSING THE VEHICLE TO ROLL BACKWARD INTO THE STREET. NO ACCIDENT OR INJURIES OCCURRED AS MY FATHER WAS ABLE TO REACH OVER AND HIT THE BRAKES. *NM

Incident date: Jul 19, 2005

DT: THE CONSUMER STATED THAT THERE IS A FAULTY FUEL PRESSURE REGULATOR IN 1996 CHEVROLET TAHOE TRUCK. THIS WAS NOTED ON 7-12-05. A REPRESENTATIVE FROM THE GM CALL CENTER TOLD THE CONSUMER THAT THERE WAS AN UPCOMING RECALL ON THIS PART AND THAT THE FUEL LINES MELT CAUSING THE FUEL PRESSURE REGULATO... Read more

Incident date: Apr 12, 2005

THE KEY SWITCH ON SOME FORD AND GENERAL MOTORS VEHICLE CAN BE TURNED ONE NOTCH OR CLICK FORWARD, ALLOWING THE VEHICLE TO BE SHIFTED OUT OF PARK WITHOUT APPLYING THE BRAKE, 1996 CHEVROLET TAHOE. *NM *SB *NM

Incident date: Jun 9, 2001

A LEAK IN THE VACCUUM BOOSTER CAUSED THE BRAKES TO FAIL WHICH RESULTED IN A COLLISION.

Crash 2 injured

Incident date: Jul 1, 2004

CONSUMER STATES: FUEL INJECTIN SYSTEM 5,6,AND 7 MISSING, AND IT IS LEAKING. VEHICLE BACK FIRED A COUPLE TIMES BEFORE IT NEEDED A TUNE UP. *AK

Incident date: Apr 12, 2005

FATALITY AS A RESULT OF IGNITION SWITCH BEING TURNED WITHOUT A KEY AND WITHOUT THE BRAKES BEING APPLIED.*MR WHEN THE COMPLAINANTS THREE YEAR OLD GRANDSON TURN THE KEY IN THE IGNITION ONE NOTCH FORWARD THIS ALLOWED THE GEAR LEVER TO BE SHIFTED OUT OF PARK AND INTO NEUTRAL WITHOUT THE BRAKE PEDAL BEI... Read more

Crash 1 deaths

Incident date: Feb 24, 2005

ABOUT 6 WEEKS AGO I SUBMITTED DOCUMENTATION REGARDING THE EXTENSIVE REPAIRS I HAD TO DO ON MY 1996 CHEVROLET TAHOE. HOWEVER, I HAVE NOT RECEIVED ANYTHING ON THE MATTER. AT THIS TIME I WOULD LIKE TO KNOW IF THE PAPERWORK WAS RECEIVED, IF THERE IS A NUMBER I SHOULD CALL TO FOLLOW UP OR IS THERE ANOTHE... Read more

Incident date: Feb 24, 2005

Incident date: Apr 12, 2005

MY 3 YEAR OLD NEPHEW WAS ABLE TO GET INTO HIS PARENTS 1996 CHEVY TAHOE AND WAS ABLE TO TURN THE KEY TO THE FIRST CLICK (BEFORE THE CLICK TO TURN ON THE RADIO AND POWER WINDOWS, ETC.). THEN WITHOUT TOUCHING THE BRAKE, THE TODDLER WAS ABLE TO PULL THE SHIFTER INTO NEUTRAL AND THE VEHICLE WAS ABLE TO ... Read more

Crash 1 deaths

Incident date: Apr 12, 2005

Crash 1 deaths

Incident date: Mar 2, 2005

WHILE DRIVING. THE BRAKES FAILED, AND A COLLISION OCCURRED. CONSUMER'S VEHICLE HIT THE BACK OF ANOTHER VEHICLE. . UPON HITTING THE BRAKES THEY PULSATED. *AK

Crash

Incident date: Feb 8, 2005

CONSUMER WAS HAVING TROUBLE WITH ELECTRICAL SYSTEM. THE EXTERIOR AND INTERIOR LIGHTS INADVERTENTLY FAIL AND CEASE WORKING. CONSUMER TOOK THE VEHICLE TO A DEALER TO DETERMINE THE CAUSE; HOWEVER, THE DEALER WAS UNABLE TO LOCATE THE PROBLEM. THE CONSUMER IS STILL EXPERIENCING UNEXPECTED FAILURE WITH T... Read more

Incident date: Feb 8, 2005

Incident date: Oct 19, 2002

CRASHED 1996 TAHOE GOING ABOUT 45 MPH, NO AIRBAGS DEPLOYED, CAUSING HEAD INJURY. NOT SURE OF DATE IT WAS FALL OF 2002.*AK

Crash 1 injured

Incident date: Jul 12, 2004

EXHAUST Y PIPE SHEARED OFF, COMMON IN THIS TYPE OF VEHICLE. VERY EXPENSIVE BECAUSE PARTS INCLUDE Y PIPE TWO CATALLETIC CONVERTERS AND THREE O2 SENSORS.*AK

Incident date: Aug 27, 2004

WHILE DRIVING AT 20 MPH CONSUMER SMELLED BURNING WIRING. PARKED THE VEHICLE, OPENED THE HOOD AND FOUND NOTHING WRONG. AT THE SAME TIME HE LOOKED TO THE REAR AND SAW A HEAVY SMOKE COMING FROM THE PASSENGER'S SIDE AND SUDDENLY VEHICLE CAUGHT ON FIRE. FIRE DEPARTMENT SHOWED UP, EXTINGUISHED TH... Read more

Fire

Incident date: Jul 25, 2004

WHILE DRIVING ALONG THE BOULEVARD AT 15 MPH, THE SMELL OF BURNING ELECTRICAL WIRES BECAME MORE PRONOUNCED. WHEN I LOOKED THROUGH THE REAR VIEW MIRROR I SAW FIRE DROPPING FROM THE REAR PASSENGER SIDE SPEAKER ENDANGERING THE LIVES OF THE PASSENGERS AND DAMAGING OUR POSSESIONS IN THE CARGO SECTION. I N... Read more

Fire

WHILE DRIVING 65 MPH, THE DRIVER NOTICED THAT SMOKE WAS COMING FROM THE FRONT REAR OF THE VEHICLE. THE DRIVER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE AND PULLED OVER. THE VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION. PLEASE PROVIDE FURTHER DETAILS. *JB

Incident date: Oct 15, 2003

WHILE DRIVING AT USUAL SPEED OF 35 MPH,DOWN A STEEP HILL MY WIFE WAS TERRIFIED WHEN SUDDENLY THE ENGINE FAILED, STEERING AND BRAKING BECAME DIFFICULT AND, IN HER MIND, NOTHING WAS WORKING. SHE MISSED A NUMBER OF CARS AT THE BOTTOM OF THE HILL AND PULLED INTO A VACANT GAS STATION. THE ENGINE STARTED ... Read more

Incident date: Sep 15, 2003

THE WIRING HARNESS THAT CONECTS TO THE TURN SIGNAL MODUAL, THE WIRES BECOME BRITTLE AND ARE BREAKING. THE FIRST WIRE TO CAUSE ME A PROBLEM WAS THE WIRE FOR THE HEADLIGHTS, THE HEADLIGHTS WOULD FLICKER ON AND OFF UNTILL THE WIRE FINALY BROKE AND THEN THERE WERE NO LIGHTS AT ALL. THE NEXT WIRE THAT BR... Read more

Incident date: Sep 15, 2003

Showing 50 of 390 complaints.

Technical Service Bulletins, 1996 CHEVROLET TAHOE

43 manufacturer communications from 30 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
350000 EQUIPMENT	7
110000 ELECTRICAL SYSTEM	4
353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES	3
353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.	3
136200 VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR	2
118000 ELECTRICAL SYSTEM:SOFTWARE	2
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL	2
100000 POWER TRAIN	2

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

070000 FUEL SYSTEM, GASOLINE

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and

030000 SERVICE BRAKES, HYDRAULIC

110000 ELECTRICAL SYSTEM

350000 EQUIPMENT

This informational bulletin provides information for dealers/technicians on Procedures to Unlock Delco Radio with Theftlock.

110000 ELECTRICAL SYSTEM

This informational bulletin provides information for dealers/technicians on Procedures to Unlock Delco Radio with Theftlock.

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock ce

353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

350000 EQUIPMENT

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

350000 EQUIPMENT

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

350000 EQUIPMENT

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco Theft Lock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock c

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco Theft Lock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock c

356000 EQUIPMENT ADAPTIVE/MOBILITY

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco Theft Lock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock c

070000 FUEL SYSTEM, GASOLINE

199000 TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

350000 EQUIPMENT

118000 ELECTRICAL SYSTEM:SOFTWARE

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This warranty administration bulletin provides policy information with the field action courtesy transportation policy.

118000 ELECTRICAL SYSTEM:SOFTWARE

353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)

Expanded Availability for Remanufacture and Return (R&R) Electronic Control Modules

060000 ENGINE AND ENGINE COOLING

This preliminary informational bulletin provides information on High Oil Pressure on Startup After Engine Replacement Concern.

350000 EQUIPMENT

This preliminary informational bulletin provides information on High Oil Pressure on Startup After Engine Replacement Concern.

021244 SUSPENSION:FRONT:SPRINGS:LEAF SPRING ASSEMBLY:U-BOLT, LEAF SPRING TO AXLE

LEFT FRONT AXLE SHAFT DIFFICULT TO REMOVE. AXLE DIFFERENTIAL LEAK SEAL SHAFT. *KB

036000 SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

ANTILOCK BRAKE (ABS) ACTIVATION AT LOW SPEEDS. *TT

060000 ENGINE AND ENGINE COOLING

REPLACEMENT OF CONNECTOR WHEN REPLACING FUEL TANK MODULE/FUEL PUMP MODULE. *TT

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

93-00 FULL SIZE UTILITIES (GMT 400 OLD STYLE ONLY) AC BLOWS WARM AND THE HIGH SIDE PRESSURE IS TOO HIGH. *MJ

110000 ELECTRICAL SYSTEM

MALFUNCTION INDICATOR LAMP ON WITH A P0300 SET AND A MISFIRE. VARIOUS MODELS INCLUDING 1996 - 1999 P32 MODELS. SIT BULLETIN 1416475. *TT

110000 ELECTRICAL SYSTEM

MALFUNCTION INDICATOR LAMP ON WITH A P0300 SET AND A MISFIRE. VARIOUS MODELS INCLUDING THE 1996-1999 P32 AND THE 1996-2002 GMC C/K TRUCK. *TT

093000 FUEL SYSTEM, OTHER:FUEL INJECTION SYSTEM

6.5L L49 L56 L57 L65 DIESEL ENGINE REQUIRING FUEL INJECTION PUMP REPLACEMENT. MODELS P32/P42 1994-1999 INCLUDED. *TT

100000 POWER TRAIN

POOR PERFORMANCE FROM A STOP IN 2WD, AUTO OR 4WD HI. 2003, 2003 CADILLAC EXT ALSO INCLUDED. *TT

136000 VISIBILITY:WINDSHIELD WIPER/WASHER

WINDSHIELD WIPER FAILURE DUE TO CRACKED BOULDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THIS SPECIAL POLICY COVERS THE CONDITION FOR A PERIOD OF SEVEN YEARS OR 70,000 MILES, WHICHEVER OCCURS FIRST FROM THE DATE THE VEHICLE WAS ORIGINALLY P

136200 VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR

SPECIAL POLICY ADJUSTMENT - WINDSHIELD WIPER MOTOR FAILURES. *TT

046000 SERVICE BRAKES, AIR:ANTILOCK

ANTILOCK BRAKE (ABS) ACTIVATION AT LOW SPEEDS ON VARIOUS MODELS INCLUDING THE 1995 AND 1996 ENVOY. *TT

100000 POWER TRAIN

DIAGNOSTIC INFORMATION FOR INTERMITTENT TRANSMISSION DOWNSHIFT, SLIP, BUSY/CYCLING TCC OR NOISY COOLING FAN. *TT

136200 VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR

PRODUCT RECALL CAMPAIGN INVOLVING WINDSHIELD WIPER MOTOR REPLACEMENT. *TT

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

TRANSMISSION FLUID LEAK FROM PUMP BODY (REPLACE BUSHING). *TW

102000 POWER TRAIN:MANUAL TRANSMISSION

MANUAL TRANSMISSION RATTLE NOISE AT IDLE (INSTALL CONVENTIONAL FLYWHEEL). *TW

061000 ENGINE AND ENGINE COOLING:ENGINE

SERVICE ENGINE SOON LIGHT AND P0300 WHEN TOWING, CRUISING UPHILL OR ON HARD ACCELERATION. *TT

105000 POWER TRAIN:DRIVELINE

4WD MODELS WITH NOISE, VIBRATION ON DRY PAVEMENT. *EH

NHTSA Safety Investigations, CHEVROLET TAHOE

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

DP, Closed , Model Year: 2010

Rollover Side Curtain Air Bags

In June 2015, the Office of Defects Investigation (ODI) opened this Defect Petition in response to a petition (see ODI 10568388) requesting a defect investigation of several alleged defects that can cause occupant ejections during rollover crashes in certain General Motors vehicles.The petition focu... Read more

EA, Closed , Model Year: 2007

Interior Door Handle Laceration Risk

The investigated concern involved chrome plating on interior door handles that could peel or separate from the plastic base material.This de-lamination could result in a sharp edge and pose a risk of laceration.In some cases, consumers reported minor hand/skin lacerations.Of these reported injuries,... the vast majority of injuries were to adults.Ninety percent of claims associated with interior door handle de-lamination were related to the front doors.In addition to the above Tahoe/Yukon vehicles, other GMT 900 series C/K vehicles (Avalanche, Escalade, Sierra, Silverado, and Suburban) have a trim level that utilizes the chrome plated interior door handles and were included in the analysis.The resultant population group had a total of 746 complaint reports with 309 injury incidents and 43,619 unique VIN regular warranty claims over a combined 451,745 vehicle population.The door handle supplier was changed in September 2006 with new tooling and process in place by October 2006.The base population prior to the September 2006 vendor change accounted for the bulk (or 89%) of all complaints and comparable injury reports and warranty claims.Due to the nature of the failure (thin chrome plating peeling off the door handle), only minor hand/skin laceration injuries similar to a paper cut were recorded.All but a few did not require professional medical treatment such as surgical or liquid sutures (i.e. stitches).Less than 10% of injury reports had specifically involved a 3-10 year old child.This was due to the fact that 90% of the claims were associated with door handles located in the front seating area (where the window glass panels usually have less solar tinting than rear window glass panels) where children are not normally seated. In July 2010, GM issued a Special Coverage Policy (SCP 09239) on the base vehicles to extend the warranty coverage to 10 years/100k miles.Recent data indicate that the base population complaint and injury reporting have subsided since the implementation of the SCP campaign.In June 2011, GM added the remaining interim population (Sep-Oct 2006) to the SCP.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstances.Read more

PE, Closed , Model Year: 2007

Interior Door Handle Laceration Risk

The statistical data regarding problem experience in the table above are net counts for unique vehicles.Review of information in this PE discloses that while accounting for approximately two-thirds of the total population, MY 2007 subject vehicles are cited in more than 90 percent of the consumer co... Read more

PE, Closed , Model Year: 1995

SEAT BELT ANCHORAGE SEPARATION

ODI HAS RECEIVED ONE (1) COMPLAINT ALLEGING THAT THE 2ND ROW PASSENGER-SIDE SEAT BELT RELEASE BUCKLE ANCHOR DETACHED FROM SEAT FRAME DURING A SIDE IMPACT CRASH.DURING THE CRASH, THE OCCUPANT WAS THROWN FROM HIS SEAT, PARTIALLY EJECTED THROUGH THE REAR QUARTER WINDOW OF THE VEHICLE.OCCUPANT SUSTAINED... Read more

PE, Closed , Model Year: 1995

HEADLIGHT

BASED ON THE REPORTS RECEIVED BY ODI FROM CONSUMERS, FAILURE OF THE HEADLIGHT ELECTRICAL CIRCUIT MAY OCCUR IN THE SUBJECT VEHICLES, AND MAY RESULT FROM REPEATED ADJUSTMENT OFTHE TILT STEERING WHEEL IN THE SUBJECT VEHICLES.REPEATED ADJUSTMENT OF THE STEERING WHEEL POSITION MAY STRAIN THE WIRING IN TH... Read more

PE, Closed , Model Year: 1995

BATTERY LEAKS ACID

ODI HAS RECEIVED 21 COMPLAINTS WHERE OWNERS ALLEGE THAT THE STANDARD GM FACTORY SUPPLIED AC DELCO BATTERY CASE FAILED, RESULTING IN THE LEAKAGE OF SULFURIC ACID.OF THE 21 COMPLAINT VEHICLES, SIX SUBURBAN, THREE TAHOES, AND ONE YUKON OWNER(S) COMPLAINED ABOUT A LOSS OF BRAKE FLUID FROM DETERIORATION ... Read more

CHEVROLET TAHOE - All Years Overview

Complete safety history for the CHEVROLET TAHOE across all model years (1994, 2026).

169 Total Recalls

12,966 Total Complaints

6 Investigations

622 Reported Crashes

195 Reported Fires

43 Reported Deaths

CHEVROLET TAHOE - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2026	3	31	View
2025	1	77	View
2024	3	100	View
2023	5	312	View
2022	4	254	View
2021	16	635	View
2020	3	68	View
2019	2	166	View
2018	3	142	View
2017	4	233	View
2016	8	353	View
2015	14	893	View
2014	3	118	View
2013	4	309	View
2012	3	253	View
2011	5	571	View
2010	4	405	View
2009	5	391	View
2008	4	687	View
2007	4	1,533	View
2006	4	144	View
2005	7	381	View
2004	5	548	View
2003	7	628	View
2002	6	543	View
2001	8	607	View
2000	10	341	View
1999	3	677	View
1998	4	315	View
1997	2	515	View
1996 (current)	5	390
1995	8	296	View
1994	2	20	View
1993	0	12	View
1992	0	8	View
1991	0	5	View
1988	0	1	View

Other CHEVROLET Models

Model	Recalls	Complaints
SUBURBAN	246	10,458	View
MALIBU	216	29,080	View
SILVERADO 1500	200	22,534	View
CORVETTE	187	6,308	View
CAMARO	179	4,298	View
SILVERADO	159	10,964	View
SILVERADO 3500	152	1,409	View
EXPRESS	151	838	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

1996 CHEVROLET TAHOE

Complaint Statistics

Top Reported Components

Technical Service Bulletins, 1996 CHEVROLET TAHOE

Most Affected Components

NHTSA Safety Investigations, CHEVROLET TAHOE

CHEVROLET TAHOE - All Years Overview

CHEVROLET TAHOE - Year by Year

Other CHEVROLET Models